Parts Catalog MDKBD MDKBE MDKBF

Transcription

1 Parts Catalog MDKBD MDKBE MDKBF Printed U.S.A. /0 00C

2 To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Onan manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY IN- STRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUC- TIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-

3 Introduction This catalog applies to the standard marine generator sets listed below. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned in the description or page heading, parts are interchangeable between models. Throughout this catalog left and right sides are determined by facing the engine end (front) of the set. MODEL HERTZ MDKBD/* 0/0 MDKBE/* 0/0 MDKBF/* 0/0 * The diagonal line (/) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from the standard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes. WIRING DIAGRAM DC V DC V AC Phase AC Phase

4 Index Actuator, Governor, Adapter, Dry Exhaust, Adapter, Engine, Adapter, Fuel Return Pipe, Adapter, Hose (MDKBD, MDKBE), Adapter, Keel Cooling, Adapter, Oil Drain (MDKBD, MDKBE), Adapter, Oil Drain (MDKBF), Adapter, Pipe, Alternator (Isolated Ground), Alternator (MDKBD, MDKBE, Negative Ground), Alternator (MDKBF, Negative Ground), Arm Assy, Rocker (MDKBD, MDKBE), Arm Assy, Rocker (MDKBF), Armature, Starter (V), Armature, Starter (V), Assy, Glow Plug, Assy, Panel, 0 Baffle, Air, Baffle, Generator, Ball, Crankshaft (MDKBD, MDKBE), Ball, Crankshaft (MDKBF), Ball, Valve Seat, Band, Pipe, Bar, Bus, Barb, Keel Cooling (Dry Exhaust), Barb, Keel Cooling (Wet Exhaust), Base, Filter, Base, Generator Mounting, Base, Mounting, Bearing, Alternator (Negative Ground, V), Bearing, Alternator (Negative Ground, V), Bearing, Connecting Rod, Bearing, Coolant Water Pump, 0 Bearing, Crankshaft (MDKBD, MDKBE), Bearing, Crankshaft (MDKBF), Bearing, Crankshaft Thrust (MDKBF), Bearing, Fuel Camshaft, Bearing, Generator, Bearing, Main (MDKBF), Bearing, Starter (V), Bearing, Starter (V), Belt, Alternator (Isolated Ground), Belt, Alternator (MDKBF, Negative Ground), Belt, Alternator(MDKBD, MDKBE, V/V), Block, Cylinder (MDKBD, MDKBE), 0 Block, Cylinder (MDKBF), Box, Control,, Bracket Assy, Solenoid, Bracket, Alternator (Isolated Ground), Bracket, Alternator (MDKBD, MDKBE, Negative Ground), Bracket, Alternator Adjusting (MDKBF, Negative Ground), Bracket, Baffle, Bracket, Belt Guard, Bracket, Fuel Pump, Bracket, Heat Exchanger, Bracket, Isolated Ground, Bracket, Lifting (MDKBD, MDKBE), 0 Bracket, Lifting (MDKBF), Bracket, Mounting Pad, Bracket, Oil Drain (MDKBD, MDKBE), Bracket, PTO, Bracket, PTO (Left), Bracket, PTO (Right), Bracket, Remote Separator Mounting, Bracket, Rocker Arm (MDKBD, MDKBE), Bracket, Rocker Arm (MDKBF), Bracket, Starter (V), Bracket, Starter (V), Break Siphon (MDKBD, MDKBE), Breaker, Circuit ( Amp), 0 Breaker, Circuit (0 Amp), 0 Breather (MDKBD, MDKBE), Breather (MDKBF), Brush, Alternator (Negative Ground, V), Brush, Alternator (Negative Ground, V), Bulkhead, Exhaust Connector, Bushing, Connecting Rod, Bushing, Dry Exhaust Reducer, Bushing, Idle Gear, Bushing, Oil Drain Reducer (MDKBF), Cam, Water Pump, Camshaft, Camshaft, Fuel, Cap, Adjusting Bolt Assy (MDKBF), Cap, Coolant Recovery Tank, Cap, Coolant Tank, 0 Cap, Cylinder Block Sealing (MDKBD, MDKBE), 0 Cap, Cylinder Block Sealing (MDKBF), Cap, Cylinder Head Sealing (MDKBD, MDKBE), 0 Cap, Cylinder Head Sealing (MDKBF), Cap, Oil Drain Line (MDKBD, MDKBE), Cap, Stop Lever Adjusting Bolt (MDKBD, MDKBE), Cap, Valve (MDKBD, MDKBE), Cap, Valve (MDKBF), Catch, Door, 0 Clamp, Fuel Pump Hose, Clamp, Fuel Return Hose, Clamp, Injection Pipe (MDKBD, MDKBE), Clamp, Nozzle Pipe (MDKBF), Cock, Cylinder Block Drain (MDKBD, MDKBE), 0 Cock, Cylinder Block Drain (MDKBF), Collar, Alternator (MDKBF, Negative Ground), Collar, Alternator (Negative Ground, V), Collar, Alternator (Negative Ground, V), Collar, Crankshaft (MDKBD, MDKBE), Collar, Crankshaft (MDKBF), Collar, Idle Gear, Collet, Valve Spring (MDKBD, MDKBE), Collet, Valve Spring (MDKBF), Components, Alternator (Negative Ground, V), Components, Alternator (Negative Ground, V), Components, Gauge Panel, Components, Injection Pump (MDKBD, MDKBE),

5 Index Components, Injection Pump (MDKBF), Components, Starter (V), Components, Starter (V), Components, Water Pump, Components, Water Separator, 0 Connector, Fuel Pump Male, Connector, Fuel Return Male, Connector, Heat Exchanger Bulkhead, Connector, Hose, Connector, Hose (MDKBF), Connector, Keel Cooling Bulkhead, Connector, Male, Control Harness, Cooling, Keel (Dry Exhaust), Cooling, Keel (Wet Exhaust), Cord, Glow Plug (MDKBD, MDKBE), Cord, Glow Plug (MDKBF), Coupling, Anchor, Coupling, Dry Exhaust Reducer, Coupling, PTO, Cover (MDKBF), Cover Assy, Starter (V), Cover Assy, Starter (V), Cover, Access, Cover, Alternator Bearing (Negative Ground, V), Cover, Alternator Bearing (Negative Ground, V), Cover, Alternator End (Negative Ground, V), Cover, Alternator End (Negative Ground, V), Cover, Bearing Housing (MDKBD, MDKBE), Cover, Bearing Housing (MDKBF), 0 Cover, Control, Cover, Cylinder Head (MDKBD, MDKBE), Cover, Cylinder Head (MDKBF), Cover, Cylinder Head Oil Fill (MDKBF), Cover, Fuel Camshaft (MDKBD, MDKBE), 0 Cover, Heat Exchanger, Cover, Hole (MDKBD, MDKBE), 0 Cover, Hole (MDKBF), Cover, Injection Pump (MDKBD, MDKBE), Cover, Injection Pump (MDKBF), Cover, Mechanical Fuel Pump (MDKBF), Cover, Thermostat, Cover, Water Pump, Crankshaft, Crankshaft (MDKBF), Crankshaft (MDKBD, MDKBE), Cylinder Block (MDKBF), Disc, Generator Drive, Door, Sound Shield, Drain Assy, Water Separator, 0 Drive Assy, Starter (V), Drive Assy, Starter (V), Elbow, Degree Street, Elbow, Degree Street Fuel, Elbow, Fuel Return, Elbow, Inverted Male, Elbow, Keel Cooling, Elbow, Keel Cooling (Dry Exhaust), Elbow, Keel Cooling (Wet Exhaust), Elbow, Oil Drain (MDKBD, MDKBE), Elbow, Oil Drain Pipe (MDKBF), Elbow, Pipe, Elbow, Street, Elbow, Street Pipe, Element, Breather (MDKBD, MDKBE), Element, Breather (MDKBF), Element, Fuel Filter, Element, Water Separator, 0 Endbell, Engine, Replacement (MDKBD, MDKBE), 0 Engine, Replacement (MDKBF), Exchanger, Heat, Excitor, Rotor, Wound, Exhaust, Dry, Exhaust, Wet, Fan, Generator, Filter, Fuel, Filter, Oil, Fitting, Oil Drain Hose Barb (MDKBF), Flange, Coolant Water Pump, 0 Flange, Dry Exhaust, Flange, Oil Fill, Flange, Water Outlet, Flange, Water Return, Flywheel Assy, Frame, Alternator Drive End (Negative Ground, V), Frame, Alternator End (Negative Ground, V), Frame, Alternator End (Negative Ground, V), Gasket, Adjusting Bolt (MDKBF), Gasket, Bearing Housing (MDKBD, MDKBE), Gasket, Bearing Housing (MDKBF), 0 Gasket, Bearing Housing Cover (MDKBD, MDKBE), Gasket, Bearing Housing Cover (MDKBF), 0 Gasket, Breather (MDKBD, MDKBE), Gasket, Breather (MDKBF), Gasket, Coolant Water Pump, 0 Gasket, Cover (MDKBF), Gasket, Cylinder Block Plug (MDKBD, MDKBE), 0 Gasket, Cylinder Block Plug (MDKBF), Gasket, Cylinder Head (MDKBD, MDKBE), 0 Gasket, Cylinder Head (MDKBF), Gasket, Cylinder Head Cover (MDKBD, MDKBE), Gasket, Cylinder Head Cover (MDKBF), Gasket, Delivery Valve (MDKBD, MDKBE), Gasket, Delivery Valve (MDKBF), Gasket, Dry Exhaust, Gasket, Dry Exhaust Adapter, Gasket, Exhaust Manifold, Gasket, Fuel Camshaft Cover (MDKBD, MDKBE), 0 Gasket, Fuel Nozzle (MDKBD, MDKBE), Gasket, Gearcase, Gasket, Heat Exchanger Cover,

6 Index Gasket, Hole Cover (MDKBD, MDKBE), 0 Gasket, Injection Pump (MDKBF), Gasket, Injection Pump Cover (MDKBD, MDKBE), Gasket, Injection Pump Cover (MDKBF), Gasket, Injection Pump Eye Joint (MDKBD, MDKBE), Gasket, Injection Pump Hollow Screw (MDKBD, MDKBE), Gasket, Injection Pump Hollow Screw (MDKBF), Gasket, Mechanical Fuel Pump Cover (MDKBF), Gasket, Mixer, Gasket, Nozzle (MDKBF), Gasket, Oil Fill Flange, Gasket, Oil Pan (MDKBD, MDKBE), Gasket, Oil Pan (MDKBF), Gasket, Oil Pan Plug (MDKBD, MDKBE), Gasket, Oil Pump (MDKBD, MDKBE), 0 Gasket, Oil Pump (MDKBF), Gasket, Raw Water Pump, Gasket, Riser/Adapter, Gasket, Speed Control Plate (MDKBF), Gasket, Stop Lever Adjusting (MDKBD, MDKBE), Gasket, Thermostat Cover, Gasket, Water Outlet Flange, Gasket, Water Pump (Wet Exhaust), Gasket, Water Return Flange, Gauge, Remote Switch and Oil Pressure, Gauge, Remote Switch and Water Temperature, Gear Assy, Idle, Gear, Camshaft, Gear, Crankshaft (MDKBD, MDKBE), Gear, Crankshaft (MDKBF), Gear, Oil Drive (MDKBF), Gear, Oil Pump Drive (MDKBD, MDKBE), 0 Gear, Oil Pump Drive (MDKBF), Gear, Ring, Gear, Starter (V), Gear, Starter (V), Gearcase Assy, Generator, Governor, Grommet, Generator, Grommet, Generator Housing, Grommet, Vacuum Relief Valve, Ground, Isolated, Guard Assy, Coupling, Guard, Belt, Guard, Belt and PTO Belt, Guard, Belt W/O PTO, Guide, Card, Guide, Valve (MDKBD, MDKBE), 0 Guide, Valve (MDKBF), Hanger, Coolant Recovery Tank, Harness, Auxiliary Control, Harness, Auxiliary Control, Harness, Battery, Harness, Control, Harness, Deluxe Remote Panel, Harness, Gauge Panel, Harness, Ground, Harness, Isolated Ground, Harness, Junction, 0 Harness, Pigtail ( ), 0 Harness, Plug, 0 Harness, Plug and Remote Panel, 0 Harness, Remote Control Panel, Harness, Remote Extension, 0 Harness, Remote Switch and Gauge Panel, Harness, Remote Switch Panel, Harnesses, 00 Head Assy, Cylinder (MDKBF), Head Assy, Water Separator Replacement, 0 Head, Cylinder (MDKBD, MDKBE), 0 Head, Cylinder (MDKBF), Holder Assy, Alternator Brush (Negative Ground, V), Holder Assy, Alternator Brush (Negative Ground, V), Holder Assy, Nozzle (MDKBD, MDKBE), Holder Assy, Nozzle (MDKBF), Holder Assy, Starter Brush (V), Holder, Delivery Valve (MDKBD, MDKBE), Holder, Delivery Valve (MDKBF), Holder, Nozzle (MDKBD, MDKBE), Holder, Nozzle (MDKBF), Holder, Starter Brush (V), Hose, Coolant, Hose, Coolant Tank Upper, 0 Hose, Engine Coolant, Hose, Exhaust Manifold, Hose, Fuel, Hose, Intake, Hose, Keel Cooling, Hose, Keel Cooling (Dry Exhaust), Hose, Keel Cooling (Wet Exhaust), Hose, Lower Coolant Tank, Hose, Mixer, Hose, Outlet, Hose, Raw Water Pump, Hose, Wet Exhaust, Hourmeter (Control Panel), 0 Housing, Generator, Housing, Main Bearing (MDKBD, MDKBE), Housing, Main Bearing (MDKBF), 0 Hub, Drive, Impeller, Coolant Water Pump, 0 Impeller, Water Pump, Indicator, Oil Level (MDKBD, MDKBE), Indicator, Oil Level (MDKBF), Insulation, Access Panel Sound, 0 Insulation, Alternator Brush (Negative Ground, V), Insulation, Alternator Brush (Negative Ground, V), Insulation, Door, Insulation, Duct (W/O PTO), Insulation, Generator Housing, Insulation, Panel (Side),

7 Index Insulation, Panel (Top), Insulation, Roof, Insulation, Roof End, Isolation, Vibration, Isolator, Mounting, Joint, Cylinder Block Drain Cock (MDKBD, MDKBE), 0 Joint, Cylinder Block Drain Cock (MDKBF), Joint, Injection Pump (MDKBF), Joint, Injection Pump Eye (MDKBD, MDKBE), Joint, Intake Manifold Pipe, Joint, Oil Filter Pipe, Jumper, Temp Switch, Key, Camshaft, Key, Crankshaft (MDKBD, MDKBE), Key, Crankshaft (MDKBF), Key, Fan Drive Pulley (MDKBD, MDKBE), Key, Oil Pump (MDKBD, MDKBE), 0 Key, Oil Pump (MDKBF), Key, Water Pump, Kit, Access Panel, 0 Kit, Belt Guard (ISO Ground), Kit, Belt Guard (Neg Ground), Kit, Belt Guard (PTO), Kit, Blank Panel V, Kit, Blank Panel V, Kit, Coolant Recovery, Kit, Coupling Guard, Kit, Door, Kit, Duct Panel, Kit, Enclosure Panel, Kit, Engine Roof Panel, Kit, Exhaust, Kit, Exhaust (Wet), Kit, Exhaust Adapter, Kit, Exhaust Flange, Kit, Fuel Adapter (/ Hose), Kit, Fuel Adapter (/ Hose), Kit, Gauge Panel, Kit, Heat Exchanger End Cap/Pencil, Kit, Heat Exchanger Zinc Pencil, Kit, Isolated Ground, Kit, Keel Cooling, Kit, Keel Cooling (Dry Exhaust), Kit, Keel Cooling (Wet Exhaust), Kit, Minor Service, Kit, Muffler, 0 Kit, Muffler/Water Separator, 0 Kit, Panel Enclosure, Kit, PTO, Kit, PTO Belt, Kit, Raw Water Pump Service, Kit, Remote Control Panel, Kit, Remote Control Panel Switch Harness, Kit, Remote Fuel/Water Separator, Kit, Remote Panel, Kit, Remote Switch and Gauge Panel, Kit, Remote Switch Panel, Kit, Roof Panel, Kit, Sender, Kit, Siphon Break (MDKBD, MDKBE), Kit, Siphon Break (MDKBF), Kit, Sound Shield, Kit, Water Separator, 0 Kit, Water Separator Metal Bowl Replacement, 0 Kits, 0 Label, Control, 0 Label, Instruction, Labels, 0 Latch, Door (/ Turn), Lever Assy, Engine Stop (MDKBF), Lever Assy, Fork, Lever Assy, Starter (V), Lever Assy, Starter (V), Lever Assy, Stop (MDKBF), Lever, Engine Stop (MDKBD, MDKBE), Lever, Engine Stop (MDKBD, MDKBE)), Lever, Engine Stop (MDKBF), Lever, Governor, Line, Flex Fuel, Line, Flex Oil (MDKBD, MDKBE), Line, Fuel Return, Line, Oil, Lock Assy, Plate (MDKBD, MDKBE), Lug, Solderless, Manifold, Exhaust, Manifold, Intake, Manifold, Oil Pressure, Meter, Remote Switch and Running Time, Meter, Remote Switch and Volt (M), Meter, Remote Switch Panel Hour, Meter, Volt (M), Mixer, Mount Assy, Engine, Mounting, Printed Circuit Board, Muffler, 0 Muffler, Dry Exhaust, Nipple, Keel Cooling (Dry Exhaust), Nipple, Keel Cooling (Wet Exhaust), Nozzle (MDKBF), Nozzle, Fuel (MDKBD, MDKBE), O Ring Kit, Water Separator, 0 O Ring, Crankshaft (MDKBD, MDKBE), O Ring, Crankshaft (MDKBF), O Ring, Cylinder Block, 0 O Ring, Cylinder Block Pipe Pin (MDKBF), O Ring, Cylinder Head (MDKBD, MDKBE), 0 O Ring, Cylinder Head (MDKBF), O Ring, Delivery Valve Holder (MDKBF), O Ring, Gearcase, O Ring, Governor Lever (MDKBF),

8 Index O Ring, Oil Fill Cover (MDKBF), O Ring, Oil Fill Plug, O Ring, Oil Pickup Tube (MDKBF), O Ring, Pickup Tube (MDKBD, MDKBE), O Ring, Valve Holder (MDKBD, MDKBE), O Ring, Water Pump, Pan, Oil (MDKBD, MDKBE), Pan, Oil (MDKBF), Panel Assy, Control, Panel, Remote Switch and Gauge, Panel, Access, 0 Panel, Control, 0 Panel, Control (Gnd), 0 Panel, Duct (W/O PTO), Panel, Enclosure, Panel, Enclosure (W/PTO), Panel, Generator Housing, Panel, Generator Housing Side, Panel, Remote Control,,, Panel, Remote Printed, Panel, Remote Switch, Panel, Remote Switch and Gauge, Panel, Remote Switch Panel Printed, Panel, Roof, Panel, Roof End, Panel, UMC Mounting, PCB Assy, Control, Pencil, Zinc, Pin, Cylinder Block Pipe (MDKBD, MDKBE), 0 Pin, Cylinder Block Pipe (MDKBF), Pin, Cylinder Block Straight (MDKBD, MDKBE), 0 Pin, Cylinder Block Straight (MDKBF), Pin, Flywheel Alignment, Pin, Gearcase, Pin, Piston, Pin, Rocker Arm Bracket Spring (MDKBD, MDKBE), Pin, Rocker Arm Spring (MDKBF), Pin, Stop Lever Spring (MDKBD, MDKBE), Pin, Stop Lever Spring (MDKBF), Pin, Tappet Guide (MDKBD, MDKBE), Pin, Tappet Guide (MDKBF), Pinion Set, Starter (V), Pipe, Injection (MDKBD, MDKBE), Pipe, Injection (MDKBF), Pipe, Overflow (MDKBD, MDKBE), Pipe, Overflow (MDKBF), Pipe, Water Return, Piston, Plate Assy, Lock (MDKBF), Plate, Alternator Retainer (Negative Ground, V), Plate, Alternator Retainer (Negative Ground, V), Plate, Breather (MDKBD, MDKBE), Plate, Breather (MDKBF), Plate, Injection Pump (MDKBF), Plate, Injection Pump (MDKBF)), Plate, Injection Pump Mounting (MDKBD, MDKBE), Plate, Speed Control (MDKBF), Plate, Water Pump Wear, Plug, Coolant Tank Hex Pipe, 0 Plug, Cylinder Block (MDKBD, MDKBE), 0 Plug, Cylinder Block (MDKBF), Plug, Cylinder Head (MDKBD, MDKBE), 0 Plug, Cylinder Head (MDKBF), Plug, Fuel Filter Drain, Plug, Gearcase, Plug, Glow, Plug, Glow (MDKBF), Plug, Hex Head Pipe, Plug, Hex Pipe, Plug, Oil Fill, Plug, Oil Pan (MDKBD, MDKBE), Plug, Oil Pan (MDKBF), Plug, Water Outlet Flange, Plug, Water Separator, 0 Plunger, Pump (MDKBD, MDKBE), Plunger, Pump (MDKBF), PTO, Pulley, Alternator (Isolated Ground), Pulley, Alternator (MDKBF, Negative Ground), Pulley, Alternator (Negative Ground, V), Pulley, Alternator (Negative Ground, V), Pulley, Coolant Water Pump, 0 Pulley, Fan Drive (MDKBD, MDKBE, Neg Gnd), Pump Assy, Coolant Water, 0 Pump Assy, Injection (MDKBD, MDKBE), Pump Assy, Injection (MDKBF), Pump Assy, Water Separator, 0 Pump, Electric Fuel, Pump, Fuel, Pump, Heat Exchanger Raw Water, Pump, Keel Cooling Raw Water (Wet Exhaust), Pump, Oil (MDKBD, MDKBE), 0 Pump, Oil (MDKBF), Rack, Injection Pump Control (MDKBD, MDKBE), Rack, Injection Pump Control (MDKBF), Rectifier, Alternator (Negative Ground, V), Rectifier, Alternator (Negative Ground, V), Regulator, Alternator (Negative Ground, V), Regulator, Alternator (Negative Ground, V), Relay (SPDT), Relay, Isolated Ground Solenoid, Resistor, Fuel Pump (V), Resistor, Remote Switch and Gauge Panel (v Only), Resistor, Remote Switch and Gauge Panel (v Only), Resonator, Intake, Retainer, Endbell, Retainer, Valve Spring (MDKBD, MDKBE), Retainer, Valve Spring (MDKBF), Ring, Idle Gear Retaining, Ring, Piston Retaining, Ring, Rocker Arm (MDKBD, MDKBE), Ring, Rocker Arm Retaining (MDKBF), Ring, Water Pump Retaining, Riser, Exhaust,

9 Index Riser, Wet Exhaust, Rod Assy, Connecting, Rod, Push, Rotor Assy, Generator, Rotor, Alternator (Negative Ground, V), Rotor, Alternator (Negative Ground, V), Screw, Follow, Seal, Bearing Housing Oil (MDKBF), 0 Seal, Coolant Water Pump, 0 Seal, Crankshaft Oil (MDKBD, MDKBE), Seal, Heat (MDKBF), Seal, Main Bearing Housing Oil (MDKBD, MDKBE), Seal, Nozzle Heat (MDKBD, MDKBE), Seal, Oil (MDKBF), Seal, Stop Lever Oil (MDKBD, MDKBE), Seal, Stop Lever Oil (MDKBF), Seal, Valve Stem (MDKBD, MDKBE), Seal, Valve Stem (MDKBF), Seal, Water Pump Lip, Seal, Water Pump Mechanical, Seal, Weather (. ), Seat, Spring (MDKBD, MDKBE), Seat, Spring (MDKBF), Seat, Valve, Sender, Low Coolant, 0 Sender, Oil, Sender, Oil Pressure, Sender, Water Temperature, Separator, Fuel/Water, 0 Separator, Remote Fuel/Water, Separator, Remote Fuel/Water Separator, Separator, Water, 0 Set, Ring, Shaft Assy, Rocker Arm (MDKBD, MDKBE), Shaft Assy, Rocker Arm (MDKBF), Shaft, Engine Stop Lever (MDKBD, MDKBE), Shaft, Fork Level, Shaft, Idle Gear, Shaft, Stop Lever (MDKBF), Shield, Engine Panel Sound (Access), 0 Shield, Engine Panel Sound (Doors), Shield, Panel Engine Sound (Front and Rear), Shield, Panel Engine Sound (Front w/pto), Shield, Sound, Engine (Cover), Shim, Injection Pump (MDKBF), Shim, Injection Pump Mounting (MDKBD, MDKBE), Shim, Injection Pump Mounting (MDKBF), Shim, PTO, Shim, Spring Seat (MDKBD, MDKBE), Siphon, Break (MDKBF), Sleeve, Air Intake, Sleeve, Crankshaft (MDKBD, MDKBE), Sleeve, Crankshaft (MDKBF), Sleeve, Injection Pump Control (MDKBF), Sleeve, Injection Pump Upper Spring (MDKBD, MDKBE), Slinger, Crankshaft Oil (MDKBF), Slinger, Oil (MDKBD, MDKBE), Socket, Relay, Spacer, Generator Fan, Spacer, Panel, 0 Spring, Alternator Brush (Negative Ground, V), Spring, Alternator Brush (Negative Ground, V), Spring, Delivery Valve (MDKBD, MDKBE), Spring, Delivery Valve (MDKBF), Spring, Plunger (MDKBD, MDKBE), Spring, Plunger (MDKBF), Spring, Rocker Arm (MDKBD, MDKBE), Spring, Rocker Arm (MDKBF), Spring, Starter (V), Spring, Starter (V), Spring, Valve (MDKBD, MDKBE), Spring, Valve (MDKBF), Spring, Valve Seat, Standoff, Insulation, Stator, Generator, Stator, Wound, Stiffener, Enclosure, Stopper, Camshaft, Stopper, Starter Set (V), Stopper, Starter Set (V), Strainer, Water Pickup, 0 Strap, Bond (MDKBF), Strap, Control Box Bond, Strap, Electrical, Support, Fuel Return, Switch, High Exhaust Temperature, Switch, Pressure, Switch, Remote Control Panel Rocker (S), Switch, Remote Gauge and Rocker (SPDT) (S), Switch, Remote Switch Panel Rocker (S), Switch, Rocker (S), Switch, Rocker SPDT (Control Panel), 0 Switch, Starter Solenoid (V), Switch, Starter Solenoid (V), System, Grounding, Tank, Coolant, 0 Tank, Coolant Recovery, Tappet, Tappet Assy (MDKBF), Tappet Assy, Injection Pump (MDKBD, MDKBE), Tee, Keel Cooling, Tee, Keel Cooling (Wet Exhaust), Tee, Street, Thermostat, Tube, Breather (MDKBD, MDKBE), Tube, Breather (MDKBF), Tube, Flexible Exhaust, Tube, Low Pressure Switch, Tube, Oil Pickup (MDKBD, MDKBE), Tube, Oil Pickup (MDKBF), Valve (MDKBF), Valve, Check (MDKBD, MDKBE), Valve, Check (MDKBF),

10 Index Valve, Delivery (MDKBD, MDKBE), Valve, Delivery (MDKBF), Valve, Exhaust (MDKBD, MDKBE), Valve, Inlet (MDKBD, MDKBE), Valve, Oil Drain Shutoff (MDKBF), Wedge, Gauge Panel Plug, Yoke Assy, Starter (V), Yoke Assy, Starter (V),

11

12 Cylinder Block, MDKBD, MDKBE Engine, Replacement MDKBD Spec A 00 0 V 00 0 V MDKBD Begin Spec B 00 0 V 00 0 V MDKBE Spec A V V MDKBE Begin Spec B 00 0 V 00 0 V Cap, Sealing Plug Plug 0 Cap, Sealing Pin, Straight Plug Plug Plug 0 Pin, Straight Pin, Straight 0 Pin, Straight *Gasket, Cover *Cover, Fuel Camshaft *Bolt 0 Pin, Pipe 0 O Ring 0 0 Bracket, Lifting 00 Washer (M) 0 0 Screw, Hex Head Cap (M x 0 x. ) 0 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x mm) Plug Gasket Washer, Spring 0 Bolt 0 Nut, Flange Gear, Oil Pump Drive Key 0 Pump, Oil Gasket, Oil Pump Gasket, Hole Cover Cover, Hole 0 00 Washer, Flat 00 0 Bolt Cock, Drain Joint, Drain Cock * Parts Included in Keel Cooling Kit Found on Keel Cooling Dry Exhaust Page). 0

13 Cylinder Block, MDKBF Engine, Replacement MDKBF 00 0 V Spec A 00 0 V Spec A Engine, Replacement MDKBF 00 0 V Begin Spec B 00 0 V Begin Spec B 0 Block Assy, Cylinder (Includes Parts Marked #) 0 #Plug 0 #Cap, Sealing #Pin, Straight 00 #Plug #Cap, Sealing #Plug #Plug 0 #Pin, Pipe 0 0 #Pin, Straight #Pin, Straight #Plug #Pin, Straight #Plug Joint, Drain Cock Cock, Drain 0 O Ring Plug Gasket 0 0 Pump, Oil Gasket, Oil Pump 0 Bolt Washer, Spring 0 Gear, Oil Pump Drive Key 0 Nut, Flange 0 0 Bracket, Lifting 0 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x mm) 0 0 Screw, Hex Head Cap (M x 0 x.mm) 00 Washer (M) *Screw, Hex Head Cap (M x 0mm) 00 Washer, Flat *Cover *Gasket Cover, Hole Gasket, Hole Cover 0 00 Washer, Flat 00 0 Bolt # Parts included in Cylinder Block Assy. * Parts Included in Keel Cooling Kit Listed on Keel Cooling Dry Exhaust Page.

14 Crankshaft MDKBD, MDKBE 0 Crankshaft (Includes Balls and Sleeve) Ball Sleeve Gear 0 Key Slinger, Oil Collar O Ring 0 Nut 0 Seal, Oil Bearing 0 Standard 0. mm Undersize 0. mm Undersize Bearing, Main 0 Standard 0. mm Undersize 0. mm Undersize Bearing, Thrust Standard 0. mm Oversize 0 0. mm Oversize Standard 0. mm Oversize 0. mm Oversize

15 Crankshaft MDKBF 0 0 Crankshaft (Includes Balls and Sleeve) Ball 0 Sleeve 00 Gear 0 Key 0 Gear, Oil Drive 0 Slinger, Oil 0 Collar O Ring 0 Bearing 0 Standard 0. mm Undersize 0. mm Undersize Bearing, Main 0 Standard 0. mm Undersize 0. mm Undersize Bearing, Thrust Standard 0. mm Oversize 0 0. mm Oversize Standard 0 0. mm Oversize 0 0. mm Oversize

16 Camshaft 0 0 Tappet 00 MDKBD, MDKBE 00 0 MDKBF Rod, Push 0 MDKBD, MDKBE 0 0 MDKBF Camshaft Assy (Includes Parts Marked *) 0 MDKBD, MDKBE 0 MDKBF *Camshaft 0 MDKBD, MDKBE 0 MDKBF *Screw, Set 0 *Screw, Set (MDKBF) 0 *Key 0 *Stopper, Camshaft *Gear, Camshaft 0 MDKBD, MDKBE 0 MDKBF 0 00 Bolt Gear Assy, Idle (Includes Bushing) 0 MDKBD, MDKBE 0 MDKBF Bushing, Idle Gear 0 MDKBD, MDKBE 0 MDKBF 0 Collar 0 Collar Ring, External Retaining Shaft, Idle Gear * Parts Included in Camshaft Assy

17 Piston Piston MDKBD Standard 0. mm Oversize MDKBE Standard 0 0. mm Oversize MDKBF Standard 0 0. mm Oversize Set, Ring MDKBD Standard 0 0. mm Oversize MDKBE Standard 0 0. mm Oversize MDKBF Standard 0 0. mm Oversize Pin, Piston MDKBD, MDKBE MDKBF Ring, Retaining MDKBD, MDKBE 0 MDKBF Rod Assy, Connecting (Includes Bushing, Bearing and Bolts) MDKBD, MDKBE MDKBF Bushing 0 MDKBD, MDKBE 0 MDKBF Bearing Standard 0 MDKBD, MDKBE 0 MDKBF 0. mm Undersize MDKBD, MDKBE MDKBF 0. mm Undersize MDKBD, MDKBE MDKBF Bolt MDKBD, MDKBE 0 MDKBF

18 Flywheel 0 Flywheel Assy (Includes Ring Gear) 0 MDKBD, MDKBE 0 MDKBF 0 Gear, Ring 0 0 Plug, Hole 0 0 Adapter, Engine 0 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x 0mm) 0 Washer, Flat (M0) Screw, Hex Head Cap (M0 x. x 0mm) 00 Pin, Parallel Hard (MDKBD, MDKBE) 0 Starter (See Separate Page For Components) V 0 V 0 Washer, Flat (M) 00 Screw, Hex Head Cap (M x. x mm)

19 Starter Components (V) 0 0 Starter 0 Set, Screw Bracket Assy, Front Gear Drive Assy Cover Assy Stopper, Set Lever Assy Spring, Set Bracket Assy, Center 0 Armature (Includes Bearings) Bearing, Center Bearing, Rear Yoke Assy Holder Assy, Brush Spring, Brush Bracket, Rear Bolt, Set Switch, Solenoid Gear, Set 0 Drive Assy

20 Starter Components (V) Starter 0 Set, Screw Bracket Assy, Front (Includes Bearing) Gear Drive Cover Assy, Rear (Includes Cover Plate, Washers, Screws, and Snap Ring) 0 Pinion Set (Includes Pinion, Spring & Stopper Set) Stopper, Set (Includes Ring) Lever Assy 0 Spring Set 0 Bracket, Center 0 Armature (Includes Bearings) Bearing, Center Sleeve Bearing, Rear Sleeve 0 Yoke Assy (Includes Pole Shoes, Field Coil, Positive Brushes) 0 Holder, Brush (Includes Negative Brushes) Spring, Brush Bracket, Rear Bolt, Set 0 Switch, Solenoid (Includes Shims) 0 Gear, Set Drive Assy

21 Main Bearing Housing MDKBD, MDKBE 0 Housing, Main Bearing 0 Bolt, Bearing Housing Gasket, Bearing Housing Cover, Bearing Housing Gasket, Bearing Housing Cover 0 Bolt 0 Bolt Seal, Oil Housing, Main Bearing 0 Housing, Main Bearing Housing, Main Bearing Bolt, Bearing Housing

22 Main Bearing Housing MDKBF 0 Housing, Main Bearing 0 0 Bolt, Bearing Housing Gasket, Bearing Housing Gasket, Bearing Housing Cover 0 Bolt 0 Bolt 0 Seal, Oil Housing, Main Bearing Housing, Main Bearing 0 Housing, Main Bearing 0 Housing, Main Bearing Bolt, Bearing Housing Cover, Bearing Housing 0

23 Fuel Camshaft Camshaft Assy, Fuel (Includes Parts Marked *) 0 0 *Camshaft, Fuel *Bearing, Ball 0 *Gear, Injection Pump *Key, Feather 0 *Clip, External Circular 0 *Sleeve, Governor 0 *Clip, Governor Sleeve 0 0 *Case, Governor Ball *Ball 0 *Clip, Circular 0 0 *Ball Bearing, Ball 0 0 Stopper, Fuel Camshaft 00 Bolt Cover, Fuel Camshaft Gasket Clip, External Circular 00 0 Bolt * Parts Included in Fuel Camshaft Assy

24 Speed Control Bolt, Adjusting Maximum Fuel 0 0 Nut Gasket Nut 00 Lever, Speed Control Key, Feather 0 0 O Ring 0 Washer, Plain 0 Nut 0 0 Collar 0 Plate, Speed Control 0 Gasket 0 Bolt 0 Stud 0 0 Washer, Spring Nut

25 Governor Lever, Governor 0 0 Lever Assy, Fork (Includes Parts Marked *) Spring, Governor 0 0 *Lever Assy, Fork (Includes Pin) 0 0 *Shaft, Fork Level *Bolt 00 0 *Bolt, Flange 0 0 *Washer, Spring 0 0 *Holder, Fork Lever *Bolt Bolt Bolt 0 00 Washer, Plain Washer, Plain Spring, Start * Parts Included in Fork Lever Assy.

26 Engine Stop Lever MDKBD, MDKBE 0 Lever Assy, Engine Stop (Includes Parts Marked #) #Lever, Engine Stop #Pin, Spring #Seal, Oil #Cover, Injection Pump #Shaft, Lever Bolt Gasket, Injection Pump Cover Bolt, Adjusting 0 Gasket Nut 0 Nut, Cap Cap # Parts Included in Engine Stop Lever Assy

27 Engine Stop Lever MDKBF 0 Cover 0 Gasket Bolt 0 Bolt Assy, Adjusting Governor Adjust (Includes Parts Marked *) *Bolt, Adjusting *Nut 0 *Nut, Cap *Gasket *Cap 0 Lever Assy, Engine Stop (Includes Parts Marked #) #Cover, Injection Pump #Shaft, Lever #Lever, Engine Stop #Seal, Oil #Pin, Spring #Bolt Gasket * Parts Included in Adjusting Bolt Assy. # Parts Included in Engine Stop Lever Assy.

28 Injection Pump MDKBD, MDKBE 0 0 Pump Assy, Injection (See Separate Page for Components) Shim Standard.0mm.mm Shim.mm.0mm 0 Bolt 0 Stud Nut Washer, Spring 0 Screw, Follow Joint, Eye 0 Gasket

29 Injection Pump MDKBF Pump Assy, Injection (See Separate Page for Components) Shim.0mm 0.mm.0mm 0 Bolt Stud Nut Washer, Spring 0 Screw, Follow Joint Gasket

30 Injection Pump Components MDKBD, MDKBE 0 Pump Assy, Injection Holder, Delivery Valve O Ring 0 Spring, Delivery Valve Gasket, Delivery Valve Valve, Delivery Plunger, Pump Plate Pin, Tappet Guide Sleeve, Control 0 Seat, Upper Spring Spring, Plunger Seat, Lower Spring Shim Tappet Assy 0 Rack, Control Gasket Screw, Hollow Lock Assy, Plate

31 Injection Pump Components MDKBF 0 0 Pump Assy, Injection Plunger, Pump Valve, Delivery Spring, Delivery Valve Gasket, Delivery Valve Holder, Delivery Valve O Ring Tappet Assy Pin, Tappet Guide 0 Spring, Plunger Seat, Upper Spring Seat, Lower Spring Shim Rack, Control Sleeve, Control Screw, Hollow Gasket Plate Plate 0 Plate Assy, Lock 0 Plate Assy, Lock

32 Cylinder Head MDKBD, MDKBE 0 Stud 0 MDKBD 0 MDKBE Head Assy, Cylinder (Includes Parts Marked *) MDKBD 0 MDKBE *Plug *Cap, Sealing *Cap, Sealing *Guide, Inlet Valve *Guide, Exhaust Valve Washer (With Rubber) Plug 0 Bolt, Cylinder Head Gasket, Cylinder Head MDKBD MDKBE 0 O Ring * Parts Included in Cylinder Head Assy. 0

33 Cylinder Head MDKBF 0 0 Head Assy, Cylinder (Includes Parts Marked #) #Cap, Sealing #Cap, Sealing #Plug #Guide, Inlet Valve #Guide, Exhaust Valve Bolt, Cylinder Head 00 Gasket, Cylinder Head Plug 0 Washer (with Rubber) 0 O Ring # Parts Included in Cylinder Head Assy.

34 Rocker Arm MDKBD, MDKBE Valve, Inlet 0 Valve, Exhaust 0 Spring, Valve 0 Retainer, Valve Spring 0 Collet, Valve Spring 0 Seal, Valve Stem 0 Cap, Valve 00 Shaft Assy, Rocker Arm (Includes Set Screws) Screw, Set 0 0 Bracket, Rocker Arm 0 Stud Nut Washer, Spring 0 00 Washer, Flat Pin, Spring 0 Washer, Rocker Arm Shaft 0 Spring, Rocker Arm 0 Ring, External Retaining 0 Arm Assy, Rocker (Includes Screw and Nut) 0 0 Screw, Adjusting 00 Nut

35 Rocker Arm MDKBF Valve, Inlet 0 Valve, Exhaust 0 0 Spring, Valve 0 0 Retainer, Valve Spring 0 0 Collet, Valve Spring 0 0 Seal, Valve Stem 0 0 Cap, Valve 0 Shaft Assy, Rocker Arm (Includes Set Screws) Screw, Set 0 0 Bracket, Rocker Arm 0 Stud Nut Washer, Spring 0 00 Washer, Flat Pin, Spring 0 Washer 0 Spring, Rocker Arm 0 Ring, External Retaining 0 0 Arm Assy, Rocker (Includes Screw and Nut) Screw, Adjusting 00 0 Nut

36 Nozzle Holder MDKBD, MDKBE 0 Clamp, Pipe Screw (With Washer) Pipe, Injection Pipe, Injection Pipe, Injection Pipe, Injection Clamp, Pipe Cord, Glow Plug Assy, Glow Plug (Includes Nut and Washer) 0 V V 0 Pipe, Overflow 0 Holder Assy, Nozzle (Includes Nozzle) 0 Nozzle Gasket, Nozzle Seal, Heat

37 Nozzle Holder and Glow Plug MDKBF 0 00 Pipe, Overflow 0 Holder Assy, Nozzle (Includes Nozzle, Gasket and Heat Seal 0 Nozzle Gasket Seal, Heat 0 Pipe, Injection 0 Pipe, Injection 0 Pipe, Injection 0 Pipe, Injection 0 00 Pipe, Injection Clamp, Pipe Clamp, Pipe Screw (With Washer) Plug, Glow 0 V V Cord, Glow Plug Nut, Flange 00 Washer, Flat

38 Water Outlet Flange 0 Flange, Water Outlet (Includes Pipe) 0 Pipe, Water Return Gasket 0 Bolt Stud Bolt MDKBD, MDKBE 00 MDKBF Nut Washer, Spring 000 Pipe, Water Return 0 00 Band, Pipe Plug 00 Cover, Thermostat 00 Gasket, Thermostat Cover Bolt MDKBD, MDKBE MDKBF 00 Thermostat +Sender, Water Temperature (E) 0 Negative Ground 0 0 Isolated Ground 0 00 Plug, Square Head Pipe (/ ) MDKBD, MDKBE 0 Clip, Wire (MDKBF) *Kit, Sender (Includes Water Temperature Sender) Negative Ground 00 0 Isolated Ground * Kit Also Includes Oil Pressure Sender Listed on Oil Pan Page. + Water Temperature Sender ties to E Iso Harness (See Isolated Ground 00 0)

39 Cylinder Head Cover MDKBD, MDKBE 0 Cover, Cylinder Head Gasket, Cover 0 Breather Gasket, Breather 00 Bolt Element, Breather Plate Tube, Breather Clamp, Hose 0 Nut, Cap Gasket

40 Cylinder Head Cover MDKBF 0 0 Cover, Cylinder Head 0 Gasket, Cover 0 Breather Gasket 00 Bolt Element, Breather Plate Nut, Cap Gasket 0 Tube, Breather Clamp 0 Cover, Oil Fill O Ring

41 Gearcase Gearcase Assy (Includes Parts Marked *) MDKBD, MDKBE MDKBF 0 *Plug Bolt 0 Bolt Bolt 0 Washer, Spring 0 Seal, Oil (MDKBF) Bolt 0 Bolt 0 Washer, Flat Joint, Pipe Spring Ball Seat, Valve *Pin, Start Spring Bolt 0 00 Washer, Flat Stud (Bottom)(MDKBD, MDKBE) Washer, Spring(MDKBD, MDKBE) 0 Nut (MDKBD, MDKBE) Bolt (Bottom)(MDKBF) 00 Filter, Oil Bolt (Top)(MDKBF) 0 Plug, Oil Fill O Ring Flange, Oil Fill Stud (Top)(MDKBD, MDKBE) Gasket 0 Gasket 0 Flange, Water Return 0 Bolt 0 Gasket 0 *O Ring *Pin, Straight *O Ring (MDKBD, MDKBE) *O Ring (MDKBF) *O Ring (MDKBF) * Parts Included in Gearcase Assy

42 Water Pump 0 Pump Assy, Water (Includes Parts Marked *) 00 MDKBD, MDKBE 0 MDKBF 00 *Bearing, Ball 00 *Impeller 0 *Seal *Flange 00 MDKBD, MDKBE MDKBF 0 Gasket 0 Bolt Stud 0 MDKBD, MDKBE 0 MDKBF Washer, Spring 0 Nut Bolt Pulley 0 MDKBD, MDKBE 0 MDKBF 0 Bolt, Flange * Parts Included in Water Pump Assy 0

43 Alternator MDKBD, MDKBE (Negative Ground) 0 Alternator, Complete (See Separate Page for Components) V V Bracket, Adjusting 0 V V Bolt MDKBD MDKBE Washer, Spring Bolt Washer, Flat Nut 0 Washer, Spring 0 Pulley, Fan Drive 0 0 Key 0 Washer, Flat Nut Belts (V) 00 (V)

44 Alternator MDKBF (Negative Ground) Volt Volt 0 0 Alternator (See Separate Page for Components) V V 0 Bolt Washer, Spring 0 Washer, Flat Nut Bolt Washer, Flat Nut Washer, Spring 0 Bracket, Adjusting 0 V V Collar 0 Pulley 0 Bolt 0 Belt Coupler Assy 0 Connector Terminal

45 Alternator Components (Negative Ground) (V) 0 0 Alternator (V) Pulley Nut Collar Frame, Drive End (Includes Parts Marked *) 0 *Bolt, Through Screw, Round Head *Bearing *Plate, Retainer *Screw, Round Head 0 0 Rotor (Includes Bearing and Cover) Bearing Cover, Bearing Insulation, Brush Nut Bolt Cover, End Screw, Round Head Holder Assy, Brush (Includes Brushes and Springs) Brush 0 Spring, Brush Screw, Round Head Regulator 0 Rectifier Nut 0 Bolt Frame, End Washer, Thrust * Parts Included in Drive End Frame

46 Alternator Components (Negative Ground) (V) 0 0 Alternator (V) 0 Pulley Nut Collar Frame, Drive End (Includes Parts Marked *) 0 *Bolt, Through Screw, Round Head *Bearing *Plate, Retainer *Screw, Round Head 0 0 Rotor (Includes Bearing and Cover) Bearing Cover, Bearing Insulation, Brush Nut Bolt Cover, End Screw, Round Head Holder Assy, Brush (Includes Brushes and Springs) Brush 0 Spring, Brush Screw, Round Head 0 Regulator Rectifier Nut 0 Bolt Frame, End * Parts Included in Drive End Frame

47 Alternator (Isolated Ground) (V/V) 0 Alternator, Complete (No Components Available) 0 V 0 V 0 Strap, Alternator 0 Bracket, Alternator Screw, Hex Head Cap (/ x / Washer, Lock (/ ) 00 Washer, Flat (/ ) Screw, Hex Head Cap (/ x / ) 0 00 Washer, Lock (/ ) 0 Belt 0 0 Washer, Flat (/ ) 00 Nut (/ ) 0 Pulley, Alternator Screw, Hex Head Cap 00 0 (M x 0mm) (MDKBD, MDKBE) 00 0 (M x 0mm)(MDKBF) Screw, Hex Head Cap (M0 x 00) 0 Washer, (M0) 0 00 Washer, Lock (M0) 0 00 Nut, Hex (M0) 0 Washer (MDKBF) * Alternator ties to G GND, Iso Ground Harness (See Isolated Ground 00 0)

48 Governor Actuator REF PART QTY. PART NO. NO. USED DESCRIPTION Actuator, Governor (V) (V) 0 Screw, Socket Head Cap (M xmm) 00 Washer, Copper (/ ) 00 Gasket, Solenoid Cover

49 Fuel Pump Bracket, Fuel Pump Elbow, Pipe 0 0 Connector, Male 0 0 Connector, Hose 0 Filter, Fuel (Includes Element, Plug and Filter Base) 0 Element 0 00 Plug, Drain Base, Filter 0 0 Washer, Centering (V) 0 0 Resistor (. ohms) (V) (R) 000 Washer, EIT (#0) (V) 0 Screw, Round Head Machine (#0 x. ) (V) 00 0 Screw, Hex Flange (M x x ) 0 0 Connector, Hose 0 0 Clamp, Hose Hose, Fuel Pump, Fuel 0 00 Elbow, Street Pipe 0 0 Elbow, Street Washer, Lock Split (M) 00 0 Screw, Hex Head (M x. x 0) Hose, Fuel (/ x.) 0 0 Adapter, Pipe (/ NPT) Elbow, Pipe

50 Fuel Return, Oil Sender, 0 0 Kit, Fuel Adapter (/ Hose) Kit, Fuel Adapter (/ Hose) 0 Adapter, Pipe 0 00 Elbow, Inverted Female 0 0 Connector, Hose 0 0 Clamp, Hose Hose, Fuel (/ x. ) 0 00 Elbow, Street 0 Tee, Street (/ NPT) 0 Support, Fuel Return 0 Washer, Fl (M) Screw, Hex Head Cap (M x. x mm) 0 Coupling, Anchor 0 0 Connector, Male Hose, Fuel (/ x 0 ) 0 0 Elbow, Inverted Male 0 Line, Oil Connector, Male IN 0 Manifold, Oil Pressure Sender, Oil Pressure 0 Neg Ground with Gauges 00 0 Iso Ground with Gauges Plug, Hex Head Pipe 0 00 without Gauges 0 00 with Gauges 0 0 Connector, Female Bulkhead 00 Washer, Flat (M) Line, Fuel MDKBD, MDKBE MDKBF Line, Fuel MDKBD, MDKBE MDKBF * Oil Sender ties to E, Iso Ground Harness (See Isolated Ground 00 0)

51 Remote Water Separator 0 Kit, Remote Fuel/Water Separator 0 0 Separator, Fuel/Water (See Separate Page for Components) Bracket, Separator Mounting 0 0 Line, Flex Fuel 00 Screw, Hex Head Cap (M x. x 0mm) 0 00 Washer, Lock (M) 0 00 Elbow, Street 0 (/ NPT) 0 0 Plug, Hex Pipe (/ NPT) 00 Washer, Flat (M) 00 Washer, EIT (/ ) 0 0 Screw, Hex Head Cap (M0 x. x 0mm)

52 Water Separator Components 0 0 Separator, Water 0 Kit, Metal Bowl Replacement (Includes Plug, O Rings and Drain Assy) Drain Assy (Includes Knob and Seal) 0 Element (Includes Seals) 0 0 Plug, Hex (/ ) Head Assy, Replacement (Includes Vent Plug, O Rings, Seal, Cap, Tube and Pump Assy) Plug, Vent (Includes O Ring) 0 Pump Assy (Includes Plunger, Retainer, Shaft, Check Ball, Knob and Screw) 0 O Ring Kit (Includes Seal and Plunger) 0

53 Blank Page

54 Break Siphon MDKBD, MDKBE 0 0 Kit, Siphon Break 0 Hose, Coolant 0 0 Valve, Check 0 0 Cap, Tube 0 0 Clamp, Hose 0 Connector, Hose 0 Hose, Water Clamp, Hose 0 0 Adapter, Hose 0 0 *Grommet, Rubber * Parts not shown but included in kit.

55 Break Siphon MDKBF 0 Kit, Siphon Break 0 Hose, Coolant 0 0 Valve, Check 0 0 Cap, Tube 0 0 Clamp, Hose 0 Connector, Hose 0 0 *Clamp, Hose 0 0 *Grommet, Rubber * Parts not shown but included in kit.

56 Heat Exchanger 0 0 0

57 Heat Exchanger 0 Kit, Minor Service (Includes O Rings and Impeller) 0 0 +Kit, End Cover (Includes Parts Marked *) 0 Kit, Heat Exchanger Zinc Pencil (Includes Parts Marked +) (MDKBD, MDKBE) Exchanger, Heat MDKBD, MDKBE MDKBF 0 Pencil, Zinc (w/screw) Clamp, Hose 0 ( )MDKBD, MDKBE 0 (. )MDKBF 00 0 Screw, Hex Head Cap (M0 x. x 0mm) 0 Washer, Flat (M0) Bracket, Heat Exchanger 0 0 MDKBD, MDKBE 0 0 MDKBF 0 Clamp, Hose ( / ) 0 Clamp, Hose ( ) 0 Hose, Exhaust Manifold ( / ) (Includes Sleeving) 0 Hose, Engine Coolant ( / ) 0 MDKBD, MDKBE 0 MDKBF 0 00 Hose, Coolant Tank Lower ( x ) 0 0 Clamp, Hose Hose, Mixer 0 (/ x ) MDKBD, MDKBE 0 0 (/ x ) MDKBF Clamp, J 0 Pump, Raw Water (See Separate Page for Components) 00 0 Screw, Hex Head Cap (M x. x 0) 00 Washer, Flat (M) 0 Gasket, Water Pump Hose, Water Pump ( ) 0 MDKBD, MDKBE 0 MDKBF Switch, Pressure Hose, Coolant 0 0 Tube, Low Pressure Switch 0 O Ring 0 Impeller Screw, Hex Head (/ x / ) 0 0 +Washer, Lock (/ ) *Cover, Heat Exchanger 0 W/O Zinc Pencil Boss) 0 0 W/Zinc Pencil Boss) *Gasket, Cover 0 W/O Zinc Pencil Hole 0 0 W/Zinc Pencil Hole 0 *Pencil, Zinc (w/o Screw) 0 0 Connector, Bulkhead Hose, Coolant mm Length MDKBD, MDKBE mm Length MDKBF 00 0 Screw, Hex Head Sems Stainless (M x x mm) + Parts Included in Heat Exchanger Zinc Pencil Kit. * Parts Included in End Cover Kit

58 Keel Cooling (Wet Exhaust) 0 0 0

59 Keel Cooling (Wet Exhaust) 0 Kit, Keel Cooling (Includes Parts Marked *) 00 Kit, Water Pump Service (Includes Impeller and O Ring, Wear Plate, Cover, Lip Seal, Cam, Seal Washer, Cam Screw, and Key) (MDKBF) 0 Gasket, Water Pump 00 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x 0mm) 0 Pump, Raw Water 0 0 Clamp, Hose Hose 0 MDKBD, MDKBE (/ x ) 0 0 MDKBF Clamp, J 0 *Clamp, Hose ( ) *Hose, Outlet ( x ) Switch, Pressure 0 0 Tube, Low Pressure Switch Hose, Lower Coolant (Cut to Fit) 0 0 *Adapter (/ NPT x Barb) 0 0 *Elbow, 0 *Adapter (/ NPT) 0 0 / Barb (MDKBD, MDKBE) 0 0 / Barb (MDKBF) 0 0 *Hose, Coolant ( / x ) *Nipple, Half *Elbow 0 00 *Tee *Barb, Hose 0 00 *Elbow 0 *Clamp, Hose ( / ) Hose, Coolant ( x 0 ) 0 Connector, Bulkhead * Parts Included in Keel Cooling Kit.

60 Water Pump Components, 0 0 Kit, Major Service 0 Cover 0 O Ring 00 Screw, Cam 0 Washer, Seal 0 Cam 0 Impeller 0 Plate, Wear 0 Seal, Seat Assy 0 Ring, Retaining 0 0 Seal, Lip 0 Key 0 Ring, Retaining 0 Kit, Minor Water Pump Service (Includes Impeller and O Ring)

61 Keel Cooling System (Dry Exhaust) Kit, Exhaust 0 Kit, Keel Cooling (Includes Parts Marked *) 0 Clamp, Hose ( / ) 0 0 *Hose, Coolant ( / x ) *Nipple, Half *Elbow 0 00 Tee 0 0 *Barb, Hose *Hose, Coolant ( x 0 ) 0 00 *Elbow 0 Clamp, Hose ( ) * Parts Included in Keel Cooling Kit. (Also Includes Cover, Gasket and Hardware Found on Cylinder Block Page.)

62 Coolant Tank 0 0 Tank, Coolant 0 Cap, Tank 0 Clamp, Hose ( / ) Hose, Upper Elbow 0 MDKBD, MDKBE 0 MDKBF 0 Hose, Upper S ( / ) 00 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x mm) 0 0 Plug, Hex Pipe (/) 0 Sender, Low Coolant 0

63 Coolant Recovery 0 Kit, Coolant Recovery 0 0 Tank, Coolant Recovery 0 Hanger, Tank 0 Hose (/ I.D. x 0 Lg.) 0 Cap, Tank 0 Hardware Package (Includes Mounting Hardware)

64 Oil Pan MDKBD, MDKBE 0 0 Pan, Oil Gasket Bolt, Flange 0 Plug Gasket 0 *Bolt *Gasket Tube, Oil Pickup Bolt 0 0 O Ring Indicator, Oil Level 0 0 Adapter, Oil Drain 0 0 Line, Flex Oil ( ) 0 0 Elbow, Pipe 0 0 Cap, Pipe 0 Washer, Oil Drain (.ID x.od x.0thk) 0 0 Bracket, Oil Drain 00 0 Screw, Hex Flanged (M x x mm) 00 0 Screw, Hex Head (M x x 0mm) Washer, Lock Split (M) 0 Washer, Flat (M) * Bolt and Gasket Removed with Installation of Oil Drain.

65 Oil Pan MDKBF 0 Pan, Oil 0 Gasket 0 Bolt Bolt *Plug (Removed with Installation of Oil Drain) *Gasket (Removed with Installation of Oil Drain) 0 Tube, Oil Pickup Bolt 0 0 O Ring 0 0 Indicator, Oil Level 0 Washer, Oil Drain (/ ) 0 0 Adapter, Oil Drain 0 Elbow, Pipe Valve, Shutoff 0 0 Bushing, Reducer 0 00 Fitting, Hose Barb * Circled Bolt and Gasket Removed with Installation of Oil Drain.

66 PTO 0 0 Kit, PTO (Includes Parts Marked *) MDKBD, MDKBE V V MDKBF V V 0 0 Kit, PTO Belt (Includes Tool Spacer and Belt) *Adapter, Coupling MDKBD, MDKBE MDKBF 00 0 *Screw, Socket Head Cap (M0 x. x mm) 0 0 *Coupling, Flex 0 *Screw, Socket Head Cap (M x. x 0mm) 0 00 *Screw, Hex Head Cap (/ x ) 0 *Washer, Flat *Adapter, Coupling *Clutch V V *Bracket, PTO Clutch *Screw, Hex Head Cap (/ x.00 ) 00 0 *Screw, Hex Head Cap 0 0 *Washer, Flat (M) 00 0 *Screw, Hex Head (M x. x 0mm)) 0 *Washer, Flat Stainless (M) 0 *Screw, Locking Flange (M x x mm) *Bracket, Mounting Pad 00 *Nut, Hex (M) 0 *Screw, Socket Head (M x. x mm) *Bracket, PTO (Left) *Screw, Hex Head Cap (M x. x mm) *Shim, PTO AR. GA AR. GA AR.0 GA *Bracket, PTO (Right) * Parts Included in PTO Kit. (Also Includes Fuel Pump Mounting Hardware Found on Fuel Pump Page)

67 Intake Manifold 0 Manifold Assy, Intake MDKBD, MDKBE 0 MDKBF Joint, Breather Gasket 0 MDKBD, MDKBE 0 MDKBF Bolt 0 MDKBD, MDKBE 0 MDKBF Resonator, Intake 0 MDKBD, MDKBE 0 0 MDKBF 0 0 Sleeve, Air Intake *Clamp, Hose 0 MDKBD, MDKBE ( / ) 0 MDKBF ( ) 0 Clamp, Hose ( ) Hose, Intake 0 MDKBD, MDKBE ( / x ) MDKBF ( / x ) 0 Cable, Tie

68 Exhaust Manifold *Gasket, Riser, Adapter Gasket, Exhaust Manifold MDKBD, MDKBE MDKBF Manifold, Exhaust MDKBD, MDKBE 00 MDKBF Stud 0 0 MDKBD, MDKBE 0 0 MDKBF Washer, Flat (M) 00 MDKBD, MDKBE 00 0 MDKBF Nut (M x.) 0 00 MDKBD, MDKBE MDKBF * Part Included in Exhaust Adapter Kit Found on Dry Exhaust Page.

69 Wet Exhaust 0 Kit, Exhaust (Wet) 0 0 MDKBD, MDKBE (Rear Out) 0 0 MDKBD, MDKBE (Front Out) 0 0 MDKBF (Rear Out) 0 0 MDKBF (Front Out) Kit, Exhaust (Wet) 00 0 Screw, Hex Head Cap (M x. x 0mm) 00 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x 0mm) Riser, Exhaust 0 00 Nut, Hex ( ) 0 00 Washer, Lock (M) 0 Gasket, Mixer Mixer 0 00 Washer, Flat (M) Screw, Socket Cap (M x x 0mm) Switch, High Exhaust Temperature (S) Hose, Exhaust Front 0 MDKBD, MDKBE 0 MDKBF Rear MDKBD, MDKBE MDKBF 00 0 Screw, Hex Head Sems Stainless (M x x mm) 0 0 Bulkhead, Exhaust Connector 0 Clamp, Hose Exhaust

70 Dry Exhaust (Up or Down) 0 0 Kit, Exhaust Flange (Includes Parts Marked +) 0 Kit, Exhaust Adapter (Includes Parts Marked *) Riser, Exhaust 00 0 Screw, Hex Head Cap (M x. x 0mm) 00 0 Screw, Hex Head Cap (M x. x 0mm) 00 Washer, Flat (M) 0 *Adapter, Exhaust 0 00 *Washer, Lock (M) 00 0 *Screw, Hex Head Cap (M x. x mm) *Gasket, Exhaust Adapter 0 0 *Flange, Exhaust *Coupling, Reducer ( x / ) 0 +Gasket, Exhaust (Mixer) 0 0 +Flange, Exhaust Washer, Flat (M) 0 0 +Screw, Allen Socket Cap (M x x 0mm) Bushing, Reducer ( / x ) Jumper, Temp Switch * Parts Included in Exhaust Adapter Kit.(Also Includes Gasket on Exhaust Manifold Page.) + Parts Included in Exhaust Flange Kit.

71 Muffler REF PART QTY PART NO. NO. USED DESCRIPTION 0 Tube, Flexible Exhaust ( ) Muffler, Dry Exhaust (Up) ( ) 0 0 Industrial 0 0 Critical

72 Water Separator, Muffler,, Kit, Muffler, Separator (Includes Parts Marked *) MDKBD, MDKBE MDKBF Kit, Muffler (Includes Parts Marked +) 00 MDKBD, MDKBE MDKBF Kit, Water Separator (Includes Parts Marked #) MDKBD, MDKBE MDKBF *+Muffler, Marine 0 MDKBD, MDKBE 0 MDKBF Clamp, Hose ( ) MDKBD, MDKBE 0 + Muffler Kit ( ) 0 # Separator Kit ( ) 0 0 * Muffler, Separator Kit ( ) MDKBF 0 + Muffler Kit ( / ) 0 # Separator Kit ( ) 0 0 * Muffler/Separator Kit ( ) 00 *+Strainer, Water Pickup *#Separator, Water ( )MDKBD, MDKBE ( / )MDKBF 0 *#Clamp, Hose ( / ) * Parts Included in Muffler/Separator Kit. + Parts Included in Muffler Kit. # Parts Included in Water Separator Kit. 0

73 Isolated Ground 0 REF PART QTY. PART REF PART QTY. PART Kit Isolated Ground (Includes Screws, Sending Units and Harness) 0 V 0 V Bracket Assy, Solenoid (Includes Parts Marked +) 0 0 V 0 0 V 0 0 Bracket, Solenoid +*Relay, Solenoid 0 V 0 V 0 +Washer, Flat (M) 0 0 +Washer, Split Lock (M) 00 +Nut, Hex (M) 00 0 Screw, Hex Head Cap (M x. x 0) Nut, ET Hex (#0 ) (V) 00 +Washer, ET Lock (/ ) Nut, Hex (/ ) Harness, Isolated Ground Harness, Ground * Relay Solenoid ties to B and K Isolated Ground Harness ( 00 0) + Solenoid Bracket Assembly Parts

74 Mounting Base 0 Base, Generator Mounting 0 0 MDKBD, MDKBE 0 0 MDKBF Isolator, Mounting MDKBD, MDKBE 0 W/O PTO W/PTO 0 Generator End 0 Engine End MDKBF 0 W/O PTO W/PTO 0 Generator End 0 0 Engine End 0 Washer, Flat (M) 0 00 Nut, Hex Machine (M x.) Washer, Flat (M) 0 Without PTO 0 With PTO 00 0 Screw, Hex Head Cap (M x. x mm) 00 Screw, Hex Head Cap (M x. x 0mm) 0 Washer, Rocker Ball (MDKBF) Screw, Hex Head Cap (MDKBF) (M0 x. x 0mm) 0 Mount, Engine MDKBF 0 0 MDKBF MDKBD, MDKBE Screw, Hex Head Cap (M x. x 0mm) 00 0 without PTO 00 0 with PTO

75 Grounding System 0 Strap, Bond 00 Washer, EIT Lock (/) 0 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x 0mm) 0 Screw, Hex Head Cap (M x. x 0mm) 00 Washer, Flat (M) 000 Washer, EIT Locking (/ ) 0 00 Nut, Hex (M x.mm) 0 Bar, Bus 0 00 Nut, Hex Brass (/ ) Strap, Electrical

76 Belt Guard and PTO Belt Guard Kit, Belt Guard (Neg Ground) (Includes Parts Marked*) 0 0 Kit, Belt Guard (ISO Ground) (Includes Parts Marked+) 0 0 Kit, Belt Guard (PTO) (Includes Parts Marked~) Guard, Belt W/O PTO 0 0 Negative Ground 0 0 Isolated Ground 0 0 ~Guard, Belt W/PTO ~Coupling Guard W/PTO Bracket, Guard 0 0 *~ Negative Ground Isolated Ground 0 0 *Bracket, Guard (Negative Ground) (W/O PTO) 0 0 *~Bracket, Guard (Negative Ground) 0 0 *+~Bracket, Guard *+~Screw, Hex Head Cap (M x ) 00 0 Negative Ground 00 0 Isolated Ground 00 0 PTO 0 *~Screw, Hex Head Cap (M x. x mm) ~Coupling, Guard 0 *+~Label, Warning All Parts are for Unhoused Units Only * Parts Included in Negative Gnd Belt Guard Kit + Parts Included in ISO Gnd Belt Guard Kit ~ Parts Included in PTO Belt Guard Kit

77 Generator Housing 0 0 Panel, Housing 0 0 Single Phase 0 0 Three Phase 00 0 Screw, Hex Head Cap (M x x mm) 00 Washer Lock ET (M) Screw, Hex Head Stainless (M x.0 x mm) Insulation, Panel (Side) 0 Single Phase 0 0 Three Phase 0 Insulation, Panel (Top) 00 Seal, Weather (. ) 0 Grommet, Rubber Isolation, Vibration Rivet, Pop 0 Insulation, Panel (Top) 0 Insulation, Panel (Rear) Cover, Enclosure (Rear) 000 Screw, Slotted Round Head (0 x.00 ) 000 Washer, EIT Lock (#0) 0 0 Nut, Sems 0 Strap, Bond 00 Washer, Flat (M) 000 Washer, EIT (#) Screw, Hex Head (M x 0mm) Washer, Flat 00 Strap, Bond 00 0 Screw, Hex Head Sems (M x. x mm) 000 Washer, EIT (#0) 0 0 Screw, Slotted Round Head (/ 0 x.) 00 Nut, Hex Brass (/ 0) 000 Washer, EIT (/)

78 Generator Housing Panel 0 REF PART QTY. PART REF PART QTY. PART 0 0 Panel, Housing 00 0 Screw, Hex Sems Stainless Steel (M x x mm) 0 0 Screw, Round Head Brass (/ 0 x /) 0 Lug, Solderless 00 Washer, ET (M) 0 Insulation, Sound 000 Washer, EIT (/ ) 0 Washer, Flat (M) 0 0 Nut, Hex (M) 0 0 Washer, Flat Harness, Battery (Includes Parts Marked *) 0 MDKBD, MDKBE 0 MDKBF 00 *Washer, Flat Brass (/ ) 0 *Block, Terminal *Cable, Welding 0 0. (MDKBD, MDKBE) 0 0 (MDKBF) 00 *Nut, (. ) 0 0 Nut, Hex Acorn (/ 0 Nylon) 00 Nut, Hex Brass (/ 0) 00 Washer, Flat (/ ) 00 0 Screw, Hex Head Cap (M x x mm) * Parts Included in Battery Harness