Instructions for Parts Books

Transcription

1 Instructions for Parts Books The heading at the top of the page will be the same for the picture of the parts at it is for the page with the part numbers. Definition of column headings on part number pages: REF.No The number refering to the part on the picture page of the parts book. Part No. The number assigned to this part at the time of printing the parts book. Description Discription of part. Q'ty S.No. I/C Quanity of part used on that page. Serial number range of the equipment that this part will fit. >= Your serial number should be greater than or equal to the number shown. <= Your serial number should be lesser than or equal to the serial number shown. Interchangeability of part shown. The part shown will work for the older and later serial number. # The part shown is not interchangable with the other serial number. new for old old for new Remarks Notes about this particulart part. Sometimes this may say except [FR] or [CA] Note about Country Codes: The parts books we use in the United States of America may also contain information about a part that would be different in another country. It is important that you are aware of the country codes in some instances. Symbol A CA FR GR PO AU Country United States of America Canada France Greece Portugal Australia If the remarks column says for example EXCEPT [FR] this part works in all countries except France. That means it will work here in the USA.

2 ALL PRODUCT INDEX B2410HSE SPEED CHANGE LEVER/BRAKE ELECTRICAL SYSTEM STEERING FUEL SYSTEM HYDRAULIC SYSTEM HOOD(BONNET)/ROPS ENGINE CLUTCH FRAME TRANSMISSION/REAR AXLE FRONT WHEEL/REAR WHEEL FRONT AXLE COOLING WATER SYSTEM LABELS OPTION ACCESSORIES Ref. B2410HSE Page 11029

3 Item Part No. Description Book ENGINE CRANKCASE 100K OIL PAN 100K CYLINDER HEAD 100K GEAR CASE 100K HEAD COVER 100K OIL FILTER 100K DIPSTICK AND GUIDE 100K MAIN BEARING CASE 100K CAMSHAFT AND IDLE GEAR SHAFT 100K PISTON AND CRANKSHAFT 100K FLYWHEEL 100K CLUTCH 100K FUEL CAMSHAFT AND GOVERNOR SHAFT 100K ENGINE STOP LEVER 100K INJECTION PUMP 100K GOVERNOR 100K GOVERNOR 100K SPEED CONTROL PLATE 100K NOZZLE HOLDER AND GLOW PLUG 100K NOZZLE HOLDER [COMPONENT PARTS] 100K FUEL PUMP(MECHANICAL) 100K DYNAMO AND PULLEY 100K DYNAMO [COMPONENT PARTS] 100K WATER FLANGE AND THERMOSTAT 100K WATER PUMP 100K VALVE AND ROCKER ARM 100K INLET MANIFOLD 100K EXHAUST MANIFOLD 100K AIR CLEANER 100K MUFFLER 100K HYDRAULIC PUMP 100K HYDRAULIC PUMP [COMPONENT PARTS] 100K UPPER GASKET KIT 100K LAWER GASKET KIT 100K ALTERNATOR KIT 100K ALTERNATOR [COMPONENT PARTS] 100K A001 ACCELERATOR LEVER 100K0566 FUEL SYSTEM 01A101 FUEL TANK 100K A110 FUEL PIPE 100K A11001 FUEL PIPE 100K A130 FUEL FILTER [COMPONENT PARTS] 100K0566 COOLING WATER SYSTEM 01A401 FAN 100K A410 WATER PIPE 100K A42003 RADIATOR [2WD] 100K A430 RESERVE TANK 100K0566 ELECTRICAL SYSTEM 01A510 STOP SOLENOID 100K A525 STARTER 100K A530 STARTER [COMPONENT PARTS] 100K A53501 BATTERY [EXCEPT[AU]] 100K B101 SWITCH 100K B10101 SWITCH 100K B115 PANEL BOARD 100K B120 PANEL BOARD [COMPONENT PARTS] 100K B301 HEAD LIGHT 100K B302 HAZARD LIGHT 100K B304 TAIL LIGHT 100K B501 ELECTRICAL WIRING 100K B50101 ELECTRICAL WIRING 100K0566 CLUTCH 01C110 CLUTCH ROD 100K0566 Ref. B2410HSE Page 11029

4 Item Part No. Description Book CLUTCH 01C301 CLUTCH PEDAL 100K C40102 CLUTCH HOUSING [2WD] 100K0566 FRAME 01C41302 FRONT FRAME [2WD] 100K C415 CENTER FRAME 100K0566 TRANSMISSION/REAR AXLE 01C420 TRANSMISSION CASE 100K C425 DIFFERENTIAL GEAR CASE 100K C42701 REAR AXLE CASE [EXCEPT[BI-SPEED TURN TYPE]] 100K D001 CLUTCH SHAFT 100K D005 PROPELLER SHAFT 100K D010 HST 100K D015 HST [COMPONENT PARTS] 100K D103 FRONT SHAFT 100K D135 PTO SHAFT 100K D137 MID PTO 100K D140 REAR DIFFERENTIAL 100K D149 2ND SHAFT 100K D152 3RD SHAFT 100K D155 4TH SHAFT 100K D217 RANGE GEAR SHIFT FORK 100K D220 PTO GEAR SHIFT FORK 100K D225 DIFFERENTIAL LOCK SHIFT FORK 100K D301 REAR AXLE 100K0566 SPEED CHANGE LEVER/BRAKE 01E001 BRAKE 100K E005 BRAKE ROD 1 100K E01501 PARKING BRAKE LEVER [EXCEPT[AU]] 100K F030 SPEED SET LEVER 100K F107 NEUTRAL HOLDER LINK 100K F108 SPEED CONTROL PEDAL 100K F110 RANGE GEAR SHIFT LEVER 100K F11302 FRONT WHEEL DRIVE LEVER [2WD] 100K F125 PTO GEAR SHIFT LEVER 100K F143 HYDRAULIC CONTROL LEVER 100K F201 BRAKE PEDAL 100K F205 DIFFERENTIAL LOCK PEDAL 100K0566 FRONT AXLE 01G101 FRONT AXLE FRAME [2WD] 100K G103 FRONT WHEEL HUB [2WD] 100K0566 STEERING 01H00102 KNUCKLE ARM [2WD] 100K H003 DRAG LINK 100K H02 TIE ROD [2WD] 100K H101 STEERING HANDLE 100K H105 STEERING POST 100K0566 HYDRAULIC SYSTEM 01J101 HYDRAULIC PUMP(PS) 100K J105 HYDRAULIC PUMP(PS) [COMPONENT PARTS] 100K J201 HYDRAULIC OIL LINE(SUCTION) 100K J210 HYDRAULIC OIL LINE(DELIVERY) 100K J215 HYDRAULIC OIL LINE(STEERING) 100K J235 HYDRAULIC OIL LINE (HST) 100K J240 HYDRAULIC OIL LINE (OIL COOLER) 100K J245 HYDRAULIC OIL LINE (F/M) 100K J301 HYDRAULIC CYLINDER 100K J310 HYDRAULIC PISTON/LIFT ARM 100K J330 FEED BACK LEVER 100K J405 CONTROL VALVE 100K J410 CONTROL VALVE [COMPONENT PARTS] 100K K101 3-POINT LINKAGE 2(LIFT ROD) 100K K115 LOWER LINK 100K K120 3-POINT LINKAGE 1(LOWER LINK) 100K K125 CHECK CHAIN 100K L105 DRAWBAR 100K0566 Ref. B2410HSE Page 11029

5 Item Part No. Description Book HYDRAULIC SYSTEM 01L115 HITCH 100K L12501 PTO PROTECTOR [EXCEPT[AU]] 100K0566 HOOD(BONNET)/ROPS 01M10101 FRONT GRILLE [EXCEPT[AU]] 100K M105 BONNET 100K M113 PANEL COVER 100K M12001 SIDE COVER [EXCEPT[AU]] 100K M130 SHUTTER PLATE 100K M21001 FENDER [EXCEPT[BI-SPEED TURN TYPE]] 100K M21201 FENDER STAY [EXCEPT[BI-SPEED TURN TYPE]] 100K M215 FLOOR SEAT 100K M217 SEAT SUPPORT 100K M225 STEP 100K M301 ROPS KIT (RIGID TYPE) 100K M501 SMV EMBLEM 100K0566 FRONT WHEEL/REAR WHEEL 01R10101 FRONT WHEEL ( ) [EXCEPT[AU]] 100K R11001 REAR WHEEL ( ) [EXCEPT[AU]] 100K R11002 REAR WHEEL (31X ) [EXCEPT[AU]] 100K R11003 REAR WHEEL (33X ) [EXCEPT[AU]] 100K R11004 REAR WHEEL ( ) [EXCEPT[AU]] 100K0566 LABELS 01S10106 LABEL [2WD] [A] 100K S10107 LABEL [2WD] [CA] 100K0566 ACCESSORIES 01T105 ACCESSORIES AND SERVICE PARTS 100K0566 OPTION 01U805 WARKING LIGHT KIT [OPTION] 100K U836 POWER STEERING HOSE KIT [OPTION] 100K U910 ROPS KIT (FOLDABLE TYPE) [OPTION] 100K0566 Ref. B2410HSE Page 11029

6 CRANKCASE Reference: Page:1

7 CRANKCASE REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) COMP.CRANKCASE 1 <=YK COMP.CRANKCASE 1 >=YL COMP.CRANKCASE 1 >=1G COMP.CRANKCASE 1 >=3L CAP SEALING CAP SEALING PLUG PLUG PLUG PLUG PLUG EXPANSION PLUG EXPANSION PIN STRAIGHT PIN STRAIGHT PIN STRAIGHT PIN PIPE PIN PIPE PLUG FUEL CAMSHAFT PIN START SPRING PLUG BUSH GOVERNOR GEAR PLUG GASKET BOLT FLANGE 1 >=3L GASKET 1 >=3L O RING PIPE WATER RETURN Reference: Page:1

8 OIL PAN Reference: Page:2

9 OIL PAN REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C COMP.OIL PAN PLUG C GASKET BOLT 22 <=2S BOLT 22 >=2U FILTER OIL BOLT O RING Reference: Page:2

10 CYLINDER HEAD Reference: Page:3

11 CYLINDER HEAD REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) HOOK ENGINE BOLT COMP.CYLINDER HEAD CAP SEALING CAP SEALING GUIDE INLET VALVE GUIDE EXHAUST VALVE PLUG BOLT CYLINDER HEAD BOLT CYLINDER HEAD E GASKET CYL.HEAD CLAMP CORD Reference: Page:3

12 GEAR CASE Reference: Page:4

13 GEAR CASE Reference: Page:4

14 GEAR CASE REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) ASSY CASE GEAR COMP.CASE GEAR 1 <=1S7639 NOT SALE.ORDER BY REF.NO COMP.CASE GEAR 1 >=1U0001 NOT SALE.ORDER BY 0 0 REF.NO COMP.CASE GEAR 1 >=1W PLUG PLUG WASHER PLAIN JOINT PIPE SPRING SEAT VALVE BALL ASSY ROTOR OIL PUMP COVER OIL PUMP SCREW CR-REC-BD-HD PIN STRAIGHT GASKET GEAR CASE BOLT BOLT BOLT BOLT BOLT STUD NUT WASHER SPRING SEAL OIL O RING 2 <=1S O RING 2 <=1S STUD ASSY GEAR CASE H/M GASKET H/METER UNIT BOLT Reference: Page:4

15 HEAD COVER Reference: Page:5

16 HEAD COVER REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) ASSY COVER CYL.HEAD GASKET HEAD COVER JOINT BREATHER PIPE PLATE B/THER ELEMENT PLATE B/THER ELEMENT ELEMENT BREATHER OIL SHIELD BREATHER SCREW WITH WASHER NUT GASKET PLUG OIL FILLER E PLUG OIL FILLER O RING PIPE BREATHER BAND PIPE Reference: Page:5

17 OIL FILTER 010 Reference: Page:6

18 OIL FILTER REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight Weight (kgf) (lb) ASSY CARTRIDGE OIL Reference: Page:6

19 DIPSTICK AND GUIDE Reference: Page:7

20 DIPSTICK AND GUIDE REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) GAUGE OIL ASSY GUIDE OIL GAUGE 1 <=3Y ASSY GUIDE OIL GAUGE 1 >=4A O RING Reference: Page:7

21 MAIN BEARING CASE Reference: Page:8

22 MAIN BEARING CASE Reference: Page:8

23 MAIN BEARING CASE REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) ASSY CASE MAIN BRG BOLT BEARING CASE GASKET BRG.CASE COVER BEARING CASE SEAL OIL GASKET BOLT BOLT ASSY CASE MAIN BRG BOLT BEARING CASE BOLT BEARING CASE ASSY CASE MAIN BRG BOLT BEARING CASE Reference: Page:8

24 CAMSHAFT AND IDLE GEAR SHAFT Reference: Page:9

25 CAMSHAFT AND IDLE GEAR SHAFT REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) TAPPET PUSH ROD ASSY CAMSHAFT SCREW SET GEAR CAM KEY FEATHER STOPPER CAMSHAFT BOLT 2 <=2D BOLT 2 >=2E COMP GEAR IDLE BUSH IDLE GEAR COLLAR IDLE GEAR COLLAR IDLE GEAR CIR CLIP IDLE GEAR SHAFT IDLE GEAR BOLT Reference: Page:9

26 PISTON AND CRANKSHAFT Reference: Page:10

27 PISTON AND CRANKSHAFT REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) PISTON 3 STD PISTON mm ASSY PISTON RING 3 STD ASSY PISTON RING mm PIN PISTON CIR CLIP PISTON PIN ASSY ROD CONNECTING BUSH PISTON PIN 3 <=3M BUSH PISTON PIN 3 >=3N BOLT CONNECTING ROD METAL CRANKPIN 3 STD SET METAL CRANKPIN mm SET METAL CRANKPIN mm SET COMP.CRANKSHAFT BALL GEAR CRANK KEY GEAR OIL PUMP DRIVE BLANK COLLAR CRANKSHAFT O RING METAL CRANKSHAFT 1 STD METAL CRANKSHAFT mm METAL CRANKSHAFT mm METAL CRANKSHAFT 2 STD SET METAL CRANKSHAFT mm SET METAL CRANKSHAFT mm SET METAL CRANKSHAFT 1 STD SET METAL CRANKSHAFT mm SET METAL CRANKSHAFT mm SET METAL SIDE 2 STD METAL SIDE mm METAL SIDE mm METAL SIDE 2 STD METAL SIDE mm METAL SIDE mm Reference: Page:10

28 FLYWHEEL Reference: Page:11

29 FLYWHEEL REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) COMP.FLYWHEEL GEAR RING BEARING DRY BOLT FLYWHEEL C PLATE REAR END BOLT PIN STRAIGHT Reference: Page:11

30 CLUTCH Reference: Page:12

31 CLUTCH REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C COMP.DISK CLUTCH C COMP.PLATE PRESSURE BOLT PIN STRAIGHT Reference: Page:12

32 FUEL CAMSHAFT AND GOVERNOR SHAFT Reference: Page:13

33 FUEL CAMSHAFT AND GOVERNOR SHAFT REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) CAMSHAFT FUEL BEARING BALL BEARING BALL BEARING BALL CAM FUEL WASHER BOLT NUT GEAR INJECTION PUMP KEY WOODRUFF STOPPER FUEL.C/SHAFT BOLT 2 <=2D BOLT 2 >=2E ASSY SHAFT GOVERNOR HOLDER GOVERNOR GEAR GEAR GOVERNOR HOLDER GOV.WEIGHT COMP.WEIGHT GOVERNOR SHAFT GOV. WEIGHT ROLLER SLEEVE GOVERNOR WASHER THRUST BEARING BALL BEARING BALL CIR CLIP GOV.SHAFT SCREW SET Reference: Page:13

34 ENGINE STOP LEVER Reference:010 Page:14

35 ENGINE STOP LEVER REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) APPARATUS FUEL LIMIT ASSY BOLT ADJUSTING NUT NUT GASKET CAP BOLT ADJUSTING G NUT LOCK NUT GASKET G GASKET Reference:010 Page:14

36 INJECTION PUMP Reference:012 Page:15

37 INJECTION PUMP REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) JOINT EYE ASSY PUMP INJECTION SHIM INJECTION PUMP mm SHIM INJECTION PUMP mm SHIM INJECTION PUMP mm BOLT HEX-SOC-HD STUD NUT WASHER SPRING SCREW FOLLOW GASKET PLUG GASKET Reference:012 Page:15

38 GOVERNOR Reference:014 Page:16

39 GOVERNOR S.No.;<=3Y0886 REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) SPRING START SPRING GOVERNOR 1 <=XZ G SPRING GOVERNOR 1 >=YA ASSY LEVER FORK 1 <=2F ASSY LEVER FORK 1 >=2G COMP.LEVER FORK 1 <=2F COMP.LEVER FORK 1 >=2G ROLLER LEVER FORK 1 <=2F LEVER FORK 1 >=2G SHAFT FORK LEVER WASHER PLAIN BLANK BEARING MINIATURIZE CIR CLIP EXTERNAL COVER FORK LEV.SHAFT GASKET BOLT COLLAR BEARING MINIATURIZE Reference:014 Page:16

40 GOVERNOR Reference:01021 Page:17

41 GOVERNOR S.No.;>=4A0001 REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) SPRING START G SPRING GOVERNOR ASSY LEVER FORK G LEVER FORK G SHAFT FORK LEVER G SHAFT FORK LEVER BEARING MINIATURIZE COVER FORK LEV.SHAFT GASKET BOLT COLLAR BEARING MINIATURIZE Reference:01021 Page:17

42 SPEED CONTROL PLATE Reference:015 Page:18

43 SPEED CONTROL PLATE REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) ASSY PLATE CONTROL LEVER SPEED CONTROL LEVER SPEED CONTROL O RING PIN SPRING PIN SPRING BOLT COMP.LEVER GOVERNOR LEVER ENGINE STOP O RING SPRING RETURN COMP.LEVER STOP GASKET BOLT STUD NUT WASHER SPRING BOLT GASKET Reference:015 Page:18

44 NOZZLE HOLDER AND GLOW PLUG Reference:016 Page:19

45 NOZZLE HOLDER AND GLOW PLUG REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) ASSY PIPE OVER FLOW SCREW AIR BREEDER GASKET ASSY HOLDER NOZZLE GASKET SEAL HEAT PIPE INJECTION PIPE INJECTION PIPE INJECTION CLAMP PIPE CLAMP PIPE SCREW WITH WASHER GLOW PLUG CORD GLOW PLUG NUT FLANGE Reference:016 Page:19

46 NOZZLE HOLDER [COMPONENT PARTS] Reference:017 Page:20

47 NOZZLE HOLDER [COMPONENT PARTS] REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) KIT HOLDER NOZZLE ASSY HOLDER NOZZLE NUT WASHER ADJUSTING SPRING NOZZLE SPACER DISTANCE PUSH ROD NUT NOZZLE WASHER PLAIN PIECE NOZZLE ASSY WASHER ADJUST 3 OPTION WASHER ADJUSTING mm WASHER ADJUSTING mm WASHER ADJUSTING mm WASHER ADJUSTING mm WASHER ADJUSTING mm WASHER ADJUSTING mm WASHER ADJUSTING mm WASHER ADJUSTING mm WASHER ADJUSTING mm WASHER ADJUSTING mm GASKET SEAL HEAT Reference:017 Page:20

48 FUEL PUMP(MECHANICAL) Reference: Page:21

49 FUEL PUMP(MECHANICAL) REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) ASSY PUMP FUEL GASKET FUEL PUMP NUT WASHER SPRING Reference: Page:21

50 DYNAMO AND PULLEY Reference:010 Page:22

51 DYNAMO AND PULLEY 030 Reference:010 Page:22

52 DYNAMO AND PULLEY REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C ASSY DYNAMO STAY DYNAMO C COLLAR 1 <=1U BOLT BOLT NUT WASHER PLAIN WASHER PLAIN WASHER SPRING BOLT WASHER PLAIN CLAMP CORD PULLEY FAN DRIVE BOLT FAN DRIVE Reference:010 Page:22

53 DYNAMO [COMPONENT PARTS] Reference:011 Page:23

54 DYNAMO [COMPONENT PARTS] REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C ASSY DYNAMO C COMP.STATOR SCREW ROUND HEAD STATOR C PLATE BEARING BALL SCREW ROUND HEAD CLAMP CORD C COMP.FLYWHEEL PULLEY C FLYWHEEL DYNAMO C COLLAR BEARING BALL C SHAFT COLLAR NUT WASHER SPRING WASHER PLAIN Reference:011 Page:23

55 WATER FLANGE AND THERMOSTAT Reference:010 Page:24

56 WATER FLANGE AND THERMOSTAT REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) COMP FLANGE WATER PIPE WATER RETURN GASKET WATER FLANGE BOLT BOLT PIPE WATER RETURN BAND PIPE ASSY THERMOSTAT 1 <=1D ASSY THERMOSTAT 1 >=1E COVER THERMOSTAT GASKET THERMOSTAT BOLT Reference:010 Page:24

57 WATER PUMP Reference:011 Page:25

58 WATER PUMP REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) ASSY PUMP WATER 1 <=1U ASSY PUMP WATER 1 >=1W BEARING 1 <=1U BEARING 1 >=1W ASSY SEAL MECHANICAL 1 <=1U G ASSY SEAL MECHANICAL 1 >=1W IMPELLER WATER PUMP 1 <=1U IMPELLER WATER PUMP 1 >=1W PIPE WATER RETURN GASKET WATER PUMP 1 <=1U GASKET WATER PUMP 1 >=1W BOLT BOLT FLANGE WATER PUMP Reference:011 Page:25

59 VALVE AND ROCKER ARM Reference:010 Page:26

60 VALVE AND ROCKER ARM REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) VALVE INLET VALVE EXHAUST SPRING VALVE RETAINER VALVE SP RETAINER SPRING COLLET VALVE SPRING 6 SET C SEAL VALVE STEM CAP VALVE SHAFT ROCKER ARM BOLT BRACKET ROCKER ARM PIN SPRING WASHER R-ARM.SHAFT WASHER PLAIN SPRING ROCKER ARM BLANK ASSY ROCKER ARM SCREW ADJUSTING NUT STUD NUT WASHER PLAIN Reference:010 Page:26

61 INLET MANIFOLD Reference:011 Page:27

62 INLET MANIFOLD REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) ASSY MANIFOLD INLET GASKET IN-MANIFOLD BOLT BOLT BOLT CLAMP CORD Reference:011 Page:27

63 EXHAUST MANIFOLD Reference:012 Page:28

64 EXHAUST MANIFOLD REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) MANIFOLD EXHAUST GASKET EX-MANIFOLD STUD NUT STUD Reference:012 Page:28

65 AIR CLEANER Reference:013 Page:29

66 AIR CLEANER REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C ASSY CLEANER AIR BLANK A BODY AIR CLEANER A GASKET LABEL CAUTION A ASSY COVER A/C A SPRING VALVE UNLOADER C ASSY ELEMENT ELEMENT INNER C BRACKET AIR CLEANER NUT 2 <= NUT FLANGE 2 >= A HOSE INLET BAND PIPE C HOSE INLET BAND AIR CLEANER Reference:013 Page:29

67 MUFFLER Reference:015 Page:30

68 MUFFLER Reference:015 Page:30

69 MUFFLER REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C COMP.MUFFLER NUT GASKET MUFFLER NA C PIPE EXHAUST CLAMP MUFFLER PIPE BOLT 1 <= BOLT FLANGE 1 >= WASHER PLAIN 2 <= NUT Reference:015 Page:30

70 HYDRAULIC PUMP Reference: Page:31

71 HYDRAULIC PUMP REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C ASSY PUMP HYDRAULIC 1 <=2K C ASSY PUMP HYDRAULIC 1 >=2L O RING BOLT BOLT NUT CLAMP CORD Reference: Page:31

72 HYDRAULIC PUMP [COMPONENT PARTS] Reference: Page:32

73 HYDRAULIC PUMP [COMPONENT PARTS] REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C ASSY PUMP HYDRAULIC 1 <=2K C ASSY PUMP HYDRAULIC 1 >=2L A BUSH 2 <=2K A BUSH 2 >=2L PIN STRAIGHT A COMP.GEAR HYD.PUMP C PLATE SIDE C RING DOUBLE 1 <=2K C RING DOUBLE 1 >=2L A COUPLING A BUSH 4 <=2K A BUSH 4 >=2L PIN STRAIGHT A COMP.GEAR HYD.PUMP C PLATE SIDE C RING DOUBLE 1 <=2K C RING DOUBLE 1 >=2L C COMP.COVER A BUSH 2 <=2K A BUSH 2 >=2L BOLT FLANGE SEAL OIL CIR CLIP INTERNAL Reference: Page:32

74 UPPER GASKET KIT Reference: Page:33

75 UPPER GASKET KIT REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) KIT GASKET UPPER O RING O RING GASKET GASKET THERMOSTAT GASKET GASKET C SEAL VALVE STEM E GASKET CYL.HEAD GASKET IN-MANIFOLD GASKET EX-MANIFOLD GASKET HEAD COVER GASKET MUFFLER NA GASKET NA 1 OUT OF USE GASKET WATER FLANGE GASKET 1 OUT OF USE SEAL HEAT Reference: Page:33

76 LAWER GASKET KIT Reference: Page:34

77 LAWER GASKET KIT REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) KIT GASKET LOWER 1 <=2S LOWER GASKET KIT 1 >=2U O RING O RING 2 <=1S O RING O RING 2 <=1S O RING O RING GASKET C GASKET O RING SEAL OIL 1 OUT OF USE SEAL OIL GASKET GASKET FUEL PUMP GASKET GEAR CASE SEAL OIL GASKET BRG.CASE GASKET GASKET GASKET GASKET H/METER UNIT GASKET 1 OUT OF USE GASKET WATER PUMP 1 <=2S GASKET WATER PUMP 1 >=2U O RING GASKET 1 OUT OF USE G GASKET GASKET 1 OUT OF USE GASKET PUMP COVER NA 1 OUT OF USE GASKET GASKET Reference: Page:34

78 ALTERNATOR KIT Reference: Page:35

79 ALTERNATOR KIT REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C KIT ALTERNATOR 1 NOT SALE ASSY ALTERNATOR 1 <= ASSY ALTERNATOR 1 >= V BELT C ASSY WIRE HARNESS FUSE COMP.RELAY STAY DYNAMO BOLT WASHER PLAIN BOLT WASHER PLAIN WASHER SPRING NUT C COLLAR ALTERNATOR BAND CORD GAUGE OIL C MANUAL ALTERNATOR K Reference: Page:35

80 ALTERNATOR [COMPONENT PARTS] Reference: Page:36

81 ALTERNATOR [COMPONENT PARTS] REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) ASSY ALTERNATOR 1 <= ASSY ALTERNATOR 1 >= PULLEY DYNAMO NUT COLLAR ROTOR 1 <=10123 NOT SALE ROTOR 1 >= COVER BEARING BEARING BALL WASHER THRUST FRAME DRIVE END PLATE RETAINER SCREW ROUND HEAD BOLT THROUGH BEARING BALL FRAME END 1 <= FRAME END 1 >= COVER END ASSY RECTIFIER ASSY RECTIFIER BUSH INSULATION HOLDER BRUSH BRUSH SPRING BRUSH SCREW ROUND HEAD SCREW ROUND HEAD SCREW ROUND HEAD BOLT NUT BOLT NUT ASSY REGULATOR K ASSY REGULATOR Reference: Page:36

82 ACCELERATOR LEVER Reference:01A001 Page:37

83 ACCELERATOR LEVER REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C BRACKET ACCEL C ROD ACCEL SPRING PLATE C ARM ACCELERATOR C WASHER ACCEL WASHER PLAIN NUT FLANGE NUT C SPRING C LINK ACCEL PIN SNAP BOLT C LEVER ACCEL TA GRIP PIN SPRING C ASSY ROD RELEASE C CONNECTOR NUT PIN SNAP PIN SNAP Reference:01A001 Page:37

84 FUEL TANK Reference:01A101 Page:38

85 FUEL TANK Reference:01A101 Page:38

86 FUEL TANK REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C ASSY TANK FUEL 1 <=10071 NOT SALE C ASSY TANK FUEL 1 >=10072 NOT SALE C ASSY TANK FUEL 1 >= C TRAY FUEL C PIPE C GAUGE FUEL 1 <= C GAUGE FUEL 1 >= A GASKET SCREW WITH WASHER C CLAMP A ASSY CAP FUEL A CAP FUEL A SPACER A GASKET BOLT C SPONGE Reference:01A101 Page:38

87 FUEL PIPE Reference:01A110 Page:39

88 FUEL PIPE S.No;<=10123 REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6A ASSY FILTER FUEL NUT C STAY FUEL FILTER C ASSY TUBE FUEL TUBE FUEL CLIP PIPE SPRING PIPE PROTECT C ASSY TUBE FUEL TUBE FUEL CLIP PIPE SPRING PIPE PROTECT C ASSY TUBE FUEL TUBE FUEL CLIP PIPE BAND CORD C ASSY PIPE OVER FLOW TUBE FUEL CLIP PIPE C ASSY PIPE AIR VENT TUBE FUEL CLIP PIPE ASSY TUBE FUEL TUBE FUEL CLIP PIPE ASSY PIPE OVER FLOW CLIP PIPE Reference:01A110 Page:39

89 FUEL PIPE Reference:01A11001 Page:40

90 FUEL PIPE S.No.;>=10124 REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6A ASSY FILTER FUEL NUT C STAY FUEL FILTER C ASSY TUBE FUEL TUBE FUEL CLIP PIPE SPRING PIPE PROTECT C ASSY TUBE FUEL TUBE FUEL CLIP PIPE SPRING PIPE PROTECT C ASSY TUBE FUEL TUBE FUEL CLIP PIPE BAND CORD C ASSY PIPE OVER FLOW TUBE FUEL CLIP PIPE ASSY TUBE FUEL TUBE FUEL CLIP PIPE ASSY PIPE OVER FLOW CLIP PIPE ASSY PIPE OVER FLOW PIPE FUEL CLIP PIPE ASSY PIPE OVER FLOW TUBE FUEL CLIP PIPE K JOINT T-PIPE Reference:01A11001 Page:40

91 FUEL FILTER [COMPONENT PARTS] Reference:01A130 Page:41

92 FUEL FILTER [COMPONENT PARTS] REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6A ASSY FILTER FUEL A BODY A CUP A FILTER A O-RING A O-RING Reference:01A130 Page:41

93 FAN Reference:01A401 Page:42

94 FAN REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C FAN PULLEY FAN BOLT FLANGE V BELT Reference:01A401 Page:42

95 WATER PIPE Reference:01A410 Page:43

96 WATER PIPE REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C HOSE WATER CLAMP HOSE C HOSE WATER CLAMP HOSE CLAMP HOSE C CLAMP WATER HOSE C COCK COCK DRAIN BOLT C HOSE DRAIN C CLAMP HOSE C HOSE DRAIN C CLAMP HOSE C CLAMP HOSE Reference:01A410 Page:43

97 RADIATOR [2WD] Reference:01A42003 Page:44

98 RADIATOR [2WD] Reference:01A42003 Page:44

99 RADIATOR [2WD] REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C ASSY RADIATOR C ASSY CAP RADIATOR C KIT SHROUD FAN CLAMP CORD BOLT 4 <= BOLT 1 >= BOLT 3 >= C NET RADIATOR C GUIDE RADIATOR NET L C GUIDE RADIATOR NET R BOLT BOLT C CUSHION RADIATOR C TAPE RADIATOR LH C TAPE RADIATOR C STAY RADIATOR BOLT C PLATE SHUTTER BOLT LABEL FAN BELT TA LABEL MUFFLER Reference:01A42003 Page:44

100 RESERVE TANK Reference:01A430 Page:45

101 RESERVE TANK REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6A SUPPORT RESERVE TANK BOLT CLAMP CORD C ASSY TANK RESERVE BODY TANK CAP GASKET PIPE WATER OVER FLOW C PIPE WATER OVER FLOW CLIP PIPE Reference:01A430 Page:45

102 STOP SOLENOID 010 Reference:01A510 Page:46

103 STOP SOLENOID 010 Reference:01A510 Page:46

104 STOP SOLENOID REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6A SOLENOID STOP 1 <= ASSY SOLENOID STOP 1 >= BOLT Reference:01A510 Page:46

105 STARTER Reference:01A525 Page:47

106 STARTER REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C ASSY STARTER BOLT CLAMP CORD Reference:01A525 Page:47

107 STARTER [COMPONENT PARTS] Reference:01A530 Page:48

108 STARTER [COMPONENT PARTS] REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C ASSY STARTER C ARMATURE C ASSY SHAFT C GEAR-SHAFT 1 NOT SALE 0 0 6C GEAR.INTERNAL C GEAR PLANETARY C CLUTCH OVER RUNNING C STOPPER C GASKET C BALL C ASSY YOKE BLANK C ASSY HOLDER BRUSH BLANK BLANK C ASSY BRACKET REAR C BUSH C ASSY BRACKET FRONT BUSH C BOLT C LEVER FORK C ASSY SWITCH MAGNETIC SCREW PAN-HEAD Reference:01A530 Page:48

109 BATTERY [EXCEPT[AU]] Reference:01A53501 Page:49

110 BATTERY [EXCEPT[AU]] REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 6C BRACKET BATTERY BOLT WASHER PLAIN C NET TRIM DUSTPROOF C RUBBER C ASSY BATTERY 1 ENGLISH C KIT BATTERY (B) 1 FRENCH C LABEL BATTERY 1 ENGLISH C LABEL BATTERY 1 FRENCH CUSHION CUSHION C CORD BATTERY(+) C CORD BATTERY(-) BAND CORD BAND CORD C RETAINER BATTERY C BOLT HOOK WASHER PLAIN NUT WING C CUSHION Reference:01A53501 Page:49

111 SWITCH Reference:01B101 Page:50

112 SWITCH S.No.;<=10183 REF.No Part No. Description Q'ty S.No. I/C REMARKS Weight (kgf) Weight (lb) 010 3F UNIT FLASHER NUT RP ASSY REGULATOR BOLT 1 <= BOLT 1 >= COMP.RELAY BOLT C ASSY SWITCH SAFETY NUT SAFETY SWITCH CAP SAFETY SWITCH C WASHER TOOTHED SWITCH SAFETY NUT SAFETY SWITCH CAP SAFETY SWITCH SENSOR THERMO SWITCH OIL Reference:01B101 Page:50