Symbol Key NOTES: E C-1* T T T. Termovar Option 2

Transcription

1 ioeat US 4 ritton Lane Lyme, N rawn by: TSP hecked by: ioeat US Piping Layout oncept iagram Wood oiler (Up to 140,000tuh) with ossil uel oiler and STSS ladder Type Tank ate W NO RV STSS1 6 SL N/ ST 1O 1 T Symbol ey irculator w/ solation langes irculator w/ nternal heck Valve solation langes all Valve entral ir Seperator Switch ontrol ΔP ifferential Pressure ypass Valve Swing heck Valve Weighted heck Valve ackflow Preventer Termovar Tempering Valve rain Valve Termovar iverter Valve utomag UTOM Wood oiler utomag UTOM # L TV * Termovar Option Supply ZV1 TV L * Vent P-1 P- P-3 eating ircuits (Typical) STSS eat Storage Tank System W nti-scald Mixing Valve ossil uel oiler NOTS: quastat-oneywell L4006 or quivalent L4006 mergency ravity low Overheat Loop Needs to be 10% of Wood oiler Output Weighted heck Valves Used as eat Traps Termovar Mixing Valve ( Options vailable) Termovar iverter Valve Termovar it-6440 irculator Switch Relay-Typical ontroller ioeat US Switch ontrol LTONTROL ackup oiler ontrol oneywell quastat L4008 or quivalent alancing Valve Required. (Start with Valve losed halfway, i.e., at 45 degrees) nti-scald Valve needs to be installed below tank s water line or swing check installed on cold water line to prevent hot water from entering cold water mtrol 60 or quivalent xpansion Tank is Suitable for most Solo Plus nstallations up to 86 gallons *irculator Notes: -3 and -1 irculator Sizing: (Multi-Speed irculator Recommended) -10' coils-taco 007 or quivalent. -180' coils-taco 010 or quivalent ' coils-taco 010 or quivalent. Wood oiler Termovar Loading Unit 483S Return This is only a concept drawing. inal design, installation and code compliance

2 ioeat US 4 ritton Lane Lyme, N rawn by: TSP hecked by: ioeat US Piping Layout oncept iagram Wood oiler (175,000-00,000tuh) with ossil uel oiler and STSS ladder Type Tank ate W NO RV STSS 6 SL N/ ST 1O 1 Switch ontrol T Symbol ey irculator w/ solation langes irculator w/ nternal heck Valve solation langes all Valve ΔP entral ir Seperator ifferential Pressure ypass Valve Swing heck Valve Weighted heck Valve ackflow Preventer Termovar Tempering Valve rain Valve Termovar iverter Valve utomag UTOM P-1 P- P-3 eating ircuits (Typical) NOTS: quastat-oneywell L4006 or quivalent L4006 mergency ravity low Overheat Loop Needs to be 10% of Wood oiler Output Weighted heck Valves Used as eat Traps Termovar Mixing Valve ( Options vailable) Wood oiler utomag UTOM L TV-1-3 * Termovar Option Supply ZV1 TV L6008-1* 1 Vent STSS eat Storage Tank System W nti-scald Mixing Valve ossil uel oiler Termovar iverter Valve(See ulletin #Termovar6440.pub) Termovar it-6440 irculator Switch Relay-Typical ontroller ioeat Switch ontrol LTONTROL ackup oiler ontrol oneywell quastat L6008 or quivalent alancing Valve Required. (Start with Valve losed halfway, i.e., at 45 degrees) nti-scald Valve needs to be installed below tank s water line or swing check installed on cold water line to prevent hot water from entering cold water mtrol 60 or quivalent xpansion Tank is Suitable for most Solo Plus nstallations up to 86 gallons *irculator Notes: -3 and -1 irculator Sizing: (Multi-Speed irculator Recommended) -10' coils-taco 007 or quivalent. -180' coils-taco 010 or quivalent ' coils-taco 010 or quivalent. Wood oiler Termovar Loading Unit 483S Return This is only a concept drawing. inal design, installation and code compliance

3 ioeat US 4 ritton Lane Lyme, N ioeat US Piping Layout oncept iagram Wood oiler (Up to 00,000tuh) with ossil uel oiler and Pressure Tank Thermal Storage eating ircuits (Typical) rawn by: TSP hecked by: ate W NO RV PT1 3 SL N/ ST 1O 1 P-1 P- P ZV1 TV LTONTROL utomag UTOM L4008 T T Three Tank onnections L #483S Wood oiler Pressure Tank Thermal Storage System ossil uel oiler irculator w/ solation langes all Valve Weighted heck Valve ackflow Preventer Symbol ey entral ir Seperator rain Valve Pressure/Temperature auge SSTM NOTS: oneywell quastat L4006 ioeat L4006-Used Only for the Solo Plus oiler mergency ravity low Overheat Loop-Needs to be 10% of Wood oiler Output ioeat US Switch ontrol LTONTROL irculator Switch Relay-Typical ontroller ackup oiler ontrol oneywell quastat L4008 or quivalent Termovar Loading Unit 483S Termovar iverting Valve xpansion Tank Sizing- Thermal Tanks-mtrol S90V or quivalent 3 Thermal Tanks-mtrol S110V or quivalent TN NOTS: Single Tank onnections Sizing: Tanks for boilers up to 140,000tuh 3 Tanks for oilers 175,000-00,000tuh The Tanks should be located next to each other and as close as possible to the boiler. onnections to the tanks must use approximately the same length pipe. This is accomplished by: 1. onnect the boiler connections diagonally, -.. onnect the radiator connections diagonally, -. This is only a concept drawing. inal design, installation and code compliance

4 ioeat US 4 ritton Lane Lyme, N ioeat US Piping Layout oncept iagram Wood oiler (Up to 00,000tuh) with ossil uel oiler and Pressure Tank Thermal Storage LTONTROL T eating ircuits (Typical) rawn by: TSP hecked by: ate W NO RV PT 4 SL N/ ST 1O 1 Switch ontrol P-1 P- P-3-1 ZV1 3 1 utomag UTOM L4008 P-4 P-5 L #483S Wood oiler irculator w/ solation langes all Valve Weighted heck Valve ackflow Preventer Symbol ey entral ir Seperator rain Valve Pressure/Temperature auge Pressure Tank Thermal Storage System SSTM NOTS: oneywell quastat L4006 L4006-Used Only for the Solo Plus oiler mergency ravity low Overheat Loop-Needs to be 10% of Wood oiler Output ioeat US Switch ontrol LTONTROL irculator Switch Relay-Typical ontroller ackup oiler ontrol oneywell quastat L4008 or quivalent Termovar Loading Unit 483S Termovar iverting Valve xpansion Tank Sizing- Thermal Tanks-mtrol S90V or quivalent 3 Thermal Tanks-mtrol S110V or quivalent TN NOTS: ossil uel oiler ndirect Water eater Sizing: Tanks for boilers up to 140,000tuh 3 Tanks for oilers 175,000-00,000tuh The Tanks should be located next to each other and as close as possible to the boiler. onnections to the tanks must use approximately the same length pipe. This is accomplished by: 1. onnect the boiler connections diagonally, -.. onnect the radiator connections diagonally, -. ollow the same guidelines for a single or two tank configuration. This is only a concept drawing. inal design, installation and code compliance

5 ioeat US 4 ritton Lane Lyme, N rawn by: TSP hecked by: ioeat US Piping Layout oncept iagram Wood oiler with ossil uel oiler and Square ladder Type Tank ate W NO RV SquareTank 1 SL N/ ST 1O 1 T Symbol ey irculator w/ solation langes irculator w/ nternal heck Valve solation langes all Valve entral ir Seperator Switch ontrol ΔP ifferential Pressure ypass Valve Swing heck Valve Weighted heck Valve ackflow Preventer Termovar Tempering Valve rain Valve Termovar iverter Valve utomag UTOM Wood oiler # L4006-3* 3 1 TV Termovar Option TV- ZV * P-1 P- P-3 eating ircuits (Typical) ossil uel oiler old Supply NOTS: quastat-oneywell L4006 or quivalent L4006 mergency ravity low Overheat Loop Needs to be 10% of Wood oiler Output Weighted heck Valves Used as eat Traps Termovar Mixing Valve ( Options vailable) Termovar iverter Valve Termovar it-6440 irculator Switch Relay-Typical ontroller ioeat US Switch ontrol LTONTROL ackup oiler ontrol oneywell quastat L4008 or quivalent alancing Valve Required. (Start with Valve losed halfway, i.e., at 45 degrees) mtrol 60 or quivalent xpansion Tank is Suitable for most Solo Plus nstallations up to 86 gallons utomag UTOM Supply L4008 Square eat Storage Tank System To ouse W onnections *irculator Notes: -3 and -1 irculator Sizing: (Multi-Speed irculator Recommended) -10' coils-taco 007 or quivalent. -180' coils-taco 010 or quivalent ' coils-taco 010 or quivalent. Wood oiler Termovar Loading Unit 483S Return This is only a concept drawing. inal design, installation and code compliance W

6 ioeat US 4 ritton Lane Lyme, N rawn by: TSP hecked by: ioeat US Piping Layout oncept iagram an-oil/ir andler Supplemental Plumbing iagram ate W NO RV anoil 1 SL N/ ST 1O 1 Symbol ey irculator w/ solation langes all Valve quastat Weighted heck Valve T rom eating System ir andler an-oil Unit rom eating System urnace NOTS: irculator Switch Relay-Typical ontroller n aquastat (oneywell L6006 or equivalent) can be used to switch on the an oil s an. Typically set to 140 º (60 º). xample Notes: ue to the many variables of furnace manufacturers, heating systems, and air handlers, control wiring and set-up needs to be installed by a qualified V professional. This is only a concept drawing. inal design, installation and code compliance