Condor, Condor EcoFlex
|
|
- Aubrey McCarthy
- 5 years ago
- Views:
Transcription
1 , Condor EcoFlex PARTS LIST Standard odels: (4030D), (4030C / w/sweep system), (4030C / w/o sweep system) (4530D), (4530C / w/sweep system), (4530C / w/o sweep system) (4830D), (4830C / w/sweep system), (4830C / w/o sweep system) Obsolete AXP odels: (4030D-AXP), (4030C-AXP / w/sweep system), (4030C-AXP / w/o sweep system) (4530D-AXP), (4530C-AXP / w/sweep system), (4530C-AXP / w/o sweep system) (4830D-AXP), (4830C-AXP / w/sweep system), (4830C-AXP / w/o sweep system) EcoFlex odels: (X4030D), (X4030C / w/sweep system), (X4030C / w/o sweep system) (X4530D), (X4530C / w/sweep system), (X4530C / w/o sweep system) (X4830D), (X4830C / w/sweep system), (X4830C / w/o sweep system) 11/05 revised 8/13
2
3 TABLE OF CONTENTS DESCRIPTION PAGE Chassis System Decal System Drive Wheel System Drive Wheel System - Steering Assy Electrical System Rear Wheel System Recovery System Scrub System-Cylindrical Scrub System-Cylindrical-Scrub Assy Before SN Scrub System-Cylindrical-Scrub Assy After SN Scrub System-Cylindrical - Skirt & Bumper Assy Scrub System-Disk Scrub System-Disk-40 Inch Scrub Assy Scrub System-Disk-45 & 48 Inch Scrub Assy Scrub System-Disk - Skirt Assy Solution System Solution System - Chemical etering Kit Solution System - Drive Pedal & Elect. Panel Assy Squeegee System Squeegee System - Squeegee Arm Assy Squeegee System - Squeegee Assy F Squeegee System - Squeegee Assy G - 45, H Sweep System Sweep System - Side Broom Assy Ladder Diagram Optional Kits & Accessories Brush Selector Guide-Disk...54 Brush Selector Guide-Cylindrical...55 Squeegee Selector Guide...56 WHEN ORDERING PARTS * Use the numbers from the Ref. No. columns in this parts list. * Specify the model and serial number of the machine. * Use the space below to record the model and serial number for future reference. odel Serial No.
4 2 CHASSIS SYSTE
5 CHASSIS SYSTE Lug, Brush Driver Wsh, Flt SAE 5/ Wsh, Flt SAE 3/ Scr, Pan Phil 1/4-20 X Wsh, Flt SAE 1/ Scr, Pan Phil 1/4-20 X Scr, Pan Phil 1/4-20 X Scr, Soc Shd.38 X.75 X 5/ Scr, Hex 3/8-16 X Nut, Hex Nyl Loc 5/ Nut, Hex Nyl Loc 1/ Nut, Hex Nyl Loc 3/ Nut, Hex Nyl Loc-Thin 5/ Nut, Hex Nyl Loc-Thin 1/ Scr, Hex Hd Loc 3/8-16x Scr, Hex Thd Form 1/4-20 X Scr, Flt Phil Thd Form 1/4-20x Grommet Weld t, Chassis Support, Chassis Support Pin Plate Weldt Panel, Side Rear Bumper, Rubber Trim, Edge Side Panel Assy (#33-37) Plate, Latch ount Latch, RH Lever Conduit Clamp, P Grommet Nut, Hex Nyl Loc Scr, Hex Thd To Hd SS 6-1 X 20mm Panel, Side Front Hinge Plate
6 4 DECAL SYSTE 08-5
7 DECAL SYSTE Decal, Caution Decal, Tie Down Decal, Emergency Decal, Battery Wiring Diagram Decal, Logo Decal, Condor Decal, Condor AXP Decal Condor EcoFlex at, Pedal Decal, Circuit Breaker Decal, Parking Brake Decal, Logo 2 Inch Decal, Advance
8 6 DRIVE WHEEL SYSTE c 14a d a3 a2 a1 14b 14e a4 a5
9 13-8 DRIVE WHEEL SYSTE Nut, Castle 7/ Insulator, Terminal Cap, Grease Bearing, Cup Bearing, Cone Bearing, Cone Bearing, Cup Seal, Radial Lip Nut, Retainer 1/ Scr, Hex 1/4-20 X Pin Cotter, 1/8 X 1 1/ Scr, Hex 7/16-14 X # Wheel Drive Poly Assy TSB-FC a Drive otor Assy a Kit Gear Driven NOTE 1 a Cover Gear a Bearing Wheel a Washer Wave a Bearing otor 14b otor, Traction (1) [ ] Carbon Brush Set (for ) [ ] Brush Spring-otor (for ) [ ] Brush Box Assembly-otor (for ) 14c Poly Front Wheel 14d Wsh, High Collar Lock 5/16 14e Scr, Soc Hd 5/16-18 x Front Spindle Weld t Steering Assy Splash Guard Boot, Rubber Clamp, Hose Support Bushing [ ] = Not Shown # = Revised or new since last update NOTE 1: contains (2) bearings, (1) woodruff key, (1) driven gear and (1) gear shaft.
10 8 DRIVE WHEEL SYSTE - STEERING ASSY FRONT
11 DRIVE WHEEL SYSTE - STEERING ASSY Wsh, Flt SAE 1/ Wsh, Flt SAE 5/ Scr, Soc Set Loc 3/8-16 x Wsh, Flt SAE 3/ Scr, Soc Set Loc 5/16-18 x Scr, Hex 1/4-20 x Nut, Hex Nyl Loc-Thin 1/ Nut, Hex Nyl Loc-Thin 1/ Scr, Hex Hd Loc 1/4-20 x.38 (before serial number ) Scr, Hex Hd Loc 1/4-20 x.50 (after serial number ) Nut, Hex Jam SS 1/ Scr, Hex Thd To Hd x 25mm Key, Wdf.75 x Ring, Ret Ext Type E 0.31 Dia Washer Flt.88 x 2.25 x Nut, Hex Nyl Loc Scr, Hex SS x 25mm Scr, Pan Phil Thd Form 1/4-20 x Bearing, Flange Spring, Extension Shroud, Lower Column Shroud, Upper Column Bushing.32 x.50 x Collar, Shaft Shaft, Lower Steering Chain, Roller Bearing, Flange.625 x.500 x Column, Upper Ratchet, Steering Column Lower Column Weldment Steering Pawl Weldment Rod Shaft, Upper Steering Knob Universal Joint Sprocket Steering Wheel Cup Cap Wheel Adapter Plug, Cap
12 10 ELECTRICAL SYSTE SEE 45" & 48" DISK SCRUB ASSEBLIES AND ALL CYLINDRICAL SCRUB ASSEBLIES (K3) SEE 45" & 48" DISK SCRUB ASSEBLIES(K4)(K4)(K4) SEE SIDEBROO SYSTE SEE DISK SCRUB SYSTE SEE SWEEP SYSTE (F3)
13 ELECTRICAL SYSTE Wsh, Flt SAE 1/ Scr, Flt Phil X Scr, Hex Thd Form 1/4-20 X Fuse Block Fuse, 250 Amp (F4) Disconnect, Battery (#29-38) Electrical Component Assembly (#9-28) Used on machines built before SN Electrical Component Assembly (#9-28) Used on machines built after SN Horn 36v (H4) Stud, 1/ Electrical ount Scr, Pan Phil 1/4-20 X Scr, Pan Phil Thd Form 8-32 X Scr, Hex Thd Form 1/4-20 X Scr, Pan Phil Thd Form X Controller, 36vdc (A1) TSBUS Circuit Breaker, 3.0 Amp (Control / F1) Circuit Breaker, 15 Amp (Auxiliary / F2) ain PCB Box Assembly (A2) Used on machines built before SN ain PCB Box Assembly (A2) Used on machines built after SN Contactor, 36vdc 200A (ain / K7) TSBUS ount, Electrical ount, Electrical Panel ount, Electrical Edge Trim, Contactor, 36vdc 200A (Right Brush / K2) TSBUS Contactor, 36vdc 200A (Vacuum / K1) TSBUS Contactor, 36vdc 200A (Auxiliary / K5) TSBUS Connector Assy Wsh, Flt SAE 1/ Scr, Pan Phil 1/4-20 X Nut, Hex Nyl Loc-Thin 1/ Scr, Pan Phil 1/4-20 X Wsh, Flt.266 X.906 X Spacer, Phenolic Spacer, Phenolic Bar, Disconnect Connector Assy * Cable, Battery * Harness-ain * Ferrite Bead (Found on ain harness) * Ferrite Bead (Found on ain Harness) * Harness, Traction otor * Cable Asm, Blk 4-1 * Cable Asm, Red 1-3 * Cable Asm, Red 6-1 * Cable Asm, Red 4-1 * Tie, Cable * Tie, Cable * Conduit * = Not Shown
14 12 REAR WHEEL SYSTE
15 REAR WHEEL SYSTE Kit Bushing.26 x.37 x Wsh, Flt SAE 3/ Wsh, Flt SAE 1/ Pin, Cotter 1/16 x 3/ Nut, Hex 6-1 TSBUS / NOTE Nut, Hex Nyl Loc 6-1 TSBUS / NOTE Nut, Hex Nyl Loc Scr, Hex SS x 30mm Scr, Hex Loc 6-1 x 16mm Scr, Hex Loc x 20mm Scr, Hex x 40mm Scr, Hex 6-1 x 45mm TSBUS / NOTE Wsh, Flt.392 x 1.00 x Wsh, Flt.406 x 1.5 x Wheel, Rear NOTE 2 * Ball Bearing for (3 per wheel) TSBUS Rotor Spacer-Bushing.410 x.500 x Equalizer Yoke Brake Pedal Assy (#26-48) Linkage, Brake Brake-CW TSBUS / TSBUS Brake-CCW TSBUS / TSBUS Spring, Extension TSBUS Bushing Bushing Yoke, Clevis Wsh, Flt SAE 5/ Wsh, Flt SAE 1/ Scr, Hex Hd Loc 5/16-18 x Nut, Hex Nut, Hex Nyl Loc Scr, Hex x 60mm Nut, Hex Nyl Loc Scr, Hex 6-1 x 35mm Scr, Hex SS 6-1 x 25mm Nut, Push Cap 3/ Nut, Hex achine 1/ Spring, Extension Cable Assy Bearing, Flange.625 x.500 x Pulley Pawl Brake Pedal Weldt Bracket-Brake Pedal Spacer NOTE 1: achines built after serial number have a modified chassis which eliminates the need for these hardware items. NOTE 2: Rear wheel (uses three bearings per wheel) replaced Rear Wheel which used two bearings per wheel.
16 RECOVERY SYSTE
17 13-8 RECOVERY SYSTE Foam, Acoustical Wsh, Flt SAE 5/ Scr, Pan Phil 1/4-20 x Scr, Pan Phil 1/4-20 x Wsh, Flt SAE 1/ Scr, Soc Shd.38 x 1.25 x 5/ Nut, Hex Nyl Loc 1/ Scr, Pan Phil 1/4-20 x Scr, Pan Phil 1/4-20 x Wsh, Flt SAE SS 1/ Scr, Pan Phil SS x Wsh, Flt SAE SS 5/ Scr, Pan Phil SS 1/4-20 x Scr, Pan Phil 5/16-18 X Scr, Hex SS 5/16-18 X Scr, Pan Phil Ss 5/16-18 X Wsh, Flt SS.33 X 1.00 X Wsh, Fender.281x1.50x Clamp, Plastic uffler, Vac Gasket, Vacuum Duct ount, Vibration Bushing 24# Vac otor Assy (5) / TSB-FC Lid, Recovery Tank Tank, Recovery Drain Hose Ribbed * Drain Hose Cap Kit ount, Recovery Tank Hose, Vac 2.00 X X Seal Assembly Vac Fan Top Cover Assy (50-61) Harness-Recovery Tank Hose, Squeegee Vac Arm, Lid Hinge Hinge Plate, Right Panel, Exhaust Prop Bumper-Right Rear Bumper-Left Rear Gasket, Recovery Lid Plate, Cable ount Cable Assembly Bushing.32x.50x Bushing.32x.50x Clamp, Hose SAE # Clamp, Hose SAE # Tie, Cable Tie, Cable Cage, Float Ball, Float Scr, Pan Phil Plastite X Scr, Pan Phil Type B 1/4-14 X Wire Rope, 9 Inch Vac Filter Lid NOTE Top, Recovery Tank Screen, Filter Filter Plate, Vac Cover Gasket, Vac Fan Top Gasket, RS Strip Wsh, Flt.266 x.906 x.060 # = Revised or new since last update NOTE 1: and are no longer used in production. If you need to replace either of these items please order
18 16 SCRUB SYSTE-CYLINDRICAL 10-7
19 SCRUB SYSTE-CYLINDRICAL Pin, Cotter Hair Housing, Spring Scr, Hex Type 1 3/8-16 X Pin, Cotter Hair.0915 X Pin, Clevis.375 X Pin, Clevis.38 X Scr, Hex Thd Form 1/4-20 X Scr, Pan Phil Thd Form 1/4-20 X ount Weldment Actuator (2) Cyl Scrub Assembly Cyl Scrub Assembly Cyl Scrub Assembly Spring, Upper Housing Spring, Lower Housing Nut Retainer Nut Retainer
20 18 SCRUB SYSTE-CYLINDRICAL-SCRUB ASSY BEFORE SN Brush Rotation Direction
21 13-1 SCRUB SYSTE-CYLINDRICAL-SCRUB ASSY BEFORE SN Cyl Scrub Assembly Cyl Scrub Assembly Cyl Scrub Assembly Decal, No Step Bushing Wheel, Roller Knob TSBUS Knob Scr, Soc Set Loc 1/4-20 X Wsh, Flt SAE 1/ Wsh, Flt SAE 3/ Nut, Hex Nyl Loc 3/ Scr-Hex Thd to Hd x 20mm Scr, Hex X 16mm Scr, Hex Thd To Hd X 20mm Ring, Ret Ext Type E Reinf Dia Nut, Hex Nyl Loc Nut, Hex Nyl Loc Nut, Hex Nyl Loc SS Scr, Hex X 30mm Scr, Pan Phil 6-1 X 16mm Scr, Hex X 40mm Scr, Hex Thd To Hd X 110mm Wsh, Flt Harden.516x.938 X Scr, Hex Thd Form 1/4-20 X Wsh, Flt.754 X X Scr, Pan Phil Thd Form 1/4-20 X Scr, Pan Phil Loc 1/4-20 X Nut, Push Cap 1/ Nut, Hex Jam Clamp, Hose SAE # Hose, Spiral.75 x Bearing.750 X.625 X Tee, Barb 3/4 X 1/2 X 1/ Broom Idler Assy (58-63, 83) Broom Drive Lug Assy (64-72, 82) Sheave, Poly V Arm Parallel 6 In Arm, Adjustable Assy Idler Tensioner Weld t Resistor Assy, 10k Ohm (40 / R2) Resistor Assy, 40k Ohm (45 & 48 / R2) Guard, Belt Kit 36VDC 1.5HP otor (9 / 10) NOTE 2, TSBUS * Kit Brush Amer otor (for ) * Brush & Spring Kit (for obsolete motor ) Belt, 260j Cyl Scrub Deck Weldt-40 (40 ) Cyl Scrub Deck Weld t-45 (45 ) Cyl Scrub Deck Weld t-48 (48 ) Hopper Assembly-40 (40 ) (73-79) Hopper Assembly-45 (73-79) Hopper Assembly-48 (48 ) (73-79) Contactor, 36vdc 200A (K3) TSBUS Left Skirt Assembly (40 ) Left Skirt Assembly (45 & 48 ) Right Guard Assy Left Guard Assy (45 & 48 ) Pin Right Skirt Assembly Hose,.75 Clear PVC Roller, Rear Pin Barb, 3/4 90 Deg. Elbow Nut, Thumb Wsh, Flt Brass.266 x x Scr, Pan Phil Loc 1/4-20 X Bearing- Ball NOTE Broom Hanger Idler, Brush NOTE 1 (TSBUS ) Scr, Hex 6-1 X 12mm Key, Sq.19 X Wsh, Flt SS.260 X X Scr, Soc Set Loc 1/4-20 X Bearing, Ball Broom Hanger Sheave, Poly V Shaft, Broom Drive Lug Drive Lug Nut, Hex Nyl Loc-Thin Ss 1/ Scr, Pan Phil SS X Scr, Pan Phil SS 1/4-20 X Wsh, Flt SS.260 X X Hopper, 40 In. (40 ) Hopper, 45 In. (45 ) Hopper, 48 In. (48 ) Screen, Hopper-40 In. (40 ) Screen, Hopper-45 In. (45 ) Screen, Hopper-48 In. (48 ) Threshold, Hopper-40 In. (40 ) Threshold, Hopper-45 In. (45 ) Threshold, Hopper-48 In. (48 ) Roll Bar Weldt (40 ) Scr, Hex x 35mm (40 ) Spacer Ring, Retainer NOTE Clamp, Hose SAE # Insulator, Terminal Insulator, Terminal * = Not Shown NOTE 1: If you need to replace these items before SN please order Broom Idler Kit NOTE 2: Brush motor is no longer used in production and replaced by The Water Shields & used on are also obsolete. To replace brush motor , order otor Kit
22 20 SCRUB SYSTE-CYLINDRICAL-SCRUB ASSY AFTER SN Brush Rotation Direction
23 13-8 SCRUB SYSTE-CYLINDRICAL-SCRUB ASSY AFTER SN Cyl Scrub Assembly Cyl Scrub Assembly Cyl Scrub Assembly Decal, No Step Bushing Cam Wheel, Roller Knob TSBUS Knob Scr, Soc Set Loc 1/4-20 X Wsh-Flt SAE SS 1/ Wsh-Flt SAE SS 5/ Nut-Hex Nyl Loc SS 3/ Scr-Hex SS x 20mm Scr-Hex SS X 16mm Scr-Flt Soc SS 5/16-18 x Ring, Ret Ext Type E Reinf Dia Nut-Hex Nyl Loc SS Nut-Hex Nyl Loc SS Nut-Hex Nyl Loc SS 5/ Scr-Hex SS X 30mm Scr-Pan Phil SS 6-1 X Bushing, 1/2-20 x 3/4 Od Scr-Hex FT SS X 110mm Scr-Hex SS 1/2-20 x Scr, Hex Thd Form 1/4-20 X Wsh, Flt.754 X X Scr, Pan Phil Thd Form 1/4-20 X Scr-Pan Phil Loc SS 1/4-20 X Nut, Push Cap 1/ Nut-Hex Jam SS Clamp, Hose SAE # Hose, Spiral.75 x Nut-Hex Jam SS 5/ Tee, Barb 3/4 X 1/2 X 1/ Broom Idler Assy (58-63, 83) Broom Drive Lug Assy (64-72, 82) Sheave, Poly V TSBUS Arm Parallel 6 In TSBUS Bumper, Rubber Idler Tensioner Weld t Resistor Assy, 10k Ohm (40 / R2) Resistor Assy, 40k Ohm (45 & 48 / R2) Guard, Belt Kit 36VDC 1.5HP otor (9 / 10) NOTE 2, NOTE 3 * Kit Brush Amer otor (for ) * Brush & Spring Kit (for obsolete motor ) Belt, 260j Cyl Scrub Deck Weldt-40 (40 ) Cyl Scrub Deck Weld t-45 (45 ) Cyl Scrub Deck Weld t-48 (48 ) Hopper Assembly-40 (40 ) (73-79) Hopper Assembly-45 (73-79) Hopper Assembly-48 (48 ) (73-79) Contactor, 36vdc 200A (K3) TSBUS Left Skirt Assembly (40 ) Left Skirt Assembly (45 & 48 ) Right Guard Assy Left Guard Assy (45 & 48 ) Pin Right Skirt Assembly Hose,.75 Clear PVC Roller, Rear Pin Barb, 3/4 90 Deg. Elbow Nut, Thumb Wsh, Flt Brass.266 x x Scr, Pan Phil Loc 1/4-20 X Bearing- Ball NOTE Broom Hanger Idler, Brush NOTE 1 (TSBUS ) Scr, Hex 6-1 X 12mm Key, Sq.19 X Wsh, Flt SS.260 X X Scr, Soc Set Loc 1/4-20 X Bearing, Ball Broom Hanger Sheave, Poly V TSBUS Shaft, Broom Drive Lug Drive Lug TSBUS Nut, Hex Nyl Loc-Thin Ss 1/ Scr, Pan Phil SS X Scr, Pan Phil SS 1/4-20 X Wsh, Flt SS.260 X X Hopper, 40 In. (40 ) Hopper, 45 In. (45 ) Hopper, 48 In. (48 ) Screen, Hopper-40 In. (40 ) Screen, Hopper-45 In. (45 ) Screen, Hopper-48 In. (48 ) Threshold, Hopper-40 In. (40 ) Threshold, Hopper-45 In. (45 ) Threshold, Hopper-48 In. (48 ) Roll Bar Weldt (40 ) Scr-Hex SS X 35mm (40 ) Spacer Ring, Retainer NOTE Clamp, Hose SAE # Insulator, Terminal Insulator, Terminal 87# Bearing IGUS * = Not Shown # = Revised or new since last update NOTE 1: If you need to replace these items before SN please order Broom Idler Kit NOTE 2: Brush motor is no longer used in production and replaced by The Water Shields & used on are also obsolete. To replace brush motor , order otor Kit NOTE 3: TSBUS
24 22 SCRUB SYSTE-CYLINDRICAL - SKIRT & BUPER ASSY
25 13-1 SCRUB SYSTE-CYLINDRICAL - SKIRT & BUPER ASSY Left Skirt Assembly (#7-11 / 40 ) Left Skirt Assembly (#7-11 / 45 & 48 ) Right Guard Assy (#1, 2, 4, 5, 6) Left Guard Assy (#1-4 / 45 & 48 ) Right Skirt Assembly (#9-13) Wheel, Roller Nut, Push cap 1/ Left Guard Weldt Pin Grip Surface Right Guard Weld t Strap, Skirt-LT Left Bracket Weldt-40 (40 ) Left Bracket Weldt (45 & 48 ) Skirt, Linatex ** Skirt, Gum Rubber ** Skirt, Polyurethane Thumb Nut Skirt Retainer Assy Right Bracket Weldt Strap, Skirt-RT ** = Optional, Not Included
26 24 SCRUB SYSTE-DISK
27 08-5 SCRUB SYSTE-DISK Plug, Cap Housing, Spring Scr, Hex Type 1 3/8-16 X Pin, Cotter Hair Pin, Clevis.375 X Pin, Clevis.38 X Scr, Hex Thd Form 1/4-20 X Scr, Pan Phil Thd Form 1/4-20 X ount Weldment Actuator (2) Disk Scrub Assembly Disk Scrub Assembly Disk Scrub Assembly Spring, Upper Housing Spring, Lower Housing Nut Retainer Nut Retainer
28 26 SCRUB SYSTE-DISK-40 INCH SCRUB ASSY ROTATION ROTATION
29 13-1 SCRUB SYSTE-DISK-40 INCH SCRUB ASSY Disk Scrub Assembly Hose Plate, Stop Spring Retainer Bushing Brush Drive Disc Knob TSBUS Knob Insulator, Terminal Bushing Wsh, Flt Sae Ss 5/ Rivet, Nylon Tree Push-In (.25) Nut Hx Nyl Loc SS Scr, Hex SS 3/8-16 X Scr, Hex Loc Ss 5/16-18 X Nut, Hex Nyl Loc Ss Scr-Hex SS X 30mm Scr, Hex Loc Ss 8-1 X 25mm Scr-Hex SS X 40mm Scr, Hex Ss X 30mm Nut, Hex Jam Ss Scr, Hex Thd To Hd Ss X 70mm Wsh, Flt Harden.516x.938 X Scr, Hex Thd Form 1/4-20 X Wsh, Flt.754 X X Scr, Hex Thd Form 1/4-20 X Scr, Pan Phil Thd Form X Wsh, Flt Harden.344x1.000x.120/ Wsh, Flt.193 X.875 X Clamp, Hose Sae # Bearing.750 X.625 X Brush Holder Hub, Drive Spacer Barb, Coupler 1/2 X 3/ Clamp, P Arm Parallel 6 In Arm, Adjustable Asm Blade, Front Blade, Rear Weldment-40 Disk Gearbox Assembly, 20» (9) * Bearing B.E. (for ) * Bearing F.E. (for ) * Brush Board Assy (for ) * Brush Assy Kit (for ) * Brush Spring Set (for ) * Gearbox (for ) Resistor Assy, 1k Ohm (R2) anifold, Solution Right Guard Assy (#52-56) Right Skirt Assembly Left Skirt Assembly Clamp,P Hose, PVC Clear In Insulator, Terminal Brush Prolene Barb, 3/4 90 Deg. Elbow Wheel, Roller Nut, Push Cap 1/ Pin Grip Surface Right Guard Weldt Roll Bar Weldt Scr Hex SS X 35 * = Not Shown
30 28 SCRUB SYSTE-DISK-45 & 48 INCH SCRUB ASSY K3 K ROTATION ROTATION ROTATION
31 13-1 SCRUB SYSTE-DISK-45 & 48 INCH SCRUB ASSY Hose Plate, Stop Spring Retainer Bushing Brush Drive Disc Knob TSBUS Knob Insulator, Terminal Hose, PVC Clear In Bushing Wsh, Flt SAE SS 5/ Rivet, Nylon Tree Push-In (.25) Nut Hx Nyl Loc SS Scr, Hex SS 3/8-16 X Scr, Hex Loc SS 5/16-18 X Nut, Hex Nyl Loc SS Scr-Hex SS X Scr, Hex Loc SS 8-1 X 25mm Scr-Hex SS X Scr, Hex SS X 30mm Nut, Hex Jam SS Scr, Hex Thd To Hd SS X 70mm Wsh, Flt Harden.516x.938 X Scr, Hex Thd Form 1/4-20 X Wsh, Flt.754 X X Scr, Hex Thd Form 1/4-20 X Scr, Pan Phil Thd Form X Wsh, Flt Harden.344x1.000x.120/ Scr, Pan Phil Thd Form 1/4-20 X Wsh, Flt.193 X.875 X Clamp, Hose SAE # Hose PVC Clear In Gearmotor (9, 10, 11) * Carbon Brush Assy (for ) * Brush Spring (for ) Bearing.750 X.625 X Brush Holder Hub, Drive Spacer Barb, Coupler 1/2 X 3/ Clamp, P Arm Parallel 6 In Arm, Adjustable Assy Right Skirt Assembly Blade Front Blade, Rear Left Skirt Assembly Resistor Assy, 20k Ohm (R2) Weldment-45 Disk Deck Weldment-48 Disk Deck anifold, Solution Contactor, 36vdc 200A (K3, K4) TSBUS Right Guard Assy (#56-60) Left Guard Assy (#56-58 & 61) Clamp,P Insulator, Terminal Brush, Prolene 16 (45 ) Brush Prolene 17 (48 ) Barb, 3/4 90 Deg. Elbow Wheel, Roller (qty per assy) Nut, Push Cap 1/2 (qty per assy) Pin (qty per assy) Grip Surface Right Guard Weldt Left Guard Weldt * = Not Shown
32 30 SCRUB SYSTE-DISK - SKIRT ASSY Scrub Assy / 48 Scrub Assy / 48 Scrub Assy 40 Scrub Assy
33 13-1 SCRUB SYSTE-DISK - SKIRT ASSY Right Skirt Assembly (40 ) Left Skirt Assembly (40 ) Right Skirt Assembly (45 & 48 ) Left Skirt Assembly (45 & 48 ) Decal, No Step (qty per skirt assy) Nut, Hex Nyl loc SS (qty per skirt assy) Scr, Hex Thd to Hd SS x 20mm (qty per skirt assy) Skirt Weldt-Left 40D (40 ) Kit, Linatex 40 Disk Blade NOTE 1 ** Kit, Gum Rubber 40 Disk Blade NOTE 1 ** Kit, Polyurethane 40 Disk Blade NOTE Thumb Nut (40 / qty per skirt assy) Thumb Nut (45 & 48 / qty per skirt assy) Strap-Left 40D (40 ) Strap (qty per skirt assy) Skirt Retainer Assy (40 / qty per skirt assy) Skirt Retainer Assy (45 & 48 / qty per skirt assy) Kit, Linatex (45 & 48 ) Disk Blade NOTE 1 ** Kit, Gum Rubber (45 & 48 ) Disk Blade NOTE 1 ** Kit, Polyurethane (45 & 48 ) Disk Blade NOTE Skirt Weldt-Left 45D-48D (45 & 48 ) Strap-Left 45D-48D (45 & 48 ) Skirt Weldt-Right Disk (40, 45 & 48 ) Strap-Right 40D-45D-48D (40, 45 & 48 ) ** = Optional, Not Included NOTE 1: All scrub deck blade kits include enough blades to replace all blades on both skirt assemblies.
34 32 SOLUTION SYSTE
35 13-1 SOLUTION SYSTE Cap, Pipe Ght Nylon Washer, Rubber Filter Barb Wsh, Flt SAE # Scr, Pan Phil X Scr, Hex 5/16-18 X Scr, Pan Phil 1/4-20 X Nut, Hex Nyl Loc-Thin 5/ Scr, Pan Phil SS 1/4-20 X Scr, Pan Phil 5/16-18 X Scr, Hex Thd Form 1/4-20 X Wsh, Flt Harden.344x1.000x.120/ Wsh, Flt.354 X X Scr, Truss Phil-Blk 10-24x Clamp, Hose SAE #10 (qty of 4 on AXP & EcoFlex models) Hose,.75 X (qty of 1 on EcoFlex models) Hose.75 X Tank, Solution Bumper-Front Touch Pad Assy (A3) NOTE Touch Pad Assy (A3) NOTE 4 [ ] Panel Assembly (for ) NOTE ount-lid Pedal Assy TSBUS Clip Solenoid Valve Assy Valve, T Shutoff Panel, Elect. Cover Asm Seat ounting Assembly (39-45) NOTE 1 * Scr, Hex Hd loc 1/2-13 x.75 NOTE 2 * Scr, Pan Phil SS 1/4-20 x.50 NOTE 2 * Seat Assy NOTE 1 * Switch, Seat (S2) NOTE 2 * Strap NOTE 2 * Clamp, Hose Support NOTE 2 * Scr, Pan Phil 1/4-20 x.75 NOTE Floor Plate ount Plate, Bumper Switch, Liquid Level (S5) Solution Lid Assembly * Solution Lid Gasket Gasket,.62 X.62 X Clamp, Hose SAE # Clamp, P Barb, Adapter 3/4 X 3/4npt Key Switch (S1) * Key, Replacement Chemical etering Assy NOTE Chemical etering Assy NOTE Seat Scr, Pan Phil Thd Form 1/4-20 x Clamp, Hose Support Strap Switch Slide, Seat Arm Rest Option Wsh, Flt.193 x.875 x.060 * = Not Shown NOTE 1: Starting in August 2007 Seat Assy will no longer be available. If you order part number you will automatically receive Seat Assy Kit When replacing with you will also need to order items (40, 41 & 42) above. achines built after August 2007 will have the new seat assembly as pictured on the left. NOTE 2: These items are replacement parts for machines built prior to August If your seat assembly looks like the one pictured on the left these parts are not used on your machine. NOTE 3: Only used before SN NOTE 4: Only used after SN
36 34 SOLUTION SYSTE - CHEICAL ETERING KIT INSTALL ON SOLUTION FILTER OUTLET INSTALL ON SOLENOID VALVE OUTLET
37 11-2 SOLUTION SYSTE - CHEICAL ETERING KIT Chemical etering Assy NOTE Chemical etering Assy NOTE Scr, Pan Phil 8-32 X Nut, Hex Nyl Loc Clamp, Hose SAE # Clamp, Hose SAE # Elbow Hose, Spiral Hose, Spiral Tee Assembly Pump-Detergent (13 / 16) Chemical Sensor Assy (A4) NOTE Cap, Dry Break, 1/8 Barb, Hose, Chemical Resistant, Barb, Coupler 1/2 X 3/ Hose, Spiral Bottle, Chemical Assy-EDS NOTE Bottle, Chemical Assy-EcoFlex NOTE Plate, ount, Chemical eter Fitting, Y, Barb Hose, Chemical Resistant, Hose, Chemical Resistant, Bracket, Pump ount Pump-Solution Control (12) TSBUS Hose, Spiral Scr, Pan Phil 1/4-20 x Wsh, Flt SAE 1/ Nut, Nyl Loc 1/ Nut, Nyl Loc Wsh, Flt SAE # Scr, Flat Phil x Hose, Spiral.50 * Tie-Cable * = Not Shown NOTE 3: Only used before SN NOTE 4: Only used after SN
38 36 SOLUTION SYSTE - DRIVE PEDAL & ELECT. PANEL ASSY
39 13-1 SOLUTION SYSTE - DRIVE PEDAL & ELECT. PANEL ASSY Pedal Assy (#1-26) TSBUS Panel, Elect. Cover Assy (#27-35) Wsh, Flt Sae 1/ Scr, Pan Phil X Nut, Hex Nyl Loc Ring, Ret Ext Type E Reinf Dia Scr, Hex 6-1 X 25mm Nut, Hex Nyl Loc Scr, Hex 6-1 X 75mm Wsh, Flt.266 X.750 X Scr, Pan Phil Thd Form X Wsh, Flt Ss.260 X X Spring, Torsion 12 NA 1 Bracket, Foot Pedal NOTE 1 13 NA 1 Foot Pedal NOTE at, Pedal Bearing, Flange Spacer, Spring Bushing Bushing, 6 X.375 X Lever, Throttle Link Weldment Housing, Potentiometer Wire Assy Potentiometer, 5k (R1) Bearing, Flange Scr-Hex 1/4-20 x Nut-Hex Nyl Loc 1/ Scr, Pan Phil Plastite 8-16 X Scr, Pan Phil Plastite 8-16 X Cover, Fan Gasket Board Holder Cover-Electrical Fan Assy (14) Gasket, Panel Gasket, Circuit Breaker NOTE 1: If you need to replace either of these items please order Pedal Assembly
40 38 SQUEEGEE SYSTE
41 13-1 SQUEEGEE SYSTE Scr Pan Phil SS 1/4-20 X Nut Hex Nyl Loc SS 1/ Scr, Hex 3/4-16 X 1.25 Grade Nut, Hex Nyl Loc 3/ Pin, Cotter Hair Pin, Clevis.375 X Pin, Clevis.375 X Scr-Soc Shd SS.50X.50X3/ Ball Joint TSBUS Squeegee Assembly F (40 ) Squeegee Assembly G (45 ) Squeegee Assembly H (48 ) Squeegee Arm Assembly Actuator 36v (3) Bearing, Flange.625 X.500 X Squeegee Lift Arm Weldment Spring, Extension Stop Plate, Small (40 ) Stop Plate, Large (40 ) * Stop Plate, edium (45 & 48 ) * = Not Shown 40" F 45" G 48" H
42 40 SQUEEGEE SYSTE - SQUEEGEE AR ASSY
43 13-1 SQUEEGEE SYSTE - SQUEEGEE AR ASSY Squeegee Arm Assembly Pin Wsh-Flt SAE SS 1/ Wsh-Flt SAE SS 5/ Wsh-Flt SAE SS 3/ Nut, Hex Nyl Loc 3/ Nut-Hex Nyl Loc SS Nut, Hex Nyl Loc Ss Scr-Hex SS X 35mm Scr, Hex Thd To Hd SS 5/16-18 X Scr, Hex SS X 60mm Nut, Wing SS 5/ Nut, Hex Jam 1/ Nut, Hex Jam 5/ Scr-Pan Phil Loc SS X Washer, Fibre Bushing Bearing, Sleeve Bracket Caster Wheel Knob, 5/16-18 Nyl Loc Squeegee ount Weldt Bracket Knob Washer, Rubber Squeegee Arm Weldment Pad, Wear, Squeegee Arm
44 42 SQUEEGEE SYSTE - SQUEEGEE ASSY F - 40 INCH Old Style
45 12-1 SQUEEGEE SYSTE - SQUEEGEE ASSY F - 40 INCH Squeegee Assembly F (40 ) Nut, Thumb Nut, Hex Nyl Loc-Thin Ss 5/ Nut, Hex Nyl Loc SS Scr, Pan Phil SS 6-32 X Scr, Hex Thd To Hd Ss 5/16-18 X Nut, Wing SS 1/ Squeegee, Cast F Kit, Linatex Squeegee Blade F NOTE 1 ** Kit, Gum Rubber Squeegee Blade F NOTE 1 ** Kit, Polyurethane Squeegee Blade F NOTE Strap, Front F Strap, Rear F Strap, Rear F Latch Assembly Wheel Bushing Wsh-Flt SAE 5/ Scr-Hex SS x 40mm Bracket NOTE Wheel, Roller NOTE 2 ** = Optional, Not Included NOTE 1: All squeegee blade kits include both front and rear squeegee blades. NOTE 2: Items are no longer used. To replace them order a quantity of 2 each of items 18, 19, 20 & 21.
46 44 SQUEEGEE SYSTE - SQUEEGEE ASSY G - 45 INCH, H - 48 INCH Old Style
47 12-1 SQUEEGEE SYSTE - SQUEEGEE ASSY G - 45 INCH, H - 48 INCH Squeegee Assembly G (45 ) Squeegee Assembly H (48 ) Nut, Thumb Nut, Hex Nyl Loc SS Scr, Pan Phil SS 6-32 X Nut, Wing SS 1/ Kit, Linatex Squeegee Blade G (45 ) NOTE Kit, Linatex Squeegee Blade H (48 ) NOTE 1 ** Kit, Gum Rubber Squeegee Blade G (45 ) NOTE 1 ** Kit, Gum Rubber Squeegee Blade H (48 ) NOTE 1 ** Kit, Polyurethane Squeegee Blade G (45 ) NOTE 1 ** Kit, Polyurethane Squeegee Blade H (48 ) NOTE Strap, Front G (45 ) Strap, Front H (48 ) Strap, Left Rear G (45 ) Strap, Left Rear H (48 ) Strap, Right Rear G (45 ) Strap, Right Rear H (48 ) Squeegee Cast Assy G (45 ) (#16-19) Squeegee Cast Assy H (48 ) (#16-19) Latch Assembly Nut, Hex Nyl Loc-Thin SS 5/ Scr, Hex Thd to Hd SS 5/16-18 x Squeegee, Cast G Top (45 ) Squeegee, Cast H Top (48 ) Squeegee, Cast G Bottom (45 ) Squeegee, Cast H Bottom (48 ) Wheel Bushing Wsh-Flt SAE 5/ Scr-Hex SS x 40mm Bracket NOTE Wheel, Roller NOTE 2 ** = Optional, Not Included NOTE 1: All squeegee blade kits include both front and rear squeegee blades. NOTE 2: Items are no longer used. To replace them order a quantity of 2 each of items 20, 21, 22 & 23.
48 46 SWEEP SYSTE 08-11
49 08-11 SWEEP SYSTE Chain Assembly Scr, Hex 1/4-20 X Scr, Hex 3/8-16 X Scr, Hex 1/4-20 X Wsh, Flt SAE 1/ Wsh, Flt SAE 5/ Scr, Hex 1/2-13 X Scr, Hex 5/16-18 X Scr, Hex 3/8-16 X Scr, Hex 1/2-13 X Nut, Hex Nyl Loc 1/ Nut, Hex Nyl Loc 3/ Nut, Hex Nyl Loc-Thin 5/ Nut, Hex Nyl Loc-Thin 1/ Pin, Cotter Hair Pin, Clevis.375 X Pin, Clevis.375 X Wsh, Flt Harden.516x.938 X Nut, Hex Jam 1/ Wsh, Flt Harden.594x1.375x Wsh, Flt Brass.266x1.250x Bearing, Flange Bearing, Sleeve.625 X.750 X Bracket, Side Broom Lift Pillow Block Bushing.50x.62x Left Side Broom Assembly Right Side Broom Assembly Link Sidebroom Lift Arm Weldment Lift Arm Actuator, otor 36V (4) Clamp, Wide Sidebroom Brkt Weld t, Lt Sidebroom Brkt Weld t, Rt Actuator ount Circuit Breaker, 20 Amp Spring, Die Contactor, 36vdc 200a (K6) TSBUS * = Not Shown NOTE: As of October 2008 machines are no longer being manufactured with the Narrow Sweep system.
50 48 SWEEP SYSTE - SIDE BROO ASSY
51 11-2 SWEEP SYSTE - SIDE BROO ASSY Left Side Broom Assembly Right Side Broom Assembly Scr, Hex 1/4-20 X Scr, Hex 1/2-13 X Nut, Hex Nyl Loc 1/ Nut, Hex Nyl Loc-Thin 1/ Wsh, Flt Harden.516x.938 X Wsh, Flt Harden.594x1.375x Gearmotor Assembly, 36VDC (Left / 7) * Gearmotor Assembly, 36VDC (Right / 8) * 52803A 2 Carbon Brush for / Sidebroom Bracket Weld t, Lt ( ) * Sidebroom Bracket Weld t, Rt ( ) Sidebroom (Standard) ** Sidebroom (Commercial Option) Sidebroom Spring t Weld t, Lt ( ) * Sidebroom Spring t Weld t, Rt ( ) Pin,.31 With Retainer Spring, Die * = Not Shown ** = Optional, Not Included
52 LADDER DIAGRA 10-3 BLK RED RED RED RED RED BLK BLK RED/BLK WHT/YEL BLK4-A2 RED 4-A1 RED GRA/ORN BLK GRN ORN BLK/YEL ORN GRN GRN ORN ORN VIO VIO VIO VIO VIO VIO BLU VIO BLU/RED ORN BLK ORN YEL/BRN BLK/ORN BLK BLK BLU/GRN RED RED RED RED RED WHT/RED BLU/GRN BLU/GRN BLU/YEL GRA/BLK WHT/ORN WHT/RED WHT/RED BLK BLK ORN/BLU BRN BLK ORN/RED ORN/RED VIO/BLK WHT/BLK BRN/RED BLU/BLK BLU/BLK RED/WHT RED/WHT VIO VIO BLU/ORN YEL/GRN TAN/BRN VIO RED GRN/BLU RED VIO BLK ORN/BLU BLK BLK BLK ORN/BLK GRN/WHT RED/BLK WHT/GRN GRA/VIO YEL/GRA BLU/BRN GRN/ORN BLK VIO/YEL BLK GRN/GRA GRA/RED WHT/VIO YEL/BLU BRN/BLK ORN/BRN YEL/BRN YEL/RED YEL/RED BLK/GRA BLK/WHT BLK/WHT GRN/BLU BRN/BLU WHT/BRN GRA ORN/WHT GRA/WHT VIO BRN BLK VIO BLK VIO BLU/WHT BLK BLK ORN/GRA BLU/GRA FAULT FOR. REV. ODE1 OTION A3 SWITCH/DISPLAY PANEL ASSEBLY A2 CONTROL BOARD ASSEBLY A4 CHEICAL SENSING BOARD 1KOHFOR40"DISK 10KOHFOR40"CYL. 20KOHFOR45"&48"DISK 40KOHFOR45"&48"CYL. J4-1 DIRECTION J1:11 J1-12 J1-4 ODE2J2-20 J2-19 J1-3 J1-2 CANL CANH J3:4 J3:3 J1-22 J V B- J3:1 J3:2 J2-6 J2:5 J2-1 J2-9 J2-8 J2-7 J2-17 J2-4 J2-16 J2-12 J1-5 J2-13 J4-2 J2-11 J4-4 J2-2 J2-3 J1-8 J2-21 J1-15 J1-23 J2-22 J1-19 J1-16 J1-17 J2-15 J1-20 J2-18 J1-21 J1-18 J1-7 J1-6 +5V B- J2-23 J2-10 J2-14 J1:10 J1-14 (+ON40"DISK) (-ON40"DISK) J1-1 J1-9 A4NOTUSEDWITHECOFLEX G F1 CIRCUITBREAKER,3AP F1 CIRCUITBREAKER,3AP PUP,ACCESSORY (OPTIONAL) 15 PUP,ACCESSORY (OPTIONAL) - + S5 SWITCH,SOLUTIONEPTY (CLOSESWHENEPTY) S5 SWITCH,SOLUTIONEPTY (CLOSESWHENEPTY) 1 2 K2 CONTACTOR,RIGHTBRUSH K2 CONTACTOR,RIGHTBRUSH 1 2 F3 CIRCUITBREAKER,20A. F3 CIRCUITBREAKER,20A. 1 2 K5 CONTACTOR,AUX. K5 CONTACTOR,AUX. 8 OTOR,SIDEBROO 8 OTOR,SIDEBROO BLK RED 7 OTOR,SIDEBROO 7 OTOR,SIDEBROO BLK RED 1 OTOR,TRACTION 1 OTOR,TRACTION F1 F2 A1 A2 L1 VALVE,SOLENOID L1 VALVE,SOLENOID OTOR,RIGHTBRUSH 9 OTOR,RIGHTBRUSH - + F2 CIRCUITBREAKER,15AP F2 CIRCUITBREAKER,15AP 1 2 K4 CONTACTOR,LEFTBRUSH K4 CONTACTOR,LEFTBRUSH 1 2 S2 SWITCH,SEAT S2 SWITCH,SEAT 2 1 BT1 BATTERY,36Vdc BT1 BATTERY,36Vdc OTOR,VACUU 6 OTOR,VACUU 1 2 K5 CONTACTOR,AUX. K5 CONTACTOR,AUX FAN,COOLING 14 FAN,COOLING - + K7 CONTACTN.O. K7 CONTACTN.O. 1 2 K1 CONTACTOR,VACUU K1 CONTACTOR,VACUU 1 2 K4 CONTACTOR,LEFTBRUSH K4 CONTACTOR,LEFTBRUSH R1 POT.5OH R1 POT.5OH S1 SWITCH,KEY S1 SWITCH,KEY B1 3 K6 CONTACTOR,SIDEBROOS K6 CONTACTOR,SIDEBROOS K3 CONTACTOR,CENTERBRUSH K3 CONTACTOR,CENTERBRUSH 1 2 X6 X K2 CONTACTOR,RIGHTBRUSH K2 CONTACTOR,RIGHTBRUSH 2 BRUSHACTUATOR 2 BRUSHACTUATOR BLK RED 10 OTOR,CENTERBRUSH (LEFTOTORON2OTORDECKS) 10 OTOR,CENTERBRUSH (LEFTOTORON2OTORDECKS) - + H2 LAP,FLASHING (OPTIONAL) H2 LAP,FLASHING (OPTIONAL) PUP,CHEICALETERING (OPTIONAL) 16 PUP,CHEICALETERING (OPTIONAL) OTOR,LEFTBRUSH (ON3OTORDECKS) 11 OTOR,LEFTBRUSH (ON3OTORDECKS) PUP,SOLUTIONCONTROL (OPTIONAL) 12 PUP,SOLUTIONCONTROL (OPTIONAL) - + K3 CONTACTOR,CENTERBRUSH K3 CONTACTOR,CENTERBRUSH K1 CONTACTOR,VACUU K1 CONTACTOR,VACUU K7 COIL,AINCONTACTOR K7 COIL,AINCONTACTOR R2 RESISTOR,SCRUBDECKSENSING R2 RESISTOR,SCRUBDECKSENSING 1 2 A1 SPEEDCONTROLLER A1 SPEEDCONTROLLER S1 S2 B- - B+ K6 CONTACTOR,SIDEBROOS K6 CONTACTOR,SIDEBROOS H4 HORN H4 HORN 1 2 X2 X2 + - S3 SWITCH,BAT.INTERLOCK (FORROLLOUTBATTERY) S3 SWITCH,BAT.INTERLOCK (FORROLLOUTBATTERY) 1 2 D2 ZENERTVS D2 ZENERTVS H3 LAP,HEAD (OPTIONAL) H3 LAP,HEAD (OPTIONAL) 1 2 F4 FUSE,250A. F4 FUSE,250A. 1 2 H1 BACKUPALAR (OPTIONAL) H1 BACKUPALAR (OPTIONAL) SQUEEGEEACTUATOR 3 SQUEEGEEACTUATOR BLK RED X1 X PUP,CHEICALETERING (OPTIONAL) 13 PUP,CHEICALETERING (OPTIONAL) SIDEBROOACTUATOR 4 SIDEBROOACTUATOR BLK RED D1 DIODE D1 DIODE 5 OTOR,VACUU 5 OTOR,VACUU
53 13-8 LADDER DIAGRA 51 A Speed Control A Control Board Assembly NOTE Control Board Assembly NOTE 2 A Switch/Display Panel Assembly NOTE Switch/Display Panel Assembly NOTE 2 A Chemical Sensing Board NOTE 1 BT1 N/A Battery D1 NA 1 Diode D2 NA 1 Diode (part of 15) F Circuit Breaker, 3 Amp (Control Circuit) F Circuit Breaker, 15 Amp (Auxiliary Circuit) F Circuit Breaker, 20 Amp (Side Brooms) F Fuse, 250 Amp H Backup Alarm (optional) H Strobe Light (optional) H Headlight (optional) H Horn K Contactor, Vacuum TSBUS K Contactor, Right Brush (all models) TSBUS K Contactor, Center Brush (45 & 48 disk and all cylindrical) TSBUS K Contactor, Left Brush (45 & 48 disk only) K Contactor, Auxiliary TSBUS K Contactor, Side Brooms TSBUS K Contactor, ain TSBUS L Solenoid Valve otor, Traction * Carbon Brush Set Lift Actuator, Brush Lift Actuator, Squeegee Lift Actuator, Side Broom 5# otor Assy, Vac TSB-FC * Carbon Brush Set 6# otor Assy, Vac (Optional) / TSB-FC * Carbon Brush Set Gearmotor Assy, 36VDC (Left-cylindrical models only) * 52803A 2 Carbon Brush for Gearmotor Assy, 36VDC (Right-cylindrical models only) * 52803A 2 Carbon Brush for Gearbox Assy (40 disk) * Bearing B.E. (for ) * Bearing F.E. (for ) * Brush Board Assy (for ) * Brush Assy Kit (for ) * Brush Spring Set (for ) Gearmotor (45 & 48 disk right motor) * Carbon Brush Assy (for ) * Brush Spring (for ) Kit 36VDC 1.5HP otor (all cylindrical right motor) NOTE 3 * Kit Brush Amer otor (for ) * Brush & Spring Kit (for obsolete motor ) Gearmotor (45 & 48 disk center motor) * Carbon Brush Assy (for ) * Brush Spring (for ) Kit 36VDC 1.5HP otor (all cylindrical left motor) NOTE 3 * Kit Brush Amer otor (for ) * Brush & Spring Kit (for obsolete motor ) Gearmotor (45 & 48 disk left motor) * Carbon Brush Assy (for ) * Brush Spring (for ) Pump-Solution Control (AXP / ECOFLEX) TSBUS Pump-Deteregent (AXP / ECOFLEX) Fan Assy Pump, Accessory (optional) ** Pump Head Assy (for ) ** Check Valve Assy (for ) Pump-Detergent (AXP / ECOFLEX) R Potentiometer, 5K Ohm R Resistor Assy, 1k Ohm (40 disk) Resistor Assy, 10k Ohm (40 cylindrical) Resistor Assy, 20k Ohm (45 & 48 disk) Resistor Assy, 40k Ohm (45 & 48 cylindrical) S Switch, Key * Key, Replacement S Switch, Seat S Switch, Batter Interlock (optional) S Switch, Solution Empty * = Not Shown # = Revised or new since last update NOTE 1: Used on machines built before SN NOTE 2: Used on machines built after SN NOTE 3: Brush motor is no longer used in production and replaced by
Electronic Service Manuals
Electronic Service Manuals This electronic document is provided as a service to our customers. We do not create the contents of the information contained in this document. Should you have detailed questions
More informationBR 1100S SBG SPECIAL PARTS LIST MODEL: /09 revised 2/11 FORM NO
PARTS LIST MODEL: 56380640 5/09 revised 2/11 09-5 TABLE OF CONTENTS 10-7 1 DESCRIPTION PAGE Chassis System... 2-3 Decal System... 4-5 Drive Wheel System... 6-7 Drive Wheel System (steering assembly)...
More informationCondor BR 1100S, 1300S
Condor BR 1100S, 1300S PARTS LIST Advance Models: 56413000(4030D), 56413001(4030C / w/sweep system), 56413891(4030C / w/o sweep system) 56413002(4530D), 56413003(4530C / w/sweep system), 56413892(4530C
More information1/14 revised 12/14 REV B FORM NO Models: (1100D), (1100C) (1300D), (1300C) SC6500 PARTS LIST
/4 revised /4 REV B FORM NO. 5604609 Models: 56440(00D), 564403(00C) 564404(300D), 564405(300C) SC6500 PARTS LIST TABLE OF CONTENTS DESCRIPTION PAGE Chassis System... -3 Decal System... 4-5 Drive Wheel
More informationSC6500 PARTS LIST. 1/14 revised 12/14 FORM NO REV B
SC600 PARTS LIST Models: 64400 (40C), 6440 (40C EcoFlex), 6440 (40D), 64403 (40D EcoFlex), 64404 (4C), 6440 (4C EcoFlex), 64406 (4D), 64407 (4D EcoFlex), 64408 (48C), 64409 (48C EcoFlex), 64400 (48D),
More informationAdhancer BA 855 TRIO EDS
Adhancer BA 855 TRIO EDS PARTS LIST Advance Models: 56316000(W28-C), 56316001(W32-C) Nilfisk Models: 56316014(BA 855 TRIO EDS ) 3/06 revised 4/08 06-3 TABLE OF CONTENTS 1 DESCRIPTION PAGE Chassis System...
More informationAdgressor, Adgressor EcoFlex
, EcoFlex PARTS LIST Standard Models: 56390900(2820D), 56390904(3220D), 56390902(2820C), 56390906(3220C) 56390908(3520D), 56390912(3820D), 56390910(3520C), 56390914(3820C) Obsolete AXP Models: 56390903(2820C-AXP),
More informationAdhancer BR 800S TRIO EDS
Adhancer BR 800S TRIO EDS PARTS LIST Advance Models: 56316025 (R28-C), 56316026 (R32-C) Nilfisk Models: 56316038 (BR 800S TRIO EDS ) 7/06 revised 3/08 08-3 Common Kits **# 56314753 1 Kit, On-Board Charger
More informationAdhancer BR 800S TRIO EDS
Adhancer BR 800S TRIO EDS PARTS LIST Advance Models: 56316025 (R28-C), 56316026 (R32-C) Nilfisk Models: 56316038 (BR 800S TRIO EDS ) 7/06 revised 2/07 SECTION 13.9.1 06-7 TABLE OF CONTENTS Adhancer /
More informationElectronic Service Manuals
Electronic Service Manuals This electronic document is provided as a service to our customers. We do not create the contents of the information contained in this document. Should you have detailed questions
More informationAquaPLUS AquaPLUS AXP
AquaPLUS AquaPLUS AXP Parts List Advance Models: 56317001, 56317002 4/07 revised 8/07 07-4 TABLE OF CONTENTS 1 DESCRIPTION PAGE Chassis System... 2-3 Decal System... 4-5 Recovery System... 6-7 Scrub System-Cylindrical...
More informationAquaRide, AquaRide AXP
PARTS LIST Advance MODELS 56314009, 56316515(AXP ) 2/03 revised 11/08 Kits * 56314753 A/R Kit, On-Board Charger TSBUS2004-872 / TSBUS2008-984 * 56314301 A/R Kit, Seat Armrests * 56314302 A/R Kit, Warning
More informationAdgressor, Adgressor EcoFlex
, EcoFlex PARTS LIST Standard Models: 56390900(2820D), 56390904(3220D), 56390902(2820C), 56390906(3220C) 56390908(3520D), 56390912(3820D), 56390910(3520C), 56390914(3820C) Obsolete AXP Models: 56390903(2820C-AXP),
More informationMODELS: (4800), (4300) (4300 AXP), (4800 AXP)
PARTS LIST Advance MODELS: 56303000 (4800), 56303001 (4300) 56303591 (4300 AXP), 56303592 (4800 AXP) 3/04 revised 3/11 04-3 08-11 TABLE OF CONTENTS DESCRIPTION PAGE Chassis System... 2-3 Chassis System
More informationAdvolution 2710 PARTS LIST MODELS , , /06 revised 5/09 FORM NO
PARTS LIST MODELS 56422000, 56422002, 56422184 3/06 revised 5/09 06-3 09-5 TABLE OF CONTENTS 1 DESCRIPTION PAGE Body System... 2-3 Chassis System... 4-5 Decal System... 6-7 Electrical System... 8-9 Pad
More informationConvertamatic 285LX Hydro-Retriever 285HD Lynx 285
Convertamatic 285LX Hydro-Retriever 285HD Lynx 285 PARTS LIST Advance MODELS 56391007(285LX) 56391008(285HD & Lynx) All models covered in this manual are Obsolete. This parts list is for machines after
More informationConvertamatic 265LX Hydro-Retriever 265HD
Convertamatic 265LX Hydro-Retriever 265HD PARTS LIST Advance MODELS 56393670, 56393675 This parts list is for machines after serial number 1002647 revised 8/00 Form Number 56042286 revised 5/00 FORM NO.
More informationWarrior ST, Warrior AXP
Warrior ST, Warrior AXP PARTS LIST Advance Models: 56315036(28D), 56315037(32D), 56315038(28C) 56315039(32C-C), 56315040, 56307250(X28D-C), 56315041(X32D-C) 56315538(28D-C), 56315539(32D-C), 56315540(28C-C),
More informationAdvolution 2710 UHR
Advolution 2710 UHR 70-1700 PARTS LIST Advance MODELS 56422000, 56422002, 56422184 Nilfisk MODEL 56422001 3/06 revised 8/08 SECTION 5.9.1 06-3 TABLE OF CONTENTS Advolution 2710 / UHR 70-1700 D 5.9.1 1
More informationVacRide 3400, 3400C. PARTS LIST Advance MODELS , /09 revised 8/11 FORM NO
PARTS LIST Advance MODELS 5660000, 5660001 10/09 revised 8/11 09-10 TABLE OF CONTENTS 11-8 1 DESCRIPTION PAGE Chassis... -3 Decal System... -5 Deck System... 6-7 Electrical System... 8-9 Front Wheel Assembly...
More informationRetriever 134B. PARTS LIST Advance MODEL This parts list is for machines after serial number /96 revised 7/02 FORM NO.
PARTS LIST Advance MODEL 56467215 This parts list is for machines after serial number 1118383 3/96 revised 7/02 96-3 TABLE OF CONTENTS 3 DESCRIPTION PAGE Handle Assembly... 4-5 Chassis and Housing... 6-7
More informationWarrior ST, Warrior AXP BA 755, BA 855
Warrior ST, Warrior AXP BA 755, BA 855 PARTS LIST Advance Models: 56315036(28D), 56315037(32D), 56315038(28C) 56315039(32C-C), 56315040, 56307250(X28D-C), 56315041(X32D-C) 56315538(28D-C), 56315539(32D-C),
More informationRetriever 4600 SR 1600
Retriever 600 SR 600 PARTS LIST Advance MODEL 66000 Nilfisk MODEL 6600 / revised 0/0 FORM NUMBER 60 BOOK F SECTION.. - TABLE OF CONTENTS BOOK F Retriever 600 / SR 600 F.. 00- DESCRIPTION PLAN CHASSIS
More informationSCRUBTEC 985. PARTS LIST Model /11 FORM NO
PARTS LIST Model 56381796 2/11 11-2 TABLE OF CONTENTS 1 DESCRIPTION PAGE Chassis System... 2-3 Chassis System (Squeegee Linkage Assy)... 4-5 Decal System... 6-7 Recovery System... 8-9 Scrub System...
More informationES4000. PARTS LIST Advance MODELS , /11 FORM NO
PARTS LIST Advance MODELS 56344200, 56344210 3/11 03-11 TABLE OF CONTENTS 1 DESCRIPTION PAGE Chassis System-1... 2-3 Chassis System-2... 4-5 Decal System... 6-7 Deck System... 8-9 Shoe Linkage Assy...
More informationConvertamatic BA 625, 725, 825
Convertamatic BA 625, 725, 825 Parts List Advance Models: 56315000(24D-C), 56315001(26D), 56315002(28D), 56315003(24C-C), 56315004(28D-C), 56315005(28C-C), 56315006(X24D-C), 56315007(X24C-C), 56315008(26D-C),
More informationHydro-Retriever 2052 CR 1300
Hydro-Retriever 2052 CR 1300 PARTS LIST Advance MODELS 565950(battery) 5659505(battery / Hydro-Max II) Nilfisk MODELS 5659992(battery) 565999(battery / Hydro-Max II) /99 revised 9/05 BOOK E SECTION 9.9.1
More informationAquamatic Selectric PARTS LIST Advance MODEL ( Vac)
Aquamatic Selectric PARTS LIST Advance MODEL 66907 (0-40Vac) This Parts List is for Machines After Serial No. 07797 11/9 revised 10/01 FORM NO. 604 revised /00 FORM NO. 604 TABLE OF CONTENTS DESCRIPTION
More informationClean Track L24 Parts List Model:
Clean Track L24 Parts List Model: 56317170 Form No. 56042598 4/12 TABLE OF CONTENTS DESCRIPTION PAGE Chassis System... 2-3 Decal System... 4-5 Recovery System... 6-7 Scrub System... 8-9 Solution System-Electrical-1...
More informationAdvenger 2800ST, 3400ST
2800ST, 3400ST PARTS LIST Advance MODELS 56601000, 56601001, 56601002, 56601003, 56601004 56601005, 56601006, 56601007, 56601008, 56601009, 56601010, 56601011 56601012, 56601013, 56601019, 56601020 11/08
More informationLARGE AUTOSCRUBBER. Parts List Models: , ,
LARGE AUTOSCRUBBER Parts List Models: 56381796, 56381825, 56381828 Form No. 56042584 2/2011 revised 8/2015 REV C revised 10/2011 PARTS LIST TABLE OF CONTENTS DESCRIPTION PAGE Chassis System... 2-3 Chassis
More informationHydroCat PARTS LIST Advance MODELS (Battery / Obsolete) (Battery Hydro-Max / Obsolete)
HydroCat 5015 PARTS LIST Advance MODELS 56459020(Battery / Obsolete) 56459025(Battery Hydro-Max / Obsolete) This parts list is for machines after serial number 488414 12/91 revised 3/01 Form Number 56042265
More informationCR 1100, CR 1200, CR 1400
CR 1100, CR 1200, CR 1400 PARTS LIST Obsolete Nilfisk MODELS 56304009, 56304010, 56304011, 56304012, 56304013, 56304014, 56304015, 56304016, 56304017 2/09 revised 11/10 Active Nilfisk MODELS 56306059,
More informationSelectScrub 17. PARTS LIST Kent MODEL This parts list is for machines after serial number /99 revised 8/02 FORM NO.
SelectScrub PARTS LIST Kent MODEL 530300 This parts list is for machines after serial number 959 3/99 revised /0 99-3 TABLE OF CONTENTS SelectScrub DESCRIPTION PAGE Chassis System... -3 Handle System...
More informationElectronic Service Manuals
Electronic Service Manuals This electronic document is provided as a service to our customers. We do not create the contents of the information contained in this document. Should you have detailed questions
More informationSC D, 20R Advance
Model: SC1500 20D - Advance SC1500 20R Part List US-English Table of Contents GENERAL VIEW 3 CHASSIS SYSTEM 5 DRIVE WHEEL ASSEMBLY 8 PLATFORM ASSEMBLY 10 CONTROL SYSTEM 12 DECAL SYSTEM 14 ELECTRICAL SYSTEM
More informationCaptor 4300, 4800, 5400
PARTS LIST Obsolete Advance MODELS 56304000, 56304001, 56304002, 56304003, 56304004, 56304005, 56304006, 56304007, 56304008 Advance MODELS 56306050, 56306051, 56306052, 56306053, 56306054 56306055, 56306056,
More informationKlenzor 16 Klenzor 18 MPH
Klenzor 16 Klenzor 18 MPH PARTS LIST Kent MODELS 56265004(16), 56265005(18) Simple. Clean. 12/04 revised 7/09 04-12 07-4 TABLE OF CONTENTS Klenzor 16, 18 MPH 1 DESCRIPTION PAGE Base System... 2-3 Brush
More informationAdvenger 2800ST, 3400ST
Advenger 800ST, 300ST PARTS LIST ACTIVE MODELS: 5660000(805D), 5660003(800D ST), 566000(300D ST) 5660005(X805D), 5660006(X305D), 5660007(X805C) 56600(X805D-C), 56600(X305D-C), 566003(X805C-C) 566089(X805R-C),
More informationRetriever /99 revised 9/05 Form Number
PARTS LIST Advance MODELS 5648000 (propane before SN 4505), 564800 (gas before SN 45899) 564800 (dual fuel before SN 4505) All models covered in this manual are OBSOLETE. 4/99 revised 9/05 Form Number
More informationRetriever 5100G/P/D. 2/96 revised 10/02 Form Number
Retriever 00G/P/D PARTS LIST Advance MODELS, 0, This parts list is for gas/propane machines after serial number 00 and diesel machines after serial number All models covered in this manual are OBSOLETE
More informationFor cleaning machines, parts & supplies click/visit This parts list is for machines after seiral number
PARTS LIST Advance MODELS 56264058, 56264001, 56264059, 56264060, 56264061, 56264062 This parts list is for machines after seiral number 1006184 5/94 revised 3/04 94-5 TABLE OF CONTENTS 1 DESCRIPTION
More informationRetriever 6250 SR 1800H
Retriever 6250 SR 1800H PARTS LIST Advance MODELS 56419500(LPG), 56419501(Gasoline/Petrol), 56419422(Diesel) Nilfisk MODELS 56419502(LPG), 56419503(Gasoline/Petrol), 56418007(Diesel) This manual covers
More informationHydro-Retriever 2052 CR 1300
Hydro-Retriever 2052 CR 1300 PARTS LIST Advance MODEL 56460240 (LPG) Nilfisk MODEL 56460280 (LPG) This manual covers GM powered 2004 certified models only. 9/04 revised 4/09 SECTION 1.3.1 04-9 TABLE OF
More informationSC6000 Parts List. 2/2016 revised 10/2018 REV F Form no Models: (SC C) (SC D) (SC D)
SC6000 Parts List /06 revised 0/08 REV F Form no. 5604639 Models: 566000 (SC6000 36C) 56600 (SC6000 40D) 56600 (SC6000 34D) PARTS LIST GENERAL VIEW 6 9 4 5 0 3 3 8 7 ii SC6000-5604639 /06 GENERAL VIEW
More informationElectronic Service Manuals
Electronic Service Manuals This electronic document is provided as a service to our customers. We do not create the contents of the information contained in this document. Should you have detailed questions
More informationClean Track S16, L18. Parts List Models: (S16), (L18) Form No /11
Clean Track S6, L8 Parts List Models: 56382723 (S6), 56382724 (L8) Form No. 56042595 / TABLE OF CONTENTS DESCRIPTION PAGE Base System... 2-3 Brush System... 4-5 Decal System... 6-7 Handle System 6...
More informationEX40 16ST, EX40 18LX. Parts List Models: (EX40 16ST), (EX40 18LX) Form No /2015 revised 1/2018 REV F
EX40 16ST, EX40 18LX Parts List Models: 56265504 (EX40 16ST), 56265505 (EX40 18LX) Form No. 56042643 7/2015 revised 1/2018 REV F revised 6/2017 PARTS LIST TABLE OF CONTENTS DESCRIPTION PAGE Base System...
More informationRIDER AUTOSCRUBBER. Parts List Models: (28D), (34D OBC), (34D) (28B), (28B OBC), (28D OBC)
RIDER AUTOSCRUBBER Parts List Models: 564000 (8D), 56400 (34D OBC), 56400 (34D) 564003 (8B), 564009 (8B OBC), 56400 (8D OBC) Form No. 5604589 6/0 revised /07 REV I PARTS LIST 5/04 GENERAL VIEW 4 5 3 7
More informationAquaClean 16ST, 16XP, 18FLX, 18ST
AquaClean 16ST, 16XP, 18FLX, 18ST PARTS LIST Active Models: 5665003(16ST), 5665000(16XP), 5665001(18FLX) Obsolete Model: 5665008(18ST) 11/04 revised 1/14 FORM NO. 560445 REV B 11/008 PARTS LIST TABLE
More informationAquaClean 16ST, 16XP, 18FLX, 18ST
AquaClean 16ST, 16XP, 18FLX, 18ST PARTS LIST MODELS: 56265003(16ST), 56265000(16XP), 56265001(18FLX), 56265008(18ST) 11/04 revised 8/11 04-11 08-11 TABLE OF CONTENTS AquaClean 1 DESCRIPTION PAGE Base
More informationCondor XL. 3/09 revised 11/12 FORM NO
PARTS LIST Active Models: 56110000(LPG/48 ), 56110001(Petrol/48 ), 56110002(Diesel/48 ), 56110003(LPG/60 ), 56110004(Petrol/60 ), 56110005(Diesel/60 ), 56110006(LPG/62 ), 56110007(Petrol/62 ), 56110008(Diesel/62
More informationSC8000 3/13 FORM NO
SC8000 PARTS LIST Models: 56080 (48 LPG), 5608 (48 LPG Ecoflex), 5608 (48 D), 56083 (48 D Ecoflex) 56084 (60 LPG), 56085 (60 LPG Ecoflex), 56086 (60 D), 56087 (60 D Ecoflex) 56088 (6 LPG), 56089 (6 LPG
More informationES300 Parts List. 7/2015 REV A Form no Models: (240V)
ES00 Parts List 7/2015 REV A Form no. 56042642 Models: 5626550 (240V) TABLE OF CONTENTS DESCRIPTION PAGE Base System... 2- Decal System... 4-5 Handle System... 6-7 Recovery System... 8-9 Solution System-1...
More informationRetriever 5100G/P. 11/89 revised 10/02 FORM NO
Retriever 5100G/P PARTS LIST Advance MODELS 56497000, 56497010 This parts list is for machines after serial number 353005 All models covered in this manual are OBSOLETE 11/89 revised 10/02 FORM NO. 56042216
More informationBR 755, BR 855. Model: BR755 BR755C BR855. Part List US-English
Model: BR755 BR755C BR855 Part List US-English Table of Contents Chassis system 3 Control system 6 Decal system 9 Electrical system 11 Recovery system 14 Scrub system-cylindrical 16 Scrub system-cylindrical-skirt
More informationES300 ST, ES300 XP, ES400 XLP Parts List
ES00 ST, ES00 XP, ES00 XLP Parts List 7/05 revised 6/07 REV E Form no. 5606 Model No: 566550 (ES00 ST) 5665500 (ES00 XP) 566550 (ES00 XLP) revised 6/07 TABLE OF CONTENTS DESCRIPTION PAGE Base System...
More informationSC6000. PARTS LIST Models: (SC C) (SC D), (SC D) 2/2016 FORM NO REV A
SC6000 PARTS LIST Models: 566000(SC6000 36C) 56600(SC6000 40D), 56600(SC6000 34D) /06 FORM NO. 5604639 REV A PARTS LIST GENERAL VIEW 6 9 4 5 0 3 3 8 7 ii SC6000-5604639 /06 GENERAL VIEW PARTS LIST Kit
More informationSA40. Parts List Model:
SA40 Parts List Model: 5604487 PARTS LIST GENERAL VIEW 3 4 6 7 5 Item Ref. No. Qty Description Chassis System Control System 3 Electrical System 4 Recovery System Item Ref. No. Qty Description 5 Scrub
More informationGU 700A PARTS LIST. 11/99 revised 8/10 FORM NO MODELS (240V), (240v-60hz) (OBS/240V/Arg.), (OBS/100V)
PARTS LIST MODELS 5633090(240V), 56330049(240v-60hz) 56330940(OBS/240V/Arg.), 5633095(OBS/00V) /99 revised 8/0 99-09-4 TABLE OF CONTENTS DESCRIPTION PAGE Base System... 2-3 Brush Motor Assembly... 4-5
More informationSC1500 PARTS LIST MODELS , /2012 revised 7/2015 FORM NO REV F
SC500 PARTS LIST MODELS 5604000, 560400 /0 revised 7/05 FORM NO. 560459 REV F PARTS LIST revised 6/03 GENERAL VIEW 3 4 7 6 8 5 Item Ref. No. Qty Description Chassis System Control System 3 Electrical System
More informationSA40. Parts List Model: Form No /2016 revised 7/2016 REV B
SA40 Parts List Model: 5604487 Form No. 5604653 /06 revised 7/06 REV B PARTS LIST GENERAL VIEW 3 4 6 7 5 Item Ref. No. Qty Description Chassis System Control System 3 Electrical System 4 Recovery System
More informationRetriever /00 revised 5/06 FORM NO All models covered in this manual are obsolete.
PARTS LIST Advance MODELS 5648000 (propane after SN 4504), 564800 (gas after SN 45898), 564800 (dual fuel after SN 4504), 564800 (diesel) Nilfisk MODELS SR 800 can now be found in PL560444 All models covered
More informationCarpetriever 28 PARTS LIST MODELS (120V), (OBS/100V) 11/1999 revised 2/2016 FORM NO REV C
Carpetriever 28 PARTS LIST MODELS 56330020(120V), 56330925(OBS/100V) 11/1999 revised 2/2016 FORM NO. 56042384 REV C 4/2009 TABLE OF CONTENTS PARTS LIST DESCRIPTION PAGE Base System... 2-3 Brush Motor
More informationSC750, SC800 SC750 ST, SC800 ST
SC750, SC800 SC750 ST, SC800 ST PARTS LIST Advance Models: 56112000(SC750-26D), 56112004(SC750-28D) 56112006(SC750-28C), 56112012(SC750 ST-26D) 56112013(SC750 ST-28C), 56112016(SC800-28D) 56112018(SC800-28C),
More informationPARTS LIST CHAMP 2929
PARTS LIST CHAMP 2929 1 ITEM PART NO. DESCRIPTION QTY. 101 9122343 3/8-16 X 2 HEX HEAD FULL THREADED BOLT 3 102 9122100 3/8 SPLIT LOCK WASHER 3 103 9121400 3/8 I.D. X 7/8 O.D. X.064/.104 THICK WROUGHT
More informationCaptor 4300, 4800, 5400
Captor 4300, 4800, 5400 ACCESSORIES PARTS LIST Obsolete MODELS: 56304000, 56304001, 56304002, 56304003, 56304004, 56304005, 56304006, 56304007, 56304008 Advance MODELS: 56306050, 56306051, 56306052, 56306053,
More informationXtrac PARTS LIST. Euroclean MODEL /05 revised 7/09 FORM NO
Xtrac PARTS LIST Euroclean MODEL 56265301 6/05 revised 7/09 ACCESSORIES AVAILABLE BRUSH 56265340 Brush Assembly 12" ACCESSORY TOOLS 56314402 Wand Assembly w/soft and Hard Floor Tools 56265173 Wand Assembly
More informationRetriever PARTS LIST Advance MODEL 5200G(OBSOLETE)
Retriever PARTS LIST Advance MODEL 5200G(OBSOLETE) 5/85 revised 2/01 FORM NO. 56042131 TABLE OF CONTENTS DESCRIPTION PAGE OUTER BODY...1-2 HYDRAULIC PUMP, ENGINE & FUEL TANK...3-4 HYDRAULIC OIL FILTER,
More informationWhirlamatic UHSB 20 Whirlamatic UHSBD 20
Whirlamatic UHSB 20 Whirlamatic UHSBD 20 PARTS LIST Advance MODELS 56393500 (UHSB 20), 56393930 (UHSB 20) 56393600 (UHSBD 20 / OBSOLETE) 1/91 revised 12/05 91-1 05-3 TABLE OF CONTENTS 1 DESCRIPTION PAGE
More informationSprite Air Scoop 12, 16 Sprite 12, 16
Sprite Air Scoop 2, 6 Sprite 2, 6 PARTS LIST Advance MODELS 5620909, 56209092, 5620907, 56209072, the following MODELS are Obsolete 5620969, 5620970, 5620999, 56209220, 56209225, 5620923, 5620924, 5620944
More informationSC750, SC800 SC750 ST, SC800 ST
SC750, SC800 SC750 ST, SC800 ST PARTS LIST Advance Models: 56112000(SC750-26D), 56112004(SC750-28D) 56112006(SC750-28C), 56112012(SC750 ST-26D) 56112013(SC750 ST-28C), 56112016(SC800-28D) 56112018(SC800-28C),
More informationSC1500. PARTS LIST Advance MODELS , /12 revised 9/13 FORM NO
SC500 PARTS LIST Advance MODELS 5604000, 560400 / revised 9/3 FORM NO. 560459 PARTS LIST revised 6/3 GENERAL VIEW 3 4 7 6 8 5 Item Ref. No. Qty Description Chassis System Control System 3 Electrical System
More informationSelectScrub 27. PARTS LIST Kent MODEL This model is obsolete. 4/99 revised 2/05 FORM NO (083399P-1)
PARTS LIST Kent MODEL 56636998 This model is obsolete. 4/99 revised 2/05 (083399P-1) 22 RECOMMENDED SPARE PARTS 99-4 04-6 Ref. No. Qty Description 56035302 1 Hose, Squeegee Blk 56035129 1 Hose, Tank Blk
More informationBR 755, BR 855. Model: BR755 BR755C BR855. Part List English
Model: BR755 BR755C BR855 Part List English Table of Contents Chassis system 3 Control system 6 Decal system 9 Electrical system 11 Recovery system 14 Scrub system-cylindrical 16 Scrub system-cylindrical-skirt
More informationWhirlamatic VS 20 PARTS LIST Advance MODEL
Whirlamatic VS 20 PARTS LIST Advance MODEL 56393705 10/93 revised 2/03 93-10 TABLE OF CONTENTS 00-9 Whirlamatic VS 20 3 DESCRIPTION PAGE CHASSIS AND SHROUD... 4-5 HANDLE ASSEMBLY... 6-7 PAD DRIVE ASSEMBLY...8-9
More informationPA R O B E Reinigungsmaschinen Hotline: 087-701 Moltkestraße 1 8981 Altenstadt-Illereichen Tel.: 0 8 7 / 7 01 Fax 0 8 7 / 7 0 info@wap-nilfisk-alto-shop.de www.wap-nilfisk-alto-shop.de 018.01.17 TABLE
More informationPARTS LIST CHAMP 3329 RB
PARTS LIST CHAMP 3329 RB 1 ITEM PART NO. DESCRIPTION QTY. 101 9122343 3/8-16 X 2 HEX HEAD FULL THREADED BOLT - PACK OF 1 3 102 9122100 3/8 SPLIT LOCK WASHER - PACK OF 10 3 103 9121400 3/8 I.D. X 7/8 O.D.
More informationHaram Captor CR ENGINE SYSTEMS PARTS LIST Nilfisk MODEL /04 revised 10/06 FORM NO BOOK E SECTION
Haram Captor CR 1400 ENGINE SYSTEMS PARTS LIST Nilfisk MODEL 56307000 8/04 revised 10/06 SECTION 15.9.1 04-8 TABLE OF CONTENTS Haram Captor CR 1400 Engine Systems E 15.9.1 1 DESCRIPTION Page Gasoline
More informationBA 5321/BA 5321 D. Parts list MODELS cod (4) Form Number
/ D Parts list MODELS 56325500-56325501 cod.08812649(4)2002-05 Form Number 56042349 2002/05 TABLE OF CONTENTS PAGE 1 GB Page Seite Page TANK ASSEMBLY 2-3 CHASSIS SYSTEM 4-5 PEDAL, LIFTING 6-7 BRUSH DRIVE
More informationCarpetriever 28 PARTS LIST MODELS (120V), (OBS/100V) 11/99 revised 12/12 FORM NO
PARTS LIST MODELS 56330020(120V), 56330925(OBS/100V) 11/99 revised 12/12 99-11 09-4 TABLE OF CONTENTS 1 DESCRIPTION PAGE Base System... 2-3 Brush Motor Assembly... 4-5 Decal System... 6-7 Handle System-1
More informationXtrac PARTS LIST. Euroclean MODEL /05 revised 2/06 FORM NO
Xtrac PARTS LIST Euroclean MODEL 56265301 6/05 revised 2/06 ACCESSORIES AVAILABLE BRUSH 56265340 Brush Assembly 12 ACCESSORY TOOLS 56314402 Wand Assembly w/soft and Hard Floor Tools 56265173 Wand Assembly
More informationSC900 ST. PARTS LIST Models: (SC900 ST-28D) (SC900 ST-34D), (SC900 ST-32C) 1/2016 FORM NO REV A
SC900 ST PARTS LIST Models: 60(SC900 ST-8D) 60(SC900 ST-D), 60(SC900 ST-C) /06 FORM NO. 606 REV A PARTS LIST GENERAL VIEW 6 9 0 8 7 Kit Item 6 7 8 9 0 ii Ref. No. Qty Description Chassis System Control
More informationSection II. Parts Manual
Section II Parts Manual 56041658 06-2 TABLE OF CONTENTS Clean Track 12 1 DESCRIPTION PAGE Back Panel Assembly... 2-3 Base System... 4-5 Brush System... 6-7 Decal System... 8-9 Handle System... 10-11 Recovery
More informationSC1500 Parts List. 11/2012 revised 4/2018 REV M Form no Models: (SC D) Obsolete Models: (SC D EcoFlex)
SC500 Parts List /0 revised 4/08 REV M Form no. 560459 Models: 560400(SC500-5D) Obsolete Models: 5604003(SC500-5D EcoFlex) PARTS LIST revised 6/03 GENERAL VIEW 3 4 6 7 5 Item Ref. No. Qty Description Chassis
More informationPARTS LIST CHAMP ZS 35
PARTS LIST CHAMP ZS 35 1 BATTERY INSTALLATION INSTRUCTIONS WET STORAGE BATTERY CORROSIVE ACID * CONTAINS ACID, AVOID CONTACT. * ANTIDOTE: * EYES - FLUSH WITH WATER 15 MINUTES. * INTERNAL - DRINK WATER
More informationRetriever 5800G/P/D. revised 2/01 Form Number
Retriever 5800G/P/D PARTS LIST Advance MODELS 56482005, 56482010, 56482015 This parts list is for machines after serial number 221134 All models covered in this manual are OBSOLETE revised 2/01 Form Number
More informationSC1500. PARTS LIST Advance MODELS , /12 revised 6/13 FORM NO
SC500 PARTS LIST Advance MODELS 5604000, 560400 / revised 6/3 FORM NO. 560459 revised 6/3 GENERAL VIEW 3 4 7 6 8 5 Item Ref. No. Qty Description Chassis System Control System 3 Electrical System 4 Recovery
More informationExterra. 12/06 revised 1/09 FORM NO
PARTS LIST Advance Models: 56507000 (3 cyl LPG), 56507001 (3 cyl Petrol) 56507003, 56307252 (4 cyl LPG), 56507004 (4 cyl Petrol), 56507005 (4 cyl Diesel) 56508639 (4 cyl LPG / cab), 56508640 (4 cyl Petrol
More informationAquaClean 12ST PARTS LIST. Advance MODEL /05 revised 8/11 FORM NO
AquaClean 2ST PARTS LIST Advance MODEL 56265300 6/05 revised 8/ OPTIONS & ACCESSORIES AVAILABLE BRUSH 56265340 Brush Assembly 2 ACCESSORY TOOLS 5634402 Wand Assembly w/soft and Hard Floor Tools 5626573
More informationElectronic Service Manuals
Electronic Service Manuals This electronic document is provided as a service to our customers. We do not create the contents of the information contained in this document. Should you have detailed questions
More informationAquaClean 12ST PARTS LIST. Advance MODEL /05 revised 10/13 FORM NO
AquaClean ST PARTS LIST Advance MODEL 566500 6/05 revised 0/ OPTIONS & ACCESSORIES AVAILABLE BRUSH 566540 Brush Assembly ACCESSORY TOOLS 56440 Wand Assembly w/soft and Hard Floor Tools 56657 Wand Assembly
More informationPARTS LIST WRANGLER 2625 DB
PARTS LIST WRANGLER 2625 DB 1 NOTES 2 BRUSH GEAR MOTOR ITEM PART NO. PART DESCRIPTION QTY. 2393501 COMPLETE MOTOR ASSEMBLY 1 101 3391221 NEGATIVE LEAD 1 102 3391201 1/4-20 X 7 3/4THRU BOLT 2 103 10-24
More informationSC750, SC800 SC750 ST, SC800 ST
SC750, SC800 SC750 ST, SC800 ST PARTS LIST Advance Models: 56112000(SC750-26D), 56112004(SC750-28D) 56112006(SC750-28C), 56112012(SC750 ST-26D) 56112013(SC750 ST-28C), 56112016(SC800-28D) 56112018(SC800-28C),
More informationPARTS LIST CHAMP 2929 WITHOUT SIDEKICK CHEMICAL DISPENSOR WITH SIDEKICK CHEMICAL DISPENSOR
PARTS LIST CHAMP 2929 WITHOUT SIDEKICK CHEMICAL DISPENSOR WITH SIDEKICK CHEMICAL DISPENSOR 1 ITEM PART NO. DESCRIPTION QTY. 101 9122343 3/8-16 X 2 HEX HEAD FULL THREADED BOLT - PACK OF 1 3 102 9122100
More informationParts Manual MZ5225 /
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. Parts Manual MZ5225 / 966690502 Please
More informationAdfinity TM 17ST / 20ST Adfinity TM X20R
Adfinity TM 7ST / 0ST Adfinity TM X0R PARTS LIST Advance models: 908 76 00 908 76 00 90879000 (6)0- 007-0 TABLE OF CONTENTS 00-009-06 Adfinity 7ST / 0ST / X0R DESCRIPTION PLAN GENERAL VIEW - 3 SOLUTION
More informationSC1500 Parts List. 11/2012 revised 9/2018 REV M Form no Model No: (X20D) (X20R)
SC500 Parts List /0 revised 9/08 REV M Form no. 560459 Model No: 5604000 (X0D) 560400 (X0R) PARTS LIST revised 6/03 GENERAL VIEW 3 4 7 6 8 5 Item Ref. No. Qty Description Chassis System Control System
More informationMM184 Rev. 12 (9 94)
465 480 490 MM184 Rev. 12 (9 94) This manual is furnished with each new TENNANT Model 465, 480, and 490. It provides necessary operating and preventive maintenance instructions. Read this manual completely
More informationRetriever 360G/P. 5/92 revised 2/01 FORM NUMBER
Retriever 360G/P PARTS LIST Advance MODELS 56468470, 56468480 This parts list is for machines after serial number 505073 All models covered in this manual are OBSOLETE 5/92 revised 2/01 FORM NUMBER 56042267
More information