Parts Catalog MDDCA, MDDCB, MDDCC, MDDCD, MDDCE, MDDCF, MDDCG, MDDCH, MDDCJ. Printed U.S.A

Transcription

1 Parts Catalog MDDCA, MDDCB, MDDCC, MDDCD, MDDCE, MDDCF, MDDCG, MDDCH, MDDCJ Printed U.S.A

2 To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Onan manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUC- TIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUC- TIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-

3 Introduction This catalog applies to Onan Generator Models MDDC, as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned in the description or page heading, parts are interchangeable between models. Throughout this catalog left and right sides are determined by facing the engine end (front) of the set. Engine parts that have been modified or added by Onan are identified in this catalog. All other engine replacement parts must be ordered from the engine manufacturer by referring to the engine manufacturer s nameplate and supplying all available information. Contact your nearest engine parts dealer for assistance in ordering replacement parts. Replacement Engine Onan/John Deere Generator Model 0MDDCA MDDCB MDDCC 80MDDCD 99MDDCE 0MDDCF 0MDDCG MDDCH 80MDDCJ John Deere Engine Model CD0TFM Cylinder CD0TFM Cylinder CD0TFM Cylinder CD08TFM Cylinder CD08TFM Cylinder CD0TFM Cylinder CD0TFM Cylinder CD08TFM Cylinder CD08TFM Cylinder Replacement engines cannot be ordered from Onan. Order from your nearest John Deere distributor. Generator Set Data Table Model and Electrical Data Battery Specification Watts Volts Hertz Wire Phase Voltage 0MDDCA* MDDCB* MDDCC* 80MDDCD* 99MDDCE* 0MDDCF* 0MDDCG* MDDCH* 80MDDCJ* 0,000,000,000 80,000 99,000 0,000 0,000,000 80,000 # Board range reconnecitable. # # # # # # # # # or or or or or or or or or or or or or or or or or or * The specification numbersdenotes customer requested options or deviations from a standard model. The specification letter advances (D to E, E to F, etc.) with major manufacturing changes. or VDC or VDC or VDC or VDC or VDC or VDC or VDC or VDC or VDC

4 Index Adapter, Generator, Adapter, Generator Stator, Adapter, Pipe ( Cylinder), Adapter, Pipe ( Cylinder), 8 Adapter, Pipe (Expansion Tank), Adapter, Water Pump (Aux Drive), Adapter, Water Pump (Wet Exhaust), Alternator, Alternator (Negative Ground Electrical System), Assy Vent, Crankcase ( Cylinder), Assy Vent, Crankcase ( Cylinder), 8 Assy, Control (ESDD), 8 Assy, Fuel Filter ( Cylinder), Assy, Fuel Filter ( Cylinder), Assy, PCB, 8 Assy, PTO Adapter, 9 Assy, Skid, Assy, Water Pump, 8 Bell, End Generator, Belt, Poly Rib, Block, Terminal Generator Heater, Box, Control (DC), 8 Box, Output, Box, Output (Cover), Box, Terminal Generator Heater, Bracket, Circuit Breaker (NSF), Bracket, Crank Vent, 0 Bracket, Engine, 0 Bracket, Exhaust, 8, 9,, Bracket, Expansion Tank, Bracket, Fan ( Cylinder), Bracket, Fan ( Cylinder), Bracket, Fuel, Bracket, Gauge, Bracket, Generator Mounting,, Bracket, PCB, 9 Bushing, Bushing ( Cylinder), Bushing ( Cylinder), Bushing, Pipe,, Cap, Coolant Recovery Tank, Cap, Tube, Cartridge, Generator Heater, Catch, Door ( Cylinder), Catch, Door ( Cylinder), Circuit Breaker,, Circuit, Breaker, 8 Clamp, Exhaust, 8, 9, 0,, Clamp, Hose,,,, 8, 9,,,, Clamp, Hose ( Cylinder), 8 Clamp, Hose (Wet Exhaust), Clamp, Water Pump Hose,, Cleaner, Air, Clutch, 9 Cock, Drain,, Cock, Special Drain, Collier, Connector, Fem Bulkhead, 0 Connector, Hose ( Cylinder), 8 Connector, Hose ( Cylinder), 8 Connector, Hose (Siphon), Cooler, Oil, Cooler, Oil ( Plate Modine), Cooling Keel, Cover, Access ( Cylinder), Cover, Access ( Cylinder), Cover, Circuit Breaker, Cover, Control, 8 Cover, Enclosure ( Cylinder), Cover, Enclosure ( Cylinder), Cover, End Bell Permanent Magnet Exciter, Cover, Generator End Bell, Cover, Heat Exchanger, Cover, Oil Fill, Cover, Stator Bottom, Cover, Stator Top, Cover, Thermostat, Current, Transformer, 8 Dipstick, Oil, 8 Disc, Generator Drive, Door, Access ( Cylinder), Door, Access ( Cylinder), Drive, Aux, Dry Exhaust (With Sound Shield), Dry Exhaust (Without Sound Shield), 0, Elbow, 90 Deg, Elbow, Exhaust, 0 Elbow, Exhaust (Mixer), 8 Elbow, Male, Elbow, Pipe ( Cylinder), Elbow, Pipe (Adaptor), Elbow, Tube ( Cylinder), Elbow, Tube ( Cylinder), 8 Element, Filter,, Exchanger, Heat, Exchanger, Heat (Wet), Exciter, Permanent Magnet, Exhaust, Dry (With Sound Shield), 9 Exhaust, Wet (With Sound Shield), 8

5 Index Filter, Fuel (MDDCA, MDDCB, MDDCC, MDDCF and MDDCG), Filter, Fuel (MDDCD, MDDCE, MDDCH and MDDCJ), Filter, Oil,, Filter, Oil (MDDCA, MDDCB, MDDCC, MDDCF and MDDCG), Filter, Oil (MDDCD, MDDCE, MDDCH and MDDCJ), Flange, Manifold, Gasket, Air Inlet, Gasket, Manifold, Gasket, Oil Cooler Adapter, Gasket, Oil Cooler Housing, Gasket, Oil Fill, Gasket, Oil Fill Cover, Gasket, Oil Filter Adapter,, Gasket, Oil Pan, 9 Gasket, Rocker Arm Cover, Gasket, Thermostat Cover, Gasket, Timing Gear Cover, Gasket, Turbocharger, 0 Gasket, Water Pump, 8 Gauge, Oil, 8 Generator, 0 Grommet,, Grommet ( Cylinder), Grommet ( Cylinder), Grommet, Boot, Grommet, Remote,, 8 Grommet, Rubber, Guard Fan (UC), Guard Fan (UCD), Guard, Belt, Guard, Coupling, Guard, Electrical Switch, 8 Guard, Generator Fan, Guide, Oil Gauge, 8 Hanger, Coolant Recovery Tank, Harness, Engine, 8 Harness, Extension (Optional), Harness, Extension AC, Harness, Extension (Standard), Harness, Extension, Harness, Junction, Harness, Regulator, 8 Harness, Remote, 9 Harness, Remote Extension, Harness, Remote Panel (W/Switch), 9, 0, Harness, Switch, Harness, Wiring Permanent Magnet Exciter, Harnesses, Wiring, Header, Oil Filter,, Heat Exchanger (Wet), Heater, Engine Coolant, Heater, Generator, Hose Coolant (Wet Exhaust), Hose, Breather ( Cylinder), 8 Hose, Breather ( Cylinder), Hose, Coolant,,,, Hose, Coolant Recovery, Hose, Fuel, 0, Hose, Fuel ( Cylinder), Hose, Fuel ( Cylinder), 8 Hose, Intake, Hose, Lower Radiator, Hose, Oil, Hose, Oil Fill ( Cylinder), 8 Hose, Oil Filler ( Cylinder), Hose, Seawater, Hose, Upper Radiator, Hourmeter, 8 Housing (MDDCA, MDDCB, MDDCC, MDDCF and MDDCG), Housing (MDDCD, MDDCE, MDDCH and MDDCJ), Housing, Control, Housing, Control (DC), 8 Housing, Oil Cooler, Housing, Oil Cooler Adapter, Housing, PTO, Housing,Thermostat, Hub, Generator Drive, Injection, Line Fuel No., 9 Injection, Line Fuel No., 9 Injection, Line Fuel No., 9 Injection, Line Fuel No., 9 Injection, Line Fuel No., 9 Injection, Line Fuel No., 9 Injection, Line Fuel No., 8 Injection, Line Fuel No., 8 Injection, Line Fuel No., 8 Injection, Line Fuel No., 8 Inlet, Water Pump, Insulation, Baffle, Insulation, Baffle ( Cylinder), Insulation, Baffle ( Cylinder), Insulation, Cover ( Cylinder), Insulation, Cover ( Cylinder), Insulation, Door ( Cylinder), Insulation, Door ( Cylinder), Insulation, Enclosure ( Cylinder), Insulation, Enclosure ( Cylinder),

6 Index Insulation, Enclosure (Stiffener) ( Cylinder), Insulation, Enclosure (Stiffener) ( Cylinder), Insulation, Exhaust, 9 Insulation, Roof ( Cylinder), Insulation, Roof ( Cylinder), Insulation, Sound, Insulation, Sound (Front), Isolator, Vibration,,, 8 Isolator, Vibration, Kit, Control (Manual Voltage Regulator), 8 Kit, Control Display, 8 Kit, Coolant Recovery, Kit, Expansion Tank, Kit, Fuel (Transfer Pump), Kit, Header Final Filter, Kit, Heater (0 V), Kit, Heater (0 0V), Kit, Heater Engine Coolant, Kit, Hose (Wet Exhaust), 8 Kit, Indicator Oil Level, Kit, Muffler (Water Lift), 8 Kit, Muffler (Water Separator), 8 Kit, PTO MDDCA, MDDCB, MDDCC, MDDCF and MDDCG, 9 Kit, PTO MDDCD, MDDCE, MDDCH, and MDDCJ, 9 Kit, Regulator PMG, Kit, Remote Control Panel (W/Switch), 9, 0, Kit, Seawater Pump Impeller Repair,, Kit, Seawater Pump Major Repair,, Kit, Siphon Break, Kit, Sound Shield ( Cylinder), Kit, Sound Shield ( Cylinder), Kit, Sound Shield (PTO), Kit, Unitized Seal, Kit, Valve,, Kit, Water Pump Insert Service, 8 Kit, Water Pump, High Flow, 8 Label, Remote Panel (W/Switch) (Start/Preheat), 0, Labels and Tag, 8 Latch, Door ( Cylinder), Latch, Door (Flush Pull) ( Cylinder), Level, Oil, Line, Flexible Oil, 0 Line, Fuel, Line, Oil, Line, Turbo Drain, 0 Lines, Fuel,, 0 Lines, Fuel Injection (MDDCA, MDDCB, MDDCC, MDDCF and MDDCG), 8 Lines, Fuel Injection (MDDCD, MDDCE, MDDCH and MDDCJ), 9 Lines, Turbocharger, 0 Louver Generator, Manifold, Intake, Motor, Starter, 9 Mount, Engine, Mounting, Printed Circuit Board, 9 Nozzle, Fuel Injection, O Ring, O Ring, Packing, O Ring, Packing, O Ring,,, 8 Pan, Drip, Pan, Skid ( Cylinder), Pan, Skid ( Cylinder), Panel,Roof (End) ( Cylinder), Panel,Roof (End) ( Cylinder), Panel Saddle (Cover), Panel, Access ( Cylinder), Panel, Access ( Cylinder), Panel, Air Baffle ( Cylinder), Panel, Air Baffle ( Cylinder), Panel, Control (Non ESDD), 8 Panel, Control Box, 8 Panel, Enclosure, Panel, Enclosure ( Cylinder), Panel, Enclosure ( Cylinder), Panel, Remote (W/Switch), 0, Panel, Roof ( Cylinder), Panel, Roof ( Cylinder), Parts, External Engine, PCB Assy, Control, 9 Pipe, Exhaust, 9 Pipe, Exhaust (Mixer), Plate, Engine, Plug, Anode, Plug, Drain, Plug, Exhaust Manifold, Plug, Hole,, 8 Plug, Hole ( Cylinder), Plug, Hole ( Cylinder), Plug, Oil Gauge, 8 Plug, Pipe Hex Head ( Cylinder), Plug, Special (With O Ring), Plug, with O Ring,, Pulley, Constant Tension Idler, Pulley, Crankshaft, Pulley, Idler,

7 Index Pulley, with Bearing, Pump, Coolant, 8 Pump, Fuel, Pump, Fuel (Mechanical), Pump, Fuel Transfer (Electric), Pump, Fuel Transfer (Mechanical), Pump, Water, Rectifier Assembly, Regulator, Automatic Voltage, 8 Regulator, Voltage Manual, 8 Regulator, Voltage Auto, 8 Relay, SPDT, 8 Relay, Starter Solenoid (V), 0 Relay, Starter Solenoid (V), 0 Rotor Permanent Magnet Exciter, Rotor Assembly, Exciter, Rotor Assembly, Generator, Saddle, Control Box, Screen, Air Inlet, Seal, Brush ( Cylinder), Seal, Brush ( Cylinder), Seal, Edge, Seal, Enclosure ( Cylinder), Seal, Enclosure ( Cylinder), Seal, Fuel Pump O Ring, Seal, Rear Oil, Seal, Weather ( Cylinder), Seal, Weather ( Cylinder), Sender, Low Coolant, Sensor, Magnetic Pick Up, Sensor, Oil Pressure, Siphon, Skid, 0 Snubber, Ring, 8 Solenoid, Starter, 0 Spacer, Idler Pulley, Spacer, Mounting End Bell Permanent Magnet Exciter, Spacer, Panel ( Cylinder), Standoff, Insulator, 8 Starter, 9 Stator, Exciter, Stator, Generator, Stator, Permanent Magnet Exciter, Stiffener, Enclosure ( Cylinder), Stiffener, Enclosure ( Cylinder), Strap, Bond, Strap, Electrical, Switch, Hi Exhaust Temperature, 8 Switch, Oil Level, Switch, Pressure, Switch, Remote Control Panel Rocker, 9, 0, Switch, Rocker SPDT, 8 Switch, Toggle, 8 System, Coolant, System, Fuel Injection, Takeoff, Power, 9 Tank, Coolant Recovery, Tank, Expansion, Tee, Street, Tee, Street ( Cylinder), Thermostat, Transformer, PCB ISLN, 8 Trim, Edge,, 8 Trim, Edge ( Cylinder), Trim, Edge ( Cylinder), Tube, Air Inlet, Tube, Seawater, Tube, Vent, Tube, Water,,, UC Generator, UC Generator, Valve, Ball ( Cylinder), Valve, Ball ( Cylinder), 8 Valve, Check, Vent, Crankcase (MDDCA, MDDCB, MDDCC, MDDCF and MDDCG), Vent, Crankcase (MDDCD, MDDCE, MDDCH and MDDCJ), 8

8 Abbreviations Some of the following abbreviations may be used throughout this Parts Catalog; Alternating Current Ampere As Required Automatic Voltage Regulator American Wire Gauge Degree Direct Current External Tooth External/Internal Tooth Ground Fault Interrupter Inside Diameter Internal Tooth Kilowatt Liquid Petroleum Gas Left Meter AC Amp A/R AVR AWG Deg DC ET EIT GFI ID IT kw LPG LT M(Meter Number) Millimeter Not For Sale Nominal Pipe Thread Outside Diameter Ounce Phase Printed Circuit Right Specification Thick Union National Coarse Union National Fine Volts Alternating Current Volts Direct Current With mm NFS NPT OD oz. Ph PC RT Spec Thk UNC UNF VAC VDC W/(ET, IT, EIT) Paint and Thread Sealant Paint, Marine Brite-White ( oz. Pressurized Spray Can) 8 00 Sealant, Thread ( ml Tube)

9 External Engine Parts Gasket, Timing Gear Cover 8 Kit, Unitized Seal Cover, Oil Fill 9 Gasket, Oil Fill Cover Screw, Cap w/ Preapplied (M8 x 0mm) Seal, Rear Oil MDDCA, MDDCB, MDDCC, MDDCF and MDCG MDDCD, MDDCE, MDDCH and MDCJ 0 89 Sensor, Magnetic Pick Up Sensor, Oil Pressure 9 Gasket, Rocker Arm Cover 00 MDDCA, MDDCB, MDDCC, MDDCF and MDCG 008 MDDCD, MDDCE, MDDCH and MDCJ Housing, Oil Cooler 00 Gasket, Oil Cooler Adapter MDDC

10 Oil Dipstick REF PART QTY PART NO. NO. USED DESCRIPTION Gauge, Oil Guide, Oil Gauge MDDCA, MDDCB, MDDCC, MDDCF and MDCG 8 MDDCD, MDDCE, MDDCH and MDCJ 80 Plug, Oil Gauge 8 MDDC

11 Oil Pan Gasket REF PART QTY PART NO. NO. USED DESCRIPTION 0 Gasket, Oil Pan (MDDCA, MDDCB, MDDCC, MDDCF and MDCG) 0 Gasket, Oil Pan (MDDCD, MDDCE, MDDCH and MDCJ) 9 MDDC

12 Turbocharger Lines REF PART QTY PART NO. NO. USED DESCRIPTION 0 08 Line, Flexible Oil 0 08 Line, Turbo Drain 0 Gasket, Turbocharger 0 Gasket, Turbocharger 0 MDDC

13 Air Cleaner Cleaner, Air 8 00 Nut, Hex (M x ) Clamp MDDCA, MDDCB, MDDCC MDDCF, MDDCG, MDDCH and MDDCJ MDDCD and MDDCE Hose, Intake 0 MDDCA, MDDCB, MDDCC MDDCF, MDDCG, MDDCH and MDDCJ 0 MDDCD and MDDCE Screw, Hex Head (M x x mm) Bracket, Air Cleaner 0 Screw, Socket Head (M x. x 0mm) Washer, Flat (M) Bracket, Engine 0 0 Screw, Socket Head (M0 x.0 x mm) 099 Washer, Flat (.8 ) Washer, Flat (M) MDDC

14 Intake Manifold Tube, Air Inlet 0 MDDCA, MDDCB, MDDCC MDDCF and MDDCG 0 MDDCD, MDDCE, MDDCH and MDDCJ 0 0 Collier Hose 0 MDDCA, MDDCB, MDDCC MDDCF and MDDCG 0 0 MDDCD, MDDCE, MDDCH and MDDCJ 8 Gasket, Air Inlet MDDC

15 Alternator Alternator 9 Volt Iso Gnd 9 Volt Iso Gnd 9 Volt Neg Gnd 9 8 Volt Neg Gnd 09 Pulley, Constant Tension Idler 09 Pulley, with Bearing 090 Pulley, Idler 0 Spacer, Idler Pulley 0 Belt, Poly Rib 089 Pulley, Crankshaft ( Cylinder) MDDC

16 Fuel Filter (MDDCA, MDDCB, MDDCC, MDDCF and MDDCG) Assy, Fuel Primary Filter 9 8 Water Separator 9 9 Water Separator 9 0 Water Separator Element, Filter 9 9. Kit, Valve Kit, Header Final Filter MDDC

17 Fuel Filter (MDDCD, MDDCE, MDDCH and MDDCJ) Assy, Fuel Filter 9 0 Mic 9 0 Mic 9 0 Mic 9 Element, Filter 9 Element, Filter Kit, Valve MDDC

18 Fuel Lines Line, Fuel MDDCA, MDDCB, MDDCC MDDCF and MDCG MDDCD, MDDCE, MDDCH and MDCJ 0 08 Line, Fuel 0 08 Line, Fuel Line, Fuel Line, Fuel MDDCA, MDDCB, MDDCC MDDCF and MDCG MDDCD, MDDCE, MDDCH and MDCJ MDDC

19 Fuel Injection System REF PART QTY PART NO. NO. USED DESCRIPTION Nozzle, Fuel Injection 088 Cylinder (00RPM) 0888 Cylinder (800RPM) 0889 Cylinder MDDC

20 Fuel Injection Lines (MDDCA, MDDCB, MDDCC, MDDCF and MDDCG) REF PART QTY PART NO. NO. USED DESCRIPTION 0 08 Injection, Line Fuel No Injection, Line Fuel No Injection, Line Fuel No Injection, Line Fuel No. 8 MDDC

21 Fuel Injection Lines (MDDCD, MDDCE, MDDCH and MDDCJ) REF PART QTY PART NO. NO. USED DESCRIPTION 0 08 Injection, Line Fuel No Injection, Line Fuel No Injection, Line Fuel No Injection, Line Fuel No Injection, Line Fuel No Injection, Line Fuel No. 9 MDDC

22 Fuel Lines 09 Clamp, Tie 0 9 Hose, Fuel 0 9 Hose, Fuel 0 89 Connector, Fem Bulkhead 0 Bracket, Crank Vent 099 Washer, Flat (M) Screw, Hex Head (M x. x 0mm) 0 MDDC

23 Fuel Transfer Pump (Mechanical) REF PART QTY PART NO. NO. USED DESCRIPTION 9 Pump, Fuel (Mechanical) Seal, Fuel Pump O Ring MDDC

24 Fuel Transfer Pump (Electric) Kit, Fuel (Transfer Pump) 8 0 V 8 0 V 9 0 *Bracket, Fuel *Pump, Fuel 9 0 V 9 0 V *Screw, Hex Head Sems (M x.8 x 0mm) 0 *Hose, Fuel 099 *Washer, Flat (M) *Screw, Hex Head Cap (M x. x 0mm) * Parts included in Fuel Kit. MDDC

25 Oil Filter (MDDCA, MDDCB, MDDCC, MDDCF and MDDCG) 8 Plug, with O Ring O Ring 088 Filter, Oil 0888 Header, Oil Filter 0889 Gasket, Oil Filter Adapter 8 Plug,Drain MDDC

26 Oil Filter (MDDCD, MDDCE, MDDCH and MDDCJ) 8 Plug, with O Ring 088 Filter, Oil 0890 Header, Oil Filter 8 Plug, Special (With O Ring) 089 Gasket, Oil Filter Adapter MDDC

27 Oil Cooler REF PART QTY PART NO. NO. USED DESCRIPTION 0 9 Housing, Oil Cooler 0 Gasket, Oil Cooler Housing Cooler, Oil 0 8 MDDCA, MDDCB, MDDCC MDDCF and MDCG 0 MDDCD, MDDCE, MDDCH and MDCJ O Ring, Packing 8 Plug O Ring MDDC

28 Oil Level Kit, Indicator Oil Level Switch, Oil Level Bushing Elbow, Male (Adaptor) 0 9 Hose, Oil 0 9 Elbow, Pipe (Adaptor) Washer, Flat (/ ) 0 00 Isolator, Vibration Nut, locking Flanged (M) Nut, Hex Head Whiz Lock (/ 0) Bracket, Gauge 0 Tube, Vent 0 0 Clamp, Hose Hose, Oil (Bulk) 0 8. (MDDCA, MDDCB, MDDCC, MDDCF and MDCG) (MDDCD, MDDCE, MDDCH and MDCJ) 0 0 Elbow, Plate, Engine 9 Gasket, Oil Fill Label, Caution 8 8 Harness, Switch * All parts included in kit. MDDC

29 Crankcase Vent (MDDCA, MDDCB, MDDCC, MDDCF and MDDCG) Assy Vent, Crankcase 0 0 Adapter, Pipe 0 98 Elbow, Tube (/ NPT x Hose) 0 99 Elbow, Tube (/ NPT x / Hose) 0 Screw, Hose Clap 0 0 Hose, Breather (/ ID) 0 Screw, Hose Clap 8 0 Hose, Oil Filler ( ID) Clamp, Hose Hose, Fuel 0 8 Elbow, Pipe 0 Adapter, Pipe 0 0 Plug, Pipe Hex Head (/8NPT) Valve, Ball 0 00 Tee, Street 0 Adapter, Pipe 0 Plug, Pipe Screw, Hex Head Cap (M0 x.0 x 0mm) MDDC

30 Crankcase Vent (MDDCD, MDDCE, MDDCH and MDDCJ) Assy Vent, Crankcase Screw, Hex Head Cap (M0 x. x 0mm) 0 0 Adapter, Pipe 0 99 Elbow, Tube (/NPT x / Hose) 0 98 Elbow, Tube (/NPT x Hose) 0 Screw, Hose Clamp 0 Hose, Oil Fill ( OD) 8 0 Screw, Hose Clamp Hose, Breather (/ ID) Clamp, Hose Hose, Fuel 0 0 Connector, Hose 0 Adapter, Pipe 0 0 Connector, Hose (/NPT x /8Hose) 0 0 Plug, Pipe Hex Head (/8 NPT) Valve, Ball 0 00 Tee, Street 8 MDDC

31 Starter REF PART QTY PART NO. NO. USED DESCRIPTION Motor, Starter 9 V Iso Gnd 9 V Iso Gnd 9 0 V Neg Gnd 9 9 V Neg Gnd 9 MDDC

32 Starter Solenoid 0 Relay, Starter Solenoid (V) 0 Relay, Starter Solenoid (V) Screw, Hex Head Sems Stainless (M x x mm) 0 MDDC

33 Belt Guard 8 0 Kit, Belt Guard Without PTO (Parts Included Marked*) 8 0 Kit, Belt Guard With PTO (Parts Included Marked+) Guard, Belt * Without PTO With PTO *+Nut, Hex Flange (M8 x.mm) *+Screw, Hex Head Sems (M x x 0mm) *+Screw, Hex Head Sems (M0 x. x 0mm) Screw, Hex Head Sems (M0 x. x 0mm) 8 00 *+Nut, Hex (M0 x.mm) *+Washer, Flat (M0) MDDC

34 Expansion Tank Kit, Expansion Tank Tank, Expansion 0 0 Hose, Coolant 0 8 Clamp, Hose 0 Adapter, Pipe 8 Flange, Manifold 8 Gasket, Manifold Bracket, Expansion Tank Bracket, Expansion Tank Screw, Hex Head Sems (M8 x. x mm) Screw, Hex Head Sems (M0 x. x 0mm) 099 Washer, Flat (M) Screw, Hex Head Cap (M x. x mm) * All parts included in kit. MDDC

35 Siphon Kit, Siphon Break 0 Hose, Coolant 0 0 Valve, Check 0 0 Cap, Tube 0 09 Clamp, Hose 0 0 Connector, Hose 0 0 Clamp, Hose 08 0 Grommet, Boot * All parts included in kit. Items and not shown shipped separately. MDDC

36 Coolant Recovery 0 Kit, Coolant Recovery 0 0 Tank, Coolant Recovery 0 Hanger, Tank 0 9 Hose (/ I.D. x 0 Lg.) 0 Cap, Tank 0 Hardware Package (Includes Mounting Hardware) MDDC

37 Engine Coolant Heater Kit, Heater Engine Coolant Volt Volt Heater, Engine Coolant (000W) 00 0 * 0 Volt (Includes Parts Marked *) 00 0 # 0 Volt (Includes Parts Marked #) Harness, Power 00 * 0 Volt 0 # 0 Volt * Parts Included in 00 0 Engine Coolant Heater Kit? # Parts Included in 00 0 Engine Coolant Heater Kit? MDDC

38 Keel Cooling (Wet Exhaust) Kit, Seawater Pump Impeller Repair 0 Kit, Seawater Pump Major Repair Adapter, Water Pump (See Aux Drive) 0 Pump, Water Clamp, Hose 0 00 Cock, Drain (Wet and Dry) (/NPT x /8 NPT) Bushing, Pipe (Wet and Dry) (/ NPT x x / NPT) 0 0 Tube, Water 0 98 Hose, Coolant 8 Hose, Coolant 0 0 MDDCA, MDDCB, MDDCC MDDCF and MDCG 0 0 MDDCD, MDDCE, MDDCH and MDCJ Screw, Hex Head Cap (M x. x 0mm) Washer, Flat (M) 8 08 Clamp, Hose 0 00 Cock, Drain (/ NPT x /8 Hose) 0 Gasket 800 Screw, Flanged Metric (M0 x mm) 09 Plug, Cap MDDC

39 Aux Drive REF PART QTY PART NO. NO. USED DESCRIPTION 0 Adapter, Water Pump 00 Gasket 0 08 Line, Oil Packing, O Ring MDDC

40 Wet Exhaust Kit, Muffler (Water Lift) Kit, Muffler (Water Separator) Kit, Hose (Wet Exhaust) Screw, Hex Head Cap (M x. x 0mm) 099 Washer, Flat (M) Elbow, Exhaust (Mixer) 8 0 with Sound Shield 8 0 without Sound Shield Clamp, Exhaust Switch, Hi Exhaust Temperature MDDCA, MDDCB, MDDCC MDDCF and MDCG (Green) MDDCD, MDDCE, MDDCH and MDDCJ (Blue) 80 0 Nut, Hex (8 ) 0 Bracket, Exhaust Washer, Flat (M8) Screw, Hex Head Cap (M8 x. x mm) Screw, Hex Head Sems Stainless (M x x mm) Clamp, Hose 8 MDDC

41 Dry Exhaust (With Sound Shield) Screw, Hex Head Cap (M x. x 0mm) Clamp, Exhaust 099 Washer, Flat (M) 0 00 Plug, Square Head 0 Bracket, Exhaust Washer, Flat Screw, Hex Head Cap (M8 x. x mm) 8 Pipe, Exhaust 9 Elbow, Exhaust 0 8 Insulation, Exhaust Clamp, Hose Screw, Hex Head Stainless (M x x mm) 9 MDDC

42 Dry Exhaust (Without Sound Shield) Screw, Hex Head Cap (M x. x 0mm) Clamp, Exhaust 099 Washer, Flat (M) Elbow, Exhaust 0 00 Plug, Square (/8 ) Bracket, Engine 0 MDDC

43 Dry Exhaust (With Sound Shield) Screw, Hex Head Cap (M x. x 0mm) Clamp, Exhaust 099 Washer, Flat (M) 0 Bracket, Exhaust 99 Elbow, Exhaust Clamp, Hose Screw, Hex Head Stainless (M x.0 x mm) Washer, Flat (M8) Screw, Hex Head (M8 x. x mm) 0 8 Insulation, Exhaust Pipe, Exhaust (Mixer) MDDC

44 Dry Exhaust (Without Sound Shield) Screw, Hex Head Cap (M x. x 0mm) Clamp, Exhaust 099 Washer, Flat (M) Clamp, Hose Screw, (M x x mm) Screw, Hex Head (M8 x. x mm) 99 Elbow, Exhaust 8 0 Bracket, Exhaust Washer, Flat (M8) MDDC

45 Heat Exchanger (Wet) Kit, Seawater Pump Impeller Repair 0 Kit, Seawater Pump Major Repair Bushing, Pipe (Wet and Dry) (/ NPT x x / NPT) 0 0 Tee, Street (/ NPT) Bushing, Pipe (/ NPT x x /8 NPT) 0 00 Cock, Drain (Wet and Dry) (/ NPT x /8 Hose) 09 0 Switch, Pressure 0 98 Hose, Coolant (Wet and Dry) 0 0 Tube, Water (Wet and Dry) Clamp, Hose (Wet and Dry) Hose, Coolant Clamp, Hose 0 Hose, Bulk 0 09 *Hose, Front Coolant 0 0 *Hose, Rear Coolant 9 08 Sender, Low Coolant (Optional) * Front and Rear Coolant Hoses shipped loose. MDDC

46 Heat Exchanger (Wet) MDDC

47 Heat Exchanger (Wet) 0 8 Plug, Anode Exchanger, Heat 0 MDDCA, MDDCB, MDDCC, MDDCF and MDDCG 0 MDDCD, MDDCE, MDDCH and MDDCJ Package, Heat Exchanger O Ring Package, Heat Exchanger 0 Cap, Radiator Clamp, Hose 0 MDDCA, MDDCB, MDDCC, MDDCF and MDDCG 0 MDDCD, MDDCE, MDDCH and MDDCJ 0 8 Cover, Heat Exchanger O Ring 8 Clamp, Hose 0 MDDCA, MDDCB, MDDCC, MDDCF and MDDCG 0 MDDCD, MDDCE, MDDCH and MDDCJ Tube, Seawater (Pump to Exchanger) 0 0 Hose, Seawater Hose, Seawater 0 MDDCA, MDDCB, MDDCC, MDDCF and MDDCG 0 MDDCD, MDDCE, MDDCH and MDDCJ Screw, Flanged (M x mm) 800 Screw, Flanged (M0 x mm) 8 Plug, Exhaust Manifold Cock, Special Drain 0 09 MDDCA, MDDCB, MDDCC, MDDCF and MDDCG 0 00 MDDCD, MDDCE, MDDCH and MDDCJ 9 Plug, Exhaust Manifold MDDC

48 Coolant System 0 0 Tube, Water 0 Clamp, Water Pump Hose 0 8 Clamp, Water Pump Hose 0 Inlet, Water Pump 0 9 Hose, Upper Radiator 0 Hose, Lower Radiator Packing, O Ring MDDC

49 Thermostat Housing Screw, Flange Metric (M0 x 80mm) 0 Cover, Thermostat 0 Gasket, Thermostat Cover 0 Thermostat 0 Thermostat ( Cylinder) 0 Thermostat 8 ( Cylinder) 9 0 Senor, Temperature MDDC

50 Coolant Pump Kit, Water Pump, High Flow Kit, Water Pump Insert Service 08 Assy, Water Pump 09 Gasket, Water Pump 800 Screw, Flanged (M x mm) Packing, O Ring 800 Screw, Flanged (M x 0mm) 8 MDDC

51 Power Takeoff 9 0 Kit, PTO MDDCA, MDDCB, MDDCC, MDDCF and MDDCG 9 0 Kit, PTO MDDCD, MDDCE, MDDCH, and MDDCJ Assy, PTO Adapter MDDCA, MDDCB, MDDCC, MDDCF and MDDCG MDDCD, MDDCE, MDDCH, and MDDCJ Clutch V, 0Horsepower V, 0Horsepower V, 00Horsepower V, 00Horsepower *Screw, Hex Head Flange (M x x 0mm) *Screw, Hex Head Flange (M x x 0mm) *Screw, Hex Head Flange (M x x 0mm) * All parts included in kit unless noted. 9 MDDC

52 Skid MDDC

53 Skid Assy, Skid PTO and Non PTO (MDDCA, MDDCF) PTO and Non PTO (MDDCB, MDDCC, MDDCG) PTO and Non PTO (MDDCD, MDDCE, MDDCH, MDDCJ) Isolator, Vibration Non PTO (MDDCA, MDDCF, MDDCB, MDDCC,MDDCG) PTO (MDDCD, MDDCE, MDDCH, MDDCJ) Non PTO(MDDCD, MDDCE MDDCH, MDDCJ) and PTO (MDDCA, MDDCF, MDDCB,MDDCC and MDDCG) Mount, Engine Screw, Hex Head Sems (M0 x. x x0mm) Isolator, Vibration PTO and Non PTO (MDDCA, MDDCF, MDDCB MDDCC, MDDCG) PTO and Non PTO (MDDCD, MDDCE, MDDCH, MDDCJ) Washer,Flat (M) Screw, Hex Head Cap (M x. x 0mm) Washer, Flat (M) Screw, Hex Head Cap (M x x 90mm) Nut, Hex (M x ) Washer, Snubbing Pan, Drip 0 0 PTO and Non PTO (MDDCD, MDDCE, MDDCH, MDDCJ) 0 0 PTO and Non PTO (MDDCB, MDDCC, MDDCG) 0 0 PTO and Non PTO (MDDCA, MDDCF) Screw, Hex Head Sems Stainless (M x mm) Plug, Hole 08 0 Plug, Hole 08 0 Grommet 8 00 Washer, ETIT Locking (/ ) Nut, Hex (M x.) Strap, Bond MDDC

54 MDDC Housing (MDDCA, MDDCB, MDDCC, MDDCF and MDDCG)

55 Housing (MDDCA, MDDCB, MDDCC, MDDCF and MDDCG) 0 Kit, Sound Shield (0,, kw) Panel, Enclosure (Front Non PTO) Panel, Roof Stiffener, Enclosure Panel, Enclosure Panel, Enclosure Panel, Enclosure Screw, Hex Head Sems Stainless (M x.0 x mm) Cover, Enclosure Panel, Air Baffle Panel, Air Baffle Seal, Brush Seal, Brush 99 0 Bracket, Fan Rivet, Pop PTO and Non PTO (MDDCA and MDDCF) PTO and Non PTO (MDDCB,MDDCC, MDDCG and MDDCH) Door, Access Door, Access 0 8 Door, Access Latch, Door (Flush Pull) Catch, Door Screw, Hex Head Sems (M x.8 x 0mm) 0 Cover, Access Panel,Roof (End) Spacer, Panel (MDDCB, MDDCC, MDDCG and MDDCH PTO and Non PTO) Panel, Access 0 8 Insulation, Door 0 8 Insulation, Enclosure (Front Non PTO only) 0 8 Insulation, Roof Insulation, Enclosure (Stiffener) Insulation, Enclosure Insulation, Baffle 0 80 Insulation, Baffle 0 88 Insulation, Enclosure 0 88 Insulation, Enclosure 0 8 Insulation, Enclosure 0 8 Insulation, Cover 0 8 Insulation, Baffle 0 89 Insulation, Enclosure Insulation, Roof Panel, Enclosure Insulation, Enclosure Panel, Access 0 80 Insulation, Enclosure Pan, Skid 0 0 MDDCA and MDDCF MDDCB, MDDCC, MDDCG and MDDCG Rivet, Pop Panel, Access Insulation, Enclosure 0 80 Insulation, Enclosure Bushing Seal, Weather (99mm) Seal, Enclosure (80mm) 08 0 Trim, Edge (88mm) 0 8 Insulation, Cover 0 8 Insulation, Baffle 08 0 Grommet Grommet 0 8 Insulation, Enclosure 0 0 Plug, Hole * All parts included with PTO and Non PTO Housing unless noted. + All parts included with Sound Shield Kit unless noted. MDDC

56 MDDC Housing (MDDCD, MDDCE, MDDCH and MDDCJ)

57 Housing (MDDCD, MDDCE, MDDCH and MDDCJ) 0 Kit, Sound Shield (80, 99kW) Panel, Enclosure (Front Non PTO) Panel, Roof Stiffener, Enclosure Screw, Hex Head Sems Stainless (M x.0 x mm) Panel,Roof (End) Panel, Enclosure Panel, Enclosure Panel, Enclosure Cover, Enclosure Panel, Air Baffle Panel, Air Baffle Seal, Brush Seal, Brush 99 0 Bracket, Fan Rivet, Pop Door, Access Door, Access Door, Access Latch, Door (Flush Pull) Catch, Door Screw, Hex Head Sems (M x.8 x 0mm) 0 Cover, Access Panel, Access Panel, Access Panel, Access 0 8 Insulation, Door 0 8 Insulation, Enclosure (Front Non PTO) Insulation, Enclosure (Stiffener) Insulation, Enclosure Insulation, Baffle 0 80 Insulation, Baffle 0 88 Insulation, Enclosure 0 88 Insulation, Enclosure 0 8 Insulation, Enclosure 0 8 Insulation, Cover 0 8 Insulation, Baffle 0 89 Insulation, Enclosure Insulation, Roof Pan, Skid Insulation, Enclosure 0 80 Insulation, Roof Rivet, Pop Panel, Enclosure 0 80 Panel, Enclosure 0 80 Insulation, Enclosure Panel, Access Insulation, Enclosure Insulation, Enclosure Bushing Seal, Weather (99mm) 89 0 Seal, Enclosure (80mm) 08 0 Trim, Edge (88mm) 0 8 Insulation, Cover 0 8 Insulation, Baffle 08 0 Grommet Grommet Screw, Hex Head Cres (M x 0mm) Insulation, Enclosure Plug, Hole * All parts included with PTO and Non PTO Housing unless noted. + All parts included with Sound Shield Kit unless noted. MDDC

58 PTO Housing Kit, Sound Shield (PTO) (Includes Parts Marked*) *Screw, Hex Head Sems Stainless (M x.0 x mm) Insulation, Baffle 0 88 * MDDCA, MDDCB, MDDCC MDDCF and MDDCG 0 89 MDDCD, MDDCE, MDDCH and MDDCJ *Grommet *Panel, Enclosure (Front) *Insulation, Sound (Front) *Guard, Coupling *Guard, Coupling *Insulation, Sound *Insulation, Sound * All Parts Included with PTO Housing Only MDDC

59 Control Housing Saddle, Control Box UCD Generator UC Generator Screw, Hex Head Sems Stainless(M x x mm) UCD Generator UC Generator Panel Saddle (Cover) Box, Output 9 0 Box, Output (Cover) 08 Grommet, Remote 08 0 Trim, Edge ( ) Plug, Hole Plug, Hole 0 08 Grommet, Rubber 08 0 Grommet, Boot Seal, Edge UCD Generator UC Generator Screw, Hex Head Cap (M0 x. x 0mm) 0090 Strap, Electrical 000 Washer, Flat Washer, Eit Lock Nut, Hex Head Machine (M0 x.mm) Trim, Edge (.9 ) Washer, Eit Lock MDDC

60 Control Housing (DC) Kit, Control Display Box, Control (DC) 9 0 Panel, Control (Non ESDD) Assy, Control (ESDD) Rivet, Drive 8 08 Screw, Pan Head Xrec (Non ESDD # x.8 ) Switch, Rocker SPDT (Non ESDD) 08 0 (V) 08 0 (V) 0 Assy, PCB Circuit, Breaker Hourmeter Grommet, Remote Panel, Control Box Relay, SPDT 0 (V) 0 89 (V) 80 8 Clip, Nut Cover, Control Screw, Hex Head Sem Stainless (M x x mm) 00 Nut, Hex Flange (M x.) Nut, Hex Flange (M x.) 8 0 Standoff, Insulator Screw, Locking Flange Head (/ 0 x. ) 0 00 Washer, Flat 0 00 Isolator, Vibration Nut, Hex Flange (/ 0 ) 0 Plug, Hole 08 0 Trim, Edge (mm) 8 9 Harness, Engine Screw, Locking Flange (/ 0 x.0) 98 8 Label, Information Screw, Flange Head Xrec (ESDD M x x 9.mm) Snubber, Ring Washer, EIT Locker (/ ) Strap, Bond 099 Washer, Flat (/ ) 8 Strap, Bond Screw, Hex Head Cap (/ ) 8 MDDC

61 PCB Mounting REF PART QTY. PART REF PART QTY. PART 0 PCB, Control Bracket, PCB Screw, Hex (M x 0) 00 Washer, Flat (M) 0 Siffener, PCB 8 0 Screw, Locking Flange (M x.8 x 0mm) 9 MDDC

62 0 MDDC Generator

63 Generator Stator, Generator UC Generator No UC Generator No Rotor Assembly, Generator (Includes Parts Marked*) UC Generator No and UC Generator No and *Key, Exciter Rotor UC Generator No and UC Generator No , 09 0 and and *Rotor Assembly, Exciter (Includes Parts Marked ) UC Generator No and UC Generator No , 09 0 and and * Rectifier Assembly (Includes Parts Marked #) 009 Forward (With Positive Diode) 009 Reverse (With Negative Diode) * #Diode Positive Negative * #Screw, Cap Hex Head (M x mm) (CR,,,,,) * #Nut, Hex (M) * #Washer, Lock Spring (M) 0 00 * #Washer, Flat (M) * Nut, Locking Nylon (M) 00 * Washer, Flat (M) *Bearing, Ball 0 0 UC Generator 0 0 UC Generator *Ring, Exciter Retaining 8 0 UC Generator UC Generator *Varistor *Nut, Hex (M) *Tie, Cable (Use As Required) 8 *Hub, Generator Drive 8 UC Generator 9 UC Generator *Washer, Lock Spring (M) 0 00 *Washer, Flat (M) O-Ring UC Generator UC Generator Adapter, Generator 0 UC Generator 0 UC Generator Screw, Cap Hex Head UC Generator (M0 x mm) UC M0 x 0mm M0 x 0mm ( O clock Position) 80 0 Washer, Lock Spring (M0) Disc, Generator Drive 99 UC Generator 99 UC Generator Screw, Cap Hex Head (M x 0mm) 09 8 Washer, Flat (/8 ) 8 Adapter, Generator Stator 08 UC Generator 09 UC Generator Seal, Edging Bulk (Order by the Foot Feet Required) 0 Cover, Stator Top UC Generator No and UC Generator No , 09 0 and and * Parts Included in Generator Rotor Assemblies # Parts Included in Rectifier Assemblies Parts Included in Exciter Rotor Assemblies MDDC

64 MDDC Generator

65 Generator Cover, Stator Bottom UC Generator No & mm Stack Length UC Generator No , 09 0 and and Screw, Cap Hex Head M0 x mm UC Generator No and UC Generator M x 0mm Washer, Lock Spring M0 UC Generator and UC Generator M Washer, Flat M0 UC Generator and UC Generator M 08 0 Grommet 0 Plug, Hole Washer, Flat UC Generator M8 UC Generator 0 M0 8 Screw, Cap Hex Head UC Generator M8 x mm UC Generator M0 x 0mm 9 Washer, Lock Spring UC Generator 80 0 M8 UC Generator 80 0 M0 0 Guard, Fan Generator (See Page ) Screen, Air Inlet (See Page ) 8 Screw, Self-Locking Hex Washer Head (See Page ) 8 Screw, Self-Locking Hex Washer Head (See Page ) Bell, End 0 UC Generator 0 UC Generator Washer, Lock Spring 80 0 M8 (UC Generator) 80 0 M0 (UC Generator) Screw, Cap Hex Head M8 x mm, UC Generator) M0 x 0mm UC Generator) Washer, Lock Spring (M) 8 Screw, Cap Hex Head (M) UC Generator No and UC Generator No , 09 0 and and Stator, Exciter UC Generator No , and UC Generator No , 09 0 and and Bracket, Generator Mounting UC Generator UC Generator Screw, Cap Hex head M0 UC Generator M UC Generator Washer, Lock Spring 80 8 M0 UC Generator 80 8 M UC Generator Washer, Flat 099 M0 UC Generator 099 M UC Generator Spacer, Mounting Foot 0 0 UC Generator 0 0 UC Generator * Parts Included in Generator Rotor Assemblies Parts Included in Exciter Rotor Assemblies # Parts Included in Rectifier Assemblies. MDDC

66 Generator Mounting Bolt, Place (/8 x ) Screw, Cap Hex Head M0 x mm UC Generator M0 x mm UC Generator Screw, Cap Hex Head (M0 x mm) (UC Generator) Washer, Lock Spring (M0) 0 8 Washer, Flat (/8 ) Bracket, Generator Mounting 0 0 UC Generator 0 0 UC Generator 08 0 Cover, End Bell Washer, Flat (M) 9 0 Spacer, Cover Screw, Lock (M x 0mm) Spacer, Mounting Foot 0 0 UC Generator 0 0 UC Generator Edging Bulk (Order by the Foot Feet Required) Screw, Cap Hex Head M0 x mm UC M x 0mm UC Washer, Lock Split M0 UC Generator M UC Generator MDDC

67 Generator Heater Kit, Heater (0 V) 0 Kit, Heater (0 0V) Cartridge, Heater 08 0 * 0 Volts Volts 0 *Clamp, Loop 8 0 *Screw, Pan Head (M x ) *Nut, Hex Steel Machine (M) *Washer, Lock Spring (M) 00 *Washer, Flat (M) 0 0 *Box, Terminal Heater (Includes Cover and Gasket [Ref. No. 8 and 9]) Cover, Terminal Box Gasket, Terminal Box 0 0 *Block, Terminal *Grommet 8 0 *Screw, Pan Head (M x 0) *Washer, Lock (M) *Screw, Cap Hex Head (M x mm) 8 *Mount, Cable Tie *Nut, Nylon 89 *Tie, Cable *Screw, Pan Crescent Head (M x mm) 9 00 *Plug, Dot Button *Label, Heater Warning * All parts included in Kit unless noted. MDDC

68 Permanent Magnet Exciter Kit, Regulator PMG (Includes Parts Marked*) 009 *Pin, Dowel *Bolt, Hex Head (M0 x 90mm) 0 *Rotor 0 *Stator 9 Clamp 08 0 *Cover, End Bell 0 *Spacer Screw, Self-Locking Hex Washer Head (M x 0mm) Washer, Lock Spring (M0) *Harness, Wiring (AUX-P, P, P to VR-P, P, P) (0 Long, Wires) 8 *Harness, Wiring (P, P, P to P, P, P) (0 Long, Wires) (Includes Terminal Housing and Receptacle Terminal [Ref. No. and ]) 0 Housing, Terminal Terminal, Receptacle *Washer, Lock Spring (M) 080 Washer, Flat MDDC

69 Louver Louver (Exhaust) UC Generator 0 0 Louver (Exhaust) UCD Generator 0 0 Louver (Inlet) UCD Generator 0 0 Louver (Inlet) UC Generator Screw, Cap Hex Head (M x.8 x mm) 00 8 Washer, Plain (/ ) Washer Locking Split (M) 8 08 Guard Fan (UCD) 9 08 Guard Fan (UC) Screw, Self Locking Hex Washer Head (M x mm) Screen, Air Inlet (UCD) Screen, Air Inlet (UC) MDDC

70 Automatic Voltage Regulator Kit, Control (Manual Voltage Regulator) 0 08 Regulator, Voltage Auto Standard w / PMG 00 Washer, Flat (M) Standard w / PMG Screw, Hex Flange Standard w / PMG 0 08 *Regulator, Voltage Manual MVR Optional *Screw, Locking (0 x / ) MVR Optional 80 0 *Nut, Sems EIT (#0 ) MVR Optional Transformer, PCB ISLN Standard w / PMG Nut, Hex (#0 ) Standard w / PMG Switch, Toggle CT Optional 0 Current, Transformer UCD UC Harness, Regulator 8 89 Standard w/ PMG 8 88 * MVR Optional 8 90 Transformer *Label (MVR) 98 Label, Cross Current (UCD and UC) *Guard, Electrical Switch * Parts included in Control Kit. 8 MDDC

71 Remote Harness 8 0 Kit, Remote Panel () 0 Kit, Remote Panel (V) Label, Instruction Switch, Rocker 08 0 V 08 0 V Harness, Remote Panel (Reaches From Extension Harness to Remote Panel) (Includes Plugs, Wedge and Pin) Plug (8 Pin) (J) 9 Plug, Connector Wedge, Plug (8 Pin) 9 Pin, Contact Connector, Switch 9 MDDC

72 Remote Control Panel Kit, Remote Panel (V) Kit, Remote Panel (V Panel, Remote (Includes Label) Label, Panel (Start/Prime) Switch, Rocker 08 0 V 08 0 V Harness, Remote Panel (Reaches From Extension Harness to Remote Panel) (Includes Plugs, Wedge and Pin) Plug (8 Pin) (J) 9 Plug, Connector Wedge, Plug (8 Pin) 8 9 Pin, Contact Connector, Switch Screw, Wood (# x ) 0 MDDC

73 Remote Control Panel Kit, Remote Panel (V) 9 0 Kit, Remote Panel (V) 9 0 Panel, Remote (Includes Label) 98 8 Label, Information Switch, Rocker 08 0 V 08 0 V Harness, Remote Panel (Reaches From Extension Harness to Remote Panel) (Includes Plugs, Wedge and Pin) Plug (8 Pin) (J) 9 Plug, Connector Wedge, Plug (8 Pin) 8 9 Pin, Contact Connector, Switch Screw, Flat Head Xrec ( 0 x. ) Nut, Hex ( Low Prof Lock) 8 08 Screw, Pan Head Xrec MDDC

74 Wiring Harnesses P J J MDDC

75 Wiring Harnesses REF PART QTY. PART REF PART QTY. PART Harness, Remote Extension (Includes Parts Marked #) 8 feet 8 8 feet 8 9 feet #%Plug (8 Pin) 9 8 #%Terminal, Socket #%Wedge, Plug (8 Pin) #Receptacle, (8 Pin) 9 8 #Terminal, Pin #Wedge, Receptacle (8 Pin) Harness, Junction (Includes Parts Marked +) 9 ±Plug, Connector (8 Pin) 0 9 AR ±Terminal, Socket ±Wedge, Plug (8 Pin) +Connector, Receptacle (8 Pin) 9 AR +Terminal, Pin +Wedge, Lock, Receptacle (8 Pin) 8 0 Harness, Pigtail (Includes Receptacle (8 Pin) 9 Pin Lock (8 Pin) Harness, Interface (Includes Parts Marked ~) 0 80 ~Connector, Receptacle (8 Pin) 9 AR ~Terminal, Pin 8 ~Wedge, Lock (8 Pin) 8 Harness, Remote Panel (Includes Parts Marked %) # Parts Included in Remote Extension Harness..+ Parts Included in Junction Harness..@ Parts Included in Pigtail Harness..~ Parts Included in Interface Harness..% Parts Included in Remote Panel Harness. MDDC

76 Extension Harness 8 9 Harness, Extension AC 8 9 Harness, Extension (Optional) 8 99 Harness, Extension (Standard) MDDC

77 Circuit Breaker 8 Cover, Circuit Breaker No Breaker NSF Breaker NSJ Breaker Screw, Hex Head Sems Stainless (M x.0 x mm) 9 0 Bracket, Circuit Breaker (NSF) 89 Screw, Pan Head Xrec (M x.8 x 0mm) 8 0 Sheet, Insulation (Breaker) Circuit, Breaker (See Breaker Page) Copper, Strip Gasket, Door (. ) MDDC

78 Circuit Breaker POLE 00/0 VOLT AMPS MDDCA MDDCB MDDCC MDDCD MDDCE MDDCF POLE 00/0 VOLT AMPS MDDCG MDDCH MDDCJ POLE 00/90 VOLT NSJ AMPS MDDCA MDDCB MDDCC MDDCD MDDCE MDDCF POLE 00/90 VOLT NSJ AMPS MDDCG MDDCH MDDCJ MDDC

79 AMPS POLE 00/90 VOLT NSJ MDDCG MDDCH MDDCJ MDDC

80 Labels and Tag MDDC

81 Labels 08 0 Grommet 98 Tag, Fuel Line 98 Tag, Fuel Line Label, Warning Label, Onan E QD No Housing Housing Label, Warning 98 8 No Housing 98 8 Housing 98 8 Tag, Caution Label, Information Label, Control (DC) Label, Information Label, Warning 98 Label, Warning (Housed) Label, Danger Label, Information Label, Instruction Label, Information MDDCA, MDDCB,MDDCC, MDDCF and MDDCG MDDCD, MDDCE, MDDCH and MDDCJ Label, Information MDDCA, MDDCB,MDDCC, MDDCF and MDDCG MDDCD, MDDCE, MDDCH and MDDCJ Label, Information Label, Caution Label, Information (No Step) (Housed) Label, Warning (Rotating Parts) 98 Label, Warning (Hazardous Voltage and Rotating Parts) 98 8 Label, Caution 98 0 Label, Voltage Adjustment 98 Label, DNV Type Product Approved 98 Tag, Warning (Oil and Coolant Levels) 98 8 Label, Model Identification Label, Danger 9 MDDC

82 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page , 098, 9 098, 8 098, 9 098, 9 098, , , , , , , , 098, 9 098, , , , , , , , 8, 098 8, , , , , , , , , , , , , 9 0, 9 0 8, 0 9, 0 0, 0, 9 0, 00, 008, 088,, 0888, 0889, 0890, 089, 0,, 8 0, 0,, 8 9,, 0,,,, 8, 8 8, 8 0, 0 0, 0 0 0, 0, 0, 0, 0, 0 9 0, 0 9 0, 0 0,, , 0 0 0, 0 0, 0, 0, 0 8, 0, 0, 0, 0, 0, 0, 0, 0 8, 0 9, 0 0, 0, 0, 0, 0, 0, 0,, 0,, 08, 8 09, 8 00, 0, 99 0,, 0 8 0, 0 89, 088, 0888, 0889, 9, 9, 9, 9, 9, 9 8, 9 9, 9 0,, 9, 9, 9 0, 9 0, 9 0, 0 89, 8, 8, 8, 8 0, 8 8 0, 8, 9, 0, 8, 9, 0,, 8, 9, 0,,, 9, 0 8, 9, 99,, 00, , , , , , , , , 9, 9 9, 9 8, 9 9, 9 9 0, 9 9, 9, 9, , 9 0 0, 9 0, 9 0, 0 0, 0 0, 0, 0 9 0, 0 9 0, 0 9 0, 0 9 0, 0 0, 0 0, 0, 0, 0, , , 0 8 0, , , 0 9 0, 0 9 0, 0 9 0, 0 9 0, , 0, 0, 08, 09, 8,,,, 0, 0, 9, 99, 0 0,, 0 0,, 89 0, 89 0, 80 0, 80 0, 9, 08, 08, 08 0, 08 0, 088, 089, 09 0, 80

83 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 09 0, 09 0, 09, 00, 0, 0 0, 0 0, 0 0, 0 0, 00, 00 88, , , , , , , 0 08, , , , 0 088, 8 0, 0 0, 0 0, , , , 9, 0, 08 0, 8, 9, 0, 08 0, 8, 9, 0, , , , 09 0, 9 9 0, , , 9 0 0, , , , 9 0 0, 9 0, 9 0 0, 9 8 0, , , 8 9 0, 8, 9 0, , , , , , , , , , , , , ,, ,, 0 90,, 0 9, 8 9, 9, 9, 0,,, 9, 0,,,, 9, 0,,, 80, 8, 9, 9, 0, 8, 9, 80, 8 8, 8, 8, 8,, 0, 8 0, , 0 0 0, 0 0, 09, 0 89, 0, 8 0, 0, 0,,, 8, 0, , 08 08, 0, 0, 00 0, 00 0, 00 0, 00 0, 00, 0, 0090,, 8, 8, 8 8 9, 8 99, 8 9, 8 9, 8, 8 8, 8 9, 8, 8 988, 9, 0, 8 0, 8 0, 8, 8 9, , , , , 8, 009, 009, 8 0 0, 8 0 0, 0 00,, , , , , , , 0 088, , 0 0 0, 0 0 0, 0 0 0, 0 0, 0 0, 0 0 0, 0 8 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0 0, , 0,, ,, 0 8 0,, 0 8, 0 8, 0 9 0, 0 9 0,, 0 9 0,, ,, ,, 0 8,, 0 8,, 0 8, 0 8,, 0 8,, 0 88, 0 89,,, 0 80,, 0 8,, 0 8,, 0 8,, 0 8 0,, 0 88,,, 0 89,, 0 80,, 0 9 0, 0 9 0, 0 9 0, ,, ,, 0 80, , , 0 80, , , ,, ,, ,, 0 80, 0 80, 0 80, 8

84 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page ,, 0 809,, , , , 0 800, 0 80, 0 80, 0 8,, 0 8,, 0 8,, 0 88,, 0 89,, 0 00,, 0 0,, 0 08, , , , , 0 08, 0 088, 0 089, 0 080, 0 08, , , , , , , , , 0 080, 0 08, 0 009, ,,, 0 0, 0 0, 0 00,, 8 0 0,, , 0 0, 8 0 0, 0 98,, ,, 8 0 0, 8 0 0, 0 0, 0,, 8 0,, 8 0 8,,, 0 0,, 0 8, 0 9, 0 8 0, 0 8 0, 0 09,, 8, 0, 0 0, 8 0 0, 0, 0, 0 9, 0 0 9, 0 0 9, 0 98,, 0 99, 0 0 0, , 0 09, 0 0, 0 0, 0 0, 0 0, 0 0, 0, 0,, 0, 0, 0, 0, 0, 0 8, 0 9, 0 0, 0, 0, 0, 0, 0 00,, 0 000,, 8 0 0, 0 09, 0 00, 0 00, 9, , 0 0, 0 8, 0 9, 0 0,, 8 0,, 8 0, 0, 08 00,,, 08 08, , 08 09, 08 0,,,, , 08 0, 8 08, 08, 08 0,,,,,, ,, , , 09 09,, 09 09,, , , , 09 00, 09 00,, , 09 00, 09 00, 09 00, 09 00, 0 0, 0 0, 0, 089, 090, 09, 09, 08 09, 098 0, 098 0, 00, 0 0,, 0, 0, , 08 0, 08 09, 09, 8 008, 8 0, , 8, 9,, 8 08, 008, 00, 000, 00, 8 0, 09, 099, 8 099, 099 8, 099 0,, 8, 9,, 099, 099, 0,,,, 8, 9, 0,,,, 099, 099, 0, 00, 9,, 00,, 8 080,,, 0, 0, 8 0, 8 0, 9 0, 9 0, 0, 8 0, 9 0, 9, 8, 8, 8 8, 9 0, 9 9 0, 9 0,,,,, 8, 8,, 8 8 0, 8

85 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 8 0, 0 9, 0, 0, 009, , , 800 0, 800 0, , , 800, , , , , , 8, 9,, , 800 0, ,, 8, 800 0, 800 0, 800 0, 800 0, 0,,, 8, 9, 0,, 800 0, 800 0,, 800 0, 800 0, , 800 0, 800 0, , , 800 8, 800 9, 800 0, 800, 800, 8 800, 8 800, , 8 0, 8 0, , , , , 8, 8 090, ,, ,, , 8 89, 8 000, , , , 8 0, , ,,,, , , , ,,, , 0, 8, 9,,,,,,,, 8, 8 0, 8 0, 80 0, 80 0,, 80, 80, 80 00, 80 00,, 80 00,, 80 00,, 80 00,, 80 0, 8 000, , 8 00,, 80 00,, 80 00, 80 08, 80 09, 8 00, 8 00, 8 00, , 80 0, , 80 0, , , , ,, , , 80 8, 8 8 0, 89 09,, 89 0,, , , 8 8