IMPORTANT SAFETY INSTRUC- TIONS

Transcription

1

2 To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Onan manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUC- TIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUC- TIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-

3 Introduction This catalog applies to the Commercial BGD above floor mounted Generator Sets as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned in the description or the page heading, parts are interchangeable between models. Using the model and specification number from your generator set nameplate, select parts that apply to your set. Right and left sides are determined by facing the engine end (front) of the set. Generator Set Data Table Model Number Wiring Diagram Carburetion Voltage Hertz Phase.BGD FB/A 6 LP Vapor 0/0 60.BGD FB/A 6 LP Vapor 0/0 60.BGD FB/00A 6 LP Vapor 0/0 60.BGD FN/A 6 Gasoline 0/0 0.BGD FN/A 6 LP Liquid 0/0 0.BGD FN/B 6 LP Liquid 0/0 0.BGD FN/C 6 0 LP Liquid 0/0 0.BGD FN/F 6 0 LP Liquid 0/0 0.BGD FN/H 6 0 LP Liquid 0/0 0.BGD FN/A 6 LP Vapor 0/0 0.BGD FN/B 6 LP Vapor 0/0 0.BGD FN/C 6 0 LP Vapor 0/0 0.BGD FN/F 6 0 LP Vapor 0/0 0.BGD FN/H 6 0 LP Vapor 0/0 0.BGD FN/00A 6 LP Vapor Extended Shaft 0/0 60.0BGD FA/00C 6 0 Gasoline Extended Shaft BGD FA/00F 6 Gasoline/Extended Shaft BGD FA/00H 6 Gasoine/Extended Shaft BGD FA/00J 6 Gasoline/Extended Shaft 0/0 0.0BGD FB/A 6 LP Liquid 0/0 60.0BGD FB/B 6 LP Liquid 0/0 60.0BGD FB/C 6 0 LP Liquid 0/0 60.0BGD FB/F 6 0 LP Liquid 0/0 60.0BGD FB/H 6 0 LP Liquid 0/0 60.0BGD FB/A 6 LP Vapor 0/0 60.0BGD FB/B 6 LP Vapor 0/0 60.0BGD FB/C 6 0 LP Vapor 0/0 60.0BGD FB/F 6 0 LP Vapor 0/0 60.0BGD FB/H 6 0 LP Vapor 0/0 60.0BGD FB/J 6 LP Vapor 0/0 60.0BGD FB/K 6 LP Vapor 0/0 60.0BGD FB/00A 6 LP Liquid/Extended Shaft 0/0 60.0BGD FB/00B 6 LP Vapor/Extended Shaft 0/0 60.0BGD FB/00C 6 0 LP Liquid/Extended Shaft 0/0 60.0BGD FB/00F 6 0 LP Liquid/Extended Shaft 0/0 60.0BGD FB/00H 6 0 LP Liquid/Extended Shaft 0/0 60.0BGD FB/00A 6 LP Vapor/Extended Shaft 0/0 60.0BGD FB/00B 6 LP Vapor/Extended Shaft 0/0 60.0BGD FB/00C 6 0 LP Vapor/Extended Shaft 0/0 60.0BGD FB/00F 6 0 LP Vapor/Extended Shaft 0/0 60.0BGD FB/00H 6 0 LP Vapor/Extended Shaft 0/0 60.0BGD FD/K 6 LP Vapor 0/0 60.0BGD FD/L 6 LP Vapor 0/0 60

4 Generator Set Data Table Model Number Wiring Diagram Carburetion Voltage Hertz Phase.0BGD FN/B 6 Gasoline 0/0 0.0BGD FN/C 6 0 Gasoline 0/0 0.0BGD FN/F 6 Gasoline 0/0 0.0BGD FN/H 6 Gasoline 0/0 0.0BGD FN/J 6 Gasoline 0/0 0.0BGD FT/H 6 Gasoline 0/0 0.0BGD FT/M 6 Gasoline 0/0 0.0BGD FT/00F 6 6 Gasoine 0/0 0.0BGD FT/00H 6 Gasoline BGD FB/A 6 Gasoline 0/0 60.BGD FB/B 6 Gasoline 0/0 60.BGD FB/C 6 0 Gasoline 0/0 60.BGD FB/F 6 Gasoline 0/0 60.BGD FB/H 6 Gasoline 0/0 60.BGD FB/J 6 Gasoine 0/0 60.BGD FB/L 6 LP Liquid 0/0 60.BGD FB/00A 6 Gasoline/Extended Shaft 0/0 60.BGD FB/00B 6 Gasoline/Extended Shaft 0/0 60.BGD FB/00C 6 0 Gasoline/Extended Shaft 0/0 60.BGD FB/00F 6 Gasoline/Extended Shaft 0/0 60.BGD FB/00H 6 Gasoline/Extended Shaft 0/0 60.BGD FB/00J 6 Gasoline 0/0 60.BGD FB/C 6 Gasoline/Mod Chrg g Syst 0/0 60.BGD FD/A 6 Gasoline 0/0 60.BGD FD/B 6 Gasoline 0/0 60.BGD FD/C 6 0 Gasoline 0/0 60.BGD FD/F 6 6 Gasoline 0/0 60.BGD FD/G 6 Gasoline 0/0 60.BGD FD/H 6 Gasoine 0/0 60.BGD FD/J 6 Gasoine 0/0 60.BGD FD/00A 6 Gasoline/Extended Shaft 0/0 60.BGD FD/00B 6 Gasoline/Extended Shaft 0/0 60.BGD FD/00C 6 0 Gasoline/Extended Shaft 0/0 60.BGD FD/00F 6 6 Gasoline/Extended Shaft 0/0 60.BGD FD/00G 6 Gasoline/Extended Shaft 0/0 60.BGD FD/00H 6 Gasoine/Extended Shaft 0/0 60.BGD FD00J 6 Gasoline/Extended Shaft 0/0 60.BGD FD/60H 6 Gasoline 0/0 60.BGD FD/60H 6 Gasoline/Extended Shaft 0/0 60 * The diagonal line (/) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from a standard (A, B, etc.) model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes.

5 Index Accessory Kits,, Actuator, Governor, 6 Adapter, Air Cleaner (Gasoline), Adapter, Air Cleaner (LP Liquid), Adapter, Air Cleaner (LP Vapor), Adapter, Exhaust, Adapter, Generator, Adapter, Harness, 6 Adapter, Oil Fill Tube Assembly, Adapter, Oil Filter, Adapter, Preheat Hose, Adapter, Reducer, Arm, Governor, Arrester, spark, Assembly, Voltatge Regulator, Axle, Dolly, Backplate, Scroll, Baffle, Air, Baffle, Breather Valve, Ball, Governor, Ball, Governor Bearing, Base, Breaker Box (Spec A), 0 Base, Oil, Bearing, Camshaft, Bearing, Crankshaft, Bearing, Governor Needle, Bearing, Rear Crankshaft, Bi Metal, Choke, Block, Control Terminal, 6 Block, Cylinder,, Block, Generator Brush, Block, Generator Terminal, Board, PC (Begin Spec J), 6 Board, PC (Spec A H), Bowl, LP Fuel, Box Assy, Breaker, Box Assy, Control (Begin Spec J), 6 Box Components, Breaker (Spec A), 0 Box, Carrying Frame Receptacle, Brace, Below Floor Housing Rear, Brace, Frame, Bracket, Exhaust, Bracket, Support, Bracket, Battery Regulator (Spec A H), Bracket, Below Floor Housing, Bracket, Below Floor Housing Fuel Pump, Bracket, Below Floor Housing Regulator Mounting, Bracket, Choke Housing Mounting, Bracket, Diaphragm Mounting, Bracket, Exhaust, Bracket, Fuel Line,, Bracket, Fuel Pump, Bracket, Fuse Holder (Spec F), 6 Bracket, Fuse Holder (Spec F H), Bracket, Gas Regulator, Bracket, Generator Support, Bracket, Governor, Bracket, Governor Adjust Cable, Bracket, Ignition Coil, Bracket, Ignition Control, Bracket, Ignition Relay, Bracket, Lifting, Bracket, LPG Filter Mounting, Bracket, Potentiometer, 6 Bracket, Starter Relay, 6 Bracket, Transformer,, 6 Bracket, Voltage Regulator Mounting (Stator Mount), Breaker, Circuit (Battery Charger), Breaker, Circuit (Control), Breaker, Circuit (Receptacle Panel), Brush, Generator, Cable, Battery, Cable, Governor Adjust, Cable, Spark Plug (Begin Spec B), Cable, Spark Plug (Spec A), Camshaft, Cap, Air Inlet Rod, Cap, Drive, 6 Cap, End (Starter), Cap, Fuel Tank, Cap, Oil Fill, Cap, Rain, Cap, Starter End, Cap, Starter Solenoid, Cap, Valve, Carburetor Components, Gasoline (Bein Spec F), Carburetor Components, Gasoline (Spec A E), 6 Carburetor Components, LP Liquid/Vapor, Carburetor Kits,, Carburetor, Gasoline, Carburetor, LP Liquid, Carburetor, LP Vapor, Charger, Battery, Clamp, Muffler, Clip, Preheater Hose, Clip, Throttle Rod (Begin Spec K), 6 Clutch and Spline, Starter, Coil, Ignition (Begin Spec B), Coil, Ignition (Spec A), Components, Starter, 6,, Condenser, Ignition (Spec A F, H, J), Condenser, Ignition (Spec G), Connector, Connector, Plug (6PL), 6 Connector, Receptacle (6 PL), 6 Connector, Receptacle ( Pin), 6, 6 Control, Control, Ignition, Control, Remote Start, 0 Cover, Air Inlet, Cover, Breaker Box, 0 Cover, Brush Block, Cover, Carrying Frame Receptacle Box, Cover, Choke, Cover, Choke Housing, Cover, Circuit Breaker, Cover, Connector Hole, 6 Cover, Control, Cover, Control Box, 6 Cover, Switch, 6 Cover, Valve, Cover, Voltage Regulator (Stator Mount), Crankshaft, Cup, Governor, Cup, Oil Pump Intake, Diode, Remote Control Panel, 0 Drain, Oil Filter, Drive Assembly, Drive Pinion Assembly, Elbow, 0 Degree Exhaust,

6 Index Element, Air Cleaner (Gasoline), Element, Air Cleaner (LP Liquid), Element, Air Cleaner (LP Vapor), Element, Choke, Element, Fuel Filter, Exhaust Assembly, Exhaust System,, Fan, Generator, Filter, Breather Tube, Filter, Carburetor Fuel, Filter, Fuel Pump, Filter, LPG, Filter, Oil, Fitting, Vacuum, Flywheel, Frame, Carrying, Fuel System (Gasoline),,, 0, Fuel System (LP Liquid), Fuel System (LP Vapor), Fuse, Automatic Choke Harness, 6 Fuse, Battery Charger, Fuse, Engine Harness, 6 Fuse, PC Board, Gasket, Bearing Plate, Gasket, Breaker Box, 0 Gasket, Control Box Window, 6 Gasket, Cylinder Head, Gasket, Exhaust,, Gasket, Exhaust Manifold,, Gasket, Gasoline Air Horn, Gasket, Gasoline Carburetor Mounting, Gasket, Gasoline Intake Manifold, Gasket, Gearcase Mounting, Gasket, Hourmeter, 6 Gasket, Ignition Plate, Gasket, Intake Manifold, Gasket, LP Carburetor Bowl, Gasket, LP Liquid Air Horn, Gasket, LP Liquid Carburetor Mounting, Gasket, LP Vapor Air Horn, Gasket, LP Vapor Carburetor Mounting, Gasket, LP Vapor Intake Manifold, Gasket, Oil Base, Gasket, Oil Drain Plug, Gasket, Oil Filter, Gasket, Oil Filter Adapter, Gasket, Valve Cover, Gear, Camshaft, Gear, Crankshaft, Gear, Ring, Gear, Starter, Gearcase (Kit), Generator, Governor (Begin Spec K), 6 Governor (Spec A J), Grip, Handle, Grommet, Guard, Scroll, Guide, Valve, Handle, Dolly, Hanger, Exhaust,, Harness Assembly, 6 Harness, Adaptor, 6 Harness, AC Outlet (Begin Spec J), 6 Harness, AC Outlet (Spec A H), Harness, Automatic Choke, 6 Harness, Battery Charge, Harness, Battery Regulator (Begin Spec J), 6 Harness, Below Floor Housing Extension, Harness, Carrying Frame, Harness, Engine (Begin Spec J), 6 Harness, Fuel Pump, Harness, PC Board, 6 Harness, PCB, 6 Harness, Positive Shutoff, 66 Harness, Remote, 6, 6 Harness, Voltage Regulator, 6 Harness, Wiring Remote, 6 Head, Cylinder, Holddown, Battery, Holder, Automatic Choke Harness Fuse, 6 Holder, Battery Charge Harness Fuse, Holder, Engine Harness Fuse, 6 Holder, PC Board Fuse, 6 Hose, Fuel, Hose, Oil, Hose, Preheat, Hose, Vacuum, Hourmeter, 6 Housing, Air, Housing, Air Cylinder, Housing, Below Floor Models, 0, Housing, Breather, Housing, Choke, Housing, Connector, 6 Housing, Gasoline Air Cleaner, Housing, LP Liquid Air Cleaner, Housing, LP Vapor Air Cleaner, Housing, Stator, Housing, Terminal, 6 Hub, Governor Cup, Ignition System (Begin Spec B), Ignition System (Spec A), Indicator and Cap Assembly, Insert, Valve Seat, Insulator, Fuse, 6 Insulator, PC Board, Insulator, Start Solenoid Terminal, Insulator, Terminal, Isolator, Vibration, Jet, Idle (Begin Spec F), Jet, Idle (Spec A E), 6 Jet, Main (Begin Spec F), Jet, Main (Spec A E), 6 Joint, Governor Rod Ball, Key, Camshaft Woodruff, Key, Crankshaft Gear, Key, Extended Shaft, Kit Assembly, Drive, 6 Kit, Accessory, Kit, Air Cleaner Housing Assembly (Gasoline), Kit, Air Cleaner Housing Assembly (LP),, Kit, Bearing Replacement, Kit, Below Floor Housing, Kit, Blower Wheel Key, Kit, Carburetor Repair (BeginSpec F), Kit, Carburetor Repair (Spec A E), 6 Kit, Choke Bimetal,

7 Index Kit, Choke Pulloff, Kit, Choke Shaft, Kit, Conversion Enhancement, 6,, Kit, Electronic Governor, 6 Kit, Enable Relay Start, 6 Kit, Exhaust Accessory, Kit, Float (Begin Spec F), Kit, Float (Spec A E), 6 Kit, Gasket,, Kit, Oil Fill Tube, Kit, Remote Adapter, 6 Kit, Rotor, Kit, RV Accessory, Kit, Starter Brush, Kit, Starter Brush Holder Assembly, Kit, Starter Bushing, Kit, Starter Drive,, Kit, Starter Dust Seal, Kit, Starter Hardware, Kit, Starter Shift Lever, Kit, Starter Solenoid, Kit, Vertical Exhaust, Kit, Voltage Regulator Conversion, Kit, Wiring, 6 Labe, Oil Capacity, Labels,, Lever, Throttle Shaft, Line, Carrying Frame Fuel, Line, Gasoline Fuel, Line, LP Liquid Fuel, Link, Governor Spring, Linkage, Choke, Linkage, Choke Pull off, Lock, Housing, 6, 6 Lock, Valve Spring, Manifold, Exhaust, Manifold, Gasoline & LP Vapor Exhaust, Manifold, Intake (Gasoline), Manifold, Intake (LP Vapor), Manifold, LP Liquid Intake, Meter, Battery Condition, 0 Meter, Time Totalizing, 0 Muffler, Muffler, Carrying Frame, Muffler, Side Inlet, Muffler, Side Outlet, Muffler, Spark Arrester,, Needle, Carburetor Idle Adjust, O Ring, Control Box Cover, 6 O Ring, Oil Fill Cap, O Ring, Preheat Hose, O Ring, Stator Housing, Package, Signal Pad Plus, Paint,, Pan, Below Floor Housing Drip, Pan, Drip, Panel, Below Floor Panel, Panel, Carrying Frame Receptacle, Panel, Remote Control, 0 Pin, Below Floor Housing Hinge, Pin, Piston, Pin, Terminal, 6, 6 Piston, Plate, Carburetor Throttle, Plate, Ignition Plunger Cover, Plate, Rear Bearing, Plug, Air Housing, Plug, Cavity, 6, 6 Plug, Seal, 6 Plug, Spark (Begin Spec B), Plug, Spark (Spec A), Plunger, Breaker Points (Spec A), 0 Plunger, Bypass Valve, Point, Breaker (Spec A), 0 Potentiometer (Begin Spec J), 6 Potentiometer (Spec A H), Pull off, Choke, Pump, Electric Fuel, Pump, Oil, Receptacle, Rectifier (Battery Charger), Rectifier Positive Shutoff Harness, 66 Rectifier, Fuel Pump Harness, Reed, Breather Valve, Regulator, Battery, 6 Regulator, Voltage (Control Mount) (Spec A H), 6 Regulator, Voltage (Drip Pan Mount) (Spec J), Regulator, Voltage (Stator Mount), Regulator, LP Liquid, Regulator, LP Vapor, Relay, Automatic Choke Harness, 6 Relay, Engine Start Harness, 6 Relay, Ignition, Relay, Starter, 6 Resistor, Fuel Pump, Resonator, Exhaust (Gasoline Only), Retainer, Governor Adjust Cable Push on, Ring Set, Piston, Ring, Armature Collector, Ring, Camshaft Retaining, Ring, Choke Housing Retainer, Ring, Flywheel Retaining, Ring, Piston Retaining, Ring, Tolerance, Rod Assembly, Air Inlet, Rod, Air Inlet, Rod, Connecting, Rod, Governor Arm to Carburetor, Rod, Throttle, Rod, Throttle Control (Begin Spec K), 6 Rotor, Generator, Rotor, Ignition, Scroll, Seal, Cable, 6, 6 Seal, Carburetor Dust, Seal, Crankshaft Oil, Seal, Crankshaft Rear Oil, Seal, Governor Shaft Oil, Seal, Intake Valve, Seal, Oil Fill Tube, Sealant, Thread,, Servive Package, Starter, Shaft, Governor, Shield, Noise, Shim, Crankshaft, Solenoid, Fuel Lock, Solenoid, LP Vapor,

8 Index Solenoid, Start, Solenoid, Starter, Spacer, Below Floor Housing Brace, Spacer, Engine Mount, Spacer, Fuel Pump Mounting, Spacer, Muffler, Spline and Clutch, Starter, Spring, Air Inlet Rod, Spring, Breather Valve, Spring, Bypass Valve, Spring, Carburetor Idle Needle, Spring, Carburetor Main Jet Screw, Spring, Carburetor Throttle Stop, Spring, Generator Brush, Spring, Governor, Spring, Governor Compression, Spring, Governor Idle Needle, Spring, Throttle Rod, 6 Spring, Valve, Standoff, Voltage Regulator Cover, Starter, Starter Components, Stator, Engine Battery Charge, Stator, Generator, Strap, Bond,, Strap, Muffler, Stud, Speed Adjustment, Support, Below Floor Housing, Switch, Low Oil Pressure, Switch, Remote Rocker, 0 Switch, Rocker (Begin Spec J), 6 Switch, Rocker (Spec A H), 6 Switch,Toggle, Tailpipe, Muffler, Tank, Fuel, Tappet, Valve, Terminal, Socket, 6 Tie, Cable,,, Tire, Transformer Assembly, Transformer, Voltage, 6 Transformer, Voltage Regulator, Tray, Battery, Tray, Mounting, Tube Bypass, Breather, Tube, Breather,,,, Tube, Carburetor Idle, Tube, Choke Housing, Tube, Cylinder Block Oil, Tube, Exhaust,,, Tube, Oil Fill, Valve, Exhaust, Valve, Fuel Shutoff, Valve, Intake, Valve, Oil Base Shutoff, Valve, Vacuum Sustain, Wedge, Plug (6PL), 6 Wheel, Window, Control Box, 6 Yoke, Governor, 6

9

10 Cylinder Block

11 Cylinder Block Block, Cylinder Not Sold, Order Shortblock (See ShortBlock Catalog # 00) 0 00 Bearing, Camshaft 006 Plug, Core Hole 6 0 Pin, Gear Cover Alignment 6 00 Pin, Bearing Stop Drive 6 Bearing, Front Crankshaft (Flanged) 0 00 Standard Undersize Undersize Undersize Undersize 0 0 Pump, Oil Washer, Spring Lock (/ ) Screw, Hex Head Cap (/ 0 x ) Tube, Cylinder Block Oil Ring Set, Piston Spec A E 0 Standard Oversize Oversize Oversize Oversize Begin Spec F 00 Standard Oversize Oversize Oversize Oversize Piston (Includes Pin and Retaining Rings) 06 Standard Oversize Oversize Oversize Oversize 0 Pin, Piston 0 Ring, Retaining Rod, Connecting (Includes Bolt and Nut) 0 Standard Undersize Undersize Undersize 6 0 Bolt, Connecting Rod 0 0 Nut, Self Lock (/6 ) 00 0 Screw, Hex Head Cap (Special) Long 6 0 Washer, Flat (/6 Screw) 0 Head, Cylinder 0 0 Right Side 0 0 Left Side 0 Gasket, Cylinder Head 0 Valve, Intake Valve, Exhaust 0 Gasoline 0 0 LP Insert, Exhaust Valve Seat 0 Standard Oversize Oversize Oversize 0.0 Oversize Insert, Intake Valve Seat 0 0 Standard Oversize Screw, Socket Set (/ 6 x / ) Washer (/ ) Lock Spec A E 6 00 Flat Begin Spec F Screw, Cap 00 0 Flanged Head (Special) Spec A E Hex Head (/ 6 x / ) Begin Spec F 0 00 Seal, Crankshaft Rear Oil Plate, Rear Bearing 0 06 AR Shim, Crankshaft End Play (.00 ) Bearing, Rear Crankshaft (Includes Thrust Washer) 0 00 Standard Undersize Undersize Undersize Undersize 0 0 Washer, Thrust (Special) 0 00 Gasket, Bearing Plate Guide, Valve 0 Exhaust 0 6 Intake Plug, Camshaft Opening Welch ( / ) 0 0 Plunger, Bypass Valve 0 00 Spring, Bypass Valve Washer, Copper Flat (/ Screw)

12 0 Cylinder Block

13 Cylinder Block Screw, Hex Head Cap (/ x / ). psi 0 0 Seal, Intake Valve 0 Spring, Valve 0 Washer, Retaining Valve Spring 0 0 Cap, Valve 0 0 Gasket, Valve Cover Cover, Right Side Valve Washer, Copper Flat (/ ) Screw, Hex Head Cap (/ 0 x / ) 0 Lock, Valve Spring Tappet, Valve Baffle, Breather Valve Reed, Breather Valve 6 00 Washer, Flat (/ Screw) Spring, Breather Valve Filter, Breather Tube 6 6 Housing, Breather

14 Camshaft Ring, Retaining 0 Hub, Governor Cup 0 0 Cup and Bushing, Governor Ball, Governor Gear, Camshaft (Includes Gear, Spacer and Plate) Washer, Thrust (Special) 000 Key, Woodruff 0 06 Camshaft (Includes Center Pin) 0 00 Pin, Center

15 Crankshaft Screw, Hex Head Cap (Special) 6 06 Washer, Flat (/6 Screw) 6 00 Washer, Flat (/6 Screw) Flywheel 0 Spec A H 0 0 Begin Spec J 00 Ring, Retaining Washer, Gear 0 00 Gear, Crankshaft 06 Kit, Blower Wheel Key (Includes Three Keys /, /, / ) 000 Key, Crankshaft Gear 0 0 Crankshaft

16 Gearcase Kit, Gearcase 0 0 Spec A H (Includes Parts Marked *) 0 0 Begin Spec J (Includes Parts Marked +) 0 00 Gasket, Gearcase Mounting *Ball, Bearing *Pin, Governor Cup Dowel 0 +*Yoke, Governor *Screw, Pan Head Machine ( x / ) 0 0 +*Screw, Pan Head (0 x / ) 00 +Washer, Conical Disc Spring 00 *Spring, Idle Needle *Nut, Self Lock (0 ) *Arm and Shaft, Governor 0 +*Link, Governor Spring *Seal, Governor Shaft Oil *Bearing, Needle 06 +*Screw, Self Tapping Hex Washer Head (/ 0 x /6 ) Washer, Copper Flat (/6 Screw) 00 0 Screw, Hex Head Cap ( / Long) (Special) *Seal, Crankshaft Oil Screw, Hex Head Cap ( / Long) (Shakeproof) Stator (Begin Spec J) 06 Screw (Begin Spec J) * Parts Included in Gearcase Kit Spec A H. + Parts Included in Gearcase Kit Begin Spec J.

17 Governor Spec A J Nut, Self Lock Hex (#0 ) 0 6 Spring, Governor Stud, Speed Adjustment Bracket, Governor 0 0 Gasoline and LP Vapor 0 0 LP Liquid 0 Cable, Governor Adjust (Begin Spec C) 6 0 Bracket, Governor Adjust Cable 0 Retainer, Push On 0006 Clip, Retaining 0 Spring, Compression (Begin Spec C) Clip, Linkage (Begin Spec C) 0 Washer, Friction (Begin Spec C) Rod, Throttle 0 Gasoline & LP Vapor 0 6 LP Liquid Rod, Governor Arm To Carburetor 0 Gasoline and LP Vapor LP Liquid 0 Spec A,B 0 0 Begin Spec C 0 0 Joint, Ball

18 Electronic Governor Begin Spec K Kit, Electronic Governor (Includes All Parts Listed on This Page) 0 Rod, Throttle Control 0 Clip, Throttle Rod 0 6 Spring, Throttle Rod 00 Actuator, Governor (K) Screw, Pan Head Torx (#0 x / ) 0 0 Screw, Pan Head Torx (#0 x / ) The Following Parts in Kit are Not Shown: G Sheet, Instructions 0 Label, Blank Kit Number 0 0 Gasket, Air Horn 0 Gasket, Carburetor 6 06 Carburetor Bracket, Governor 0 0 Plate, Mounting 0 Controller, Governor 6 Harness, Electric Governor Screw, Hex Head Cap 0 Screw, Hex Head Thread Cutting 06 Screw, Hex Washer Thread Forming 0 0 Rivet, Pop Nut, Self Locking 6

19

20 Fuel System Gasoline & Spec C E 6 Spec A, B 6 Begin Spec F 0

21 Fuel System Gasoline Manifold, Intake Spec A J 06 Begin Spec K Gasket, Intake Manifold Screw, Hex Head Cap (/6 x ) 0 00 Washer, Spring Lock (/6 ) 0 Screw, Hex Washer Head (Special) Spacer, Fuel Pump Mounting (Spec C E) Pump, Electric Fuel (Includes Mounting Bracket) (E) 0 Spec A,B 6 Spec C E Spec F H 0 Begin Spec J Filter, Fuel (Fuel Pump) 0 Bracket, Fuel Pump (Begin Spec F) Elbow, Street 0 (Begin Spec F) Connector, Inverted Male Washer, EIT (/ ) 0 Screw, Pan Head (/ 0 x / ) (Begin Spec F) 06 0 Screw, Pan Head (/ 0 x ) 0 0 Nut, Lock Head (/ 0) (Begin Spec F) 6 6 Harness, Fuel Pump (Includes Rectifier) Volt Code FD 006 Rectifier, Fuel Pump Harness (CR6) 0 0 Elbow, 0 Screw,Thread Form Torx 00 Spec A (/ 0 x.6 ) 0 Begin Spec B Pan Head (Special) 0 6 Washer, Fuel Pump (Spec A) 06 Connector, Splice Window Fuel Pump (Not Shown) Elbow, Inverted Male 0 0 Spec A,B Heavy Duty Spec C E Standard 0 0 Begin Spec F Heavy Duty 0 0 Nut, Cap (6 ) Line, Fuel (Includes Inverted Nuts) 00 Spec A Spec B Spec C E Begin Spec F 066 Clip, Choke Housing 0 Cover, Choke Housing 6 0 Screw, Hex Washer Head (Special) 0 Element and Cover, Choke (H) 0 Bi Metal, Choke 0 Tube, Choke Housing 0 06 Housing, Choke (Includes Choke Shaft) 0 Ring, Choke Housing Retainer (Not Illustrated) 0 Bracket, Choke Housing Mounting 0 Linkage, Choke 0 Screw, Hex Washer Head (Special) Spec A F Connector, Inverted Flare Male (Begin Spec B) 0 00 Plug, Brass Pipe (/ ) (Begin Spec F) 6 Filter, Fuel (Carburetor) 6 00 Nut, Hex (/6 ) Gasket, Carburetor Mounting 00 Spec A E 0 Begin Spec F Carburetor (Includes Mounting Gasket) (See Separate Page for Components) 6 0 Spec A E Begin Spec F Automatic Choke Gasket, Air Horn 06 Bracket, Diaphragm Mounting 0 0 Fitting, Vacuum (Intake 0 Manifold To Vacuum Hose) 0 0 Clamp, Hose 0 Hose, Vacuum (Spec F) (/6 ID x Long) 06 Pull off, Choke (Spec A E) 6 00 Clip, Diaphragm Mounting Bracket U 0 Linkage, Choke Pull off 0 Clamp, Breather Tube Hose 00 Screw, Hex Head (Special) 0 Adapter, Air Cleaner 0 Spec A E Standard 0 Spec F Heavy Duty 0 Begin Spec J 0 0 * Begin Spec K 0 Element, Air Cleaner 00 Plug, Button (Begin Spec J) Housing, Air Cleaner (Includes Label) 0 0 Spec A H 0 0 * Begin Spec J 0 6 Begin Spec K 0 *Cap, Air Inlet Rod Screw, Hex Head Cap (/ 0 x / ) Washer, Flat (/ Screw) 0 00 *Spring, Air Inlet Rod *Washer, Flat (#6 Screw)

22 Fuel System Gasoline & Spec C E 6 Spec A, B 6 Begin Spec F 0 0

23 Fuel System Gasoline Rod, Air Inlet 066 Spec A H Begin Spec J 60 Air Inlet 6 0 Clip, Preheater Hose Ring (Begin Spec F) (Spec A J Only) 6 0 Hose, Preheat (Spec A J Only) 6 Adapter, Preheat Hose 0 0 Spec A H 0 0 Begin Spec J 6 6 Tube, Breather Clamp, Breather Tube Hose 6 0 Bracket, Fuel Line Kit, Air Cleaner Housing Assembly (Gasoline) (Includes Parts Marked *) 6 00 *Rod Assembly, Air Inlet (Includes Rod & Cover * Parts included in Air Cleaner Housing Assembly Parts Included in Air Inlet Rod Assembly.

24 Fuel System LP Vapor 6 6,

25 Fuel System LP Vapor 00 Screw, Hex Head Cap (/ 0 x / ) Regulator 0 Spec A J 00 Spec K & Up (LPG Vapor) 0 0 Connector, Hose 0 06 Hose, Oil (Vent) Long 0 Bracket, Gas Regulator Screw, Hex Head Cap (/6 x ) 0 0 Nut, Self Lock Hex (/6 ) 6 Tube, Breather 0 0 Clamp, Hose (/6 to /6 ) Screw, Hex Head Cap (/6 x ) Washer, Flat (M) Gasket, Intake Manifold Manifold, Intake Spec A J 06 Begin Spec K 0 Screw, Hex Washer Head (Special) 0 6 Plug, Hex Pipe (/ ) Bracket, Ignition Relay 0 Screw, Hex Washer Head (Special) Spec A F 6 00 Nut, Hex (/6 ) 0 Gasket, Carburetor Mounting 0 Carburetor (See Separate Page for Components) 0 Spec A J 6 0 Spec K & Up (LPG Vapor) 0 0 Gasket, Air Horn 0 Clamp, Breather Tube Hose 0 Kit, Air Cleaner Housing Assembly (LP) (Includes Adapter & Housing Marked *) Adapter, Air Cleaner 0 Spec A J 0 0 * Begin Spec K 00 Screw, Hex Head Cap (Special) 6 0 Element, Air Cleaner Housing, Air Cleaner 0 Spec A J 0 6 * Begin Spec K 6 00 Washer, Flat (/ ) Screw, Hex Head Cap (/ 0 x / ) Nut, Hex (/ 0) Washer, Lock (/ ) 0 00 Elbow, 0 Street 0 0 Nipple, Pipe (/ x.00 Lg) 0 Solenoid 0 00 Plug, Square Head Connector, Hose 00 Clamp, Insulated (/ OD) 0 0 Clamp, Hose (#) 0 0 Hose, 0 Fuel * Parts Included in (LP) Air Cleaner Housing Assembly Kit.

26 Fuel System LP Liquid

27 Fuel System LP Liquid Manifold, Intake 0 Screw, Hex Washer Head (Special) 0 0 Plug, Hex Pipe (/ ) Gasket, Intake Manifold Washer, Flat (M) Screw, Hex Head Cap (/6 x ) 6 00 Nut, Hex (/6 ) 0 0 Gasket, Air Horn Carburetor (See Separate Page For Components) 0 Spec A J 6 0 Spec K & Up (LPG Liquid) 0 0 Gasket, Carburetor Mounting 0 0 Clamp, Hose (/6 to /6 ) 6 Tube, Breather 0 Clamp, Breather Tube Hose 0 Kit, Air Cleaner Housing Assembly (LP) (Includes Adapter & Housing Marked *) Adapter, Air Cleaner 0 Spec A J 0 0 * Begin Spec K 6 00 Screw, Hex Head Cap (Special) 0 Element, Air Cleaner Housing, Air Cleaner 0 Spec A J 0 6 * Begin Spec K 6 00 Washer, Flat (/ Screw) Screw, Hex Head Cap (/ 0 x / ) Line, Fuel 0 0 With 0 Swivel ( / Long) 0 0 Without Swivel ( / Long) Elbow, Reducing (Bottom Outlet, Exhaust Manifold) 0 0 Valve, Fuel Shutoff (Bottom Outlet, Exhaust Manifold) Nipple, Close (Bottom Outlet, Exhaust Manifold) 00 Filter, LPG (Includes Element and O Rings) 6 Screw, Thread Forming (Special) 066 Spec A 0 Begin Spec B Screw, Pan Head (Special) 06 0 Spec A 06 0 Begin Spec B 06 Screw, Hex Washer Head (/ 0 x / ) Bracket, Filter Mounting (Spec and 00) 06 Spec A 00 0 Begin Spec B Adapter, Reducer (Front Outlet Exhaust Manifold) 0 Solenoid, Fuel Lock (E) (Front Outlet Exhaust Manifold) Elbow, 0 Male Front Outlet, Exhaust Manifold 0 00 Bottom Outlet, Exhaust Manifold Elbow, Street (Front Outlet, Exhaust Manifold) 0 Element, Fuel Filter 6 6 Lead, Filter Mounting Bracket Hose, Fuel ( / Long) 0 0 Elbow, Elbow, 0 Reducing Bushing, Reducer (/ x / ) 0 Regulator, LP Liquid 0 Spec A J 0 Spec K & Up (LPG Liquid) 0 Washer, Regulator Mounting Washer, Lock (/ ) 06 Screw, Hex Washer Head (/ 0 x / ) 0 0 Bracket, Fuel Line 0 0 Nut, Hex ( ) Clamp, Hose Washer, Flat (#) 06 Screw, Hex Head Machine ( x / ) * Parts Included in (LP) Air Cleaner Housing Assembly Kit.

28 Carburetor Components Gasoline (Spec A E) REF PART QTY PART NO. NO. USED DESCRIPTION 6 0 Carburetor, Complete 6 0 Kit, Float (Includes Float, Pin, Valve and Set Screw) 6 00 Jet, Main 6 0 Jet, Idle 6 0 Kit, Repair (Includes Air Horn Gasket, Flange Gasket, Float Chamber Gasket, Float Valve, Idle Adjust Spring, Idle Adjust Screw, Idle Adjust Cap, Power Limiter Cap, Power Jet Assembly Gasket, Throttle Stop Spring, Throttle Stop Screw, Throttle Adjust Screw and Throttle Adjust Screw Nut) 6 06 Kit, Conversion Enhancement (See Page ) 6

29 Carburetor Components Gasoline (Begin Spec F) Carburetor, Complete 6 00 Valve, Vacuum Sustain 6 0 Jet, Idle 6 00 Jet, Main 6 0 Kit, Choke Pulloff (Includes Piston Rod, Link Washer, Snap Pin and Breaker) 6 0 Kit, Choke Bimetal (Includes Holder, Thermostat Cover, Set Plate and Case Set Screw) Kit, Choke Shaft (Includes Choke Shaft, Collar, Arm Return Spring, Valve, Set Screw and Lever) 6 0 Kit, Float (Includes Float, Pin, Valve and Set Screw) 6 0 Kit, Repair (Includes Air Horn Gasket, Flange Gasket, Float Chamber Gasket, Float Valve, Idle Adjust Spring, Idle Adjust Screw, Idle Adjust Cap, Power Limiter Cap, Power Jet Assembly Gasket, Throttle Stop Spring, Throttle Stop Screw, Throttle Adjust Screw and Throttle Adjust Screw Nut) 6 06 Kit, Conversion Enhancement (See Page )

30 Carburetor Components (LP Liquid and Vapor) Carburetor, Complete 0 Spec A J 6 0 Spec K & Up (LPG Liquid) 6 0 Spec K & Up (LPG Vapor) 06 Plug, Bowl 00 Washer, Bowl Plug 00 Bowl, Fuel 00 Gasket, Bowl 06 Lever, Throttle Shaft 6 0 Seal, Rubber Dust 006 Screw, Round Head with Washer 0 Plate, Throttle 0 Spring, Throttle Stop Screw, Throttle Stop 0 Needle, Idle Adjust 0 Spring, Idle Needle 0 Screw, Main Jet Adjust 0 Spring, Main Jet Screw Tube, Idle (Rubber) 0 Spec A J 0 Begin Spec K 6 00 Seal, Dust

31 Ignition System (Spec A) Coil, Ignition (T) (Includes Nuts and Washers) 66 0 Clamp, Coil 06 Screw, Hex Washer Head Thread Cutting (/ 0 x / ) 66 0 Nut, Hex (MM) 0 00 Washer, Lock (MM) Plug, Spark (E, E) Cable, Spark Plug Long 6 60 Long 60 Box Assy, Breaker (See Separate Page for Components)

32 Breaker Box (Spec A) 6 60 Box, Breaker (Includes Parts Marked *) 60 *Clip, Breaker Box Cover 60 6 *Cover, Breaker Box 60 *Point, Breaker 0 00 *Screw, Socket Head Cap (/ 0 x / ) 0 00 *Washer, Spring Lock (/ ) *Gasket, Breaker Box 60 Plunger, Breaker Points 6 Lead, Breaker Box To Coil 60 *Base, Breaker Box * Parts Included in Breaker Box. 0

33 Ignition System Electronic (Begin Spec B) Gasket, Plate 60 0 Plate, Ignition Plunger Cover 0 00 Washer, Flat (M6) Screw, Hex Head Cap (/ 0 x / ) 66 0 Rotor Assembly, Ignition (Includes Rotor and Magnet) 6 Cable, Spark Plug Spec A G Spec G 6 60 Spec A F 060 Screw, Hex Washer Head (/ 0 x ) Coil, Ignition (T) (Includes Nuts) Spec B thru Serial Number G During Spec F Begin Serial Number G During Spec F 66 0 Nut, Hex Flange (M Negative Terminal) Nut, Hex Flange (M Positive Terminal) 6 0 Plug, Spark (E, E) Bracket, Ignition Coil Spec B thru Serial Number G During Spec F 00 Screw, Hex Washer Head Thread Forming (/ 0 x / ) Control, Ignition (S) 66 0 Leads Gasoline Fueled Leads LP Fueled 66 0 Bracket, Ignition Control Nut, Self Lock (0 ) 00 Screw, Hex Washer Head Thread Forming (0 x / ) 66 0 Clamp, Coil (Begin Serial Number G During Spec F) Connector

34 Battery Charger (Spec A H) Harness, Battery Charge (Includes Parts Marked *) Spec A,B 0 Gasoline 0 LP Spec C 6 0 Gasoline 6 0 LP Spec D,E 6 0 Gasoline 6 0 LP Spec F 0 Gasoline 6 LP Spec G, H 0 *Pin, Contact 006 *Rectifier (CR6) 0 6 *Breaker, Circuit 0 Ampere, 6,, Volt (CB) *Holder, Fuse 0 0 Spec F 0 0 Spec G 6 6 *Socket, Contact 0 06 *Fuse, 0 Amp (F) (Begin F) 0 6 *Relay, Ignition (K,K6) 000 Screw, Flange Lock Head (0 x /6 ) 0 00 Screw, FlangeLock Head (/ 0 x / ) 0 0 Charger, Battery (Spec A F & H) Bracket, Battery Regulator Mounting 00 0 Spec A E 0 Spec F, Volt Code FA 0 06 Washer, Center Volt Code FD 0 0 Resistor, Fuel Pump Volt Code FD Washer, Lock (#0) Volt Code FD Volt Code FB,FN Washer, EIT Lock (#0) Screw, Pan Head (Special) 066 Volt Code FD 066 Volt Code FB,FN 0 Screw, Pan Head (Special) Volt Code FD 06 Condenser, Ignition (Spec A F & H) Screw, Hex Flange Head (M x 0mm) (Spec H) Tray, Mounting (Spec H) 00 Screw, Hex Washer Head Thread Forming (#0 x / ) * Parts Included in Battery Charge Wiring Harness.

35 Single Hole Mount 0 Voltage Regulator Stator Mount 0 Triple Hole Mount Kit, Voltage Regulator Conversion (SR00) (Includes 0 0) 0 0 Assembly, Voltage Regulator (Includes Parts Marked *) *Cover Single Hole Mount Triple Hole Mount 06 0 *Screw, Thread Forming Pan Head (#0 x / ) (Single Hole Mount Only) 00 *Screw, Thread Forming Hex Head (/ 0 x / ) *Bracket, Mounting *Regulator, Voltage (Begin Spec G) (Volt Code FD, FT) ( Phase) *Standoff 0 06 Single Hole Mount 0 06 Triple Hole Mount *Washer, Flat (/6 ) Single Hole Mount Triple Hole Mount 0 *Screw, Round Head Machine (#0 x / ) 0 Single Hole Mount 0 Triple Hole Mount *Washer, EIT (/ ) 0 Transformer Assembly (Used With Voltage Regulator) * Parts included in Voltage Regulator Assembly.

36 Starter 0 6 Starter (B) 60 Spec A G (See Separate Page for Components) * Spec (Spec H Only) 0 Begin Spec J Washer, Lock (/ ) Spec A H Begin Spec J Screw, Hex Head Cap (Special) Spec A H 00 0 Begin Spec J Washer, Lock (/ ) Nut, Hex (/ 0) 6 0 Tie, Cable 0 Tube 6 Lead, Starter (Includes Tube) Nut, Hex (/ 6) Spec A H 6 00 Begin Spec J 0 Clip, Harness * Components not Available at Time of Print.

37 Starter Components For Starter 60 (B) 6 0 Kit, Starter Drive (Includes Parts Marked *) *Retainer, Spring *Washer, Pinion *Retainer, Clutch *Cover, Spring 6 6 *Pin, Roll *Washer, Drive *Gear, Starter *Clutch and Spline 0 0 *Spring, Pinion 6 Cap, Drive End Cap, End * Parts Included in Starter

38 Starter Components For Starters & REF PART QTY PART NO. NO. USED DESCRIPTION 6 Cap, Drive Kit Assembly, Drive (Includes Washers, Retainers, Spring, Cover, Roll Pin, Pinion Gear, and Drive Clutch). 6

39 #Starter Components For Starter REF PART QTY PART NO. NO. USED DESCRIPTION Service Package, Starter (Includes Parts Marked *) 0 *Cover, Dust 0 *Spring, Anti Drift 0 *Nut, Stop 06 *Washer, Stop Nut 0 *Spacer, Dust Cover 0 Drive Pinion Assembly 6 Drive Assembly # Illustration Not Available At Time Of Printing.

40 Starter Components For Starter 0 6 Kit, Hardware (Includes Two Solenoid Mounting Screws, Two Thru Bolts, Armature Shims, Pinion Stop Collar, Retaining Ring & Solenoid Terminal Nuts) 6 Kit, Solenoid (Includes Solenoid & Spring Plunger) Kit, Bushing (Includes Rear Cap With Bushing & Front Bushing) Kit, Brush (Includes Two Negative and Two Positive Brushes & Brush Holder) 66 Kit, Shift Lever (Includes Lever, Wear Plate, Rubber Plug and Grease 6 Kit, Drive (Includes Pinion Gear and Drive Assembly) Kit, Dust Seal (Includes ID & OD Pinion Seals) Cap, Solenoid Nut, Hex Grounding (M) 0 0 Solenoid (Not Shown) 0 Kit, Brush Holder Assembly (Not Shown)

41 Oil Fill Tube Kit, Oil Fill Tube (Includes All Parts Listed on This Page) 000 Indicator & Cap Assembly 06 Screw (/ 0 x /) Clamp, Coated 0 Tube, Oil Fill Seal, Oil Fill Tube 00 Adapter, Assembly 66 0 Label, Oil Capacity Label, Warning 0 G Sheet, Instruction (Not Shown)

42 Oil Base

43 Oil Base 0 6 Base,. Quart Oil 0 Gasket, Oil Base 66 Cup, Oil Pump Intake 6 Cap, Oil Fill O Ring, Oil Fill Cap Valve, Oil Base Shutoff 0 0 Gasket, Oil Drain Plug Screw, Hex Head Cap (/ 0 x / ) 00 Washer, ET 0 Regulator, Voltage (VR) (Spec J Only) (Transformer) 0 0 Volt Code FB 0 0 Volt Code FN 0 Volt Code FC, FD, FT ( Phase) 6 0 Washer, Flat (/ Screw) Screw, Hex Head Cap Isolator, Generator End Vibration Spec A,B 0 0 Top Half 0 0 Bottom Half Begin Spec C Plug, Oil Drain (/ 6 x ) Washer, EIT Screw (/ 6 x / ) 06 Screw, Thread Cutting (/6 x / ) Washer, EIT Strap, Bond 0 Pan, Drip 0 0 Spec A H 0 0 Begin Spec J 00 Screw, Self Lock Hex Washer Head (/ 6 x / ) 6 0 Washer, Flat (/6 Screw) 0 0 Isolator, Engine End Vibration 006 Screw, Self Lock Hex Washer Head (/6 x / ) 6 00 Washer, Flat (/ Screw) Washer, Flat (/ Screw) 0 Screw, Hex Head Thread Form (/ 6 x. ) 000 Screw, Self Lock Hex Washer Head (/ 0 x / )

44 Oil Filter 6 00 Gasket, Oil Filter 06 Filter, Oil Drain, Oil Filter 0 Gasket, Oil Filter Adapter 0 Adapter, Oil Filter (Includes Oil Filter Drain Screws) 6 00 Screw, Hex Washer Head Cap (#0 x / ) Washer, Copper Flat (/6 Screw) Screw, Hex Head Cap (/6 x ) 0 0 Switch, Low Oil Pressure (S)

45 Breather Tube Bypass (Cold Weather Use) REF PART QTY PART NO. NO. USED DESCRIPTION 0 Tube, Breather 0 06 Elbow, Plug, Cap

46 Exhaust System ,,,, 6

47 Exhaust System 66 Bracket, Exhaust (Use With 66 Tube) Screw, Hex Washer Head Thread Forming 0 Spec A (/ 0 x / ) 00 Begin Spec B (/ 0 x / ) 06 0 Strap, Muffler (Spec A H) Bracket, Exhaust Manifold 06 LP Liquid (. Long) Gasoline & LP Vapor (. Long) Screw, Hex Head Cap (/ 0 x / ) Washer, Flat (/ Screw) Tube, Exhaust 66 Spec A L ( Long) (Use With 66 Bracket) 06 Begin Spec M 0 0 Bracket, Exhaust Washer, Flat (M) Screw, Hex Head Cap (/6 x ) Muffler, Side Inlet End Outlet With Spark Arrestor Without Spark Arrestor Clamp, Muffler Adapter, Exhaust (Flange Type) 0 / Long 6 6 / Long Long Gasket, Exhaust Screw, Hex Head Cap (/ 0 x ) 6 00 Screw, Hex Washer Head Self Lock (/ 6 x / ) 0 0 Spacer, Muffler Long (Used Only On RVs With 6 / Long Exhaust Adapter) Strap, Muffler 0 0. ID. Long.0 ID.6 Long Use with Muffler w/o Spark Arrestor Screw, Hex Head Cap Use Without Spacer (/6 x / ) Use With Spacer (/6 x / ) 0 Hanger, Exhaust 0 Clamp, Muffler 0 00 Washer, Flat (M6) 0 0 Nut, Self Lock (/ 0) Resonator, Exhaust Gasoline Only Manifold, Exhaust Gasoline & LP Vapor Screw, Hex Head Cap (/6 x / ) 6 Gasket, Exhaust Manifold Muffler, Side Outlet End Outlet Near Inlet with Spark Arrestor 6 Manifold, LP Liquid Exhaust 0 Flange, Exhaust Manifold Kit, Exhaust Accessory (See Last Pages for Components) 0 Spec B F 06 Spec A D 0 Spec J and Up Kit, Vertical Exhaust (All Specs) 0 (Includes Parts Marked *) 0 (Includes Parts Marked #) 0 *Elbow, 0 Degree Exhaust #*Gasket, Exhaust Manifold #*Screw, Hex Head Cap (/6 x / ) 0 00 #*Washer, Lock (/6) 0 *Clamp, Muffler *Muffler 0 #*Arrester, Spark 0 #*Screw, Hex Washer Head Self Drill (# x / ) 6 0 *Tailpipe, Muffler 0 #*Bracket, Exhaust #*Screw, Hex Head Cap (/ 0 x / ) 0 00 #*Nut, Lock (/6 ) #*Screw, Hex Head Cap (/6 x / ) 0 #*Strap, Muffler 0 #*Bracket, Support G #*Sheet, Instruction Kit, Vertical Exhaust (All Specs) 0 Includes Parts Marked ~ 0 Includes Parts 0 ~Exhaust Assembly Muffler 006 ~Screw, Lock Head Flange (/6 x / ) Lock Head Flange (/ 0 x / Exhaust Exhaust 6 ~Muffler, Spark Arrester Spark Arrester 00 Hex Head Crescent Cap (/6 x ) 0 Lock (/6) 00 Hex Head Cap (/ 0 x / ) 0 Lock (/) 6 Flat

48 Exhaust System ,,,, 6 6

49 Exhaust System 06 Kit, Accessory (Includes Parts Marked ^) A 00 ^Sheet, Instruction ^Muffler, Spark Arrester 6 ^Clamp, Muffler ^Gasket, Exhaust Manifold ^Tube, Exhaust 6 00 ^Washer, Flat (Muffler) ^Screw, Hex Head Cap (/ 0 x / ) ^Screw, Hex Head Crescent Cap (/6 x ) ^Washer, Lock (/ ) 0 00 ^Washer, Lock (/6 ) ^Insulator, Terminal 0 Kit, Accessory (Includes Parts Marked &) G 6 &Sheet, Instruction 06 &Tube, Exhaust &Gasket, Exhaust Manifold 0 &Clamp, Muffler &Clamp, Muffler &Muffler, Spark Arrester &Hanger, Exhaust 00 &Carton 6 0 &Washer, Flat Special &Screw 6 Kit, Accessory 0 Spec A (Includes Parts Marked <) 0 Spec J (Includes Parts Marked +) G6 +<Sheet, Instruction <Screw, Hex Head Cap (/6 x ) +<Insulator, Terminal 6 0 +<Washer, Flat (/6) <Nut, Hex (/6 ) <Screw, Hex Head Cap (/6 x / ) 6 0 +<Strap, Muffler Mounting 06 +<Screw, Hex Washer Head Thread Forming (/6 x / ) 0 +<Bar, Muffler Support +<Gasket, Exhaust 0 +<Clamp, Muffler +<Hanger, Exhaust 0 +<Tube, Exhaust +<Clamp, Muffler <Muffler, Spark Arrester +Muffler, Spark Arrester Kit, RV Accessory 06 Includes Parts Marked > 00 Includes Parts Marked A 00 > Sheet, Instruction 0 >Muffler, Spark Arrester 06 Muffler, Spark Arrester 6 > Clamp, Muffler > Gasket, Exhaust Manifold > Tube, Exhaust 6 00 > Washer, Flat (Muffler) > Screw, Hex Head Cap (/ 0 x / ) > Screw, Hex Head Crescent Cap (/6 x ) > Washer, Lock (/ ) 0 00 > Washer, Lock (/6 ) > Insulator, Terminal 0 Kit, RV Accessory (Includes Parts Marked =) A 00 =Sheet, Instruction 6 =Muffler, Spark Arrester 6 =Clamp, Muffler =Gasket, Exhaust Manifold =Tube, Exhaust 6 00 =Washer, Flat (Muffler) =Screw, Hex Head Cap (/ 0 x / ) =Screw, Hex Head Crescent Cap (/6 x ) =Washer, Lock (/ ) 0 00 =Washer, Lock (/6 ) =Insulator, Terminal =Hanger, Exhaust 0 =Clamp, Muffler 00 Cap, Rain (Option to be Used With Kits 0, 0, and 0) (For / Outside Diameter Tubing) * Parts included in 0 Vertical Exhaust Kit. # Parts included in 0 Vertical Exhaust Valve Kit. ~ Parts included in 0 Vertical Exhaust Parts included in 0 Vertical Exhaust Kit. ^ Parts Included in 06 Accessory Kit. & Parts Included in 0 Accessory Kit. < Parts Included in 0 Accessory Kit. + Parts Included in 0 Accessory Kit. > Parts Included in 06 RV Accessory Kit. Parts Included in 00 RV Accessory Kit. = Parts Included in 0 RV Accessory Kit.

50 Air Housing 6 0

51 Air Housing Scroll (Includes Baffle) 6 0 Spec A H 00 Begin Spec J Housing, Left Air Cylinder 0 Spec A H (Onan Green) 0 Begin Spec J (Premium Green) Screw, Hex Washer Head Self Locking 000 Spec A (/ 0 x / ) 000 Spec B (/ 0 x / ) Begin Spec C LP Vapor 000 LP Liquid Shield, Noise Spec A,B Begin Spec C (For Specs.0 FN/M,. FD/ M,. FB/M, and. FB/00M Screw, Flanged Hex Head Tapping 0 Spec A (/6 x ) 00 Begin Spec B (/6 x / ) Bracket, Lifting Housing, Right Air Cylinder 0 Spec A H (Onan Green) 0 Begin Spec J (Premium Green) 06 Screw, Hex Head Tapping 0 Backplate, Scroll 0 Guard, Scroll Nut, Self Tapping (/ ) 0 Plug, Dot Button

52 Housing Below Floor Models , 6 0 0

53 Housing Below Floor Models 0 Kit, Below Floor Housing (Spec J and Up) (Includes All Parts on This Page) 0 Support (Includes Label) 0 Support (Includes Label) 0 6 Panel, Housing (Rear) 0 Panel, Housing (Left Hand) 6 0 Panel, Housing (Right Hand) Spacer, Brace 0 0 Bracket, Housing Brace, Rear Bracket, Housing Pin, Hinge Support, Hinge 0 00 Grommet, Rubber 6 0 Washer, Flat (/6 Hardened) 6 0 Washer, Flat (/ Hardened) Screw, Hex Head Cap (/6 x / ) Screw, Hex Head Cap (/6 x / ) Screw, Hex Head Cap (/ 6 x ) 00 0 Screw, Hex Head Cap (/ 6 x / ) 0 0 Screw, Hex Head Cap Locking Thread Pan, Drip 0 Support, Drip Pan Support, Drip Pan Assembly 0 0 Spacer, Engine Mount Plate, Hinge Washer, Flat (/6 ) Screw, Hex Head Cap (/6 x ) Label, Warning G 6 Sheet, Instruction (Not Shown) 0 00 Template, Mounting (Not Shown) 60 Line, Fuel (Not Shown) Elbow, Degree Inverted (Not Shown) Harness, Extension (Not Shown) 0 Bracket, Fuel Pump (Not Shown) 0 0 Bracket, Regulator Mounting (Not Shown) 6 00 Screw, Hex Washer Head Thread Forming (/ 0 x / ) (Not Shown) Screw, Hex Head Cap (/ 0 x / ) (Not Shown) 0 0 Nut, Lock (/ 0) (Not Shown)

54 Carrying Frame and Dolly

55 Carrying Frame and Dolly 6 Harness, Wiring 0 Grip, Handle 0 Handle, Dolly 0 Baffle, Air 6 00 Holddown, Battery Tray, Battery 0 6 Brace, Frame ( Hole) 0 6 Brace, Frame ( Hole) 0 0 Bracket, Generator Support Brace, Frame Cable, Battery (Negative) 6 Long 0 6 Frame, Carrying (Side) Cable, Battery (Positive) 0 Long 06 Box, Receptacle 0 Panel, Receptacle 6 0 Cover, Receptacle Box Receptacle, 0 Ampere /0 Volt 0 0 Breaker, Circuit, 0 Ampere /0 VAC 0 0 Switch, Toggle ( PDT) 0 0 Receptacle, Ampere 0 Volt 0 00 Breaker, Circuit 0 0 Breaker, Circuit 0 Receptacle, 0 Ampere 0 Volt 0 66 Brace, Frame ( Hole) 0 Connector, Conduit (/ ) 6 Tank, Fuel ( gal) 0 00 Line, Fuel 0 00 Clamp, Hose 0 Strainer and Elbow Cap, Fuel Tank Tube, Pickup Clamp, Loop 0 Lug, Solderless Gasket, Exhaust Tube, Exhaust 6 Muffler 6 Clamp, Muffler 6 00 Washer, Flat ( Screw) 0 0 Axle, Dolly Tire and Wheel 00 Ring, External Retaining Hardware (Not Illustrated) Screw, Cap Hex Head (/6 x.0) Washer, Lock (/6) 00 Screw, Cap Hex Head (/6 x.) 0 0 Nut, Lock Hex (/6 ) Screw, Cap Hex Head (/ 0 x.0) Washer, Lock (/) Screw, Cap Hex Head (/ 0 x.0) 0 0 Nut, Hex W/ET (0 ) 000 Screw, Hex Washer Head (0 x.) Screw, Cap Hex Head (/ 6 x.) Washer, Lock (/) Screw, Cap Hex Head (/ 6 x.) Washer, EIT (/) Nut, Hex (/ 6) 0 0 Nut, Hex Washer Head (/ 6) 00 Screw, Shoulder (0 ) 0 Screw, Thread Form (/) Screw, Cap Hex Head (/6 x /) Battery Connectors Washer, EIT (/6) Battery Connectors 6 00 Nut, Hex (/6 ) Battery Connectors Washer, EIT (/) Screw, Cap Hex Head (/ 0 x.0) Screw, Cap Hex Head (/ 0 x.6) Washer, Lock (/) Screw, Cap Hex Head (/6 x.00) 0 00 Washer, Lock (/6) 6 00 Washer, Flat (/ Screw) Screw, Cap Hex Head (/ 6 x.0) Nut, Hex Washer Head (/ 6) Washer, Lock (/) Screw, Cap Hex Head (/ 6 x.00)

56 Generator

57 Generator Rotor Assy (Includes, Ball Bearing and Collector Ring) Spec A E (Includes Gen Fan andtolerance Ring) Standard Shaft 0 0 Volt Code FA,FB,FN 0 0 Volt Code FD,FT Extended Shaft 0 0 Volt Code FA,FB,FN 0 06 Volt Code FD,FT Spec F, G Standard Shaft Volt Code FA,FB,FN Volt Code FD,FT Extended Shaft Volt Code FA,FB,FN Volt Code FD,FT Spec H (Includes Fan & Gear) Standard Shaft 0 0 Volt Code FA,FB,FN 0 0 Volt Code FD,FT Extended Shaft 0 0 Volt Code FA,FB,FN 0 0 Volt Code FD,FT Begin Spec J (Includes Fan & Gear) Standard Shaft 0 0 Volt Code FA,FB,FN 0 0 Volt Code FD,FT Extended Shaft 0 0 Volt Code FA,FB,FN 0 0 Volt Code FD,FT 0 0 Kit, Bearing Replacement 0 0 Ring, Armature Collector 060 Ring, Tolerance (Spec A E) Fan, Generator 0 06 Spec A G (Note: When replacing generator fan, tolerance ring 060 must also be replaced) 0 0 Spec H (Includes Ring Gear) 0 0 Begin Spec J (Includes Ring Gear) 6 Gear, Ring 0 0 Spec H 0 0 Begin Spec J Adapter, Generator 0 0 Spec A H Begin Spec J 0 0 Single Phase 0 0 Three Phase Nut, Hex Spec A H (/ 6) 6 00 Begin Spec J 06 Condenser, Ignition (Spec A F, H,J) 0 Screw, Hex Washer Head Thread Forming 00 Spec A (0 x / ) 00 Begin Spec B (Special) 0 Clamp, Stator 066 Screw, Hex Washer Head Cap (/ 0 x / ) 0 0 Screw, Armature Socket Through (Standard Shaft) (/6 x 0. ) Stud. Long Extended Shaft 6 00 Washer, Flat (/6 ) Washer, Lock (/6 ) 0 00 Nut, Hex (/6 0) Stator, Generator Spec A F 0 0 Volt Code FA,FB 0 0 Volt Code FD 0 0 Volt Code FN 0 0 Volt Code FT Spec G, H 0 0 Volt Code FA,FB 0 06 Volt Code FD 0 0 Volt Code FN 0 0 Volt Code FT Begin Spec J 0 0 Volt Code FB 0 0 Volt Code FD 0 0 Volt Code FN 0 Tie, Cable 0 Connector, Tab 0 Connector, Receptacle 0 Key, Extended Shaft (/ x ) Housing, Stator Standard Shaft 0 Spec A F Spec G H 0 Volt Code FB, FN 0 0 Volt Code FD, FT 0 0 Begin Spec J Begin Spec K 0 0 Single Phase 0 0 Three Phase Extended Shaft 0 0 Spec A H Begin Spec J 0 Volt Code FB, FN 0 0 Volt Code FD, FT 0 Plug, Control Box (Spec A H) 06 Connector, Conduit (Includes Fastener) (Begin Spec G) 6 Grommet, Nylon (.6 ID) 0 0 Spec A H 0 0 Begin Spec J 0 Strap, Bond (Begin Spec J) Washer, EIT (/ ) (Begin Spec J) 00 Nut, Hex (/6 ) (Begin Spec J) 0 Screw (0 x / ) 0 Spec A,B Hex Head Thread Forming 0 Begin Spec C, Pan Head Torx Drive

58 Generator

59 Generator Cover, Brush Block Block, Brush (Includes Parts Marked *) 00 *Brush, Generator 6 *Block, Terminal 6 0 *Spring, Generator Brush 6 Stud, Grounding Washer, EIT Lock (/ ) (Gasoline Sets) 00 Screw (/ 6 x ) (Gasoline Sets) Screw, Head Hex Flange 00 0 Spec A F (/ 6 x / ) Spec G, H (/ 6 x / ) Spec J (/ 6 x / ) 00 Begin Spec K (/ 6 x /) 0 Washer, Spring Lock (/ ) Spec A H Spec J Only Clip, Harness 0 06 O Ring, Stator Housing Kit, Rotor (Includes Rotor Assy and Starter) Standard Shaft 00 Volt Code FA, FB, FN 00 Volt Code FD, FT Extended Shaft 00 Volt Code FA.,FB, FN 00 Volt Code FD, FT * Parts Included in Generator Brush Block.

60 Control (Spec A H) Spec H Spec A F

61 Control (Spec A H) Cover, Control Spec A,B Spec C E Spec F 0.0kW 06.kW 0.kW Spec G,H.0kW 0 Volt Code FA, FB, FN 0 Volt Code FT 0.kW.kW 06 Volt Code FB Volt Code FD 0 Screw, Round Head (Spec A F) (#6 x / ) 0 06 Potentiometer (R) 0 0 Nut, Hex (#6 ) (Spec A F) 0 Pin, Contact 6 0 Fuse, Amp (F) Board, Printed Circuit (Includes Fuse) (A) 00 Spec A,B Spec C H Sets without Battery Charger Sets with Battery Charger 0 0 Nut, W/ET (0 ) Bracket, Transformer 06 Spec A F 0 0 Begin Spec H Pin, Cotter (Spec A F) Transformer, Voltage Regulator (T) 06 Spec A F 0 Begin Spec H 0 Insulator, PC Board 00 Screw, Pan Head Cross Recessed (6 x / ) 0 Nut, Hex W/ET (#6 ) (Begin Spec H) 000 Screw, Lock Head Flange (#0 x ) 6 Screw, ( per each Circuit Breaker) 066 Slotted Head IT (6/ x / ) 00 Pan Head Cross Recessed (6/ x / ) Volt Code FA,FB,FD,FN (Begin Spec C) 6 0 Clamp, Conduit 066 Screw, Pan Head Thread Forming (0 x / ) 06 0 Screw, Pan Head Torx (Special) Bracket, Fuse Holder (Begin Spec F) Lead, Circuit Breaker 6 0 Volt Code FA,FB,FD,FN 6 0 Volt Code FD 6 0 Volt Code FD 6 0 Volt Code FD Begin Spec C Volt Code FB,FD,FN 0 6 Cover, Circuit Breaker Volt Code FT (Begin Spec C) Breaker, Circuit (CB, CB) Spec A D A 0 0A Spec F J 0 0. KW (A).0 KW 0 0 Volt Code FA (A) 0 Volt Code FB, FN (0A) 0 Spec FB/J Only. KW 0 Volt Code FB (0A) Volt Code FD Spec & 00 (A) Spec 60 & 60 (0A) Begin Spec M Amps Amps 0 Tie, Cable 0 0 Solenoid, Start (K) (Includes Nuts and Washers) 6 Insulator Start Solenoid Terminal (Optional) Harness, AC Outlet Volt Code FA,FB,FN 60 Volt Code FD VoltCode FT (Begin Spec C) 0 Volt Code FB (Begin Spec C)