PART'S MANUAL. Boom Arm. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas

Transcription

1 Rev PART'S MANUAL Boom Arm Part No P An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this machine and must be maintained with the unit at all times. READ, UNDERSTAND, and FOLLOW the Safety and Operation Instructions contained in this manual before operating the equipment. If the Operator's Manual is not with the equipment, contact your dealer or Alamo Industrial ( ) to obtain a Free copy before operating the equipment. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Alamo Group Inc.

2

3 To the Owner/Operator/Dealer All implements with moving parts are potentially hazardous. There is no substitute for a cautious, safe-minded operator who recognizes the potential hazards and follows reasonable safety practices. The manufacturer has designed this implement to be used with all its safety equipment properly attached to minimize the chance of accidents. BEFORE YOU START!! Read the safety messages on the implement and shown in your manual. Observe the rules of safety and common sense! WARRANTY INFORMATION: Read and understand the complete Warranty Statement found in this Manual. Fill out the Warranty Registration Form in full and return it within 30 Days. Make certain the Serial Number of the Machine is recorded on the Warranty Card and on the Warranty Form that you retain. The use of "will-fit" parts will void your warranty and can cause catastrophic failure with possible injury or death.

4 BOLT TORQUE Mounting procedures for mowers will require a significant amount of bolt nut and washer installation. Frame and structure mounting bolts should be installed using Red Loctite, and torqued to the dry values listed in the torque chart based on the bolt size and hardness. Other structures such as pump mounting bolts should be installed with Blue Loctite and torqued to the dry values indicated in the chart. Bolt tightness should be completed with and checked with a suitable torque wrench. Torque checks should be completed throughout the life of the mower in accordance with the maintenance chart provided in this manual. Loose bolts on a frame or in a casting may be a result of: Vibration from the mower due to imbalance of the mower blades Pulled threads due to over tightening Distortion of the hole due to under tightening during installation Bolts broken or sheared in the mounting structure or tractor may be the result of: Improper alignment of the Mounting Plate or Structure such that it is not sitting flat on the mating surface Distortion of the bolt due to over-tightening Under tightening of the bolts Check the bolt torque during installation and prior to delivery with a suitable torque wrench.

5 Parts Section 1 PARTS SECTION

6 PARTS ORDERING GUIDE The following instructions are offered to help eliminate needless delay and error in processing purchase orders for the equipment in this section. 1. The Parts Section is prepared in logical sequence and grouping of parts that belong to the basic machine featured in this manual. Part Numbers and Descriptions are given to help locate the parts and quantities required. 2. The Purchase Order must include the name and address of the person or organization ordering the parts, who should be charged, and if possible, the serial number of the machine for which the parts are ordered. 3. The Purchase Order must clearly list the quantity of each part, the complete and correct part number (be sure to include all periods), and the basic name of the part. 4. The Manufacturer reserves the right to substitute parts where applicable. 5. Some parts are unlisted items which are special production items not normally stocked and are subject to special handling. Request a quotation for such parts before sending a Purchase Order. 6. The Manufacturer reserves the right to change prices without prior notice. For maximum safety and to guarantee optimum product reliability, always use genuine Alamo Industrial Parts. The use of inferior replacement parts may cause premature or catastrophic failure which could result in serious injury or death. Direct any questions regarding parts to: ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Alamo Group Inc. Parts Section 2

7 PART NAME INDEX 48 IN FLAIL - HEAD ASY (SOLID MNT) (PART 1) IN FLAIL - HEAD ASY (SOLID MNT) (PART 2) IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 1) IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 2) IN FLAIL - HEAD ASY (SWIVEL MNT) (PART 3) IN FLAIL - ROTOR W/KNIVES IN ROTARY - BLADE BAR ASY IN ROTARY - BLADE BAR HEAD ASY (SOLID MNT) IN ROTARY - BLADE BAR HEAD ASY (SWIVEL MNT) IN ROTARY - BLADE BAR HEAD SUB-ASY (SOLID MNT) IN ROTARY - BLADE BAR HEAD SUB-ASY (SWIVEL MNT) IN ROTARY - BLADE PAN HEAD ASY (SOLID MNT) IN ROTARY - BLADE PAN HEAD ASY (SWIVEL MNT) IN ROTARY - BLADE PAN HEAD SUB-ASY (SOLID MNT) IN ROTARY - BLADE PAN HEAD SUB-ASY (SWIVEL MNT) IN ROTARY - BLADE BAR ASY IN ROTARY - BLADE BAR HEAD ASY (SOLID MNT) IN ROTARY - BLADE BAR HEAD ASY (SWIVEL MNT) IN ROTARY - BLADE BAR HEAD SUB-ASY (SOLID MNT) IN ROTARY - BLADE BAR HEAD SUB-ASY (SWIVEL MNT) IN ROTARY - MOTOR (PARTS) (MODEL NO ) IN ROTARY - MOTOR (PARTS) (MODEL NO ) IN BUZZBAR - 2 BLADES (PART 1) IN BUZZBAR - 2 BLADES (PART 2) IN BUZZBAR - 3 BLADES - STD HEAD (PART 1) IN BUZZBAR - 3 BLADES - STD HEAD (PART 2) IN BUZZBAR - 4 BLADES - STD HEAD (PART 1) IN BUZZBAR - 4 BLADES - STD HEAD (PART 2) BUZZ BAR SPINDLE ASSEMBLY BUZZ BAR - HYD MOTOR PARTS - P/N BOOM ASY - 18 FT BOOM (PART 1) BOOM ASY - 18 FT BOOM (PART 2) BOOM ASY - 22 FT BOOM (PART 1) BOOM ASY - 22 FT BOOM (PART 2) BOOM ASY - 25 FT BOOM (PART 1) BOOM ASY - 25 FT BOOM (PART 2) BOOM ASY - 28FT TELESCOPING BOOM (PART 1) BOOM ASY - 28FT TELESCOPING BOOM (PART 2) COMMON CRATE COMPONENTS - ELECT VALVE COMMON CRATE COMPONENTS - MAN VALVE (PART 1) Alamo Group Inc. Parts Section -3

8 PART NAME INDEX COMMON CRATE COMPONENTS - MAN VALVE (PART 2) COMMON CRATE COMPONENTS 28FT TELESCOPING - ELECT VALVE COMMON CRATE COMPONENTS 28FT TELESCOPING - MANUAL VALVE DECALS FT BOOM DECALS - 28FT TELESCOPING BOOM DECALS - 48 IN BUZZBAR - 2 BLADES DECALS - 48 IN FLAIL HEAD DECALS - 50 & 60 IN ROTARY HEAD DECALS - 69 IN BUZZBAR - 3 BLADES DECALS - 90 IN BUZZBAR - 4 BLADES DECALS - HYD TANK & PUMP - ELECT VALVE DECALS - HYD TANK & PUMP - MAN VALVE DECALS - UNDER MOUNT COUNTER WEIGHT - CAST DECALS - UNDER MOUNT COUNTER WEIGHT - WELDED DECALS - VALVE MAN HANDLE OPERATION DITCHER ASSEMBLY DIVERTER VALVE - DOOR & SWIVEL FILTER ASY - PN HOSE ROUTING - 18 FT BOOM HOSE ROUTING - 18 FT BOOM NOTES HOSE ROUTING - 22 FT BOOM HOSE ROUTING - 22 FT BOOM NOTES HOSE ROUTING - 25 FT BOOM HOSE ROUTING - 25 FT BOOM NOTES HOSE ROUTING - 28FT TELESCOPING BOOM HOSE ROUTING - 28FT TELESCOPING BOOM (NOTES) HOSE ROUTING - SWING CYL (18-22 FT BOOM) HYD CYL ASY - DIPPER (18 FT BOOM) HYD CYL ASY - DIPPER (22 FT BOOM) HYD CYL ASY - EXTENSION (28FT TELESCOPING BOOM) HYD CYL ASY - HEAD SWIVEL HYD CYL ASY - LIFT (18-22 FT BOOM) HYD CYL ASY - SWING W/ SPHERICAL ROD END HYD CYL ASY - SWING W/ TUBE ROD END HYD CYL ASY - TILT (18-22 FT BOOM) HYD CYL ASY - TILT (28FT TELESCOPING BOOM) HYD OIL COOLER & FAN ASY HYD SCHEMATIC - SOLID MNT HEAD (OPT) 28FT TELESCOPING BOOM HYD SCHEMATIC - SWIVEL MNT HEAD (OPT) 28FT TELESCOPING BOOM Alamo Group Inc. Parts Section -4

9 PART NAME INDEX HYD SCHEMATIC - SOLID MNT HEAD (STD) FT BOOM HYD SCHEMATIC - SWIVEL MNT HEAD (OPT) FT BOOM HYD TANK SUB-ASY HYD TANK W-PUMP & ELECT VALVE ASY FT BOOM HYD TANK W-PUMP & ELECT VALVE ASY 28FT TELESCOPING BOOM HYD TANK W-PUMP & MAN VALVE ASY FT BOOM HYD TANK W-PUMP & MAN VALVE ASY 28FT TELESCOPING BOOM PUMP ASY - SERVO CONTROLLED CUTTER CONTROL VALVE BLOCK PUMP-TANK-VALVE COVER JOYSTICK CONSOLE ASY SPINDLE ASSEMBLY - ROTARY HEAD WIRE HARNESS - JOYSTICK RESISTER (OPT) UNDER MOUNT COUNTER WEIGHT - CAST UNDER MOUNT COUNTER WEIGHT - WELDED UNDER MOUNT FRAME ASY (PART 1) UNDER MOUNT FRAME ASY (PART 2) VALVE ASSEMBLY - ELECTRO-HYDRAULIC VALVE VALVE ASSEMBLY - MANUAL-HYDRAULIC VALVE WIRE HARNESS (ELECT-HYD VALVE OPT) WIRE HARNESS (ELECT-HYD VALVE OPT) 28 FT TELESCOPING BOOM WIRE HARNESS (MAN-HYD VALVE STD) WIRE HARNESS (SWIVEL HEAD OPT) Alamo Group Inc. Parts Section -5

10 48 IN FLAIL - head ASY (SOLID MNT) (PART 1) 2011 Alamo Group Inc. Parts Section -6

11 48 IN FLAIL - head ASY (SOLID MNT) (PART 1) Continued ASY,48" FLAIL AXE, GEAR WLDMT, FLAIL AXE HEAD ASY, CUTTERSHAFT, 48" F/A WLDMT DOOR, 48" FLAIL AXE WLDMT, MOTOR MOUNT PLATE, COVER FLAIL AXE HHCS 5/16 NC 1 PL FLATWASHER 5/16, TYPE AW, ZP NUT, TOPLOCK 5/16 NC PL B FLANG BEARING ASY CLAMP BAR RUBBER FLAP ROD-HINGE, F/A DOOR /2 X 1/2 X 1 7/8 LG WLDM SKIDSHOE INSIDE FLAIL AXE SKID SHOE WLDMT WLDMT - REAR ROLLER PULLEY, 3G5V DIA PLATE-BELT & PULLEY COVER FLAIL AXE BEARING GUARD HHCS 5/8 X 1-1/2 PL GR LOCKWASHER 5/ FLATWASHER 5/8 PL STD HHCS, 1/2"-13 NC x 1-1/2" PL LOCKNUT TLM 1/2 NC PLB GREASE FITTING 1/4-28 BOLT THD BOLT, HHCS 5/8" NC X 1-3/4" PL LOCKNUT TOPLOCK 5/8NC PLB CYL, DOOR, 48" F/A PLATE-CLAMP, HITCHPOST GREASE ZERK 1/ BOLT THD SHCS 3/8 NF 1-1/2 PL GR JAMNUT 3/8 NF CARR 5/8 NC X 3 PL GR BUSHIN, QD HUB SF 1-15/16 ID BUSHING, QD HUB SF 1 ID NUT, 3/8 NC JAMNUT V BELT PIN, ROLL 5/32X LOCKWASHER 5/16 PL STD HHCS 5/16 NC X 3/4 GR Alamo Group Inc. Parts Section -7

12 48 IN FLAIL - head ASY (SOLID MNT) (PART 2) 2011 Alamo Group Inc. Parts Section -8

13 48 IN FLAIL - head ASY (SOLID MNT) (PART 2) Continued NUT,1/2NF CENTERLOCK FLATWASHER, 1/2 PL STD HHCS 1/2 NF 1-1/2 PL ROLLER BEARING & FLANGE BOLT, HHCS 1/2" NC X 2" PL BOLT 3/8 NC GR8 X 1-1/ WASHER, 2 X 7/16 X 3/ HHCS 3/8 NC 1-1/2 PL LOCKNUT TLM 3/8 NC PLC HHCS 3/4" X 4" LG NUT 3/4 NC LOCKNUT BOLT, HHCS 1/2" NC X 3-3/4" PL ADP, HYD, ELBOW, 4MB-4MJ HHCS 3/4 NC 2 PL WELDMENT, PIN, HITCH POST FLATWASHER, 1-3/8 TYPE B PL NARROW NUT, SLOTTED 1-3/8 12NF PLB PIN, COTTER 5/16 X 2-1/2 PL PLASTIC TIE, ORANGE, 11LG PLASTIC TIE, RED, 11LG WELDMENT, HITCHPOST STOP, FLAIL AXE SWIVEL BOLT, HHCS 1/4" NC X 3/4" PL NUT, TOPLOCK 1/4 NC PLB PLASTIC TIE, YELLOW PLASTIC TIE, YELLOW & WHITE METAL TACK PLATE, S/N FLAIL AXE 48" GEAR MOTOR #20 SPLIT FLANGE KIT ADP HYD ELBOW 20FL-16MJ FJX - 16MJ ST BOLT, HHCS 3/8 NC 1 PL Alamo Group Inc. Parts Section -9

14 48 IN FLAIL - head ASY (SWIVEL MNT) (PART 1) 2011 Alamo Group Inc. Parts Section -10

15 48 IN FLAIL - head ASY (SWIVEL MNT) (PART 1) Continued " FLAILAXE GEAR SWIVEL WLDMT, FLAIL AXE HEAD ASY, CUTTERSHAFT, 48" F/A WLDMT DOOR, 48" FLAIL AXE WLDMT, MOTOR MOUNT PLATE, COVER FLAIL AXE HHCS 5/16 NC 1 PL FLATWASHER 5/16, TYPE AW, ZP NUT, TOPLOCK 5/16 NC PL B FLANG BEARING ASY CLAMP BAR RUBBER FLAP ROD-HINGE, F/A DOOR /2 X 1/2 X 1 7/8 LG WLDM SKIDSHOE INSIDE FLAIL AXE SKID SHOE WLDMT WLDMT - REAR ROLLER PULLEY, 3G5V DIA PLATE-BELT & PULLEY COVER FLAIL AXE BEARING GUARD HHCS 5/8 X 1-1/2 PL GR LOCKWASHER 5/ FLATWASHER 5/8 PL STD HHCS 1/2 X 1-1/2 NF GR5 PL LOCKNUT TLM 1/2 NC PLB GREASE FITTING 1/4-28 BOLT THD BOLT, HHCS 5/8" NC X 1-3/4" PL LOCKNUT TOPLOCK 5/8NC PLB CYL, DOOR, 48" F/A PLATE-CLAMP, HITCHPOST GREASE ZERK 1/ BOLT THD SHCS 3/8 NF 1-1/2 PL GR JAMNUT 3/8 NF CARR 5/8 NC X 3 PL GR BUSHIN, QD HUB SF 1-15/16 ID BUSHING, QD HUB SF 1 ID NUT, 3/8 NC JAMNUT V BELT PIN, ROLL 5/32X LOCKWASHER 5/16 PL STD HHCS 5/16 NC X 3/4 GR Alamo Group Inc. Parts Section -11

16 48 IN FLAIL - head ASY (SWIVEL MNT) (PART 2) 2011 Alamo Group Inc. Parts Section -12

17 48 IN FLAIL - head ASY (SWIVEL MNT) (PART 2) Continued NUT,1/2NF CENTERLOCK FLATWASHER, 1/2 PL STD HHCS 1/2 NF 1-1/2 PL ROLLER BEARING & FLANGE BOLT, HHCS 1/2" NC X 2" PL BOLT 3/8 NC GR8 X 1-1/ WASHER, 2 X 7/16 X 3/ HHCS 3/8 NC 1-1/2 PL LOCKNUT TLM 3/8 NC PLC HHCS 3/4" X 4" LG NUT 3/4 NC LOCKNUT BOLT, HHCS 1/2" NC X 3-3/4" PL ADP, HYD, ELBOW, 4MB-4MJ HHCS 3/4 NC 2 PL WELDMENT, PIN, HITCH POST FLATWASHER, 1-3/8 TYPE B PL NARROW NUT, SLOTTED 1-3/8 12NF PLB PIN, COTTER 5/16 X 2-1/2 PL PLASTIC TIE, ORANGE, 11LG PLASTIC TIE, RED, 11LG ADP, SWIVEL, FLAIL AXE BEARING, 12OD X 5.8ID WELDMENT, HITCH POST CYLINDER, 2.5B X 1.5R X 14.38S WLDMNT, SWIVEL, CYL BRKT SHCS 1/2 NC 1-1/2 PL HHCS 3/4 NC 2-1/2 PL HHCS 3/4 NC 4 1/2 PL CLAMP, PLATE, SWIVEL STOP, FLAIL AXE SWIVEL BOLT, HHCS 1/4" NC X 3/4" PL NUT, TOPLOCK 1/4 NC PLB PLASTIC TIE, GREEN PLASTIC TIE, GREEN & WHITE PLASTIC TIE, YELLOW PLASTIC TIE, YELLOW & WHITE METAL TACK PLATE, S/N FLAIL AXE 48" GEAR MOTOR #20 SPLIT FLANGE KIT ADP HYD 20FL-20MJ FLANGE 2011 Alamo Group Inc. Parts Section -13

18 48 IN FLAIL - head ASY (SWIVEL MNT) (PART 3) 2011 Alamo Group Inc. Parts Section -14

19 48 IN FLAIL - head ASY (SWIVEL MNT) (PART 3) Continued FJX - 16MJ ST BOLT, HHCS 3/8 NC 1 PL Alamo Group Inc. Parts Section -15

20 48 IN FLAIL - ROTOR W/KNIVES ROTOR W/KNIVES ASY KIT - BLADE, FLAIL AXE FLAIL HANGER BUSHING HHCS HANGER BOLT PER DWG LOCKNUT,CENTERLOCK 5/8 NC PLC 2011 Alamo Group Inc. Parts Section -16

21 50 IN ROTARY - BLADE BAR ASY ASY, BLADE BAR W/BLADES LEAF, MIDDLE, BLADE BAR LEAF, BOTTOM, BLADE BAR BLADE, CW ROTATION WLDMT. TOP BLADE BAR BOLT, BLADE LOCKWASHER 1-1/8 PL STD NUT, SLOTTED, HVY,1-1/8NF PL GR PIN, ROLL, 3/16X1-3/4 9 15C WASHER, X 2.50 X.165, HARDENED HHCS, 1-1/4X3 PL GR HHCS, 1-1/4X2-1/4 PL GR Alamo Group Inc. Parts Section -17

22 50 IN ROTARY - BLADE BAR head ASY (SOLID MNT) 2011 Alamo Group Inc. Parts Section -18

23 50 IN ROTARY - BLADE BAR head ASY (SOLID MNT) Continued ASY, 50" ROT, GEAR, BAR A 1 HYD CYLINDER 2BORE X 9-1/4 STROKE WELDMENT, DOOR ROD, HINGE S 2 PIN ROLL 1/4 X 3/ FLAP, 8 1/2 X 52 X 1/4 THK BAR, HOLD DOWN, FLAP FLAP, REAR 10 X 53 X 3/8 THK BAR, CLAMP, REAR FLATWASHER 3/8 STD HHCS 3/8 X 1-1/2 NC PL GR LOCKNUT TLM 3/8 NC PLC HHCS 3/8 NC 1-3/4 PL WELDMENT, PIN, HITCH POST FLATWASHER, 1-3/8 TYPE B PL NARROW NUT, SLOTTED 1-3/8 12NF PLB PIN, COTTER 5/16 X 2-1/2 PL PIN-DRILLED PIN - MACHINED HEAD PIN, COTTER 3/16 X 1-1/2 PL PLASTIC TIE, YELLOW & WHITE PLASTIC TIE, YELLOW ADP, HYD, ELBOW, 4MB-4MJ PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG MOTOR PRESSURE HOSE (RED) MOTOR RETURN HOSE (ORANGE) DOOR BASE HOSE (YELLOW/WHITE) DOOR ROD HOSE (YELLOW) SWIVEL ROD HOSE (GREEN) SWIVEL BASE HOSE (GREEN/WHITE) 2011 Alamo Group Inc. Parts Section -19

24 50 IN ROTARY - BLADE BAR head ASY (SWIVEL MNT) 2011 Alamo Group Inc. Parts Section -20

25 50 IN ROTARY - BLADE BAR head ASY (SWIVEL MNT) Continued ASY, 50" ROT,GEAR,BAR,SWIVEL A 1 HYD CYLINDER 2BORE X 9-1/4 STROKE WELDMENT, DOOR ROD, HINGE S 2 PIN ROLL 1/4 X 3/ FLAP, 8 1/2 X 52 X 1/4 THK BAR, HOLD DOWN, FLAP FLAP, REAR 10 X 53 X 3/8 THK BAR, CLAMP, REAR FLATWASHER 3/8 STD HHCS 3/8 X 1-1/2 NC PL GR LOCKNUT TLM 3/8 NC PLC HHCS 3/8 NC 1-3/4 PL CYLINDER, 2.5B X 1.5R X 14.38S WELDMENT, PIN, HITCH POST FLATWASHER, 1-3/8 TYPE B PL NARROW NUT, SLOTTED 1-3/8 12NF PLB PIN, COTTER 5/16 X 2-1/2 PL PIN-DRILLED PIN - MACHINED HEAD PIN, COTTER 3/16 X 1-1/2 PL HHCS 3/4 NC 5 PL HHCS 3/4 NC 2-1/2 PL NUT 3/4 NC LOCKNUT PLASTIC TIE, YELLOW & WHITE PLASTIC TIE, YELLOW ADP, HYD, ELBOW, 4MB-4MJ PLASTIC TIE, GREEN PLASTIC TIE, GREEN & WHITE ADP, HYD 6MB-4MJ PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG MOTOR PRESSURE HOSE (RED) MOTOR RETURN HOSE (ORANGE) DOOR BASE HOSE (YELLOW/WHITE) DOOR ROD HOSE (YELLOW) SWIVEL ROD HOSE (GREEN) SWIVEL BASE HOSE (GREEN/WHITE) 2011 Alamo Group Inc. Parts Section -21

26 50 IN ROTARY - BLADE BAR head SUB-ASY (SOLID MNT) 2011 Alamo Group Inc. Parts Section -22

27 50 IN ROTARY - BLADE BAR head SUB-ASY (SOLID MNT) Continued LOCKNUT TLM 3/8 NC PLC HHCS 1/2 NC 1-3/4 PL LOCKWASHER 1/2 HEAVY SKID SHOE WELDMENT, DECK 50" HEAD GASKET ASY, BLADE BAR W/BLADES SHCS 3/4 NC 4" LG PL8 9 15B WASHER 3/8 SAE P LOCKWASHER 3/4 HEAVY FSCS 3/8 NC X 1-1/ A 1 ASSEMBLY, SPINDLE HOUSING-SPLINED HHCS 3/4 NC 3 PL HHCS 3/4 NC X 1 3/4" LG NUT 3/4 NC LOCKNUT FLATWASHER 3/4 HARDENED WELDMENT, HITCH POST HYD MOTOR - CAST IRON SPLINED SPLIT FLANGE KIT # ADP HYD ELBOW 24FL - 16MJ ADP HYD ELBOW 24FL - 16MJ #16MJ-16FJ TUBE Alamo Group Inc. Parts Section -23

28 50 IN ROTARY - BLADE BAR head SUB-ASY (SWIVEL MNT) 2011 Alamo Group Inc. Parts Section -24

29 50 IN ROTARY - BLADE BAR head SUB-ASY (SWIVEL MNT) Continued LOCKNUT TLM 3/8 NC PLC HHCS 3/4 NC 2-1/2 PL NUT 3/4 NC LOCKNUT HHCS 1/2 NC 1-3/4 PL LOCKWASHER 1/2 HEAVY SKID SHOE SHCS 1/2 NC X 1 1/2" LG PL SLEWING BEARING, 12 OD X 5.8 ID WELDMENT, HITCH POST WELDMENT, DECK 50" HEAD GASKET ASY, BLADE BAR W/BLADES PLATE, HITCH POST BOTTOM, MAVERICK SHCS 3/4 NC 4" LG PL B WASHER 3/8 SAE P LOCKWASHER 3/4 HEAVY FSCS 3/8 NC X 1-1/ A 1 ASSEMBLY, SPINDLE HOUSING-SPLINED HHCS 3/4 NC X 1 3/4" LG FLATWASHER 3/4 HARDENED HHCS 3/4 NC 3 PL HYD MOTOR - CAST IRON SPLINED SPLIT FLANGE KIT # ADP HYD ELBOW 24FL - 16MJ ADP HYD ELBOW 24FL - 16MJ WLDMNT, STOP, SWIVEL #16MJ-16FJ TUBE Alamo Group Inc. Parts Section -25

30 50 IN ROTARY - BLADE PAN head ASY (SOLID MNT) 2011 Alamo Group Inc. Parts Section -26

31 50 IN ROTARY - BLADE PAN head ASY (SOLID MNT) Continued ASY, 50" ROT, GEAR, PAN A 1 HYD CYLINDER 2BORE X 9-1/4 STROKE WELDMENT, DOOR ROD, HINGE S 2 PIN ROLL 1/4 X 3/ FLAP, 8 1/2 X 52 X 1/4 THK BAR, HOLD DOWN, FLAP FLAP, REAR 10 X 53 X 3/8 THK BAR, CLAMP, REAR FLATWASHER 3/8 STD HHCS 3/8 X 1-1/2 NC PL GR LOCKNUT TLM 3/8 NC PLC HHCS 3/8 NC 1-3/4 PL WELDMENT, PIN, HITCH POST FLATWASHER, 1-3/8 TYPE B PL NARROW NUT, SLOTTED 1-3/8 12NF PLB PIN, COTTER 5/16 X 2-1/2 PL PIN-DRILLED PIN - MACHINED HEAD PIN, COTTER 3/16 X 1-1/2 PL PLASTIC TIE, YELLOW & WHITE PLASTIC TIE, YELLOW ADP, HYD, ELBOW, 4MB-4MJ PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG MOTOR PRESSURE HOSE (RED) MOTOR RETURN HOSE (ORANGE) DOOR BASE HOSE (YELLOW/WHITE) DOOR ROD HOSE (YELLOW) 2011 Alamo Group Inc. Parts Section -27

32 50 IN ROTARY - BLADE PAN head ASY (SWIVEL MNT) 2011 Alamo Group Inc. Parts Section -28

33 50 IN ROTARY - BLADE PAN head ASY (SWIVEL MNT) Continued ASY, 50" ROT,GEAR,PAN,SWIVEL A 1 HYD CYLINDER 2BORE X 9-1/4 STROKE WELDMENT, DOOR ROD, HINGE S 2 PIN ROLL 1/4 X 3/ FLAP, 8 1/2 X 52 X 1/4 THK BAR, HOLD DOWN, FLAP FLAP, REAR 10 X 53 X 3/8 THK BAR, CLAMP, REAR FLATWASHER 3/8 STD HHCS 3/8 X 1-1/2 NC PL GR LOCKNUT TLM 3/8 NC PLC HHCS 3/8 NC 1-3/4 PL CYLINDER, 2.5B X 1.5R X 14.38S WELDMENT, PIN, HITCH POST FLATWASHER, 1-3/8 TYPE B PL NARROW NUT, SLOTTED 1-3/8 12NF PLB PIN, COTTER 5/16 X 2-1/2 PL PIN-DRILLED PIN - MACHINED HEAD PIN, COTTER 3/16 X 1-1/2 PL HHCS 3/4 NC 5 PL HHCS 3/4 NC 2-1/2 PL NUT 3/4 NC LOCKNUT PLASTIC TIE, YELLOW & WHITE PLASTIC TIE, YELLOW ADP, HYD, ELBOW, 4MB-4MJ PLASTIC TIE, GREEN PLASTIC TIE, GREEN & WHITE ADP, HYD 6MB-4MJ PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG MOTOR PRESSURE HOSE (RED) MOTOR RETURN HOSE (ORANGE) DOOR BASE HOSE (YELLOW/WHITE) DOOR ROD HOSE (YELLOW) SWIVEL ROD HOSE (GREEN) SWIVEL BASE HOSE (GREEN/WHITE) 2011 Alamo Group Inc. Parts Section -29

34 50 IN ROTARY - BLADE PAN head SUB-ASY (SOLID MNT) 2011 Alamo Group Inc. Parts Section -30

35 50 IN ROTARY - BLADE PAN head SUB-ASY (SOLID MNT) Continued LOCKNUT TLM 3/8 NC PLC HHCS 1/2 NC 1-3/4 PL LOCKWASHER 1/2 HEAVY SKID SHOE WELDMENT, DECK 50" HEAD GASKET PAN ASSY 50" HEAD SHCS 3/4 NC 4" LG PL8 9 15B WASHER 3/8 SAE P LOCKWASHER 3/4 HEAVY FSCS 3/8 NC X 1-1/ A 1 ASSEMBLY, SPINDLE HOUSING-SPLINED HHCS 3/4 NC 3 PL HHCS 3/4 NC X 1 3/4" LG NUT 3/4 NC LOCKNUT FLATWASHER 3/4 HARDENED WELDMENT, HITCH POST HYD MOTOR - CAST IRON SPLINED SPLIT FLANGE KIT # ADP HYD ELBOW 24FL - 16MJ ADP HYD ELBOW 24FL - 16MJ #16MJ-16FJ TUBE Alamo Group Inc. Parts Section -31

36 50 IN ROTARY - BLADE PAN head SUB-ASY (SWIVEL MNT) 2011 Alamo Group Inc. Parts Section -32

37 50 IN ROTARY - BLADE PAN head SUB-ASY (SWIVEL MNT) Continued LOCKNUT TLM 3/8 NC PLC HHCS 3/4 NC 2-1/2 PL NUT 3/4 NC LOCKNUT HHCS 1/2 NC 1-3/4 PL LOCKWASHER 1/2 HEAVY SKID SHOE SHCS 1/2 NC X 1 1/2" LG PL SLEWING BEARING, 12 OD X 5.8 ID WELDMENT, HITCH POST WELDMENT, DECK 50" HEAD GASKET PAN ASSY 50" HEAD PLATE, HITCH POST BOTTOM, MAVERICK SHCS 3/4 NC 4" LG PL B WASHER 3/8 SAE P LOCKWASHER 3/4 HEAVY FSCS 3/8 NC X 1-1/ A 1 ASSEMBLY, SPINDLE HOUSING-SPLINED HHCS 3/4 NC X 1 3/4" LG FLATWASHER 3/4 HARDENED HHCS 3/4 NC 3 PL HYD MOTOR - CAST IRON SPLINED SPLIT FLANGE KIT # ADP HYD ELBOW 24FL - 16MJ ADP HYD ELBOW 24FL - 16MJ WLDMNT, STOP, SWIVEL #16MJ-16FJ TUBE Alamo Group Inc. Parts Section -33

38 60 IN ROTARY - BLADE BAR ASY BLADE BAR ASY, W/ BLADES HEX SLOTTED NUT, HVY 1-1/8"-NF PL GR ROLL PIN, 3/16" X 1-3/4" FLATWASHER, 1-1/4" HARDENED PL BLADE SET, MATCHED SET OF TWO LEAF BLADE BAR, TOP LEAF BLADE BAR, MIDDLE LEAF BLADE BAR, BOTTOM BOLT, HEX HEAD 1-1/4"-NC X 3" PL GR BOLT, HEX HEAD 1-1/4"-NC X 2-1/4" PL GR BLADE BOLT, SHOULDERED LOCKWASHER, 1-1/8" PL STD BLADE BOLTS, NUTS, ROLLPIN KIT (INCLUDES 2 EACH OF ITEMS 1, 2, & 10) 2011 Alamo Group Inc. Parts Section -34

39 ThIS PAGE INTENTIONAL LEFT BLANK 2011 Alamo Group Inc. Parts Section -35

40 60 IN ROTARY - BLADE BAR head ASY (SOLID MNT) 2011 Alamo Group Inc. Parts Section -36

41 60 IN ROTARY - BLADE BAR head ASY (SOLID MNT) Continued ASY, 60" ROT, GEAR BAR WELDMENT, DOOR ROD-HINGE S 2 PIN ROLL 1/4 X 3/ A 1 HYD CYLINDER 2BORE X 9-1/4 STROKE WELDMENT, PIN, HITCH POST FLATWASHER, 1-3/8 TYPE B PL NARROW NUT, SLOTTED 1-3/8 12NF PLB PIN, COTTER 5/16 X 2-1/2 PL PIN-DRILLED PIN - MACHINED HEAD PIN, COTTER 3/16 X 1-1/2 PL REAR FLAP 10 X 63 X 3/8 THK REAR CLAMP BAR DEBRIS DEFLECTOR FLAP HOLD DOWN BAR HHCS 3/8 X 1-1/2 NC PL GR FLATWASHER 3/8 STD LOCKNUT TLM 3/8 NC PLC HHCS 3/8 NC 1-3/4 PL ADP, HYD, ELBOW, 4MB-4MJ PLASTIC TIE, YELLOW PLASTIC TIE, YELLOW & WHITE PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG BOLT, HHCS 3/8 NC 1-1/4 PL LOCKWASHER, 3/8" PL MOTOR PRESSURE HOSE (RED) MOTOR RETURN HOSE (ORANGE) DOOR BASE HOSE (YELLOW/WHITE) DOOR ROD HOSE (YELLOW) 2011 Alamo Group Inc. Parts Section -37

42 60 IN ROTARY - BLADE BAR head ASY (SWIVEL MNT) 2011 Alamo Group Inc. Parts Section -38

43 60 IN ROTARY - BLADE BAR head ASY (SWIVEL MNT) Continued WELDMENT, DOOR ROD-HINGE S 2 PIN ROLL 1/4 X 3/ A 1 HYD CYLINDER 2BORE X 9-1/4 STROKE WELDMENT, PIN, HITCH POST FLATWASHER, 1-3/8 TYPE B PL NARROW NUT, SLOTTED 1-3/8 12NF PLB PIN, COTTER 5/16 X 2-1/2 PL PIN-DRILLED PIN - MACHINED HEAD PIN, COTTER 3/16 X 1-1/2 PL REAR FLAP 10 X 63 X 3/8 THK REAR CLAMP BAR DEBRIS DEFLECTOR FLAP HOLD DOWN BAR HHCS 3/8 X 1-1/2 NC PL GR FLATWASHER 3/8 STD LOCKNUT TLM 3/8 NC PLC HHCS 3/8 NC 1-3/4 PL ADP, HYD, ELBOW, 4MB-4MJ PLASTIC TIE, YELLOW PLASTIC TIE, YELLOW & WHITE PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG HHCS 3/4 NC 2-1/2 PL CYLINDER, 2.5B X 1.5R X 14.38S HHCS 3/4 NC 5 PL ADP, HYD 6MB-4MJ PLASTIC TIE, GREEN & WHITE PLASTIC TIE, GREEN #16MJ-16FJ TUBE WLDMNT, STOP, SWIVEL BOLT, HHCS 3/8 NC 1-1/4 PL LOCKWASHER, 3/8" PL NUT 3/4-NC TOPLOCK MOTOR PRESSURE HOSE (RED) MOTOR RETURN HOSE (ORANGE) DOOR BASE HOSE (YELLOW/WHITE) DOOR ROD HOSE (YELLOW) SWIVEL ROD HOSE (GREEN) SWIVEL BASE HOSE (GREEN/WHITE) 2011 Alamo Group Inc. Parts Section -39

44 60 IN ROTARY - BLADE BAR head SUB-ASY (SOLID MNT) 2011 Alamo Group Inc. Parts Section -40

45 60 IN ROTARY - BLADE BAR head SUB-ASY (SOLID MNT) Continued ASY, 60" ROT, GEAR, BAR WELDMENT,60" ROTARY,SWIVEL LOCKNUT TLM 3/8 NC PLC ADP HYD ELBOW 24FL - 16MJ ADP HYD ELBOW 24FL - 16MJ HHCS 3/4 NC X 1 3/4" LG NUT 3/4 NC LOCKNUT LOCKWASHER, 1/2 HVY, PLATED HHCS 3/4 NC 3 PL MOTOR, HYD, GEAR, 5.73 HP SEAL HHCS 1/2 NC 1-3/4 PL GASKET 12 15B WASHER 3/8 SAE P FSCS 3/8 NC X 1-1/ LOCKWASHER 3/4 HEAVY SKID SHOE ASY, BLADE BAR W/BLADES SHCS 3/4 NC 4" LG PL A 1 ASSEMBLY, SPINDLE HOUSING-SPLINED FLATWASHER 3/4 HARDENED WELDMENT, HITCH POST SPLIT FLANGE KIT # #16MJ-16FJ TUBE Alamo Group Inc. Parts Section -41

46 60 IN ROTARY - BLADE BAR head SUB-ASY (SWIVEL MNT) 2011 Alamo Group Inc. Parts Section -42

47 60 IN ROTARY - BLADE BAR head SUB-ASY (SWIVEL MNT) Continued ASY, 60" ROT, GEAR BAR, SWIVEL LOCKNUT TLM 3/8 NC PLC ADP HYD ELBOW 24FL - 16MJ ADP HYD ELBOW 24FL - 16MJ HHCS 3/4 NC X 1 3/4" LG NUT 3/4 NC LOCKNUT LOCKWASHER, 1/2 HVY, PLATED HHCS 3/4 NC 3 PL MOTOR, HYD, GEAR, 5.73 HP SEAL HHCS 1/2 NC 1-3/4 PL GASKET 11 15B WASHER 3/8 SAE P FSCS 3/8 NC X 1-1/ LOCKWASHER 3/4 HEAVY SKID SHOE ASY, BLADE BAR W/BLADES SHCS 3/4 NC 4" LG PL A 1 ASSEMBLY, SPINDLE HOUSING-SPLINED FLATWASHER 3/4 HARDENED WELDMENT,60" ROTARY,SWIVEL HHCS 3/4 NC 2-1/2 PL SPLIT FLANGE KIT # WELDMENT, HITCH POST PLATE, HITCH POST BOTTOM, MAVERICK SLEWING BEARING, 12 OD X 5.8 ID SHCS 1/2 NC X 1 1/2" LG PL #16MJ-16FJ TUBE WLDMNT, STOP, SWIVEL 2011 Alamo Group Inc. Parts Section -43

48 60 IN ROTARY - MOTOR (PARTS) (MODEL NO ) 2011 Alamo Group Inc. Parts Section -44

49 60 IN ROTARY - MOTOR (PARTS) (MODEL NO ) Continued MOTOR ASY, CAST IRON W/ SPLINED SHAFT SNAP RING O-RING (SEE SEAL KIT) SEAL RETAINER SEAL (SEE SEAL KIT) MOUNTING FLANGE PLUG, HEX SOCKET HEAD 4MB CHECK ASY SEAL END (SEE SEAL KIT) THRUST PLATE (SEE SEAL KIT) GEAR SET SQUARE SEAL, (SEE SEAL KIT) DOWEL PIN GEAR HOUSING PORTING FLANGE WASHER BOLT, HEX HEAD SIDE SEAL, (SEE SEAL KIT) NOT SHOWN SEAL RETAINER SEAL KIT, MINOR REBUILD (ITEMS 2,4,8,11&17) SEAL KIT, MAJOR REBUILD (ITEMS 2,4,8,9,11&17) 2011 Alamo Group Inc. Parts Section -45

50 60 IN ROTARY - MOTOR (PARTS) (MODEL NO ) 2011 Alamo Group Inc. Parts Section -46

51 60 IN ROTARY - MOTOR (PARTS) (MODEL NO ) Continued MOTOR,HYD, GEAR, 5.73, HP SEAL HOUSING, SEC HOUSING, PEC HOUSING, GEAR SET, GEAR SHAFT CAP SCREW SCREW, DRIVE PIN, DOWEL THRPL RTNR, SEAL RING, SNAP SEAL,O-R SEAL, LIP SEAL, LIP SEAL, SQ-R SEAL, SIDE SEAL, END SEAL, BACK-UP RTNR, SEAL CHECK ASS`Y WASHER KIT, HP, SEAL, 5.73 CID MOTOR 2011 Alamo Group Inc. Parts Section -47

52 48 IN BUZZBAR - 2 BLADES (PART 1) 2011 Alamo Group Inc. Parts Section -48

53 48 IN BUZZBAR - 2 BLADES (PART 1) Continued BLADE BUZZBAR ASSEMBLY WELDMENT, SAW BODY 2 BLADE BUMPER WLDMT, REAR SHIELD 2 BLADE MACHINED TUBE, MOTOR MOUNT ASSEMBLY, SPINDLE SHAFT BLADE SPACER PLATE, SHAFT END CAP HUB ASSY BLADES BRACKET TENSION ADJUST NUT HEX 1/2 NC HHCS 1/2 NC 3-1/2, FULL THREAD NUT 1/2 NF FLAT SOCKET HEAD 1/2 NC X 3-1/2 W/ HOLE FLAT SOCKET HEAD 1/2 NC X 2" W/ HOLE SLOT NUT SHEAVE QD BUSHING BELT, MICRO-V SQ KEY HUB, 20R10 W/1-1/8" BORE INSERT, URETHANE COVER, NYLON HUB, 20R10 W/1-1/8" BORE SHEET, BELT COVER, LEFT 2 BLADE BELT COVER, SHORT GEAR MOTOR LOCKNUT TLM 1/2 NC PLB HHCS 1/2-13UNC 1 3/4 PL PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG PLATE-CLAMP, HITCHPOST WELDMENT, HITCHPOST NUT 3/4 NC LOCKNUT HHCS 3/4 NC 2 PL SLIP ON RECEPTACLE 9MM STUD 9MM 1/4 TURN BOLT, HHCS 3/8 NC 1 PL FLATWASHER 3/8 STD LOCKNUT TLM 3/8 NC PLC 2011 Alamo Group Inc. Parts Section -49

54 48 IN BUZZBAR - 2 BLADES (PART 2) 2011 Alamo Group Inc. Parts Section -50

55 48 IN BUZZBAR - 2 BLADES (PART 2) Continued HHCS 3/8 X 1-1/2 NC PL GR WELDMENT, PIN, HITCH POST PIN, COTTER 5/16 X 2-1/2 PL NUT, SLOTTED 1-3/8 12NF PLB FLATWASHER, 1-3/8 TYPE B PL NARROW #20 SPLIT FLANGE KIT ADP,HYD 20FL-16MJ O-RING MANIFOLD COMM. MOTOR HYDRO FLATWASHER STD 1/4 PL HHCS RELIEF CARTRIDGE HOSE #16-16FJX -16FJX -74LG HOSE #16-16FJX -16FJX45-74LG PLUG LOCKWASHER 3/ WASHER TYRONE #11146, PLATED PIN, COTTER 1/8 X CORDURA SLEEVE 2011 Alamo Group Inc. Parts Section -51

56 69 IN BUZZBAR - 3 BLADES - STD head (PART 1) 2011 Alamo Group Inc. Parts Section -52

57 69 IN BUZZBAR - 3 BLADES - STD head (PART 1) Continued ASY 3-BLADE BUZZBAR GEAR WELDMENT, SAW BODY 3 BLADE BUMPER WLDMT, SHIELD 3 BLADE BRACKET TENSION ADJUST MACHINED TUBE, MOTOR MOUNT HUB ASSY ASSEMBLY, SPINDLE SHAFT PLATE, SHAFT END CAP BLADE SPACER NUT 1/2 NF BLADES FLAT SOCKET HEAD 1/2 NC X 3-1/2 W/ HOLE FLAT SOCKET HEAD 1/2 NC X 2" W/ HOLE SLOT NUT HHCS 1/2 NC 3-1/2, FULL THREAD NUT HEX 1/2 NC FLATWASHER 3/8 STD SHEAVE QD BUSHING BELT, MICRO-V STUD 9MM 1/4 TURN SLIP ON RECEPTACLE 9MM HUB, 20R10 W/1-1/8" BORE SQ KEY INSERT, URETHANE COVER, NYLON HUB, 20R10 W/1-1/8" BORE BOLT, HHCS 3/8 NC 1 PL HHCS 3/8 X 1-1/2 NC PL GR LOCKNUT TLM 3/8 NC PLC GEAR MOTOR HHCS 1/2-13UNC 1 3/4 PL LOCKNUT TLM 1/2 NC PLB PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG BELT COVER, SHORT BELT COVER, LEFT 3 BLADE PLATE-CLAMP, HITCHPOST WELDMENT, HITCHPOST NUT 3/4 NC LOCKNUT 2011 Alamo Group Inc. Parts Section -53

58 69 IN BUZZBAR - 3 BLADES - STD head (PART 2) 2011 Alamo Group Inc. Parts Section -54

59 69 IN BUZZBAR - 3 BLADES - STD head (PART 2) Continued HHCS 3/4 NC 2 PL WELDMENT, PIN, HITCH POST FLATWASHER, 1-3/8 TYPE B PL NARROW NUT, SLOTTED 1-3/8 12NF PLB PIN, COTTER 5/16 X 2-1/2 PL #20 SPLIT FLANGE KIT ADP,HYD 20FL-16MJ O-RING MANIFOLD COMM. MOTOR HYDRO FLATWASHER STD 1/4 PL HHCS RELIEF CARTRIDGE PLUG HOSE #16-16FJX -16FJX -74LG HOSE #16-16FJX -16FJX45-74LG LOCKWASHER 3/ WASHER TYRONE #11146, PLATED PIN, COTTER 1/8 X CORDURA SLEEVE 2011 Alamo Group Inc. Parts Section -55

60 90 IN BUZZBAR - 4 BLADES - STD head (PART 1) 2011 Alamo Group Inc. Parts Section -56

61 90 IN BUZZBAR - 4 BLADES - STD head (PART 1) Continued ASY 4-BLADE BUZZBAR, GEAR WELDMENT, SAW BODY 4 BLADE WLDMT, REAR SHIELD HUB ASSY BUMPER ASSEMBLY, SPINDLE SHAFT SHEAVE QD BUSHING BLADES BLADE SPACER BRACKET TENSION ADJUST PLATE, SHAFT END CAP MACHINED TUBE, MOTOR MOUNT BELT COVER, LONG BELT COVER, SHORT SQ KEY HUB, 20R10 W/1-1/8" BORE HUB, 20R10 W/1-1/8" BORE COVER, NYLON INSERT, URETHANE BELT, MICRO-V SLIP ON RECEPTACLE 9MM PLASTIC TIE, ORANGE, 11LG PLASTIC TIE, RED, 11LG PLATE-CLAMP, HITCHPOST WELDMENT, HITCHPOST HHCS 1/2-13UNC 1 3/4 PL LOCKNUT TLM 1/2 NC PLB NUT 3/4 NC LOCKNUT HHCS 3/4 NC 2 PL FLATWASHER 3/8 STD BOLT, HHCS 3/8 NC 1 PL LOCKNUT TLM 3/8 NC PLC HHCS 3/8 X 1-1/2 NC PL GR FLAT SOCKET HEAD 1/2 NC X 3-1/2 W/ HOLE FLAT SOCKET HEAD 1/2 NC X 2" W/ HOLE SLOT NUT NUT 1/2 NF HHCS 1/2 NC 3-1/2, FULL THREAD NUT HEX 1/2 NC STUD 9MM 1/4 TURN 2011 Alamo Group Inc. Parts Section -57

62 90 IN BUZZBAR - 4 BLADES - STD head (PART 2) 2011 Alamo Group Inc. Parts Section -58

63 90 IN BUZZBAR - 4 BLADES - STD head (PART 2) Continued WELDMENT, PIN, HITCH POST FLATWASHER, 1-3/8 TYPE B PL NARROW NUT, SLOTTED 1-3/8 12NF PLB PIN, COTTER 5/16 X 2-1/2 PL PLATE S/N PR GEAR MOTOR #20 SPLIT FLANGE KIT ADP,HYD 20FL-16MJ O-RING MANIFOLD COMM. MOTOR HYDRO FLATWASHER STD 1/4 PL HHCS HOSE #16-16FJX -16FJX45-74LG HOSE #16-16FJX -16FJX -74LG RELIEF CARTRIDGE PLUG LOCKWASHER 3/ PIN, COTTER 1/8 X WASHER, FLAT, PLATED 2011 Alamo Group Inc. Parts Section -59

64 BUZZ BAR SPINDLE ASSEMBLY 2011 Alamo Group Inc. Parts Section -60

65 BUZZ BAR SPINDLE ASSEMBLY Continued ASSEMBLY SPINDLE SHAFT HOUSING, MACHINED WLDMT, SHAFT W/ ANTI-WRAP COLLAR, BEARING PRELOAD BEARING CUP BEARING ROLLER 6 15C WASHER, HARDENED 7 5D NUT, HEX SLOTTED SEAL GREASE FITTING, 1/8 MP STRGHT GREASE VENT 1/8 MP, 1-5 LB STUD COTTER PIN 2011 Alamo Group Inc. Parts Section -61

66 BUZZ BAR - hyd MOTOR PARTS - P/N Alamo Group Inc. Parts Section -62

67 BUZZ BAR - hyd MOTOR PARTS - P/N Continued MOTOR ASY, GEAR TYPE 3.94 CIR SNAP RING SPACER RETAINER SEAL SEAL (IN ITEM 19 & 20) FLANGE, MOUNTING PLUG, HEX SOCKET HEAD CHECK ASY SEAL END (IN ITEM 19 & 20) THRUST PLATE (IN ITEM 20 ONLY ) GEAR & SHAFT SET SQUARE SEAL, (IN ITEM 19 & 20) DOWEL PIN GEAR HOUSING PORTING FLANGE WASHER BOLT SIDE SEAL, NOT SHOWN (IN ITEM 19 & 20) KEY SEAL KIT, MINOR (ITEMS 4,8,11 & 17) SEAL KIT, MAJOR (ITEMS 4,8,9,11 & 17) 2011 Alamo Group Inc. Parts Section -63

68 BOOM ASY - 18 FT BOOM (PART 1) 2011 Alamo Group Inc. Parts Section -64

69 BOOM ASY - 18 FT BOOM (PART 1) Continued ASSEMBLY, 18 AXTREME WELDMENT,18` LIFT WLDMNT, DIPPER, GEN2, U.M CYLINDER, 4.0B X 2.25R X 24.63S CYLINDER, 3.5B X 1.5R X 16.0S CYL, 3.5B X 1.5R X 30.0S PIN, 1-1/2 X 5-3/16 & 13/32 HOLE CONNEX BUSHING, 2 1/4 X 2 X WELDMENT, PIN, LIFT/ DIPPER WELDMENT, CYLINDER PIN LONG, NEW BOOM CONNEX BUSHING, 1 3/4 X 1 1/2 X SPACER, PIN, DIPPER, MAVERICK SLOTTED NUT, 1-1/2 NF HYDRAULIC TUBE, # HYDRAULIC TUBE, # ASSEMBLY, TILT CYLINDER COVER ADP, HYD 4MJ -4MJ BULKHEAD CAP, HYD 4FJ PIN, COTTER 5/16 X 2-1/2 PL ADP, HYD ELBOW 6MB-6MJ FLATWASHER, 1/2 PL STD HHCS 1/2 NC X 2 1/4 PL LOCKNUT TLM 1/2 NC PLB HHCS 3/8 X 1-1/2 NC PL GR HHCS 3/8 NC 2-3/4 PL LOCKNUT TLM 3/8 NC PLC ADP HYD ELBOW 6MJ-6FJX GREASE ZERK 1/ BOLT THD GREASE FITTING 1/4-28 BOLT THD PLASTIC TIE, ORANGE & WHITE PLASTIC TIE, BLUE & WHITE PLASTIC TIE, ORANGE PLASTIC TIE, BLUE PLASTIC TIE, RED & WHITE PLASTIC TIE, RED PLASTIC TIE, YELLOW & WHITE PLASTIC TIE, YELLOW PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG PLASTIC TIE, GREEN PLASTIC TIE, GREEN & WHITE 2011 Alamo Group Inc. Parts Section -65

70 BOOM ASY - 18 FT BOOM (PART 2) 2011 Alamo Group Inc. Parts Section -66

71 BOOM ASY - 18 FT BOOM (PART 2) Continued DECAL, PINCH POINT COVER, LIFT TUBE COVER CAP, 16 FJ CLAMP, TUBE 1-POSTION PLATE, LINKAGE WELDMENT, LINKAGE WELDMENT, PIN, LINKAGE BOLT, HHCS 3/8 NC 1 PL RETAINING RING,1.5 SHAFT WELDMENT, CYLINDER PIN, NEW BOOM CARB 1/2-13 X LOCKWASHER, 1/2 HVY, PLATED NUT HEX 1/2 NC SPRING NUT 1/ HIGH ALLOY, L/W 3/8 YZ PLATE, BULKHEAD BOLT, HHCS 1/4" X 1/2" LG ADP HYD STGHT 16MJ - 16MJ BULKHEAD ADP, HYD, 4MJ-4FJX ADP HYD ELBOW 16 MJ-16 JX ADAPTER 16MJ - 16MJ 90 BULKHEAD 2011 Alamo Group Inc. Parts Section -67

72 BOOM ASY - 22 FT BOOM (PART 1) 2011 Alamo Group Inc. Parts Section -68

73 BOOM ASY - 22 FT BOOM (PART 1) Continued ASY, 22 AXTREME WELDMENT, 22` LIFT WELDMENT, 22` DIPPER WELDMENT, PIN, LIFT/ DIPPER CYLINDER, 4.0B X 2.25R X 24.63S WELDMENT, CYLINDER PIN, NEW BOOM WELDMENT, CYLINDER PIN SHORT, NEW BOOM SPACER, PIN, DIPPER, MAVERICK CYLINDER, 4.0B X 2.25R X 21.5S SLOTTED NUT, 1-1/2 NF ADP, HYD ELBOW 6MB-6MJ CONNEX BUSHING, 2 1/4 X 2 X CONNEX BUSHING, 1 3/4 X 1 1/2 X HYDRAULIC TUBE, # HYDRAULIC TUBE, # ADP, HYD 4MJ -4MJ BULKHEAD CAP, HYD 4FJ FLATWASHER, 1/2 PL STD HHCS 3/8NC 1-3/4 PL GR HHCS 3/8 X 1-1/2 NC PL GR LOCKNUT TLM 3/8 NC PLC GREASE FITTING 1/4-28 BOLT THD GREASE ZERK 1/ BOLT THD PLASTIC TIE, ORANGE & WHITE PIN, COTTER 5/16 X 2-1/2 PL PLASTIC TIE, ORANGE PLASTIC TIE, BLUE & WHITE PLASTIC TIE, BLUE PLASTIC TIE, RED & WHITE PLASTIC TIE, RED PLASTIC TIE, YELLOW & WHITE PLASTIC TIE, YELLOW PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG ADP HYD ELBOW 6MJ-6FJX PLASTIC TIE, GREEN PLASTIC TIE, GREEN & WHITE CLAMP, TUBE 1-POSTION COVER, LIFT TUBE COVER COVER, LIFT TUBE COVER CAP, 16 FJ 2011 Alamo Group Inc. Parts Section -69

74 BOOM ASY - 22 FT BOOM (PART 2) 2011 Alamo Group Inc. Parts Section -70

75 BOOM ASY - 22 FT BOOM (PART 2) Continued BOLT, HHCS 3/8 NC 1 PL RETAINING RING,1.5 SHAFT WELDMENT, LINKAGE WELDMENT, PIN, LINKAGE PLATE, LINKAGE ASSEMBLY, TILT CYLINDER COVER CYLINDER, 3.5B X 1.5R X 16.0S CARB 1/2-13 X LOCKWASHER, 1/2 HVY, PLATED NUT HEX 1/2 NC SPRING NUT 1/ HIGH ALLOY, L/W 3/8 YZ ADP HYD STGHT 16MJ - 16MJ BULKHEAD ADAPTER 16MJ - 16MJ 90 BULKHEAD ADP HYD ELBOW 16 MJ-16 JX ADP, HYD, 4MJ-4FJX PLATE, BULKHEAD BOLT, HHCS 1/4" X 1/2" LG HHCS 1/2NC 1-1/2 LG PL NUT, TOPLOCK 1/4 NC PLB 2011 Alamo Group Inc. Parts Section -71

76 BOOM ASY - 25 FT BOOM (PART 1) 2011 Alamo Group Inc. Parts Section -72

77 BOOM ASY - 25 FT BOOM (PART 1) Continued ASSEMBLY, 25 AXTREME WELDMENT, 25` LIFT WLDMT, 25` DIPPER CYLINDER, 4.0B X 2.25R X 24.63S CYLINDER, 4.0B X 2.25R X 21.5S CONNEX BUSHING, 2 1/4 X 2 X CONNEX BUSHING, 1 3/4 X 1 1/2 X WELDMENT, PIN, LIFT/ DIPPER SPACER, PIN, DIPPER SLOTTED NUT, 1-1/2 NF WELDMENT, CYLINDER PIN, NEW BOOM WELDMENT, CYLINDER PIN SHORT, NEW BOOM ADP, HYD 4MJ -4MJ BULKHEAD CAP, HYD 4FJ ADP, HYD ELBOW 6MB-6MJ FLATWASHER, 1/2 PL STD HHCS 1/2 NC 1-3/4 PL HHCS 3/8NC 1-3/4 PL GR HHCS 3/8 X 1-1/2 NC PL GR LOCKNUT TLM 3/8 NC PLC GREASE ZERK 1/ BOLT THD GREASE FITTING 1/4-28 BOLT THD PIN, COTTER 5/16 X 2-1/2 PL PLASTIC TIE, ORANGE & WHITE PLASTIC TIE, ORANGE PLASTIC TIE, BLUE & WHITE PLASTIC TIE, BLUE PLASTIC TIE, RED PLASTIC TIE, RED & WHITE PLASTIC TIE, YELLOW PLASTIC TIE, YELLOW & WHITE PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG ADP HYD ELBOW 6MJ-6FJX PLASTIC TIE, GREEN PLASTIC TIE, GREEN & WHITE CLAMP, TUBE 1-POSTION HYDRAULIC TUBE, # HYDRAULIC TUBE, # COVER, LIFT TUBE COVER COVER, LIFT TUBE COVER 2011 Alamo Group Inc. Parts Section -73

78 BOOM ASY - 25 FT BOOM (PART 2) 2011 Alamo Group Inc. Parts Section -74

79 BOOM ASY - 25 FT BOOM (PART 2) Continued CAP, 16 FJ NUT HEX 1/2 NC LOCKWASHER, 1/2 HVY, PLATED CARB 1/2-13 X SPRING NUT 1/ PLATE, LINKAGE WELDMENT, PIN, LINKAGE RETAINING RING,1.5 SHAFT ASSEMBLY, TILT CYLINDER COVER CYLINDER, 3.5B X 1.5R X 16.0S WELDMENT, LINKAGE BOLT, HHCS 3/8 NC 1 PL HIGH ALLOY, L/W 3/8 YZ ADP, HYD, 4MJ-4FJX ADP HYD STGHT 16MJ - 16MJ BULKHEAD ADP HYD ELBOW 16 MJ-16 JX ADAPTER 16MJ - 16MJ 90 BULKHEAD PLATE, BULKHEAD BOLT, HHCS 1/4" X 1/2" LG 2011 Alamo Group Inc. Parts Section -75

80 BOOM ASY - 28FT TELESCOPING BOOM (PART 1) 2011 Alamo Group Inc. Parts Section -76

81 BOOM ASY - 28FT TELESCOPING BOOM (PART 1) Continued ASSEMBLY, AXTREME 28T BOOM WELDMENT, 25` LIFT CYLINDER, 4.5B X 2.5R X 24.63S CYLINDER, 4.0B X 2.25R X 21.5S CONNEX BUSHING, 2 1/4 X 2 X CONNEX BUSHING, 1 3/4 X 1 1/2 X WELDMENT, PIN, LIFT/ DIPPER SPACER, PIN, DIPPER SLOTTED NUT, 1-1/2 NF WELDMENT, CYLINDER PIN, NEW BOOM WELDMENT, CYLINDER PIN SHORT, NEW BOOM CARB 1/2-13 X COVER, LIFT TUBE COVER ADP, HYD ELBOW 6MB-6MJ FLATWASHER, 1/2 PL STD HHCS 1/2 NC 1-3/4 PL HHCS 3/8NC 1-3/4 PL GR HHCS 3/8 X 1-1/2 NC PL GR LOCKNUT TLM 3/8 NC PLC GREASE ZERK 1/ BOLT THD GREASE FITTING 1/4-28 BOLT THD PIN, COTTER 5/16 X 2-1/2 PL PLASTIC TIE, ORANGE & WHITE PLASTIC TIE, ORANGE PLASTIC TIE, BLUE & WHITE PLASTIC TIE, BLUE PLASTIC TIE, RED PLASTIC TIE, RED & WHITE PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG ADP HYD ELBOW 6MJ-6FJX LOCKWASHER, 1/2 HVY, PLATED SPRING NUT 1/ WELDMENT, TELESCOPING, AXTREME WLDMT, 28` A-BOOM DIPPER CYLINDER, 2.5B X 1.5R X 36.0S CAP, 16 FJ HHCS 1 NC 4 1/2 PL NUT TOPLOCK 1 NC PL HHCS 1 NC 2 3/4 PL PLASTIC TIE, YELLOW & WHITE 2011 Alamo Group Inc. Parts Section -77

82 BOOM ASY - 28FT TELESCOPING BOOM (PART 2) 2011 Alamo Group Inc. Parts Section -78

83 BOOM ASY - 28FT TELESCOPING BOOM (PART 2) Continued ASSEMBLY, EXTENSION CYLINDER GUARD, MAVERICK WELDMENT, PIN, TILT CYINDER SLIDE BLOCK, DIPPER SLIDE PUCK, DIPPER SHCS 1/2 NC X 7/ PLATE, LINKAGE WELDMENT, LINKAGE WELDMENT, PIN, LINKAGE RETAINING RING,1.5 SHAFT HYDRAULIC TUBE, # HYDRAULIC TUBE, # CLAMP, TUBE 1-POSTION COVER, LIFT TUBE COVER CYLINDER, 3.5B X 1.5R X 16.0S ASSEMBLY, TILT CYLINDER COVER ADP, HYD 4MJ -4MJ BULKHEAD CAP, HYD 4FJ PLASTIC TIE, YELLOW PLASTIC TIE, GREEN PLASTIC TIE, GREEN & WHITE BOLT, HHCS 3/8 NC 1 PL ADAPTER 16MJ - 16MJ 90 BULKHEAD ADP, HYD, 4MJ-4FJX NUT HEX 1/2 NC HIGH ALLOY, L/W 3/8 YZ 2011 Alamo Group Inc. Parts Section -79

84 COMMON CRATE COMPONENTS - ELECT VALVE 2011 Alamo Group Inc. Parts Section -80

85 COMMON CRATE COMPONENTS - ELECT VALVE Continued MT KIT, JD7130 MID SP FL MV ASY, PUMP COVER KNOB 3/8NC X 1-1/2 STUD COOLER, OIL/AIR W/FAN MOUNT, COOLER, RH MOUNT, COOLER, LH HANGER, FORMED, HOSE 7 D377 1 BOOKLET, DECAL BOOM MOWER WELDMENT,HOSE BRACKET, UM HOSE #12-12FJX-12FJX90-30LG BOLT BAG, AXTREME, COMMON CANISTER, PARTS MANUAL A 1 ASY, MANUALS, AXTREME GEN CA 1 ASY, CANISTER, AXTREME GEN ADP TUBE ELBOW 20MJ-20FJX PLUG 1/2-14 NPT BOOT,CABLE ADP HYD ELBOW 12MB-12MJ DECAL, JOYSTICK CONTROL, AXTR HOSE #8-8FJX - 8FJX90-32LG WLDMT. HOSE GUIDE SPLIT FLANGE KIT 1-1/ MANUAL, AXTREME ASSEMBLY ASY, TANK & ELEC VALVE AX CABLE, MANUAL CANISTER, 24" LG CABLE, PUMP COVER 36" LG DECAL-PROPER ENGINE OPERATING ASY, HARNESS, MACHETE ASY JSTK CONSOLE, SAMURAI WIRE HARNESS, SWIVEL, JS, SAM 2011 Alamo Group Inc. Parts Section -81

86 COMMON CRATE COMPONENTS - MAN VALVE (PART 1) 2011 Alamo Group Inc. Parts Section -82

87 COMMON CRATE COMPONENTS - MAN VALVE (PART 1) Continued COMMON BOX,MAN VALVE,AXTREME WIRE HARNESS, MANUAL, AXTREME ASY, PUMP COVER KNOB 3/8NC X 1-1/2 STUD COOLER, OIL/AIR W/FAN MOUNT, COOLER, RH MOUNT, COOLER, LH HANGER, FORMED, HOSE 8 D377 1 BOOKLET, DECAL BOOM MOWER WELDMENT,HOSE BRACKET, UM CLEVIS, MANUAL VALVE, AXTREME HOSE #12-12FJX-12FJX90-30LG BOLT BAG, AXTREME, COMMON CANISTER, PARTS MANUAL A 1 ASY, MANUALS, AXTREME GEN CA 1 ASY, CANISTER, AXTREME GEN WELDMENT,SWITCH MOUNT SWITCH PUSH-PULL SPDT 10A@12V DECAL-ON-OFF SWITCH CUTTER VLV ADP TUBE ELBOW 20MJ-20FJX FLATWASHER 5/16 PL HHCS 5/16NC 9-1/2 PL LOCKNUT TLM 5/16 NC PLB DECAL, LEVER CONTROL, AXTREME PLUG 1/2-14 NPT HEXB 5/16 X 1 NC GR LOCKNUT TLM 5/16 NC PLB LEVER SHORT SNGL AXIS CONTROL BOOT,CABLE NUT HEX 1/4 NF ADP HYD STGHT 12MB-12MJ ADP HYD ELBOW 12MB-12MJ HOSE #8-8FJX - 8FJX90-32LG WLDMT. HOSE GUIDE SPLIT FLANGE KIT 1-1/ MANUAL, AXTREME ASSEMBLY ASY, TANK & MAN VALVE AX CABLE, MANUAL CANISTER, 24" LG CABLE, PUMP COVER 36" LG DECAL-PROPER ENGINE OPERATING HOSE #12-12FJX-12FJX90-36LG 2011 Alamo Group Inc. Parts Section -83

88 COMMON CRATE COMPONENTS - MAN VALVE (PART 2) 2011 Alamo Group Inc. Parts Section -84

89 COMMON CRATE COMPONENTS - MAN VALVE (PART 2) Continued DECAL, GENUINE OEM PARTS,WHTE DECAL, GENUINE OEM PARTS,CLEAR 43 D726 1 DECAL, FITTING, GREASE 2011 Alamo Group Inc. Parts Section -85

90 COMMON CRATE COMPONENTS 28FT TELESCOPING - ELECT VALVE 2011 Alamo Group Inc. Parts Section -86

91 COMMON CRATE COMPONENTS 28FT TELESCOPING - ELECT VALVE Continued WELDMENT,HOSE BRACKET, UM JOYSTICK, AXTREME HOSE #12-12FJX-12FJX90-30LG BOLT BAG, AXTREME, COMMON CANISTER, PARTS MANUAL A 1 ASSEMBLY AXTREME OPERATORS & CA 1 ASSEMBLY AXTREME CANISTER ADP TUBE ELBOW 20MJ-20FJX 90? PLUG 1/2-14 NPT ASY, TANK, ELECVALVE, AXT ADP HYD ELBOW 12MB-12MJ DECAL, JOYSTICK CONTROL, AXTR HOSE #8-8FJX - 8FJX90-32LG HARNESS, LAYOUT, ELEC, 28` AX ASY, PUMP COVER KNOB 3/8NC X 1-1/2 STUD COOLER, OIL/AIR W/FAN MOUNT, COOLER, RH MOUNT, COOLER, LH HANGER, FORMED, HOSE D377 1 BOOKLET, DECAL BOOM MOWER MANUAL, AXTREME ASSEMBLY WLDMT. HOSE GUIDE SPLIT FLANGE KIT 1-1/ CABLE, MANUAL CANISTER, CABLE, PUMP COVER Alamo Group Inc. Parts Section -87

92 COMMON CRATE COMPONENTS 28FT TELESCOPING - MANUAL VALVE 2011 Alamo Group Inc. Parts Section -88

93 COMMON CRATE COMPONENTS 28FT TELESCOPING - MANUAL VALVE Continued WIRE HARENESS, MANUAL, AXTREME ASY, PUMP COVER KNOB 3/8NC X 1-1/2 STUD COOLER, OIL/AIR W/FAN MOUNT, COOLER, RH MOUNT, COOLER, LH HANGER, FORMED, HOSE D377 1 BOOKLET, DECAL BOOM MOWER WELDMENT,HOSE BRACKET, UM CLEVIS, MANUAL VALVE, AXTREME HOSE #12-12FJX-12FJX90-30LG BOLT BAG, AXTREME, COMMON CANISTER, PARTS MANUAL A 1 ASSEMBLY AXTREME OPERATORS & CA 1 ASSEMBLY AXTREME CANISTER SWITCH PUSH-PULL SPDT 10A@12V DECAL-ON-OFF SWITCH CUTTER VLV LOCKNUT TLM 5/16 NC PLB ASY, TANK, MAN VALVE, AXT PLUG 1/2-14 NPT HEXB 5/16 X 1 NC GR BOOT,CABLE NUT HEX 1/4 NF ADP HYD ELBOW 12MB-12MJ HOSE #8-8FJX - 8FJX90-32LG WLDMT. HOSE GUIDE SPLIT FLANGE KIT 1-1/ MANUAL, AXTREME ASSEMBLY LEVER SHORT SNGL AXIS CONTROL DECAL, MANUAL CONTROLS HANDLES CABLE, MANUAL CANISTER, CABLE, PUMP COVER ADP HYD ELBOW 16MJ -16FJX Alamo Group Inc. Parts Section -89

94 DECALS FT BOOM DECAL, LOGO - (18 FT BOOM ONLY) DECAL, LOGO - (22 FT BOOM ONLY) DECAL, LOGO - (25 FT BOOM ONLY) DECAL, PINCH POINTS ( FT BOOMS) 2011 Alamo Group Inc. Parts Section -90

95 DECALS - 28FT TELESCOPING BOOM DECAL, AXTREME 28T DECAL, PINCH POINT 2011 Alamo Group Inc. Parts Section -91

96 DECALS - 48 IN BUZZBAR - 2 BLADES DECAL -LOGO BUZZBAR DECAL LOGO SQ PLATE S/N PR DECAL, USE/REPAIR GUARDS DECAL, REPLACEMENT PARTS DECAL, TRACTOR OPERATOR SAFETY DECAL, MULTI HAZARD DECAL -WARNING DISCONNECT SOLENOID DECAL, BLADES THROWN OBJECTS DECAL, WARNING, BELT SHIELD DECAL YELLOW REFLECTOR DECAL RED REFLECTOR DECAL -NO HITCHPOST HERE 2011 Alamo Group Inc. Parts Section -92

97 DECALS - 48 IN BUZZBAR - 2 BLADES Continued DECAL -DANGER ROTATING BLADES (BUZZBAR) DECAL -WARNING HEARING PROTECTION REQD DECAL -WARNING -HOSE BURST DECAL, PINCH POINT DECAL, GUARD MISSING 19 D138 1 DECAL, CW BLADE ROTATION 2011 Alamo Group Inc. Parts Section -93

98 DECALS - 48 IN FLAIL head DECAL, INSTRUC, FLAIL OPER DECAL, GREASE FITTING INSIDE DECAL, LOGO (ALAMO BY T.K.) DECAL, LOGO, FLAIL AXE 48" DECAL, ALAMO INDUSTRIAL LOGO 6 D661 1 DECAL, LUBE PIONT, F/AXE HEAD 7 D564 1 DECAL, SAFETY, OPERATOR 8 D622 1 DECAL, DANGER, OPERATION, DOOR 9 D637 1 DECAL, SOLENIOD, DISCONNECT 10 D641 1 DECAL, HAZARD, PINCH POINTS 11 D646 1 DECAL, DANGER, GUARD, MISSING 2011 Alamo Group Inc. Parts Section -94

99 ThIS PAGE INTENTIONAL LEFT BLANK 2011 Alamo Group Inc. Parts Section -95

100 DECALS - 50 & 60 IN ROTARY head DECAL, LOGO (ALAMO BY T.K.) DECAL, ALAMO INDUSTRIAL LOGO DECAL, USE/REPAIR GUARDS DECAL, BLADES THROWN OBJECTS DECAL, REPLACEMENT PARTS DECAL, MULTI HAZARD DECAL, DANGER SAFETY SHIELD DECAL, RED OBLONG REFLECTOR DECAL, YELLOW OBLONG REFLECTOR DECAL, 60 ROTARY DECAL, 50 ROTARY 2011 Alamo Group Inc. Parts Section -96

101 DECALS - 69 IN BUZZBAR - 3 BLADES PLATE S/N PR DECAL, USE/REPAIR GUARDS DECAL, REPLACEMENT PARTS DECAL, TRACTOR OPERATOR SAFETY DECAL, MULTI HAZARD DECAL -WARNING DISCONNECT SOLENOID DECAL, BLADES THROWN OBJECTS DECAL, WARNING, BELT SHIELD DECAL -LOGO BUZZBAR DECAL YELLOW REFLECTOR DECAL RED REFLECTOR DECAL, ALAMO IND. LOGO DECAL -NO HITCHPOST HERE DECAL -DANGER ROTATING BLADES (BUZZBAR) DECAL -WARNING HEARING PROTECTION REQD DECAL -WARNING -HOSE BURST DECAL, PINCH POINT DECAL, GUARD MISSING DECAL, LOGO (ALAMO BY T.K.) 20 D138 1 DECAL, CW BLADE ROTATION 2011 Alamo Group Inc. Parts Section -97

102 DECALS - 90 IN BUZZBAR - 4 BLADES PLATE S/N PR DECAL, USE/REPAIR GUARDS DECAL, REPLACEMENT PARTS DECAL, TRACTOR OPERATOR SAFETY DECAL, MULTI HAZARD DECAL -DANGER ROTATING BLADES (BUZZBAR) DECAL -WARNING DISCONNECT SOLENOID DECAL -WARNING HEARING PROTECTION REQD DECAL, BLADES THROWN OBJECTS DECAL, WARNING, BELT SHIELD 11 D138 1 DECAL, CW BLADE ROTATION DECAL -LOGO BUZZBAR DECAL RED REFLECTOR DECAL YELLOW REFLECTOR DECAL -NO HITCHPOST HERE DECAL, LOGO (ALAMO BY T.K.) DECAL -WARNING -HOSE BURST DECAL, PINCH POINT DECAL, GUARD MISSING 2011 Alamo Group Inc. Parts Section -98

103 DECALS - hyd TANK & PUMP - ELECT VALVE DECAL, VALVE LAYOUT FT DECAL, ALAMO INDUSTRIAL YELLOW DECAL, WARNING HOSE BURST DECAL, WARNING PRESSURIZED TANK DECAL, TEMPERATURE RANGE DECAL, CAUTION - DO NOT WELD 2011 Alamo Group Inc. Parts Section -99

104 DECALS - hyd TANK & PUMP - MAN VALVE DECAL, MAN VALVE LAYOUT, AXT DECAL, ALAMO INDUSTRIAL YELLOW DECAL, WARNING HOSE BURST DECAL, WARNING PRESSURIZED TANK DECAL, TEMPERATURE RANGE DECAL, CAUTION - DO NOT WELD 2011 Alamo Group Inc. Parts Section -100

105 DECALS - UNDER MOUNT COUNTER WEIGhT - CAST DECAL RED REFLECTOR DECAL YELLOW REFLECTOR DECAL, ALAMO LOGO DECAL, LOGO RECT CLEAR Y/W, 2 7/8 X DECAL, SPANISH TRANSLATION DECAL, TRACTOR OPERATOR SAFETY DECAL, MULTI HAZARD DECAL, GRIP TAPE 2011 Alamo Group Inc. Parts Section -101

106 DECALS - UNDER MOUNT COUNTER WEIGhT - WELDED DECAL, TRACTOR OPERATOR SAFETY DECAL, ALAMO LOGO DECAL, SPANISH TRANSLATION DECAL RED REFLECTOR DECAL YELLOW REFLECTOR DECAL, LOGO RECT CLEAR Y/W, 2 7/8 X DECAL, MULTI HAZARD 2011 Alamo Group Inc. Parts Section -102

107 DECALS - VALVE MAN handle OPERATION DECAL, MAN VALVE CABLE OPERATION Alamo Group Inc. Parts Section -103

108 DITChER ASSEMBLY 2011 Alamo Group Inc. Parts Section -104

109 DITChER ASSEMBLY Continued DITCHER ASSEMBLY MACH WLDMT, HITCHPOST, BOOM MOUNT DITCHER SPACER PLATE MOTOR, HYD GEAR 15.5 CUIN/REV BLADE HOUSING ASSY SPINDLE ASSY BLADE HEAD ASSY, ROUGH CUT LOCKWASHER 1/ FLATWASHER,3/4 STD PL LOCKNUT TLM 1/2 NC PLB NUT 3/4 NC LOCKNUT HHCS 1/2 NC 1-3/4 PL HHCS 3/4" NC 3-1/2" PL HHCS 1/2 NC X 2 1/4 PL METAL TACK DECAL WARN. SHEILD&GUARDS DECAL - WARNING - HOSE BURST DECAL, REPLACEMENT PARTS DECAL LOGO SQ DECAL BOOM DITCHER PLATE S/N DTMV DECAL, DITCHER DECAL, MULTI HAZARD PLASTIC TIE, YELLOW PLASTIC TIE, YELLOW & WHITE WLDMT, PIN, HITCH POST, DITCHER BOLT, HHCS 3/8 NC 1 PL PIN, COTTER 5/16 X 2-1/2 PL NUT, SLOTTED 1-3/8 12NF PLB FLATWASHER, 1-3/8 TYPE B PL NARROW ADP HYD STGHT 32FL-20FP ADP HYD ELBOW 20MP-16MJ PLASTIC TIE, RED, 11LG PLASTIC TIE, ORANGE, 11LG 2011 Alamo Group Inc. Parts Section -105

110 DIVERTER VALVE - DOOR & SWIVEL VALVE SOLENOID DIVERTER SOLENOID VALVE ASY (INCLUDES ITEMS 2 & 3) SOLENOID SOLENOID RETAINING KNOB 2011 Alamo Group Inc. Parts Section -106

111 FILTER ASY - PN FILTER ASY, RETURN FILTER FILTER TOP COVER NUT & BOLT KIT, F/ TOP COVER SPRING, FILTER CARTRIDGE VALVE, FILTER BYPASS SEAL KIT GASKET, FILTER ASY TO TANK, FIBER DIAL INDICATOR, RETURN FLOW (NOT INCLUDED IN FILTER ASY) FILTER ELEMENT, REPLACEMENT CARTRIDGE O-RING, TOP COVER SEAL (INCLUDED IN ITEM 5) O-RING, CANNISTER SEAL (INCLUDED IN ITEM 5) 2011 Alamo Group Inc. Parts Section -107

112 hose ROUTING - 18 FT BOOM 2011 Alamo Group Inc. Parts Section -108

113 hose ROUTING - 18 FT BOOM NOTES HOSE, TILT RED (LIFT) HOSE, TILT R/W (LIFT) HOSE, DOOR YELLOW (LIFT) HOSE, DOOR Y/W (LIFT) HOSE, SWIVEL GREEN (LIFT) HOSE, SWIVEL G/W (LIFT) HOSE, TILT RED (DIPPER) HOSE, TILT R/W (DIPPER) HOSE, DOOR YELLOW (DIPPER) HOSE, DOOR Y/W (DIPPER) HOSE, SWIVEL GREEN (DIPPER) HOSE, SWIVEL G/W (DIPPER) HOSE, DIPPER CYL BLUE HOSE, DIPPER CYL B/W HOSE, MOTOR PRESSURE HOSE, MOTOR RETURN HOSE, MOTOR PRESSURE HOSE, MOTOR RETURN CORDURA SLEEVING - 54 LG CORDURA SLEEVE, 2.54 ID, 10 LG SLEEVE 66" CORDURA 2.54 ID 2011 Alamo Group Inc. Parts Section -109

114 hose ROUTING - 22 FT BOOM 2011 Alamo Group Inc. Parts Section -110

115 hose ROUTING - 22 FT BOOM NOTES HOSE, DIPPER BLU HOSE, DIPPER B/W HOSE, TILT RED (LIFT) HOSE, TILT R/W (LIFT) HOSE, DOOR YELLOW (LIFT) HOSE, DOOR Y/W (LIFT) HOSE, SWIVEL GREEN (LIFT) HOSE, SWIVEL G/W (LIFT) HOSE, TILT RED (DIPPER) HOSE, TILT R/W (DIPPER) HOSE, DOOR YELLOW (DIPPER) HOSE, DOOR Y/W (DIPPER) HOSE, SWIVEL GREEN (DIPPER) HOSE, SWIVEL G/W (DIPPER) HOSE, MOTOR PRESSURE HOSE, MOTOR RETURN HOSE, MOTOR PRESSURE HOSE, MOTOR RETURN CORDURA SLEEVE, 3.66 ID, 58 LG CORDURA SLEEVE, 2.54 ID,140LG CORDURA SLEEVE, 1.81 ID, 15 LG 2011 Alamo Group Inc. Parts Section -111

116 hose ROUTING - 25 FT BOOM 2011 Alamo Group Inc. Parts Section -112

117 hose ROUTING - 25 FT BOOM NOTES HOSE, DIPPER BLU HOSE, DIPPER B/W HOSE, TILT RED (LIFT) HOSE, TILT R/W ( LIFT) HOSE, DOOR YLW (LIFT) HOSE, DOOR Y/W (LIFT) HOSE, SWIVEL GRN (LIFT) HOSE, SWIVEL G/W (LIFT) HOSE, TILT RED (DIPPER) HOSE, TILT R/W (DIPPER) HOSE, DOOR YLW (DIPPER) HOSE, DOOR Y/W (DIPPER) HOSE, SWIVEL GRN (DIPPER) HOSE, SWIVEL G/W (DIPPER) HOSE, MOTOR PRESSURE HOSE, MOTOR RETURN HOSE, MOTOR PRESSURE HOSE, MOTOR RETURN CORDURA SLEEVE, 3.66ID, 58LG CORDURA SLEEVE, 1.81 ID 15 LG CORDURA SLEEVE, 2.54ID,156LG 2011 Alamo Group Inc. Parts Section -113

118 hose ROUTING - 28FT TELESCOPING BOOM 2011 Alamo Group Inc. Parts Section -114

119 hose ROUTING - 28FT TELESCOPING BOOM (NOTES) HOSE, DIPPER CYL (BLUE) HOSE, DIPPER CYL (BLUE/WHITE) HOSE, TILT (RED) HOSE, TILT (RED/WHITE) HOSE, DOOR (YELLOW) HOSE, DOOR (YELLOW/WHITE) HOSE, SWIVEL (GREEN) HOSE, SWIVEL (GREEN/WHITE) HOSE, TILT (RED) HOSE, TILT (RED/WHITE) HOSE, DOOR (YELLOW) HOSE, DOOR (YELLOW/WHITE) HOSE, SWIVEL (GREEN) HOSE, SWIVEL (GREEN/WHITE) HOSE, MOTOR PRESSURE (RED) HOSE, MOTOR RETURN (ORANGE) HOSE, EXTENSION (YELLOW) HOSE, EXTENSION (YELLOW/WHITE) CORDURA SLEEVING 3.25 ID 156" LG CORDURA SLEEVING 2.54 ID 156" LG CORDURA SLEEVING 1.81 ID 20" LG CORDURA SLEEVING 1.81 ID 32" LG TIE, PLASTIC 2011 Alamo Group Inc. Parts Section -115

120 hose ROUTING - SWING CYL (18-22 FT BOOM) A HOSE #6-6FJX-6FJX-28LG B HOSE #6-6FJX-6FJX-28LG C HOSE #6-6FJX-6MJ-22LG C HOSE #6-6FJX-6MJ-16LG F LINE,GREASE,MANIFOLD,SHORT G LINE,GREASE,MANIFOLD,LONG H LINE,GREASE,MANIFOLD,MED J LINE,GREASE,MANIFOLD,LONG 2011 Alamo Group Inc. Parts Section -116

121 hyd CYL ASY - DIPPER (18 FT BOOM) DIPPER CYLINDER ASY CYLINDER HEAD ADAPTER, ELBOW PLASTIC TIE - W/ BLUE TIE PLASTIC TIE - W/ BLUE / WHITE TIE BUSHING 6 5JRC LOCKNUT PISTON ROD WLDMT CYLINDER HEAD TUBE / BARREL WLDMT SEAL KIT 2011 Alamo Group Inc. Parts Section -117

122 hyd CYL ASY - DIPPER (22 FT BOOM) HYD CYL ASY, 4" BORE X 21.5" STROKE (22 & 25 FT BOOM) BARREL WLDMT ROD WLDMT BUSHING, ROD END 1-1/2" LG BUSHING, BARREL END 2" LG SEAL KIT 2011 Alamo Group Inc. Parts Section -118

123 hyd CYL ASY - EXTENSION (28FT TELESCOPING BOOM) CYLINDER, 2.5B X 1.5R X 36.0S BARREL ASSEMBLY, ROD ASSEMBLY SEAL KIT 2011 Alamo Group Inc. Parts Section -119

124 hyd CYL ASY - head SWIVEL HYD CYL ASY, HEAD SWIVEL (OPTIONAL) WEAR RING, (SEE SEAL KIT) BACK-UP RING, (SEE SEAL KIT) O-RING, (SEE SEAL KIT) O-RING, (SEE SEAL KIT) O-RING, (SEE SEAL KIT) BACK-UP RING, (SEE SEAL KIT) WEAR RING, (SEE SEAL KIT) LOADED U-CUP, (SEE SEAL KIT) ROD WIPER, (SEE SEAL KIT) LOCKNUT, (NON-SALEABLE) PISTON, (NON-SALEABLE) PISTON WASHER, (NON-SALEABLE) BARREL WLDMT ROD WLDMT INTERNAL HEAD, (NON-SALEABLE) SEAL KIT (ITEMS 1 THRU 9) 2011 Alamo Group Inc. Parts Section -120

125 hyd CYL ASY - LIFT (18-22 FT BOOM) CYLINDER ASY, 4" BORE X 24.63" STROKE BARREL WLDMT ROD WLDMT BUSHING, ROD END 1-1/2" LG BUSHING, BARREL END 2" LG SEAL KIT 2011 Alamo Group Inc. Parts Section -121

126 hyd CYL ASY - SWING W/ SPhERICAL ROD END HYD CYL ASY, SWING CYL (W/ SPHERICAL ROD END) BARREL WELDMENT ROD ASY (W/ SPHERICAL ROD END) GREASE FITTING SEAL KIT 2011 Alamo Group Inc. Parts Section -122

127 hyd CYL ASY - SWING W/ TUBE ROD END HYD CYL ASY, SWING CYL (W/ TUBE ROD END) BARREL ASY ROD ASY (W/ TUBE ROD END) GREASE FITTING 1/4-28 BOLT THD SEAL KIT 2011 Alamo Group Inc. Parts Section -123

128 hyd CYL ASY - TILT (18-22 FT BOOM) CYLINDER, 3.5B X 1.75R X16S BARREL WLDMT ROD WLDMT BUSHING, ROD END 1-1/2" LG SEAL KIT 2011 Alamo Group Inc. Parts Section -124

129 hyd CYL ASY - TILT (28FT TELESCOPING BOOM) CYLINDER, 3.5B X 1.75R X16S BARREL WLD`MT ROD WLD`MT BUSHING ROD END 1-1/2" LG SEAL KIT 2011 Alamo Group Inc. Parts Section -125

130 hyd OIL COOLER & FAN ASY HYD OIL COOLER & ELECTRIC FAN ASY HEAT EXCHANGE CORE HEAT EXCHANGE FAN 2011 Alamo Group Inc. Parts Section -126

131 ThIS PAGE INTENTIONAL LEFT BLANK 2011 Alamo Group Inc. Parts Section -127

132 hyd SChEMATIC - SOLID MNT head (OPT) 28FT TELESCOPING BOOM 2011 Alamo Group Inc. Parts Section -128

133 hyd SChEMATIC - SWIVEL MNT head (OPT) 28FT TELESCOPING BOOM 2011 Alamo Group Inc. Parts Section -129

134 hyd SChEMATIC - SOLID MNT head (STD) FT BOOM 2011 Alamo Group Inc. Parts Section -130

135 hyd SChEMATIC - SWIVEL MNT head (OPT) FT BOOM 2011 Alamo Group Inc. Parts Section -131