CALIFORNIA Proposition 65 Warning:

Size: px
Start display at page:

Download "CALIFORNIA Proposition 65 Warning:"

Transcription

1 PARTS MANUAL P1064 For Models: L1064D, L1064A, M1064D, M1064T1, M1064T2, M1064A, M1064H, NL1064D, NL1064T1, NL1064T2, NL1064H1, NL1064H2, M40C2, M55C2, & M65C2

2 CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents are known to the State of California to cause cancer, birth defects, and other reproductive harm. Northern Lights th Avenue N.W. Seattle, WA Tel: (206) Fax: (206) Copyright 2017 Northern Lights, Inc. All rights reserved. Northern Lights, and the Northern Lights logo are trademarks of Northern Lights, Inc. Printed in U.S.A. PART NO.:

3 PARTS CATALOG for Models L1064D, L1064A, L1064T1, M1064D, M1064T1, M1064T2, M1064A, M1064H, NL1064D, NL1064T1, NL1064T2, NL1064H1, NL1064H2, M40C2, M55C2, and M65C2 Please read thoroughly before attempting to use this manual: Table of Content...I Model Designation & Serial Numbers... II Reading a Parts Page... III Table of Contents Oil Cooler GROUP 1 - ENGINE Idler Shaft Cylinder Block Assembly Radiator Flywheel Housing GROUP 4 - FUEL SYSTEM Crankshaft & Main Bearings...10 Fuel Injection Pump & Fuel Lines Crankshaft Pulley Injection Pump Applications...18 Cylinder Liner Assembly & Connecting Rod Engine Control Unit Applications...19 Timing Cover Plate Fuel Injectors Camshaft Fuel Filter & Lines Balance Shaft Fuel Supply & Return Connections Timing Cover Fuel Filters Oil Filter Assembly, Mounting, & Adapter Fuel Filter Bypass Oil Pump Fuel Transfer Pump Oil Pan Throttle Oil Drain & Dipstick GROUP 5 - ELECTRICAL SYSTEM Oil Fill Assembly & 24 Volt, Standard & Isolated Ground Low Oil Level Switch/Gauge Oil Pressure Manifold Cylinder Head, Head Gasket, Valves Stop Solenoid, Cold Start Sensor & Solenoid Rocker Cover, Rocker Shaft, Rocker Arm Alternators and Mounting Ventilating System Circuit Breaker, Relay Panels, DC Enclosure GROUP 2 - INTAKE & EXHAUST Drive Belt and Tensioner , 59 Intake Manifold and Air Cleaner Idler Pulley & Mounting Air Intake & Turbocharger , 14-17, Control Panels 12 & 24 Volt Air Intake & Air Filter , Remote Alarm Intake & Aftercooler , Belt Guards Crankcase Breather , GROUP 6 - GASKET SETS Intake Manifold & Air Filter (Industrial) Engine Overhaul Exhaust Manifold & Adapter , GROUP 7 - GEAR AND ADAPTER PARTS Exhaust Elbows , 47 Gear Oil Cooler Turbocharger Assemblies , GROUP 8 - FRAMES & MOUNTING Exhaust Adapter (Industrial) Base Frames GROUP 3 - COOLING SYSTEM GROUP 9 - ACCESSORIES & OPTIONAL Expansion Tank Assembly EQUIPMENT Heat Exchanger Low Coolant Level Switch Coolant Pump Inlet & Assembly Raw Water Flow Switch Raw Water Pump & Mounting Governor Actuator & Mounting... 8 Thermostat Housing Electric Clutch & PTO Assembly... 9 Proprietary Information This publication is the property of Northern Lights, Inc. It may not be reproduced in whole or in part without the written permission of Northern Lights, Inc. Northern Lights, Inc. All rights reserved. Litho U.S.A. Publication number I

4 INTRODUCTION MODEL DESIGNATION Refer to the category designations below to find the correct parts pages for your model. L - M - NL 1064 D - T - A - H - C L - Lugger propulsion unit M - Northern Lights marine generator set NL - Northern Lights industrial generator set Base Model # (Deere 4045 Powertech Series engine block) Aspiration D Natural T Turbocharged A Aftercooled H High Output C Commercial L 1064 D = Northern Lights naturally aspirated propulsion engine with a John Deere 4045 engine. MP 40 C2 = Northern Lights naturally aspirated marine diesel generator set with a John Deere 4045 engine, 40 kw. M 1064 D = Northern Lights naturally aspirated marine diesel generator with a John Deere 4045 engine. MP 55 C2 = Northern Lights turbocharged marine diesel generator set with a John Deere 4045 engine, 55 kw. M 1064 T M 1064 A = = Northern Lights turbocharged marine diesel generator set with a John Deere 4045 engine. Northern Lights turbocharged marine diesel generator set with a John Deere 4045 engine, aftercooled. MP 65 C2 NL 1064 = Northern Lights turbocharged marine diesel generator set with a John Deere 4045 engine, 65 kw. = Northern Lights industrial diesel engine, with a John Deere 4045 engine. M 1064 H = Northern Lights turbocharged high output marine diesel generator set with a John Deere 4045 engine. All model numbers in parentheses will indicate a John Deere base engine. All variations requiring serial numbers for proper identification will be noted as Northern Lights or John Deere. SERIAL NUMBERS NORTHERN LIGHTS Your set has three serial numbers: 1 an engine number stamped on the block, 2 a generator plate, and 3 a generator set plate. Use the serial number on the generator set plate when ordering parts or in correspondence. The generator set plate is found on the service side of the generator and resembles one of the drawings below. Lugger Serial Number Generator Set Serial Number Generator Set Serial Number II

5 INTRODUCTION READING A PARTS PAGE IMPORTANT: Before selecting parts, be sure that you are choosing parts from the correct page. Check the model designation at the page top. Do not use this illustration for parts purchasing. 1 ELECTRICAL SYSTEM ALTERNATOR ASSEMBLY: M - NL KEY PART NUMBER QTY. DESCRIPTION SERIALNUMBER Alternator Assembly Flywheel, complete Plate, complete Plate Stator, complete Bearing Nut Spring washer Washer Clamp Screw Screw Collar P445 06/ REFERENCES: 1. Grouping section title. 7. Quantity of parts used. 2. Model designation of equipment that uses parts 8. Description of each component part. listed on this page. 9. Serial number of unit the part fits. 3. Title and description of assembly. 10. Assembly or kit designated by Key 0 or /. 4. Drawing numbers that correspond to key 11. Grouping index number. column numbers for parts identification. 12. Page number within the grouping index. 5. Key column for locating parts shown on drawing. 13. Manual title. 6. Part number. 14. Page publication date. NOTE: a Arrows always point toward the front of the engine. III

6 GROUP 1 ENGINE Cylinder Block L-M-NL1064D, M-NL1064T1-T2, L-M1064A, NL1064H1, M40C2, M55C2, & M65C2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. TP

7 GROUP 1 ENGINE Cylinder Block L-M-NL1064D, M-NL1064T1-T2, L-M1064A, NL1064H1, M40C2, M55C2, & M65C2 1 Cylinder Block (marked R115081)* - 2 R Bearing Cap - 3 R Bearing Cap - 4 T Capscrew - 5 T Washer - 6 R Bushing - 7 R Plate M Screw, M8 x 25-9 R Oil By-pass Valve - 10 R Spring - 11 RE Oil Pressure Regulating Valve - 12 R Bushing, Balancer Shaft - 13 R Dowel Pin - 14 AT Drain Valve - 15 R Receptacle Connector Body - 16 R O-ring - 17 R Dowel Pin - 18 T Plug - 19 R Pipe Plug - 20 R Pipe Plug - 21 R Orifice - 22 RE Plug - 23 U O-ring - 24 T Gasket - 25 R Plug H624 1 Pipe Plug, 1/2" NPT H623 1 Pipe Plug, 3/8" NPT - *Not available separately - see short block listing. 1-1

8 GROUP 1 ENGINE Cylinder Block M1064H & NL1064H2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP

9 GROUP 1 ENGINE Cylinder Block M1064H & NL1064H2 1 1 Cylinder Block (marked R504849) - 2 R Bearing Cap - 3 R Bearing Cap - 4 T Capscrew - 5 T Washer - 6 R Bushing - 7 R Plate M Screw, M8 x 25-9 R Valve, Engine Oil By-pass - 10 R Spring - 11 RE Oil Pressure Regulating Valve - 12 R Bushing, Balancer Shaft - 13 R Dowel Pin - 14 AT Drain Valve - 15 R Receptacle Connector Body - 16 R O-ring - 17 R Dowel Pin - 18 T Plug - 19 R Pipe Plug - 20 R Pipe Plug - 21 R Orifice - 22 RE Plug - 23 U O-ring - 24 T Gasket - 25 R Plug H624 1 Pipe Plug, 1/2" NPT H623 1 Pipe Plug, 3/8" NPT - 1-3

10 GROUP 1 ENGINE Cylinder Block Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. TP

11 GROUP 1 ENGINE Cylinder Block RE Short Block (for 1064D & M40C2, marked R115081) RE Short Block (for 1064T1, T2 & A, & M55C2 marked R for Stanadyne DE10 injection pump without auxiliary drive, furnish RE kit, for Stanadyne DE10 injection pump with auxiliary drive furnish RE kit. Piston marked RE code 4822) RE Short Block (for 1064H, marked R504849, Piston marked RE507758) - RE Short Block (for 1064T2 & M55C2, marked R115081, Piston marked RE code 4823) - 1-5

12 GROUP 1 ENGINE Flywheel Housing SAE #4 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP R Housing (also order R61467) - 2 R Plug - 3 R O-ring - 4 RE Seal M Screw, M12 x R Bolt M Screw, M12 x 50-8 R39112 ** Plug - **As required 1-6

13 GROUP 1 ENGINE Flywheel Housing SAE #3 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP R Housing - 2 R O-ring - 3 RE Seal - 4 T Plug H624 1 Pipe Plug, 12.7 mm - 6 R Plate M Capscrew, M6 x 12-8 R Plug M Screw, M12 x R Bolt - 11 R39112 ** Plug - **As required 1-7

14 GROUP 1 ENGINE Flywheel Housing SAE #3 Special Units with Dual Starting Systems Reproduced by permission of Deere & Co., c2007. Deere & Company. All rights reserved. RGP R Flywheel Housing - 2 R Plug - 3 R O-ring - 4 RE Seal H624 1 Pipe Plug M Screw, M12 x 50-7 R Bolt - 8 R39112 ** Plug - **As required 1-8

15 GROUP 1 ENGINE Flywheel SAE #10 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. TP RE Flywheel (marked R122409, includes key #2) - 2 R Ring Gear (142 Teeth) - 3 R Bolt Flywheel SAE #11-1/2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. TP RE Flywheel (marked R500219, includes key #2) - RE Flywheel (special for Dual Starting Systems) - 2 R Ring Gear (129 teeth) - 3 R Bolt - 1-9

16 GROUP 1 ENGINE Crankshaft and Main Bearings Reproduced by permission of Deere & Co., c2006. Deere & Company. All rights reserved. RGP RE Crankshaft (marked R503715, includes keys 2-4) M Shaft Key - R Shaft Key (1064D & T1) - 3 R Gear (30 teeth) - 4 R Dowel Pin - 5 RE Main Bearing Kit (Standard) - RE Main Bearing Kit (undersize.254 mm) - 6 RE Thrust Bearing Kit (Standard) - RE Thrust Bearing (undersize.254 mm)

17 GROUP 1 ENGINE Crankshaft Pulley, Marine Applications Reproduced by permission of Deere & Co., c2006. Deere & Company. All rights reserved. RGP R Pulley (168 mm O.D.)* - R Pulley (188 mm O.D.)** - 2 R Washer - 3 R Capscrew, Hex Head M20 x 2.5 x 70 mm Grade *for L-M1064D **for M1064T1-T2, L-M1064A, and M1064H 1-11

18 GROUP 1 ENGINE Crankshaft Pulley, Industrial Application Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP R Pulley (168 mm O.D.)* - R Pulley (188 mm O.D.)** - 2 R Washer Bolt - *for NL1064D -T1- T2 - H1 **for NL1064H2 1-12

19 GROUP 1 ENGINE Crankshaft Pulley Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. A & A-10447/ B Pulley, Crankshaft 3-A/B x 8" Pulley, Crankshaft 4-A x 8" Capscrew, Hex Head Flanged M10 x 1.5 x 65 mm

20 GROUP 1 ENGINE Cylinder Liner Assembly and Connecting Rod L-M-NL1064D, & M40C2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP6650 RE Piston Liner Kit (marked RE505101) - 1 M Snap Ring - 2 R Piston Pin - 3 R Bushing - 4 R Screw - 5 RE Connecting Rod (marked R500000) - 6 RE Bearing (Standard) - RE Bearing (undersize.010") - 7 RE Piston Ring Kit - 8 AR O-ring Kit - R O-ring - R Packing - R O-ring

21 Updated GROUP 1 ENGINE Cylinder Liner Assembly and Connecting Rod M-NL1064T1, & M55C2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP6650 RE Piston Liner Kit (marked RE515372, includes keys #7-8) - 1 M Snap Ring - 2 R Piston Pin - 3 R Bushing - 4 R Screw - 5 RE Connecting Rod (marked R500000, includes keys #3-4) - 6 RE Bearing (Standard) - RE Bearing (undersize.254 mm) - 7 RE Piston Ring Kit - 8 AR O-ring Kit

22 Updated GROUP 1 ENGINE Cylinder Liner Assembly and Connecting Rod M-NL1064T2, L-M1064A, NL1064H1, & M65C2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP6650 RE Piston Liner Kit (marked RE509540, includes keys #7-8) - 1 M Snap Ring - 2 R Piston Pin - 3 R Bushing - 4 R Screw - 5 RE Connecting Rod (marked R500335, includes keys #3-4) - 6 RE Bearing (Standard) - RE Bearing (undersize.254 mm) - 7 RE Piston Ring Kit - 8 AR O-ring Kit

23 Updated GROUP 1 ENGINE Cylinder Liner Assembly and Connecting Rod M1064H & NL1064H2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP6650 RE Piston Liner Kit (marked RE507758, includes keys #7-8) - 1 R Snap Ring - 2 R Piston Pin - 3 R Bushing - 4 R Screw - 5 RE Connecting Rod (marked R500335, includes keys #3-4) - 6 RE Bearing (Standard) - RE Bearing (undersize.254 mm) - 7 RE Piston Ring Kit - 8 AR O-ring Kit

24 GROUP 1 ENGINE Timing Gear Front Plate L- M1064D, M1064T1 & T2, L- M1064A, M40C2, M55C2, & M65C2 Reproduced by permission of Deere & Co., c2006. Deere & Company. All rights reserved. RGP R Plate - 2 R Stud - 3 R Lock Washer - 4 R Shaft, Upper (use with key #5) H288 1 Spring Pin - 6 RE Gear, Upper Idler (marked R120635, includes R130912) - 7 R Thrust Washer, M10 x M Screw - 9 R Shaft, Lower - 10 R Thrust Washer - 11 R Stud - 12 R Screw M Screw, M10 x R Thrust Washer - 15 R Bushing - 16 RE Gear - 17 R Stud ** O-ring (formerly #T20758) - 19 R ** Cover - **As required 1-18

25 GROUP 1 ENGINE Timing Gear Front Plate M1064H Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP R Plate - 2 R Stud - 3 R Lock Washer - 4 R Shaft,Upper - 5 R Dowel Pin - 6 RE Gear (marked R504614) - 7 R Lock Washer M Capscrew, M10 x 60 mm - 9 R Shaft, Lower - 10 R Thrust Washer - 11 R Stud - 12 R Screw M Capscrew, M10 x 50 mm - 14 R Thrust Washer - 15 R Bushing - 16 RE Gear

26 GROUP 1 ENGINE Timing Gear Front Plate NL1064D, T1, T2, & H1 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP R Plate - 2 R Stud - 3 R Stud - 4 R Stud - 5 R Thrust Washer - 6 R Shaft, Upper H288 1 Spring Pin - 8 RE Gear (marked R120635) - 9 R Thrust Washer, Upper Idler M Screw - 11 R Shaft, Lower - 12 R Screw M Capscrew, M10 x 50 mm - 14 R Thrust Washer - 15 R Bushing - 16 RE Gear

27 GROUP 1 ENGINE Timing Gear Front Plate NL1064H2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP R Plate - 2 R Stud - 3 R Lock Washer - 4 R Shaft,Upper - 5 R Dowel Pin - 6 RE Gear (marked R504614) - 7 R Lock Washer M Capscrew, M10 x 60 mm - 9 R Shaft, Lower - 10 R Thrust Washer - 11 R Stud - 12 R Screw M Capscrew, M10 x 50 mm - 14 R Thrust Washer - 15 R Bushing - 16 RE Gear

28 GROUP 1 ENGINE Camshaft L-M-NL1064D, M-NL1064T1-T2, L-M1064A, NL1064H1, M40C2, M55C2, & M65C2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. TP RE Camshaft (marked R504534, includes keys #2-3) - 2 R Shaft Key Gear (60 Teeth, marked R133812)* - *Not available separately - order camshaft assembly 1-22

29 GROUP 1 ENGINE Camshaft M1064H & NL1064H2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. TP RE Camshaft (marked R515247, includes keys #2-3) - 2 R Shaft Key Gear (60 Teeth, marked R516237)* - *Not available separately, order camshaft assembly 1-23

30 GROUP 1 ENGINE Engine Balancer Shaft L-M-NL1064D, M-NL1064T1, M40C2, & M55C2 Reproduced by permission of Deere & Co., c2006. Deere & Company. All rights reserved. RGP R Bushing - 2 R Weight M Capscrew, M8 x 40 mm - 4 R Gear (Left hand Shaft) - 5 R Plate - 6 R Shaft Key - 7 RE Balancer Shaft (Left hand, marked R500266) M Capscrew, M8 x 12 mm - 9 R Gear (Right hand) - 10 RE Balancer Shaft (Right hand, marked R500668)

31 GROUP 1 ENGINE Engine Balancer Shaft M-NL1064T2, L-M1064A, M1064H, NL1064H1-H2, & M65C2 Reproduced by permission of Deere & Co., c2006. Deere & Company. All rights reserved. RGP R Bushing - 2 R Weight M Capscrew, M8 x 40 mm - 4 R Gear (Left hand shaft, 15 teeth) - 5 R Plate M Dowel Pin, 4 x 12 mm 7 RE Balancer Shaft (marked R500266) M Screw, M8 x 12-9 R Gear (Right hand) - 10 RE Balancer Shaft (marked R500668)

32 GROUP 1 ENGINE Timing Gear Cover L-M1064D, M1064T1, T2 & A, M40C2, M55C2, & M65C2 Reproduced by permission of Deere & Co., c2006. Deere & Company. All rights reserved. RGP R Cover (Replaced by R520129, also order installation kit RE515978) - R Cover 2 R Gasket (use with cover R504724) R Gasket (use with cover R520129) 3 51M O-ring - 4 RE Plug M20 x 1.5 (formerly RE501938) - 5 RE Screw M Capscrew, M8 x 35 mm 7 R O-ring - 8 R Cover M Capscrew, M6 x 16 mm - 10 RE Capscrew - 11 RE Seal Kit M Flange Nut M Screw M Capscrew, M8 x 60 mm

33 Updated page GROUP 1 ENGINE Timing Gear Cover M1064H Reproduced by permission of Deere & Co., c2006. Deere & Company. All rights reserved. RGP RE Timing Gear Cover (former # RE503596) - 2 R Adapter M Capscrew, M10 x 45 mm - 4 RE Drain Plug M O-ring M O-ring - 7 RE Plug M Flange Nut M Capscrew, M8 x 60 mm - 10 RE Bearing Kit M Screw - 12 R O-ring - 13 R Gasket

34 GROUP 1 ENGINE Updated page Timing Gear Cover NL1064D, T1, T2 & H1 Reproduced by permission of Deere & Co., c2006. Deere & Company. All rights reserved. 1 R Cover - (replaced by R cover, R gasket & RE Installation kit) R Timing Cover - 2 R Gasket (use with R504725) - R Gasket (use with R520130) 3 RE Fitting Plug (includes key #4) M O-ring M Capscrew, M8 x 40 mm - 6 R O-ring 7 R Cover M Capscrew, M6 x 16 mm M Capscrew, M8 x 35 mm - 10 RE Capscrew, M8 x 45 mm M Flange Nut - 12 RE Seal Kit M Capscrew, M8 x 60 mm M Capscrew, M8 x 55 mm RGP8338a

35 GROUP 1 ENGINE Timing Gear Cover NL1064H Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RE516919SPA 1 RE Timing Gear Cover - 2 R Adapter M Capscrew, M10 x 45 mm - 4 RE Drain Plug M O-ring M O-ring - 7 RE Plug M Flange Nut M Capscrew, M8 x 60 mm - 10 RE Bearing Kit M Screw - 12 R O-ring - 13 R Gasket M Capscrew, M8 x 25 mm - 15 RE Drain Plug

36 GROUP 1 - ENGINE Oil Filter Assembly L1064D- T1 A-10570/ B

37 GROUP 1 - ENGINE Oil Filter Assembly L1064D - T1 1 RE Oil Filter Head Assembly (includes key #16) Bracket, Rear Engine & Oil Filter (see Engine Mounting) Capscrew, Hex Head, M12 x 1.75 x 35 mm Lock Washer, Helical M Cap Screw, Hex Head, M10 x 1.5 x 25 mm Wave Washer, M Male Connector, Steel, 1-14 O-Ring Face Seal - (Includes keys 18-19) Hose Assembly, 1/2" I.D. x 16" Hose Assembly, 1/2" I.D. x 18" - 10 R Gasket - 11 RE Adapter - 12 RE52242 ** Plug M Capscrew, M8 x RE Capscrew, M8 x 20 (with pre-applied sealant) M Capscrew, M8 x R Sealing Ring - 17 RE Oil Filter ** O-ring ** O-ring - ** As required 1-31

38 GROUP 1 - ENGINE Oil Filter Assembly L1064A A / B

39 GROUP 1 - ENGINE Oil Filter Assembly L1064A Adapter 2 1 Bracket, Rear Engine & Oil Filter (see Engine Mounting) Capscrew, Hex Head, M12 x 1.75 x 35 mm Lock Washer, Helical M Capscrew, Hex Head, M10 x 1.5 x 25 mm Wave Washer, M Male Connector, Steel, 1-14 O-Ring Face Seal Hose Assembly, 1/2" I.D. x 21" Hose Assembly, 1/2" I.D. x 25" - 10 R Gasket - 11 RE Adapter (formerly #RE71062) 12 RE52242 ** Plug M Capscrew, M8 x RE Capscrew, M8 x 20 (with pre-applied sealant) M Capscrew, M8 x R Gasket - 17 RE Oil Filter ** O-ring ** O-ring Male Elbow, 90 Steel 1-14 O-ring Face Seal Plug - ** As required 1-33

40 GROUP 1 - ENGINE Oil Filter and Adapter M- NL1064D- T1, M40C2, & M55C2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP RE Filter Head (marked R502338, includes keys #2-3) - 2 RE Valve - 3 R Seal - 4 R Gasket M Capscrew, M8 x 65 mm - 6 RE Capscrew, M8 x 20 mm - 7 RE52242 ** Plug, M16 x 1.5 (includes key #8) M7042 ** O-ring - 9 RE Oil Filter - **As required 1-34

41 GROUP 1 - ENGINE Oil Pump Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP M Capscrew, M8 x Cover (not available separately) Gear (not available separately) Housing (not available separately) Gear (not available separately) - 6 RE Oil Pump (marked R502687, includes keys #2-5) - 7 R Tube - 8 R O-ring M Nut, M12-10 R Gear

42 GROUP 1 - ENGINE Oil Pan, Aluminum Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP R Gasket - 2 RE Oil Pump Intake M Capscrew, M8 x 100 mm - 4 R O-ring - 5 R Oil Pan M Capscrew, M8 x 30 mm M O-ring - 8 RE Plug M Capscrew, M8 x 25 mm H690 1 Pipe Plug M O-ring - 12 RE Drain Plug M Capscrew, M8 x 45 mm

43 GROUP 1 - ENGINE Oil Pan, Steel L -M -NL1064D, M -NL1064T1 & T2, M40C2, M55C2, & M65C2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. CDP R Gasket - 2 RE Oil Pump Intake M Capscrew, M8 x 100 mm - 4 R O-ring - 5 RE Oil Pan M Capscrew, M8 x 20 mm M O-ring - 8 RE Plug M Capscrew, M8 x 16 mm H690 1 Pipe Plug M O-ring - 12 RE Drain Plug, M22 x

44 GROUP 1 - ENGINE Oil Pan Updated page L - M1064A & H, NL1064H2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP R Gasket M O-ring - 3 RE Drain Plug, M22 x 1.5 mm O-ring - 5 RE Plug, M18 x 1.5 mm M Capscrew, M8 x 45 mm M Capscrew, M8 x 25 mm ** Capscrew M8 x 30 mm - 9 R Oil Pan (20.5 qts) - 10 RE Oil Pump Intake M Screw M8 x 100mm - 12 R O-ring - ** as required 1-38

45 GROUP 1 - ENGINE Oil Drain Assembly M1064D, T1, T2, M40C2, M55C2, & M65C2 A-8361/ B Female Adapter, Steel, 3/8 NPT x M18 x Shut Off Valve, 3/8 NPT x 1/2-45T Hose, 1/2" ID Push-on Female Swivel Brass, 1/2 Hose Barb x T Male Connector Brass, 1/2 NPT x 1/2-45T Plug, Hex Head, Steel, 1/2 NPT O-ring

46 GROUP 1 - ENGINE Oil Drain Assembly M1064A-H A-10827/ B Male Elbow, 90º Steel M18 x 1.5 x 1/2-37T Hose Assembly 1/2" I.D. x 21" Shut-off Valve, Brass 3/8 NPT x 1/ ** Bulkhead Union, Steel 3/8 NPT Plug, Hex Head Brass 3/8 NPT - **As required 1-40

47 GROUP 1 - ENGINE Dipstick & Tube (Right or Left Hand) Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP RE Dipstick - 2 R Dipstick Tube, Right Hand - R Dipstick Tube, Left Hand - 3 R ** Plug - **As required 1-41

48 GROUP 1 - ENGINE Oil Fill Assembly, Right or Left Hand Marine & Propulsion Units A-8347/ B Oil Filler Neck Oil Filler Mounting Gasket Capscrew, Hex Head M8 x 1.25 x 40 mm Flat Washer, M Oil Fill Cap O-Ring ** Plug, Hex Head, Brass, 1/8 NPT - ** As required 1-42

49 GROUP 1 - ENGINE Oil Fill Assembly, Left Side (with Governor Actuator) M1064D-T1, M40C2, M55C2 and Oil Fill Block-off, Left or Right Side, All Models Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP RE Filler Neck Gasket - 3 R Spacer Capscrew, Hex Head M8 x 1.25 x 115 mm Flat Washer M8-6 RE Filler Cap - 7 R Plate - 8 RE Screw, M8 x 20 (with pre-applied sealant) Spacer (use with actuator bracket, not shown)

50 GROUP 1 - ENGINE Added 11/7/11 Low Oil Level Switch/Gauge, ISO Ground R.H. 50 Hz - M1064A-H - NL1064H43 B8619A 1-44

51 Added 11/7/11 GROUP 1 - ENGINE Low Oil Level Switch/Gauge, ISO Ground R.H. 50 Hz - M1064A-H - NL1064H Oil Level Switch/Gauge, ISO Ground Bracket, Oil level Switch Gauge RH (Cast Oil Pan) Capscrew, Hex Head 1/4-20 x 3/4" Lock Washer, Helitical 1/ Flat Washer M Capscrew, Hex Head Flanged M8 x 1.5 x 55mm Grade Female Swivel, STL M18 x 1.5 x 3/8-37T female Run Tee, STL. 3/8 NPT x 3/8-37T Tube Assembly, Low oil Level SW/GA Male Elbow, 90 STL, 1/2 NPT x 3/8-37 T Flat Washer M10 S/S (316) Din Code 125-A Female Elbow, 90, BRS 1/8 NPT x 1/4-45 T Female Swivel, BRS 1/4 HB x 1/4-45 T Push-On (Universal Seat) Hose 1/4" ID Push-On Male, Connector, BRS 1/8 NPT x 1/4-45 T Male Elbow 90, BRS 1/8 NPT x 1/4-45 T Strain Relief Connection 1/2 NPT with 3/16" ID to 5/16" Grommet Plug, Hex Head BRS, 3/8 NPT

52 GROUP 1 - ENGINE Cylinder Head L- M1064D, M- NL1064T1-T2, L- M1064A, NL1064H1, M40C2, M55C2, & M65C2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. TP

53 GROUP 1 - ENGINE Cylinder Head L- M1064D, M- NL1064T1-T2, L- M1064A, NL1064H1, M40C2, M55C2, & M65C2 1 RE Cylinder Head (marked R121402, includes keys 2-6 & 8-13) ** Plug - R O-ring 3 R Cap - 4 R Valve Seat Insert, Standard Size Intake Valve - R98335 ** Valve Seat Insert, Oversize Intake Valve - R Valve Seat Insert, Standard Size Intake Valve R Valve Seat Insert, Standard Size Exhaust Valve - R93910 ** Valve Seat Insert, Oversize Exhaust Valve - R Valve Seat Insert, Standard Size Exhaust Valve 5 CD Cap - 6 R Pipe Plug, 1/8" H624 1 Pipe Plug, 1/2" - 8 R Intake Valve, Standard - R97490 ** Intake Valve,.015" Oversize - R97491 ** Intake Valve,.030" Oversize - 9 R Exhaust Valve, Standard - R97492 ** Exhaust Valve,.015" Oversize - R97493 ** Exhaust Valve,.030" Oversize - 10 RE Seal - 11 R Spring - 12 RE Rotater - 13 R Retainer - 14 R Head Gasket - 15 R Capscrew 1/2" x 112 mm - **As required 1-47

54 GROUP 1 - ENGINE Cylinder Head M1064H, NL1064H2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP

55 GROUP 1 - ENGINE Cylinder Head M1064H, NL1064H2 1 RE Cylinder Head (marked R503381, includes keys 2-17) - 2 R Keep - 3 R Retainer - 4 R Valve Spring - 5 RE Seal - 6 CD Plug - 7 R Sleeve - 8 R Valve Seat Insert, Exhaust - 9 R Valve Seat Insert, Intake - 10 R Intake Valve - 11 R Exhaust Valve H624 4 Pipe Plug - 13 R Pipe Plug - 14 RE O-ring - 15 RE O-ring - 16 RE Sleeve (includes keys #14-15) - 17 R Cylinder Head Gasket - 18 R Screw

56 updated GROUP 1 - ENGINE Rocker Shaft Assembly & Push Rods L- M- NL1064D, M- NL1064T1, T2, L- M1064A, NL1064H1, M40C2, M55C2, & M65C2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. TP R Plug - 2 R Rocker Arm Shaft - 3 T Washer - 4 T Spring - 5 R Stud M Washer (L-M1064D & T1) - R Washer (L-M1064T2 & A) - 7 R Support M Nut, M10-8 RE Rocker Arm (includes keys 9 & 10) M Nut, M10-10 R Adjusting Stud - 11 R Push Rod - 12 R Cam Follower

57 GROUP 1 - ENGINE Notes 1-51

58 GROUP 1 - ENGINE Rocker Shaft Assembly & Push Rods M1064H, NL1064H2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP

59 Updated GROUP 1 - ENGINE Rocker Shaft Assembly & Push Rods M1064H, NL1064H2 RE Rocker Arm Shaft Assembly (includes keys #1-3, 7-9, 11-14) M Capscrew, M8 x 50-2 R Starter Relay - 3 RE Rocker Arm Shaft - 30M Cap M7096 ** Washer - 5 R Bolt (Tapped M6 x 1.0, formerly #R504636)* - R Bolt (Tapped M8 x 1.25)* - 6 R Strap M Nut, M10-8 RE Rocker Arm, Intake (replaces RE504209, includes key #7) - 9 RE Rocker Arm, Exhaust (includes key #7) - 10 R Cross Bar - 11 R Spring - 12 R Support - R Support (replaces R505159) - 13 R O-ring (use with R505159) - R O-ring (replaces R47154, use with R519740) - 14 R Gasket (marked R121402) - 15 R Push Rod - 16 R Cam Follower - *See Rocker Arm Cover assembly detail **As required 1-53

60 GROUP 1 - ENGINE Rocker Arm Cover L - M1064D, M1064T1,T2, A, M40C2, M55C2, & M65C2 A-8281/ C Rocker Arm Cover Hex Nut, M8 x 1.25 x 53.5 mm Special Flat Washer, M12 S/S O-ring - 5 R Gasket, Rocker Arm Cover Mounting - 6 R Elbow, Vent System Connection O-ring ** Label "Lugger" ** Label "Northern Lights" ** Hose, 3/4" I.D. (sold per inch) ** Vent Elbow - **As required 1-54

61 GROUP 1 - ENGINE Rocker Arm Cover M1064H A-10238/ C Rocker Arm Cover Capscrew, Hex Head Special M6 x 1.0 x 78.8 mm S/S* Capscrew, Hex Head Special M8 x 1.25 x 78.8 mm S/S* Flat Washer, M12 S/S O-ring - 5 R Gasket, Rocker Arm Cover Mounting - 6 R Elbow, Vent System Connection O-ring Label "Northern Lights" ** Hose 3/4" ID (sold per inch) Vent Elbow 3/4" Hose Barb - *Verify thread size. See also Rocker Shaft Assembly. 1-55

62 GROUP 1 - ENGINE Rocker Arm Cover NL1064D, M40C2, & NL1064T1, T2, H1 Rear Fill Front Fill Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. RGP5989, RGP5987 1a RE Rocker Arm Cover, Rear Oil Fill (NL1064D, M40C2) - 1b RE Rocker Arm Cover, Front Fill (NL1064T1, T2, H1) 2 R Gasket - 3 H Plug - 4 R Nut - 5 R O-ring - 6 RE Filler Cap (includes key #7) - 7 R Packing Nameplate "Northern Lights"

63 GROUP 1 - ENGINE Rocker Arm Cover NL1064H2, Early Production Reproduced by permission of Deere & Co., c2006. Deere & Company. All rights reserved. RGP R Rocker Arm Cover - 2 R Deflector M Capscrew, M6 x 16 mm - 4 R Gasket (formerly #R505174) - 5 R Screw, M6 x 1.0 x 12 mm* - 6 R O-ring - 7 H Plug - 8 R Heat Shield M Capscrew, M6 x 12 mm M Capscrew, M12 x 20 mm M Washer - 12 RE Filler Cap (includes key 13) - 13 R Packing Nameplate "Northern Lights" - *See Rocker Arm Assembly detail

64 GROUP 1 - ENGINE Rocker Arm Cover NL1064H2, Late Production Reproduced by permission of Deere & Co., c2006. Deere & Company. All rights reserved. RGP R Rocker Arm Cover - 2 R Deflector M Capscrew, M6 x 16 mm - 4 R Gasket - 5 R Screw, M8 x 1.25 x 12 mm* - 6 R O-ring - 7 H Plug - 8 R Heat Shield M Capscrew, M6 x 12 mm M Capscrew, M12 x 20 mm M Washer - 12 RE Filler Cap (includes key 13) - 13 R Packing Nameplate "Northern Lights" - *See Rocker Arm Assembly detail

65 GROUP 1 - ENGINE Ventilating System NL1064D, T1, T2, H1, & H2 Reproduced by permission of Deere & Co., c2005. Deere & Company. All rights reserved. TP R Elbow Fitting, 90-2 R O-ring - 3 R Clamp M Capscrew, M8 x ** Hose, 3/4" I.D. (sold per inch) - **As required 1-59

66 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake Manifold & Air Filter L- M1064D, M40C2 -TO ROCKER ARM COVER A-3821/ B-1731B 2-0

67 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake Manifold & Air Filter L- M1064D, M40C Intake Manifold Gasket Capscrew, Hex Head, M10 x 1.5 x 75 mm Capscrew, Hex Head, M10 x 1.5 x 95 mm Wave Washer, M Bracket Capscrew, Hex Head 3/ Lock Washer 3/8" Air Filter Hump Hose Hose Clamp # Hose Clamp # Hose Clamp # Hex Plug 1/8 NPT - 15a Spacer (M1064) - 15b Bracket (L1064) Flat Washer 3/ Male Elbow 90 PVC 3/4" Hose Barb ** Hose 3/4" I.D. (sold per inch) Plug, M14 x 1.5 O-ring - **As required 2-1

68 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake and Turbocharger Assembly L1064T1 A-10587/ C

69 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake and Turbocharger Assembly Turbocharger K26 (see parts detail) Gasket Stud, M10 x 1.5 x 30 mm (42 mm LOA) Hex Nut, M10 x 1.5 S/S Wave Washer, M Hose, 2" ID x 1-3/4" 3 Ply Silicone Hose Clamp #28 Extended Band S/S Intake Tube Assembly (includes keys #50-52) Hose 2" ID x 2-3/8" 3 Ply Silicone Intake Manifold Gasket, Intake Port Capscrew, Hex Head M10 x 1.5 x 75 mm Capscrew, Hex Head M10 x 1.5 x 95 mm Wave Washer M Plug, Hex Head Brass 1/8 NPT Gasket, Turbo Oil Return Pipe, Turbo Oil Return (Upper) Capscrew, Hex Head M8 x 1.25 x 20 mm Lock Washer, Helical M Hose 3/4" ID x 4-1/4" 3 Ply Silicone Hose Clamp #12 Extended Band S/S Pipe, Turbo Oil Return (Lower) - 23 R Adapter, O-ring Seal x 1/2 NPT O-ring 3/4" ID x 3/32" - 25 R Adapter, Turbo Oil Supply Gasket Capscrew, Hex Head M8 x 1.25 x 40 mm Male Connector, Steel 3/8 NPT x 3/8-37T Tube Assembly, Turbocharger Oil Supply Male Connector, Steel 3/8-37T x M16 x Elbow 90 Swivel, Steel 3/8-37T Adelle Clamp 3/8" ID x 3/8" Stud Capscrew, Hex Head M8 x 1.25 x 16 mm Lock Washer M Flat Washer M Hump Hose 4-1/8" ID x 2" ID x 1-3/4" Hose Clamp # Hose Clamp # Air Filter Bracket, Air Filter Support Capscrew, Hex Head M10 x 1.5 x 35 mm Lock Washer, Helical M Flat Washer M Hose Clamp # Male Elbow 90 PVC 3/4 HB x 3/4 HB Hose 3/4" ID 1 Ply SAE 100R Female Adapter, Steel 1/8 NPT x M22 x Sealing Washer Copper M Drain Cock Brass 1/8 NPT Intake Tube O-ring Intake Elbow - L1064T1 2-3

70 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake and Turbocharger Assembly M1064T1, M1064T2, M55C2, & M65C2 A-10587/ C

71 2-5 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake and Turbocharger Assembly M1064T1, M1064T2, M55C2, & M65C Turbocharger K26 (M1064T1, M55C2, see parts detail) Turbocharger K26 (M1064T2, M65C2, see parts detail) Gasket Stud, M10 x 1.5 x 30 mm (42 mm LOA) Hex Nut, M10 x 1.5 S/S Wave Washer, M Hose, 2" ID x 1-3/4" 3 Ply Silicone Hose Clamp #28 Extended Band S/S Intake Tube Assembly (includes keys #50-52) Hose 2" ID x 2-3/8" 3 Ply Silicone Intake Manifold Gasket, Intake Port Capscrew, Hex Head M10 x 1.5 x 70 mm Capscrew, Hex Head M10 x 1.5 x 90 mm Wave Washer M Plug, Hex Head Brass 1/8 NPT Gasket, Turbo Oil Return Pipe, Turbo Oil Return (Upper) Capscrew, Hex Head M8 x 1.25 x 20 mm Lock Washer, Helical M Hose 3/4" ID x 4-1/4" 3 Ply Silicone Hose Clamp #12 Extended Band S/S Pipe, Turbo Oil Return (Lower) - 23 R Adapter, O-ring Seal x 1/2 NPT O-ring 3/4" ID x 3/32" - 25 R Adapter, Turbo Oil Supply Gasket Capscrew, Hex Head M8 x 1.25 x 40 mm Male Connector, Steel 3/8 NPT x 3/8-37T Tube Assembly, Turbocharger Oil Supply Male Connector, Steel 3/8-37T x M16 x Elbow 90 Swivel, Steel 3/8-37T Adelle Clamp 3/8" ID x 3/8" Stud Capscrew, Hex Head M8 x 1.25 x 16 mm Lock Washer M Flat Washer M Hump Hose 4-1/8" ID x 2" ID x 1-3/4" Hose Clamp # Hose Clamp # Air Filter Bracket, Air Filter Support Capscrew, Hex Head M10 x 1.5 x 35 mm Lock Washer, Helical M Flat Washer M Hose Clamp # Male Elbow 90 PVC 3/4 HB x 3/4 HB Hose 3/4" ID 1 Ply SAE 100R Female Adapter, Steel 1/8 NPT x M22 x Sealing Washer Copper M Drain Cock Brass 1/8 NPT Intake Tube O-ring Intake Elbow -

72 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Air Filter and Mounting L- M1064A A-10680/ B Air Filter Hump Hose 4-1/8" I.D. x 2" I.D Hose Clamp # Hose Clamp # Bracket M Capscrew, Hex Head Flanged M10 x 1.5 x 25 mm Hose Clamp # Male Elbow 90 PVC 3/4 HB x 3/4 HB Hose 3/4" ID 1 Ply SAE 100R

73 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Air Filter and Mounting M1064H A-10677/ B Air Filter Hump Hose 4-1/8" I.D. x 2" I.D Hose Clamp # Hose Clamp # Bracket M Capscrew, Hex Head Flanged M10 x 1.5 x 30 mm Hose Clamp # Hose Male Union, Brass 3/4 HB Male Elbow, 90 PVC 3/4 HB x 3/4 HB - 2-7

74 Updated & GROUP 2 - INTAKE AND EXHAUST SYSTEMS Crankcase Breather Filter Assembly M1064A Oil Pan A-12094/ B-9426A 2-8

75 Updated & GROUP 2 - INTAKE AND EXHAUST SYSTEMS Crankcase Breather Assembly M1064A Crankcase Breather Filter Bracket M Capscrew, Hex Head Flanged M10 x 1.5 x 25 mm Grade Snubbing Washer S/S Capscrew, Hex Head Flanged M10 x 1.5 x 30 mm Grade Hex Nut, Flanged M10 x R Elbow, /4 HB with o-ring, Vent system connection O-ring 3/4" I.D " Hose 3/4" I.D. Wire reinforced SAE J Female Adapter, Steel 3/4 NPT x 7/8 o-ring port Male Elbow, 90 0 Nylon 3/4 NPT x 3/4 HB Female Swivel, Brass 3/8 HB x 3/8-37T Push-on " Hose 3/8" I.D. Push-on One way Valve, Brass 1/4 NPT x 3/8-37T Street Elbow 90 0, Brass 1/4 NPT Female Adapter, Steel 1/4 NPT x M22 x Hose Clamp # O-ring Lock Nut, Flanged M Elbow, 45 0 Swivel 3/8-37T - 2-9

76 Updated & GROUP 2 - INTAKE AND EXHAUST SYSTEMS Crankcase Breather Filter Assembly M1064H Oil Pan A-12095/ B-9427A 2-10

77 Updated & GROUP 2 - INTAKE AND EXHAUST SYSTEMS Crankcase Breather Assembly M1064H Crankcase Breather Filter Bracket M Capscrew, Hex Head Flanged M10 x 1.5 x 25 mm Grade Flat Washer M Capscrew, Hex Head Flanged M10 x 1.5 x 30 mm Grade Hex Nut, Flanged M10 x R Elbow, /4 HB with o-ring, Vent system connection O-ring 3/4" I.D " Hose 3/4" I.D. Wire reinforced SAE J Female Adapter, Steel 3/4 NPT x 7/8 o-ring port Male Elbow, 90 0 Nylon 3/4 NPT x 3/4 HB Female Swivel, Brass 3/8 HB x 3/8-37T Push-on " Hose 3/8" I.D. Push-on One way Valve, Brass 1/4 NPT x 3/8-37T Street Elbow 90 0, Brass 1/4 NPT Female Adapter, Steel 1/4 NPT x M22 x Hose Clamp # O-ring Lock Nut, Flanged M Elbow, 45 0 Swivel 3/8-37T

78 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake and Aftercooler Assembly L- M1064A A-10284/ C

79 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake and Aftercooler Assembly L- M1064A Manifold, Intake & Aftercooler O-ring Capscrew, Hex Head Flanged M10 x 1.5 x 30 mm Element, Intake Aftercooler O-ring Aftercooler Cover M Capscrew, Hex Head Flanged M8 x 1.25 x 16 mm (Grade 10) Capscrew, Hex Head M8 x 1.25 x 180 mm (Grade 8.8) Capscrew, Hex Head M8 x 1.25 x 180 mm (Grade 8.8) Flat Washer M8 S/S Aftercooler Cover Aftercooler Cover O-ring Plate, Threaded (3 Places) Plate, Threaded (2 Places) M Capscrew, Hex Head Flanged M8 x 1.25 x 20 mm (Grade 10) M Capscrew, Hex Head Flanged M8 x 1.25 x 25 mm (Grade 10) M Hex Nut, Flanged M8 x Connector, Raw Water Pump Outlet Connector, Aftercooler Outlet O-ring Plug, Socket Head Brass, 1/8 NPT Drain Cock Brass 1/4 NPT Hose 2" ID x 3-3/4" 3 Ply Silicone Hose Clamp #32 Extended Band Tube, Heat Exchanger Inlet M Capscrew, Hex Head Flanged M10 x 1.5 x 45 mm (Grade 10) Capscrew, Hex Head M12 x 1.75 x 35 mm Wave Washer M Connector, Aftercooler Intake Gasket, Aftercooler Mounting Capscrew, Hex Head M10 x 1.5 x 140 mm Wave Washer M Capscrew, Hex Head Flanged M10 x 1.5 x 35 mm Male Connector, S/S 3/8-37T x 3/8 OR Port Tube Assembly, Aftercooler Condensate Drain Drain, Aftercooler Condensate Adelle Clamp, 3/8" I.D. x 3/8" Stud Capscrew, Hex Head M8 x 1.25 x 20 mm S/S Lock Washer, Helical M8 S/S Flat Washer, M8 S/S

80 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake and Turbocharger Assembly L1064A A-11068/ C-5550z 2-14

81 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake and Turbocharger Assembly L1064A Turbocharger K26, L1064A (see parts detail) Gasket Stud, M10 x 1.5 x 30 mm (42 mm LOA) Hex Nut, M10 x 1.5 S/S Wave Washer, M Gasket, Turbo Oil Return Tube, Turbo Oil Return Capscrew, Hex Head M8 x 1.25 x 20 mm Lock Washer, M Hose, 3/4" I.D. x 4-1/4" Hose Clamp # Pipe, Turbo Oil Return (Lower) - 13 R Adapter, O-ring Seal x 1/2 NPT O-ring - 15 R Adapter, Turbo Oil Supply Gasket Capscrew, Hex Head M8 x 1.25 x 40 mm Male Connector, Steel 3/8 NPT x 3/8-37T Tube Assembly, Turbo Oil Supply Male Elbow, 90 Steel 3/8-37T x M16 x M O-ring Adelle Clamp 3/8" I.D. x 3/8" Stud Capscrew, Hex Head M8 x 1.25 x 16 mm Lock Washer, Helical M Flat Washer M Female Adapter, Steel 1/8 NPT x M22 x Sealing Washer, Copper M Drain Cock, Brass 1/8 NPT Tube, Air Inlet K O-ring 2-7/8" I.D Hose, 2" I.D. x 2-3/8" Hose Clamp #28 Extended Band S/S Elbow Retaining Clip Capscrew, Hex Head M8 x 1.25 x 20 mm Wave Washer M

82 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake and Turbocharger Assembly M1064A A-10823, A-10423/ C

83 GROUP 2 - INTAKE AND EXHAUST SYSTEMS Intake and Turbocharger Assembly M1064A Turbocharger K26, RPM (see parts detail) Turbocharger K26, RPM (see parts detail) Gasket Stud, M10 x 1.5 x 30 mm (42 mm LOA) Hex Nut, M10 x 1.5 S/S Wave Washer, M Gasket, Turbo Oil Return Tube, Turbo Oil Return Capscrew, Hex Head M8 x 1.25 x 20 mm Lock Washer, M Hose, 3/4" I.D. x 4-1/4" Hose Clamp # Pipe, Turbo Oil Return (Lower) - 13 R Adapter, O-ring Seal x 1/2 NPT O-ring - 15 R Adapter, Turbo Oil Supply Gasket Capscrew, Hex Head M8 x 1.25 x 40 mm Male Connector, Steel 3/8 NPT x 3/8-37T Tube Assembly, Turbo Oil Supply Male Elbow, 90 Steel 3/8-37T x M16 x 1.5 (includes key 21) M O-ring Adelle Clamp 3/8" I.D. x 3/8" Stud Capscrew, Hex Head M8 x 1.25 x 16 mm Lock Washer, Helical M Flat Washer M Female Adapter, Steel 1/8 NPT x M22 x Sealing Washer, Copper M Drain Cock, Brass 1/8 NPT Tube, Air Inlet K O-ring 2-7/8" I.D Hose, 2" I.D. x 2-3/8" Hose Clamp #28 Extended Band S/S Elbow Retaining Clip Capscrew, Hex Head M8 x 1.25 x 20 mm Wave Washer M

Marine Generators Marine Diesel Engines Land-Based Generators

Marine Generators Marine Diesel Engines Land-Based Generators P1066 For Models: L1066T, L1066A, L1066H, M1066T, M1066A1, M1066A2, M1066A3, M1066H, M1066TMCA, NL1066T, NL1066H1, NL1066H2, NL1066H3, NL1066H4, and M99C2 PARTS CATALOG Marine Generators Marine Diesel

More information

P1276 For Models: L1276, M1276, and NL1276 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators

P1276 For Models: L1276, M1276, and NL1276 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators P1276 For Models: L1276, M1276, and NL1276 PARTS CATALOG Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents

More information

P773-2 For Model: M773LW2 PARTS MANUAL. Marine Generators Marine Diesel Engines Land-Based Generators

P773-2 For Model: M773LW2 PARTS MANUAL. Marine Generators Marine Diesel Engines Land-Based Generators P773-2 For Model: M773LW2 PARTS MANUAL Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents are known to the

More information

P843NSATS For Models: NL843N2, NL843NW2, and NL843NW3 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators

P843NSATS For Models: NL843N2, NL843NW2, and NL843NW3 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators P843NSATS For Models: NL843N2, NL843NW2, and NL843NW3 PARTS CATALOG Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its

More information

P844L3MS For Models: NL844L3.1MS1 and NL844L3.1MS2 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators

P844L3MS For Models: NL844L3.1MS1 and NL844L3.1MS2 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators P844L3MS For Models: NL844L3.1MS1 and NL844L3.1MS2 PARTS CATALOG Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents

More information

P864 For Models: M864K, M864W, and M864W3 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators

P864 For Models: M864K, M864W, and M864W3 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators P864 For Models: M864K, M864W, and M864W3 PARTS CATALOG Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents

More information

P753-2 For Models: M753W2 and NL753W2 PARTS MANUAL. Marine Generators Marine Diesel Engines Land-Based Generators

P753-2 For Models: M753W2 and NL753W2 PARTS MANUAL. Marine Generators Marine Diesel Engines Land-Based Generators P753-2 For Models: M753W2 and NL753W2 PARTS MANUAL Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents are

More information

PARTS MANUAL P For Models: NL773LW4 and NL773LW4E.

PARTS MANUAL P For Models: NL773LW4 and NL773LW4E. PARTS MANUAL P773-4 For Models: NL773LW4 and NL773LW4E www.northern-lights.com CALIFORNIA Proposition 65 Warning: Breathing Diesel engine exhaust and some of its constituents are known to the State of

More information

PARTS MANUAL P For Models: M843NW3 and NL843NW3.

PARTS MANUAL P For Models: M843NW3 and NL843NW3. PARTS MANUAL P843-3 For Models: M843NW3 and NL843NW3 www.northern-lights.com CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents are known to the State of California to

More information

P843-2 For Models: M843NW2 and NL843NW2 PARTS MANUAL. Marine Generators Marine Diesel Engines Land-Based Generators

P843-2 For Models: M843NW2 and NL843NW2 PARTS MANUAL. Marine Generators Marine Diesel Engines Land-Based Generators P843-2 For Models: M843NW2 and NL843NW2 PARTS MANUAL Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents

More information

P984 For Models: M984K, ML984, L984, M30C, M984W and M33CW OPERATOR S MANUAL. Marine Generators Marine Diesel Engines Land-Based Generators

P984 For Models: M984K, ML984, L984, M30C, M984W and M33CW OPERATOR S MANUAL. Marine Generators Marine Diesel Engines Land-Based Generators P984 For Models: M984K, ML984, L984, M30C, M984W and M33CW OPERATOR S MANUAL Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some

More information

P864 For Models: M864K, M864W, and M864W3 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators

P864 For Models: M864K, M864W, and M864W3 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators P864 For Models: M864K, M864W, and M864W3 PARTS CATALOG Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents

More information

PARTS MANUAL P For Models: L844D, M844W3, M844LW3, NL844W3, NL844LW and M20CRW3.

PARTS MANUAL P For Models: L844D, M844W3, M844LW3, NL844W3, NL844LW and M20CRW3. PARTS MANUAL P844-3 For Models: L844D, M844W3, M844LW3, NL844W3, NL844LW and M20CRW3 www.northern-lights.com CALIFORNIA Proposition 65 Warning: Breathing Diesel engine exhaust and some of its constituents

More information

P673L For Models: M673L and NL673L PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators

P673L For Models: M673L and NL673L PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators P673L For Models: M673L and NL673L PARTS CATALOG Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents are

More information

P844K For Models: M844K, M844LK, NL844K, NL844LK, M16C, M20CL, & M20CR PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators

P844K For Models: M844K, M844LK, NL844K, NL844LK, M16C, M20CL, & M20CR PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators P844K For Models: M844K, M844LK, NL844K, NL844LK, M16C, M20CL, & M20CR PARTS CATALOG Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust

More information

P843K For Models: M843NK, NL843NK, M843JK, and NL843JK PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators

P843K For Models: M843NK, NL843NK, M843JK, and NL843JK PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators P843K For Models: M843NK, NL843NK, M843JK, and NL843JK PARTS CATALOG Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its

More information

PARTS MANUAL P For Models: M773LW3 and NL773LW3.

PARTS MANUAL P For Models: M773LW3 and NL773LW3. PARTS MANUAL P773-3 For Models: M773LW3 and NL773LW3 www.northern-lights.com CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents are known to the State of California to

More information

P673-2 For Models: M673LD2, M673L2, NL673L2, M673LD3, M673L3 and NL673L3 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators

P673-2 For Models: M673LD2, M673L2, NL673L2, M673LD3, M673L3 and NL673L3 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators P673-2 For Models: M673LD2, M673L2, NL673L2, M673LD3, M673L3 and NL673L3 PARTS CATALOG Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust

More information

PARTS MANUAL P For Models: M773LW3, M773LW3G and NL773LW3.

PARTS MANUAL P For Models: M773LW3, M773LW3G and NL773LW3. PARTS MANUAL P773-3 For Models: M773LW3, M773LW3G and NL773LW3 www.northern-lights.com CALIFORNIA Proposition 65 Warning: Breathing Diesel engine exhaust and some of its constituents are known to the State

More information

PARTS MANUAL P For Models: M673L2, M673L3, M673LD2, M673LD3, NL673L2 and NL673L.

PARTS MANUAL P For Models: M673L2, M673L3, M673LD2, M673LD3, NL673L2 and NL673L. PARTS MANUAL P673-2 For Models: M673L2, M673L3, M673LD2, M673LD3, NL673L2 and NL673L www.northern-lights.com CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some of its constituents are known

More information

Service Parts. John Deere 3029DF 3029TF 3029TF270. Engine. Engine Models: Generator Models: 20ROZJB REOZJB 20DSJB DSEJB.

Service Parts. John Deere 3029DF 3029TF 3029TF270. Engine. Engine Models: Generator Models: 20ROZJB REOZJB 20DSJB DSEJB. Service Parts Engine Engine Models: John Deere 3029DF 3029TF 3029TF270 Generator Models: 20ROZJB 20--40REOZJB 20DSJB 20--40DSEJB TP- 12/03b Table of Contents Description Page Description Page Introduction...

More information

P65C-3 For Models: M50C13, M50T13, M55C13, M65C13 and M65T13 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators

P65C-3 For Models: M50C13, M50T13, M55C13, M65C13 and M65T13 PARTS CATALOG. Marine Generators Marine Diesel Engines Land-Based Generators P65C-3 For Models: M50C13, M50T13, M55C13, M65C13 and M65T13 PARTS CATALOG Marine Generators Marine Diesel Engines Land-Based Generators CALIFORNIA Proposition 65 Warning: Diesel engine exhaust and some

More information

Service Parts. John Deere 6068HFG08. Engine. Engine Models: Generator Models: 125/150REOZJ4 145/175REOZT4 TP /15

Service Parts. John Deere 6068HFG08. Engine. Engine Models: Generator Models: 125/150REOZJ4 145/175REOZT4 TP /15 Service s Engine Engine Models: John Deere 6068HFG08 Generator Models: 125/150REOZJ4 145/175REOZT4 Table of Contents Subject Page Subject Page Introduction... 3 Group 42: DEF Line... 27 Numbering System

More information

Illustrated Parts List. 58A400 to 58A499 TURBO DIESEL

Illustrated Parts List. 58A400 to 58A499 TURBO DIESEL Illustrated Parts List Model Series 58A400 to 58A499 TURBO DIESEL FORM MS 5473 12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT. 2 OF SERVICE MANUAL 58A400 to 58A499 TYPE NUMBERS 0205, 0209, 0210,

More information

REQUIRES SPECIAL TOOLS TO INSTALL. SEE REPAIR INSTRUCTION MANUAL. 411 718 38 3 1027 1 127 127 127A 1080 1081 1028 127 718A 127 718 44B 718A 2 44A 493 44 1069 112 718B 1019 LABEL KIT 1058 OWNER S MANUAL

More information

Appendix 3 Exploded Views and Parts Lists

Appendix 3 Exploded Views and Parts Lists Engine, Alternator Drive and Starter Assembly Drawing No. 0D5057-A 40 Generac Power Systems, Inc. Engine, Alternator Drive and Starter Assembly Drawing No. 0D5057-A 1 0C5598 1 BEARING CARRIER, FRONT 2

More information

Genset. Parts Catalog GHAB. Parts Manual

Genset. Parts Catalog GHAB. Parts Manual Genset Parts Manual Parts Catalog To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate

More information

TD 3.6 L4. Parts Manual. Deutz Engine. Telescopic Handlers. Gehl RS6-34 (Tier IV) Manitou MT6034 T (Tier IV)

TD 3.6 L4. Parts Manual. Deutz Engine. Telescopic Handlers. Gehl RS6-34 (Tier IV) Manitou MT6034 T (Tier IV) TD 3.6 L4 Form No. 50960088 Revision A September 04 Deutz Engine Telescopic Handlers Gehl RS6-34 (Tier IV) Manitou MT6034 T (Tier IV) Parts Manual Introduction Deutz TD 3.6 L4 The Table of Contents pages

More information

Parts Catalog MDKBD MDKBE MDKBF

Parts Catalog MDKBD MDKBE MDKBF Parts Catalog MDKBD MDKBE MDKBF Printed U.S.A. /0 00C To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference,

More information

Genset. Parts Catalog HDKAG

Genset. Parts Catalog HDKAG Genset Parts Catalog HDKAG To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information

More information

O-540-F1B5 SERIES PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

O-540-F1B5 SERIES PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES INTRODUCTION This illustrated parts catalog contains a complete parts listing for the Lycoming O-540-F1B5 series wide cylinder flange crankcase model aircraft engines. Major assembly and sub-assembly parts

More information

Spare Parts List. EW-3500-C and D EW-4200-C and D Marine Diesel Generators

Spare Parts List. EW-3500-C and D EW-4200-C and D Marine Diesel Generators ENTEC WEST, INC. Spare Parts List EW-3500-C and D EW-4200-C and D Marine Diesel Generators Every generator produced by Entec West, Inc. has been recorded in a master computer file by serial number. This

More information

MARINE ILLUSTRATED PARTS MANUAL

MARINE ILLUSTRATED PARTS MANUAL MARINE ILLUSTRATED PARTS MANUAL MODEL MP454 XLi SERIAL NUMBER 101810 THRU 103880 MODEL MP7.4L SERIAL NUMBER 103538 AND ABOVE L510008 10/01 This Page Was Intentially Left Blank Contents: MODEL MP7.4L PARTS

More information

Parts Manual. RV Generator Set. HDCAA (Spec A D) HDCAB (Spec A D) English Original Instructions (Issue 9)

Parts Manual. RV Generator Set. HDCAA (Spec A D) HDCAB (Spec A D) English Original Instructions (Issue 9) Parts Manual RV Generator Set HDCAA (Spec A D) HDCAB (Spec A D) English Original Instructions 0-0 9 09 (Issue 9) Introduction This parts catalog applies to the standard generator sets listed below. Parts

More information

Parts Catalog MDKBP MDKBR MDKBS

Parts Catalog MDKBP MDKBR MDKBS Parts Catalog MDKBP MDKBR MDKBS Printed U.S.A. 0 0 To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert

More information

Service Parts. Doosan 11.1 L. Engine. Engine Model: Generator Models: 180/200REZX 180/200RZX TP /09

Service Parts. Doosan 11.1 L. Engine. Engine Model: Generator Models: 180/200REZX 180/200RZX TP /09 Service Parts Engine Engine Model: Doosan. L Generator Models: 80/00REZX 80/00RZX TP-0 /09 Table of Contents Introduction... Numbering System Significance... Illustrations... How to Find Part Numbers...

More information

Parts Catalog. Generator Set TGHAA (Spec A C) Printed in U.S.A. Replaces (Spec A) 1 97

Parts Catalog. Generator Set TGHAA (Spec A C) Printed in U.S.A. Replaces (Spec A) 1 97 Parts Catalog TGHAA Generator Set Printed in U.S.A. 9 00 (Spec A C) 9 Replaces 9 00 (Spec A) 97 To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from

More information

FORD - Cyl Block and Related Parts

FORD - Cyl Block and Related Parts FORD - Cyl Block and Related Parts Ref Description Qty All 302 Qty 351 Qty 351-HP 1 BLOCK ASSEMBLY 1 59-4046 1 59-4047 1 59-4047 2 PLUG - 1½ CUP - BRASS 6 59-4048 6 59-4048 6 59-4048 3 PLUG - OIL PASSAGE

More information

Engine Parts Manual. Kubota Diesel Engine D1305-E3B-TXRN-1 WARNING Rev A

Engine Parts Manual. Kubota Diesel Engine D1305-E3B-TXRN-1 WARNING Rev A 9 8 9 0 8 - INCLUDES ITEMS - 0-Rev A Engine Parts Manual Kubota Diesel Engine D0-EB-TXRN- WARNING If incorrectly used, this machine can cause severe injury. Those who use and maintain this machine should

More information

LYCOMING A Textron Company

LYCOMING A Textron Company LYCOMING AEIO-360-HB PARTS CATALOG This illustrated parts catalog contains a complete parts listing for the Lycoming AEIO-360-HB wide cylinder flange crankcase model aircraft engines. Major assembly and

More information

Illustrated Parts List

Illustrated Parts List FORM MS 4183 10/31/2006 REPLACES FORM MS 9748 7/1997 FILE IN SECT. 2 OF SERVICE MANUAL 290700 Illustrated Parts List Model Series 290700 TYPE NUMBERS 0100, 0102, 0106, 0107, 0108, 0333, 0402, 0410. TO

More information

Illustrated Parts List to

Illustrated Parts List to TYPE NUMBERS 0022 through 0035, 0040 through 0062, 0070, 0076,0100, 0102, 0120 through 0125, 0307, 0318,0320, 0326, 0340 through 0366, 0370 through 0378, 0382, 0385, 0390, 0391, 0394, 0398, 0402, Illustrated

More information

PARTS MANUAL SUPPORTED BY HUSTLER TURF EQUIPMENT AND EXCEL INDUSTRIES, INC.

PARTS MANUAL SUPPORTED BY HUSTLER TURF EQUIPMENT AND EXCEL INDUSTRIES, INC. SHIBAURA DIESEL ENGINE MODEL: N843 and N843L PARTS MANUAL SUPPORTED BY HUSTLER TURF EQUIPMENT AND EXCEL INDUSTRIES, INC. Table of Contents Chapter 1 General Information....................................

More information

Lycoming AIRCRAFT ENGINES. IO-540-AC1A5 Wide Series Flange Crankcase Model Engine PARTS CATALOG PC

Lycoming AIRCRAFT ENGINES. IO-540-AC1A5 Wide Series Flange Crankcase Model Engine PARTS CATALOG PC AIRCRAFT ENGINES IO-540-ACA5 Wide Series Flange Crankcase Model Engine PARTS CATALOG PC-5- November 008 Lycoming 5 Oliver Street Williamsport, PA 770 U.S.A. 570/33-8 IO-540-ACA5 PARTS CATALOG This illustrated

More information

Service Parts 4CCFOZ 4/6.5EFOZ 5CCOZ 5/8EOZ. Marine Generator Sets. Models: TP /05c. Specification Series 126

Service Parts 4CCFOZ 4/6.5EFOZ 5CCOZ 5/8EOZ. Marine Generator Sets. Models: TP /05c. Specification Series 126 Service Parts Marine Generator Sets Models: 4CCFOZ 4/6.5EFOZ 5CCOZ 5/8EOZ Specification Series 126 TP-5616 9/05c Description Page Introduction... 3 Numbering System Significance... 3 Illustrations... 3

More information

O-540-A4B5 PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

O-540-A4B5 PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES INTRODUCTION This illustrated parts catalog contains a complete parts listing for the Lycoming O-540-A4B5 wide cylinder flange crankcase model aircraft engines. Major assembly and sub-assembly parts of

More information

Parts Catalog MDKAU. Printed U.S.A C

Parts Catalog MDKAU. Printed U.S.A C Parts Catalog Printed U.S.A. 00 0C To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate

More information

Carrier Transicold Diesel Engine CT4-91-TV (V1505) Service Parts List Rev A

Carrier Transicold Diesel Engine CT4-91-TV (V1505) Service Parts List Rev A Carrier Transicold Diesel Engine CT--TV (V0) Service Parts List -0 Rev A Service Parts List DIESEL ENGINE CT--TV (V0) CONTENTS INTRODUCTION... REPLACEMENT ENGINE PART NO.... ORDERING INSTRUCTIONS... GENERAL

More information

STX-26 Stump Grinder

STX-26 Stump Grinder Form No. 3383-656 Rev B STX-26 Stump Grinder Model No. 23208 Serial No. 314000001 and Up Model No. 23208G Serial No. 314000001 and Up Register at www.toro.com. Original Instructions (EN) *3383-656* B Ordering

More information

TEXTRON Lycoming AIRCRAFT ENGINES

TEXTRON Lycoming AIRCRAFT ENGINES TEXTRON Lycoming AIRCRAFT ENGINES O-60-AP Wide Cylinder Flange Crankcase Model Engines PARTS CATALOG PC-06-6 MARCH 99 0-60-AP PARTS CATALOG This illustrated parts catalog contains a complete parts listing

More information

Illustrated Parts List

Illustrated Parts List FORM MS 2264 07/20/2005 REPLACES FORM MS 2264 03/04/2005 FILE IN SECT. 2 OF SERVICE MANUAL 350700 Illustrated Parts List Model Series 350700 TYPE NUMBERS 0034 through 1171. TABLE OF CONTENTS Air Cleaner.........................

More information

Parts Manual. Marine Generator Set. MDKAL (Spec A C) English Original Instructions (Issue 4)

Parts Manual. Marine Generator Set. MDKAL (Spec A C) English Original Instructions (Issue 4) Parts Manual Marine Generator Set MDKAL (Spec A C) English Original Instructions 00 0 (Issue ) To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from

More information

Parts Catalog

Parts Catalog R Ingersoll Parts Catalog 8-3112 COMPACT TRACTORS WITH VANGUARD ENGINES 3012 - PIN 14145700 AND AFTER 3014 - PIN 14146700 AND AFTER 3016 - PIN 14147800 AND AFTER 3018 - ALL 4016 - PIN 14170800 AND AFTER

More information

UNIVERSAL ATOMIC DIESEL MODEL (16 H.P.) PARTS MANUAL. Universal Motors

UNIVERSAL ATOMIC DIESEL MODEL (16 H.P.) PARTS MANUAL. Universal Motors UNIVERSAL ATOMIC DIESEL MODEL 20 5416 (16 H.P.) PARTS MANUAL Universal Motors This copy of the Universal Motors Owners Manual has been re-created using images computer scanned from a manual rather than

More information

Illustrated Parts List to

Illustrated Parts List to Illustrated Parts List Model Series 176400 to 176499 TYPE NUMBERS 0035, 0049, 0050, 0101, 0103, 0113, 0114, 0115, 0116. FORM MS 0419 9/97 REPLACES FORM MS 0419 5/97 FILE IN SECT. 2 OF SERVICE MANUAL 176400

More information

STX-26 Stump Grinder

STX-26 Stump Grinder Form No. 3365-311 Rev B STX-26 Stump Grinder Model No. 23210 Serial No. 310000001 and Up Model No. 23210G Serial No. 310000001 and Up Register at www.toro.com. Original Instructions (EN) *3365-311* B Ordering

More information

E70PL4EEC 1999 : CAMSHAFT [1/23] Page 1 of 49

E70PL4EEC 1999 : CAMSHAFT [1/23] Page 1 of 49 E70PL4EEC 1999 : CAMSHAFT [1/23] Page 1 of 49 E70PL4EEC 1999 : CAMSHAFT [1/23] 1 5030657 1 CAMSHAFT 2 5030658 1 PLATE, Camshaft thrust 3 5030549 1 SEAL, Camshaft 4 5030989 2 BOLT, Plate 5 5030663 8 ARM,

More information

PARTS CATALOG

PARTS CATALOG R Ingersoll COMPACT TRACTORS WITH DIESEL ENGINES 3118D AND 4118D PARTS CATALOG 8-3310 PAINT ENGINES GENERAL INFO MODEL 3118D and 4118D COMPACT TRACTORS PRODUCT IDENTIFICATION NUMBERS (PIN) OR SERIAL NUMBERS

More information

Illustrated Parts List to

Illustrated Parts List to TYPE NUMBERS 0101, 0102, 0106, 0108, 0109, 0115 through 0224, 0415, 0418, 0467, 0468, 0601 through 0683, 3101 through 3108, 3110 through 3163, 3167 through 3181. Illustrated Parts List Model Series 124700

More information

Mfg. No: 12S F8

Mfg. No: 12S F8 Parts Manual Mfg. No: 12S452-0049-F8 Copyright Briggs and Stratton. All Rights reserved 03-Oct-2017 Model Components Table Of Contents Page Air Cleaner, Exhaust System...........................................................................

More information

For Discount Tecumseh Engine Parts Call or HH E Page 1 of 8 Engine Parts List #1

For Discount Tecumseh Engine Parts Call or HH E Page 1 of 8 Engine Parts List #1 HH60-105080E Page 1 of 8 Engine Parts List #1 HH60-105080E Page 2 of 8 Engine Parts List #1 1 34761 0 Cylinder Assy. (Cast iron liner) (2-5/8" 2 27652 0 Pin, Dowel 3 27642 0 Plug, Drain 4 27876B 0 Seal,

More information

Parts Catalog. Marine Generator Set. MDKBT (Spec A) MDKBU (Spec A) English (Issue 2)

Parts Catalog. Marine Generator Set. MDKBT (Spec A) MDKBU (Spec A) English (Issue 2) Parts Catalog Marine Generator Set MDKBT (Spec A) MDKBU (Spec A) English 00 0 (Issue ) To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan

More information

Illustrated Parts List to

Illustrated Parts List to Illustrated Parts List Model Series TYPE NUMBERS 0111 through 0199, 0200 through 0213, 0300 through 0353, 1345,1353, 2035 through 2073, 2135 through 2174, 4001 through 4090, 5001, 5005, 5006, 5035 through

More information

Illustrated Parts List

Illustrated Parts List FORM MS 6217 7C 1/2003 REPLACES FORM MS 6217 3C 2/2001 FILE IN SECT. 2 OF SERVICE MANUAL Illustrated Parts List Model Series TYPE NUMBERS 0023 through 0242. For Use On Engines Built Before Date Code 03010100

More information

Illustrated Parts List

Illustrated Parts List FORM MS 0670 3C 8/2001 REPLACES FORM MS 0670 2Q 11/2000 FILE IN SECT. 2 OF SERVICE MANUAL Illustrated Parts List Model Series TYPE NUMBERS 0042 through 1256. For Use On Engines Built Before Date Code 01070100.

More information

Lycoming Aircraft Engines Parts Catalog

Lycoming Aircraft Engines Parts Catalog Aircraft Engines Parts Catalog IO-0-BG Wide Cylinder Flange Crankcase Model Engine Part No. PC-0- Oliver Street Williamsport, PA 770 Aircraft Engines Parts Catalog IO-0-BG Wide Cylinder Flange Crankcase

More information

JCB Engine Tier III Parts

JCB Engine Tier III Parts GVF JCB Engine Tier III Parts 3033 Benzie Hwy. Benzonia, MI 49616 231-882-5921 Fax 231-882-5637 www.gillisons.com 800-392-6059 2 JCB TIER III ENGINE PARTS 1 MAIN INDEX TITLE PAGE NUMBER CHANGE NUMBER A

More information

EXPLODED VIEW BASE AND PULLEYS Drawing No

EXPLODED VIEW BASE AND PULLEYS Drawing No Generac NP-50LPG EXPLODED VIEW BASE AND PULLEYS Drawing No. 95865 20 Generac NP-50LPG REPAIR PARTS BASE AND PULLEYS Drawing No. 95865 ITEM DESCRIPTION PART NO. QTY. ITEM DESCRIPTION PART NO. QTY. 1 BASE,

More information

PUBLICATION REVISION

PUBLICATION REVISION Lycomlng 65 Oliver Street Williamsport, PA 770 U.S.A. 77/-6 TECHNICAL PUBLICATION REVISION REVISIOI No. PUBLICATION PUBLICATION No. PUBLICATION DATE IO-60-LA PC-06-A Engines PC-06- MAY, 996 This page(s)

More information

Illustrated Parts List 31L700

Illustrated Parts List 31L700 FORM MS 5070 06/30/2004 REPLACES FORM MS 5070 02/20/2004 FILE IN SECT. 2 OF SERVICE MANUAL 31L700 Illustrated Parts List Model Series 31L700 TYPE NUMBERS 0036 Through 0192 TABLE OF CONTENTS Alternator..........................

More information

GREAVES COTTON LTD. SPARE PARTS CATALOGUE. G SERIES 3G11Tx - ENGINE GREAVES COTTON LTD.

GREAVES COTTON LTD. SPARE PARTS CATALOGUE. G SERIES 3G11Tx - ENGINE GREAVES COTTON LTD. GREAVES COTTON LTD. SPARE PARTS CATALOGUE G SERIES 3G11Tx - ENGINE GREAVES COTTON LTD. Diesel Engines Unit, Chinchwad, Pune 411019, India, Tel: (91) 20 27473564 Fax: (91) 20-27472276 Document number. P

More information

Illustrated Parts List

Illustrated Parts List FORM MS 3388 6C 01/02/2003 REPLACES FORM MS 3388 3Q 10/2001 FILE IN SECT. 2 OF SERVICE MANUAL 121400 Illustrated Parts List Model Series 121400 TYPE NUMBERS 0014 through 0269. TABLE OF CONTENTS Air Cleaner.........................

More information

Replacement Engine Kit Diesel-Powered Workman 3000/4000 Series Utility Vehicle

Replacement Engine Kit Diesel-Powered Workman 3000/4000 Series Utility Vehicle Form Number 3362-384 Rev A Replacement Engine Kit Diesel-Powered Workman 3000/4000 Series Utility Vehicle Model No. 117-4986 Parts Catalog Ordering Replacement Parts To order replacement parts, please

More information

Illustrated Parts List to

Illustrated Parts List to TYPE NUMBERS 0001 through 0026, 0027 through 0049, 0059 through 0075, 0079 through 0093, 0105 through 0128, 0129 through 0169, 0171 through 0200, 0202 through 0217, 0219 through 0238, 0240 through 0256,

More information

Page 1 of HP B&S Vanguard Engine

Page 1 of HP B&S Vanguard Engine 1405 Page 1 of 41 14 HP B&S Vanguard Engine 1405 Page 2 of 41 14 HP B&S Vanguard Engine Ref # Part Number Qty S/P/F Description BS-28Q777-0647-E1 1 14 HP B&S Vanguard Engine 1 BS-496412 1 Cylinder Assembly

More information

Illustrated Parts List

Illustrated Parts List FORM MS 5349 4C 8/2002 REPLACES FORM MS 5349 3C 1/2001 FILE IN SECT. 2 OF SERVICE MANUAL 110400 Illustrated Parts List Model Series 110400 TYPE NUMBERS 0023 through 0224. For Use On Engines Built Before

More information

Illustrated Parts List to

Illustrated Parts List to Illustrated Parts List Vanguard Model Series 161400 to 161499 TYPE NUMBERS 0010 through 0036, 0040, 0041, 0047, 0049, 0051, 0070, 0073, 0079 through 0085, 0090, 0101, 0110 through 0135, 0199. FORM MS 9877

More information

Service Parts 28/32EOZD 23/27EFOZD 25/28EFOZD. Marine Generator Sets. Models: TP /09b

Service Parts 28/32EOZD 23/27EFOZD 25/28EFOZD. Marine Generator Sets. Models: TP /09b Service Parts Marine Generator Sets Models: 28/32EOZD 23/27EFOZD 25/28EFOZD TP-6273 2/09b Description Page Introduction... 3 Numbering System Significance... 3 Illustrations... 3 How to Find Part Numbers...

More information

Illustrated Parts List to

Illustrated Parts List to Illustrated Parts List Model Series 171400 to 171499 TYPE NUMBERS 0035 through 0131, 0235, 0249, 0270, 0300 through 0308, 0435 through 0470, 0500 through 0505, 0520 through 0535, 1035, 1049, 1070, 1100,

More information

Illustrated Parts List

Illustrated Parts List FORM MS 56 08/11/2004 REPLACES FORM MS 56 11/14/2002 FILE IN SECT. 2 OF SERVICE MANUAL 312700 Illustrated Parts List Model Series 312700 TYPE NUMBERS 0101 through 01. TABLE OF CONTENTS Air Cleaner.........................

More information

Replacement Engine Kit Reelmaster

Replacement Engine Kit Reelmaster Form Number 3361-327 Rev A Replacement Engine Kit Reelmaster 5400-D/5500-D Traction Unit Model No. 115-8009 Parts Catalog Ordering Replacement Parts To order replacement parts, please supply the part number,

More information

DIAMO TURISTA 300CC ENGINE PARTS CATALOG. Second Edition March 2008

DIAMO TURISTA 300CC ENGINE PARTS CATALOG. Second Edition March 2008 DIAMO TURISTA 300CC ENGINE PARTS CATALOG Second Edition March 2008 Copyright 2004-2008 LS MotorSports, LLC. Reproduction without written permission is completely forbidden. The information and diagrams

More information

Illustrated Parts List

Illustrated Parts List FORM MS 2263 12/08/2004 REPLACES FORM MS 2263 03/20/2004 FILE IN SECT. 2 OF SERVICE MANUAL Illustrated Parts List Model Series TYPE NUMBERS 0001 through 1421. TABLE OF CONTENTS Air Cleaners........................

More information

5.7L ENGINE PARTS BOOK. Not for. Reproduction

5.7L ENGINE PARTS BOOK. Not for. Reproduction 5.7L ENGINE PARTS BOOK Engine Model: Engine Family: PSI, Industrial Engine Spec N.: 39004120-39004248 Parts Book Revision: December, 2015 TABLE OF CONTENTS SECTION PAGE CYLINDER BLOCK... 3-5 CYLINDER HEAD...

More information

Illustrated Parts List

Illustrated Parts List FORM MS 54 08/11/2004 REPLACES FORM MS 54 11/14/2002 FILE IN SECT. 2 OF SERVICE MANUAL 311700 Illustrated Parts List Model Series 311700 TYPE NUMBERS 0005 through 0209. TABLE OF CONTENTS Air Cleaner.........................

More information

Reproduction. Not for. Illustrated Parts List 49E700. Model Series TYPE NUMBERS FORM MS /17/2014 FILE IN SECT. 2 OF SERVICE MANUAL 49E700

Reproduction. Not for. Illustrated Parts List 49E700. Model Series TYPE NUMBERS FORM MS /17/2014 FILE IN SECT. 2 OF SERVICE MANUAL 49E700 FORM MS10562 10/17/2014 FILE IN SECT. 2 OF SERVICE MANUAL 49E700 Illustrated Parts List Model Series 49E700 TYPE NUMBERS 0001. PRINTED IN U.S.A. COPYRIGHT by BRIGGS & STRATTON CORPORATION All rights reserved.

More information

For Discount Tecumseh Engine Parts Call or V J Page 1 of 8 Engine Parts List #1

For Discount Tecumseh Engine Parts Call or V J Page 1 of 8 Engine Parts List #1 V60-70346J Page 1 of 8 Engine Parts List #1 V60-70346J Page 2 of 8 Engine Parts List #1 1 34177 0 Cylinder Assy. (2-5/8" Bore) 2 27652 0 Pin, Dowel 3 31461 0 Bushing, Crankshaft 4 27876B 0 Seal, Oil 5

More information

mi Model 108 Compact Tractor Parts Catalog

mi Model 108 Compact Tractor Parts Catalog mi Model 108 Compact Tractor Parts Catalog Catalog No. 1226 PRICE 75 CENTS CASE MODEL 108 COMPACT TRACTOR Parts Catalog No. 1226 Leitch 2500 9-72 "'^^^l" 1" ifif --C: ^1=5 t^dj d- CASE MODEL 108 COMPACT

More information

Illustrated Parts List. Model Series 31Q700. TYPE NUMBERS 0036 Through TABLE OF CONTENTS

Illustrated Parts List. Model Series 31Q700. TYPE NUMBERS 0036 Through TABLE OF CONTENTS Illustrated Parts List Model Series 31Q700 TYPE NUMBERS 0036 Through 3136. TABLE OF CONTENTS FORM MS5767 REV P 05/17/2012 REPLACES FORM MS5767 REV M 01/16/2012 FILE IN SECT. 2 OF SERVICE MANUAL 31Q700

More information

Reproduction. Not for. Illustrated Parts List. Model Series. John Deere B1 TYPE NUMBER B1. 10/13/2009 MSC PRINTED IN U.S.A.

Reproduction. Not for. Illustrated Parts List. Model Series. John Deere B1 TYPE NUMBER B1. 10/13/2009 MSC PRINTED IN U.S.A. 10/13/2009 MSC000147 John Deere 407777-0232 -B1 Illustrated Parts List Model Series 407777 TYPE NUMBER 0232--B1. PRINTED IN U.S.A. COPYRIGHT by BRIGGS & STRATTON CORPORATION All rights reserved. No part

More information

Illustrated Parts List. Model Series. TYPE NUMBERS 0110 through TABLE OF CONTENTS

Illustrated Parts List. Model Series. TYPE NUMBERS 0110 through TABLE OF CONTENTS Illustrated Parts List Model Series TYPE NUMBERS 0110 through 5159. TABLE OF CONTENTS FORM MS10113 REV G 07/12/2012 REPLACES FORM MS10113 REV F 02/07/2012 FILE IN SECT. 2 OF SERVICE MANUAL Air Cleaner...

More information

Engine Parts Manual. Kubota Diesel Engine V3800DICR-E3B-TXN-1 HR 9016 WARNING Rev A

Engine Parts Manual. Kubota Diesel Engine V3800DICR-E3B-TXN-1 HR 9016 WARNING Rev A - INCLUDES ITEMS - 0-Rev A Engine Parts Manual Kubota Diesel Engine V00DICR-EB-TXN- HR 0 WARNING If incorrectly used, this machine can cause severe injury. Those who use and maintain this machine should

More information

Illustrated Parts List to 95999

Illustrated Parts List to 95999 TYPE NUMBERS 0100, 0101, 0102, 0106 through 0115, 0117 through 0126, 0128 through 0139, 0206, 0207, 0210, 0215 through 0229, Illustrated Parts List Model Series 95900 to 95999 FORM MS 2413 8/97 REPLACES

More information

Illustrated Parts List

Illustrated Parts List FORM MS 0323 6/27/2003 REPLACES FORM MS 0323 4C 9/2001 FILE IN SECT. 2 OF SERVICE MANUAL 93400 Illustrated Parts List Model Series 93400 TYPE NUMBERS 0010 through 1278. TABLE OF CONTENTS Air Cleaner.........................

More information

Illustrated Parts List

Illustrated Parts List FORM MS 9492 4C 1/2002 REPLACES FORM MS 9492 3C 6/2001 FILE IN SECT. 2 OF SERVICE MANUAL 422400 Illustrated Parts List Model Series 422400 TYPE NUMBERS 0728 through 4888. For Use On Engines Built Before

More information

Illustrated Parts List

Illustrated Parts List FORM MS 0670 08/09/2006 REPLACES FORM MS 0670 05/01/2006 FILE IN SECT. 2 OF SERVICE MANUAL 351400 Illustrated Parts List Model Series 351400 TYPE NUMBERS 0042 through 1256. TABLE OF CONTENTS Air Cleaner.........................

More information

DISASSEMBLED VIEWS. Disassembled Views. Engine Covers and Component Assemblies (1 of 2) (LF1, LFW or LFX)

DISASSEMBLED VIEWS. Disassembled Views. Engine Covers and Component Assemblies (1 of 2) (LF1, LFW or LFX) 2012 Cadillac CTS Wagon AWD V6-3.0L Vehicle > Engine, Cooling and Exhaust > Engine > Locations > Components DISASSEMBLED VIEWS Disassembled Views Engine Covers and Component Assemblies (1 of 2) (LF1, LFW

More information

TM T.O. 38G

TM T.O. 38G T.O. 38G1-48-12-2-1 TECHNICAL MANUAL VOLUME 2 OF 2 PART 1 OF 2 MAINTENANCE DIRECT SUPPORT AND GENERAL SUPPORT LEVEL ENGINE ASSEMBLY, DIESEL (MULTIFUEL): NATURALLY ASPIRATED OR TURBOCHARGED, FUEL-INJECTED,

More information

Z-Force 60 KW 53AA5DBJ Page 1 of 57 Air Filter & Muffler

Z-Force 60 KW 53AA5DBJ Page 1 of 57 Air Filter & Muffler Z-Force 60 KW 53AA5DBJ Page 1 of 57 Air Filter & Muffler Z-Force 60 KW 53AA5DBJ Page 2 of 57 Air Filter & Muffler Ref # Part Number Qty S/P/F Description 11011 KM-11011-7003 1 S CASE-AIR FILTER 11013 KM-11013-7009

More information

TRX-26 Trencher. Model No Serial No and Up * * B. Register at Original Instructions (EN)

TRX-26 Trencher. Model No Serial No and Up * * B. Register at   Original Instructions (EN) Form No. 3414-278 Rev B TRX-26 Trencher Model No. 22974 Serial No. 400000000 and Up Register at www.toro.com. Original Instructions (EN) *3414-278* B Ordering Replacement Parts To order replacement parts,

More information