PARTS MANUAL. ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas SN to Current - Remote Controlled Mower

Transcription

1 SN to Current - Remote Controlled Mower Rev PARTS MANUAL Part No. TR477927P ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas An Operator's Manual was shipped with the equipment in the Manual Canister. This Operator's Manual is an integral part of the safe operation of this machine and must be maintained with the unit at all times. READ, UNDERSTAND, and FOLLOW the Safety and Operation Instructions contained in this manual before operating the equipment. If the Operator's Manual is not with the equipment, contact your dealer or Alamo Industrial ( ) to obtain a Free copy before operating the equipment Alamo Group, Inc.

2

3 BOLT TORQUE Mounting procedures for mowers will require a significant amount of bolt nut and washer installation. Frame and structure mounting bolts should be installed using Red Loctite, and torqued to the dry values listed in the torque chart based on the bolt size and hardness. Other structures such as pump mounting bolts should be installed with Blue Loctite and torqued to the dry values indicated in the chart. Bolt tightness should be completed with and checked with a suitable torque wrench. Torque checks should be completed throughout the life of the mower in accordance with the maintenance chart provided in this manual. Loose bolts on a frame or in a casting may be a result of: Vibration from the mower due to imbalance of the mower blades Pulled threads due to over tightening Distortion of the hole due to under tightening during installation Bolts broken or sheared in the mounting structure or tractor may be the result of: Improper alignment of the Mounting Plate or Structure such that it is not sitting flat on the mating surface Distortion of the bolt due to over-tightening Under tightening of the bolts Check the bolt torque during installation and prior to delivery with a suitable torque wrench.

4 TO THE OWNER/OPERATOR/DEALER All implements with moving parts are potentially hazardous. There is no substitute for a cautious, safe-minded operator who recognizes the potential hazards and follows reasonable safety practices. The manufacturer has designed this implement to be used with all its safety equipment properly attached to minimize the chance of accidents. BEFORE YOU START!! Read the safety messages on the implement and shown in your manual. Observe the rules of safety and common sense! WARRANTY INFORMATION: Read and understand the complete Warranty Statement found in this Manual. Fill out the Warranty Registration Form in full and return it within 30 Days. Make certain the Serial Number of the Machine is recorded on the Warranty Card and on the Warranty Form that you retain. The use of "will-fit" parts will void your warranty and can cause catastrophic failure with possible injury or death.

5 CHANGE PAGES Date of Change Page Number (EXAMPLE ONLY: ECN##### - chg pages 17, 23, 137) document release date chg pg chg pg chg pgs chg pg chg pgs chg pg chg pgs 31,45, chg pg chg pg59 Change Pages - 5

6 CHANGE PAGES The following is a listing of pages that have been changed since the latest publication date for the overall document. Change Pages - 6

7 PARTS ORDERING GUIDE The following instructions are offered to help eliminate needless delay and error in processing purchase orders for the equipment in this section. 1. The Parts Section is prepared in logical sequence and grouping of parts that belong to the basic machine featured in this manual. Part Numbers and Descriptions are given to help locate the parts and quantities required. 2. The Purchase Order must include the name and address of the person or organization ordering the parts, who should be charged, and if possible, the serial number of the machine for which the parts are ordered. 3. The Purchase Order must clearly list the quantity of each part, the complete and correct part number (be sure to include all periods), and the basic name of the part. 4. The Manufacturer reserves the right to substitute parts where applicable. 5. Some parts are unlisted items which are special production items not normally stocked and are subject to special handling. Request a quotation for such parts before sending a Purchase Order. 6. The Manufacturer reserves the right to change prices without prior notice. Note: Please refer to The Safety Section in the front of this Manual for the proper part number when ordering replacement safety decals. For maximum safety and to guarantee optimum product reliability, always use genuine Alamo Industrial Parts. The use of inferior replacement parts may cause premature or catastrophic failure which could result in serious injury or death. Direct any questions regarding parts to: ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas Alamo Group Inc. Parts Section 2

8 PART NAME INDEX CHASSIS... 4 UPPER AND LOWER MOUNTED ROLLER... 6 TENSIONER KIT... 8 RUBBER TRACK FRONT TOOLBAR ENGINE COVER ASSY COMPLETE RADIATOR COVER MACHINE COVER ASSEMBLY ROLL BAR DIESEL ENGINE PART DIESEL ENGINE PART DIESEL ENGINE COMPONENTS PUMP ASSEMBLY ACTUATOR REVERSIBLE FAN SYSTEM SN REVERSIBLE FAN SYSTEM SN CURRENT DIESEL FUEL CIRCUIT OIL TANK ELECTRICAL COMPONENTS PART ELECTRICAL COMPONENTS PART ELECTRICAL WIRING REMOTE CONTROL INTAKE AND DRAIN PUMPS HYDRAULIC LINE RIGHT AND LEFT HYDRAULIC LINE - LIFT CYLINDERS HYDRAULIC LINE - EQUIPMENT HOSES CUTTING HEAD, ROLL SUPPORT AND ROTOR SUPPORT (PART 1) CUTTING HEAD, ROLL SUPPORT AND ROTOR SUPPORT (PART 2) POWER TRANSMISSION ROTOR AND CUTTING TOOLS CUTTING HEAD HYDRAULIC LINE MISCELLANEOUS PARTS Alamo Group Inc. Parts Section -3

9 CHASSIS 1 TR SPROCKET, REAR DRIVE 2 TR SET, TRACK, RUBBER (QTY 2) 3 TR SCREW, M12X25 GR8.8 4 TR WASHER, KNURLED, M12 5 TR MOTOR, RH TRACK DRIVE 6 TR PLATE, GUARD, MOTOR 7 TR FLCS M6-1.0 X 16MM PL8.8 8 TR PLATE, TENSIONER COVER 9 TR GUARD, MANUAL TENSIONER 10 TR MOTOR, LH TRACK DRIVE 11 TR FLCS M X 20MM PL TR BLOCK, TRACK KEEPER 13 TR SEAL KIT, TRACK MOTOR 14 TR UNDERCARRIAGE 15 TR BUSHING, FRONT SPROCKET 16 TR SEAL, FRONT SPROCKET 17 TR KEEPER, BEARING 18 TR SPROCKET, FRONT 19 TR FRONT WHEEL FORK 2016 Alamo Group Inc. Parts Section -4

10 CHASSIS Continued TR FLCS M X 16MM PL TR ROLL PIN 22 TR PIN, FRONT SPROCKET 23 TR BEARING, FRONT SPROCKET 2016 Alamo Group Inc. Parts Section -5

11 UPPER AND LOWER MOUNTED ROLLER 1 TR ASY UPPER TRACK ROLLER 2 TR NUT TOPLOCK M PL 3 TR FLATWASHER M14X44X3MM PL 4 TR WASHER, TOP ROLLER 5 TR WASHER, ROLLER 6 TR SEAL, ROLLER 7 TR SNAP RING, 25MM 8 TR BEARING, INNER, TRACK ROLLER 9 TR AXLE, TRACK ROLLER 10 TR WHEEL, TRACK ROLLER 11 TR ASY, TRACK ROLLER 12 TR NUT TOPLOCK M PL 13 TR FLATWASHER M14X44X3MM PL 14 TR WASHER, ROLLER 15 TR SEAL, ROLLER 2016 Alamo Group Inc. Parts Section -6

12 UPPER AND LOWER MOUNTED ROLLER Continued TR SNAP RING, 25MM 17 TR BEARING, INNER, TRACK ROLLER 18 TR AXLE, TRACK ROLLER 19 TR WHEEL, TRACK ROLLER 2016 Alamo Group Inc. Parts Section -7

13 TENSIONER KIT 10 TR KIT, HYDRAULIC TENSION 2016 Alamo Group Inc. Parts Section -8

14 TENSIONER KIT Continued TR TENSIONER ROD 12 TR TENSIONER CYLINDER 13 TR TENSIONER CAP 14 TR BUTTON HEAD FITTING 15 TR VALVE, TRACK TENSION 16 TR WASHER, TRACK PRESSURE 17 TR O-RING 18 TR CYLINDER, TRACK VALVE 20 TR SPRING, TRACK VALVE 21 TR NUT, PERFORATED 22 TR WASHER, FRONT CAP 23 TR BUSHING, FRONT CAP 24 TR SET SCREW M6X DIN TR LOCKNUT M20X Alamo Group Inc. Parts Section -9

15 RUBBER TRACK 1 TR TRACK, RUBBER, 11 IN WIDE 2 TR TRACK, FOR CLEATS/SPIKES 3 TR STEEL CLEAT 4 TR SCREW, STEEL CLEAT 5 TR FULL SET, SPIKE/PAD 6 TR BLOCK, RUBBER, SPIKE 7 TR SCREW, STEEL SPIKE 8 TR STEEL SPIKE 2016 Alamo Group Inc. Parts Section -10

16 FRONT TOOLBAR 1 TR SHCS M X 80MM PL8.8 2 TR FLATWASHER M8 PL 3 TR DOUBLE HOSE COLLAR 20MM 4 TR LOCKNUT M20X1.5 5 TR BRACKET, RH LIFT CYLINDER 6 TR FLATWASHER M6 PL 7 TR SHCS M6-1.0 X 60MM PL8.8 8 TR FLATWASHER M20X37X4MM PL 9 TR SPRING, HEAD LIFT 10 TR SET SCREW, M8X8 11 TR PIN, LIFT CYLINDER 12 TR RETAINER, LIFT SPRING 2016 Alamo Group Inc. Parts Section -11

17 FRONT TOOLBAR Continued TR CHAIN, TOOLBAR LIFT 14 TR FLATWASHER, LIFT CYLINDER 15 TR HHCS M X 120MM PL TR GREASE FITTING 45DEG M6X1 17 TR FLATWASHER M14X28X4MM PL 18 TR NUT, JAM 13/ TR NUT TOPLOCK NYLON M6-1.0 PL 20 TR TOOLBAR, FRONT 21 TR BULKHEAD, RH TOOLBAR 22 TR ADP HYD 13/16-1/2 BLKHD 23 TR SEAL, HYD FITTING, 1/2 24 TR ADP HYD QD 1/2F VVS 25 TR PLUG HYD QD 1/2M VV/VVS 26 TR ADP HYD QD 1/2M VV 27 TR CAP HYD QD 1/2F VV/VVS 28 TR CAP HYD QD 3/8F VV/VVS 29 TR PLUG HYD QD 3/8M VV/VVS 30 TR ADP HYD QD 3/8F VV 31 TR ADP HYD QD 3/8M VV 32 TR SEAL, HYD FITTING, 3/8 33 TR ADP HYD 11/16-3/8 BLKHD 34 TR FLCS M6-1.0 X 16MM PL TR BULKHEAD, LH TOOLBAR 36 TR SHCS M6-1.0 X 30MM PL TR NUT, JAM 11/ TR COTTER PIN 39 TR BRACKET, LH LIFT CYLINDER 40 TR DOUBLE HOSE COLLAR 12MM 2016 Alamo Group Inc. Parts Section -12

18 ENGINE COVER ASSY 1 TR MOUNT, HINGE, REAR DOOR 2 TR MOUNT, LATCH, REAR DOOR 3 TR STUD M6-1.0 X 25MM 4 TR NUT TOPLOCK M6-1.0 PL DIN980 5 TR FLATWASHER M6 PL 6 TR BRACKET, SIDE GUARD 7 TR FLCS M6-1.0 X 10MM PL8.8 8 TR GUARD, ENGINE, RH 9 TR FLCS M X 20 PL TR PLATE, SKID, REAR 11 TR FLATWASHER M8 PL 12 TR NUT TOP LOCK M PL 13 TR GUARD, ENGINE, LH 14 TR FLCS M X 16MM PL TR BRACKET, ENGINE GUARD 2016 Alamo Group Inc. Parts Section -13

19 ENGINE COVER ASSY Continued TR NUT TOPLOCK NYLON M4-0.7 PL 17 TR FLATWASHER M4 PL 18 TR HINGE, REAR DOOR 19 TR FSCS M6-1.0 X 25MM PL TR SHCS M4-0.7 X 55MM PL TR FLCS M6-1.0 X 16MM PL TR SUPPORT, RADIATOR TOP 23 TR KIT, AIR FILTER GUARD (OPTIONAL) 24 TR ISO BLOCK, AF GUARD 25 TR FLATWASHER M8 PL 26 TR HHCS M X 12MM PL TR LOCKWASHER SPRING M8 PL 28 TR ENGINE GUARD 2016 Alamo Group Inc. Parts Section -14

20 COMPLETE RADIATOR COVER 1 TR ASY, REAR DOOR, COMPLETE 2 TR NUT TOPLOCK NYLON M5-0.8 PL 3 TR FLATWASHER M5 PL 4 TR MESH, REAR DOOR BACK 5 TR MESH, REAR DOOR SIDE 6 TR SHCS M4-0.7 X 40MM PL8.8 7 TR FLATWASHER M4 PL 8 TR NUT TOPLOCK NYLON M4-0.7 PL 9 TR LATCH, RUBBER, HOOD 10 TR DOOR, REAR 11 TR MESH, REAR DOOR TOP 2016 Alamo Group Inc. Parts Section -15

21 MACHINE COVER ASSEMBLY 1 TR MOUNT, RUBBER ISO, M6 LG 2 TR NUT TOPLOCK NYLON M6-1.0 PL 3 TR FLATWASHER M6X18MM PL 4 TR FLCS M X 16MM PL8.8 5 TR GASKET, FUSE BOX 6 TR COVER, FUSE BOX 7 TR WASHER RUBBER M6X18X2MM 8 TR PLATE, VALVE COVER 9 TR PLATE, TANK CAVITY 10 TR PLATE, SKID, OIL PAN 11 TR HHCS M X 12MM PL TR FLATWASHER M6X18MM PL 13 TR SHCS M4-0.7 X 40MM PL TR FLCS M6-1.0 X 16MM PL TR COVER, BATTERY 16 TR NUT TOPLOCK NYLON M4-0.7 PL 17 TR BSCS M6-1.0 X 18MM PL TR LATCH, RUBBER, HOOD 19 TR FLATWASHER M4 PL 20 TR BRACKET, ELECTRIC BOX 2016 Alamo Group Inc. Parts Section -16

22 MACHINE COVER ASSEMBLY Continued TR FLATWASHER M8 PL 22 TR LOCKWASHER SPRING M8 PL 23 TR BRACKET, RADIO RECEIVER 24 TR KIT, HOOD W/HARDWARE 25 TR HOOD 26 TR BUSHING RUBBER M8 27 TR STUD M X 35MM PL TR NUT TOP LOCK M PL 29 TR NUT TOPLOCK M6-1.0 PL DIN TR FLATWASHER M6 PL 31 TR FLATWASHER M8X24 PL 32 TR STOP, HOOD 2016 Alamo Group Inc. Parts Section -17

23 ROLL BAR 1 TR KIT, ROLL BAR 2 TR SUPPORT, ROLL-BAR 3 TR ROLL-BAR 4 TR HHCS M X 40MM PL10.9 DIN933 5 TR FLATWASHER M16 PL 6 TR LOCKWASHER SPRING M16 PL 2016 Alamo Group Inc. Parts Section -18

24 DIESEL ENGINE PART 1 1 TR ENGINE, ISUZU DIESEL 2 TR BELT, ENGINE 3 TR SUPPORT, AIR FILTER 4 TR FLCS M X 16MM PL8.8 5 TR NUT TOP LOCK M PL 6 TR FLCS M X 20 PL8.8 7 TR MOUNT, RADIATOR, TOP 8 TR HHCS M X 30MM PL8.8 9 TR FLATWASHER M8X24 PL 10 TR RUBBER ISO MNT, RADIATOR TOP 11 TR BUSHING, TOP RAD ISO MOUNT 2016 Alamo Group Inc. Parts Section -19

25 DIESEL ENGINE PART 1 Continued TR FLATWASHER M12X32MM PL 13 TR HHCS M X 40MM PL TR BRACKET, RADIATOR SUPPORT 15 TR NUT TOPLOCK M PL 16 TR WASHER, M11 LARGE 17 TR STUD M X 80MM PL TR ISO MOUNT, RADIATOR 19 TR BUSHING, RAD ISO MOUNT 20 TR ASY, RADIATOR 21 TR LOCKNUT 22 TR HOSE CLAMP 36-39MM 23 TR HOSE, WATER, RADIATOR, LEFT 24 TR HOSE, WATER, RADIATOR, RIGHT 25 TR GUARD, FAN, LEFT SIDE 26 TR FLCS M6-1.0 X 12MM PL TR GUARD, RADIATOR 28 TR GUARD, FAN, TOP 29 TR GUARD, FAN, RIGHT SIDE 30 TR SHCS M6-1.0 X 16MM PL TR LOCKWASHER SPRING M6 PL 32 TR FLATWASHER M6 PL 33 TR BRACKET, ANTENNA 34 TR FLATWASHER M8 PL 35 TR LOCKWASHER SPRING M8 PL 36 TR HHCS M X 35MM PL TR BRACKET, BEACON 38 TR HOSE CLAMP 40-60MM 39 TR ASY, AIR FILTER CANISTER 40 TR BRACKET, AIR FILT CONTAINER 2016 Alamo Group Inc. Parts Section -20

26 DIESEL ENGINE PART 2 41 TR CONTIANER, AIR FILTER 42 TR COVER, AIR INTAKE 43 TR FILTER, SECONDARY AIR 44 TR FILTER, PRIMARY AIR 45 TR CAP, AIR FILTER 46 TR VALVE, DUST 47 TR SENSOR, FILTER 48 TR GUARD, EXHAUST/ALTERNATOR 49 TR FLCS M6-1.0 X 10MM PL TR SUPPORT, MUFFLER 51 TR MANIFOLD, MUFFLER 2016 Alamo Group Inc. Parts Section -21

27 DIESEL ENGINE PART 2 Continued TR NUT HEX M PL 53 TR CLAMP, EXHAUST PIPE 54 TR MUFFLER 55 TR HOSE, AIR INTAKE 56 TR FLCS M X 12MM PL Alamo Group Inc. Parts Section -22

28 DIESEL ENGINE COMPONENTS 1 TR ENGINE OIL SENSOR 2 TR ENGINE STOP SOLENOID 3 TR ALTERNATOR 4 TR STARTER MOTOR 5 TR STARTER SOLENOID 6 TR DIPSTICK, ENGINE OIL 7 TR HHCS M X 90MM PL TR FLATWASHER M12 PL 9 TR WASHER, KNURLED, M10 10 TR SHCS M X 35MM PL TR FLATWASHER, ISO MOUNT 12 TR SCREW, ISO BLOCK 13 TR ISO MOUNT, ENGINE FRONT AND REAR 14 TR FLATWASHER M10 PL 15 TR LOCKWASHER SPRING M10 PL 2016 Alamo Group Inc. Parts Section -23

29 DIESEL ENGINE COMPONENTS Continued TR NUT TOPLOCK M PL 17 TR SPACER, ISO MOUNT 18 TR NUT TOPLOCK M PL 19 TR BRACKET, ENGINE, LH 20 TR BRACKET, ENGINE, RH 21 TR SHCS M X 30MM PL TR FILTER, ENGINE OIL 24 TR FILTER, PRIMARY FUEL 25 TR SENSOR, WATER 26 TR WASHER, COPPER, 16MM 27 TR PICKUP TUBE, ENGINE 28 TR OIL PAN 29 TR FLCS M X 16MM PL TR FLCS 31 TR WASHER, COPPER, 22MM 32 TR DRAIN PLUG, ENGINE 33 TR WASHER, ALUMINUM 34 TR WATER PUMP 35 TR FLANGE NUT 36 TR FILLER CAP, ENGINE OIL 2016 Alamo Group Inc. Parts Section -24

30 PUMP ASSEMBLY 1 TR ADAPTER, FLYWHEEL-PUMP 2 TR WASHER, KNURLED, M10 3 TR HHCS M X 25MM PL TR FLYWHEEL 5 TR FLCS M X 30MM PL8.8 6 TR PUMP MANIFOLD 7 TR FLYWHEEL-PUMP COUPLER 8 TR HHCS M X 55MM PL8.8 9 TR BRACKET, PUMP 10 TR WASHER, NORD LOCK M14 11 TR HHCS M X 40MM PL TR ADP HYD FTG 1/2-13/16 13 TR SHCS M X 50MM PL TR FLATWASHER M10 PL 15 TR PUMP, GEAR 16 TR ASY, PUMP, PISTON 2016 Alamo Group Inc. Parts Section -25

31 PUMP ASSEMBLY Continued TR PUMP, HEAD 18 TR PUMP, TANDEM, TRACK W/VALVE 19 TR SCREW M10X30 GR TR WASHER, KNURLED, M10 21 TR WASHER, PUMP 22 TR O-RING, PUMP 23 TR SEAL, OIL, VITON, GEAR PUMP 24 TR O-RING, OIL, GEAR PUMP 25 TR KEEPER, BEARING 2016 Alamo Group Inc. Parts Section -26

32 ACTUATOR 2016 Alamo Group Inc. Parts Section -27

33 ACTUATOR Continued... 1 TR BRACKET, ACTUATOR 2 TR FSCS M X 20MM PL TR FLCS M X 20MM PL8.8 4 TR ACTUATOR, THROTTLE 5 TR NUT TOP LOCK M PL 6 TR FLATWASHER M8 PL 7 TR HHCS M X 30MM PL8.8 8 TR FLCS M6-1.0 X 16MM PL8.8 9 TR BRACKET, THROTTLE 10 TR LINKAGE, THROTTLE 11 TR SPRING, THROTTLE 12 TR LINKAGE, THROTTLE SPRING 13 TR NUT TOPLOCK M6-1.0 PL 2016 Alamo Group Inc. Parts Section -28

34 REVERSIBLE FAN SYSTEM SN TR ASY, COMPRESSOR, FAN REVERSE 2 TR SHCS M6-1.0 X 70MM 3 TR FLATWASHER M6 PL 4 TR CLAMP, COMPRESSOR 5 TR NUT, FLANGE, M6 6 TR COMPRESSOR, FAN REVERSE 7 TR HOSE CLAMP 9-11MM 8 TR WASHER, KNURLED, M6 10 TR FLANGE, FAN 11 TR SHCS M6-1.0 X 20MM PL TR FLCS M6-1.0 X 20MM PL TR FAN, REVERSIBLE 14 TR SCREW, FAN 15 TR KIT, SPRING, FAN 16 TR BLADE PAIR, FAN 17 TR KIT, PIPE, FAN 18 TR AIR FILTER LINE KIT 19 TR SLEEVING, AIR LINE 2016 Alamo Group Inc. Parts Section -29

35 REVERSIBLE FAN SYSTEM SN Continued TR CLAMP, AIR LINE 21 TR ELBOW 22 TR CONNECTOR, AIR HOSE 23 TR HOSE CLAMP 13-15MM 24 TR HOSE, INLET, AIR COMPRESSOR 25 TR COVER, COMPRESSOR, REAR 26 TR COVER, COMPRESSOR, FRONT 27 TR FLCS M6-1.0 X 16MM PL Alamo Group Inc. Parts Section -30

36 REVERSIBLE FAN SYSTEM SN CURRENT 1 TR REVERSIBLE FAN 2 TR SHCS M6-1.0 X 20MM PL8.8 3 TR BLADE, REVERSIBLE FAN 4 TR HYD ADAPTER 5 TR HOSE, REVERSIBLE FAN 2016 Alamo Group Inc. Parts Section -31

37 DIESEL FUEL CIRCUIT 1 TR FILTER, FINAL FUEL 2 TR CANISTER, FUEL FILTER 3 TR ELEMENT, PRIMARY FUEL FILTER 4 TR HHCS M X 70MM PL8.8 5 TR FLATWASHER M8 PL 6 TR HOSE CLAMP 13-15MM 7 TR TANK, FUEL 8 TR FUEL PUMP 9 TR FLCS M6-1.0 X 20MM PL TR FLATWASHER M6 PL 11 TR NUT TOPLOCK M6-1.0 PL 12 TR SHCS M4-0.7 X 20MM PL TR LOCKWASHER SPRING M4 PL 14 TR FLATWASHER M4 PL 15 TR SENSOR, FUEL LEVEL 16 TR CAP, FUEL, KEYED 17 TR FLCS M X 25 PL Alamo Group Inc. Parts Section -32

38 DIESEL FUEL CIRCUIT Continued TR PLUG, TANK 19 TR HOSE, FUEL, 47IN 20 TR HOSE, FUEL, 34IN 21 TR HOSE, FUEL, 10IN 22 TR HOSE, FUEL, 53IN 2016 Alamo Group Inc. Parts Section -33

39 OIL TANK 1 TR TANK, HYDRAULIC 2 TR FLCS M X 25 PL8.8 3 TR PLUG, TANK 4 TR SENSOR, HYD OIL LEVEL 5 TR CAP, HYD OIL 6 TR ADAPTER, OIL SENSOR 7 TR SENSOR, HYD VAC PRESS 8 TR HYD OIL FILTER HOUSING 2016 Alamo Group Inc. Parts Section -34

40 OIL TANK Continued TR FILTER, HYD ELEMENT 11 TR NUT 12 TR WASHER, O-RING 13 TR O-RING 14 TR STOPPER, O-RING 15 TR SEAL, HYD FITTING, 1/ Alamo Group Inc. Parts Section -35

41 ELECTRICAL COMPONENTS PART 1 1 TR BEACON, AMBER LED 2 TR CONNECTOR, BEACON 3 TR LOCKWASHER SPRING M5 4 TR LOCKWASHER SPRING M6 PL 5 TR FLATWASHER M6 PL 6 TR SHCS M5 X 16 7 TR SHCS M6-1.0 X 75MM PL8.8 8 TR BATTERY, TRAXXRF 9 TR SWITCH, EMERGENCY STOP 10 TR V OUTLET 11 TR CONNECTOR, WIRED REMOTE 12 TR BSCS M4-0.7 X 12MM PL TR FUSE PANEL ASSEMBLY 13A TR RELAY W/DIODE 13B TR RELAY 13C TR FUSE MAXI 40A 14 TR SWITCH, IGNITION 15 TR TIMER, GLOW PLUGS (OPTIONAL) 2016 Alamo Group Inc. Parts Section -36

42 ELECTRICAL COMPONENTS PART 1 Continued TR TIMER, INJECTION PUMP 17 TR ASY, FUSE/RELAY BOX 18 TR FLCS M6-1.0 X 16MM PL TR FLATWASHER M6 PL 20 TR NUT TOPLOCK M6-1.0 PL DIN TR KIT, FULL ELECTRICAL 22 TR CAP, WIRED REMOTE CONN. 23 TR FLATWASHER M4 PL 24 TR NUT TOPLOCK NYLON M4-0.7 PL 25 TR HORN 26 TR FLCS M6-1.0 X 16MM PL TR FLATWASHER M5 PL 28 TR NUT TOPLOCK NYLON M6-1.0 PL 29 TR FLATWASHER M6X18MM PL 30 TR SHUNT BOX 31 TR PROTECTION, BOX SIDE 32 TR CONTROL UNIT 33 TR DISPLAY, INDICATOR 34 TR BOX, FUSE/RELAY 35 TR RECEIVER UNIT 36 TR HARNESS, CONTROL 37 TR BRACKET, CAN RECEIVER 2016 Alamo Group Inc. Parts Section -37

43 ELECTRICAL COMPONENTS PART 2 38 TR RUBBER CLIP 39 TR SPACER, CAN RECEIVER MT 40 TR HARNESS, CHASSIS 41 TR HARNESS, BATTERY POS 42 TR HARNESS, BATTERY NEG 43 TR HARNESS, STARTER/ALTERNATOR 44 TR SWITCH 45 TR FLATWASHER M6 46 TR ISO MOUNT, RECEIVER 47 TR SHCS M4 X TR HEX NUT M4 49 TR BRACKET, DISPLAY 50 TR HEX NUT M4 51 TR MAT, BOTTOM, FUSE BOX 52 TR PROTECTION, BOX TOP 53 TR HARNESS, REMOTE CONTROL 2016 Alamo Group Inc. Parts Section -38

44 ELECTRICAL WIRING 1 TR CONNECTOR 2 TR CONNECTOR 3 TR CONNECTOR 4 TR CONNECTOR 5 TR CONNECTOR 6 TR CONNECTOR 7 TR CONNECTOR 8 TR CONNECTOR, EV 9 TR CONNECTOR 10 TR CONNECTOR 11 TR BOOT, RUBBER 12 TR CONNECTOR 13 TR HARNESS, CHASSIS 14 TR CONNECTOR 15 TR CONNECTOR 16 TR CONNECTOR 17 TR END, RUBBER 18 TR SLIDE, CONNECTOR 2016 Alamo Group Inc. Parts Section -39

45 ELECTRICAL WIRING Continued TR HARNESS, CONTROL 20 TR HARNESS, BATTERY POS 21 TR HARNESS, BATTERY NEG 22 TR HARNESS, STARTER/ALTERNATOR 23 TR SWITCH 24 TR KIT, FULL ELECTRICAL 25 TR CONNECTOR 26 TR CONNECTOR 27 TR HARNESS, REMOTE CONTROL 28 TR CONNECTOR 29 TR CONNECTOR 30 TR CONNECTOR 2016 Alamo Group Inc. Parts Section -40

46 REMOTE CONTROL 1 TR ANTENNA, COMMUNICATION 3 TR ANTENNA, REMOTE 4 TR COVER, SWITCH 5 TR BASE, KEY 6 TR KEY, COMMUNICATION 7 TR JOYSTICK, PROPORTIONAL 8 TR WAIST BELT 8A TR HARNESS, WAIST, EXT. 66" 9 TR KIT, PLUG, RECVR 10 TR JOYSTICK, PROPORTIONAL 11 TR BASE, REMOTE 12 TR TOGGLE SWITCH 13 TR TOGGLE SWITCH 14 TR TOGGLE SWITCH 15 TR TOGGLE SWITCH 16 TR TOGGLE SWITCH 17 TR BUTTON, BLACK 18 TR STOP SWITCH 19 TR BUTTON, GREEN 2016 Alamo Group Inc. Parts Section -41

47 REMOTE CONTROL Continued TR POTENTIOMETER 22 TR MODULE, RADIO 23 TR TOP, REMOTE 24 TR FRAME, TOP, REMOTE 25 TR ASY, LED LIGHT, REMOTE 26 TR RUBBER BOOT, JOYSTICK 27 TR CODE CARD, REM-SN REQD 29 TR CHARGER, REMOTE BATTERY, DC 30 TR CHARGER, REMOTE BATTERY, AC 31 TR BATTERY, REMOTE 33 TR REMOTE CONTROL 35 TR RECEIVER UNIT 37 TR KIT, REMOTE CONTROL 38 TR BELT, SHOULDER 39 TR CONNECTOR 40 TR REMOTE, WIRED, 12-PIN 2016 Alamo Group Inc. Parts Section -42

48 INTAKE AND DRAIN PUMPS 1 TR SUPPLY HOSE, GEAR PUMP 2 TR PRESSURE HOSE, GEAR PUMP 3 TR RETURN HOSE, VALVE 4 TR RETURN HOSE, COOLER 5 TR SUPPLY HOSE, COOLER 6 TR SUPPLY HOSE, PISTON PUMP 7 TR HOSE, PISTON PUMP 8 TR RETURN HOSE, HEAD PUMP 9 TR RETURN HOSE, TRACK PUMPS 10 TR ADP HYD FTG 1/2-13/16 11 TR ADP HYD FTG 3/8-11/16 12 TR ADP HYD FTG 1/2-11/16 13 TR ADP HYD FTG 3/4-1-3/ Alamo Group Inc. Parts Section -43

49 INTAKE AND DRAIN PUMPS Continued TR ADP HYD FTG 1-1-3/16 15 TR SHCS M6-1.0 X 20MM PL TR LOCKWASHER SPRING M6 PL 17 TR HYD FTG, 90DEG, PUMP 18 TR SERVICE PORT W/CAP, 1/8" 19 TR SERVICE PORT W/CAP, 1/4" 20 TR HHCS M X 70MM PL TR O-RING, VITON 1.78X18.77MM 22 TR O-RING, VITON 1.78X12.42MM 23 TR O-RING, VITON 2.62X15.54MM 24 TR BRACKET, VALVE MOUNT 25 TR FLCS M X 16MM PL TR MANIFOLD, RETURN OIL 27 TR VALVE BLOCK 28 TR LOCKWASHER SPRING M8 PL 29 TR FLATWASHER M8 PL 30 TR PLUG 2016 Alamo Group Inc. Parts Section -44

50 HYDRAULIC LINE RIGHT AND LEFT 1 TR HOSE, TRACK, POSITION 08 2 TR HOSE, TRACK, POSITION 04 3 TR HOSE, TRACK, POSITION 07 4 TR HOSE, TRACK, POSITION 06 5 TR HOSE, TRACK, POSITION 02 6 TR HOSE, TRACK, POSITION 03 7 TR HOSE, TRACK, POSITION 11 8 TR HOSE, TRACK, POSITION 12 9 TR HOSE, TRACK, POSITION TR HOSE, TRACK, POSITION 11A 11 TR HOSE, TRACK, POSITION TR HOSE, TRACK, POSITION TR ADP HYD FTG 7/8-13/16 14 TR ADP HYD FTG 9/16-11/ Alamo Group Inc. Parts Section -45

51 HYDRAULIC LINE RIGHT AND LEFT Continued TR ADP HYD FTG 9/16-9/16 16 TR SEAL, HYD FITTING, 1/4 17 TR ADP HYD FTG 1/2-11/16 18 TR ADP HYD FTG 1/4-11/16 19 TR ADP HYD FTG 1/4-9/16 20 TR O-RING, VITON 1.78X12.42MM 21 TR SERVICE PORT W/CAP, 1/8" 22 TR SHCS M6-1.0 X 50MM PL TR SPEED/BRAKE VALVE TR SPEED - BRAKE - FAN VALVE 24 TR HEX SPACER M-F 1/4"X22MM 25 TR LOCKWASHER SPRING M6 PL 26 TR FLATWASHER M6 PL 27 TR PLUG, 1/8" 2016 Alamo Group Inc. Parts Section -46

52 HYDRAULIC LINE - LIFT CYLINDERS 1 TR HOSE, LIFT, RH UP 2 TR HOSE, LIFT, LH UP 3 TR HOSE, LIFT, RH DN 4 TR HOSE, LIFT, LH DN 5 TR ADP HYD FTG 1/4-9/16 6 TR ADP HYD FTG 3/8-9/16 7 TR ADP HYD TEE 9/16-9/16-9/16 8 TR NUT, PERFORATED 9 TR NUT, PERFORATED 10 TR GREASE FITTING M6X1 11 TR CYLINDER, HEAD LIFT 12 TR KIT, SEAL, LIFT CYLINDER 2016 Alamo Group Inc. Parts Section -47

53 HYDRAULIC LINE - EQUIPMENT HOSES 1 TR HOSE, ACCY 1A 2 TR HOSE, ACCY 2A 3 TR HOSE, ACCY 1 4 TR HOSE, ACCY 2 5 TR HOSE, POWER 1 6 TR HOSE, POWER 2 7 TR HOSE, POWER 3 8 TR ADP HYD FTG 1/2-13/16 9 TR ADP HYD FTG 3/8-9/16 10 TR O-RING, VITON 1.78X8.74MM 11 TR O-RING, VITON 1.78X12.42MM 2016 Alamo Group Inc. Parts Section -48

54 CUTTING HEAD, ROLL SUPPORT AND ROTOR SUPPORT (PART 1) 2016 Alamo Group Inc. Parts Section -49

55 CUTTING HEAD, ROLL SUPPORT AND ROTOR SUPPORT (PART 1) Continued... 1 TR CYL ROD CLEVIS 2 TR FLATWASHER 11MM 3 TR BRKT, DOOR SUPPORT 4 TR DOOR SUPPORT 5 TR CYL BARREL CLEVIS 6 TR DOOR CYLINDER 7 TR FRAME, HEAD 8 TR DOOR FLAP CLAMP 9 TR DOOR FLAP 10 TR BEARING COLLAR 11 TR OSCILLATING FLANGE 12 TR OSCILLATION JOINT 13 TR REAR ROLLER 14 TR RH ROLLER MOUNT 15 TR LH ROLLER MOUNT 16 TR LEFT SKID 17 TR WASHER 18 TR FLANGE, ROTOR, POWER IN 19 TR RIGHT SKID 20 TR PLATE, MOTOR MOUNT 21 TR DRIVE SYSTEM GUARD 22 TR DOOR 23 TR SPRING TENSIONER 24 TR SPRING HOOK 25 TR WASHER M13 26 TR SPRING BRACKET, LATERAL 27 TR HHCS M10X30 GR TR HHCS M10X35 GR TR SCREW M10X80 GR TR HHCS M10X45 GR TR HHCS M12X30 32 TR HHCS M12X40 GR TR SCREW M16X40 GR TR HHCS M16X90 35 TR SCREW M6X30 GR TR HHCS M12X45 37 TR SCREW M8X16 GR TR FHCS M8X20 39 TR FLCS M10X20 GR TR NUT M10 41 TR NUT M Alamo Group Inc. Parts Section -50

56 CUTTING HEAD, ROLL SUPPORT AND ROTOR SUPPORT (PART 2) 2016 Alamo Group Inc. Parts Section -51

57 CUTTING HEAD, ROLL SUPPORT AND ROTOR SUPPORT (PART 2) Continued TR SPRING, LATERAL TENSION 43 TR NUT, FLANGE, M10 44 TR LOCKNUT M10 45 TR LOCKNUT M12 46 TR LOCKNUT M6 47 TR LOCKNUT M16 48 TR LOCKNUT M10 49 TR LOCKNUT M16X TR WASHER M10 51 TR FLATWASHER M12 52 TR FLATWASHER M16 53 TR LOCKWASHER M12 54 TR WASHER M16 55 TR WASHER, NORD LOCK M12 56 TR WASHER, KNURLED, M12 57 TR GREASE FITTING M6X1 58 TR GREASE FITTING M10X1 59 TR FLANGE BEARING 60 TR ROLLER BEARING 61 TR SNAP RING, 25MM 62 TR SNAP RING, 30MM 63 TR KEEPER, BEARING 64 TR CUTTERSHAFT MOTOR 65 TR OIL SEAL 66 TR OIL SEAL, 30MM 67 TR SEAL KEEPER 68 TR SWIVEL BUSHING 69 TR KEEPER WASHER 70 TR LOCKNUT M12 71 TR KIT, DOOR FLAP 72 TR KIT, ROLLER W/BEARINGS 73 TR KIT, ROLLER W/BRNGS, BRKTS 2016 Alamo Group Inc. Parts Section -52

58 POWER TRANSMISSION 2016 Alamo Group Inc. Parts Section -53

59 POWER TRANSMISSION Continued... 1 TR SHEAVE, MOTOR SHAFT 2 TR LOWER SHAFT LOCK 3 TR LOWER PULLEY 4 TR UPPER PULLEY 5 TR DRIVE BELT 2016 Alamo Group Inc. Parts Section -54

60 ROTOR AND CUTTING TOOLS 2016 Alamo Group Inc. Parts Section -55

61 ROTOR AND CUTTING TOOLS Continued... 1 TR Y-FLAIL ROTOR, NO KNIVES 3 TR Y-FLAIL SET, WITH BOLT, NUT 4 TR KIT, HAMMER FLAIL, SINGLE 5 TR HAMMER ROTOR, NO KNIVES 7 TR ROTOR, Y-FLAILS TR ASY, CTRSHFT,Y-FLAIL W/BEARINGS 8 TR ASY, CUTTERSHAFT, HAMMER KNIFE TR ASY,CTRSHFT,HAMMER KNVS W/BEARINGS 2016 Alamo Group Inc. Parts Section -56

62 CUTTING HEAD HYDRAULIC LINE 2016 Alamo Group Inc. Parts Section -57

63 CUTTING HEAD HYDRAULIC LINE Continued... 1 TR HOSE, DOOR CLOSE 2 TR HOSE, DOOR OPEN 3 TR HOSE, MOTOR 1 4 TR HOSE, MOTOR 2 5 TR HOSE, MOTOR 3 6 TR ADP HYD FTG 1/2-13/16 7 TR ADP HYD FTG 1/4-9/16 8 TR ADP HYD FTG 3/4-13/16 9 TR ADP HYD FTG 3/8-9/16 10 TR ADP HYD QD 1/2F VVS 11 TR PLUG HYD QD 1/2M VV/VVS 12 TR ADP HYD QD 1/2M VVS 13 TR CAP HYD QD 1/2F VV/VVS 14 TR ADP HYD QD 1/2F VV 15 TR ADP HYD QD 3/8F VV 16 TR PLUG HYD QD 3/8M VV/VVS 17 TR ADP HYD QD 3/8M VV 18 TR CAP HYD QD 3/8F VV/VVS 2016 Alamo Group Inc. Parts Section -58

64 MISCELLANEOUS PARTS 1 TR KIT, GREASE GUN 2 TR BUTTON HEAD GREASE FITTING; INCLUDED IN GREASE GUN KIT TR TR KIT, BRAKE RELEASE/TOW 4 TR PLATE, TENSION; INCLUDED IN BRAKE RELEASE/TOW KIT TR TR SPREADER BAR; INCLUDED IN BRAKE RELEASE/TOW KIT TR TR HYDRAULIC OIL 22L CONTAINER 8 TR OPERATOR`S MANUAL 12 TR SPRAY PAINT, TRAXX GREY 13 TR SPRAY PAINT, TRAXX YELLOW 14 TR FIRE EXTINGUISHER, 2.5 LB 15 TR KEY, POWER, ROBO-UNIT 16 TR CONNECTOR, RADIO CAPACITOR 17 TR SHROUD, RADIATOR FAN 2016 Alamo Group Inc. Parts Section -59

65

66 TO THE OWNER/OPERATOR/DEALER To keep your implement running efficiently and safely, read your manuals thoroughly and follow these directions and the Safety Messages in this Manual. The Table of Contents clearly identifies each section where you can easily find the information you need. The OCCUPATIONAL SAFETY AND HEALTH ACT ( Subpart C) makes these minimum safety requirements of tractor operators: REQUIRED OF THE OWNER 1. Provide a Roll-Over-Protective Structure that meets the requirements of this standard. 2. Provide seat belts that meet the requirements of this paragraph of this standard and SAE J4C. 3. Ensure that each employee uses such seat belt while the tractor is moving. 4. Ensure that each employee tightens the seat belt sufficiently to confine the employee to the protected area provided by the ROPS. REQUIRED OF THE OPERATOR 1. Securely fasten seat belt if the tractor has a ROPS. 2. Where possible, avoid operating the tractor near ditches, embankments, and holes. 3. Reduce speed when turning, crossing slopes, and on rough, slick, or muddy surfaces. 4. Stay off slopes too steep for safe operation. 5. Watch where you are going, especially at row ends, on roads, and around trees. 6. Do not permit others to ride. 7. Operate the tractor smoothly, no jerky turns, starts, or stops. 8. Hitch only to the draw bar and hitch points recommended by the tractor manufacturer. 9. When the tractor is stopped, set brakes securely and use park lock, if available. Keep children away from danger all day, every day... Equip tractors with rollover protection (ROPS) and keep all machinery guards in place... Please work, drive, play and live each day with care and concern for your safety and that of your family and fellow citizens.

67 ALAMO INDUSTRIAL Limited Warranty 1. Limited Warranties Alamo industrial warrants for one year from the purchase date to the original non-commercial, governmental, or municipal purchaser ( purchaser ) and warrants for six months to the original commercial or industrial purchaser ( purchaser ) that the goods purchased are free from defects in material or workmanship Manufacturer will replace for the purchaser any part or parts found, upon examination at one of its factories, to be defective under normal use and service due to defects in material or workmanship This limited warranty does not apply to any part of the goods which has been subjected to improper or abnormal use, negligence, alteration, modification, or accident, damaged due to lack of maintenance or use of wrong fuel, oil, or lubricants, or which has served its normal life. This limited warranty does not apply to any part of any internal combustion engine, or expendable items such as blades, shields, guards, or pneumatic tires except as specifically found in your operator s manual Except as provided herein, no employee, agent, dealer, or other person is authorized to give any warranties of any nature on behalf of manufacturer. 2. Remedies And Procedures This limited warranty is not effective unless the purchaser returns the registration and warranty form to manufacturer within 30 days of purchase Purchaser claims must be made in writing to the authorized dealer ( dealer ) from whom purchaser purchased the goods or an approved authorized dealer ( dealer ) within 30 days after purchaser learns of the facts on which the claim is based Purchaser is responsible for returning the goods in question to the dealer If after examining the goods and/or parts in question, manufacturer finds them to be defective under normal use and service due to defects in material or workmanship, manufacturer will: (A) repair or replace the defective goods or part(s) or (B) reimburse purchaser for the cost of the part(s) and reasonable labor charges (as determined by manufacturer) if purchaser paid for the repair and/or replacement prior to the final determination of applicability of the warranty by manufacturer. The choice of remedy shall belong to manufacturer Purchaser is responsible for any labor charges exceeding a reasonable amount as determined by manufacturer and for returning the goods to the dealer, whether or not the claim is approved. Purchaser is responsible for the transportation cost for the goods or part(s) from the dealer to the designated factory. 3. Limitation Of Liability Manufacturer disclaims any express (except as set forth herein) and implied warranties with respect to the goods including, but not limited to, merchantability and fitness for a particular purpose Manufacturer makes no warranty as to the design, capability, capacity, or suitability for use of the goods Except as provided herein, manufacturer shall have no liability or responsibility to purchaser or any other person or entity with respect to any liability, loss, or damage caused or alleged to be caused directly or indirectly by the goods including, but not limited to, any indirect, special, consequential, or incidental damages resulting from the use or operation of the goods or any breach of this warranty. Not withstanding the above limitations and warranties, manufacturer s liability hereunder for damages incurred by purchaser or others shall not exceed the price of the goods No action arising out of any claimed breach of this warranty or transactions under this warranty may be brought more than two (2) years after the cause of action has occurred. 4. Miscellaneous Proper venue for any lawsuits arising from or related to this limited warranty shall be only in Guadalupe county, Texas Manufacturer may waive compliance with any of the terms of this limited warranty, but no waiver of any terms shall be deemed to be a waiver of any other term If any provision of this limited warranty shall violate any applicable law and is held to be unenforceable, then the invalidity of such provision shall not invalidate any other provisions herein Applicable law may provide rights and benefits to purchaser in addition to those provided herein. Keep for your records Attention: Purchaser should fill in the blanks below for his reference when buying repair parts and/or for proper machine identification when applying for warranty. Alamo Industrial Implement Model Serial Number Date Purchased Dealer Attention: Read your operator s manual ALAMO INDUSTRIAL 1502 E. Walnut Seguin, Texas

68

69 1502 E. Walnut St. Seguin, Texas Sales and Marketing Tel Fax Warranty Registration/Claims Return Authorizations Online Part Orders Techical Information Tel Fax TRAXXRF SN00323 Parts Manual (PUB 10-14) P/N TR477927