Parts Manual. Generator Set. DQKAA (Spec A D) DQKAB (Spec A D) with PowerCommand 3201 Controller

Transcription

1 Parts Manual Generator Set with PowerCommand 0 Controller DQKAA (Spec A D) DQKAB (Spec A D) English Original Instructions (Issue 9)

2

3 To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Cummins Power Generation nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Cummins Power Generation manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Cummins Power Generation equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-

4 Introduction This catalog applies to Cummins Power Generation Generator Model DQKAA and DQKAB as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned in the description or page heading, parts are interchangeable between models. Throughout this catalog left and right sides are determined by facing the engine end (front) of the set unless noted in the description column. Engine parts that have been modified or added by Cummins Power Generation are identified in this catalog. All other engine replacement parts must be ordered from the engine manufacturer by referring to the engine manufacturer s nameplate and supplying all available information. Contact your nearest engine parts distributor for assistance in ordering replacement parts. Cummins Power Generation Generator Model DQKAA DQKAB Cummins Engine Model QSK0 G QSK0 G Generator Set Data Table Model and Electrical Data Battery Specification Watts Volts Hertz Wire Phase Voltage 50DQKAA/*,50,000 # 0 L, L VDC 000DQKAB/*,000,000 # 0 L, L VDC * The diagonal line (/) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from the standard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes. # 80,800V (Refer to Genset Data Sheet).

5 Index B Belt, 8 Belt, Fan, Block, Terminal Engine Coolant Heater Control, Box, Control, 5 Box, Control Installation, 8 Box, Entrance,, 8 Box, Entrance Assembly Bottom Entry, 5, Box, Entrance Assembly Top Entry,, Box, Terminal Generator Heater, Box, Terminal MV Alternators, 9 Box, Terminal P Alternators, 8 Breaker, Circuit, C Cable, Battery, Cage, Card Control, 5 Cartridge, Heater Generator Heater, Cleaner, Air, 8, 9 Control, Engine Coolant Heater, Cover, Control Engine Coolant Heater, D Detectors, Resistive Temperature, 9 Door, Control, 5 F Fan, 8 Fan Drive, 0 Filter, Fuel, G Generator, 5 Generator Installation, Lug, Solderless, Guard Kit, 9 H Harness, Wiring AC, 9 Harness, Wiring Control, 9 Harness, Wiring Engine, 80 Harness, Wiring Low Coolant Level Sensor, Heater, Control, Heater, Engine Coolant, Heater, Generator, Hose Assembly, Engine Coolant Heater, Housing, Terminal,, I Isolator, K Kit Heater, Relay, Kit, Contro, 85 Kits, 85 L Labels, Control Box, 5 Labels, Miscellaneous, 8 Lug, Solderless, M Module, Audible Alarm, 59 Module, Bus PT, 5 Module, PT/CT, 5 Muffler, 8 P Paint, 5 Parts, External Engine,

6 Index PCB Assy, 85 Pyrometer, 0 R Radiator, 8,,, Radiator, Remote, Relay, Alarm, 55 Relay, Customer, 55 Relay, Ground Fault, 58 Relay, Power Engine Coolant Heater Control, Relay, Run, 55 S Sealant, Thread, 5 Sensor, Low Coolant, Shim, Generator Mounting,, 5 Socket, Relay, 55 Spacer, Engine Mounting,, 5 Spacer, Generator Mounting,, 5 Switch, Key Operator, 8 Switch, Trip Alarm or Auxiliary Contact Circuit Breaker, T Transformer, Transformer P/P, 5, Transformer P80LV,, 8 Transformer P80MV, HV, 9, Transformer P, Transformer, Current Differential, 5 Trip, Shunt Circuit Breaker, Tube Assembly, Engine Coolant Heater, Tube, Radiator J/W L/H, 8 Tube, Radiator J/W R/H, 8 W Wiring Harness Control, 8, 8

7 Abbreviations Some of the following abbreviations may be used throughout this Parts Catalog: AC Amp A/R AVR AWG DC Deg EFC EIT EPROM ET GFI ID IEC IT kw LPG LT M(meter number) Alternating Current Ampere As Required Automatic Voltage Regulator American Wire Gauge Direct Current Degree Electronic Fuel Control External/Internal Tooth Erasable Programmable Read Only Memory External Tooth Ground Fault Interrupter Inside Diameter International Electrotechnical Commission Internal Tooth Kilowatt Liquid Petroleum Gas Left Meter mm MOH NFS NPT OD oz. PC Ph PMG PT/CT RFI RT Spec Thk UL UNC UNF VAC VDC W/(ET, IT, EIT) Millimeter Mobile Off Highway Not For Sale National Pipe Thread Outside Diameter Ounce Printed Circuit Phase Permanent Magnet Generator Potential Transformer/Current Transformer Radio Frequency Interference Right Specification Thick Underwriters Laboratories Inc. Union National Coarse Union National Fine Volts Alternating Current Volts Direct Current With Paint and Thread Sealant Onan Green Enamel (Non Metallic) oz. Pressurized Spray Can Quart Can Gallon Can Sealant, Thread ( ml Tube) 5

8 External Engine Parts Adapter (M to /) Valve, Ball Washer, Lock W/EIT (/) 5 0 Washer, Flat (M) Washer, Lock Spring (M) 800 Screw, Cap Hex Head (M x.5 x 5) 080 Cable, Battery Starters 8 09 Cable, Jumper 9 09 Cable, Battery 0 09 Boot, Battery Red 50 8 Hose Bulk (Order by the Foot Feet Rquired) Clamp, Hose Strap, Electrical 08 0 Boot, Starter Red Elbow, Tube 0 Cable, Starter Seal, O Ring 8 Belt, Fan Used on 0 Bearward Radiator Only 05 0 Used on IEA 50 Radiator Only

9 Fuel Filter Filter, Fuel Bracket, Fuel Filter Elbow, Tube Line, Fuel Screw, Cap Hex Head (/8 x ) Washer, Flat (/8) Washer, Split Lock (/8) Bushing, Reducer (-/ x ) Elbow, Tube Harness, Accessory Fuel Filter 900 Harness, Extension Fuel Filter

10 Air Cleaner Elbow, Reducer Elbow Hose ( ) Tube, Air Cleaner Bracket, Air Cleaner Vertical Right Bracket, Air Cleaner Plate Bracket, Air Cleaner Angle Bracket, Air Cleaner Vertical Left Screw, Hex Head (M8 x.5 x 0) Bracket, Air Cleaner Top Clamp, Hose Clamp, Hose Bracket, Air Cleaner Tube, Air Cleaner Tube, Air Cleaner Housing, Air Cleaner Flame Retardant 0 0 Fitting, Safety Filter Nut, Hex Flange Plug, Tapered (Not Illustrated) Screw, Cap Hex Head (M0 x.5 x 5) Washer, Lock (M0) 55 0 Shield, Heat Label, Information Bracket, Air Cleaner Angled Clamp (Not illustrated, fitment with 0 5 0) A09Y0 Element, Replacement (Not Illustrated) (Fleetguard Part Number) 8

11 Heavy Duty Air Cleaner, 8,, 0,,,, 5,, 8, 9, 0, 8, 0, 0 8, 5, 0, 5, 0, 9,0 9,, 5, Bracket, Air Filter 0 0 Bracket, Air Filter 0 0 Bracket, Air Filter Bracket, Air Filter Bracket, Air Filter Bracket, Air Filter Bracket, Air Filter Bracket, Air Filter Band, Mounting Filter, Air Elbow, Hose, Hump A0H Tube, Air Filter 0 9 Filter, Air Elbow 50 0 Elbow, Reducer 0 9 Filter, Air Bracket, Tube Clamp, Hose Clamp, Hose Clamp, Hose 55 0 Shield, Heat Screw, Hex Head 5 0 Washer, Flat Screw, Hex Head 80 0 Nut, Hex Flange Washer, Lock Screw, Hex Head Hood, Air Inlet Plug, Plastic A0H Tube, Air Filter 0 0 Fitting, Filter 0 58 Indicator, Service 0 9 Tube, Air 9

12 Engine Coolant Heater

13 Engine Coolant Heater Bracket, Water Heater 0 5 Non IBC Seismic A00A089 IBC Seismic Heater, Water Watts Watts 5 Manifold, Heater 0 9 Tube, Heater Tube, Heater 50 0 Hose, Connector 505 Adapter, Pipe (M x NPT) Valve, Ball Seal, O-Ring Tube, Water Heater 9 88 Cover, Control 0 89 Tube, Water Heater 0 9 Tube, Water Heater Clamp, Hose 5 Clamp, J Control Assembly, Heater (See Separate Page for Components) Hose, Silicone Rubber Clamp, Hose Insulation, Hose Seal, O Ring (M) 55 0 Clamp, Water Heater Nut, Hex Flange (/8 ) Tube Assembly, Heater Seal, Rect. Ring Hose Assembly, Coolant 80 0 Nut, Hex W/ET (#8 ) 50 8 Adapter, Pipe (M x /) Screw, Hex Head SEMS (/ 0 x 5/8 ) Washer, Flat Screw, Hex Head SEMS (M8 x / x 0) Screw, Cross Recessed (#8 x 5/8 ) A00X58 Switch, Temperature

14 Coolant Heater Control

15 Coolant Heater Control Box, Terminal 0 55 Cover, Coolant Heater Nut, Connector Lock (/ ) Plug, Hole (Fits /8 Hole) 5 9 Strip, Marker 8 Block, Terminal Place (TB) Relay, Power Screw, Machine Round Head Cross Recessed W/IT (#8 x / ) 9 0 Jumper, Terminal 0 00 Connector, Wiring DC Romex (/ ) Harness, Wiring Eng Harness, Wiring Eng Harness, Wiring (Includes Parts Marked *) * Rectifier ( Amp) 5 9 * Pin, Contact 9 * Socket, Contact 9 * Connector, Receptacle ( Pin) 8 50 * Wedge, Receptacle 9 50 * Connector, Plug ( Pin) * Wedge, Plug 5 * Connector, Plug Way ( Pin) 8 * Pin, Contact 5 * Seal, Cable Screw, Machine Round Head W/ET (#0 x /8 ) Washer, ET Lock (#0) Nut, Hex Brass (#0 ) Washer, Flat Brass (#0) Nut, Hex w/ ET (#0 ) Screw, Round Head Cross Recessed Thread Cutting W/IT (#8 x.50) Label, Danger Label, Ground * Parts Included In 8 98 Wiring Harness

16 Low Coolant Level Sensor Sensor, Level Coolant Harness, Engine Low Coolant (Includes the Following Items) Connector, Plug 0 Seal, Connector 5 Connector, Receptacle A/R Sleeving, Convoluted 59 Connector, Receptacle 8 5 Wedge, Receptacle 9 59 Plug, Seal

17 This Page Intentionally Left Blank. 5

18 Remote Radiator

19 Remote Radiator Bracket, Support Washer, Flat (M) Screw, Cap Hex Head (M x x 80) Bracket, Guard Washer, Flat (M) Screw, Cap Hex Head (M x.5 x 0) Cover, Guard Left Screw, Hex Head (M8 x.5 x ) Cover, Guard Cover, Guard Screw, Hex Head (M8 x.5 x 5) Without Flanges With Flanges 50 Adapter, Pipe (M x /) Nipple, Pipe (/ x.00) Line, Radiator Vent Adapter, Pipe (M x /) Elbow, Street 90 (/) Harness, Wiring Low Coolant Level (Includes Parts Marked *) Valve Valve, Check Coupling, Reducer (/8 x /) Nipple, Half (/8) Spacer CT (Not Shown) 5 09 Washer, Flat (M0) 0 5 Tube, Water Inlet With Flanges 5 A0E5 Tube, Water Outlet With Flanges Tube, Water Inlet With Flanges 50 Hose, Radiator (5.00 x.00) With Flanges Hose, Radiator (.00 x 5.50) With Flanges Clamp, Hose With Flanges Clamp, Hose With Flanges Bracket, Tube With Flanges Clamp, Muffler (5 in. Dia.) With Flanges Clamp, Muffler ( in. Dia.) With Flanges 0 8 Gasket, Connection With Flanges Tube, Water Outlet With Flanges Screw, Cap Hex Head (M0 x.5 x 5) With Flanges Washer, Flat (M0) With Flanges Washer, Lock Split (M0) With Flanges Nut, Hex (M0 x.5) With Flanges Line, Radiator Vent * Connector, Plug * Contact, Socket 0 * Seal, Connector * Connector, Receptacle 5 5 * Contact, Pin 59 * Connector, Receptacle 5 * Wedge, Receptacle 8 59 * Plug, Seal * Parts Included In Wiring Harness

20 Radiator DQKAB Enhanced High Ambient ,, 5, A00D Radiator A00S5 Bracket, Pipe 0 55 Pipe (I.D. ) Clamp, Hose 5 A00S50 Pipe (Bottom) 50 Clamp, Hose Pipe (I.D..) 8 A09Y80 Vent, Line Clamp, Hose 0 A09Y8 Vent, Line A09Y8 Vent, Line 0 5 Duct, Transition R/H A00S5 Guard, Fan A00S Guard, Fan Cap, Radiator A09B98 Belt (Not Shown) Fan (Not Shown) Screw, with Washer (M8 x 5) 9 A00S0 Pipe (I.D. ) Clamp, U Bolt 0 55 Hose, J/W 0 Tube, Radiator J/W R/H 0 Tube, Radiator J/W L/H 0 88 Hose, J/W 5 A00S 5 Screw, with Washer (M x 0) Clip, 95 SP0 Clamp, U Bolt 8 A00S5 Pipe (I.D. ) 9 A09X98 Sight Gauge (Mounted to Top Tank) 8

21 Guard Kit A00S0 Guard (Bottom RH) A00S Guard (Top) A00S Guard (Front) A00S8 Guard (Bottom) 5 A00S9 Guard (Infill RH) A00S Guard (Extension) A00S Guard (Infill Angle) Guard Belt (Rear) Bracket, Radiator Bracket, Radiator Bracket, Radiator 0 58 Bracket, Fan Guard 9

22 Fan Drive REF PART QTY. PART NO. NO. USED DESCRIPTION Pulley 5 0 Belt V Ribbed 0

23 Radiator (0 ) Radiator Complete A09B98 Belt 0 50 Bolt, C/W Washer (M8 x 5) Bolt (M x 50) 80 0 Nut, Nyloc (M) Washer, Flat (M) 0 8 Duct, Radiator (Trans Frame Side) 0 9 Gauge, Sight Nut, Comby (M8) Slab, J/W Radiator (Consists of Cores P/N 0 509) Slab, LTA Radiator (Consists of Cores P/N 0 50) 0 Stoneguard Fan A00S5 Guard, Fan A00S Guard, Fan Cap, Radiator (0 KPA) Label (Lifting/Warning) Label (Hot Pressurized Coolant) Label (Water Drain) Label (Rotating Fan) Label (Voltage & Rotating Parts) Label (Grease) 5 8 Kit, LTA and J/W Gasket

24 Radiator Hoses (0 ) A00S5 Bracket, Support SP0 Clamp, U-Bolt ( ) 0 55 Hose, J/W ( ID) 50 9 Clip ( 55) 5 A00S5 Pipe, J/W ( OD) 50 9 U-Bolt A00S50 Pipe, J/W (Bottom) 8 50 Clip (95 ) Hose, J/W Hose, Radiator ( ) A00S Pipe, LTA (Bottom) 50 8 Clip (0 9) 0 0 Bracket, Pipe Support 0 88 Pipe, LTA (Top) Washer, Flat (/) 5 Washer, Flat (M) 0 5 Strip, Foam 8 0 Pipe, J/W (Top L/H) 9 0 Pipe, J/W (Top R/H) Line, J/W Vent 0 Bracket, Pipe Support A00S Line, LTA Vent 0 59 Nut, Comby (M8) 0 5 Line, LTA Vent Hose (5. I/D) Clamp 50 5 Hose (5. I/D) Clamp

25 Radiator Guards (0 ) Bolt, C/W Washer (M8 x 5) A00S0 Guard, Bottom R/H Panel 80 0 Nut, Comby (M) 0 59 Nut, Comby (M8) Guard, Radiator (Lower Rear) 0 58 Guard, Radiator (Upper Rear) A00S Guard, Top Panel 8 A00S Guard, Front Panel 9 A00S8 Guard, Bottom Panel Guard, Side Bracket (L/H) Guard, Side Bracket (R/H) Bolt, C/W Washer (M x 0) 0 Guard, Side Bracket (R/H) A00S9 Guard, Infill Panel (R/H) 5 A00S Guard, Extension Panel A00S Guard, Infill Angle

26 Skid Skid A00A5 Radiator Skid A00C9 Remote Radiator Skid Screw, Cap Hex Head (M0 x.5 x 00) 0 Spacer, Engine Mounting ( ID x 5 OD x 9/ Thk) Nut, Hex (M0 x.5) Washer, Flat (M0) Screw, Cap Hex Head (M0 x.5 x 0) Screw, Cap Hex Head (M0 x.5 x 0) Screw, Cap Hex Head (M0 x.5 x 0) Washer, Generator Mounting Screw, Cap Hex Head (M x x 0) P80 Alternators Washer, Flat (M) Nut, Hex (M x ) 0 Spacer, Generator Mounting ( / ID x 5 OD x /8 Thk) P Alternators Screw, Cap Hex Head (M x x 0) P Alternators 5 Shim, Generator Mounting (Quantity Used As Required) Thk Thk Thk Thk Line, Fuel Flexible Fuel In Fuel Out

27 Skid (IBC) A00A5 Skid Screw, Cap Hex Head (M0 x.5 x 00) 0 Spacer, Engine Mounting ( ID x 5 OD x 9/ Thk) Nut, Hex (M0 x.5) Washer, Flat (M0) Screw, Cap Hex Head (M0 x.5 x 0) Screw, Cap Hex Head (M0 x.5 x 0) Screw, Cap Hex Head (M0 x.5 x 0) Washer, Generator Mounting Screw, Cap Hex Head (M x x 0) P80 Alternators Washer, Flat (M) Nut, Hex (M x ) 0 Spacer, Generator Mounting ( / ID x 5 OD x /8 Thk) P Alternators Screw, Cap Hex Head (M x x 0) P Alternators 5 Shim, Generator Mounting (Quantity Used As Required) Thk Thk Thk Thk Line, Fuel Flexible Fuel In Fuel Out 5

28 Isolator A00S Isolator (Spec A D) Isolator (Spec E)

29 Entrance Box Box, Circuit Breaker Panel, Terminal Cover, Circuit Breaker Bottom Entrance Cover, Circuit Breaker Top and Bottom Entrance Cover, Circuit Breaker Screw, Hex (M8 x.5 x 0) A0K5 Bracket, Circuit Breaker Stiffener, Cover Screw, Hex (M x x ) Label, Ground Cover, Circuit Breaker Adapter Plug Top and Bottom Entrance Cover, Circuit Breaker Front Label, Danger English French

30 Entrance Box Box, Outlet Cover, Outlet Box Cover, Outlet Box Cover, Outlet Box Cover, Outlet Box 9 58 Stiffener, Cover Panel, Output Box Panel, Output Box Panel, Output Box Panel, Output Box Panel, Mounting Screw, Hex Head (M8 x.5 x 0) Washer, Lock W/EIT (5/) Washer, Lock Split (/) Washer, Lock W/EIT (/) Screw, Cap Hex Head (/ 0 x 5/8) 8

31 This Page Intentionally Left Blank. 9

32 Entrance Box Assembly Top Entry Illustration #

33 Entrance Box Assembly Top Entry Channel, Support 8 00 Standoff Plate, Mounting Bus, Bar 5 8 Lug, Cable Screw, Hex Head (M8 x.5 x 0) Washer, Flat (/8) (Not Shown) Washer, Spring (/8) (Not Shown) Screw, Cap Hex Head (/8 x ) Washer, Lock Split (M) Nut, Hex (M8 x.5) Screw, Cap Hex Head (M x.5 x 0) Washer, Belleville (M) Nut, Hex (M x.5) Washer, Flat (M) Panel Panel, Output Box Grommet Cover, Outlet Box Screw, Locking Flange (M x.5 x 0) Washer, Flat Washer, Lock W/EIT (5/) Washer, Lock W/EIT (/) Washer, Lock Spring (/8) Bracket, Terminal Block 89 Bus, Bar (MV/HV) 88 Bus, Bar (MV/HV) 8 8 Bus, Bar (MV/HV) Cable Assembly Cable Assembly Cable Assembly Cable Assembly Screw, Hex Head (M8 x.5 x 5) Label, Warning Lifting Cable Assembly 85 Bus, Bar Ground Washer, Flat (M8) Washer, Lock Split (M) Nut, Hex (M8 x.5) (Not Shown) Label, Logo Bracket, Cable 9 58 Channel, Mounting 0 Clamp, Cable Label, Danger Label, Danger French Label, Marker (0 Characters Per Card) (Quantity Used As Required) Marked L Marked Marked Marked Marked Label, Ground 8 9 Clamp, J Screw, Cap Hex Head (/8 x -/) Screw, Cap Hex Head (/8 x ) Washer, Flat (/8) Nut, Hex (/8 )

34 Entrance Box Assembly Top Entry Illustration #

35 Entrance Box Assembly Top Entry Channel, Support 8 00 Standoff Plate, Mounting Bus, Bar 5 8 Lug, Cable Screw, Hex Head (M8 x.5 x 0) Washer, Flat (/8) (Not Shown) Washer, Spring (/8) (Not Shown) Screw, Cap Hex Head (/8 x ) Washer, Lock Split (M) Nut, Hex (M8 x.5) Screw, Cap Hex Head (M x.5 x 0) Washer, Belleville (M) Nut, Hex (M x.5) Washer, Flat (M) Panel Panel, Output Box Grommet Cover, Outlet Box Screw, Locking Flange (M x.5 x 0) Washer, Flat Washer, Lock W/EIT (5/) Washer, Lock W/EIT (/) Washer, Lock Spring (/8) Bracket, Terminal Block 89 Bus, Bar (MV/HV) 88 Bus, Bar (MV/HV) 8 8 Bus, Bar (MV/HV) Cable Assembly Cable Assembly Cable Assembly Cable Assembly Screw, Hex Head (M8 x.5 x 5) Label, Warning Lifting Cable Assembly 85 Bus, Bar Ground Washer, Flat (M8) Washer, Lock Split (M) Nut, Hex (M8 x.5) (Not Shown) Label, Logo Bracket, Cable 9 58 Channel, Mounting 0 Clamp, Cable Label, Danger Label, Danger French Label, Marker (0 Characters Per Card) (Quantity Used As Required) Marked L Marked Marked Marked Marked Label, Ground 8 9 Clamp, J Screw, Cap Hex Head (/8 x -/) Screw, Cap Hex Head (/8 x ) Washer, Flat (/8) Nut, Hex (/8 )

36 Entrance Box Assembly Bottom Entry Illustration #

37 Entrance Box Assembly Bottom Entry Channel, Support 8 00 Standoff Plate, Mounting 80 Bus, Bar 5 Bus, Bar Bus, Bar Bus, Bar Cable Assembly Cable Assembly Cable Assembly Cable Assembly 8 Lug, Cable Screw, Hex Head (M8 x.5 x 0) Washer, Flat (/8) Washer, Spring (/8) Screw, Cap Hex Head (/8 x ) Washer, Lock Split (M) Nut, Hex (M8 x.5) Screw, Cap Hex Head (M x.5 x 0) Washer, Belleville (M) Nut, Hex (M) Washer, Flat (M) 0 0 Housing, Terminal Duct 0 Housing, Terminal Duct 5 0 Housing, Terminal Duct Panel 8 0 Housing, Terminal Base 8 0 Housing, Terminal Duct Panel, Output Box Screw, Hex Head (M8 x.5 x ) Grommet 0 08 Cover, Outlet Box Screw, Locking Flange (M x.5 x 0) Washer, Flat Washer, Lock W/EIT (5/) Washer, Lock W/EIT (/) Washer, Lock Spring (/8) Cable, Ground Bracket, Terminal Block Screw, Hex Head (M8 x.5 x 5) Label, Warning Lifting 85 Bus, Bar Ground 009 Strap, Bond Washer, Flat (M8) Washer, Lock Split (M) Nut, Hex (M8 x.5) (Not Shown) Label, Logo Label, Danger Label, Danger French 50 Label, Marker (0 Characters Per Card) (Quantity Used As Required) Marked L Marked Marked Marked Marked Label, Ground 5 9 Clamp, J Screw, Cap Hex Head (/8 x -/) Screw, Cap Hex Head (/8 x ) Washer, Flat (/8) Nut, Hex (/8 ) 5

38 Entrance Box Assembly Bottom Entry Illustration #

39 Entrance Box Assembly Bottom Entry Channel, Support 8 00 Standoff Plate, Mounting 80 Bus, Bar 5 Bus, Bar Bus, Bar Bus, Bar Cable Assembly Cable Assembly Cable Assembly Cable Assembly 8 Lug, Cable Screw, Hex Head (M8 x.5 x 0) Washer, Flat (/8) Washer, Spring (/8) Screw, Cap Hex Head (/8 x ) Washer, Lock Split (M) Nut, Hex (M8 x.5) Screw, Cap Hex Head (M x.5 x 0) Washer, Belleville (M) Nut, Hex (M) Washer, Flat (M) 0 0 Housing, Terminal Duct 0 Housing, Terminal Duct 5 0 Housing, Terminal Duct Panel 8 0 Housing, Terminal Base 8 0 Housing, Terminal Duct Panel, Output Box Screw, Hex Head (M8 x.5 x ) Grommet 0 08 Cover, Outlet Box Screw, Locking Flange (M x.5 x 0) Washer, Flat Washer, Lock W/EIT (5/) Washer, Lock W/EIT (/) Washer, Lock Spring (/8) Cable, Ground Bracket, Terminal Block Screw, Hex Head (M8 x.5 x 5) Label, Warning Lifting 85 Bus, Bar Ground 009 Strap, Bond Washer, Flat (M8) Washer, Lock Split (M) Nut, Hex (M8 x.5) (Not Shown) Label, Logo Label, Danger Label, Danger French 50 Label, Marker (0 Characters Per Card) (Quantity Used As Required) Marked L Marked Marked Marked Marked Label, Ground 5 9 Clamp, J Screw, Cap Hex Head (/8 x -/) Screw, Cap Hex Head (/8 x ) Washer, Flat (/8) Nut, Hex (/8 )

40 Terminal Box P Alternators Panel, Terminal Front Panel, Terminal Back Panel, Terminal Left Panel, Terminal Right Panel, Terminal Top Screw, Hex Head (M8 x.5 x 0) Panel, Terminal Box, Terminal Spacer Screw, Hex Head (M8 x 0) Washer, Flat (M8) 8

41 Terminal Box MV Panel, Terminal Panel, Terminal Panel, Terminal Panel, Terminal Panel, Terminal Screw, Hex Head (M8 x.5 x 0) Panel, Terminal Screw, Hex Head (M0 x.5 x 0) 9

42 Terminal Housing

43 Terminal Housing 9 0 Housing, Terminal 99 0 Housing, Terminal Top 90 0 Housing, Terminal Front Low Voltage Bottom Entry A0Y595 Bus, Bar Ground Housing, Terminal Base Screw, Hex Head (M8 x.5 x 0) 800 A/R Screw, Cap Hex Head (M x.5 x 0) A/R Nut, Hex (M x.5) Housing, Terminal Low Voltage Bottom Entry 0 8 Insulation, Bus Bar 8 Bus, Bar 5 09 A/R Washer, Flat (/) A/R Washer, Spring (/) 9 0 Housing, Terminal Low Voltage Top Entry 5 8 Bus, Bar Low Voltage Top Entry Bus, Bar Low Voltage Top Entry A/R Screw, Cap Hex Head (M x.5 x 0) (Not Shown) Handle, Door Plug, Hole Extrusion, Aluminum Low Voltage Top Entry 05 0 Housing, Terminal Brace Low Voltage Top Entry 898 Clamp, Loop Low Voltage Top Entry Washer, Lock W/EIT 9 0 Panel, Filler Label, Logo 00 Insulator, Cable Low Voltage Top Entry 0 0 Housing, Terminal Right Side Housing, Terminal Left Side Label, Ground 0 Label, Marker (0 Characters Per Card) (Quantity Used As Required) Marked L Marked Marked Marked Marked Edging Bulk (Order by the Foot Feet Required) Label, Danger Screw, Cap Hex Head (M x.5 x 80) 5 0 Plug, Hole Low Voltage Top Entry

44 Terminal Housing Housing, Terminal 90 0 Housing, Terminal 98 0 Housing, Terminal Screw, Hex Head (M8 x.5 x 0) Handle, Door Housing, Terminal 99 0 Housing, Terminal Screw, Cap Hex Head (M x.5 x 0) Washer, Flat (/) Nut, Hex (M x.5) 9 0 Panel, Filler Nut, Hex Flange (Not Shown) 05 Insulator, Cable (Not Shown) Housing, Terminal Duct (Not Shown) Housing, Terminal Duct (Not Shown) Housing, Terminal Bracket (Not Shown) Extrusion, Aluminum (Not Shown) Plug, Hole Label, Danger Edging Bulk (Order by the Foot Feet Required) Label, Logo (White) Label, Information 0 0 Housing, Terminal (Right Side) 0 0 Housing, Terminal (Left Side) 5 A00X58 Switch, Temperature (not shown)

45 Generator Heater * Kit Heater, Relay Cartridge, Heater (00 Watt) Volt Volt 89 Bracket, Mounting Heater 0 Clamp, Loop 8 05 Screw, Machine Slotted Pan Head (M x mm) Washer W/EIT (M) Nut, Hex (M) Washer, Lock Spring (M5) Nut, Hex (M5) Screw, Cap Hex Head (M5 x mm) Washer, Lock Spring (M) 8 0 Screw, Machine Pan Head (M x 0mm) Grommet 0 Block, Terminal A00F Sleeving Heater Leads (59 ) Box, Terminal 5 00 Plug, Dot Button Cover Assy Cover, Box Gasket, Cover * Available for failed units, models DQKAA and DQKAB. Not required for functioning units.

46 Generator Installation Washer, Flat Screw, Cap Hex Head (M x.5 x 55) 5 0 Washer, Flat (5/8) Bolt, Place 5 9 Clamp, J

47 Generator Generator component parts cannot be ordered from Cummins Power Generation. Refer to the Newage nameplate and supply all available information. Contact your nearest Newage distributor for assistance in ordering component parts. For COMPLETE generator replacement use the 00 XXXX XX Cummins Power Generation identification number listed below. NOTE: From Field Flash Titled Hardened Cartridge for Alternator Bearing UPDATE Kit to replace a Standard or Hardened Cartridge. The new kit includes a new bearing and cartridge. 05 Alternator Kit for HC or MV or P 05 8 Alternator Kit for Frame 8 Mark 05 9 Alternator Kit for P80 Cummins Power Generation Identification Number Continued... Generator Model Number or Frame/Core P80R P80S P80R P80S P80S P80R P80S P80R P80S P80S P80T P80T P80R P80R P80S P80R P80S 5

48 Generator Cummins Power Generation Identification Number Generator Model Number or Frame/Core Continued P80T 00 P80T 00 P80T PD PE PF PG PD PE 00 8 PF 00 8 PG 00 8 PD 00 8 PE 00 8 PF 00 8 PG 00 8 PD PE PF PG PE MVH MVSI80R HVSI80R HVSI80R LVSI80T LVSI80T MVSI80T HVSI80T

49 Control Heater 5 Heater Assembly, Control 50 Watt Volt Volt Rivet, Drive 5 0 Block, Terminal 0 Endplate, Terminal Label, Caution 00 Block, Terminal Ground Relay, Power (K, K5 and K0)

50 5 Control Box Installation   Â Â Bracket, Control 9 0 Bracket, Control Screw, Hex Head (M8 x.5 x 0) Isolator, Vibration Washer, Flat (/8) 85 0 Screw, Hex Flange Head (M8 x.5 x 5) Rivet, Pop Strap, Bond Washer, Lock W/ET (M8) Washer, Flat Screw, Cap Hex Head (M0 x.5 x 5) Nut, Lock Flange (M0 x.5) 50 8 Hose, Fuel A0S508 Label, Caution 5 0 Strap, Bond 5 00 Washer, Flat (M8) Screw, Cap Hex Head (M8 x.5 x 5) Nut, Locking Flange (M8 x.5) Screw, Hex Head (M0 x.5 x 0) 8

51 Resistive Temperature Detectors Detectors, Resistive Detectors Package P Without Mounting Plate With Mounting Plate Screw, Cap Hex Head P Screw, Hex head Detector, Temperature Frame 8 9

52 Control Door

53 Control Door Door, Control Box 9 5 Spacer, LED Board, Printed Circuit Bargraph Board, Printed Circuit Operator Panel Digital 5 00 Display, Digital Screw, Pan Head Thread Forming (M x 0.5 x ) 5 0 Washer, Double Hole Nut, Hex (M5 x.8) Nut, Nyloc (M) Nut, Nylon Lock (M5) Display, Control Board, Printed Circuit Software Panel 00 0 Regulator, Auto Voltage Standoff 5 A05Y98 Light, Panel 00 Lamp, Panel Latch, Door (/ Turn) Latch, Cam (Single Point) Lens, LED Bracket, Printed Circuit Board Screw, Pan Head Thread Cutting ( x 5/) 5 99 Clamp, Cable 80 0 Nut, Nylon Lock (M5) 005 Clip, Wire Hinge, Block Screw, Hex Head (M5 x 0.8 x 0) Bumper Gasket, Enclosure Cover, Printed Circuit Board Bracket, Control A05H895 Harness, Switch A05H89 Switch, Pushbutton A09R8 Harness, Control Harness, Control (Parts Below Included ) 89 Connector, Six Pin Socket, Terminal Switch, Selector 08 8 Switch, Pushbotton 5

54 Control Box A0M8 Box, Control Label, Information Rivet, Drive A09D9 Rail, Terminal Screw, Flange Head (M5 x 0.8 x 0) Screw, Pan Head Torx Thread Forming (M x 0. x ) 88 Block, Terminal Harness, Lonworks Label, Ground Plug, Hole 80 0 Nut, Nylon Lock (M5) Washer, Lock W/ET (M8) 009 Strap, Ground Nut, Lock Flange (M8) Screw, Locking Flange (M8 x.5 x ) Washer, Flat (M5) Bracket, Cable Screw, Pan Head Cross Recessed (M x x 50) 9 A09R8 Control, Harness Washer, Flat 8 Harness, Meter 5

55 Card Cage Frame, Cabinet 08 Heatsink, Genset Board, Printed Circuit NCM 90 Board, Printed Circuit Backplane Screw, Torq (M x ) Guide, Metal Guide 0 09 Left Side 0 09 Right Side Screw ( 0 x /) Screw (M x 0) Cover, Control Blank 0 Board, Printed Circuit Parallel Genset 0 Full Feature (Supports PTC Power Transfer Control) (Marked #) 0 Depop Feature (PTC Power Transfer Control Not Supported)(Marked #) 88 Cover, 9-Pin Header 9 Board, Printed Circuit Genset Base 5

56 Control Cabinet Labels Label, Warning Label, Cabinet Label, Logo (White) Label, Warning Label, Warning Label, Danger Label, Information Label, Caution Label, Information Label, Instruction Label, Danger Label, Warning Label, Warning Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC Volts AC 5

57 Customer Relays Relay ( Volt) 0 05 Alarm Relay (K) Run Relay (K,,) Socket, Relay 0 0 Alarm Relay 0 0 Run Relay 55

58 Bus PT Module Board, Printed Circuit Bus PT Module Volts Volts Volts 80 0 Nut, Nylon Lock (M5) Standoff Guard, Electrical 5

59 PT/CT Module Board, Printed Circuit PT/CT Module Volts Volts Volts 80 0 Nut, Nylon Lock (M5) Standoff 005 Clip, Wire 5

60 Ground Fault Relay Relay, Ground Fault 0 98 Bracket, Watts Transducer 8 00 Screw, Locking (5/ 8 x /) Nut, Self-Locking (5/ 8) Mount, Shock Washer, Lock W/ET (#8) Nut, Hex W/ET (#8 ) Harness, Relay 9 0 Mount, Cable Tie Plate, Mounting Relay Transformer, Current (Used With Pole Separately Derived Transfer Switch) Screw, Locking (/ 0 x /) 80 0 Nut, Self-Locking (/ 0) 8 8 Harness, Meter Resistor 5 5 * Bracket, Transformer Current 5 * Transformer, Current * Washer, Flat (/) * Screw, Slotted Round Head (#8 x.50) * Washer, Lock Split (#8) * Screw, Slotted Round Head (#8 x.5) * Nut, Hex (#8 ) * Used With Pole Non-Separately Derived Transfer Switch 58

61 Audible Alarm Module Label, Alarm 8 5 Harness, Alarm (Includes the Following Parts) Connecter, LED 09 Lamp, LED High Intensity Lens, LED (Amber) 09 0 Lens, LED (Green) 09 0 Lens, LED (Red) Switch, Toggle 9 05 Alarm, Audible Gasket, Audible Alarm 59

62 Pyrometer Label, Exhaust Pyrometer A0T9 Contol, Temperature A0J Harness, Meter Pyrometer (Labeled) A0J9 Harness, Meter Pyrometer (Labeled) Sender, Temperature Label, Instruction Clamp Screw Adapter, Pipe (/8 x M) Label, Instruction Switch Elbow, Exhaust Outlet 0

63 Solderless Lug 5 Lug, Solderless 0 0 Lug, Solderless

64 Solderless Lug Washer, Lock W/ET 00 Lug, Solderless Washer, Lock Washer, Flat Screw, Cap Hex Head

65 Transformer Transformer, Current 0: 9 5 Base, Transformer

66 Transformer P A/R Transformer, Current 550: Base, Transformer Screw, Hex Head (M)

67 Transformer P/P Dual Metering/Differential Current Transformer A/R 000:/5000: A/R 000:/000: A/R 000:/5000: A/R 000:/000: A/R 000:/500: A/R 5000:/500: A/R 5000:/000:5 Line Side Differential Current Transformer A/R 5000/ A/R 000/ A/R 500/ A/R 000/ Rail, Terminal 88 Block, Terminal Block, Terminal 0 Block, Terminal 8 Harness, Transformer Screw, Hex Head Washer, Lock Nut, Hex 9 Lead, Ground 5

68 Transformer P/P Transformer, Current A/R 000/ A/R 000/ A/R 5000/ Screw, Cap Hex Head (M x 0) Washer, Flat Washer, Lock

69 Transformer P80LV 8 5 Transformer, Current / / /5 8 Harness, AC Clip, Wire Nut, Hex Flange Screw, Hex Head (M8 x.5 x 0) Washer, Flat Washer, Belleville Stud (M8 x.5) 9 0 Jumper, Terminal (Not Shown) Harness AC(CT) (Not Shown)

70 Transformer P80LV 8 5 Transformer, Current A/R 000/ A/R 000/ 8 0 Harness, AC Clip, Wire Nut, Hex Flange Screw, Hex Head (M8 x.5 x 0) Washer, Flat Washer, Belleville Stud (M8 x.5) 8

71 Transformer P80MV, HV 5 8 Transformer, Current / / / / / /5 8 Harness, AC Clip, Wire Nut, Hex Flange Screw, Hex Head (M8 x.5 x 0) Washer, Flat Washer, Belleville Stud (M8 x.5) 9 0 Jumper, Terminal (Not Shown) 9

72 Transformer P80MV, HV

73 Transformer P80MV, HV Transformer, Current A/R 800/ A/R 00/ A/R 50/ A/R 00/ 8 0 Harness, AC Clip, Wire Nut, Hex Flange Screw, Hex Head (M8 x.5 x 0) Washer, Flat Washer, Belleville Stud (M8 x.5) Screw, Cap Hex Head (M8 x.5 x 0) Screw, Cap Hex Head (M8 x.5 x 0) 0 Clamp, Cable

74 Transformer Differential MV, HV Transformer, Current C0/00: C0/00: : Bracket Transformer non slotted slotted

75 This Page Intentionally Left Blank.

76 Differential Current Transformer

77 Differential Current Transformer Transformer, Current CT,CT,CT) Ratio 00/ Ratio 500/ Screw, Machine Round Head (#0 x /8 ) 9 5 Bracket, Current Transformer Washer, Lock Spring (#0) Washer, Flat (#0) A/R Plug, Hole (Fits 5/ Hole) (Quantity Used As Required) 9 9 Bracket, Foot Screw, Cap Hex Head (5/ 8 x / ) Washer, Flat (5/ ) Washer, Lock Spring (5/ ) Nut, Hex (5/ 8) 89 0 Rail, Terminal 88 Block, Terminal 5 0 Block, Terminal 5 0 Block, Terminal 8 5 Harness, Transfer Differential 9 Lead GND 5

78 Circuit Breaker

79 Circuit Breaker Breaker, Circuit Pole (UL & IEC) (Includes Mounting Hardware) Amp Amp Amp Box, Circuit Breaker Panel, Terminal Cover, Circuit Breaker Top Cover, Circuit Breaker Bottom Screw, Hex Head (M8 x.5 x 0) Cover, Circuit Breaker Left Side Installation Right Side Installation Cup, Switch Bracket, Circuit Breaker 0 Spacer, Mounting Foot Label, Information Service Disconnect 0 Standoff, Insulator 5 5 Standoff, Insulator Washer, Lock Split (/8) Screw, Cap Hex Head (/8 x.5) 0 Standoff, Insulator Washer, Lock Split (/) Screw, Cap Hex Head (/ x.00) 9 Bus, Bar Ground Washer, Flat Washer, Belleville (/8) Screw, Cap Hex Head (/8 x ) 09 Lug, Solderless Screw, Cap Hex Head (5/ 8 x ) Washer, Belleville (5/) Nut, Hex (5/) 85 0 Screw, Hex Washer Head Thread Forming (/ 0 x.50) Stiffener, Cover Screw, Hex Head (M x x 0) 0 8 Bus, Bar Breaker Screw, Cap Hex Head (/ x ) Washer, Belleville (/) Nut, Hex (/) Bus, Bar Neutral 5 Bus, Bar Neutral Bus, Bar Neutral 5 Bus, Bar Jumper 8 Bus, Bar Neutral Screw, Cap Hex Head (/8 x.5) 0 Bus, Bar Breaker 0 0 Left Side Insulation 0 0 Right Side Insulation Bus, Bar Breaker 0 Left Side Insulation 0 Right Side Insulation 9 0 Bus, Bar Breaker 9 0 Bus, Bar Breaker Bus, Bar Breaker 0 0 Left Side Insulation 0 0 Right Side Insulation 5 Bus, Bar Breaker 0 Left Side Insulation 0 Right Side Insulation Screw, Cap Hex Head (/ x.5) Label, Neutral Disconnect Label, Bonding Jumper Label, Information Lug Installation Label, Ground Label, Conduit Location 5 Label, Marker (0 Characters Per Card) (Quantity Used As Required) Marked L Marked Marked Marked Marked 0 5 Lead (Quantity Used As Required) Screw, Cap Hex Head (M x.5 x 0) Nut, Hex (M) Washer, Lock Split (M) Washer, Flat (M) Accessories, Circuit Breaker: Switch Used as a Trip Alarm or Auxiliary Contact Volt Shunt Trip Lug, Cable Solderless Screw, Cap Hex Head (/8 x.00) Washer, Spring (/8) Nut, Hex (/8) Bus, Bar Ground Screw, Cap Hex Head (5/ 8 x -/) Screw, Cap Hex Head (M8 x 50) Screw, Cap Hex Head (M8 x.5 x 5) 8 Label, Warning English French 9 Label, Danger English French

80 Muffler Muffler 55 0 Residential 55 0 Critical 8

81 Wiring Harness AC Harness, AC (Includes Parts Listed Below) 8 Frame, and 5 LV Alternators 8 Frame 8 Alternators 8 0 Set Mounted Integrated PCC II Controls With P LV Alternators 8 0 Set Mounted Integrated PCC0 Controls With P & MV Alternators 0 Housing, Plug and Cap 0 Housing, Plug and Cap 8 5 Socket, Terminal 9

82 Wiring Harness Engine Harness, Engine (Includes Parts Listed Below) 80 Socket, Contact 0 0 Boot, Ring Red 58 0 Plug, Connector ( Place) 5 99 Socket, Contact 58 Wedge, Plug 80

83 Wiring Harness Control Harness, Control (Includes Parts Listed Below) 05 0 Connector, Plug 05 0 Connector, Plug 58 Plug, Pin 5 58 Wedge, Plug Connector, Plug Wedge, Plug 8 8 Connector, Contact 9 8 Connector, Contact 0 8 Connector, Contect 9 Socket, Terminal 0 Socket, Terminal Relay, Power Rectifier, Silicon Contact, Socket 99 8 Terminal, Receptacle 99 Terminal, Receptacle (not shown) Splice, Butt (not shown) 9 00 Terminal, Block 0 0 Terminal, Jumper (not shown) 8 0 Pin, Contact 8 Grommet 05 0 Plug, Grommet Splice, Parallel (not shown) A/R Tube (not shown) Label 5 Pin, Contact (not shown) 8 9 Connector, Receptacle 9 0 A/R Wire (not shown) Switch, Pushbutton (not shown) Socket, Receptacle 58 Wedge, Receptacle 0 0 Fuse 05 Fuse, Holder Pin, Terminal (not shown) 8 Socket, Contact (not shown) 9 5 Spade, Terminal A/R Sleeve 9 50 Plug, Wedge 0 9 Plug, Connector 888 Connector, Boot A/R Sleeve, Insulated 80 Socket, Contact (not shown) A/R Sleeve, Convoluted 5 50 Splice, Window (not shown) 8

84 Wiring Harness Control A09R8 Harness, Control (Includes Parts Listed Below) 05 0 Connector, Plug 05 0 Connector, Plug 58 Plug, Pin 5 58 Wedge, Plug Connector, Plug Wedge, Plug 8 8 Connector, Contact 9 8 Connector, Contact 0 8 Connector, Contect 9 Socket, Terminal 0 Socket, Terminal Relay, Power Rectifier, Silicon Contact, Socket 99 8 Terminal, Receptacle 99 Terminal, Receptacle (not shown) Splice, Butt (not shown) 9 00 Terminal, Block 0 0 Terminal, Jumper (not shown) 8 0 Pin, Contact 8 Grommet 05 0 Plug, Grommet Splice, Parallel (not shown) A/R Tube (not shown) Label 5 Pin, Contact (not shown) 8 9 Connector, Receptacle 9 0 A/R Wire (not shown) Switch, Pushbutton (not shown) Socket, Receptacle 58 Wedge, Receptacle 0 0 Fuse 05 Fuse, Holder Pin, Terminal (not shown) 8 Socket, Contact (not shown) 9 5 Spade, Terminal A/R Sleeve 9 50 Plug, Wedge 0 9 Plug, Connector 888 Connector, Boot A/R Sleeve, Insulated 80 Socket, Contact (not shown) A/R Sleeve, Convoluted 5 50 Splice, Window (not shown) 8

85 Key Operator Switch Switch, Key Operator 08 0 Key 8

86 Labels Miscellaneous A/R Label, Warning Label, Water Drain and Oil Drain Label, Prototype Tested Label, Warning Label, Caution A/R Label, Danger A/R Label, Warning A/R Label, Warning 9 Label, Logo A/R 00mm x 0mm A/R 5mm x mm Label, Warning A/R Label, Danger Label, Insert Portuguese French Dutch German Swedish Italian Czech Finnish Label, Information Label, Information 8

87 Kits Kit, Control Kit, Control 09 PCB Assy (Annunciator) Kit, Filter Kit, Control 85

88 This Page Intentionally Left Blank. 8

89 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 050, , , 0 0, 8, 050, , , 8 0, 050 9, , , 0 0,, , , , 8 0 8, 05 0, , , 0 9, , , , 0 5, , , , 0 58, , , 8 0 8, 0, 098 0, , 8 0 5, 0, , , 8 0 5, , , ,, 8 098,, , ,,,, 5,,, ,,,, 5,, ,,, , , 5, ,,,, 5,, , ,,, 5,,, ,,, 5,,, ,,, 5,,, ,,, 5,,, ,,, 5,,, , 5, , , 098 5,,,, 5,,, 5, , ,, , 098, , 8, , 098 0, ,,, 5,, 5, ,,, , , , , , , , , , , , , , , , , , , , , , , , , , , , , , 0 55, , , , 0 55, 0 55, 0 55, 0 55, 8, 0 58, 0 59,,, 0 50, 8,, , 0 555, 8, 0 509, 0 50, 0 5, 0 5, 8, 0 58, 9, 0 58, 9, 0 588, 9, , , 0 90, 0 9, 0 9, 0 9, , , , 0 0, 0, 8, 0 0, , 0 8, 0 850, 0 88, 8, 0 0, 8, , , , 9 0 0, , , , , , 8, , , , , , , , , , 9 0 0, 9 0 0, 9 0 0, 9 0 9, 9 0 9, 9 0 9, , 9 8

90 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page , , 0 058, 5 0 0, 5 9 9, 00 8, 0 058, 5 0 0, , 00 8, 0 05, , 5, 00 8, , , 55 0, , ,, 8, , 55 0, , , , 55 0, 00 8, 0 089, 5 0 0, 55 89, , 08 05, 8 9 5, , , 08 0, 8 9 9, , 8, , 08 05, ,, 55 59, , 08 80, 8, , 9 9 0, , 08 8, , , , , , , 00 80, , , , , , 9 500, , , , , 9 00, 00 80, , 9 509, , , , , , , , , , 5 9, 5, , , , , 5 0 0, , 8, , , 5 0 0, ,, , 5 0 0,, , , , 5 0 0,, 5 5 0, ,, , 5 0 0,, 5 5 0, , , 5 0 0,, 5 5 0, , 8, , 5 89, 5 0, , , 5 0,, 5 5 0, , , 5, 5 05, , , , 5 5 0, ,, 00, , , , 00 5, , 5 5 0, , 00, , , ,, 00 8, , , , 00 9, , , , 00, , , , 00, 00 59, 5 5, , , , 5 5, , , 00 58, , , , , , , , 0 98, , , , , , , , , , , 9 88

91 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page , 8 50, 8, , 99, , 50, 0 0, 9 0,, 9 58, 8 5,, , ,, ,,, 5, ,,, 5, 9 589,,, 5, , ,,, 5, , , , , ,,, 5, 9 0, 8 9 0, ,, 9 58,, 9 88, 9 5, 0 0, 0 0, 0 0, 0 9 0, 0 9 0, 05, 8, 8 0 0, 8, 8 00, 5 088, 5 09, , , , , 55 5, 9, 9,, 8, 8 9, 8, 8 9,, 8, 8 500, 50, 59,, 580 0, 8, 8 58, 8, 8 58, 8, , 80 58, 80, 8, 8 59,, 05 0, 8, 8 0, 8, 8, 8, 8, 8, 8 0, 9 0, 9 8, 9 5, 8, 85 0, 8, 8 8, 8, 8 8, 8, 8 8, 8, 8 8, 8, 8 8 0, 8, 8 88, 5 888, 8, , 59 5,, 8, 8, 8, 8 80, 80, 8, 8 99, 80 0,,,,,,, 00, 5 09, 85 0, 5 0, 5 90, 5 9, , , , , ,,, 5, 00, 0555, 005, 5, , 8, 8 00, 8, 8 0, 8, 8 8, 9, 50, 8, 8 9, 5 99, 8, 8 99, 8, 8 00, 0, 58 5,, 0, 0, 0 0, 88, 5, 5, , 5, 5 898, 9,,, 5, 9, 8, 8 0, 0, 09, 058, 8, 8 5 0,, 5, 5 0,, 5, 5 9, 0, 9 0, 8, 8 5, 90 0,, 9 0, 98 0,, 990 0, 00, 0, 0,, 9 05, 05 0, 055 0, 058 0, 059 0, 00, 0 0,, 0 0,,,,, 5, 0 0, 5, 0, 5, 0, 5, 0,, 0, 5, 0, 5, 08 05, 08 0, 05 0, 05 0, 05, , 0 0, 0, 8, , 5, ,, ,, ,, ,, ,, , 5, , 5, , 5, 89