Parts Manual. RV Generator Set. KY (Spec A P) KYD (Spec A C) English Original Instructions (Issue 21)

Transcription

1 Parts Manual RV Generator Set KY (Spec A P) KYD (Spec A C) English Original Instructions 0 0 (Issue )

2 To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Onan manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY IN- STRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUC- TIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-

3 Introduction This parts manual applies to the KY Recreational Vehicle Sets as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is defined by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Using the model and specification number from your generator set nameplate, select parts that apply to your set. Right and left sides are determined by facing the engine end (front) of the set. Generator Set Data Table MODEL AND Wiring SPECIFICATION WATTS VOLTS HERTZ FUEL Diagram.KY FR/F LPG Vapor 0.KY FR/G LPG Vapor 0.KY FR/B E LPG Vapor?.KY FR/F LPG Vapor 0.KY FR/G H LPG Vapor 0.KY FR/J L LPG Vapor 0.KYD A B LPG Vapor 0.KY FA/A LPG Vapor.KY FA/0B E LPG Vapor.KY FA/0F LPG Vapor.KY FA/0G H LPG Vapor.KY FA/0J M LPG Vapor.KY FA/0P LPV Vapor.KY FR/G H Gasoline 0.KY FR/J K Gasoline 0.KY FR/B E Gasoline?.KY FR/F H Gasoline 0.KY FR/J K Gasoline 0.KYD 0A B LPG Vapor.KYD A Gasoline 0.0KY FA/0E Gasoline.0KY FA/0F Gasoline.0KY FA/0G H Gasoline.0KY FA/0J Gasoline Continued on next page. >

4 * The diagonal line (/) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from a standard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes. Continued from page. Generator Set Data Table MODEL AND Wiring SPECIFICATION WATTS VOLTS HERTZ FUEL Diagram.0KY FA/0G H Gasoline.0KY FA/0J K Gasoline.0KY FA/00A Gasoline.0KY FA/00B E Gasoline.0KY FA/00F Gasoline.0KY FA/00G H Gasoline.0KY FA/00J L Gasoline.0KY FA/00P Gasoline.0KY FA/P Gasoline.0KY FR/E Gasoline 0.0KY FR/F Gasoline 0.0KY FR/G H Gasoline 0.0KY FR/J L Gasoline 0.0KY FR/E Gasoline 0.0KY FR/F Gasoline 0.0KY FR/G H Gasoline 0.0KY FR/J L Gasoline 0.0KYD A Gasoline * The diagonal line (/) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from a standard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes.

5 Index A Adapter, Exhaust (KY), Adapter, Gasoline Air Cleaner (KY Begin Spec D and KYD), Adapter, Gasoline Air Cleaner (KY Spec A H), Adapter, LP Air Cleaner (KY Begin Spec L and KYD Begin Spec B), Adapter, LP Air Cleaner (KY Spec E K and KYD), Adapter, Resonator (KY Spec A), Arm, Rocker, 0, B Backplate, Exhaust (KY), Base, Enclosure (KY Begin Spec B), Base, Enclosure (KY Spec A), Base, Enclosure (KYD), Base, KY Underfloor, Base, Oil (KY Begin Spec B and KYD),, Base, Oil (KY Spec A), Bearing,, Bearing, Balancer Shaft,, Bearing, Camshaft, Bearing, Flange (KY Begin Spec J and KYD), Bearing, Flange (KY Spec A H), Bearing, Gearcase End,, Bearing, Rotor (KY Begin Spec B and KYD), Bearing, Rotor (KY Spec A), Bezel, On/Off Switch Mounting (KY Spec A), Block Assy, Brush, 0 Block Assy, Brush (KY Spec A), Block, Brush, 0 Block, Brush (KY Spec A), Board, PC (KY Begin Spec B), Board, PC (KY Begin Spec J), Board, PC (KY Spec A), Boot, Generator Harness Insulating (KY Begin Spec J and KYD), Boot, Generator Harness Insulating (KY Spec B F), Boot, Generator Harness Insulating (KY Spec G H), Boot, Spark Plug, 0 Boot, Spark Plug (KY Spec A), Boot, Spark Plug (KY Spec B H), 0 Bracket, Control (KY Begin Spec J), Bracket, Control (KY Spec A), Bracket, Control (KY Spec B H), Bracket, Fuel Regulator (KY Begin Spec L and KYD Begin Spec B), Bracket, Inlet Insulation (KY Begin Spec B), Bracket, Muffler (KY Spec A), Bracket, Regulator (KY Spec A D), Bracket, Regulator (KY Spec E K and KYD), Bracket, Solenoid (KY Spec A D), Bracket, Solenoid (KY Spec E K and KYD Spec B), Bracket, Solenoid (KY Spec E K and KYD), Bracket, Transformer (KY Begin Spec B and KYD), Breaker, Circuit (KY Begin Spec J and KYD), Breaker, Circuit (KY Spec A), Breaker, Circuit (KY Spec B H), 0 Brush, Generator, 0 Brush, Generator (KY Spec A), Bushing, Enclosure Base (KY Begin Spec F), C Cable, Starter, 0 Cable, Starter (KY Spec A), Camshaft,, Camshaft Assy, Cap, Choke Dome (KY Begin Spec J and KYD), Cap, Choke Dome (KY Spec A H), Carburetor (KY Spec A H), Carburetor Gasoline (KY Spec A H), Carburetor, (KY Begin Spec J and KYD), 0 Carburetor, LP (KY Spec A D), Carburetor, LP (KY Spec E K and KYD), Charger, Battery (KY Begin Spec B), Clip, Governor Retainer, Clip, Piston Pin,, Coil, Ignition (KY Begin Spec J and KYD), 0 Coil, Ignition (KY Spec A), Coil, Ignition (KY Spec B H), 0

6 Index Conduit (KY Begin Spec B), Connector, Fuel Valve Female (KY Spec A D), Connector, Fuel Valve Female (KY Spec E K and KYD Spec B), Connector, Fuel Valve Female (KY Spec E K and KYD), Connector, LP Regulator Hose (KY Spec A D), Connector, Straight (KY Begin Spec B), Control (KY Spec A), Control (KY Spec B H), 0 Coupling, Fuel Valve Anchor (KY Spec A D), Coupling, Fuel Valve Anchor (KY Spec E K and KYD Spec B), Coupling, Fuel Valve Anchor (KY Spec E K and KYD), Cover Assy, Enclosure (KY Begin Spec B), Cover Assy, Enclosure (Spec A), Cover, Air Cleaner (KY Begin Spec B and KYD), Cover, Air Cleaner (KY Spec A), Cover, Air Cylinder, Cover, Air Filter Thermostat (KY Spec A), Cover, Choke (KY Begin Spec J and KYD), Cover, Choke (KY Spec A H), Cover, Choke Element (KY Begin Spec J and KYD), Cover, Choke Element (KY Spec A H), Cover, Crankcase, Cover, Drain (KY Begin Spec B), Cover, KY Housing Panel, Cover, Resonator (KY Begin Spec B and KYD), Cover, Valve, 0, Crankshaft,, Cylinder, Air, D Dipper, Oil,, E Edging, Base Pan (KY Begin Spec B), Edging, Base Pan (KY Spec A), Elbow, Enclosure Base Conduit (KY Spec A), Elbow, Exhaust (KY Spec A), Elbow, Exhaust (KY), Element, Air Cleaner (KY Begin Spec B and KYD), Element, Air Cleaner (KY Spec A), Element, Choke Thermostat (KY Begin Spec J and KYD), Element, Choke Thermostat (KY Spec A H), Element, Thermostat (KY Begin Spec B and KYD), Element, Thermostat Preheat (KY Spec A), Enclosure, Generator (KY Begin Spec B and KYD), Enclosure, Generator (KY Spec A), Endbell, 0 Endbell (KY Spec A), Endbell (KY Spec B and KYD), 0 Engine, 0, Exhaust (KY Begin Spec B), Exhaust (KY Spec A), Exhaust (KYD), Exhaust Installation KY (Spec P), F Filter, Fuel (KY Begin Spec J and KYD), Filter, Fuel (KY Spec A H), Fitting, Fuel Valve Barbed Hose (KY Spec A D), Fitting, Fuel Valve Barbed Hose (KY Spec E K and KYD Spec A), Fitting, Fuel Valve Barbed Hose (KY Spec E K and KYD Spec B), Fitting, Fuel Valve Barbed Hose (KY Spec E K and KYD), Fuel System EVAP Gasoline System, Fuel System LP (KY Begin Spec L and KYD Begin Spec B), Fuel System LP (KY Spec A D), Fuel System LP (KY Spec E K and KYD), Fuse, Generator Harness (KY Spec A), Fuse, Generator Harness (KY Spec B F), Fuse, Generator Harness (KY Spec G H),

7 Index G Gasket, Air Cleaner (KY Begin Spec L and KYD Begin Spec B), Gasket, Carburetor (KY Begin Spec J and KYD), Gasket, Carburetor (KY Spec A H), Gasket, Carburetor Flange (KY Begin Spec J and KYD), Gasket, Carburetor Flange (KY Spec A H), Gasket, Crankcase, Gasket, Cylinder Head, 0, Gasket, Exhaust (KY Begin Spec B), Gasket, Exhaust (KY Spec A), Gasket, Exhaust Manifold (KYD), Gasket, Exhaust Muffler (KYD), Gasket, Gasoline Air Cleaner Adapter (KY Begin Spec J and KYD), Gasket, Gasoline Air Cleaner Adapter (KY Spec A H), Gasket, Gasoline Intake Manifold (KY Spec A H), Gasket, Gasoline Manifold Insulator (KY Spec A H), Gasket, Insulator (KY Begin Spec L and KYD Begin Spec B), Gasket, Intake Manifold (KY Begin Spec J and KYD), Gasket, LP Air Cleaner Adapter (KY Spec A D), Gasket, LP Air Cleaner Adapter (KY Spec E K and KYD), Gasket, LP Carburetor (KY Begin Spec L and KYD Begin Spec B), Gasket, LP Carburetor (KY Spec A D), Gasket, LP Carburetor (KY Spec E K and KYD), Gasket, LP Carburetor Flange (KY Begin Spec L and KYD Begin Spec B), Gasket, LP Carburetor Flange (KY Spec A D), Gasket, LP Carburetor Flange (KY Spec E K and KYD), Gasket, LP Intake Manifold (KY Spec A D), Gasket, LP Intake Manifold (KY Spec E K and KYD), Gasket, LP Manifold Insulator (KY Spec A D), Gasket, LP Manifold Insulator (KY Spec E K and KYD), Gasket, Manifold Insulator (KY Begin Spec J and KYD), Gasket, Oil Base (KY Begin Spec B and KYD),, Gasket, Oil Base (KY Spec A), Gasket, Resonator (KY Spec A), Gasket, Service Panel (KY Begin Spec B), Gasket, Valve Cover, 0, Gear, Balancer, Gear, Camshaft, Gear, Crankshaft, Gear, Governor,, Generator (KY Begin Spec B and KYD), Generator (KY Spec A), Governor, Grommet, Enclosure Base (KY Begin Spec B), Grommet, Enclosure Base (KY Spec A), Grommet, Enclosure Base (KYD), Grommet, Enclosure Cover (KY Begin Spec B), Grommet, Enclosure Cover (Spec A), Grommet, KY Housing Rubber, Grommet, Underfloor Mounting Remote (KY), Ground Terminal, Guide, Push Rod, 0, H Hanger, Exhaust (KY), Harness, AC Output (KY Begin Spec J and KYD), Harness, AC Output (KY Spec B H), 0 Harness, Adapter (KY Spec F H and KYD), Harness, Adapter (Spec F H), Harness, Customer Interface Pigtail (Spec F H), Harness, Customer Interface Pigtail (KY Spec B E), Harness, Customer Interface Pigtail (Spec B E), Harness, Engine (KY Begin Spec J and KYD), Harness, Extension (KY Spec B E), Harness, Extension (KY Spec F H and KYD), Harness, Generator (KY Spec A), Harness, Generator (KY Spec B F), Harness, Generator (KY Spec G H), Harness, Generator Harness Splitter (KY Spec B F),

8 Index Harness, Generator Harness Splitter (KY Spec G H), Harness, Remote, Harness, Remote Panel (Switch Only),, Harness, Remote Panel (Switch Only) (KY Begin Spec Fand KYD), 0 Harness, Remote Panel Adapter (KY Spec F H and KYD), Head, Cylinder, 0, Holder, Governor Spring, Hose, Air Cleaner Preheat (KY Spec J and KYD), 0 Hose, Choke Preheat (KY Begin Spec B), Hose, Gasoline Fuel (KY Begin Spec J and KYD), Hose, Gasoline Fuel (KY Spec A H), Hose, LP Fuel (KY Spec A D), Hose, LP Fuel (KY Spec E K and KYD), Hose, Preheat (KYD), Housing, Air (KY Begin Spec B and KYD), Housing, Choke (KY Begin Spec J and KYD), Housing, Choke (KY Spec A H), Housing, Scroll (KY Spec A), Housing, Stator (KY Begin Spec B and KYD), Housing, Stator (KY Spec A), I Indicator, Oil (KY Begin Spec B and KYD),, Indicator, Oil (KY Spec A), Insulation, Cover (KY Begin Spec B and KYD), Insulation, Door (KY Begin Spec B), Insulation, Exhaust (KY Spec A), Insulation, Exhaust Baffle (Spec A), Insulation, Exhaust Barrier (KY Begin Spec B), Insulation, Inlet (KY Spec B H), Insulation, Inlet (Spec A), Insulation, Inlet Baffle (KY Begin Spec B and KYD), Insulation, Sound, 0 Insulator, Carburetor (KY Begin Spec J and KYD), Insulator, Carburetor (KY Spec A H), Insulator, Exhaust (KY), Insulator, Gasoline Intake Manifold (KY Spec A H), Insulator, Intake Manifold (KY Begin Spec J and KYD), Insulator, LP Carburetor (KY Spec A D), Insulator, LP Carburetor (KY Spec E K and KYD), Insulator, LP Intake Manifold (KY Spec A D), Insulator, LP Intake Manifold (KY Spec E K and KYD), Isolator, Engine Mount (KY Begin Spec B), Isolator, Generator Mount (KY Begin Spec B), Isolator, Generator/Engine Mount (KY Spec A), Isolator, Mount (KYD), Isolator, Muffler (KY Begin Spec B), Isolator, Snubber (KY Begin Spec B), Isolator, Snubber (KY Spec A), Isolator, Snubber (KYD), K Key, Camshaft, Key, Crankshaft, Key, Fan Hub (KY Begin Spec B and KYD), Key, Fan Hub (KY Spec A), Kit Hose, Vent, Kit Rod, Connecting, Kit, Air Filter (KY Begin Spec B and KYD), Kit, Carburetor (KY Begin Spec K and KYD), Kit, Carburetor Repair (KY Spec A C), Kit, Carburetor Repair (KY Spec A J),, Kit, Carburetor Solenoid Repair (KY Spec B C)), Kit, Enclosure Cover, Kit, Exhaust Elbow, Kit, Exhaust Elbow Adapter (KY), Kit, Exhaust Tailpipe (KY), Kit, Exhaust Tube (KY), Kit, Filter, Kit, Governor Sleeve, Kit, KY Housing, Kit, KY Underfloor Base, Kit, KY Underfloor Housing, Kit, Mounting (Underfloor), Kit, Muffler, Kit, Remote Adapter,

9 Index Kit, Remote Panel (KY Spec B E), Kit, Remote Panel (Switch and Hourmeter), Kit, Remote Panel (Switch and Voltmeter), Kit, Remote Panel (Switch and Voltmeter) (KY Begin Spec F and KYD), Kit, Remote Panel (Switch Only), 0 Kit, Remote, Panel (Switch Only), 0 Kit, Set Mounting, Kit, Tailpipe Hanger, Kit, Underfloor Mounting (KY Begin Spec B)), Kit, Underfloor Mounting (KY), Kit, Underfloor Mounting (KYD), Kits (Misc), Kits, KY Exhaust, KY and KYD Labels, L Label, Air Cleaner (KY Begin Spec B and KYD), Label, Charger (KY Begin Spec B), Latch Assy, Service Panel (KY Begin Spec B), Latch, Service Panel (Spec A), Lever, Governor, Lever, Governor Control, Line, LP Fuel Inlet (KY Spec A D), Line, LP Fuel Inlet (KY Spec E K and KYD Spec B), Line, LP Fuel Inlet (KY Spec E K and KYD), Linkage, Choke (KY Begin Spec J and KYD), Linkage, Choke (KY Spec A H), Lock, Valve Spring, 0, M Magneto (KY Begin Spec B and KYD), 0 Magneto (KY Spec A), Manifold, Exhaust, Manifold, Exhaust (KY Begin Spec B), Manifold, Gasoline Intake (KY Spec A H), Manifold, Intake (KY Begin Spec J and KYD), Manifold, LP Intake (KY Spec A D), Manifold, LP Intake (KY Spec E K and KYD), Meter, Hour (Begin Spec F), Meter, Volt (Begin Spec F), Mixer (KY Begin Spec L and KYD Begin Spec B), Module, Secondary Air Injection, Mount, Generator, Mount, Isolating, Muffler (KY Begin Spec B), Muffler (KY Spec A), Muffler (KYD), N Nipple, Fuel Valve (KY Spec A D), Nipple, Fuel Valve (KY Spec E K and KYD Spec B), Nipple, Fuel Valve (KY Spec E K and KYD), O O Ring, Oil Fill Tube (KY Spec A), O Ring, Oil Indicator (KY Begin Spec B and KYD),, O Ring, Oil Indicator (KY Spec A), O Ring, Rotor (KY Begin Spec B and KYD), O Ring, Rotor (KY Spec A), P Paint, Paint, Enamel Green, Panel, Control (KY Begin Spec J and KYD), Panel, Control (KY Spec A), Panel, Control (KY Spec B H), 0 Panel, KY Housing, Panel, Remote, 0, Panel, Remote (KY Begin Spec F and KYD), Panel, Remote (KY Spec B E), Panel, Remote Switch and Hourmeter, Panel, Remote Switch and Voltmeter (KY Begin Spec F and KYD), Panel, Remote Switch only, 0 Panel, Service (KY Begin Spec B), Panel, Service (Spec A), Panel, Under Floor (KYD),

10 Index Panel, Underfloor Mounting (KY), PCB, Control (KYD), Pin, Cylinder Head Hollow Dowel, 0, Pin, Decompression, Pin, Endbell Roll (KY Spec A), Pin, Piston,, Pipe, Exhaust (KYD), Piston,, Pivot, Speed Adjusting, Plate, Oil Shield,, Plug, Drain (KY Begin Spec B and KYD),, Plug, Drain (KY Spec A), Plug, Hole (KY Spec A), Plug, Hole (KY Spec B H), 0 Plug, Spark, 0, Potentiometer (KY Begin Spec J and KYD), Potentiometer (KY Spec A), Potentiometer (KY Spec B H), 0 Pump, Fuel (KY Begin Spec J and KYD), Pump, Fuel (KY Spec A H), R Rail, KY Underfloor Mounting Bottom, Rail, Mounting (KYD), Rail, Underfloor Mounting (KY), Rectifier, Generator Harness Bridge (KY Spec A), Regulator, Fuel (KY Begin Spec L and KYD Begin Spec B), Regulator, LP (KY Spec A D), Regulator, LP (KY Spec E K and KYD), Regulator, Voltage (KY Spec A), Regulator, Voltage (KY Spec B H), Relay, Start Solenoid (KY Spec A), Relay, Start Solenoid (KY Spec B H), Relay, Start Solenoid (KYD), Resistor, Generator Harness (KY Spec A), Resonator, Exhaust (KY), Resonator, Intake (KY Begin Spec B and KYD), Retainer, Valve Spring, 0, Ring Set, Piston,, Ring, Collector (KY Begin Spec B and KYD), Ring, Collector (KY Spec A), Rings, Valve Guide, 0, Rod, Air Inlet (KY Spec A), Rod, Connecting, Rod, Governor, Rod, Push,, Rotor Assy, Generator (KY Begin Spec B and KYD), Rotor Assy, Generator (KY Spec A), S Seal,, Seal, Air (KY Begin Spec B and KYD), Seal, Air Filter Foam (KY Begin Spec B and KYD), Seal, Barrier Edge (KY Begin Spec B), Seal, Crankshaft Oil,, Seal, Cylinder Block Oil, Seal, Endbell (KY Spec A), Seal, Valve Stem, 0, Secondary Air Assy, 0 Secondary Air Injeciton (SAI) KY (Spec P), 0 Shaft, Balancer, Shaft, Flyweight, Shaft, Governor Lever, Shield, Carburetor (KY Begin Spec J and KYD), Shield, Carburetor (KY Spec A), Shield, Carburetor (KY Spec B H), 0 Shield, Exhaust, Shield, Exhaust Insulation (KYD), Shim, Balancer, Shim, Breather Valve, 0, Shim, Camshaft,, Shim, Crankshaft,, Silencer, Exhaust, Sleeve, Governor,, Solenoid, Gasoline Fuel Cut (KY Begin Spec B C), Solenoid, Start (KY Begin Spec B), Spacer, Muffler (Isolator KYD), Spring, Decompression,

11 Index Spring, Generator Brush, 0 Spring, Generator Brush (KY Spec A), Spring, Governor, Spring, Governor Adjusting Screw, Spring, Governor Rod, Spring, Valve, 0, Starter, 0 Starter (KY Spec A), Stator, Generator (KY Begin Spec B and KYD), Stator, Generator (KY Spec A), Stiffener, Bracket (KY Spec A D), Stiffener, Bracket (KY Spec E K and KYD), Strap, Bond (KY Begin Spec B and KYD), Strap, Bond (KY Spec A), Stud, Exhaust (KY Begin Spec B), Stud, Exhaust (KY Spec A), Stud, Exhaust (KYD), Switch, Oil Level (KY Spec A), Switch, Oil Level (KY Spec B F Only), Switch, Remote Panel Start/Stop (KY Begin Spec F and KYD), 0 Switch, Remote Panel Start/Stop (KY Spec B E), Switch, Remote Panel Start/Stop Switch and Hourmeter (Begin Spec F), Switch, Start/Stop (Generator Harness) (KY Spec A), Switch, Start/Stop (KY Begin Spec J and KYD), Switch, Start/Stop (KY Spec B H), 0 T Tappet,, Terminal, Spark Plug, 0 Terminal, Spark Plug (KY Spec B H), 0 Transformer, Voltage (KY Begin Spec B and KYD), Transformer, Voltage (KY Begin Spec J and KYD), Tube, Breather, 0, Tube, Exhaust (KY), Tube, Oil Fill (KY Spec A), Tube, Spacer (KY Begin Spec B), V Valve Assy, Fuel (KY Spec A D), Valve Assy, Fuel (KY Spec E K and KYD Spec B), Valve Assy, Fuel (KY Spec E K and KYD), Valve, Breather, 0, Valve, Intake/Exhaust, 0, Valve, PCV, W Wheel Assy, Blower (KY Begin Spec B and KYD), Wheel Assy, Blower (KY Spec A), Wrapper, Air Cylinder,

12 Cylinder Head (All Spec A K) (.KYFR and.kyfa Spec L) Engine (Spec A L) Valve 0 Intake 0 Exhaust 0 Gasket, Cylinder Head 0 0 Head, Cylinder (Includes Guides, Seats and Valve Guide Rings) 0 Rings, Valve Guide (Not Shown) Plug, Spark 0 0Hz 00 0Hz 0 00 Washer, Flat (M0) 0 0 Bolt, Cylinder Head (M0 x. x mm) 0 Washer, Valve Spring 0 0 Spring, Valve Retainer, Valve Spring 0 Lock, Valve Spring 0 0 Seal, Valve Stem Bolt, Flange (M0 x. x mm) 0 Valve, Breather Shim, Breather Valve Bolt, Cylinder Head (M x. x mm) 0 0 Bolt, Cylinder Head (M x. x mm) 0 Pin, Hollow Dowel 0 Cover, Valve 0 0 Gasket, Valve Cover 00 0 Screw, Hex Flange Head (M x x mm) Tube, Breather 0 Clamp, Hose 0 Arm, Rocker Nut, Rocker Arm Adjusting 0 Nut, Lock Adjusting 0 Guide, Push Rod 0 Stud, Rocker Arm 0

13 Cylinder Head (.KYFR,.KYFA Begin Spec M) (.KYFR,.0KY Begin Spec L) Engine 00 Spec L,M Valve 0 0 Intake 0 0 Exhaust 0 Gasket, Cylinder Head 0 0 Head, Cylinder (Includes Guides, Seats and Valve Guide Rings) 0 Rings, Valve Guide (Not Shown) Plug, Spark 0 0Hz 00 0Hz A0V0 Washer, Flat (M0) A0X0 Bolt, Cylinder Head 0 Washer, Valve Spring 0 0 Spring, Valve Retainer, Valve Spring 0 Lock, Valve Spring A0V Seal, Valve Stem A0X Bolt, Flange (M x. x mm) 0 Valve, Breather Shim, Breather Valve A0X Bolt, Cylinder Head (M0 x. x mm) A0X0 Bolt, Cylinder Head (M0 x. x 0mm) 0 Pin, Hollow Dowel 0 Cover, Valve 0 0 Gasket, Valve Cover A0X00 Screw, Hex Flange Head (M x x mm) Tube, Breather 0 Clamp, Hose 0 Arm, Rocker Nut, Rocker Arm Adjusting 0 Nut, Lock Adjusting 0 Guide, Push Rod 0 Stud, Rocker Arm

14 Crankshaft (Spec A L) 0 Piston (Includes Pin & Clip) 0 Standard 0. Oversize 0.0 Oversize A0X Kit, Piston Rings 00 Pin, Piston 0 Clip, Piston Pin 0 00 Bearing, Block End 0 0 Gear, Crankshaft 0 Gear, Balancer 0 0 Crankshaft 0 Key, Woodruff Bearing 0 0 Seal, Oil Shim (Use As Required) mm mm mm mm mm mm Rod Assy, Connecting (Includes Bolt) 0 Standard No Replacement 0. Undersize No Replacement 0.0 Undersize 0 Plate, Oil Shield 0 Dipper, Oil

15 Crankshaft (Begin Spec.KY Spec M and.0ky Spec L) 0 0 Piston A0X Kit, Piston Rings 00 Pin, Piston 0 Clip, Piston Pin 0 00 Bearing, Block End 0 Crankshaft 0 0 Bearing A0V Seal, Oil Shim (Use As Required) mm mm mm mm mm mm 0 A0X Kit Rod, Connecting (Includes Cap, Bolt, and Rod) A0V Bolt, Connecting Rod 0 Plate, Oil Shield A0X0 Dipper, Oil

16 Camshaft (Spec A L) & 0 0 Tappet 0 0 Camshaft (Begin Spec E) (Includes Parts Marked ) 0 0 +Gear Assy, Camshaft (Spec A D) (Includes Flyweight, Flyweight Shaft and Pin) 0 0 Shaft, Flyweight 0 0 Pin, Decompression Spring 00 +Key, Woodruff 0 +Pin, Decompression 0 +Spring, Decompression 0 0 Gear, Governor 0 0 *Washer, Flat 0 *Washer, Flat 00 Sleeve Kit, Governor (Includes Washers Marked *, Governor Stop, Governor Sleeve and Governor Shaft) 0 0 Bearing, Ball Shim (Use As Required) 0 0.0mm 0 0.0mm 0 0.0mm 0 Rod, Push 0 0 Seal + Parts Included in Camshaft Assy (Spec A D) Parts Included in Camshaft Assy (Begin Spec E) * Washers Included in Governor Sleeve Kit.

17 Camshaft (Begin Spec.KY Spec M and.0ky Spec L) 0 0 Tappet 0 0 Camshaft Assy 0 0 Gear, Governor 0 Sleeve, Governor 0 0 Bearing, Balancer Shaft Shim (Use As Required) 0 0.0mm 0 0.0mm 0 0.0mm 0 Rod, Push 0 Shaft, Governor A0X00 Washer, Governor Shaft Seal

18 Crankcase Cover 0 0 Cover, Crankcase A0X Bolt, Crankcase Cover (M x. x 0mm) 0 0 Gasket, Crankcase Shaft, Balancer (Includes Shaft and Gear) 0 0 Spec A L 0 0 Begin Spec M 0 0 Bearing, Ball Shim, Balancer (Use as Required) mm mm mm

19 Governor Lever, Governor 0 Holder, Governor Spring 0 0 Nut, Square (M x.mm) 0 Washer, Flat (/ ) 0 Screw, Hex Head Cap (M x. x mm) 0 Clip, Retainer 0 00 Washer, Flat (M) 0 Spring, Adjusting Screw 0 Screw, Special 0 0 Spring, Governor Rod 0 Rod, Governor 0 Clip, Retainer 0 0 Shaft, Governor Lever 0 Seal, Oil 0 0 Spring, Governor 0 Nut, Flanged (M x.) 0 Pivot, Speed Adjusting 0 0 Lever, Governor Control 0 Stud, Control Lever Mounting *Bolt, Flange (M x ) * Item 0 may be used as an alternate option for items and.

20 Carburetor Gasoline (KY Spec A H)

21 Carburetor Gasoline (KY Spec A H) 0 Kit, (Parts Without Part Numbers are Not Sold Separately) Solenoid (Spec B, C) (For use with Carburetor 0 (Includes Solenoid Valve Assy, Gaskets and Solenoid Holder) 0 +Kit, Carburetor (Spec B H)(Con tains Parts in 0) (For use with Carburetor 0)(Includes Gas kets Marked,Parts Marked + Float, Float, Pin, Float Valve andgaskets) 0 Kit, Carburetor (Spec A C) (For use with Carburetors 0 and 0) (Includes Gaskets Marked, Parts Marked ^, Float, Gaskets, Float Valve, Float Pin and Main Limiter Cap) 0 Kit, Spec A (Includes Gaskets Marked, Parts Marked * and Carburetor 0) Spec B C 0 Kit, Emissions Conversion (Includes Gaskets Marked and Parts Marked ~) (Converts to Emissions Carburetor 0 introduced for Spec D) 0 xkit, Spec D H, (Includes Carb 00 and Parts Marked x) 00 Insulator Gasket, Intake Manifold 0 Manifold, Intake 0 +x Gasket, Manifold Insulator 0 +Insulator 0 +x Gasket, Carburetor Carburetor (Carburetor only) 0 Spec A 0 Spec B C 0 Spec D H 0 Linkage, Choke 0 Bearing, Flange Housing, Choke 0 Cover, Choke Element 00 Cap, Dome 00 Element, Choke Thermostat Cover, Choke 0 0 Spec A H 000 Washer, Flat (/ ) 0 00 Nut, Hex (M x.mm) Adapter, Air Cleaner 00 0 ~ Spec D H 0 00 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x x 0mm) 0 Gasket, Carburetor Flange 0 * Spec A 0 ~ Spec B H Gasket, Air Cleaner Adapter 0 *^ Spec A D 0 0 +~x Spec E H Filter, Fuel 0 Pump, Fuel (Electric) (E) (Spade Terminal) 00 0 Screw, Pan Head Torx (M x x 0mm) 0 0 Clamp, Hose (. ) Hose, Fuel 0 Spec B J (mm) 0 Solenoid, Fuel Cutoff (Spec B C Non Emissions Only) (E)(Not Replaceable Spec D J) 0 Sleeving, Convoluted 0 Nut, Flanged (M x.mm) 0 Stud Gaskets Included with Carburetors and Repair Kits. Carburetor Part Numbers are embossed on the Carburetor. * Parts Included with Carburetor (Spec A) ~ Parts Included with Emissions Carburetor Conversion Kit (Spec B C) ^ Parts Included with Carburetor Repair Kit (Spec A C) + Parts Included in Carburetor Repair Kit (Begin Spec B and During Spec J) Parts Included with Carburetor (During Spec J)

22 Carburetor, Gasoline (KY Begin Spec J and KYD)

23 Carburetor, Gasoline (KY Begin Spec J and KYD) A0P Kit, Carburetor (Non Evap) (w/carburetor A0D In cludes Gaskets Marked +, Float, Float Pin, Float Valve Covers Spec A P) 0 Kit, Carburetor (Spec B H, J thru S/N F0) (For use withcarburetor 0) (Includes Gaskets Marked, Parts Marked +, Float, Float Pin, Float Valve and Gaskets) Includes 0 0 +Obsolete Kit Carburetor Pack age, Repair(Includes Float, Float Valve, Float Pin, and Gaskets, Float Chamber) Carburetor Only 0 KYFA Spec A L (Evap) 00 All other KY Spec A L (Non Evap) A0D KYFA begin Spec M (Evap) A0D All other KY begin Spec M (Non Evap) 00 Insulator, Head Gasket, Intake Manifold 0 Manifold, Intake 0 +xgasket, Manifold Insulator 0 +Insulator, Carburetor 0 +xgasket, Carburetor 0 Linkage, Choke 0 Bearing, Flange Housing, Choke 0 Cover, Choke Element 00 Cap, Dome 00 Element, Choke Thermostat 0 0 Cover, Choke (KY Begin Spec and KYD) 000 Washer, Flat (/ ) 0 00 Nut, Hex (M x.mm) 00 0 Adapter, Air Cleaner (KY Begin Spec D and KYD) 0 00 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x x 0mm) Seal, Air Cleaner Spacer 0 Gasket, Carburetor Flange 0 0 +xgasket, Air Cleaner Adapter Filter, Fuel A0F Pump, Fuel (Electric) (E) (Ring Terminal) 00 0 Screw, Pan Head Torx (M x x 0mm) 0 0 Clamp, Hose 0 Hose, Fuel (mm) 0 Nut, Flanged (M x.mm) Stud 0 0 Sleeving, Convoluted

24 Fuel System LP (KY Spec A D)

25 Fuel System LP (KY Spec A D) 00 Insulator, Head Gasket, Intake Manifold 0 Manifold, Intake Stud 0 Nut, Flanged (M x.mm) 0 Gasket, Manifold Insulator 0 Insulator 0 Gasket, Carburetor 0 00 Hose, Fuel (. Lg) (. ID x. OD) 0 0 Clamp, Hose 0 Hose, Fuel 0 Carburetor Kit, LPG 0 Gasket, Air Cleaner Adapter Gasket, Carburetor Flange 0 Spec A 0 Begin Spec B 00 0 Screw, Hex Head Cap (M x x 0mm) 0 00 Washer, Flat (M) 0 0 Hose, Fuel (0 ) (. ID x. OD) 0 0 Connector, Hose (/ NPT x / ID) (Beginning Spec E, Hose Connector Supplied with Regulator) 0 Regulator (K)(Includes Inlet Fitting) 0 0 Clamp, Hose 0 0 Stiffener, Bracket Screw, Torx Pan Head Thread Forming (M x mm) 000 Screw, Lock Head Flange (0 x / ) 0 0 Bracket, Regulator 000 Screw, Flange Lock Hex (#0 x / ) 0 Fitting, Barbed Hose Valve Assy, Fuel (E) 0 0 LP Liquid sets 0 0 LP Vapor sets 0 00 Nipple, Close 0 Coupling, Anchor 0 Line, Inlet Fuel (KY Begin Spec B)( LG x / NPT) 0 Connector, Female (/ NPT) (KY Begin Spec B and Spec A) 0 00 Fitting, Barbed Hose (Spec A Except Spec A) Nipple 0 00 KY Spec A Bracket, Solenoid 0 0 KY Spec A 0 0 KY Begin Spec B Obsolete 00 0 Screw, Torx Pan Head (M x x 0mm) 000 Washer, EIT Lock Torx (M)

26 Fuel System LP (KY Spec E K and KYD Spec A)

27 Fuel System LP (KY Spec E K and KYD) 0 Kit,Carburetor (Includes Parts Marked +) 00 Insulator, Head Gasket, Intake Manifold 0 *Manifold, Intake Stud 0 Nut, Flanged (M x.mm) 0 *+Gasket, Manifold Insulator 0 *Insulator 0 *+Gasket, Carburetor 0 00 *Hose, Fuel (. Lg) (. ID x. OD) 0 0 *Clamp, Hose 0 *+Carburetor 0 0 *+Gasket, Air Cleaner Adapter 0 *Gasket, Carburetor Flange (KY Begin Spec B and KYD) 00 0 *Screw, Hex Head Cap (M x x 0mm) 0 00 *Washer, Flat (M) 00 0 *Adapter, Air Cleaner 0 0 *Hose, Fuel (0 ) (. ID x. OD) 0 Clamp, Hose 0 Regulator (K) Stiffener, Bracket Screw, Torx Pan Head Thread Forming (M x mm) 000 Screw, Lock Head Flange (0 x / ) 0 0 Bracket, Regulator 000 Screw, Flange Lock Hex (#0 x / ) 0 Fitting, Barbed Hose 0 0 Valve, Fuel (Shut Off) 0 00 Nipple, Close 0 Coupling, Anchor Line, Inlet Fuel (Begin Spec B) ( LG x / NPT) 0 0 Connector, Female (/ NPT) (Begin Spec B and Spec A) 0 00 Nipple 0 0 Bracket, Solenoid 00 0 Screw, Torx Pan Head (M x x 0mm) 000 Washer, EIT Lock Torx (M) 0 0 Hose, LP Fuel Sleeving, Convoluted * Parts Included in Carburetor Assy.

28 Fuel System LP (KY Begin Spec L and KYD Spec B) 0 0 0

29 Fuel System LP (KY Begin Spec L and KYD Begin Spec B) Kit Hose, Vent (Includes Hose, Cable Tie and Instructions) 0 Gasket, Carburetor Flange 0 0 Seal, Air Cleaner Spacer 0 00 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x x 0mm) 00 0 Adapter, Air Cleaner 0 Gasket, Carburetor 0 Nut, Locking Flange 0 Insulator, Carb 0 Gasket, Insulator 0 0 Elbow, Intake (Machine) Gasket, Intake Elbow 00 Insulator, Head 0 0 Hose, Vapor LPG (.OD x. ) 0 0 Hose, Vent (.ID x ) Screw, Pan Head Torx Thread Form (M x x mm) 0 Bracket, Fuel Regulator 00 Screw, Locking Head (/ 0 x / ) 0 Clamp, Hose Tube, Breather Gasket, Air Cleaner 0 Mixer Regulator, Fuel 0 Bracket, Fuel Regulator 0 Fitting, Barbed Hose 0 0 Valve, Fuel (Shut Off) 0 00 Nipple, Close 0 Coupling, Anchor Line, Inlet Fuel (Begin Spec B) ( LG x / NPT) 0 Connector, Female (/ NPT) (Begin Spec B and Spec A) Nipple 0 0 Bracket, Solenoid 00 0 Screw, Torx Pan Head (M x x 0mm) 000 Washer, EIT Lock Torx (M) 0 0 Hose, LP Fuel Sleeving, Convoluted 0 0 Clamp, Hose Kit, Filter (Vent Hose) (Includes Filter, Cable Tie & Instruction Sheet)

30 Fuel System EVAP Gasoline System 0 Spring, Valve A0N0 Tube, Breather 0 Bracket 0 Hose, Fuel 0 0 Hose, Fuel 0 Hose, Fuel Valve, PCV

31 Endbell (KY Spec A), Endbell, Obsolete 0 Pin, Roll Seal, Endbell Screw, Pan Head Torx (M x. x mm) 000 Washer, Flat (#) S0 Block Assy, Brush (Includes Brush, Spring and Block) S0 Block, Brush 0 Spring, Generator Brush 00 Brush, Generator Element, Air Cleaner 0 Element, Thermostat Preheat 0 Cover, Air Filter Thermostat 0 Rod, Air Inlet 00 Washer, Flat (/) Screw, Hex Head Cap (/ 0 x / ) 0 Cover, Air Cleaner 0 S0 Magneto Screw, Torx Pan Head (M x x mm) Regulator, Voltage (VR) Hz Hz Screw, Pan Head (M x. x 0mm) Strap, Bond 000 Washer, EIT Lock (/ )

32 Endbell (KY Begin Spec B and KYD) 0 0, Endbell 00 KY Spec B H 0 00 Gasoline (KY Begin Spec J and KYD)(Includes Parts Marked *) 0 0 LP (KY Begin Spec J and KYD)(Includes Parts Marked *) Screw, Pan Head Torx Thread Forming (M x mm) KY Spec G H KY Begin Spec J and KYD 0 S0 +Magneto (G) (KY Spec B H and KYD) Screw, Pan Head Torx (M x. x mm) KY Spec B H * KY Begin Spec J and KYD 0 Coil Ignition (KY Begin Spec J and KYD, Includes Boot and Terminal) 0 Terminal, Spark Plug Boot, Spark Plug 000 *Washer, Flat (/ ) S0 *Block Assy, Brush (Includes Brush, Spring and Block) 0 00 *Brush, Generator 0 *Spring, Generator Brush S0 *Block, Brush 0 +Hose, Preheat (Gasoline Units) (KY Spec B H and Part of J) 00 Plug (LP Units) 0 0 +O Ring (Gasoline Units) (KY Spec B H and Part of J) Cable, Starter KY Spec B H KY Begin Spec J and KYD 0 Screw, Hex Washer Head Cap (M x. x 0mm) Starter KY Spec B J KY Begin Spec K and KYD 000 Nut, Hex Washer, Lock Spring (/ ) * Parts Included with Endbell Beginning Spec J. + Eliminated During Spec J. 0

33 Air Housing (KY Begin Spec B and KYD) 0 0, Housing, Air 0 KY Spec B H KY Begin Spec J and KYD 0 Door, Preheat (Gasoline Units) 0 00 Seal, Air (Right) 0 00 Seal, Air (Left) Screw, Torx Pan Head Thread Forming (M x x 0mm) 0 Resonator, Intake 0 Cover, Resonator 0 0 Screw, Torx Pan Head Thread Forming 00 Washer, Flat (.D x.00 x ) 0 0 Insulation, Inlet Baffle Cover, Air Cleaner 00 Nut, Wing 0 Kit, Air Filter (Includes Parts Marked *) 0 0 *Element, Air Cleaner 0 0 *Seal, Air Cleaner Spacer 000 Washer, EIT Lock (/ ) Strap, Bond KY Spec B H KY Begin Spec J and KYD 00 Screw, Pan Head Thread Forming (M x. x mm) 0 Clip, Push On (Gasoline Units) 0 0 Element, Thermostat (Gasoline Units) *Label, Air Cleaner * Parts Included in Air Filter Kit

34 Air Cylinder REF PART QTY PART NO. NO. USED DESCRIPTION 0 Cover, Air Cylinder Screw, Torx Pan Head Thread Forming (M x x mm) 0 Gasoline 0 LP Wrapper, Air Cylinder

35 Oil Base (KY Spec A) 0 Gasket, Oil Base Screw, Hex Washer Head (M x. x mm) 0 0 Plug, Hex Head Drain (/ ) O Ring 0 Tube, Oil Fill 0 0 O Ring Indicator, Oil (Includes O Ring) 0 0 Switch, Oil Level (S)

36 Oil Base (KY Begin Spec B and KYD) Screw, Hex Head Cap (M x. x mm) 0 0 Plug, Drain (/ NPT) (All Specs Except 0) 0 0 Plug, Drain (/ NPT 0 00 O Ring 0 Indicator, Oil (Includes O Ring) 0 0 Switch, Oil Level (S) (KY Spec B F Only) 0 Base, Oil 0 Gasket, Oil Base

37 Oil Base (Begin Spec.KY Spec M and.0ky Spec L) A0X 0 Screw, Hex Head Cap (M x. x mm) 00 Washer 0 Plug, Drain A0V Plug, Drain (/ NPT) 0 00 O Ring 0 Indicator, Oil (Includes O Ring) 0 Base, Oil (Begin Spec B) 0 Gasket, Oil Base

38 Exhaust (KY Spec A) 0 Bracket, Muffler Screw, Torx Pan Head (M x. x 0mm) 0 0 Nut, Hex (#0 ) 0 Screw, Locking Flange (M x. x 0mm) Muffler Gasket, Exhaust 0 Stud, Exhaust 0 0 Nut, Locking Flange Hex (M.)

39 Exhaust (KY Spec B N) 0 Stud, Exhaust 0 KY Spec B H 0 KY Begin Spec J Gasket, Exhaust Manifold, Exhaust (Includes Tube) 0 0 Nut, Torque Hex (M) 0 0 Isolator, Bottom Muffler Muffler 0 0 Isolator, Top Muffler 00 Washer, Flat (#0) 00 0 Screw, Pan Head Machine (M x. x 0mm) Hose, PreHeat 00 0 Screw

40 Exhaust Installation KY (0Hz) (KYFA00 Begine Spec P) (KYFA Begin Spec P) (.KYFA0 Begin Spec P) Mount, Isolating A0F Silencer, Exhaust 0 0 Isolator, Muffler 00 Washer, Flat 00 0 Screw, Pan Head Gasket A0T Manifold, Exhaust 00 0 Screw, Hex Head 0 0 Nut, Flange 0 A0H Clamp 0 Stud, Exhaust

41 Exhaust (KYD) 0 0 Kit, Muffler (Includes Parts Marked *) 0 *Muffler *Gasket, Exhaust Muffler 0 *Grommet 0 *Spacer, Muffler (Isolator) 0 *Washer, Flat 0 *Washer, Flat (/ ) *Screw, Hex Head (/ NC x / ) 0 Pipe, Exhaust Gasket, Exhaust Manifold Hose, Preheat ( ) 0 0 Nut, Hex Flange (M X.mm) 0 Stud, Exhaust * Parts Included in Muffler Kit. Module, Secondary Air Injection A0L0 (LP) A0L (Gas)

42 Exhaust/Secondary Air Module KY (0Hz) (KYFA00 Begine Spec P) (KYFA Begin Spec P) (.KYFA0 Begin Spec P) Secondary Air Assy A0L0 (Gas) A0L (LP) A00J Valve A00J Cover, Access 00 0 Screw, Hex Head A00J Insulation, Sound A0G0 Orifice 0

43 KY Exhaust Kits Exhaust Tube Elbow Adapter Tailpipe & 0 0 Kit, Exhaust Tube (Includes Adapter and Clamp) 0 Adapter, Exhaust *~Clamp Kit, Exhaust Elbow Adapter (Includes Exhaust Elbow and Clamp) Elbow, Exhaust Kit, Exhaust Tailpipe 0mm Tube (Includes Parts Marked *) mm Tube (Includes Parts Marked ~) Tube, Exhaust S0 * 0mm S ~ mm 0 *~Insulator, Exhaust *~Clamp, Exhaust *~Screw, Hex Head Cap / x. *~Backplate, Exhaust *~Screw Hex Head Cap / x. 00 *~Nut, Hex / Hanger, Exhaust. O.D. Resonator, Exhaust

44 Enclosure Base (KY Spec A) Insulation, Exhaust 0 00 Isolator, Mounting 00 Nut, Lock Base, Enclosure 000 Nut, Hex (/ ) Washer, Spring Lock (/ ) Hz Hz 00 0 Screw, Torx Pan Head (M x x mm) 0 Relay, Start Solenoid (K) 0 Bracket, Control 0 00 Board, PC 0 Tie, Cable 0 0 Grommet, Enclosure Base 0 Elbow, Conduit 000 Washer, EIT Lock (/ ) 00 Nut, Hex (/ 00 Screw, Isolator Mounting (Includes Washer) 0 0 Isolator, Snubber 00 Bolt, Carriage (/ x / ) 0 Gasket, Resonator 0 Adapter, Resonator Clamp, Exhaust ( / ) Elbow, Exhaust Angle 0 Angle Screw, Cap Hex Head (/ x ) 0 0 Edging, Base Pan (mm) Edging, Base Pan (mm)) 00 Washer

45 Blank Page

46 Enclosure Base (KY Spec B P)

47 Enclosure Base (KY Spec B P) 0 0 Base, Enclosure 0 0 Grommet, Enclosure Base 00 0 Screw, Pan Head Torx Machine (M x x 0mm) 0 0 Clamp, Conduit (Not Included With Spec 0 or 0) 0 Connector, Straight (/ Pipe Thread) (Spec 0) 0 Conduit (/ x ) (Spec 0) Bushing 0 00 Snap (Begin Spec F Except Spec 0 G & H) 0 Armor (Spec 0 G & H only) Tube, Spacer (Gasoline Spec B D; LP Spec B, C) 000 Washer, EIT Lock (/ ) 0 00 Nut, Hex (/ ) 00 Washer, Flat (/ ) (Gasoline Spec B D; LP Spec B, C) Screw, Hex Head Thread Forming (M0 x. x 0mm) Gasoline 0 0 Spec B D (Hex Head) 0 0 Begin Spec E (Socket Head) LP 0 0 Spec B, C 0 0 Begin Spec D 0 0 Isolator, Snubber (Gasoline Begin Spec E; LP Begin Spec D) 00 Washer, Flat (Gasoline Spec E; LP Spec D) Screw, Isolator 00 Spec D/E H (Includes Washer) (Gasoline Spec E; LP Spec D) 0 Begin Spec J Cover, Drain Gasoline 0 0 Spec B D 0 0 Begin Spec E LP 0 0 Begin Spec D Bolt, Carriage (/ x / ) Edging (mm) Isolator, Engine End Isolator, Generator End Board, PC (Begin Spec J) 0 0 Screw, Torx Pan Head (Begin Spec J) 0 Bracket, Control (Begin Spec J) 000 Nut, Hex (/ ) 0 00 Washer, Spring Lock (/ ) 0 Relay, Start Solenoid (K) Board, PC 00 0 Spec B E 00 Spec F H 0 Bracket, Control (Spec B H) Gasoline Units) (Spec B H) *Regulator, Voltage (VR) (Spec B H) (0Hz, 0V, Gasoline Units) Hz Hz Screw, Torx Pan Head (Spec B H) (M x mm) Seal, Barrier Edge 0 00 (Spec B M) 0 0 (Spec P) A0K0 Shield, Exhaust (Spec B P) 0 0 Nut, Flange Lock (M x ) 0 Insulation, Exhaust Barrier 0 Nut, Push On 0 Ground Terminal * Voltage regulator Spec J M included on PCB.

48 Enclosure Base (KYD)

49 Enclosure Base (KYD) 0 0 Grommet, Enclosure Base 0 0 Screw, SKT TH Head Torx 0 0 Screw, Pan Head Torx (M x x mm) 0 0 Clamp, Conduit 0 Screw, Isolated Mounting 0 0 Isolator, Snubber 000 Washer, EIT Locking (/ ) 00 Nut, Hex (/ UNC) 0 Shield, Exhaust Insulation Edging Isolator, Mount Isolator, Mount Screw, Hex Head (/ NC x.) 0 00 Bushing, Snap Strap, Bond PCB, Control 0 Bracket, Control Mounting 0 0 Screw, Hex Washer Head Thread Forming (/ 0 x. ) 000 Nut, Hex Jam (/ UNC) Washer, Split Locking (/ ) 0 Relay, Start Solenoid

50 Generator Enclosure (KY Spec A) 0 0 Cover Assy, Enclosure (Includes Parts Marked *) 0 *Clip, Christmas Tree 0 0 *Grommet, Remote 0 0 *Insulation, Inlet 0 *Washer, Flat (Special) Screw, Shoulder Torx (M x mm) Insulation, Upper Exhaust Baffle 0 0 *Panel, Service (Includes Latches, Insulation, Label, Gasket and Washers) 0 0 Latch Assy, Service Panel (Later Spec A) 0 0 Nut, Hex (M x.) * Parts Included in Enclosure Cover.

51 Blank Page

52 Generator Enclosure (KY Begin Spec B and KYD) ~ 0 0,, 0

53 Generator Enclosure (KY Begin Spec B and KYD) 0 0 Kit, Enclosure Cover Includes (KY Enclosure Cover Assy.) Cover Assy, Enclosure (Includes Parts Marked *) 0 0 KY 0 KYD *Grommet 0 0 KY Spec B E 0 KY Begin Spec F and KYD 0 0 *Rivet *Insulation, Cover 0 KY Begin Spec B 0 KYD 0 *Nut, Push On *Panel Assy, Service Onan (Includes Parts Marked +) 0 0 Onan Green 0 0 Onan Marine White 0 0 Onan Camp Power Grn 0 0 +Insulation, Door 0 +Washer, Flat (Special) 0 0 +Gasket, Service Panel (0mm) 0 0 +Nut, Hex (M x.) 0 0 +Latch Assy, Service Panel (Includes Pawl and Latch) 0 Label, Charger 0 0 Nut, Lock (M x.) (0Hz, 00V 0Hz) 000 Washer, EIT (#0) (0Hz, 00V 0Hz) Terminal, Spade (0Hz, 00V 0Hz 00 0 Screw, Hex Head Cap (M x. x 0mm) (0 Hz, 00V 0Hz) 000 Washer, Flat (M) (0 Hz, 00V 0Hz) 0 0 Bracket, Inlet Insulation (0 Hz) (Spec B H) 0 0 Charger, Battery (0 Hz, 00V 0Hz) 0 0 Insulation, Inlet (0 Hz) (Spec B H) 00 0 Screw, Torx Pan Head (M x x mm) (0 Hz) (Spec B H) Screw, Torx Shoulder (M) * Included in Enclosure Cover Assy. + Included in Service Panel Assy.

54 Underfloor Mounting Kit (KY Begin Spec B) 0 A00X Kit, Underfloor Mounting 0 Panel, Underfloor 00 Screw, Hex Head Lock Flange (/ x. ) 0 0 Panel, Back 0 0 Grommet, Remote Screw, Hex Head Cap (/ x. ) 0 Washer, Flat (/ Hardened) 0 0 Rail, Underfloor Screw, Hex Head Cap (/ x. ) 0 Washer, Flat (/ Hardened) Nut, Hex Flange Lock (/ )

55 Underfloor Mounting Kit (KYD) Kit, Mounting (Underfloor) 0 0 Rail, Mounting 0 Panel, Under Floor 0 Washer, Flat 0 0 Mount, Generator 0 Washer, Flat (/ ) Screw, Hex Head Cap (/ x. ) Screw, Hex Head Cap (/ x. ) 0 0 Grommet, Remote Nut, Hex Flanged (/ ) 0 00 Screw, Locking Head (/ x / )

56 Underfloor Mounting Kit (KY Spec A) A00X Kit, Underfloor Mounting (Replaced by 0 0) 0 0 Rail, Bottom (w/o Weldnuts) 0 Washer, Flat (/ ) Screw, Hex Head Cap (/ x / ) 0 Washer, Flat (/ ) Screw, Hex Head Cap (/ x. )

57 KY Underfloor Housing/Base Kit Kit, Housing (Includes Parts Marked +) 0 S0 +Panel, Housing (Rear) 0 S0 +Panel, Housing (LH) 0 0 +Cover, Panel Grommet, Rubber (. Id) Grommet, Rubber (.0 Id) 00 +Screw, RH (#0 X.) 000 +Washer, EIT Lk (/) Washer, Lock (#0) Screw, Hex Head Cap (/ X.) 0 +Washer, Flat (/ ) 0 0 Kit, Underfloor Base (Includes Parts Marked *) 0 0 *Base, Underfloor *Screw, Hex Head Cap (/ X.) 0 +Washer, Flat (/ ) * Parts Included in Base Kit. + Parts Included in Housing Kit.

58 Generator/Control (KY Spec A) 0 0 0,, 0

59 Generator/Control (KY Spec A) 0 0 Nut, Locking Flange (M x ) (LP) 0 Shield, Carburetor (Gasoline) Screw, Torx Pan Head (M x x mm) 0 0 Bezel Panel, Control 0 Hz 0 Plug, Hole (0 Hz) 0 00 Potentiometer Assy (R) (0 Hz) (Includes Lead, Bracket and Potentiometer) 0 0 Potentiometer (R)(0 Hz) Breaker, Circuit (CB) 0 0 Hz (0 Amp) Hz ( Amp) 0 0 S0 Coil Assy, Ignition (Includes Spark Plug Terminal and Boot) 0 Terminal, Spark Plug 0 Boot, Spark Plug Screw, Torx Pan Head (M x. x mm) Screw, Torx Pan Head (M x. x mm) 0 0 Housing, Stator Stator, Generator 0 S 0 Hz 0 S 0 Hz 0 S0 Rotor Assy (Includes Bearing and Collector Ring) 0 Key, Fan Hub 0 0 Ring, Collector 0 0 0, Rotor 0 0 O Ring 0 Screw, Torx Socket Head (M x x 0mm) Housing, Scroll 0 0 S0 Wheel Assy, Blower 0 Bolt, Rotor Thru (/ x. ) 0 Washer, Fan Hub Screw, Torx Pan Head (M x x 0mm) Endbell Assy (See Separate Page for Components) 0 00 Nut, Hex (M) Washer, Flat (M) Starter (B) (See Separate Page for Components) 0 0 Screw, Hex Head Cap (M x 0mm) Cable, Starter Washer, Lock Spring (/ ) 000 Nut, Hex (/ 0) 000 Screw, Pan Head Torx (M x. x 0mm) 0 0 Washer, Center (M) 0 0 Nut, Hex (#0 )

60 Generator (KY Begin Spec B and KYD) 0 0 0

61 Generator (KY Begin Spec B and KYD) Rotor Assy, (Includes Bearing) 0 Hz 0 S0 Spec B H 0 S Begin Spec J 0 Hz Gasoline 0 S0 Spec B D 0 S0 Begin Spec E LP 0 S0 Spec B C 0 S0 Begin Spec D 0 0 Bearing, Rotor 0 0 Ring, Collector 0 Key, Hub 0 0 O Ring 0 Washer, Fan Hub 0 Bolt, Rotor Thru (/ x / ) Wheel Assy, Blower (Includes Magnet) 0 0 S0 Spec B H 0 0 Begin Spec J Stator, Generator 0 Hz Spec B H 0 S 0V V Begin Spec J 0 S 0V V 0 Hz Gasoline 0 S Spec B D 0 0 S Spec E H 0 Begin Spec J LP 0 S Spec B C 0 0 S Spec D H 0 Begin Spec J 0 Clamp (0Hz) Spec B H (Angled) 00 Begin Spec J (Flat) 00 Washer, Flat (0Hz) (Begin Spec J) Screw, Torx Socket Head 0 0 Hz (M x x 0mm) 0 0 Hz (M x x 00mm) Begin Spec B Screw, Pan Head Torx Thread Forming (M x. x mm) Housing, Stator 0 Hz Begin Spec B 0 0 Gasoline Units 0 0 LP Units 0 Hz 0 0 Begin Spec B 0 0 Bracket, Transformer (0 Hz,00v 0Hz) (Spec B H) 0 Clip(0 Hz,00v 0Hz) (Spec B H) Screw, Torx Pan Head Thread Forming (0 Hz,00v 0Hz) (Spec B H) (M x x mm) 0 0 Screw, Thread Hex Flange Forming (M x. x mm) (Spec B H) (0 Hz, 00V 0Hz) 0 Transformer, Voltage (T) (Spec B H) (0 Hz, 00V 0Hz) Screw, Pan Head Torx Machine (M x x mm) (Spec B H) (0 Hz, 00V 0Hz) When a Rotor is ordered for KY Spec A or B prior to Serial #H then use a 0 S0 Rotor and one of the Following Stators unless it has already been replaced: 0Hz Spec A, Order 0 S 0Hz Spec B Order 0 S 0Hz Spec A or B Order 0 S

62 Control (KY Spec B H),, 0, 0 Breaker, Circuit (CB) 0 Hz 0 0A (0V Sets) A (00V Sets) 0 Hz A A A Potentiometer Assy (R) (0 Hz and 00V/0Hz) (Includes Lead, Bracket and Potentiometer) 0 0 Potentiometer (R) (0 Hz and 00V/0Hz) Panel, Control 0 0 Hz 0 0 Hz 0 Plug, Hole (0 Hz Only) 0 0 Switch, Start/Stop (S) Screw, Cross Pan Head Recessed w/et (# x / ) 0 Hz V 0 0 Hz 00 Washer, ET Lock (/ ) Screw, Torx Pan Head Thread Forming 0 Hz (M x x mm) Screw, Torx Pan Head (M x. x mm) 0 Coil Assy, Ignition (T Ign) (Includes Terminal and Boot) 0 Terminal, Spark Plug Boot, Spark Plug Screw, Torx Pan Head (M x x 0mm) 00 Washer, Flat (/ ) 0 Shield, Carburetor 00 0 Screw, Pan Head Torx (M x x 0mm) 00 Washer, Flat (/ ) Harness, AC Output 0 0 Hz 0 0 Hz 0

63 Control Panel (KY Begin Spec J and KYD) Washer, Flat (/ ) 0 Screw, Pan Head Torx (M x x mm) 0 Transformer, Voltage (T) (00V, 0V) 0 0 Nut, Lock Flange (00V, 0V) 0 0 Potentiometer Assy (R) (00V, 0V) (Includes Lead, Bracket and Potentiometer) 0 0 Potentiometer (R) (00V, 0V) Breaker, Circuit (CB) A (Spec, ) A (Spec,, ) 0 0A (Spec 0, 00, 0) 0 Shield, Carburetor 0 Screw, Torx Pan Head (M x x mm) 0 Washer, ET Lock (/ ) 00 (0V, 0Hz) 00 (00V, 0V) 0 0 Switch, Start/Stop (S) Screw, Cross Pan Head Recessed w/et (# x / ) 0 0V 0 00V, 0V 0 Panel, Control Harness, AC Output wire (Spec, 0, 00, 0) wire (Spec,,, )

64 Generator Harness (KY Spec A) 0 Harness, Generator 0 0 Hz 0 0Hz 0 0 Rectifier, Bridge (CR) 0 0 Resistor (R) 0 Tie, Cable 0 Terminal, Ground 0 S Fuse ( Ampere)(F) 0 0 Switch, Start/Stop (S) Connector, Plug ( Pin)(P) Connector, Plug ( Pin)(P) 00 Pin, Contact 0 0 Connector, Plug (P) 0 Connector, Plug (P)

65 Generator Harness (KY Spec B F), 0 Harness, Generator 0 Hz Gasoline Volt (Includes Parts Marked *) 00Volt 0 Isolated Neutral (Includes Parts Marked * and +) 0 Grounded Neutral (Includes Parts Marked * and ) 0 0 LP (Includes Parts Marked *) 0 Hz (Includes Parts Marked * and 0 0 Gasoline 0 0 LP 0 0 *Fuse Assy (F) (Includes A Fuse) 00 0 *Fuse, A (F) *Connector, Plug ( Pin)(P) *Pin,Contact *Cap, Circuit ( Pin)(J) *Socket, Contact 00 0V, 0V 00 00V 0 *Connector, Plug (P) 0 *Connector, Plug (P) 0 +Harness, Splitter (Includes Boot) 0 Boot, Insulating * Parts Included with all Harnesses + Parts Included in 00V, Isolated Neutral Harness Part Included in 00V, Grounded Neutral Harness Part Included in 0Hz Harnesses.

66 Generator Harness (KY Spec G H), 0 Harness, Generator 0 Hz Gasoline 0 0 Volt (Includes Parts Marked *) 00 Volt 0 Isolated Neutral (Includes Parts Marked * and +) 0 Grounded Neutral (Includes Parts Marked * and ) 0 LP (Includes Parts Marked *) 0 Hz Gasoline Volt (Includes Parts Marked * and ) 0 00 Volt (Includes Parts Marked * and +) LP 0 0 0V (Includes Parts Marked * and ) 0 00 Volt (Includes Parts Marked * and +) 0 0 *Fuse Assy (F) (Includes Amp Fuse) 00 0 *Fuse, Amp (F) Connector, Plug ( Pin)(P) *Pin,Contact *Cap, Circuit ( Pin)(J) *Socket, Contact 00 0V, 0V 00 00V 0 *Connector, Plug (P) 0 *Connector, Plug (P) 0 +Harness Assy, Splitter (Isolated Neutral Harnesses only. Includes Boot) 0 Boot, Insulating * Parts Included with all Harnesses + Parts Included with 00V, Isolated Neutral Harness. Part Included in 00V, Grounded Neutral Harness Part Included in 0Hz Harness.

67 Engine Harness (KY Begin Spec J and KYD), P, P P P 0 J Harness, Engine 0 Hz Gasoline 00 Volt 0 Volt LP 0 Hz 0 Connector, Plug (P) 0 Connector, Plug (P) 0 0 Connector, Plug (P) ( Pin) 0 AR Socket, Terminal (P) Boot, Insulating (Not Used on ) Connector, Plug (J)( Pin) 0 Terminal, Socket (J) Plug, Cavity (J) 0 Seal, Cable (J) 0 Housing, Lock (J) 0 0 Connector, Switch (P)

68 Extension/Pigtail Harness (KY Spec B E) Harness, Extension (Reaches from Genset to Remote Panel) (Includes Housing and Pins) 0 0 Ten Feet Long 0 0 Thirty Feet Long 0 Harness, Pigtail ( ) (Reaches from Genset Harness to Customer Hookup) (Includes Connector Housing) 0 Housing, Connector Pin, Contact

69 Extension/Pigtail/Adapter Harness (KY Spec F H and KYD) 0 Harness, Extension (Reaches from Genset Harness to Remote Panel) (Includes Parts Marked +) Harness, Customer Interface Pigtail (Reaches from Genset Harness to Customer Hookup or Remote Panel [with use of Following Adapter Harness]) (Includes Parts Marked *) Harness, Adapter (Reaches from Remote Panel to Pigtail Harness) (Includes Parts Marked #) +*Connector, Receptacle ( Pin) +*Plug, Cavity 0 +*Seal, Cable 0 *Pin, Contact +*Housing, Lock 00 +#Socket, Contact 0 +#Cap, Connector + Parts Included in Extension Harness. * Parts Included in Customer Interface Pigtail Harness. # Parts Included in Adapter Harness.