Parts Manual COMPACT TRACTOR MODEL CUB CADET LLC P.O. BOX CLEVELAND, OHIO [

Transcription

1 Parts Manual SERIES 000 COMPACT TRACTOR MODEL CUB CADET LLC P.O. BOX CLEVELAND, OHIO -00 [ PRINTED IN U.S.A. FORM -000B ECO (/0)

2 -- TABLE OF CONTENTS DESCRIPTION PAGE Frame... Pedestal... Front Axle WD... WD Axle Assembly... Hydraulics... 0 Lift Valve and Position Control... Dash Panel and Steering Wheel... Controls... Battery and Electrical... Transmission Connections... Transmission WD Transmission... Differential and Final Drive... WD Traction Drive... PTO Drive... 0 Engine and Drive Shaft... Engine Cylinder Heads and Crankcase... Pistons and Crankshaft... Valves and Camshaft... Lubrication... Electrical... Cooling... Control Linkage and Governor... Carburetor... Air Filter... Starter... 0 Hood, Grill and Side Panels... 0 Fender and Running Board... Seat Assembly... Fuel Tank... Foldable ROPS... Three Point Hitch... Auxiliary Hydraulic Loader Valve (If Equipped) Wheels 0

3 -- FRAME 0 NUMBER CODE DESCRIPTION QTY. 0-0 Frame A Lever, Hood Latch... 0-A Bracket, Running Board Mtg. LH... 0-A Bracket, Running Board Mtg. RH Bracket, Hood Latch Mtg Screw, Hex Cap,... /- x. GR 0-0 Screw, Carriage,... /- x. 0-0A Screw, Hex Wash. Hd.... /- x. -00A Nut, Hex Flange Lock, / Latch, Hood...

4 -- PEDESTAL 0 0 NUMBER CODE DESCRIPTION QTY. 0-A Pedestal Bracket, Dash Mtg. RH Bracket, Dash Mtg. LH Bracket, Steering Column Bracket, Brake Lever Bracket, Pump Mtg Screw, Hex Wash, Hd Tapp... /- x. 0-0 Screw, Hex Wash, Hd Tapp... /-0 x. 0-0 Screw, Hex Wash, Hd Tapp... /-0 x A Screw, Hex Wash, Hd Tapp... /- x. NUMBER CODE DESCRIPTION QTY Screw, Hex Cap... /- x. GR - Shaft, Steering Nut, Speed, / Nut, Hex Nylon Insert Lock,... /- GR -00A Nut, Hex Flange Lock, /- -00 Pin, Internal Cotter Ring, Snap,. ID... - Pump, Hydraulic Steering... - Lever, Parking Brake Washer, Flat,. x. x Bearing, Hex Flange,. ID... - Pin, Parking Brake Pivot... -A Rod, Parking Brake...

5 -- FRONT AXLE WD 0 NUMBER CODE DESCRIPTION QTY Plate, Steering Cylinder Mtg Axle Assembly, Front WD Screw, Hex Cap, M-. x.gr 0-00 Screw, Set, /- x / Screw, Hex Cap, /- x. GR -0 Stud, Cylinder Mtg Nut, Hex Nylon Insert Lock... /- GR -0 Nut, Hex Nylon Insert Lock... /- GR -0 Nut, Hex Lock, / Cylinder, Steering... -A Shaft, Drive WD... - Bracket, Axle Mtg....

6 , WD AXLE ASSEMBLY

7 -- WD AXLE ASSEMBLY NUMBER DESCRIPTION QTY. IM-00 Housing Assembly, Axle... Includes Ref. No. IM Pin, Dowel... IM-00 Housing, Axle LH... IM-000 Gauge, Oil Level... IM-00 Housing Assembly, Pinion Gear.. Includes Ref. No. IM O-Ring... IM-000 Bearing, Ball... IM-0000 Bearing, Ball... IM-0000 Ring, Snap... 0 IM-00 Gear, Final Pinion Idler... IM-0 Shaft, Idler Drive... IM-0000 O-Ring... IM-0 Housing, Final Drive LH... IM-0 Housing, Final Drive RH... IM-00 Gear, Final Drive Pinion... IM-000 Bearing, Tapered... IM Bearing, Ball... IM Seal, Oil... IM-0000 Plug... 0 IM-0000 Washer, Seal... IM-0000 Washer, Seal... IM- Housing, Final Drive... IM-0 Wheel Hub/Shaft... IM-00 Gear, Final Drive... IM-0000 Seal, Oil, mm x mm x mm IM-0000 Bearing, Ball... NUMBER DESCRIPTION QTY. IM-0000 Bearing, Ball... IM Ring, Snap... IM-00 Kingpin... 0 IM-0 Arm, Steering LH... IM-00 Arm, Steering RH... IM-00 Bolt, M0 x... IM-000 Bolt, M0 x 0... IM-000 Bolt, M x 0... IM-00 Bolt, M x... IM-000 Bolt, M0 x... IM-000 Bolt, M x... IM Nut, M... IM-0 Collar... 0 IM-000 Bolt, M x... IM-00 Rod, Tie... IM-00 Tie Rod End, LH... Includes Ref. Nos. thru IM-00 Cover, Dust... IM-00 Nut, Castle, M x.... IM-0000 Pin,Cotter... IM-00 Tie Rod End, RH... Includes Ref. Nos. thru IM-0000 Nut, Jam, LH Thrd... IM Nut, Jam, M RH Thrd... 0 IM Washer, Seal... IM-0000 Bearing, Ball... IM-00 Shim, 0.T... AR IM-00 Shim, 0.T... AR

8 -- WD AXLE ASSEMBLY

9 -- WD AXLE ASSEMBLY NUMBER DESCRIPTION QTY. IM-00 Mtg. Bracket, Axle Front... Includes Ref. No. IM-000 Bushing... IM-000 Mtg. Bracket, Axle Rear... Includes Ref. No. IM-00 Bushing... IM-0000 Seal, Oil... IM-0 Washer, Thrust... IM-0000 Seal, Oil... IM-0 Washer, Thrust... IM Fitting, Grease... 0 IM-000 Shim Kit, Service Only... IM-0 Collar... IM-0000 O-Ring... IM-0000 Nut... IM-0 Shaft, Differential LH... IM-0 Shaft, Differential RH... IM-00 Shim, 0.T... AR IM-00 Shim, 0.T... AR IM-00 Shim, 0.T... AR IM-0000 Bearing, Ball... 0 IM-0 Spacer... IM-000 Bearing, Ball... IM-00 Housing, Differential... IM-00 Plate, Locking... IM-000 Bolt, M x... IM-00 Shaft, Pinion... IM Pin, Spring... IM-00 Gear Set, Ring and Pinion... IM-000 Gear, Pinion... IM-00 Washer, Thrust... 0 IM-000 Gear, Differential... IM-0000 Bearing, Ball... IM-0 Spacer... IM-00 Shim, 0.T... AR IM-00 Shim, 0.T... AR IM-00 Shim, 0.T... AR IM-00 Washer, Thrust... IM-0 Shim, 0.T... AR IM-0 Shim, 0.T... AR IM-00 Shim, 0.T... AR 0 IM-000 Bearing, Tapered Roller... IM Seal, Oil...

10 -0- HYDRAULICS 0 - Cylinder Piston End - Cylinder Base End -A -A -A NUMBER CODE DESCRIPTION QTY Screw, Hex Wash Hd. Tapp... /- x. -00A Nut, Hex Flange Lock,... /- GR -0 Clamp, Adjustable Hose -000 Clamp, Hose Clamp, Hose Fitting, 0 Degree... - Hose, Steering... - Tube, Oil Cooler Return... NUMBER CODE DESCRIPTION QTY. - Hose, Oil Return Tube, Lift Return Line... - Hose, Lift Cylinder... -A Hose, Lift Inlet... -A Hose, Steering Pressure... -A Hose, Steering Tank... - Manifold, Return Tube, Cylinder Return... - Fitting, 0 Degree...

11 -- LIFT VALVE AND POSITION CONTROL NUMBER CODE DESCRIPTION QTY. 0-0 Link Assembly, Feedback Link Assembly, Input Link, HI-LO Shifter Link, Feedback Bracket, Lift Brace Bracket, Valve Mtg A Handle, HI-LO Shifter Bracket, Lift Mtg A Handle, Lift Screw, Hex Cap,... /-0 x. GR 0-00 Screw, Hex Wash Hd. Tapp... /- x Screw, Hex Cap,... /- x. GR - Ferrule, Feedback Adjustment.. - Pin,. x Link, Valve Nut, Hex Nylon Insert Lock GR NUMBER CODE DESCRIPTION QTY. -00A Nut, Hex Flange Lock,... /- GR -0 Nut, Hex Jam, /-0 GR Pin, Spirol, / x Valve, Hydaulic Lift Washer, Friction,. x. x. - Grip, Handle Spring, Compression Spring, Compression Washer, Flat,. x.0 x. -0 Washer, Belleville,.... x. x.0-0 Clevis, Adjustment Bearing, Nylon Flange. ID... - Rod, Feedback Rod, Hi-LO Connecting Shaft, Hi-Lo Shifter Nut, Hex Nylon Lock, / Pin, Internal Cotter...

12 -- DASH PANEL AND STEERING WHEEL 0 THROTTLE ASSEMBLY HARDWARE POSITIONS 0

13 -- DASH PANEL AND STEERING WHEEL NUMBER CODE DESCRIPTION QTY. 0-0 Tab Assembly, Throttle Wire Harness, Dash Boot, Steering Shaft A Dash Plate, Throttle Mtg A Screw, Hex Wash. Hd. Tapp... /- x. 0-0 Screw, Pan Hd., /-0 x Screw, Hex Cap, /-0 x. GR.. -0 Nut, Hex Lock, / Nut, Speed, / Nut, Hex Insert Jam Lock, /- -0 Washer, Friction,. x. x Plug Panel, Instrument... Bulb... Plug... - Switch, Headlight... - Switch, PTO... - Switch, Ignition... - Switch, Hazard Steering Wheel, Soft Grip Cover, Steering Wheel... - Handle, Throttle... - Panel, Dash Insert Washer, Belleville,. x. x.0-0 Washer, Lock, / Washer, Belleville,. x. x.0-0 Washer, Flat,.0 x.0 x A Cable, Throttle Key Set, Ingition...

14 -- CONTROLS A A B B

15 -- CONTROLS NUMBER CODE DESCRIPTION QTY. 0-0 Shaft Assembly, Brake Shaft Assembly, Forward A Link Assembly, Pedal A Plate, Bearing Link Assembly, Brake LH A Link Assembly, Parking Brake Link Assembly, Brake RH Shaft Assembly, Differential Link, PTO Select Bracket, Reverse Switch Bracket, Differential Pivot Handle, PTO Link, Differential Pivot Bracket, Diff. Actuator Mtg Bracket, Reverse Switch Screw, Hex Wash Hd Tapp... /-0 x. 0-0 Screw, Hex Wash Hd Tapp... /-0 x. 0-0A Screw, Hex Wash Hd Tapp... /- x. 0-0A Screw, Hex Wash Hd Tapp... /- x Pin, Clevis, / x A Ferrule, /- x. Dia. Hdn - Ferrule, Brake... - Ferrule, /- x Nut, Hex Lock, / Nut, Hex Flange Lock, / Nut, Hex Flange Lock, / Nut, Hex Jam, / Nut, Hex Flange Lock, / Nut, Hex, M x. GR Link, Chain Pin, Internal Cotter Pin, Internal Cotter... NUMBER CODE DESCRIPTION QTY. -00 Pin, Internal Cotter... -A Switch, Plunger... -A Switch, Plunger Cylinder, Damper... - Pedal, Brake... -A Pedal, Forward/Reverse Pedal, Differential Grip, Handle Spring, Compression... -0A Spring, Torsion Spring, Rev/No Cut Spring, Compression... - Spring, Switch Actuator... - Spring, Extension Washer, Flat,. x. x Washer, Flat,. x. x.0-0 Washer, Wave,. x. x Washer, Flat,. x..0 x. -0 Washer, Flat,. x. x Screw, Shoulder,.0 x Screw, Shoulder,. x. -0 Screw, Shoulder... / x.0: /- -0 Bearing, Nylon..0 ID x Bearing, Hex Flange,. ID Bearing, Flange,. x. x. -0 Bearing, Flange.... x. x. -0 Bearing, Flange.... x. x. 0 - Rod, Hydro Control... - Rod, Brake, LH Rod, Brake, RH... - Rod, PTO Control... - Rod, Diff. Lock Control...

16 -- BATTERY AND ELECTRICAL 0 NUMBER CODE DESCRIPTION QTY. -00 Harness, Main Wire Strap, Battery Holddown Bracket, Fuse Center Screw, Hex Cap, /-0 x. GR 0-0 Screw, Hex Wash Hd. Tapp... /-0 x. -0 Nut, Hex Nylon Insert Lock, /-0-0 Nut, Wing w/bell Washer, /- - Battery, 00 cca Dry... - Switch, PTO Reverse Override Rod, Battery Holddown... Not Shown

17 -- TRANSMISSION CONNECTIONS NUMBER CODE DESCRIPTION QTY Bracket, Lower Hitch RH Bracket, Lower Hitch LH Bracket, Top Link A 0 Bracket, Cylinder Bracket, Drawbar... 0-A S0 Shield, PTO... Graphic, Warning... 0-A Bracket, Chain LH... 0-A Bracket, Chain RH Screw, Hex Cap... /- x /0 GR 0 0-0A Screw, Hex Cap... /- x. GR 0- Screw, Hex Cap... /- x. GR NUMBER CODE DESCRIPTION QTY. 0-0 Screw, Hex Cap... /- x. GR 0-0 Screw, Hex Cap... /- x. GR 0- Screw, Hex Cap... /- x. GR 0- Screw, Hex Cap... 0 /- x.0 GR -0 Pin, Lift,. x Nut, Hex Lock, / Ring, Snap, Dia Cylinder, Lift Washer, Flat,. x. x Bracket, Hitch Clip Rod, Top Link Retainer...

18 -- WD TRANSMISSION

19 -- WD TRANSMISSION -00 NUMBER CODE DESCRIPTION QTY. Service Transmission Ass y. See Note below. -0 Transmission Oil, Qt.. gl. -0 Transmission Oil, Gal. -0 Transmission Oil, Gal. - Sealant, Loctite Black,. oz. AR 0-0A Arm, Hydro Control A Bracket, Transmission Mtg. RH 0-0A Bracket, Transmission Mtg. RH -0 Cover, Transmission Housing.. 0- Plate, Feedback Baffle, Oil Arm, Neutral RH Arm, Neutral LH Screw, Hex Cap,... /-0 x. GR Screw, Hex Cap Lock,....- x.0 GR 0-0 Screw, Hex Cap,... /- x. GR 0- Screw, Plug, M x. x Screw, Hex Special Set,... /- x Screw, Hex Cap,... /- x. GR 0-0 Screw, Hex Cap,... /-0 x. GR 0-0 Screw, Hex Cap,... /- x. GR 0-0 Screw, Hex Cap Lock,... /- x. GR 0- Screw, Low Hd. Cap,... /- x. - Shaft, Rock Nut, Hex Flange Lock, /-... NUMBER CODE DESCRIPTION QTY. -0 Ring, Retaining Ring, Retaining Pump, Hydrostatic Transmission - Pump, Auxiliary Hydraulic... - Arm, Upper Hitch RH... - Arm, Upper Hitch LH O-Ring,. ID x.0 Dia Seal, Oil,. x.0 x Filter, Oil Filter, Oil Breather, Transmission... - Sensor, RPM Fitting, Tube, Auxiliary Pump Suction.. - Tube, Hydro Suction Grommet... - Spring, Extension Washer, Flat,.0 x.0 x Fitting, Grease Plug, Fitting Fitting, Filter Nipple Fitting, Fitting, Fitting, Straight... - Fitting, Straight Screw, Shoulder,. Dia x. -00 Screw, Shoulder,.0 Dia x Screw, Shoulder,.... x.: /- -0 Bearing, Sleeve,.... x. x Spacer,.0 x.0 x Spacer,. x. x Dipstick... DOES NOT include the following components and their associated mounting hardware: Brake Assemblies; Hydro Pump w/filter and Linkage; Transmission Mounting Brackets; Point Hitch Rock Shaft and Arms; and RPM Sensor. Also DOES NOT include the hydraulic tubes and fittings.

20 -0- DIFFERENTIAL AND FINAL DRIVE

21 -- DIFFERENTIAL AND FINAL DRIVE NUMBER CODE DESCRIPTION QTY. -00 Housing, Axle Brake Assembly, Drum Screw, Hex Cap Lock,... 0 /- x. GR 0- Screw, Socket Hd. Cap, /- x Screw, Hex Cap Lock, /- x. GR 0- Screw, Hex Cap Lock,... /- x. GR - Shaft, Axle Stub RH... - Shaft, Axle... - Shaft, Axle Stub LH A Shaft, Differential Lock Actuator Pin, Dowel,. x Pin, Dowel,. x Ring, Retaining Rjng, Retaining Ring, Retaining Ring, Retaining Ring, Retaining Clip, Rotor Ring, Retaining Gear, Differential, 0T... - Shaft, Cross... - Shaft, Cross Block, Differential Pinion... - Gear, Bevel, T... - Gear, Miter, T... - Gear, Drop Axle, T RH... - Gear, Drop Axle, T LH Carrier, Differential Collar, Differential Lock Yoke, Differential Lock... - Cover, Bearing Seal, Oil, 0mm x mm x 0mm Seal, Oil A Seal, Oil,. x. x Spring, Compression Washer, Flat,. x.0 x Washer, Thrust,. x. x Bearing, Ball Bearing, Ball Bearing, Ball... - Bearing, Thrust... -0A Bearing, Ball Bearing, Needle Drum, Brake...

22 -- WD TRACTION DRIVE 0 0 0

23 -- WD TRACTION DRIVE NUMBER CODE DESCRIPTION QTY Pin Assembly, Speed Screw, Hex Cap Lock,... /- x. GR 0-00 Screw, Cup Set, /- x /... - Shaft, Motor... - Shaft, Pinion, T... - Shaft, WD... - Shaft, Speed Actuator Pin, Spirol, / x Ring, Retaining Ring, Retaining Ring, Retaining Ring, Retaining Clip, Rotor... - Gear, Drive Pinion, LO T:T... - Gear, Drive Pinion, HI T: T Gear, Drive, LO:T; HI 0T... - Clutch, Overrunning Cover, Front Spacer, Drive Collar, Speed Seal, Oil O-Ring Seal, Oil Spring, Detent Washer, Thrust Ball, Detent Bearing, Ball Bearing, Ball Bearing, Angular Contact Ball Bearing, Thrust Bearing, Ball Bearing, Ball... - Bearing, Sleeve Yoke, Speed...

24 -- A A PTO DRIVE

25 -- PTO DRIVE NUMBER CODE DESCRIPTION QTY. - Clutch Assembly, PTO... -0A Housing, Rear Screw, Hex Cap Lock,... /- x. GR 0- Screw, Hex Wash Hd,... /- x. GR 0-00 Screw, Cup Set, /- x / Screw, Hex Cap, /-0 x. GR 0- Screw, Hex Cap Lock,... /- x.0 GR Screw, Round Hd, mm x 0mm - Shaft, 0 PTO Shaft, Input... - Shaft, 000 PTO... - Shaft, PTO Back... - Shaft, PTO Actuator Ring, Retaining Ring, Retaining Ring, Retaining Ring, Retaining Ring, Retaining Ring, Retaining Ring, Retaining... - Gear, 0 PTO: T... - Gear, Auxiliary Drive Idler: T. - Gear, 000 PTO: T Gear, Auxiliary Drive Pinion: T - Gear, Auxiliary Drive: T... - Gear, 0 PTO Pinion: T... -B Gear, 000 PTO Pinion: T Gear, 000 PTO Pinion: T Gear, Spline Coupling Cover, 000 PTO... NUMBER CODE DESCRIPTION QTY. - Collar, Speed... - Coupling, PTO... -0A Actuator, PTO Seal, Oil Seal, Oil O-Ring Plug, Oil Seal, Oil A Seal, Oil Spring, Compression Spring, Detent Spring, Compression Washer, Flat,. x.0 x Washer, Flat,.... x.0 x.0-0 Washer, Thrust, x. x.0-0 Bearing, Sleeve,... 0mm x mm x 0mm -0 Ball, Detent Bearing, Sleeve,... mm x mm x 0mm -00 Bearing, Ball Bearing, Needle... -0A Bearing, Ball Bearing, Ball Bearing, Ball Bearing, Needle Thrust Arm, PTO Select Spacer, mm x 0mm x mm 0- Spacer,.0 x. x Washer, Flat,. x. x Spacer,.0 x. x.0...

26 ENGINE AND DRIVE SHAFT

27 -- ENGINE AND DRIVE SHAFT NUMBER CODE DESCRIPTION QTY. -0 Harness, Engine... 0-A Plate, Engine Mtg Bracket, Filler Neck S0 0- S0 0- S0 S0 Bracket, Radiator Mtg. RH. Graphic, Warning... Bracket, Radiator Mtg. LH. Graphic, Warning... Plate, Radiator Baffle... Graphic, Fan Warning... Graphic, Warning Bracket, Radiator Mtg Bracket, Ovrflw Bottle Mtg Plate, Baffle RH Plate, Baffle LH Shield, Heat Screw, Square Hd. Set,... /- 0-0 Screw, Hex Cap,... /- x.0 GR 0-0 Screw, Hex Cap,... /-0 x.0 GR 0-0 Screw, Hex Wash Hd Tapp /-0 x Screw, Hex Wash Hd Tapp /- x. 0-0 Screw, Hex Wash Hd Tapp /- x. 0-0A Screw, Hex Wash Hd Tapp /- x. 0- Screw, Hex Cap, M-0 x 0-0 Screw, Hex Cap,... /-0 x. GR Screw, Hex Cap,... M0 x. x -0 Nut, Hex Nylon Insert Lock /-0 GR -0 Nut, Hx Flnge Lock, /- NUMBER CODE DESCRIPTION QTY. - Shaft, Drive... - Cooler, Oil Tape, Foam,. wide... in. -0 Seal, Heat Baffle... in. - Wire, Battery Neg Wire, Battery Pos Tie, Cable - Push Mount Clamp, Hose Clamp, Hose - Adjustable Clamp, Hose Grommet... - Shroud, Fan Grommet Washer, Flat,.... x. x.0-00 Cable, Choke Control Fuel Line / ID... in. - Muffler Hose, Filler to Radiator... - Radiator... - Hose, Lower Radiator... - Hose, Engine to Filler Neck -0 Filler Neck, Remote Radiator - Cap, Remote Filler... - Screen, Radiator Hose, Intake Air... KM-00-0 Pump, Fuel... KM-0-0 Filter, Fuel... 0 KM-00- Gasket, Exhaust... KM-F000 Washer, Spring... KM-R000 Nut, Hex... KM-0-0 Key, Crankshaft... KM-0-0 Bottle, Over Flow... KM-0-0 Tube... Not Shown

28 -- CYLINDER HEADS AND CRANKCASE A 0 0 A 0 0

29 -- CYLINDER HEADS AND CRANKCASE NUMBER DESCRIPTION QTY. KM-00- Gasket, Head... KM-00- Head, Cylinder... KM-00- Head, Cylinder... KM-0-0 Cover, Rocker... KM-0-0 Cover, Rocker... KM-00- Gasket, Breather... KM-00-0 Gasket, Rocker Cover... KM--0 Plate, Breather... KM-0-0 Cover, Breather... 0 KM-- Valve, Breather... KM-0- Cover, Crankcase... KM-0- Crankcase,... (Includes Ref. Nos. and ) KM-0-0 Joint... KM-00-0 Screw... KM-0-0 Pin... KM-0- Seal, Oil... KM-0- Seal, Oil... KM-0-0 Seal... KM-- Bearing, Plane... 0 KM-- Bearing, Plane... KM-- Bolt, M x... KM-- Bolt, M x 0... KM-0-00 Clamp... KM--0 Tube... KM-0G00 Bolt, Flange... KM-0G00 Bolt, Flange... KM-0G0 Bolt, Flange... KM-0G00 Bolt, Flange... KM-G0 Bolt, Stud... 0 KM-0B0 O-Ring...

30 -0- PISTONS AND CRANKSHAFT NUMBER DESCRIPTION QTY. KM-00- Piston... KM-00-0 Pin, Piston... KM Ring Set, Piston... KM--0 Rod, Connecting... (Includes Ref No. [Qty. ]) KM-- Crankshaft Assembly... (Includes Ref Nos. and ) KM-0- Gear, Spur, T... KM-0-00 Ring, Snap... KM--0 Bolt, x... KM-0A00 Key, Woodruff...

31 -- VALVES AND CAMSHAFT NUMBER DESCRIPTION QTY. KM-0-0 Bracket... KM-00- Valve, Intake... KM Valve, Exhaust... KM Retainer, Valve Spring... KM-0-0 Collet... KM-0-0 Arm, Rocker... KM-0-00 Tappet... KM--0 Rod, Push... KM-00-0 Seat, Spring... NUMBER DESCRIPTION QTY. 0 KM-0-00 Spring, Valve... KM-- Camshaft... KM-0-00 Seal, Oil... KM--0 Spring... KM-- Bolt, M... KM--0 Collar... KM-00- Washer,. x x.... KM-0G0 Bolt, Flanged... KM-B000 Nut, Hex...

32 -- LUBRICATION 0 0 NUMBER DESCRIPTION QTY. NUMBER DESCRIPTION QTY. KM-00- Gasket, Drain Plug... KM-0- Gear, Spur, T... KM-0- Shaft, Oil Pump... KM-- Drain, Oil... KM-0-0 Holder, Oil Pump... KM-0-0 Pin... KM-0-0 Cover, Oil Pump... KM-0-0 Plug, Drain... KM-- Cap, Oil Filler... KM--0 Spring... KM--0 Rotor, Pump Outer... KM-0G0 Bolt, Flanged... KM--0 Rotor, Pump Inner... KM-0G0 Bolt, Flanged... KM--0H Pipe, Oil Gauge... KM-00A00 Ball, Steel... KM-0-0 Filter, Oil... 0 KM-0B00 O-Ring... 0 KM-0-0 Filter, Oil Suction... KM-0B0 O-Ring... KM-00- Gauge, Oil...

33 -- ELECTRICAL NUMBER DESCRIPTION QTY. KM-00- Gasket... KM-0-0 Bracket... KM-0-0 Cover, Flywheel... KM-0-0 Regulator, Voltage... KM--00 Coil, Ignition, No.... KM--0 Coil, Ignition, No.... KM-- Flywheel Assembly... KM-00-0 Fuse... KM-00- Harness (Includes Ref. No. ). 0 KM-00-0 Switch... KM-00- Switch... KM-0- Coil, Charging... KM-00- Screw... KM-0-0 Washer... KM-0- Collar,. x. x... NUMBER DESCRIPTION QTY. KM-0-0 Clamp... KM-BPRES Plug, Spark... KM-0- Band... KM--0 Bolt, x KM-0-00 Clamp... KM--00 Clamp... KM-00- Washer,. x 0 x.0... KM-0G00 Bolt, Flanged... KM-0G00 Bolt, Flanged... KM-0G0 Bolt, Flanged... KM-0G0 Bolt, Flanged... KM-0G00 Bolt, Flanged... KM-B00 Screw, Pan... KM-B00 Screw, Pan... 0 KM-0A00 Key, Woodruff...

34 -- COOLING 0 0, 0 0

35 -- COOLING NUMBER DESCRIPTION QTY. KM-00-0 Gasket... KM-00- Gasket, Thermostat... KM-0-0 Shaft, Impeller... KM-0- Shaft, Pulley... KM-0-00 Housing Assembly... Includes Ref. Nos., & KM--0 Cover, Pump... KM-0- Body, Upper... KM-0-00 Body, Valve... KM-0-0 Hose, Cooling... 0 KM-0-0 Hose, Cooling... KM-0-0 Hose, Cooling... KM-0-0 Adapter... KM-0-0 Pump Assembly, Water... KM-0-0 Thermostat... KM-0-0 Seal, Mechanical... KM-0-0 Belt... KM-0-0 Fan... KM-0- Gear, Spur, T... KM-0-0 Pulley... 0 KM-0-0H Pulley... KM--0 Impeller... KM--0 Case, Pump... KM-0- Spacer, x x.... KM-0- Pin... KM-0- Bearing, Ball... KM-0- Seal, Oil... KM-0- Clamp... KM--0 Clamp... KM-0-0 Shim, T=0.... AR 0 KM-0-0 Shim, T=.... AR KM-00- Washer... KM-00- Washer 0. x x KM-0C0 Bolt, Flanged... KM-0G0 Bolt, Flanged... KM-0G0 Bolt, Flanged... KM-0G00 Bolt, Flanged... KM-0G00 Bolt, Flanged... KM-0G0 Bolt, Flanged... KM-0G0 Bolt, Flanged... 0 KM-0G00 Bolt, Flanged... KM-0G00 Bolt, Flanged... KM-B000 Nut, Hex Fine... KM-0B000 Washer, Plain... KM-F000 Washer, Spring... KM-J00 Circlip... KM-A0 Pin, Dowel... KM-0B0 O-Ring...

36 -- CONTROL LINKAGE AND GOVERNOR NUMBER DESCRIPTION QTY. KM-0- Bracket... KM-- Lever, Throttle... KM-- Lever, Choke... KM-- Link, Choke... KM--0 Link... KM--0 Arm Assembly... KM-00-0 Arm, Governor Pivot... KM--0 Spring, Governor... KM-0-00 Sleeve... 0 KM-0-0 Gear Assembly, Governor... KM--0 Panel, Control Complete... KM-00-0 Bolt... KM-00- Bolt... KM-00- Screw, x 0... KM-0- Nut... KM-0- Washer, x x.... KM-0- Collar... NUMBER DESCRIPTION QTY. KM-0-0 Clamp... KM-- Collar, x x KM-- Collar... KM--0 Spring... KM--0 Spring... KM--0 Spring... KM-0- Bolt, x... KM-00-0 Washer... KM-00-0 Washer,. x x.... KM-00-0 Washer,. x x.... KM-00- Washer,. x 0 x KM-0B00 Bolt, Flanged... 0 KM-0G0 Bolt, Flanged... KM-B000 Nut, Hex... KM-B000 Nut, Hex... KM-B000 Washer, Plain... KM-J000 Circlip, E-Ring...

37 -- CARBURETOR 0 0 NUMBER DESCRIPTION QTY. KM-00- Gasket, Intake Manifold... KM-00- Gasket, Intake Manifold... KM-00- Gasket, Intake Pipe... KM-0-0 Gasket... KM-00- Carburetor Assembly... KM-00- Pipe, Intake... KM-0-0 Insulator... KM-- Cover Assembly... KM--00 Float Assembly... 0 KM--00 Chamber, Float... KM--0 Valve Assembly, Throttle... KM--0 Valve Assembly, Choke... KM-0-0 Screw Assembly... NUMBER DESCRIPTION QTY. KM-0-0 Screw Assembly... KM-0-0 Manifold, Intake... KM-0-0 Clamp... KM-0- KM-0-0 KM-0-0 KM-0-0 KM-0-0 KM-0- Jet, Main, #0... Jet, Main, #0... Jet, Main, #0.... Jet, Main, #.... Jet, Main, #0.... Jet, Main, #0.... AR AR AR AR KM-0-0 Jet, Pilot, #... 0 KM-0G0 Bolt, Flanged... KM-0T00 Bolt, Flanged... KM-0Q0000 Tube, PVC...

38 -- 0 AIR FILTER NUMBER DESCRIPTION QTY. KM-0- Case, Air Filter Body... KM-0- Case, Air Filter Upper... KM-0- Case, Air Filter Lower... KM-0- Element, Air Filter... KM-0- Precleaner, Foam... KM-0-0 Bracket... KM-0-0 Bracket, Air Filter... KM-0-0 Gasket, Air Filter... KM-00- Stud, x KM-0- Nut... KM-0- Seal... KM-00- Washer... KM-0-0 Nut... KM-0G0 Bolt, Flanged... KM-0G00 Bolt, Flanged... KM-R000 Nut, Hex... KM-F000 Washer, Spring...

39 -- STARTER NUMBER DESCRIPTION QTY. KM-0- Cap... KM-0-0 Clutch Assembly... KM-0-0 Holder, Brush... KM-- Lever, Shift... KM-0-0 Cover... KM-0-0 Insulator... KM-- Cap, Starter End... KM-- Cone, Starter Nose... KM-0-0 Brush... 0 KM-00-0 Spring, Brush... KM-00-0 Armature... KM--0 Starter, Electric... KM-00- Solenoid, Starter... KM-0-0 Stopper... KM-00- Bolt... KM-0- Nut... KM-0- Nut... KM-0-0 Ring, Snap... KM-0G0 Bolt, Flanged... 0 KM-B000 Nut, Hex... KM-F000 Washer, Spring...

40 -0- HOOD, GRILL AND SIDE PANELS 0 0 0

41 -- HOOD, GRILL AND SIDE PANELS NUMBER CODE DESCRIPTION QTY Hinge Assembly, Hood Bracket, Side Panel Mtg. RH Bracket, Side Panel Mtg. LH Bracket, Side Panel Mtg. RH Rear Bracket, Side Panel Mtg. LH Rear -00 -A Headlight Assembly... Bulb, Headlight Screen, Intake Shield, Upper Heat Bracket, Panel Mtg Shield, Lower Heat Screw, Truss Hd, 0- x Screw, Hex Wash Hd Tapp... /-0 x. 0-0 Screw, Hex Cap, /-0 x. GR 0-0 Stud, Cylinder, /- Thrd Nut, Hex Sems, Nut, Hex Nylon Insert Lock, /-0-0 Nut, Hex Flange Lock, / A Nut, Hex Flange Lock, / Latch, / Turn Panel Cylinder, Gas Spring... - D0 D00 D0 D0 Hood... Graphic, Hood RH... Graphic, Hood LH... Graphic, Model PosiTrak RH Graphic, Model PosiTrak LH - Panel, Side RH... - Panel, Side LH Clip, Spring Spring, Compression Washer, Flat,.0 x.. x Screw, Shoulder,. x. Lg / Clip, Retaining...

42 -- FENDER AND RUNNING BOARD 0 0 0

43 -- FENDER AND RUNNING BOARD NUMBER CODE DESCRIPTION QTY. -00B B Light Assembly, Rear RH... Bulb Only, Tail Light... Bulb Only, Reverse Indicator Light Harness, Tail Light... Light Assembly, Rear RH... Bulb Only, Tail Light... Bulb Only, Reverse Indicator Light Harness, Tail Light Bracket, Seat Mtg. LH Bracket, Seat Mtg. RH Bracket, Rear Seat Support A Screw, Hex Wash Hd. Tapp... /- x. 0-0 Screw, Hex Cap... /- x. GR 0-00 Screw, Hex Cap... /-0 x. GR 0-0 Screw, Hex Wash Hd. Tapp... /- x Screw, Hex Cap... /- x. GR 0- Screw, Truss Phillips Hd.... /- x. 0-0A Screw, Hex Wash Hd. Tapp... /- x. 0-0 Screw, Pan Hd. /- x Clip, Tail Light Clip, Ratchet Fastener Speed Nut, U Type, / S00 Cover, Fender... Graphic, Warning... - S0 D0 Fender... Graphic, Warning... Graphic, Series Cover, Fender, RH Cover, Fender, LH Pad, Floor, RH Pad, Floor, LH Grommet,. ID x Washer, Flat,. x.0 x Spacer, Flange,. x. x. 0-0 Spacer,. x. x....

44 -- SEAT ASSEMBLY NUMBER CODE DESCRIPTION QTY Support, Seat - Upper Track Ass y., Seat w/latch Track Ass y., Seat w/o Latch... 0-A Tray, Lower Seat Bracket, Seat Belt Screw, Hex Cap, /- x.0 GR 0-0 Screw, Carriage, /- x. 0-0 Screw, Hex Cap, /- x. GR 0-0 Screw, Hex Flange,... /- x. GR Screw, Socket Hd Cap, /- x. -00A Nut, Hex Flange Lock, / Switch, Snap Mount (N.O.) A Spring, Compression,. x Screw, Shoulder,. x.-/- 0-0 Spacer,. x.0 x D0 D0 Seat, High Back... Graphic, Cub Cadet... Graphic, USA Belt Assembly, Seat...

45 -- FUEL TANK NUMBER CODE DESCRIPTION QTY. 0- Bracket, Front Tank Mtg Screw, Hex Wash Hd Tapp... /- x. 0-0A Screw, Hex Wash Hd Tapp... /- x. -0 Washer, Flat,. x. x.... -B Cap, Fuel... - Sensor, Fuel Level A Tank, Fuel...

46 -- FOLDABLE ROPS 0 0 NUMBER CODE DESCRIPTION QTY. 0-0 ROPS Assembly, Lower ROPS Assembly, Upper Mounting Assembly, ROPS RH Mounting Assembly, ROPS LH Screw, Hex Cap, /- x.0 GR 0-0 Screw, Hex Cap, /-0 x. GR 0-0 Screw, Hex Cap, /- x. GR 0- Screw, Hex Cap, /- x.0 GR -0 Pin, Clevis,. x Nut, Hex Jam, / Nut, Hex Nylon Insert Lock, /-0-0 Nut, Hex, /-0 GR Pin, Internal Cotter Light Assembly, Hazard... Bulb, Light Washer, Lock, / Conduit... in.

47 -- THREE POINT HITCH NUMBER CODE DESCRIPTION QTY Link, Lower Hitch Link, Lift - Fixed Link, Lift - Adjustable Link, Upper Center Chain Assembly, Check Pin, Clevis,. Dia Pin, Klik,. Lg Pin, Upper Lift Arm... - U Clevis, Check Chain Pin, Clevis,. x.... NUMBER CODE DESCRIPTION QTY. -00 Nut, Hex, /-0 GR Nut, Hex Insert Lock, / Pin, Internal Cotter,. x Pin, Internal Cotter,. x. -0B Pin, Internal Cotter Washer, Flat,. x. x.0-0 Washer, Flat,. x. x.0-0 Washer, Lock, / Bar, Draw Pin, Double Clevis...

48 -- AUXILIARY HYDRAULIC LOADER VALVE (IF EQUIPPED) 0 Primary Pump on Transmission (For Reference Only) A B 0 0 A B 0

49 -- AUXILIARY HYDRAULIC LOADER VALVE (IF EQUIPPED) NUMBER DESCRIPTION QTY. 0-0 Pivot Bracket Assembly Valve Handle Assembly Loader Valve Mount Bracket Fitting Mount Plate Rear Fitting Mount Plate Hex Screw, /-0,.00, Gr Hex Wash. Hd. Tapp Screw... /-0 x A Hex Wash. Hd. Tapp Screw... /- x. 0-0A Hex Wash. Hd. Tapp Screw... /- x. 0 - Valve Pivot Shaft... - Valve Spool Link... - Ball Joint Pivot Stud... - Clevis Pin,. x Jam Nut, /-, Gr Hex Lock Nut, /-0, Gr, Nylon -000 Chain Link Internal Cotter Pin Snap Ring, Auxiliary Hydraulic Pump... Pin, Dowel... Bolt, Mounting... Coupler, Splined Loader Control Valve Ball Joint,. Id x / Fitting, 0 - Orb Tube, Tandum Pump Suction Tube, Hydraulic - Bucket Rollback - Tube, Hydraulic - Bucket Dump.. - Tube, Hydraulic - Boom Lift... - Tube, Hydraulic - Boom Lower... - Coupling, Male Hydraulic, /- - Coupling, Female Hydr. / Tube, Auxiliary Pump Pressure.. - Tube, Valve Pressure... - Tube, Valve Return... - Tube, Valve Return... - Plug, Hydraulic Coupler - Male... - Plug, Hydraulic Coupler - Female - Knob,. Dia x /- Thd - Washer, Indicator - Red... - Washer, Indicator - Yellow... - Washer, Indicator - Green Washer, Indicator - Blue Joystick Boot... - Fitting, 0 - Orb... - Fitting, Straight - Orb... - Fitting, Straight... - Fitting, Straight - Orb... - Fitting, Bulkhead /- x /- -0 Fitting, Bulkhead /- x /- 0-0 Spacer,. ID x. OD x....

50 -0- WHEELS NUMBER CODE DESCRIPTION QTY Rim, TURF Tire - Front... Rim, INDUSTRIAL Tire - Front... Valve Stem... Tire, Turf... Tire, Industrial... Rim, TURF Tire - Rear... Rim, INDUSTRIAL Tire - Rear... Valve Stem... Tire, Turf... Tire, Industrial Screw, Lug, M Bolt, Lug, M x. x 0...

51 -- NOTES