TRAILBLAZER PARTS CATALOG

Transcription

1 TRALBLAZER PARTS CATALOG MODELS E00 A E00 E0 A MARNE CORPORATON 97 ALL RGHTS RESERVED

2 HOOD & WNDSHELD GROUP MODEL E00A, E00B,E0A, E0B - sa!;.~ 7 s / / / '~ <> /* 7 NDENTE D PART NAMES ND CATE T HA T THESE PARTS A RE NCLUDED N PRE C E DNG A SSEMBLY SPECFY MODEL AND SERAL NUMBER OF VEHCLE WHEN ORDERNG PARTS t 700

3 HOOD & WNDSHELD GROUP MODEL E00A, E00B, E0A, E0 REF. PART REF. PART HOOD ASSY SCREW, Latch mtg LOCKW ASHER SEAL. Hood PLATE. Latch LATCH, ,..... NUT. Latch mtg PUSHNUT. Hinge... PLATE, Mounting.... RVET, Mounting plate..... PLUG, Housing PN, Hinge DOOR. Gas tank COVER. Hinge..... WASHER. Nut , SPRNG, Gas tank door..... SPACER, Hinge ACORN NUT SPRNG WASHER, Lever.... CLP. Rod to leve r SPACER, Leve r pivot..... TRM PLATE CLEVS, Headlight CLEVS PN COTTER PN..., ROD. Headlight actuator SCREW, Headlight bracket.... WASHER, Bracket BRACKET, Headlight mounting LOCKNUT SPACER. Lever SPRNG WASHER. Lever.... LEVER Housing STOP PLATE SHOULDER SCREW, Arm to lvr. PVOT ARM ASSY SCREW, Arm to housing * 9 SPACER. Pivot arm STEP BOLT PLATE. Hinge CLAMP, Cable. headlight LOUVER. R.H HEADLGHT HOUSNG BRACKET, Lever mounting WASHER. Lever bracket LEVER Headlight BUM, Housing WASHER, Lever RETANNG RNG, Headlight HARNESS ASSY, Headlight... 9 CLAMP. Cable SCREW. Lever mounting SCREW, Restraint WASHER, Restraint RESTRANT. Hood PLATE, Warning WNDSHELD TRM TRM. Windshield HEADLGHT , 0 LOCKNUT WASHER, WASHER WASHER RAVL NUT......,, SCREW, Windshield CLP. Windshield. L. H CLP. Windshield, R.H WASHER. Windshield.... SPACER. Clip mounting LOCKNUT. Clip REFLECTOR, Amber LOUVER, L.H DECAL SET *Not Shown NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY ORDER ALL PARTS FROM YOUR LOCAL AUTHORZED DEALER

4 SK & STEERNG GROUP MODEL E00A, E00B, E0A, E0B / ;.,/ 9... ~ / // / r--, _... lf / L g J L..J "'--- 0 >r rr j ~ 9 NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY SPECFY MODEL AND SERAL NUMBER OF VEH CLE WHEN OR DERNG PARTS 70

5 SK & STEERNG GROUP MODEL E00A, E00B,E0A,E0B REF. PART REF. PART QTY PEB ASSY STRG COL ASSY, Upper STRG COL ASSY, Upper.... STRG COL ASSY, Lower.... LOCKNUT / LOCKNUT / CUSHON ASSY, Handlebar.... THROTTLE LEVER ASSY.... CLP, Cable to column CABLE ASSY, Throttle.... SCREW, Saddle to column..... LOCKNUT, Cushion mounting.. CABLE ASSY, Brake.... BUSHNG, Column.... SCREW, Support to engine..... GRP, Handle SUPPORT, Steering column... LOCK, Brake lever..... SUPPORT, Strg col, upper.... NUT, Brake cable LOCKWASHER, Yoke.... JAM NUT, Yoke.... LOCKW ASHER, Saddle to col.. NUT, Saddle to column.... U-BOLT, Saddle..... WASHER, U-bolt WASHER, Strg col, upr to lwr.. RUBBER MOUNT ASSY NUT, Tie rod to ball joint.... ARM, Steering COTTER PN RETANNG BAR ROD, Column to arm.... BRAKE LEVER ASSY.... LOCKW ASHER, Sprt to engine.. LOCKNUT NTERMEDATE LEAF..... SCREW, Arm to column SPRNG, Brake r eturn.... YOKE, Bushing, upper.... BALL JONT YOKE, Bushing, lower COTTER PN, Nut PN, Grip mtg RETANNG RNG, Cable..... SK COLUMN, R.H....., PLATE, Wear SK ASSEMBLY RUNNER, Ski WASHER, Ski to runne r.... NUT, Ski to runner RETANNG PN, Rear.... RETANNG PN, Front.... SK COLUMN, L.H.... SPACER, Lever mounting.... SCREW, Grip mounting.... MAN LEAF.... CENTER LEAF TOP LEAF SADDLE & PN ASSY.... LOCKNUT.... UP MOUNT, Column.... LOWER MOUNT, Column.... BUSHNG ASSY, Strg column.. BUSHNG, Uppe r.... BUSHNG, Lowe r.... LOCKNUT, Arm to column... NUT, Throttle cable.... WASHER, Ski column WASHER, Ski column.... SPRNG WASHER, Column.... COTTER PN, Retaine r.... LOCKW ASHER, Retainer.... SCREW, Rtnr to strg column.. LOCKWASHER, Brkt to support SCREW, Brkt to support.... WASHER, Brkt support NUT, Brkt to support.... RETANER, Strg column.... BUSHNG, spring mtg.... STOP, Ski.... THRUST BEARNG WASHER Use with lower column having / " mounting studs Use with lower column having / " mounting studs NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY ORDER ALL PARTS FROM YOUR LOCAL AUTHORZED DEALER

6 NSTRUMENT PANEL GROUP MODEL E00A,E00B,E0A,E0B '~a ' ' NDENTED PART NAMES NDCAT E THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMB LY SPECFY MODEL AND SERAL NUMBER OF VEHCLE WHEN ORDERNG PARTS 70

7 NSTRUMENT PANEL GROUP MODEL E00A, E00B, E0A, E0B REF. PART L REF. PART t 7 tts t tt0 tt tt t * L EAD, Ground to switch... METAL CAL, Primer pump METAL CAL, Neutral lockout. METAL CAL, Comp relief. METAL CAL, Choke.. METAL CAL, Reverse ME TAL CAL, gnition & lights METAL CAL, Lighter... METAL CAL, Blank..... NSTR PANEL DOOR, nstrument panel.... METAL CAL, Start instr. PUSHNUT, Hinge APPLQUE, Panel PUSHNUT, Applique... HNGE PN, Door SPRNG, Door BUSHNG, Starter rope..... LOCKWASHER.... NUT LEAD, Ground LGHTER SOCKET ASSY.. LGHTER ASSY PLUG, Lighter hole GNTON SWTCH..... KEY NUT, Switch SPACER, Switch LOCKWASHER, Switch.... LOCKWASHER NUT CHOKE CABLE ASSY..... NUT, Choke cable LOCKWASHER, Choke cable tt tt 909 tt 00 tt 0 t t 099 tt COMPR RLSE CABLE ASSY... PRMER CABLE ASSY.... NUT, Neutral lockout cable. SEAL, Column to panel.... BRACKET CLAMP, Neutral cable.... JAM NUT, Primer cable... AR DUC T ASSY SEAL SEAL SEAL SEAL SEAL.... SEAL CLAMP, Brake cable.... WASHER, Panel to bracket. SCREW, Panel to frame... LOCKNUT, Panel to frame... BOOT, Lighter..... STRP ASSY WASHER, Screw, panel... RVET, Strip assy..... FUE L GAUGE ASSY BRACKET, nst r panel..... CLAMP, Wire harnes s & hos e.. NEUTRAL LOCKOUT CABLE.. SCREW, Panel to bracket.... LOCKW ASHER, Panel to brkt.. NUT, Panel to bracket..... LEAD ASSY, Lighter to s ol... TERMNAL FUSE, 0 amp LOCKW ASHER, Lead..... NUT, L ead NUT, Neutral lockout cable.... WASHER, P anel to brkt tmanual start only ttelectric start only *For each replacem ent _key, send vehicl e model number and $. 0 to: Stevens Experimental Co., Greenwood Ave., P.O. Box 9, Waukegan, ll. 00 NDENTED PA RT NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY ORDER ALL PARTS FROM YOUR LOCA L AUTHORZED DEALER 7

8 TRACK GROUP MODEL E00A, E00B, E0A, E0B.,_, \ ) ( NDENTE D PART NAMES NDCATE THAT THES E PARTS ARE NCL UDED N PREC-EDNG ASSEMBLY 70 SPECFY MODEL AND SERAL NUMBER OF V EH CLE WHEN ORDERNG PARTS

9 TRACK GROUP MODEL E00A, E00B, E0A, E0B REF. PART REF. PART TRACK, Molded.... AXLE, Rear.... CROSS SHAFT ASSEMBLY.... GASKET, C/ case to flangette.. SCREW, Truck to frame COLLAR, Axle bearing.... SET SCREW, Collar..... SCREW, Truck to frame.... RETANNG RNG RETANNG RNG, Front axle.. SPRNG, Pivot axle, L.H SPRNG, Pivot axle, R.H.... SPACER, Rear axle, center... SPROCKET WHEEL, Rear.... NUT, Rear axle pivot LOCKW ASHER, Rear axle pivot. WASHER, Rear axle pivot.... SPRNG, Rear axle, L.H.... SPRNG, Rear axle, R.H.... BUSHNG, Rear axle pivot.... PVOT ARM, L.H PVOT ARM, R. H SET SCREW, Rear spr ocket... BRACKET, Track adj, L.H.... BRACKET, Track adj, R.H.... SCREW, Rear axle pivot.... SCREW, Bracket to frame.... ANCHOR, Track adjusting RNG, Front axle L'WASHER, Brkt to frame. NUT, Bracket to frame.... SCREW, Track adjusting.... NUT, Adjusting screw.... BEARNG, Rear axle SPACER, Front axle * ARM, Truck pivot..... AXLE, Truck, rear..... SPACER, Pivot axle BUSHNG, Short SPACER, Pivot axle, outer... NUT, Truck axle SPACER, Front axle, outer... HUB & TRE ASSEMBLY... BEARNG, Wheel..... RETANNG RNG, Wheel.... AXLE, Truck, front AXLE, Track idler.... SPACER, dler wheel, outer.. DLER WHEEL SPACER, dler wheel, inner... WASHER, Bracket BEARNG RETANER.... SCREW, dler axle to frame.. SCREW, Flangette to frame... L'WASHER, Flangette to frame. SPACER, Rear axle, outer... FLANGETTE, Front axle.... BEARNG, Front axle... o FLANGETTE ASSEMBLY.... RETANNG RNG, Rear axle.. FRONT AXLE ASSEMBLY. o ROLL PN SPROCKET WHEEL... :.. AXLE, Front PLUG, Axle CHAN, 9 pitch, std.... DRVE SPROCKET, t ooth... SPACER, Front axle, center... SCREW, Flangette to c/ case... *Not Shown NDENTED PART NAMES NDCATE THAT THESE PAR]"S ARE NCLUDED N PRECEDNG ASSEMBLY ORDER ALL PARTS FROM YOUR LOCAL AUTHORZED DEALER 9

10 TRM GROUP MODEL E00A,E00B,E0A,E0B NDENTE D PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY SPECFY MODEL AND SERAL NUMBER OF VEHCLE WHEN ORDERNG PARTS 0 7 0

11 TRM GROUP MODEL E00A, E00B, E0A, E0B REF. PART REF. PART CLAMP, Taillight lead..... WASHER, Bracket GROMMET, Crossmember. CLAMP, Fuel hose to frame.. SCREW, Bracket to cushion. LOCKW ASHER, Bracket.... SEAT BACK ASSY SCREW, Strike mounting... SCREW, Bumper to bracket... LOCKWASHER BUM ASSY, Rear. STRAP & GRP KT... BACK REST ASSY..... SCREW HOUSNG, Taillight.... BULB, Taillight..... LENS, Taillight GASKET SOCKET ASSY..... RVET, Support SUPPORT, R. H SUPPORT, L. H HOOD STRKE, R.H HOOD STRKE, L.H..... L'WASHER, Cover & seat mtg ROLLER LATCH ASSY. SCREW, Latch WASHER, Latch LOCKWASHER, Roller latch SCREW, Seat to hinge.... LOCKWASHER, Bumper mtg.. SNOW DEFLECTOR.... RETANER SCREW, Deflector..... SCREW, Back rest.... LOCKSCREW, Bumper..... WASHER, Back rest..... WASHER, Bumper BOLT, Rear bumper... CLP, Taillight wire... SPEEDNUT, Back rest... WASHER, Seat to hinge.... TRM STRP L'WASHER, Back rest mtg... BUM ASSY..... LOCKWASHER, Bumper.... BRACKET, Seat cushion.... SEAT ASSEMBLY. MAN FRAME ASSY.... LOCKW ASHER, Frame... LOCKNUT, Engine frame.. WASHER, Frame ffinge, Seat NUT PLATE SCREW, Back r est mounting.. WASHER, Back rest mounting. LOCKW ASHER, Back rest mtg REFLECTOR, red NDENTED PART NAMES NDCATE THAT THESE PAR.:rS ARE NCLUDED N PRECEDNG ASSEMBLY O RDER ALL PARTS FRO M YOU R LOCA L AUTHORZ ED DEALER

12 FUEL TANK GROUP MODEL E00A,E00B,E0A,E0B 7 ', ~ ~ ~?. ~ r--\ : 0 COAT ADAPTOR THREADS WTH SEALANT 77 REF. PART REF. PART * 90 FUEL TANK ASSY, Complete.. BAR, Strap FUEL TANK ASSY.... PAD, Strap WASHER, Fitting.. 0 SCREW, Strap to fram e FTTNG, Primer NUT, Primer cable t o piston HOSE, Pickup LOCKWASHER, Cable to piston. 90 FUEL PCKUP CLAMP, Fuel hose ADAPTOR ASSY FUEL HOSE, Tank to primer NUT, Fitting SCREW, Primer t o frame WASHER FUEL HOSE, Tank t o pump CLAMP * 90 PRMER ASSY GASKET, Tank adaptor PSTON, Primer NUT PLATE GROMMET SCREW, Sender SPRNG, Primer..... NLET VALVE ASSEMB LY EXHAUST VALVE ASSY CAP ASSY END CAP, Primer WASHER PLATE RNG, Piston SENDER ASSY HEAT SHELD ASSEMBLY... 7 COVER, Sender SEAL GASKET, Sender SEAL LOCKWASHER, P rimer... 0 GROMMET, Wire HOSE, Primer t o m anifold SCREW, Heat s hield LOCKWASHER, Strap WASHER, Heat shield..... STRAP, Fuel t ank TUBE, nsulating NSTRUCTON PLATE *Not Shown NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY SPECFY MODEL AND SERAL NUMBER OF VEHCLE WHEN ORDERNG PARTS

13 SHEAVE GROUP MODEL E00A,E00B,E0A,E0B 7 0 REF. PART REF. PART * 9 PRMARY SHEAVE ASSY... 9 BRACKET, Neutral lockout BOLT, End cap PN, Bracket LOCKWASHER RECEPTACLE, Wing stud SPRNG RETANER, Wing stud FLAT WASHER SUPPORT BAR, Belt guard.. 9. PLUNGER & ROD ASSY WNG STUD, Guard to frame... END CAP ASSY BELT GUARD SPRNG, Activating DRVE BELT SLDNG SHEAVE ASSY SCREW, Brake to sheave... 9 SPRNG, Primary LOCKWASHER, Brake to sheave 0. CUP, Spring BRAKE DSC BEARNG, Drive belt FXED SHEAVE ASSY BALL, Neutral lockout... 9 MOVABLE SHEAVE ASSY MAN SHAFT & SHEAVE WOODRUFF KEY WEAR DSC... 7 SLEEVE, Sheave LOCKPLATE SPRNG, Sheave. 0 COTTER PN... 0 SHOE, Drive ramp SCREW CAP, Spring SPRNG WASHER, Cap COTTER PN LOCKWASHER, Tab EMERGENCY STARTER ROPE. 79 SCREW, Sleeve LOCKWASHER, Actuator RETANER, Wing stud... 0 SCREW, Actuator mounting REC EPT AC LE, Wing stud ACTUATOR, Lockout WNG STUD, Belt guard.... *Not Shown NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY ORDER ALL PARTS FROM YOUR LOCAL AUTHORZED DEALER.707

14 TRANS.MSSON GROUP MODEL E00A, E00B, E0A, E0B t t) 9 - (i] ' ' NDENTED PART NAMES NDCATE THAT T HESE PARTS A RE NCLUDED N PREC E DNG ASSEMBL Y SPECFY MODEL AND SERAL NUMBER OF VEHCLE WHEN ORDERNG PARTS 7

15 TRANSMSSON GROUP MODEL E00A, E00B, E0A, E0B REF. PART NO. REF. PART ASSY. t ~ * 97 * ' *Not Shown TRANSMSSON & CASE ASSY. TRANSMSSON & CASE ASSY. HOUSNG, Transmission. B EARNG, nner SEAL, Housing to shaft CHAN CASE ASSY CHAN CASE ASSY KEY, Output gear. BRACKET, Spring retainer WASHER, Link. WAVE WASHER NUT, Link SCREW, Link. SCREW, Lockplate. RETANNG RNG BEARNG, Oute r. GEAR AND SHAFT, nput NEEDLE BRG, Shaft, o ute r LNK, Shift lever. COTTER PN. WASHER, Link. SHFTER DOG CRADLE, Shifter dog PN, Link WASHER, Shifter dog SPRNG, Shifter dog RETANNG RNG, Output shaft GEAR, Output SHAFT, Output. RETANNG RNG, nput shaft. RETANNG RNG BALL BRG, Output shaft END CAP ASSY LOCKWASHER. LOCKWASHER. SCREW. SCREW. PPE P LUG, Fill and drain SCREW, Cl evis. SHFTER CLEVS PNON, Reverse idler.. BEARNG, Reverse idler THRUST WASHER, Rev idle r THRUST WASHER, Rev idler SHM,.00" SHM,.00" SHM,.00" 0 - RNG, Shaft to housing SHAFT, Pinion gear RETANNG RNG, Shaft. P VOT PLATE. LOCKWASHER, Plate to h sg SCREW, P late to housing PN, Cl evis to plate CLEVS, Reverse lock. NUT, Eye bolt EYE BOLT. LOCKPLATE.. SCREW. SPACER, Output gear GASKET, C/case to housing. GASKET, C/case to housing. "A" Model s "B" Models 9 PLUG, Breathe r 0 CLAMP, C/case cover SEAL, Cover to c/casc. 0 SCREW, C/case to fram e 9 7 PPE PLUG, Chain case 0 97 COTTER PN, Pivot pin 009 WASHER, Pivot pin. 0 PVOT PN, Brake control. 90 SUPPORT ROD. 7 SCREW, Sprocket to s haft WASHER, Sprocket to shaft 79 SPRNG, Linkage. 7 0 L/WASHER, Brake to pedestal.. 0 SCREW, Brake to housing 9 7 WASHER, Sprocket NUT, Rod to trans 7 79 SPROCKET, tooth, std * 909 CAL BRAKE ASSY 7 PN, Cam limit 7 9 CAM, Caliper brake 7 7 BRACKET, Caliper brake 7 PUCK, Brake.07" 7A PUCK, Brake.9" 7 WASHER, Puck back-up t77 COTTER P N, Cam to body 7 SPACER, Caliper brake br kt 79 THRUST WASHER 0 7 LOCKNUT SCREW, Hex he ad cap t 0 BODY, Cam side. tt BODY, Cam side. 70 BODY, Carrier side P N, Caliper brake. SPRNG, Brake cam 9 t NUT, Castellated. tt 0 NUT, Vibresist. 9 7 BASE & SHAFT, dler PLATE, Chain idler NUT, Handle to r od SHFT ROD ASSY SCREW, P late to c/case 9 BEARNG, dler sprocket SHFT HANDLE ASSY 9 SPROCKET, dler AR 9 07 RETANNG RNG AR 9 SCREW, dler adjustment AR NUT, dler adjustment RNG, dler screw SUPPORT BRACKET SCREW, Support bracket LOCKWASHER 0 0 WASHER, C/case to frame SCREW, C/case to frame 0 COVER, Chain case 0 PLUG. 0 9 PLUG, Breather LOCKWASHER, Cover to c/case. 0 SEAL, C/ case to frame WASHER, Support bracket l 0 00 SCREW, Cover to c/case 09 WASHER, T ic rod 07 SCREW, Clamp. tearly Production Models Only ttlate Production Models Only l l NDE NTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY ORDER ALL PARTS FROM YOUR LOCAL AUTHORZED DEALER

16 GNTON SYSTEM MODEL E00A, E00B, E0A, E0B N \ N o -.. ~y!~-\-clllllllll==~ NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY SPECFY MODEL AND SERAL NUMBER OF VEHCLE WHEN ORDERNG PARTS 70

17 GNTON SYSTEM MODEL E00A, E00B, E0A, E0B.. REF. PART REF. PART 0 COVER & DECAL..... * 07 NUT, Cable GASKET..... *7 0 LOCKWASHER, Ground stud LEAD ASSY, Ground..... * 0799 LOCKWASHER, Ground stud TERMNAL *9 9 CAP, Battery TERMNAL *0 HOOK, Hold down GROMMET * 0 WASHER, Hold down COL ASSY, Long * 907 HOLD DOWN, Battery COL ASSY, Short * 9 COVER, Battery box TUBNG, Long * 9 BATTERY BOX TUBNG, Short... COVER, Elect components RNG, Terminal SCREW, Cover mounting GROMMET NUT, Cover to frame TERMNAL WASHER, Cover to frame SPRNG, Terminal WASHER, Cover & panel BOOT, Spring, terminal LOCKWASHER, Stator... SPACER, Coil mounting SCREW, Stator POWER PACK ASSY * 09 STATOR ASSY, Battery... SCREW, Terminal ** 099 STATOR ASSY, Lighting SCREW. Cover TERMNAL NUT, Coil & pack mounting TERMNAL LEAD ASSY, Ground TERMNAL GROMMET. ~ GROMMET... GROMMET *7 00 TERMNAL PANEL ASSY * 00. TERMNAL... 0 CLAMP, Battery cable ** 09 TERMNAL WASHER, Clamp **9 0 TERMNAL... 0 NUT, Clamp MOUNTNG PLATE & SENSOR 99 SLEEVE, Battery cable SLEEVE.. *7 00 LOCKWASHER, Rectifier TERMNAL.. * 7 SCREW, Rectifier GROMMET... *9 0 RECTFER ASSY ROTOR & MAGNET.... *0 09 SOLENOD ASSY ". 7 WAVE WASHER, Rotor... * 0009 SCREW, Solenoid KEY, Rotor to flywheel... * 007 WASHER, Solenoid FLYWHEEL ASSY... * 00 LOCKW ASHER, Stud LOCKWASHER, Flywheel... * 09 NUT, Stud NUT, Flywheel.. * LEAD, Ground, rectifier CLAMP, Solenoid.. * LEAD, Rectifier to solenoid.. 07 CONNECTOR... **7 00 PLUG GASKET, Panel... *7 00 GROMMET... * 0 NUT, Terminal... * 9U9 WRNG HARNESS.... * 09 LOCKW ASHER, Terminal.. ** 909 WRNG HARNESS SCREW, Plate mounting. *9 909 CABLE ASSY, Sol to starter. 09 CLAMP, Wire harness * CABLE ASSY, Sol to battery. 7 0 SCREW, Clamp... * BOLT, Positive terminal LOCKNUT, Clamp... * 0 NUT, Hold down CLAMP, Wire harness& s leeve * 0 NUT, Cable & stud SLEEVE, Leads... * 907 BATTERY CABLE, Negative SPACER, P/ pack mounting. * 9 BOLT, Negative t erminal SCREW, Panel mtg_ LOCKWASHER, Panel... *El ectric models only **Manual models only 7 NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY ORDER ALL PARTS FROM YOUR LOCAL AUTHORZED DEALER 7

18 ELECTRC STARTER GROUP MODEL E0A, E0 7 :"-j //- 0 / / 9 ~~f r- --_ -- 7 ~ l (gl 0 ~ 9/ 7 REF. PART REF. PART * *Not Shown STARTER MOTOR ASSY.... THRU BOLT PACKAGE... ARMATURE... 7 HEAD, Commutator end.... HEAD, Drive end BEARNG, Drive end BRUSH PLATE SPRNG SET, Brush FELD COL ASSY TERMNAL STUD PKG..... THRUST WASHER PKG.... BRUSH SET BELT, Starte r drive ADJ BRKT, El ec s tarter..... PULLEY, Fixed, elec starter PULLEY, Movable, elec starter SPROL PN, Pulley to s tarter SPROL PN, Pulley to starter LOCKWASHER BRACKET ASSY, Starter mtg.. SCREW, Starter to brkt WASHER, Adj brkt to starter.. SCREW, Bracket mtg SCREW, Adj brkt to rear fan hsg SCREW, Adj brkt to starter... LOCKWASHER, Adj brkt... LOCKWASHER, Brkt mtg NUT, Bracket mtg STUD, Belt guide NUT, Belt guide stud SPACER, Bracket SCREW Bracket mtg NDENTED PART NAMES ND CATE THAT THESE PARTS A RE NCLUDED N PREC EDNG ASSEMBLY SPECFY MODEL AND SERAL NUMBER OF VEHCLE WHEN ORDERNG PARTS

19 REWND STARTER GROUP MODEL E00A, E00B,E0A,E0 ~~~ i 0 0 )J.. 7 ~ "!J ()0@ ~~~.-... ~ REF. * PART REF. PART 970 REWND STARTER ASSY... 7 SPACER 0 NUT, Housing to pulley..... SCREW, Hsg to pulley 0. 0 LOCKWASHER 0 0 t ROPE, Starter WASHER STARTER HSG ASSY SPNDLE & PN ASSY HANDLE SPRNG WASHER BUM, Handle FRCTON RNG RATCHET BUSHNG, Spindle MOUNT, Ratchet SCREW, Retainer to pulley.. 0 SCREW, Mount RETANER LOCKWASHER PAWL SCREW, Mount STARTER PULLEY ASSY SCREW, Starter hsg 0 7 STARTER SPRNG ASSY... 0 LOCKW ASHER, Mount *Not Shown tcut from 00' roll 70, cutting length 7-/ " NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY ORDER ALL PARTS FROM YOUR LOCAL AUTHORZED DEALER 9

20 ENGNE GROUP MODEL E00A,E00B,E0A,E0B NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASS EMBLY SPECFY MODEL AND SERAL NUMBER OF VEHCLE WHEN ORDERNG PARTS 0.707

21 ENGNE GROUP MODEL E00A E00B E0A E0B REF. PART REF. PART ** 9 * ~ CRANKCASE ASSY SCREW, C/ case SCREW, C/ case... SCREW, Engine mounting.... LOCKWASHER, Engine mounting LOCKWASHER, C/case halves FRAME, Engine mounting... SCREW, Frame mounting... WASHER, Frame mounting. LOCKWASHER, Housing screw. SCREW, Housing to c/ case.. GASKET, Crankcase.... FAN HOUSNG, Outer.... FAN HOUSNG, Outer.... CLP, Magneto lead.... SCREW, Front to rear housing PLUG, Fan housing... ROLL PN FAN HOUSNG, nne r... GASKET, Bottom..... SCREW, Shroud.... SHROUD & PLATE, Rear... PLATE, Reinforcement. SHROUD & PLATE, Front. PLATE, Reinforcement... SPARK PLUG, Champion UJ-J CYLNDER & STUD.... STUD STUD, Exhaust manifold... LOCKWASHER, Cylinder... GASKET, Cylinder. RNG SET, Piston PSTON & PN ASSY... WRST PN RETANNG RNG, Pin... NEEDLE BRG ASSY, Wrist pin. CONNECTNG ROD ASSY.... SCREW RETANER ASSY, Rod bearing BEARNG ASSY, Connecting rod SEAL, Crankshaft..... CRANKSHAFT, Brg & shim. BEARNG, Cranks haft.... BEARNG, Crankshaft... VALVE, Compression relief. 0-RNG PLUG, Compression..... NUT, Cylinder...,... SEAL, Crankshaft.... KEY, Cam & flywheel... CLAMP, Fuel gage cable.... GASKET SET. *Electric Start **Manual Start +Not Shown NDENTED PART NA MES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY ORDER ALL PA RTS FROM YOUR LOCAL AUTHORZED DEALER

22 CARBURETOR ASSEMBLY GROUP MODEL E00A, E00B, E0A, E0B o - J NDENTED PART NAMES NDCATE THAT THES E PARTS (\RE NCLUDED N PRECED NG ASSEMBL Y SPECFY MODEL AND SERAL NUMBER OF VEHCLE WHEN ORDERNG PARTS 7

23 CARBURETOR ASSEMBLY GROUP MODEL E00A, E00B, E0A,E0B REF. PART REF. PART * t t t7 9 0 tll t7 t 9 0 t t t t t7 t 9 t0 t t t 7 t CARBURETOR ASSY, Complete WELCH PLUG WELCH PLUG BALL, Choke friction SPRNG, Choke friction.... LEVER & CHOKE SHAFT... SCREW, Choke wire rtnr... SHUTTER, Choke.... VALVE, Choke SPRNG, Choke valve SCREW, Throt & choke shutter DAPHRAGM..... COVER, Diaphragm SCREW, Diaphragm cover... GASKET, Diaphragm CHECK BALL FLANGE GASKET.... SCREW, dle mixture.... SPRNG, Screw, idle mixture. WASHER, Scr, idle mixture.. PACKNG, Mixture s c r ew... SCREW, dle speed SPRNG, Screw, idle speed.. BRACKET, Scr, idle speed.. SCREW, dle speed brkt.... LEVER, nlet control..... LEVER PN, nlet control... SCREW, nlet control lever.. SEAT & GSKT, nlet needle.. SEAT GASKET, nlet SPRNG, nlet tens ion SCREEN, nlet SCREW, High speed mixture GLAND SCREW GASKET, Gland screw.... SCREW, Throt shaft clip rtnr. SPRNG, Throt shaft r etur n.. SLEEVE, Throttle shaft.... MAN FUEL J ET (.09).... GASKET, Main fuel jet..... NOZ ZLE, Check valve..... SHAFT & LEVER, Throttle.. CLP, Throttle s haft.... LOCKW ASHER, Clip THROTTLE VALVE HOUSNG, Air cleaner SCREW, ntake manifold * LOCKW ASHER, ntake manifold. 00 LOCKWASHER, Carb. to manf 0 SCREW, Housing to carb WASHE R, Housing mounting... 0 SCREW, Cable to carburetor... 0 HOSE CLAMP ELBOW, Hose to tank GASKET, Carburetor NUT, Carburetor... 0 CAP, Air cleaner SCREEN, Air cleaner FLTER, Air cleaner GASKET, Air cleaner KNOB, Carburetor adjusting... MANFOLD, ntake... 0 CHECK VALVE ASSEMBLY WASHER, Check valve.... SPRNG, Check valve..... FUEL PUMP ASSEMBLY CAP SCREEN GASKET SCREW SCREW GASKET, Fuel pump NUT PLATE, Fuel pump mtg HOSE, Pulse line PVOT PN, Leve r LEAF PL & BASE ASSY.... L EAF PLATE ASSEMBLY SCREW, Leaf stop GASKET, Leaf plate to base.. BASE, Leaf plate SCREW, Base to leaf plate... GASKET, ntake manifold ELBOW, Fuel hos e SCREW, Fuel pump mounting.. SCREW, Carburetor m ounting.. 0 HOSE CLAMP, Fuel pump... 9 WASHER, Pin HOSE, P um p to car buretor GROMMET CLAMP, Fuel return hose ELBOW, Pulse line COTTER PN, Lever HOSE, Carburetor to tank ELBOW, Puls e line *Not Shown talso available in Carburetor Repair Kit 909 NDENTED PART NAMES NDCA T E THAT THESE PART S ARE NC L UDE D N PRE CE DNG ASSEMBLY ORDER ALL PARTS FROM YOUR LOCAL AUTHORZED DEALER

24 EXHAUST SYSTEM MODEL E00A, E00B, E0A, E0B J (!)-- --< ) 707 REF. PART REF. PART MUFFLER ASSY..... BRACKET, Muffler..... WASHER, Muffler bracket... NUT, Muffler bracket... LOCKWASHER, Muffler brkt. WASHER, Bracket to frame... LOCKNUT, Bracket to frame.. EXHAUST MANFOLD, Front CLAMP, Exhaust pipe EXHAUST PPE, Front EXHAUST PPE, Rear.. 0 NUT, Manifold. 0 LOCKWASHER, Manifold GASKET, Exhaust manifold EXHAUST MANFOLD, Rear. NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY SPECFY MODEL AND SERAL NUMBER OF VEHCLE WHEN ORDERNG PARTS

25 ACCESSORY SLEGH GROUP MODEL E00A, E00, E0A, E0B ~ 7.0 REF. PART REF. PART * SLEGH ASSY, Complete LOCKWASHER, Body to frame. PLUG BUTTON, Windshield 7 FRAME ASSY frame.... " SEAT ASSY SCREW, Body to frame BODY ASSY... WASHER, Body to frame LOCKW ASHER, Seat to body SCREW, Seat to body * 90 HTCH KT... NUT, Body to frame CLEVS ASSY WASHER, Body to frame NUT, Bracket TRANSFER, Sleigh-mate SCREW, Bracket.... COTTER PN, Ski to frame.. 90 BRACKET ASSY... SPRNG, Ski WASHER, Clevis... SADDLE, Spring HAR PN, Clevis pin... BUSHNG, Ski spring SPACER, Hitch SK & RUNNER ASSY CLEVS PN RUNNER ROLL PN, Clevis WASHER, Runne r to ski... 7 WNDSHELD ACCESSORY KT.. NUT, Runner to ski... 9 WNDSHELD NUT, Saddle to spring... THUMB SCREW SCREW, Saddle to spring WNG NUT RETANNG PN ASSY SCREW, Windshield to frame. RETANNG PN ASSY WASHER WELL NUT *Not Shown NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY ORDER ALL PARTS FROM YOUR LOCAL AUTHORZED DEALER

26 ACCESSORES MODEL E00A, E00B,E0A,E0B SPEEDOMETER KT- 907 REF. PART 9 SPACER, Applique NUT, Applique DRVE CABLE SPEEDOMETER CORE, Speedom et e r ANGLE DRVE JONT PLUG, Axle coupling.... ~-- 'lj HGH ALTTUDE DRVE KT -7 REF. PART 07 END CAP & PULLEY ASSY SPRNG, Actuating... TACHOMETER KT REF. PART 7 TACHOMETER CORE, Tachometer DRVE CABLE NUT, Applique GROMMET, Air duct ANGLE DRVE JONT CLUTCH BUSHNG DRVE MOUNT SPACER, Applique ~ 7079 NDENTED PART NAMES NDCATE THAT THESE PARTS ARE NCLUDED N PRECEDNG ASSEMBLY SPECFY MODEL AND SERAL NUMBER OF VEHCLE WHEN ORDERNG PARTS

27 EVNRUDE TRALBLAZER PARTS CATALOG ;, EVNRUDE MOTORS MLWAUKEE, WSCONSN