Genset. Parts Catalog KV KVC KVD

Transcription

1 Genset Parts Catalog KV KVC KVD Printed in U.S.A. /0 0G (KV Spec A L) (KVC Spec A C) (KVD Spec A B) Replaces 0 (KV Spec A K KVC Spec A C and KVD)

2 To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Onan manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY IN- STRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUC- TIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-

3 Introduction This manual applies to the standard Recreational Vehicle Generator Sets as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Using the model and specification number from your generator set nameplate, select parts that apply to your set. Right and left sides are determined by facing the engine end (front) of the set. Generator Set Data Table MODEL AND WIRING SPECIFICATION VOLTS HERTZ FUEL DIAGRAM.KV FU/A,B 0 0 Gasoline 0 0.0KV FR/B 0 0 LP 0 0.0KV FR/,C,D,E 0 0 LP 0 0.0KV FR/F,G,H,J 0 0 LP 0 0.0KV FR/K,L 0 0 LP 0 0.0KV FR/B 0 0 Gasoline 0 0.0KV FR/C,D,E 0 0 Gasoline 0 0.0KV FR/F,G 0 0 Gasoline 0 0.0KV FR/A,B 0/0 0 Gasoline KV FR/C,E 0 0 Gasoline 0 0.0KV FR/F,G 0 0 Gasoline 0 00.KV FA/00A,B 0 0 Gasoline 0 0.KV FR/F,G,J,K 0 0 Gasoline 0 0.KV FR/F,G,J,K 0 0 Gasoline 0 00.KV FR/0F,G,H,J 00 0 LP 0 0.KV FR/0K,L 00 0 LP 0 0.KV FA/0B 0 0 LP 0 0.KV FA/0C,D,E 0 0 LP 0 0.KV FA/0F,G,H,J 0 0 LP 0 0.KV FA/0K,L 00 0 LP 0 0.KV FR/C,E 00 0 Gasoline 0 0.KV FR/F,G,J,K 00 0 Gasoline 0 0.KV FA/F,G,J,K 0 0 Gasoline 0 0.KV FA/00A,B 0 0 Gasoline 0 0.KV FA/00C,E 0 0 Gasoline 0 0.KV FA/00F,G,J 0 0 Gasoline 0 0.0KVC A,B,C 0 0 Gasoline 0 0.0KVC A,B,C 00 0 Gasoline 0 0.KVD 0A,B 0 0 LP.0KVD 0B 0 0 LP.KVD 00A 0 0 Gasoline.KVD A 0 0 Gasoline Note The diagonal line (/) or dash ( ) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from a standard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes.

4 Index Arm, Governor Adjust, Arm, Rocker, Armature, Starter,, Baffle, Air, Baffle, Inlet (KV, KVD, Gasoline), Baffle, Inlet (KV, KVD, LP), Baffle, Seal, Base Mounting KV, Base Mounting KVD, Base, Housing (KV), Base, Housing (KVC), Base, Housing (KVD), Base, Mounting (KV), Base, Mounting (KVC), Base, Mounting (KVD), Base, Oil, 0 Bearing, Ball, Bearing, Choke Flange (KV Begin Spec C), Bearing, Choke Flange (KVC, KVD, Gasoline), Bearing, Crankshaft Ball, Bearing, Generator Rotor Ball, Block, Cylinder, Block, Generator Brush, Boot, Inlet Baffle Insulation (KV, KVD, Gasoline), Boot, Inlet Baffle Insulation (KV, KVD, LP), Boot, Spark Plug (KV), Boot, Spark Plug (KVC), Boot, Spark Plug (KVD), Box, Control (KV Spec A F), Box, Control (KVD and KV Begin Spec G), Brace, Generator, Bracket, Choke Mounting (KV Spec A, B), Bracket, Fuel Regulator (KV Begin Spec L and KVD Begin Spec B), Bracket, Lifting, Bracket, Muffler (KV Spec A G), Bracket, Muffler (KVD), Bracket, Muffler Hanger (KVC), Bracket, Regulator, Bracket, Solenoid, Bracket, Starter, Bracket, Underfloor Mounting, Breaker, Circuit (KV Spec A F), Breaker, Circuit (KVC), Breaker, Circuit (KVD and KV Spec Begin Spec G), Breather, Cylinder Head, Brush, Generator Brush Block, Bushing, Inlet Baffle Strain Relief (KV, KVD, Gasoline), Bushing, Inlet Baffle Strain Relief (KV, KVD, LP), Camshaft, Cap, Choke Dome (KV Begin Spec C), Cap, Choke Dome (KVC, KVD, Gasoline), Cap, Starter Drive,, Cap, Starter End,, Capacitor (KV Spec A F), Carburetor (LP), Carburetor, Gasoline, Choke (KV Begin Spec C), Choke (KV Spec A, B), Clamp, Loop, Clamp, Muffler (KVD), Clip, J, Clip, Choke U (KV Spec A, B), Clip, Governor Retainer, Clip, Rod End (KV Spec A, B), Clutch, Starter, Coil, Ignition (KV), Coil, Ignition (KVC), Coil, Ignition (KVD), Collar, Governor Control Lever, Components, Carburetor, Components, Starter (Begin Spec K), Components, Starter (Spec A J), Conduit (KVC), Connector, Barbed Hose (KV, KVD, LP), Connector, Conduit (KVC), Connector, Plug ( Pin) (KVC, KVD and KV begin Spec F), Connector, Receptacle ( Pin) (KVC, KVD and KV begin Spec F), Connector, Receptacle ( Pin) (KVC, KVD and KV begin Spec F), Control (KVC), Coupling, Anchor (KV, KVD, LP), Cover, Air Filter Element, Cover, Choke (KV Begin Spec C), Cover, Choke (KV Spec A, B), Cover, Choke (KVC, KVD, Gasoline), Cover, Choke Thermostat Element (KV Begin Spec C), Cover, Choke Thermostat Element (KVC, KVD, Gasoline), Cover, Cylinder Head, Cover, Housing (KV), 0 Cover, Housing (KVD), Cover, Mounting Base (KVC), Cover, Rocker Switch (KV Spec C F), Cover, Rocker Switch (KVC), Cover, Rocker Switch (KVD and KV Spec Begin Spec G), Cover, Starter Spring, Cover, Switch (KVC), Crankshaft, Diaphragm, Pull Off (KV Spec A, B), Diode, Remote Panel (KV Spec A E), Door, Generator Scroll Preheat, Duct, Endbell Air, Edging, Underfloor Mounting, Elbow, Fuel Pump (KVC), Elbow, Inlet Baffle (KV, KVD, Gasoline), Elbow, Inlet Baffle (KV, KVD, LP), Elbow, Intake (Gasoline), Elbow, Male (KV, KVD, LP),

5 Index Element, Air Filter, Element, Thermostat (KV Begin Spec C), Element, Thermostat (KV Spec A, B), Element, Thermostat (KVC, KVD, Gasoline), Endbell, Engine, Replacement, Ferrule, Muffler Hanger Wire Rope (KVC), Filter, Fuel, Flange, Air Cleaner, Flange, Air Cleaner (Gasoline), Flange, Air Cleaner (LP), Flyweight, Foam, Carburetor (KVC, KVD), Foam, Fuel Filter, Fuse (KV Spec A F), Fuse, Generator Harness (KV Spec C E), Fuse, Generator Harness (KVC), Fuse, Generator Harness (KVD and KV Begin Spec F), Fuse, Generator Harness (KVD and KV, Begin Spec F), Gasket, Carburetor (Gasoline), Gasket, Carburetor (LP), Gasket, Cylinder Head, Gasket, Drain Plug, 0 Gasket, Exhaust (KVD), Gasket, Gearcase, Gasket, Governor Retainer Clip, Gasket, Head, Gasket, Housing Base (KV), Gasket, Housing Cover (KV), 0 Gasket, Housing Cover (KVD), Gasket, Inlet Baffle Foam (KV, KVD, Gasoline), Gasket, Inlet Baffle Foam (KV, KVD, LP), Gasket, Intake Elbow (Gasoline), Gasket, Muffler (KV Begin Spec H), 0 Gasket, Muffler (KV Spec A G), Gasket, Muffler (KVC), Gasket, Muffler (KVD), Gasket, Oil Base, 0 Gear, Camshaft, Gear, Crankshaft, Gear, Governor, Gear, Starter, Gearcase, Generator, Governor, Grommet, Generator Harness (KVC), Grommet, Housing Base (KVC), Grommet, Inlet Baffle (KV, KVD, Gasoline), Grommet, Inlet Baffle (KV, KVD, LP), Grommet, Inlet Baffle (KVD, Gasoline), Grommet, Inlet Baffle (KVD, LP), Grommet, Muffler Bracket (KVC), Guard, Housing Cover Air Inlet (KV), 0 Guide, Push Rod, Hanger, Tailpipe (KV), Harness, AC Output (KVC), Harness, Adapter (KVC, KVD and KV Begin Spec F), Harness, DC (Z, Z, Z, Z) (KV Spec A, B), 0 Harness, DC (Z, Z) (KV Spec C E), Harness, DC (Z, Z) (KVD and KV Begin Spec F), Harness, Generator (J, J)(KVC), Harness, Generator (KV Spec A, B), 0 Harness, Generator (KV Spec C E), Harness, Generator (KVD and KV Begin Spec F), Harness, Generator (KVD), Harness, PCB, Harness, PCB (KV Spec C F), Harness, PCB (KVC, KVD and KV Spec ), Harness, PCB (KVC), Harness, PCB (KVD and KV Spec Begin Spec G), Harness, Remote Panel (KVD and KV Begin Spec F), Harness, Remote Panel (Switch Only), Harness, Remote Switch Panel (KV Begin Spec F), Harness, Remote Wiring (KV Spec A E), Harness, Remote Wiring (KVC, KVD and KV Begin Spec F), Harness, Wiring (Z)(KVC), Head, Cylinder, Holder Assy, Brush, Holder, Fuse (KV Spec A F), Holder, Generator Harness Fuse (KVC), Holder, Governor Spring, Hose, Breather,, Hose, Fuel (Gasoline), Hose, Fuel (LP), Hose, Vacuum (KV Spec A, B), Hose, Vapor, LP, Hose, Vent (LP), Hourmeter (KVD and KV Begin Spec F), Housing, Air Guide, Housing, Choke (KV Begin Spec C), Housing, Choke (KV Spec A, B), Housing, Choke (KVC, KVD, Gasoline), Housing, Scroll, Housing, Stator, Housing, Terminal (KVC, KVD and KV begin Spec F), Hub, Fan, Indicator, Oil Level, 0 Inlet Assy, Insulation, Inlet Baffle (KV), Insulation, Inlet Baffle (KVD), Insulation, Lower Exhaust Baffle (KV), Insulation, Upper Exhaust Baffle (KV), Insulation, Upper Exhaust Baffle (KVD), Insulator, Carburetor (Gasoline), Insulator, Carburetor (LP), Isolator, Vibration (KV Spec A), Isolator, Vibration (KV), Isolator, Vibration (KVC), Isolator, Vibration (KVD), Key, Camshaft,

6 Index Key, Crankshaft, Key, Fan Hub, Kit, Carburetor, Kit, Carburetor (Conversion), Kit, Carburetor Service (LP), Kit, Exhaust (KV), Kit, Filter Cover, Kit, Fuel Tank (KV), Kit, Muffler (KVD), Kit, Muffler Exhaust (KV Begin Spec H), 0 Kit, Piston Ring, Kit, Remote Adapter (KVC, KVD and KV begin Spec F), Kit, Remote Switch Panel (KV Begin Spec F), Kit, Remote Switch/Hourmeter Panel (KVD and KV Begin Spec F), Kit, Remote Switch/Voltmeter Panel (KVD and KV Begin Spec F), Kit, Starter Drive,, Kit, Underfloor Mounting, Kit, Underfloor Mounting (KV, KVD), Labels, Latch, Housing Cover Service Panel (KV), 0 Latch, Housing Cover Service Panel (KVD), Lever, Governor, Lever, Governor Control (Gasoline), Link, Generator Scroll Preheat, Link, Pulloff (KV Spec A, B), Linkage, Choke (KV Begin Spec C), Linkage, Choke (KV Spec A, B), Linkage, Choke (KVC, KVD, Gasoline), Lock, Housing (KVC, KVD and KV begin Spec F), LPG Mixer, Magneto, Meter, Hour (KVC), Meter, Remote Panel Battery Condition (KV Spec A E), Meter, Remote Panel Hour (KV Spec A E), Mixer (KV Begin Spec L and KVD Begin Spec B), Muffler (KV Begin Spec H), 0 Muffler (KV Spec A G), Muffler (KVC), Muffler (KVD), O Ring, End Bell, O Ring, Oil Base, 0 Paint, Panel Printed (KVD and KV Begin Spec F), Panel, Air Inlet (KVC), Panel, Housing Cover Service (KV), 0 Panel, Housing Cover Service (KVD), Panel, Printed (KVD and KV Begin Spec F), Panel, Remote (KV Spec A E), Panel, Remote Switch (KV Begin Spec F), Panel, Remote Switch Panel Printed (KV Begin Spec F), Panel, Remote Switch/Hourmeter (KVD and KV Begin Spec F), Panel, Remote Switch/Voltmeter (KVD and KV Begin Spec F), PCB Assy (KV Spec C F), PCB Assy (KVD and KV Spec Begin Spec G), PCB Assy, Capacitor (KV, KVD, Gasoline), PCB Assy, Capacitor (KV, KVD, LP), PCB, Capacitor (KVC), PCB, Control (KVC), Pin, Cylinder Block Alignment, Pin, Decompression Spring, Pin, Piston, Pin, Starter Spiral Roll, Pin, Terminal (KVC, KVD and KV begin Spec F), Pipe, Exhaust (KVD), Pipe, Vacuum Hose (Gasoline), Piston, Plate, Circuit Breaker (KV Spec A F), Plate, Circuit Breaker (KVD and KV Spec Begin Spec G), Plate, Governor Control Lever Pressure, Plug, Cavity (KVC, KVD and KV begin Spec F), Plug, Cavity (KVC, KVD and KV begin Spec F), Plug, Control Box Hole (KV Spec A F), Plug, Oil Drain, 0 Plug, Spark, Plug, Spark Plug Access Hole (KV), Plug, Spark Plug Access Hole (KVD), Pump, Electric Fuel (KV, KVD, Gasoline), Pump, Fuel (KVC), Rectifier, Generator Harness (KV Spec A, B), 0 Rectifier, Generator Harness (KV Spec C E), Regulator, Regulator, Fuel (KV Begin Spec L and KVD Begin Spec B), Regulator, Micro, Regulator, Voltage (KV), Regulator, Voltage (KVC), Relay, Disconnect (KV Spec A F), Relay, Generator Harness (KV Spec A, B), 0 Relay, Start Solenoid (KV, KVD, Gasoline), Relay, Start Solenoid (KV, KVD, LP), Relay, Start Solenoid (KVC), Relay, Stop (KV Spec A F), Resistor, Charging, Resistor, Generator Harness (KV Spec A, B), 0 Resistor, Generator Harness (KV Spec C E), Resistor, Generator Harness (KVD and KV Begin Spec F), Resonator, Exhaust (KV), Retainer, Air Filter Element, Retainer, Choke Cover (KV Spec A, B), Retainer, Starter Clutch, Retainer, Starter Ring, Retainer, Starter Spring, Retainer, Valve Spring, Ring, Choke Extension Retaining (KV Spec A, B), Ring, Choke Retaining (KV Spec A, B),

7 Index Ring, Collector, Ring, Piston Retaining, Rivet, Standoff (KV Spec C F), Rivet, Standoff (KVD and KV Spec Begin Spec G), Rod, Connecting, Rod, Governor, Rod, Push, Rope, Muffler Hanger Wire (KVC), Rotor, Generator, Scroll, Scroll Assy, Generator, Seal, Baffle Air (KVC), Seal, Baffle Panel (KVC), Seal, Cable (KVC, KVD and KV begin Spec F), Seal, Generator Scroll Air Intake, Seal, Mounting Base Air (KVC), Seal, Mounting Base Frame (KVC), Seal, Mounting Base Pan (KVC), Seal, Oil, Seal, Valve, Shaft, Choke (KV Spec A, B), Shaft, Flyweight, Shaft, Governor Lever, Shim, Camshaft, Shim, Crankshaft, Sleeve, Governor, Slinger, Oil, Solenoid, Shutdown (KV, KVD, LP), Solenoid, Throttle Closing, Spacer, Muffler Hanger (KVC), Splasher (Crankshaft), Spline, Starter, Spring, Choke Adjust (KV Spec A, B), Spring, Decompression, Spring, Generator Brush Block, Spring, Generator Stator, Spring, Governor, Spring, Governor Rod, Spring, Regulator Hose (LP), Spring, Starter Pinion, Spring, Valve, Standoff, PCB (KV Spec C F), Standoff, PCB (KVD and KV Spec Begin Spec G), Starter, Stator, Generator, Stop, Governor Adjust, Stopper, Governor Gear, Strap, Ground (KV Spec A G), Strap, Ground (KVC), Stud, B+, Stud, Generator Mounting, Stud, Generator Mounting (KV), Stud, Generator Mounting (KVD), Stud, Muffler Mounting (KV Begin Spec H), 0 Stud, Muffler Mounting (KV Spec A G), Stud, Muffler Mounting (KVC), Stud, Muffler Mounting (KVD), Stud, Vibration Isolator Mounting (KVC), Switch, Low Oil Pressure, Switch, Remote Panel Rocker (KV Spec A E), Switch, Remote Switch Panel Rocker (KV Begin Spec F), Switch, Rocker (KV Spec A F), Switch, Rocker (KV Spec C F), Switch, Rocker (KVC), Switch, Rocker (KVD and KV Begin Spec F), Switch, Rocker (KVD and KV Spec Begin Spec G), Switch, Rocker (KVD and KV, Begin Spec F), System, Choke (KVC, KVD, Gasoline), Tappet, Transformer (KV Spec A F), Transformer (KVC), Transformer (KVD and KV Spec Begin Spec G), Tube, Breather, Tube, Endbell, Tube, Exhaust (KV), Tube, Exhaust (KVC), Tube, Oil Fill, 0 Valve, Exhaust, Valve, Intake, Voltmeter (KVD and KV Begin Spec F),

8 Cylinder Block Engine, Replacement Gearcase (Includes Pin) Bolt Pin, Alignment Gasket, Gearcase 0 Bolt Slinger, Oil Block, Cylinder 0 0 Bracket, Lifting Clamp, J (LP Sets) 0 Screw, Hex Head Thread Form 00 0 KVC, Spec A (M x. x mm) 00 KV, KVC (Begin Spec B) and KVD (/ x. ) 0 0 Switch, Low Oil Pressure (S) Bolt 0 Gasket, Head 0 Pin, Alignment 0 Valve, Exhaust 0 Valve, Intake 00 Head, Cylinder (Includes Valve Guides and Valve Seats) 0 Breather 0 Bolt, Cylinder Head 0 Seal, Intake Valve 0 Spring, Valve 0 Retainer, Valve Spring 0 Cotter KV / KVC / KVD

9 Crankshaft 0 Rod, Connecting (Includes Following Bolt and Splasher) Bolt, Connecting Rod Splasher 0 Key, Crankshaft Bearing, Ball Shim, Crankshaft.0mm.0mm.mm.0mm.mm.0mm 0.mm.0mm Gear, Crankshaft 0 Key, Crankshaft Crankshaft KV Spec A B 0 Begin Spec C 0 KVC, KVD 0 Bearing, Ball Seal, Oil 0 Piston Ring, Retaining 0 Kit, Piston Ring Pin, Piston KV / KVC / KVD

10 Camshaft Washer Gear, Governor 0 Washer 0 Stopper Sleeve, Governor 0 Tappet 0 0 *Shaft, Flyweight *Flyweight Pin, Decompression (KVC, KVD and KV, Begin Spec C) *Pin, Decompression Spring Spring, Decompression(KVC, KVD and KV, Begin Spec C) Shim, Camshaft.0mm.0mm.mm.0mm.mm.0mm.mm.0mm.mm Gear, Camshaft KV 0 Spec A, B Begin Spec C KVC, KVD Key, Camshaft Camshaft KV 0 Spec A, B Begin Spec C (Includes Parts Marked *) KVC, KVD(Includes Parts Marked *) 0 Rod, Push 0 Guide, Push Rod 0 Stud 00 Arm, Rocker 0 0 Nut (Special) 0 Nut * Parts Included with Camshaft KVC, KVD and KV Beginning Spec C. KV / KVC / KVD

11 Cylinder Head Cover 0 0 Housing, Top Air Guide 0 Bolt 0 0 Clamp, Breather Hose Hose, Breather KV 0 Spec A F Begin Spec G KVC, KVD Gas (See page for LP) Gasket, Cover Cover, Cylinder Head (Includes Breather Tube) Tube, Breather Bolt 0 0 Plug, Spark (E) 0 0 Housing, Bottom Air Guide 0 Clip, J (KV, KVC) Screw, Pan Head Torx Thread Form (M x x mm) KV / KVC / KVD

12 Oil Base 0 0 Gasket, Oil Base Base, Oil O Ring Nut Indicator, Oil Level (Includes O Ring) 0 O Ring Tube, Oil Fill Bolt Bolt 0 0 Gasket 0 Plug, Oil Drain (M x.mm) 0 KV / KVC / KVD

13 Governor Screw, Hex Washer Head Thread Form (/ 0 x / )(LP) Stop, Governor Adjust (LP) 0 0 Arm, Governor Adjust (LP) 000 Washer, Flat (/ ) (LP) 00 Screw, Round Head Machine ( x. )(LP) Lever, Governor (Includes Parts Marked *) *Nut *Bolt 00 *Clip, Retainer 0 *Washer, Flat 0 *Holder, Governor Spring 0 *Spring 0 *Screw Shaft, Governor Lever (Includes Retainer Clip) 0 Clip, Retainer Spring, Rod Rod, Governor 0 Gasket Washer, Flat 0 0 Spring, Governor Nut, Flanged (M) Washer, Spring Lock Plate, Pressure Collar 000 Lever, Control (Includes Screw and Spring)(Gasoline Sets) 0 Spring 0 Screw 0 Stud * Parts Included in Governor Lever. KV / KVC / KVD

14 Choke System (KV Spec A, B) Clip, Rod End 000 Diaphragm, Pull Off 00 Clip, U 0 Hose, Vacuum Screw, Socket Drive Pan Head (M x x mm) 00 Choke (H) 0 Link, Pull Off 0 Housing, Choke 0 Ring, Choke Retaining Adjust 0 0 Element, Thermostat 00 Cover, Choke (Includes Choke Heater Element, Washers and Heater Spider) 00 Retainer, Choke Cover Screw, Pan Head Thread Forming with Socket Drive and IT Lockwasher (M x 0. x mm) Screw, Pan Head Thread Forming with Socket Drive and IT Lockwasher (M x 0. x 0mm) 0 Screw, Choke Adjust 00 Spring, Choke Adjust 000 Washer, Flat 0 Ring, Extension Retaining 00 0 Bracket, Choke Mounting 0 0 Shaft, Choke 0 Linkage, Choke KV / KVC / KVD

15 Choke System (KV Begin Spec C) 0 0 Cover, Element 00 Cap, Dome 0 0 Cover, Choke 000 Washer, Flat (#) 0 00 Nut, Lock Flange (M) 0 Linkage, Choke 00 Element, Thermostat 0 Bearing, Choke Flange 0 0 Cover, Choke Washer, Lock (#) Screw, Pan Head (# x / ) KV / KVC / KVD

16 Choke System KVC, KVD (Gasoline) 0 0 Linkage, Choke 0 Bearing, Choke Flange 00 Element, Thermostat 0 Cover, Element 00 Cap, Dome 0 0 Housing, Choke 0 00 Nut, Lock Flange (M x.) 000 Washer, Flat (#) 0 0 Cover, Choke Screw, Pan Head Sheet Metal (# x.) Washer, Lock (#) 0 0 Cover, Choke Housing KV / KVC / KVD

17 Fuel Filter Gasoline & Filter, Fuel Foam, Fuel Filter KV KVC, KVD Cover, Fuel Filter (KVC, KVD) Hose, Upper Fuel 0 KV Spec A (mm) 0 KV Begin Spec B (0mm) and KVC, KVD Begin Spec A 0 0 Clamp, Black Hose Hose, Lower Fuel KV 0 Spec A (mm) 0 Spec B (0mm) 0 Begin Spec C (00mm) KVC (mm) 0 Spec A 0 Begin Spec B 0 00 KVD (mm) Begin Spec A 0 Kit, Filter Cover (Includes Fuel Filter Foam, Foam Cover and Fuel Filter Foam Shown on Carburetor Page) Sleeving, Convoluted ( ) KV, KVD KVC Sleeving, Convoluted (KVD, / ) KV / KVC / KVD

18 Gasoline Carburetor 0 00 Kit, Carburetor (KV Begin Spec E, KVC Begin Spec C and KVD Begin Spec A) Bolt (M x x 0mm) 0 00 Washer, Flat (M) 0 Gasket, Carburetor Flange Flange, Air Cleaner KV Spec A D 0 KV Begin Spec E, KVC Begin Spec C, KVD Begin Spec A Gasket, Flange KV Spec A D 0 * Begin Spec E, KVC, KVD Carburetor KV 00 Spec A, B 0 Spec C D 00 * Begin Spec E (Includes Gaskets Marked *) 00 KVC Begin Spec A (Includes Parts Marked *) 00 KVD Begin Spec A Gaskets Marked *) 0 *Gasket, Carburetor Insulator KV Spec A D 0 0 KV Begin Spec E, KVC Begin Spec C KVD Begin Spec A Elbow, Intake (Includes Vacuum Hose Pipe) 0 Pipe, Vacuum Hose (KV, Spec A & B with hole) Gasket, Intake Elbow Insulator Bolt, Flange +Foam, Fuel Filter (KVC, KVD) * Parts Included when ordering carburetor 00 or carburetor kit Filter Foam Included in Filter Cover Kit Listed on Fuel Filter Page. KV / KVC / KVD

19 Gasoline Carburetor *Components (KV Spec A B) Carburetor Screw Valve, Choke Shaft, Choke Jet, Pilot Spring Adjuster 0 Shaft, Throttle Valve, Throttle Screw 0 Seal Spring Screw Packing, Chamber Float Pin 0 Nozzle, Main Float Body, Float O Ring Adjuster 0 Cap Screw Plate, Spring Bolt, Float Body O Ring Washer Clip (Obsolete) Needle * Service Parts Not Available for Other Carburetors. KV / KVC / KVD

20 LPG Carburetor/Regulator (KV Spec A K and KVD Spec A) KV / KVC / KVD

21 LPG Carburetor/Regulator (KV Spec A K and KVD Spec A B) Carburetor KV 0 Spec A,B (Includes Parts Marked *) 00 Spec C, D 0 Spec E, F, G (Includes Gaskets Marked ) 00 Spec H 00 Begin Spec J K (Includes Parts Marked~) KVD 00 Spec A 00 Begin Spec B 0 Gasket, Flange 0 Gasket, Carburetor Flange, Air Cleaner KV Spec A D 0 Spec E K 0 KVD Insulator KV Spec A D 0 0 Spec E K 0 0 KVD 0 Gasket, Carburetor Flange 0 00 Washer, Flat Bolt (M x x 0mm) 0 0 Spring, Regulator Hose(Used on KV during Spec F, G Only) 0 0 ~Clamp, Hose 0 +*Spring, Load Adjust 0 +*Screw, Load Adjust 0 +*Spring, Idle Adjust 0 +*Screw, Idle Adjust Hose, Vent KV 0 00 Spec A D (. ) 0 Begin Spec E (No Shorter Than ) 0 KVD (No Shorter Than ) 0 0 ~Clamp, Hose Regulator KV 0 Spec A D 0 Spec E G ~ Begin Spec H ~ KVD Hose, Outlet Fuel KV 0 00 Spec A D (. ) 0 00 Spec E G (/ ) 00 ~ Spec H J (. ) 0 0 ~ Begin Spec K (00mm) 0 0 ~ KVD (00mm) 0 Clamp, Hose Hose, Fuel ( ) Bracket, Regulator KV 0 0 Spec A G 0 Spec H K 0 KVD 000 Screw, Self Locking Hex Head Flange (#0 x /) Screw, Pan Head (M x x mm) 0 Kit, Carburetor (Conversion) (Used to Replace KV Spec A D) Carburetor and Components) (Includes Parts Air Cleaner Air Cleaner 0 Insulator Carburetor Flange LPG Emission 0 Hose Barb 0 Hose Vent Hose 0 LPG Fuel ( ) 0 Regulator Hose 00 Kit, Carburetor Service (Used to Service KV Spec A D Carburetors (Includes Parts Marked +) Clamp, Loop 0 Screw * Parts Included with KV Spec A, B Carburetor. ~ Parts Included with KV Spec J K Carburetor. Gaskets Included with KV Spec E G Parts Included in LPG Conversion Carburetor Kit. + Parts Included in LPG Carburetor Service Kit. KV / KVC / KVD

22 0 KV / KVC / KVD

23 LPG Mixer LP (KV FR0, FA0, FR Begin Spec L and KVD 0 0 Begin Spec B) 0 0 Regulator, Fuel 0 Obsolete KVFR,.KVFR0,.KVFA0,.KVD0, KVD0 Hose, Breather Mixer 00 Obsolete 00 LPG (0Hz) 0 LPG (0Hz) 0 0 Clamp, Hose 0 Hose, Fuel 0 Bracket, Fuel Regulator 00 Screw, Round Head (Mach) Washer, Spring Locking 0 Screw, Hex Thread Form Round, Head (Mach) 0 Bracket, Fuel Regulator 000 Screw, Locking Hex Head Flange (/ 0UNF x ) 0 Gasket, Carb Flange 0 00 Washer, Flat (M) Bolt, (M x x 0mm) Flange, Air Cleaner 0 0 Obsolete 0 LPG 0 and 0 Hz 0 Gasket, Air Cleaner 0 Gasket, Insulator 0 0 Insulator 0 Elbow, Intake 0 00 Washer, Flat (M) Bolt, Flange Gasket, Intake Elbow Insulator 0 0 Clamp, Hose 0 0 Hose, Vapor, LP 0 0 Hose, Clamp KV / KVC / KVD

24 Inlet Baffle KV, KVD (Gasoline) 0 KVD Mounting KV Mounting 0 KV / KVC / KVD

25 Inlet Baffle KV, KVD (Gasoline) Baffle, Inlet (Includes Conduit Elbow) KV 0 Spec A 0 0 Spec B 0 0 Spec C E 0 0 Spec F K 0 0 FR0, FR, FA0 Begin Spec L and KVD 0, 0 Begin Spec B 0 Elbow, 0 Conduit Screw, Pan Head Trox (M) 000 Clamp, Capacitor Mount 00 PCB Assy, Capacitor 00 Screw, Round Head Machine (# x. ) Nut, Hex (# ) 0 Gasket, Foam 0 0 Nut, Hex Flange Lock (M x mm) Grommet 000 Nut, Hex (/ ) 0 00 Washer, Spring Lock (/ ) Terminal 0 Relay, Start Solenoid Elbow, Inverted Male (0 ) 000 Washer, EIT Lock (/ ) 0 0 Elbow, 0 Hose (KV Spec C K and KVD)(Not used on KV Spec A,B) Pump, Electric Fuel (E) KV 0 Spec A,B Spec C E Spec F K FR0, FR, FA0, Begin Spec L and KVD 0, 0 Begin Spec B Clamp KV 00 Spec A,B 0 Begin Spec C 0 KVD Bushing, Strain Relief 0 Bushing, Strain Relief Boot, Insulation (B+ Lead) 0 Grommet (KVD) 0 Grommet (KVD) Line, Inlet Fuel KV 0 Spec A,B Begin Spec C KVD 0 0 Grommet, Fuel Line KV Spec A, B 00 Line Fuel (Includes Nut) KV Spec A, B KV / KVC / KVD

26 Inlet Baffle KV, KVD (LP) 0 KVD Mounting KV Mounting 0 0 KV / KVC / KVD

27 Inlet Baffle KV, KVD (LP) Baffle, Inlet (Includes Elbow) 0 0 KV 0 0 KVD 0 Elbow, 0 Conduit Screw, Pan Head (M) 000 Clamp, Capacitor Mount 00 PCB Assy, Capacitor 00 Screw, Round Head Machine (# x. ) Nut, Hex (# ) 0 Gasket, Foam 0 Grommet (KVD) Nut, Hex Flange Lock (M x mm) 0 0 Grommet 000 Nut, Hex (/ ) 0 00 Washer, Spring Lock (/ ) Terminal 0 Relay, Start Solenoid (K) 0 Clamp Begin(KVD and KV Spec C) 0 0 Bushing, Strain Relief 0 Bushing, Strain Relief Boot, Insulation (B+ Lead) 0 0 Connector, Barbed Hose 0 Solenoid, Shutdown 0 Coupling, Anchor 0 Line, Fuel Inlet 0 0 Elbow, Male (. x 0 ) Clamp, Hose 0 Spec C 0 0 Begin Spec L Hose, Fuel Line (. ID x ) KV 0 00 Spec C 0 0 Begin Spec L 0 0 KVD KV / KVC / KVD

28 Air Inlet Panel KVC 0 0 Inlet Assy (Includes Parts Marked +) 0 +Seal, Air (mm x 0mm) 0 0 +Seal, Air (mm) 0 0 +Seal, Air (.mm x 0mm) 0 0 +Seal, Air (mm x 0mm) 0 0 +Seal, Air (mm x 0mm) 0 0 Baffle, Air 0 Panel Assy (Includes Parts Marked *) 0 *Seal, Panel ( x.mm) *Seal, Panel (. x.mm) *Seal, Panel (. x.mm) *Seal, Panel ( x 0mm) 0 0 Baffle, Seal 00 0 Screw, Lock Flange (M x x mm) * Parts Included in Panel Assy. + Parts Included in Baffle Assy. KV / KVC / KVD

29 Fuel Pump/Start Solenoid Relay KVC Pump, Electric Fuel 0 0 Elbow, 0 Hose(. x. x ) 000 Washer, EIT (/ ) Screw, Pan Head Torx (M x 0. x mm) 00 Screw, Slotted Head (. x.) 00 PCB Assy, Capacitor 000 Clamp, Capacitor Mounting Nut, Hex (# ) 0 00 Nut (M x 0.mm) Screw, Pan Head Torx Thread Form (M x x mm) 0 0 Regulator, Voltage Stud, B+ 000 Nut, Hex Jam (/ ) 0 Washer, Flat (/ ) 0 0 Washer, Phenolic 00 Washer, EIT Lock 0 0 Relay, Start Solenoid Terminal 0 00 Washer, Spring Lock (/ ) Nut, Hex (/ ) 000 Screw, Lock Head (/ 0 x / ) KV / KVC / KVD

30 Fuel Tank Kit KV OBSOLETE 0 Tank, Fuel ( Gallon) Bushing, Reducer (/ x / ) 0 0 Valve, Shutoff (/ ) 0 0 Connector, Barbed Hose (/ ) 0 Hose, Fuel (/ ID x ) 0 0 Clamp, Hose 0 0 Coupling, Quick Disconnect Female 0 0 Coupling, Quick Disconnect Male Resonator KV REF PART QTY PART NO. NO. USED DESCRIPTION Resonator, Exhaust KV / KVC / KVD

31 Muffler (KV Spec A G) 0 Muffler 0 LP 0 Gasoline (Includes Choke Housing) 0 0 Nut, Hex Flange Locking (M) 0 0 Nut 0 Screw, Lock Flange (M x / x mm) 00 0 Screw, Hex Head Thread Forming (M x mm) 0 0 Bracket, Muffler 00 Strap, Ground 000 Washer, EIT Lock (/ ) 0 Bracket, Muffler 0 Clamp, J (LPG Units Only) Gasket, Muffler 0 Stud, Muffler Mounting KV / KVC / KVD

32 Muffler (KV Begin Spec H) Kit, Muffler Exhaust 0 LP 0 Gasoline Muffler (Includes Choke Housing) 0 LP 0 Gasoline 00 Screw, Hex Head Thread Form (/ x. ) 0 0 Nut Supplied with Engine Gasket, Muffler (Included with Engine) 0 Stud, Muffler Mounting 0 KV / KVC / KVD

33 Muffler KVC 0 Muffler, Exhaust Tube, Exhaust Clamp, Muffler (Includes Clamp, U Bolt and Nuts) 00 0 Screw, Hex Head Cap (M x x 0mm) Gasket, Muffler Tube, Flex Exhaust 0 0 Nut, Lock Flange 0 Bracket, Muffler Hanger (Includes Parts Marked*) 0 00 *Grommet, Rubber Obsolete *Spacer, Muffler Hanger Obsolete 0 0 *Ferrule, Wire Rope 0 0 *Rope, Wire (0mm) 0 Screw, Hex Head Cap (M x.) 00 Washer, Flat (M) 0 00 Nut, Hex (M x.) Clamp, Muffler (Includes Clamp, U Bolt and Nuts) Tube, Exhaust 0 0 Nut, Lock Flange 0 Stud, Muffler Mounting * Parts Included in Hanger, Not Sold Separate. KV / KVC / KVD

34 Muffler KVD 0 0 Bracket, Muffler Gasket, Muffler 00 Screw, Hex Washer Head Thread Form (/ x. ) 0 0 Nut Supplied w/engine 0 Kit, Muffler (Includes Parts Marked *) *Pipe, Exhaust *Gasket, Exhaust *Clamp, Muffler (Includes Clamp, U Bolt and Nuts) 00 *Screw, (/ x /) *Nut, Flanged *Muffler 00 *Washer, #0 0 Stud, Muffler Mounting * Parts Included in Muffler Kit KV / KVC / KVD

35 Exhaust Kit KV,,, Kit, Exhaust Tubing (Includes Parts Marked *) Kit, Exhaust Tubing (Flexible) (Includes Parts Marked #) Kit, Exhaust Tubing (Flexible) (Includes Parts Marked ~) Kit, Vertical Exhaust Tubing Extension (Includes Parts Marked +) ~Tube, Straight Exhaust (00mm) *Tube, Exhaust (mm) +Tube, Exhaust (mm) #Tube, Exhaust (mm) +~#* Hanger, Tailpipe (Included in all Kits Listed) 0 +~#Clamp (Marked / ) +~#* Clamp (Marked / ) (Included in all Kits Listed) * Parts Included in Exhaust Tubing Kit. # Parts Included in Flexible Exhaust Tubing Kit. ~ Parts Included in Flexible Exhaust Tubing Kit. + Parts Included in Vertical Exhaust Tubing Extension Kit. KV / KVC / KVD

36 Mounting Base KV, 0 Base, Housing 0 Spec A 0 0 Spec B 0 0 Begin Spec C 00 0 Gasket (0mm x mm x 0mm) 0 Insulation, Lower Exhaust Baffle 00 0 Screw, Pan Head Socket Clamp, Regulator 0 Terminal, Spark Plug 0 Boot, Spark Plug Regulator, Voltage Spec A, B Hz Hz 0 0 Begin Spec C 0 S0 Coil, Ignition (T) (Includes Lead, Cap, and Boot) Nut, Hex (M) 0 Plug, Spark Plug Access Hole 000 Washer, EIT Lock (#) 00 0 Screw, Pan Head Socket Drive (M x mm) 0 0 Nut, Locking Hex Flange (M) 000 Washer, EIT (/ ) 0 Clip (Begin Spec L) KV / KVC / KVD

37 Mounting Base KVD, Base, Housing 00 0 Gasket Foam (0mm x mm x 0mm) 00 0 Screw, Pan Head Torx (M x x mm) 0 0 Regulator, Micro Voltage 0 Terminal, Spark Plug 0 Boot, Spark Plug Screw, Pan Head Torx (M x 0. x mm) 0 S0 Coil, Ignition (T)(Includes Lead, Cap, and Boot) 000 Washer, EIT Lock (#) Nut, Hex (M) 0 Plug, Spark Plug Access Hole 0 0 Nut, Locking Hex Flange (M x mm) 000 Washer, EIT Lock (/ ) 0 Clip (Begin Spec B) KV / KVC / KVD

38 Mounting Base KVC Base, Housing 0 Grommet (mm ID) 0 0 Nut, Hex Flange Locking (M) 0 0 Isolator, Vibration 0 Nut, Pan Head with Internal Thread (M x. x.0mm) 0 0 Grommet ( / ID) Grommet (/ ID) 0 0 Cover, Base 00 0 Screw, Hex Head Sems (M x x mm) 0 0 Seal, Pan (.mm) 0 Grommet, Oval 0 Seal, Pan (.mm) 0 0 Seal, Pan (mm) 0 Seal, Frame (.mm) 0 0 Seal, Air (0mm) Isolator, Vibration With Yellow Dot (Generator End) With Blue Dot (Engine End) 0 0 Stud, Mounting KV / KVC / KVD

39 Ground Strap KVC 000 Washer, EIT Lock (/ ) 0 Washer, Spring Conical (Spec A Only) 00 Strap, Ground 00 0 Screw, Hex Head Thread Form (M x. x mm) KV / KVC / KVD

40 Base Mounting KV Isolator, Vibration 0 Nut, Pan Head with Internal Thread (M x.0mm) 0 0 Nut, Hex Flange Locking (/ 0) Spec A Isolator, Generator Mount Vibration (With Yellow Dot) 0 0 Stud, Generator Mounting Isolator, Engine Mount Vibration (With Blue Dot) 0 Insulation, Inlet Baffle 00 Screw, Thread Form (/ x.) 0 Screw, Hex Washer Head Locking (M x 0mm) 0 00 Strap, Bond Nut, Hex Flange Locking (M) 0 0 Spec A 0 0 Spec B 0 0 Spec C 000 Washer, EIT Lock (/ ) 000 Washer, EIT (/) 0 00 Washer, Flat (M) (K Relay Mounting) 0 00 Nut, Hex (M) (K Relay Mounting) 0 Insulation, Exhaust Baffle (Upper) KV / KVC / KVD

41 Base Mounting KVD Nut, Hex Flange Locking (M) 0 0 Isolator, Vibration 0 Nut, Pan Head with Internal Thread (M x.0mm) 0 0 Nut, Hex Flange Locking (/ 0) Isolator, Generator Mount Vibration (With Yellow Dot) 0 0 Stud, Generator Mounting Isolator, Engine Mount Vibration (With Blue Dot) 0 Insulation, Inlet Baffle (Inlet) 00 Screw, Thread Form (/ x. ) 0 0 Screw, Hex Washer Head Lock Flange (M x 0mm) 000 Washer, EIT Lock (/ ) 00 Strap, Bond 000 Washer, EIT (/) Insulation, Exhaust Washer, Split Lock (/ ) 000 Nut, Hex (/ 0) KV / KVC / KVD

42 Housing Cover KV Cover, Housing 0 Spec A 0 Begin Spec B 0 0 S0 Panel, Service( Includes Gasket and Latch) 0 Gasket 0 0 Latch 00 0 Gasket, Foam (Spec A) Obsolete (mm x.mm x.mm) 00 0 Gasket, Foam (Spec A) (0mm x.mm x.mm) Obsolete 0 Guard, Air Inlet (Spec A) 0 Screw, Thread Cutting Socket Drive (Spec A) (# x.mm) 0 Screw, Truss Head (M x mm) 0 KV / KVC / KVD

43 Housing Cover KVD 0 Cover, Housing 0 0 S0 Panel, Service (Includes Gasket and Latch) 0 Gasket 0 0 Latch 0 Screw, Truss Head (M x mm) KV / KVC / KVD

44 KV / KVC / KVD

45 Underfloor Mounting Kit KV, KVD Kit, Underfloor Mounting (Includes all Parts Listed) 0 KV 0 KVD 0 0 Bracket 0 Washer, Flat (/ ) Screw, Hex Head Cap (/ x / ) 0 0 Nut, Locking Head Flange (/ ) 0 0 Edging Brace, Generator KV 0 0 KVD 00 Washer, Flat (/ ) Screw, Hex Head Cap (/ x ) KV / KVC / KVD

46 Endbell 0 0 LPG Gasoline KV / KVC / KVD

47 Endbell Starter (B) (See Separate Page for Components) KV Spec A J and KVC Spec A B KV Begin Spec K, KVC Begin Spec C and KVD Begin A Supercede and Washer, Flat (M) 0 00 KVD Spec A G 0 00 KVC, KVD and KV, Spec H K 0 Screw, Hex Head Washer (M x. x 0mm) 00 Washer, ET Lock (/ ) 0 Bracket, Starter 0 0 Nut, Lock (#0 ) Screw, Pan Head (M x x 0mm) 000 Nut, Hex (/ 0) Washer, Spring Lock (/ ) Nut, Hex (M x.) (KV, Spec A H) 0 0 Washer, Centering (KV only) 0 0 Resistor, Charging (R) (KV only) 00 Screw, Hex Head Thread Forming Socket Drive (#0 x / )(KV only) Spring, Stator Block, Generator Brush (Includes Spring and Brush) 0 Spring 00 Brush Screw, Pan Head (M x mm) 000 Washer, Flat (/ ) 0 0 S0 Magneto Tube, Endbell 00 KV Spec A K, KVC Spec A B KVD Spec A (Gasoline) 0 KV FR0 FR FA0 Begin Spec L and KVD 0, 0 Begin Spec B (LP) 0 Screw, Phillips Head (# 0 x / ) Duct, Air Endbell KV 00 Spec A,B 00 Spec C F 0 Spec G K 0 Begin Spec J KVC 0 Spec A B 0 Begin Spec C KVD 0 Spec A 0 A, Begin Spec B KV / KVC / KVD

48 Scroll S Scroll Assy (Includes Parts Marked *) 0 0 *Seal, Air Intake *Housing, Scroll *Link, Preheat (Early Specs Only) *Door, Preheat (Early Specs Only) Screw, Pan Head Torx Threads Forming (M0 x. x mm) 0 0 Element, Air Filter 0 Retainer, Element 0 Cover, Element * Parts Included in Gasoline Units Scroll Assy. KV / KVC / KVD

49 Starter Components KV (Spec A J) KVC (Spec A B) 0 Starter (B) Cap Assy, End (Includes Brushes) Armature Cap Assy, Drive (Includes Bushing) Kit, Drive (Includes Parts Marked *) *Retainer, Spring 0 *Spring, Pinion *Pin, Spiral Roll *Cover, Spring *Retainer, Clutch 0 *Washer *Gear, Starter *Clutch and Spline * Parts Included in Drive Kit. KV / KVC / KVD

50 KV / KVC / KVD

51 Starter Components KV (Begin Spec K) KVC (Begin Spec C) KVD (Begin Spec A) Starter, Complete (B) 0 Retainer, Ring Cap Assy, Drive (Includes Bushing) Armature Cap Assy, End (Includes Bushing) Holder Assy, Brush (Includes Brushes) Kit, Drive (Includes Ring Retainer, Retainer Spacer, Wave Washer, Spring, Starter Gear, and Clutch/Spline) KV / KVC / KVD

52 Generator KV / KVC / KVD

53 Generator 0 Bolt, Rotor Thru (/ NC x.0 ) 0 Washer, Fan Hub Hub Assy, Fan (Includes Magnet & Rivets) KV 0 0 Spec A B (Includes Parts 0 Insert 000 Screw, Socket Drive Pan Head (M x 0mm) 0 00 Begin Spec C 0 00 KVC, KVD Screw, Pan Head Trox Thread Forming (M x x mm) Washer, Flat (M) (KV Begin Spec J, KVC Begin Spec B, KVD) 0 00 O Ring (Supersedes 0 0) 0 00 Bearing, Ball 0 0 Ring, Collector Stator, Generator KV 0Hz 0 S Spec A H 0 0 Begin Spec J 0Hz 0 0 Spec A E Spec F G & 0 0 Spec F H 0 0 Begin Spec J KVC 0Hz 0 0 Spec A 0 0 Begin Spec B KVD 0Hz 0 0 Spec A 0Hz 0 0 Begin Spec B 0 Cap, Terminal (Black) Cap, Terminal (Natural) 0 Key, Fan Hub Rotor, Generator (Includes Bearing and Collector Ring) KV 0Hz Spec A B Spec C H Begin Spec J 0Hz Spec A B Spec C E Spec F G & Begin Spec F KVC 0Hz Begin Spec A KVD 0Hz and 0Hz Begin Spec A 0 Solenoid, Throttle Closing (Includes Nut and Washer) (K) (KV) 0 00 Washer, Flat (M) (KV Spec A H) 0 0 Bracket, Solenoid (KV) Housing, Stator KV Spec A H V, 0V, 0V 0 0 0V 0 0 Spec J L KVC, Spec B KVD (mm) 0 0 Stud, Generator Mounting 0 0 Nut, Hex Flange Locking (/ 0) (KV Spec A) Isolator, Vibration (KV Spec A) 0 S0 Assy, Parts Included in Spec A B Fan Hub Assy KV / KVC / KVD

54 Control (KV Spec A F), P P 0 0 Box, Control Spec A,B 0 Spec C F 0 0 Nut, Self Locking ( ) 00 PCB Assy (Includes PCB Harnesses, Switch Cover and Switch) (Spec C F) Harness, PCB (P)(Spec C F) Obsolete Harness, PCB (P)(Spec C F) Obsolete 0 0 Switch, Rocker (Spec C F) 0 0 Cover, Rocker Switch (Spec C F) 0 0 Standoff, PCB (Spec C F) 0 0 Rivet, Standoff (Spec C F) 0 Breaker, Circuit (CB) 0.A 0 0.A 0 0 A 0 0A 0 0.KV FR/F KV FR/A 0 0.0KV FR/F.KV FR/F 0 A Terminal, Tab Adapter (Used on. KV) Screw, Socket Drive Pan Head (M x MM) 0 Relay, Start Disconnect (K) Capacitor (C) 0 0 Spec A, B 00 Spec C F 00 Screw, Round Head Machine (# x / ) 000 Clamp Nut, Hex (# ) 00 0 Screw, Pan Head Machine (M x x mm) Relay, Stop (V) 0 K 0 K (Used on. And.0 KV) ( Wire) 0 K Magneto Grounding 0 00 Screw, Round Head Machine (# x / ) 000 Washer, Flat 0 Fuse (F, F) 00 Holder, Fuse (Cap and Base) 0 0 Switch, Rocker (S) 0 Screw, Cross Recessed ET Phillips (# x / ) 0 Plug, Hole 0 Plate, Circuit Breaker (Used with 0 0 Spec Spec A F) 0 0 Transformer Assy (00V Sets) KV / KVC / KVD

55 Control (KVD and KV Begin Spec G), 0 P P 0 Box, Control 00 PCB Assy (Includes PCB Harnesses, Switch Cover Label and Switch) Harness, PCB (P)Obsolete Harness, PCB (P) 0 0 Switch, Rocker (S) 0 0 Cover, Rocker Switch 0 0 Standoff, PCB 0 0 Rivet, Standoff Breaker, Circuit Amps.KVFR KVFR Amps.KVFR 0 Amps.KV FA00,FR FA.KVFR0 0 0 Screw, Cross Recessed ET Phillips (# x / ) 0 Plate, Circuit Breaker (Used with Transformer Assy (00V Sets) 00 0 Screw, Pan Head Torx (M x x mm) KV / KVC / KVD

56 Control KVC 0, 0 0 P P 0 S0 Coil Assy, Ignition (Includes Lead, Boot and Terminal) 0 Boot, Spark Plug 0 Terminal, Spark Plug 0 Coil, Ignition Screw, Pan Head Torx Thread Form (M x 0. x mm) 0 0 Cover, Switch 0 00 Meter, Hour 0 0 Transformer Assy (00V Units) (Reaches from Control PCB to Genset [J] Harness) 0 Breaker, Circuit (A) 0 0 Screw, Pan Head Cross Recessed (# x / ) 0 0 Rivet, Standoff Harness, PCB (P) Harness, PCB (P)Obsolete 00 PCB, Control (Includes PCB Harnesses, Switch Cover and Switch) 0 0 Switch, Rocker 0 0 Cover, Rocker Switch 0 *Conduit Assy (Includes Connectors and Conduit) 0 *Connector, 0 *Conduit, Flex (/ ) *Connector, Straight Conduit (/ ) Obsolete 0 Bushing, Anti Short (/ ) Harness, AC Output * Marked Items For Reference only Not For Sale KV / KVC / KVD

57 Remote Panel (KV Spec A E) Screw, Oval Head Cross Recessed Wood (# x / ) 00 Standard Control 00 Deluxe Control 0 0 Switch, Rocker (S) Panel, Control 0 Standard Control 0 0 Deluxe Control (Obsolete) 0 0 Meter, Hour (M) 0 0 Meter, Battery Condition (M) 00 Diode Obsolete 0 Screw, Round Head Machine (# x / ) Nut, Hex Head (# ) KV / KVC / KVD

58 Remote Switch Panel (KV Begin Spec F) 00 Kit, Remote Switch Panel 00 Screw, Wood (# x ) 0 Panel, Printed 0 0 Switch, Rocker 0 Harness, Remote Panel (Includes Plug and Pins) 0 Plug, Pin Pin, Contact KV / KVC / KVD

59 Remote Switch/Hourmeter Panel (KVD and KV Begin Spec F) 00 Kit, Remote Switch/Hourmeter Panel 00 Screw, Wood (# x ) 0 0 Panel, Printed 0 0 Switch, Rocker 0 00 Hourmeter Harness, Remote Panel (Includes Plug and Pins) 0 Plug, Pin Pin, Contact KV / KVC / KVD

60 Remote Switch/Voltmeter Panel (KVD and KV Begin Spec F) 0 00 Kit, Remote Switch/Voltmeter Panel 00 Screw, Wood (# x ) 0 Panel, Printed 0 0 Switch, Rocker 0 Voltmeter 00 Washer, Nylon Flat (#0) 00 Washer, Brass Flat (#0) Washer, Lock (#0) 000 Nut, Hex Brass Machine (#0 ) 0 Harness, Remote Panel (Includes Plug and Pins) 0 0 Plug, Pin Pin, Contact KV / KVC / KVD

61 Remote Wiring Harness (KV Spec A E) 0 0 Harness, Wiring (Includes Parts Marked *) 000 *Pin, Contact 0 +*Tie, Cable 000 *Housing, Connector ( Place) 0 Harness, Wiring (Includes Parts Marked +) 0 +Housing, Connector ( Place) +Pin, Contact Harness, Wiring (Includes Parts Marked ~) 0 ~Housing, Connector ( Place) 0 ~Pin, Contact 0 ~Socket, Connector 00 ~Housing, Connector ( Place) Harness, Wiring (Includes Parts Marked &) 0 0 Ten Foot 0 0 Thirty Foot &Pin, Contact 0 &Housing, Connector ( Place) (J) * Parts Included in 0 Wiring Harness. + Parts Included in 0 Wiring Harness. ~ Parts Included in Wiring Harness. & Parts Included in 0 0 & 0 Wiring Harness. KV / KVC / KVD

62 Generator Harness (KV Spec A, B) 0 0 Harness, Generator Gasoline Sets (Includes Parts Marked *) 0 Spec 0 Spec, A 0 Spec B 0 Spec 00 LP Sets (Includes Parts Marked +) Spec Spec *Rectifier, Silicon (CR, CR) +*Socket, Relay ( Pin) (K) Obsolete +*Plug, Connector ( Pin) (P) *Resistor, Fixed (P to P ) (Includes Sleeving & Sockets) Spec Spec, 0 +*Relay (LP=K) (Gasoline=K) +*Housing, Terminal (P) ( Pin) 0 *Relay (Gasoline=K) 0 Harness, Wiring Z (DC) 0 * Gasoline Units + LP Units Z (DC)Obsolete 0 * Gasoline Units + LP Units Obsolete * Z (Spec B Only) Z 0 +* Spec,, A, Obsolete * Spec B * Parts Included in Gasoline Generator Harness. + Parts Included in LP Generator Harness. 0 KV / KVC / KVD

63 Generator Harness (KV Spec C E) J 0 J Harness, Generator J (Includes Parts Marked *) Spec, 00,, 0,, 0A Spec J (Includes Parts Marked +) Spec 00, 0 Spec Spec, Spec *Housing, Terminal ( Pin) (J) 0 S *Fuse Assy, A (F) (Includes Fuse) 00 0 *Fuse, A (F) *Receptacle ( Pin) (J) *Wedge, Receptacle ( Pin) (J) *Plug, Connector ( Pin) (P) +Harness, DC 0 Z Z Spec, Spec 0 0 +Resistor (R) 0 0 +Rectifier, Bridge (CR) 0 +Wedge, Receptacle (J)( Pin) +Socket, Receptacle (J) +Resistor, Fixed (P P ) (Includes Sleeving & Sockets) Spec (J to J ) Spec, (P to P ) Spec (P, P ) * Parts Included in (J) Generator Harness. + Parts Included in (J) Generator Harness. KV / KVC / KVD

64 Generator Harness (KV Begin Spec F) J 0 J Harness, Generator J (Includes Parts Marked *) Spec, 0, 00,, 0, Spec Obsolete Spec Obsolete J (Includes Parts Marked +) 0 Spec Spec, 0 Spec, 0 Spec, 00, 0 0 Begin Spec L *Connector, Plug ( Pin) (J) 0 S *Fuse Assy, A (F) (Includes Fuse) 00 0 *Fuse, A (F) *Receptacle ( Pin) (J) *Wedge, Receptacle ( Pin) (J) 0 *Seal, Cable (J) *Housing, Lock (J) *Plug, Cavity (J) Resistor (R) Spec, 0 (P, P ) Spec,, (P, P ) 0 +Wedge, Receptacle ( Pin) (J) +Socket, Receptacle (J) +Plug, Connector ( Pin) (P) +Harness, DC 0 Z Z (Spec Only) * Parts Included in (J) Generator Harness. + Parts Included in (J) Generator Harness. KV / KVC / KVD

65 Generator Harness KVC 0 J J J J J Harness, Generator J (Includes Parts Marked +) J (Includes Parts Marked *) 0V Units 00V Units *Plug, Connector (P) ( Pin) *Socket, Receptacle (J) *Wedge, Receptacle (J) ( Pin) +Receptacle (J) ( Pin) +Wedge, Receptacle (J) ( Pin) +Terminal, Pin (J) 0 +Holder, Fuse (F) Fuse (A) (F) +Connector, Plug (J) ( Pin) 0 0 +Terminal, Socket (J) +Housing, Lock (J) +Plug, Cavity (J) 0 +Seal, Cable (J) Grommet + Parts Included in (J) Genset Harness. * Parts Included in (J) Genset Harness. * Parts Included in Wiring Harness KV / KVC / KVD

66 Generator Harness KVD J P J 0 J Harness, Generator (Included with Harness*) 00 Spec A Begin Spec B *Socket, Receptacle *Wedge, Receptacle ( Pin) *Plug, Connector ( Pin) AR *Terminal, Pin AR *Terminal, Receptacle ( x 0) Harness, Generator Spec A 0 A and Begin Spec B 0 S +Fuse Assy, (Amp)(F) +Receptacle ( Pin) 0 +Wedge, Receptacle ( Pin) +Connector, Plug ( Pin)(J) +Housing, Lock +Plug, Cavity 0 +Terminal, Socket KV / KVC / KVD

67 PCB Harness,, Harness, PCB (Includes Parts Marked *)(KVC, KVD and KV, Spec ) *Cap, Connector ( Pl) *Terminal, PCB Tab *Pin, Contact 0 Harness, Wiring (Z)(Includes Parts Marked #)(KVC) KV / KVC / KVD

68 Remote Wiring Harness (KVC, KVD and KV Begin Spec F) 0, 0 0 KV / KVC / KVD

69 Remote Wiring Harness (KVC, KVD and KV Begin Spec F) Harness, Adapter (Pigtail at Control Panel) (Includes Parts Marked *) (Use With Gasoline and LP Kits 00, 00,& 00 ) *Housing, Terminal 00 *Socket, Contact 0 0 Kit, Remote Adapter (Pigtail at Genset End) (Includes Parts Marked ^) 0 ^Seal, Cable ^Splice, Thermal (Not Shown) C ^Sheet, Instruction (Not Shown) 00 ^Harness, Remote (Includes Parts Marked #) #Lock, Housing ( Pin) 0 #Connector, Receptacle ( Pin) 0 #Pin, Terminal #Plug, Cavity 0 #Seal, Cable Kit, Remote Adapter (Lead Assemblies) Harness, Adaptor ( Inches) (New Set to Old Panel) (Includes Parts Harness, Remote (Includes Parts Marked <) 0 0 Feet 0 0 Feet <@Lock, Housing ( Pin) <@Connector, Receptacle ( Pin) Terminal 0 <@Plug, Cavity 0 <@Seal, Cable <@Housing, Terminal 00 <@Socket, Contact Harness, Adaptor ( Inches) (For Sets Prior to Spec F) (Include Parts Marked ~) ~Pin, Contact 0 ~Housing, Connector ( Place) ~Connector, Plug ( Pin) ~Lock, Housing ( Pin) ~Plug, Cavity 0 0 ~Seal, Cable 0 ~Socket, Terminal * Parts Included in Adapter Harness. ^ Parts Included in 0 0 Remote Adapter Kit. # Parts Included in 00 Remote Parts Included in Adapter Harness. < Parts Included in 0 & 0 Remote Harness. ~ Parts Included in Adapter Harness. KV / KVC / KVD

70 Labels and Paint Label, Warning (Hazardous Voltage) (KV, KVD) Label, Air Filter (Gasoline) Label, Rating (Amp) (KV) 0 Label, Warning (Noxious Fumes) (KV) Label, Barcode (KVC and KVD) Label, Amp Rating (KV) 0 A (KVD.0 and.) 0.A 0 0A (Begin Spec F and KVD.0 and.) 0 Label, Amp Rating ( Amp) (KVD) 0 0 *Label, Warning (Substances) 0 Label, Air Filter (All Units) Label, AC Notice (.) (KV) (Gasoline) 0 Label, Phone Info Label, Control (KVD) *Label, Ground (All Units) *Label, Ground (KVD) KV Gasoline KV LP KVD 0 Label, Listed (White, KVD. and.) 0 Label, Logo (00) 0 Label, Logo (00) 0 Label, Logo (000) 0 Label, Logo (00) 0 Label, Phone Info 0 Label, Warning (Substances) Label, Warning (Hazardous Voltage) 0 Label, Listed (KVD) Label, Warning (Install)(KVC) Label, Warning (Install, Hazardous Volt/Exhaust Gasoline)(KVC) Label, Warning (Install)(KVD) Label, Warning (Install)(KVD) 0 Label, Blank (KVC and KVD) 00 AR Paint, Green Enamel ( oz. Pressurized Spray Can) 0 AR Sealant, Thread (0 cc Bottle) 0 LP 0 Gasoline * Parts Sold in Kit Only KV / KVC / KVD

71 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0, 0, 0, 0 0, 0, 0 0, 0 0, 0 0, 0 0 0, 0 0, 0, 0 0, 0, 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0, 0, 0, 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 00, 0, 0 0,,,,, 0,, S,,, 0 0, 0, 0, 0,,, 0,,, 0 0,,, 0,,, 0 0, 0,,, 00,, 0, 0, 00, 0, 0, 0, 0, 0, 00, 0, 0, 00, 00, 00, 00, 00, 00,, 0, 0 0, 0, 0, 0,, 0, 0, 0,, 0,, 0, 00,, 0, 0,,,,,, 0, 0 0, 0 0, 0, 0, 0, 0, 0 0, 0 0 0, 0, 000, 0, 0, 0, 0, 0, 000, 00, 00, 00 0, 00, 00, 0, 00,, 0, 0 0, 0 0,, 0,, 0 0, 0 0, 0,,,,,,, 0, 0 0,,,,,,,,,,,, 0,,,,,, 0, 0, 0 0, 0 0,, 0 0,, 0,, 0,, 0 S0, 0, 0 S0,,, 0 S0, 0 0, 0,,, 0,,,,,,

72 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page,, 0, 0 0, 0 0, 0,,,,,,,, 0,,,,,,,,,,,, 0,,, 0,,,,,,,,, 0, 0, 0, 0,, 0,, 0, 00, 0, 0, 0, 0, 0, 0, 0, 0, 0, 0,,,,,,,,,, 0 0, 0, 0, 0, 0, 0, 0, 0,,,,,,,,,,,,,,,,,,, 0,,,,,,, 0,,,,,,,, 0,,,,,,,,, 0,,,,,,,,,,,,, 00, 0, 0, 0, 0, 0,,,,,,,,, 00, 0,,,,, 0,,,,,,, 0,,,,,,,,, 0,,,, 0 0 0, 0 0 0, 0 0 0, 0 0, 0 0, 0 0, 0

73 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 00, 00, 00, 0, 0, 0,, 00, 0 0, 0 0, 0 0, 0 0, 0 0, 0 S, 0 0, 0 0, 0 0,,,, 0,, 00, 00,,,, 00, 00, 00, 00, 00,,, 0, 0 0, 0 0 0, 0 0, 0 0, 0, 0 00,, 0 0,,, 0 0, 0 0, , , 0, , , 0 0, 0 0, 0 0 0, , 0 0, 0 0,,, 0 0, 0, 0 0,, 0 0, 0 0, 0,, 0, 0 0, 0, 0, 0 0, 0 0, 0 0, 0 0,,, 0 0,,, 0 0, 0 0,,, 0,, 0,, 0, 0 0, 0, 0, 0, 0 0, 0,,, 0 0, 0 0,, 0 0,, 0, 00, 00 0,,, 0 S,,, 0, 000, 00, 0, 000,,,,,,, 00, 0,,,,,, 0,,,,,, 0,,, 0,, 0,,,,,,,,,,,,,,,,,, 0, 0,,, 0,,,,,,,,,,,,,,,, 000, 0,, 0, 0, 0, 0, 0,, 0,,,,,,,,,, 00,, 00,,,, 0, 0,, 0, 0 0, 0 0, 0 0 0, 0 0,, 0, 0 0, 0 0, 0, 0, 0, 0 0, 0, 0, 0, 0, 0,,,,,,,,,,,,,,,,, 0, 0, 0,

74 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0,,,,, 0,,, 0,,,,,,, 0, 00, 0,,, 000,,,, 0 0, 000, 0 00, 0 0 0,, 0 0,,,, ,,, ,,, 0 0, 0 0 0, 0, 0 0, 0 0, 0, 0, 0, 0, S0, 0, 0, 0, 0, 0, 0 0, 0 0, 0, 0 0, 0 0 0, 0 0, 0,, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0, 0, 0 0, 0, 0, 0, 0, 0 0 0, 0 0 0, 0 0 0, 0, 0 0, 0 0, 0 0, 0 0, 0, 0 0, 0 0, 0, 0 0, 0, 0, 0 000, 0 0,, 0 0, 0 0, 0 0, 0, 0 0, 0, 0 00, 0 0, 0 0,,,, 0,, 0,, 0, 0,, 0 0,, 0, 0, 0, 0 00,, 0 00, 0 0, 0 0, 0 0, 0, 0 00, 0 0, 0 0, 0 000, 0, 0 000, 0 00, 0 00, 0 0,, 0 0, 0 0, 0 0,, 0 0, 0 0, 0, 0,, 0, 0, 0 0, 0 00, 0 00, 0, 0, 0,, 00,, 0, 0, 00, 0, 0, 0, 0, 0,, 0 0 0, 0 0, 0 0,,, 00, 000,,,,, 000, 00, 00, 00, 0, 0, 0, 00, 0, 0, 0, 00, 0, 0, 0, 00, 0, 0 00,,,,, 0 00,

75 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 00, 0 00,, 00 00, , 00 0, 0 000,, 00,,,, 00, 00, 00, 0,,, 00, 0, 00,, 0,,, 0,,, 00, 0, 0, 0 0, 0, 00 0,,, 0, 0, 00,,, 000, 000,, 00, 0,, 0, 00 0,, 000 0,,, 000 0,,, 000 0, 000 0,, 000 0,, 000 0,, 000 0,,, 000 0, 000 0, 00 0, 00 0,,,, 0 000,, 0 000,, 0 000,, 0 00,,, 00, 00, 000,, 000,,,,,, 000,,,, 0 000,,,,, 0 00,,,,, 000,, 000, 000,,, 0 0,,,, 0 0, 0 0, 0 0, 0 0,,, 0 0,, 0 0,,,, 0,,,,,,, 0 0, 0,,, 000, 0 0, 0 0, 0 0, 00 0, , ,,,,,