Parts Catalog. Generator Set GGFB GGFC B (Spec A, B) Printed in U.S.A. Replaces (Spec A) 7 97

Transcription

1 Parts Catalog GGFB GGFC Generator Set Printed in U.S.A. 98 0B (Spec A, B) 98 Replaces 98 0 (Spec A) 7 97

2 To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Onan manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUC- TIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-

3 Introduction This Parts Catalog applies to the standard generator models GGFB and GGFC as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding with the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned in the description or the page heading, parts are interchangeable between models. Throughout this catalog left and right sides are determined by facing the engine (front) of the set unless noted in the description column. Engine parts that have been modified or added by Onan are identified in this catalog. All other Engine replacement parts must be ordered from the engine manufacturer by referring to the engine manufacturers nameplate and supplying all available information. Contact your nearest engine parts distributor for assistance in ordering replacement parts. Replacement Engine Onan Generator Model GGFB GGFC Ford Engine Model CSG69I 600 A CSG69I 600 A Replacement engines cannot be ordered from Onan. Order from your nearest Ford Distributor. Generator Set Data Table Model/ Electrical Data Specification Watts Volts Hertz Wire Phase Battery Voltage 0.0GGFB* 0,000 # 0,6, or VDC.0GGFB*,000 # 60,6, or VDC 7.0GGFC* 7,000 # 0,6, or VDC.0GGFC*,000 # 60,6, or VDC * The specification number denotes customer requested options or deviations from the Standard model. The specification letter advances with major manufacturing changes. # Broad Range Reconnectible.

4 Index Adapter, Duct Radiator, Adapter, Generator, 7 Alarm, Common, 68 Alarm, Fuel Spec B, 9 Alternator, 8 Ammeter, AC Detector Control, Ammeter, Blank Scale Emergency Stop Switch, 70 Ammeter, Dual Scale Sentinel Control, 6 Arm, Adjusting Alternator, 7 Armature, Starter, 7 Bearing, Starter (Commutator End), 7 Bearing, Starter (Pinion End), 7 Bell, End Generator, 7 Belt, Vee External Engine Parts, 7 Block, Terminal Engine Harness Spec A, 7 Block, Terminal Engine Harness Spec B, 7 Block, Terminal Generator, 7 Block, Terminal Generator Heater, 9 Board, Printed Circuit Alarm Relay, 66 Board, Printed Circuit Common Alarm, 68 Board, Printed Circuit Engine Monitor Detector Control, Board, Printed Circuit Time Delay Start/Stop, 69 Boot, Battery External Engine Parts, 7 Box, Air Air Cleaner, 9 Box, Circuit Breaker, Box, Control Control Housing, 8 Box, Control Detector Control, Box, Entrance, 9 Box, Terminal Generator Heater, 9 Bracket, Engine Mounting Skid, Bracket, Governor, 0 Bracket, Mechanical Overspeed, Bracket, Mounting Alternator, 7 Bracket, Mounting Circuit Breaker Box, Bracket, Mounting Control, 8 Bracket, Mounting Coolant Heater, 0 Bracket, Mounting Generator Foot, 7 Bracket, Muffler Residential Muffler, Bracket, Transformer, 7 Breaker, Circuit Sentinel Control, 7 Breaker, Circuit Spec A, Breaker, Circuit Spec B, Breaker, Circuit Voltage Regulator Sets With Detector Control, 9 Breaker, Circuit Voltage Regulator Sets With Sentinel Control, 60 Breather, Air Cleaner, 9 Bulb, Replacement Emergency Stop Switch, 70 Cable, Battery External Engine Parts, 7 Cable, Heater Control, 8 Cap, Heater Tube External Engine Parts, 7 Cap, Radiator, Cap, Rain Critical Muffler, Cap, Rain Residential Muffler, Carburetor, 8 Cartridge, Heater Generator, 9 Cleaner, Air, 9 Clutch, Starter, 7 Cock, Drain Radiator, Contact, Dry Spec B, 6 Control, Sentinel, 7 Cover, Circuit Breaker Box, Cover, End Bell Mechanical Overspeed, Cover, End Bell PMG, 8 Cover, Housing Control, 8 Cover, Stator Generator, 7 Cushion, Vibration Insulator Skid, Diode Generator, 7 Diode, Zener Engine Harness Spec A, 7 Diode, Zener Engine Harness Spec B, 7 Disc, Drive Generator, 7 Door, Control Detector Control, Drain, Oil, Element, Air Filter, 9 External Engine Parts, 7 Fan, Alternator, 8 Fan, Radiator, Filter, Oil External Engine Parts, 7 Flywheel External Engine Parts, 7 Frame, Starter (Commutator End), 7 Fuel System LP Liquid, Fuel System LP Vapor Without Low Fuel Pressure Warning Switch, 6 Fuel System Natural Gas Without Low Fuel Pressure Warning Switch, Fuel System Natural Gas and LP Liquid, Fuel System Natural Gas and LP Vapor, 7 Fuel System Natural Gas or LP Vapor With Low Fuel Pressure Warning Switch Spec B, Fuse Sentinel Control, 7 Gasket, Carburetor, 8 Gasket, Muffler Critical Muffler, Gasket, Oil Drain, Gauge, Oil Pressure Sets With Detector Control, Gauge, Oil Pressure Sets With Sentinel Control, 6 Gauge, Water Temperature Sets With Detector Control, Gauge, Water Temperature Sets With Sentinel Control, 6 Gear, Ring External Engine Parts, 7 Generator, 7 Governor, 0 Grille Radiator, Guard, Alternator Radiator, Guard, Alternator Remote Radiator, Guard, Fan Generator, 7 Guard, Fan Radiator, Guard, Fan Remote Radiator,

5 Index Harness, Wiring AC Sets With Detector Control, Harness, Wiring AC Control, 7 Harness, Wiring AC Control Sets With Sentinel Control, 60 Harness, Wiring Alarm Relay Board, 66 Harness, Wiring Common Alarm, 68 Harness, Wiring DC Sets With Detector Control, Harness, Wiring Dry Contact, 6 Harness, Wiring Electronic Overspeed Sets With Detector Control, Harness, Wiring Electronic Overspeed Sets With Sentinel Control, 0 Harness, Wiring Engine to Control Spec A, 7 Harness, Wiring Engine to Control Spec B, 7 Harness, Wiring Ignition, 7 Harness, Wiring Low Battery Voltage, 6 Harness, Wiring Low Coolant Level With Continuously Monitored Low Coolant Level, 7 Harness, Wiring Low Coolant Level Without Continuously Monitored Low Coolant Level Spec A, 8 Harness, Wiring Low Coolant Level Without Continuously Monitored Low Coolant Level Spec B, 9 Harness, Wiring PMG, 8 Harness, Wiring TB, Harness, Wiring Time Delay Start/Stop, 69 Harness, Wiring Transformer, 7 Harness, Wiring Vacuum Switch, 6 Heater, Control, 8 Heater, Engine Coolant, 0 Holder, Fuse Sentinel Control, 7 Hose, Air Inlet Air Cleaner, 9 Hose, Breather External Engine Parts, 7 Hose, Coolant Drain Engine, 6 Hose, Radiator, Hose, Radiator Remote Radiator, Housing, Control, 8 Housing, Flywheel External Engine Parts, 7 Housing, Generator Set Quiet Site, Housing, Generator Set Standard Weather Protective, Housing, Starter, 7 Indicator, Oil Level External Engine Parts, 7 Isolator, Vibration Detector Control, Isolator, Vibration Sentinel Control, 7 Joint, Ball Governor, 0 Key, Exciter Rotor Generator, 7 Kit, Starter Brush, 7 Labels, Miscellaneous, 7 Lamp Detector Control, Lead Main Circuit Breaker, Lens, Indicator, 6 Lens, Replacement Low Coolant Level With Continuously Monitored Low Coolant Level, 7 Light, Panel Detector Control, Link, Terminal Generator, 7 Lug, Solderless Circuit Breaker Box, Lug, Solderless Entrance Box, 9 Manifold, Oil Pressure Engine Harness Spec A, 7 Meter, Frequency Detector Control, Meter, Time Totalizing Detector Control, Module, Electronic Overspeed Sets With Detector Control, Module, Electronic Overspeed Sets With Sentinel Control, 0 Module, Ignition External Engine Parts, 7 Muffler, Critical, Muffler, Residential, Overspeed, Electronic Sets With Detector Control, Overspeed, Electronic Sets With Sentinel Control, 0 Overspeed, Mechanical, Paint, Pan, Skid, 6 Panel, Control Sentinel Control, 7 Pickup, Magnetic Governor, 0 Pin, Parallel PMG, 8 Plate, Audible Signal, 67 Plate, Fan Guard Radiator, Plate, Fan Guard Remote Radiator, Plate, Overspeed Electronic Overspeed Sets With Detector Control, Point, Mechanical Overspeed, Potentiometer Voltage Regulator Sets With Detector Control, 9 Potentiometer Voltage Regulator Sets With Sentinel Control, 60 Potentiometer, Volt Adjust Detector Control, Pulley, Alternator External Engine Parts, 7 Pulley, Water Pump External Engine Parts, 7 Radiator, Radiator, Remote, Rectifier Generator, 7 Rectifier, Power Control Heater, 8 Rectifier, Silicon Engine Harness Spec A, 7 Rectifier, Silicon Engine Harness Spec B, 7 Rectifier, Silicon Low Coolant Level With Continuously Monitored Low Coolant Level, 7 Regulator, Voltage Sets With Detector Control, 9 Regulator, Voltage Sets With Sentinel Control, 60 Relay Engine Harness Spec A, 7 Relay Engine Harness Spec B, 7 Relay Sentinel Control, 7 Relay, Timer Sentinel Control, 7 Resistor Voltage Regulator Sets With Detector Control, 9 Rotor, Exciter Generator, 7 Rotor, Generator, 7 Rotor, PMG, 8

6 Index Screen, Air Inlet Generator, 7 Sealant, Thread, Sender, Low Coolant Level With Continuously Monitored Low Coolant Level, 7 Sender, Low Coolant Level Without Continuously Monitored Low Coolant Level Spec A, 8 Sender, Low Coolant Level Without Continuously Monitored Low Coolant Level Spec B, 9 Sender, Pressure Oil Engine Harness Spec A, 7 Sender, Pressure Oil Sets With Detector Control, 7 Sender, Temperature Water External Engine Parts, 7 Sensor, Low Battery, 6 Shield, Alternator External Engine Parts, 7 Shield, Rain Critical Muffler, Shield, Rain Residential Muffler, Shroud Radiator, Signal, Audible, 67 Skid, Starter, 7 Starter Components, 7 Stator, Exciter Generator, 7 Stator, Generator, Stator, PMG, 8 Strap, Ground Skid, Switch Blank Emergency Stop Switch, 70 Switch, Mechanical Overspeed, Switch, Pressure (LOP) Engine Harness Spec A, 7 Switch, Pressure (Pre LOP) Engine Harness Spec A, 7 Switch, Pressure Oil Sets With Sentinel Control, 7 Switch, Pushbutton Emergency Stop, 70 Switch, Rheostat Detector Control, Switch, Rocker Detector Control, Switch, Rocker Sentinel Control, 7 Switch, Starter, 7 Switch, Thermostat External Engine Parts, 7 Switch, Vacuum, 6 Thermostat External Engine Parts, 7 Transformer Voltage Regulator Sets With Sentinel Control, 60 Transformer, Current, Transformer, Meter, 7 Tray, Battery, Tube, Exhaust, Valve, Drain Coolant, 6 Valve, Oil Drain, Valve, Vent Crankcase, 7 Varistor Generator, 7 Voltmeter Detector Control, Wrapper, Control Sentinel Control, 7

7 Abbreviations Some of the following abbreviations may be used throughout this Parts Catalog: AC Amp A/R AVR AWG Deg DC EFC ET EIT GFI ID IT IEC kw LPG LT M(meter Number) Alternating Current Ampere As Required Automatic Voltage Regulator American Wire Gauge Degree Direct Current Electronic Fuel Control External Tooth External/Internal Tooth Ground Fault Interrupter Inside Diameter Internal Tooth International Electrotechnical Commission Kilowatt Liquid Petroleum Gas Left Meter mm MOH NFS NPT OD oz. PMG Ph PC RFI RT Spec Thk UL UNC UNF VAC VDC W/(ET, IT, EIT) Millimeter Mobile Off Highway Not For Sale National Pipe Thread Outside Diameter Ounce Permanent Magnet Generator Phase Printed Circuit Radio Frequency Interference Right Specification Thick Underwriters Laboratories Inc. Union National Coarse Union National Fine Volts Alternating Current Volts Direct Current With Paint and Thread Sealant Onan Green Enamel (Non-Metallic) 00 oz. Pressurized Spray Can 006 Quart Can 00 Gallon Can Sealant, Thread (6 ml Tube)

8 6 External Engine Parts

9 External Engine Parts 087 Housing, Flywheel Washer, Lock Screw, Cap Hex Head (7/6 x.) 0 97 Flywheel and Ring Gear (Includes Parts Marked *) 0 9 * Flywheel * Gear, Ring Screw, Cap Hex Head (7/6 0 x -/6) Washer, Lock Spring (M0) Screw, Cap Hex Head (M0 x. x.) Spacer, Bracket Alternator Washer, End Bell Washer, Lock Spring (M8) Screw, Cap Hex Head (M8 x. x 0) Screw, Cap Hex Head (M0 x. x 0) Nut, Lock Flange (M0) Washer, Flat (/8) Pulley, Alternator (Double) Washer, Lock Spring Nut, Hex (M6) Cable, Battery Nut, Hex (M8) Washer, Lock Spring (M) Nut, Hex (M) 007 Belt, Vee Shield, Alternator Switch, Thermostat (S) Sentinel Control and Detector Control W/Gauge Board Spec A 7 9 Clamp, Loop Screw, Cap Hex Head (7/6 x.7) Bushing, Reducer (/ x /8) (Sentinel Control) Harness, Ignition Tube, Oil Level Indicator Indicator, Oil Level Thermostat Gasket, Water Outlet 0 90 Connector, Water Outlet Bolt, Washer Head (/6 8 x.87) Bolt, Lock Hex (/8 6 x ) Pulley, Water Pump Bolt, Lock Bracket, Mounting Alternator 9 Bolt, Lock Hex 9 Arm Adjusting Alternator 9 Bolt, Lock Hex (7/6 0 x.06) Module, Ignition 0 07 Valve, Vent Crankcase 6 0 Cap, Heater Tube Screw, SEMS Hex Head 8 09 Filter, Oil Sender, Temperature Water (Detector Control) (E) Elbow Hose, Vent Crankcase Hose, Breather Switch, Pressure LOP (Sentinel Control) (S) Nut, SEMS ET (#0 ) (Detector Control) 6 09 Boot, Battery (Red) 6 79 A/R Tie, Wrap 7 89 A/R Tie, Wrap 8 6 Clamp, J 9 9 Starter (See separate page for components) Sender, Pressure Oil (Detector Control W/Sensor Board) (E) Spec B Screw, Cap Hex Head (/6 8 x.88) (Sentinel Control and Detector Control W/Sensor Board) Spec B Screw, Cap Hex Head (/6 8 x.7) (Detector Control W/Gauge Board) Spec A Elbow, Inverted (Detector Control W/Gauge Board) Spec A Line, Flexible Fuel (Detector Control W/Gauge Board) Spec A Bushing, Pipe (Detector Control W/Gauge Board) Spec A * Parts Included in 0 97 Flywheel Assembly 7

10 Alternator 6 CP Alternator 9 98 Fan, Alternator Washer, Lock (M8) Nut, Hex (M8 x.) Washer, Lock (M) Nut, Hex (M x 0.8) 8

11 Air Cleaner CP0,F7,F7 0 9 Air Cleaner Bottom 0 0 Air Cleaner Top 0 Air Box (Units w/fresh Air Intake Hose) 0 7 Element, Air Filter 0 6 Breather, Air Cleaner Hose, Air Inlet (Units w/fresh Air Intake Hose) Plug, Hole Clamp, Hose (Units w/fresh Air Intake Hose) Rivet, Pop /8 (Units w/fresh Air Intake Hose) Stud Wingnut (/ 0) 89 Tie, Cable (Units w/fresh Air Intake Hose) 6 Mounting, Base Tie Wrap (Units w/fresh Air Intake Hose) Rivet /6 (Units w/fresh Air Intake Hose) Nut, Wing (/ 0) Washer, Flat (/) 9

12 Fuel System LP Liquid C0 0

13 Fuel System LP Liquid Bracket, Converter 8 06 Converter, Gas 0 09 Connector, Hose (/ NPT x /8 Hose) 0 09 Elbow, Hose (90 ) Nipple, Pipe (/ x ) Valve, Solenoid Washer, Flat (7/6) Screw, Cap Hex Head (7/6 x /) Screw, Cap Hex Head (M8 x.0 x 0) Nut, Lock Flange (M6 x.0) Nipple, Pipe (/ x.0) 0 00 Bushing, Reducer (/ x /) 0 7 Elbow, Hose ( ) 0 00 Nipple, Close (/8) Tee, Pipe (/8) Hose, Silicone Rubber Tube, Heater Water Bushing, Reducer (.0 x /) Elbow, Pipe Coupling, Pipe Clamp, Hose Connector, Hose (/ NPT x.0 Hose) 0 0. Hose, LPG (.0 x.0) 0 0. Hose, LPG (.0 x 6.0) Clamp, Hose Tube, Fuel Plug, Square Head (/8) Hose, Engine Coolant (/ x 6.0 ) Hose, Engine Coolant (/ x.0 ) Clamp, Hose Washer, Flat (/8) Nut, Lock (/8 6) 8 6 Harness, LPG Screw, Cap Hex Head (7/6 x.7) 09 A/R Tie, Cable

14 Fuel System Natural Gas & LP Liquid C090

15 Fuel System Natural Gas & LP Liquid Bracket, Converter 8 06 Converter, Gas 0 09 Connector, Hose (/ NPT x /8 Hose) 0 09 Elbow, Hose Nipple, Pipe (/ x.) Valve, Solenoid Washer, Flat (7/6) Screw, Cap Hex Head (7/6 x /) Screw, Cap Hex Head (M6 x.0 x 0) Nut, Flange Lock (M6 x.0) Nipple, Pipe (/ x.0) 0 00 Bushing, Reducer (/ x /) 0 7 Elbow, Hose 0 00 Nipple, Close (/8) Tee, Pipe (/8) Hose, Silicone Rubber Tube, Water Heater Bushing, Reducer ((.0 x /) Pipe, Lateral (/) Nipple, Pipe (/ x.0) Regulator, Natural Gas 0 00 Nipple, Close (/) Valve, Solenoid 0 97 Tee, Reducing (.0 x / x /) Bushing, Reducer (/ x /) Nipple, Pipe (/ x.88) Switch, Pressure ( Volt) Bracket, Fuel System Valve (/) Connector, Hose (/ NPT x.0 Hose) Screw, SEMS Hex Head (M6 x.0 x 6) 0 0. Hose, LPG (.0 x.0) 0 0. Hose, LPG (.0 x.0) Clamp, Hose 8 0 Tube, Fuel System Plug, Square Head (/8) Hose, Engine Coolant (/) Hose, Engine Coolant (/) Clamp, Hose Clamp (/ NPT) Washer, Flat (/8) Nut, Lock (/8 6) Screw, SEMS Hex Head (M8 x. x 0) Harness, Dual Fuel 8 6 Harness, LPG Connector, Romex Coupling, Pipe Clamp, Hose Screw, Cap Hex Head (7/6 x.7) 0 09 A/R Tie, Cable

16 Fuel System Natural Gas Without Low Fuel Pressure Warning Switch C Nipple, Pipe (/ NPT x.) Coupling, Reducer (/ NPT x / NPT) 0 08 Nipple, Pipe (/8 NPT x 8.00) Regulator, Natural Gas 0 00 Nipple, Close (/ NPT) Valve, Solenoid Elbow, Street Reducer (.00 x / x 90 ) Bracket, Fuel System Screw, SEMS Hex Head (M8 x. x 0) Clamp (/ NPT) Screw, SEMS Hex Head (M6 x.0 x 6)

17 Fuel System Natural Gas or LP Vapor With Low Fuel Pressure Warning Switch Spec B C00,H69 and/or C099,H Tee, Pipe 0 00 Nipple, Pipe (/ x.0) Bushing, Reducer Switch, Pressure (V) 007 Box, Connector

18 Fuel System LP Vapor Without Low Fuel Pressure Warning Switch C Nipple, Pipe (/ NPT x.) Coupling, Reducer (/ NPT x / NPT) 0 08 Nipple, Pipe (/8 NPT x 8.00) Regulator, Natural Gas 0 00 Nipple, Close (/ NPT) Valve, Solenoid Elbow, Street (/ x 90 ) Bracket, Fuel System Screw, SEMS Hex Head (M8 x. x 0) Clamp (/ NPT) Screw, SEMS Hex Head (M6 x.0 x 6) 6

19 Fuel System Natural Gas & LP Vapor C Nipple. Pipe (/ NPT x ) 0 00 Bushing, Reducer (/ NPT x / NPT) Tee, Pipe (/) 0 00 Nipple, Close (/) 0 07 Valve (/) Elbow, Street 90 (/) Nipple, Pipe (/ NPT x ) Regulator, Natural Gas Valve, Solenoid Regulator, Propane 0 97 Tee, Reducing ( NPT x / NPT) Bushing, Reducer (/ NPT) Nipple, Pipe (/ x.88) Switch, Pressure ( Volt) Bracket, Fuel System Screw, SEMS Hex Head (/8 6 x /) Clamp (/ NPT) Screw, SEMS Hex Head (M6 x x 6) Nut, Retainer (M6) Harness, Dual Fuel 007 Connector, Romex 7

20 Carburetor CP Carburetor 08 Gasket, Carburetor 098 Gasket, Carburetor 8

21 Fuel Alarm Spec B H9,H60,H Harness, Fuel Alarm 9

22 Governor CP Joint, Ball Bracket, Governor Governor 6 0 Washer, Flat (.0 x. x.) Nut, SEMS W/ET (#0 ) Washer, Flat (/) Washer, Lock Split (/) Screw, Cap Hex Head (/ 8 x /) Screw, SEMS Hex Head (/8 6 x.0) Stud, Governor linkage (#0 ) 0 0 Stud (/8) Washer, Lock EIT (/8) Nut, Hex (/8 ) Screw, Cap Hex Head (M6 x.0 x 0) Nut, Lock Flange (M6 x.0) Pickup, Magnetic 7 A/R Tie, Cable 8 Clamp, Loop Insulated Nut, Self-Locking (/ 0) 0

23 Exhaust Pipe CP0,A99 99 Tube, Exhaust Screw, Cap Hex Head (7/6 x.7) 6 06 Washer, Flat (7/6) Washer, Lock (7/6)

24 Muffler Residential A76,F8 00 Muffler Residential 0 0 Shield, Rain (Housed) 0 Bracket, Muffler Washer, Flat (/) Nut, Hex (/6 8) Screw, Cap Hex Head (/6 8 x /) Cap, Rain Screw, Cap Hex Head (/6 8 x ) Washer, Flat (7/6) Screw, Cap Hex Head (7/6 x -/)

25 Muffler Critical F7,F7,L0,L06 67 Muffler Critical Tube, Exhaust 0 0 Shield, Rain 06 0 Cap, Rain Screw, SEMS Hex Head (M8 x 0.8 x 0) 6 7 Clamp, Muffler Washer, Flat (7/6) Screw, Cap Hex Head (7/6 x -/) 9 9 Gasket, Muffler 0 7 Clamp, Muffler 60 Hz 0 Bracket, Muffler 60 Hz 6 0 Washer, Flat (/) 60 Hz Screw, Cap Hex Head (/6 8 x /) 60 Hz

26 Radiator E07,E08,F0 Radiator Standard (0 ) Enhanced (0 ) Shroud Side, Housing Screw, SEMS Hex Head (M8 x. x 0) 0 60 Grille (Unhoused Sets Only) Cock, Drain Fan Spacer, Fan Hose, Radiator Outlet Guard, Fan Right Side Guard, Fan Left Side 0 08 Hose, Radiator Inlet Washer, Flat (M8) 0 79 Plate, Fan Guard 0 06 Clamp, Hose Rivet, Pop Screw, Cap Hex Head Edge, Protection Guard, Alternator Clamp, Hose Cap, Radiator 0 6 Adapter, Duct 0 6 Adapter, Duct

27 Remote Radiator E Guard, Alternator 0 6 Panel, Front Radiator Housing Screw, SEMS Hex Head (M8 x. x 0) Guard, Fan Left Side Edge, Protection Plate, Fan Guard Rivet, Pop Guard, Fan Right Side Hose, Radiator Outlet Hose, Radiator Inlet 0 06 Clamp, Hose 0 06 Clamp, Hose Washer, Flat (M8) Screw, Cap Hex Head (/6 x.88) 79 A/R Tie, Cable

28 Coolant Drain E Valve, Coolant Drain Hose, Coolant Drain Engine 0 0 Clamp, Hose 6

29 Low Coolant Level Sender With Continuously Monitored Low Coolant Level Light Indicator Controls H Lens, Replacement Harness, Low Coolant Level Sender, Low Coolant Level Rectifier, Silicon 8 9 Harness, Pigtail (Includes Parts Marked *) 6 76 *Housing, Connector ( Pin) *Socket, Contact (Used in S) *Seal, Cable * Parts Included in 8 9 Pigtail Harness 7

30 Low Coolant Level Without Continuously Monitored Low Coolant Level Spec A Harness, Low Coolant Level 9 08 Sender, Low Coolant Level 8

31 Low Coolant Level Without Continuously Monitored Low Coolant Level Spec B 6 H89,H9,H7 8 7 Harness, Low Coolant Level (Includes Parts Marked *) Sender, Low Coolant Level 76 *Housing, Connector ( Pin) 709 *Socket, Contact (Used in S7) 708 *Seal, Cable 6 7 *Plug, Cavity * Parts Included in 8 7 Wiring Harness 9

32 Water Heater H06,H6,H07,H9,H Bracket, Mounting Heater Heater, Engine Coolant Volt Volt Hose, Engine Coolant 0 00 Nipple, Pipe (/8 NPT x ) Elbow, Pipe (/8 x 90 ) Detector Control Sentinel Control 6 0 Connector, Male Nipple, Pipe (/ NPT x ) Tube, Heater Clamp, Hose Screw, Hex Head (M6 x x 6) 09 Tie, Cable Bushing, Reducer (/8 x / NPT) * Tee, Pipe * = Used with Detector Control. 0

33 Housing Standard Weather Protective F80,F Panel, Side Radiator Housing 0 90 Panel, Front Radiator Housing Roof 0 7 Post, Housing Center Hinge, Housing Post, Corner Housing Door, Housing Weatherstrip (Units with Window) Window, Control Rivet Pop (/6) Latch, Door Key, Replacement (Fits Latch 06 08) Screw, SEMS Hex Head (M8 x. x 0) 8 Cover, Exhaust Rivet, Pop (/8) Label, Model Identification Label, Warning Label, Prototype Bumper, Door Nut, Captive Floating (M6 x.0) Screw, SEMS Hex Head (M6 x.0 x 6) Label, Warning Label, Coolant Fill Door, Housing Rear 0 90 W/Window Cutout 0 90 WO/Window Cutout

34 Housing Quiet Site F7,F7

35 Housing Quiet Site Weather Seal Top & Bottom Weather Strip Window Screw (M8 x. x 0) Rivet (/8 ) Rivet (/6 ) Plug, Hole Plug, Hole Latch, Door Key, Replacement (fits Latch, Door 06 08) Hinge 0 60 Baffle, Air Discharge Baffle, Recirculation Muffler Roof 0 60 Cover, Perforated * Cover, Discharge Fiberglass Muffler Box, Radiator Fill Barrier, Air Flow Fiberglass Fiberglass Fiberglass Support, Muffler Fiberglass Extension, Side RH 0 99 Extension, Side LH * Side, Discharge LH * Side, Discharge RH * Discharge, Front * Discharge, Bottom Barrier, Air Box, Muffler Fill Neck, Radiator 0 96 Cover, Perforated Retainer, Insulation 0 98 Inlet, Perforated Angle, Support Duct, Support Inlet, Perforated Duct, Bottom Inlet Extension, Rear 0 9 Extension, Front 8 Cover, Exhaust 0 96 Post, Corner Housing 0 90 Panel, Front Radiator Housing Panel, Side Radiator Housing Door, Housing W/Window Cutout 7 Door, Housing 0 90 Sets W/Window 0 90 Sets WO/Window Fiberglass Post, Housing Center Window, Control (if equipped) Label, Caution Label, Caution Label, Coolant Fill Label, Model 0 60 Retainer, Insulation Screw, Hex Head (M6 x.0 x 6) Washer, Flat Nut, Cage Weather Seal Side Plug Label, Prototype Tested Weather Seal Fiberglass Label, Warning Insulation, Foam * Parts used only on F7 Housing

36 Battery Tray F Tray, Battery Screw, SEMS Hex Head (M8 x. x 0) 6 0 Hold Down, Battery Rod, Hold Down Battery Nut, Wing (M6)

37 Skid F79,F77 Skid 0 70 Non-Housing Compatible 0 0 Housing Compatible Cushion, Vibration Isolator Washer, Hardened Screw, Cap Hex Head (M x.7 x ) Washer, Lock EIT (/) Strap, Ground Bracket, Mounting Engine Washer, Flat (/) Screw, Cap Hex Head (Grade 8) (/ 0 x.0) Nut, Hex (/ 0) Spacer, Shock Absorbing Washer, Flat Hardened (7/6) Screw, Cap Hex Head (Grade 8) (7/6 x.0) Screw, Cap Hex Head (Grade 8) (7/6 x.7)

38 Skid Pan F Pan, Skid Clamp Screw, Self-Locking Hex Washer Head (M6 x x 6mm) 0 6 Cover, Stub-Up 6

39 Starter Components CP0 9 Starter (.kw) 9 Kit, Starter Brush 9 6 Switch 9 7 Clutch 9 8 Armature 9 9 Frame, Commutator End Housing 7 9 Bearing, Commutator End 8 9 Bearing, Pinion End Screw, Socket Head Cap (M0 x. x mm) Washer, Spring (M0) Nut, Hex (M8 x.) Washer, Spring (M8) 7

40 Control Housing CP Box, Control Cover, Housing Control Screw, SEMS Hex Head (M6 x x 6) Nut, Machine Hex (M0 x.) Washer, Lock (M0) Washer, Flat (M0) Link, Terminal Screw, Lock (/6 8 x.0) Washer, Lock ET (/6) Edging 7 0 Plug, Hole 9 07 Bracket, Mounting Control 8

41 Entrance Box K Panel, End CB Box Panel, Side CB Box Cover, CB Box Screw, Hex Head (M6 x 6) Edging Bulk (Order By The Foot Feet Required) Cover, Control Housing Screw, Hex Head (M8 x. x 0) 8 7 Lug, Solderless Washer, Lock EIT (/6) 9

42 Circuit Breaker Box K08 0

43 Circuit Breaker Box 9 07 Panel, End CB Box Panel, Side CB Box 9 9 Bracket, Mounting CB Label, Warning Edging Bulk (Order By The Foot Feet Required) *Standoff, Insulator *Screw, Cap Hex Head (/8 6 x.7) *Washer, Lock (/8) *Washer, Flat (/8) *Label, Bus Warning 7 Lug, Solderless Washer, Lock EIT (/6) Screw, SEMS Hex Head (M8 x. x 0) Screw, SEMS Hex Head (M6 x x 6) 9 Cover, CB Box 6 Cutout, CB Box UL Volt, Amp, Pole Volt, Amp, / Pole 9 0 Volt, 00 0 Amp, / Pole Volt, 0 0 Amp, Pole IEC Volt, Amp, / Pole Volt, 70 0 Amp, / Pole Rivet, Pop Cover, Housing Control * = UL Rated Breakers only.

44 Circuit Breaker Spec A Breaker, Circuit Molded Case 600 Volt Pole (UL & IEC) A Frame/00 A (KM) A Frame/7 A (KM) A Frame/0 A (KM) A Frame/ A (KM) A Frame/00 A (KM) A Frame/90 A (KM0) A Frame/80 A (KM09) A Frame/70 A (KM08) A Frame/60 A (KM07) A Frame/0 A (KM06) Pole (IEC) A Frame/00A (KM6) A Frame/60 A (KM) AFrame/ A (KM) A Frame/00 A (KM) A Frame/80 A (KM) 0 Volt (UL) Pole A Frame/00 A (KB) Amp (KB) Amp (KB) Amp (KB Amp (KB0) Pole Amp (KD) Amp (KD) Amp (KD0) Amp (KD9) 0 96 Amp (KD8) Switch, Disconnect (600 Volt) Amp Frame Amp Frame Amp Frame Amp Frame Trip, Shunt ( VDC) (600 Volt) Pole Amp (UL & IEC) Amp (IEC) Amp (IEC) Pole Amp (IEC) Amp (IEC) Contact, Auxiliary (600 Volt) Pole Amp (UL & IEC) Amp (IEC) Amp (IEC) Pole Amp (IEC) Amp (IEC) Alarm, Trip (600 Volt) Amp (IEC)

45 Circuit Breaker Spec B Breaker, Circuit Pole (UL) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) * 00 Amp (0 Volts) Pole (UL) Amp (0 Volts) 0 96 Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Pole (UL & IEC) 0 99 * Amp (600/70 Volts) 0 99 * 0 Amp (600/70 Volts) * 0 Amp (600/70 Volts) * 0 Amp (600/70 Volts) * 0 Amp (600/70 Volts) * 60 Amp (600/70 Volts) * 70 Amp (600/70 Volts) * 80 Amp (600/70 Volts) * 90 Amp (600/70 Volts) * 00 Amp (600/70 Volts) * Amp (600/70 Volts) * 0 Amp (600/70 Volts) * 7 Amp (600/70 Volts) * 00 Amp (600/70 Volts) * Amp (600/70 Volts) * 0 Amp (600/70 Volts) * 00 Amp (600/70 Volts) Pole (IEC) * 80 Amp (70 Volts) 0 99 * 00 Amp (70 Volts) 0 99 * Amp (70 Volts) 0 99 * 60 Amp (70 Volts) 0 99 * 00 Amp (70 Volts) 0 99 * 0 Amp (70 Volts) * 0 Amp (70 Volts) Package, Hardware Circuit Breaker Mounting (Includes Screws, Nuts and Lock Washers) Used With 0 99 XX Circuit Breakers Used With XX Circuit Breakers (Screws Only) Used With 0 96 XX Circuit Breakers (Screws Only) Accessories, Circuit Breaker: The following are used on 0 99 XX and XX Circuit Breakers Trip, Shunt (V) Switch Used as an Auxiliary Contact or Trip Alarm Lead (Quantity Used As Required) /8 Ring Terminal End to Stripped End No Markings ( ) (#/0 Wire) /8 Ring Terminal End to Stripped End No Markings (0 ) (# Wire) /8 Ring Terminal End to /8 Ring Terminal End Marked LO (0 ) (# Wire) /8 Ring Terminal End to /8 Ring Terminal End Marked LO (0 ) (#/0 Wire) * Includes Mounting Hardware

46 Oil Drain H Gasket, Oil Drain 0 6 Adapter, Oil Drain 0 0 Clamp, Hose 0 67 Hose, Oil Drain Valve, Oil Drain

47 Generator Stator Stator, Generator GGFB 0 Hertz 0 7 Wire, BR, C 0mm Stack (B7) 0 7 Wire, BR, 0C 0mm Stack (B0) 0 7 Wire, BR, C 60mm Stack (B9) 0 7 Wire, BR, 0C 60mm Stack (B0) 0 7 Wire, BR, 0C (B8) 60 Hertz wire, Phase, C 0mm Stack (B7) wire, Phase, 0C 60mm Stack (B7) 0 7 Wire, UBR, C 0mm Stack (B) 0 7 Wire, UBR, 0C 0mm Stack (B) 0 7 Wire, BR, C 60mm Stack (B67) 0 7 Wire, BR, 0C 60mm Stack (B68) Wire, LBR, 0C 0mm Stack (B6) Wire, LBR, C 0mm Stack (B7) Wire, LBR, 0C 0mm Stack (B8) 0 7 Wire, UBR, 0C, (B) /600 Volt, C 0mm Stack (B0) /600 Volt, 0C 0mm Stack (B0) /600 Volt, 0C 0mm Stack (B9) GGFC 0 Hertz 0 7 Wire, BR, C 60mm Stack (B7) 0 7 Wire, BR, 0C 60mm Stack (B8) 0 7 Wire, BR, C 60mm Stack (B9) 0 7 Wire, BR, 0C 0mm Stack (B0) 0 7 Wire, BR, 0C 60mm Stack (B0) 60 Hertz wire, Phase, C 80mm Stack (B7) wire, Phase, 0C 80mm Stack (B7) 0 7 Wire, UBR, 0C 60mm Stack (B6) 0 7 Wire, BR, C, 80mm Stack (B67) 0 7 Wire, BR, 0C, 80mm Stack (B68) 0 7 Wire, UBR, 0C 60mm Stack (B) 0 7 Wire, UBR, 0C 80mm Stack (B) 0 7 Wire, UBR, C 60mm Stack (B) Wire, LBR, C 60mm Stack (B7) Wire, LBR, 0C 60mm Stack (B8) /600 Volt, 0C 0mm Stack (B9) /600 Volt, C 60 mm Stack (B0) /600 Volt, 0C 60mm Stack (B0)

48 6 Generator

49 Generator Stator, Generator (See seperate page for part numbers) Rotor Assembly, Generator (Includes parts marked *) mm Stack Length GGFB B7, B0, B0, B7, B, B, B, B6, B7, B8, B9,B0 GGFC B6,B mm Stack Length GGFB B67, B68, B7, B8, B9, B0 GGFC B0, B0, B7, B, B, B7, B8, B mm Stack Length GGFC B67, B7, B7, B8, B9, B mm Stack Length GGFC B68, B0 * Key, Exciter Rotor , 60mm Stack Length , 0mm Stack Length * Rotor Assembly, Exciter (Includes Parts Marked #) 0 0 0, 60mm Stack Length , 0mm Stack Length *# Rectifier Assembly (Includes Parts Marked +) Forward (with Positive Diode) Reverse (with Negative Diode) 6 *#+ Diode Positive Negative *#+ Screw, Cap Hex Head (M x mm) (CR,,,,,6) *#+ Nut, Hex (M) *#+ Washer, Lock Spring (M) *#+ Washer, Flat (M) *# Nut, Locking Nylon (M) *# Washer, Flat (M) 0 06 * Bearing, Ball 8 0 * Ring, Retaining * Varistor * Nut, Hex (M) * Washer, Lock Spring (M) * Washer, Flat (M) O-Ring 0 08 Adapter, Generator Screw, Cap Hex Head (M8 x. x ) Washer, Lock (M8) Seal, Edging Bulk (Order by the foot Feet Required) Cover, Stator Top , 60mm Stack Length , 0mm Stack Length Cover, Stator Bottom , 60mm Stack Length , 0mm Stack Length 6 Screw, Cap Hex Head , 60mm Stack Length (M0 x. x mm) , 0mm Stack Length (M0 x. x mm) 7 Washer, Lock Spring (M0) /60 Stack Length /0 Stack Length 8 Washer, Flat (M0) /60 Stack Length /0 Stack Length Grommet 0 Block, Terminal 7 0 Plug, Hole 0980 Guard, Fan 0878 Screen, Air Inlet Screw, SEMS (M x mm) 0 Bell, End Washer, Lock (M8) Screw, Cap Hex Head (M8 x. x ) Washer, Lock Spring (M6) 9 Screw, Cap Hex Head M6 x 60mm 0 Stator, Exciter , 60mm Stack Length , 0mm Stack Length 90 Bracket, Mounting Generator Foot Washer, Lock (M0) Screw, Cap Hex Head (M0) Washer, Flat (M0) 70 0 Spacer, Foot Mounting Bolt, Place (/8 6 x ) Screw, Cap Hex Head (M0 x mm) Washer, Lock Spring (M0) Washer, Flat (/8) M6 x 80mm Nut, Hex (M0) Washer, Lock Spring (M0) Washer, Flat (M0) 987 Link, Terminal Screw, Self Locking Hex Washer Head (M x 0mm) 99 0 Disc, Drive Screw, Cap Socket Head * Parts Included in Generator Rotor Assemblies # Parts Included in Exciter Rotor Assemblies + Parts Included in Rectifier Assemblies 7

50 Permanent Magnet Generator (PMG) B Pin, Parallel Bolt, Mounting PMG 0 6 Rotor, PMG 0 Stator, PMG 97 Clamp, Stator PMG Cover, End Bell Spacer, Cover Screw, SEMS Hex Head (M x 0.8 x 0) Washer, Lock (M0) Harness, Wiring PMG Washer, Lock (M6) 8

51 Generator Heater A9,A9 Cartridge, Heater Volt Volt 0 Clamp, Loop 8 07 Screw, Pan Head (M x 6) Nut, Hex (M) Washer, Lock (M) Washer, Flat (M) Box, Terminal Heater 8 0 Block, Terminal Grommet Label, Warning Heater 8 07 Screw, Pan Head (M x 0) Washer, Lock (M) Screw, Cap Hex Head (M x.7 x ) 8 Mount, Tie Cable Nut, Nylon 6 89 Tie, Cable Screw, Countersunk Pan Head (M x.7 x ) Plug, Dot Button 9

52 Electronic Overspeed Generator Sets With Sentinel Control B8,H Module, Electronic Overspeed Screw, Thread Cutting Cross Recessed (#6 x /) 8 Harness, Overspeed 7 Terminal, Tab 0

53 Electronic Overspeed Generator Sets With Detector Control 6 B8,H9,H Module, Frequency (A6) 9 07 Plate, Overspeed 8 96 Harness, Overspeed Screw, Machine Cross Recessed Thread Forming (#6 x /) Screw, Machine Round Head (#8 x /) 6 7 Terminal, Tab Adapter

54 Mechanical Overspeed B0,H Bracket, Overspeed Switch, Overspeed 0 07 Point, Overspeed Nut, Insulating (/) Nut, Hex (/) Washer, Lock ET (/) Washer, Lock EIT (/8) Screw, Cap Hex Head (M0 x. x ) Washer, Flat (.06 x. x.) Screw, SEMS Hex Head (M x 0.8 x 0) Cover, End Bell 6 0 Spacer, Cover Washer, Flat (M6)

55 Current Transformers H9,H60,H6,R,K00 Transformer, Current (CT, CT, CT) Less than 00 Volts / Primary Ratio / Primary Ratio Greater than 00 Volts / Primary Ratio / Primary Ratio

56 Detector Control ,6,7,8, (7 9) 6 6 6,

57 Detector Control 9 00 Box, Control 0 07 Isolator, Vibration Screw, Machine Round Head Cross Recessed Thread Cutting (#6 x /) Screw, Locking Head (#0 x /6) 8 6 Harness DC 6 08 *Housing, PCB ( Pin) 7 0 A/R *Pin, Contact 8 A/R *Tie, Cable Board, PC Engine Monitor 0 00 Clip, Wire Nut, Hex W/ET (#0 ) Door, Control (RH) 8 08 Screw, Machine Round Head (#6 x /) (Black Zinc) Nut, Hex W/ET (#6 ) Lamp Assembly Label, Panel DC (Front) 7 06 Light, Panel Lamp, Pilot Gauge, Oil Pressure Gauge, Water Temperature 0 6 Voltmeter Meter, Time Totalizing Spec A 0 00 Spec B 7 0 Plug, Hole Board, PC Sensor Board Switch, Rocker (W/Light) Switch (WO/Light) Washer, Lock ET (#0) Washer, Lock (/6) Grommet ( ) Receptacle, Fastener 06 0 Stud, Fastener 06 0 Washer, Stud Retainer Nut, Hex (/ 0) Washer, Flat (/) Bond, Strap Screw, Hex Head Self-Locking (/6 8 x /) Screw, Pan Head Cross Recessed (#0 ) Washer, Lock EIT (/6) Screw, Locking Head (#0 x /6) Door, Control (LH) 8 78 Harness AC (Includes Parts Marked *) 06 Lamp Assembly (Upper/Lower Scale) 0 8 Voltmeter AC Ammeter AC / / / Meter, Frequency ( 6 Hz.) Potentiometer Volts Adjust Knob, Rheostat Washer, Lock ET (#0) Switch, Rotory (Volt/Ammeter) 0 7 Strip, Marker Screw, Cross Recessed Thread Cutting (#6 x /8) Label, Danger 089 Capacitor Nut, Hex W/ET (#6 ) Screw, Machine Round Head (m x.7 x 8G) Harness, TB (Includes Parts 7 6 Cap 8 68 Terminal 9 Cable Label, Panel AC (Front) Nut ( 0) * Parts Included in 8 78 Wiring Parts Included in 8 9 Wiring Harness

58 Sentinel Control H6 6

59 Sentinel Control 9 99 Wrapper, Control Panel, Control 08 0 Switch, Rocker Relay, Timer Relay (0 Amp, 0 VAC) Tie, Cable Screw, Hex Head (M6 x 6) Nut, Lock Acorn (#6 ) Isolator, Vibration Screw, Self-Locking Hex Washer Head (/6 8 x.0) Screw, Cross Recessed Thread Cutting (#6 x /) Strap, Bond 97 Terminal, Spade 07 Holder, Fuse 0 Fuse (0 Amp) Washer, Flat (/6) Washer, Lock EIT (/6) Edging Bulk (Order By The Foot Foot Required) Washer, Lock ET (/6) Meter, Hour Voltmeter, AC /0 600 (600 Volt) (All except 600 Volt) Meter, Hz/RPM 08 0 Switch, Rotary (Volt & Ammeter) 8 9 Harness, Wiring Meters (Includes Parts Marked *) * Terminal, Ring 6 99 * Socket, Contact * Housing, Cap 8 60 * Terminal, Spade * Terminal, Ring * Pin, Contact 68 * Terminal, Faston 990 * Socket, Contact Nut W/ET (# 0) Nut, Acorn Screw, Machine Round Head (M x 8) 6 Breaker, Circuit 0 9 Pin Pin * Parts Included in Wiring Harness 8 9 7

60 Control Heater Detector Control A6,A6 8 Mount, Tie Cable Label, Caution Heater, Control Volt Volt A/R Sleeving, Convoluted 7 0 Rectifier, Power 6 99 Terminal, Receptical 7 0 Terminal, Tab A/R Tubing, Heat Shrink Splice, Window (8 Gauge) 0 07 Cable, Heater Control (Includes Parts Marked *) 00 * Cable 697 * Terminal, Ring 99 * Terminal, Receptical 0 * Terminal, Tab 09 Tie, Cable Screw, Cap Hex Head (/6 8 x /) Nut, Hex Self Locking (/6 8) Washer, Lock EIT (/6) * Parts Included in 07 Heater Cable 8

61 Voltage Regulator Detector Control 6 B8,H9,H60R Potentiometer 0 06 Used With SX60 Regulator (Shunt Excited) Used With MX Regulator (PMG Excited) Regulator, Voltage SX60 Regulator (Shunt Excited) 0 08 MX Regulator (PMG Excited) 0 Resistor Screw, Cross Recessed (#0 x 7/8) 0 Jumper Breaker, Circuit 9

62 Voltage Regulator Sentinel Control 6 B0,H6,K00,R,B8 Regulator, Voltage SX60 (Shunt Excited) 0 08 MX (PMG Excited) Potentiometer (Units with Meters) 0 06 Used With SX60 Regulator (Shunt Excited) Used With MX Regulator (PMG Excited) Breaker, Circuit Transformer (Used With MX (PMG Excited Regulator) except 600 Volt W/Meters) Screw, Pan Head Cross Recessed (#0 ) Used With SX60 Regulator (Shunt Excited) Used With MX (PMG Excited) 600 Volt W/Meters Used With MX (PMG Excited) except 600 Volt W/Meters Harness AC Control (Less than 600 Volts WO/Meters) 60

63 Dry Contact Spec B H Panel, Relay Relay Screw, Hex Head (M x ) Screw, Hex Head (#0 x.0) 8 7 Harness, Wiring Control Harness, Wiring Dry Contact (Includes Parts Marked #) 7 76 # Housing, Connector ( Pin) 8 7 A/R # Plug, Cavity A/R # Socket, Contact (Used in S7) A/R # Seal, Cable Standoff, Hex (#0 ) Nut, Hex W/ET (#0 ) # Parts Included in 8 7 Wiring Harness 6

64 Low Battery Voltage 6 H60,H 0 08 Lens, Indicator 8 0 Harness, Low Battery Voltage 0 0 Base, Relay Screw, Machine Round Head (#8 x ) 870 Nut, Hex W/ET (#8 ) Sensor, Low Battery 6

65 Ammeter H6,K00,R Ammeter, Dual Scale / / Nut, Hex W/ET (# 0) Nut, Acorn (/ 8) 6

66 Engine Gauges Sentinel Control H Tee, Pipe Bushing, Reducer 9 0 Gauge, Oil Pressure 9 06 Gauge, Water Temperature Nipple, Pipe 6

67 Vacuum Switch C Nipple, Close Tee, Pipe 0 09 Bushing, Reducer 0 6 Elbow Nipple, Close Switch, Vacuum Harness, Vacuum Switch 8 79 A/R Tie, Cable 6

68 Alarm Relay Board KJ Board, PC Alarm Relay Screw, Machine Round Head Cross Recessed W/IT (#6 x.0) Relay ( VDC) (K, K, K) * Sleeving (/ ) Standoff Alarm Board (. lg.) Standoff Alarm Board (. lg.) Harness, Alarm Relay Board (Includes parts marked *) 8 9 * Plug, 9 Pin 9 A/R * Tie, Cable * Pin, Contact 00 * Socket, Contact 9 * Plug, Pin * = Parts includes in 8 87 Harness Assembly 66

69 Audible Alarm KL9 0 Signal, Audible Plate, Audible Signal 8 08 Screw, Machine Round Head (#6 x /) Nut, Hex W/ET (#6 ) 67

70 Common Alarm H Board, PC Diode 8 0 Harness, Common Alarm Screw, Machine Round Head (#6 x /) A/R Tie, Cable 68

71 Time Delay Start/Stop KL9 8 0 Screw, Machine Round Head Cross Recessed W/ IT (#6 x /) PCB, Time Delay Start/Stop Tie, Cable 8 90 Harness, Time Delay Start/ Stop 69

72 Emergency Stop Switch KL9 0 7 Ammeter Blank Scale 0 67 Switch Blank Switch, Pushbutton Emergency Stop (Includes Bulb) (S) 09 Bulb, Replacement 70

73 Meter Transformer 6 H60,H6,H9,R,K Bracket, Transformer 077 Transformer, Meter 8 7 Harness, Transformer Nut, Hex W/ET (#8 ) Screw, Self-Locking Hex Flange Head (/6 8 x /) Nut, Self Locking (/6 8) 7

74 Wiring Harness AC Control CP0,H9,60,6,R,K00 Harness, Wiring AC Control (Includes Connector Plug and Contact Pins) 8 0 Generators With Full Rated, Phase, 60 Hertz Output at 7/600 Volts (6 Wire, ) (Includes Parts Marked *) (J to,6,7,8, GND, P, CT,,) 8 0 All Other Generators ( Wire, 8 ) (Includes Parts Marked #) (J to,,6,7,8, GND, CT,,) Plug, Connector (9 Place) 6 0 * Generators With Full Rated, Phase, 60 Hertz Output at 7/600 Volts (P, J) 6 0 # All Other Generators (J) Pin, Contact 67 8 * Generators With Full Rated, Phase, 60 Hertz Output at 7/600 Volts 67 9 # All Other Generators * Parts Used In 8 0 AC Control Wiring Harness # Parts Used In 8 0 AC Control Wiring Harness 7

75 Engine Harness Spec A H6,H9,H69 Harness, Engine 8 67 Detector Control (Includes Parts Marked +) 8 66 Sentinel Control (Includes Parts Marked #) 06 + Housing, Connector 8 Place (J) 0 + Housing, Connector 6 Place (J) #+ Relay 00 + Socket, Contact (Used in J, J) 6 #+ Rectifier, Silicon Sentinel Control Detector Control 7 99 #+ Resistor ( ohm, watt) Manifold, Oil Pressure Socket, Contact Bracket, Terminal 9 + Plug, Connector 8 + Wedge, Plug ( Pin) 6 + Plug ( Pin) Switch, Pressure (pre LOP) (S) Switch, Pressure (LOP) (S) #+ Block, Terminal # Diode, Zener 8 0 #+ Jumper Sender, Pressure Oil (E) (Includes Parts Marked *) 0 9 * Connector, Receptacle Place 8 * Wedge, Receptacle 9 * Socket, Contact 9 + Screw, Machine Round Head Cross Recessed W/IT (8 x.0) + Parts Included in 8 67 Wiring Harness # Parts Included in 8 66 Wiring Harness * Parts Included in 9 08 Oil Pressure Sender 7

76 Engine Harness Spec B H6,H9,H69 Harness, Engine 8 66 Detector Control (Includes Parts Marked *) 8 66 Sentinel Control (Includes Parts Marked ^) 06 * Housing, Connector 8 Place (J) 0 * Housing, Connector 6 Place (J) 7 * Housing, Connector Place (J) *^ Relay 6 00 A/R * Socket, Contact 7 *^ Rectifier, Silicon Detector Control Sentinel Control 8 99 *^ Resistor (Ω) 9 99 A/R * Socket, Contact 0 9 A/R * Terminal, Socket * Bracket, Terminal 060 *^ Block, Terminal 0 *^ Jumper 8 08 * Screw, Machine Round Head Cross Recessed W/IT (8 x.0) 9 * Plug, Connector 6 8 * Wedge, Plug ( Pin) 7 6 * Plug ( Pin) 8 0 A/R * Pin, Contact ^ Diode, Zener * Parts Included in 8 66 Wiring Harness ^ Parts Included in 8 66 Wiring Harness 7

77 Labels Label, Warning Label, Warning Label, Caution Label, Danger Label, Warning Label, Warning Label, Warning Label, PTS Label, Model ID Label, Model ID Label, Warning Label, Warning 7

78 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 098 0,, 7 0 6, 00, 0, ,,, 7 0 6, 0,, 0, ,,, ,, 0 9 0, ,,, , 9, 0 9 0, , , 8,, , , 0 786,, 66 07, , 098 7, ,, 86 67, , , 0 79,, , 7 0 7, 098 9,, 0 806, , 7 0 7, , ,, , 7 0 7, 098 8, 7 0 8,, 9 078, 7 0 7, , 0, 7 9, , , 7 0 9, 9 9, , , 7 0 0, 9 9, , ,, 7 0, , , , 8 0 6, 9 9 0, , , 9 0 7, 9 9 0, , 098 7, 0 8, , 7 08, , 08, , 7 087, , 098, , 8, , ,,, 7 9, 7, 7, , 8 06,, 9, 7 6 0, 0 6, 8 067, 6, 7 9 6, 7 6 0, , ,, 7 9 7, , 7 0 9, , 8 9 8, , , ,,, 6, 7 9 9, , , ,, 9, 7 90, 7 0 0, , 6 9, , 7 09, 7 8 0,, 9 08, 7 97, 8, , 9 0, 087 0,, , , 7, , , 0 096, 9 0, , , 0 09, 9 06, , , 7 0 6, , 096 0, , , , 7, , 7 0 9, , , , , 7 99, 0 0, , , 06 09, 0 0, , , , 0 6, , 0 8, 0 7, 0 7 0, , , 0 0, 0 7 0, , , 0 0, 0 7 0, , 0 60, 67, 0 7 0, , 70 76

79 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page , 9 98, , 07, , , 7, , 0, , 9 6,, ,, 000, 0 7, , 9, ,, 060 0, 0 8,, , ,, 06, 0 6, 9 989, ,, 06, 0 68, , , 09, , 9 996, 8, 9, , 0 07, 7 0 7, , , 0 08, 6 0 7, 9 07, 9, , 99, , 9 9, ,, 00, 66, 7, 7 0 7, 7 9 0, ,, 9, , 9, 0 96,, 9, , 9 07, ,, 0,, ,, , ,, 0, 7, ,, 7 9 0, 0 96, 06, 7, , 9, ,, 08, 0 06,, 9, , , 7, , 9, , 9, , 0 0, , , , 9, 7, , 9, , , 6, 7, , , , 8, 7, , , , 9, , 0, , , 9, 7, , 9, , , 6 0, ,, , , 6 0,, ,,, 6, , , 67, , , , 68,, , , , 708, 7, 9, , 6, 7, , , 709, 7, 9, , , , 7, 9, , , , 76, 7, 9, , 0 99,, , 0 0, ,, ,, , 007,,, ,, ,, ,, 00, 09 00, ,, ,, 060, 7, , ,, , 080, , , , 0897, , , , 09,,, , , , 09, 8 077, , , 0, 9, 7, , 0 99, , 89, 7, 9, , , ,, 0,, 66, 68, 69 77