Zero Turn Mowers. ZSR54 & ZSR60 Accu-Z Razor P Parts Manual. Copyright 2017 Printed 12/27/17

Transcription

1 Zero Turn Mowers ZSR54 & ZSR60 Accu-Z Razor P Parts Manual Read the Operator's Manual entirely. When you see this symbol, the subsequent instructions and warnings are serious - follow without exception. Your life and the lives of others depend on it! Copyright 2017 Printed 12/27/17 Cover photo may show optional equipment not supplied with standard unit.

2 Table of Contents Section 1: Introduction...4 Using This Manual...4 Manual Replacement Information...4 Manual Revisions...4 Touch-up Paint...4 Hardware Legend...5 Replacement Hardware...5 Serial Numbers...5 Part Number Service Coding...5 Section 2: Main Frame, Seat & Bumper...6 Frame & Bumper...6 Rops Folding W/ Seat Belt...8 Seat & Footrest S/N Seat & Footrest S/N Section 3: Electrical, Levers & Transmission...14 Brake Park...14 Control Levers...16 Deck Lift...18 Electrical Components...20 Electrical Wiring Schematic Briggs Engine...22 Electrical Wiring Schematic Kawasaki Engine...24 Electrical Wiring Schematic Main Harness...26 Transmission Components ( C & C)...28 Transmission to Frame Assembly...30 Section 4: Engine, Fuel & Air Cleaner...32 Air Cleaner Kawasaki 23.5 HP...32 Engine Assembly Briggs & Stratton 26 HP...34 Engine Assembly Kawasaki 23 HP...36 Engine Assembly Kawasaki 23.5 HP...38 Fuel System S/N Fuel System S/N Section 5: Wheels...44 Drive Wheels...44 Front Floating Wheels...46 Section 6: Deck...48 Deck Assembly ZSR...48 Deck Pulleys & Drive Belt ZSR...50 Section 7: Labels...52 Label Placement...52 Touch-up Paints...54 Section 8: Accessories...56 Blade Bundle Kit...56 Deck Lift Electric...58 Light Kit Z-Mowers...60 Mulch Kit...62 Soft Top Canopy Copyright All rights reserved. provides this publication as is without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this product at the time of its publication, and may not reflect the product in the future. The illustrations in this manual are not intended for safe and proper assembly or disassembly of equipment. The illustrations are intended for ordering parts only. is registered trademark. All other brands and product names are trademarks or registered trademarks of their respective holders. Printed in the United States of America. 2 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

3 A B C D E F L M R S T Air Cleaner Kawasaki 23.5 HP...32 Blade Bundle Kit...56 Brake Park...14 Control Levers...16 Deck Assembly ZSR...48 Deck Lift...18 Deck Lift Electric...58 Deck Pulleys & Drive Belt ZSR...50 Drive Wheels...44 Electrical Components...20 Electrical Wiring Schematic Briggs Engine...22 Electrical Wiring Schematic Kawasaki Engine...24 Electrical Wiring Schematic Main Harness...26 Engine Assembly Briggs & Stratton 26 HP...34 Engine Assembly Kawasaki 23 HP...36 Engine Assembly Kawasaki 23.5 HP...38 Frame & Bumper...6 Front Floating Wheels...46 Fuel System S/N Fuel System S/N Label Placement...52 Touch-up Paints...54 Light Kit Z-Mowers...60 Mulch Kit...62 Rops Folding W/ Seat Belt...8 Seat & Footrest S/N Seat & Footrest S/N Soft Top Canopy...64 Transmission Components ( C & C)...28 Transmission to Frame Assembly...30 Alphabetized Table of Contents 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 3

4 4 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

5 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 5

6 Frame & Bumper Table of Contents Section 2: Main Frame, Seat & Bumper ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

7 Frame & Bumper Section 2: Main Frame, Seat & Bumper Ref. Part No. Part Description Comments Revision dwg D V H S H C C C C C C C Drawing Image Number HITCH, BUMPER BUMPER, CTR SECT W/NUTZERTS WMT, ENGINE GUARD ASY, ENGINE GUARD FRAME WELDMENT, RAZOR SCR HX SKT BUT CP 3/8-16X3/4 RHSNB 3/8-16X3/4 GR5 HFSS 5/16-18X1 GR5 PLT HFSS 1/2-13X1 GR5 NUT HEX FLANGE 3/8-16 PLT NUT HEX FLG. LOCK 1/2-13 PLT. NUT FLANGE LOCK 3/8-16 PLT Optional on S/N Standard on S/N Optional on S/N Standard on S/N /27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 7

8 Rops Folding W/ Seat Belt Section 2: Main Frame, Seat & Bumper ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

9 Rops Folding W/ Seat Belt Section 2: Main Frame, Seat & Bumper Ref. Part No. Part Description Comments Revision dwg N/A C C C C C C C C C C A Drawing Image Number LOCKING KNOB PIN, ROPS HINGE ROPS STOP FOLDING ROPS HHCS 1/2-13X3 GR5 HHCS 1/2-13X3 3/4 GR5 HHCS 1/2-13X3 1/4 GR5 HHCS 7/16-20X1 1/4 GR8 NUT LOCK 1/2-13 PLT NUT HEX NYLOCK 7/16-20 PLT WASHER FLAT 7/16 SAE PLT ASY, RAZOR FOLDING ROPS ISO RPBY C SEAT BELT RETRACTABLE KIT, Z-MWRS RTRCTABLE SEAT BLT S/N S/N /27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 9

10 Seat & Footrest S/N Section 2: Main Frame, Seat & Bumper ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

11 Seat & Footrest S/N Section 2: Main Frame, Seat & Bumper Ref. Part No. Part Description Comments Revision dwg D H H D D C C C C C C C C C C C C C C C C C C C C C C C C C Drawing Image Number SPCR DELUXE SEAT MNT RAZOR PRO PEDESTAL FRONT, RAZOR SEAT PAN, RAZOR FLOOR PAN SEAT LATCH ARM TPHMS Y 5/16-18X3/4 ZNYCR RHSNB 5/16-18X3/4 GR5 HFSS 3/8-16X3/4 LG HHCS 1/2-13X1 GR5 RHSNB 1/4-20X5/8 PLT SHLDR BLT 1/2DX1/2L 3/8-16 SS SHOULDER BOLT 3/8X1/2X5/16-18 NUT LOCK 5/16-18 PLT NUT HEX NYLOCK 5/16-18 PLT NUT HEX FLG LOCK 1/2-13 PLT NUT HEX FLANGE 1/4-20 PLT WASHER FLAT 1/2 SAE PLT WASHER FLAT 5/16 SAE PLT WASHER WAVE SPRING 5/16 SPRING TORSION.054 WIRE SPRG 55ODX65WX3.5L SEATPAN BSHG FLG.50IDX.62ODX.31L OPERATOR PRESENCE SWITCH KIT SEAT BLACK DELUXE CUSHION SKING ARM REST KIT SKING BACK SEAT COVER SKING BOTTOM SEAT COVER KY SEAT TRACK (PAIR) C TREAD, FLOOR PANEL TREAD, RAZOR FLOOR PANEL If This Part Is Ordered Replace With A 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 11

12 Seat & Footrest S/N Section 2: Main Frame, Seat & Bumper ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

13 Seat & Footrest S/N Section 2: Main Frame, Seat & Bumper Ref. Part No. Part Description Comments Revision dwg D H H D D C C C C C C C C C C C C C C C C C C C C C C C C C Drawing Image Number SPCR DELUXE SEAT MNT RAZOR PRO PEDESTAL FRONT, RAZOR SEAT PAN, RAZOR FLOOR PAN SEAT LATCH ARM TPHMS Y 5/16-18X3/4 ZNYCR RHSNB 5/16-18X3/4 GR5 HFSS 3/8-16X3/4 LG HHCS 1/2-13X1 GR5 RHSNB 1/4-20X5/8 PLT SHLDR BLT 1/2DX1/2L 3/8-16 SS SHOULDER BOLT 3/8X1/2X5/16-18 NUT LOCK 5/16-18 PLT NUT HEX NYLOCK 5/16-18 PLT NUT HEX FLG LOCK 1/2-13 PLT NUT HEX FLANGE 1/4-20 PLT WASHER FLAT 1/2 SAE PLT WASHER FLAT 5/16 SAE PLT WASHER WAVE SPRING 5/16 SPRING COMP 1/2 OD X 1 LG SPRG 55ODX65WX3.5L SEATPAN BSHG FLG.50IDX.62ODX.31L OPERATOR PRESENCE SWITCH KIT SEAT BLACK DELUXE CUSHION SKING ARM REST KIT SKING BACK SEAT COVER SKING BOTTOM SEAT COVER KY SEAT TRACK (PAIR) C TREAD, FLOOR PANEL TREAD, RAZOR FLOOR PANEL 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 13

14 Brake Park Table of Contents Section 3: Electrical, Levers & Transmission ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

15 Section 3: Electrical, Levers & Transmission Brake Park Table of Contents Ref. Part No. Part Description Comments Revision dwg H D D C C C C C C C C C C C C C Drawing Image Number PARK LEVER PIVOT ASSY PARK BRAKE HANDLE PARK BRAKE LINK HSBHCS #10-24 X 3/4 RHSNB 3/8-16X1 1/4 GR5 NUT HEX PLT NUT FLANGE LOCK 3/8-16 PLT WASHER FLAT 5/16 SAE PLT WASHER LOCK #10 PIN COTTER 3/32 X 1 LONG PIN CLEVIS 5/16 X 3/4 PLT SPRING COMP.72 X 5 X.072WD SPRING COMP.85DX3.5L X.068W GRIP HANDLE.84 ID X 4 LG BSHG FLG.50IDX.62ODX.31L SWITCH, 2-POLE 12V 5A PLUNGER 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 15

16 Control Levers Table of Contents Section 3: Electrical, Levers & Transmission ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

17 Section 3: Electrical, Levers & Transmission Control Levers Table of Contents Ref. Part No. Part Description Comments Revision dwg H D D C C C C C C C C C C C C C C H H C C C C D C C C C C C C C Drawing Image Number PIVOT ARM, STEERING BAR,DRIVE CONTROL STUB BUSHING,.397ID X.75OD HHCS 3/8-16X3 GR5 DOUBLE DISK ARM PIVOT BUSHINGS WASHER FLAT 3/8 SAE PLT SPRING COMP.905OD.24W 22L NUT LOCK 3/8-16 NYLON INSERT HSHCS 3/8-16X5/8 GR5 BLK BALL STUD 10MM X 5/16-18 UNC WASHER FLAT 5/16 SAE PLT ROD ASSY,DRIVE CONTROL HHCS 5/16-18X1 1/4 GR5 NUT HEX NYLOCK 5/16-18 PLT WASHER FLAT 5/8 SAE PLT NUT 5/8-11 NYLON COLLAR THIN NUT HEX NYLOCK 5/8-11 PLT LEVER AY, DRIVE CONTROL LH LEVER AY, DRIVE CONTROL RH CAPLUG, CCF-7/ BLACK HFSS 3/8-16X1 1/2 GR5 WASHER FLAT 3/8 SAE PLT NUT LOCK 3/8-16 NYLON INSERT MOUNT, NEUTRAL SWITCH RHSNB 1/4-20X5/8 PLT NUT HEX FLANGE 1/4-20 PLT SWITCH, 2 POLE 12 V PLUNGER NUT CLIP U-TYPE 5/16-18 BALL STUD 10MM X 5/16-18 UNC DAMPER, DRIVE CONTROL BSHG FLG.31IDX.44ODX.19L GRIP, DRIVE CONTROL LEVER S/N S/N (Sub With C) 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 17

18 Deck Lift Table of Contents Section 3: Electrical, Levers & Transmission ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

19 Section 3: Electrical, Levers & Transmission Deck Lift Table of Contents Ref. Part No. Part Description Comments Revision dwg H D H D D D S D D C C C C C C C C C C C C C C C C C C C C C Drawing Image Number STOP AY, DECK HEIGHT ROD, DECK LIFT YOKE AY, DECK LIFT ADJUSTING BAR, DECK HEIGHT GAGE TRUNION, 3/4 DECK LIFT TRUNION, 5/8 DECK LIFT DECK LIFT SPRING ASSY PAWL, DECK HEIGHT GAUGE BOLT ROCKER GREASE ZERK 1/4-28 THD FORMING EXTERNAL E-RING 3/4 I.D. HEAVY HHCS 7/16-14X1 3/4 GR5 HHCS 5/16-18X1 1/2 FTHD G5 CLOSED EYE BOLT 3/8-16X4 1/2 HHCS 7/16-14X2 GR5 FTHD NUT HEX JAM 3/8-16 PLT NUT HEX WHIZ 7/16-14 PLT NUT HEX FLANGE 5/8-11 PLT NUT HEX WHIZ 3/8-16 PLT NUT HEX FLANGE 3/4-10 GR5 PLT NUT HEX 5/16-18 GR8 PLT WASHER FLAT 1/2 SAE PLT WASHER FLAT 5/8 USS PLT WASHER MACH 1 1/4X3/4X14GA PIN,CLEVIS.75X5X00 E-CLIP SPRING EXT 1 7/8ODX8 3/8X.25W SPRING, COMP 05ODX16LX.148W LID LATCH GRIP RPBY C CHAIN, 5/16 LONG LINK PROOF 3X 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 19

20 Electrical Components Section 3: Electrical, Levers & Transmission ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

21 Electrical Components Section 3: Electrical, Levers & Transmission Ref. Part No. Part Description Comments Revision dwg D D D C C C C C C C C C C C N/A C C C C C C C Drawing Image Number BRACKET, BATTERY HOLD-DOWN PANEL, CONTROL BATTERY TRAY SCREW HEX 5/16-12 X 1 THD CUTT TTHMS 1/4-20X1/2 ZNYCR RHSNB 5/16-18X3/4 GR5 RHSNB 5/16-18X3 FTHD HFSS 1/4-20X3/4 GR5 NUT HEX NYLOCK 5/16-18 PLT NUT HEX 1/4-20 ZNYCR WASHER LOCK SPRING 1/4 PLT WASHER FLAT 1/4 SAE PLT WASHER FLAT 5/16 SAE PLT BATTERY CABLE 6GA RED 32 1/4 BATTERY IGNITION SWITCH W/2 KEYS(6PIN) KEY W/SHIELD (RP FOR C) LIGHT, 14V INDICATOR BLADE SWITCH HOUR METER CABLE,4GAX24X.25X.38 BLK BATT NUT HEX FLANGE 5/16-18 PLT UL1HD (245 CCA) Or U1L-X (300CCA) B.C.I. Group Size 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 21

22 Electrical Wiring Schematic Briggs Engine Section 3: Electrical, Levers & Transmission ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

23 Electrical Wiring Schematic Briggs Engine Section 3: Electrical, Levers & Transmission Ref. Part No. Part Description Comments Revision dwg C Drawing Image Number HARNESS ASY, B&S RAZOR ENG 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 23

24 Electrical Wiring Schematic Kawasaki Engine Section 3: Electrical, Levers & Transmission ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

25 Electrical Wiring Schematic Kawasaki Engine Section 3: Electrical, Levers & Transmission Ref. Part No. Part Description Comments Revision 3. dwg C C C Drawing Image Number HARNESS ASY, KAW RAZOR ENG CABLE TIE 2 DIA MIN - BLK DIODE ASSY, STARTER 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 25

26 Electrical Wiring Schematic Main Harness Section 3: Electrical, Levers & Transmission ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

27 Electrical Wiring Schematic Main Harness Section 3: Electrical, Levers & Transmission Ref. Part No. Part Description Comments Revision dwg C D C C Drawing Image Number HARNESS ASY, RAZOR MAIN PLATE, HARNESS MOUNT RHSNB 1/4-20X5/8 PLT NUT HEX LOCK 1/4-20 FLG 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 27

28 Transmission Components ( C & C) Section 3: Electrical, Levers & Transmission ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

29 Transmission Components ( C & C) Section 3: Electrical, Levers & Transmission Ref. Part No. Part Description Comments Revision dwg C C Drawing Image Number TRANSAXLE RH, CUT GEARS TRANSAXLE LH, CUT GEARS * HG FAN/PULLY KIT HG CLIP, RETAINING RPBY HG HANDLE, BRAKE HG FILTER, OIL HG KIT, HUB, 5 BOLT HG SEAL, LIP 25X52X10 TC(GREY) SEAL KIT FOR THE ZT-2800 Shown S/N S/N Also in Seal Kit 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 29

30 Transmission to Frame Assembly Section 3: Electrical, Levers & Transmission ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

31 Transmission to Frame Assembly Section 3: Electrical, Levers & Transmission Ref. Part No. Part Description Comments Revision Dwg D L H S D D C C C C C C C C C C C C C C C C C C C C C C Drawing Image Number BUSHING,.64X00X.45L PLAIN SPRING ASSY,IZT BYPASS ROD HYDRO TENSIONER ARM, RAZOR TENSIONER ARM ASSY ROD,2800 IZT BYPASS HYD RES TUBE 1/2"ID HOSE CLAMP NO.12 3/4 ID HHCS 5/8-11X2 GR5 HFS 5/16-18X4 G5 ZNYCR HFSS 5/16-18X2 1/2 GR5 RHSNB 1/4-20X5/8 PLT NUT HEX NYLOCK 5/8-11 PLT NUT HEX FLG TP LK 5/16-18ZNYCR NUT HEX FLANGE LOCK 5/8-11 PLT NUT HEX NYLOCK 5/16-24 NUT HEX FLG TL 1/4-20 ZNYCR NUT LUG 1/2-20X60DEG PLT(.81AF WASHER FLAT 1/4 SAE PLT PIN HAIR COTTER.094 PIN COTTER 3/32 X 1/2 PULLEY,3.00X.63IDX.72W IDLER V-BELT, A-SEC EL RPBY C DOUBLE DISK ARM PIVOT BUSHINGS TANK, 350 ML EXPANSION TRANSAXLE RH, CUT GEARS TRANSAXLE LH, CUT GEARS ROD ASSY,IZT PARKING BRAKE S/N S/N /27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 31

32 Air Cleaner Kawasaki 23.5 HP Section 4: Engine, Fuel & Air Cleaner ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

33 Air Cleaner Kawasaki 23.5 HP Section 4: Engine, Fuel & Air Cleaner Ref. Part No. Part Description Comments Revision dwg N/A H H AA C C Drawing Image Number KAW FILTER-ASSY-AIR KAW FILTER CANNISTER KAW CASE-AIR FILTER KAW BRACKET KAW BRACKET KAW CAP KAW CAP KAW CAP KAW BOLT-FLANGED,6X16 FILTER ELEMENT, KAW OUTER FILTER ELEMENT, KAW INNER KAW CLAMP KAW TUBE 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 33

34 Engine Assembly Briggs & Stratton 26 HP Section 4: Engine, Fuel & Air Cleaner ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

35 Engine Assembly Briggs & Stratton 26 HP Section 4: Engine, Fuel & Air Cleaner Ref. Part No. Part Description Comments Revision dwg D D C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C R D Drawing Image Number KEY, 1/4 X 1/4 X 3 LG BRACKET, CLUTCH CLOCKING TPHMS Y #10-24 X 1/2 ZNYCR HHCS 5/16-18X1 1/2 GR5 HHCS 5/16-18X1 3/4 GR5 HHCS 5/16-18X3 1/2 GR5 FTHD RHSNB 5/16-18X1 1/2 GR5 RHSNB 1/4-20X5/8 PLT HHCS 7/16-20X2 1/4 GR8 HHCS 7/16-20X2 GR8 PLT NUT HEX PLT NUT HEX 5/16-18 PLT NUT HEX FLG TP LK 5/16-18ZNYCR NUT HEX FLG TL 1/4-20 ZNYCR WASHER LOCK 7/16 PLT WASHER FLAT #10 SAE PLT WASHER LOCK #10 WASHER INTERNAL STAR 5/16 PLT WASHER.460 X 75 X.25 PLT PULLEY, 4.5 PD X 00 ID A-SEC EXTNSION, 1 3/8X60DEG TAILPIPE ENGINE, 26HP B&S EPA RPBY C MUFFLER, 26 HP, BRIGGS VALVE, B & S OIL DRAIN FILTER, B&S INTEK ELS OIL FILTER, B&S INTEK ELS AIR SOLENOID, SEALED ENGINE STARTR RPBY A CABLE, 4GAX10X.25X.31 CABLE, 53X.062X87 CHOKE CABLE, 50X.062X12 THROTTLE CLAMP,1 1/2 MUFFLER CLUTCH, 12V HI TORQ BLD BRAKE RPBY C RPBY C HEAT SHIELD, 1/4" I.D. SPACER, ENG PTO, 1 ID,.25 THK S/N S/N S/N S/N S/N S/N S/N S/N Sold per Foot S/N /27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 35

36 Engine Assembly Kawasaki 23 HP Section 4: Engine, Fuel & Air Cleaner ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

37 Engine Assembly Kawasaki 23 HP Section 4: Engine, Fuel & Air Cleaner Ref. Part No. Part Description Comments Revision dwg D D C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C R D C Drawing Image Number KEY, 1/4 X 1/4 X 3 LG BRACKET, CLUTCH CLOCKING TPHMS Y #10-24 X 1/2 ZNYCR HHCS 3/8-16X1 1/2 GR5 HHCS 3/8-16X1 1/4 GR5 HHCS M8X25X16 GR8.8 RHSNB 1/4-20X5/8 PLT HHCS 7/16-20X2 1/4 GR8 HHCS 7/16-20X2 GR8 PLT NUT HEX PLT NUT HEX FLANGE M8X25 PLT NUT HEX FLG TL 1/4-20 ZNYCR WASHER LOCK SPRING 3/8 PLT WASHER LOCK 7/16 PLT WASHER FLAT #10 SAE PLT WASHER LOCK #10 WASHER.460 X 75 X.25 PLT PULLEY, 4.5 PD X 00 ID A-SEC MUFFLER 26HP KAW KAW, FS691V, 23HP VALVE,20MM O-RING OIL DRAIN FILTER, KAW OIL FILTER, KAW FS AIR W/CLAMP CABLE, 4GAX10X.25X.31 SWITCH,N.C. OIL PRESSURE SOLENOID, SEALED ENGINE STARTR RPBY A GASKET MUFFLER HONDA 20HP CABLE, 53X.062X87 CHOKE CABLE, 50X.062X12 THROTTLE CLUTCH, 12V HI TORQ BLD BRAKE RPBY C RPBY C HEAT SHIELD, 1/4" I.D. SPACER, ENG PTO, 1 ID,.25 THK PRE FILTER, KAW FS SERIES AIR S/N S/N S/N S/N S/N S/N S/N /27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 37

38 Engine Assembly Kawasaki 23.5 HP Section 4: Engine, Fuel & Air Cleaner ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

39 Engine Assembly Kawasaki 23.5 HP Section 4: Engine, Fuel & Air Cleaner Ref. Part No. Part Description Comments Revision dwg D D C C C C C C C C C C C C C C C C C C C C C C C C R D Drawing Image Number KEY, 1/4 X 1/4 X 3 LG BRACKET, CLUTCH CLOCKING TPHMS Y #10-24 X 1/2 ZNYCR HHCS 3/8-16X1 1/2 GR5 HHCS 3/8-16X1 1/4 GR5 HHCS 7/16-20X2 1/4 GR8 HHCS 7/16-20X2 GR8 PLT NUT HEX PLT NUT HEX FLANGE M8X25 PLT WASHER LOCK SPRING 3/8 PLT WASHER LOCK 7/16 PLT WASHER FLAT #10 SAE PLT WASHER LOCK #10 WASHER.460 X 75 X.25 PLT PULLEY, 4.5 PD X 00 ID A-SEC KAW, FX730V, 23.5HP MUFFLER 26HP KAW VALVE,20MM O-RING OIL DRAIN FILTER, KAW OIL SWITCH,N.C. OIL PRESSURE KAW (23) GASKET, MUFFLER CABLE, 53X.062X87 CHOKE CABLE, 50X.062X12 THROTTLE CLUTCH, 12V HI TORQ BLD BRAKE RPBY C RPBY C HEAT SHIELD, 1/4" I.D. SPACER, ENG PTO, 1 ID,.25 THK S/N S/N S/N S/N S/N /27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 39

40 Fuel System S/N Section 4: Engine, Fuel & Air Cleaner ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

41 Fuel System S/N Section 4: Engine, Fuel & Air Cleaner Ref. Part No. Part Description Comments Revision dwg S C C C C C C C C C C C R R R Drawing Image Number GAS TANK FITTING W/NUT&WASHER RETAINER PUSHIN, HOSE.56ID CABLE TIE 2 DIA MIN - BLK CLAMP PINCH FOR.50 OD HOSE HFSS 3/8-16X5/8 GR5 ZNYCR GROMMET,.875X25X.25T CAP, LARGE DIAMETER FUEL RH FUEL TANK, RED GRAPHICS LH FUEL TANK, RED GRAPHICS VALVE,FUEL SELECTOR FUEL FILTER FUEL FILTER HOSE RUBBER.25ID/.5 OD SAE30R7 HOSE RUBBER.25ID/.5 OD SAE30R7 HOSE RUBBER.25ID/.5 OD SAE30R7 Briggs & Stratton Kawasaki 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 41

42 Fuel System S/N Section 4: Engine, Fuel & Air Cleaner ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

43 Fuel System S/N Section 4: Engine, Fuel & Air Cleaner Ref. Part No. Part Description Comments Revision Dwg S A C C C C C C C C C C C C C C R R R R R R A AO GAR-1330 Drawing Image Number CAP, NON-VENTED FUEL RPBY GAS TANK FITTING W/NUT&WASHER SV KIT, EPA VALVE & GROMMET RETAINER PUSHIN, HOSE.56ID CABLE TIE 2 DIA MIN - BLK CLAMP PINCH FOR.50 OD HOSE CLAMP WRM DRV ( ) HFSS 3/8-16X5/8 GR5 ZNYCR GROMMET,.875X25X.25T LH FUEL TANK, RED, COMPLIANT RPBY C RH FUEL TANK, RED, COMPLIANT RPBY C VALVE,FUEL SELECTOR TEE 1/4HB POLYPROP FUEL FILTER FUEL FILTER HOSE RUBBER.25ID/.5 OD SAE30R7 HOSE RUBBER.25ID/.5 OD SAE30R7 HOSE RUBBER.25ID/.5 OD SAE30R7 HOSE RUBBER.25ID/.5 OD SAE30R7 HOSE RUBBER.25ID/.5 OD SAE30R7 HOSE RUBBER.25ID/.5 OD SAE30R7 RPBY AO-6890 RPBY A RPBY GAR-1330 RPBY A S/N S/N Use up inventory S/N + S/N S/N S/N S/N Briggs & Stratton Kawasaki 5 1/4" Lg. 32" Lg. 65" Lg. 32" Lg. 32" Lg. 36" Lg. S/N (Obsolete) S/N to S/N (Obsolete) S/N (Obsolete) S/N to S/N (Obsolete) 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 43

44 Drive Wheels Table of Contents Section 5: Wheels ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

45 Section 5: Wheels Drive Wheels Table of Contents Ref. Part No. Part Description Comments Revision dwg S C C C TR-412 Drawing Image Number TIRE/RIM ASY 20X BLT NUT LUG 1/2-20X60DEG PLT(.81AF RIM, 10X8 1/2 5 BOLT TIRE, 20X PLY TURF T VALVE MARTIN 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 45

46 Front Floating Wheels Section 5: Wheels ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

47 Front Floating Wheels Section 5: Wheels Ref. Part No. Part Description Comments Revision dwg D D H H H D D D C C C C C C C C C C C C C C C Drawing Image Number HS BRG 3/4ID X 407OD X 5/8LG BRG,.75X38X20L ROLLER SPACER TUBE RD 25ODX11GWX3 CAP, CASTER SPINDLE HUB FRONT AXLE, PIVOT PIVOT FRONT END MOUNT FORK WMT, FRONT CASTER TUBE,CASTER WHEEL AXLE BRACKET, FLOOR PAN ATTACHMENT LOCKING PIN NUT CLIP U-TYPE 5/16-18 RHSNB 3/8-16X3/4 GR5 HFSS 3/8-16X3/4 LG RHSNB 1/2-13X7 1/4 GR5 SPTHD HSBHCS 1/2-13X1 GR5 NYL HFS 5/16-18X3/4 GR5 RHSNB 3/8-16X2 3/4 GR5 PLT NUT HEX FLG LOCK 1/2-13 PLT NUT FLANGE LOCK 3/8-16 PLT WASHER FLAT 1/2 USS PLT PIN HAIR COTTER.120 PLT SPRING COMP.72 X 5 X.072WD TIRE/WHL,13X5.00-6NHS 4PR RIB BEARING, 50X69X50LG FLG BRG 00IDX04OD 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 47

48 Deck Assembly ZSR Section 6: Deck ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

49 Deck Assembly ZSR Section 6: Deck Ref. Part No. Part Description Comments Revision dwg D H H S S H H D D D D D D D C C C C C C C C C C C C C C C C C C C C C C C Drawing Image Number CHUTE BRACKET LH STRUT WMT, RAZOR RH STRUT WMT, RAZOR RH STRUT ASSY, RAZOR LH STRUT ASSY, RAZOR DECK WMT, RAZOR 60 DECK WMT, RAZOR 54 SPACER 3/4OD X 11GA WL X 3/4L CHUTE BRACKET, TOP CHUTE BRACKET, BOTTOM BELT GUARD, RAZOR 60 LH BELT GUARD, RAZOR 54 LH BELT GUARD, RAZOR 60 RH BELT GUARD, RAZOR 54 RH GREASE ZERK 1/4-28 THD FORMING RHSNB 3/8-16X1 GR5 HHCS 3/8-16X1 GR5 HHCS 1/2-13X1 3/4 GR5 HHCS 7/16-14X1 3/4 GR5 RHSNB 1/2-13X4 1/2 GR8 PLT RHSNB 1/2-13X7 1/4 GR5 SPTHD HFS 5/16-18X3/4 GR5 HFS 1/2-13X6 1/8GR5 PLT SHOULDER BOLT 3/8X1/2X5/16-18 NUT HEX WHIZ 7/16-14 PLT NUT HEX JAM 1/2-20 PLT NUT HEX NYLOCK 5/16-18 PLT NUT HEX FLG. LOCK 1/2-13 PLT. NUT NYLOCK JAM NUT 1/2-13 NUT FLANGE LOCK 3/8-16 PLT WASHER FLAT 1/2 SAE PLT RUBBER PLUG 1 3/8 W/CROSS SLIT BUMPER, 00X.31THK PUSH IN CHUTE, RUBBER DISCHARGE WHEEL, ANTI SCALP GIMBAL, 1/2 ROD END CHAIN, 5/16 LONG LINK PROOF 3X Razor ZSR60 Razor ZSR54 Razor ZSR60 Razor ZSR54 Razor ZSR60 Razor ZSR54 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 49

50 Deck Pulleys & Drive Belt ZSR Section 6: Deck ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

51 Deck Pulleys & Drive Belt ZSR Section 6: Deck Ref. Part No. Part Description Comments Revision Dwg D H D H H D D S S C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C A A A A A Drawing Image Number 1/4 SQ. KEY X 7/8 LG CW SPRING EYE-BOLT BRACKET BLADE SPINDLE SHAFT CW TG LEVER AY, BELT TENSION IDLER OVER CENTER LATCH-90 BLADE HUB BOTTOM MOUNT BLADE HUB - 7/8 (PLATED) 29T CW HUB ASSY BTM MNT 6"PULLEY SPINDLE ASSY, CW TG, 5.5 PULL GREASE ZERK STRAIGHT 1/4-28 SNAP RING EXT 7/16 HHCS 5/8-11X2 GR5 HHCS 5/8-11X2 1/2 GR5 HHCS 7/16-20X1 1/2 GR8 RHSNB 5/8-11X3 GR5 SP EYE 3/8-16X 3 7/8 HFS 1/2-20X2 1/2 GR8 NUT LOCK 3/4-16 NYLOC COLLAR NUT HEX 7/16-20 PLT NUT LOCK 5/8-18 NYLOK COLLAR P NUT HEX WHIZ 3/8-16 PLT NUT HEX FLANGE LOCK 5/8-11 PLT WASHER LOCK 7/16 PLT WASHER LOCK SPRING 5/8 PLT WASHER FLAT 3/4 HARD ASTMF436 WASHER BLADE 2ODX.56THKX.51ID PIN 1/4 X 1/2 COTTERLESS HITCH SPRING EXT BELT HANDLE B-GROOVE DRIVE PULLEY 6 O.D. B-GROOVE PULLEY 5.5 OD FLAT IDLER 6" PULLEY (6 3/4 OD FLAT IIDLER PULLEY, 6.75 O.D. V-BELT, B-SEC, EL RPBY C V-BELT, B-SEC, EL RPBY C DOUBLE DISK ARM PIVOT BUSHINGS BRG BALL 30IDX62OD 206 BRG 18IDX44OD 6206 W/SHLD MWR BLD 1/4X20.91 HL CW MWR BLD 5/16X20 29/32SD LL CW MWR BLD MULCH 1/4X20.91SD CW MWR BLD 1/4X18.77SD MLS CW MWR BLD MULCH 1/4X18.77SD CW 40/60" MWR BLADE KIT, MED LIFT 40/60" MWR BLADE KIT, LOW LIFT 40/60" MWR BLADE KIT, MULCH 54" MOWER BLADE KIT, MED LIFT 54" MOWER BLADE KIT, MULCH Razor ZSR60 Razor ZSR54 Razor ZSR60 Razor ZSR54 Razor ZSR60 S/N Razor ZSR60 S/N Razor ZSR54 S/N Razor ZSR54 S/N Razor ZSR60 Standard Razor ZSR60 Optional Razor ZSR60 Optional Razor ZSR54 Standard Razor ZSR54 Optional Razor ZSR60 Standard Razor ZSR60 Optional Razor ZSR60 Optional Razor ZSR54 Standard Razor ZSR54 Optional 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 51

52 Label Placement Table of Contents Section 7: Labels ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

53 Label Placement Section 7: Labels Ref. Part No. Part Description Comments Revision Dwg C C C C C C C C C C C C C C C C C C C C C C C C C C Drawing Image Number DECAL FLAG DECAL DANGER PD GUARD MISS SML DECAL DANGER BATTERY DECAL WARNING DO NOT OPERATE DECAL MOVING PART HAZARD DECAL ROTATING BLADE HAZARD DECAL WARNING GEN SAFE MOWER DECAL BELT ROUTING Z60 DECAL DANGER HOT DECAL DECK CUTTING HEIGHT RZR DECAL FUEL SELECTOR 3 WAY DECAL, RAZOR 2 CONTROL PANEL DECAL, PARK LEVER OPERATION DECAL, STEERING CONTROL DECAL, ROLLOVER HAZARD DECAL,CAUTION DO NOT PWR WASH DECAL LANDPRIDE 10" BROWN/GOLD DECAL,ZXT OPERATING DECAL, RAZOR SERVICE PARTS DECAL, RAZOR ZSR GOLD/RED DECAL, RAZOR ZSR GOLD/BLACK DECAL, ZSR60 DECAL, ZSR54 DECAL EPA ZMOWERS 2015 DECAL EPA ZMOWERS 2016 DECAL EPA ZMOWERS 2017 S/N Obsolete S/N to Obsolete S/N /27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 53

54 Touch-up Paints Section 7: Labels No diagram associated with this Parts List 54 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

55 Touch-up Paints Section 7: Labels Ref. Part No. Part Description Comments Revision C C C C C C CTU CTU CTU CTU CTU CTU CQT CQT CQT CQT CQT CQT CGL CGL CGL CGL CGL CGL LP BEIGE SPRAY CAN GLOSS BLACK SPRAY CAN MED. RED SPRAY TRCK/CTR GREEN SPRAY CUTTERS ORANGE SPRAY CAN BLUE SPRAY CAN LP BEIGE TOUCH-UP 5OZ GLOSS BLACK TOUCH-UP 5OZ MED RED TOUCH-UP 5OZ GREEN TOUCH-UP 5OZ ORANGE TOUCH-UP 5OZ BLUE TOUCH-UP 5OZ LP BEIGE QUART GLOSS BLACK QUART MED RED QUART GREEN QUART ORANGE QUART BLUE QUART LP BEIGE GALLON GLOSS BLACK GALLON MED RED GALLON GREEN GALLON ORANGE GALLON BLUE GALLON Spray can Spray can Spray can Spray can Spray can Spray can Touch-up bottle with brush Touch-up bottle with brush Touch-up bottle with brush Touch-up bottle with brush Touch-up bottle with brush Touch-up bottle with brush Quart can Quart can Quart can Quart can Quart can Quart can Gallon can Gallon can Gallon can Gallon can Gallon can Gallon can 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 55

56 Blade Bundle Kit Table of Contents Section 8: Accessories ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

57 Blade Bundle Kit Section 8: Accessories Ref. Part No. Part Description Comments Revision Dwg C A Drawing Image Number MWR BLD 1/4X20.91 HL CW 20.91" MWR BLD KIT, HL CW 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 57

58 Deck Lift Electric Table of Contents Section 8: Accessories ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

59 Deck Lift Electric Section 8: Accessories Ref. Part No. Part Description Comments Revision dwg A H D C C C C C C C C Drawing Image Number ELECTRIC DECK LIFT KIT, RAZOR * ELEC DECK LIFT BRACKET SPACER, 1ODX1/4WL RHSNB 3/8-16X3/4 GR5 NUT HEX FLANGE 3/8-16 PLT WASHER FLAT 1/2 SAE PLT PIN COTTER 5/32 X 1 1/2 LONG PIN CLEVIS 1/2 X 3 1/2 PLT ELECT. LINEAR ACTUATOR 4IN STK HARNESS,ELECTRIC DECK LIFT DECAL, DECK LIFT, UP DOWN Located by the Deck Cutting Height Decal 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 59

60 Light Kit Z-Mowers Section 8: Accessories ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

61 Light Kit Z-Mowers Section 8: Accessories Ref. Part No. Part Description Comments Revision dwg A D D C C C C C C C C C C C D Drawing Image Number LIGHT KIT, Z-MOWER * LIGHT BRCKT RH, Z MOWER ADAPTER PLATE LIGHT KIT CABLE TIE.19X DIA 50LB CLAMP WRM DRV #48SS (63-3.5) HFSS 1/4-20X1/2 GR5 RHSNB 3/8-16X3/4 GR5 HFSS 3/8-16X3/4 LG NUT HEX LOCK 1/4-20 FLG NUT FLANGE LOCK 3/8-16 PLT SWITCH ROCKER SPST SWITCH ACTUATOR HEADLIGHT WIRE HARNESS,LIGHT KIT Z-MOWER LIGHT BRCKT LH, Z MOWER 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 61

62 Mulch Kit Table of Contents Section 8: Accessories ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

63 Section 8: Accessories Mulch Kit Table of Contents Ref. Part No. Part Description Comments Revision dwg A A H H H H D D C C C C Drawing Image Number MULCH KIT, 60 IN RAZOR MULCH KIT, 54 IN RAZOR * MULCH BAFFLE, 60 IN, RAZOR MULCH BAFFLE, 54 IN, RAZOR MULCH PLUG, 60 IN, RAZOR MULCH PLUG, 54 IN, RAZOR MULCH PLUG COVER, 60 MULCH PLUG COVER, 54 RHSNB 3/8-16X1 GR5 RHSNB 5/16-18X1 GR5 NUT HEX WHIZ 5/16-18 PLT NUT FLANGE LOCK 3/8-16 PLT 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 63

64 Soft Top Canopy Table of Contents Section 8: Accessories ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

65 Soft Top Canopy Section 8: Accessories Ref. Part No. Part Description Comments Revision dwg A Drawing Image Number ZT SOFT TOP SUN CANOPY GREY * U-BOLT SQ. 2X3X2 TUBE MOUNTING 2" ROTATE 3/8 WASHER 3/8 NYLOCK TUBE FRONT HINGED TUBE REAR HINGED COVER FABRIC GREY STRAP ASSEMBLY 12/27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 65

66 The is a numeric index of all part numbers included in this manual. The index shows what page(s) the part is used on. Part Number Page Part Number Page Part Number Page Part Number Page H H AA D H A A D D...11, S...41, H D H H D D D D H H S S D D D D A D D L V A H S H S D D D H...11, H...11, H H H H S H H H H H S S H H H H A H H A H A S D A D D D A D D...35, 37, D...35, 37, A A A D A D D D D D D D D...11, D D D D D D D D...11, D D D D D D...35, 37, D A C C C...19, C C...17, C C C...41, C...25, 41, C C...41, C C C C C C...11, C...35, 37, C C C C C...49, C C...37, C C C C...31, C C...37, C C...11, 13, C C...19, C C C...7, 47, 59, C C C...11, 13, 47, C C...47, C C C C C C...11, C C C C C...47, C C C C C C C C... 11, 13, 17, 27, 31, 35, C C C...41, C C...11, C...11, 13, C C...35, 37, C C...35, 37, C...15, 35, 37, C C...11, C C C C...19, C C...7, C C...11, 13, 17, 21, C...27, C C C C C...17, C...7, 11, 13, 47, C...31, C C C...19, C C... 7, 15, 47, 49, 61, C C...37, C...11, 13, C...31, C C C...31, 35, C C...31, C C C...21, C C...37, C...35, 37, 39, C...11, 13, 19, 49, C C C C C...11, 13, 15, 17, C C...35, 37, C...15, 35, 37, C...11, C C C C C...35, 37, C C C C C C C C C C C C C...15, C C C C C...11, C C C C C...35, 37, ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 12/27/17

67 (continued) Part Number Page Part Number Page Part Number Page C C C C C C C C...41, C C C C C C C C...17, 31, C C C...11, 13, C C C C C C C C C C C C C C C C CGL CQT CTU C CGL CQT CTU C CGL CQT CTU C CGL CQT CTU C CGL CQT CTU C CGL CQT CTU C C C C C C C C C C...37, C C C C...37, C...41, C C...41, C...41, C C C...29, C...29, C...37, C C C C C C C C C C C C C C C...35, C...35, C...37, C C C C C C C C C C...35, C C C C C C C C C C C C C C C C...11, C...11, C C...11, C...11, C...11, C...11, C...11, C C...11, C C C C C C C C C C C C C...35, 37, C...35, 37, C C C...19, C C C C C...35, 37, C C C...35, 37, C...35, 37, C...51, R...41, R...35, 37, 39 AO Dwg Dwg Dwg Dwg Dwg dwg dwg dwg dwg dwg , 27 dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg GAR N/A...9, 21, 33 TR /27/17 ZSR54 & ZSR60 Accu-Z Razor Zero Turn Mowers P 67

68 Great Plains Manufacturing, Inc. Corporate Office: P.O. Box 5060 Salina, Kansas USA