Models GGHG (SPEC A) GGHH (SPEC A) Printed in U.S.A.

Transcription

1 Models GGHG (SPEC A) GGHH (SPEC A) Printed in U.S.A

2 This catalog covers models produced under the Cummins /Onan and Cummins Power Generation brand names. To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Cummins Power Generation nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Cummins Power Generation manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Cummins Power Generation equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-

3 Introduction This catalog applies to Cummins Power Generation Generator Models DFEG, DFEH, DFEJ and DFEK as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned in the description or page heading, parts are interchangeable between models. Throughout this catalog left and right sides are determined by facing the engine end (front) of the set unless noted in the description column. Engine parts that have been modified or added by Cummins Power Generation are identified in this catalog. All other engine replacement parts must be ordered from the engine manufacturer by referring to the engine manufacturer s nameplate and supplying all available information. Contact your nearest engine parts distributor for assistance in ordering replacement parts. Replacement Engine Cummins Power Generation Generator Model DFEG, DFEH, DFEJ, DFEK (0 Hertz) DFEG, DFEH, DFEJ, DFEK (0 Hertz) Cummins Engine Model QSX G8 QSX G9 Generator Set Data Table Model and Electrical Data Battery Specification Watts Volts Hertz Wire Phase Voltage 0DFEG/* 0,000 # 0 VDC 0DFEG/* 0,000 # 0 VDC DFEH/*,000 # 0 VDC 00DFEH/* 00,000 # 0 VDC 00DFEJ/* 00,000 # 0 VDC 0DFEJ/* 0,000 # 0 VDC 0DFEK/* 0,000 # 0 VDC 00DFEK/* 00,000 # 0 VDC * The diagonal line (/) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from the standard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes. # Broad range reconnectible Copyright 00 Cummins Power Generation. All rights reserved.

4 Index Adapter, Duct, Adapter, Generator, 7, Adapter, Generator Stator, Adapter, Oil Drain, Adapter, Oil Filter, Alarm, Common, 0 Alarm, Fuel, Alternator, Ammeter, AC Detector Control, Armature, Starter, Bearing, Ball Generator, Bearing, Starter (Commutator End), Bearing, Starter (Pinion End), Bell, End, Belt, Serpentine, 7 Block, Terminal Detector Control, Block, Terminal Generator Heater, 9 Board, Printed Circuit Alarm Relay, 9 Board, Printed Circuit Common Alarm, 0 Board, Printed Circuit Engine Monitor Detector Control, Board, Printed Circuit Isolation Transformer, 8 Board, Printed Circuit Sensor Board Detector Control, Board, Printed Circuit Time Delay Start/Stop, Board, Printed Circuit Voltage Regulator, 8 Box, Control, Box, Entrance, Box, Terminal Generator Heater, 9 Bracket, Alternator, 7 Bracket, Ignition Module, Bracket, Mounting Generator Foot, Bracket, Mounting Main Circuit Breaker, 9 Bracket, Transformer, Breaker, Circuit Main, 7 Bulb, Replacement Emergency Stop Switch, Cable, Battery, 7 Cable, Heater Control, Cap, Radiator, 9 Cartridge, Generator Heater, 9 Clutch, Starter, Control, Detector, Cooler, Oil Remote Radiator, 7 Cover Main Circuit Breaker, 9 Cover, End Bell PMG, Cover, Housing Control, 7 Cover, Rocker, 7 Cover, Shroud Radiator, 9 Cover, Stator Generator, Cover, Terminal Box Generator Heater, 9 Cushion, Vibration Skid, Disc, Drive Generator, Door, Control Detector Control, Drain, Oil, Enclosure, Generator Set F7, Enclosure, Generator Set F7, Enclosure, Generator Set F8, 7 Exhaust System Industrial, 9 Exhaust System Residential, 7 Exhaust System With Threaded Exhaust Pipe, Extension, Radiator Drain, 0 External Engine Parts, 7 Fan, Alternator, Fan, Radiator, 9 Filter, Oil, Frame, Starter (Commutator End), Fuel System Natural Gas, 8 Fuel System Natural Gas / Propane Liquid Withdrawl With Automatic Changeover, Fuel System Natural Gas / Propane Vapor Withdrawl With Automatic Changeover, Fuel System Propane Liquid Withdrawl, Fuel System Propane Vapor Withdrawl, 9 Fuse Engine Monitor Board Detector Control, Gasket, Oil Drain, Gasket, Oil Filter Adapter, Gauge, Oil Pressure Control Mounted Detector Control, Gauge, Water Temperature Control Mounted Detector Control, Generator, Generator, Permanent Magnet, Governor, Grille, Guard, Fan Generator, Guard, Fan Radiator, 9 Guard, Fan Remote Radiator, 7 Harness, Wiring AC Auxiliary, 7 Harness, Wiring AC Control Door Detector Control, Harness, Wiring Alarm Relay Board, 9 Harness, Wiring Common Alarm, 0 Harness, Wiring DC Control Door Detector Control, Harness, Wiring Engine to Control, 7 Harness, Wiring Fuel Alarm, Harness, Wiring Low Battery Voltage, Harness, Wiring Low Coolant Level Sender With Continuously Monitored Low Coolant Level, Harness, Wiring Low Coolant Level Sender Without Continuously Monitored Low Coolant Level, Harness, Wiring PMG, Harness, Wiring Terminal Block Detector Control, Harness, Wiring Time Delay Start/Stop, Harness, Wiring Transformer,

5 Index Heater, Control, Heater, Coolant, Heater, Generator, 9 Hose, Breather, 7 Hose, Drain Radiator Drain Extension, 0 Hose, Inlet Remote Radiator, 7 Hose, Oil Drain, Hose, Radiator, 9 Hose, Vacuum, Housing, Control,, 7 Housing, Starter, Hub, Drive Generator, Isolator, Vibration Detector Control, Kit, Starter Brush, Lead Main Circuit Breaker, 7 Lens, Indicator Low Battery Voltage, Lens, Replacement Low Coolant Level With Continuously Monitored Low Coolant Level, Light Assembly, Indicator Detector Control, Light, Indicator Upper and Lower Scale Detector Control, Light, Panel Detector Control, Lug, Solderless Entrance Box, Lug, Solderless Main Circuit Breaker, 9 Meter, Frequency Detector Control, Meter, Hour Detector Control, Module, Ignition, 7 Package, Mounting Hardware Main Circuit Breaker, 7 Paint, Pan, Skid, 9 Panel, Radiator Housing Remote Radiator, 7 Pick Up, Magnetic, Pin, Parallel PMG, Plate, Audible Signal, Plug, Spark, 7 Potentiometer Voltage Regulator, 8 Pulley, Alternator, Radiator, 9 Radiator, Remote, 7 Rectifier, Power Control Heater, Rectifier, Silicon Low Coolant Level With Continuously Monitored Low Coolant Level, Regulator, Voltage, 8 Resistor Voltage Regulator, 8 Rotor, Exciter, Rotor, Generator, Rotor, PMG, Sealant, Thread, Sender, Low Coolant Level With Continuously Monitored Low Coolant Level, Sender, Low Coolant Level Without Continuously Monitored Low Coolant Level, Sender, Oil Pressure, Sensor, Low Battery Voltage, Separater, Oil, 7 Signal, Audible, Skid, Standoff, Insulator Main Circuit Breaker, 9 Starter Components, Stator, Exciter Generator, Stator, Generator, Stator, PMG, Strap, Ground Detector Control, Switch, Emergency Stop, Switch, Rocker Lamp Test/Reset Panel Lamp Detector Control, Switch, Rocker Run/Stop/Remote Detector Control, Switch, Rotary Voltmeter/Ammeter Detector Control, Switch, Starter, Switch, Trip Alarm Main Circuit Breaker, 7 Thermostat, 7 Transformer, Current, Transformer, Meter, Tray, Battery, 8 Trip, Shunt Main Circuit Breaker, 7 Valve, Shutoff Oil Drain, Valve, Shutoff Radiator Drain Extension, 0 Voltmeter, AC Detector Control, Voltmeter, DC Detector Control,

6 Abbreviations Some of the following abbreviations may be used throughout this Parts Catalog: AC Amp A/R AVR AWG Deg DC EFC ET EIT GFI ID IT IEC kw LPG LT M(meter Number) Alternating Current Ampere As Required Automatic Voltage Regulator American Wire Gauge Degree Direct Current Electronic Fuel Control External Tooth External/Internal Tooth Ground Fault Interrupter Inside Diameter Internal Tooth International Electrotechnical Commission Kilowatt Liquid Petroleum Gas Left Meter mm MOH NFS NPT OD oz. PMG Ph PC RFI RT Spec Thk UL UNC UNF VAC VDC W/(ET, IT, EIT) Millimeter Mobile Off Highway Not For Sale National Pipe Thread Outside Diameter Ounce Permanent Magnet Generator Phase Printed Circuit Radio Frequency Interference Right Specification Thick Underwriters Laboratories Inc. Union National Coarse Union National Fine Volts Alternating Current Volts Direct Current With Paint and Thread Sealant Onan Green Enamel (Non-Metallic) 00 oz. Pressurized Spray Can 00 Quart Can 00 Gallon Can 8 00 Sealant, Thread ( ml Tube)

7 Fuel Alarm Harness, Fuel Alarm Single Fuel 8 07 Dual Fuel

8 External Engine Parts

9 External Engine Parts 09 0 Adapter, Generator 0 97 Flywheel (Includes Ring Gear) 0 99 Gear, Ring 9 0 Bracket, Alternator Rear Bracket, Alternator Front 0 8 Belt, Serpentine 8 Groove Bracket, Alternator Fan, Alternator 9 00 Washer, Flat (M8) 0 0 Washer, Flat (M0) Screw, Cap Hex Head (M8 x. x ) Screw, Cap Hex Head (M0 x. x 80) Screw, Cap Hex Head (M0 x. x ) Nut, Hex (M8 x.) 07 0 Strap, Guard Manifold 00 0 Guard, Manifold Screw, Hex Head (M x.0 x ) Washer, Lock Split (M8) Sender, Water Temperature Washer, Lock Split (M0) Screw, Cap Hex Head (M0 x. x ) 09 Cable, Battery 09 Boot, Battery Red 0 Hose, Breather 0 Hose, Crank Case Vent Clamp, J Clamp, Hose Washer (M) Nut (M) 0 08 Grommet 0 Insulation, Hose Module, Ignition 0 98 Cover, Rocker 0 Cap, Heater Tube (/ ) 0 Cap, Heater Tube (/8 ) 77 0 Separater, Oil 7 08 Grommet Fitting, Hose 9 09 Tie, Cable Adapter, Hose 0 8 Thermostat 8 F (Ford Part Number YC 87 BA) (Not Illustrated) Thermostat 9 F (Ford Part Number YC 87 AA) (Optional) (Not Illustrated) 7 9 A/R Plug, Spark (Ford Part Number AGSF FM) (.0 Gap) (Not Illustrated) 7

10 Fuel System Natural Gas Bracket, Fuel System Mounting Screw, Cap Hex Head (M0 x. x ) 00 Washer, Flat (M8) Screw, Cap Hex Head (M8 x. x ) 8 0 Regulator, Natural Gas Nipple, Pipe (-/ x.) Fuel Systems Without Pressure Switch Fuel Systems With Pressure Switch Elbow, Pipe Nipple, Pipe (-/ x.00) Valve, Solenoid Bushing, Reducer (. x.7) 0 08 Nipple, Pipe (/ x 9.00) 8 7 Mixer (Includes Parts Marked *) * Adapter, Hose 0 * G 7 Gasket 00 * G Gasket 0 09 # Tee, Pipe # Bushing, Reducer (-/ x.00) # Bushing, Reducer (.00 x /) # Harness, Fuel Alarm # Bushing, Reducer (/ x /8) # Switch, Low Pressure 0 8 Connector, Hose Clamp, Fuel System (.) Screw, Hex Head (M8 x. x 0) 0 Cleaner, Air (Includes Stud and Wing Nut) 0 Element, Replacement Air Cleaner Hose, Mixer Adapter Clamp, Hose 9 Clamp, Muffler (.0 ) Bracket, Fuel System Support 07 Washer, Flat Screw, Cap Hex Head (M0 x. x 0) 0 00 Stud Air Cleaner * Parts Included with 8 7 Mixer # Parts Included with Fuel Systems With Pressure Switch 8

11 Fuel System Propane Vapor Withdrawl Bracket, Fuel System Mounting Screw, Cap Hex Head (M0 x. x ) 00 Washer, Flat (M8) Screw, Cap Hex Head (M8 x. x ) 8 0 Regulator, Propane Vapor Nipple, Pipe (.00 x.00) Fuel Systems Without Pressure Switch Fuel Systems With Pressure Switch Elbow, Pipe Bushing, Reducer (.00 x.7) Nipple, Pipe (.00 x.00) Valve, Solenoid 0 08 Nipple, Pipe (/ x 9.00) 8 7 Mixer (Includes Parts Marked *) * Adapter, Hose 0 * G 7 Gasket 00 * G Gasket 0 00 # Tee, Pipe # Bushing, Reducer (.00 x /) # Harness, Fuel Alarm # Bushing, Reducer (/ x /8) # Switch, Low Pressure 0 8 Connector, Hose Clamp, Fuel System (.) Screw, Hex Head (M8 x. x 0) 0 Cleaner, Air (Includes Stud and Wing Nut) 0 Element, Replacement Air Cleaner 8 8 Hose, Mixer Adapter Clamp, Hose 8 Clamp, Muffler (.0 ) Bracket, Fuel System Support 0 07 Washer, Flat Screw, Cap Hex Head (M0 x. x 0) 0 00 Stud Air Cleaner * Parts Included with 8 7 Mixer # Parts Included with Fuel Systems With Pressure Switch 9

12 0 Fuel System Propane Liquid Withdrawl

13 Fuel System Propane Liquid Withdrawl 8 0 Bracket, Fuel System Mounting Reducer, Bushing Pipe (. x.7) Cap, Pipe (.00) Harness, Wiring Dual Fuel (Includes Relay) Relay ( Volt) 0 08 Nipple, Pipe (/ x 9.00) Mixer (Includes Parts Marked *) * Adapter, Hose 9 0 * G 7 Gasket 0 00 * G Gasket 0 8 Connector, Hose 0 09 Tee, Pipe 0 08 Nipple, Pipe (-/ x.00) 0 07 Elbow, Reducer 90 ( x.) Nipple, Pipe ( x.0) 8 0 Valve, Load Adjusting Nipple, Pipe ( x 0.00) Screw, Hex Head (M x x ) Bracket, Fuel System Support 0 0 Cleaner, Air (Includes Stud and Wing Nut) 0 Element, Replacement Air Cleaner 8 8 Hose, Mixer Adapter Clamp, Hose 00 Washer, Flat (M8) Screw, Cap Hex Head (M8 x. x ) Clamp, Muffler (.0 ) 7 07 Washer, Flat Screw, Cap Hex Head (M0 x. x 0) Screw, Cap Hex Head (M0 x. x ) Clamp, Fuel System (.00) Screw, Hex Head (M8 x. x 0) Bracket, Converter 800 Screw, Cap Hex Head (M x.7 x ) (Genset Mounted Converter Only) 8 0 Converter, Gas 8 Solenoid, Primer Nipple, Pipe ( x.0) Tee, Pipe Nipple, Pipe ( x.0) Elbow, Pipe Hose 0 00 Elbow, Pipe Street Nipple, Pipe (/ x.88) Valve, Solenoid 0 09 Elbow, Hose Hose Bulk (Order by the Foot 8 Feet Required) 0 00 Connector, Hose (/ x /8) Elbow, Pipe Hose, Barb Hose Bulk (Order by the Foot Foot Required) Screw, Hex Washer Head (M x x 0) Clamp, J 0 08 Clamp, Hose Clamp, Hose 8 0 Harness, LPG 0 00 Stud Air Cleaner * Parts Included with 8 7 Mixer

14 Fuel System Natural Gas / Propane Vapor Withdrawl With Automatic Changeover

15 Fuel System Natural Gas / Propane Vapor Withdrawl With Automatic Changeover 8 0 Bracket, Fuel System Mounting Screw, Cap Hex Head (M0 x. x ) 00 Washer, Flat (M8) Screw, Cap Hex Head (M8 x. x ) 8 0 Regulator, Natural Gas Nipple, Pipe (-/ x.) Tee, Pipe Bushing, Reducer (. x.7) Nipple, Pipe (/ x 9.00) Mixer (Includes Parts Marked *) * Adapter, Hose 0 * G 7 Gasket 00 * G Gasket 0 07 Nipple, Pipe (-/ x.00) Valve, Solenoid 0 08 Nipple, Pipe (-/ x.00) Elbow, Reducer 90 ( x.) Nipple, Pipe ( x.0) Valve, Load Adjusting Nipple, Pipe ( x.00) 8 0 Regulator, Propane Vapor Valve, Solenoid 0 00 Bushing, Reducer (-/ x.00) Bushing, Reducer (.00 x /) Harness, Dual Fuel Bushing, Reducer (/ x /8) Switch, Low Pressure Connector, Hose Harness, Fuel Alarm Clamp, Fuel System (.00) Clamp, Fuel System (.) Screw, Hex Head (M8 x. x 0) 0 Cleaner, Air (Includes Stud and Wing Nut) 0 Element, Replacement Air Cleaner 8 8 Hose, Mixer Adapter Clamp, Hose 7 Clamp, Muffler (.0 ) Bracket, Fuel System Support 9 07 Washer, Flat Screw, Cap Hex Head (M0 x. x 0) 0 00 Stud Air Cleaner * Parts Included with 8 7 Mixer

16 Fuel System Natural Gas / Propane Liquid Withdrawl With Automatic Changeover

17 Fuel System Natural Gas / Propane Liquid Withdrawl With Automatic Changeover 8 0 Bracket, Fuel System Mounting Reducer, Bushing Pipe (. x.7) Cap, Pipe (.00) Harness, Wiring Dual Fuel (Includes Relay) Relay ( Volt) 0 08 Nipple, Pipe (/ x 9.00) Mixer (Includes Parts Marked *) * Adapter, Hose 9 0 * G 7 Gasket 0 00 * G Gasket 0 8 Connector, Hose 0 09 Tee, Pipe 0 08 Nipple, Pipe (-/ x.00) 0 07 Elbow, Reducer 90 ( x.) Nipple, Pipe ( x.0) 8 0 Valve, Load Adjusting Nipple, Pipe (-/ x.00) Harness, Fuel Alarm Screw, Hex Head (M x x ) Bracket, Fuel System Support 0 Cleaner, Air (Includes Stud and Wing Nut) 0 Element, Replacement Air Cleaner 8 8 Hose, Mixer Adapter Clamp, Hose 00 Washer, Flat (M8) Screw, Cap Hex Head (M8 x. x ) 7 Clamp, Muffler (.0 ) 8 07 Washer, Flat Screw, Cap Hex Head (M0 x. x 0) Screw, Cap Hex Head (M0 x. x ) Clamp, Fuel System (.) Screw, Hex Head (M8 x. x 0) Bracket, Converter 800 Screw, Cap Hex Head (M x.7 x ) (Genset Mounted Converter Only) 8 0 Converter, Gas 8 Solenoid, Primer Nipple, Pipe ( x.0) Tee, Pipe Nipple, Pipe ( x.0) Elbow, Pipe 0 00 Hose 0 00 Elbow, Pipe Street Nipple, Pipe (/ x.88) Valve, Solenoid 0 09 Elbow, Hose Hose Bulk (Order by the Foot 8 Feet Required) Connector, Hose (/ x /8) Elbow, Pipe Hose, Barb Hose Bulk (Order by the Foot Foot Required) 8 09 Screw, Hex Washer Head (M x x 0) Clamp, J 0 08 Clamp, Hose Clamp, Hose 8 0 Harness, LPG 0 00 Stud Air Cleaner Regulator, Natural Gas Valve, Solenoid Nipple, Pipe (-/ x.00) Bushing, Reducer (-/ x.00) Bushing, Reducer ( x /) Nipple, Pipe (-/ x.) Bushing, Reducer (/ x /8) Switch, Low Pressure * Parts Included with 8 7 Mixer

18 Exhaust System Residential

19 Exhaust System Residential 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust 9 Tube, Exhaust Clamp, V-Band Silencer Critical 8 9 Gasket, Muffler 9 80 Shield, Rain 0 0 Clamp, Muffler ( ) 0 Cap, Rain Screw, Hex Head (M8 x. x 0) 0 7 Elbow, Hose Barb 0 Hose, Turbo Drain 7 0 Gasket, Oil Drain Tube, Oil Drain Washer, Lock Split (M8) Screw, Cap Hex Head (M8 x. x 0) Clamp, Hose 0 0 Washer, Flat (M) 800 Screw, Cap Hex Head (M x.7 x ) 0 07 Stud (M0 x. x 0) 0 Gasket, Exhaust Manifold 0 Gasket, Exhaust Manifold 0 Washer, Flat (M0) Nut, Hex (M0 x.) Seal, O-Ring (/) Connector, Restricted Adapter, Pipe Tube, Turbo Feed Clamp, J Screw, Cap Hex Head (M0 x. x 0) 0 Clamp 7

20 Exhaust System Industrial

21 Exhaust System Industrial 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust Clamp, V-Band 9 Silencer Shield, Rain Cap, Rain Elbow, Hose Barb 0 0 Hose, Turbo Drain 7 0 Gasket, Oil Drain Tube, Oil Drain Washer, Lock Split (M8) Screw, Cap Hex Head (M8 x. x 0) 0 08 Clamp, Hose 0 Washer, Flat (M) Screw, Cap Hex Head (M x.7 x ) Stud (M0 x. x 0) 9 0 Gasket, Exhaust Manifold 0 0 Gasket, Exhaust Manifold 0 Washer, Flat (M0) Nut, Hex (M0 x.) Seal, O-Ring (/) 0 8 Connector, Restricted 0 0 Adapter, Pipe 7 0 Tube, Turbo Feed 7 Clamp, J Screw, Cap Hex Head (M0 x. x 0) 9 08 Washer, Flat (M) Screw, Cap Hex Head (M x x ) 0 Clamp 9

22 Exhaust System With Threaded Exhaust Pipe

23 Exhaust System With Threaded Exhaust Pipe 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust Clamp, V-Band 0 7 Elbow, Hose Barb 7 0 Hose, Turbo Drain Gasket, Oil Drain Tube, Oil Drain Washer, Lock Split (M8) Screw, Cap Hex Head (M8 x. x 0) 0 08 Clamp, Hose 0 Washer, Flat (M) 800 Screw, Cap Hex Head (M x.7 x ) 0 07 Stud (M0 x. x 0) 0 Gasket, Exhaust Manifold 7 0 Gasket, Exhaust Manifold 8 0 Washer, Flat (M0) Nut, Hex (M0 x.) Seal, O-Ring (/) 0 8 Connector, Restricted 0 0 Adapter, Pipe 7 0 Tube, Turbo Feed Clamp, J Screw, Cap Hex Head (M0 x. x 0) Adapter, Exhaust 7 0 Clamp

24 Low Coolant Level Sender Without Continuously Monitored Low Coolant Level 8 7 Harness, Low Coolant Level (Includes Parts Marked *) 9 08 Sender, Low Coolant Level 7 *Housing, Connector ( Pin) 709 *Socket, Contact (Used in S7) 708 *Seal, Cable 7 *Plug, Cavity * Parts Included in 8 7 Wiring Harness

25 Low Coolant Level Sender With Continuously Monitored Low Coolant Level Light Indicator Controls 7 8 H Lens, Replacement Harness, Low Coolant Level 9 08 Sender, Low Coolant Level Rectifier, Silicon 8 9 Harness, Pigtail (Includes Parts Marked *) 7 *Housing, Connector ( Pin) *Socket, Contact (Used in S) *Seal, Cable * Parts Included in 8 9 Pigtail Harness

26 Coolant Heater 0 Bracket, Mounting Heater, Coolant Volt Volt 0 09 Connector, Hose 0 08 Hose, Heater Bulk (Order by the Foot Feet Required) 0 08 Clamp, Hose Screw, Hex Head Stainless Steel (M x x )

27 Oil Drain H8 0 0 Adapter, Oil Drain 0 00 Valve, Shutoff Barb, Hose (/ x /) Hose, Oil Drain Bulk (Order by the Foot Feet Required) Clip, Hose 0 0 Gasket, Oil Drain

28 Oil Filter 087 Adapter, Oil Filter 08 Gasket, Oil Filter Adapter Stud, Oil Filter 08 Filter, Oil 9 08 Sender, Oil Pressure Screw, Hex Flange Head (M8 x. x 0)

29 Remote Radiator Panel, Radiator Housing Front Panel, Radiator Housing Side Cover, Shroud Bottom Guard, Fan Left Side 0 0 Guard, Fan Right Side Guard, Alternator Guard, Fan Lower Guard, Fan Support, Tube Edging Bulk (Order by the Foot Foot Required) 0 0 Tube, Inlet 0 0 Hose, Inlet Bracket, Oil Cooler 0 8 Cooler, Oil Bushing, Reducer (/ x /8) 0 07 Elbow 90 (.0 x /8 8) Hose, Hydraulic Bulk (Order by the Foot Feet Required) Connector, Hose (/8 x /) 9 0 Hose, Radiator Flexible Clamp, Hose 0 0 Clamp, Hose Screw, Hex Head (M8 x. x 0) Screw, Hex Head (M x x ) 7

30 Radiator

31 Radiator Radiator (Includes Over Flow Hose) Row Row 0 07 Hose, Over Flow Bulk (Order by the Foot Feet Required) 0 9 Side, Housing 0 0 Cover, Shroud Panel, Shroud Side Cover, Shroud Latch Shroud Fan Spacer, Fan Fan, Radiator Guard, Fan Right Hand 0 0 Guard, Fan Left Hand Guard, Alternator Guard, Fan Lower Guard, Fan 0 Hose, Radiator 0 0 Tube, Outlet 7 0 Hose, Outlet 8 0 Hose, Inlet Tube, Inlet Hose, Inlet Cap, Radiator ( PSI) Cock, Drain Clamp, Hose 0 Washer, Flat (M8) Screw, Cap Hex Head (M8 x. x 0) Screw, Hex Head (Stainless Steel) (M8 x. x 0) Screw, Hex Head (M8 x. x 0) Rivet, Pop Hanger, Hose (Lower) Support, Tube Edging Bulk (Order by the Foot Foot Required) 9

32 Radiator Drain Extension E Nipple, Pipe Brass (/8 ) 0 07 Bushing, Flush (/8 X / ) 0 00 Valve, Shutoff (/ ) Barb, Hose (/ x /) 0 9 Hose, Drain ( ) Clamp, Hose 0

33 Duct Adapter 0 Adapter, Duct 0 7 Adapter, Duct Side Rivet, Pop 0 7 Grille

34 F7 Enclosure

35 F7 Enclosure Panel, Side Radiator Housing 0 9 Extension, Side Left Hand 0 9 Post, Corner 0 7 Post, Housing Center Support, Muffler 0 9 Box, Muffler Panel, End Roof Panel, End Roof Extension, Side Right Hand Retainer, Insulation 0 9 Support, Center 0 97 Angle 0 9 Baffle, Air 0 98 Retainer, Insulation 0 9 Retainer, Insulation 0 0 Retainer, Insulation Roof Tube, Fill Radiator Box, Radiator Fill Panel, Front Radiator Housing 0 97 Panel, End Roof 0 09 Fiberglass 0 08 Hinge, Housing Door, Housing Without Window 0 90 With Window 0 90 Door, Housing With Window 8 Cover, Exhaust Insulation, Exhaust Bulk (Order by the Foot 0 Feet Required) 8 0 Washer, Flat Stainless Steel Latch, Door Key, Replacement Fits Latch Label, Prototype Label, Warning Label, Coolant Fill Screw, Hex Head Stainless Steel (M8 x. x 0) 0 99 Baffle, Recirculation Rivet, Pop (/ ) Rivet, Pop (/8 ) Weatherstrip Bulk (Order by the foot Feet Required) Units With Window 9 9 Window, Control Label, Model 7 0 Plug, Hole Seal, Weather Seal, Weather Seal, Weather Label, Caution 0 8 Fiberglass Retainer, Insulation Retainer, Insulation Plug, Hole (.7 ) Plug, Hole (.7 ) 0 00 Air Dam Nut, Captive Floating (M x.0) Screw, Hex Head Stainless Steel (M x x ) 0 98 Cover, Exhaust Inlet 00 Washer, Flat 0 9 Baffle, Air Discharge Insulation, Foam Fiberglass Insulation, Door Fiberglass Fiberglass Fiberglass Fiberglass Fiberglass

36 F7 Enclosure

37 F7 Enclosure Panel, Side Radiator Housing 0 9 Extension, Side Left Hand 0 9 Post, Corner 0 7 Post, Housing Center Support, Muffler 0 9 Box, Muffler Panel, End Roof Panel, End Roof Extension, Side Right Hand Retainer, Insulation 0 9 Support, Center 0 97 Angle 0 9 Baffle, Air 0 98 Retainer, Insulation 0 9 Retainer, Insulation 0 0 Retainer, Insulation Roof Tube, Fill Radiator Box, Radiator Fill Panel, Front Radiator Housing 0 97 Panel, End Roof 0 09 Fiberglass 0 08 Hinge, Housing Door, Housing Without Window 0 90 With Window 0 90 Door, Housing With Window 8 Cover, Exhaust Insulation, Exhaust Bulk (Order by the Foot 0 Feet Required) 8 0 Washer, Flat Stainless Steel Latch, Door Key, Replacement Fits Latch Label, Prototype Label, Warning Label, Coolant Fill Screw, Hex Head Stainless Steel (M8 x. x 0) 0 99 Baffle, Recirculation Rivet, Pop (/ ) Rivet, Pop (/8 ) Weatherstrip Bulk (Order by the foot Feet Required) Units With Window 9 9 Window, Control Label, Model 7 0 Plug, Hole Seal, Weather Seal, Weather Seal, Weather Label, Caution 0 8 Fiberglass Retainer, Insulation Retainer, Insulation Plug, Hole (.7 ) Plug, Hole (.7 ) 0 00 Air Dam Nut, Captive Floating (M x.0) Screw, Hex Head Stainless Steel (M x x ) 0 98 Cover, Exhaust Inlet 00 Washer, Flat 0 9 Baffle, Air Discharge Insulation, Foam Fiberglass Insulation, Door Fiberglass Fiberglass Fiberglass Fiberglass Fiberglass Panel, Side Discharge (Right Hand) Panel, Bottom Panel, Side Discharge (Left Hand) Panel, Center Cover, Duct Retainer, Insulation Retainer, Insulation Cover, Air Discharge Box (Top) Retainer, Insulation Fiberglass 7 0 Retainer, Insulation Fiberglass Cover, Air Discharge Box (Top) Cover, Air Discharge Retainer, Insulation Fiberglass

38 F8 Enclosure

39 F8 Enclosure Panel, Side Radiator Housing Panel, Front Radiator Housing 0 9 Roof 0 7 Post, Housing Center 0 9 Angle, Roof 0 9 Post, Corner Housing Insulation, Foam Bulk (Order by the Foot 0 Feet Required) Hinge, Door 9 8 Cover, Exhaust Label, Warning Label, Coolant Fill Label, Prototype Tested Rivet, Pop (/) Screw, Hex Head (M8 x. x 0) 0 8 Door, Housing Latch, Door Key, Replacement (fits Latch 0 098) 7 Door, Housing 0 90 Sets With Control Window 0 90 Sets W/O Control Window Weatherstrip Window Bulk (Order By The Foot Feet Required) 9 9 Window, Control (If Equipped) Bumper, Door 0 97 Panel, End Roof Rivet, Pop (/8) Insulation, Foam Nut, Captive Floating (M x.0) Screw, Hex Head (M x.0 x ) Insulation, Foam Bulk (Order by the Foot Feet Required) 7

40 Battery Tray F0 0 7 Tray, Battery Screw, Hex Head (M8 x. x 0) 0 Hold Down, Battery Rod, Hold Down Battery Nut, Wing (M) 8

41 Skid Pan 0 87 Pan, Skid 0 0 Clamp Screw, Self Locking Hex Washer Head (M x mm) 0 Cover, Stub Up End (7 / x 8 ) 0 Cover, Stub Up Side (7 / x /8 ) 9

42 Skid

43 Skid Skid 0 0 Cushion, Vibration Washer, Flat (/) 0 0 Bracket, Mounting Engine Plug, Hole Screw, Cap Hex Head (/ 0 x ) Washer, Hardened Screw, Cap Hex Head (M x ) Washer, Flat Screw, Cap Hex Head (M0 x. x ) 8 00 Washer, Lock W/EIT (/) Strap, Electrical Bracket, Ignition Module Screw, Hex Head (M x.0 x ) Screw, Hex Flange Head Thread Forming (M x 0.8 x ) 8 00 Nut, Hex (/ 0) Hose, Vacuum Washer, Lock W/EIT (/8)

44 Starter Components CP0 9 Starter (.kw) 9 Kit, Starter Brush 9 Switch 9 7 Clutch 9 8 Armature 9 9 Frame, Commutator End 9 0 Housing 7 9 Bearing, Commutator End 8 9 Bearing, Pinion End Screw, Cap Socket Head (M0 x. x mm) Washer, Lock (M0)

45 Alternator 7 CP Alternator 9 98 Fan, Alternator Washer, Lock (M8) Nut, Hex (M8 x.) Washer, Lock (M) Nut, Hex (M x 0.8) Pulley, Alternator

46 Governor Plate, Throttle Body Governor Hz GGHG, GGHH Hz GGHH 08 Gasket, Throttle Body 08 Adapter, Throttle Body 0 0 Stud (M) Washer, Flat (M) Nut, Hex (M) Connector, Hose (/8 x /) Plug, Square Head Hose, Turbocharger Clamp, Hose 0 Pick-Up, Magnetic Screw, Cap Hex Head (M x x 80) 078 Gasket, Throttle Body

47 Entrance Box Panel, Box Top and Bottom Panel, Box Side Cover, Entrance Box Screw, Self Locking Hex Washer Head (M x x mm) Edging Bulk (Order By The Foot Feet Required) Washer, Lock EIT (/ ) Screw, Self Locking Hex Washer Head (M8 x. x 0mm) 8 7 Lug, Solderless Cover, Control Housing Label, Ground

48 Control Housing

49 Control Housing 9 97 Housing, Control 9 99 Cover, Housing Control Screw, Hex Head (M x ) Nut, Hex (M0 x.) Washer, Lock (M0) 0 8 Washer, Flat (M0) Link, Terminal Screw, Locking Hex Head (/ 8 x.0) Washer, Lock ET (/) Edging Bulk (Order by the Foot Foot Required) 7 0 Plug, Hole Rivet, Pop Screw, Self-Locking Hex Washer Head (/ x 0.0 ) 9 0 Brace, Control Housing 7

50 Generator Heater

51 Generator Heater Cartridge, Heater (00 Watt) Volt Volt 0 Clamp, Loop 8 07 Screw, Machine Pan Head (M x mm) Nut, Hex (M) Washer, Lock Spring (M) 00 Washer, Flat (M) Box, Terminal Cover, Terminal Box Gasket, Terminal Box 0 0 Block, Terminal Grommet 8 07 Screw, Machine Pan Head (M x 0mm) Washer, Lock Spring (M) Screw, Cap Hex Head (M x mm) 8 Mount, Cable Tie Nut, Hex (M) Screw, Pan Head (M x mm) Plug, Dot Button 9

52 0 Generator

53 Generator Stator, Generator (See Separate Pages for Part Numbers) Rotor Assembly, Generator (Includes Parts Marked *) mm Stack Length mm Stack Length mm Stack Length mm Stack Length mm Stack Length *Key, Exciter Rotor , 90mm Stack Length , 8mm Stack Length mm Stack Length *Rotor Assembly, Exciter (Includes Parts Marked #) 0 0, 90mm Stack Length 0 0 0, 8, mm Stack Length *#Rectifier Assembly (Includes Parts Marked +) Forward ( With Positive Diode) Reverse (With Negative Diode) *#+Diode Positive Negative *#+Screw, Cap Hex Head (M x mm) (CR,,,,,) *#+Nut, Hex (M) *#+Washer, Lock Spring (M) 0 00 *#+Washer, Flat (M) *#Nut, Locking Nylon (M) 00 *#Washer, Flat (M) 0 0 *Bearing, Ball *Ring, Retaining *Varistor *Nut, Hex (M) 7 9 *Hub, Drive *Washer, Lock Spring (M) 9 00 *Washer, Flat (M) O-Ring 07 Adapter, Generator Screw, Cap Hex Head M0 x 0mm M0 x 0mm ( O Clock Position) 80 0 Washer, Lock Spring (M0) Screw, Cap Hex Head (M x 0mm) 99 Disc, Drive Generator 09 8 Washer, Flat (/8 ) Hardened 7 09 Adapter, Generator Stator Seal, Edging Bulk (Order by the Foot Feet Required) 9 Cover, Stator Top 097 0, 90mm Stack Length , 8mm Stack Length mm Stack Length 0 Cover, Stator Bottom 80 0, 90mm Stack Length , 8mm Stack Length 80 0 mm Stack Length Screw, Cap Hex Head (M x 0mm) Washer, Lock Spring (M) Washer, Flat (M) Grommet Block, Terminal 7 0 Plug, Hole 7 0 Washer, Flat (/ ID x / OD x / Thk) Screw, Cap Hex Head (M0 x 0mm) Washer, Lock Spring (M8) Screw, Cap Hex Head (M8 x mm) 00 Washer, Flat (M8) 80 0 Washer, Lock Spring (M0) 087 Guard, Fan Generator 0879 Screen, Air Inlet Screw, Self Locking Hex Washer Head (M x mm) 0 Bell, End Washer, Lock Spring (M0) Screw, Cap Hex Head (M0 x 0mm) Washer, Lock Spring (M) 0 Screw, Cap Hex Head (M) 800 0, 90mm Stack Length , 8, mm Stack Length Stator, Exciter 0 9 0, 90mm Stack Length , 8, mm Stack Length 9 Bracket, Mounting Generator Foot Screw, Cap Hex Head (M x 0mm) Washer, Lock Spring (M) 0 8 Washer, Flat (M) 70 0 Spacer, Mounting Foot Screw, Self Locking Hex Washer Head (M x 0mm) Bolt, Place (/8 x.7 ) Screw, Cap Hex Head (M0 x mm) Washer, Lock Spring (M0) 07 8 Washer, Flat (/8 ) Screw, Cap Hex Head (M x 0mm) * Parts Included in Generator Rotor Assemblies # Parts Included in Exciter Rotor Assemblies + Parts Included in Rectifier Assemblies

54 Generator Stator REF PART QTY PART NO. NO. USED DESCRIPTION Stator, Generator GGHG mm Stack Length, Winding Code mm Stack Length, Winding Code 0 8 mm Stack Length, Winding Code mm Stack Length, Winding Code 0 8 0mm Stack Length, Winding Code 0 8 8mm Stack Length, Winding Code mm Stack Length, Winding Code 0 8 mm Stack Length, Winding Code 7 GGHH mm Stack Length, Winding Code mm Stack Length, Winding Code 0 8 mm Stack Length, Winding Code mm Stack Length, Winding Code 0 8 0mm Stack Length, Winding Code 0 8 8mm Stack Length, Winding Code mm Stack Length, Winding Code mm Stack Length, Winding Code mm Stack Length, Winding Code 0 8 0mm Stack Length, Winding Code 0 8 mm Stack Length, Winding Code mm Stack Length, Winding Code 7

55 Permanent Magnet Generator (PMG) B Pin, Parallel Bolt, Mounting PMG 0 Rotor, PMG 0 Stator, PMG 97 Clamp, Stator PMG Cover, End Bell 7 0 Spacer, Cover Screw, Hex Head (M x 0.8 x 0) Washer, Lock (M0) Harness, Wiring PMG Washer, Lock (M)

56 Detector Control ÂÂ Â

57 Detector Control 9 00 Box, Control 0 07 Isolator, Vibration 7 00 Plug, Hole (Fits Hole) (Quantity Used As Required) Grommet (Fits Hole) 0 0 Receptacle, Fastener 0 0 Stud, Fastener Washer, Stud Retainer 8 00 Clip, Wire Nut, Hex W/ET (#0 ) Nut, Hex (/ 0) 008 Washer, Flat (/ ) Strap, Ground 8 00 Screw, Self-Locking Hex Head (/ 8 x / ) 7 00 Plug, Hole (Fits / Hole) (Quantity Used As Required) Washer, Lock EIT (/ ) Screw, Self Locking Hex Washer Head (#0 x / ) Door, Control AC Harness, Wiring AC Control Door (Includes Terminal Block) (9 Wire, ) (TB, GND to GND, M,,, S, DS,) Block, Terminal ( Place) (TB) 0 0 Light, Indicator Upper/Lower Scale (DS,) Voltmeter, AC (M) / Ammeter (M) / / / Meter, Frequency (M) Washer, Lock ET (#0) 08 0 Switch, Rotary Voltmeter/Ammeter (Includes Handle) (S) 7 Strip, Marker Screw, Cross Recessed Thread Forming (# x /8 ) Capaciter Voltmeter (. Mfd., 00 WVDC) (C) Nut, Hex W/ET (# ) Screw, Machine Round Head (M x 8mm) 8 9 Harness, Wiring Terminal Block (9 Wire, ) (Includes Connector Plug and Sockets) (P to TB) 0 Plug, Connector (P) 8 9 Socket, Contact Screw, Cap Hex Head (/ 8 x /8 ) Nut, Hex (# 0) Screw, Self Locking Hex Washer Head (#0 x / ) Screw, Pan Head (Cross Recessed (# x / ) Door, Control DC Screw, Machine Round Head (# x / ) Nut, Hex W/ET (# ) 8 Harness, Wiring DC Control Door (Includes Connector Housing and Contact Pins) ( Wire, ) (AJ to GND, M,,,, S,, DS) 08 Housing, Connector (J) 0 Pin, Contact 00 9 Board Assembly, Printed Circuit Engine Monitor (Includes Fuses) (A) Fuse Amp (Tan) (F, F) Amp (Light Blue) (F) Amp (Yellow) (F, F) 00 0 Light Assembly, Indicator (Includes Wiring Harness and Connector Housing) (A) Light, Indicator Replacement 8 0 Light, Panel (DS) Bulb, Panel Light Replacement Gauge, Oil Pressure (M) 9 0 Gauge, Water Temperature (M) 0 Voltmeter (M) 0 00 Meter, Hour (M) 7 0 Plug, Hole (Fits 7/8 Hole) Switch, Rocker Lamp Test/Reset Panel Lamp (S) 08 0 Switch, Rocker Run/Stop/Remote (S) Washer, Lock ET (#0) Board, Printed Circuit Sensor Board (A7) Handle, Rotary Switch

58 Control Heater Mount, Tie Cable Label, Caution Heater, Control Volt Volt A/R Sleeving, Convoluted 7 0 Rectifier, Power 99 Terminal, Receptical 7 0 Terminal, Tab A/R Tubing, Heat Shrink Splice, Window (8 Gauge) 0 07 Cable, Heater Control (Includes Parts Marked *) 00 * Cable 97 * Terminal, Ring 99 * Terminal, Receptical 0 * Terminal, Tab 09 Tie, Cable Screw, Cap Hex Head (/ 8 x /) Nut, Hex Self Locking (/ 8) Washer, Lock EIT (/) * Parts Included in 07 Heater Cable

59 Engine Wiring Harness Harness, Wiring Engine to Control (Includes Parts Marked #) 0 # Housing, Connector 8 Place (J) 0 # Housing, Connector Place (J) 7 # Housing, Connector Place (J) # Relay (K, K) 00 # Socket, Contact (Used in J, J) 7 7 A/R # Plug, Cavity (P8) # Rectifier, Silicon (CR) # Seal, Cable (P8) # Socket, Contact 9 # Plug, Seal # Bracket, Terminal Mounting 00 # Block, Terminal (T) 0 # Jumper (T) 8 08 # Screw, Machine Round Head Cross Recessed W/IT (8 x.0) 8 # Wedge, Plug ( Pin) 7 # Plug ( Pin) 8 0 # Pin, Contact (Used in J) 9 70 # Connector (0 Pin) (P8) 0 79 # Housing, Lock (P8) # Pin, Terminal (P8) 8 # Wedge, Plug ( Pin) 8 # Plug ( Pin) Harness, Wiring AC Auxiliary (Includes Parts Marked +) Volts 8 0 Less than 00 Volts + Connector, Plug (9 Place) 0 00 Volts 0 Less than 00 Volts 7 A/R + Pin, Contact # Parts Included in 8 9 Wiring Harness + Parts Included in 8 0 and 8 0 Wiring Harness 7

60 Voltage Regulator Potentiometer (R) 0 0 *.K Ohms (Used With Model SX0 Voltage Regulator) # K Ohms (Used With Model MX Voltage Regulator) Board, Printed Circuit Voltage Regulator (VR) * Model SX # Model MX #Screw, Pan Head Cross Recessed Thread Cutting (# x /8 ) 000 #Washer, Flat (#8) 0 *#Resistor (.K Ohms) (Used on TB) *#Breaker, Circuit (CB) 7 *#Screw, Pan Head Cross Recessed (#0 x 7/8 ) SX0 Voltage Regulator MX Voltage Regulator 8 0 *#Jumper (Used on TB) #Board, Printed Circuit Isolation Transformer (T0) * Parts Used on Generators Without Permanent Magnet Exciter # Parts Used on Generators With Permanent Magnet Exciter 8

61 Alarm Relay Board Board, PC Alarm Relay Screw, Machine Round Head Cross Recessed (# x.0) Relay ( VDC) (K, K, K) * Sleeving (/ ) Standoff Alarm Board (. Long) Standoff Alarm Board (. Long) Harness, Alarm Relay Board (Includes parts marked *) 8 9 * Plug, 9 Pin 9 A/R * Tie, Cable * Pin, Contact 00 * Socket, Contact 9 * Plug, Pin * = Parts includes in 8 87 Harness Assembly 9

62 Common Alarm Board, Printed Circuit Diode 8 0 Harness, Common Alarm 8 00 Screw, Machine Round Head (# x /) 0

63 Low Battery Voltage Sensor 0 08 Lens, Indicator 8 0 Harness, Low Battery Voltage 0 0 Base, Relay Screw, Machine Round Head (#8 x ) 870 Nut, Hex W/ET (#8 ) Sensor, Low Battery Voltage

64 Audible Alarm 0 Signal, Audible Plate, Audible Signal 8 08 Screw, Machine Round Head (# x /) Nut, Hex W/ET (# )

65 Emergency Stop Switch 0 7 Ammeter Blank Scale 0 7 Switch Blank Switch, Pushbutton Emergency Stop (Includes Bulb) (S) 087 Bulb, Replacement

66 Time Delay Start/Stop Screw, Pan Head Cross Recessed (# x /) PCB, Time Delay Start/Stop Tie, Cable 8 90 Harness, Time Delay Start/ Stop

67 Current Transformer Transformer, Current (CT, CT, CT) Ratio 0/ or 00/ Ratio 00/ or 00/ Ratio 0/ or 00/

68 Meter Transformer Bracket, Transformer Transformer, Meter 8 7 Harness, Transformer (Includes Parts Marked *) 0 * Housing, Cap (J) 8 9 * Socket, Terminal Nut, Hex W/ET (#8 ) Screw, Self-Locking Hex Flange Head (/ 8 x /) Nut, Self Locking (/ 8) * Parts Included in 8 7 Wiring Harness

69 7

70 Circuit Breaker

71 Circuit Breaker 9 07 Panel, Box Top and Bottom Panel, Box Side 9 9 Bracket, Mounting Circuit Breaker Edging Bulk (Order By The Foot Feet Required) 7 07 *Standoff, Insulator *Screw, Cap Hex Head (/8 x / ) *Washer, Lock Spring (/8 ) *Washer, Flat (/8 ) 9 7 Lug, Solderless Washer, Lock EIT (/ ) Screw, Self Locking Hex Washer Head (M8 x 0mm) Screw, Self Locking Hex Washer Head (M x mm) 9 Cover, Box Cup 9 / x / Opening 9 0 / x / Opening 9 0 x / Opening Rivet, Pop Nut, Hex (# ) Mounting Mounting Hardware Used On 0 9 XX Circuit Breakers Nut, Hex W/ET (#8 ) Mounting Hardware Used On 0 9 XX Circuit Washer, Lock EIT (#) Mounting Hardware Used On 0 9 XX Circuit Breakers Strip, Copper (Used for wrapping end of leads before securing to circuit breakers) (Quantity Used As Required) Label, Warning Label, Ground * Parts Used On Generator Sets With Or Pole Circuit Breakers Continued... 9

72 Circuit Breaker

73 Circuit Breaker Continued... Breaker, Circuit Pole (UL) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) * 00 Amp (0 Volts) * 0 Amp (0 Volts) * 00 Amp (0 Volts) Pole (UL) Amp (0 Volts) 0 9 Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) Amp (0 Volts) * 00 Amp (0 Volts) * 0 Amp (0 Volts) * 00 Amp (0 Volts) Pole (UL & IEC) * 0 Amp (00/70 Volts) * 0 Amp (00/70 Volts) * 0 Amp (00/70 Volts) * 70 Amp (00/70 Volts) * 80 Amp (00/70 Volts) * 90 Amp (00/70 Volts) * 00 Amp (00/70 Volts) * Amp (00/70 Volts) * 0 Amp (00/70 Volts) * 7 Amp (00/70 Volts) * 00 Amp (00/70 Volts) * Amp (00/70 Volts) * 0 Amp (00/70 Volts) * 00 Amp (00/70 Volts) * 0 Amp (00/70 Volts) * 00 Amp (00/70 Volts) Pole (IEC) 0 99 * 0 Amp (70 Volts) 0 99 * 00 Amp (70 Volts) 0 99 * 0 Amp (70 Volts) * 0 Amp (70 Volts) * 00 Amp (70 Volts) * 00 Amp (70 Volts) Package, Hardware Circuit Breaker Mounting (Includes Screws, Nuts and Lock Washers) Used With 0 99 XX Circuit Breakers Used With 0 90 XX Circuit Breakers Used With 0 9 XX Circuit Breakers (Screws Only) Accessories, Circuit Breaker: The following are used on 0 99 XX and 0 90 XX Circuit Breakers Trip, Shunt (V) Switch Used as an Auxiliary Contact or Trip Alarm Lead (Quantity Used As Required) 089 /8 Ring Terminal End to Stripped End No Markings ( ) (#/0 Wire) 0 0 /8 Ring Terminal End to Stripped End No Markings (0 ) (# Wire) 0 0 /8 Ring Terminal End to /8 Ring Terminal End Marked LO (0 ) (# Wire) 0 0 /8 Ring Terminal End to /8 Ring Terminal End Marked LO (0 ) (#/0 Wire) * Includes Mounting Hardware 7

74 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page , , 7, 9 0, 9 08, 098 0, , 7, , 9 0, ,,, , , 9 08,, ,,, , 7, 9 09, 7, 9, 0 0, 098 9,,, 7 0 0, 7, , 7 0 0, 098 9, 0 0, 7, 9 0, 7, 9, 0, 098 7,, 9 0, 9 0, 7, 9, , 098 7,, 0 0, , , ,, 0, 9 0, 7, 9, , 0 0, , 7, 8, 9,,, , 0 8, , 9 0 0, , 0 0, , 9 0, 7 0, 0 0 0, , 7 0, 7 0, 0 99, , 7, 7, 9, 0 9 0, 0 97, 7 0, 7 0 0, , 0 98, , 7, 9, , 087, 0, 7 0 0, , 088 0, 0, 7 80, , 08, 0, 8, 9,,, 9, 7 0 8, 08, 0, 8, 9,,, 8,,, 7 0 8, 77 0, 7 0, 8, 9,,, 9, 7 0 8, 7 0, 7, 9, 00, 8, 9,,, 9, 9 0 8, 7 0, 7, 9, 078, 087 0, , 7 0, 7, 9, 079, 7, 9, 7 9, , 7 0, 08, 8 9, 0 8 0, 8 0 0, 7 08, 8 7, 0 8, 8 0,, 08, 9 98, 7, 0 8, 0 7 0, , 7, 9, 9 00, 0 8, 0, 8 0,, , 089, , 9 8 0,,, 9, 0 0, , 9 8 0, 9, 9, 0 0, 7 0 9, 9 8 0, 8,, 9, 0 0, 7 0 7, 8 089, 8, 9,, 9 7, 07, 0 7, 8 090,, 9 8, 09, 0 88,,, ,, 9 9, 09 0, , 7 8,, 9,, 0 0, 9 0 8, , , 7, 9 0 0, 9 0 0, 9 0 0, 7, 9 8 0, 8, 9,,, 8 0, 8, 9,,, 8 7 0, 8, 9,,, 8 7, 8, 9,,, 8 8, 8, 9,,, 9, , , 7 9 8, 9 0, , 7 9 0, 0, 9, 99, 70 0, 80 0, 80 0, 80 0, 7

75 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 9, 08 0, , 7 0, 7 97, 08 0, , 7 0, 7 087, 08 08, 0 9 0, 7 08, 087 0, 08 09, 0 9 0, 7 7, , 09 09, 8, 9,, 0 9 0, 7 0 0, 097 0, , 0 9 0, 7 9, , , 0 9 0, 7, , 9, 0 9 0, 7 8, , , , 7 8, , 9 9,,, , 7 8, , , , 7 9, , 9 978,, , 7 0, , , 0 9, 7 0,, 00 0, 9 99,, 7 0 9, 7 7, , 9 00, 0 9, 7 8,, 0 7, 9 07,, 9 0 9, 7 707, , 9 9, , 7 708,,, , 9 0, , 7 709,, 0 8, 9, , 7 70, 7 0, 9 0, , 7 7,, 7 0 8, 9, , 7 79, 7 0 8, 9 0, , 7 7,, 0 7, , , , 9 0 7, , , , 9 0 7, , , 7 0 0, , , , 7 00, 0 8 0, , , 7 00, , , , 007, 0 98, , , 09, , , , 09, 0 0, , 7 000, 0, , , ,, 9, , , 7 0, 7,, , , 7 0, 789, 0 088, , , 99, 0 090, 0 99, , 0, 0 098, , , 0, ,, , 7 087, 0, , ,,, , 9, 07 88, 8,, 08 00, , , , , , 7 99, 9 00, 7, 9 9, 9 9, 9 0,, 7, 7,,, 7, 9, 97, 7, 7 07, 9 7

76 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 987, 7 0 0, , 0 7, 7, 9, 0, 9 0, ,, 0 8, 7, 9, 0, 9 0, ,, , 8, 9 0, 08 07, , , 088 0, 0, 00, 07, 7 009, , 8 90, 8 78, 8 87, 9 8 0, 8 0, 0 8 0, 8 0 0, 8, 8 7, 8 0, 7 8 0, 7 8 9, 8 9, 8 0,, ,, 8, 9 8 7, 8 8 0,,, 8 9, ,,, 0, 8 089, 7 000,, , 7 009, 7 0, 8 0 0, 8 0 0, 0 07, 0 0, 0 7, , 9 0 0, 0 0 0, 0 8 0, 0 7,, 0 7,,, 7 0 8, 7 0 8,, 0 90,,, ,,, ,,, ,,, 7 0 9, 7 0 9,,, ,,, 7 0 9,,, ,, 0 9,, 0 9,, 0 9,, 0 9,, 0 9,, 0 9,, 0 97,, 0 98,, 0 99,, 0 90,, 0 9,, 0 9,, 0 9,, 0 9,, 0 98,, 0 988, 0 989, 0 990, , , 0 99, 0 99, , ,, ,, , , ,, ,, 0 00,, 0 00,, 0 00,, 0 00, 0 0, 0 0, 0 0,, 0 0,, 0 0, 0 09,, 0, 0 0, 0 0, 0 0, 0 078,,, ,,, ,,, 7 09, , 8 09, 7 0, ,, 0 00,, 0 008, , ,,,, ,, 0 09, 0 00,, 0 8, 7 0 8, 8, 9,,, 0 0, 7, 9, 0 99, 0 08, 7,,, 7, 9,, 0 09,, 0 097,, , , 0 0, 7 0 0, 7, 9 0 0, 7 0, 7, 9, 0 9, 0 0, , , 8, 9,,, ,, 0 988,, 0 79, 0, 7 0, 7 0, 7 0, 7, 9, 0 9, , ,, ,,, , 8, 9,, 0 009, , 8,, 0 000,, 0 00, 9,, 0 00, , 0 008,, , 9, ,, 0 007, , , , 8,, 7

77 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 077, 8,, 000, , 8 07, , 0 09, 8,,, 0 08,,, 0 08, 8, 9,,, 0 097, 8,,, 0 00, 9,, 0 07,,, 0 079,, 0 0, 0 080, 8, 9,, 0 0 0, , 08 09, 08 08, ,, , 7, 9, , 08, 7 08, , , 7, 9, 0 0, 0 8, , 097 0, 097 0, 7 00, , 7 0,,, 7 0, 7, ,, 7 00, 7 00, 7 0,, 8 008, 8 00, 0 0, 0 00, 8, 9,,, 0 07, 7, 9, 00, 00, 00, 00,, 008, 009, 9 07, 8, 9,,,,, 08 0, 09, 099, 0, 0,, 0,, 00, 9, 00, 080, 7, 08, 9 00, 7, 8, 9,,,, 0, 9 0, 7, 7, 9,, 7 0, 7, 9, 70 9, , , , , , 800 0, , 800 0, , , 7, 9, , , , 7, 9, , 7, 8, 9,,, , 7, , 8, 9,,, , 7 800,,, 7, 9, , 800 0, 800 0, , 8, 9,,, , , , , 800 0, , 80 00, 8 00, , 8 08,, 8 08, , , , , ,, , ,, 8 097,, 9, , , 9,,,, 7, 7, ,,, , , 8 00, 7, 8 00, , ,, , , 7, ,,, 9,, 7, , 7, 7, 9,, , 8, 9,,, ,,,, 7, , 9,,, 7, , , , 80 0, 80 07, 80 00, , 9, 80 00,, 80 00,, , 7, 7, 9,,, 80 00, 7, 7,, , 8 000, ,, 7,,, , 8 00, 80 00, , 9, 80 00,, , 7, , 7, 9,, , 7, 8 00, 8 000, , ,, 870 0,, ,, ,,, , , , 870, , 9, 87 00, 89 0,,, , ,, 89 08,, 7