Retriever 5100G/P/D. 2/96 revised 10/02 Form Number

Transcription

1 Retriever 00G/P/D PARTS LIST Advance MODELS, 0, This parts list is for gas/propane machines after serial number 00 and diesel machines after serial number All models covered in this manual are OBSOLETE / revised 0/0 Form Number 00

2 revised / FORM NO. 00 TABLE OF CONTENTS DESCRIPTION PAGE Housing Assembly... - Gas Engine Assembly (before SN )... - Gas Engine Assembly (after SN )... - L.P. System... - Diesel Engine Assembly (before SN ) Diesel Engine Assembly (after SN )... - Fuel Tank Assemblies... - Accelerator Linkage... - Impeller Assembly... - Brake Pedal Assembly Front Wheel Assembly... - Manual Steering Assembly... - Hydraulic System... - Power Steering System... - Rear Axle Assembly Main Broom Assembly... - Broom Housing and Skirts... - Side Broom Assembly... - Hopper Lift Arms and Cylinders... - Hopper Dust Control Filter and Shaker Motor... - Dump Door Assembly... - Hydraulic Control Valves... - Gas / LP Wiring Diagram... - Diesel Wiring Diagram WHEN ORDERING PARTS * Use the digit numbers from the Part No. columns in this parts list. * Specify the model and serial number of the machine. * Use the space below to record the model and serial number for future reference. ModelSerialNo.

3 FORM NO. 00 revised /

4 revised /0 FORM NO. 00 HOUSING ASSEMBLY 000 Decal, Gas 00 Scr, Hex Hd /-0 x. Cover Panel 000 Nut, Hex Nyl Loc /-0 Duct 0 Safety Pin Grommet 00 Decal, Safety Pin Hood * 00 Decal, RPM * 0" Seal ( cm) * Hinge * Prop Rod * Grommet * Cotter Pin 0 Left Panel 0 Decal, Retriever 00 0 Panel Bracket Door Panel * Leveler * Hinge 0 Decal, Control 0 Decal, Hydraulic System (w/o power steering) 0 Decal, Hydraulic System (w/power steering) 0 Decal, Wiring/Gas/LP 0 Decal, Wiring/Diesel 000 Red and Black Stripe 0 Grey Stripe 0 Radiator Cowl * Radiator Flashing * 0 Panel Retainer 0 Front Grill Panel Cover, Access * 0 Screw Fastener * 0 Washer Retainer * 0 Screw Receptacle Broom Guard 0 Light, Oil 0 Light, Temperature 0 Light, Battery 0 Key Switch, Gas/LP Channel Key Switch, Diesel 0 Decal, Advance 0 0 Decal, Control Panel 0 Decal, Logo Chassis Throttle Control * Throttle Cable Bracket * 0 Spacer 0 Choke Cable Assembly/Gas Seat Deck 00 Scr, Hex Hd /-0 x. 00 Scr, Hex Hd /- x. Seat Bracket, Standard * Seat Bracket, Optional 00 Seat, Standard * Seat, Optional 0 Right Panel Wrench 0 Clip 0 Decal, Lower Panel Latch TSB 0 * 0 Floor Mat * Battery Hold Down Assy ** 0 Overhead Guard Kit ** 0 Vacuum Hose and Wand Kit * = Not Shown ** = Optional Kit

5 FORM NO. 00 revised / Hood Weld't Ford Gas Engine Model No. VSG-I-00-A

6 revised / FORM NO. 00 GAS / LP ENGINE ASSEMBLY (before SN ) Air Inlet Hood Air Filter Cover 0 Gasket Air Filter Tube Air Cleaner Mount Air Cleaner Assembly * Air Filter Service Indicator * 0 Safety Element * 0 Primary Element Clevis (includes pin) Hydro-Back 0 Control Cable 0 Bracket, Hydro-Back Pump, Hydraulic O-Ring Arm Weld t Hydraulic Pump Assembly * Seal Kit for 0 Rear Engine Plates 0 Exhaust Donut gasket 0 Exhaust Pipe 0 Scr, Hex Hd M0 x. Mount Weld t 0 Starter Solenoid 0 Starter Motor 0 Alternator * 0 Alternator Connector Alternator Belt Mount, Rubber Mount Weld t Mount Weld t Fan Shroud Crankshaft Sheave Fan * 0 Spacer, Fan 0 0 Bracket, Throttle Cable Adapter, Oil Drain Hose Clamp Hose, Oil Drain Plug, Oil Drain Cable, Throttle * 000 Nut, Hex Nyl Loc-Thin 0-0 Ball Joint 000 Gasket Plug Governor * 00 Plug (used in governor) 0 Carburetor, Gas Air Intake * Gasket * 0.in Hose, Raw 0 Hose Clamp Hose 000 Scr, Hex /- x.0 Hose * Hose Clamp 000 Gasket Stud Spacer, Carburetor 0 Engine, Gas (w/carb) 00 Engine, Propane (w/o carb) 0 0 Coupler 0 Bell Housing 0 Bolt M0x.0 Bolt 0 Washer Screw * 0 Gasket 000 Scr, Pan Phil /-0 x. 000 Wsh, Flt SAE / 000 Nut, Hex Nyl Loc /-0 00 Scr, Hex Hd /-0 x Scr, Hex Hd /- x. 000 Wsh, Flt SAE / 00 Scr, Hex Hd /- x.0 00 Wsh, Flt SAE / 00 Scr, Hex Hd /- x Scr, Hex Hd /- x.0 00 Scr, Hex Hd /- x Nut, Hex Nyl Loc /- 0 Exhaust Shield 0 Mounting Band * Ignition Module w/harness * Oil Filter * Engine Wiring Harness * Sender, Temperature * Sender, Oil Pressure * 0 Fuel Separator * Fuel Filter (gas only) * Fuel Pump (gas only) * Fuel Pump Gasket (gas only) * Water Pump (w/gasket) * Thermostat * 0 Upper Radiator Hose * 0 Lower Radiator Hose * 0 Radiator * Radiator Cap * Muffler * = Not Shown

7 FORM NO. 00 revised / Hood Weld't

8 revised / FORM NO. 00 GAS / LP ENGINE ASSEMBLY (after SN ) Air Inlet Hood Air Filter Cover 0 Gasket Air Filter Tube Air Cleaner Mount Air Cleaner Assembly * Air Filter Service Indicator * 0 Safety Element * 0 Primary Element Clevis (includes pin) Hydro-Back 0 Control Cable 0 Bracket, Hydro-Back Pump, Hydraulic (manual steering) Pump, Hydraulic (power steering) 00 O-Ring Arm Weld t Hydraulic Pump Assembly 0 Rear Engine Plates 0 Exhaust Donut gasket 0 Exhaust Pipe 0 Scr, Hex Hd M0 x. Mount Weld t 0 Starter Solenoid 0 Starter Motor 0 Alternator * 0 Alternator Connector Alternator Belt Mount, Rubber Mount Weld t Mount Weld t Fan Shroud Crankshaft Sheave Fan * 0 Spacer, Fan 0 0 Bracket, Throttle Cable Adapter, Oil Drain Hose Clamp Hose, Oil Drain Plug, Oil Drain Cable, Throttle * 000 Nut, Hex Nyl Loc-Thin 0-0 Ball Joint 000 Gasket Plug Governor * 00 Plug (used in governor) 0 Carburetor, Gas Air Intake * Gasket * 0.in Hose, Raw 0 Hose Clamp Hose 000 Scr, Hex /- x.0 Hose * Hose Clamp 000 Gasket Stud Spacer, Carburetor 0 Engine, Gas (w/carb) 00 Engine, Propane (w/o carb) 0 0 Coupler 0 Bell Housing 0 Bolt M0x.0 Bolt 0 Washer Screw * 0 Gasket 000 Scr, Pan Phil /-0 x. 000 Wsh, Flt SAE / 000 Nut, Hex Nyl Loc /-0 00 Scr, Hex Hd /-0 x Scr, Hex Hd /- x. 000 Wsh, Flt SAE / 00 Scr, Hex Hd /- x.0 00 Wsh, Flt SAE / 00 Scr, Hex Hd /- x Scr, Hex Hd /- x.0 00 Scr, Hex Hd /- x Nut, Hex Nyl Loc /- 0 Exhaust Shield 0 Mounting Band * Ignition Module w/harness * Oil Filter * Engine Wiring Harness * Sender, Temperature * Sender, Oil Pressure * 0 Fuel Separator * Fuel Filter (gas only) * Fuel Pump (gas only) * Fuel Pump Gasket (gas only) * Water Pump (w/gasket) * Thermostat * 0 Upper Radiator Hose * 0 Lower Radiator Hose * 0 Radiator * Radiator Cap * Muffler * = Not Shown

9 FORM NO. 00 revised / To LP Tank 0 FRONT To Intake Manifold 0 To Water Pump 0 To Engine Block

10 revised / FORM NO. 00 L.P. SYSTEM 0 Elbow 0 Carburetor 0 Push-Lok Hose Regulator 0 Elbow 0 Hose Hose Clamp Barb 000 Elbow 0 Elbow Shut-Off Valve 00 Hose Hose L.P. Filter 00 Fitting Hose Vent Oil Pressure Sender 00 Tee 0 0 Nipple Pressure Switch 0 Bracket 0 Elbow Adapter 0 Adapter Coupler Coupler, Propane Tank

11 FORM NO. 00 revised / Hood Weld't Radiator Cowl 0 Kubota Diesel Engine Model No. D0E-

12 revised / FORM NO. 00 DIESEL ENGINE ASSEMBLY (before SN ) Air Inlet Hood Air Filter Cover Gasket Inlet Tube Air Cleaner Mounting Band Air Cleaner Assembly * Air Filter Service Indicator * 0 Replacement Safety Element * 0 Replacement Primary Element Hydro-Back 0 Control Cable Bracket, Hydro-Back 0 00 Scr, Hex Hd /- x.0 00 Scr, Hex Hd /- x. 000 Wsh, Flt SAE / Pump, Hydraulic Auxiliary O-Ring Arm Weld t 00 Scr, Hex Hd /- x.0 00 Wsh, Flt SAE / Hydraulic Pump * Seal Kit for Scr, Hex Hd M0 x. x 0 Scr, Soc Hd M x 0 Coupler Assembly Scr, Soc Hd /- x.0 00 Scr, Hex Hd /-0 x.0 Starter W/Connector Adapter Elbow Drain Hose Plug, Oil Drain 0 Gasket, Exhaust 0 Screw w/engine Exhaust Pipe Wsh, Flt M0 Scr, Hex Hd M0 x 0mm 00 Scr, Hex Hd /- x.00 0 Washer Rubber Mount 000 Nut, Hex Nyl Loc /- Left Engine Mount Clamp 0 Muffler Clevis w/pin 000 Nut, Hex /- Bracket U-Bolt 0 Hose Clamp 0 Upper / Lower Radiator Hose 0 Radiator 000 Nut, Hex Nyl Loc /-0 Spacer 0 Fan Shroud 00 Scr, Hex Hd M0 x. x 0mm Sheave, Impeller Scr, Hex Hd /-0 x. Radiator Cap 00 Scr, Hex Hd /-0 x. 000 Nut, Hex Nyl Loc /- Bracket 000 Scr, Pan Phil /-0 x. 0 Bracket Scr, Hex Hd /- x. 0 Coolant Recovery Tank Bracket Throttle Cable Throttle Cable 0 Ball Joint Engine, Diesel Hose Clamp Hose 0 Intake Adapter 0 Right Engine/Impeller Mount 0 0 Fuel Filter Kit * Replacement Spin-On Fuel Filter * Fuel Line (from filter to engine) Scr, Hex Hd M x 0 Hose Hose Clamp Mount, Air Cleaner 000 Wsh, Flt SAE / * A/R Glow Plug * Thermostat * Fan Belt * A/R Replacement Spin-On Oil Filter * 0 Fuel Pump * Alternator, V, 0A * Alternator Coupler * Shut Down Solenoid * Water Pump * Glow Plug Indicator Lamp w/timer * 0 Fan Spacer * Scr, Hex Hd M x x 0mm for Fan * Sender, Oil Pressure * Sender, Coolant Temperature * Kubota Operator Manual * = Not Shown 0

13 FORM NO. 00 revised / Hood Weld't Radiator Cowl 0

14 revised / FORM NO. 00 DIESEL ENGINE ASSEMBLY (after SN ) Air Inlet Hood Air Filter Cover Gasket Inlet Tube Air Cleaner Mounting Band Air Cleaner Assembly * Air Filter Service Indicator * 0 Replacement Safety Element * 0 Replacement Primary Element Hydro-Back 0 Control Cable Bracket, Hydro-Back Scr, Hex /- x.0 00 Scr, Hex Hd /- x. 000 Wsh, Flt SAE / Pump, Hydraulic (manual steering) Pump, Hydraulic (power steering) 00 O-Ring Arm Weld t 00 Scr, Hex Hd /- x.0 00 Wsh, Flt SAE / Hydraulic Pump Scr, Hex Hd M0 x. x 0 Scr, Soc Hd M x 0 Coupler Assembly Scr, Soc Hd /- x.0 00 Scr, Hex Hd /-0 x.0 Starter W/Connector Adapter Elbow Drain Hose Plug, Oil Drain 0 Gasket, Exhaust 0 Screw w/engine Exhaust Pipe Wsh, Flt M0 Scr, Hex Hd M0 x 0mm 00 Scr, Hex Hd /- x.00 0 Washer Rubber Mount 000 Nut, Hex Nyl Loc /- Left Engine Mount Clamp 0 Muffler Clevis w/pin 000 Nut, Hex /- Bracket U-Bolt 0 Hose Clamp 0 Upper / Lower Radiator Hose 0 Radiator 000 Nut, Hex Nyl Loc /-0 Spacer 0 Fan Shroud 00 Scr, Hex Hd M0 x. x 0mm Sheave, Impeller Scr, Hex Hd /-0 x. Radiator Cap 00 Scr, Hex Hd /-0 x. 000 Nut, Hex Nyl Loc /- Bracket 000 Scr, Pan Phil /-0 x. 0 Bracket Scr, Hex Hd /- x. 0 Coolant Recovery Tank Bracket Throttle Cable Throttle Cable 0 Ball Joint Engine, Diesel Hose Clamp Hose 0 Intake Adapter 0 Right Engine/Impeller Mount 0 0 Fuel Filter Kit * Replacement Spin-On Fuel Filter * Fuel Line (from filter to engine) Scr, Hex Hd M x 0 Hose Hose Clamp Mount, Air Cleaner 000 Wsh, Flt SAE / * A/R Glow Plug * Thermostat * Fan Belt * A/R Replacement Spin-On Oil Filter * 0 Fuel Pump * Alternator, V, 0A * Alternator Coupler * Shut Down Solenoid * Water Pump * Glow Plug Indicator Lamp w/timer * 0 Fan Spacer * Scr, Hex Hd M x x 0mm for Fan * Sender, Oil Pressure * Sender, Coolant Temperature * Kubota Operator Manual * = Not Shown

15 FORM NO. 00 revised / 0 To Fuel Filter Return Line (Diesel Only)

16 revised / FORM NO. 00 Fuel Tank Cap/Gauge Fuel Tank (Gas) Fuel Tank (Diesel) Hose Clamp Hose Hose Stand Tube Fuel Filter Assembly Hose Stand Tube (Diesel) 0 Hose Clamp (Diesel) 0 Hose (Diesel) Barb (Diesel) Hose (Diesel) * A/R Fuel Filter, Spin On * = Not Shown FUEL TANK ASSEMBLY - GAS / DIESEL Pin Weldment Mounting Bracket Right 0 LP Tank Mounting Bracket Left 00 Scr, Hex Hd / - 0 x. Latch 00 Scr, Hex Hd / - 0 x.0 FUEL TANK - LIQUID PROPANE

17 FORM NO. 00 revised / 0 FRONT

18 revised / FORM NO. 00 ACCELERATOR LINKAGE 000 Scr, Hex Hd /-0 x Pedal Mat Pedal 0 Cable 00 Nut, Hex /- 000 Nut, Hex Nyl Loc /-0 Clevis (includes pin) Hydro-Back Bracket, Hydro-Back (before SN ) Brakcet, Hydro-Back (after SN ) 0 00 Scr, Hex Hd /- x.0 (before SN ) 000 Scr, Hex /- x.0 (after SN ) 0 Bushings

19 FORM NO. 00 revised / 0 FRONT

20 revised / FORM NO. 00 IMPELLER ASSEMBLY Bushing 0 Shaft 0 Bar Retaining Ring 0 Spring Flex Hose Hose Clamp Shroud 000 Scr, Hex Hd Loc /- x Mount, Jackshaft (gas / LP) * 0 Mount, Jackshaft (diesel) Washer Impeller Spacer 0 ' Gasket (0 mm) Plate 0 Bracket 00 Nut, Hex Nyl Loc /- 0 Pillow Block 0 Grease Fitting Spacer 0 V-Belt Pulley 000 /- x / Set Screw 0 Shaft 000 / Flat Washer 000 Scr, Hex Hd /- x Scr, Hex Hd /- x.0 Square Key 000 Scr, Hex Hd /-0 x Scr, Hex Hd /-0 x. 000 Nut, Hex Jam/-0 00 Linkage Arm 0 00 Scr, Hex Hd /-0 x. Shaker Switch * Shaker Switch Cord Bushing 000 / Flat Washer Lever Knob 00 Scr, Hex Hd #- x # Flat Washer 0 Bearing 0 Plate 0 Acorn Nut 0 Nut Plate * = Not Shown

21 FORM NO. 00 revised / FRONT 0

22 revised / FORM NO. 00 BRAKE PEDAL ASSEMBLY 00 Brake Lever Assembly Link 0 Pedal Mat 0 Pedal Flange Bearing Bracket Retaining Ring 0 Bushing Retaining Ring 0 00 Scr, Hex Hd /- x.00 0 Spring 0 Clevis 00 Cable 00 / x / Cotter Pin 00 Pin 00 Scr, Hex Hd Thd Form /-0 x.0 0

23 FORM NO. 00 revised / 0 0 FRONT

24 revised / FORM NO. 00 FRONT WHEEL ASSEMBLY Grease Cap 0 Castle Nut 00 Cotter Pin / x -/ 0 Washer Bushing Bearing * Bearing Race Mounting Plate 00 Bearing * 0 Bearing Race Seal 0 00 Scr, Hex Hd /- x. Sprocket (manual steering) Spacer Spindle Motor * 000 Seal Kit for 00 Nut, Hex Nyl Loc /-0 0 Clevis 0000 Connector 000 Elbow 00 Elbow 0 00 Elbow Hub Tire Tire Assembly (# & ) Washer Nut, Castle -/- 00 Cotter Pin / x 00 Clevis Pin 000 Cotter Pin / x 00 Brake Cable 0 Sprocket (power steering) * = Not Shown

25 FORM NO. 00 revised / FRONT 0 0

26 revised / FORM NO Decal, Logo 00 Nut, Hex Nyl Loc /-0 00 / Flat Washer 0 Steering Wheel 0 Cup 0 Woodruff Key 00 /- x / Set Screw 000 Nut, Hex Nyl Loc /- 00 / Flat Washer 0 Channel Flange Bushing 0 Sprocket 0 Grease Fitting 000 Wsh, Flt SAE / 000 Scr, Hex Hd /- x. 0 Chain Sprocket 0 Collar 000 /- x. Set Screw 0 Lower Shaft 0 0 Universal Joint 0 Flange Bearing 0 Upper Shaft 0 Adapter Washer 00 / Shakeproof Washer Cap MANUAL STEERING ASSEMBLY

27 FORM NO. 00 revised / revised 0/0 FORM NO. 00 HYDRAULIC SYSTEM Hose 000 Elbow Hose 000 Tee Side Broom Speed Valve Hose 000 Elbow 0 Hose Hose 0 Hose Hydraulic Oil Tank 0000 Connector Hydraulic Filter Assembly 0 Hydraulic Oil Filter Element 00 Filter Head Assy. 000 Tee 00 Reducer 000 Nut Hose Hose 0 Hose Elbow Hopper Lift Cylinder 00 Tee 00 Elbow Oil Cooler Hose 0000 Connector Main Broom Motor 00 Seal Kit for 00 Elbow 000 Elbow 0 Pump Assembly (manual steering) *Note Pump Assembly (power steering) *Note 000 Connector Hydraulic Pump 0000 Connector 00 Elbow 00 Connector Hose 000 Elbow w/nut 00 Reducer 00 Elbow 0 0 Hose 000 Elbow 0000 Connector Wheel Drive Motor 000 Seal Kit for 00 Elbow 000 Elbow Hose 0000 Connector 000 Elbow 0 Side Broom Motor Seal Kit for Control Valve Filler Cap Hose Hose 0 Grommet 000 Connector Hose 00 Elbow 000 Elbow w/nut Hose Connector 0 Block Torque Generator 00 Tee 000 Elbow 000 Elbow 00 Connector Hydraulic Pump * NOTE: After SN Item 0 attaches with mounting holes horizontal rather than at an angle.

28 FORM NO. 00 FRONT revised /

29 revised / FORM NO Decal, Logo Cap 00 Nut, Hex Nyl Loc /-0 00 Wsh, SHPRF / 00 Wsh, Flt SAE / Washer 0 Steering Wheel 0 Adapter 0 Cup 0 0 Bearing, Flange Spacer, Steering Wheel 0 Collar 000 Scr, Soc Set Loc /- x. 0 Key, Woodruff 0 Shaft, Steering Upper Coupling, Shaft 000 Scr, Soc Set Loc /-0 x. Torque Generator 0 Port Block Kit 0 00 Scr, Hex Hd /- x. 0 Universal Joint 000 Scr, Soc Set Loc /- x. 0 Shaft, Steering Lower 00 Scr, Hex Hd /- x.00 Bearing 000 Nut, Hex Nyl Loc /- Sprocket 0 Chain, Steering 0 Channel Nut, Hex Nyl Loc /- 00 Wsh, Flt SAE / 000 Scr, Hex Hd /- x. Bushing, Flange 0 Sprocket Assembly POWER STEERING ASSEMBLY

30 FORM NO. 00 revised / 0

31 revised / FORM NO. 00 REAR AXLE ASSEMBLY 00 Scr, Hex Hd /- x. 000 / Washer Plate 00 / x Cotter Pin 0 Castle Nut 0 Washer Spacer Seal Roller Bearing * Bearing Race 0 Tire Hub Axle Grease Fitting * = Not Shown 0

32 FORM NO. 00 revised / A FRONT 0 0 A 0 0 0

33 revised / FORM NO. 00 MAIN BROOM ASSEMBLY 000 Scr, Hex Thd Form 0- x.0 0 Strap 0 Wrap Side Seal 0 Strap 00 Wrap Skirt Wrap Arm 00 / x Cotter Pin Wrap Adjuster 00 / Flat Washer 0 00 Scr, Hex Hd /- x. / x Spring Pin Wrap Link Washer 0 Sleeve Bearing 00 Scr, Hex Loc /-0 x. Washer Broom Motor Hub 000 Scr, Hex Thd Form /-0 x. Motor Mount 0 Bracket String Guard ' Gasket ( mm) Arm 000 Scr, Hex Hd /- x / Flat Washer 00 Scr, Hex Hd /- x Nut, Hex Nyl Loc /- Main Broom Motor Seal Kit for above 00 Scr, Hex Hd /- x Nut, Hex Nyl Loc /- 000 Scr, Hex Hd /- x.00 Adjuster 00 / x -/ Roll Pin 00 / x -/ Roll Pin Lift Arm Block 000 Scr, Hex Hd /- x.00 Flange Bearing 0 Collar 000 Scr, Soc Set /- x. 0 0 Pivot Shaft 000 Scr, Hex Hd /- x. Plated Washer 0 Idler Hub 00 Scr, Hex Hd /-0 x.0 Arm 0 Bushing 000 Scr, Hex Hd /- x. String Guard Bushing 0 0 Roller Bearing 00 Standard Main Broom/ Row Drive Insert for Broom ** 00 Optional Main Broom/ Row ** 00 Optional Main Broom/ Row Bushing Wrap Pivot Block 00 Scr, Hex Hd /-0 x. Knob Handle 0 Bushing 0 Lever Retaining Ring 0 0 Flange Bearing 0 Swivel 0 Swivel Flange Bearing 0 Adjuster Rod 0 Pin / Flat Washer Spacer ** = Optional

34 FORM NO. 00 FRONT 0 A 0 0 A 0 revised /

35 revised / FORM NO Strap 00 0 Scr, Hex Hd /-0 x. 0 Outer Rear Skirt Skirt Bracket 0 Inner Rear Skirt Skirt Bracket Strap 00 Scr, Hex Hd /-0 x.0 00 Nut, Hex Machine / Outer Left Skirt 0 Inner Left Skirt 00 Scr, Hex Thd Form /-0 x Scr, Flt Hd Phil /-0 x.00 Strap Front Skirt Angle Weldment Front Skirt 00 Nut, Hex /-0 Front Strap 0 Skirt Bracket 0 Outer Right Skirt Strap Inner Right Skirt Strap 00 ' Gasket (0 mm) Seal Seal Bracket Hand Grip Lever 0 00 Pin / x 0 Flange Bearing Lever Clevis Cable 00 Nut, Hex #0-00 Scr, Hex Thd Form /-0 x. 00 Cotter Pin Door 0 Bearing 0 0 Bushing Washer 00 Scr, Hex Hd /- x. 00 Scr, Pan Hd Phil Thd Form /-0 x.0 Washer BROOM HOUSING AND SKIRTS

36 FORM NO. 00 FRONT A A revised /

37 revised / FORM NO. 00 SIDE BROOM 0 Side Broom Motor Seal Kit for 0 Motor 00 Scr, Hex Hd /- x.0 00 / Flat Washer Mount Plate 0 Hair Pin Pin Pivot 0 Bushing 0 Bushing 0 Lift Arm Bushing 000 Scr, Hex Hd /- x.00 Bracket 000 Scr, Hex Hd /- x / Flat Washer 0 Bracket 00 Nut, Hex Nyl Loc-Thin /- Side Broom 00 / Flat Washer 0 00 Scr, Hex Hd /- x. 000 Scr, Hex Hd /-0 x.00 Hub Bracket 00 Scr, Hex Hd /- x Nut, Hex Nyl Loc /- Plate Lift Rod 0 Bearing 000 / Flat Washer 0 00 Scr, Hex Hd /-0 x.0 Knob Link 00 Scr, Hex Hd /- x. 0 Bushing

38 FORM NO. 00 revised / FRONT 0

39 revised / FORM NO. 00 Left Plate * Right Plate 00 Pin, Cotter. x.0 00 Wsh, Flt SAE / 000 Wsh, Loc Spr / 00 Scr, Hex Hd /- x. Bearing, Flange Upper Left Arm * Upper Right Arm * Grease Fitting 00 Scr, Hex Thd Form /-0 x. 000 Wsh, Flt SAE / 0 Cylinder pin Cylinder Bushing 0 Lower Arm 00 Scr, Hex Hd /- x.00 * 000 Nut, Hex Nyl Loc /- 0 Pin * = Not Shown HOPPER LIFT ARMS AND CYLINDERS

40 FORM NO. 00 revised / 0 0 FRONT

41 revised / FORM NO. 00 HOPPER 0 Door 00 Nut, Flx Loc / Wsh, Flt SAE / 0 Bushing, Step 00 Scr, Hex Hd /-0 x. 0 Bushing Latch ' Seal ( cm) 0 Clamp, Hold Down * 00 Scr, Phil Pn Thd Form - x. 0 Lever Ring, Ret. Ext Pin 0 Hopper 00.' Gasket ( cm) 00 Nut, Hex Keps - Clamp, Cable 0 Strain Relief Prefilter 0000 Scr, Pan Hd Phil - x.0 0 Left Hopper Side Panel Left Brace 0 Decal, Logo 000 Decal, Red / Black Stripe 000 Decal, Warning Right Brace 0 Right Hopper Side Panel 0

42 FORM NO. 00 revised / 0 FRONT

43 revised / FORM NO. 00 DUST CONTROL FILTER AND SHAKER MOTOR 0 Motor, Shaker Volt DC * Cord, Shaker Motor U-Bolt, / Decal, Hands Clear 000 Scr, Soc Set 0- x. Eccentric 00 Scr, Cap Socket Hd 0- x.0 Mount,Motor 00 Nut, Hex Nyl Loc-Thin /- Hold Down 0 Bolt, Shoulder /- 0 Bracket 00 Scr, Hex Thd Form /-0 x. Spring 00 Decal, Filter Filter Panel Assy (includes # & ) Filter Panel Only Gasket * = Not Shown

44 FORM NO. 00 revised / FRONT 0

45 revised / FORM NO. 00 DUMP DOOR ASSEMBLY Grip Lever ' Gasket ( cm) Dump Door 000 Scr, Hex Loc /- x. Washer, Hardened 0 Bushing 0 Bearing, Flange Link 0 Collar 00 Pin, Spring. x.0 00 Scr, Hex Loc /- x. Plate 0 Bearing, Sleave Retainer Ring Link 00 Scr, Soc Set Loc - x. 00 Wsh, Flt SAE /

46 FORM NO. 00 revised / 0 0

47 revised / FORM NO Scr, Hex Hd /-0 x. Valve, Side Broom Knob Lever 0 Washer 00 Scr, Hex Hd #0- x. Knob Lever Flange Bushing 0 Retaining Ring Linkage 0 Valve, Hyd. Directional Control 00 Scr, Hex Hd /-0 x. Lever 000 Nut, Hex Nyl Loc #0- Plate 00 Scr, Hex Hd /- x. Washer HYDRAULIC CONTROL VALVES

48 FORM NO. 00 revised / RED RED RED/GRN 0 AMP FUSE WHT/BRN IGNITION SWITCH YEL YEL YEL WHT/BRN STARTER OIL PRESSURE SAFTY SWITCH IGNITION MODULE 0 RED 0 MAGNETIC SENSOR GASOLINE SOLENOID VALVE YEL L.P. SOLENOID VALVE GRA/RED BLK BLK BLK IGNITION COIL BRN/WHT GRN/WHT COOLANT TEMPERATURE SENSOR YEL/WHT YEL/BLK WHT BRN RED/GRN 0 AMP FUSE VIO VIO YEL/RED YEL/RED RED/BLK YEL BLK VIO VIO BATTERY LIGHT TEMPERATURE LIGHT VIO/BLK GRA/BLK COOLANT TEMPERATURE SWITCH OIL PRESSURE SWITCH RED ALTERNATOR BLK BLK VIO OIL PRESSURE LIGHT SHAKER SWITCH WHT SHAKER MOTOR BLK HEAD LIGHT SWITCH (OPTIONAL) HEAD LIGHTS (OPTIONAL) BEACON (OPTIONAL) HOUR METER (OPTIONAL) HORN SWITCH (OPTIONAL) HORN (OPTIONAL) FUSE 0 AMP (OPTIONAL)

49 revised / FORM NO. 00 GAS / LP WIRING DIAGRAM 00 0 Amp Fuse, Ignition Switch 00 0 Amp Fuse, Charging Circuit 0 Temperature Light 0 Oil Light 0 Battery Light 0 Starter Motor 0 Shaker Motor 0 Ignition Switch Shaker Switch 0 Oil Pressure Safety Switch Oil Pressure Switch Coolant Temperature Switch Gasoline Solenoid Valve w/engine L.P. Solenoid Valve * Main Wiring Harness * 00 Fuse Holder ** 0 Horn Kit ** 0 Headlight Kit ** 0 Beacon Kit ** 0 Hour Meter Kit * = Not Shown ** = Optional Kit

50 FORM NO. 00 revised / + V BRN STARTER SOLENOID - V BLK RED RED BLU BLU FUSE BRN 0AMP IGNITION SWITCH RED FUSE OPTIONAL BLU VIO 0 0 RED/WHT AC VIO BRN GLOW PLUG TIMER VIO RED/WHT RED/WHT YEL YEL GLOW PLUG IND. LIGHT WHT STARTER FUEL SHUT-OFF SOLENOID GLOW PLUGS BLK BLK BLK BLK BLK VIO SHAKER SWITCH 0 WHT SHAKER MOTOR BLK BLU VIO VIO VIO VIO ALTERNATOR GRN BATT. WARNING LIGHT WHT/BLK COOLANT TEMP. WARNING LIGHT ORN/BLK OIL PRESS. WARNING LIGHT HEAD LIGHT SWITCH (OPTIONAL) COOLANT TEMP. SENDER OIL PRESS. SENDER HEAD LIGHTS (OPTIONAL) BLK BLK HOUR METER (OPTIONAL) FUSE 0 AMP (OPTIONAL) HORN SWITCH (OPTIONAL) BEACON (OPTIONAL) HORN (OPTIONAL)

51 revised / FORM NO. 00 DIESEL WIRING DIAGRAM 00 Fuse, 0Amp 00 Fuse, Optional 0Amp Starter Solenoid (included with starter) Key Switch, Diesel Starter Glow Plug Light w/timer Fuel Shut-Off Solenoid Glow Plug Timer (included with Glow Plug Light) Glow Plug 0 Shaker Switch 0 Shaker Motor Alternator 0 Battery Warning Light 0 Coolant Temp. Warning Light 0 Oil Press. Warning Light Coolant Temp. Sender Oil Press. Sender * 0 Main Wiring Harness * 00 Fuse Holder ** 0 Horn Kit * 00 Fuse for Horn Kit ** 0 Headlight Kit ** 0 Beacon Kit ** 0 Hour Meter Kit * = Not Shown ** = Optional Kit 0

52 Nilfisk-Advance, Inc. 00 st Avenue North Plymouth, MN, -0 Phone: 00-- Fax: Nilfisk-Advance, Inc., Plymouth, MN -0 Printed in the U.S.A.