CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks

Transcription

1 A1

2 A2

3 A3

4 A4

5 CYLINDER HEAD 1 3FA CYLINDER HEAD ASSY BOLT, STUD F GUIDE, EXHAUST VALVE CIRCLIP FA BREATHER ASSY FA PIPE, BREATHER CLIP O-RING SCREW, PAN HEAD F COVER, CYLINDER HEAD SIDE O-RING WASHER, PLATE BOLT, WASHER BASED NGK-C7HSA PLUG, SPARK (NGK CR7HS). 1 UR 15 50M GASKET, CYLINDER HEAD PIN, DOWEL PIN, DOWEL BOLT FA CYLINDER FA GASKET, CYLINDER O-RING A5

6 CRANKSHAFT - PISTON 1 3FA CRANKSHAFT ASSY KEY, WOODRUFF FA A0 PISTON (STD) FA PISTON (0.50MM O/S) AP 3FA PISTON (1.00MM O/S) AP 4 22K PIN, PISTON CIRCLIP HX PISTON RING SET (STD) HX PISTON RING SET (0.50MM O/S) AP 2HX PISTON RING SET (1.00MM O/S) AP 7 3FA BALANCER ASSY BEARING BEARING A6

7 VALVE 1 50M VALVE, INTAKE M VALVE, EXHAUST HX SEAL, VALVE STEM F SEAT, VALVE SPRING FA SPRING, VALVE INNER F COTTER, VALVE F RETAINER, VALVE SPRING M ARM, VALVE ROCKER F SCREW, VALVE ADJUSTING NUT F SHAFT, ROCKER A7

8 CAMSHAFT - CHAIN 1 50M CAMSHAFT ASSY M SPROCKET, CAM CHAIN (28T) L5-00 COLLAR FA PLATE, BREATHER WASHER, PLATE BOLT CHAIN M GUIDE, STOPPER M GUIDE, STOPPER M TENSIONER ASSY, CAM CHAIN RF GASKET, TENSIONER CASE BOLT GASKET M-1111F PLATE BOLT A8

9 OIL PUMP 1 3FA OIL PUMP ASSY FA GEAR, PUMP DRIVEN CIRCLIP F GASKET, PUMP COVER SCREW, FLAT FILLISTER Y PIPE, OIL Y STRAINER, OIL SPRING, COMPRESSION X PLUG, DRAIN A1-00 O-RING FA OIL PIPE COMP CIRCLIP O-RING A9

10 INTAKE 1 3FA JOINT, CARBURETOR O-RING BOLT NUT, FLANGE FA CAP, CLEANER CASE F SEAL FA PLATE, ELEMENT FA CLIP, CAP FITTING V SEAL CLIP SCREW, PAN HEAD WASHER, PLATE XJ ELEMENT, AIR CLEANER XJ GUIDE WASHER SCREW, PAN HEAD FA DUCT CLAMP, HOSE FA JOINT, AIR CLEANER HOSE CLAMP ASSY NL PIPE FA-2179T PLATE, EPA 3 (CALIFORNIA). 1 A10

11 CARBURETOR 1 3FA CARBURETOR ASSY FA CARBURETOR ASSY V SPRING, THROTTLE VALVE FA-1490J NEEDLE SET FA-1490J NEEDLE SET X CABLE ADJUST SCREW SET 1 5 3X CAP U GASKET FA VALVE, THROTTLE FA-1410A STARTER SET M JET, STARTER G THROTTLE SCREW SET SCREW, PAN HEAD WASHER V PLATE W GASKET, FLOAT CHAMBER V NOZZLE, MAIN V-1414M NOZZLE, MAIN A JET, MAIN ( 77.5) A JET, MINE (82.5) O-RING FA PIPE V FLOAT PIN, FLOAT V NEEDLE VALVE ASSY FA PIPE R PLUG, DRAIN NT JET, PILOT ( 12.5) V PILOT SCREW SET CONTINUED ON NEXT FRAME A11

12 CARBURETOR SCREW, PAN HEAD WASHER, SPRING U PIPE W O-RING V WASHER, MAIN JET SCREW, PAN HEAD V WASHER W PIPE A TUBE, FLEXIBLE VINYL A12

13 EXHAUST 1 3FA PROTECTOR, EXHAUST PIPE FA MUFFLER X PIPE, OUTLET SCREW, PAN HEAD WASHER, PLATE SCREW, BIND BD WASHER, PROTECTOR WASHER, WAVE DM GASKET, EXHAUST PIPE NUT, FLANGE BOLT, FLANGE WASHER, PLATE B1

14 CRANKCASE 1 3FA CRANKCASE ASSY V PIPE, BREATHER PIN, DOWEL F6-00 HOSE (L700) CLIP SCREW, PAN HEAD SCREW, PAN HEAD SCREW, PAN HEAD SCREW, PAN HEAD CLAMP SCREW, PAN HEAD WASHER, PLATE FA GASKET, CRANKCASE COVER M COVER, CHAIN CASE OIL SEAL PIN, DOWEL A7-00 O-RING SCREW, FLAT HEAD O-RING GASKET PLUG, STRAIGHT SCREW GROMMET FA ADAPTOR FA GASKET, CRANKCASE COVER PIN, DOWEL PIN, DOWEL SCREW, PAN HEAD CONTINUED ON NEXT FRAME B2

15 CRANKCASE SCREW, PAN HEAD CLAMP PLUG, STRAIGHT SCREW O-RING PLUG, STRAIGHT SCREW A3-00 O-RING B3

16 CRANKCASE COVER 1 1 3FA COVER, CRANKCASE FA GASKET, CRANKCASE COVER FA GASKET PIN, DOWEL PIN, DOWEL SCREW, PAN HEAD SCREW, PAN HEAD SCREW, PAN HEAD WASHER, PLATE FA PLUG, OIL LEVEL O-RING FA DUCT, AIR FA SEAL, AIR DUCT SCREW, PAN HEAD SCREW, PAN HEAD FA DUCT, AIR CLAMP, HOSE FA DUCT, AIR B4

17 STARTER CLUTCH 1 50M GEAR, IDLER 1 (55T-14T) BEARING FA SHAFT CIRCLIP WASHER, PLATE M WHEEL, STARTER (55T) BEARING CIRCLIP M STARTER CLUTCH ASSY F8-00 WASHER, PLATE B5

18 CLUTCH 1 3FA GEAR, PRIMARY DRIVE (14T) CIRCLIP BEARING OIL SEAL WASHER, PLATE SCREW, PAN HEAD FA CLUTCH CARRIER ASSY T SPRING, CLUTCH WEIGHT NUT DH CLUTCH HOUSING COMP NUT BEARING M PLATE, BEARING COVER SCREW, PAN HEAD FA PRIMARY SLIDING SHEAVE COMP OIL SEAL M WEIGHT W CAM CW SLIDER O-RING M PRIMARY SHEAVE CAP COMP SCREW, BIND WASHER, CLAW M-1763E PLATE V0-00 COLLAR FA V-BELT FA SHEAVE, PRIMARY FIXED WASHER, LOCK CONTINUED ON NEXT FRAME B6

19 CLUTCH NUT FA SECONDARY FIXED SHEAVE COMP FA SECONDARY SLIDING SHEAVE OIL SEAL O-RING W PIN, GUIDE W COLLAR, GUIDE F1-00 SPRING, COMPRESSION FA SEAT, SECONDARY SPRING. 1 B7

20 TRANSMISSION 1 3FA AXLE, MAIN (17T) FA GEAR, PRIMARY DRIVEN (43T) WASHER, PLATE SPACER FA REDUCTION GEAR ASSY (49T) WASHER, LOCK CIRCLIP M8-00 WASHER, PLATE FA CLUTCH, DOG BEARING (B6202) BEARING (B6204) FA AXLE, DRIVE (40T) A4-00 WASHER, PLATE BEARING BEARING FA HOUSING, BEARING FA GASKET, HOUSING CAP BOLT NUT FA PLATE, COVER W4-00 COLLAR OIL SEAL SPROCKET, DRIVE 12T (38V ) WASHER, LOCK NUT FA COUNTER AXLE ASSY (15T) BEARING BEARING (B6302) B8

21 SHIFT CAM - FORK 1 3FA SHIFT CAM ASSY BALL SPRING, COMPRESSION BOLT, WASHER BASED GASKET GB FORK, SHIFT HX BAR, SHIFT FORK GUIDE FA SHIFT SHAFT ASSY CIRCLIP OIL SEAL FA LEVER, SHIFT FA BOSS, SHIFT SPRING, TORSION PIN, CLEVIS WASHER, PLATE PIN, COTTER FA KNOB, SHIFT LEVER RIVET BOLT, FLANGE BOLT, HEXAGON SOCKET HEAD FA BRACKET WASHER, PLATE FA LEVER SPRING, TORSION F7-00 BOLT B9

22 FRAME 1 3FA FRAME COMP YB BOLT, WASHER BASED BOLT, WASHER BASED SPRING, TENSION V TENSIONER V BUSH WASHER, PLATE BOLT NUT, SELF-LOCKING BUSH, SOLID O-RING NIPPLE, GREASE FA STAY, ENGINE BOLT, FLANGE GB TOOL KIT NV-2811A GAUGE, AIR O-RING B10

23 FRONT FENDER 1 3FA-W FRONT FENDER COMP BOLT, WITH WASHER BOLT, WITH WASHER FA PANEL, FRONT FA CAP, CLEANER CASE FA ELEMENT, AIR CLEANER SCREW, PAN HEAD WASHER, PLATE FA-2171A COVER, TOP NUT SCREW, BINDING B11

24 REAR FENDER 1 3FA-W REAR FENDER COMP BOLT, WITH WASHER FA FLAP FA FLAP SCREW, BINDING WASHER, PLATE NUT, FLANGE UY DAMPER W SEAT, BATTERY FA STAY, FENDER FA STAY, FENDER BOLT WASHER B12

25 REAR ARM - SUSPENSION 1 3FA REAR ARM COMP YB NIPPLE, GREASE WASHER JX SHAFT, PIVOT A7-00 WASHER, PLATE NUT, SELF-LOCKING SEAL, GUARD BUSH FA COLLAR, DISTANCE A SEAL, GUARD A SEAL, GUARD FA-2219X COVER BOLT, FLANGE FA SHOCK ABSORBER ASSY, REAR YB BOLT, WASHER BASED SPRING, TENSION PIN, CLEVIS W COVER, THRUST WASHER, PLATE PIN, COTTER C1

26 STEERING 1 3FA COLUMN, STEERING PLUG, TAPER HR HOLDER, HANDLE LOWER K HOLDER, HANDLE BOLT, FLANGE UY PLANE BEARING, STEERING OIL SEAL FA BRACKET, STEERING LOWER BOLT UY WASHER, LOCK R0-00 COLLAR WASHER, PLATE NUT, SELF-LOCKING PIN, COTTER FA ROD, TIE UY JOINT, UNIVERSAL NUT UY JOINT, UNIVERSAL NUT (L.H. THREAD) 20 3FA ROD, TIE UY JOINT, UNIVERSAL NUT UY JOINT, UNIVERSAL NUT (L.H. THREAD) NUT, CASTLE WASHER, PLATE PIN, COTTER C2

27 FRONT SUSPENSION - WHEEL 1 3FA KNUCKLE, STEERING BUSH, SOLID NIPPLE, GREASE FA KNUCKLE, STEERING BUSH, SOLID NIPPLE, GREASE GB SPACER NL COVER, THRUST A8-00 BOLT WASHER, PLATE NUT, CASTLE PIN, COTTER FA FRONT LOWER ARM COMP. (LEFT) YB 14 3FA FRONT LOWER ARM COMP. (RIGHT) YB BUSH, SOLID R3-00 COLLAR UY COVER, THRUST NIPPLE, GREASE WASHER BOLT, WASHER BASED SPRING, TENSION FA SHOCK ABSORBER ASSY... 2 YB BOLT, WASHER BASED SPRING, TENSION C3

28 FUEL TANK 1 3FA FUEL TANK COMP FJ CAP ASSY HOSE (L310) GROMMET COLLAR L5-00 WASHER, PLATE BOLT, WITH WASHER GROMMET H4-00 COLLAR W FUEL COCK ASSY AJ SEAL, COCK SCREW, PAN HEAD X O-RING AJ VALVE PACKING WASHER, PLATE SCREW HOSE (L95) CLIP FA-2414A COVER, FILLER C4

29 SEAT 1 3FA SINGLE SEAT ASSY FA COVER, SEAT STOPPER, MAIN STAND NUT, FLANGE U LEVER, SEAT K BRACKET, SEAT LEVER K PIN SPRING, TORSION CIRCLIP C5

30 FRONT WHEEL 1 3FA HUB, FRONT BOLT, SERRATION FA SPACER, BEARING BEARING (B6003) OIL SEAL FA WHEEL COMP SL NUT W7-00 TIRE (AT20X7-8KT536A T/L N) 2 DUNLOP VALVE, RIM TAIHEIYO R2-00 COLLAR WASHER, PLATE NUT, CASTLE PIN, COTTER FA PLATE, BRAKE SHOE FOR LEFT 15 4BE-W BRAKE SHOE SET SPRING, TENSION G CAMSHAFT FA LEVER, CAMSHAFT FOR LEFT BOLT NUT H-2513A PLATE, INDICATOR O-RING OIL SEAL FA PLATE, BRAKE SHOE FOR RIGHT 25 4BE-W BRAKE SHOE SET SPRING, TENSION G CAMSHAFT FA LEVER, CAMSHAFT FOR RIGHT BOLT CONTINUED ON NEXT FRAME C6

31 FRONT WHEEL NUT H-2513A PLATE, INDICATOR O-RING OIL SEAL C7

32 REAR WHEEL 1 3FA COLLAR, WHEEL BOLT, SERRATION FA REAR WHEEL COMP SL W8-00 TIRE (AT22X10-8KT537A T/L N) 2 DUNLOP VALVE, RIM TAIHEIYO NUT FA HUB, REAR BEARING OIL SEAL FA SPACER, BEARING FA-W BRAKE SHOE SET SPRING, TENSION X CAMSHAFT N LEVER, CAMSHAFT BOLT NUT F-2533A PLATE, INDICATOR O-RING FA SPROCKET, DRIVEN (32T) V WASHER FA COLLAR, SPROCKET AXLE NUT V COVER, HUB DUST BOLT, STUD FA AXLE, WHEEL FA BOSS NUT BOLT, STUD FA-2531E DRUM, BRAKE CONTINUED ON NEXT FRAME C8

33 REAR WHEEL WASHER NUT FA RING SCREW, PAN HEAD WASHER, SPRING WASHER, PLATE X COVER SCREW, PAN HEAD WASHER, SPRING O-RING OIL SEAL BOLT, WASHER BASED BOLT, WASHER BASED W0-00 COLLAR A5-00 WASHER, PLATE F2-00 WASHER, PLATE BOLT NUT WASHER, PLATE NUT, CASTLE PIN, COTTER UY PULLER, CHAIN BOLT NUT CHAIN (DID520V6 74L-ENDLESS) C9

34 STEERING HANDLE - CABLE 1 3FA HANDLEBAR GB GRIP FA PROTECTOR, HANDLEBAR GT-2836B TUNING FORK MARK FA CABLE, THROTTLE FA CABLE, BRAKE BOLT NUT NUT, WING E1-00 SPRING, COMPRESSION WASHER, PLATE PIN GB THROTTLE LEVER ASSY GB-2628F CAP, GEAR GB-2625E BODY, THROTTLE GB-2625G LEVER, THROTTLE GB-2625H ARM, THROTTLE GB-2628G GASKET SPRING, TORSION M4-00. WASHER, PLATE BOLT, FLANGE SCREW, PAN HEAD SCREW, PAN HEAD NUT GB LEVER F3-00. BOLT NUT, U GB JOINT, CABLE V8-00. COLLAR CONTINUED ON NEXT FRAME C10

35 STEERING HANDLE - CABLE BOLT, FLANGE SCREW, PAN HEAD FA BOOT, HANDLEBAR GB CABLE, BRAKE SPRING, COMPRESSION BOLT NUT FA CABLE, STARTER FA HOLDER BOLT, FLANGE C11

36 STAND - FOOTREST 1 3FA FOOTREST BOLT, FLANGE FA COVER FA COVER SCREW, BINDING SCREW, BINDING NUT, FLANGE WASHER, PLATE NUT, FLANGE FA BOARD, FOOTREST SCREW, BINDING NUT, FLANGE C12

37 GUARD 1 3FA-2845N BAR, CARRY FRONT YB BOLT, FLANGE FA-2845R BAR, CARRY REAR YB BOLT, FLANGE D1

38 GENERATOR 1 3FA ROTOR ASSY FA BASE ASSY FA COIL, CHARGE FA COIL, LIGHTING KG COIL, PULSER SCREW, PAN HEAD SCREW, PAN HEAD SCREW, PAN HEAD WASHER, SPRING SCREW, PAN HEAD WASHER, SPRING SCREW, PAN HEAD H1-00 WASHER, PLATE NUT FA SPACER D2

39 STARTING MOTOR 1 3FA STARTING MOTOR ASSY M M0-00. BRUSH SET O-RING O-RING FA BOLT FA-8183G CORD COMP BOLT WASHER, SPRING WASHER, PLATE D3

40 HEADLIGHT BULB (12V-25/25W) FA LENS ASSY FA HOLDER, SOCKET FA RIM, HEADLIGHT FA SCREW, RIM ADJUSTING FA NUT FA BODY, HEADLIGHT FA SCREW, RIM FITTING FA PILOT LIGHT ASSY BULB (12V-3.4W) FA PILOT LIGHT ASSY BULB (12V-3.4W) GROMMET COLLAR WASHER, PLATE BOLT WASHER, SPRING D4

41 TAILLIGHT 1 38W TAILLIGHT UNIT ASSY W LENS, TAILLIGHT W BULB (12V-3.8W) SCREW, PAN HEAD WASHER UY BRACKET, TAILLIGHT W DAMPER, TAIL COLLAR BOLT WASHER, SPRING WASHER, PLATE D5

42 HANDLE SWITCH - LEVER 1 3FA HOLDER, LEVER FA LEVER FA LEVER, LOCK BOLT YW FRONT STOP SWITCH ASSY SCREW, PAN HEAD NUT, U FA SPRING, RETURN FA PIN, LOCK FA RING, SNAP FA SWITCH, HANDLE SCREW, PAN HEAD D6

43 ELECTRICAL 1 1 3FA C.D.I. UNIT ASSY SCREW, PAN HEAD WASHER, SPRING WASHER, PLATE KJ IGNITION COIL ASSY BOLT WASHER, SPRING BOLT UY PLUG CAP ASSY H NEUTRAL SWITCH ASSY KM NEUTRAL SWITCH ASSY GASKET FA SWITCH SCREW FA WIRE, LEAD GB RECTIFIER & REGULATOR ASSY SCREW, PAN HEAD WASHER, PLATE KD STARTER RELAY ASSY NUT WASHER, SPRING U RELAY ASSY NL RELAY ASSY FA BATTERY ASSY HOSE (L500) FA WIRE, PLUS LEAD FA WIRE, MINUS LEAD BAND, BATTERY CONTINUED ON NEXT FRAME D7

44 ELECTRICAL GB FUSE HOLDER ASSY GB FUSE (5A) FA WIRE HARNESS ASSY TB BAND, SWITCH CORD BAND CLAMP BAND, SWITCH CORD GB MAIN SWITCH ASSY HN CAP, KEY ATV KEY BLANK (TYPE-A)... 1 NOT SHOWN ATV KEY BLANK (TYPE-B)... 1 NOT SHOWN D8

45 EMBLEM - LABEL 1 1 3FA GRAPHIC SET, FRONT FENDER EMBLEM, YAMAHA FE LABEL, WARNING RIVET, BLIND WASHER, PLATE FA-2151E-A0-00 LABEL FE LABEL, CAUTION RIVET, BLIND WASHER, PLATE FA-2163G EMBLEM FE-2151H LABEL RIVET, BLIND WASHER, PLATE FA LABEL, CAUTION RIVET, BLIND WASHER, PLATE FA-2819R TAG, WARNING D9

46 ALTERNATE (ENGINE) 1 3FA STARTER ASSY FA CASE, STARTER FA DRUM, SHEAVE R PAWL, DRIVE R SPRING, STARTER R SPRING, FRICTION R SPRING R PLATE, DRIVE BOLT FA WIRE, STARTER FA HANDLE, STARTER FA WASHER, FLAT FA COVER FA PULLEY, STARTER AP SCREW, PAN HEAD AP 16 3FA GASKET AP OIL SEAL AP 18 3FA ADAPTOR AP FOR MANUAL STARTER D10