BATTERY CHARGERS HIGH FREQUENCY HIGH FREQUENCY CHARGERS. 0,5 4 36kW THE ELECTRONIC CHARGER OF THE FUTURE FOR ALL TYPES OF BATTERIES!

Transcription

1 BATTERY CHARGERS HIGH FREQENCY CHARGERS THE ELECTRONIC CHARGER OF THE FTRE FOR ALL TYPES OF BATTERIES! HIGH FREQENCY 0,5 4 36kW Characerisics High frequency All Zivan high frequency chargers work in accordance wih he principle of SMPS (Swiching Mode Power Supply) Principle: he 220 vol AC or 3 x 380V.AC of he nework comes o an EMI filer. The filer is locaed behind he diode bridge. The mains volage is recified and hen sufficienly smoohed (= AC / DC conversion). This high DC volage arrives a he primary side of he ransformer. The ransformer for is par is swiched by one or more mosfe(s) or power ransisor(s). A he gae or base of he power componens, a pulse-couning signal (PWM = Pulse Widh Modulaion) arrives. This PWM signal causes he cuing of he high inpu volage wih a high frequency. The PWM signal is supplied by he conrol sage which is on is par conrolled by he conrol logic, which ges he informaion a he baery side. By swiching he power componen on he primary side of he ransformer, here s a pulse shaped signal a he secondary side, which is recified backward o a much lower volage (V) han hose a he primary side bu wih a higher curren value (A). Before his curren is brough o he baery i passes again hrough an EMI filer which eliminaes he las differences of ension and suchlike. Resul: There s always a consan curren o he baery, independen of he variaions on he mains volage. Funcioning of a zivan high frequency charger Conrolled recharging = recharging according o he sae of discharge. The Zivan charger conrols consanly he ension of your baery! The charger sars wih a maximum charging curren unil he baery reaches 2.4V/cell. When he 2.4V/cell us reached, he curren drops back and he charger sars o charge he baery wih a charging curren which comes o 4 % of he baery capaciy. So: The charge of your baery is always adaped o he sae of discharge -> he more your baery is discharged, he longer is he charge ime; he less discharged, he shorer he charge ime! Maximum efficiency: Saving of approximaely 25 % on your energy bill. Thanks o he use of a microprocessor which conrols permanenly he deph of discharge and he sae of charge of your baery, he energy consumpion is reduced during he charge cycles, as he charger only delivers he curren needed o charge he discharged par of he baery! Also, he classic ransformer is replaced by a special ransformer in a HF-charger: his means less los of warmh --> less energy loss --> more efficiency. Advanages: less heaing of he baery = less waer consumpion! 14 BATTERY SPPLIES.BE

2 2,4V/ élém. 2,6V/élém. IIa: IIa: Consan I - consan - consan I - urn off I = curren (ampere) = ension (vol) -consan Tension I-consan I-consan The curren decreases: o keep and no o increase he 2,4V/elem.: less waer consumpion. 1Kw Transformer Classical charger 1Kw Transformer HF-Charger Final charge: 4% of he baery capaciy ±0,75 Significan loss of warmh! ±0,85 Almos no loss of warmh! WHY DO HIGH FREQENCY BATTERY CHARGERS HAVE SCCESS? Because hey guaranee several advanages if compared o he radiional echnology ones, above all because we re alking abou CONTROLLED baery chargers. Wha s he meaning of CONTROLLED? I means ha he baery charger is able o make he opimal recharge by succeeding in conrolling and adjusing he curren, he volage and all he charging parameers as saed by he baeries manufacurers. MLTI-CRVE ZIVAN: VERSATILE, EFFICIENT RELIABLE Flexible and inuiive o use: same iem may recharge muliple baery chemisries and a wide window of baery capaciies. This means reducion of he number of par numbers in cusomer warehouse and less references on he IT sysem. By an easy adjusmen, he mos suiable charging profile {cyclic racion charge including week end equalizaion, mainenance floaing charge, power supply saionary charge, oher peculiar o implemen) fiing o specific applicaion {maerial handling: lif rucks, palle rucks, aerial plaforms, PS& elecom sysems, boaing, solar, windmills, EV, NEV, AGV, LGV, indusrial cleaning). CAN BS INTERFACE NEW RANGE: ADDITIONAL FEATRES Chargers unis are parallelable Insulaed can bus communicaion Daa logging and clock calendar Sorage up o 1500 cycles (corresponding o baery sandard lifeime ) Can open funcion: charger can work wih run ime parameers conrolled by exernal devices (e.g. BMS - PC - Vehicle Maser conroller) Dynamic compensaion of he volage drop on he oupu cable Digial display shows parameers : volage, curren, charged Ah, and ime lef o he end of he charge Suiable for several baery ypes (Lead acid, gel, Li-Ion ) Flashable micro conroller HIGH FREQENCY ADVANTAGES Excepional charging qualiy. p o 15% of saving on he charging coss on he energy invoice. Waer consumpion almos halved. Baery mainenance reduced of abou 50%. Gas emissions reduced (lower risk of explosion). Weigh and size abou 10 imes reduced: 4 Every baery charger can be buil-in. THERMAL SENSOR OPTION: By using he hermal sensor opion, he charge profile is auomaically adjused and compensaed based on he baery emperaure. I is warmly suggesed when he baery ofen works in sress condiions and/ or when he climae environmen is characerized by imporan modificaions during he year. VARIATION OF GASIFICATION VOLTAGE FOR A 80V BATTERY BASED ON BATTERY TEMPERATRE The hermal sensor prevens damages o he baery. If an elemen is fauly, he res of he baery is safeguarded. The charger auomaically sops he charge if he emperaure of he baery increases above a predeermined value. Temperaure effec: As you know life of he baery is shorened if i works a higher emperaures. By using he Zivan HF charger baery life is exended. BATTERY SPPLIES.BE 15

3 BATTERY CHARGERS HIGH FREQENCY CHARGERS Reference Vols Amp Charging ime (Ah/C5) L W H Ah Ah 7-8,5h 9-11h 12-13h From To BC 12/ BC1 12/ NG1 12/ BC 24/ BC 24/ BC1 24/ NG1 24/ NG1 24/ NG3 24/ NG3 24/ NG3 24/ NG5 24/ NG9 24/ NG9PLS 24/ NG1 36/ NG3 36/ NG5 36/ NG9 36V 145A NG9PLS 36/ NG1 48/ NG3 48/ NG3 48/ NG5 48/ NG7 48/ NG7 48/100 IP NG9PLS 48/ NG9 48V 145A NG9PLS 48/ NGTOP 48/ NG1 72/ NG3 72/ NG5 72/ NG7 72/ NG9 72/ NG5 80/ NG7 80/ NG9 80/ NG9 80/100 IP NG9PLS 80/ NGTOP 80/ Opions for chargers Reference Can-Bus Sandard reference + CB NG1 & NG3 / NG5 & NG7 & NG9 & NGTOP & IP54 Pump Sandard reference + P NG1 / NG3 & NG5 & NG7 & NG9 & NGTOP & IP54 The BC e BC1 iem references refer o lead acid racion baeries WIA curve only. The recharging imes are purely indicaive and refer o baeries discharged a he 80% of heir capaciies. 16 BATTERY SPPLIES.BE

4 BATTERY CHARGER OVERVIEW 420 V 250 V 72/80 V 36/48 V 24 V 12 V 0,5 kw 0,7 kw 1 kw 3 kw 5 kw 9 kw 18 kw 36 kw BATTERY SPPLIES.BE 17

5 BATTERY CHARGERS HIGH FREQENCY CHARGERS BC BATTERY CHARGER SINGLE-PHASE 65 mm 235 mm 115 mm BC SINGLE PHASE The Single Phase Baery Charger BC is an innovaive device wih exraordinary versailiy, reliabiliy and efficiency. Differen sofware may be insalled o change he charging feaures and adap hem o every kind of baery. Due o is size and ligh weigh, his model is especially suiable for on-board insallaion, in addiion o he on wall insallaion. Consequenly, he machine can be recharged from any available oule, wihou driving he machine o a specific charging area. TECHNICAL FEATRES Inpu volage: 230 VAC ± 10% 115 VAC ± 10% Inpu frequency: Hz Efficiency: > 85% Curren absorbed by he baery: < 1 ma Operaing emperaure: from 20 o +50 C Oupu shor-circui proecion (fuse) Inverse polariy proecion (fuse) Accuracy on oupu volage: ± 0,5% Cooling: forced Case: meal base, cover in self-exinguishable ABS Size: 235 x 115 x 65 mm Weigh: 0,850 kg Enclosure class: IP20 CE In conformiy wih he requiremens of he Low Volage Direcive and of he Direcive EMC. Vibraion Tes: Sinusoidal vibraions (referring regulaion IEC ); Shock Tes (referring regulaion IEC ); Bump Tes (referring regulaion IEC ). Opions: adjusable charging curves or baery capaciy Baery Volage Charging ime 7-8,5 h 9-11 h h Type VAC IMAX Mains V 18A V 15A , IIa/WIa Wo W 1 2 ob m I T1 T2 T3 Sop F1 F2 F1 F2 F3 18 BATTERY SPPLIES.BE

6 BC1 BATTERY CHARGER SINGLE-PHASE 75 mm 285 mm 285 mm BC1 SINGLE PHASE The Single Phase Baery Charger BC1 is an innovaive device wih exraordinary versailiy, reliabiliy and efficiency. Differen sofware may be insalled o change he charging feaures and adap hem o every kind of baery. Due o is size and ligh weigh, his model is especially suiable for on-board insallaion, in addiion o he on wall insallaion. Consequenly, he machine can be recharged from any available oule, wihou driving he machine o a specific charging area. TECHNICAL FEATRES Inpu volage: 230 VAC ± 10% Inpu frequency: Hz Efficiency: > 85% Curren absorbed by he baery: < 1 ma Operaing emperaure: from 20 o +50 C Oupu shor-circui proecion (fuse) Inverse polariy proecion (fuse) Accuracy on oupu volage: ± 0,5% Cooling: forced Case: meal base, cover in self-exinguishable ABS mm mm peso weigh Gewich peso: 1,39 kg Size: 285 x 105 x 75 mm Weigh: 1,390 kg Enclosure class: IP20 CE In conformiy wih he requiremens of he Low Volage Direcive and of he Direcive EMC. Vibraion Tes: Sinusoidal vibraions (referring regulaion IEC ); Shock Tes (referring regulaion IEC ); Bump Tes (referring regulaion IEC ). Opions: adjusable charging curves or baery capaciy Baery Volage Charging ime 7-8,5 h 9-11 h h Type VAC IMAX Mains V 35A V 30A IIa/WIa Wo W 1 2 ob m I T1 T2 T3 Sop F1 F2 F1 F2 F3 BATTERY SPPLIES.BE 19

7 BATTERY CHARGERS HIGH FREQENCY CHARGERS NG1 BATTERY CHARGER SINGLE-PHASE 80 mm 300 mm 160 mm NG1 SINGLE PHASE The Single-phase baery charger NG1 is an innovaive device wih exraordinary versailiy, reliabiliy and efficiency. Differen sofware may be insalled in order o change he charging feaures and o adap hem o every kind of baery. The reduced size of his model allows boh insallaion on a wall, and on-board. Consequenly he baery can be recharged from any available oule, wihou driving he machine o a specific charging area. TECHNICAL FEATRES Inpu volage: 230 VAC ± 10% 115 VAC ± 10% Inpu frequency: Hz Efficiency: > 85% Minimum power absorbed: < 5 W Curren absorbed by he baery: < 0.2 ma Operaing emperaure: from 20 o + 50 C Oupu shor-circui proecion (fuse) Inverse polariy proecion (fuse) Charging curve: programmable Accuracy on oupu volage: ± 0,5% Thermal compensaion of baery volage (opional wih hermal sensor) Acousic alarm Auxiliary conacs of main presence and end of charge (Sandard Charger) or of air pump conrol and end of charge (Charger wih air pump) Cooling: forced Case: Meal base, cover in self-exinguishable ABS Size: 300 x 160 x 80 mm Weigh: 2,2 kg Enclosure class: IP20 CE In conformiy wih he requiremens of he Low Volage Direcive and of he Direcive EMC. Baery Volage Charging ime 7-8,5 h 9-11 h h Type VAC IMAX Mains V 60A V 35A V 45A , V 25A V 22A , V 12A IIa/WIa Wo W 1 2 ob m I T1 T2 T3 Sop F1 F2 F1 F2 F3 20 BATTERY SPPLIES.BE

8 NG1 CAN BS BATTERY CHARGER SINGLE-PHASE POWER IS COMMNICATION NG1 CAN BS The new single-phase baery charger wih CAN BS inerface represens an innovaion in Zivan s range. Is powerful flash microconroller, wih inegraed CAN-BS inerface, paves he way for communicaion wih oher devices such as he conroller, BMS, PC, DISPLAYS, ec.; allowing inegraion ino he mos advanced sysems. Large onboard memory provides access o relevan iems of he charge hisory, hereby increasing he charger s performance and flexibiliy. sing a single buon on he opional display, i is easy o modify charging feaures and parameers allowing correc maching o any ype of baery (including Lihium echnologies). The high power and efficiency of Zivan s chargers guaranees significan energy savings and subsequen economic advanage. All of hese feaures posiion ZIVAN as leaders in he marke, providing sae-ofhe-ar echnology and high qualiy while mainaining a compeiive price. 80 mm TECHNICAL FEATRES (idem NG1) Insulaed CAN BS Inerface INNOVATIVE FEATRES Powerful and flexible logic conrol wih can bus connexion opion Daa logging and clock calendar funcions Sorage of up o 1000 charging cycles parallelable Can open funcion: charger can work wih runime parameers conrolled by an exernal device (e.g. bms) 160 mm 300 mm Inerne connecion for remoe managing & flashing Digial display shows parameers: volage, curren, charged ah and ime lef o he end of charge Dynamic compensaion of he volage drop on he oupu cable Suiable for several baery ypes (Li-Ion, lead acid, gel, ni-mh, ec.) Baery Charging ime Volage 7-8,5 h 9-11 h h Type VAC Code IMAX Mains V 60A GGAQCB-07040Q V 35A GGBMCB-07040Q V 50A ,5 GGBOCB-07040Q V 25A GGCHCB-07040Q V 22A GGEHCVB-07040Q 21, V 12A GGHECB-07000Q 12 6 Furher models are available for oher baery volages. The recharging imes are purely indicaive and refer o baeries discharged a he 80% of heir capaciies. Every model is available for air lif baeries (please, allocae he correc code in he Purchase Order). Air pump NG1 CAN BS Murale ACCESSORIES Thermal sensor Compensaes he recharging parameers depending on baery emperaure. Zivan CAN console Sofware for he visualizaion of charging parameers hrough PC. PC CONNECTION KIT SB o CAN adapor Cable for connecing baery charger o PC hrough ZIVAN Can Console. Maser-slave connecion ki Iner-connecion cable for connecing more devices in parallel (available in he following versions: MASTER-SLAVE, MASTER-2 SLAVES, MASTER-3 SLAVES). BATTERY SPPLIES.BE 21

9 BATTERY CHARGERS HIGH FREQENCY CHARGERS NG3 BATTERY CHARGER SINGLE-PHASE 110 mm 430 mm 220 mm NG3 SINGLE PHASE The Single Phase charger NG3 is an innovaive device wih exraordinary versailiy, reliabiliy and efficiency. Differen sofware may be insalled o change he charging feaures and o adap hem o every kind of baery. The reduced size of his model means ha i can be no only insalled on he wall, bu also carried on-board. Consequenly he baery can be charged in whichever plug available, wihou driving he machine o he charging area. TECHNICAL FEATRES Inpu volage: 230 VAC ± 10% 115 VAC ± 10% Inpu frequency: Hz Efficiency: > 85% Minimum power absorbed: < 5 W Curren absorbed by he baery: < 0,5 ma Operaing emperaure: from 20 o+ 50 C Oupu shor-circui proecion (fuse) Inverse polariy proecion (fuse) Charging curve: programmable Accuracy on oupu volage: ± 0,5 % Thermal compensaion of baery volage (opional wih hermal sensor) Acousic alarm Auxiliary conacs of main presence and end of charge (Sandard Charger) or of air pump conrol and end of charge (Charger wih air pump) Cooling: forced Case: Meal base, cover in self-exinguishable PST Size: 430 x 220 x 110 mm Weigh: 5,5 kg Enclosure class: IP20 CE In conformiy wih he requiremens of he Low Volage Direcive and of he Direcive EMC. Air pump NG3 Murale Baery Volage Charging ime 7-8,5 h 9-11 h h Type VAC IMAX Mains V 60A V 85A V 95A V 100A V 60A V 70A V 45V , V 60A V 25A , V 35A V 25A , V 30A ,4 19 Every model is available for air lif baeries (please, allocae he correc code in he Purchase Order). Furher models are available for oher baery volages. 22 BATTERY SPPLIES.BE

10 NG3 CAN BS BATTERY CHARGER SINGLE-PHASE POWER IS COMMNICATION NG3 CAN BS The new single-phase baery charger wih CAN BS inerface represens an innovaion in Zivan s range. Is powerful flash microconroller, wih inegraed CAN-BS inerface, paves he way for communicaion wih oher devices such as he conroller, BMS, PC, DISPLAYS, ec.; allowing inegraion ino he mos advanced sysems. Large onboard memory provides access o relevan iems of he charge hisory, hereby increasing he charger s performance and flexibiliy. sing a single buon on he opional display, i is easy o modify charging feaures and parameers allowing correc maching o any ype of baery (including Lihium echnologies). The high power and efficiency of Zivan s chargers guaranees significan energy savings and subsequen economic advanage. All of hese feaures posiion ZIVAN as leaders in he marke, providing saeof-he-ar echnology and high qualiy while mainaining a compeiive price. 110 mm TECHNICAL FEATRES (idem NG3) Insulaed CAN BS Inerface INNOVATIVE FEATRES Powerful and flexible logic conrol wih can bus connexion opion Daa logging and clock calendar funcions Sorage of up o 1000 charging cycles Parallelable Can open funcion: charger can work wih runime parameers conrolled by an exernal device (e.g. bms) 220 mm gh peso poids Gewich peso: 5,5 kg 430 mm Inerne connecion for remoe managing & flashing Digial display shows parameers: volage, curren, charged ah and ime lef o he end of charge Dynamic compensaion of he volage drop on he oupu cable Suiable for several baery ypes (lyhium-ion, lead acid, gel, ni-mh, ec.) Baery Charging ime Volage 7-8,5 h 9-11 h h Type VAC Code IMAX Mains G7AVCB-07050Q G7BQCB-07020Q G7BSCB-07030Q G7BTCB-07030Q G7BVCB-07030Q G7CQCB-07020Q G7CRCB-07020Q G7ENCB-07020Q 43, G7EQCB-07020Q G7HICB-07020Q 26, G7HMCB-07020Q G7IICB-07000Q 26, G7ILCB-07020Q 32,4 19 Furher models are available for oher baery volages. The recharging imes are purely indicaive and refer o baeries discharged a he 80% of heir capaciies. Every model is available for air lif baeries (please, allocae he correc code in he Purchase Order). Air pump NG3 CAN BS Murale ACCESSORIES Thermal sensor Compensaes he recharging parameers depending on baery emperaure. Zivan CAN console Sofware for he visualizaion of charging parameers hrough PC. PC CONNECTION KIT SB o CAN adapor Cable for connecing baery charger o PC hrough ZIVAN Can Console. Maser-slave connecion ki Iner-connecion cable for connecing more devices in parallel (available in he following versions: MASTER- SLAVE, MASTER-2 SLAVES, MASTER-3 SLAVES). BATTERY SPPLIES.BE 23

11 BATTERY CHARGERS HIGH FREQENCY CHARGERS NG5/NG7/NG9 CAN BS BATTERY CHARGER THREE-PHASE POWER IS COMMNICATION NG5/NG7/NG9 THREE PHASE The new hree-phase baery charger wih CAN BS inerface represens he innovaion in Zivan s range. Thanks o a flash microprocessor endowing wih high calculaion power and huge sorage capaciy i is able o view in hisorical perspecive he main daa concerning las recharging cycles, elevaing is feasibiliy and performance. By a sole buon i is easy o modify he charging feaures, visualize hem on he display and fi hem o any ype of baery. The high power and efficiency of hese Zivan s chargers guaranee a significan energy saving and subsequen economic advanage. This allows o amorize wihin shor imes he invesmen on choosing high frequency, ranking hese chargers among he leader iems available on he marke wih he bes relaionship beween qualiy and price. 15 mm 265mm weigh peso poids Gewich peso: 9,0 kg 545mm TECHNICAL FEATRES Inpu volage: 400 VAC ± 15% Three Phase Inpu frequency: Hz Efficiency: > 93% Minimum power absorbed: < 10 W Curren absorbed by he baery: < 0,5 ma Operaing emperaure: from 20 o+ 50 C Oupu shor-circui proecion (fuse) Inverse polariy proecion (fuse) Charging curve: programmable Visualizaion by display of he parameers: Volage, Curren, charged Ah and ime lef o he end of charge Accuracy on oupu volage: ± 0,5% Thermal compensaion of baery volage (opional wih hermal sensor) Dynamic compensaion of he volage drop on he oupu cable Acousic alarm Auxiliary conacs of main presence and end of charge (Sandard Charger) or of air pump conrol and end of charge (Charger wih air pump) Cooling: forced Case: Meal base, cover in self-exinguishable PST Size: 545 x 265 x 115 mm Weigh: 9kg Enclosure class: IP20 CE In conformiy wih he requiremens of he Low Volage Direcive and of he Direcive EMC. INNOVATIVE FEATRES LOGIC BOARD WITH FLASH MICROPROCESSOR STORAGE OF OVER 250 CHARGING CYCLES EVEN MORE FLEXIBLE SOFTWARE DELAYED START MASTER AND SLAVE CONFIGRATION WITH POWER EXCEEDING 70KW DESLPHATION CHARGING CRVE SITABLE FOR SEVERAL BATTERY TYPES (LEAD ACID, GEL, LITHIM-ION, NI-MH, ETC.) IIa/WIa Io/Wo I 1 2 ob/w 1 2 ob m NG5 con Air pump Every model is available for air lif baeries (please, allocae he correc code in he Purchase Order). T1 T2 T3 Sop More and differen charging curves are available for special baeries and non-sandard applicaions F1 F2 F1 F2 F3 24 BATTERY SPPLIES.BE

12 Visualizaion of he charging parameers hrough PC Simplified programming wihou PC By pressing he MODE buon i can be seleced he following: Node (MASTER, SLAVE, STAND ALONE) Baery ype Curve ype Baery capaciy in Ah Recharging ime BMS Sand alone 1 Slave Maser Slave 2 Slave 1 Maser SB o CAN Charging room managemen sysem Sand alone 2 Sand alone n... Lapop wih Zivan CAN Console SB o CAN Maser-Slave connecion Through he iner-connecion cable i can be pu in parallel up o 9 devices. The Ex connecor is used o connec PC, make adjusmens and readings. To se he Maser, ad jus Node 0: hen follow sep by sep he procedure recommended by he sysem paying aenion o selec a baery capaciy corresponding o C5. Baery Volage Charging ime Model Type VAC Code IMAX Mains 7-8,5 h 9-11 h h NG G9BVCB-D70D0Q NG G9BZCB-D70E0Q NG G9BXCB-D70P0Q NG G9CVCB-D70D0Q NG G9CZCB-D70E0Q NG GJCKCB-470E0X NG G9ETCB-D70D0Q NG G9EVCB-D70D0Q NG G9EZCB-D70E0Q NG G9EWCB-D70P0Q NG G9HRCB-D70D0Q NG G9HSCB-D70D0Q NG G9HCB-D70D0Q NG G9IQCB-D70D0Q NG ,5 G9ISCB-D70D0Q NG G9ITCB-D70D0Q NG GJIVCB-470E0Q On he hree-phase models 480Vac, he 2nd digi of he par number mus be replaced by a D (example: GDBVCB-D70D0Q). The recharging imes are purely indicaive and refer o baeries discharged a he 80% of heir capaciies. Furher models are available for oher baery volages. BATTERY SPPLIES.BE 25

13 BATTERY CHARGERS HIGH FREQENCY CHARGERS NGTOP THREE PHASE NGTOP BATTERY CHARGER THREE-PHASE The Three-Phase charger NGTOP is an innovaive device wih exraordinary versailiy, reliabiliy and efficiency. Differen sofware may be insalled in order o change he charging feaures and o adap hem o everye kind of baery. NGTOP is he highes power charger from Zivan s producion range. The high power and efficiency of his charger assures he user of considerable energy savings wih subsequen economic benefi. 610 mm Baery Volage Charging ime 7-8,5 h 9-11 h h TECHNICAL FEATRES Inpu volage: 400 VAC ± 15 % Three phase Inpu frequency: Hz Efficiency: > 85% Minimum power absorbed: < 10 W Curren absorbed by he baery: < 1 ma Operaional emperaure: from 20 o 50 C Oupu shor-circui proecion (fuse) Inverse polariy proecion (fuse) Charging curve: programmable Accuracy on oupu volage: ± 0,5% Thermal compensaion of baery volage (opional wih hermal sensor) Type VAC IMAX Mains V 200A V 170A V 150A Every model is available for air lif baeries (please, allocae he correc code in he Purchase Order). Furher models are available for oher baery volages. More and differen charging curves are available for special baeries and non-sandard applicaions. 490 mm 290 mm Acousic Alarm Auxiliary conacs of main presence and end of charge (Sandard Charger) or of air pump conrol and end of charge (Charger wih air pump) Cooling: forced Case: Meal Size: 490 x 290 x 610 mm Weigh: 30 kg Enclosure class: IP20 CE In conformiy wih he requiremens of he Low Volage Direcive and of he Direcive EMC. i THERMAL SENSOR ADVANTAGES The hermal sensor prevens damages o he baery. If an elemen is fauly, he res of he baery is safeguarded. The charger auomaically sops he charge if he emperaure of he baery increases above a predeermined value. Temperaure effec: as you know life of he baery is shorened if i works a higher emperaures. By using he Zivan HF charger baery life is exended. Please inser he sensor in he middle of he baery, along he free space among cells for a deph of around 20 cm. Never inside he cells, because acid damages he sensor! 26 BATTERY SPPLIES.BE

14 ACCESSORIES BC & BC1 ALL CHARGERS BAT/23419 BAT/ cm BAT/ cm BAT/ cm BAT/48423 SCHKO SPPORT - Disables he machine when he plug of he charger is removed from is locaion. BAT/41869 BAT/28999 BAT/ cm 250 cm 400 cm LED EXTENSION Ø 5 - fixing hole Ø 6,5 mm. REMOTE INDICATOR Ø 20 - Displays he charging phase of he charger - fixing hole Ø 22 mm. KABLE HOLDER FRAME AIR PMP KIT. KIT LED EXTENSION Ø 10 Displays he charging phase of he charger (fixing hole Ø 14 mm). NG1 / NG3 / NG5 / NG7 / NG9 BAT/ cm KIT LED EXTENSION Ø 10 Displays he charging phase of he charger (fixing hole Ø 14 mm). BAT/17529 BAT/ cm 400 cm REMOTE INDICATOR Ø 20 Displays he charging phase of he charger (fixing hole d 14mm). BAT/ cm BAT/ cm (sandard) BAT/ m THERMAL SENSOR Conrols he charging volage depending on he baery emperaure. BAT/48422 THERMAL SENSOR AND LED INDICATOR Ø 10 - fixing hole Ø 14 mm. BAT/47886 BAT/ cm 10 m THERMAL SENSOR AND REMOTE INDICATOR Ø 20 - fixing hole Ø 22 mm. NG3 NG5 / NG7 / NG9 NGTOP BAT/42150 CABLES WAY THROGH Allows an appropriae wall insallaion, hanks o an adequae passage of he cables behind he charger. BAT/47888 BAT/42209 BAT/48424 ROLL BAR. STAND A suppor o place he charger on he ground. THERMAL SENSOR wih din socke go - Conrols he consan volage of he gasificaion phase depending on he baery emperaure. BATTERY SPPLIES.BE 27