HB-1230 BY CUSTOM EQUIPMENT LLC PARTS MANUAL SELF-PROPELLED AERIAL WORK PLATFORM SUPO-684 REV F SERIES III

Transcription

1 BY CUSTOM EQUIPMENT LLC MANUAL SELF-PROPELLED AERIAL WORK PLATFORM HB-230 SERIES III Model HB-230 Serial #Ranges: D D D D

2 NOTES If there is a question about application and/or operation, contact: Custom Equipment, LLC 2647 Hwy 75 Richfield, WI U.S.A. P: F: HB-230 2

3 FOREWORD Original instructions written in English. This parts manual is applicable to the following machines: Model HB-230 Serial #Ranges: D D D D To read the serial number plate, open the lower control panel. The serial number is located on the chassis behind the controls. An additional reference is on the platform below the manual box. HB-230 3

4 TABLE OF CONTENTS NOTES... 2 FOREWORD... 3 TABLE OF CONTENTS... 4 INDEX OF FIGURES... 5 SECTION BASE POTHOLE GUARD CASTER CASTER SUB REAR WHEEL SUB DRIVE DRIVE SUB BRAKE SUB PUMP....9 PUMP SUB BASE MISC... 4 SECTION 2 CONTROLS CONTROLS/ELECTRICAL MAIN CABLE SUB UPPER CONTROL LOWER CONTROL MASTER POWER SWITCH SUB KEY SWITCH SUB E-STOP SWITCH SUB SELECTOR SWITCH SUB...24 SECTION 3 SCISSORS HB-230 SCISSORS HB-230 CYLINDER SUB...28 SECTION 4 PLATFORM & RAILS PLATFORM & RAILS...30 SECTION 5 DECALS HB-230 DECALS...32 SECTION 6 OPTIONS & MISCELLANEOUS HB-230 OPTIONS & MISCELLANEOUS...34 HB-230 4

5 INDEX OF FIGURES FIGURE : HB-230 Pothole Guard Parts... 6 FIGURE 2: HB-230 Caster Parts... 7 FIGURE 3: K Caster Subparts...8 FIGURE 4: WHEE-68 Rear Wheel Subparts...8 FIGURE 5: HB-230 Drive Parts... 9 FIGURE 6: HB-230 Drive Subparts... 0 FIGURE 7: HB-230 Brake Subparts... 0 FIGURE 8: HB-230 Pump Parts... FIGURE 9: HYDR Pump Subparts... 2 FIGURE 0: HB-230 Misc Parts... 4 FIGURE : HB-230 Controls/Electrical Parts... 6 FIGURE 2: HB-230 Main Cable Subparts... 9 FIGURE 3: HB-230 Upper Control Parts...20 FIGURE 4: HB-230 Lower Control Parts...22 FIGURE 5: HB-230 Master Power Switch Subparts...23 FIGURE 6: HB-230 Key Switch Subparts...23 FIGURE 7: HB-230 E-Stop Switch Subparts...24 FIGURE 8: HB-230 Selector Switch Subparts...24 FIGURE 9: HB-230 Scissors...26 FIGURE 20: HB-230 Cylinder Subparts...28 FIGURE 2: Platform And Rails...30 FIGURE 22: HB-230 Decal Parts...32 FIGURE 23: HB-230 Options & Misc Parts...34 HB-230 5

6 SECTION BASE. POTHOLE GUARD FIGURE : HB-230 Pothole Guard Parts ELEC-23-5 SWITCH,LIMIT,ROT LVR,NO/NC PO 2 2 HARD-696 SPRING,EXT 2.25 X HARD-804 SPRING, EXT 4.0 X BASE,PH BAR L (HBMD) BASE,PH BAR R (HBMD) 6 RND-HB-002-P PIN,HINGE,0.50, K ASM,BASE PH ARM,L K ASM,BASE PH ARM,R HB-230 6

7 SECTION BASE.2 CASTER FIGURE 2: HB-230 Caster Parts K ASM,CASTER 2 WHEE-78 BEARING 2 3 WHEE-77 SEAL 4 WHEE-79-4 HEX SLOTTED AXLE NUT 5 WHEE-76 WASHER,.06IDX.75ODX.55THK 6 HARD-725 COTTER PIN, 3/6 X 2 7 WHEE HUB,COVER HITCH PIN,5/8 X COILED SPRING PIN, 5/32, L 2 HB-230 7

8 SECTION BASE.3 CASTER SUB FIGURE 3: K Caster Subparts BASE,CASTER WLDMNT BASE,CASTER PIN 3 HARD-00-2 DU BEARING,.0 ID X.0 L 4 4 HARD-02 RET RING WHEE-609-SS WASHER,.05ID,2OD,.03 THK SS 3 6 WHEE-706-KIT WHL,8X2,GREY NM RUBBER 2 7 WHEE-708 WHL, RACEWAY SPLIT REAR WHEEL SUB FIGURE 4: WHEE-68 Rear Wheel Subparts WHEE-67 WHL,2X4,NM RUBBER 2 WHEE-72 WHL,LUG NUT / WHEE KIT HUB,KEYWAY.0,2.0 HB-230 8

9 SECTION BASE.5 DRIVE FIGURE 5: HB-230 Drive Parts BASE,REAR PIVOT WLDMNT D D ELEC-758-L-KIT 3 ELEC-759-R-KIT DRIVE MOTOR,24V ELEC,HB,DUM,L,HT DRIVE MOTOR,24V ELEC,HB,DUM,R,HT D D , D , D D ;ORANGE/VIOLET LEADS D D , D , D D ; WHT-YEL/YEL LEADS 4 HARD-00 DU BEARING,.25 ID, LENGTH PIN,DRIVE MNT,.25,4.06 D D SET COLLAR,.25 ID D D HARD-57 KEY,0.25 X 0.25 X HARD-02 RET RING WHEE-68-KIT WHL,2X4 NM RUBBER W/HUB PIN,DRIVE MNT,.25,4.06 Superseded;D D BASE,REAR PIVOT WLDMNT Superseded;D D BASE,REAR PIVOT WLDMNT D , D , D BASE,REAR PIVOT WLDMNT D D PIN,DRIVE MNT,.25,4.06 D D WASH-026 WASHER,.25ID,.87OD,.048THK D D BASE,SPACER PIVOT D D ELEC-626-5A-KIT 7 ELEC-626-5B-KIT DRIVE MOTOR,24V ELEC,HB,DUM,R DRIVE MOTOR,24V ELEC,HB,DUM,L D , 44-45, 64-77, D ; GREY/YEL LEADS; D , 44-45, 64-77, D ; BLUE/VIOLET LEADS; HB-230 9

10 SECTION BASE.6 DRIVE SUB FIGURE 6: HB-230 Drive Subparts ELEC-627-5R DRIVE MOTOR,BRAKE LEFT BRAKE ON HB ELEC-627-5L DRIVE MOTOR,BRAKE RIGHT BRAKE ON HB ELEC-626-4A DRIVE MOTOR SHAFT SEAL,DUM 4 ELEC-626-4B.7 BRAKE SUB DRIVE MOTOR HOUSING GASKET,DUM 5 ELEC-626-4G DRIVE MOTOR GEARS,HB,DUM 6 ELEC-626-4C DRIVE MOTOR GEARBOX,DUM 7 ELEC-760-G DRIVE MOTOR GEARS,HB,DUM 8 ELEC-760-C DRIVE MOTOR GEARBOX,DUM HT D D ; D D D D ; D D D ; D D D ; D D FIGURE 7: HB-230 Brake Subparts ELEC-26-7-KIT SWITCH,LIMIT,LVR MICRO HB-230 0

11 SECTION BASE.8 PUMP FIGURE 8: HB-230 Pump Parts HYDR-09 FITTING,ELB,NPTM 3/8-/4 PUSH 2 HYDR LOW PRESSURE HOSE Quantity in inches 32 3 HYDR PUMP,24VDC,0.25,0.88,2.5 Entire Pump 4 HYDR-600 HOSE ASM,PRECUT HYDR-032 HYDRAULIC OIL Not available as a replacement part. Replace with Flomite #50, Dexron II, Mobil-DTE 2 or equivalent 6 HARD LOW FRICTION CABLE, 43/52 7 HARD-650 SET COLLAR 0.44 ID 8 LAS-M5 SCISSOR,PLATE E-DOWN ACT 9 HYDR-677 FITNG,ELB,JICM 9/6-SAEORM #6 0 HARD-62 BUSHING,.44,.63,.750 ELEC-634D TERMINAL BOOT (BLACK) BASE, E-DOWN BRKT HB-230

12 SECTION BASE.9 PUMP SUB FIGURE 9: HYDR Pump Subparts HYDR-007-2E-5 VALVE,NC,2W/2P,#8,DWN,PULL,DEL 2 HYDR-042 PUMP RESERVOIR CAP 3 HYDR PUMP RESERVOIR,0.88 GAL 4 HYDR-068 PUMP RESERVOIR O-RING 5 HYDR-664 COIL,8V 2 6 HYDR-665 VALVE,NO,2W/2P,#8,UP 7 HYDR-666- SOLENOID,24V,ISOLATED,SPST 8 HYDR-667 WASH,0.38 ID,0.75 OD,PRES SEAL HB-230 2

13 THIS PAGE WAS INTENTIONALLY LEFT BLANK HB-230 3

14 SECTION BASE.0 BASE MISC FIGURE 0: HB-230 Misc Parts HB-230 4

15 SECTION BASE BASE,COVER WLDMNT L BASE,COVER WLDMNT R BASE,INSIDE COVER WLDMNT, R D D BASE,INSIDE COVER WLDMNT,L D D HARD-067 SNAP BUTTON,0.38 SINGLE END BASE,SCISSORS LOCK K ASM,BASE,PIVOT LOCK D D K ASM,BASE MID-COVER K ASM, CLAMSHELL BASE,COVER REAR SIDE BASE,COVER REAR SIDE BASE,BLOCK GUIDE D ,44-45, D ,44-45, D ,44-45, D ,44-45, D ,44-45, BASE,BLOCK GUIDE D D BASE,BLOCK GUIDE D D BASE, LOCK, PIVOT REAR Superseded;D ,44-45, D D BASE,LOCK,PIVOT REAR D D BASE, LOCK, PIVOT REAR D03-D D BASE, LOCK, PIVOT REAR Superseded;D ,44-45, D D BASE,LOCK,PIVOT REAR D D BASE, LOCK, PIVOT REAR D D BASE,COVER,R Superseded; BASE,COVER LS Superseded; BASE,COVER LS Superseded; BASE,COVER,L Superseded; HB-230 5

16 SECTION 2 CONTROLS 2. CONTROLS/ELECTRICAL FIGURE : HB-230 Controls/Electrical Parts HB-230 6

17 SECTION 2 CONTROLS ASM,CTL LWR (HBMD S3.) ASM,CTL UPR ZTR CTL,WIRE HARNESS MAIN HB- 230 CTL,WIRE HARNESS MAIN HB- 230 CTL,WIRE HARNESS MAIN HB- 230 D D ; Lwr Ctl includes Battery Meter D D ; Used with lwr ctl that has battery meter D , 44-45, ; Includes 3-pin connector D D ; Includes 6-pin connector D D ; Includes 6-pin connector 4 HYDR-666 SOLENOID,24V,ISOLATED,SPST BOARD,DRIVE/LIFT CTL HB-MID K BOARD,DRIVE/LIFT CTL HB-MID D ,44-45,64-99, D D , D BOARD,DRIVE/LIFT CTL HB-MID D D ELEC BATTERY,2V,GR27 AGM 2 7 ELEC-634D TERMINAL BOOT (BLACK) 2 8 ELEC-634C TERMINAL COVER (RED) 3 9 ELEC-64E CABLE,6GA,BLACK,22.00,B/B CABLE,6GA,RED,0,R/R,.38 EYES CBL,6GA,RED,42&50,R/R,.38 EYES 2 ELEC-64C CABLE,6GA,RED,50,B/R 3 ELEC-64A CABLE,6GA,BLACK,63,B/B 2 4 ELEC-770 CHARGER,24V,2A AGM LES PRIME D ,09-5,49, ; FOR AGM BATT 5 ELEC-647 SENSOR,ANGLE WD WD WD WD WS WS WS WD,HB-230 S2 WD,HB-230 S2-RETRO WD,HB-230 S3 WD,HB-230 S3 ELEC SCH,HB-230 S2 ELEC SCH,HB-230 S3 ELEC SCH,HB-230 S BASE,COVER HINGE ASM,CTL LWR (HBMD S2) D ,44-45, , ; WIRING DIAGRAM D D ; WIRING DIAGRAM D D ; WIRING DIAGRAM D D ; WIRING DIAGRAM D ,44-45, , ; ELECTRICAL SCHEMATIC D D ; ELECTRICAL SCHEMATIC D D ; ELECTRICAL SCHEMATIC D ,44-45, , D ,44-45,64-99; Mates with board , Panel has hinge HB-230 7

18 SECTION 2 CONTROLS ASM,CTL LWR (HBMD S2) D D ; Mates with board , Panel has hinge ASM,CTL UPR D ,44-45, ASM,CTL LWR (HBMD S3) ASM,CTL LWR (HBMD S3 HT) ASM,CTL LWR (HBMD S3 HT.) K 23 ELEC-23-5 D ,78; Mates with board , Panel has bolt pivot D D ; Mates with board , Panel has bolt pivot D D ; Mates with board , mates with cable CTL,CHR INTERLOCK KIT FOR USE WITH ELEC-770 SWITCH,LIMIT,ROT LVR,NO/NC PO 24 ELEC-639 CORD,NEMA 5-5P/5-6R,6.0 6 INCH CHARGER PIGTAIL 25 ELEC CORD,NEMA 55/IEC C3,36 36 INCH LENGTH CHARGER CORD 26 ELEC FUSE 20 AMP AGC D D ELEC-747 CHARGER,24V 28 ELEC-770-KITC CHARGER,24V,LES PRI RETRO HBMD D D ,07-08,6-48,50-059; PCS RETROFIT TO ELEC ELEC-772 CHARGER,24V,25A,LES SLM D D ELEC-772-KITB CHARGER,24V,LES SLM RETRO MDS2 RETROFIT TO ELEC ELEC RESISTOR K OHM, WATT 32 ELEC-959 FUSE, 20A ATC D D ELEC FUSE 30 AMP,PCS 4 34 ELEC TOOL,PGT PROGRAMMER,EZ- CAL HB-230 8

19 SECTION 2 CONTROLS 2.2 MAIN CABLE SUB FIGURE 2: HB-230 Main Cable Subparts ELEC-749 CONN,CPC,PLUG,4 POS 2 ELEC-750 CABLE CLAMP,CPC,BACK SHELL 3 ELEC-752 CONTACT PIN,CPC,4-8GA TIN 2 HB-230 9

20 SECTION 2 CONTROLS 2.3 UPPER CONTROL FIGURE 3: HB-230 Upper Control Parts HB

21 SECTION 2 CONTROLS CTL,WIRE HARNESS,UPR CTL 2 ELEC-002C-KIT 3 ELEC-07-KIT SWITCH,ROTARY MAINTAINED BUTTON,PUSH/PULL RED E-STOP 4 ELEC-60-4 METER,VOLT,24V 5 WD WD,UPR CTL HB-230 S2.5/3 5 WD WD,UPR CTL HB-230 S2.5/3 D ,44-45, D ,44-45, D ,44-45, WIRING DIAGRAM D D ; WIRING DIAGRAM RAIL,CTL MNT CHNL D D ELEC-892 POWER PORT,USB 2/24V CTL,WIRE HARNESS,UPR CTL D D ELEC-606 JOYSTICK,MULTI-AXIS 0 ELEC-609 JOYSTICK,MULTI-AXIS W/ GUARD Superseded; D D ELEC-609 HARD-707 PLUG,.09 DIA, BLACK Superseded; HARD-726 HARD-726 PLUG,.09 DIA,BLACK 2 ELEC ELEC ELEC-609-KIT BUTTON,TWIST REL. RED E-STOP SWITCH, ROTARY MAINT.,2-POS JOYSTICK,MULTI-AXIS GUARD KIT D D ELEC-636 LED, RED 6 HARD-706 PLUG,0.88 DIA,BLACK HB-230 2

22 SECTION 2 CONTROLS 2.4 LOWER CONTROL FIGURE 4: HB-230 Lower Control Parts WD WD,LWR CTL HB-230 S2 WD WD,LWR CTL HB-230 S3 WD WD,LWR CTL HB-230 S3 WD WD,LWR CTL HB-230 S3 D ,44-45, , , WIRING DIAGRAM D , D D , WIRING DIAGRAM D D , WIRING DIAGRAM 2 ELEC SWITCH,MASTER DISCONNECT 3 ELEC-60-2 METER,HOUR 4 ELEC ALARM, CONTINUOUS 5 ELEC-07-KIT 6 ELEC-073D-KIT BUTTON,PUSH/PULL RED E-STOP SWITCH,KEY,3-POS MAINTAINED 7 HARD-692 PLUG,0.50 DIA,TRANSPARENT 8 ELEC-636 LED, RED 9 ELEC-60-4 METER,VOLT,24V 0 ELEC-33B SWITCH,ROCKER DPDT HB

23 SECTION 2 CONTROLS 2.5 MASTER POWER SWITCH SUB FIGURE 5: HB-230 Master Power Switch Subparts ELEC SWITCH KNOB,MASTER DISCONNECT 2.6 KEY SWITCH SUB FIGURE 6: HB-230 Key Switch Subparts ELEC-87-KIT CONTACT BLOCK,NO W/BASE 2 ELEC-603 CONTACT BLOCK,NO 3 ELEC-073EKEY KEY,SPARE HB

24 SECTION 2 CONTROLS 2.7 E-STOP SWITCH SUB FIGURE 7: HB-230 E-Stop Switch Subparts ELEC-872-KIT CONTACT BLOCK,NC W/BASE 2 ELEC-072 CONTACT BLOCK,NC 2.8 SELECTOR SWITCH SUB FIGURE 8: HB-230 Selector Switch Subparts ELEC-87-KIT CONTACT BLOCK,NO W/BASE 2 ELEC-072 CONTACT BLOCK,NC HB

25 THIS PAGE WAS INTENTIONALLY LEFT BLANK HB

26 SECTION 3 SCISSORS 3. HB-230 SCISSORS FIGURE 9: HB-230 Scissors HB

27 SECTION 3 SCISSORS HARD-00 DU BEARING,.25 ID, LENGTH 4 2 HYDR LOW PRESSURE HOSE Quantity in inches 32 3 HYDR-600 HOSE ASM,PRECUT K ASM,ROLLER,.25 W/DU 2 5 HARD-022 RET RING SET COLLAR,.25 ID 6 7 BM KIT ASM,ROLLER,.00 W/DU SCISSOR, ANG SENSOR MNT 9 ELEC-647 SENSOR,ANGLE 2 0 HARD-694 PUSH-IN BUMPER D K ASM,SCISSOR CYL HB2-ANSI 2 MISC KIT 3/8 MOLDING BOND D SCISSOR,CONDUIT BRKT D HB

28 SECTION 3 SCISSORS 3.2 HB-230 CYLINDER SUB FIGURE 20: HB-230 Cylinder Subparts HARD-00.25X.00 SLEEVE BEARING,PTFE 4 2 HYDR-02-SK CYL,SEAL KIT 2.5 B,.5 R 3 HYDR-033 VELOCITY FUSE-7.0 GPM 4 HYDR-09 FITTING,ELB,NPTM 3/8-/4 PUSH 5 HYDR-035 FITTING,ELB,JICM9/6-SAEORM#6 6 HARD X.00 FLNGE BEARING,PTFE HB

29 THIS PAGE WAS INTENTIONALLY LEFT BLANK HB

30 SECTION 4 PLATFORM & RAILS 4. PLATFORM & RAILS FIGURE 2: Platform And Rails HB

31 SECTION 4 PLATFORM & RAILS PF,CONDUIT CHANNEL LOWER STANDARD YELLOW PF,CONDUIT CHANNEL UPPER STANDARD YELLOW 3 HARD X0.50X0.9 SLD WASH,NYL W Superseded; Obsolete 0 HARD HARD X0.50X0.9 SLD WASH,NYL W PF,WLDMNT STANDARD YELLOW PF,WLDMNT,GRN GREEN RAIL,WC R STANDARD YELLOW RAIL,WC R,GRN GREEN RAIL,WC L STANDARD YELLOW RAIL,WC L,GRN GREEN RAIL,SO R STANDARD YELLOW RAIL,SO R,GRN GREEN RAIL,SO L STANDARD YELLOW RAIL,SO L,GRN GREEN RAIL, SO FLOOR BOLT-ON STANDARD YELLOW RAIL, SO FLOOR BOLT-ON,GRN GREEN 0 SCREW X 0.50 PAN HEAD SCRW 3 HARD X.25 BARREL SCRW, HARD ORING,0.25 X 5 3 HARD-656- QUICK NUT-/2 ROD SPACER,.5ID,.25OD, 0.5 THK RAIL,GATE STANDARD YELLOW RAIL,GATE,GRN GREEN RAIL,GATE LATCH KIT ASM,RAIL SLIDE LOCK STANDARD YELLOW KITG ASM,RAIL SLIDE LOCK GREEN 8 MISC-03--KIT ANTI-SLIP TAPE,4.00,54.00 LENG 3 9 LAS-M078--KIT ASM,RAIL SLIDE CHNL W/WASHERS STANDARD YELLOW 4 9 LAS-M078--KITG ASM,RAIL SLIDE CHNL W/WASHERS GREEN 4 20 MISC-03-0-KIT ANTI-SLIP TAPE,4.00,3.00 LENG K ASM,RAIL TOOL TRAY RAIL, SO TOE BOARD STANDARD YELLOW RAIL, SO TOE BOARD,GRN GREEN 23 HARD-603 MANUAL BOX 24 HARD SNAP BUTTON,SINGLE END RAIL,SO END WLDMNT Superseded; STANDARD YELLOW K RAIL,SO END WLDMNT,GRN Superseded; GREEN K HB-230 3

32 SECTION 5 DECALS 5. HB-230 DECALS FIGURE 22: HB-230 Decal Parts HB

33 SECTION 5 DECALS K K K DECALS,HB-230 S2 ANSI DECALS,HB-230 S3 ANSI DECALS,HB-230 S3 ANSI D D ; DECAL SET D D ; DECAL SET D D ; DECAL SET 2 DE77-62 DECAL,SAFETY STRIPE (2.00) 4 3 DE600E-0 DECAL,MANUAL BOX 4 DE603-6 MODEL# DECAL-HB DE708 DECAL,CLEAR 2 6 DE707 DECAL,KEEP 2 7 DE600E-4 DECAL,MAINT LOCK 2 8 DE746 DECAL,LANYARD ATTACHMENT 2 9 DE72 DECAL,CAPACITY,550#,2P,I,W/SO 2 0 DE82 DECAL,LOGO HY-BRID DE709 DECAL, LWR 2 2 DE706 DECAL,UPR HB 3 DE79 DECAL,CASTERLOCK 4 DE72 DECAL,CASTERLOCK 2 5 DE747 DECAL,BRAKE RELEASE/NO TOW 6 DE75 DECAL,E-DOWN CABLE 7 DE753 DECAL,CHARGER CORD 8 DE679 DECAL,HYDR FLUID 9 DE748 DECAL,WHEEL LOAD HB-230 S2 D D DE765 DECAL,WHEEL LOAD HB-230 S3 D D DE755 DECAL,ERROR ALARMS 2 DE777 DECAL,BATT CHARGE DAILY 22 DE782 DECAL,MADE IN USA 23 DE649 DECAL,CAPACITY, TOOL TRAY 24 DE822 DECAL,WEBSITE 2 25 DE764 DECAL, CTL UPR D D DE773 DECAL,CTL UPR ZTR D D DE704 DECAL,CTL LWR ANSI ZTR-MID 27 DE77-6 DECAL,SAFETY STRIPE (24.00) 2 28 DE797 DECAL,BATT/CHR COMPATABILITY 3 DE60 DECAL,LOGO HY-BRID Superseded; 0 DE82 33 DE652 DECAL,WEBSITE Superseded; 0 DE N/A SERIAL NUMBER 0 99 N/A SERIAL NUMBER REFERENCE 0 HB

34 SECTION 6 OPTIONS & MISCELLANEOUS 6. HB-230 OPTIONS & MISCELLANEOUS FIGURE 23: HB-230 Options & Misc Parts HB

35 SECTION 6 OPTIONS & MISCELLANEOUS K ASM,PTP HB230-S3. W PWR INV ASM,PTP HB230S2 Superseded; D D K K ASM,PTP HB230 S3. D D K BEACON,FLASHING(AMBER) HBMD S3 D D K ASM,UPR CTL CONNECTOR ALT 5 MISC-625 PAINT,YELLOW TOUCH-UP SPRAY 6 MISC-627 PAINT,GREEN TOUCH-UP SPRAY 7 MISC-624 PAINT,WHITE TOUCH-UP SPRAY 8 SUPO-667 DOCUMENT,CSA DECL HB-230 S2 D D SUPO-685 DOCUMENT,CSA DECL HB-230 S3 D D SUPO-677 MANUAL,OP HB-830/230 S3 D ,44-45,64-99, SUPO-677FRC MANUAL,OP HB-830/230 S3,FR D ,44-45,64-99, SUPO-677SPA MANUAL,OP HB-830/230 S3,FR D ,44-45,64-99, ; 3 SUPO-695 MANUAL,OP HB-830/230 S3. D D ,07-08,6-48, SUPO-695FRC MANUAL,OP HB-830/230 S3,FR D D ,07-08,6-48, SUPO-695SPA MANUAL,OP HB-830/230 S3,FR D D ,07-08,6-48, SUPO-728 MANUAL,OP HB-830/230 S3.2 D ,09-5,49, SUPO-728FRC MANUAL,OP HB-230 S3.2,FR D ,09-5,49, SUPO-728SPA MANUAL,OP HB-230 S3.2,SP D ,09-5,49, MANUAL,230 S3 20 MISC-60 MANUAL,RESPONSIBILITIES A MISC-600 MANUAL,AERIAL PF 22 SUPO-674 DOC,HB-230 UNIQUE FEATURES 23 SUPO-688 MANUAL,MAINT HB-230 S3 D D SUPO-687 MANUAL,MAINT HB-230 S3 D D SUPO-687SPA MANUAL,MAINT HB-830/230 S3,FR D D SUPO-687FRC MANUAL,MAINT HB-830/230 S3,FR D D SUPO-678 MANUAL,MAINT HB-830/230 S3 D ,44-45,64-99, SUPO-678FRC MANUAL,MAINT HB-830/230 S3,FR D ,44-45,64-99, SUPO-678SPA MANUAL,MAINT HB-830/230 S3,FR D ,44-45,64-99, ; 30 SUPO-696 MANUAL,MAINT HB-230 S3. D D ,07-08,6-48, SUPO-696FRC MANUAL,MAINT HB-830/230 S3,FR D D ,07-08,6-48, SUPO-696SPA MANUAL,MAINT HB-830/230 S3,FR D D ,07-08,6-48, SUPO-659 MANUAL,MAINT HBMD S2-RETRO D D SUPO-689 MANUAL,MAINT HB-230 S3 D D SUPO-689FRC MANUAL,MAINT HB-830/230 S3,FR D D SUPO-689SPA MANUAL,MAINT HB-830/230 S3,FR D D ; 37 SUPO-729 MANUAL,MAINT HB-230 S3.2 D ,09-5,49, SUPO-729FRC MANUAL,MAINT HB-230 S3.2,FR D D SUPO-729SPA MANUAL,MAINT HB-230 S3.2,SP D D K BEACON,FLASHING(AMBER) HBMD S2 D D HB

36 BY CU STO M EQUIPMENT LLC Self-Propelled Aerial Work Platform Parts Manual HB-230 Series III 208 Custom Equipment, LLC 2647 Highway 75 Richfield, WI Tel Fax: service@customequipmentlifts.com Hy-Brid Lifts is a trademark of Custom Equipment, LLC These machines comply with ANSI/SIA A92.6 and CSA B Revision Date: March 208 Printed in the U.S.A.