SpeedGleam /Plus. 36 Volt Dust Control Burnisher. Operator and Parts Manual

Transcription

1 SpeedGleam /Plus 36 Volt Dust Control Burnisher Model No.: SpeedGleam SpeedGleam Pac SpeedGleam Pac. Can SpeedGleam Plus SpeedGleam Plus Pac SpeedGleam Plus Pac. Can. Operator and Parts Manual NOBLES 2875 RANSOM STREET HOLLAND MI U.S.A. CUSTOMER SERVICE: FAX: Rev. 00 (0-02)

2 ELECTRICAL DIAGRAMS 20V WIRING DIAGRAM PLUS MODEL BATTERY METER AMP. METER 62 RG 62 2 HOUR METER (OPTIONAL) YEL K ADJUSTABLE FORWARD 4.7K K LOCKABLE REVERSE F DIRECTION 70 R LEFT TRIGGER RIGHT TRIGGER PAD MOTOR SAFETY OPTIONAL EMERGENCY STOP OPTIONAL KEY FLASHER MAIN BRN YEL DRIVE MOTOR MAIN 66 CONTACTOR 5 MAIN AMP CIRCUIT BREAKER CHARGER CUTOFF WARNING LIGHTS (OPTIONAL) M2 M 28 T T PAD MOTOR PAD MOTOR CONTACTOR 52 YEL UP DOWN 78 ACTUATOR BRN SPEED CONTROL BOARD HARNESS CONNECTOR OPTIONAL LOW VOLTAGE CUT OFF FUSE 2A 83 RELAY 83 AMMETER SHUNT NEGATIVE STANDOFF PAD MOTOR 80 AMP PAD MOTOR CIRCUIT BREAKER BRN BRN ACTUATOR MOTOR + (3) 2 VOLT BATTERIES 36 VDC CHARGER PLUG 3 8

3 ELECTRICAL DIAGRAMS 20V LADDER DIAGRAM PLUS MODEL (3) 2 VOLT BATTERIES 36 VDC + 34 MASTER CIRCUIT BREAKER 0 5A 4 E STOP KEY 6 MAIN G 24 MAIN BATTERY METER K LEFT TRIGGER 90 RIGHT TRIGGER REVERSE POT 50K K FOWARD POT 74 F R N.C DRIVE MOTOR 2 M2 T M T FLASHER OPTIONAL WARNING LIGHTS UP 58 BRN ACTUATOR MOTOR FUSE 2 AMP DOWN ACTUATOR 3 28 G PAD MOTOR SAFETY 47 PAD MOTOR CONTACTOR BRUSH AMMETER 80 AMMETER 80A SHUNT CIRCUIT BREAKER PAD MOTOR HOUR METER 37 YEL NOT USED 87 OPTIONAL FUNCTIONS LOW VOLTAGE PAD INTERRUPT 9

4 ELECTRICAL DIAGRAMS 20V WIRING DIAGRAM PUSH MODEL BATTERY METER AMP METER OPTIONAL KEY MAIN BRN HARNESS CONNECTOR UP DOWN ACTUATOR BRN HOUR METER (OPTIONAL) OPTIONAL FLASHER BRN BRN RIGHT TRIGGER 5 20 ACTUATOR MOTOR LEFT TRIGGER 5 AMP MAIN CIRCUIT BREAKER OPTIONAL CHARGER CUTOFF 20 RELAY 7 NEGATIVE STANDOFF OPTIONAL LOW VOLTAGE CUT OFF YEL YEL PAD MOTOR PAD MOTOR CONTACTOR PAD MOTOR SAFETY AMMETER SHUNT AMP PAD MOTOR CIRCUIT BREAKER WARNING LIGHTS (OPTIONAL) + CHARGER PLUG + (3) 2 VOLT BATTERIES 36 VDC

5 ELECTRICAL DIAGRAMS 20V LADDER DIAGRAM PUSH MODEL (3) 2 VOLT BATTERIES 36 VDC + 34 CHARGER CUT OFF (OPTIONAL) MASTER CIRCUITBREAKER 0 5A 4 44 KEY (OPTIONAL) 50 MAIN G BATTERY METER FLASHER OPTIONAL WARNING LIGHTS 82 UP 58 BRN ACTUATOR MOTOR DOWN ACTUATOR 3 88 RIGHT TRIGGER LEFT TRIGGER 86 SAFETY 46 PAD MOTOR CONTACTOR BRUSH 78 4 AMMETER 80 AMMETER SHUNT 80A CIRCUIT BREAKER PAD MOTOR HOUR METER 5 5 YEL NOT USED 56 LOW VOLTAGE PAD INTERRUPT OPTIONAL FUNCTIONS 2

6 22 MAIN HOUSING GROUP

7 MAIN HOUSING GROUP BRACKET, ELECTRICAL CHASSIS WASHER, LOCK / SCREW, M6X.0X2 PANPHL SCREW, M5X26 PANPHL DECAL, PAD CIRCIUT BREAKER SCREW, #0X5/8 PANPHL GROMMET, DIA 25.4X ASM, WIRE #4 X ASM, WIRE #4 X CONTACTOR, 36 VDC NUT, M6 NYLOCK WASHER, FLAT / SCREW, /4 20X/2 HXHDCP ASM, WIRE #4 X STANDOFF, TERMINAL NUT, M5X.8 NYLOCK SCREW, M6X6MM SHUNT SCREW, M5X26 PANPHL ASM, WIRE #4 X NUT, /4 20 KEP WASHER, #6 FLAT NUT, M5X.8 NYLOCK WASHER, 3/6 FLAT BREAKER, CIRCUIT 80 AMP DECAL, DO NOT SPRAY CHASSIS, GREEN SCREW, M6X20MM WASHER, /4 LOCK WASHER, /4 FLAT BUSHING, /4IDX3/8OD ASM., CABLE, TANK ASM., CABLE, DUST COVER SCREW, M6X.0X WASHER, /4 LOCK BRACKET, MOTOR STOP NUT, /4 X 20 KEP STOP, MOTOR GASKET, ELBOW / ELBOW, DEFLECTOR RM NAT WASHER, 3/6 FLAT SCREW, RNDPHL #0, WHEEL, RUBBER DIA 76 X 23 WD WASHER, 5/6 FLAT SCREW, M8X.25X PLUG, HOLE DIA WASHER, 5/6 FLAT WASHER, 5/6 SPLITLOCK SCREW, M8X.25X6 HXHDCP CASTER, SWIVEL DECAL, MOVING PARTS BAG, CLOTH 678 BAG, PAPER FILTER PK= SCREW, 6 32X PANPHL WASHER, 36 EXT ASM., CABLE CHARGE PLUG SPACER, CHARGER PLUG BRACKET, CHARGER PLUG NUT, 6 32 KEP NUT, M3 HEXLOCK (PLUS MODEL) WASHER, FLAT (PLUS MODEL) WASHER, /4 LOCK SCREW, M6X.0X2 PANPHL , ROLLER 5A (PLUS MODEL) PLATE, BACKING (PLUS MODEL) SCREW, M3X20 PANPHL (PLUS MODEL) DECAL, SPEEDGLEAM DECAL, SPEEDGLEAM PLUS HARNESS, WIRE MAIN (PLUS MODEL) HARNESS, WIRE MAIN DRIVE (STANDARD MODEL) DECAL, BATTERY DIAGRAM LATCH, HOOD RUBBER SCREW, M4X.7X8 PANPHL WASHER, #8 INT SUPPORT BUSHING, 5/6ID X 7/6OD X WASHER, 5/6 FLAT WASHER, 5/6 SPLITLOCK SCREW, M8X.25X6 HXHDCP SCREW, M8X.25X6 HXHDCP WASHER, 5/6 SPLITLOCK WASHER, 5/6 FLAT PLATE, LOCK CONTROL HOUSING WIRE TIE 2 23

8 DUST BAG AND BATTERY COVER GROUP 6287 COVER, DUST BAG DECAL, NOBLES LOGO DECAL, RECESS BLACK LATCH, HOOD RUBBER SCREW, M4X.7X8 PANPHL WASHER, #8 INT HINGE, DUST COVER SCREW, M6X.0X WASHER, /4 LOCK WASHER, /4 FLAT COVER, BATTERY, GREEN GRILL, BATTERY COVER SCREW, #6X/2 SHTMTL WASHER, /4 FLAT WASHER, /4 LOCK SCREW, M6X.0X HINGE, BATTERY COVER 24

9 BATTERY AND CHARGER GROUP BATTERY, 2V 25A (OPTIONAL) CABLE, BATTERY #6 BLACKX BOOT, BATTERY, BLACK BOOT, BATTERY, GASKET, BATTERY TRAY TRAY, BATTERY CHARGER, 36DC 25 AMP (OPTIONAL) 25

10 PAD DRIVER GROUP 26

11 PAD DRIVER GROUP BRACKET, MOTOR SPRING SPRING, EXT /2X4X NUT, M6X.0 NYLOCK SCREW, M6X.0X40 HXHDCP SCREW, 0 24X/2 TRSPHL CLAMP, NYLON /2 ID MOTOR, 36VDC 2000 RPM 3HP BRUSH, CARBON KEY, MOTOR 3/6X BRACKET, MOTOR SCREW, M2X.75X25 HXHDSS WASHER, /2 LOCK WASHER, FLAT.50X.25X LIFT ARM MOTOR SLEEVE,.625ODX.5B NUT, 3/8 6 JAM NYLOCK WASHER, 3/8 FLAT WASHER, NYLON SLEEVE,.5ODX.375B WASHER, 3/8 FLAT WASHER, 3/8 SPLIT LOCK SCREW, 3/8 6X3/4 HXHDCP WASHER, FLAT.77X.26X ASM., DRIVER PAD HUB, PAD DRIVER SCREW & CAPS (PACK OF 8) DISC, FLEXIBLE ASM., CENTERLOCK RING, PAD RETAINER WASHER, PAD DRIVER LOCK WASHER, 5/6 BELLEVILLE SCREW, 5/6 24X /4 HXHDCP STRAP, 3/8X74 IN SKIRT, DUST CONTROL SCREW CLAMP, BANDING SCREW, #0X5/8 PANPHL RING, DUST SHIELD SEAL, MOTOR BASE SCREW, M6X.0X20 PANPHL TERMINAL, RING /4 8GA WASHER, FLAT.25X.359X PAD, BURNISH 20 HAIRBLEND CARTON = 5 PADS 27

12 DRIVE GROUP (Drive Model) 28

13 DRIVE GROUP (Drive Model) FRAME WELDMENT SPRING, EXT X.095X SLEEVE, SPRING WHEEL, 8 DIA, 2 WIDE NEOPRENE BRACKET, TRANSAXLE MTG WASHER, FLAT 3/ WASHER, M0 SPLITLOCK SCREW, HXHD M0X SPACER, 3/4X4X/ TRANSAXLE, 36V 6RPM BODY, TRANSAXLE ONLY COUPLING, NYLON TRANSAXLE KEY, TRANSAXLE MOTOR, TRANSAXLE BRUSH, CARBON KIT BRUSHES W/CAPS (2/PK) SLEEVE, TRANSAXLE HUB, WHEEL TRANSAXLE NUT, 0 24 NYLOCK BOLT, SHOULDER.25X WASHER, INT. LOCK SCREW, SCKT /4 20X3/ WASHER, /4 FLAT NUT, /4 28 HXLOCK SCREW, M0X.50X20 HXHDCP BRACKET, SPRING ACTUATOR PIN, CLEVIS 0X28MM PIN, COTTER TERMINAL, MALE PLATE, PIVOT ARM SCREW, M6X.0X6 FLTPHL WHEEL, 4 DIAX.5X.50 GRAY WASHER,.50X.25X.06 FLAT AXLE, REAR WHEELS BUSHING,.375X WASHER, FLAT 3/ WASHER, 3/8 SPLITLOCK SCREW, 3/8 6X HXHDCP SCREW, 6 32X PANPHL , SNAP 25A LEVER NUT, 6 32 KEP 2 29

14 WHEEL GROUP (Push Model) 30

15 WHEEL GROUP (Push Model) FRAME WELDMENT WHEEL, 8X 5/ BEARING, WHEEL REPLACEMENT SPACER, 3/4X4X/ AXLE WELDMENT WASHER, M0 SPLITLOCK SCREW, HXHD M0X PLUG, CAP BLACK SCREW, M8X.25X6 HXHDCP WASHER, 5/6 SPLITLOCK WASHER, 5/6 (FOR #5020) WASHER,.24X.754X SPRING, EXT.0X BRACKET, SPRING ACTUATOR PIN, CLEVIS 0X28MM PIN, COTTER TERMINAL, MALE PLATE, PIVOT ARM SCREW, M6X.0X6 FLTPHL WHEEL, 4 DIAX.5X.50 GRAY WASHER,.50X.25X.06 FLAT AXLE, REAR WHEELS BUSHING,.375X WASHER, 3/8 FLAT WASHER, 3/8 SPLITLOCK SCREW, 3/8 6X HXHDCP SCREW, 6 32X PANPHL , SNAP 25A LEVER NUT, 6 32 KEP WASHER, FLAT.343X.25X SCREW, M0X.50X SLEEVE, SPRING 2 3

16 CONTROL CONSOLE GROUP (Drive Model)

17 CONTROL CONSOLE GROUP (Drive Model) SCREW, PAN , DPDT MOM ON/OFF METER, PAD PRESSURE METER, BATTERY VOLTAGE , LIGHTED ROCKER DECAL, PANEL, DRIVE PANEL, UPPER WIRE TIE KNOB, SPEED CONTROL GRIP, HANDLE HOUSING, CONTROL, GREEN , TOGGLE BOOT, 6470 ASM., TRIGGER CONSOLE LT 647 ASM., TRIGGER CONSOLE RT SCREW, M3 X.5 X WASHER, LOCK WASHER, FLAT, 4.3 X 2 X SPACER, TRIGGER ARM, TRIGGER CONSOLE, TRIGGER , MOMENTARY PULSE WASHER, SPRING, DISC WASHER, INT # SCREW, M4X.7X25 PAN PHL PANEL, LOWER DECAL, METER PANEL O RING,.926IDX PLUG, HOUR METER PLUG, DOME.75OD DECAL, READ MANUAL DECAL WARNING BATT PLUG, DOME.875OD FUSE HOLDER, BAYONETTE 6009 FUSE, 2AMP, 3AG FAST BLOW DECAL, CIRCUIT BREAKER CIRCUIT BREAKER, 5.0A SOLENIOD, 36V ASM., DIODE W/RING TERMINALS ASM., DIODE SPLICED NUT, M6X.0 NYLOCK WASHER, /4 FLAT BRACKET, CIRCUIT BOARD MNT CONTROLLER, PROPEL, 36VDC NUT, M4X.7 HEX WASHER, M4.3X0.X FLAT SPACER SCREW, M4X.7X25MM PAN PHL NUT, M6X.0 NYLOCK WASHER, FLAT / SCREW, M6X.0X PIN, HANDLE LOCK SPRING, LOCK PIN PIN, HANDLE ADJUSTMENT TUBE, HANDLE ADJUSTMENT SCREW, M2X70MM WASHER, LOCK / WASHER, FLAT / BUSHING HARNESS, WIRE MAIN HARNESS, POTIENTIOMETER 33

18 CONTROL CONSOLE GROUP (Push Model)

19 CONTROL CONSOLE GROUP (Push Model) SCREW, PAN , DPDT MOM ON/OFF METER, PAD PRESSURE METER, BATTERY VOLTAGE , LIGHTED ROCKER DECAL, PANEL, PUSH PANEL, UPPER WIRE TIE GRIP, HANDLE HOUSING, CONTROL, GREEN 6470 ASM., TRIGGER CONSOLE LT 647 ASM., TRIGGER CONSOLE RT SCREW, M3 X.5 X WASHER, LOCK WASHER, FLAT, 4.3 X 2 X SPACER, TRIGGER ARM, TRIGGER CONSOLE, TRIGGER , MOMENTARY PULSE WASHER, SPRING, DISC WASHER, INT # SCREW, M4X.7X25 PAN PHL PANEL, LOWER DECAL, METER PANEL O RING,.926IDX PLUG, HOUR METER PLUG, DOME.75OD DECAL, READ MANUAL DECAL WARNING BATT DECAL, CIRCUIT BREAKER CIRCUIT BREAKER, 5.0A PIN, HANDLE LOCK SPRING, LOCK PIN PIN, HANDLE ADJUSTMENT TUBE, HANDLE ADJUSTMENT SCREW, M2X70MM WASHER, LOCK / WASHER, FLAT / BUSHING HARNESS, WIRE MAIN 35

20 OPTIONS HOUR METER, LOW VOLTAGE SHUT-OFF, EMERGENCY STOP AND KEY KITS KIT, HOUR METER HOUR METER & HARDWARE 6294 KIT, LOW VOLTAGE SHUT-OFF GAUGE, BATTERY ASM., RELAY LOW VOLTAGE KIT ASM., WIRE #8X9 GREEN ASM., WIRE #8X8 BLACK ASM., WIRE #8X WIRE TIE, NYLON KIT, KEY KEY KEY, REPLACEMENT 6297 KIT, EMERGENCY STOP , EMERGENCY STOP BUTTON , CONTACT BLOCK ASM, WIRE #6X5 /4FX/4F ASM, WIRE #6X5 /4MX/4F 36

21 OPTIONS FLASHING LIGHT KIT KIT, FLASHING LIGHTS SHIELD, LIGHT SCREW, #6X/2 SHTMTL CLAMP, WIRE LIGHT, SAFETY GASKET BUSHING, STRAIN RELIEF BRACKET, HOLE COVER FLASHER, 36VDC TAPE, ACRYLIC FOAM 37

22 OPTIONS PARKING BRAKE KIT KIT, PARKING BRAKE CLAMP, PARKING BRAKE BRACKET, PARKING BRAKE SCREW, #0 24X3/ WASHER, #0 4 38