SR 1800H P-D-LPG after

Transcription

1 Model: SR 1800 H LPG SR 1800 H P Part List US-English

2 Table of Contents Brake lever assembly 3 Chassis system Chassis system Chassis system Circuit breaker assembly (Diesel) 12 Circuit breaker assembly (Gas & Propan) 14 Control panel assembly 16 Control system 18 Decal system 20 Diesel engine system 22 Diesel engine system components 25 Diesel radiator assembly 29 Drive wheel system 32 Dust control system 35 Electrical diagram (Diesel) Electrical diagram (Diesel) Electrical diagram (Gas & Propane) Electrical diagram (Gas & Propane) Hydraulic system 1 45 Hydraulic system 2 51 Front wheel system 57 Gasoline & Propane engine system 59 Gasoline/Petrol & LPG engine system components 62 ENGINE REPLACEMENT PARTS 65 ENGINE SYSTEM COMPONENTS, PETROL ONLY 67 ENGINE SYSTEM COMPONENTS, LPG ONLY 69 Gasoline/Petrol & LPG radiator assembly 71 Gasoline/Petrol fuel system 74 LPG fuel system 76 Hopper system Hopper system Linkage assembly 84 Main broom system Main broom system Side broom system Side broom system Throttle pedal assembly 95 Tilt steering assembly 97 Recommended spare parts 99

3 Table of Contents Recommended spare parts 101 Broom selector guide 103 OPTIONS AND ACCESSORIES Temperature Switch Kit Temperature Gauge Kit 109

4 Brake lever assembly F

5 Brake lever assembly F BRAKE LEVER ASSY SCR HEX LOC 3/8-16 X NUT HEX NYL LOC 5/ PIN COT.06 X RING RET EXT BEARING FLANGE.625 E BEARING FLANGE E PAD RUBBER CLEVIS ASSEMBLY LINKAGE HANDBRAKE BRAKE YOKE WELDT BRAKE LEVER WELDT LINK WELDT ROD END PIN BUSHING.39X.50X.56

6 Chassis system - 1 F

7 Chassis system - 1 F NUT HEX NYL LOC 1/ NUT HEX NYL LOC 3/ RING RET EXT TYPE E BUSHING.37X.62X.18CV19H BUMPER.812 SQ CR BUMPER ROLLER PIN GROMMET E PLUG BUTTON BUMPER SELF-ADHESIVE CHASSIS WELDT RIGHT DOOR ASSY SEE CHASSIS SYSTEM LEFT DOOR ASSY SEE CHASSIS SYSTEM GROMMET COVER ACCESS DOOR LATCH LOCKABLE SEAT PLATE ASSY SEE CHASSIS SYSTEM TOWER DOOR ASSY SEE CHASSIS SYSTEM HINGE ASSY INSULATION TOWER PETROL AND LPG FOAM TOWER WALL DIESEL LIFT LINK WELDT GASKET SEAT PLATE WSH FLT SAE 5/ SCR HEX 5/16 18 X WSH FLT SAE 3/ WSH FLT SAE 1/ SCR HEX 3/8-16 X SCR HEX 5/16-18 X SCR FLT PHIL 1/4-20 X SCR PAN PHIL X SCR HEX THD FORM 1/4-20X SCR HEX THD FORM 1/4 20X SCR PANPHILTHD FORM 1/4-20X SH FLT.382X1.000X SCR PHIL THDFORM BLK1/4 20X PLUG BUTTON E TRAY BATTERY BLADE STRAP PLUG CAP BLADE DUMP DOOR SHIELD STRAP DUMP DOOR SHIELD

8 Chassis system - 1 F DEFLECTOR TAILLIGHT COVER WELDMENT SIDE DOOR ASSY DIESEL, SEE CHASSIS SYSTEM SIDE DOOR ASSEMBLY PETROL AND LPG, SEE CHASSIS SYSTEM HOOD ASSY DIESEL, SEE CHASSIS SYSTEM HOOD ASSEMBLY PETROL AND LPG, SEE CHASSIS SYETM STOP OIL COOLER DIESEL STOP OIL COOLER PETROL AND LPG SCR HEX 1/4 20 X BUSHING.25X.37X.40HC42C NUT HEX NYL LOC-THIN 1/4-20

9 Chassis system - 2 F

10 Chassis system - 2 F RIGHT DOOR ASSY POS LEFT DOOR ASSY POS SEAT PLATE ASSY POS NUT HEX NYL LOC-THIN 1/ RIGHT DOOR WELDT BLADE HOPPER FABRIC RT STRAP RIGHT DOOR GASKET STRIP GASKET STRIP SCR HEX 1/4-20 X WASHER FLAT.266X.906X NUT HEX NYL LOC 1/ LEFT DOOR WELDT SKIRT LEFT DOOR STRAP LEFT DOOR SCR HEX 1/4 20 X WSH FLT SAE 1/ NUT HEX NYL LOC 5/ SEAT PLATE WELDT INSULATION SEAT PLATE WSH FLT SAE 5/ SCR SOC HD 5/16 18 X SEAT ASSY LEFT ARM REST KIT OPTIONAL RIGHT ARM REST KIT

11 Chassis system - 3 F

12 Chassis system - 3 F TOWER DOOR ASSY POS HOOD ASSY DIESEL, POS SIDE DOOR ASSY DIESEL, POS SIDE DOOR ASSEMBLY PETROL AND LPG, POS HOOD ASSEMBLY PETROL AND LPG, POS NUT HEX NYL LOC 3/ NUT HEX JAM 5/ CYLINDER HOOD PULL POCKET SCR HEX 3/8-16 X TRIM SEAL TRIM SEAL DIESEL TRIM SEAL PETROL AND LPG PROP OIL COOLER HOOD WELDT SR1800D DIESEL HOOD WELDMENT PETROL AND LPG INSULATION HOOD DIESEL INSULATION HOOD PETROL AND LPG INSULATION HOOD DIESEL INSULATION HOOD PETROL AND LPG TRIM SEAL PETROL AND LPG TRIM SEAL DIESEL GASKET ENGINE DOOR TRIM SEAL SIDE DOOR WELDT SIDE DOOR WELDMENT LEFT DOOR WELDT GASKET TOWER DOOR

13 Circuit breaker assembly (Diesel) F

14 Circuit breaker assembly (Diesel) F CIRCUIT BREAKER ASSY DIESEL SCR PAN PHIL X NUT HEX NYL LOC-THIN CIRCUIT BREAKER 20A HEADLIGHTS, TAIL LIGHTS / F CIRCUIT BREAKER 10A HORN / F CIRCUIT BREAKER 8A SHAKER MOTOR / F PANEL CIRCUIT BREAKER RELAY SPDT HOPPER DOOR / K CIRCUIT BREAKER 40A MAIN / F CIRCUIT BREAKER 10A ACCESSORY CIRCUIT / F BOOT RESET BUTTON E BOOT RESET BUTTON E RELAY W/MTG BRACKET SHAKER MOTOR / K GLOW PLUG TIMER E RELAY W/MTG BRACKET ACCESSORY / K CIRCUIT BREAKER 15A ACCESSORY CIRCUIT / F3

15 Circuit breaker assembly (Gas & Propan) F

16 Circuit breaker assembly (Gas & Propan) F CIRCUIT BREAKER ASSY PETROL AND LPG SCR PAN PHIL X NUT HEX NYL LOC-THIN CIRCUIT BREAKER 8A SHAKER MOTOR / F CIRCUIT BREAKER 10A HORN / F CIRCUIT BREAKER 20A HEAD LIGHTS / TAIL LIGHTS / F PANEL CIRCUIT BREAKER RELAY SPDT CIRCUIT BREAKER 40A MAIN / F CIRCUIT BREAKER 15A IGNITION CIRCUIT / F BOOT RESET BUTTON E BOOT RESET BUTTON E RELAY W/MTG BRACKET CIRCUIT BREAKER 15A ACCESSORY CIRCUIT 1 / F3

17 Control panel assembly F

18 Control panel assembly F CONTROL PANEL ASSY DIESEL, POS CONTROL PANEL ASSY PETROL AND LPG, POS SCR PAN PHIL-BLK X SCR PANPHILTHD FORMBLK10-24X SWITCH FOR AG-16 SHAKER MOTOR, DUST CONTROL / S SWITCH ROCKER HEADLIGHTS / S LIGHT DISPLAY 10 BULB CONTROL PANEL METER HOUR GAUGE-FUEL GAUGE PRESSURE NOTE METER VOLT NOTE GAUGE TEMPERATURE NOTE SCR PAN PHIL-BLK X SCR PANPHILTHD FORMBLK10-24X SWITCH FOR AG-16 SHAKER MOTOR, DUST CONTROL / S SWITCH ROCKER HEADLIGHTS / S LIGHT DISPLAY 10 BULB CONTROL PANEL METER HOUR GAUGE PRESSURE NOTE GAUGE TEMPERATURE TSBUS , NOTE SWITCH ROCKER ENGINE SPEED / S GAUGE TEMPERATURE TSBUS , NOTE GAUGE PRESSURE NOTE METER VOLT GAUGE-FUEL PETROL NOTE #1: The Coolant Temp Gauge( ) is installed in this location before TSBUS The Oil Pressure Gauge( ) is installed in this location after TSBUS NOTE #2: The Oil Pressure Gauge( ) is installed in this location before TSBUS The Coolant Temp Gauge ( ) is installed in this location after TSBUS

19 Control system F

20 Control system F HARNESS CONTROL PANEL HARNESS CONTROL PANEL SCR HEX 5/16-18 X SCR PAN PHIL 1/4-20 X NUT HEX NYL LOC 5/ NUT HEX NYL LOC 1/ THROTTLE PEDAL ASSY SEE THROTTLE PEDAL ASSEMBLY BRAKE LEVER ASSY SEE BRAKE LEVER ASSEMBLY TILT STEERING ASSY SEE TILT STEERING ASSEMBLY CONSOLE FINISHED LEVER ASSY BRAKE CV618B CIRCUIT BREAKER ASSY PETROL AND LPG, SEE CIRCUIT BREAKER ASSEMBLY CIRCUIT BREAKER ASSY DIESEL, SEE CIRCUIT BREAKER ASSEMBLY GAUGE KIT SEE POS 9-11 ON CONTROL PANEL ASSEMBLY HARNESS CONTROL PANEL CONTROL PANEL ASSY DIESEL, SEE CONTROL PANEL ASSEMBLY CONTROL PANEL ASSY PETROL AND LPG, SEE CONTROL PANEL ASSEMBLY

21 Decal system F

22 Decal system F PEDAL MAT CV696C FLOOR MAT DECAL-WARNING HYDRAULIC DECAL WARNING FAN DECAL WARNING FAN DECAL UNLEADED FUEL PETROL DECAL DIESEL FUEL DIESEL DECAL OIL FILL DECAL CIRCUIT BREAKER PETROL AND LPG DECAL CIRCUIT BREAKER DIESEL DECAL WARNING BROOM DECAL SR1800H DECAL CONTROL REAR PETROL AND LPG DECAL CONTROL REAR D DIESEL DECAL CONTROL FRONT PETROL AND LPG DECAL CONTROL FRONT D DIESEL DECAL REFLECTIVE INSIDE TAIL LIGHT DECAL WARNING TIP O DECAL TIE DOWN DECAL WARNING HOT QTY OF 3 ON PETROL AND LPG DECAL-WARNING-HOPPER DECAL NO STEP

23 Diesel engine system F

24 Diesel engine system F ALTERNATOR BELT ALTERNATOR FUEL FILTER CARTRIDGE FAN BELT THERMOSTAT STARTER MOTOR SWITCH ENGINE OIL PRESSURE SWITCH TEMPERATURE EXHAUST GASKET STIFF ENGINE MOUNT KIT OPTIONAL SOFT ENGINE MOUNT KIT OPTIONAL SOLENOID REPLACEMENT KIT GLOW PLUG TIMER OIL FILTER SPIN ON KEY SWITCH PANEL REAR HEAT SHIELD WSH FLT SAE 5/ SCR HEX 5/16-18 X NUT HEX NYL LOC 5/ SCR HEX LOC 5/16-18 X SCR HEX THD FORM 1/4 20X CLAMP HOSE SAE 6 E FUEL TANK ASSY NOTE FUEL TANK GUARD WELDT SCR HEX THD FORM 1/4-20X EXHAUST PIPE ASSY NOTE SCR HEX 1/4 20 X SCR SOC HD M6 X FAN COOLING FAN SPACER REAR MOUNT ASSY BEFORE SN , NOTE REAR ENGINE MOUNT ASSEMBLY AFTER SN , NOTE FITTING ADAPTER ASSEMBLY RADIATOR SEE DIESEL RADIATOR ASSEMBLY AIR TUBE ASSY NOTE HOSE FUEL LINE RIGHT MOUNT ASSY BEFORE SN , NOTE RIGHT ENGINE MOUNT ASSEMBLY AFTER SN , NOTE LEFT MOUNT ASSY BEFORE SN , NOTE LEFT ENGINE MOUNT ASSEMBLY AFTER SN , NOTE ENGINE DIESEL MUFFLER ASSY NOTE 2 Note 1: Item 35 Conduit goes over item 20 Fuel Line. Note 2: See "Diesel Engine System Components".

25 Diesel engine system F LINKAGE ASSY SEE LINKAGE ASSEMBLY AIR CLEANER ASSY NOTE HOSE THROTTLE CABLE ASSY HOSE FUEL LINE E FUEL FILTER CARTRIDGE BRACKET FUEL FILTER CONNECTOR O/R 6 E CAP FLARE TUBE END TUBE RUBBER.25X48 E00529 AFTER SN , TSBUS FUEL FILTER KIT AFTER SN , TSBUS STRAIN RELIEF E00220 AFTER SN , TSBUS CONDUIT NOTE 1 Note 1: Item 35 Conduit goes over item 20 Fuel Line. Note 2: See "Diesel Engine System Components".

26 Diesel engine system components F

27 Diesel engine system components F FUEL TANK ASSY POS 1-12, SCR HEX THD FORM 10-24X FUEL TANK WELDT FUEL PUMP ASSY POS 7-12, SENDER FUEL LEVEL RE437A CAP NON VENTED CAP FUEL TANK RE442WC TSBUS PLUG 1/8 27 NPT E00040 SR 1800 AFTER SN , TSBUS CLAMP HOSE SAE 24 E FUEL PUMP BRACKET WELDT IN-TANK FUEL PUMP GASKET HOSE FUEL 30R REAR MOUNT ASSY POS 13-21, NOTE REAR ENGINE MOUNT ASSEMBLY POS 13-21, NOTE CLAMP HOSE SAE 4 E SCR HEX 3/8-16 X SCR HEX 5/16-18 X NUT HEX NYL LOC 5/ NUT HEX NYL LOC 3/ SCR HEX THD/HD M X20MM WSH FLT.453X1.000X WSH FLT.438 X 2.00 X MOUNT ISOLATOR MOUNT ISOLATOR WELDMENT ENGINE MOUNT NOTE AIR TUBE ASSY POS 22-29, ENGINE MOUNT WELDMENT NOTE SCR HEX 1/4 20 X SCR HEX THD FORM 1/4-20X CLAMP HOSE SAE 16 E HOSE LOWER RADIATOR CLAMP HOSE SAE 32E AIR TUBE WELDT HEAT SHIELD RIGHT MOUNT ASSY POS 30-38, NOTE HOSE FLEX RIGHT ENGINE MOUNT ASSEMBLY POS 30-38, NOTE SCR HEX 3/8-16 X SCR HEX 5/16-18 X NUT HEX NYL LOC 5/ NUT HEX NYL LOC 3/ SCR HEX THD/HD M X20MM Note 1: Used before SN Note 2: Used after SN

28 Diesel engine system components F WSH FLT.453X1.000X WSH FLT.438 X 2.00 X MOUNT ISOLATOR MOUNT ISOLATOR BRACKET ENGINE RIGHT NOTE LEFT MOUNT ASSY POS 39-47, NOTE BRACKET ENGINE RIGHT NOTE LEFT ENGINE MOUNT ASSEMBLY POS 39-47, NOTE SCR HEX 3/8-16 X SCR HEX 5/16-18 X NUT HEX NYL LOC 5/ NUT HEX NYL LOC 3/ SCR HEX THD/HD M X20MM WSH FLT.453X1.000X WSH FLT.438 X 2.00 X MOUNT ISOLATOR MOUNT ISOLATOR BRACKET ENGINE LEFT NOTE EXHAUST PIPE ASSY POS BRACKET ENGINE LEFT NOTE WSH FLT SAE 5/ CLAMP MUFFLER AS42U E EXHAUST GASKET EXHAUST PIPE WELDT MUFFLER ASSY POS EXHAUST PIPE WELDT SCR HEX 1/4 20 X SCR HEX 1/4 20 X NUT HEX NYL LOC 1/ SCR HEX THD FORM 1/4-20X SCR HEX THD FORM 1/4 20X CLAMP MUFFLER AS42U E SHIELD HEAT CLAMP WELDT PLATE MUFFLER HANGING STRAP RIGHT BROOM HOUSING MUFFLER DIESEL MOUNT DIAPHRAGM RE446Y AIR CLEANER ASSY POS NUT PLATE 1/ SCR HEX 5/16 18 X WSH FLT SAE 5/ NUT HEX NYL LOC 5/16-18 Note 1: Used before SN Note 2: Used after SN

29 Diesel engine system components F HOSE FLEXIBLE AIR INLET CLAMP HOSE SAE 32E BARB 5/16 X 1/8 E SERVICE INDICATOR RE442DA HOSE FUEL LINE E FILTER SAFETY FILTER PRIMARY CLEANER AIR BAND ASSY INLET HOOD ASSY. POS 77-80, TSBUS BARB 5/16 X 1/8 BR E SCR HEX 1/4-20 X NUT HEX NYL LOC 1/ FLANGE WELDMENT THROTTLE CABLE ASSY POS HOOD INLET SCR HEX LOC 1/4-20 X SCR HEX THD TO HD M8 1.25X12MM CABLE PUSH/PULL ROD END BRACKET THROTTLE CABLE THROTTLE LEVER EXTENSION LEVER ASSEMBLY SCR HEX 1/4 20 X NUT HEX NYL LOC THIN NUT HEX NYL LOC 1/ NUT HEX NYL LOC GASOLINE STRAINER-30 MICRON CLAMP CABLE.438 E00129 Note 1: Used before SN Note 2: Used after SN

30 Diesel radiator assembly F

31 Diesel radiator assembly F ASSEMBLY RADIATOR POS SCR HEX 1/4 20 X SCR HEX 1/4-20 X SCR HEX 1/4-20 X NUT HEX NYL LOC 1/ NUT HEX NYL LOC-THIN NUT HEX NYL LOC 1/ NUT HEX NYL LOC 1/ SCR HEX THD FORM 1/4 20X SCR PANPHILTHD BLK 10-24X CLAMP HOSE SAE 16 E LENS TAIL LIGHT HOSE RADIATOR HOSE LOWER RADIATOR RADIATOR GASKET BULB OIL COOLER ASSY POS AND SHROUD WELDT WELDMENT RADIATOR MOUNT BACK PANEL TUBE RADIATOR WELDMENT STIFFENER CLAMP CLAMP PLATE SCR HEX 1/4 20 X WSH FLT SAE 5/ SCR HEX 5/16-18 X NUT HEX NYL LOC 5/ NUT HEX NYL LOC 1/ ELBOW 90D 0/R E GASKET BULB COOLER OIL SWIVEL GASKET HOSE ASSY TUBE ASSY DIESEL GRILL WELDT AXLE WELDMENT ROLLER ROLLER STOP WELDMENT HOSE ASSY PROP REST PLUG BRASS E00040

32 Diesel radiator assembly F HOSE FUEL LINE E SCR HEX 5/16-18 X WSH FLT SAE 5/ NUT HEX NYL LOC 5/ WSH FLT.266X.750X OVERFLOW BOTTLE ASSY SCR HEX 5/16-18 X 1.00

33 Drive wheel system F

34 Drive wheel system F STEERING ASSY POS 1-31 AND SCR HEX LOC 1/2-13 X WSH FLT SAE 1/ SCR PAN PHIL X SCR HEX 1/4-20 X SCR SOC SET LOC 5/16 18 X PIN COT.12 X SCR SOC HD 1/2-13X KEY SQ.25 X SCR HEX THD FORM 1/4-20X NUT HEX NYL LOC 5/ FITTING LUBE 1/ NUT CAS THNE9A BEARING TR CP E BEARING TR CN E SEAL SHAFT RE416JC GASKET 1/16X1/2X120HC525F GASKET 1/16X1/2X120HC525F RACK GEAR SPUR SPINDLE WELDT ANGLE ADJUSTER PLATE WEAR CASTING STEERING BRACKET CYLINDER SPACER GEAR COVER PLATE COVER INSPECTION BRACKET BULKHEAD CYLINDER HYDRAULIC STEERING CYLINDER ASSY ELBOW 90 DEG.O/R 4 E GROMMET E PIN.5 X NUT HEX NYL LOC 1/ SCR HEX 1/2-13 X NUT LUG 1/2 20 TSBUS CUSHION TIRE ASSY OPTIONAL CUSHION TIRE ASSY NON MARKING OPTIONAL TIRE ASSEMBLY REAR TSBUS TUBE TIRE 5.00-R8, TSBUS RIM HEAVY, TSBUS797

35 Drive wheel system F HUB KIT 2060 OPTIONAL HUB KIT 2060 TSBUS775, HUB KIT 2060 OPTIONAL, POS 34 AND PIN COT.156X SCR HEX LOC 1/2-13 X 1.25

36 Dust control system F

37 Dust control system F SHAKER ASSEMBLY POS IMPELLOR ASSEMBLY POS WSH FLT SAE 5/ SCR PAN PHIL X SCR SOC SET LOC 10-24X WSH FLT SAE 3/ SCR HEX 1/4-20 X WSH FLT SAE 1/ SCR HEX THD/HD 5/16-18 X SCR PAN PHIL X NUT HEX NYL LOC 5/ NUT HEX NYL LOC 1/ SCR HEX LOC 5/16 18 X WSH BOWED.516X.906X WSH FLT.516X.938X NUT HEX JAM 5/ BUSHING.31X.50X.28HC18M BUSHING.25X.37X.40HC42C BEARING SLEEVE.379CV211KE SHIELD SHAKER LATCH SHAKER SHAKER HINGE WELDT ECCENTRIC BUSHING FLANGE SHAKER WELDT U-BOLT MOTOR BRUSH SET SHAKER MOTOR KIT PIN UNIV MATE-N-LOK PLUG 2 CIR MATE-N-LOK FILTER PANEL ASSY WSH FLT SAE 3/ NUT HEX NYL LOC-THIN 5/ NUT HEX NYL LOC 5/ SCR HEX LOC 5/16-18 X WSH FLT SS.378/.373X1.00X TRIM SEAL IMPELLOR BRACKET WELDT IMPELLOR

38 Electrical diagram (Diesel) - 1 F

39 Electrical diagram (Diesel) - 1 F HARNESS HOPPER HARNESS CONTROL PANEL HARNESS INTERLOCK HARNESS MAIN, TSBUS825 G ALTERNATOR BT BATTERY 12V 26AH WET Machine outphased 2006 E TIME DELAY OPTIONAL, TSBUS E GLOW PLUG TIMER F CIRCUIT BREAKER 40A MAIN F CIRCUIT BREAKER 10A ACCESSORY CIRCUIT F CIRCUIT BREAKER 15A ACCESSORY CIRCUIT K RELAY W/MTG BRACKET SHAKER MOTOR K RELAY W/MTG BRACKET ACCESSORIES K RELAY SPDT HOPPER DOOR L SHUTDOWN SOLENOID TSBUS825 L VALVE SOLENOID L VALVE SOLENOID L VALVE SOLENOID M STARTER MOTOR M IN-TANK FUEL PUMP P METER HOUR P GAUGE-FUEL R SENDER FUEL LEVEL RE437A S KEY SWITCH S SWITCH ENGINE OIL PRESSURE S SWITCH TEMPERATURE S SWITCH VACUUM OPTIONAL S SWITCH TEMPERATURE OPTIONAL S SWITCH FOR AG-16 SHAKER MOTOR, DUST CONTROL H STROBE OPTIONAL H FLASH TUBE, FOR S SWITCH WATERPROOF S SWITCH WATERPROOF S SWITCH WATERPROOF S SWITCH WATERPROOF S SWITCH N.O. PRESSURE S SEALED BALL SWITCH ASSY Note 1: When the Shaker Timer is not used, there is a jumper w ire connected betw een the RED/BLK and RED/BRN wires.

40 Electrical diagram (Diesel) - 2 F

41 Electrical diagram (Diesel) - 2 F GAUGE KIT TURN SIGNAL KIT VACUUM SWITCH KIT TEMPERATURE SWITCH KIT BACK UP ALARM KIT BEACON KIT SHAKER TIMER KIT E FLASHER OPTIONAL F CIRCUIT BREAKER 20A HEADLIGHTS, TAIL, LIGHTS F CIRCUIT BREAKER 8A SHAKER MOTOR F CIRCUIT BREAKER 10A HORN F CIRCUIT BREAKER 20A SIGNAL LIGHTS, OPTIONAL H HEAD LAMP ASSY. H HEAD LAMP ASSY. H BULB LIGHT H LIGHT SOCKET ASSY H BULB LIGHT K RELAY W/MTG BRACKET SHAKER MOTOR K RELAY W/MTG BRACKET OPTIONAL M MOTOR BRUSH SET M SHAKER MOTOR KIT M PIN UNIV MATE-N-LOK M PLUG 2 CIR MATE-N-LOK P GAUGE PRESSURE STANDARD AFTER SN P GAUGE TEMPERATURE STANDARD AFTER SN P METER VOLT STANDARD AFTER SN R SENDER PRESS 0 80 RE446N STANDARD AFTER SN R SENDER TEMPERATURE STANDARD AFTER SN S SWITCH ROCKER HEADLIGHTS S SWITCH WATERPROOF OPTIONAL H AMBER 12V DC TURN SIGNAL BULB OPTIONAL H LAMP AMBER/RED/CLEAR OPTIONAL H AMBER 12V DC TURN SIGNAL BULB OPTIONAL H LAMP AMBER/RED/CLEAR OPTIONAL H BACK-UP ALARM OPTIONAL H HORN 12 VOLT CV438 H LAMP AMBER/RED/CLEAR OPTIONAL H LAMP AMBER/RED/CLEAR OPTIONAL H LAMP AMBER/RED/CLEAR OPTIONAL H LAMP AMBER/RED/CLEAR OPTIONAL S SWITCH N.O. ASSEMBLY OPTIONAL S SWITCH START SPST S SWITCH WATERPROOF Note: For Gauge Option the follow ing items are not used: H2 and S4. R7 replaces S4 w ith Gauge Option. Cut the VIO / BLK w ire off the connector at the lights and connect it to the VIO / BLK w ire supplied w ith the

42 Electrical diagram (Gas & Propane) - 1 F

43 Electrical diagram (Gas & Propane) - 1 F PLUG WIRE KIT HARNESS HOPPER HARNESS INTERLOCK HARNESS MAIN HARNESS CONTROL PANEL, TSBUS HARNESS CONTROL PANEL, TSBUS A ENGINE CONTROL MODULE GM 1.6 BT CABLE BATTERY E00232 BT CABLE BATTERY E00232 BT BATTERY 12V 26AH WET Machine outphased 2006 E TIME DELAY OPTIONALTSBUS F CIRCUIT BREAKER 40A MAIN F CIRCUIT BREAKER 15A IGNITION CIRCUIT F CIRCUIT BREAKER 15A ACCESSORY CIRCUIT 1 K RELAY W/MTG BRACKET K RELAY SPDT L SOLENOID COIL ASSY. M FUEL PUMP PETROL P METER HOUR P GAUGE-FUEL PETROL P GAUGE PRESSURE P GAUGE TEMPERATURE TSBUS P GAUGE TEMPERATURE TSBUS P METER VOLT R SENDER FUEL LEVEL RE437A PETROL R SENDER PRESS 0 80 RE446N S SWITCH STARTER S KEY IGNITION REPLACEMENT FOR S SWITCH ROCKER S SWITCH VACUUM OPTIONAL S SWITCH TEMPERATURE OPTIONAL S SWITCH FOR AG-16 H STROBE OPTIONAL H FLASH TUBE, FOR S SWITCH N C PRESSURE S SWITCH N.O. PRESSURE S SEALED BALL SWITCH ASSY Note 1: When the Shaker Timer is not used, there is a jumper w ire connected betw een the RED/BLK and RED/BRN wires.

44 Electrical diagram (Gas & Propane) - 2 F

45 Electrical diagram (Gas & Propane) - 2 F TURN SIGNAL KIT VACUUM SWITCH KIT TEMPERATURE SWITCH KIT BACK UP ALARM KIT BEACON KIT SHAKER TIMER KIT E FLASHER OPTIONAL F CIRCUIT BREAKER 20A HEADLIGHTS / TAIL LIGHTS F CIRCUIT BREAKER 8A SHAKER MOTOR F CIRCUIT BREAKER 10A HORN F CIRCUIT BREAKER 20A SIGNAL LIGHTS / OPTIONAL H HEAD LAMP ASSY. H HEAD LAMP ASSY. H BULB LIGHT H LIGHT SOCKET ASSY H BULB LIGHT K RELAY W/MTG BRACKET K RELAY SPDT K RELAY W/MTG BRACKET OPTIONAL L VALVE SOLENOID M SHAKER MOTOR KIT R VARISTOR ASSY S SWITCH ROCKER S SWITCH WATERPROOF H AMBER 12V DC TURN SIGNAL BULB OPTIONAL H LAMP AMBER/RED/CLEAR OPTIONAL H AMBER 12V DC TURN SIGNAL BULB OPTIONAL H LAMP AMBER/RED/CLEAR OPTIONAL H BACK-UP ALARM OPTIONAL H HORN 12 VOLT CV438 H LAMP AMBER/RED/CLEAR OPTIONAL H LAMP AMBER/RED/CLEAR OPTIONAL H LAMP AMBER/RED/CLEAR OPTIONAL H LAMP AMBER/RED/CLEAR OPTIONAL S SWITCH N.O. ASSEMBLY S SWITCH START SPST S SWITCH WATERPROOF S SWITCH WATERPROOF S SWITCH WATERPROOF S SWITCH WATERPROOF S SWITCH WATERPROOF

46 Hydraulic system 1 F103140A 45

47 Hydraulic system 1 F103140A SCR HEX THD FORM 1/4-20X HOPPER DOOR CYLINDER ASSY POS HYDRAULIC HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY WHEEL MOTOR ASSY POS 59-64, TSBUS LOCKNUT BULKHEAD E LOCKNUT BULKHEAD E LIFT CYLINDER ASSY POS STEERING CYLINDER ASSY POS SLEEVE 24 IN. NYLON SLEEVE 32 IN. NYLON RELIEF BLOCK ASSY POS 80-91, DIRECTIONAL CONTROL VALVE ASSY POS PUMP ASSY POS AND IMPELLER MOTOR ASSY POS MAIN BROOM MOTOR ASSY POS , SIDE BROOM MOTOR ASSY POS SIDE BROOM VALVE ASSY POS MANIFOLD HYDRAULIC ASSY POS PLATE BULKHEAD SCR HEX 1/4 20 X SCR HEX 1/4-20 X NUT HEX NYL LOC 1/ HOSE BRACKET ASSY BRACKET HOSE CLAMP 10 DBL. E RESERVOIR ASSY POS , ELBOW E LOCKNUT BULKHEAD E HOSE ASSY HOSE ASSY

48 Hydraulic system 1 F103140A HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY PIN COT.12 X CYLINDER HYDRAULIC PIN.5 X ELBOW 90DEG O/R 4 6 E PIN COT.12 X SEAL KIT MOTOR WHEEL 4 KC TSBUSUS775 AND ELBOW 90 O/R E ELBOW 45 DEG O/R 4 E SCR HEX THD/HD M6 1.0 X 16MM STEERING CONTROL UNIT STEERING COLUMN CONNECTOR 4 6 E ELBOW 90DEG O/R 4 6 E ELBOW 90D W/NUT 4 E RING RET EXT CYLINDER HYD CYLINDER REPAIR KITRE482AU PIN CYLINDER SHORT PIN 1.00X3.500 RE409GA PIN COT HAIR.148 X DIA.62/ CONNECTOR 0 RING 4 E ELBOW 90 DEG.O/R 4 E CYLINDER HYDRAULIC SEAL KIT ELBOW 90 DEG.O/R 4 E SCR HEX 1/4-20 X 3.00

49 Hydraulic system 1 F103140A NUT HEX NYL LOC 1/ COUPLING 6 TEST PORT BLOCK RELIEF FLOW DIVIDER CARTRIDGE RELIEF VALVE CARTRIDGE CONNECTOR O/R 6 E CONNECTOR 4 6 E ELBOW 90 DEG O/R 6 E ELBOW 90 DEG.O/R -8 E ELBOW 45 DEG.O/R -6 E TEE RUN O/R -6 E ELBOW 90DEG W/NUT-6 E TEE E SCR HEX 1/4-20 X SCR HEX 1/4-20 X SCR HEX X NUT HEX NYL LOC 1/ NUT HEX NYL LOC-THIN KNOB 1.12X3/8 16 CR29C U CLIP VALVE BUSHING LEFT LEVER WELDT RIGHT LEVER WELDT BRACKET VALVE SEAL KIT VALVE DIRECTIONAL CONTROL CONNECTOR 4 6 E CONNECTOR O/R 6 8 E TEE RUN O/R -6 E SCR HEX 1/2 13 X SCR HEX 3/8-24 X O-RING SEAL KIT PUMP PISTON PUMP TRIPLE GEAR SEAL KIT TRIPLE PUMP CONNECTOR O/R 6 10 E ELBOW 90 O/R E ELBOW 90 O/R 8 12 E OIL FILTER ASSY POS ELBOW 45 O RING W/NUT E MOTOR HYDRAULIC.161CIR SOLENOID CARTRIDGE

50 Hydraulic system 1 F103140A SOLENOID COIL ASSY SEAL KIT CONNECTOR O/R 8 E ELBOW 90 DEG.O/R 4 E MOTOR MAIN BROOM TSBUS SEAL KIT ELBOW LG 90D O/R -8 E MOTOR SIDE BROOM SEAL KIT ELBOW 90 DEG.O/R -8 E SCR HEX 1/4 20 X NUT HEX NYL LOC 1/ VALVE SOLENOID SEAL KIT SPACER SOLENOID VALVE TEE BRANCH O/R -8 E SCR HEX 1/4 20 X NUT HEX NYL LOC 1/ TEE E MANIFOLD HYDRAULIC TEE RUN W/NUT 4 E CONNECTOR O/R 6 E PLUG HEX 0 RING E CONNECTOR O/R 12 E CONNECTOR 4 6 E ELBOW 90D W/NUT 6C6X S E ELBOW 90D W/NUT -12 E SCR HEX 5/16 18 X WSH FLT SAE 5/ SCR HEX 5/16-18 X NUT HEX NYL LOC 5/ SCR PAN PHIL LOC 5/16-18 X ELBOW ST 1/8X90 BR E ELBOW 90D W/NUT 4 E STRAP HYDRAULIC.RESERVOIR PLUG HEX 0 RING E FILLER CAP RE483B RESERVOIR WELDT IN-TANK OIL FILTER HYDRAULIC OIL FILTER ADAPTER 1/8 NPT SWITCH N.O. PRESSURE DUST BOOT

51 Hydraulic system 1 F103140A CONNECTOR 0 RING 4 E CONNECTOR O/R 12 E TEE RUN W/NUT E REDUCER E HEAD OIL FILTER FILTER HYDRAULIC OIL UNION STRAIGHT THREAD REDUCER W/O E TEE BRANCH O/R -8 E TEE E OIL COOLER ASSY DIESEL, SEE RADIATOR ASSEMBLY OIL COOLER ASSEMBLY PETROL/LPG/DUAL FUEL, SEE RADIATOR ASSEMBLY ELBOW 90D W/NUT 6C6X S E CONN EXT O/R -4 E00002 TSBUS TEE RUN W/NUT 4 E00009 TSBUS HOSE ASSY TSBUS731

52 Hydraulic system 2 F103140B 51

53 Hydraulic system 2 F103140B SCR HEX THD FORM 1/4-20X HOPPER DOOR CYLINDER ASSY POS HYDRAULIC HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY WHEEL MOTOR ASSY POS 59-64, TSBUS LOCKNUT BULKHEAD E LOCKNUT BULKHEAD E LIFT CYLINDER ASSY POS STEERING CYLINDER ASSY POS SLEEVE 24 IN. NYLON SLEEVE 32 IN. NYLON RELIEF BLOCK ASSY POS 80-91, DIRECTIONAL CONTROL VALVE ASSY POS PUMP ASSY POS AND IMPELLER MOTOR ASSY POS MAIN BROOM MOTOR ASSY POS , SIDE BROOM MOTOR ASSY POS SIDE BROOM VALVE ASSY POS MANIFOLD HYDRAULIC ASSY POS PLATE BULKHEAD SCR HEX 1/4 20 X SCR HEX 1/4-20 X NUT HEX NYL LOC 1/ HOSE BRACKET ASSY BRACKET HOSE CLAMP 10 DBL. E RESERVOIR ASSY POS , ELBOW E LOCKNUT BULKHEAD E HOSE ASSY HOSE ASSY

54 Hydraulic system 2 F103140B HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY HOSE ASSY PIN COT.12 X CYLINDER HYDRAULIC PIN.5 X ELBOW 90DEG O/R 4 6 E PIN COT.12 X SEAL KIT MOTOR WHEEL 4 KC TSBUS775 AND ELBOW 90 O/R E ELBOW 45 DEG O/R 4 E SCR HEX THD/HD M6 1.0 X 16MM STEERING CONTROL UNIT STEERING COLUMN CONNECTOR 4 6 E ELBOW 90DEG O/R 4 6 E ELBOW 90D W/NUT 4 E RING RET EXT CYLINDER HYD CYLINDER REPAIR KITRE482AU PIN CYLINDER SHORT PIN 1.00X3.500 RE409GA PIN COT HAIR.148 X DIA.62/ CONNECTOR 0 RING 4 E ELBOW 90 DEG.O/R 4 E CYLINDER HYDRAULIC SEAL KIT ELBOW 90 DEG.O/R 4 E SCR HEX 1/4-20 X 3.00

55 Hydraulic system 2 F103140B NUT HEX NYL LOC 1/ COUPLING 6 TEST PORT BLOCK RELIEF FLOW DIVIDER CARTRIDGE RELIEF VALVE CARTRIDGE CONNECTOR O/R 6 E CONNECTOR 4 6 E ELBOW 90 DEG O/R 6 E ELBOW 90 DEG.O/R -8 E ELBOW 45 DEG.O/R -6 E TEE RUN O/R -6 E ELBOW 90DEG W/NUT-6 E TEE E SCR HEX 1/4-20 X SCR HEX 1/4-20 X SCR HEX X NUT HEX NYL LOC 1/ NUT HEX NYL LOC-THIN KNOB 1.12X3/8 16 CR29C U CLIP VALVE BUSHING LEFT LEVER WELDT RIGHT LEVER WELDT BRACKET VALVE SEAL KIT VALVE DIRECTIONAL CONTROL CONNECTOR 4 6 E CONNECTOR O/R 6 8 E TEE RUN O/R -6 E SCR HEX 1/2 13 X SCR HEX 3/8-24 X O-RING SEAL KIT PUMP PISTON PUMP TRIPLE GEAR SEAL KIT TRIPLE PUMP CONNECTOR O/R 6 10 E ELBOW 90 O/R E ELBOW 90 O/R 8 12 E OIL FILTER ASSY POS ELBOW 45 O RING W/NUT E MOTOR HYDRAULIC.161CIR SOLENOID CARTRIDGE

56 Hydraulic system 2 F103140B SOLENOID COIL ASSY SEAL KIT CONNECTOR O/R 8 E ELBOW 90 DEG.O/R 4 E MOTOR MAIN BROOM TSBUS SEAL KIT ELBOW LG 90D O/R -8 E MOTOR SIDE BROOM SEAL KIT ELBOW 90 DEG.O/R -8 E SCR HEX 1/4 20 X NUT HEX NYL LOC 1/ VALVE SOLENOID SEAL KIT SPACER SOLENOID VALVE TEE BRANCH O/R -8 E SCR HEX 1/4 20 X NUT HEX NYL LOC 1/ TEE E MANIFOLD HYDRAULIC TEE RUN W/NUT 4 E CONNECTOR O/R 6 E PLUG HEX 0 RING E CONNECTOR O/R 12 E CONNECTOR 4 6 E ELBOW 90D W/NUT 6C6X S E ELBOW 90D W/NUT -12 E SCR HEX 5/16 18 X WSH FLT SAE 5/ SCR HEX 5/16-18 X NUT HEX NYL LOC 5/ SCR PAN PHIL LOC 5/16-18 X ELBOW ST 1/8X90 BR E ELBOW 90D W/NUT 4 E STRAP HYDRAULIC.RESERVOIR PLUG HEX 0 RING E FILLER CAP RE483B RESERVOIR WELDT IN-TANK OIL FILTER HYDRAULIC OIL FILTER ADAPTER 1/8 NPT SWITCH N.O. PRESSURE DUST BOOT

57 Hydraulic system 2 F103140B CONNECTOR 0 RING 4 E CONNECTOR O/R 12 E TEE RUN W/NUT E REDUCER E HEAD OIL FILTER FILTER HYDRAULIC OIL UNION STRAIGHT THREAD REDUCER W/O E TEE BRANCH O/R -8 E TEE E OIL COOLER ASSY DIESEL, SEE RADIATOR ASSEMBLY OIL COOLER ASSEMBLY PETROL/LPG/DUAL FUEL, SEE RADIATOR ASSEMBLY ELBOW 90D W/NUT 6C6X S E CONN EXT O/R -4 E00002 TSBUS TEE RUN W/NUT 4 E00009 TSBUS HOSE ASSY TSBUS731

58 Front wheel system F

59 Front wheel system F PIN COT.19 X NUT LUG M14X SCR HEX 1/2-20 X NUT CAS THNA SCR HEX THD/HD M8-1.25X20MM NUT HEX NYL LOC M8X TIRE ASSY FRONT TIRE 5.70/5.00-8N CUSHION TIRE ASSY TUBE CUSHION TIRE ASSY NON MARKING FOAM FILL FRONT TIRE ASSY FRONT HUB ASSY BRAKE ASSEMBLY WASHER ADAPTOR WASHER THICK HUB CAP WSH FLT SAE 1/2 6A STUD M14-1.5X35.5 6B HUB FRONT 6C BUSHING.75 X.56 X.29 6D BEARING BALL 7A SCR HEX 3/8-16 X B CAM 7D RING RET EXT..75DIA 7E BRAKE SHOE 7F SPRING BRAKE 7H NUT HEX NYL LOC 3/8-16 7I LEVER BRAKE Note: All quantities show n on this page reflect one Front Wheel System only, there are tw o Front Wheel Systems on the machine

60 Gasoline & Propane engine system F

61 Gasoline & Propane engine system F WSH FLT SAE 10 LPG WSH FLT SAE 3/8 LPG SCR HEX 3/8-16 X.88 LPG NUT HEX NYL LOC-THIN LPG NUT HEX NYL LOC 3/8-16 LPG SCR HEX THD FORM 1/4 20X.50 LPG SCR PANPHILTHD FORMBLK10-24X.5 LPG CLAMP HOSE SAE 12 E HOSE AIR INLET COVER FUEL OPENING LPG GASKET BULB LPG LP CLAMP ASSY LPG PLATE LP CLAMP LPG CLAMP HOSE SAE 32E HOSE FORMED-AIR LINKAGE ASSY PANEL REAR PETROL RADIATOR ASSEMBLY SEE PETROL AND LPG RADIATOR ASSEMBLY TUBE WELDMENT SCR HEX 5/16-18 X.75 PETROL NUT HEX NYL LOC 5/16-18 PETROL SCR HEX THD FORM 1/4-20X.75 PETROL SCR HEX THD FORM 1/4 20X.50 PETROL FUEL TANK GUARD WELDT PETROL AIR CLEANER ASSY POS SCR HEX 5/16 18 X WSH FLT SAE 5/ NUT HEX NYL LOC 5/ HOSE FLEXIBLE AIR INLET CLAMP HOSE SAE 32E BARB 5/16 X 1/8 E SERVICE INDICATOR RE442DA FILTER SAFETY FILTER PRIMARY CLEANER AIR BAND ASSY HOSE FUEL LINE E INLET HOOD ASSY. POS BARB 5/16 X 1/8 BR E SCR HEX 1/4-20 X NUT HEX NYL LOC 1/ HOOD INLET FLANGE WELDMENT

62 Gasoline & Propane engine system F CONDUIT LPG ONLY

63 Gasoline/Petrol & LPG engine system components F

64 Gasoline/Petrol & LPG engine system components F NUT HEX NYL LOC 5/ NUT HEX NYL LOC 3/ NUT HEX NYL LOC-THIN 1/ NUT HEX NYL LOC 1/ CLAMP HOSE SAE 24 E MOUNT ISOLATOR HOSE LOWER RADIATOR SCR HEX 1/4 20 X SCR HEX 5/16-18 X SCR HEX 3/8-16 X WSH FLT SAE 3/ SCR HEX LOC 3/8-16 X SCR HEX THD/HD M6 1.0 X 16MM LPG ONLY WSH FLT.453X1.000X WSH FLT.438 X 2.00 X OIL SWITCH ASSEMBLY POS FAN COOLING PUMP ASSY SEE HYDRAULIC SYSTEM ENGINE GM 1.6L PROPANE ENGINE GM 1.6L GAS ENGINE MOUNT WELDMENT TUBE WELDMENT SHEAVE FAN BELT FAN FAN SPACER ASSEMBLY MUFFLER CLAMP 1 5/8 E NUT HEX NYL LOC 1/ WSH FLT SAE 5/ SCR HEX 5/16 18 X SCR HEX 3/8-24 X SCR HEX LOC 1/4-20 X SCR PAN PHIL THD FORM 8-32X MUFFLER STUD MOUNT SILICON TAILPIPE EXHAUST PIPE WELDMENT HEATSHIELD HANGER MUFFLER REAR HANGER MUFFLER FRONT NUTPLATE SPARK ARRESTER VAPORIZER REGULATOR FUEL LOCKOFF VALVE

65 Gasoline/Petrol & LPG engine system components F BOSCH THROTTLE ACUATOR PROPANE MIXER COIL GM STARTER MOTOR GM 1.6L AFTER TSBUS SCR HEX 1/4-20 X HOSE 1/8 X 11.5 E CONNECTOR 0 RING 4 E ELBOW 45 DEG O/R 4 E SWITCH BLOCK SEAL WASHER COPPER ADAPTER BRASS SENDER PRESSURE ENGINE OIL PRESSURE SWITCH SEAL WASHER COPPER SCR HEX LOC M X20MM CLAMP HOSE SAE 10 E00047 LPG ONLY HOSE HEATER E00538 LPG ONLY GASKET EXHAUST 8A BARB HOSE E00039 LPG 8B PLUG BRASS E00040 PETROL

66 ENGINE REPLACEMENT PARTS F103147A 65 No Drawing For Part List

67 ENGINE REPLACEMENT PARTS F103147A THERMOSTAT 192 DEGREE OXYGEN SENSOR BOSCH THROTTLE ACTUATOR MAP SENSOR WIRE HARNESS ENGINE PLUG WIRE KIT SPARK PLUG COIL GM ALTERNATOR 70 AMP STARTER MOTOR GM 1.6L AFTER TSBUS CRANKSHAFT POSITION SENSOR TEMP SWITCH WATER PUMP OIL FILTER CARTRIDGE GASKET EXHAUST BELT ENGINE TIMING ENGINE OIL PRESSURE SWITCH PCV VALVE MUFFLER CAT/CON MUFFLER Note: Parts Not Show n

68 ENGINE SYSTEM COMPONENTS, PETROL ONLY F103147B 67 No Drawing For Part List

69 ENGINE SYSTEM COMPONENTS, PETROL ONLY F103147B FUEL INJECTOR FUEL PUMP PRESSURE REGULATOR PETROL FUEL FILTER Note: Parts Not Show n

70 ENGINE SYSTEM COMPONENTS, LPG ONLY F103147C 69 No Drawing For Part List

71 ENGINE SYSTEM COMPONENTS, LPG ONLY F103147C PROPANE MIXER VAPORIZER REGULATOR ECU LPG TRIM VALVE 90 DEGREE TRIM VALVE STRAIGHT VALVE-FUEL LOCKOFF LPG FUEL FILTER Note: Parts Not Show n

72 Gasoline/Petrol & LPG radiator assembly F

73 Gasoline/Petrol & LPG radiator assembly F RADIATOR ASSEMBLY POS NUT HEX NYL LOC 1/ NUT HEX NYL LOC-THIN 1/ NUT HEX NYL LOC 1/ HOSE FUEL LINE E SCR HEX 1/4-20 X WSH FLT.266X.750X SCR HEX THD FORM 1/4 20X OVERFLOW BOTTLE ASSY CLAMP CLAMP PLATE BACK PANEL ASSEMBLY POS PROP REST ROD SUPPORT OIL COOLER ASSEMBLY POS RADIATOR SHROUD ASSEMBLY POS CLAMP HOSE SAE 4 E SCR HEX 1/4 20 X NUT HEX NYL LOC 1/ NUT HEX NYL LOC-THIN SCR HEX THD FORM 1/4 20X SCR PANPHILTHD BLK 10-24X SCR PHIL THDFORM BLK1/4 20X LENS TAIL LIGHT GROMMET E BACK PANEL NUT HEX NYL LOC 5/ NUT HEX NYL LOC 1/ GASKET BULB GASKET BULB SCR HEX 1/4 20 X WSH FLT SAE 5/ SCR HEX 5/16-18 X COOLER OIL SWIVEL AXLE WELDMENT ROLLER TUBE ASSY GAS HOSE ASSY HOSE ASSY GRILL WELDMENT ROLLER STOP WELDMENT BAFFLE AIR

74 Gasoline/Petrol & LPG radiator assembly F ELBOW 90D 0/R E NUT HEX NYL LOC 5/ CLAMP HOSE SAE 24 E GASKET BULB HOSE RADIATOR E SCR HEX 1/4 20 X WSH FLT SAE 5/ SCR HEX 5/16-18 X RADIATOR RADIATOR MOUNT WELDMENT G/P RADIATOR SHROUD WELDMENT G/P HOSE RADIATOR BRACKET VAPORIZER SCR HEX LOC 1/4 20 X SCR HEX 5/16-18 X 1.00

75 Gasoline/Petrol fuel system F

76 Gasoline/Petrol fuel system F GASOLINE ASSY pos 1-13, CLAMP HOSE SAE 6 E FUEL TANK WELDT GASKET SENDER FUEL LEVEL RE437A CAP NON VENTED HOSE FUEL 30R SCR HEX THD FORM 10-24X HOSE CLAMP PRESSURE BARBED ELBOW FUEL LINE WIRE ASM PIGTAIL HOSE FUEL PRESSURE GASOLINE STRAINER-30 MICRON FUEL PUMP ASSEMBLY pos and ADAPTOR WELDMENT NUT HEX NYL LOC 5/ CLAMP HOSE SAE 6 E WSH FLT SAE 5/ SCR HEX 5/16-18 X SCR HEX THD FORM 1/4 20X FUEL FILTER HOSE ASSEMBLY pos CLAMP P BARBED ELBOW FUEL LINE FUEL PUMP BRACKET HOSE ASSEMBLY LP HOSE FUEL LINE E HOSE CLAMP PRESSURE COUPLER FUEL LINE HOSE FUEL PRESSURE HOSE CLAMP PRESSURE COUPLER FUEL LINE BARBED ELBOW FUEL LINE HOSE FUEL PRESSURE FUEL PUMP TUBE RUBBER.25X48 E FUEL FILTER KIT STRAIN RELIEF E00220

77 LPG fuel system F

78 LPG fuel system F PROPANE ASSY POS PIN LOCATOR CRADLE LP TANK L.P. TANK WSH FLT SAE 1/ SCR HEX THD FORM 1/4-20X FILTER ASSY POS NUT HEX JAM 7/ ELBOW ST 1/4X90 BR E COUPLER FEMALE CV140P SWITCH N C PRESSURE FITTING BULKHEAD HOSE 5/16 X 28.0 E ELBOW MALE 45 DEG E VENT 1/4 NPT CLAMP HOSE SUPPORT TEE ADAPTER SAE 45 DEGREE CONDUIT DUST BOOT HOSE 5/16 X 38.0 E ELBOW 90 DEG-4-6B E00034

79 Hopper system - 1 F

80 Hopper system - 1 F WSH FLT SAE 5/ SCR PAN PHIL X WSH FLT SAE 3/ WSH FLT SAE 1/ SCR HEX 1/4-20 X NUT HEX NYL LOC 5/ NUT HEX NYL LOC 1/ SCR HEX 5/16-18 X NUT HEX NYL LOC-THIN NUT HEX NYL LOC 3/ SCR HEX THD FORM 1/4-20X SCR PANPHILTHD FORMBLK10-24X SCR PAN PHIL THD FOM 10-24X SCR HEX THD FORM 1/4 20X SCR HEX THD FORM 10-24X SCR PANPHILTHD BLK 10-24X GASKET 1/16X1/2X120HC525F BUSHING.33X.50X1.3HA515A PLATE BOOT HINGE WLMT. HOPPER COVER BOOT HOPPER PLATE HINGE BUMPER SELF-ADHESIVE FILTER CLAMP WELDMT BRACKET HEADLIGHT GASKET LITTER DOOR LITTER DOOR WELDT HOPPER WELDT HOOD PROP WELDT STRAP INSIDE BLADE BLADE HOPPER FABRIC STRAP DUST SHIELD SHEILD DUST LENS AMBER PANEL ACCESS COVER GASKET LATCH LIFT AND TURN COVER HOPPER LATCH ASSY POS FOAM LATCH HEAD LAMP ASSY.

81 Hopper system - 1 F GROMMET E SCR HEX 1/4 20 X WSH FLT SAE 1/ NUT HEX NYL LOC 1/ SCR HEX LOC 1/4-20 X SCR HEX THD FORM 10-24X BRACKET LATCH LATCH LATCH PULL STRIKE LATCH TRIM RAW GRILLE WELDMENT SWITCH WATERPROOF AFTER SN BRACKET SWITCH AFTER SN SCR HEX X.38 AFTER SN

82 Hopper system - 2 F

83 Hopper system - 2 F WSH FLT SAE 1/ SCR HEX 1/2 13 X WSH FLT SAE 3/ NUT HEX NYL LOC SS 1/ NUT HEX NYL LOC-THIN 1/ SCR HEX LOC 3/8-16 X SCR SOC SET LOC 3/8-16 X SCR FLT PHIL 1/4-20 X RING RET EXT TYPE E NUT HEX NYL LOC 1/ SCR HEX THD FORM 1/4-20X SCR PAN PHIL THD FOM 10-24X SCR HEX THD FORM 1/4 20X NUT PUSH CAP 1/ PLUG PIPE 1/8 BRASS E NYLON BEARING BUSHING.50X.62X.41CT32G BEARING SLEEVE.627CV213FE BUMPER ROLLER PIN HOPPER PROP HINGE WELDMENT HINGE PIN WLMT. LEFT HINGE PIN WLMT. RIGHT STRAIN RELIEF STRAP SIDE BLADE STRAP SIDE BLADE COLLAR HOPPER HINGE BEARING SLEEVE BEARING SLEEVE ROD PULL GUIDE PULL ROD BLADE HOPPER FABRIC PANEL HOPPER RIGHT PANEL HOPPER LEFT SWITCH ACTUATOR ASSY POS HOPPER WELDT NUT HEX NYL LOC SS 1/ SCR HEX SS 1/4-20 X ANGLE DUMP DOOR BLADE DUMP DOOR DUMP DOOR ASSEMBLY TSBUS AND DUMP DOOR ASSEMBLY TSBUS

84 Hopper system - 2 F NUT HEX NYL LOC SS 1/ WSH FLT SAE SS 1/ SCR HEX SS 1/4-20 X SCR HEX SS 1/4-20 X ANGLE DUMP DOOR BLADE DUMP DOOR BLADE HOPPER NEOPRENE STRAP DUMP DOOR WELDT BUMPER 1.43 DIA. CV660N SCR HEX 1/4 20 X NUT HEX NYL LOC THIN WSH FLT SAE 1/ SCR HEX 5/16-18 X NUT HEX NYL LOC 5/ NUT HEX NYL LOC 1/ GROMMET.375 E BUSHING.25X.37X.21CR211H BRACKET LEVER WELDT ROD NUT BEARING FLANGE.312CV489M ROD END PLUG CAP E SCR HEX 3/8-16 X NUT HEX NYL LOC 3/ CONN.WR.PK.2 WAY FE STRAIN RELIEF E STRAP HORIZONTAL SEAL HORIZONTAL STRAP THRESHOLD SKIRT THRESHOLD FOAM FOAM FOAM

85 Linkage assembly F

86 Linkage assembly F LINKAGE ASSY SCR HEX 1/4 20 X SCR HEX 1/4-20 X 2.00 BEFORE SN WSH FLT SAE 5/ SCR SOC HD 1/4 20 X WSH FLT SAE 3/ SCR SOC SET LOC 5/16-18 X.25 BEFORE SN SCR HEX 3/8-16 X WSH FLT SAE 1/ SCR SOC SET LOC 1/4 20 X SCR HEX 3/8-16 X COLLAR SHAFT.750 CV31A BEFORE SN ARM WELDT PLATE CAM CABLE PUSH/PULL BRACKET WELDT HYDRO BACK CABLE CONTROL CLEVIS ASSEMBLY ROD END BEARING FLANGE BEFORE SN MOUNT NEUTRAL START SWITCH SEALED BALL SWITCH ASSY NEUTRAL START SWITCH INTERLOCK BRKT. WELDMENT USED AFTER SN CAM NYLON USED AFTER SN WASHER FENDER USED AFTER SN SCR HEX LOC 1/4 20 X 0.75 USED AFTER SN

87 Main broom system - 1 F

88 Main broom system - 1 F SCR HEX 1/4 20 X WSH FLT SAE 1/ SCR HEX 1/2 13 X SCR HEX 5/16 18 X WSH FLT SAE 3/ SCR HEX 1/4-20 X SCR HEX 5/16-18 X SCR HEX 3/8-16 X BROOM STOP WELDMENT SCR HEX 1/4-20 X SCR HEX 3/8-16 X SCR FLT PHIL 1/4-20 X NUT HEX NYL LOC 1/ NUT HEX NYL LOC 3/ NUT HEX NYL LOC-THIN 1/ NUT HEX NYL LOC 3/ SCR HEX GRD8 1/4-20 X WSH FLT SS.260X1.000X SCR HEX THD FORM 1/4 20X HANDLE ADJUSTABLE BUSHING.31X.50X.28HC18M BUSHING CA334D BEARING HEX FLANGE SPACER SHAFT BROOM ARM NUT WLMT SPACER SHAFT RIGHT HEX ARM WELDT ARM HEX BROOM IDLER HUB ASSY SEE MAIN BROOM SYSTEM LINK LIFT PLATE LEFT ACCESS BLADE HOPPER FABRIC LT SKIRT BROOM HOUSING DRIVE LUG ASSY SEE MAIN BROOM SYSTEM LIFT LEVER ASSY SEE MAIN BROOM SYSTEM BLOCK HEX CLAMP STRAP RIGHT BROOM HOUSING LIFT LINK WELDT GASKET STRIP LINK LIFT STOP BROOM BROOM ADJUSTER WELDT SUPPORT BLADE

89 Main broom system - 1 F STRAP BLADE BLADE BROOM HSG BLADE HOPPER PU BEARING SLEEVE.627RE450CE BROOM MAIN 4500PL OPTIONAL BROOM MAIN PROEX/WIRE 12 OPTIONAL BROOM MAIN POLY/WIRE 8 OPTIONAL BROOM MAIN PROEX 12 DOUBLE OPTIONAL BROOM MAIN NYLON 8 DOUBLE OPTIONAL BROOM MAIN PROEX 8 DOUBLE OPTIONAL BROOM PROEX/WIRE SCR HEX 3/8-16 X 2.50

90 Main broom system - 2 F

91 Main broom system - 2 F IDLER HUB ASSY POS DRIVE LUG ASSY POS LIFT LEVER ASSY POS LEVER WELDT LEVER WLDMT KNOB 1.62X5/16-18 CA BUSHING.31X.50X.28HC18M SCR HEX 5/16 18 X LEFT SIDE ARM WELDT NUT HEX NYL LOC 1/ HUB DRIVER RE WSH FLT BRASS.266X1.250X SCR HEX 1/4-20 X SCR HEX GRD8 1/4-20 X SCR HEX 1/2 13 X BROOM MOTOR SEAL GUARD WLMT WSH PLATED AR131C BEARING BALL.9843 RE470AG HUB-IDLER BUSHING 1.0X1.2X.78RE470AJ IDLER ARM WELDT SCR HEX LOC 5/16 18 X.75

92 Side broom system - 1 F

93 Side broom system - 1 F WSH FLT SAE 1/ WSH FLT SAE 5/ SCR HEX 5/16-18 X NUT HEX NYL LOC 5/ SCR HEX LOC 5/16 18 X SCR HEX 1/2-13 X SCR HEX LOC 5/16-18 X NUT HEX JAM 5/ BUSHING.31X.50X.28HC18M BEARING SLEEVE.627CV32DE STOP BROOM STOP BROOM HANDLE ADJUSTABLE SIDE BROOM LIFT LEVER ASSY SEE SIDE BROOM SYSTEM BUSHING.52 X.62 X LINKAGE LINKAGE SIDE BROOM ASSY SEE SIDE BROOM SYSTEM LEVER WELDT SWITCH WATERPROOF

94 Side broom system - 2 F

95 Side broom system - 2 F SIDE BROOM LIFT LEVER ASSY POS SIDE BROOM ASSY POS WSH FLT SAE 1/ WSH FLT SAE 5/ SCR HEX LOC 5/16 18 X SCR HEX 1/2-13 X BUSHING.31X.50X.28HC18M KNOB 1.62X5/16-18 CA BEARING SLEEVE.627CV32DE LEVER WELDT LEVER WELDT BUSHING.52 X.62 X SCR HEX 1/2 13 X WSH FLT SAE 1/ SCR HEX 1/2 13 X SCR HEX 3/8-16 X SCR HEX 3/8-16 X SCR HEX 5/16-18 X NUT HEX NYL LOC-THIN 1/ PIN SPRING 5/16 X WSH FLT.752/.756X1.250X NUT HEX JAM 5/ BEARING SLEEVE E BEARING SLEEVE.627CV32DE BUSHING CV32G THUMB NUT WELDT LOWER BRACKET SIDE BROOM RIGHT SIDE BROOM HUB ASSY SIDE BROOM ARM WELDT GUARD SIDE BROOM ARM SIDE BROOM LOWER BROOM SIDE NYLON OPTIONAL BROOM SIDE WIRE OPTIONAL BROOM SIDE H. DUTY MOTOR SIDE BROOM SIDE BROOM MOTOR ASSY ELBOW 90 DEG.O/R -8 E MOTOR BRACKET WELDT BRACKET SIDE BROOM UPPER BRACKET SIDE BROOM SIDE BROOM PIVOT WELDT CABLE SIDE BROOM SPRING COMP.73X1.75 E00453

96 Throttle pedal assembly F

97 Throttle pedal assembly F THROTTLE PEDAL ASSY SCR HEX 1/4 20 X NUT HEX NYL LOC 1/ BUSHING.25X.37X.34G31J PEDAL WELDT PEDAL WELDT BEARING FLANGE PIN COT HAIR.059 X PIN CLEVIS.250 X CLEVIS ASSEMBLY

98 Tilt steering assembly F

99 Tilt steering assembly F TILT STEERING ASSY SCR HEX 1/4 20 X SCR HEX 1/4 20 X WSH FLT SAE 5/ WSH FLT SAE 5/ SCR HEX 1/4-20 X WSH FLT SAE 1/ SCR HEX 5/16-18 X NUT HEX NYL LOC 5/ NUT HEX NYL LOC-THIN 1/ HEX NUT M16 X SCR SOC SET LOC 1/4-20X NUT HEX JAM 1/ NUT HEX NYL LOC 5/ BUSHING.31X.50X.28HC18M KNOB 1.62X5/16-18 CA SPRING EXT.62X2.50CA333G SPRING COM.91X3.37 E BUSHING.25X.37X.21CR211H STEERING BRACKET WELDT PAWL WELDT LEVER STEERING LOCK COVER STEERING HOSES COVER-STEERING WHEEL STEERING WHEEL SPRING BRACKET WELDT PLUG PLASTIC BEARING FLANGE.312CV489M LATCH ADJUSTABLE STEERING NUT HEX NYL LOC 1/ SCR HEX 1/4-20 X.75

100 Recommended spare parts F

101 Recommended spare parts F WEAR ITEM KIT SKIRT THRESHOLD SKIRT THRESHOLD BLADE DUMP DOOR GASKET GASKET LITTER DOOR FILTER PANEL ASSY SEAL HORIZONTAL BLADE HOPPER FABRIC BLADE HOPPER FABRIC SHEILD DUST BLADE HOPPER NEOPRENE BROOM PROEX/WIRE BROOM SIDE H. DUTY BLADE HOPPER FABRIC LT BLADE HOPPER FABRIC RT SKIRT BROOM HOUSING BLADE BROOM HSG BLADE HOPPER PU SKIRT LEFT DOOR BLADE FILTER SAFETY FILTER PRIMARY FUEL FILTER CARTRIDGE OIL FILTER SPIN ON OIL FILTER CARTRIDGE FUEL FILTER LPG FUEL FILTER FAN COOLING

102 Recommended spare parts F

103 Recommended spare parts F TIRE ASSY FRONT NUT LUG M14X TIRE ASSEMBLY REAR NUT LUG 1/ DOOR LATCH HYDRAULIC OIL FILTER FILTER HYDRAULIC OIL SEAL KIT SEAL KIT TRIPLE PUMP SEAL KIT SEAL KIT SEAL KIT SEAL KIT SEALED BALL SWITCH ASSY SWITCH WATERPROOF RELAY SPDT RELAY W/MTG BRACKET SWITCH FOR AG SWITCH ROCKER SWITCH ROCKER SWITCH WATERPROOF FUEL LOCKOFF VALVE THUMB NUT WELDT KEY IGNITION REPLACEMENT KEYS REPLACEMENT SET OF 2

104 Broom selector guide F

105 Broom selector guide F BROOM PROEX/WIRE BROOM MAIN PROEX/WIRE BROOM MAIN 4500PL BROOM MAIN NYLON 8 DOUBLE BROOM MAIN PROEX 12 DOUBLE BROOM MAIN PROEX 8 DOUBLE BROOM MAIN POLY/WIRE BROOM SIDE H. DUTY BROOM SIDE NYLON BROOM SIDE WIRE

106 OPTIONS AND ACCESSORIES F10315A 105