Hustler Raptor SD CE Parts Manual

Transcription

1 Hustler Raptor SD CE Parts Manual

2 Contents General Information 1 Frame, Fenders, Instrument Panel & Engine Guard Section Frame 3-1 Fenders & Instrument Panel 3-2 Guards 3-3 Transmission & Steering Section Hydraulic System 4-1 Transmission Assembly (Multi-Page) 4-2 Transmission Service Parts - Right Side 4-3 Transmission Service Parts - Left Side 4-4 Steering & Brake 4-5 Steering Cover Assembly 4-6 Wheels & Tires Section Wheel & Tire 5-1 Front Tire Breakdown 5-2 Drive Wheel Breakdown 5-3 Engine & Fuel Tank Section Engine - S/N & Higher (Multi-Page) 6-1 Engine - S/N Prior to (Multi-Page) 6-2 Engine Service Parts 6-3 Fuel System 6-4 Electrical Section Battery 7-1 Deck Section Service Deck 8-1 Deck Pulleys & Spindles - S/N & Higher 8-2 Deck Pulleys & Spindles - S/N Prior to Deck 8-4 Deck Lift (Multi-Page) 8-5 Seat Section Seat 9-1 Seat Service Parts 9-2 Appendix B:Parts Index B Appendix A:Pages Index A

3

4

5 Frame, Fenders, Instrument Panel & Engine Guard Section Frame Frame Thu Feb 25 03:27:59 MST

6 Frame Item Part No. Name Qty Uom SEAT SUPPORT, RSD 1 EA SPRING SUPPORT, RSD 1 EA CS X0.750FLK 6 EA CS x.75 HXFLK PLN 30 EA BRACKET, RS REAR 1 EA DECAL, HOT 1 EA SERVICE, BUMPER 1 EA CS X1.000 HXFLK 4 EA SVC, ENGINE PLATE 1 EA NT HXFLK PLN 30 EA DECAL, ENGINE COMPART 1 EA BRACKET, LS REAR 1 EA CN X.150 MAX THK 5 EA HYDRO BRACKET 2 EA SVC, RS FRM CHNL 1 EA RS FRONT BRACKET 2 EA SVC, CROSS SUPPORT 2 EA NT FLKG5 10 EA SVC, LS FRAME CHANNEL 1 EA 20 N/A SERIAL NUMBER / SPEC DECAL 1 EA FRONT CROSS FRAME W/A 1 EA FAIRING 2 EA SVC, FOOT PAN 1 EA DECAL, SAFE OPERATE-GRAY 1 EA DECAL, LEVEL FUEL BLOWM 1 EA MOUNT, PUSH BUTTON 6 EA WIRE TIE, SMALL/SHORT 6 EA BATTERY TRAY 1 EA DECAL, CE MARK 1 EA CE DBA LIMIT DECAL 1 EA Frame Thu Feb 25 03:27:59 MST

7 Frame Comments for Page: Frame on May 1, Serial number decal. In the event the serial number decal becomes damaged or illegible, please contact your dealer to order a replacement. 2. Torque all the hardware to a minimum of 45 N m. 3. Bumper (552217), engine plate (551858), LS frame channel (551868) and foot pan (551865) include decals. 4. The fuel fill level decal (605782) was located on the seat pan. Frame Thu Feb 25 03:27:59 MST

8 Frame, Fenders, Instrument Panel & Engine Guard Section Fenders & Instrument Panel Fenders & Instrument Panel Thu Feb 25 03:28:01 MST

9 Fenders & Instrument Panel Item Part No. Name Qty Uom CABLE, CHOKE 1 EA SWITCH, PTO EA HOUR METER 1 EA KEY ASSEMBLY 1 EA SERVICE, INSTR PANEL 1 EA DECAL, INSTRUMENT PANEL 1 EA IGNITION SWITCH 1 EA CS X0.750HXG5 1 EA CB X.500 ZYNC 2 EA FW 0.219X0.500X EA NT #10-24 HX NL ZN 2 EA CABLE, THROTTLE 1 EA CS X.75 HX FLG 8 EA SVC, FENDER RS 1 EA SVC, FENDER LS 1 EA CN X.150 MAX THK 1 EA SVC, FOOTREST 1 EA DECAL, HUSTLER ID 1 EA CS X0.750FLK 2 EA NT FLKG5 2 EA WIRE TIE, SMALL/SHORT 2 EA DECAL, RAPTOR FENDER 2 EA WIRE HARNESS 1 EA KIT, CLUTCH CONN. REP. 1 EA Fenders & Instrument Panel Thu Feb 25 03:28:01 MST

10 Frame, Fenders, Instrument Panel & Engine Guard Section Guards Guards Thu Feb 25 03:28:02 MST

11 Guards Item Part No. Name Qty Uom SERVICE GUARD 1 EA DECAL, NO SERVICE 2 EA CS X0.750HXG5 4 EA FW 0.281SAE 4 EA CN X.150 MAX THK 4 EA PULLEY GUARD 1 EA GUARD, TRANS. SIDE, CE 2 EA GUARD, RAPTOR CLUTCH, CE 1 EA Comments for Page: Guards jmumford@excelii.com on May 1, Part of the Frame Assembly. 2. Part of the Transmission Assembly. 3. Part of the Deck Lift Assembly. Guards Thu Feb 25 03:28:02 MST

12 Transmission & Steering Section Hydraulic System Hydraulic System Thu Feb 25 03:28:05 MST

13 Hydraulic System Item Part No. Name Qty Uom CS X2.500HXG5 4 EA CB X 2.75 STD ZN 1 EA CS X3.000HXG5 4 EA NT FLKG5 3 EA BELT, DRIVE 1 EA SPACER, IDLER 1 EA IDLER ARM 1 EA FW 0.406X1.250X EA NT NLG5 2 EA CS X1.500HXG5 1 EA FW x x EA PULLEY, 2.0" IDLER 1 EA NT HXG5 1 EA SPRING, 3.00 X.50 EXT 1 EA CS X 2.50 FULTH 1 EA HP0.080X EA LINK, TOW VALVE 2 EA FW 0.343SAE 16 EA NT NLG5 8 EA CS X0.750FLK 1 EA 21 N/A TRANSMISSION ASSEMBLY 1 EA Comments for Page: Hydraulic System jmumford@excelii.com on May 1, Torque to 23 N m. Hydraulic System Thu Feb 25 03:28:05 MST

14 Transmission & Steering Section Transmission Assembly (Multi-Page) Transmission Assembly (Multi-Page) Thu Feb 25 03:28:07 MST

15 Transmission Assembly (Multi-Page) Item Part No. Name Qty Uom NT NLG5 2 EA FW 0.343SAE 6 EA OVERTRAVEL SPRING 2 EA SPRING, BRAKE ARM RET. 2 EA ROD, BRAKE ACTUATOR 2 EA FTG, 90-9/16 SAE 2 EA ZT2800, 20.69:1 LH TRANS 1 EA CS X2.250HXG5 2 EA FW x x EA SPRING CLAMP,.75" DIA 4 EA HOSE, 1/2" LOW PRESSURE 19" FT HOSE, 1/2" LOW PRESSURE 28" FT WIRE TIE, SMALL/SHORT 2 EA NT NLG5 2 EA CROSS BRACE, RSD 1 EA ZT2800, 20.69:1 RH TRANS 1 EA CS X0.750HXG5 2 EA BRAKE SPRING LINK, LS 1 EA NT FLKG5 2 EA BRAKE SPRING LINK, RS 1 EA NT HXZY NL 2 EA FW 0.281SAE 4 EA EXPANSION TANK MNT 1 EA EXPANSION TANK, ZT EA CS X0.750HXG5 2 EA CAP, OVERFLOW TANK 1 EA Transmission Assembly (Multi-Page) Thu Feb 25 03:28:07 MST

16 Transmission Assembly (Multi-Page) Transmission Assembly (Multi-Page) Thu Feb 25 03:28:07 MST

17 Transmission & Steering Section Transmission Service Parts - Right Side Transmission Service Parts - Right Side Thu Feb 25 03:28:08 MST

18 Transmission Service Parts - Right Side Item Part No. Name Qty Uom HG RTN CW 1 EA HG RTN SPRING 1 EA FAN / PULLEY KIT 1 EA GUARD, FILTER, LH 1 EA FILTER, OIL 1 EA KIT, HUB, 4 BOLT 1 EA ZT2800 BRAKE ARM EA CLIP, RETAINING 1 EA Comments for Page: Transmission Service Parts - Right Side jmumford@excelii.com on May 1, LS filter guard (600975) includes hardware. 2. Hub kit (600970) includes the hub nut. Transmission Service Parts - Right Side Thu Feb 25 03:28:08 MST

19 Transmission & Steering Section Transmission Service Parts - Left Side Transmission Service Parts - Left Side Thu Feb 25 03:28:10 MST

20 Transmission Service Parts - Left Side Item Part No. Name Qty Uom FAN / PULLEY KIT 1 EA KIT, HUB, 4 BOLT 1 EA HG RTN CCW 1 EA HG RTN SPRING 1 EA FILTER, OIL 1 EA GUARD, FILTER, RH 1 EA ZT2800 BRAKE ARM EA CLIP, RETAINING 1 EA Comments for Page: Transmission Service Parts - Left Side jmumford@excelii.com on Oct 28, The LS filter guard kit (600975) includes the bolts. 2. The hub kit (600970) includes the hub nut. Transmission Service Parts - Left Side Thu Feb 25 03:28:10 MST

21 Transmission & Steering Section Steering & Brake Steering & Brake Thu Feb 25 03:28:12 MST

22 Steering & Brake Item Part No. Name Qty Uom DAMPER 2 EA BALL STUD, DAMPER 4 EA FW 0.343SAE 6 EA NT NLG5 2 EA CN x.200 MAX THK 2 EA SB0.312X0.750SH EA YOKE, 5/ EA NT HX ZNYC 6 EA ROD, STEERING 2 EA FW 0.281SAE 2 EA NT HXZY NL 2 EA STEERING BAR W/ GRIP 2 EA Not Shown GRIP, STEERING BAR 1 EA NT HXG5 4 EA FW x x EA CS X1.500HXG5 4 EA CS X0.750FLK 7 EA NT FLKG5 7 EA NT HXG5 2 EA BLOCK, STEERING CONTROL 2 EA CLIP E.66 X.303 X EA 21 N/A STEERING COVER ASSEMBLY 1 EA Steering & Brake Thu Feb 25 03:28:12 MST

23 Transmission & Steering Section Steering Cover Assembly Steering Cover Assembly Thu Feb 25 03:28:15 MST

24 Steering Cover Assembly Item Part No. Name Qty Uom CS x2.00 HX FLTHD 2 EA FW 0.281SAE 4 EA STOP, STEERING 2 EA CS X0.750HXG5 2 EA NUT PLATE,.420 CENTERS 2 EA SWITCH, PUSH BUTTON 2 EA NT NLG5 3 EA SVC, STEERING S/A 1 EA CS X4.250HXG5 2 EA SPACER, STEERING 2 EA STEERING BOX SUB, LH 1 EA Not Shown STEERING BOX SUB, LH 1 EA FW 0.343SAE 8 EA NT NLG5 4 EA BRAKE LINK 2 EA BUSHING,IGUS#0608 (FS) 4 EA BRAKE BLCRNK, LH 1 EA NT NLG5 2 EA CS#10-24X0.750FLKG5 4 EA CS X3.500HXG5 2 EA STEERING BOX SUB, RH 1 EA Not Shown STEERING BOX SUB, RH 1 EA BRAKE BLCRNK, RH 1 EA TRANSPORT LATCH 1 EA FW x x EA CS X0.750FLK 1 EA SERVICE, INDICATOR PANEL 1 EA DECAL, DECK HEIGHT 1 EA CS X2.250HXG5 1 EA NT FLKG5 1 EA Steering Cover Assembly Thu Feb 25 03:28:15 MST

25 Steering Cover Assembly Steering Cover Assembly Thu Feb 25 03:28:16 MST

26 Steering Cover Assembly Item Part No. Name Qty Uom DECAL, STEERING R.S. 1 EA DECAL, ID RSD 1 EA DECAL, STEERING L.S. 1 EA BUSHING, UHMW 4 EA Comments for Page: Steering Cover Assembly jmumford@excelii.com on May 1, and are used on mowers S/N & higher and are used on mowers S/N prior to Steering cover (552415) includes decals. 3. Indicator (552177) includes the decal (604819). Steering Cover Assembly Thu Feb 25 03:28:16 MST

27 Wheels & Tires Section Wheel & Tire Wheel & Tire Thu Feb 25 03:28:18 MST

28 Wheel & Tire Item Part No. Name Qty Uom TIRE/WHEEL ASSY 20x EA WHEEL NUT 8 EA CS X1.250HSG5 2 EA FW.510X 2.15X.187 SPL 2 EA FW 0.531X1.375X EA BEARING 4 EA SPACER 2 EA 8 N/A TIRE/WHEEL ASSEMBLY 1 EA Comments for Page: Wheel & Tire jmumford@excelii.com on May 1, Torque to N m. Wheel & Tire Thu Feb 25 03:28:18 MST

29 Wheels & Tires Section Front Tire Breakdown Front Tire Breakdown Thu Feb 25 03:28:19 MST

30 Front Tire Breakdown Item Part No. Name Qty Uom FORK W/A, 13X5 1 EA NT HX ZY NL GR B 1 EA FW.760X1.625X EA CS X8.000HXG5 1 EA TIRE/WHEEL ASSY 13X EA TIRE 13X5.0-6 SMOOTH 1 EA WHEEL BEARING 2 EA WHEEL 1 EA TIRE VALVE TR-412 GOODY 1 EA Front Tire Breakdown Thu Feb 25 03:28:19 MST

31 Wheels & Tires Section Drive Wheel Breakdown Drive Wheel Breakdown Thu Feb 25 03:28:20 MST

32 Drive Wheel Breakdown Item Part No. Name Qty Uom TIRE 20X EA WHEEL 10X7 RIM, 4-4 BC 1 EA TIRE VALVE TR-412 GOODY 1 EA Drive Wheel Breakdown Thu Feb 25 03:28:20 MST

33 Engine & Fuel Tank Section Engine - S/N & Higher (Multi-Page) Engine - S/N & Higher (Multi-Page) Thu Feb 25 03:28:24 MST

34 Engine - S/N & Higher (Multi-Page) Item Part No. Name Qty Uom 1 ENGINE, KAW FR691V 1 EA Not Shown N/A KAWASAKI FR730V ENGINE 1 EA HOSE, OIL DRAIN 12" FT MUFFLER, FR730V 1 EA NT FLKG5 1 EA CLUTCH ANCHOR 1 EA FW x x EA CS x1.25 HXG8 P85 4 EA CS X1.000HXG5 1 EA WIRE TIE, SMALL/SHORT 4 EA KEY 1/4 SQ X 0.66 LG(FS) 1 EA PULLEY, ENG OP 1 EA K CLUTCH KIT, EA FW.453X 1.12X.119 HRD 1 EA CS X3.25 HXG5 P85 1 EA BUSHING, CLUTCH 1 EA HARNESS, CLUTCH PIGTAIL 1 EA Comments for Part Num parts@excelii.com on Aug 28, 2015 Pigtail was updated with epoxy to hold the wires steady. The wire sheath was also updated to a more flexible material LW0.325INTEXT 1 EA CS M8-1.25X16HX FL EA CS X0.750HXG5 2 EA FW 0.281SAE 4 EA STARTER SOLENOID HW KIT 1 EA NT #10-32HXG5 1 EA NT HXG5 2 EA CLIP, HOSE CLAMP 2 EA FUEL LINE, 1/4" 18" FT Engine - S/N & Higher (Multi-Page) Thu Feb 25 03:28:24 MST

35 Engine - S/N & Higher (Multi-Page) Engine - S/N & Higher (Multi-Page) Thu Feb 25 03:28:24 MST

36 Engine - S/N & Higher (Multi-Page) Item Part No. Name Qty Uom VAPOR LINE, 3/16 FORMED 1 EA Comments for Page: Engine - S/N & Higher (Multi-Page) tmenadue@excelii.com on May 1, 2015 FUEL LINE LENGTHS Flag A: 46 cm TANK TO FUEL FILTER (FUEL) 1. Supplied with the engine. 2. Torque to N m. Replace (do not reuse) the cap screw if it is removed or loosened. Use only hand tools to install this fastener. 3. Torque to N m. Replace (do not reuse) the cap screw if it is removed or loosened. Use only hand tools to install this fastener. 4. Torque to 30 N m. 5. Part of the fuel system. 6. Part of the wire harness. Engine - S/N & Higher (Multi-Page) Thu Feb 25 03:28:25 MST

37 Engine & Fuel Tank Section Engine - S/N Prior to (Multi-Page) Engine - S/N Prior to (Multi-Page) Thu Feb 25 03:28:27 MST

38 Engine - S/N Prior to (Multi-Page) Item Part No. Name Qty Uom 1 ENGINE, KAW FR691V 1 EA O-RING 1 EA VALVE, OIL DRAIN 1 EA HOSE, OIL DRAIN 30 cm FT MUFFLER, FR730V 1 EA NT FLKG5 1 EA CLUTCH ANCHOR 1 EA FW x x EA CS X1.000HXG5 1 EA CS x1.25 HXG8 P85 4 EA WIRE TIE, SMALL/SHORT 4 EA PULLEY, PUMP STUB SHAFT 1 EA K CLUTCH KIT, RSD 1 EA FW.453X 1.12X.119 HRD 1 EA CS X4.75 HXG5 P85 1 EA HARNESS, CLUTCH PIGTAIL 1 EA Comments for Part Num parts@excelii.com on Aug 28, 2015 Pigtail was updated with epoxy to hold the wires steady. The wire sheath was also updated to a more flexible material CS X0.750HXG5 2 EA FW 0.281SAE 4 EA NT #10-32HXG5 1 EA STARTER SOLENOID HW KIT 1 EA NT HXG5 2 EA LW0.325INTEXT 1 EA CS M8-1.25X16HX FL EA CLIP, HOSE CLAMP 2 EA FUEL LINE, 1/4" 46 cm FT VAPOR LINE, 3/16 FORMED 1 EA Engine - S/N Prior to (Multi-Page) Thu Feb 25 03:28:27 MST

39 Engine - S/N Prior to (Multi-Page) Engine - S/N Prior to (Multi-Page) Thu Feb 25 03:28:28 MST

40 Engine - S/N Prior to (Multi-Page) Comments for Page: Engine - S/N Prior to (Multi-Page) jmumford@excelii.com on Nov 5, 2015 FUEL LINE LENGTHS Flag A: 46 cm TANK TO FUEL FILTER (FUEL) 1. Supplied with the engine. 2. Torque to N m. Replace (do not reuse) the cap screw if it is removed or loosened. Use only hand tools to install this fastener. 3. Torque to N m. Replace (do not reuse) the cap screw if it is removed or loosened. Use only hand tools to install this fastener. 4. Torque to 30 N m. 5. Part of the fuel system. 6. Part of the wire harness. Engine - S/N Prior to (Multi-Page) Thu Feb 25 03:28:28 MST

41 Engine & Fuel Tank Section Engine Service Parts Engine Service Parts Thu Feb 25 03:28:29 MST

42 Engine Service Parts Item Part No. Name Qty Uom AIR FILTER, KAW W/CLAMP 1 EA OIL FILTER, KAW ENG. 1 EA FUEL FILTER IN-LINE 1 EA Engine Service Parts Thu Feb 25 03:28:29 MST

43 Engine & Fuel Tank Section Fuel System Fuel System Thu Feb 25 03:28:31 MST

44 Fuel System Item Part No. Name Qty Uom ASSEMBLY. FUEL TANK 1 EA Comments for Part Num parts@excelii.com on Jul 7, 2015 FUEL TANK HAS NO SERVICEABLE PARTS. MUST ORDER COMPLETE FUEL TANK. Not Shown ASSEMBLY, FUEL TANK 1 EA Comments for Part Num parts@excelii.com on Feb 11, 2015 FUEL TANK HAS NO SERVICEABLE PARTS. MUST ORDER COMPLETE FUEL TANK CAP, 3.5" RATCHETING GAS 1 EA TANK MNT LEFT 1 EA TANK MNT RIGHT 1 EA SEAL 3/8x3/4 SOLD BY FT 47 cm FT CS X0.750HXG5 3 EA FW 0.281SAE 3 EA VAPOR LINE, 3/16 FORMED 1 EA /4" HOSE BARB CROSS 1 EA VAPOR LINE, 3/16 FORMED 1 EA BOOT, 3/16" TO 1/4" BARB 1 EA FILTER, VAPOR SYSTEM 1 EA WIRE TIE, SMALL/SHORT 2 EA MOUNT, PUSH BUTTON 2 EA WEATHERSTRIP.12X cm FT GM.63 x1.13 x.88 x.13 1 EA Fuel System Thu Feb 25 03:28:31 MST

45 Electrical Section Battery Battery Thu Feb 25 03:28:33 MST

46 Battery Item Part No. Name Qty Uom STRAP, TIE DOWN 1 EA CS x 7.50 HX G5 2 EA FW 0.281SAE 2 EA BATTERY CBL BOOT-RED(FS) 1 EA NT HXG5 2 EA LW0.250INTEXT 4 EA CS X0.750HXG5 2 EA WIRE TIE, SMALL/SHORT 2 EA CN X.150 MAX THK 2 EA Comments for Page: Battery jmumford@excelii.com on May 1, When performing service on the mower, disconnect the negative battery cable and do not reconnect it to the battery until ready to start the engine. Battery Thu Feb 25 03:28:33 MST

47 Deck Section Service Deck Service Deck Thu Feb 25 03:28:35 MST

48 Service Deck Item Part No. Name Qty Uom SVC DECK DECAL 48" RSD 1 EA DECAL, DISCHARGE CHUTE 1 EA DECAL, DECK DANGERS 1 EA DECAL,48"DECK ID 1 EA DECAL, DANGER / OBJECTS 1 EA Comments for Page: Service Deck jmumford@excelii.com on Nov 9, The deck includes decals. Service Deck Thu Feb 25 03:28:36 MST

49 Deck Section Deck Pulleys & Spindles - S/N & Higher Deck Pulleys & Spindles - S/N & Higher Thu Feb 25 03:28:38 MST

50 Deck Pulleys & Spindles - S/N & Higher Item Part No. Name Qty Uom NT NLG5 3 EA FW.531 x x EA IDLER PULLEY, 4.00" FLAT 1 EA NT HXNL JAM G2ZN 5 EA FW.340 X.675 X.035 ZN 4 EA ANCHOR, SPRING TENSIONER 2 EA SPRING 1 EA SLED, IDLER 1 EA IDLER SLIDE, EXTRUDED 2 EA CB X 2.00 STD ZN 1 EA CS X1.250HSG5 3 EA FW.515X1.65X.125 HD ZY 3 EA SPACER, SPINDLE PULLEY 6 EA PULLEY, DECK DRIVE B-SEC 3 EA NT HXG5 12 EA FW x x EA PULLEY, IDLER 5.00" O.D. 1 EA IDLER PULLEY, 4.00" FLAT 1 EA FW.440X1.000X EA SPINDLE ASSEMBLY 3 EA CS X EA CB X.620 G5 ZN 5 EA FW.531 x 2.25 x.25 ZNY 2 EA CS X2.750HXG5 2 EA Comments for Page: Deck Pulleys & Spindles - S/N & Higher jmumford@excelii.com on May 1, Torque to 99 N m. 2. Torque to 40 N m. Deck Pulleys & Spindles - S/N & Higher Thu Feb 25 03:28:38 MST

51 Deck Pulleys & Spindles - S/N Prior to Deck Section Deck Pulleys & Spindles - S/N Prior to Thu Feb 25 03:28:41 MST

52 Deck Pulleys & Spindles - S/N Prior to Item Part No. Name Qty Uom NT NLG5 3 EA BELT GUIDE 1 EA FW.531 x x EA IDLER PULLEY, 4.00" FLAT 1 EA NT HXNL JAM G2ZN 5 EA FW.340 X.675 X.035 ZN 4 EA ANCHOR, SPRING TENSIONER 2 EA IDLER SPRING 1 EA SLED, IDLER 1 EA IDLER SLIDE, EXTRUDED 2 EA CB X 2.00 STD ZN 1 EA CS X1.250HSG5 3 EA FW.515X1.65X.125 HD ZY 3 EA SPACER, SPINDLE PULLEY 6 EA PULLEY, DECK DRIVE B-SEC 3 EA NT HXG5 12 EA FW x x EA PULLEY, IDLER 5.00" O.D. 1 EA IDLER PULLEY, 4.00" FLAT 1 EA SPINDLE ASSEMBLY 3 EA CS X EA CB X.620 G5 ZN 5 EA FW.531 x 2.25 x.25 ZNY 2 EA CS X2.750HXG5 2 EA FW.440X1.000X EA Comments for Page: Deck Pulleys & Spindles - S/N Prior to jmumford@excelii.com on May 1, Torque to 99 N m. 2. Torque to 40 N m. Deck Pulleys & Spindles - S/N Prior to Thu Feb 25 03:28:41 MST

53 Deck Section Deck Deck Thu Feb 25 03:28:44 MST

54 Deck Item Part No. Name Qty Uom SVC PULLEY COVER 2 EA Not Shown Not Shown SVC PULLEY COVER CE LS 2 EA SVC PULLEY COVER CE RS 2 EA CS X.75 HX FLG 4 EA DECAL, NO SERVICE 2 EA BELT, B-SECTION 1 EA DISCHARGE CHUTE 1 EA PIN, DISCHARGE CHUTE 1 EA CHUTE SPRING 1 EA NT NLG5 1 EA PIN, PULLER 2 EA HP.125 X2.375 ZN 2 EA PULLER, RS 1 EA PULLER, LS 1 EA NT NLG5 3 EA FW.531 x x EA WHEEL ASSY, ANTI SCALP 3 EA BLADE, 16.50"-L-F-CW 3 EA Not Shown Not Shown Not Shown BLADE, F16.50"-H-F-CW 3 EA BLADE, 16.50"-GAT-F-CW 3 EA BLADE, 16.50"-CAT-F-CW 3 EA CW.678 X X EA CS X1.250HXG5 3 EA CS X4.250HXG5 1 EA ANTI-SCALP WHEEL 1 EA NT JAMG5 1 EA Comments for Page: Deck jmumford@excelii.com on May 1, 2015 Deck Thu Feb 25 03:28:44 MST

55 1. Torque to 160 N m. 2. Torque to 11 N m on these 4 self-tapping screws. 3. Do not torque; the discharge chute must pivot freely. 4. Mowers with serial numbers prior to require kit , which includes drill templates and (1) pulley cover Pulley covers include decals. Deck Deck Thu Feb 25 03:28:44 MST

56 Deck Section Deck Lift (Multi-Page) Deck Lift (Multi-Page) Thu Feb 25 03:28:47 MST

57 Deck Lift (Multi-Page) Item Part No. Name Qty Uom PIN, INDICATOR 1 EA NT FLKG5 8 EA DECK LIFT W/A, REAR 1 EA NT HXG5 2 EA FW x x EA PIVOT SPACER BUSHING 2 EA LIFT PEDAL, LINK 1 EA CS X1.12 HX G5 Z 1 EA NT NLG5 4 EA FW.41X.94X.25 UHMW 4 EA CLIP E,.625x.480x.042 Z 8 EA PIVOT, DECK LIFT 4 EA LINK, DECK LIFT 4 EA CE.375 x 2.00 W/BALE 4 EA PIVOT BLOCK, DECK LIFT 4 EA CS X0.750FLK 8 EA CS X1.000HXG5 1 EA DECK LIFT W/A, FRONT 1 EA PIVOT SPACER BUSHING 2 EA FW.531 x x EA NT NLG5 2 EA CS X1.500 HX G5 2 EA Deck Lift (Multi-Page) Thu Feb 25 03:28:47 MST

58 Hustler Raptor SD CE Parts Manual Deck Lift (Multi-Page) Deck Lift (Multi-Page) Thu Feb 25 03:28:48 MST

59 Seat Section Seat Seat Thu Feb 25 03:28:51 MST

60 Seat Item Part No. Name Qty Uom SEAT, MICHIGAN STANDARD 1 EA SVC, SEAT PAN 1 EA MOUNT, PUSH BUTTON 1 EA WIRE TIE, SMALL/SHORT 1 EA NT NLG5 2 EA FW 0.343SAE 4 EA CS X1.250HXG5 4 EA CS X0.750FLK 2 EA SPRING,COMP 1.25X4.00X. 2 EA NT FLKG5 2 EA CS X1.000HXG5 2 EA DECAL, BELT ROUTING 1 EA DECAL, BATTERY WARNINGS 1 EA FW 0.406X1.000X0.120HD 2 EA Comments for Page: Seat jmumford@excelii.com on May 1, Do not torque; the seat pan must pivot freely. 2. Torque to 9.5 N m. 3. When replacing the seat pan, order (2) washers, (item 14). 4. Seat pan (552751) includes decals. Seat Thu Feb 25 03:28:51 MST

61 Seat Section Seat Service Parts Seat Service Parts Thu Feb 25 03:28:52 MST

62 Seat Service Parts Item Part No. Name Qty Uom SWITCH, SEAT 1 EA EXT. ARMREST KIT R.H. 1 EA EXT. ARMREST KIT L.H. 1 EA ARMREST,STOP ASSY 2 EA Seat Service Parts Thu Feb 25 03:28:52 MST

63 Appendix B:Parts Index , , 3-2, 4-2, 6-1, 6-2, 6-4, 7-1, , , , 3-2, 4-1, 4-5, 4-6, 6-1, 6-2, 8-5, , , , 6-2, , 3-2, 4-1, 4-5, 4-6, 8-5, , , , 6-2, 8-5, , , 4-5, 8-2, 8-3, , 3-3, 4-2, 4-2, 4-6, 6-1, 6-2, 6-4, , , 4-2, 4-5, , , , , 4-2, 4-6, 8-4, 8-5, Thu Feb 25 03:28:53 MST 2016 B-1

64 , , , , , , 3-2, 3-3, , , , , , , , 6-2 Thu Feb 25 03:28:53 MST 2016 B-2

65 , , , , , , , , , , 6-4, , , , , K , , K Thu Feb 25 03:28:53 MST 2016 B-3

66 , 8-2, , , , 4-2, 4-5, 4-6, 6-1, 6-2, 8-2, 8-3, , 8-3, 8-4, , 4-2, 4-5, 4-6, 6-1, 6-2, 6-4, , 4-2, 4-5, 4-6, , 8-2, 8-3, 8-4, , , CE , , 8-3 Thu Feb 25 03:28:53 MST 2016 B-4

67 Appendix A:Pages Index Battery 7-1 Deck 8-4 Deck Lift (Multi-Page) 8-5 Deck Pulleys & Spindles - S/N & Higher 8-2 Deck Pulleys & Spindles - S/N Prior to Drive Wheel Breakdown 5-3 Engine - S/N & Higher (Multi-Page) 6-1 Engine - S/N Prior to (Multi-Page) 6-2 Engine Service Parts 6-3 Fenders & Instrument Panel 3-2 Frame 3-1 Front Tire Breakdown 5-2 Fuel System 6-4 General Information 1 Guards 3-3 Hydraulic System 4-1 Seat 9-1 Seat Service Parts 9-2 Service Deck 8-1 Steering & Brake 4-5 Steering Cover Assembly 4-6 Transmission Assembly (Multi-Page) 4-2 Transmission Service Parts - Left Side 4-4 Transmission Service Parts - Right Side 4-3 Wheel & Tire 5-1 Thu Feb 25 03:28:53 MST 2016 A-1