SWITCH BLADE PART'S MANUAL. 5 ft. & 6 ft. Sickle Bar Mower Model With Hydraulic Break-A-Way
|
|
- Margery Todd
- 5 years ago
- Views:
Transcription
1 Published 02/05 SWITCH BLADE 5 ft. & 6 ft. Sickle Bar Mower Model With Hydraulic Break-A-Way PART'S MANUAL P/N P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this machine and must be maintained with the unit at all times. READ, UNDERSTAND, and FOLLOW the Safety and Operation Instructions contained in this manual before operating the equipment. If the Operator's Manual is not with the equipment, contact your dealer or Alamo Industrial ( ) to obtain a Free copy before operating the equipment. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Alamo Group Inc.
2
3 TO THE OWNER/OPERATOR/DEALER All implements with moving parts are potentially hazardous. There is no substitute for a cautious, safe-minded operator who recognizes the potential hazards and follows reasonable safety practices. The manufacturer has designed this implement to be used with all its safety equipment properly attached to minimize the chance of accidents. BEFORE YOU START!! Read the safety messages on the implement and shown in your manual. Observe the rules of safety and common sense! WARRANTY INFORMATION: Read and understand the complete Warranty Statement found in this Manual. Fill out the Warranty Registration Form in full and return it to within 30 Days. Make certain the Serial Number of the Machine is recorded on the Warranty Card and on the Warranty Form that you retain.
4
5 PARTS ORDERING GUIDE The following instructions are offered to help eliminate needless delay and error in processing purchase orders for the equipment in this section. 1. The Parts Section is prepared in logical sequence and grouping of parts that belong to the basic machine featured in this manual. Part Numbers and Descriptions are given to help locate the parts and quantities required. 2. The Purchase Order must include the name and address of the person or organization ordering the parts, who should be charged, and if possible, the serial number of the machine for which the parts are ordered. 3. The Purchase Order must clearly list the quantity of each part, the complete and correct part number (be sure to include all periods), and the basic name of the part. 4. The Manufacturer reserves the right to substitute parts where applicable. 5. Some parts are unlisted items which are special production items not normally stocked and are subject to special handling. Request a quotation for such parts before sending a Purchase Order. 6. The Manufacturer reserves the right to change prices without prior notice. NOTE: Please refer to The Safety Section in the front of this Manual for the proper Part Number when ordering Replacement Safety Decals. For maximum safety and to guarantee optimum product reliability, always use genuine Servis-Rhino Parts. The use of inferior replacement parts may cause premature or catastrophic failure which could result in serious injury or death. Direct any questions regarding parts to: ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Alamo Group Inc. Parts Section - 1
6 Parts Section - 2 PARTS SECTION
7 PART NAME INDEX CARRIAGE ARM ASY - LH WING - P/N CARRIAGE ARM ASY - RH WING - P/N COMMON COMPONENT BOX - RH SINGLE WING - P/N COMMON COMPONENT BOX - LH DUAL WINGS - P/N CONTROL VALVE REMOTE CABLES ASY CONTROL VALVE ASY W/O FITTINGS P/N CONTROL VALVE ASY W/ FITTING CYLINDER ASY - BAR TILT - P/N A CYLINDER ASY - CURB LIFT - P/N A DECALS - CAB & ROPS DECALS - FRAME AND TANK DIVERTER VALVE - P/N MOTOR CONTROL - LH DUAL WING DIVERTER VALVE - P/N CYLINDER CONTROL - LH DUAL WING DIVERTER VALVES & LH DUAL WING HYDRAULIC DIAGRAM - RH SINGLE WING HYDRAULIC TANK ASSEMBLY P/N KNIFE DRIVE ASSEMBLY P/N MOTOR ASSEMBLY P/N MOTOR VALVE CONTROL SOLENOID ASY P/N PUMP ASY - P/N S/N SWB (09-04) & DOWN PUMP ASY - P/N A - S/N SWB (10-04) & UP PUMP ASY - P/N S/N SWB (09-04) & DOWN PUMP ASY - P/N A - S/N SWB (10-04) & UP SHOE,DRIVE & BREAKAWAY - LH MOUNTED ASY P/N SHOE,DRIVE & BREAKAWAY - RH MOUNTED ASY P/N SKID SHOE & BREAKAWAY PRE-ASY - LH MOUNTED P/N SKID SHOE & BREAKAWAY PRE-ASY - RH MOUNTED P/N WIRE HARNESS ASY - P/N RH SINGLE WING WIRE HARNESS ASY - P/N LH DUAL WING CUTTER BAR ASY - LH WING - P/N CUTTER BAR ASY - RH WING - P/N KNIFE BAR ASY - LH WING - P/N KNIFE BAR ASY - RH WING - P/N CUTTER BAR ASY - LH WING - P/N CUTTER BAR ASY - RH WING - P/N KNIFE BAR ASY - LH WING - P/N KNIFE BAR ASY - RH WING - P/N Alamo Group Inc. Parts Section 3
8 COMMON COMPONENT BOX - RH SINGLE WING - P/N Alamo Group Inc. Parts Section 4
9 COMMON COMPONENT BOX - RH SINGLE WING - P/N COMMON COMPONENT BOX RH SINGLE WING * DECAL, PELIGRO (NOT SHOWN MOUNT IN CAB OR ON FENDER) PUSH PULL SWITCH ( W/ ITEM # 3 ) SWITCH KNOB ( REPLACEMENT PART ) FACE NUT ( REPLACEMENT PARTS ) JAM NUT ( REPLACEMENT PARTS ) * DECAL, PROPER ENGINE OPERATING (NOT SHOWN MOUNT IN CAB OR ON FENDER) * DECAL, KNIFE CLEARANCE (NOT SHOWN MOUNT IN CAB OR ON FENDER) FILTER ELEMENT WIRE HARNESS DECAL, VALVE & SWITCH OPERATION POSITION TOGGLE SWITCH HYDRAULIC TANK ASY. ( INCLUDES ITEM # 18 ) VALVE ASY. 2 SPOOL W/ FITTINGS TOGGLE SWITCH BOOT COVER DECAL, REVERSING SWITCH INSTRUCTION * DECAL, WARNING SIGN (NOT SHOWN MOUNT IN CAB OR ON FENDER) A 1 SB5/6 OPERATORS MANUAL ASY BREAK-A-WAY VALVE KIT ( CONSIST OF NEXT 6 ITEMS ) VALVE BODY CARTRIDGE RELIEF PIPE PLUG HYD. ELBOW ADAPTER BOLT LOCKNUT ROTOR ACTUATOR ( NOT INCLUDED IN COMMON COMPONET BOX ) HOSE, # 8-14" LG ( TANK RETURN F/ SOLENOID TO RETURN FILTER INCLUDED IN ITEM # 10 ) HYD. TEE ADAPTER DECAL, CUTTERHEAD BREAK-A-WAY RESET INSRUCTIONS NOTE * : Some decals will be mounted in view of the operator on the cab window, tractor fender or other place where operator can see them Alamo Group Inc. Parts Section 5
10 COMMON COMPONENT BOX - LH DUAL WINGS - P/N Alamo Group Inc. Parts Section 6
11 COMMON COMPONENT BOX - LH DUAL WINGS - P/N COMMON COMPONENT BOX DUAL WINGS * DECAL, PELIGRO (NOT SHOWN MOUNT IN CAB OR ON FENDER) PUSH PULL SWITCH ( W/ ITEM # 3 ) SWITCH KNOB ( REPLACEMENT PART ) FACE NUT ( REPLACEMENT PART ) JAM NUT ( REPLACEMENT PART ) * DECAL, PROPER ENGINE OPERATING (NOT SHOWN MOUNT IN CAB OR ON FENDER) * DECAL, KNIFE CLEARANCE (NOT SHOWN MOUNT IN CAB OR ON FENDER) FILTER ELEMENT WIRE HARNESS DECAL, VALVE & SWITCH OPERATION POSITION TOGGLE SWITCH HYDRAULIC TANK ASY. ( INCLUDES ITEM # 18 ) VALVE ASY. 2 SPOOL W/ FITTINGS TOGGLE SWITCH BOOT COVER DECAL, REVERSING SWITCH INSTRUCTION * DECAL, WARNING SIGN (NOT SHOWN MOUNT IN CAB OR ON FENDER) A 1 SB5/6 OPERATORS MANUAL ASY BREAK-A-WAY VALVE KIT ( CONSIST OF NEXT 6 ITEMS ) VALVE BODY CARTRIDGE RELIEF PIPE PLUG HYD. ELBOW ADAPTER BOLT LOCKNUT ROTOR ACTUATOR ( NOT INCLUDED IN COMMON COMPONET BOX ) HOSE, # 8-14" LG ( TANK RETURN F/ SOLENOID TO RETURN FILTER INCLUDED IN ITEM # 10 ) HYD. TEE ADAPTER DIVERTER VALVE / SOLENOID, # 8 PORTS F/ MOTOR (F/ DUAL WINGS) HYD. ELBOW ADAPTER HYD. ADAPTER, STRAIGHT HYD. ADAPTER ELBOW DIVERTER VALVE / SOLENOID, # 4 PORTS F/ CYLINDERS (F/ DUAL WINGS) HYD. ELBOW ADAPTER HYD. ADAPTER STRAIGHT WIRE HARNESS, LH DUAL WINGS (NOT SHOWN) DECAL INST. LH & RH SWITCH (NOT SHOWN MOUNT IN CAB OR ON FENDER) SWITCH SPST 2-POSITION ( LH DUAL WINGS ) DECAL, CUTTER BREAK-A-WAY RESET INSTRUCTIONS NOTE * : Some decals will be mounted in view of the operator on the cab window, tractor fender or other place where operator can see them. NOTE: Some Items listed above are only used with dual LH & RH Wing Units, some items shown in drawing will be included with the RH unit. NOTE: Diverter Valves and Cylinder Control Valve will have markings on them to match the markings in the drawing Alamo Group Inc. Parts Section 7
12 HYDRAULIC TANK ASSEMBLY P/N Alamo Group Inc. Parts Section 8
13 HYDRAULIC TANK ASSEMBLY P/N HYDRAULIC TANK ASSEMBLY LOCKWASHER HYD. ADAPTER ELBOW HYD. ADAPTER STRAIGHT BOLT MAGNETIC DRAIN PLUG LOCKNUT HYD. ADAPTER ELBOW DECAL - WARNING HOSE BURST DECAL - UNIVERSAL TRACTOR GAUGE, SIGHT/TEMPERATURE VALVE SOLENOID CONTROL FILTER ASY, W/ INT FILLER/BREATHER & GAUGE SUCTION STRAINER HOSE, # 8-14"LG HYDRAULIC TANK WLD MT COVER, TANK ACCESS HYD. ADAPTER ELBOW D 1 COVER GASKET BOLT BOLT DECAL - NAME SWITCH BLADE SICKLE ELBOW, STREET WASHER, SEALING LOCKWASHER FLATWASHER BOLT CANISTER, PARTS MANUAL CA 1 CANISTER, MANUAL ASY DECAL - OPERATORS MANUAL INSIDE 2005 Alamo Group Inc. Parts Section 9
14 CARRIAGE ARM ASY - RH WING - P/N CARRIAGE ARM ASY RED LUBRICAPS GREASE FITTING COTTER PIN CARRIAGE PIN PIN ROLL ELBOW HOSE TEE SWIVEL ADAPTER CARRIAGE ARM WLD MT PIVOT MOUNT WLD MT CYLINDER LUG PIN A 1 CURB LIFT CYLINDER A 1 BAR TILT CYLINDER DECAL-MULTIPLE HAZARD DECAL, TRIUMPH LOGO NFS S/N PLATE (NOT AVAILABLE AS PARTS) SWITCHBLADE 5 & 6 HYD. BRK-A-WAY (02-05) 2006 Alamo Group Inc. Parts Section 10
15 CARRIAGE ARM ASY - LH WING - P/N CARRIAGE ARM ASY, LH WING RED LUBRICAPS GREASE FITTING COTTER PIN CARRIAGE PIN PIN ROLL ELBOW DECAL, MULTIPLE HAZARD HOSE, # 4-18" LG HYD. ADAPTER CARRIAGE ARM WLD MT, LH PIVOT MOUNT WLD MT PIN FOR CYLINDER LUGS A 1 CURB STOP CYLINDER ASY A 1 BAR LIFT CYLINDER ASY 2005 Alamo Group Inc. Parts Section 11
16 SHOE,DRIVE & BREAKAWAY - RH MOUNTED ASY P/N Alamo Group Inc. Parts Section 12
17 SHOE,DRIVE & BREAKAWAY - RH MOUNTED ASY P/N SHOE, DRIVE & BREAKAWAY ASY SPACER, CUTTER BAR MOTOR COVER WLD MT ROD DEFLECTOR BOLT BOLT SKID SHOE & ACTUATOR PRE-ASY HORIZONTAL KNIFE DRIVE ASY MOTOR, GEROTOR BRACKET HYDRAULIC, MOTOR ADAPTER TUBE, 4-5/8" LG TUBE, 3-3/4" LG PLOW BOLT, # SHOE BOTTOM PLOW BOLT, # NUT LOCKNUT FLATWASHER 18 5C JAM NUT LOCKNUT HYD. ADAPTER STRAIGHT HYD. ADAPTER STRAIGHT LOCKWASHER BOLT BOLT LOCKNUT FLATWASHER DECAL, GREASE FITTING INSIDE 2005 Alamo Group Inc. Parts Section 13
18 SHOE,DRIVE & BREAKAWAY - LH MOUNTED ASY P/N Alamo Group Inc. Parts Section 14
19 SHOE,DRIVE & BREAKAWAY - LH MOUNTED ASY P/N SHOE, DRIVE & BREAK-A-WAY ASY, LH MOUNT SHOE, DRIVE & BREAK-A-WAY PRE-ASY, LH MOUNT CUTTER BAR SPACER PLOW BOLT PLOW BOLT TUBE TUBE HORIZONTAL KNIFE DRIVE ASY HYD. MOTOR ADAPTER, BRKT MOTOR ASY BOLT HYD. ADAPTER STRAIGHT HYD. ADAPTER SHOE BOTTOM LOCKNUT DEFLECTOR ROD, LH 16 5C NUT NUT LOCKNUT FLATWASHER HYD. ADAPTER STRIAGHT MOTOR COVER WLD MT, LH LOCKWASHER BOLT BOLT LOCKNUT FLATWASHER DECAL - GREASE FITTING INSIDE 2005 Alamo Group Inc. Parts Section 15
20 SKID SHOE & BREAKAWAY PRE-ASY - RH MOUNTED P/N SKID SHOE & BREAK-A-WAY PRE-ASY SKID SHOE WLD MT ROTOR ACTUATOR BREAK-A-WAY PIN WLD MT LOCKWASHER BOLT RUBBER BUMPER PAD WASHER BACK PIVOT PLATE, TAPPED LOCKWASHER LOCKWASHER BOLT BOLT 2005 Alamo Group Inc. Parts Section 16
21 SKID SHOE & BREAKAWAY PRE-ASY - LH MOUNTED P/N SKIDSHOE & BREAK-A-WAY PRE-ASY. LH MOUNTED SKID SHOE WLD MT ROTOR ACTUATOR BACK PIVOT PLATE, TAPPED BREAK-A-WAY PIN WLD MT LOCKWASHER BOLT RUBBER BUMBER PAD FLATWASHER LOCKWASHER BOLT LOCKWASHER BOLT 2005 Alamo Group Inc. Parts Section 17
22 5 CUTTER BAR ASY - RH WING - P/N CUTTER BAR ASY. RH WING NUT LOCKWASHER LOCKWASHER CARRIAGE BOLT KNIFE CLIP HIGH PLOW BOLT NUT OUTER SHOE SOLE, RH CARRIAGE BOLT KNIFE CLIP CUTTER BAR, WEAR PLATE OUTER SHOE ASSEMBLY, RH PLOW BOLT WEAR PLATE OUTER ROCK GUARD, RH CENTER ROCK GUARD INNER ROCK GUARD, RH CARRIAGE BOLT 2005 Alamo Group Inc. Parts Section 18
23 5 CUTTER BAR ASY - LH WING - P/N CUTTER BAR ASY. LH WING NUT LOCKWASHER LOCKWASHER CARRIAGE BOLT KNIFE CLIP HIGH PLOW BOLT NUT OUTER SHOE SOLE, LH CARRIAGE BOLT KNIFE CLIP CUTTER BAR, WEAR PLATE OUTER SHOE ASSEMBLY PLOW BOLT WEAR PLATE OUTER ROCK GUARD CENTER ROCK GUARD INNER ROCK GUARD, LH CARRIAGE BOLT 2005 Alamo Group Inc. Parts Section 19
24 5 KNIFE BAR ASY - RH WING - P/N KNIFE BAR, ASY RH WING SERRATED KNIFE SECTION, 3" KNIFE PROTECTOR, CARDBOARD 63" INSERT NYLON DRIVE BRG CLAMP KNIFE HEAD WLD MT BOLT SECTION BOLT HEAD BOLT LOCKNUT M 1 BACKING STRIP, Alamo Group Inc. Parts Section 20
25 5 KNIFE BAR ASY - LH WING - P/N KNIFE BAR ASY, LH WING SERRATED KNIFE SECTION, 3" KNIFE PROTECTOR, CARDBOARD 63" INSERT NYLON DRIVE BRG CLAMP KNIFE HEAD WLD MT BOLT SECTION BOLT HEAD BOLT LOCKNUT M 1 BACKING STRIP, Alamo Group Inc. Parts Section 21
26 6 CUTTER BAR ASY - RH WING - P/N CUTTER BAR ASY, RH WING NUT LOCKWASHER LOCKWASHER CARRIAGE BOLT KNIFE CLIP HIGH PLOW BOLT NUT OUTER SHOE SOLE, RH WING CARRIAGE BOLT KNIFE CLIP BAR CUTTER, WEAR PLATE OUTER SHOE ASY, RH WING PLOW BOLT WEAR PLATE OUTER ROCK GUARD, RH WING CENTER ROCK GUARD INNER ROCK GUARD, RH CARRIAGE BOLT 2005 Alamo Group Inc. Parts Section 22
27 6 CUTTER BAR ASY - LH WING - P/N CUTTER BAR ASY, RH WING NUT LOCKWASHER LOCKWASHER CARRIAGE BOLT KNIFE CLIP HIGH PLOW BOLT NUT OUTER SHOE SOLE CARRIAGE BOLT KNIFE CLIP BAR CUTTER, WEAR PLATE OUTER SHOE ASSEMBLY PLOW BOLT WEAR PLATE OUTER ROCK GUARD CENTER ROCK GUARD INNER ROCK GUARD, RH CARRIAGE BOLT 2005 Alamo Group Inc. Parts Section 23
28 6 KNIFE BAR ASY - RH WING - P/N KNIFE BAR ASY, RH WING SERRATED KNIFE SECTION, 3" KNIFE PROTECTOR, CARDBOARD 63" INSERT NYLON DRIVE BRG CLAMP KNIFE HEAD WLD MT BOLT SECTION BOLT HEAD BOLT LOCKNUT BACKING STRIP, Alamo Group Inc. Parts Section 24
29 6 KNIFE BAR ASY - LH WING - P/N KNIFE BAR ASY, LH WING SERRATED KNIFE SECTION, 3" KNIFE PROTECTOR, CARDBOARD 63" INSERT NYLON DRIVE BRG CLAMP KNIFE HEAD WLD MT BOLT SECTION BOLT HEAD BOLT LOCKNUT BACKING STRIP, Alamo Group Inc. Parts Section 25
30 KNIFE DRIVE ASSEMBLY P/N KNIFE DRIVE ASY FLYWHEEL HUB ADAPTER KNIFE DRIVE STUD ASY. 4* SOCKET HEAD CAPSCREW, ( TORQUE TO 35 FT. LBS ) SUPPORT HORIZONTAL KNIFE DRIVE HEX BOLT NOTE: * Torque Bolts Item # 4 to 35 ft. lbs. Drive Assembly P/N will include items 1, 2, 3 & 4. It WILL NOT include items 5 & 6 in the assembly Alamo Group Inc. Parts Section 26
31 MOTOR ASSEMBLY P/N MOTOR GEROTOR 2.8 CID, 1" SHAFT INTERNAL DRIVE SHAFT STAR & HOUSING SET HOUSING TIE SCREW FLANGE ATTACHMENT SCREW FLANGE MOUNT THRUST BEARING RACE THRUST BEARING OUTPUT SHAFT MOTOR HOUSING PLUG SPACER PLATE END CAP 13 MA KEY * REF SEAL KIT ( INCLUDES ITEMS W / * ) 2005 Alamo Group Inc. Parts Section 27
32 PUMP ASY - P/N S/N SWB (09-04) & DOWN PUMP ASY, 1.16/0.49 CID/REV (STEEL MOUNTING FLANGE & END CAP) CONNECTING SHAFT GEAR SET GEAR SET END CAP (STEEL END CAP) MOUNTING FLANGE (STEEL MOUNTING FLANGE) GEAR HOUSING GEAR HOUSING HOUSING TIE BOLT DOWEL PIN DOWEL PIN MID SPACER PLATE THRUST BLOCK (F/ LARGE OR SMALL GEAR SECTION, Not Included In Seal Kit) WASHER REF Seal Kit (Includes Seal for Both Large and Small Gear Section)
33 PUMP ASY - P/N A - S/N SWB (10-04) & UP A -- PUMP ASY, 1.16/0.49 CID/REV (ALUMINUM MOUNTING FLANGE & END CAP) MOUNTING FLANGE, (ALUMINUM MOUNTING FLANGE) END CAP, (ALUMINUM END CAP) HOUSING, (F/ LARGE GEAR SECTION) MID SECTION SPACER PLATE HOUSING, (F/ SMALL GEAR SECTION) SEAL, BACK UP (INCLUDED N SEAL KIT) DRIVE GEAR, (LARGE GEAR) DRIVEN GEAR, (LARGE GEAR) DRIVE GEAR, (SMALL GEAR) DRIVEN GEAR, (SMALL GEAR) SHAFT SEAL, (INCLUDED IN SEAL KIT) SNAP RING THRUST BLOCK, (F/ LARGE OR SMALL GEAR SECTION, Not Included In Seal Kit) CHANNEL SEAL, (INCLUDED IN SEAL KIT) WASHER FASTENER, (173MM) NUT SECTIONAL SEAL, (INCLUDED IN SEAL KIT) PIN, DOWEL, (SHORT PIN) PIN, DOWEL, (LONG PIN) CONNECTING, SHAFT SEAL KIT, (F/ LARGE GEAR SECTION) SEAL KIT, (F/ SMALL GEAR SECTION) NOTE: Seal Kit Item 22 includes input seal (1), backup seals (2), channel seals (2) and section seal o-rings (2)or first pump section. NOTE: Seal Kit Item 23 includes backup seals (2), channel seals (2) and section seal o-rings (2)or second pump section.
34 PUMP ASY - P/N S/N SWB (09-04) & DOWN PUMP ASY, 0.98/0.37 CID/REV (STEEL END CAP & MOUNTING FLANGE) CONNECTING SHAFT GEAR SET, (SMALL GEARS) GEAR SET, (LARGE GEARS) END CAP (STEEL END CAP) MOUNTING FLANGE (STEEL MOUNTING FLANGE) GEAR HOUSING (F/ SMALL GEAR END) GEAR HOUSING (F/ LARGE GEAR END) HOUSING TIE BOLT DOWEL PIN, (F/ MOUNTING FLANGE) DOWEL PIN, (F/ GEAR HOUSINGS) MID SPACER PLATE THRUST BLOCK (F/ SMALL OR LARGE GEAR SECTION, Not Included In Seal Kit) WASHER (F/ HOUSING TIE BOLTS) REF SEAL KIT (Seal Kit for Large And Small Gear Section) 2005 Alamo Group Inc. Parts Section 30
35 PUMP ASY - P/N A - S/N SWB (10-04) & UP A -- PUMP ASY, 0.98/0.37 CID/REV (ALUMINUM MOUNTING FLANGE & END CAP) WASHER MID SPACER PLATE PIN, DOWEL PIN, DOWEL CONNECTING, SHAFT MOUNTING FLANGE (ALUMINUM MOUNTING FLANGE) END CAP ( ALUMINUM END CAP ) GEAR HOUSING, ( F/ LARGE GEAR SET ) GEAR HOUSING, ( F/ SMALL GEAR SET ) DRIVE GEAR & INPUT SHAFT ( F/ LARGE GEAR ) DRIVEN GEAR ( F/ LARGE GEAR ) DRIVE GEAR ( F/ SMALL GEAR ) DRIVEN GEAR ( F/ SMALL GEAR ) HOUSING TIE BOLT MM SNAP RING THRUST BLOCK, (F/ LARGE OR SMALL GEAR SECTION, Not Included In Seal Kit) INPUT SEAL, (INCLUDED IN SEAL KIT) SEAL KIT, (F/ LARGE GEAR SECTION) SEAL KIT, (F/ SMALL GEAR SECTION) NOTE: Seal Kit Item 18 includes input seal (1), backup seals (2), channel seals (2) and section seal o-rings (2)or first pump section. NOTE: Seal Kit Item 19 includes backup seals (2), channel seals (2) and section seal o-rings (2)or second pump section Alamo Group Inc. Parts Section 31
36 CONTROL VALVE ASY W/ FITTING VALVE ASY, W/ FITTINGS ( 2-SPOOL ) VALVE, DIRECTIONAL CONTROL HYD. ADAPTER STRAIGHT HYD. ADAPTER STRAIGHT HYD. TEE ADAPTER HYD. ADAPTER 2005 Alamo Group Inc. Parts Section 32
37
38 CONTROL VALVE ASY W/O FITTINGS P/N Alamo Group Inc. Parts Section 33
39 CONTROL VALVE ASY W/O FITTINGS P/N VALVE ASY, 2 SPOOL W/O FITTINGS UNLOAD PLUNGER POPPET ASY SPACER SPOOL SEAT ASY PLUG ASY PLUG ASY BUSHING LOCKOUT SPRING CAP ASY PLUG ASY BODY POPPET SEAT O-RING RETAINING RING AR WASHER AR WASHER AR WASHER WASHER CAP ASY SPRING SPRING PLUG ASY WASHER WASHER BALL SPRING SPRING CONE SPACER ADAPTER CAP AR WASHER WIPER SEAL HANDLE KIT 2005 Alamo Group Inc. Parts Section 34
40 CONTROL VALVE REMOTE CABLES ASY 2005 Alamo Group Inc. Parts Section 35
41 CONTROL VALVE REMOTE CABLES ASY LOCKNUT BOLT BOLT LOCKNUT LOCKNUT ADJUSTING YOKE END CLEVIS PIN COTTER PIN A/R CABLE, REMOTE CONTROL - 48" LG A/R CABLE, REMOTE CONTROL - 60" LG A/R CABLE, REMOTE CONTROL - 72" LG A/R CABLE, REMOTE CONTROL - 102" LG SWITCH MOUNT WLD MT ANGLE, MOUNT ANGLED SINGLE AXIS CONTROL ASY SWITCH, PUSH PULL ( W/ ITEMS 14 ) KNOB ( REPLACEMENT KNOB F/ ITEM # 13 ) JAM NUT ( REPLACEMENT F/ ITEM # 13 ) NUT ( REPLACEMNT F/ ITEM # 13 ) RELIEF VALVE ( 2500 PSI ) DECAL INSTRUCT VALVE & SWITCH POSITION TOGGLE SWITCH VALVE ASY, W/ FITTINGS BOOT, TOGGLE SWITCH COVER FLATWASHER BOLT DECAL INSTRUCTIONS, REVERSING SWITCH NOTE: Remote control cables are used on tractors w/ cabs & will be shipped w/ mount kit. Cables vary in length as to which tractor unit is for, for replacement cables match length of cables. Two cables used per unit, cables allow control valve to be mounted somewhere else & still give the operat NOTE: The above Items with the exception of Item 19, 13, 17 & 14 which are in the common box the rest of the items are sent with the mount kit for cab tractors Alamo Group Inc. Parts Section 36
42 MOTOR VALVE CONTROL SOLENOID ASY P/N VALVE SOLENOID ASY BODY RELIEF CARTRIDGE BOLT KIT 4* SOLENOID ASY STEM TUBE ASY COIL SOLENOID COIL NUT * * * CONSISTS OF REPLACEMENT PARTS; STEM TUBE,COIL SOLENOID,COIL NUT 2005 Alamo Group Inc. Parts Section 37
43 WIRE HARNESS ASY - P/N RH SINGLE WING WIRE HARNESS SINGLE WING CONNECTOR, COIL-HRSCHMANN TYPE FUSE 10 AMP, TYPE ATO NOTE: This wire harness is used with a RH Wing Mower, Wire harness will not include Push Pull Switch or Toggle Switch. NOTE: If LH Wing is used this wire harness will still be used and the LH wing harness will also be used Alamo Group Inc. Parts Section 38
44 WIRE HARNESS ASY - P/N LH DUAL WING WIRE HARNESS LH DUAL WING FUSE 10 AMP, TYPE ATO NOTE: Toggle Switch is shown for illustration only and is not included with wire harness. NOTE: This wire harness is only used when LH wing is mounted. It does not replace the RH Harness but is used with it Alamo Group Inc. Parts Section 39
45 DIVERTER VALVES & LH DUAL WING BOOT, TOGGLE SWITCH COVER DECAL, INSTUCT. LEFT & RIGHT SWITCH SWITCH, 2-POSITION "ON" & "OFF" DIVERTER VALVE & SOLENOID, # 4 PORTS HYD. ADAPTER STRAIGHT HYD. ADAPTER ELBOW DIVERTER VALVE & SOLENOID DIVERTER, # 8 PORTS HYD. ADAPTER ELBOW HYD. ADAPTER STRAIGHT HYD. ADAPTER ELBOW WIRE HARNESS, LH DUAL WINGS 2005 Alamo Group Inc. Parts Section 40
46 DIVERTER VALVE - P/N CYLINDER CONTROL - LH DUAL WING VALVE, SOLENOID DIVERTER (USE W/ DUAL WINGS) 2005 Alamo Group Inc. Parts Section 41
47 DIVERTER VALVE - P/N MOTOR CONTROL - LH DUAL WING VALVE, SOLENOID DIVERTER (USE W/ DUAL WINGS) 2005 Alamo Group Inc. Parts Section 42
48 HYDRAULIC DIAGRAM - RH SINGLE WING 2005 Alamo Group Inc. Parts Section 43
49 HYDRAULIC DIAGRAM - RH SINGLE WING A/R PUMP TANDEM GEAR, 1.16/0.49 CID A/R PUMP TANDEM GEAR, 0.98/0.37 CID HYDRAULIC TANK ASY. ( NCLUDES NEXT 4 ITEMS ) FILTER ASY SUCTION STRAINER CONTROL VALVE SOLENOID TANK WLD MT A 1 CURB STOP CYLINDER ASY A 1 BAR LIFT CYLINDER ASY BREAK-A-WAY VALVE ASY ( CONSIST OF THE FOLLOWING 6 ITEMS ) VALVE BODY ONLY PIPE PLUG HYD. ADAPTER ELBOW BOLT LOCKNUT RELIEF CARTRIDGE ( 1550 PSI SETTING ) ROTARY ACTUATOR ASY MOTOR, 2.8 CID NOTE: For dual wing hydraulic diagram see Common Component Box Page Alamo Group Inc. Parts Section 44
50 CYLINDER ASY - BAR TILT - P/N A A -- BAR LIFT CYLINDER ASY TUBE WLD MT CYL HEAD ROD WLD MT * O-RING * BACK-UP SEAL RING * ROD SEAL * ROD WIPER * WIRE RING SEAL KIT, ( * INCLUDES ITEMS 4, 5, 6, 7 & 8 ) 2005 Alamo Group Inc. Parts Section 45
51 CYLINDER ASY - CURB LIFT - P/N A A -- CURB STOP CYLINDER ASY TUBE WLD MT CYLINDER HEAD PISTON ROD WLDMT CYLINDER ROD LOCKNUT * PSP SEAL * O-RING * BACK-UP RING * ROD SEAL * NYLON WEAR RING * SNAP IN ROD SEAL * WIRE RING SEAL KIT, ( * INCLUDES ITEMS 7, 8, 9, 10, 11, 12 & 13 ) 2005 Alamo Group Inc. Parts Section 46
52 DECALS - FRAME AND TANK 2005 Alamo Group Inc. Parts Section 47
53 DECALS - FRAME AND TANK ITEM PART NO. QTY. TYPE DESCRIPTION INSTRUCTION DECAL, UNIVERSAL TRACTOR NAME DECAL, NAME SWITCH BLADE SICKLE WARNING DECAL, WARNING HOSE BURST DANGER DECAL, MULTIPLE HAZARD CAUTION DECAL, CAUTION REF S/N PLATE SERIAL NUMBER PLATE INSTRUCTION SHEET, MANUAL CANISTER DECAL PARTS CANISTER, PARTS MANUAL C 1 PARTS MANUAL OPERATORS SWITCH BLADE BOLT LOCKWASHER FLATWASHER LOCKNUT INSTRUCTION DECAL, GREASE FITTING INSIDE PARTS MOTOR / DRIVE ASY. COVER PARTS GAUGE, SIGHT / TEMPERATURE 2005 Alamo Group Inc. Parts Section 48
54 DECALS - CAB & ROPS ITEM PART NO. QTY. TYPE DESCRIPTION INSTRUCTION DECAL, KNIFE CLEARANCE INSTRUCTION DECAL, PROPER ENGINE OPERATING PELIGRO DECAL, PELIGRO WARNING DECAL, WARNING SIGN INSTRUCTION DECAL, REVERSING SWITCH INSTRUCTION DECAL, VALVE & SWITCH INSTRUCTION DECAL, CUTTER BREAK-A-WAY RESET INSTRUCTIONS SWITCH,PUSH PULL (W/ KNOB & HARDWARE) KNOB (HARDWARE F/ ) FACE NUT (HARDWARE F/ ) JAM NUT (HARDWARE F/ ) 2005 Alamo Group Inc. Parts Section 49
55
56 TO THE OWNER/OPERATOR/DEALER To keep your implement running efficiently and safely, read your manual thoroughly and follow these directions and the Safety Messages in this Manual. The Table of Contents clearly identifies each section where you can easily find the information you need. The OCCUPATIONAL SAFETY AND HEALTH ACT ( Subpart C) makes these minimum safety requirements of tractor operators: REQUIRED OF THE OWNER: 1. Provide a Roll-Over-Protective Structure that meets the requirements of this Standard; and 2. Provide Seatbelts that meet the requirements of this paragraph of this Standard and SAE J4C; and 3. Ensure that each employee uses such Seatbelt while the tractor is moving; and 4. Ensure that each employee tightens the Seatbelt sufficiently to confine the employee to the protected area provided by the ROPS. REQUIRED OF THE OPERATOR 1. Securely fasten seatbelt if the tractor has a ROPS. 2. Where possible, avoid operating the tractor near ditches, embankments, and holes. 3. Reduce speed when turning, crossing slopes, and on rough, slick, or muddy surfaces. 4. Stay off slopes too steep for safe operation. 5. Watch where you are going - especially at row ends, on roads, and around trees. 6. Do not permit others to ride. 7. Operate the tractor smoothly - no jerky turns, starts, or stops. 8. Hitch only to the drawbar and hitch points recommended by the tractor manufacturer. 9. When the tractor is stopped, set brakes securely and use park lock, if available. Keep children away from danger all day, every day... Equip tractors with rollover protection (ROPS) and keep all machinery guards in place... Please work, drive, play and live each day with care and concern for your safety and that of your family and fellow citizens.
57
58 Switch Blade 5 ft. & 6 ft (02/05) 2005 Alamo Group Inc. Printed U.S.A. Manual P/N P
SWITCH BLADE PART'S MANUAL. 5 ft. & 6 ft. Sickle Bar Mower Model With Mechanical Break-A-Way
Published 06/04 SWITCH BLADE 5 ft. & 6 ft. Sickle Bar Mower Model With Mechanical Break-A-Way PART'S MANUAL P/N 02974374P An Operator's Manual was shipped with the equipment in the Manual Canister. This
More informationGrizzly 52. Tree Cutter. OPERATOR S MANUAL with PARTS LISTING. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas
Grizzly 52 Tree Cutter Published (06-05) Part No. 02975192 OPERATOR S MANUAL with PARTS LISTING ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas 78155 830-379-1480 2005 Alamo Group Inc. An Alamo Group Company
More informationSWITCH BLADE PART'S MANUAL. 5 ft. & 6 ft. Sickle Bar Mower Model With Spring Break-A-Way
SWITCH BLADE ft. & ft. Sickle Bar Mower Model With Spring Break-A-Way Rev 08- PART'S MANUAL Part No. 0977P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual
More informationPART'S MANUAL. Rear Mounted Blade RHINO
850 Revised 06-10 PART'S MANUAL Rear Mounted Blade Part No. 00787017P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe
More informationDISC HARROW PART'S MANUAL DHP8/10/12. RHINO 1020 S. Sangamon Ave. Gibson City, IL
DISC HARROW DHP8/10/12 Published 03/16 PART'S MANUAL P/N 00789085P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation
More informationPublished Effective Serial No through Current Part No P PARTS MANUAL
TREE CUTTER Published 07-05 Effective Serial No. 10240 through Current Part No. 00772057P PARTS MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual
More informationBOX BLADES PART'S MANUAL SBX/MBX/RO. RHINO 1020 S. Sangamon Ave. Gibson City, IL
Published 03/6 BOX BLADES PART'S MANUAL SBX/MBX/RO P/N 0078930P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation
More informationSWITCHBLADE PARTS MANUAL. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas ft & 6 ft Sickle Bar Mower with Spring Break-Away
SWITCHBLADE 5 ft & 6 ft Sickle Bar Mower with Spring Break-Away Rev 08-17 PARTS MANUAL Part No. 02974374P ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas 78155 830-372-9595 An Operator's Manual was shipped
More informationSnow Blower Published P/N 5048P PART'S MANUAL
Snow Blower Published 08-05 P/N 5048P PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this
More informationSnow Blower Published P/N 5042P PART'S MANUAL
Snow Blower Published 08-05 P/N 5042P PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this
More informationRevised Part No. 4928WP PART'S MANUAL
DYNA-MASTER Revised 09-14-01 Part No. 4928WP PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of
More informationPublished Part No P PARTS MANUAL
A60/A72/A72SD Rotary Mower Published 03-04 Part No. 00757274P PARTS MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the
More informationSnow Blower Published P/N 5041P PART'S MANUAL
Snow Blower Published 08-05 P/N 5041P PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this
More informationEXTEN-A-KUT II ROTARY DITCH AND BANK MOWER
EXTEN-A-KUT II ROTARY DITCH AND BANK MOWER Rev - Part No. 099P PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the
More informationSnow Blower Published P/N 5044P PART'S MANUAL
Snow Blower Published 08-05 P/N 5044P PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this
More informationSnow Blower Published P/N 5043P PART'S MANUAL
Snow Blower Published 08-05 P/N 5043P PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this
More informationGrass King PART'S MANUAL. Boom Arm Mower. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas
Grass King Rev 05- PART'S MANUAL Boom Arm Mower Part No. 09650P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation
More informationTW14 PART'S MANUAL RHINO ROTARY MOWER
Rev 11 PART'S MANUAL ROTARY MOWER Part No. 00792245P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this
More informationPART'S MANUAL. Rear Mounted Blade. RHINO 1020 S. Sangamon Ave. Gibson City, IL
2500 PART'S MANUAL Rear Mounted Blade Rev 02-16 Part No. 00767428P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation
More informationPub 11/ S/N CURRENT 1465 S/N CURRENT
EARTHMASTER Pub 11/05 1165 S/N 2300 -CURRENT Part No. 4353P 1465 S/N 1239 -CURRENT PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an
More informationPARTS MANUAL AG60B & AG72B. Rotary Mower. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Alamo Group Inc.
AG60B & AG72B Rotary Mower Published 03/04 Effective Serial No. A60B-01820 To Current Part No.00759354P Effective Serial No. A72B-02600 To Current PARTS MANUAL An Operator's Manual was shipped with the
More informationExten-A-Kut II PARTS MANUAL. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Rotary Ditch and Bank Mower
Exten-A-Kut II Rotary Ditch and Bank Mower Rev 0- PARTS MANUAL Part No. 099P ALAMO INDUSTRIAL 0 E. Walnut Seguin, Texas 78 80-7-99 An Operator's Manual was shipped with the equipment in the Manual Canister.
More informationHYDRO 88 & 96 PARTS MANUAL. Flail Cutter. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas
HYDRO 88 & 96 PARTS MANUAL Flail Cutter Rev 03-3 P/N 8033 An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of
More informationPART'S MANUAL. Rear Mounted Blade. RHINO 1020 S. Sangamon Ave. Gibson City, IL
1540 PART'S MANUAL Rear Mounted Blade Rev 03-16 Part No. 697PB An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation
More informationHydro 88 & 96 PARTS MANUAL. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Flail
Hydro 88 & 96 Flail Rev 0- PARTS MANUAL Part No.8033 ALAMO INDUSTRIAL 50 E. Walnut Seguin, Texas 7855 830-37-9595 An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's
More informationVERSA Boom Arm Mower - Flail Mower Rotary Cutter
VERSA Boom Arm Mower - Flail Mower Rotary Cutter Rev 0-11 PART'S MANUAL Part No. 02897300P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral
More informationVERSA Published 04/03 Effective Serial No through Current PartNo P
VERSA Published 0/03 Effective Serial No. 000 through Current PartNo.02897300P MANUAL ALAMO INDUSTRIAL 502 E. Walnut Seguin, Texas 7855 830-372-355 TO THE OWNER/OPERATOR/DEALER All implements with moving
More informationMODELS EWR820, EWR1023, EWR1227 PULL TYPE HAY RAKES PARTS MANUAL SECTION 19
EWR MODELS EWR820, EWR1023, EWR1227 PULL TYPE HAY RAKES Published 04/11 PARTS MANUAL SECTION 19 MATERIAL HANDLING PARTS MANUAL PARTS ORDERING GUIDE The following instructions are offered to help eliminate
More information8600-AR. Snow Blower Part No.5037P. RHINO 1020 S. Sangamon Ave. Gibson City, IL
8600-AR Rev 07-05 PART'S MANUAL Snow Blower Part No.5037P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of
More informationDYNA-DRIVE. M&W 1020 South Sangamon Ave. Gibson City, Illinois GROUND-DRIVEN CULTIVATOR
DYNA-DRIVE GROUND-DRIVEN CULTIVATOR Rev 02-07 DD 60 S/N 10095 -CURRENT Part No. 00771093P PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual
More information8650-AR. Snow Blower Part No.5039P. RHINO 1020 S. Sangamon Ave. Gibson City, IL
8650-AR Pub 02-05 PART'S MANUAL Snow Blower Part No.5039P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of
More informationCommercial Snow Blower PART'S MANUAL
Commercial Snow Blower Published 08/05 P/N 5040P PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation
More informationMECHANICAL LEVEL LIFT ROTARY CUTTER/SHREDDER
EAGLE 20 & 14 20 ft. & 14 ft. FLEX-WING MECHANICAL LEVEL LIFT ROTARY CUTTER/SHREDDER Published 02/06 Part No. 00779092P PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister.
More informationPART'S MANUAL MODEL 5600 & 5690 ROUND BALERS M&W
ROUND BALERS Published 10/01 P/N 4895WP PART'S MANUAL An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this
More informationKSM60 SIDE MOWER Parts Manual
Terrain King 1502 E WALNUT ST SEGUIN TX 78155-5202 800-882-5756 Rev 4-14 KSM60 SIDE MOWER Parts Manual Part No. 37002993750P An Operator's Manual was shipped with the equipment in the Manual Canister.
More informationBH200 SERIES ROTARY CUTTER
Revised Published01/19 BH200 SERIES ROTARY CUTTER PARTS MANUAL SECTION 121 MODELS BH215, BH216, BH217 An Operator s Manual was shipped with the equipment. The Operator s Manual is an integral part of the
More informationBUSH HOG 2501 Griffin Ave. Selma, AL Contact Us
RD5/RD6 ROTARY MOWER Published 01/11 PART'S MANUAL SECTION 88 An Operator's Manual was shipped with the equipment. The Operator's Manual is an integral part of the safe operation of this machine and must
More informationPARTS MANUAL. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas SN to SN Remote Controlled Mower
SN 00061 to SN 00073 - Remote Controlled Mower Rev 11-17 PARTS MANUAL Part No. TR477642 ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas 78155 830-372-9595 An Operator's Manual was shipped with the equipment
More informationAG84-B ARCHIVE BOOK ROTARY MOWER. By Serial Number / Production COMPLETE PARTS LISTING. ALAMO INDUSTRIAL 1502 E. Walnut
AG8-B ROTARY MOWER ARCHIVE BOOK By Serial Number / Production April 99 May 00 () AG8-B Model - 8" Rotary Pull Type or Lift Type Option COMPLETE PARTS LISTING Archive Book Part No. 0979 ALAMO INDUSTRIAL
More informationModel 802 Center Mount Adapter For New Holland 9030 & TV140 Bi-Directional Tractors PARTS CATALOG
Model 802 Center Mount Adapter For New Holland 9030 & TV140 Bi-Directional Tractors 1 PARTS CATALOG TABLE OF CONTENTS Frame & Tractor Linkage...2,3 Header Linkage & Float Group...4,5 Header Drive Hydraulics
More informationVERSA PARTS MANUAL. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Boom, Flail, Rotary Cutter. Rev Part No.
VERSA Boom, Flail, Rotary Cutter Rev 08-17 PARTS MANUAL Part No.02897300P ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas 78155 830-372-9595 An Operator's Manual was shipped with the equipment in the Manual
More informationPublished 10/12 SICKLE BAR BOOM MOWER PART'S MANUAL SECTION 90
Published 10/12 PT5/PT5-2 POWERTRIM SICKLE BAR BOOM MOWER PART'S MANUAL SECTION 90 PARTS ORDERING GUIDE The following instructions are offered to help eliminate needless delay and error in processing purchase
More informationHR24TS Rotary Rake. Serial Numbers and higher. Illustrated Parts Breakdown. Guards and Guard Arm, Front Hay Curtain Mount.
HRTS Rotary Rake Serial Numbers 00 and higher Illustrated Parts Breakdown Page Page Page Page Page Page Page Page Page Page 0 Page Page Page Page Page Page Page Page Page Page 0 Tongue Front Frame Guards
More informationINTERSTATER Rear Mount
INTERSTATER Rear Mount Flail Rev 05-16 Part No. 02977160 PARTS MANUAL ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas 78155 830-372-9595 An Operator's Manual was shipped with the equipment in the Manual
More informationPARTS CATALOG ODYSSEY INCLUDES MOWER
PARTS CATALOG 8-3350 ODYSSEY INCLUDES MOWER INDEX PAINT ENGINES GENERAL INFO PRODUCT IDENTIFICATION NUMBERS (P.I.N.) OR SERIAL NUMBERS (S/N) ENGINE MODEL, SERIAL AND SPECIFICATION NUMBERS TRACTOR MODEL
More informationBOOM ARM MOWER PARTS MANUAL. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Alamo Group Inc.
Rev 04-09 Effective S/N 01108 - Current BOOM ARM MOWER Part No. 02968915P PARTS MANUAL ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas 78155 210-372-3551 2008 Alamo Group Inc. TO THE OWNER/OPERATOR/DEALER
More informationA-Boom PARTS MANUAL. Boom Arm Mower. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Effective SN through Current
A-Boom Boom Arm Mower Rev 05-17 PARTS MANUAL Effective SN 04837 through Current Part No. 02924700P ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas 78155 830-372-9595 An Operator's Manual was shipped with
More informationARCHIVE BOOK - II AG20-IV / AG14-IV ROTARY FLEX WING MOWER
AG0-IV / AG-IV ROTARY FLEX WING MOWER ARCHIVE BOOK - II By Serial Number / Production Book = Apr. 99 s/n AG0-0300 Jun. 00 AG0-IV Model - 0' Flex Wing Rotary AG-IV Model - ' Flex Wing Rotary COMPLETE PARTS
More informationPART'S MANUAL. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas BOOM ARM MOWER
Rev 0-07 PART'S MANUAL BOOM ARM MOWER Part No. 09P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this machine
More informationTURBO 120 PART'S MANUAL ROTARY CUTTER. RHINO 1020 S. Sangamon Ave. Gibson City, IL
TURBO 120 PART'S MANUAL ROTARY CUTTER Rev 10-12 S/N 10200 -CURRENT Part No. 00778487P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part
More informationPART'S MANUAL 3-POINT POSTHOLE DIGGER 130P, 240P, 340P, & 440P
3-POINT POSTHOLE DIGGER 130P, 240P, 340P, & 440P Rev 05-07 PART'S MANUAL Part No. 01430870P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral
More information2720/12720 PARTS MANUAL 72A SECTION FLEX WING ROTARY MOWER
0/0 This Manual applies to models 0 and 0 that use a blade pan which measures. blade hole center to blade hole center. Also blades measure 8. from hole center to blade tip. See Section if these dimensions
More informationPARTS MANUAL SECTION 94
DISC MOWER Published 06/12 HMG7, HMG8, HMG9, HMG10 Disc Mower PARTS MANUAL SECTION 94 An Operator s Manual was shipped with the equipment. The Operator s Manual is an integral part of the safe operation
More informationPARTSBOOK. Hall Manufacturing, Inc E. Washington Ave., P.O. Box Drawer 5638 North Little Rock, AR (501)
540 RPM 2 PARTSBOOK This part of the manual contains part numbers and illustrations based on the latest information available at the time of print. Hall Manufacturing, Inc. reserves the right to make changes
More informationFLX15 ROTARY CUTTERS PARTS MANUAL ATENCIÓN! LEA EL INSTRUCTIVO
Published: /0 FLX ROTARY CUTTERS S/N A00000 A0000 inclusive PARTS MANUAL Part No. A0-00P An Operators Manual with IMPORTANT Safety, Assembly, Operation and Maintenance information was packaged with this
More informationPARTSBOOK. This part of the manual contains part numbers and illustrations based on the latest information available at the time of print.
2 PARTSBOOK This part of the manual contains part numbers and illustrations based on the latest information available at the time of print. Hall Manufacturing, Inc. reserves the right to make changes at
More informationSERVICE PARTS MANUAL
SERVICE PARTS MANUAL 28V SERIES SNOW PLOWS FOR PLOW SERIAL NUMBERS AFTER 28VG100000 28VD100000 07 Sno-Way International 9710097F TABLE OF CONTENTS Page PARTS LIST INTRODUCTION... 2 POWER PACK FRAME...
More informationREAR MOUNTED BOOM PARTS MANUAL. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Flail. Rev Part No.
REAR MOUNTED BOOM Flail Rev 08-14 Part No. 02963600 PARTS MANUAL ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas 78155 830-372-9595 An Operator's Manual was shipped with the equipment in the Manual Canister.
More informationCOMPACT WHEEL LOADERS 7020, 7020BH Parts Catalog Ingersoll HOME TRACTORS ATTACHMENTS INDEX ENGINES GENERAL INFO. casecoltingersoll.
R Ingersoll COMPACT WHEEL LOADERS 7020, 7020BH Parts Catalog 8-3370 HOME TRACTORS ATTACHMENTS PAINT ENGINES GENERAL INFO PRODUCT IDENTIFICATION NUMBERS (PIN) AND SERIAL NUMBERS (S/N) TRACTOR MODEL AND
More information320 Series Models 325, 326, 327
0 Series Models,, ROTARY MOWER Published 0/ PARTS MANUAL SECTION An Operator s Manual was shipped with the equipment. The Operator s Manual is an integral part of the safe operation of this machine and
More informationPART'S MANUAL. Boom Arm. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas
Rev 08-11 PART'S MANUAL Boom Arm Part No.02988075P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this machine
More information365L (2001) Page 1 of 36 54" Deck Assembly
365L (2001) Page 1 of 36 54" Deck Assembly 365L (2001) Page 2 of 36 54" Deck Assembly 1 720-0241 1 S Wing Nut Knob 2 703-2817 1 Belt Cover LH 3 703-2816 1 Belt Cover RH 4 747-3306 1 Idler Spring Mounting
More informationHydrostatic Zero-Turn Commercial Riding Mower
Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment 54" Fabricated Deck ILLUSTRATED PARTS LIST TABLE OF CONTENTS Frame Assembly.................................. 3 54" Fabricated
More informationHYDRO-15 PARTS MANUAL HYDRAULIC FLEX WING ROTARY MOWER. Alamo Industrial 1502 E. Walnut Seguin, Texas Alamo Group Inc.
HYDRO-15 Published 08-05 HYDRAULIC FLEX WING ROTARY MOWER PARTS MANUAL Part No. 00756179P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral
More informationMODEL NO & UP SAFETY AND INSTRUCTION DECALS
FORM NO. 95-2194 REV. B MODEL NO. 41105-90001 & UP PARTS CATALOG MULTI PRO 1100 VEHICLE SAFETY AND INSTRUCTION DECALS The following safety and instruction decals are installed on the vehicle. If any become
More informationPARTS BOOK CATALOG IMPLEMENT ASSEMBLIES STANDARD BOOM 3PT HITCH MOUNT
PARTS BOOK CATALOG IMPLEMENT ASSEMBLIES STANDARD BOOM 3PT HITCH MOUNT DIAMOND MOWERS, Inc. 350 E 60 th St. North Sioux Falls, SD 57104 FOR WARRANTY CALL DIAMOND MOWERS DIRECT: 888-960-0364 OUR TECHNICIANS
More informationSpearhead Excel 565, 605 & 645T
1 Spearhead Twiga 5000, 6000, 6000LR & 6000 T Parts Book 11 th Edition February 2010 Green-Tec A/S Merkurvej 25 DK 6000 Kolding Tel: +45 7555 3644 Fax: +45 7555 4243 www.greentec.eu info@greentec.eu Spearhead
More informationHydrostatic Zero-Turn Commercial Riding Mower
Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment 0" Fabricated Deck ILLUSTRATED PARTS LIST TABLE OF CONTENTS Frame Assembly.................................. 3 0" Fabricated Cutter
More informationParts Manual PZ Please read the operator manual carefully and make sure you understand the instructions before using the machine.
Parts Manual PZ 60 967 045601-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support in service questions,
More informationReel Mower TRM Parts Manual. Locke Turf 307 Highway 52E, Opp, Alabama 36467, (334)
Reel Mower TRM-0 Parts Manual Locke Turf 0 Highway E, Opp, Alabama, () -00 General Information Mower Layout Please note that Left and Right are determined by standing at eh rear of the mower and facing
More informationAEROTHATCH 83/SEEDER 93
FORM NO. 01-505-0110 Rev. B MODEL NO. 44830-20101 & UP MODEL NO. 44831-20101 & UP MODEL NO. 44835-40162 & UP PARTS CATALOG AEROTHATCH 83/SEEDER 93 AEROTHATCH 83 - MODEL NO. 44830 & 44831 MAIN FRAME ASSEMBLY
More informationReel Mower TRM 5138 and TRM 7192
Reel Mower TRM and TRM Parts Manual Locke Turf 0 Highway E, Opp, Alabama () -00 General Information Mower Layout Please note that Left and Right are determined by standing at eh rear of the mower and facing
More information2820/12820 SECTION 103. This Manual applies to Models: 2820R1, 12820R1, 12820S1 2820RR1, 12820RR1, 12820SR1 FLEX WING ROTARY CUTTER/SHREDDER
0/0 This Manual applies to Models: 0R, 0R, 0S 0RR, 0RR, 0SR FLEX WING ROTARY CUTTER/SHREDDER Published 0/ PARTS MANUAL SECTION 0 An Operator s Manual was shipped with the equipment. The Operator s Manual
More informationParts Manual FRONT-FOLD BOOMS MODELS 80, 90 & 100 HYDRAULIC FOR TA1200 & TA1600 SPRAYERS. Serial Number B & Higher. Part No.
Parts Manual FRONT-FOLD BOOMS MODELS 80, 90 & 100 HYDRAULIC FOR TA1200 & TA1600 SPRAYERS Serial Number B30970200 & Higher Part No. 408920 Front-Fold Booms 80 / 90 / 100 Introduction Foreward This symbol
More informationPARTS MANUAL SECTION 105 FLEX WING ROTARY CUTTER. Published 09/14
8 FLEX WING ROTARY CUTTER Published 09/ PARTS MANUAL SECTION 0 An Operator s Manual was shipped with the equipment. The Operator s Manual is an integral part of the safe operation of this machine and must
More informationChampion Series Zero-Turn Riders & Mower Decks
Parts Manual Champion Series Zero-Turn Riders & Mower Decks HP Tractors Mfg. No. Description Champion, HP Zero-Turn Rider Champion, HP Zero-Turn Rider (CE) 0HP Tractors Mfg. No. Description Champion, 0HP
More informationSTX-26 Stump Grinder
Form No. 3365-311 Rev B STX-26 Stump Grinder Model No. 23210 Serial No. 310000001 and Up Model No. 23210G Serial No. 310000001 and Up Register at www.toro.com. Original Instructions (EN) *3365-311* B Ordering
More informationAG60 ARCHIVE BOOK ROTARY MOWER. By Serial Number / Production July 1988 to January 2004 (Current) (AG60 Model - 60" Rotary) COMPLETE PARTS LISTING
AG0 ROTARY MOWER ARCHIVE BOOK By Serial Number / Production July January 00 (Current) (AG0 Model - 0" Rotary) COMPLETE PARTS LISTING Archive Book Part No. 070 ALAMO INDUSTRIAL 0 E. Walnut Seguin, Texas
More informationTT4100 Rotary Tedder
TT0 Rotary Tedder Serial numbers 0 and higher Illustrated Parts Breakdown Page Page Tongue Assembly S/N - Tongue Assembly S/N to Page Page Page Page Page Tongue Assembly S/N to Tongue Assembly S/N + Main
More information72K850ZP PARTS MANUAL
7 2 K 8 5 0 Z P PARTS MANUAL 72 MID-CUT GAS ENGINE OPTION SECTION 72 MID-CUT DECK ASSEMBLY 72" Mid-Cut Deck Assembly # PART NO. QTY DESCRIPTION 1 582096 1 72" MC DECK WELDMENT 2 582098 1 72" DECK CHANNEL
More informationReproduction. Not for. Mid Frame Dual Stage Snowthrower. Parts Manual
Parts Manual Attachment Mfg. No. Description 1695994 (I924EX), 9TP 24" Snowthrower (CE/Export) Mid Frame Dual Stage Snowthrower Not for Reproduction Manual Part No. Revision - Rev. Date: 7/20/2011 Table
More informationSERVICE PARTS MANUAL
SERVICE PARTS MANUAL SERIES SNOW PLOWS FOR PLOW SERIAL NUMBERS AFTER D0000 G0000 00 Sno-Way International 9F TABLE OF CONTENTS Page PARTS LIST INTRODUCTION... POWER PACK FRAME... BLADES... HYDRAULIC SYSTEM
More informationParts Manual EZF 3417/ Please read the operator s manual carefully and make sure you understand the instructions before using the machine.
Parts Manual EZF 3417/ 96579301 Please read the operator s manual carefully and make sure you understand the instructions before using the machine. English 200 HTC. All Rights Reserved. Beatrice, NE. Printed
More informationParts Manual Zero Turn Mower / Z 248F
Parts Manual Zero Turn Mower / Z 248F 967262501-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support
More informationILLUSTRATED PARTS LIST THIS MANUAL CONTAINS THE ILLUSTRATED PARTS LIST FOR MODELS:
IPL MODEL SWZU 1 6 2 6 6 6 6 ILLUSTRATED PARTS LIST 0 2 6 8 THIS MANUAL CONTAINS THE ILLUSTRATED PARTS LIST FOR MODELS: SWZU6-1KA with a serial number of 260001 to 26 SWZU8-1KA with a serial number of
More informationReproduction. Not for PARTS LIST. Models. Manual Part No
PARTS LIST Models Mfg. No. Description 1696063 ML761650, Murray 16.5TP 30" Dual Stage Snowthrower, CE (2011) Revision - Manual Part No. Rev. Date: 5/17/2011 Table Of Contents PRODUCT COMPONENTS PAGES
More informationSERVICE PARTS MANUAL
SERVICE PARTS MANUAL SERIES SNOW PLOWS FOR PLOW SERIAL NUMBERS AFTER D00000 G00000 007 Sno-Way International 9700D TABLE OF CONTENTS Page PARTS LIST INTRODUCTION... POWER PACK FRAME... BLADES... HYDRAULIC
More informationTT4101 Rotary Tedder
TT Rotary Tedder 0//0 Illustrated Parts Breakdown Page Page Page Page Page Page Page Page Page Page Page Tongue Assembly S/N S/N - Tongue Assembly S/N + Main Frame S/N - Main Frame S/N to Main Frame S/N
More informationBUSH HOG LAND MAINTENANCE REPAIR PARTS MANUAL
BUSH HOG LAND MAINTENANCE REPAIR PARTS MANUAL MODEL: DM7, DM8, DM9 SECTION: 43 2501 Griffin Ave. Selma, AL 36703 (334) 872-6261 (334) 874-2700 Parts Ordering 1-800-304-2836 Fax 1-800-572-1784 www.bushhog.com
More informationPA 32. Parts Manual HEDGE/GRASS TRIMMER. Publication 410 August 2001 Part No Revision:
Publication 410 August 2001 Part No. 41570.11 Revision: 17.01.07 PA 32 HEDGE/GRASS TRIMMER Parts Manual For best performance USE ONLY GENUINE McCONNEL SERVICE PARTS To be assured of the latest design improvements
More informationSTX-38 EFI Stump Grinder with Intelli-Sweep
Form No. 3421-244 Rev A STX-38 EFI Stump Grinder with Intelli-Sweep Model No. 23214 Serial No. 402000000 and Up Register at www.toro.com. Original Instructions (EN) *3421-244* A Ordering Replacement Parts
More informationCOMPACT WHEEL LOADERS PIN and after 6018BH - PIN and after 6020L, 6020BH Parts Catalog
R Ingersoll HOME COMPACT WHEEL LOADERS 6018 - PIN 14190349 and after 6018BH - PIN 14190351 and after 6020L, 6020BH Parts Catalog 8-3360 TRACTORS ATTACHMENTS INDEX PAINT ENGINES GENERAL INFO MAIN INDEX
More informationSERVICE PARTS MANUAL
SERVICE PARTS MANUAL 9, 9T & SERIES SNOW PLOWS WITH EIS FOR PLOW SERIAL NUMBERS AFTER 9G100000, 9D100000, 9C100000 9TG100000, 9TD100000, 9TC100000 G10000, D100, C10000 00 Sno-Way International 910089H
More information25 Horsepower Hydrostatic Zero-Turn Commercial Riding Mower
MMZ 2, 260 2 Horsepower Hydrostatic Zero-Turn Commercial Riding Mower ILLUSTRATED PARTS LIST " Float Cutter Deck - Figure 1 3 1 27 32 17 6 1 11 31 36 3 19 7 23 1 33 38 18 37 22 3 20 2 10 2 12 21 30 39
More informationLAND MAINTENANCE REPAIR PARTS MANUAL BUSH HOG MODEL: 307 SECTION: 16
BUSH HOG LAND MAINTENANCE REPAIR S MANUAL MODEL: 0 SECTION: P.O. Box 0 Selma, AL 0-0 () - () -00 Parts Ordering -00-0- Fax -00-- www.bushhog.com BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL SEPTEMBER, 0
More informationReproduction. Not for. Mid Frame Dual Stage Snowthrowers. Parts Manual
Parts Manual Attachment Mfg. No. Description 1695821 (I1224E), 11.5TP 24" Dual Stage Snowthrower 1695842 (I924EX), 9TP 24" Snowthrower (CE/Export) Mid Frame Dual Stage Snowthrowers Not for Reproduction
More informationPARTS BOOK CATALOG IMPLEMENT ASSEMBLIES STANDARD BOOM 3PT HITCH MOUNT
PARTS BOOK CATALOG IMPLEMENT ASSEMBLIES STANDARD BOOM 3PT HITCH MOUNT DIAMOND MOWERS, Inc. 350 E 60 th St. North Sioux Falls, SD 57104 FOR WARRANTY CALL DIAMOND MOWERS DIRECT: 888-960-0364 OUR TECHNICIANS
More informationPARTS MANUAL. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas SN to Current - Remote Controlled Mower
SN 00323 to Current - Remote Controlled Mower Rev 12-16 PARTS MANUAL Part No. TR477927P ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas 78155 830-372-9595 An Operator's Manual was shipped with the equipment
More informationPA47 Mk3 HEDGECUTTER / MOWER. Parts Manual. Publication 555 October 2008 Part No Revision:
Publication 555 October 2008 Part No. 41571.55 Revision: 17.03.09 PA47 Mk3 HEDGECUTTER / MOWER Parts Manual For best performance USE ONLY GENUINE SERVICE PARTS To be assured of the latest design improvements
More informationCOMPACT WHEEL LOADERS before PIN BH - before PIN Parts Catalog Ingersoll HOME TRACTORS ATTACHMENTS INDEX ENGINES
R Ingersoll HOME COMPACT WHEEL LOADERS 6018 - before PIN 14190349 6018BH - before PIN 14190351 Parts Catalog 8-3052 TRACTORS ATTACHMENTS INDEX PAINT ENGINES GENERAL INFO PRODUCT IDENTIFICATION NUMBERS
More information