Parts Manual. Models: ZCBI48180 MANUAL NO REV. IR (12/01/03)

Transcription

1 Parts Manual Models: ZCBI880 MANUAL NO REV. IR (/0/0)

2

3 INDEX MAIN FRAME ASSEMBLY... - CONSOLE ASSEMBLY... 8 CASTER ASSEMBLY... 9 MOTION CONTROL ASSEMBLY MOTION CONTROL LEVERS... - DECK LIFT ASSEMBLY... - IZT ASSEMBLY... - ENGINE ASSEMBLY... 8 DECAL PLACEMENT... 0 ELECTRICAL COMPONENTS... 8" DECK ASSEMBLY... - WIRING SCHEMATIC Yazoo/Kees Power Equipment. All Rights Reserved. Beatrice, NE. Printed in U.S.A.

4 MAIN FRAME ASSEMBLY ENGINE STARTER STUD REF. CASTER ASSEMBLY (TWO PER UNIT)

5 MAIN FRAME ASSEMBLY ITEM PART NO. QTY. DESCRIPTION MAINFRAME W/DECALS CASTER AXLE W/BUSHINGS BUSHING, FLANGED - PM RETAINING RING GROMMET GROMMET, RUBBER SEAT SUPPORT W/DECALS FOOT PLATE, FRONT SEAT BRACKET JAM NUTS, /C, NYLOC STUD PLATE MOUNT BUSHING, NYLON FLANGED FRAME SIDE, RIGHT FRAME SIDE, LEFT SOLENOID CLIP STRUT MOUNT SPRING, TANK MOUNT TIRE ASSEMBLY TIRE RIM VALVE STEM NUT, LUG /" BUMPER, REAR PAN, FLOOR STOP, RUBBER VALVE, FUEL SEAT MOUNT W/DECALS PUMP IDLER ARM IDLER SPINDLE PULLEY, IDLER HCS /8C X / HCS /C X / CONTINUED ON PAGES AND

6 MAIN FRAME ASSEMBLY ENGINE STARTER STUD REF. CASTER ASSEMBLY (TWO PER UNIT)

7 MAIN FRAME ASSEMBLY ITEM PART NO. QTY. DESCRIPTION SCREW, #0- X / WASHER, /, FLAT NUT, /8C, CENTER LOCK NUT, /C, NYLOC SPRING, TRACTION STUD, /C FUEL CAP INSULATOR FUEL TANK, LEFT SCREW /C X /8, SELF TAPPING HCS /C X / HCS /8C X / HCS /8C X / HCS /C X / NUT, /C, NYLOC NUT, /C, NYLOC NUT, /8C, CENTER LOCK NUT, /8C, NYLOC NUT, /8C, SERR WASHER NUT, /C, NYLOC LOCK WASHER, / WASHER, /, FLAT WASHER, /, FLAT BOLT, /-8 X /, THREAD FORMING KNOB W/STUD SEAT DECAL, Y/K WASHER, /, FLAT SWITCH, SEAT

8 CONSOLE ASSEMBLY ITEM PART NO. QTY. DESCRIPTION CONSOLE CLUTCH SWITCH THROTTLE CABLE CONTROL CONSOLE SCREW #0- X / NUT #0-, NYLOC IGNITION SWITCH KEY HOUR METER DECAL, THROTTLE CHOKE CABLE 8

9 CASTER ASSEMBLY 8 ITEM PART NO. QTY. DESCRIPTION TIRE (COMPLETE) RIM TIRE 0/0-, PLY ZERK VALVE STEM CASTER WELDMENT NUT /C, NYLOC HCS /C X / SPACER 9

10 MOTION CONTROL ASSEMBLY REF. 8 9 TO PARK BRAKE TO RIGHT IZT REF. SEE PAGE TO LEFT IZT REF. SEE PAGE REF. REF. 0 0 REF. 0

11 MOTION CONTROL ASSEMBLY ITEM PART NO. QTY. DESCRIPTION BATTERY SUPPORT, LEFT BATTERY SUPPORT, RIGHT CONTROL PIVOT SHAFT WASHER, / FLAT BUSHING, NYLON FLANGED E-RING, /" BRAKE LEVER UPPER BRAKE LEVER SPRING SWITCH N.C GRIP, PARK BRAKE SCREW, #0- X /8 MACH TAPPED PLATE CONTROL LEVER DRIVE LEVER CUSHION PUSH NUT, NYLON BOLT, /-0 X / BATTERY HOLD DOWN BATTERY, DRY LOWER CABLE END CABLE, BRAKE CABLE, RIGHT CABLE, LEFT COTTER, HAIRPIN WASHER, /8 SPRING HCS /C X HCS /8C X NUT, /C NYLOC BOLT /-8 X /, THREAD FORMING SPACER BOLT /C X /8, SHLD DAMPENER BRACKET, DAMPENER NUT /C, THIN NYLOC WASHER UPPER CABLE END

12 MOTION CONTROL LEVERS REF.

13 MOTION CONTROL LEVERS ITEM PART NO. QTY. DESCRIPTION BUSHING, NYLON FLANGED SWITCH N.C CONTROL ARM WASHER, / FLAT SCREW 0- X /, SELF TAPPING TAPBOLT /8C X / NUT /8C, CENTER LOCK CONTROL BRACKET, LEFT CONTROL BRACKET, RIGHT HCS /8C X WASHER, /8, SPRING

14 DECK LIFT ASSEMBLY REF REF REF. 0

15 DECK LIFT ASSEMBLY ITEM PART NO. QTY. DESCRIPTION CROSSSHAFT WLDMT PILLOW BLOCK REINFORCEMENT BAR LIFT ARM WLDMT BUSHING, NYLON FLANGED FOOT PEDAL WLDMT HEIGHT PLATE E-RING, /" PIN-HAIR COTTER STRUT LINKAGE LIFT LINKAGE, LEFT, PRIMARY LIFT LINKAGE, RIGHT, PRIMARY SWIVEL REAR BELLCRANK LIFT LINKAGE EYE BOLT PIN, COTTER, /8 X / DECAL, CUTTING HEIGHT CLEVIS PIN FOOT PAD HCS /C X / HCS /8C X / NUT, /C, NYLOC NUT, /8C, NYLOC WASHER, /8, FLAT WASHER, / SAE COTTER PIN, / X /8

16 IZT ASSEMBLY (Integraded Zeroturn Transaxle)

17 IZT ASSEMBLY (Integraded Zeroturn Transaxle) ITEM PART NO. QTY. DESCRIPTION TIE ROD HCS /C X / NUT, /C, NYLOC WASHER, /, FLAT HCS /C X /, GR IZT LEFT IZT RIGHT IZT SUPPORT HAIRPIN COTTER BOLT, BRAKE BUSHING, NYLON FLANGED SPRING E-RING, /" SPRING-TORSION BYPASS LINKAGE, RIGHT BRAKE "U" ARM RETAINER BYPASS LINKAGE, LEFT LOCKWASHER / CLIP IZT PUMP BELT (NOT SHOWN)

18 BRIGGS & STRATTON ENGINE ASSEMBLY GROUND WIRES MOUNTED TO SHROUD BOLT USE SHROUD BOLTS TO MOUNT TO FUEL VALVE 9 TO FUEL FILTER 8 0 TORQUE TO FT./LBS. TURNED SHOULDER ON PULLEY HUB MUST FACE THE CLUTCH 8

19 BRIGGS & STRATTON ENGINE ASSEMBLY ITEM PART NO. QTY. DESCRIPTION CLUTCH, FT/LB HCS /-0 X /, GR LOCKWASHER, / KEY, / SQ. X / BOLT, /8- X, THREAD FORMING CLUTCH HARNESS HOSE CLAMP FUEL LINE, HOSE, OIL DRAIN MUFFLER PULLEY WASHER, /8, INTERNAL TOOTH CLUTCH TIE DOWN WELDMENT CLAMP DRAIN VALVE KOHLER PIGTAIL MANIFOLD CLAMP, EXHAUST (NOT SHOWN) 9

20 DECAL PLACEMENT BACK OF SEAT ITEM PART NO. QTY. DESCRIPTION ABRASIVE PAD DECAL, WARNING DECAL, DO NOT TOW DECAL, YAZOO/KEES EURO DECAL, BATTERY WARNING DECAL, PROP DECAL, MOTION CONTROL DECAL, CUTTING HEIGHT DECAL, SERVICE EURO DANGER DECAL, BELT DRIVES DECAL, YAZOO/KEES DECAL, DRIVE LEVER DECAL, START DECAL, YAZOO/KEES DECAL, YAZOO/KEES 0

21 ELECTRICAL COMPONENTS PARK BRAKE LEFT MOTION CONTROL LEVER ACCESSORY RIGHT MOTION CONTROL LEVER 0 TO ENGINE GROUND 9 8 TO STARTER ON ENGINE TO ELECTRIC CLUTCH TO KOHLER WIRING HARNESS ITEM PART NO. QTY. DESCRIPTION BATTERY, DRY SWITCH N.C SWITCH, CLUTCH SOLENOID INSULATOR HOUR METER SWITCH, IGNITION KEY RELAY FUSE, 0 AMP FUSE,. AMP SWITCH, SEAT BATTERY CABLE, POSITIVE BATTERY CABLE, NEGATIVE WIRING HARNESS PIGTAIL WIRING HARNESS, CLUTCH

22 8" DECK ASSEMBLY

23 8" DECK ASSEMBLY ITEM PART NO. QTY. DESCRIPTION DECK W/DECAL BELT SHIELD WHEEL, GAUGE BAFFLE, VORTEX, MOWER TENSION RELIEF LEVER ROLLER, NOSE, 8" ROD, ROLLER, NOSE, NARROW IDLER PULLEY IDLER BUSHING SUPPORT PLATE PULLEY, IDLER SCREW, /-0 X /8, THDROLL SCREW, WASHER HEAD BOLT, SHOULDER DISCHARGE CHUTE SPRING, TORSION ROD, HINGE PUSHNUT CAP-SLEEVE BUSHING, PIVOT, TENSION RELIEF COTTER PIN HCS /8C X, SERRATED HEAD NUT, /C, NYLOC NUT, /8C, NYLOC RHSNB /C X BOLT, /C X /8, CARRIAGE HCS /8C X / HCS /8C, / TENSION RELIEF LINKAGE SWIVEL WASHER, /, FLAT DECAL, CPSC NUT, /C DECK BELT DECAL, BELT ROUTING DECK IDLER ARM WLDMT IDLER PULLEY IDLER SPINDLE PAD TRACTION SPRING NUT, /C, NYLOC HCS /C X WASHER, /, FLAT STRIPPER, ROUND, UNIVERSAL BLADE, HIGH LIFT WASHER-SPACER PULLEY BOLT, /, ASSY BLADE NUT, 9/, TOP CENTER LOCK CUTTER HOUSING ASM, INCLUDES:...BALL BEARINGS, MANDREL ASM,... SHAFT ASM W/LOWER BEARING DECAL, CONSUMER DECAL, 8

24 WIRING SCHEMATIC

25

26