Parts Manual. Home Standby Generator Set. GNAA (Spec A D) GNAB (Spec A D) GNAC (Spec A D) English Original Instructions (Issue 13)

Transcription

1 Parts Manual Home Standby Generator Set GNAA (Spec A D) GNAB (Spec A D) GNAC (Spec A D) English Original Instructions (Issue )

2

3 Introduction This manual applies to the standard Home Standby Generator Sets as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Using the model and specification number from your generator set nameplate, select parts that apply to your set. Right and left sides are determined by facing the engine end (front) of the set. Generator Set Data Table Model Name Watts Volts Hertz Wire Phase Battery Voltage. GNAA/* 00 Reconnectible 0 / / V.0 GNAA/* 000 Reconnectible 0 / / V.0 GNAB/* 000 Reconnectible 0 / / V. GNAB/* 00 Reconnectible 0 / / V. GNAC/* 00 Reconnectible 0 / / V.0 GNAC/* 000 Reconnectible 0 / / V Note The diagonal line (/) or dash ( ) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from a standard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes.

4 Index A Actuator, Electronic Governor, 0 Adapter, Adapter, Brass, Adapter, Cylinder Head, Adapter, Oil Filter, Adapter, Oil Pressure Switch, Adapter, Radiator Outlet Duct, 0 Alternator (Spec A), Alternator (Begin Spec B), Ammeter, AC Detector (Begin Spec B), 00 Ammeter, AC Detector (Spec A), Ammeter, Meter Panel (Manual/Remote), Ammeter, Meter Panel (Manual/Remote)(Spec A), Armature, Starter, Assy Panel, Circuit Breaker (Begin Spec D), Assy. Control (Begin Spec D), B Baffle, Housing Front Duct (GNAC), Band, Heavy Duty A/C Mounting, Band, Heavy Duty A/C Mounting (Spec A), Barb, Coolant Heater Hose, Barb, Regulator Hose, Base Skid (Begin Spec D), 0 Base, Mounting, Bearing, Connecting Rod Large, Bearing, Connecting Rod Small End, Bearing, Crankshaft Center, Bearing, Flywheel End Main, Bearing, Gear End Camshaft, Bearing, Gear End Main, Bearing, Generator Rotor Ball, Bearing, Starter (Commutator End), Bearing, Starter (Pinion End), Belt, Alternator (Spec A), Belt, Alternator (Begin Spec B), Bend, Coolant Heater Hose, Block, AC Detector Control Harness Terminal (Spec A), Block, AC Detector Control Terminal (Spec A), Block, AC Detector Terminal (Begin Spec B), 00 Block, Control Manual/Remote Control Terminal (Spec A), 0 Block, Control Saddle Terminal, 0 Block, Control Terminal Manual/Remote, Block, Cylinder, Block, DC Detector Control Terminal, 0 Block, Detector Control Terminal, Block, Manual/Remote Control Terminal, Block, Manual/Remote Control Terminal (Spec A), 0 Block, Oil Distribution, Block, Output Box Detector Terminal, Board Assy, PC Engine, 0 Board, Aux Relay, Board, Engine Monitor, 0 Board, PC Sensor Board, 0 Board, Time Delay, 0 Boot, Control On/Off/Start Switch (Spec A), 0 Bottom, Control Box, 0 Box, Control (Manual/Remote), 0, Box, Control (Manual/Remote)(Spec A), 0 Box, DC Detector Control, 0 Box, Meter Panel Control (Manual/Remote), Box, Meter Panel Control (Manual/Remote)(Spec A), Brace, Fuel/Air Breather Support, Brace, Rear Engine, Bracket, AC Detector Lamp (Spec A), Bracket, AC Detector Rotary Switch (Volt/Ammeter) (Spec A), Bracket, Alternator Adjusting (Spec A), Bracket, Alternator Adjusting(Begin Spec B), Bracket, Breather (Spec A), Bracket, Breather Drain Hose, Bracket, CB Mounting, Bracket, Control Saddle, 0

5 Index Bracket, Coolant Heater, Bracket, Detector Control CB Mounting, 0 Bracket, Engine Harness Terminal, 0 Bracket, Extended Oil Level Indicator, Bracket, Fan Guard, 0 Bracket, Fuel System, Bracket, Governor Actuator, 0 Bracket, Governor Controller, 0 Bracket, Heavy Duty A/C (Spec A), Bracket, Ignition Coil, Bracket, Mounting (Gauge Kit), Bracket, Regulator Support, Bracket, Terminal Block Mounting (Dectector Control), Breaker, AC Detector Circuit (Begin Spec B), 00 Breaker, AC Detector Circuit (Spec A), Breaker, Circuit (Manual/Remote Spec A), Breaker, Control Box Circuit (Manual/Remote), Breaker, Control Circuit, Breaker, Control Circuit (Spec A), 0 Breaker, Detector Control Circuit, 0 Breaker, Output Box Detector Circuit, Breather, 0 Breather (Spec A), Breather, Crankcase, Bulb, Panel Replacement Light, 0 Bushing, Control Nylon, Bushing, Low Coolant Switch, 0 C Cable, Battery, Cable, Control Heater, Cable, Detector Control Mount Ground, 0 Cable, Generator Heater Control, Cable, Ground, Cable, Mounting Base Ground, Camshaft, Cap, Battery Breather, Cap, Cylinder Block Oil Fill, Cap, Cylinder Head Oil Fill, Cap, Housing Rain, Cap, Housing Rain Top, Cap, Housing Rain Top (Begin Spec D), Cap, Muffler Rain, Cap, Muffler Rain, Cap, Radiator, 0 Cap, Water Pump, Capacitor, AC Detector Voltmeter (Begin Spec B), 00 Carburetor, 0 Carrier, Valve Spring, Channel, AC Detector Rubber (Spec A), Circlip, Piston Pin, Circuit Breaker Panel (Begin Spec D), Cleaner, Heavy Duty Air, Cleaner, Heavy Duty Air (Spec B C), Cleaner, Heavy Duty Air (Spec A), Cleaner, Standard Air, 0 Cleaner, Standard Air (Spec A), Clevis, Electronic Governor, 0 Clutch, Starter, Coil, Ignition, Components, Starter, Control (Begin Spec D), Control Assembly (Begin Spec D),, Control, AC Detector (Begin Spec B), 00 Control, AC Detector (Spec A), Control, DC Detector (Begin Spec B), 0 Control, DC Detector (Spec A), 0 Control, Detector Circuit Breaker (Begin Spec B), 0 Control, Display Panel (Begin Spec D), Control, Ignition, Control, Manual/Remote (Spec B C), Control, Manual/Remote (Spec A), 0 Control, Output Box Detector, Controller, Electronic Governor, 0 Cotter, Valve,

6 Index Coupling, Pipe, Coupling, Regulator, Cover, AC Detector Meter (Spec A), Cover, Battery (Spec A), Cover, Control, Cover, Control Box,,, Cover, Control Box (Spec A), 0 Cover, Control Housing, 0 Cover, Cylinder Head,, Cover, Detector Control Box, 0 Cover, Detector Control Housing (W/O CB), 0 Cover, Endbell Inlet, Cover, Gear End, Cover, Housing Battery, Cover, Housing Battery (F and F), 0 Cover, Meter Panel (Manual/Remote), Cover, Meter Panel (Manual/Remote)(Spec A), Cover, Output Box Detector Circuit Breaker, Cover, Output Box Detector Control Box, Cover, Radiator Cowl, 0 Cowl, Radiator, 0 Crankshaft, D Diode Assy, Control Zener (Spec A), 0 Diode, Control (Spec A), 0 Diode, Control Harness, Diode, Control Zener, Dipstick, Cylinder Block Oil, Disc, Drive, Door, AC Detector Control (Begin Spec B), 00 Door, DC Detector Control, 0 Door, Housing, Dowel, Center Bearing, Dowel, Flywheel, 0 Dowel, Gear End Cover, Duct, Housing,, Duct, Housing (Begin Spec D)(F), Duct, Housing (F), Duct, Housing Front (Begin Spec D)(F), Duct, Housing Front (F), Duct, Housing Rear (Begin Spec B)(F), Duct, Housing Rear (F and F), 0 E Edging, Control Mount, 0 Elbow, 0 Deg Regulator, Elbow, Coolant Heater Street, Elbow, Gas Valve Reducing, Elbow, Oil Pressure Gauge, Elbow, Regulator 0 Deg., Element, Coolant Heater, Element, Heavy Duty Air Cleaner, Element, Heavy Duty Air Cleaner (Spec A), End, Female Rod, 0 End, Male Rod, 0 Endbell, Engine, Replacement, Eye, Lifting, F Fan, Generator, Fan, Radiator, 0 Filter, Oil, Fitting, Coolant Heater Conduit, Flange, Exhaust, Flange, Flexible Exhaust Pipe Mating, Flywheel, 0 Foot, Mounting Base Sliding, Frame, Starter (Commutator End), Fuse, 0 Fuse, Control, Fuse, Control (Spec A), 0

7 Index G Gasket Set, Cylinder Head, Gasket, AC Detector Rotary Switch (Spec A), Gasket, Blanking (Begin Spec C), Gasket, Breather Drain Hose Bracket, Gasket, Carburetor Flange, 0 Gasket, Cylinder Head Cover, Gasket, Dectector Control Side Cover, 0 Gasket, Detector Control Box Cover, 0 Gasket, Detector Control Box Hinge, 0 Gasket, Detector Control Box Side, 0 Gasket, Detector Control Box Top, 0 Gasket, Exhaust, Gasket, Exhaust Flange, Gasket, Flexible Exhaust, Gasket, Gear End Cover, Gasket, Housing,,, Gasket, Housing (Begin Spec B)(Rear), Gasket, Housing Rear Panel, 0 Gasket, Housing Top (F and F),, Gasket, Muffler, Gasket, Radiator Drain Plug, 0 Gasket, Side Cover, Gasket, Terminal Block, 0 Gasket, Water Pump, Gauge, DC Detector Water Temperature, 0, 0 Gauge, Oil Pressure, Gauge, Oil Pressure (Begin Spec B C), 0 Gauge, Oil Pressure (Spec A), 0 Gauge, Temperature (Gauge Kit), Gear, Ring, 0 Generator, Governor, Electronic, 0 Grommet, AC Detector (Begin Spec B), 00 Grommet, Extended Oil Level Indicator, Grommet, Manual/Remote Control Box (Spec A), 0 Grommet, Output Box Detector, Grommet, Stator Housing, Guard, Fan, 0 Guard, Radiator (Bottom LH), Guard, Radiator (Bottom RH), Guard, Radiator (Top LH), Guard, Radiator (Top RH), Guide, Valve, H Handle, AC Detector Rotary Switch (Begin Spec B), 00 Harness, AC Detector Aux (Begin Spec B), 00 Harness, AC Detector Control (Spec A), Harness, AC Detector Door (Begin Spec B), 00 Harness, AC Detector Regulator (Spec A), Harness, AC Detector Terminal Block (Begin Spec B), 00 Harness, Control Engine, Harness, Control Engine (Spec A), 0 Harness, Control Manual/Remote Panel, Harness, Control Manual/Remote Panel (Spec A), 0 Harness, DC Control Door, 0 Harness, Dry Contact, Harness, Engine, 0, 0 Harness, Genset (Begin Spec D), Harness, Ignition, Harness, Meter Panel (Manual/Remote), Harness, Meter Panel (Manual/Remote)(Spec A), Harness, Output Box Detector AC Generator, Harness, Relay Board Control, Harness, Voltage Sensing, 0 Harness, Wiring (Gauge Kit), Head, Cylinder, Heater, Control, Heater, Coolant, Heater, Generator Control, Heater, Generator Control (0V), Hinge, Housing Rear Duct,

8 Index Hold Down, Battery, Holder, AC Detector Control Harness Fuse (Spec A), Holder, Control Fuse, Holder, Control Fuse (Spec A), 0 Hose, Battery Breather, Hose, Bottom, Hose, Breather (Spec A), Hose, Coolant Heater, Hose, Fuel, Hose, Heavy Duty A/C Elbow, Hose, Heavy Duty A/C Elbow (Spec A), Hose, Oil Distribution Block, Hose, Radiator, 0 Hose, Top, Housing, Housing (F, F)(Begin Spec B), Housing (F, F)(Begin Spec D), Housing (F, F)(Begin Spec B), Housing Front Duct (F)(Begin Spec D), Housing Rear Panel (Begin Spec D), Housing Rear Panel (F) (FGNAA, GNAB) (Spec B C), 0 Housing Rear Panel (F)(F GNAA, GNAB)(Begin Spec D), Housing Rear Panel (FGNAC)(Spec B C), Housing Top Panel (F, F)(Begin Spec D), Housing, Center Bearing, Housing, Flywheel, 0 Housing, Main Bearing, Housing, Starter, I Ignition, Primary, Ignition, Secondary, Indicator, Extended Oil Level, Insert, Exhaust Valve, Insert, Inlet Valve, Insulation, Door Panel, Insulation, Housing Door, Insulation, Housing Duct(F), Insulation, Housing Rear (Begin Spec B)(F), Insulation, Housing Top (Begin Spec D) (F and F), Insulation, Housing Top (F and F), Isolator, AC Detector Vibration (Begin Spec B), 00 Isolator, Vibration (Begin Spec D), 0 J Jumper, AC Dectector Harness Terminal Block (Begin Spec B), 00 Jumper, Terminal Block, K Key, Crankshaft, Kit, Battery Vent Hose, Kit, Carburetor Repair, 0 Kit, Control Heater, Kit, Coolant Heater, Kit, Exhaust Flange, Kit, Expansion Plug, Kit, Extended Oil Level Indicator, Kit, Flexible Exhaust Pipe, Kit, Gauge (Manual/Remote), Kit, High Oil Fill, Kit, Housing, Kit, Meter Panel (Spec A), Kit, Muffler, Kit, Oil Pressure Gauge, Kit, Radiator, 0 Kit, Radiator Duct Adapter, 0 Kit, Skid Base, Kit, Starter Aid, Kit, Starter Brush, Knob, Air Cleaner (Spec A), Knob, Air Cleaner Rear (F and F), 0

9 Index Knob, Battery Cover, Knob, Selector Switch, Knob, Selector Switch (Spec A), L Labels, Lamp, 0 Lamp Assy, 0 Lamp, AC Detector Over/Under (Spec A), Latch, Housing Door Panel,,, Latch, Lockable Lever, Lead, High Tension, Lever, Rocker, Light Assy, Indicator, 0 Light, AC Detector Upper/Lower Indicator (Begin Spec B), 00 Light, Panel, 0 Light, Panel (Spec A), 0 Light, Replacement Indicator, 0 M Manifold, Manifold, Exhaust, Manifold, Inlet, Meter, AC Detector Frequency (Begin Spec B C), 00 Meter, AC Detector Frequency (Spec A), Meter, AC Volt, Meter, Control Hour, Meter, DC Voltage, 0 Meter, Hour, 0 Meter, Meter Panel Frequency (Manual/Remote), Meter, Meter Panel Frequency (Manual/Remote)(Spec A), Meter, Meter Panel Volt (Manual/Remote), Meter, Meter Panel Volt (Manual/Remote)(Spec A), Meter, Running Time, 0 Meter, Volt, 0 Meter, Volt (Gauge Kit), Mount, Detector Control, 0 Mount, Engine, Mount, Flexible (Gauge Kit), Mount, Manual/Remote Control, 0 Mount, Vibration, 0 Mounting Base (Begin Spec D), Mounting, Vibration (Begin Spec D), Muffler, Muffler, N Nipple, Gas Valve Close, Nipple, Oil Drain, Nipple, Oil Drain Pipe, Nipple, Regulator, Nipple, Regulator Close, Nipple, Regulator Pipe, O O Ring, Cylinder Block Oil Dipstick, O Ring, Cylinder Block Oil Fill Cap, O Ring, Cylinder Head Cover Nut, O Ring, Endbell Seal, O Ring, Extended Oil Level Indicator, O Ring, Oil Fill Cap, O Ring, Water Pump, Outlet, Water Pump Thermostat, Overspeed, P Panel, Output Box Detector (Box Side), Panel, CB (Manual/Remote Spec A), Panel, Control, Panel, Control (Begin Spec D), Panel, Control (Spec A), 0 Panel, Control Box Back (Manual/Remote),

10 Index Panel, Control Box Back (Manual/Remote)(Spec B C), Panel, Control Box Back (Spec A), Panel, DC Control, 0 Panel, Detector Control CB, 0 Panel, Door (Begin Spec D)(F and F), Panel, Door (F and F), Panel, Double Gauge (Gauge Kit), Panel, Gauge (Gauge Kit), Panel, Housing (Begin Spec D)(F and F), Panel, Housing (F and F), Panel, Housing Door (F and F), Panel, Housing Rear (Begin Spec B)(F), Panel, Housing Rear (F and F), 0 Panel, Housing Rear (F and F), Panel, Housing Rear (Spec A), Panel, Housing Top (Begin Spec D)(F and F), Panel, Housing Top (F and F), Panel, Housing Top (F and F), Panel, Housing Top (Spec A), Panel, Meter (Manual/Remote)(Begin Spec B), Panel, Meter (Manual/Remote)(Spec A), Panel, Radiator HSG, Panel, Rear (Begin Spec D),, Panel, Relay, Panel, Top (Begin Spec D), PCB Assy, Gauge, 0 PCB Assy, Overspeed, Pick Up, Magnetic, 0 Pin, Generator Installation Dowel, Pinion, Crankshaft, Piston Assy, Pivot, Front Spacer (Begin Spec B), Plate, AC Detector Control Harness Relay (Spec A), Plate, AC Detector Voltage Regulator (Spec A), Plate, Alternator Adjustment, 0 Plate, Front Engine, Plate, Fuel Lift Pump Blanking (Begin Spec C), Plate, Ignition, Plate, Output Box Detector Circuit Breaker Cover, Plate, Valve Spring, Plate, Water Pump Mounting, Plug, Control Plastic, Plug, Control Plastic, Plug, Detector Control Door, 0 Plug, Flywheel Banking, 0 Plug, Heater, Plug, Housing Button, Plug, Housing Button Top, Plug, Housing Button Top (Begin Spec D), Plug, Radiator Drain, 0 Plug, Reducing Tee Square Head, Plug, Spark, Potentiometer, AC Detector (Begin Spec B), 00 Potentiometer, AC Detector (Spec A), Pulley, Alternator (Spec A), Pulley, Crankshaft, Pump, Oil, Pump, Water, R Radiator,, 0, Radiator (Begin Spec D), Radiator, Cap, Rail, Detector Box Support, 0 Rectifier, Control Heater Power, Rectifier, Engine Harness Silicon, 0 Regulator, AC Detector Voltage (Begin Spec B), 00 Regulator, AC Detector Voltage (Spec A), Regulator, Control Voltage, Regulator, Control Voltage (Spec A), 0 Regulator, Gas, Relay,

11 Index Relay, AC Detector Control Harness (Spec A), Relay, Control, Relay, Control (Spec A), 0 Relay, Control Fault, Relay, Control Fault (Spec A), 0 Relay, Engine Harness, 0 Resistor, AC Detector (Begin Spec B), 00 Resistor, AC Detector Control Harness (Spec A), Resistor, Control (Spec A), 0 Resistor, Control Harness, Resistor, Engine Harness, 0 Restrictor, Breather (Spec A), Restrictor, Inlet Manifold, Ring Set, Piston, Rod Assy, Connecting, Rod, Push, Rotor, Exciter, Rotor, Generator, Rotor, Ignition, Rotor, Overspeed Ignition, Rubber, Sealing Tube, S Saddle, 0 Saddle, Detector Box Mounting, 0 Seal, Control Switch (Spec A), 0 Seal, Crankshaft Oil, Seal, Gear End Oil, Seal, Housing Sound (Begin Spec B)(F), Seal, Housing Sound (Begin Spec D)(F and F)), Seal, Housing Sound (F and F), Seal, Housing Sound Rear (F and F), 0 Seal, Housing Sound Top (F),, Seal, Valve Stem, Sender, Oil Pressure, Sender, Temperature, Sender, Temperature (Gauge Kit), Senor, Level (Coolant), Sets, Gasket, Shield, Housing Rain, Shield, Housing Rain Top, Shield, Housing Rain Top (Begin Spec D), Shim, Crankshaft, Shroud, Fan, Sleeve, Air Cleaner Transition (Spec A), Sleeve, Carburetor Hose (Spec A), Sleeve, Heavy Duty A/C Hose, Sleeve, Heavy Duty A/C Hose (Spec A), Sleeve, Water Pump, Spacer, Spacer (Gauge Kit), Spacer, Alternator Mounting (Spec A), Spacer, Alternator Mounting (Begin Spec B), Spacer, Disc Drive, Spacer, Heavy Duty Air Cleaner Bracket, Spacer, Ignition Plate, Spacer, Oil Distribution Block, Spacer, Oil Strainer, Spacer, Overspeed, Spacer, Radiator, 0 Spacer, Rocker Lever, Spring, Valve, Standoff, Relay Board, Starter, Starter Valve (Begin Spec D), Stator, Exciter, Stator, Generator, Strainer, Oil, Strap, AC Detector Ground (Begin Spec B), 00 Strap, Ground, 0 Strip, AC Detector Marker (Begin Spec B), 00 Strip, AC Detector Marker (Spec A), Strip, Control Marker, Strut, Housing, Strut, Housing Duct (Begin Spec B)(F), Strut, Housing Left (F and F), Strut, Housing left (F and F),

12 Index Strut, Housing Right (F and F), Strut, Housing Right (F and F), Support, Housing Insulation, 0 Support, Housing Insulation (F and F), Support, Housing Insulation Front (Spec B C)(F), Support, Housing Insulation Rear (F and F), 0 Support, Housing Insulation Top (F and F), Switch, AC Detector Rotary (Begin Spec B), 00 Switch, AC Detector Rotary (Spec A), Switch, Control Off/On Toggle (Spec A), 0 Switch, Control On/Off/Start, Switch, Control On/Off/Start (Spec A), 0 Switch, Low Coolant, 0 Switch, Meter Panel Rotary (Manual/Remote), Switch, Meter Panel Rotary (Manual/Remote)(Spec A), Switch, Oil Pressure, Switch, Pressure, Switch, Reset/Lamp Test, 0 Switch, Rocker, 0 Switch, Run/Stop/Remote, 0 Switch, Starter, Switch, Water Temperature, System, Breather (Begin Spec C), System, Breather (Spec A), System, Breather (Spec B), System, Oil Pressure, T Tappet, Hydraulic, Tee, Oil Switch Street, Tee, Regulator Reducing, Terminal, Gas Valve Insulated, Thermostat, Coolant Heater, Thermostat, Water Pump, Timer, Control Unit, Timer, Control Unit (Remote, Spec A), 0 Top, Control Box Housing, 0 Transformer, Current (Begin Spec D), Transformer, Meter Panel Current (Manual/Remote), Transformer, Meter Panel Current (Manual/Remote)(Spec A), Transformer, Output Box Detector Current, Tube Assy, Fuel, Tube, Center Bearing Locating, Tube, Copper, Tube, Exhaust, Tube, Extended Oil Level Indicator, Tube, Push Rod Sealing, U Union, Oil Distribution Block, V Valve, Exhaust, Valve, Inlet, Valve, Magnetic Gas,, Valve, Oil Drain Ball, Valve, Oil Relief, Valve, Radiator Drain, 0 Voltmeter, AC, 00 0

13 Abbreviations Some of the following abbreviations may be used throughout the Parts Catalog. AC Alternating Current MOH Mobile Off Highway Amp Ampere NFS Not For Sale A/R As Required NPT National Pipe Thread AVR Automatic Voltage Regulator OD Outside Diameter AWG Amerian Wire Gauge oz. Ounce DC Direct Current PC Printed Circuit Deg Degree Ph Phase EFC Electronic Fuel Control PMG Permanent Magnet Generator EIT External/Internal Tooth PT/CT Potential Transformer/Current Transformer EPROM Erasable Programmable Read Only Memory RFI Radio Frequency Interference ET External Tooth RT Right GFI Ground Fault Interrupter Spec Specification ID Inside Diameter Thk Thick IEC Internal Electrotechnical Commission UL Underwriters Laboratories, Inc. IT Internal Tooth UNC Union National Coarse kw Kilowatt UNF Union National Fine LPG Liquid Petroleum Gas VAC Volts Alternating Current LT Left VDC Volts Direct Current M Meter W/(ET, IT, EIT) With (meter number) mm Millimeter Paint and Thread Sealant REF NO. PART NO. QTY USED PART DESCRIPTION Onan Green Enamel (Non Metallic) 00 oz. Pressurized Spray Can 00 Quart Can 00 Gallon Can 00 Sealant, Thread ( ml Tube)

14 Cylinder Block 0 0

15 Cylinder Block Engine, Replacement Spec A GNAA GNAB GNAC Begin Spec B GNAA Natural Gas Propane GNAB Natural Gas Propane GNAC Natural Gas Propane Block Assy, Cylinder (Includes Parts Marked *) - GNAA -0 GNAB -0 GNAC -000 *Kit, Expansion Plug *Plug - GNAA - GNAB - GNAC *Bearing, Gear End Main -00 Standard mm Undersize mm Undersize -00 *Bearing, Gear End Camshaft -00 *Plug, / - *Plug Gasket, Side Cover -00 GNAA -0 GNAB -0 GNAC Cover, Side (Includes Bearing) -0 GNAA -0 GNAB -0 GNAC - DNAF 0 Washer (M) -0 GNAA -0 GNAB -0 GNAC Bolt, (M x x mm) -0 GNAA -0 GNAB -0 GNAC -0 Adapter, Oil Filter -0 Filter, Oil - Nipple, Pipe (/ x -/ ) - Valve, Ball (/ ) - Nipple (/ ) Nut (M x ) -0 GNAA -0 GNAB -0 GNAC Stud -0 GNAA -0 GNAB -0 GNAC -0 Cap, Oil Fill 0-0 O Ring -0 O Ring Dipstick, Oil (Includes O Ring) -0 GNAA -0 GNAB, GNAC - Stud (M x mm) - Washer, Spring (M) - Nut, Hex (M x.) -0 Bracket, Breather Drain Hose -0 Gasket * Parts Included in Cylinder Block Assy.

16 Oil Pressure System Spec A/B, // Cylinder Manual/Remote Control 0 0 Spec A/B, / Cylinder Manual/Remote Control W/gage Spec A/B, Cylinder Manual/Remote Control W/gage Spec B C, / Cylinder Detector Control Spec A, / Cylinder Detector Control 0 Spec B C, Cylinder Detector Control, Spec D Without Detector thru

17 Oil Pressure System -0 Switch, Oil Pressure Shutoff (psi)(used with and w/o Display) -0 Kit, Oil Pressure Gauge (Includes Street Tee and Gauge) (GNAB) - Adapter, Oil Pressure Switch - Tee, / NPT Street -0 Kit, Oil Pressure Gauge (Includes Parts Marked +) -0 +Elbow (/ NPT) (GNAA) -0 +Tube, Copper (GNAA) - +Gauge, Oil Pressure -0 +Block, Oil Distribution (GNAA) 0-0 +Screw, Hex Head Cap (GNAA) (M0 x. x mm) - Switch, Oil Pressure Warning ( psi) (Used With Detector Control) Sender, Oil Pressure (With Display only) -0 Spec A (Used with Detector) -0 Begin Spec D(Not Used with Detector) -0 Block, Oil Distribution (Includes Parts Marked ) (Used With Detector Control) -0 Block, Oil Distribution -0 Spacer - Screw, Hex Head Cap (M0 x 0mm) -0 Union -0 Hose -0 Plug Plug, / NPT Screw, Hex Head Cap (M0 x. x mm) + Parts Included in Oil Pressure Gauge Kit. Parts Included in Oil Distribution Block Assy.

18 Crankshaft 0 0 0

19 Crankshaft -0 Seal, Oil -0 Screw, Hex Head Cap (M x. x 0mm) -0 Housing, Main Bearing Shim -0 AR.mm -0 AR.0mm Crankshaft Assy (Includes Parts Marked *) -0 GNAA -0 GNAB -0 GNAC *Bearing Set, Flywheel End Main -00 Standard mm Undersize mm Undersize -0 *Washer Set, Thrust *Bearing, Center GNAA -0 Standard -0.mm -0.0mm GNAB -0 Standard -0.mm -0.0mm GNAC -0 Standard -0.mm -0.0mm *Bearing, Large Standard -0 GNAA -0 GNAB -0 GNAC.mm Undersize -0 GNAA -0 GNAB -0 GNAC.0mm Undersize -0 GNAA -0 GNAB -0 GNAC 0-0 Key -0 Pinion, Crankshaft Housing, Center Bearing (Includes Cap Screw and Dowel) -0 GNAA -0 GNAB -0 GNAC Screw, Cap (M x 0mm) -00 GNAA -00 GNAB -00 GNAC Dowel -0 GNAA -0 GNAB -0 GNAC Tube, Locating -0 GNAA -0 GNAB -0 GNAC Rod Assy, Connecting (Includes Rod, Bolt and Small Bearing) -0 GNAA -0 GNAB -0 GNAC Bolt, Connecting Rod -0 GNAA -0 GNAB -0 GNAC Bearing, Small -00 GNAA -00 GNAB -00 GNAC +Piston Assy (Includes Pin, Piston, Circlip and Ring Set) Standard -0 GNAA -0 GNAB -0 GNAC.0mm Oversize -0 GNAA -0 GNAB -0 GNAC 0 Circlip -0 GNAA -0 GNAB -0 GNAC Ring Set, Piston Standard -0 GNAA -0 GNAB -0 GNAC.0mm Oversize -0 GNAA -0 GNAB -0 GNAC.00mm Oversize -0 GNAA -0 GNAB -0 GNAC * Parts Included in Crankshaft Assy. + Piston Pin Not For Sale Separately.

20 Camshaft Camshaft Assy (Includes Gearwheel & Thrust Plate) -0 GNAA - GNAB -0 GNAC -0 Washer, Spring (M) -0 Screw, Set (M x mm)

21 Flywheel -00 Flywheel (Includes Ring Gear) -0 Gear, Ring - Plug, Banking - Dowel - Screw, Hex Head Cap (M0 x mm) - Screw, Self-Lock Set (M x mm) - Housing, Flywheel

22 Cylinder Head

23 Cylinder Head Head Assy, Cylinder (Includes Parts Marked *) -0 GNAA -0 GNAB -0 GNAC *Plate, Valve Spring -0 GNAA -0 GNAB -0 GNAC *Seal, Valve Stem -0 GNAA -0 GNAB -0 GNAC *Spring, Valve -0 GNAA -0 GNAB -0 GNAC *Carrier, Valve Spring -00 GNAA -00 GNAB -00 GNAC *Cotter, Valve -0 GNAA -0 GNAB -0 GNAC -0 *Valve, Exhaust *Valve, Inlet - GNAA - GNAB - GNAC *Insert, Exhaust Valve -00 GNAA -00 GNAB -00 GNAC 0 *Insert, Inlet Valve -00 GNAA -00 GNAB -00 GNAC *Guide, Valve -0 GNAA -0 GNAB -0 GNAC Gasket Set, Cylinder Head (Includes either 0., 0. or 0.mm) -0 GNAA - GNAB - GNAC Bolt (M0) -0 GNAA -0 GNAC - Bolt (M0) -0 GNAA, GNAB -0 GNAC -00 Nut, Hex (M x.) -00 GNAA, GNAB -00 GNAC - Eye, Lifting - GNAA, GNAB - GNAC Nut (M) -0 GNAA -0 GNAB -0 GNAC Lever, Rocker (Includes Pivot) - GNAA -0 GNAB -0 GNAC Bolt (M0) -0 GNAA -0 GNAB -0 GNAC 0 Spacer -0 GNAA -0 GNAB -0 GNAC Rubber, Head Sealing Tube -0 GNAA -0 GNAB -0 GNAC Rod, Push -0 GNAA -0 GNAB -0 GNAC Tube, Push Rod Sealing -0 GNAA -0 GNAB -0 GNAC Rubber, Sealing Tube -00 GNAA -00 GNAB -00 GNAC Washer -0 GNAA -0 GNAB -0 GNAC Tappet, Hydraulic -0 GNAA -0 GNAB -0 GNAC O Ring -0 GNAA -0 GNAB -0 GNAC Nut - GNAA - GNAB - GNAC -0 Cap, Oil Fill (DNAF) 0 Cover, Cylinder Head - GNAA GNAB - Single Cover - Double Cover GNAC - Single Cover - Double Cover

24 Cylinder Head

25 Cylinder Head -0 O Ring, Oil Fill Cap (DNAF) Gasket, Head Cover - GNAA - GNAB - GNAC - Kit, High Oil Fill (Includes Parts Marked +) -0 +Cap, Oil Fill -0 +O Ring -0 +Cover, Cylinder Head - +Gasket, Cover

26 Gear End Cover DNAD - Cover, Gear End - Gasket, Cover - Seal, Rear Crank Oil - Dowel -0 Screw, Hex Head Cap (M x x 0mm) -0 Washer (M)

27 Alternator (Spec A) 0 - Alternator (V, A) (Includes Nut and Washer for Mounting Pulley) -0 Bracket, Adjusting - Spacer - Screw, Hex Head Cap (M x 0mm) -0 Bolt (M x 0mm) - Washer (M) -0 Washer, Spring (M) - Nut, Hex (M x.) - Pulley 0 Belt - Plug, Connector - Spacer -0 Spacer - Screw, Hex Head Cap (M x 0mm)

28 Alternator (Begin Spec B) 0 0 Alternator (Includes Nut and Pulley) - Nut, Hex (M x.) - Washer, Spring (M) 0 Pivot, Front Spacer 0 Bolt (M x 00mm) Spacer - Belt Bracket, Adjusting - Washer (M) 0 Bolt 0 M x. x mm 0 M x. x 0mm - Screw, Hex Head Cap (M x mm)

29 This Page Intentionally Left Blank.

30 Electronic Governor 0 0

31 Electronic Governor - Actuator, Electronic Governor (Includes Nut)) -* Nut (M x mm) -0 Screw, Hex Head Cap (M x 0mm) - Washer, Lock (M) - Nut, Hex (#0-) - Washer, Spring (/ ) - End, Male Rod (/ ) - Clevis - End, Female Rod (/ ) 0 - Screw, Fillister Head Machine (#0- x /) Carburetor Spec A - Propane - Natural Gas Begin Spec B GNAA - Natural Gas - Propane GNAB - Natural Gas - Propane GNAC - Natural Gas - Propane - Gasket, Flange - Bracket, Governor Actuator -0 Nut, Hex (M x ) - Washer, Spring (/ ) - Screw, Hex Head Cap (/- x. ) - Bracket, Governor Controller - Pick-Up, Magnetic (/- x ) - Washer, Spring (M) 0-0 Screw, Hex Head Cap (M x. x 0mm) -0 Controller, Electronic Governor - Screw, Hex Machine (#0- x / ) -0 Kit, Carburetor Repair (Includes Air-Gas Valve Assy, Sealing Ring, Check Valve Plate, Throttle Body to Mixer Gasket, Screw (0- x / ) Idle Cutoff Piston, Idle Cutoff Spring, Instruction Sheet) * Not Sold Separately, Included with Actuator.

32 Regulator (Spec A) Valve, Magnetic Gas - Nipple, Close (/ NPT) - Elbow, Reducing - Nipple, Pipe (/ NPT x. Lg) - Regulator, Propane (C0) - Regulator, Natural Gas (C00) -0 Screw, Hex Head Cap (M x. x 0mm) - Washer, Spring (M) - Bracket, Gas Regulator Support Adapter, Brass - Tube Assy, Fuel (/ x -/ ) - Adapter - Adapter, Brass -0 Tube Assy, Balance (/ x -/ )) - Elbow, 0 (/ NPT) - Nipple, Close (/ NPT x Close) 0

33 Regulator (Begin Spec B) Valve, Magnetic Gas - Nipple, Close (/ NPT) 0-0 Elbow, 0 (/ NPT) 0-0 Nipple (/ x ) - Coupling, 0 (/ NPT to / NPT -0 Terminal, Fully Insulated (/ ) -0 Brace, Fuel/Air Breather Support -0 Clamp, Pipe (/ ) - Washer (/ ) 0 - Washer, Spring (/ ) - Washer, Flat (M) 00-0 Screw, Hex Head Cap (M x. x 0mm) Nipple -0 / NPT x -/ Lg 0-00 / NPT x -/ Lg -0 Barb, Hose (/ NPT to / Hose) - Clamp, Hose (.-. OD) -00 Hose (/ ID x Lg) Nipple (/ NPT x Close) 0-00 Plug, Square Head (/ NPT) 0-00 Nipple, Coupled (/ NPT Close) 0-0 Tee, Reducing (/ x / x / ) Bracket, Fuel System GNAA, GNAB GNAC Regulator GNAA - Natural Gas -0 Propane GNAB - Natural Gas - Propane GNAC - Natural Gas - Propane

34 Primary Ignition 0 Harness, Ignition - GNAA -0 GNAB - GNAC Nut, Hex (0-) - GNAA - GNAB - GNAC - Spacer - Washer - Screw, Hex Head Cap (M x. x 0mm) Screw, Fillister Head Machine (0- x / ) - GNAA - GNAB - GNAC Washer, Spring (/ ) - GNAA - GNAB - GNAC - Plate, Ignition - Screw, Hex Head Cap (M x x mm) 0-0 Washer - Spacer Control, Ignition -0 GNAA -0 GNAB -0 GNAC - Screw, (M x x mm) - Washer, Fan -00 Washer, Retaining -0 Rotor, Ignition

35 Secondary Ignition 0 Lead, High Tension - GNAA ( ) - GNAB ( ) GNAC - - Plug, Spark - GNAA - GNAB - GNAC Screw, Hex Head Cap (M x 00mm) - GNAA - GNAB - GNAC Washer, Lock (M) - GNAA - GNAB - GNAC Nut, Hex (M x.) - GNAA - GNAB - GNAC Bracket, Coil - GNAA - GNAB - GNAC Nut, Hex (M x mm) -0 GNAA -0 GNAB -0 GNAC Bracket, Coil - GNAA - GNAB - GNAC Screw, Hex Head Cap (M x. x mm) - GNAA - GNAB - GNAC 0 Washer, Spring (M) - GNAA - GNAB - GNAC Coil, Ignition -00 GNAA -00 GNAC -0 Coil, Ignition - GNAB

36 Starter Components 0 - Starter (.kw) - Kit, Starter Brush - Switch - Clutch - Armature - Frame, Commutator End -0 Housing - Bearing, Commutator End - Bearing, Pinion End - Screw, Socket Head Cap (M0 x. x mm) 0 - Washer, Spring (M0) - Nut, Hex (M x.) - Washer, Spring (M)

37 Starter Valve (Begin Spec D) REF PART QTY PART NO. NO. USED DESCRIPTION 0 Kit, Starter Aid(Fittings Included) 0 Hose, Vacuum 0 Harness, Starter Aid

38 Blank Page

39 Breather System (Spec A) 0 - Cleaner, Air (Element Not Replaceable) - Clamp, Hose - Sleeve, Transition - Sleeve, Hose - Clamp, Hose (/ ) - Hose (/ ID x Long) - Restrictor - Breather - Clip, Hose 0 - Hose, Inlet - Clamp, Hose - Hose, Drain - Bracket, Breather - Washer (M) - Bolt (M x mm)

40 Breather System (Spec B) 0

41 Breather System (Spec B) -0 Hose (/ ID x Lg) - Clamp, Hose (/ ) - Breather - Screw, Hex Head Cap (M x. x mm) - Washer, Flat (M) -0 Screw, Hex Head Cap (M x. x 0mm) - Clamp, Hose (. -. OD) -00 Hose (/ ID x 0 Lg) -0 Bracket, Fuel/Air Breather 0-0 Spacer (mm Lg) 00-0 Screw, Hex Head Cap (M0 x. x 0mm) -0 Washer, Plain (/ ) -0 Hose (/ ID x 0 Lg) - Sleeve, Transition - Clamp, Hose - Sleeve, Hose ( ID x -/ Lg) - Cleaner, Air (Element Not Replaceable)

42 Breather System (Begin Spec C), 0 Breather, Crankcase 00 *Elbow *Clamp, Hose 00 Hose Cap Clamp, Hose Sleeve,Transition 0 Plate, Fuel Lift Pump Blanking 0 Gasket, Blanking * Included in Breather, Crankcase 0

43 Heavy Duty Air Cleaner (Spec A) 0 0, - Cleaner Assy, Air (-/ ) (Includes Element) - Element, Air Cleaner - Nut, Hex (M x.) -000 Band, Mounting - Clamp, Hose - Hose, Elbow - Sleeve, Hose ( ID x -/ Lg) -0 Hose, Elbow -0 Screw, Hex Head Cap (M x. x 0mm) 0-0 Washer, Lock (M) - Bracket, Air Cleaner

44 Blank Page

45 Heavy Duty Air Cleaner (Begin Spec B) 0, - Cleaner Assy, Air (-/ ) (Includes Element) - Element, Air Cleaner - Nut, Hex (M x.) -000 Band, Mounting - Clamp, Hose Hose, Elbow - Sleeve, Hose ( ID x -/ Lg) -0 Hose, Elbow 0 Screw, Hex Head Cap (M x. x 0mm) 0 - Washer, Lock (M) -00 Spacer - Washer, Flat

46 Water Pump 0 0

47 Water Pump - Outlet, Thermostat - Plate, Mounting - Sender, Temperature (Used With Detector Control) - Gasket - O Ring - Sleeve - Stud (M x mm) - Clip, Hose - Cap 0 - Switch, Water Temperature (Used With all Controls for Spec A, Used with Manual and Remote Controls for Begin Spec B) -0 Gasket - Pump, Water (Puller Not Sold Separately) -00 Bolt, Crankshaft Pulley - Pulley, Crankshaft -00 Nut, Hex (M x.) - Washer (M) - Bolt (M x mm) - Nut, Fan - Bolt (M x mm) 0 - Thermostat (0 F) -0 Gasket - Bolt (M x 0mm)

48 Oil Pump -00 Pump, Oil -0 Valve, Oil Relief -0 Strainer, Oil -0 GNAA, GNAB -0 GNAC -0 Screw, Hex Head Cap (M x x mm) -0 Washer (M) - Spacer - Washer (M) - Screw, Hex Head Cap (M x mm) - Nut, Lock (M)

49 Extended Oil Level Indicator Kit, Extended Oil Level Indicator - GNAA - GNAB, GNAC -0 Oil Level Indicator (Includes O Ring) -0 O Ring -0 Screw -0 Bracket -0 Grommet Tube -0 GNAA -0 GNAB, GNAC

50 Radiator

51 Radiator 0-0 Kit, Radiator Duct Adapter (Includes Adapter, Screws and Washers) - Adapter, Radiator Outlet Duct Screw, Hex Head Cap Spec A GNAA W/O Adapter (M x x mm) W/Adapter M x x mm - M x x mm GNAB, GNAC W/O Adapter (M x x mm) W/Adapter M x x mm - M x x mm Begin Spec B Washer, Flat (M) (Spec A) GNAA - W/O Adapter - W/Adapter GNAB, GNAC - W/O Adapter - W/Adapter - Washer, Flat (M0) - Screw, Hex Head Cap (M0 x. x 0mm) Cowl, Radiator Spec A GNAA --00 Green --0 Sandstone GNAB, GNAC - Green --0 Sandstone Spec B C -0 GNAA - GNAB, GNAC - Valve, Drain - Gasket, Drain Plug - Plug, Drain 0 - AR Screw, Hex Head Cap Cover, Radiator Support (Unhoused Units) - Spec A - Spec B C Washer, Flat (M) - Spec A - Spec B C Kit, Radiator (Includes Parts Marked *) - GNAA - GNAB, GNAC *Radiator - GNAA -0 GNAB, GNAC - *Cap, Radiator *Hose, Top - GNAA -0 GNAB, GNAC -0 *Clip, Hose *Hose, Bottom -0 GNAA -0 GNAB, GNAC 0-00 Bushing (/ x / NPT) 0 Switch, Low Coolant (S) Fan, Radiator - GNAA - GNAB, GNAC -0 Nut, Fan -0 Spacer, Radiator - Bracket, Right Guard (Spec A) - Bracket, Left Guard (Spec A) - Guard, Left Fan (Spec A) - Guard, Right Fan (Spec A) - Guard, Bottom Right Fan (Spec B C) - Guard, Top Right Fan (Spec B C) 0-0 Guard, Top Left Fan (Spec B C) - Guard, Bottom Left Fan (Begin Spec B) - Plate, Alternator Adjustment (Spec B C) * Parts Included in Radiator Kit.

52 Radiator (Begin Spec D) Washer, Flat (/ ) Washer, Flat (M) Washer, Flat (M0) Screw, Hex Head Cap (M x.0 x mm) 00 Guard, Radiator (Top LH) 0 Guard, Radiator (Bottom LH) 0 Guard, Radiator (Top RH) 0 Guard, Radiator (Bottom RH) 0 Panel, Radiator HSG 0 Screw, Hex Head Cap (M x. x mm) Screw, Hex Head Cap (M0 x. x 0mm) 0 Radiator 0 Clip, Hose 0 Hose, Bottom 0 Hose, Top Radiator, Cap 0 Shroud, Fan 0 U Nut Washer, Lock (M0) 0 Nut, Hex (M0 x.mm) 0 Screw, Hex Head Cap (M x. x 0mm) 0 Washer, Nylon Flat 0 Plug, Bottom ( Dia) 0 Senor, Level (Coolant) 0 Bushing (/ x /NPT) 0

53 Coolant Heater 0, Kit, Coolant Heater V (H0) /0V (H0) - Clamp, Hose (/ ) - Clamp, Tubing (/ ) - Barb, Hose - Barb, 0 Hose - Elbow, Street (/ ) - Washer, Flat Spring (M) Heater, Coolant (Includes Thermostat and Element) V /0V -0 Thermostat, Coolant Heater Element, Coolant Heater -0 0V -0 0/0 - Adapter, Cylinder Head - Bracket, Heater 0 - Bend, Hose Hose - GNAA ( ) - GNAB ( ) - GNAC ( ) -0 Nut, Hex (M x ) - Screw, Hex Head Cap (M x x mm) - Washer, Flat - Fitting, Conduit (/ ) - Screw, Self Tapping (# x / )

54 Manifold 0 0 Manifold, Exhaust (Includes Manifold Gaskets) -00 GNAA - GNAB -00 GNAC Gasket, Exhaust Manifold -0 GNAA -0 GNAB -0 GNAC Stud (M) -0 GNAA -0 GNAB -0 GNAC Nut (M x ) -0 GNAA -0 GNAB -0 GNAC - Plug, Heater (Includes Screw) - Screw - Restrictor, Inlet Manifold (Includes Decal) Manifold, Inlet 00 GNAA 00 GNAB 00 GNAC Gasket, Inlet Manifold -0 GNAA -0 GNAB -0 GNAC 0 Bolt (M x x mm) -0 GNAA -0 GNAB -0 GNAC Washer (M) -0 GNAA -0 GNAB -0 GNAC

55 Muffler -0 Kit, Industrial Muffler (Includes Parts Marked *) Cap, Rain Spec A (-/ ) - * Industrial - Critical - Begin Spec B( ) Muffler Spec A - * Industrial - Critical - Begin Spec B(Critical) - GNAB -0 GNAC - *Screw, Hex Head Cap (M0 x. x 0mm) - *Washer, Flat (M0) - *Gasket, Muffler (Fibre) - *Washer * Parts Included in Industrial Muffler Kit.

56 Blank Page

57 Exhaust Flanges 0-0 Kit, Unthreaded Exhaust Flange (Includes Gasket, Flange and Screw) -0 Kit, Threaded Exhaust Flange (Includes Gasket, Flange and Screw) - Kit, Flexible Exhaust Pipe (Includes Parts Marked *) - Gasket - Flange, Exhaust -0 Screw, Hex Head Cap - Gasket -0 Flange, NPT Exhaust - Screw, Hex Head Cap (M0 x. x 0mm) - *Gasket 00 *Washer, Flat 00 0 *Screw, Hex Head Cap (M0 x mm) 0 0 *Tube, Exhaust - *Flange, Mating * Parts Included in Flexible Exhaust Pipe Kit.

58 Mounting Base

59 Mounting Base Kit, Skid Base (Spec A) (Includes Parts Marked +) 0- GNAA 0- GNAB Base, Mounting Spec A Green - Begin Spec B Screw, Hex Head Cap -0 + Spec A (M0 x. x 0mm) - Begin Spec B (/- x -/ ) - +Nut, Hex (M0 x.) - 0 +Washer, Spring (M0) Mount Engine + Spec A -0 GNAA -0 GNAB -0 GNAC Spec B C GNAA, GNAB GNAC - +Screw, Hex Head Cap (M0 x. x 0mm) - +Washer, Rebound -0 +Foot, Sliding Green -0-0 Sandstone 0 - +Washer, EIT (/ ) - +Screw, Hex Head Cap (M x. x mm) -0 +Cable, Ground - +Screw, Hex Head Cap (M x. x mm) - +Nut, Hex (M x.) -0-0 Plug, Hole (Begin Spec B) -0-0 Plug, Hole (Begin Spec B) -0 +Washer, Spring (M) -0 +*Bolt, Hold-Down (/-0) - +*Cap 0 - +*Hose (/ ID x ) - +*Hold-Down, Battery Cable, Positive Battery + Spec A - GNAA - GNAB, GNAC Spec B C - GNAA - GNAB - GNAC +Cable, Negative Battery - GNAA - GNAB, GNAC -0 Brace, Rear Engine - Nut, Hex (/ ) - Washer, Spring (/ ) - Screw, Hex Head Cap (M0 x. x 0mm) - Washer, Spring (/ ) -0 Washer, Spring (M) 0 - Nut, Lock (M x.) -0 Plate, Front Engine - Screw, Hex Head Cap (M x. x mm) -0 Kit, Battery Vent Hose (Includes Parts Marked * and Washers/Nuts) -0 Block, Terminal (Use With Detector Control) -0 Jumper, Terminal Block (Use With Detector Control) -00 Nut, Hex (M x.) (Use With Detector Control) (Use With Detector Control) - Bracket, Mounting (Use With Detector Control) - Washer, Spring (M) (Use With Detector Control) + Parts Included in Skid Base Kit (Spec A) * Parts Included in Battery Vent Hose Kit.

60 Mounting Base (Begin Spec D)

61 Mounting Base (Begin Spec D) 00 Base Skid 0 Steel, Cold Rolled Commercial Washer, Rebound Isolator, Vibration GNAA and GNAB GNAC Nut, Hex (M0 X.MM) 0 Washer, Flat (M0) Screw, Hex Head Cap (M0 x. x 0mm) 0 Screw, Hex Head Cap (/ x ) Washer, Tooth 0 0 Cable, Ground Screw, Hex Head Cap (M x. x mm) Screw, Hex Head Cap (M x. x mm) Nut, Hex (M x.) 0 Washer, Lock (M) Hold Down, Battery 0 Bolt, Battery Hold Down Cable, Positive Battery Cable, Negative Battery 00 Nut, Hex (/ ) Washer, Lock (/ ) Hose (/ ID ) Cap 0 Bolt, Carriage (/ x ) Screw, Hex Head Cap (M x. x mm) Screw, Hex Head Cap (M0 x. x 0mm) Nut, Lock (M x.) 0 Mount, Engine (LH Rear) 00 Mount, Engine (RH Rear) 0 Plate, (Front Engine) 0 0 Washer, Flat (M) Washer, Flat (M0)

62 Housing (F) (Spec A) 0 0 0

63 Housing (F) (Spec A) Kit, Housing (Includes Parts Marked *) 0- GNAA (Includes Parts Marked *) 0- GNAB, GNAC (Includes Parts Marked *) - +*Panel, Rear --00 Green --0 Sandstone *Panel, Top GNAA --00 Green --0 Sandstone GNAB, GNAC --00 Green --0 Sandstone *Door, Housing Green -0-0 Sandstone - +*Cover, Battery --00 Green --0 Sandstone - +*Strut, Right Side Housing --00 Green --0 Sandstone - +*Strut, Left Side Housing --00 Green --0 Sandstone - +*Latch, Lockable Lever 0- +*Knob, Air Cleaner 0- +*Clip, Door *Rivet, Pivot Block *Washer, Rivet 0-0 +*Pin, Door Pivot - +*Screw, Hex Head Cap (/-0 x / ) - +*Washer, Flat Spring (M) - Washer, Flat (M) - +*Screw, Hex Head Cap (M x. x mm) - Washer, Spring Flat (M0) - +Screw, Hex Head Cap (M0 x. x 0mm) -0 +Plug, Button ( ) 0-0 +Screw, Hex Head Cap (M x. x 0mm) - +Spacer - Coupling, Pipe * Parts Included in Housing Kits.

64 Housing (F, F) (Begin Spec B) Plug, Button ( ) Screw, Hex Head Sems (M x. x 0mm) - Cap, Rain - Shield, Rain Panel, Top - GNAA - GNAB, GNAC - Latch - Panel, Door -000 Washer, Flat (#) 0- Clip, Door 0-00 Rivet, Drive (/) - Panel, Rear 0- Knob - Cover, Battery - Washer (M) -0 Screw, Hex Head Cap (M x. x 0mm) 0-0 Rivet, Pivot Block - Washer, Flat (M) - Screw, Hex Head Cap (/-0 x / ) - Strut, Housing (Left) 0-0 Strut, Housing (Right)

65 Housing (F, F) (Spec B C) 0 - Panel, Top (See Separate Page for Components) - Duct, Front (F) (See Separate Page for Components) - Panel, Door - Seal, Sound (0mm) - Strut, Housing (Left) --0 Seal, Sound (0mm) - Washer (M) -0 Screw, Hex Head Cap (M x. x 0mm) --0 Gasket (0mm) 0-0 Strut, Housing (Right) - Insulation, Door - Latch -0-0 Rivet, Pop - Support, Insulation 0- Clip, Door -000 Washer, Flat (#) -00 Rivet, Drive (/) - Duct, Rear (F) (See Separate Page for Components) - Panel, Rear (See Separate Page for Components)

66 Housing (F, F) (Begin Spec D) 0 - Panel, Top (See Separate Page for Components) - Duct, Front (F) (See Separate Page for Components) 0 Panel, Door 0 Insulation, Door Panel - Seal, Sound (. ) 0 0 Plug, Hole 0 0 Plug, Hole 0 Washer, Rubber (/ I.D.) Latch 0 - Duct, Rear (F) (See Separate Page for Components) - Panel, Rear (See Separate Page for Components)

67 Housing - Top Panel (F, F) (Spec B C) 0 Panel, Top - GNAA - GNAB, GNAC Screw, Hex Head Sems (M x. x 0mm) - Cap, Rain -0 Button, Plug ( ) - Shield, Rain - Insulation, Front Top - Support, Insulation --0 Gasket (mm) Rivet, Pop Type I, II Control (Mnl/Rmt) -0-0 Type III Control (Detector) 0 - Insulation (Used With Manual/ Remote Controls Only - Type I, II) - Support, Insulation (Used With Manual/Remote Controls Only - Type I, Type II) --0 Seal, Sound (mm) (F) --0 Seal, Sound (0mm) (F)

68 Housing - Top Panel (F, F) (Begin Spec D) 0 Panel, Top 0 GNAA 0 GNAB, GNAC Screw, Hex Head Sems (M x. x 0mm) -0 Cap, Rain(-/ to -/ I.D.) -0 Button, Plug ( ) - Shield, Rain (mm I.D.) 00 Insulation, Front Top --0 Gasket (mm) 0 Insulation, Rear Top --0 Seal, Sound (mm) (F) Seal, Sound (0mm) (F)

69 Housing - Front Duct (F) (Spec B C) Duct, Front -00 GNAA, GNAB - GNAC Rivet, Pop -0-0 GNAA, GNAB GNAC Screw, Hex Head Sems (M x. x 0mm) Strut, Duct --0 GNAA, GNAB --0 GNAC - Insulation, Duct - Support, Insulation (Front) - Baffle, Front Duct GNAC -0 Washer, Plain (#0)GNAC

70 Housing - Front Duct (F) (Begin Spec D) Duct, Front 0 GNAA 0 GNAB, GNAC Screw, Hex Head Sems (M x. x 0mm) 0 Insulation, Front Duct Washer, Flat (M). Seal, Sound. Gasket

71 Housing - Rear Panel (F) (F GNAA, GNAB) (Spec B C) 0 Screw, Hex Head Sems (M x. x 0mm) F Housing F Housing - Panel, Rear 0- Knob, Air Cleaner --0 Gasket (mm) -0-0 Rivet, Pop (F) --0 Gasket (0mm) Cover, Battery F - GNAA, GNAB - GNAC - F GNAA, GNAB --0 Gasket (0mm) -0 Support, Rear Insulation (F) 0 - Insulation, Rear Duct (F) -0 Duct, Rear (F) --0 Seal, Sound (mm) 0-0 Rivet, Pivot Block - Washer, Flat (M) - Screw, Hex Head Cap (/-0 x / ) - Washer, Flat (M) -0 Screw, Hex Head Cap (M x. x 0mm)

72 Housing - Rear Panel (F GNAC) (Spec B C) Gasket (0mm) - Screw, Hex Head Cap (M x x 0mm) - Nut, Hex (M x ) - Washer, Split Lock (M) --0 Gasket (0mm) - Panel, Rear --0 Gasket (0mm) - Panel, Rear -0-0 Rivet, Pop Gasket (mm) Screw, Hex Head Sems (M x. x 0mm) --0 Seal, Sound (mm) --0 Seal, Sound (mm) -0 Washer, Plain (M0) - Support, Insulation - Insulation, Rear Duct 0-0 Hinge - Duct, Rear --0 Seal, Sound (mm) Rivet, Pivot Block - Washer, Flat (M) - Screw, Hex Head Cap (/-0 x / ) - Washer, Flat (M) -0 Screw, Hex Head Cap (M x. x 0mm) -0-0 Rivet, Pop (F) 0

73 Housing - Rear Panel (F) (F) (Begin Spec D) 0 Panel, Rear 0 Duct, Rear 0 Insulation, Rear Duct GNAA and GNAB Screw, Hex Head Sems (M x. x 0mm) 0 Nut U (M x.mm) Gasket ( ) 0 Washer, Nylon Flat (M) Washer, Flat (M)

74 Blank Page

75 Housing - Rear Panel (F) (Begin Spec D) 0 Panel, Rear 00 0 Screw, Hex Head Cap (M x. x 0mm) 0 Nut, U (M x.) 0 Insulation, Rear Duct 0 Duct, Rear (GNAB and GNAC) 0 Insulation, Rear Duct Gasket (.0 ) 0 Washer, Nylon Flat (M) Washer, Flat (M)

76 Generator 0 0

77 Generator Stator (Includes Grommet) Single Phase 0--0 GNAA 0--0 GNAB 0--0 GNAC Three Phase Up to 0V Standard Stack 0--0 GNAA 0--0 GNAB 0--0 GNAC Extended Stack 0--0 GNAA 0--0 GNAB 0--0 GNAC + 00V (Standard Stack) 0--0 GNAA 0--0 GNAB 0--0 GNAC 0-0 Grommet Rotor Assy (Includes Parts Marked *) Single Phase 0--0 GNAA 0--0 GNAB 0--0 GNAC Three Phase Standard Stack (B) 0--0 GNAA 0--0 GNAB 0--0 GNAC Extended Stack (B) 0--0 GNAA 0--0 GNAB 0--0 GNAC 0--0 *Rotor, Exciter --0 *Disc, Drive *Fan, Generator --0 *Spacer, Drive Disc 0-0 *Bearing, Ball -0- *Washer, Flat (#0) *Nut, ET Hex (#0) -0- *Washer, Flat (M) *Bolt, Hex Head Cap (M x. x 0mm) Stud Extended Stack GNAA GNAB GNAC Standard Stack GNAA GNAB GNAC Screw, Hex Head Cap (M0 x. x 0mm) Nut, Hex (/-) -0- Washer, Flat (/ ) -0 Endbell 0--0 Stator, Exciter 0-0 O Ring, Seal Screw (/-0) Washer, Lock (/ ) -0-0 Cover, Inlet Screw, Lock Head Flange (/- x. ) - Pin, Dowel * Parts Included in Rotor Assy. + Extended Stack Not Available in 00V.

78 Overspeed Detector Spec A C Screw, Hex Head Cap (/- x -/) - Spacer -0 Rotor, Ignition -0 Washer, Flat (/ ) 00- PCB Assy, Overspeed -0 Screw, IT Cross Recessed (#- x / ) Washer, Lock (/ ) -0- Screw, Pan Head Machine (M x. x mm) 0-00 Washer, Lock (M) Nut, Hex (M x.)

79 Generator Heater Heater Assy, Generator (Includes Heater and Splice) V /0V Heater, Control (0V) V /0V - Splice, Window ( Gauge) Cable, Control Heater -00 0V -0 Screw, Hex Washer Head (M x x.) - Plate, Heater Mounting - Cover, Heater

80 Control Manual (Type I) Remote (Type II) (Spec A) 0 thru 0 0, 0 0 0

81 Control Manual (Type I) Remote (Type II) (Spec A) Box Assy, Control (Includes Parts Marked *) -0 Manual - Remote - *Harness, Voltage Sensing -0 *Box, Control 0- *Breaker, Circuit (DC) (Remote (Includes Mounting Hardware /- Thread) - *Screw, Fillister Head Machine (M x. x mm) - *Block, AC Terminal - *Grommet - *Relay (Remote) 0- *Timer, Control Unit (Remote) 0 *Nut, Lock (M) - Manual - Remote -0 *Holder, Fuse -0 *Fuse - *Panel, Control 0-0 *Regulator, Voltage *Switch, On/Off/Start - Manual - Remote - *Boot, On/Off/Start Switch *Relay, Fault 0--0 Manual 0--0 Remote - *Plug, Plastic (Preheat) - *Plug, Plastic (Manual) 0 *Washer (#) - Manual - Remote - *Nut (/) (Remote) *Nut (M) - Manual - Remote - *Block, DC Terminal - *Diode Assy, Zener (.V, W) (Remote) - *Resistor Assy, Metal Oxide (Remote) - *Washer (mm) (Remote) -0 *Diode Assy (Manual) - *Cover, Control Box - 0 *Washer, Flat Spring (M) 0-0 *Screw, Hex Head Cap (M x 0mm) - +Switch, Off/On Toggle - +Seal, Switch - Harness, Engine *Harness, Panel - Manual - Remote * Parts Included in Control Box Assy. + Parts Included in Manual Preheat Kit Listed on Preheat Kit Page.

82 Control Manual (Type I) Remote (Type II) (Spec B C),, 0 0,,, 0

83 Control Manual (Type I) Remote (Type II) (Spec B C) - Box, Control Screw (M x. x 0mm) -0-0 Manual -0-0 Remote 0--0 Relay (Remote) Screw, Hex Head Sems (M x. x mm) - Block, AC Terminal 0- Bushing, Nylon 0- Timer, Control Unit (Remote) Nut, Nylon Lock (M) Manual Remote - #Block, DC Terminal 0 - Strip, Marker 0-0 Nut, Hex (M) -000 Washer, EIT Lock (/ ) #Relay, Fault (K) 0--0 Manual 0--0 Remote -0 Plug, Plastic (Manual Only) -0 Plug, Plastic -0 Holder, Fuse -0 Fuse (0A) (F) 0-00 Meter, Hour (Remote Only) Switch, On/Off/Start (S) 0-0 Manual 0-0 Remote 0 - Panel, Control 0-0 Regulator, Voltage (VR) 0--0 Breaker, Circuit (DC) (Remote Only) (Includes Mounting Hardware /- Thread) - Cover, Control Box Screw, Hex Head Sems (M x x mm) - Harness, Engine (Includes Diode, Zener, and Resistor) -000 #Diode (CR) -0 Zener (CR) 0-00 Resistor (0O, W, %) Harness, Control (Includes Parts Marked #) - Manual - Remote # Parts Included in Control Harness.

84 Aux Relay Board (Manual/Remote Control) (Spec B C) K K 0 r -0-0 Panel, Relay 0--0 Relay (K, K) (V) Screw, Hex Head Sem (M x 0. x mm) 0-0 Nut, ET Sems 0-0 Standoff, Male/Female Hex (#0-) Screw, Hex Head Sems - Harness, Control Harness, Dry Contact (Includes Parts Marked) - AR *Plug, Cavity 0 - *Housing, Connector ( Pin) -0 AR *Terminal, Socket -0 AR *Seal, Cable * Parts Included in Dry Contact Harness.

85 Control Box Back Panel Manual (Type I) Remote (Type II) (Spec A) Breaker, Circuit Pole, 0V A 0--0 A A 0--0 A A 0--0 A A 0--0 A A 0--0 A 0-- 0A 0-- A 0-- 0A 0-- A 0-- 0A 0-- A 0-- 0A 0-- A A Pole 0V A 0--0 A A 0--0 A A 0--0 A A 0--0 A A 0--0 A 0-- 0A 0-- A 0-- 0A 0-- A 0-- 0A 0-- A 0-- 0A 0-- A A 00V A 0--0 A A -0 Screw (M x x 0mm) - Washer, Flat (M) Washer, Lock (#) - Pole Circuit Breaker - Pole Circuit Breaker Screw (#- x / ) - Pole Circuit Breaker - Pole Circuit Breaker Washer, Flat (#) - Pole Circuit Breaker - Pole Circuit Breaker Panel, Control Box Back - W/O Circuit Breaker Hole W/Circuit Breaker Hole -0 Pole Circuit Breaker - Pole Circuit Breaker

86 Blank Page

87 Control Box Back Panel Manual (Type I) Remote (Type II) (Spec B C) Breaker, Circuit Pole, 0V A A A A A A A A A A A A A A Pole 0V A A A A A A A A 00V 0-- A 0-- 0A A - Nut, Nylock (M x 0.) (W/ Pole Circuit Breaker) -0 Screw, Hex Head Cap (M x 0. x mm) (W/ Pole Circuit Breaker) Panel, Control Box Back (W/Circuit Breaker Hole) - Pole Circuit Breaker - -0A (All Sets) - 0-A (DNAE, DNAF Only)(GNAC Only) Pole Circuit Breaker - 0V Sets - 00V Sets Screw, Hex Head Cap (M x x mm) - Pole CB (and W/O CB) - Pole CB - Panel, Control Box Back (W/O Circuit Breaker Hole) Bracket, Circuit Breaker (W/ Pole CB) --0 0V Sets V Sets - Washer, Flat (M) (W/ Pole CB)

88 Circuit Breaker Panel (Begin Spec D) 0 0

89 Circuit Breaker Panel (Begin Spec D) Assy Panel, Circuit Breaker 00 Pole 0V (Includes Parts Marked *) 0 Pole 00V Includes Parts Marked +) 0 Pole 0A (Includes Parts Marked #) 0 Panel, Blank (Includes Parts Marked %) 0 %Panel, Circuit Breaker 0 +Panel, Circuit Breaker 0 *Panel, Circuit Breaker 00 #Panel, Circuit Breaker #%+* Screw, Hex Head Cap (M x.0 x mm) *+Washer, Flat M 0 00 *+Breaker, Circuit 0 00 #Breaker, Circuit 0 *+Screw (M x. x 0mm) 0 ^#*+Nut, Nylon (M x.mm) 0 #Screw, Hex Head Cap (M x. x mm)

90 Blank Page

91 Control Mount Manual (Type I) Remote (Type II) 0 - Saddle Mount, Vibration - Cylinder - / Cylinder - Washer, EIT (/ ) - Screw (M x. x mm) -0 Nut, Hex (M x ) - Washer, Spring (M) - Strap, Ground - Washer, EIT (/ ) - Washer, Flat (M) 0 - Washer, Lock (M)

92 Control (Begin Spec D) 0 0

93 Control (Begin Spec D) 0 Assy. Control (Includes Saddle and Box) 00 Saddle, Control Box 00 Cover, Control Washer, Tooth (/ ) Screw, Hex Head (M x. x mm) 0 Sleeve, Insulation Cable, Ground 0 0 Nut,Hex (M) Washer, Lock (M) 0 0 Washer, Flat (M) Washer, Tooth (/ ) 00 Washer, Star (M) Mounting, Vibration 0 Screw, Hex Head Cap (M x.0 x 0mm) 0 Transformer, Current

94 Control Assembly (Begin Spec D)

95 Control Assembly (Begin Spec D) 0 Assy Panel, Display Control (Includes Parts Marked +) 0 Assy Panel, Metered Control (Includes Parts Marked *) Panel, Control 00 +Panel, Control 00 *Panel, Control 00 +*Cover, Control Box 0 0 +*Plug 0 +*Fuse, Holder 0 0 +*Fuse, 0A 0 0 +*Fuse, A 0 0 +*Fuse, 0A 00 +Control, Display Panel 0 0 *Switch, Rocker *Hour, Meter *Label, Information 00 +*Harness, Genset +*Screw, Hex Head Cap (M x.0 x ) +*Washer, Flat (M) 0 +*Cable, Ground +*Blocks, Power Dist. +*Screw, Hex Head Cap (M x 0. x mm) 00 +*Washer, Flat (M) *Nut, Hex (M) *Washer, Star (M) 0 +*Board, PCC0 Control 00 +*Bushing, Plastic 0 +*Relay, VDC 0 +*Block, Terminal (M) 0 +Label, Ground Symbol 00 +Label, Information 0 Relay, Control (VDC) 0 Rail, Terminal 00 Washer, Flat Nut, Hex (M x.mm) Bracket, End + Part Included in Assembly 0 * Part Included in Assembly 0

96 Meter Panel Manual (Type I) Remote (Type II) (Spec A) 0 thru Kit, Meter Panel or 0-0 Amps or 0-00 Amps - Screw, Hex Head Cap (M x x 0mm) - Washer (M) Box, Control (Includes Parts Marked +) --0 A Ammeter --0 0A Ammeter --0 0A Ammeter A Ammeter - +Screw, Hex Head Cap (M x x 0mm) - +Washer (M) 0-0 +Switch, Phase Selector (Includes Knob) 0-0 +Knob, Selector Switch 0- +Meter, Volt +Ammeter 0-0 /0A 0-0/00A Meter, Frequency -00 +Washer (/ ) -00 +Nut, Hex (/-) - + Box, AC Control -00 +Nut (-0) -0 +Washer (#) - +Cover, AC Control +Transformer, Current W/-0A Ammeter W/0-00A Ammeter - +Harness, Wiring + Parts Included in Control Box.

97 Meter Panel Manual (Type I) Remote (Type II) (Begin Spec B) Screw, Hex Head Sems (M x x mm) 0-0 Switch, Phase Selector (Includes Knob) 0-0 Knob, Selector Switch 0- Meter, Volt Ammeter 0-0 /0A 0-0/00A 0- Meter, Frequency - Washer (/ ) -00 Nut, Hex (/-) Box, AC Control Nut (-0) Cover, AC Control Transformer, Current W/-0A Ammeter W/0-00A Ammeter - Harness, AC Control

98 AC Detector Control (Type III) (Spec A)

99 AC Detector Control (Type III) (Spec A) - Strip, Marker Screw, Hex Head Cap (M x x mm) -00 Screw, Round Head Machine (#-0 x / ) -0 Washer, Nylon Retainer 0-0 Nut, ET Hex (#-0) Meter, AC Volt (M) 0- Up to 0V 0-00V 0- Meter, Frequency (M) -0 Lamp, Over/Under (DS, DS) - Bracket, Lamp Switch, Rotary (Volt & Ammeter) -0 Bracket, Switch --0 Harness, Control (Includes the Following Indented Parts) -00 Holder Assy, Fuse -00 Block, Terminal -000 Screw, Lock Head Flange (#0- x / ) 0--0 Relay -0 Plate, Relay --0 Connector, Receptacle ( Pin) --0 Connector, Receptacle ( Pin) - Plug, Connector 0- Resistor Assy - Wedge, Receptacle -0 Pin, Contact -0 Housing, PCB ( Pin) Contact, Socket -0 Housing, Connector ( Pl) -0 Housing, Connector ( Pl) - Cover, Meter 0-0 Nut, Acorn (/-) -00 Screw, IT Phillips Cross Recessed (#- x / ) -000 Washer, ET Lock (#) 0-0 Gasket, Switch -0-0 Screw, Pan Head Machine (M x 0. x mm) 0-0 Regulator Assy, Voltage (VR) (Includes Parts Marked *) *Regulator, Voltage (VR) -0 *Block, Terminal (0 Place) 0-0 *Plate, Voltage Regulator Mounting - *Harness, Regulator -00 *Screw (#- x ) - *Strip, Marker -00 *Screw (#- x / ) 0-0 *Channel, Rubber 0--0 Breaker, Circuit (CB) 0-0 Potentiometer (R) 0-0 Screw, ET Pan Head (#0- x / ) Ammeter (M) 0-0-0, , 0-0 * Parts Included in Voltage Regulator Assy.

100 AC Detector Control (Type III) (Begin Spec B) ÂÂÂÂ

101 AC Detector Control (Type III) (Begin Spec B) -00 Box, Control Screw, Pan Head Cross Recessed (#0- x / ) -000 Washer, EIT Lock (/ ) -00 Screw, Hex Head Cap (/- x / ) 0-0 Isolator, Vibration -00 Strap, Ground -00 Screw, Hex Head Cap (/- x / ) 0-00 Washer,Spring Lock (/) 0-0 Receptacle, Fastener 0-00 Nut, Hex (/-0) -00 Washer, Flat (/ ) 0-00 Grommet (Fits Hole) - Strip, Marker Screw, Cross Recessed Thread Forming (#- x / ) -00 Block, Terminal ( Place) (TB) - Harness, AC Control Door (Includes Terminal Block) ( Wire, ) (TB, GND to GND, M,,, S, DS,) -0 Light, Upper/Lower Indicator Scale (DS,) 0-0 Regulator, Voltage Screw, Cross Recessed (#0- x / ) 0-0 Jumper 0- Resistor Assy 0--0 Breaker, Circuit 0-0 Potentiometer -0 Capacitor, Voltmeter (. Mfd., 00 WVDC) (C) 0-0 Nut, Hex (#-0) Voltmeter, AC (M) / Ammeter, AC (M) , , Meter, Frequency (M) Door, AC Control Screw, Hex Washer Head Self- Locking (#0- x / ) -00 Grommet (Fits -/ Hole) 0-0 Stud, Fastener 0-0 Washer, Stud Retainer -000 Washer, ET Lock (#0) 0-0 Switch, Rotary (Voltmeter/Am meter (Includes Handle) (S) -0-0 Screw, Round Head Machine (M x mm) 0-0 Handle, Rotary Switch - Harness, Terminal Block ( Wire, ) (Includes Connector Plug and Sockets) (P to TB) --0 Plug, Connector (P) 0 - Socket, Contact - Harness, AC Aux - AR Pin, Terminal --0 Housing, Plug

102 00 DC Detector Control (Type III) (Spec A)

103 DC Detector Control (Type III) (Spec A) 00- PCB, Gauge Cover, Control Box -0 Box, Control --0 Panel, Control Bolt, Hex Head Cap (M x x 0mm) 0-00 Nut, Hex (M x.) -0 Gasket, Hinge -0 Gasket, Side -0 Gasket, Top 0-0 Gasket, Cover -000 Washer, ET Lock (#0) - Block, Terminal - Gasket, Terminal Block 0-0 Nut, ET Hex (#0-) -00 Screw, Round Head Machine Slotted (#0- x. ) -000 Washer, Flat (#0) 00- Board, Engine Monitor (V, Light) -000 Lamp (V) (DS) -0 Light, Panel (DS) Lamp Assy (V, Light) (A) (Includes the Following Indented Lights) -0 Run (Green) -0 Pre Lo Oil Pres (Amber) -00 Pre Hi Engine Temp (Amber) -00 Lo Oil Pres (Red) -00 Hi Engine Temp (Red) -0 Overspeed (Red) -00 Overcrank (Red) -00 Lo Engine Temp (Amber) -0 Lo Fuel (Amber) -0 Switch Off (Red) -0 Blank (Red) -0 Blank (Amber) -0 Washer, Flat (/ x / x /) 00- Board, Time Delay Start/Stop /Preheat (V) -00 Screw, IT Round Head Machine Cross Recessed (#- x / ) 0-0 Nut, ET Hex (#-) -0 Gauge, Water Temperature (M) -0 Gauge, Oil Pressure (M) 0- Meter, Volt (V) (M) 0-0 Meter, Running Time (M) 0-0 Nut, ET Hex (#-0) Switch, Run/Stop/Remote (S) 0-00 Switch, Reset/Lamp Test (S) -00 Washer, Flat Brass (#0) Washer, Lock (#0) Nut, Hex Brass (#0-) -00 Washer, Nylon -0 Washer, Nylon Retainer 0- Nut, Captive Floating -0 Gasket, Cover (Sides) -000 Washer, Flat (#) Washer, ET Lock (#) - Harness, Engine 0

104 DC Detector Control (Type III) (Begin Spec B) Screw, Pan Head Cross Recessed (#- x / ) Board, PC Sensor Board (A) -000 Screw, Hex Washer Head Self- Locking (#0- x / ) 00- Board Assy, PC Engine Monitor (Includes Fuses) (A) Fuse Amp (Tan) (F, F) Amp (Light Blue) (F) Amp (Yellow) (F, F) 0-0 Nut, ET Hex (#0-) -000 Washer, ET Lock (#0) -00 Clip, Wire -000 Bulb, Panel Replacement Light 0-0 Light, Panel (DS) 0-00 Switch, Rocker (Lamp Test/Reset Panel Lamp) (S) 0-0 Switch, Rocker (Run/Stop/Re mote) (S) -0 Gauge, Oil Pressure (M) -0 Gauge, Water Temperature (M) 0- Meter, Voltage (M) Door, DC Control -00 Plug, Hole (Fits Hole) -0 Plug, Hole (Fits / Hole) 0-00 Meter, Hour (M) Nut, ET Hex (#-) -0 Screw, Round Head Machine (#- x / ) Light Assy, Indicator (Includes Wiring Harness and Connector Housing) (A) -0-0 Light, Replacement Indicator - Harness, DC Control Door (Includes Connector Housing and Contact Pins) ( Wire, ) (AJ to GND, M,,,, S,, DS) -0 Housing, Connector (J) -0 Pin, Contact 0

105 Detector Control Engine Harness (Begin Spec B) 0 - Harness, Engine -0 Contact, Socket -- Connector, Housing (J) ( Pin) -0 Seal, Cable - Connector, Housing ( Pin) -0 Socket, Terminal - Plug ( Pin) - Wedge, Plug ( Pin) --0 Bracket Assy, Terminal (T) 0--0 Relay (V) 0 - Connector, Plug - AR Wedge, Plug (P) ( Pin) -000 AR Rectifier, Silicon (A, 00V) -- Resistor ( Ohms, W) -00 AR Socket, Contract -0 Housing, Connector ( Pl) -0 Housing, Connector ( Pl) - Plug, Pin (P) 0

106 0 Detector Control Mount (Type III) (Spec A) (GNAA, GNAB) - Washer, Flat (M) - Saddle, Detector Box Mounting - Rail, Front Detector Box Support - Rail, Rear Detector Box Support (Use W/Single Wall Fuel Tank) - Rail, Rear Detector Box Support (Use W/Dual Wall Fuel Tank) - Screw, Hex Head Cap (M x. x mm) -0 Screw, Hex Head Cap (M x. x 0mm) - Washer, Spring (M) - Washer, EIT (/ ) 0 - Screw (M x. x mm) 0

107 This Page Intentionally Left Blank. 0

108 Detector Control Mount (Type III) (Begin Spec B), 0,,, 0, 0

109 Detector Control Mount (Type III) (Begin Spec B) - Bottom, Control Box -0 Screw, Hex Head Cap (M x. x 0mm) - Washer, Flat (M) (Rear Mounted Brackets) -0 Screw, Hex Head Cap (M x x mm) - Washer, Flat (M) Nut, Hex (M x.) - For Rear Mounted Brackets - For Front and Middle Mounted Brackets - Bracket, Control Saddle - Bracket, Control Saddle - Washer, Spring Lock (M) 0-0 Nut, Hex (M) - Washer, Flat (/ ) - Block, Terminal -0 Washer, Flat (M) Screw, Hex Head Cap Thread Cutting (M x. x mm) -0 Edging ( ) - Cover, Control Housing - Top, Control Box Housing Screw, Hex Head Cap (/- NC x / ) -0 Screw, Hex Head Thread Cutting (/- x / ) 0-0 Washer, Flat (/ ) -000 Nut, Hex (/-) - Cable, Ground -000 Nut, Hex (/-0) -00 Clamp, Tubing (-/ ) Transformer W/0-00A Ammeter W/-0A Ammeter 0

110 Detector Control Circuit Breaker (Begin Spec B) 0 0

111 Detector Control Circuit Breaker (Begin Spec B) Bracket, Mounting - Pole CB Pole CB - 0V Sets V Sets Breaker, Circuit Pole, 0V A A A A A A A A A A A A A A Pole 0V A A A A A A A A 00V 0-- A 0-- 0A A - 0 Washer, Flat (M) -0 0 Screw, Hex Head Cap (M x.0 x mm) Nylock (M x 0.) - Single CB - Dual CB Screw, Hex Head Cap (M x 0. x 0mm) -0 Single CB -0 Dual CB Panel, CB W/Circuit Breaker Pole - Single CB - Dual CB Pole CB 0V Sets - Single CB - Dual CB 00V Sets -0-0 Single CB - Dual CB - Cover, Control Housing (W/O Circuit Breaker) - Washer, Flat (M) 0-0 Screw, Hex Head Cap (M x x mm) 0

112 Output Box Detector Control (Type III)

113 Output Box Detector Control (Type III) -0 Panel, Control Box Side - Block, AC Terminal -0 Harness, AC Generator (Includes Wedge and Plugs) - Wedge, Plug ( Pin) --0 Plug ( Pin) - Plug, Connector - Cover, Control Box 0--0 Transformer, Current -000 Washer, EIT Lock Washer, Spring Lock 0-0 Nut, Hex 0-0 Grommet Screw, Hex Head (M x 0.) -0 Screw, Lock Flange - Washer, Lock (M) - Washer, Spring (M) -0 Nut, Hex (M x ) - Screw, Hex Head Cap (M x. x mm) - Screw, Hex Head Cap (M x. x ) 0 - Washer, EIT (/ ) - Washer, Flat (M) Without Circuit Breaker, Use: - Plate, Cover - Screw (#- x / ) - Washer, Flat (#) - Washer, Lock (#) With Circuit Breaker, Use: - Nut, Lock (M x ) - Cover, CB - Plate, CB Cover (Use With Pole CB Only) - Washer, Lock (#) 0 - Screw (#- x / ) Breaker, Circuit Pole 0--0 A A 0--0 A A 0--0 A A 0--0 A A 0--0 A 0-- 0A 0-- A 0-- 0A 0-- A 0-- 0A 0-- A 0-- 0A 0-- A A Pole 0--0 A A 0--0 A A 0--0 A A 0--0 A A 0--0 A 0-- 0A 0-- A 0-- 0A 0-- A 0-- 0A 0-- A A 0--0 A A

114 Control Assembly (Begin Spec D)

115 Control Assembly (Begin Spec D) 0 Assy Panel, Display Control (Includes Parts Marked +) 0 Assy Panel, Metered Control (Includes Parts Marked *) Panel, Control 00 +Panel, Control 00 *Panel, Control 00 +*Cover, Control Box 0 0 +*Plug 0 +*Fuse, Holder 0 0 +*Fuse, 0A 0 0 +*Fuse, A +*Cable, Ground 0 0 +*Fuse, 0A 00 +Control, Display Panel *Switch, Rocker 0 00 *Hour, Meter *Label, Information 00 +*Harness, Genset +*Screw, Hex Head Cap (M x.0 x ) +*Washer, Flat (M) 0 +*Cable, Ground +*Blocks, Power Dist. +*Screw, Hex Head Cap (M x 0. x mm) 00 +*Washer, Flat (M) *Nut, Hex (M) 00 +*Washer, Star (M) 0 +*Board, PCC0 Control 0 +*Bushing, Rubber 00 +*Bushing, Plastic 0 +*Relay, VDC 0 +*Block, Terminal (M) 0 +Label, Ground Symbol 00 +Label, Information 0 Relay, Control (VDC) 0 0 Rail, Terminal 00 Washer, Flat 0 00 Nut, Hex (M x.mm) Bracket, End + Part Included in Assembly 0 * Part Included in Assembly 0

116 Control Heater Kit, Control Heater 00-0V (Includes Parts Marked *) 0V 00- W/O Cord (Includes Parts Marked +) W/Cord (Includes Parts Marked + and #) - +*Mount, Cable Tie Heater Assy, Control (Includes Heater, Rectifier and Splice) * 0V V Heater, Control (0V) V V -0 Rectifier, Power - Splice, Window ( Gauge) Cable, Control Heater -0 * 0V -0-0 # 0V #*Screw, Hex Head Cap (/- x /) 0-0 #*Nut, Self Locking Hex (/-) -000 #*Washer, Lock EIT (/) * Parts Included in 0V Control Heater Kit. + Parts Included in 0V Control Heater Kits W/ and W/O Cord. # Parts Included in 0V Control Heater Kit W/Cord.

117 Gauge Panel Manual (Type I) Remote (Type II) 0-0 Kit, Temperature/Voltmeter Meter/Gauge -0 Gauge, Temperature -0 Meter, Volt -0 Panel, Double Gauge -00 Mount, Flexible -0 Washer, Spring 0 Nut -0 Bracket, Mounting -0 Spacer Screw, Hex Head Cap - Washer, Spring (M0) 0-0 Sender, Temperature -0 Harness, Wiring

118 Gasket Sets +Set, Decarbonizing Gasket (Includes Parts Marked *) - GNAA - GNAB -0 GNAC Gasket, Cylinder Head Cover - GNAA - GNAB - GNAC *O Ring, Cylinder Head Cover -0 GNAA -0 GNAB -0 GNAC Gasket, Cylinder Head.0mm.mm.mm *Gasket, Inlet Manifold -0 GNAA -0 GNAB -0 GNAC *Gasket, Exhaust Manifold -0 GNAA -0 GNAB -0 GNAC *Rubber, Bottom Sealing Tube -00 GNAA -00 GNAB -00 GNAC *Rubber, Top Sealing Tube -0 GNAA -0 GNAB -0 GNAC *Washer, Sealing Tube Rubber -0 GNAA -0 GNAB -0 GNAC *Washer, Injector (No Hole in Center) - GNAA - GNAB - GNAC - #*Washer, Injector (Hole in Center) - #*Seal, Valve Stem *Seal, Valve Stem - GNAA - GNAB - GNAC -0 *Gasket, Water Pump - *O Ring, Water Pump - *Gasket, Water Pump Mounting Plate -0 *Gasket, Thermostat Housing Set, Overhaul Gasket (Includes all listed in Decarbonizing Set Plus Parts Marked +) - GNAA - GNAB - GNAC - #+Gasket, End Cover (Cork) - +Gasket, End Cover (Paper) +Gasket, Crankcase Door -00 GNAA -0 GNAB -0 GNAC -0 +Gasket, Fuel Lift Pump +Shims, Main Bearing Housing -0.mm -0.0mm - +O Ring, Speed Control - +Washer, Speed Control (M) - +Washers, Fuel Filter +Seal, Oil -0 Flywheel End - Gear End # Discard. * Parts Included in Decarbonizing Gasket Set. + Parts Included in Overhaul Gasket Set.

119 Labels - Label, Caution Label, Control Panel (Start/Run/Off) -0 Manual -0 Remote - Label, Danger (Hazardous Voltage --0 Label, Logo -0 Label, Loose Leads Label, On/Off/Start Switch -0 Remote - Label, Phase Selection Label, Reconnection Diagram - Spec A Begin Spec B - Manual/Remote Control --0 Detector Control - Label, Switch -0 Label, Warning (Voltage) - Label, Warning (Automatic Start --0 Label, Warning (Rotating Parts) - Label, Warning (Backfeed Utility) 0--0 Label, Warning (Skid Lift) --0 GNAB --0 GNAC -0-0 Label, Warning (Operation, Maintenance, Service Risk) Made In England - Label, Voltage Disconnect 0 0 Label, Home Standby Model ID GNAC

120 Blank Page

121 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 00000, 0 0, 0, 0 0, 0, 0, 0 0, 0 0 0, 0 0, 0, 0 0, 0, 0 0, 0, 0, 0, 0,, 00 0, , 00 0, 00 0, 00 0, 00 0, 00 0, 00 0, 00 0,,,, 0 0, 0 0,,, 0,, 0, 0, 0, 0,, 0,, 0, 00, 00, 00, 00,, 00,, 00, 00, 00, 00,, 00, 0 0,, 0, 0, 0, 0, 0, 0, 0 0, 0 00, 0 0, 0, 0, 0, 0, 0, 0,,, 0, 0, 00, 0, 0, 0, 0, 00, 0, 0,, 0, 0, 0, 0, 0, 0, 00, 00,, 0,, 0, 0, 0, 0,, 0,,, 0,, 0, 00,, 0,, 0, 0, 0, 0, 0, 0 0, 0 0, 0, 0,, 0, 00, 00, 00, 00, 00, 00, 00,, 0,, 0,, 0,,,,, 0, 0,,, 0,,,, 0 00,,, 0, 0, 0,,, 0,, 0, 0, 0,, 0,, 00, 0, 0, 0, 0, 0,, 0, 0, 0,, 0, 0 0, 0, 0, 0, 0, 00, 0, 0, 0, 0, 0, 0, 0, 0, 00, 0, 0, 0,, 0,, 0,, 0,,,,, 0,, 0, 0 0,, 0,, 0, 0,

122 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0, 0, 0, 0, 00, 0, 0, 0, 0, 0, 0, 00, 0, 0, 0, 0, 0, 0, 0, 00,, 0,, 0,, 0, 0, 0, 0, 0, 0,,,,,,,,,,,,,,, 0,,, 0,,,,,,,,,,,,,, 0,, 0,,,,, 0 0,, 0, 0,, 0, 0,, 0,,,, 0,, 0, 0,,,,, 0,,,,,,,,,,,,,, 0, 0,,,,, 0 00, 00 00, 0, 0, 0, 0, 0,, 0 0, 0 00, 0 0, 0, 0, 0, 0, 0, 0, 0, 0, 0 0, 0, 0, , 0 0,, 00, 0,, 00, 0, 00, 0,, 00, 0,, 00, 0,, 0,,,, 0,, 0,, 0 0,, 0, 0, 0, 0,, 0 0,,, 0, 0, 0, 0, 0, 0 0, 0, 0, 0, 0,, 00, 0 0, 0 00, 0,,, 0, 0, 0,, 0 0, 0, 0, 0,, 0,, 0 0,,,,,,,, 0

123 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0,,,,,,,,,,, 0,, 0, 0, 0, 0, 0, 0, 0,,,, 0,,,, 0,,,,, 0,,,,,,, 0, 0,,,,,, 0,,, 0,,,,,,,,,,, 0,, 0 0,,,, 0,,, 0, 0,,, 0,, 0,,,,,,,,,,,,, 0, 0, 0,,,,,,,,,,, 0 0,, 0, 0,, 0,, 0,,, 0, 0,, 0,,,,,,,,, 0,,, 0,,,,,,, 0, 0, 0 0, 0, 0,,, 0, 0,,, 0,,,,, 0,,,,, 0,,,, 0,, 0,, 0,,, 0,, 0,, 0,, 0 0,,,,,, 0,, 0,, 0,,,, 0,,, 0,,,,, 0,, 0 0, 0, 0 0, 0, 0, 0, 0, 0,,,,, 0,,, 0, 0, 0, 0, 0,,,, 0, 0, 0, 0,, 0,,, 0, 0, 0, 0,, 0 0,,,,, 0,, 0,, 0, 0 0, 0, 0,,, 0, 0, 0, 0,, 0, 0, 0

124 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page, 0,,,,,, 0,,,,,, 0,,, 0, 0, 0, 0, 0, 0, 0,,, 0,, 0, 0, 0, 0, 0 0, 0,,,,, 0,,,,,,,,,,, 0,,,,, 0, 0, 0,,,,,,, 0,,,,, 0,, 0,,,, 0,,,, 0,,,, 0, 0, 0,,, 0,,,,,,, 0, 0,,, 0,, 0,,,,,, 0,,,, 0, 0, 0,,, 0,, 0,,,,,,,,,, 0,,,,,,, 0,, 000,, 00, 00, 00, 00, 00, 00, 00, 00, 00, 00, 0 0, 0, 0, 0, 0, 0, 0, 0, 0, 00, 0, 0, 0, 0, 0, 0, 0, 0 0, 00, 0, 0, 0, 0, 0, 0, 00,, 0, 0, 0 0,, 0, 0, 0, 00, 0, 0, 0, 0, 0 0, 00,, 0 0, 0 0, 0, 0 0, 0 0, 0 0, 0, 0 00, 0 0, 0 0,, 0 0, 0 00, 00, 0, 0 0, 0 0, 0 0,,,,, 0, 0

125 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page,, 0, 0, 0 0, 0,,, 0, 0, 0, 0, 0, 0, 0,,,,,,,,, 0, 0,,,,,,, 0,,,,, 0, 0, 0,, 0, 0 0, 0, 0, 0, 0, 0, 0,,, 0, 0, 0,, 0,,,, 0,,, 0, 0, 0 0, 0, 0, 0, 0, 0, 0,,,,, 0,,,,,,, 0,,, 0, 0, 0 0, 0, 0, 0, 0 0, 0, 0, 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0 0, 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0,, 0, 0 0, 00, 0 00, 0, 0 00, 0 00, 00, 00, 00 0, 00 0, 00 0, , , , , 00 0, 00 0, 00 0, 00,, 0 0 0, , 0 0 0, 0 0,,,, 00 0,,,, 00 0, 0, 0 0,, 00 0,,,, , 0 00,,, 0, 0 0,,,, ,,, ,,, 0 0 0,, , 0,, , 0 0, 0 0, 0 0,, 0 0, 0 0, 0,,, 0 0 0, 0, 0, 0,, 0 00, 0, 0 0 0,, 0, 0 0 0,,,, , 0 0,,, , 0 0,, 00 0, 0 0, 0 0,

126 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page,,,, 0, 0, 0 00, 00 0,,, 0,,,,,, 0 0,, 0, 0, 0 0 0, 0, 0 0, 0 0,, 0,,, 0, 0, 0, 0 0, 0 0 0,, , 0 0, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0,, 0,, 0,, 0,, 0,, 0,, 0, 0, 0, 0 0, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0,, 0,, 0,, 0,, 0,, 0,, 0,, 0,, 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, 0 0,, , ,, ,, ,, ,, ,, ,, ,, ,, ,, ,, ,, ,, ,, ,, , ,, ,, ,, ,, ,, ,, ,, ,, 0 0, 0,,, 0, , , , 0 0 0,, 0 0,, 0 0,, 00, 0, 000, 0, 0 00, 0 00, 0 00, 0 00, 0 0, 0 0, 0 0, 0 0, 0 0, 0 00, 0 0, 0 0, , 0, 0 0, 0, 0 0,, , 0 00, , 0,, 0, 0 0,, 0 0,, 0 0,, 0, 0, 0, 0, 0, 0, 0,,,, 0, 0, 0, 0, 00 0, 00, 00, 00 0,, 0 0,, 0,,, 0 0,, 00, 0 00,, 00 0,,, 0,

127 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0,, 00,,,, 00,, 0,,, 0, 0,, 0,,, 0,, 0, 0,,, 0, 0, 0, 00 0,, 00 0,, 0 0, 0 0, 0 0, 0 0, 00, 0, 0 0, 00, 00, 00 0, 0,, 0, 00,,,,,, 0,, 00, 0 00, 0,, 00, 0 0, ,, 0 0, 0, 0 0, ,, ,, 0 0, 0, 0,,, 0, 0, 0 0, , , , 0, 0 00, , 0 00, 0 000, 0 00, 0 00, 0 0, 0 0, 0 00, , 0 0, 0 0, 0, 0 0, 0 0, 0,, 0 0, 0 0,, 0 0,, 0 0,, 00, 0 00, , , , , 000, 0 000,,, 000, 0 00, 00 00, 00, 0 0, 0, 0 0, 0, 0, 00, 0 0,, 0 00,, 00 00, 0, 00 0, 00 00, , , , 00 00, 00 0, 00 0, , 00 0, 00 0, 0 00, 00, 00, 00, 00, 0 0, 0 0, 0 0, 00,, 0 0, 0, 0, 0 0,, , , , 00,,, 0 0,, 0, 0 0,,, 000 0, 000, 00, 0 00, , 0, 000 0, 00 0, 00 0, 00 0, 0,,, 00 0, ,,,,,, 0,,, 0 000, , , 0 0 0, 0 00, , 0 0, 000, 000, 0 000, 00, 0, 0 00,,, 000,, 000, 00,

128 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 00, 0 00,, 0, 0 0,, 000, 0 000, , 00, 0 0 0,, 0, , 0 0, 0, 0 0 0, 0 0,,, 0, 0 0, 0 0,,, 00, , 0, 0 0 0, 000, 0 00, 00 0, 0 0, 0 0, 0 0, 0 0, 0 0,