SERVICE PARTS MANUAL

Transcription

1 INCLUDES ITEMS SERVICE PARTS MANUAL GASOLINE POWERED UTILITY VEHICLES ISSUED DATE APRIL 2006 REVISED DATE JULY 2008

2

3 SERVICE PARTS MANUAL GASOLINE POWERED UTILITY VEHICLES E-Z-GO ST 480 E-Z-GO ST 480 (CAMO) JACOBSEN 4800 STARTING MODEL YEAR DISCLAIMER: The E-Z-GO Division of Textron Inc. reserves the right to incorporate engineering and design changes to products in this Manual, without obligation to include these changes on units leased/sold previously. The information contained in this Manual may be revised periodically by the E-Z-GO Division, and therefore is subject to change without notice. The E-Z-GO Division DISCLAIMS LIABLITY FOR ERRORS IN THIS MANUAL, and the E-Z-GO Division SPECIFICALLY DISCLAIMS LIABILITY FOR INCI- DENTAL AND CONSEQUENTIAL DAMAGES resulting from the use of the information and materials in this Manual. CUSTOMER SERVICE DEPARTMENT IN USA PHONE: FAX: OUTSIDE USA PHONE: , FAX: TEXTRON GOLF, TURF & SPECIALTY PRODUCTS, P.O.BOX 388, AUGUSTA, GEORGIA USA Page i

4 NOTES To obtain a copy of the limited warranty applicable to the vehicle, call or write a local Distributor, an authorized Branch or the Warranty Department with vehicle serial number and manufacture date code. The use of non Original Equipment Manufacturer (OEM) approved parts may void the warranty. Tampering with or adjusting the governor to permit vehicle to operate at above factory specifications will void the vehicle warranty. When servicing engines, all adjustments and replacement components must be per original vehicle specifications in order to maintain the United States of America Federal and State emission certification applicable at time of manufacture. BATTERY PROLONGED STORAGE All batteries will self discharge over time. The rate of self discharge varies depending on the ambient temperature and the age and condition of the batteries. A fully charged battery will not freeze in winter temperatures unless the temperature falls below -75 F (-60 C). Page ii

5 TABLE OF CONTENTS SECTION Page No. HOW TO USE THE SERVICE PARTS MANUAL v ILLUSTRATED PARTS BREAKDOWN vii ACCELERATOR A-1 AIR CLEANER B-1 BODY C-1 BRAKES D-1 PARK BRAKE E-1 CLUTCH F-1 DIRECTION SELECTOR G-1 ELECTRICAL SYSTEM H-1 ENGINE J-1 FRONT SUSPENSION K-1 FUEL SYSTEM L-1 REAR AXLE M-1 REAR SUSPENSION N-1 SEATS P-1 STARTER / GENERATOR Q-1 STEERING R-1 TRUCK BED S-1 WEATHER PROTECTION T-1 WHEELS AND TIRES U-1 WINCH W-1 OPTIONS/ACCESSORIES APPENDIX A-1 Page iii

6 TABLE OF CONTENTS Notes: Page iv

7 HOW TO USE THE SERVICE PARTS MANUAL This manual is divided into several sections: GENERAL INFORMATION TABLE OF CONTENTS HOW TO USE THE SERVICE PARTS MANUAL ILLUSTRATED PARTS BREAKDOWN Contains illustrations and parts lists for all systems of the vehicle APPENDIX Contains a listing of specialty products and options/accessories USE OF THE MANUAL To use this manual, consult the TABLE OF CONTENTS (page iii) to locate the information or illustration required. Introduction of some revisions varies due to supply of components; therefore, it is possible that various combinations of components may be found that are not directly reflected by each illustration. Consult the illustration that best suits your situation. Locate the serial number plate (see BODY located in the Illustrated Parts Breakdown section of this manual for its location) and note the complete number shown on the plate. It is important that the serial number of your vehicle and its model number be supplied to Service Parts when ordering any replacement components. Locate the serial number plate (see BODY located in the Illustrated Parts Breakdown section of this manual for its location) and note the complete number shown on the plate. Page v

8 ,87 67 Front of Vehicle 83,88 81,86 84, , *See Body Section for decal information 79 HOW TO USE THE SERVICE PARTS MANUAL Title Title 62 - Includes Items 63-66, Includes Items Includes Items Includes Items Includes Items 95, Includes Items Includes Items Includes Items Left hand illustration page (continued on right hand page if required) Parts list (continued on rear of page if required) 1. WHEN THE PART NUMBER IS NOT KNOWN Determine the function and application of the part required. Turn to the INDEX OF MAJOR COMPONENTS and select the most appropriate component description. Turn to the page number indicated and locate the part description in the parts list. Read the full accompanying description for specific information regarding the part that was not shown in the index. From the parts list, obtain the item number assigned to it and confirm that the part selected is correct by verifying it with the pictorial representation on the illustrated page. 2. IF YOU KNOW THE PART NUMBER Use the INDEX OF MAJOR COMPONENTS to find the page(s) the part number appears on. Turn to the page number indicated and locate the part number in the parts list. Refer to the accompanying description for specific information regarding the part. From the parts list, obtain the item number assigned to it and confirm that the part selected is correct by verifying it with the pictorial representation on the illustrated page. Should an asterisk (*) appear in the part number column on the parts list page, read upwards until a part number is found. The part number is the lowest assembly sold by Service Parts. The asterisk (*) indicates that the part depicted is not available for purchase. NOTE: Descriptions are indented under the assembly that they are used on. That assembly is, in turn listed under the assembly that it is used on. This process is repeated until the highest final assembly is reached. To facilitate the maintenance and repair of the vehicle, a Technician s Repair and Service Manual is available from the Service Parts Department. Page vi

9 ILLUSTRATED PARTS BREAKDOWN ILLUSTRATED PARTS BREAKDOWN Page vii

10 ACCELERATOR 1 - Includes Items Includes Items Includes Items 42, To Chassis Harness To Rear Axle Part of Frame Page A-1

11 ACCELERATOR 62 To Choke To Throttle 67 - Includes Items Includes Items To Pedal Box Accelerator Cable Page A-2

12 ACCELERATOR When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G03 PEDAL BOX ASSEMBLY (INCLUDES ITEMS 2-44) G02 ACCELERATOR PEDAL BRACKET G01 SCREW, #8-16 X 1/2" LG G02 PEDAL BOX AND COVER G6 SCREW, #8-32 X 3/4" LG (STAINLESS STEEL) G01 MICRO SWITCH G02 SCREW, #4-20 X 1 1/8" LG G01 CONTROL ARM G1 BEARING G1 NYLON WASHER, 5/16" G1 PUSH NUT, 5/16" G01 PIVOT ROD G01 PIVOT BRACKET G1 LOCK NUT, 3/ G03 MICRO SWITCH CAM G1 LOCK NUT, 5/ G3 SETSCREW, 1/4-20 X 3/8" LG G01 CONTROL ARM LINK G01 SHOULDER BOLT, #10-24 X 11/16" LG G4 NUT, 5/ G1 SPRING RETAINER, 1/2" G1 ACCELERATOR ROD BUSHING G01 COMPRESSION SPRING, 3/8" G2 SPRING RETAINER G01 ACCELERATOR ROD G4 CLEVIS YOKE (ADJUSTABLE) G3 CLEVIS PIN, 5/16" X 13/16" LG G1 NYLON BUSHING... 3 Page A-3

13 ACCELERATOR When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G1 TEFLON WASHER, 5/16" G3 COTTER PIN, 3/32" X 3/4" LG G01 PEDAL PIVOT PIN G01 PUSH NUT, 5/16" G10 LOCK NUT, # G02 WIRE HARNESS (PEDAL BOX) G01 ACCELERATOR CABLE G8 WASHER, 5/16" G03 ACCELERATOR PEDAL ASSEMBLY (INCLUDES ITEMS 41-44) G01 ACCELERATOR PEDAL PAD KIT (INCLUDES ITEMS 42-43) G1 OVAL RIVET, 3/16" X 3/8" LG * ACCELERATOR PEDAL PAD * ACCELERATOR PEDAL G01 PEDAL PIVOT COVER G2 BOLT, 5/16-18 X 13/16" LG G2 BOLT, 1/4-20 X 1 1/4" LG G7 WASHER, 1/4" G01 CHOKE PIVOT LEVER G1 BALL JOINT G5 LOCK NUT, # G01 BUSHING G1 TORSION SPRING G7 SPACER, 9/16" G4 LOCK NUT, 1/ G01 CHOKE AND GOVERNOR CABLE BRACKET G2 LOCK WASHER, 7/16" G7 BOLT, 7/16-14 X 7/8" LG... 2 Page A-4

14 ACCELERATOR When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 CHOKE LINK G01 CHOKE CABLE G01 GOVERNOR CABLE G01 GOVERNOR BELLCRANK ASSEMBLY (INCLUDES ITEMS 68-80) G01 GOVERNOR BELLCRANK G1 BALL JOINT G5 LOCK NUT, # G4 LOCK NUT, 1/ G2 GOVERNOR BRACKET ASSEMBLY (INCLUDES ITEMS 73-80) G1 GOVERNOR BRACKET G1 GOVERNOR ROD G1 BUSHING G01 CUP WASHER G1 COMPRESSION SPRING G2 BUSHING G1 GOVERNOR ADJUSTER G4 NUT, # G4 SETSCREW, 1/4-20 X 1/2" LG G01 SPRING G1 SAFETY SEAL, 3/8" G3 PUSH NUT, 3/16" G01 ACCELERATOR CABLE BRACKET G01 LOCK WASHER, 8 MM G01 NUT, M8 X 1.25 MM G01 WIRE AND TUBE RETAINER, 3/8" CAPACITY... 1 Page A-5

15 ACCELERATOR When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 PLATE G6 BOLT, 1/4-20 X 3/4" LG G7 WASHER, 1/4" G2 LOCK NUT, 1/4-20 (STAINLESS STEEL)... 4 Page A-6

16 AIR CLEANER Front of Vehicle Side Panel (Passenger Side) Page B-1

17 AIR CLEANER THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 INLET ADAPTER G01 GASKET G01 RIVET, 3/16" X 1" LG (ALUMINUM) G2 HOSE CLAMP, 2 1/16" G01 HOSE G5 HOSE CLAMP, 13/16" G01 DECAL PRE-CLEANER AND AIR CLEANER CARTRIDGE (INCLUDES ITEMS 10, 11) PRE-CLEANER AIR CLEANER CARTRIDGE... 1 Page B-2

18 BODY 9 - Includes Items See ELECTRICAL SYSTEM Section Ref Bod 10-1 Page C-1

19 BODY Ref Bod 10-2 Page C-2

20 BODY See BRAKES Section See REAR AXLE Section Part of Frame ASH TRAY Includes Items Ref Bod 10-3 Page C-3

21 BODY Includes Items Includes items Includes items Includes Items Includes items Includes items Vehicle Rear Bumper HITCHES Dropped Heavy Duty Hitch Dropped Angle Hitch Dropped Clevis Hitch Ref Bod Drop Angle Hitch Drop Ball Hitch Drop Clevis Hitch 193 Page C-4

22 BODY THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 UPPER FLOORPAN G11 RIVET, 3/16" X 9/16" LG (ALUMINUM) G01 LOWER FLOORPAN G11 RIVET, 3/16" X 9/16" LG (ALUMINUM) G01 ACCESS COVER G03 INSTRUMENT PANEL ASSEMBLY (INCLUDES ITEMS 10-13) G01 DEFLECTOR (PASSENGER SIDE) G01 DEFLECTOR (DRIVER SIDE) G5 SCREW, #8-18 X 5/8" LG G01 INSTRUMENT PANEL INSERT (FOUR CUP) G01 LABEL (SAFETY) G01 LABEL (TEE HOLDER COVER) G01 SPLASH PANEL G2 RATCHET FASTENER, 1/4" X 3/4" LG G01 VINYL TRIM G01 RIVET, 3/16" X 1" LG (ALUMINUM) G** COWL G002...ST COWL SPECIAL COLOR G005...ST COWL FRONT JAC ORANGE Page C-5

23 BODY THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G006...ST COWL FRONT LIGHT GOLD PEARL G007...ST COWL SILVER PEARL METAL G011...ST COWL BLACK PAINT G012...ST COWL EMERALD GREEN PEARL G013...ST COWL CLOUD GREY G014...ST COWL VIPER BLUE METAL G019...ST COWL PATRIOT BLUE PEARL G020...ST COWL INFERNO RED METAL G023...ST COWL ADV CLASSICE CAMO G024...ST COWL FRONT NATURAL G025...ST COWL FRONT NEW HOLLAND BLUE G026...ST COWL FRONT STEEL BLUE PEARL G027...ST COWL BRIGHT SILVER METAL G029...ST COWL PRIME G030...ST COWL HD ADV CAMO G031...ST COWL FRONT METALLIC CHARCOAL G033...ST COWL TIMERLINE GREEN G034...ST COWL DEEP MOLTEN RED G035...ST COWL SAFETY YELLOW G036...ST COWL CAMPAGNE BEIGE TEXT G037...ST COWL HUNTER GREEN G038...ST COWL BRIGHT WHITE G039...ST COWL FLAME RED G040...ST COWL BLACK G041...ST COWL ELECTRIC BLUE G042...ST COWL PLATINUM G043...ST COWL BURGUNDY ON CH BG G044...ST COWL ALMOND G046...ST COWL BURGANDY ON BLACK G047...ST COWL BURLINGTON GREEN G048...ST COWL BLACK ON CHAM BEIGE G049...ST COWL RED ON CHAM BEIGE G02 COWL SUPPORT BRACKET G02 BOLT, 1/4-20 X 1/2" LG G01 RIVET, 3/16" X 1" LG (ALUMINUM) NAMEPLATE, WOODS (COWL) G01 RIVET, 3/16" X 1" LG (ALUMINUM) G01 FENDER FLARE (DRIVER SIDE) G02 FENDER FLARE (PASSENGER SIDE)... 1 Page C-6

24 BODY THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 RIVET, 3/16" X 1" LG (ALUMINUM) G02 BUMPER G04 SPACER 1" G01 SPACER, 1/2" G2 WASHER, 5/16" G8 LOCK WASHER, 5/16" G02 BOLT, 5/16-18 X 2 1/2" LG G01 GLOVE BOX DOORS (PAIR) G02 GLOVE BOX DOOR (DRIVER SIDE) G03 GLOVE BOX DOOR (PASSENGER SIDE) G06 FLOORMAT W/HORN HOLES (1/8") G02 SEAT FRAME G2 BOLT, 5/16-18 X 13/16" LG G** SEAT SUPPORT PANEL G10 RIVET, 5/32" X 9/16" LG (STAINLESS STEEL) G03 SPLASH PANEL G2 BOLT, 5/16-18 X 13/16" LG... 2 Page C-7

25 BODY THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G8 BOLT, 5/16-18 X 1" LG G8 WASHER, 5/16" G6 LOCK NUT, 5/ BATTERY TRAY G2 BOLT, 5/16-18 X 4/5" LG G8 BOLT, 5/16-18 X 1" LG G8 WASHER, 5/16" G6 LOCK NUT, 5/ G** SIDE PANEL (DRIVER SIDE) G** SIDE PANEL (PASSENGER SIDE) G10 RIVET, 5/32" X 9/16" LG G12 RIVET, 1/4" X 9/16" LG (ALUMINUM) G1 WASHER, 1/4" DECAL (ST 480) G01 DECAL (JACOBSEN) (DRIVER SIDE) G02 DECAL (JACOBSEN) (PASSENGER SIDE) DECAL (MAV 480) G03 ROCKER PANEL (DRIVER SIDE) G04 ROCKER PANEL (PASSENGER SIDE) G03 BRACE (DRIVER SIDE) G04 BRACE (PASSENGER SIDE) G2 SCREW, #10-24 X 1 1/4" LG G01 SPACER (DRIVER SIDE) G02 SPACER (PASSENGER SIDE)... 1 Page C-8

26 BODY THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G5 WASHER, #10 (STAINLESS STEEL) G10 LOCK NUT, # G1 SCREW, 1/4-20 X 1" LG (STAINLESS STEEL) G2 SPACER, 1/4" G7 WASHER, 1/4" G4 LOCK NUT, 1/ G01 FENDER (DRIVER SIDE) G02 FENDER (PASSENGER SIDE) G03 FENDER WITH TAILLIGHT (DRIVER SIDE) G04 FENDER WITH TAILLIGHT (PASSENGER SIDE) G2 RATCHET FASTENER, 1/4" X 3/4" LG G2 RATCHET FASTENER, 1/4" X 3/4" LG G01 REAR PANEL G01 RIVET, 3/16" X 1" LG G01 SEAT FILLER PANEL (DRIVER SIDE) G02 SEAT FILLER PANEL (PASSENGER SIDE)... 1 Page C-9

27 BODY THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G10 RIVET, 5/32" X 9/16" LG (STAINLESS STEEL) G01 LABEL (WARNING) G01 LABEL (HOT EXHAUST) G1 LABEL (GOVERNOR WARNING) G03 ASH TRAY KIT (INCLUDES ITEMS ) G01 ASH TRAY G01 GASKET G02 BRACKET G4 SCREW, #10-16 X 1/2" LG G02 HITCH RECEIVER G8 SCREW, 5/16-18 X 1" LG G8 WASHER, 5/16" G6 LOCK NUT, 5/ G4 BOLT, 7/16-14 X 1 1/2" LG G3 WASHER, 7/16" G1 LOCK NUT, 7/ G10 DROP BALL HITCH KIT (INCLUDES ITEMS ) G02 DROP BALL HITCH G1 HITCH BALL, 1 7/8" (INCLUDES ITEMS ) G6 LOCK WASHER, 3/4" G11 NUT, 3/ G01 CLEVIS PIN, 5/8" X 3" LG G1 COTTER PIN, 15/32" X 2 13/16" LG... 1 Page C-10

28 BODY THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G08 DROP ANGLE HITCH KIT (INCLUDES ITEMS ) G02 DROP ANGLE HITCH G01 CLEVIS PIN, 5/8" X 3" LG G1 COTTER PIN, 15/32" X 2 13/16" LG G12 DROP CLEVIS HITCH KIT (INCLUDES ITEMS ) G02 DROP CLEVIS HITCH G01 CLEVIS PIN, 5/8" X 3" LG G1 COTTER PIN, 15/32" X 2 13/16" LG G7 CLEVIS PIN, 1/2" X 2 5/8" LG G1 COTTER PIN, 2 1/2" LG G02 DROP ANGLE HITCH KIT (INCLUDES ITEMS ) G01 CLEVIS PIN, 5/8" X 3" LG G1 COTTER PIN, 15/32" X 2 11/16" LG G02 DROP BALL HITCH KIT (INCLUDES ITEMS ) G01 CLEVIS PIN, 5/8" X 3" LG G1 COTTER PIN, 15/32" X 2 11/16" LG G1 HITCH BALL, 1 7/ G6 LOCK WASHER, 3/ G11 NUT, 3/ Page C-11

29 BODY THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G02 DROP CLEVIS HITCH (INCLUDES ITEMS ) G01 CLEVIS PIN, 5/8" X 3" LG G1 COTTER PIN, 15/32" X 2 11/16" LG G7 CLEVIS PIN, 1/2" X 2 1/2" LG G1 COTTER PIN, 2 1/2" LG... 1 Page C-12

30 BRAKES Part of Frame To Brake Line Item Page D-1

31 BRAKES 61 - Includes Items Includes Items Includes Items Includes Items Page D-2

32 BRAKES THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 BRAKE PEDAL G01 BRAKE PEDAL PAD G1 RIVET, 3/16" X 1/2" LG G01 ADJUSTABLE BUMPER G1 LOCK NUT, 5/ G01 SHOULDER BOLT, 3/8-16 X 4" LG (STAINLESS STEEL) G01 FLANGED BUSHING G01 TORSION SPRING G1 WASHER, 3/8" G5 LOCK NUT, 3/ G02 LINKAGE ROD G3 CLEVIS PIN, 5/16" X 13/16" LG G3 COTTER PIN, 3/32" X 3/4" LG G01 BELL CRANK G01 FLANGED BUSHING G02 SHAFT, 5 1/2" LG G01 RETAINING RING, 13/32" (STAINLESS STEEL) G2 PUSH ROD ASSEMBLY (INCLUDES ITEMS 24-26) G2 PUSH ROD, 3 1/8" LG G1 CLEVIS YOKE G6 JAM NUT, 3/ G3 CLEVIS PIN, 5/16" X 1" LG G3 COTTER PIN, 3/32" X 3/4" LG Page D-3

33 BRAKES THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G02 MASTER CYLINDER KIT (INCLUDES ITEMS 32-34) * MASTER CYLINDER G1 MASTER CYLINDER BOOT G1 WASHER, 3/8" (STAINLESS STEEL) G4 BOLT, 3/8-16 X 1 1/2" LG G1 WASHER, 3/8" G5 LOCK NUT, 3/ G01 BRANCH TEE (MALE) G1 BRAKE LIGHT SWITCH G1 PLUG G01 FLEXIBLE BRAKE HOSE G1 CLIP G01 PRIMARY BRAKE LINE G6 BOLT, 5/16-18 X 3/4" LG G8 WASHER, 5/16" G6 LOCK NUT, 5/ G5 INSULATED CABLE CLAMP, 3/8" G6 SCREW, #12-24 X 3/4" LG G01 SECONDARY BRAKE LINE G01 BANJO BOLT G01 COPPER GASKET Page D-4

34 BRAKES THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 BRAKE ASSEMBLY (DRIVER SIDE) (INCLUDES ITEMS 63-73) G02 BRAKE ASSEMBLY (PASSENGER SIDE) (INCLUDES ITEMS 63-73) G01 BRAKE SHOE G** PARK BRAKE WHEEL LEVER G01 WHEEL CYLINDER * WHEEL CYLINDER BOLT * UPPER RETURN SPRING * LOWER RETURN SPRING * CUP AND SPRING * ADJUSTER * WASHER * BOLT, 1/4-28 X 1/2" LG * DUST COVER G01 ADJUSTER KIT (INCLUDES ITEMS 70-73) G01 HARDWARE KIT (INCLUDES ITEMS 66-69) G01 SCREW, 5/16-24 X 3/4" LG G1 LOCK NUT, 5/ G01 BRAKE DRUM ASSEMBLY (INCLUDES ITEMS 84-85) * BRAKE DRUM G2 LUG BOLT, 1/2-20 X 1 11/16" LG G2 SPINDLE CAP ADAPTER G01 OUTER BRAKE DRUM WASHER G8 SLOTTED NUT, 3/ G1 COTTER PIN, 1/8" X 1 1/2" LG G2 SPINDLE CAP... 2 Page D-5

35 BRAKES Page D-6

36 PARK BRAKE 38 Front of Vehicle Seat Support Panel Page E-1

37 PARK BRAKE Park Brake Cable Front of Vehicle 46 Part of Frame Page E-2

38 PARK BRAKE THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G03 PARKING BRAKE LEVER ASSEMBLY (INCLUDES ITEMS 2-5) G01 PARKING BRAKE LEVER G01 PARKING BRAKE CABLE * COTTER PIN, 3.32"x1" LG * HAIRCLIP G01 PULLEY MOUNT BRACKET (DRIVER SIDE) G01 PULLEY MOUNT BRACKET (PASSENGER SIDE) G01 PULLEY, 2" DIA G4 BOLT, 5/16-18 X 1 1/2" LG G8 WASHER, 5/16" G6 LOCK NUT, 5/ G08 SCREW, 5/16-18 X 1" LG G8 WASHER, 5/16" G6 LOCK NUT, 5/16-18 (STAINLESS STEEL) G01 CENTER CONSOLE G01 SUPPORT BRACKET G1 SCREW, 1/4-20 X 1" LG (STAINLESS STEEL) G12 SPACER, 3/8" G7 WASHER, 1/4" G4 LOCK NUT, 1/ G01 SUPPORT PLATE G3 SCREW, 1/4-20 X 3/4" LG (STAINLESS STEEL) G7 WASHER, 1/4" G4 LOCK NUT, 1/ Page E-3

39 PARK BRAKE THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 DECAL (CENTER CONSOLE) G3 SCREW, 1/4-20 X 3/4" LG (STAINLESS STEEL) G7 WASHER, 1/4" G4 LOCK NUT, 1/ G01 PARKING BRAKE BOOT G01 SPHERICAL NUT, 5/ G4 JAM NUT, 5/ G01 PARKING BRAKE CABLE (DRIVER SIDE) G02 PARKING BRAKE CABLE (PASSENGER SIDE) G01 RETAINING RING, 13/32" (STAINLESS STEEL) G2 CLEVIS PIN, 5/16" X 13/16" LG G3 COTTER PIN, 3/32" X 3/4" LG G01 EQUALIZER G3 CLEVIS PIN, 5/16" X 13/16" LG G3 COTTER PIN, 3/32" X 3/4" LG... 2 Page E-4

40 CLUTCH Page F-1

41 CLUTCH THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G03 DRIVE CLUTCH G9 BOLT, 7/16-20 X 6 1/2" LG G2 LOCK WASHER, 7/16" G1 PILOT WASHER G02 DRIVEN CLUTCH ASSEMBLY (INCLUDES ITEMS 8-15) * MOVABLE SHEAVE (INCLUDES ITEMS 9-10) G01 SCREW, #10-24 X 7/8" LG G01 RAMP BUTTON * CAM G1 SPACER, 1 1/2" G01 COMPRESSION SPRING * SHEAVE AND POST G01 HEAVY DUTY RETAINING RING G8 BOLT, 5/16-18 X 4" LG G8 LOCK WASHER, 5/16" G1 RETAINING WASHER G01 DRIVE BELT... 1 Page F-2

42 DIRECTION SELECTOR Includes Items To Rear Axle Page G-1

43 DIRECTION SELECTOR Direction Selector Cable Front of Vehicle Page G-2

44 DIRECTION SELECTOR THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 DIRECTION SELECTOR ASSEMBLY (INCLUDES ITEMS 2-41) G01 SHIFTER BRACKET ASSEMBLY (INCLUDES ITEM 3 AND 4) G01 SHIFTER BRACKET G2 BUSHING, 1/2" X 3/4" G01 NEUTRAL LOCK PIN G01 COMPRESSION SPRING G01 NEUTRAL LOCK LEVER G2 LOCK NUT, 1/ G01 DIRECTION SELECTOR CAM / HANDLE G01 BALL STUD, 1/4" G5 LOCK NUT, # G01 PIVOT SHAFT G01 LOCK NUT, 3/ G1 MICRO SWITCH G01 SPACER G02 SCREW, #6-32 X 1 1/4" LG G3 WASHER, # G3 LOCK WASHER, # G5 NUT, # G1 FASTON TAB, 5/16" X 5/16" G1 SCREW G3 LOCK WASHER, # G03 BUZZER G01 SCREW, SELF TAPPING, #6-32 X 3/8" G GA WIRE (RED 6") Page G-3

45 DIRECTION SELECTOR THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 EXTENSION SPRING G04 DIRECTION SELECTOR CABLE G01 CUP WASHER, 1/4" G01 COMPRESSION SPRING G5 LOCK NUT, # G01 SHIFTER ARM ASSEMBLY (INCLUDES ITEMS 40 AND 41) G01 SHIFTER ARM G4 BUSHING G2 SCREW, 1/4-20 X 5/8" LG (STAINLESS STEEL) G7 LOCK WASHER, 1/4" (STAINLESS STEEL) G1 DIRECTION SELECTOR KNOB G8 WASHER, 5/16" G01 LOCK NUT, M8 X 1.25 MM LG... 1 Page G-4

46 ELECTRICAL SYSTEM To Electronic Ignition Control Module To Ground Terminal on Engine 16 F2 DF See Starter/Generator Section 51 F1 50 A2 A To Engine Block 48 Page H-1

47 ELECTRICAL SYSTEM 18 - Includes Items BLACK RED To F2 On Starter/Generator To Battery (+) Page H-2

48 ELECTRICAL SYSTEM Seatwrap Support 72 YEL BLK BLU/WHT RED/YEL RED RED/WHT ORN/WHT WHT NOTE: Truck Bed and Driver Seat Not Shown For Clarity Floorboard HORN Ref Ele 10-3 Page H-3

49 ELECTRICAL SYSTEM Wire Harness (Chassis) OFF ON 85 E F FUEL Part of Ignition Switch 82 Page H-4

50 ELECTRICAL SYSTEM Includes Items REAR FENDER 107 Page H-5

51 ELECTRICAL SYSTEM Includes Items HOUR METER 116 Hour Meter BLACK 118 YELLOW 120 (+) (-) Solenoid Page H-6

52 ELECTRICAL SYSTEM THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G* BATTERY, 12V G02 BATTERY HOLD DOWN G6 BOLT, 5/16-18 X 3/4" LG G8 LOCK WASHER, 5/16" G2 WASHER, 5/16" G1 BOLT, 5/16-18 X 1 1/4" LG G01 LOCK WASHER, 5/16" (SILICON BRONZE) G01 NUT, 5/16-18 (SILICON BRONZE) G01 BATTERY GROUND CABLE G6 BOLT, 5/16-18 X 3/4" LG G1 LOCK NUT, 5/ G01 WIRE HARNESS (CHASSIS) G01 ELECTRICAL PLATE ASSEMBLY (INCLUDES ITEMS 19-40) G01 BRACKET G01 VOLTAGE REGULATOR G2 BOLT, 1/4-20 X 1 1/4" LG G01 SOLENOID G5 BOLT, 1/4-20 X 5/8" LG G2 LOCK NUT, 1/ G01 FASTON TAB, G1 FASTON TAB G5 LOCK WASHER, # G4 NUT, # G56 18 GA WIRE (BLACK 5 3/4") (SOL - GND) Page H-7

53 ELECTRICAL SYSTEM THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G8 LOCK WASHER, 5/16" G4 NUT, 5/ G33 6 GA WIRE (BLACK 24") (B+ - SOL) G8 BOLT, 1/4-20 X 1" LG G2 LOCK NUT, 1/ G2 FASTON TAB G7 WASHER, 1/4" G7 LOCK WASHER, 1/4" G1 NUT, 1/ G01 COVER G1 WASHER, 1/4" G6 SCREW, 1/4-14 X 3/4" LG G1 6 GA WIRE (BLACK 15") (B- - GND) G2 BOLT, 5/16-18 X 3/4" LG G129 6 GA WIRE (BLACK 31") (F2 - SOL) G1 WIRE TIE... AR G02 GROUND CABLE G01 SCREW, 1/4-20 X 3/4" LG G01 6 GA WIRE (BLACK 6") (F1 - A2) G01 TERMINAL COVER G90 16 GA WIRE (GREEN 12") (DF - CHASSIS HARNESS) G01 FUSE BLOCK G1 FASTON TAB G2 SCREW, #10-24 X 1 1/4" LG G5 WASHER, # G10 LOCK NUT, # G01 FUSE, 15 AMP... 4 Page H-8

54 ELECTRICAL SYSTEM THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G05 FUSE, 7.5 AMP G1 HORN SWITCH G2 HORN SWITCH CAP AND NUT G01 HORN SWITCH BOOT G1 HORN SWITCH LABEL G01 RIVET, 3/16" X 1" LG (ALUMINUM) G1 HORN G5 BOLT, 1/4-20 X 5/8" LG G8 WASHER, 5/16" G2 LOCK NUT, 1/ G07 PLATE (FUEL GAUGE AND OIL LIGHT) G01 LABEL (FUEL GAUGE AND LOW OIL WITH LIGHTS) G02 RIVET, 3/16" X 3/8" LG G01 IGNITION SWITCH AND KEY (INDIVIDUALLY KEYED) G01 IGNITION SWITCH SPACER G** IGNITION KEY (ORDER BY 4 DIGIT NUMBER ON KEY) G1 FUEL GAUGE G1 INDICATOR LIGHT G01 POWER OUTLET PLATE ( INCLUDES ITEMS 89-92) G03 CONSOLE PLATE G01 LABEL, CONSOLE... 1 Page H-9

55 ELECTRICAL SYSTEM THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 POWER OUTLET (12 VOLT) G10 RIVET, 3/16" X 7/16" LG (ALUMINUM) G02 DRIVE RIVET, 3/16" X 3/8" LG G1 HEADLIGHT (RECTANGULAR) (INCLUDES ITEM 95) G6 SCREW, #10-16 X 1" LG G01 JUMPER WIRE (HEADLIGHT) G3 TURN SIGNAL LIGHT (INCLUDES ITEMS ) G3 TURN SIGNAL LIGHT G7 WASHER, 1/4" (STAINLESS STEEL) G1 WIRE G7 LOCK WASHER, 1/4" G1 NUT, 1/ G1 PUSH-ON MALE TERMINAL G5 LENS, AMBER G5 SCREW, #6-18 X 5/8" LG G3 TAILLIGHT (WITH SEALED CONNECTORS) G01 TAILLIGHT JUMPER PLUG (FOR VEHICLE WITHOUT TURN SIGNAL) G1 TURN SIGNAL (WITH MOUNTING HARDWARE) (INCLUDES ITEM 110) G1 TURN SIGNAL FLASHER G3 FLEX LOOM, 3/8" X 8" LG G1 WIRE TIE G3 STEERING COLUMN COVER G06 HOUR METER KIT (INCLUDES ITEMS ) G1 HOUR METER ASSEMBLY G02 HOUR METER BRACKET G4 SCREW, #10-24 X 1/2" LG G10 LOCK NUT, # G01 WIRE HARNESS (HOUR METER)... 1 Page H-10

56 ENGINE Part of Frame Page J-1

57 ENGINE THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 SUBFRAME G01 ENGINE, 480CC (INCLUDES ITEMS 4-11) CARBURETOR SPARK PLUG (RC12YC) G01 OIL DRAIN VALVE OIL FILTER G01 45 ELBOW, 1/8 NPT X 1/8 NPT OIL PRESSURE SWITCH MUFFLER ELECTRONIC IGNITION CONTROL MODULE... 1 For internal engine replacement parts, see an Authorized Briggs & Stratton Dealer. To locate the nearest dealer, see the dealer locator map at the web site or in the Yellow Pages directory under Engines, Gasoline, Gasoline Engines, Lawn Mowers or similar catagory. The following information, located on the fan housing, must be provided when requesting information or ordering replacement parts: Model: Type: Code: Page J-2

58 ENGINE THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G8 BOLT, 5/16-18 X 2" LG G8 WASHER, 5/16" G6 LOCK NUT, 5/ G01 FRONT ENGINE MOUNTING BRACKET G4 BOLT, 3/8-16 X 3 1/2" LG G1 WASHER, 3/8" G01 PLATE WASHER G5 LOCK NUT, 3/ G01 ISOLATOR G01 EXHAUST PIPE (INCLUDES ITEMS 27-29) * CLAMP * SPARK ARRESTOR G01 SCREW, #6-20 X 5/16" LG G01 ENGINE, 480CC (HIGH ALTITUDE 5,000-7,500 FT) (INCL ITEMS 3, 33) G01 CARBURETOR HIGH ALTITUDE KIT (INCLUDES ITEMS 34, 35) G01 MAIN JET # G01 LABEL (HIGH ALTITUDE - 5,000-7,500 FT) G02 ENGINE, 480CC (HIGH ALTITUDE 7,500-10,000 FT) (INCL ITEMS 3, 38) G02 CARBURETOR HIGH ALTITUDE KIT (INCLUDES ITEMS 39, 40) G02 MAIN JET # G01 LABEL (HIGH ALTITUDE - 7,500-10,000 FT)... 1 Page J-3

59 ENGINE Page J-4

60 FRONT SUSPENSION 14 - Includes Items 5-12 and 15 3, , Part of Frame Part of Frame Page K-1

61 FRONT SUSPENSION Where applicable, THE USE OF NON UL PARTS WILL VOID ANY UL LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 FRONT AXLE G03 SPINDLE ASSEMBLY (DRIVER SIDE) (INCLUDES ITEMS 4-12) * SPINDLE (DRIVER SIDE) G1 BEARING G3 GREASE FITTING, STRAIGHT G1 GREASE SEAL G01 WHEEL HUB ASSEMBLY WITH RACES (INCLUDES ITEMS 9) G1 LUG BOLT, 1/2-20 X 1 3/16" LG G2 BEARING AND RACE ASSEMBLY (COMPLETE) G1 SLOTTED NUT, G8 COTTER PIN, 5/32" X 1 3/4" LG G03 SPINDLE ASSEMBLY (PASSENGER SIDE) (INCL ITEMS 5-12, 15) * SPINDLE (PASSENGER SIDE) G2 SPINDLE CAP G01 BOLT, 1/2-13 X 5" LG G5 WASHER, 1/2" G01 KING PIN TUBE G1 THRUST WASHER, 7/8" G6 LOCK NUT, 1/ G01 SHOCK ABSORBER G1 SHOCK ABSORBER WASHER G1 RUBBER BUSHING G6 NUT, 3/ G01 SHOCK ABSORBER BOOT... 2 Page K-2

62 FRONT SUSPENSION Where applicable, THE USE OF NON UL PARTS WILL VOID ANY UL LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G1 WIRE TIE G01 LEAF SPRING (HEAVY DUTY) G03 SPRING PLATE G1 LOCK NUT, 7/ G11 BOLT, 7/16-14 X 1 3/4" LG G01 WINCH RECEIVER G01 VINYL CAP... 2 Page K-3

63 FRONT SUSPENSION Page K-4

64 FUEL SYSTEM Front of Vehicle Fuel Line From Tank Front of Vehicle To Fuel Filter Includes Items Page L-1

65 FUEL SYSTEM THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY FUEL TANK ASSEMBLY (INCLUDES ITEMS 2-7) FUEL TANK G01 FUEL TANK CAP G01 FUEL LEVEL SENDER ADAPTER G01 SCREW, #6-32 X 1/2" LG G2 FUEL LEVEL SENDER G01 SCREW, #10-32 X 3/4" G8 BOLT, 5/16-18 X 1" LG G8 WASHER, 5/16" G6 LOCK NUT, 5/ G01 SPACER G8 WASHER, 5/16" G6 LOCK NUT, 5/ G1 CLAMP G01 TUBING, 1/4" I.D. X 1/2" O.D. (BULK, 1 FT. INCREMENTS)... AR G1 VINYL TRIM, (BULK)... AR G1 CLAMP FUEL FILTER FUEL PUMP... 1 Page L-2

66 FUEL SYSTEM - CALIFORNIA REQUIREMENT Front of Vehicle CALIFORNIA EMISSION REQUIREMENT 3 Item 1 - includes items To Carburetor 15 To Crankcase Pulse Fitting 2 Part of Frame 11 Page L-3

67 FUEL SYSTEM - CALIFORNIA REQUIREMENT THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY FUEL TANK ASSEMBLY (INCLUDES ITEMS 2-7) FUEL TANK G01 FUEL TANK CAP G01 FUEL LEVEL SENDER ADAPTER G01 SCREW, #6-32 X 1/2" LG G2 FUEL LEVEL SENDER G01 SCREW, #10-32 X 3/4" G8 BOLT, 5/16-18 X 1" LG G8 WASHER, 5/16" G6 LOCK NUT, 5/ G01 SPACER G8 WASHER, 5/16" G6 LOCK NUT, 5/ G1 CLAMP FUEL HOSE CARB... 26" G6 VINYL TRIM, (BULK)... AR G1 NYLON CLAMP LABEL EVP CARB FUEL FILTER FUEL PUMP... 1 Page L-4

68 REAR AXLE Includes Items OIL Subframe Front Includes Items Includes Items Page M-1

69 REAR AXLE THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 REAR AXLE (INCLUDES ITEMS 2-27) G01 FLANGED BOLT, M8 X 1.25 X 100 MM LG G01 FLANGED BOLT, M8 X 1.25 X 110 MM LG G01 FLANGED BOLT, M8 X 1.25 X 130 MM LG G01 FLANGED NUT, M8 X G01 INPUT SHAFT SEAL G01 SHIFTER SHAFT SEAL G01 AXLE SHAFT SEAL G01 OIL CHECK PLUG G01 GASKET, 8 MM G01 OIL DRAIN PLUG G01 GASKET, 14 MM G01 OIL FILLER PLUG AXLE TUBE (DRIVER SIDE) AXLE TUBE (PASSENGER SIDE) G01 AXLE SHAFT (DRIVER SIDE) (INCLUDES ITEMS 22-24) G01 AXLE SHAFT (PASSENGER SIDE) (INCLUDES ITEMS 22-25) G01 SNAP RING, 30 MM G01 COLLAR, 30 X 20 MM G01 BALL BEARING G01 SEAL COLLAR G01 SNAP RING, 55 MM G01 FLANGED BOLT, M10 X 1.5 X 23 MM Page M-2

70 REAR AXLE THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 DIFFERENTIAL LOCK CABLE (INCLUDES HARDWARE) G03 J RETAINER NUT G01 PLATE G1 SCREW, #8-18 X 7/8" LG G4 LOCK WASHER, # G01 BRACKET G01 SPACER, 1/2" G01 LOCK WASHER, 8 MM G01 NUT, M8 X 1.25 MM G01 DIFFERENTIAL LINK G8 BOLT, 3/8-16 X 1" LG G1 WASHER, 3/8" G5 LOCK NUT, 3/ G01 DIFFERENTIAL LOCK CABLE BRACKET G01 CLAMP G01 LOCK NUT, M8 X 1.25 MM G3 CLEVIS PIN, 5/16" X 13/16" LG G3 COTTER PIN, 3/32" X 3/4" LG G02 DIFFERENTIAL SKID PLATE... 1 Page M-3

71 REAR AXLE Page M-4

72 REAR SUSPENSION Front of Vehicle See Engine Section 11 See Rear Axle Section Page N-1

73 REAR SUSPENSION THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 HEAVY DUTY LEAF SPRING G02 SHOCK/STOP MOUNT (PASSENGER SIDE) G01 SHOCK/STOP MOUNT (DRIVER SIDE) G01 RUBBER BUMPER G01 LOCK WASHER, 10 MM G01 NUT, M10 X G01 U BOLT, 3/8-16 X 2" X 2 1/2" LG G1 WASHER, 3/8" G5 LOCK NUT, 3/ G1 SHOULDER BOLT, 3/8-16 X 3 1/4" LG G1 LOCK NUT, 3/ G01 FLANGED BUSHING G02 SPACER G4 BOLT, 3/8-16 X 3 1/2" LG G02 SHACKLE PLATE G5 LOCK NUT, 3/ G01 SHOCK ABSORBER G1 SHOCK ABSORBER WASHER G1 RUBBER BUSHING G6 NUT, 3/ Page N-2

74 SEATS 1 - Includes Items Includes Items Includes Items Part of Seat Frame Page P-1

75 SEATS THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G** SEAT BOTTOM (DRIVER SIDE) (INCLUDES ITEMS 3-8) G** SEAT BOTTOM (PASSENGER SIDE) (INCLUDES ITEMS 5-10) G** SEAT BOTTOM CUSHION (DRIVER SIDE) G01 HIP RESTRAINT (DRIVER SIDE) G01 HINGE G1 SCREW, 1/4-20 X 1" LG (STAINLESS STEEL) G1 RUBBER PAD G01 BOLT, 1/4-20 X 7/8" LG GXX SEAT BOTTOM CUSHION (PASSENGER SIDE) G01 HIP RESTRAINT (PASSENGER SIDE) G01 SEAT PROP G6 SCREW, #12-14 X 3/4" LG G11 RIVET, 3/16" X 3/4" LG (STAINLESS STEEL) G** SEAT BACK (INCLUDES ITEMS 16-21) G** SEAT BACK CUSHION G01 SEAT BACK PLATE G3 SCREW, 1/4-20 X 3/4" LG (STAINLESS STEEL) G7 LOCK WASHER, 1/4" (STAINLESS STEEL) G02 SEAT BACK SUPPORT G1 SCREW, 1/4-20 X 1" LG (STAINLESS STEEL) G01 BRACKET G01 ADJUSTABLE BUMPER G1 LOCK NUT, 5/ G01 BOLT, 3/8-16 X 1 1/4" LG G1 WASHER, 3/8" G5 LOCK NUT, 3/ Page P-2

76 STARTER / GENERATOR Includes Items Includes Items Includes Items Includes Items Includes Items Includes Items Includes Items Page Q-1

77 STARTER / GENERATOR REAR VIEW 62 To Engine Block Ref Stg 10-2 Page Q-2

78 STARTER / GENERATOR THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 STARTER / GENERATOR (INCLUDES ITEMS 2-43) G01 ARMATURE (INCLUDES ITEMS 3-5) G01 REAR BALL BEARING G01 FRONT BALL BEARING G01 BEARING HOLDER G01 FIELD COIL G01 INSULATING BRUSH ASSEMBLY ( F ) (INCLUDES ITEMS 10-13) * NUT * LOCK WASHER * WASHER * INSULATOR G01 POLE CORE SETSCREW G01 FRONT COVER G01 REAR COVER G01 TERMINAL ASSEMBLY ( A ) (INCLUDES ITEMS 18-23) * TERMINAL * INSULATOR * INSULATOR * WASHER * LOCK WASHER * NUT G01 BRUSH HOLDER ASSEMBLY (INCLUDES ITEMS 26-28) G01 BRUSH G01 BRUSH SPRING G01 BRUSH CONNECTOR G01 KEY... 1 Page Q-3

79 STARTER / GENERATOR THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY. 31 * PULLEY G01 PULLEY HARDWARE KIT (INCLUDES ITEMS 33-37) * NUT * LOCK WASHER * SCREW * SCREW * SCREW G01 BRUSH 1 COVER G01 BRUSH 2 COVER G01 BOLT AND WASHER ASSEMBLY (INCLUDES ITEMS 41-43) * BOLT * LOCK WASHER * WASHER G01 FRONT STARTER BRACKET G7 BOLT, 7/16-14 X 7/8" LG G2 LOCK WASHER, 7/16" G2 BOLT, 5/16-18 X 1 1/4" LG G8 WASHER, 5/16" G6 LOCK NUT, 5/ G01 SCREW, 1/2-13 X 1 1/2" LG G01 STARTER/GENERATOR BELT... 1 Page Q-4

80 STARTER / GENERATOR THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 REAR STARTER BRACKET G01 SCREW, M X 20MM LG G2 BOLT, 1/2-13 X 2 1/4" LG G3 LOCK WASHER, 1/2" G3 WASHER, 1/2" G01 SPACER... 1 Page Q-5

81 STARTER / GENERATOR Page Q-6

82 STEERING Includes Items Includes Items Includes Items Includes Items Front of Vehicle STEERING SHAFT AND COLUMN RACK, BELLOWS AND TENSIONER Page R-1

83 STEERING IDLER, TIE RODS AND MOUNTING To Passenger Side Front Spindle To Driver Side Front Spindle 74 Page R-2

84 STEERING Where applicable, THE USE OF NON UL PARTS WILL VOID ANY UL LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G02 STEERING BOX ASSEMBLY (COMPLETE) G01 STEERING HOUSING (INCLUDES ITEMS 3-6) * SLEEVE BEARING * SLEEVE BEARING * FLANGED BEARING G3 GREASE FITTING, STRAIGHT G6 BOLT, 3/8-16 X 3/4" LG G1 GREASE FITTING, G01 RACK GUIDE COVER G01 GASKET G01 COMPRESSION SPRING G01 RACK GUIDE G1 HOSE CLAMP, 1 5/16" G01 RACK COVER G1 HOSE CLAMP, 1 5/16" G01 BELLOWS G5 HOSE CLAMP, 13/16" G01 STEERING GEAR KIT (INCLUDES ITEMS 21-28) G01 GEAR PINION G1 BALL BEARING G01 EXTERNAL RETAINING RING G01 STEERING RACK G01 RACK BALL END G8 JAM NUT, 7/ G1 GREASE FITTING, G01 RETAINER G01 IDLER... 1 Page R-3

85 STEERING Where applicable, THE USE OF NON UL PARTS WILL VOID ANY UL LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 THRUST WASHER, 1 1/2" G01 THRUST WASHER, 7/8" G6 LOCK NUT, 7/ G8 COTTER PIN, 5/32" X 1 3/4" LG G01 STEERING SHAFT/COLUMN KIT (INCLUDES ITEMS 37-48) G6 STEERING SHAFT G01 COUPLING G1 LOCK NUT, 1/ G01 SCREW, 1/4-20 X 7/8" LG G01 GASKET G01 BOLT, 3/8-16 X 1 1/4" LG WITH PATCHLOCK G1 LOCK WASHER, 3/8" G01 RETAINER G01 STEERING COLUMN KIT (INCLUDES ITEMS 46-48) * STEERING COLUMN G01 STEERING COLUMN BUSHING G01 SCREW, #6-20 X 5/16" LG G4 BOLT, 7/16-20 X 2 1/2" LG G3 LOCK NUT, 7/ G01 BOLT, 7/16-14 X 1 1/4" LG WITH PATCHLOCK G2 LOCK WASHER, 7/16" STEERING WHEEL G01 HUB COVER Page R-4

86 STEERING Where applicable, THE USE OF NON UL PARTS WILL VOID ANY UL LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 COVER G01 LABEL (E-Z-GO) G01 LABEL (CUSHMAN) G2 LOCK NUT, 5/ G04 TIE ROD ASSEMBLY (INCLUDES ITEMS 68-72) G03 THREADED ROD (10 1/8" LG) G01 TIE ROD END (LEFT HAND THREADS) G01 JAM NUT, M12 X (LEFT HAND THREADS) G02 TIE ROD END (RIGHT HAND THREADS) G02 JAM NUT, M12 X (RIGHT HAND THREADS) G1 LOCK NUT, 7/ G2 CASTELLATED NUT, 7/ G2 COTTER PIN, 3/32" X 1" LG... 1 Page R-5

87 STEERING Page R-6

88 TRUCK BED 1 - INCLUDES ITEMS A B 10 4 A 5 B Page S-1

89 TRUCK BED A A Ref Tbp 21-2 Page S-2

90 TRUCK BED INCLUDES ITEMS SEEING FROM THE BOTTOM Page S-3

91 TRUCK BED Front of Vehicle Includes Items WHT from Actuator BLK from Battery RED from Battery RED from Actuator Battery Connections 64 Front of Vehicle BLK Lead RED Lead Front of Vehicle To Circuit Breaker and Toggle Switch 51 To Control Harness Rear Frame Member Ref Tbe 3-3 Page S-4

92 TRUCK BED Where applicable, THE USE OF NON UL PARTS WILL VOID ANY UL LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G01 ASSEMBLY PLASTIC BED ( INCLUDES ITEMS 2-11 ) G01 PLASTIC BED 40" G01 TAILGATE 36", PLASTIC G01 ANGLE, BOWED G01 SHAFT, PIVOT G01 CABLE ASSEMBLY, TAILGATE G2 SCREW, 1/4-20 X 5/8" LG G01 BOLT, SHOULDER G01 CHANNEL, EXTRUSION G2 SCREW, 1/4-2 X 5/8" LG G5 RACHET FASTNER G02 GAS SPRING G01 CLEVIS PIN G5 WASHER, 1/2" G1 COTTER PIN G01 SCREW, 1/4-20 X 5/8" LG G7 WASHER, 1/4" G02 CHANNEL GAS SPRING G01 BUSHING CABLE ASSEMBLY G1 COTTER PIN G10 CLEVIS PIN, 1/2 X 3" G12 CLEVIS PIN, 1/2" X 2.00" Page S-5

93 TRUCK BED Where applicable, THE USE OF NON UL PARTS WILL VOID ANY UL LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G02 INSTALLATION LATCH ( INCLUDES ITEMS ) G01 WELDMENT LATCH BED G02 BRACKET G02 LATCH PLATE G01 TORSION SPRING G01 SCREW, 1/4-2 X 5/8" LG G01 HANDLE GRIP G01 BUMPER G1 LOCK NUT, 5/ G01 BRACKET BUMPER G04 ELECTRIC DUMP KIT ( INCLUDES ITEMS ) G02 ELECTRIC ACTUATOR 36 V G01 TOGGLE SWITCH G01 TOGGLE GUARD G02 CIRCUIT BREAKER MOUNTING BRACKET G4 SCREW, X 1/2" LG G5 LOCK WASHER, # G3 CIRCUIT BREAKER 15A 24V G1 WIRE TIE G3 NUT, # G9 RIVET, 5/32 X Page S-6

94 TRUCK BED Where applicable, THE USE OF NON UL PARTS WILL VOID ANY UL LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G14 14 GA WIRE (RED 5") G01 WIRE HARNESS ( CONTROL ) G10 CLEVIS PIN, 1/2" X 2 7/8" LG G11 CLEVIS PIN, 1/2" X 1 3/4" LG G1 COTTER PIN, 15/32" X 2 13/16" LG G01 SPACER LABEL EZGO MPT G01 BED CAPACITY LABEL (500 LB) G01 RIVET, 3/16"... 5 Page S-7

95 TRUCK BED Page S-8

96 WEATHER PROTECTION SUN TOP CAP (CAMO) 23 SUN TOP C 1 - Includes Items Includes Items Includes Items 8-21 D A B 4 Front of Vehicle B , DETAIL A DETAIL B Front of Vehicle , 24 2, 24 Front of Vehicle DETAIL C (FRONT) , 6 DETAIL D (REAR) Page T-1

97 WEATHER PROTECTION REAR VIEW MIRROR 26 - Includes Items Front Top Strut Setscrew 32 ENCLOSURE 31 - Includes Items 32, Page T-2

98 WEATHER PROTECTION WINDSHIELDS 36 - Includes Items Includes Items 52, , Strut Front of Vehicle 45 - Includes Items 46-47, Includes Items 55, 47, Front of Vehicle Strut 42 Ref Wea 10-3 Page T-3

99 WEATHER PROTECTION BRUSHGUARD 58 - Includes Items Seat Support Side Bumper Bolt Bumper Spacer Body Page T-4

100 WEATHER PROTECTION BRUSHGUARD SUN TOP 67 - Includes Items Existing Brush Guard Cage BRUSHGUARD WINDSHIELD 79 - Includes Items Windshield Sash Strut Strut Front of Vehicle Ref Wea 10-5 Page T-5

101 WEATHER PROTECTION THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G0* SUN TOP KIT (INCLUDES ITEMS 2-21) G0* SUN TOP G06 HARDWARE KIT (INCLUDES ITEMS 4-21) G05 FRONT STRUT G03 REAR STRUT (DRIVER SIDE) G04 REAR STRUT (PASSENGER SIDE) G01 FASTENING HARDWARE KIT (INCLUDES ITEMS 8-21) G2 BOLT, 5/16-18 X 2 1/4" LG G8 LOCK WASHER, 5/16" G01 SPACER, 1/2" G2 WASHER, 5/16" G7 BOLT, 5/16-18 X 1 3/4" LG (STAINLESS STEEL) G03 WASHER, 5/16" (STAINLESS STEEL) G6 LOCK NUT, 5/16-18 (STAINLESS STEEL) G5 SCREW, 1/4-20 X 2" LG (STAINLESS STEEL) G6 SCREW, 1/4-20 X 2 1/4" LG (STAINLESS STEEL) G01 WASHER, 1/4" (STAINLESS STEEL) G01 PLASTIC SPACER G2 LOCK NUT, 1/4-20 (STAINLESS STEEL) G1 END CAP, 1" G0* SUN TOP CAP (CAMO) (OVER ITEM 1) G2 REAR VIEW MIRROR KIT (INCLUDES ITEMS 27-29) G1 REAR VIEW MIRROR G2 SUPPORT BRACKET G1 SCREW, #8-32 X 5/8" LG (STAINLESS STEEL) Page T-6

102 WEATHER PROTECTION Replacement parts for the windshield may be obtained from Eagle Parts, Inc Wilkinson Rd. Augusta, GA Telephone (706) or FAX (706) * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G** 3 SIDED SOFT ENCLOSURE KIT (INCLUDES ITEMS 32-33) * ENCLOSURE * VELCRO... AR G01 WINDSHIELD KIT (FULL POLYCARBONATE) (REQUIRES SUN TOP KIT) G01 WINDSHIELD (FULL) (LEXAN) EGWHC12 SASH, 26" LG EGWHS12 SCREW, 1/4-20 X 1 3/4" LG (STAINLESS STEEL) EGWHG12 WASHER, 1/4" (STAINLESS STEEL) EGWHG13 RUBBER GROMET EGWHN12 LOCK NUT, 1/4-20 (STAINLESS STEEL) EGWHL14 SAFETY LABEL G02 WINDSHIELD KIT (FOLDING POLYCARBONATE (REQUIRES SUN TOP KIT) G01 WINDSHIELD (FOLD DOWN) (LEXAN) EGWHC10 SASH, 12" LG G03 WINDSHIELD KIT (FULL ACRYLIC) (REQUIRES SUN TOP KIT) G01 WINDSHIELD (FULL) (ACRYLIC) G04 WINDSHIELD KIT (FOLDING ACRYLIC) (REQUIRES SUN TOP KIT) G01 WINDSHIELD (FOLD DOWN) (ACRYLIC) G02 BRUSH GUARD KIT (INCLUDES ITEMS 59-65) G03 BACK G03 SIDE (DRIVER SIDE)... 1 Page T-7

103 WEATHER PROTECTION THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G03 SIDE (PASSENGER SIDE) G03 TOP G2 BOLT, 3/8-16 X 2 1/4" LG G7 BOLT, 5/16-18 X 7/8" LG G6 LOCK NUT, 5/ G0* SUN TOP KIT (WITH BRUSH GUARD) (INCLUDES ITEMS 68-77) G03 MOUNTING BRACKET G5 BOLT, 5/16-18 X 5/8" LG G8 LOCK WASHER, 5/16" G3 NUT, 5/ G0* SUN TOP G7 WASHER, 1/4" G6 SCREW, 1/4-20 X 2 1/4" LG (STAINLESS STEEL) G2 LOCK NUT, 1/ G7 SCREW, 1/4-20 X 2 1/2" LG G01 SPACER G01 WINDSHIELD KIT, POLYCARBONATE (WITH BRUSH GUARD) (Replacement Parts available from Eagle Parts, ) A WINDSHIELD (POLYCARBONATE) EGWHC12 SASH, 26" LG E SCREW, 1/4-20 X 1/2" LG (STAINLESS STEEL) EGWHG12 WASHER, 1/4" (STAINLESS STEEL) EGWHG13 RUBBER GROMET EGWHN12 LOCK NUT, 1/4-20 (STAINLESS STEEL)... 2 Page T-8

104 WHEELS AND TIRES 1 - Includes Items 3, 4, Includes Items 3, 4, Includes Items 11, 12, 13 (Style of tire may differ from tire shown) 5 13 Rotation Page U-1

105 WHEELS AND TIRES THE USE OF NON U.L. PARTS WILL VOID ANY U.L. LISTING. When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G04 BLACK WHEEL AND STRYKER 1 TIRE ASSEMBLY (DRIVER SIDE) (INCLUDES ITEMS 3, 4, 5) G05 BLACK WHEEL AND STRYKER 1 TIRE ASSEMBLY (PASSENGER SIDE) (INCLUDES ITEMS 3, 4, 5)... AR AR G01 TIRE, 22 X 9-10 STRYKER G02 WHEEL RIM, BLACK (4 LUG) G1 VALVE STEM G03 BLACK WHEEL AND TURF SAVER TIRE ASSEMBLY (ITEMS 11, 12, 13)... AR G02 TIRE, 20 X TURF SAVER G02 WHEEL RIM, BLACK (4 LUG) G1 VALVE STEM G1 LUG NUT, 1/ AR Page U-2

106 WINCH Note: Winch shown mounted at front of vehicle Includes Items See BODY Page W-1

107 WINCH Front of Vehicle Page W-2

108 WINCH Page W-3

109 WINCH When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY G04 WINCH KIT (INCLUDES ITEMS 2-44) WINCH ASSEMBLY, T G01 WINCH MOUNTING TUBE G6 BOLT, 5/16-18 X 2 3/4" LG G2 WASHER, 5/16" G3 LOCK NUT, 5/ G1 CLEVIS PIN, 5/8" x 3" LG G1 COTTER PIN, 15/32" X 2 13/16" LG G03 REMOTE SOLENOID (INCLUDES ITEMS 11-32) G02 SOLENOID KIT G01 MOUNTING BRACKET G6 BOLT, 1/4-20 X 3/4" LG G1 SPACER, 1/4" G4 LOCK NUT, 1/ G01 WIRE HARNESS (SOLENOID - BATTERY) WIRE HARNESS (SOLENOID - RECEPTACLE) G1 FLEX LOOM, 4" (BULK) WIRE HARNESS (SOLENOID - FRONT) G1 FLEX LOOM, 84" (BULK) G01 CONNECTOR WIRE HARNESS (SOLENOID - REAR) (INCLUDES 28, 29) G1 FLEX LOOM, 49" (BULK) G01 CONNECTOR Page W-4

110 WINCH When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY RECEPTACLE WITH LEADS (GREEN, WHITE, BLACK) * CIRCUIT BREAKER WITH BRACKET G01 LABEL (READ INSTRUCTIONS) G5 BOLT, 1/4-20 X 5/8" LG G4 LOCK NUT, 1/ G01 CONNECTOR MOUNT PLATE G4 SCREW, #10-32 x 1/2" LG (STAINLESS STEEL) G5 WASHER, # G8 LOCK NUT, # G8 SCREW, #10-32 X 1" LG G4 LOCK NUT, # The following items are replacement components for the winch. For service or replacement parts, contact Superwinch, Inc., Winch Drive, Putnam, CT Phone: (860) , FAX: (860) Always provide the following information when requesting information or ordering replacement parts: Winch Part Number: T1500 Serial Number: (found on housing) Part Number and Description KNOB ASSEMBLY, T-SERIES F/W TENSION PLATE NUT, HEX, FLANGED, M5 X SCREW, ST HEX SKY FH, M6 X 1 X BASEPLATE ASSEMBLY, T-SERIES AS REQ D WASHER,.020" OR.030" THICK... A/R BUSHING, T-SERIES... 1 Page W-5

111 WINCH When ordering parts, please specify the model and serial number of the product. * Indicates a component that is not available as an individual part. G** Indicates consult Customer Service Department for additional information. ITEM PART NO DESCRIPTION QTY SET SCREW, M5 X 0.8 X DRUM ASSEMBLY DRUM SUPPORT BUSHING DRUM SUPPORT PLATE SCREW, ST PAN HEAD, M4 X 0.7 X ROTATOR GEAR, T-SERIES CARRIER ASSEMBLY, T-SERIES STATIONARY GEAR HOUSING ASSEMBLY, T-SERIES MOTOR, 12 VOLT MOTOR PINION GEAR A WIRE ROPE AND HOOK ASSEMBLY, 5/32" X 25 FEET HANDSAVER BAR CIRCUIT BREAKER ASSEMBLY, 12 VOLT, T-SERIES REMOTE CONTROL ASSEMBLY SOLENOID, 12 VOLT SOLENOID BACK PLATE SOLENOID COVER... 1 Page W-6

112 WINCH Page W-1

113 OPTIONS/ACCESSORIES OPTIONS/ACCESSORIES Appendix A-1

114 OPTIONS/ACCESSORIES ITEM KIT NO. COMMENTS ACCESSORY LIST KIT NO. LOCATION IN MANUAL ASHTRAY KIT G03... See BODY BRUSHGUARD G02... See WEATHER PROTECTION BRUSHGUARD SUN TOP G0*... See WEATHER PROTECTION BRUSHGUARD WINDSHIELD G01... See WEATHER PROTECTION REAR BASKET G01 FRONT BASKET G02 HITCH G0*... See BODY GLOVE BOX DOOR G0*... See BODY GUN HOLDER G01 HOUR METER KIT G06... See ELECTRICAL SYSTEM REAR VIEW MIRROR KIT (REQUIRES SUN TOP KIT) G2... See WEATHER PROTECTION SOFT ENCLOSURE (3 SIDED) G0*... See WEATHER PROTECTION SUN TOP KIT G0*... See WEATHER PROTECTION SUN TOP CAP (CAMO) G02... See WEATHER PROTECTION TURN SIGNAL G1... See ELECTRICAL SYSTEM WINCH G04... See WINCH WINDSHIELD KIT (REQUIRES SUN TOP KIT) G0*... See WEATHER PROTECTION WINDSHIELD KIT (FOLD DOWN) (REQUIRES SUN TOP KIT) G0*... See WEATHER PROTECTION TIRE DOMINATOR 20X Wheels and Tires PATHFINDER TIRE, BRUSHED WHEEL LH Wheels and Tires PATHFINDER TIRE, BURSHED WHEEL RH Wheels and Tires V-STEM BRUSHED SPOKED WHEEL Wheels and Tires DOMINATOR POLISHED WHEEL Wheels and Tires DOMINATOR BRUSHED WHEEL Wheels and Tires CHROME CENTER CAP - SPOKED WHEEL Wheels and Tires NUT, LUG-CHROME Wheels and Tires V-STEM POLISHED SPOKED WHEEL Wheels and Tires PATHFINDER TIRE 22X Wheels and Tires PATHFINDER TIRE POLISHED WHEEL LH Wheels and Tires PATHFINDER TIRE POLISHED WHEEL RH Wheels and Tires Appendix A-2

115

116 E-Z-GO Division Of Textron, Inc., 1451 Marvin Griffin Road, Augusta, Georgia USA TO CONTACT US North America: Technical Assistance & Warranty Phone: , FAX: Service Parts Phone: GET-EZGO ( ), FAX: International: Phone: , FAX: Copyrighted Material This manual may not be reproduced in whole or in part without the express permission of E-Z-GO Division of Textron, Inc. Technical Communications Department