BUSH HOG LAND MAINTENANCE REPAIR PARTS MANUAL MODEL: 280 SERIES SECTION: 59

Size: px

Start display at page:

Download "BUSH HOG LAND MAINTENANCE REPAIR PARTS MANUAL MODEL: 280 SERIES SECTION: 59"

Britney Bishop
6 years ago
Views:

1 BUSH HOG LAND MAINTENANCE REPAIR S MANUAL MODEL: 0 SERIES SECTION: 0 Griffin Ave. Selma, AL 0 () () 00 Parts Ordering 00 0 Fax 00

2 BUSH HOG/ LAND MAINTENANCE REPAIR S MANUAL October, 0 0 SERIES ROTARY CUTTER MODELS,, ALPHABETICAL INDEX CONTENTS PAGE Base Assembly, Model (Serial Numbers -00 and Below)...-- (Serial Numbers and Above)...-- Base Assembly, Model (Serial Numbers -0 and Below)...-- (Serial Numbers and Above)...-- Base Assembly, Model (Serial Numbers -0 and Below)...-- (Serial Numbers -000 and Above)...-- Blade & Blade Holder Assembly, Model (Serial Numbers -00 and Below)...-- (Serial Numbers and Above)...-- Blade & Blade Holder Assembly, Model (Serial Numbers -0 and Below)...-- (Serial Numbers and Above)...-- Blade & Blade Holder Assembly, Model (Serial Numbers -0 and Below)...-- (Serial Numbers -000 and Above)...-- Chain, Safety...-- Deflector, Safety...-- Driveshaft Assemblies...-- through -- Decals...See Base Assemblies Frame, Tailwheel Single...-- Frame, Tailwheel Dual...-- Gearbox Assembly, Comer, Model, 0 RPM (Serial Numbers and Above)...-- Model, 0 RPM (Serial Numbers and Above)...-- Model, 0 RPM (Serial Numbers -000 and Above)...-- Model, 000 RPM (Serial Numbers -000 and Above)...-- Gearbox Assembly, Omni, Model (Serial Numbers -00 and Below)...-- Model (Serial Numbers -0 and Below)...-- Model (Serial Numbers -0 and Below)...-- Hitch, Point Lift...-- Hitch, Quick...--, -- Hitch, Semi-Mount...-- Hydraulic Bundle...-- Hydraulic Cylinder...-- Ratchet Assembly...-- Tailwheel Assembly (Old Style)...-- Tailwheel Assembly (New Style)...--

3 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL APRIL, 00 DECK ASSEMBLY (Omni Gearbox) Model - Cutter & Model - Cutter Model Serial Numbers -00 and Below Model Serial Numbers -0 and Below Gearbox Assembly Shield Assembly Capscrew / x / Gr. Flatwasher / Capscrew / x Gr. 0 0 Locknut / Flanged Front Skid Rear Skid 0 0 Plow Bolt / x -/ 0 Flatwasher Lockwasher Hex Nut / Flatwasher Castle Nut - UNC Cotter Pin x Blade Pan Weldment Blade Bar Uplift Bar (Std.) 0 Double Edge Blade (Opt.) 0 0 Blade Bolt Kit 0 Blade Bolt 0 0 Lockwasher -/ Jam Nut -/ Deck Assembly, Red Deck Assembly, Orange Deck Assembly, Green Deck Assembly, Blue 0 0 Decal Kit 0 Bush Hog Decal Model Decal Red Reflector Sheet Decal Sheet Decal --

4 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL APRIL, 00 DECK ASSEMBLY (Comer Gearbox) Model - Cutter & Model - Cutter Model Serial Numbers and Above Model Serial Numbers and Above Gearbox Assembly, Red Gearbox Assembly, Orange Gearbox Assembly, Green Gearbox Assembly, Blue Cover Shield Weldment Lynch Pin Capscrew / x -/ Gr. 0 0 Locknut / Flanged Front Skid Rear Skid 0 0 Plow Bolt / x -/ 0 Flatwasher / Lockwasher / Hex Nut / Flatwasher Castle Nut - UNC Cotter Pin x 0 00 Blade Pan Blade Bar Uplift Blade (Std.) 0 Double Edge Blade (Opt.) 0 0 Blade Bolt Kit 0 Blade Bolt 0 0 Lockwasher -/ Jam Nut -/ Deck Assembly, Red Deck Assembly, Orange Deck Assembly, Green Deck Assembly, Blue 0 0 Decal Kit Bush Hog Decal Model Decal Red Reflector Capscrew M x. x Lockwasher M Capscrew / x -/ 0 Flatwasher / Locknut / Flatwasher M Sheet Decal Sheet Decal --

5 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL APRIL, DECK ASSEMBLY (Omni Gearbox) Model - Cutter Serial Numbers -0 and Below 0 Gearbox Assembly Shield Assembly Capscrew / x / Gr. Flatwasher / Capscrew / x Gr. 0 Locknut / Flanged 000 Front Skid 000 Rear Skid 0 Plow Bolt / x -/ 0 Flatwasher / Lockwasher / Hex Nut / 00 Flatwasher Castle Nut - UNC Cotter Pin x 0 0 Pan Weldment Uplift Blades (Std.) Double Edge Blade (Opt.) 0 Blade Bolt Kit Blade Bolt 0 0 Lockwasher -/ Jam Nut -/ Deck Assembly, Red 000 Deck Assembly, Orange 000 Deck Assembly, Green 000 Deck Assembly, Blue 00 Decal Kit () 0 Bush Hog Decal Model Decal Red Reflector 00 Sheet Decal 00 Sheet Decal --

6 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL APRIL, 00 DECK ASSEMBLY (Comer Gearbox) (0 RPM) & (000 RPM) Models Serial Numbers -000 and Above Gearbox (0 RPM), Red 000 Gearbox (0 RPM), Orange 000 Gearbox (0 RPM), Green 000 Gearbox (0 RPM), Blue 000 Gearbox (000 RPM), Red 000 Gearbox (000 RPM), Orange 000 Gearbox (000 RPM), Green 0000 Gearbox (000 RPM), Blue 00 Cover Base Weldment Lynch Pin Capscrew / x -/ Gr. 0 Locknut / Flanged 000 Front Skid 000 Rear Skid 0 Plow Bolt / x -/ 0 Flatwasher / Lockwasher / Hex Nut / 00 Flatwasher 00 Castle Nut - UNC Cotter Pin x Pan Weldment Uplift Blades (Std.) Double Edge Blade (Opt.) 0 Blade Bolt Kit Blade Bolt 0 0 Lockwasher -/ Jam Nut -/ Deck Assembly (0 RPM), Red 0000 Deck Assembly (0 RPM), Orange 000 Deck Assembly (0 RPM), Green 000 Deck Assembly (0 RPM), Blue Deck Assembly (000 RPM), Red 000 Deck Assembly (000 RPM), Orange 000 Deck Assembly (000 RPM), Green 000 Deck Assembly (000 RPM), Blue 00 Decal Kit () 000 Bush Hog Decal Model Decal 00 Red Reflector 00 Capscrew M x. x Flatwasher M Capscrew / x -/ Flatwasher / 0 Locknut / Lockwasher M 00 Sheet Decal, 0 RPM 00 Sheet Decal, 000 RPM 00 Sheet Decal --

7 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL JUNE, 00 FRONT & REAR CHAINS 0 SERIES 0 0 Part No. Ref. No. Description 0 Capscrew / x Gr Capscrew / x -/ Gr. 0 0 Locknut / 0 Lockwasher / 0 Flatwasher / Hex Nut / Front Chain Assembly Chain, Link Front Mount Bracket Front Retainer Rod Pin. x Center Rear Chain Assembly Chain, Link Center Mount Bracket Center Retainer Rod Spirol Pin. x L.H.Rear Chain Assy Chain, Link 0 L.H. Bracket Retaining Rod Spirol Pin. x R.H.Rear Chain Assy Chain, Link R.H. Bracket Retaining Rod Spirol Pin. x. -- Qty.

8 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL SEPTEMBER, Part No. FRONT & REAR DEFLECTORS 0 SERIES Qty. Ref. No. Description 0 Capscrew / x -/ Gr Capscrew / x Gr. 0 Hex Nut / 0 Lockwasher / 0 Flatwasher / 0 Belting Belting Clamp Rear Band --

9 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL November, 0 GEARBOX ASSEMBLY (0 RPM) Manufactured by Omni For Models - and - Cutter Models Serial Numbers -00 and Below Models Serial Numbers -0 and Below 0 0 GEARBOX ASSEMBLY (0 RPM) Manufactured by Omni For Model - Cutter Models Serial Number -0 and Below 0 0 Housing Cap, Output Cap, Input Pinion Gear Teeth for 0 Assy. Pinion Gear Teeth for 0 Assy. Input Gear Teeth for 0 Assy. Input Gear Teeth for 0 Assy. Shaft, Output Shaft Input 00 Bearing Cone 0 Bearing Cone 0 0 Bearing Cup Bearing Cup Bearing Cup Seal, Lip 0 Seal, Lip A/R Gasket,.0mm Input Cap A/R Gasket,.mm Input Cap A/R Gasket,.0mm Input Cap A/R Gasket,.0mm Output Cap A/R Gasket,.mm Output Cap 0 A/R Gasket,.0mm Output Cap Spacer for 0 Assy. 0 Spacer for 0 Assy. A/R Shim.mm Cotter Pin mm x 0mm Capscrew / x / Gr. 0 Capscrew / x / Gr. Castle Nut, Flanged "- Lockwasher / 0 Lockwasher / Breather Plug / - NPTF 0 0 Pipe Plug / - NPTF Retaining Ring 0 --

10 BUSH HOG / MATERIAL HANDLING REPAIR S MANUAL APRIL, 00 0 GEARBOX (0 RPM) Manufactured by Comer For Model Serial Numbers and Above 0 GEARBOX (0 RPM) Manufactured by Comer For Model Serial Numbers -000 and Above Gearbox Housing Gear, Crown Teeth (0) Gear, Crown Teeth (0) 0 Bearing Oil Seal x x 0 Input Shaft -/ spline 0 Snap Ring 0 Shim 0 Shim 0 Shim 0 Shim 0 Snap Ring 0 Nut M0 x. 0 0 Shim 0 Shim 0 Shim 0 Shim 000 Bolt Washer 00 Castle Nut M0 x Shim. mm Shim. mm Shim. mm Shim.0 mm 00 Protective Washer 0 Oil Seal 000 Bearing 00 Shaft, Output Gear, Pinion Teeth (0) Gear, Pinion Teeth (0) 0 Cotter Pin 0 00 Shim 0 Plug, Gas / 0 Cap 0 Bolt, M x 0 Oil Level Plug Cover Cotter pin

11 BUSH HOG / MATERIAL HANDLING REPAIR S MANUAL APRIL, 00 0 GEARBOX (000 RPM) RED Manufactured by Comer For Model Serial Numbers -000 and Above 0 0 Gearbox Housing Gear, Crown Teeth 0 Bearing Oil Seal x x 0 Input Shaft -/ 0 Snap Ring 0 Shim 0 Shim 0 Shim 0 Shim 0 Snap Ring 0 Nut M0 x. 0 0 Shim 0 Shim 0 Shim 0 Shim 000 Bolt Washer 00 Castle Nut M0 x Shim. mm Shim. mm Shim. mm Shim.0 mm 00 Protective Washer 0 Oil Seal 000 Bearing 00 Shaft, Output Gear, Pinion Teeth 0 Cotter Pin 0 00 Shim 0 Plug, Gas / 0 Cap 0 Bolt, M x 0 Oil Level Plug Cover Cotter Pin --

12 BUSH HOG / MATERIAL HANDLING REPAIR S MANUAL APRIL, 00 0 GEARBOX (0 RPM) Manufactured by Comer For Model Serial Numbers and Above 0 0 Gearbox Housing Gear, Crown Teeth 0 Bearing Oil Seal x x 0 Input Shaft -/ 0 Snap Ring 0 Shim 0 Shim 0 Shim 0 Shim 0 Snap Ring 00 Nut M0 x. 0 0 Shim 0 Shim 0 Shim 0 Shim 000 Bolt Washer 00 Castle Nut M0 x 0 Shim.mm 0 Shim.mm 0 Shim.mm 0 Shim mm 00 Protective Washer 0 Oil Seal 000 Bearing 00 Shaft, Output Gear, Pinion Teeth 0 Cotter Pin 0 00 Shim 0 Plug, Gas / 0 Cap 0 Bolt, M x 0 Oil Level Plug Cover Cotter Pin --

13 BUSH HOG/ LAND MAINTENANCE REPAIR S MANUAL MAY, DRIVESHAFT ASSEMBLY (0 RPM) MODEL - (Mfd. by Binacchi) Replaced by 00 Driveshaft (Binacchi) Replaced by 000 Driveshaft (B&P) 0 DRIVESHAFT ASSEMBLY (0 RPM) MODEL - (Mfd. by Binacchi) Replaced by 00 Driveshaft (Binacchi) Replaced by 000 Driveshaft (B&P) 0 00 Front Half, Complete () 000 Front Half, Complete () 00 Rear Half, Complete () 00 Rear Half, Complete () 00 Tractor Yoke -/ - Spline Q.D. Pin Kit 0 Cross Bearing Kit Grease Fitting Yoke, Outer Tube Flexible Pin 0 Outer Tube (- ) Outer Tube (- ) 0 Danger Decal Torque Limiter Capscrew M0 x. x Locknut M0 x. Pressure Plate Inner Plate Torque Limiter Kit Brake Lining Sup. Kit w/pivot 0 Pivot Assy. Flatwasher M Hex Nut M x. Bushing 0 Flange 0 Yoke, Inner Tube Inner Tube (- ) Inner Tube (- ) 0 Flexible Pin 00 Shield Assembly (- ) 00 Shield Assembly (- ) 00 Shield Bearing, Outer Shield 00 Shield Bearing, Inner Shield 0 Danger Decal Safety Chain Spring --

14 BUSH HOG/ LAND MAINTENANCE REPAIR S MANUAL APRIL, DRIVELINE ASSEMBLY (0 RPM) MODEL - (Mfd. by Binacchi) Replaced by: 00 Driveshaft Assy. (Mfd. by Binacchi) Replaced by: Driveshaft Assy. (Mfd. by Comer/EG) 0 Front Half, Complete 0 Rear Half, Complete 0 Tractor Yoke -/ - Spline Q.D. Pin Kit Cross Bearing Kit Grease Fitting Yoke, Outer Tube Flexible Pin 00 Outer Tube 0 Danger Decal Torque Limiter Capscrew M0 x 00 Locknut M0 Pressure Plate 0 Inner Plate Torque Limiter Kit 0 Hub w/pivot 0 Pivot Assy. Flatwasher M Hex Nut M x. Bushing 0 Flange Brake Lining Support 0 Inner Plate 0 Yoke, Inner Tube Inner Tube Flexible Pin 0 Shield Assy. 00 Shield Bearing - Outer Shield 000 Shield Bearing - Inner Shield 0 Danger Decal 0 Safety Chain Spring --

15 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL FEBRUARY DRIVELINE ASSEMBLY (000 RPM) Mfd. by Comer/EG Used on Model Replaces 00 Driveshaft Outer Half w/shield Inner Half w/shield 0 Complete Collar Yoke 000 Ball Collar Kit -/ Cross Bearing Kit Grease Fitting Outer Yoke Roll Pin Outer Yoke 00 Outer Tube 0 Danger Decal Inner Tube Roll Pin Inner Tube 0 Inner Yoke Slip Clutch Assy. Hex Nut M0 x. 00 Spring Flange 0 Bushing 0 Lining 0 Support 0 Taper Pin Kit 0 Inner Plate 0 Push Pin Set Note: Some early driveshafts were shipped with push pins on the tractor yoke end. Order 0 push pin set to replace pin. Order 0 for complete yoke replacement. Intermediate Plate 0 Pressure Plate Capscrew, M0 x. x 00 0 Complete Shield 0 Outer Bearing Shield Bolt 0 Inner Bearing 0 0 Danger Decal Safety Chain --

16 BUSH HOG/ LAND MAINTENANCE REPAIR S MANUAL JUNE, DRIVESHAFT ASSEMBLY W/ CLUTCH -/ Spline, 0 RPM, Mfd. by Binacchi REPLACED BY 000 Driveshaft Assy. (Mfd. By B&P) Used on Model DRIVESHAFT ASSEMBLY W/ CLUTCH -/ Spline, 0 RPM, Mfd. by Binacchi REPLACED BY 000 Driveshaft Assy. (Mfd. By B&P) Used on Model - 00 Front Half, Complete () 000 Front Half, Complete () 00 Rear Half, Complete () 00 Rear Half, Complete () 00 Complete Collar Yoke 00 Ball Collar Kit 0 Cross Bearing Kit Grease Fitting Yoke, Outer Tube Flexible Pin 0 Outer Tube () Outer Tube () 0 Danger Decal Torque Limiter Capscrew M0 x. x Locknut M0 x. Pressure Plate Inner Plate Torque Limiter Kit -- 0 Lining 0 Pivot Assy. Flatwasher M Hex Nut M x. Bushing 0 Flange 0 Yoke, Inner Tube Inner Tube () Inner Tube () 0 Flexible Pin 00 Shield Assembly () 00 Shield Assembly () 00 Shield Bearing, Outer Shield 00 Shield Bearing, Inner Shield 0 Danger Decal Safety Chain Spring 0 Hub

17 BUSH HOG/ LAND MAINTENANCE REPAIR S MANUAL APRIL, DRIVESHAFT ASSEMBLY W/ CLUTCH 0 RPM, -/ Spline, Mfd. by Binacchi REPLACED BY Driveshaft Assy. (Mfd. By Comer/EG) Used on Model 00 DRIVESHAFT ASSEMBLY W/ CLUTCH 000 RPM, -/ Spline, Mfd. by Binacchi Used on Model 00 Front Half, Complete (0 RPM) 00 Front Half, Complete (000 RPM) 00 Rear Half, Complete (0 RPM) 00 Rear Half, Complete (000 RPM) 00 Complete Collar Yoke 00 Ball Collar Kit Cross Bearing Kit Grease Fitting Yoke, Outer Tube Flexible Pin 00 Outer Tube 0 Danger Decal Torque Limiter Capscrew M0 x 00 Locknut M0 Pressure Plate 0 Inner Plate -- Torque Limiter Kit 0 Hub w/pivot 0 Tapered Pin Kit Bushing 0 Flange Brake Lining Support Lining 0 Yoke, Inner Tube Inner Tube Flexible Pin 000 Shield Assy. 00 Shield Bearing - Outer Shield 000 Shield Bearing - Inner Shield 0 Danger Decal 0 Safety Chain Spring

18 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL JANUARY DRIVESHAFT W/ SLIP CLUTCH Mfr: Comer / EG Model: Supersession: Replaces Driveshaft, Replaced by 00 Driveshaft 0 Push Pin Set DRIVESHAFT W/ SLIP CLUTCH Mfr: Comer / EG Model: Supersession: Replaced by 00 Driveshaft 0 Complete Collar Yoke 0 Cross Journal Set Grease Nipple Outer Yoke Roll Pin for Outer Tube 0 Outer Tube () Outer Tube () Inner Tube () Inner Tube () 0 Roll Pin for Inner Tube 0 Inner Yoke 0 0 Complete Disc Clutch Guard Retaining Collar, Outer Bolt Guard Retaining Collar, Inner Safety Chain Complete Shield () Complete Shield () Note ( Driveshaft): Some early driveshafts were shipped with push pins on the tractor yoke end. Order 0 Push Pin Set to replace pin. For complete yoke replacement, order 0 Collar Yoke. 000 Ball Collar Kit -/ 00 Spring 0 Flanged Yoke 0 Bushing 0 0 Lining Ring 0 Tapered Pin Set -/ 0 Clutch Support 0 Inner Plate 0 Pressure Plate Capscrew M0 x. x Lock Nut M0 x. Half Female Shaft w/ Shield () Half Female Shaft w/ Shield () Half Male Shaft w/ Shield () Half Male Shaft w/ Shield () Danger Decal, Outer Tube 0 0 Danger Decal, Outer Shield --

19 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL JUNE, DRIVESHAFT W/ SLIP CLUTCH Manufactured by Comer / EG Used on Model 0 Ball Collar Yoke Cross Journal Set Grease Nipple Outer Yoke Roll Pin for Outer Tube 00 Outer Tube Inner Tube Roll Pin for Inner Tube 0 Inner Yoke 0 Complete Disc Clutch 0 Guard Retaining Collar, Outer Bolt 0 Guard Retaining Collar, Inner Safety Chain 0 Complete Shield 000 Ball Collar Kit -/ 00 Spring Flanged Yoke 0 Bushing 0 0 Lining Ring 0 Tapered Pin Set -/ Clutch Support 0 Inner Plate 0 Push Pin Set Note: Some early driveshafts were shipped with push pins on the tractor yoke end. Order 0 push pin set to replace pin. Order 0 for complete yoke replacement. Intermediate Plate 0 Pressure Plate Capscrew M0 x. x 00 Lock Nut M0 x. Half Female Shaft w/ Shield Half Male Shaft w/ Shield 0 Danger Decal, Outer Tube 0 Danger Decal, Outer Shield --

20 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL JANUARY DRIVESHAFT W/ SLIP CLUTCH 0 RPM, -/ SPLINE Mfr: Comer Model: Supersession: Replaces Driveshaft 00 DRIVESHAFT W/ SLIP CLUTCH 0 RPM, -/ SPLINE Mfr: Comer Model: Supersession: Replaces Driveshaft 0 Complete Collar Yoke 0 Cross Journal Set 0 Complete Disc Clutch 00 Guard Retaining Collar, Outer 000 Bolt 000 Guard Retaining Collar, Inner Safety Chain 00 Complete Shield (00) 00 Complete Shield (00) 000 Ball Collar Kit -/ 0 00 Spring 0 Flanged Yoke 0 Bushing 0 Lining Ring 0 Tapered Pin Set -/ 0 Clutch Support 0 Inner Plate 0 Pressure Plate Capscrew M0 x. x Lock Nut M0 x Half Female Shaft w/ Shield (00) 000 Half Female Shaft w/ Shield (00) 00 Half Male Shaft w/ Shield (00) 00 Half Male Shaft w/ Shield (00) Danger Decal, Outer Tube 0 Danger Decal, Outer Shield --

21 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL December, DRIVESHAFT ASSY. Used On: (Replaces the 00 Driveshaft Assy.) Mfd. by Bondioli & Pavesi B & P Size - ASAE Size 0 RPM 0000 Complete Collar Yoke 00 Cross Bearing Kit Yoke for Outer Tube Roll Pin, Outer Tube 00 Outer Tube 00 Inner Tube 0 Roll Pin, Inner Tube 0 Yoke for Inner Tube N/A Order Complete Driveline Assy Outer Shield Bearing 0 Self Tapping Screw 00 Inner Shield Bearing 000 Chain, Shield Danger Decal, Outer Tube 0 Danger Decal, Outer Shield Tube 00 Ball Collar Repair Kit 0 Taper Pin Kit Capscrew M0 x. x Gr.. 00 Spring 0 00 Flange Yoke Bushing # Clutch 00 Lining, x x.mm N/A Order Complete Driveline Assy. 00 Inner Plate Pressure Plate 00 Shield Assy. Complete Locknut, M0 x. 00 Torque Limiter Repair Kit DRIVESHAFT ASSY. Used On : (Replaces the 00 Driveshaft Assy.) Mfd. by Bondioli & Pavesi B & P Size - ASAE Size 0 RPM 0000 Complete Collar Yoke 00 Cross Bearing Kit Yoke for Outer Tube Roll Pin, Outer Tube Outer Tube 00 Inner Tube 0 Roll Pin, Inner Tube 0 Yoke for Inner Tube N/A Order Complete Driveline Assy Outer Shield Bearing 0 Self Tapping Screw 00 Inner Shield Bearing 000 Chain, Shield Danger Decal, Outer Tube 0 Danger Decal, Outer Shield Tube 00 Ball Collar Repair Kit 0 Taper Pin Kit Capscrew M0 x. x Gr.. 00 Spring mm 0 N/A Order Complete Driveline Assy. Bushing # Clutch 00 Lining, x x.mm N/A Order Complete Driveline Assy. 00 Inner Plate Pressure Plate 000 Shield Assy. Complete Locknut, M0 x. 00 Torque Limiter Repair Kit

22 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL JANUARY 00 0 POINT LIFT Models: & 0 0 Strut Yoke Models Yoke Models Pivot Tube Flex Link 0000 Lift Pin 0 Hex Nut -/ Fine Thread 0 Lockwasher -/ Capscrew / x Gr. Capscrew / x Gr. 0 Locknut / 0 POINT HITCH & SEMI-MOUNT HITCH Model: Strut Yoke Pivot Tube Flex Link Cat. II 0 Pin Weld. (Lift & Semi-Mount) 0 Spacer Cat. II 0 Spacer 000 Klick Pin 0 Capscrew / x Gr. 0 Capscrew / x Gr. Capscrew / x Gr. Locknut / --

23 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL JULY, 00 0 QUICK HITCH MODEL CUTTER 0 0 Yoke 0 Upper Strut, Cat. II Flatwasher / Hex Nut / Lockwasher / Hex Nut Lockwasher 0 Capscrew x -/ Gr. Capscrew / x Gr. 0 Capscrew / x -/ Gr. Capscrew / x -/ Gr. 00 Bushing 00 Bushing Pivot Arm 000 Bushing 0 Spacer Bushing 0 Top Plate Locknut / Capscrew / x Gr Klick Pin 0 Spacer 0 Spacer, Cat. II 0 Pin Weldment 0 Capscrew / x Gr. --

24 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL JUNE, QUICK HITCH ASSEMBLY For Models & 00 Yoke, Model (Shown) 00 Yoke, Model 00 Cat. I Upper Strut 00 Top Plate Pivot Arm Weldment 00 Cat. I Quick Hitch Bottom Bushing 00 Cat. I Quick Hitch Top Bushing 00 Hitch Spacer Bushing 00 Wear Bushing 000 Lynch Pin Lift Pin / Capscrew / x Capscrew / x 0 Capscrew / x Capscrew / x -/ Capscrew / x Lockwasher / 0 Lockwasher -/ Locknut / 0 Locknut / 0 Hex Nut / 0 Hex Nut -/ NF 000 Spacer, Mast --

25 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL JUNE, 00 CASTER ASSEMBLY (OBSOLETE) Order 00 Caster Assembly for complete replacement NO NO Flatwasher Roll Pin / x -/ 0 Fork Weldment Capscrew / x Gr. Lockwasher / 0 Bearing Repair Kit 0 Capscrew / x Gr. Locknut, Toplock / - 0 Wear Washer 0 Spacer Tube 0 Roller Bearings 00BH Tire Assembly N/A Solid Tire (Order Ref No.) N/A Wheel Flange (Order Ref No.) Capscrew / x Gr. Lockwasher / Hex Nut / Hub Assembly BH Grease Fitting SINGLE TAILWHEEL BRACKET FOR 0 SERIES MODELS, & Tailwheel Frame Adjusting Bracket Capscrew / x -/ Gr. Lockwasher / Hex Nut / Capscrew / x Gr. Locknut / --

26 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL JUNE, 00 DUAL TAILWHEEL MOUNT 0 Series Model 0 Axle Weldment 00 Bushing, Pivot 0 Capscrew, / x Gr. Locknut, / Gr.G, Flanged RATCHET ASSEMBLY 00 Pin 00 Clip Pin 0 Handle Cotter Pin --

27 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL October, 0 Ref. Part Description Qty. No. No. Req d. 00 Fork Assy. 00BH Tire Assy. 00 Hub Casting Flatwasher M 0BH Capscrew M.x 00 Axle Bolt 00 Hex Nut Slotted M x 00 Bearing Assy, Tapered 00 Seal 0 00 Bushing 000 Cap, Protective 00 Washer 00 Roll Pin M0 x Cotter Pin / x BH Grease Fitting 00 Caster Assembly --

28 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL APRIL, 00 0 HYDRAULIC BUNDLE 0 Adaptor / JIC to / SAE -- Adaptor / JIC to / NPT -0-0 Elbow / ORB to / JIC 000 Breather Plug Hydraulic Hose 00 Hydraulic Cylinder Assy. (See Next Page) Stop Collar Kit HOSE HOLDER Flatwasher / Capscrew / - Gr. Locknut / 0 Hose Holder --

29 BUSH HOG / LAND MAINTENANCE REPAIR S MANUAL SEPTEMBER, 0 Cylinder Assembly Part Number Stamped Here. 00 HYDRAULIC CYLINDER (Was Part No. ) Manufactured by Monarch Bore X Stroke. Rod Dia. / ORB Ports Clevis Cap Rod Cap 0 Piston Rod. Dia. Cylinder Tube Tie Rod Pin Dia. 00 Cotter Pin / x / Thread Lock 0 Rod Clevis. x Set Screw / x / Knurled 0 Hex Nut / Hex Nut / UNF Plug / Caution Decal 000 Seal Kit --

31 0 Griffin Ave. Selma, AL 0 () () 00 Parts Ordering 00 0 Fax 00

BUSH HOG LAND MAINTENANCE REPAIR PARTS MANUAL MODEL: 280 SERIES SECTION: 59

BUSH HOG LAND MAINTENANCE REPAIR S MANUAL MODEL: 0 SERIES SECTION: P.O. Box 0 Selma, AL 0-0 () - () -00 Parts Ordering -00-0- Fax -00-- www.bushhog.com BUSH HOG/ LAND MAINTENANCE REPAIR S MANUAL JUNE,