Illustrated Parts Manual

Transcription

1 Illustrated Parts Manual Beginning S/N: Effective Date: P/N

2 KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation What it Represents º (Dimension)Degrees (Angle) " (Dimension)inches (-)Negative (Polarity) (+) Positive (Polarity) ATAll-Terrain CCWCounter-clockwise Conn Connector CWClockwise D Diameter DCDeck, Collection (number refers to size in inches) DM Deck, Mulching (number refers to size in inches) DRDeck, Rear Discharge (number refers to size in inches) DSDeck, Side Discharge (number refers to size in inches) DUGarlock (Bearing) ESNA (Fastener)Nylon Insert Locknut FSC Forward Speed Control GA Gauge gal gallon GHSGrass Handling System GR (Fastener)Grade HDHeavy Duty HP Horse Power IDIdentification or Inside Diameter LLength LHLeft Hand (orientated with operator on seat) LP Low Profile mm (Dimension)millimeters MS (Fastener)Machine Screw NS (as part number) Item is not sold by Walker Manufacturing OD Outside Diameter oz ounce PFH (Fastener) Phillips Flat Head P/NPart Number PPH (Fastener)Phillips Pan Head PTH (Fastener)Phillips Truss Head PTO Power Take-Off QKSQuick Slide qtquart RH Right Hand (orientated with operator on seat) SAE (Fastener)Society of Automotive Engineers SBH (Fastener)Socket Button Head (Bolt) SDSide Discharge SFH (Fastener)Slotted Flat Head SHC (Fastener) Socket Head Cap SHL (Fastener) Shoulder (Bolt) SM (Fastener)Sheet Metal (Screw) S/N Serial Number SpgSpring SQH (Fastener)Square Head SS (Fastener) Stainless Steel ST (Fastener)Self-Tapping (Screw) Term Terminal V Volts NOTE: In some instances, combinations of abbreviations may be used (eg PPHMS - Phillips Pan Head Machine Screw) Use only genuine Walker replacement parts

3 ILLUSTRATED PARTS LIST Section of Tractor Covered Page Section of Tractor Covered Page Decals Tractor Decals2 Body / Chassis Assemblies Body / Chassis Assembly4 Rear Body Assembly6 Tractor Components Main Component Power Transmission8 Engine Group Hydrostatic Ground Drive Assemblies12 Steering Control Assemblies14 GHS Group16 GHS Powerfil Assembly (0)18 GHS 0 Bushel Catcher Assembly20 Electrical Components Electrical Assembly 22 Electrical Assemblies (GHS 0 Bushel Components)24 Electrical Connectors26 Maintenance Lubrication Points28 Wiring Schematic 30 Operator s Notes31 Warranty Limited Warranty 33 Use only genuine Walker replacement parts 1

4 TRACTOR DECALS ITEM PART DESCRIPTION LOCATION NO NO NO REQ D GHS Walker Product Decals Walker (8" Round) 0 Bushel Catcher (one on each side) Axle Lockout Chassis LH Fender Body, LH near Seat Decal, S14 Body Made in USA Body RH Fender Body, RH near Seat 1 Danger Decals Warning Decals Caution Decals Danger, Pinch Point 0 Bushel Catcher Mounting Frame Assembly 2 (one on each side) Danger, Engine Exhaust Engine Danger, Rotating Blower Blades Body, Near Body Chute 1 Maintenance Decals 5869 Removable Screen 0 Bushel Catcher Removable Screen Important, Engine Cooling Engine Fuel Recommendations Engine Oil Reservoir Reservoir Cap (one on each) PTO Alignment Arrow Universal Joint Tube Assembly 1 NOTE: All parts requiring decals are shipped with decals applied 2 Use only genuine Walker replacement parts

5 TRACTOR DECALS < Decks Parts Manual for Deck Decals Use only genuine Walker replacement parts 3

6 BODY / CHASSIS ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Seat Assembly 1 53 Seat Compression Spring Retainer Washer Washer (3/8 x 1-1/4 x 1/4) Rubber Bumper (135 x 50) Shock Mount (1-1/4 x 3/4) 2 Rear Bumper Assembly Catcher Pivot Bushing Rear Bumper Catcher Pivot Plate Roller Wheel (5" Rubber) 2 Body Assembly Leaf Spring Welded Body Body Guide, Upper Rubber Bumper (125 x 250) 2 15 NS Body ID Plate Edge Molding, Lever Opening Hinge (19") 1 Tilt-Up Latch Assembly** Plastic Tip Spring Arm, Tilt-Up Latch Spring Pivot Bushing Compression Spring (3/8 x 5/8) Mount Angle, LH Hook, Tilt-Up Latch Mount Angle, RH 1 Chassis Assembly Chassis Side Cover, RH Chassis Frame Retainer Collar (1") 1 (Includes Item # F413) Pivot Bearing Tail Wheel Fork Bearing, Tail Wheel Tail Wheel & Tire Assembly (13 x 650-6) Tail Wheel Tire (13 x 650-6) * 5036 Tail Wheel & Hub (6 x 45) * Axle Spacer Tube (6-5/8) Chassis Side Cover, LH mm Ball Stud Gas Spring Assembly 1 (Includes Item # 34) Body Latch Hook Plastic Tip, Red Extension Spring (1/4 x 3) Body Guide, Lower 1 Deck Support Arm & Hitch Assemblies Grease Fitting Support Arm Bushing (2-1/16) Deck Arm Mount Deck Support Arm, LH (Includes Item # 40) Lynch Pin (5/16 x 1-1/4) Deck Arm Hydro Mount, LH Deck Arm Hydro Mount, RH Deck Support Arm, RH (Includes Item # 40) 1 Fasteners -24 Keps Nut 12 1/4-20 Keps Nut 6 F005 1/4-20 ESNA Nut 1 5/16-18 Whiz Locknut 22 F012 3/8-16 Keps Nut 2 F013 3/8-16 Whiz Locknut 4 F014 3/8-16 ESNA Nut 2 F016 1/2-13 Self-Locking Nut 1 F020 5/16-18 ESNA Nut 1 F x 3/8 PPHMS 2 F x 3/4 PPHMS 1 F029 1/4-20 x 1/2 Hex Bolt 4 F031 1/4-20 x 5/8 Hex Bolt 8 F034 5/16-18 x 3/4 Hex Bolt 8 F042 3/8-16 x 2-1/4 Hex Bolt 2 F048 1/2 SAE Washer 2 F049 5/16 SAE Washer 8 F053 /16 Int Star Lock Washer 2 F059 3/8 Wave Spring Washer 2 F093 5/16-18 x 1 Hex Bolt 1 F116 1/4-20 x 1-1/4 Hex Bolt 1 F151 3/8-16 x /8 Hex Bolt 2 F x 00 x 04 Washer 2 F200 /16-20 x 3 Grade 8 Bolt 2 F206 #2 x 3/16 Drive Pin 2 F22 3/8 x 1-1/4 x 1/8 Washer 2 F x 85 x Washer 4 F246 1/4-20 x 1/2 PTHMS 8 F25 3/8 x 1-11/16 Shoulder Bolt 2 F292 1/2-13 x 8-1/2 Hex Bolt, GR 2 1 F341 Coil Roll Pin (/64 x 9/16) 1 F342 5/16 Conical Washer 2 F413 5/16-24 x 5/16 Set Screw 2 F438 5/16-18 x 2-3/4 Hex Bolt 4 F4 1/4-20 x 5/8 Carriage Bolt 2 * Service Part Only ** Complete Tilt-Up Latch Assembly Kit available by ordering kit # 54 4 Use only genuine Walker replacement parts

7 5 Use only genuine Walker replacement parts < F4 F246 F F034 F020 F342 F342 F093 F034 F034 F034 F034 F029 F029 F031 F031 F031 F F025 F22 F183 F183 F F014 F241 F241 F042 F013 F014 F012 F241 F012 F151 F151 F F F413 F292 F048 F016 1 F25 F25 F F059 F059 F042 Hydrostatic Ground Drive Assemblies F005 F F034 F034 F049 F049 F049 F049 F200 F200 F053 F438 F438 F151 F013 F013 F151 F053 F029 BODY / CHASSIS ASSEMBLY

8 REAR BODY ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Rear Body Assembly Catcher Support Frame Grommet (1 x 1-1/4) Rear Body Tie-In Rear Body Panel, LH Rear Body Panel, RH Catcher Handle Plate, RH Catcher Handle Plate, LH Spring Clip mm Ball Stud Gas Spring Assembly 1 (Includes Items # 8 & 9) Fasteners -24 Keps Nut 4 1/4-20 Keps Nut 5 5/16-18 Whiz Locknut F x 3/8 PPHMS 4 F031 1/4-20 x 5/8 Hex Bolt 3 F034 5/16-18 x 3/4 Hex Bolt 8 F390 1/4-20 x /8 Carriage Bolt 2 NOTE: Rear Bumper Assembly for GHS Models is not shown here BODY / CHASSIS ASSEMBLY, Page 4 6 Use only genuine Walker replacement parts

9 REAR BODY ASSEMBLY GHS 0 Bushel Catcher Assembly F031 2 F031 F031 F390 GHS 0 Bushel Catcher Assembly F390 6 GHS 0 Bushel Catcher Assembly F F025 F Engine Group F091 Body / Chassis Assembly Use only genuine Walker replacement parts

10 MAIN COMPONENT POWER TRANSMISSION ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D PTO Drive Assembly Handle Grip, Black Clutch Lever Grease Fitting Clutch Actuator Bolt (5/16) Knuckle Joint Grease Fitting (90 Degree) /16-18 x 1-3/4 Stud Pivot Bushing (5/16 ID) Clutch Arm 1 3 Plastic Washer (1 x 438 x 025) Pivot Bearing (/16 x 9/16) Ball Joint (5/16-24LH) (Nylon Lined) Clutch Arm Support Bracket Clutch Pull Rod 8-5/ Ball Joint (5/16-24) (Nylon Lined) Extension Spring (3/4 x 4) Ball Joint (5/16-24) W/O Stud Spring (3/4 x 2-1/2) V-Groove Idler (4") PTO Drive Belt PTO Drive Pulley (5/B) 1 (Includes Items # F06 & F11) Grease Fitting (45 Degree) PTO / Clutch / Brake Actuator 1 (Includes Items # 22 & 25) PTO / Clutch / Brake Support Fiberglide Bearing Inner Race (2-1/4) Belt Guide Mount 1 Engine Belt Tightener Assembly Compound Pulley, 4/B 1 (Includes Items # F135 & F11) Engine Drive Belt Engine Idler Arm 1 (Includes Item # 3) Bushing 500 x 3125 x Extension Spring (3/4 x 5) Engine Pulley (4-1/4B) 1 (Includes Items # F066 & F11) Bearing W/Collar (3/4) Jackshaft Bearing Housing Jackshaft (3/4 x 1150) 1 Blower Brake Assembly Clevis Pin W/Hole (1/4 x 5/8) Brake Band (14-1/2) Brake Band Link, Front 2 Fasteners 1/4-20 Keps Nut 8 F005 1/4-20 ESNA Nut 1 F008 5/16-24 Keps Nut 2 5/16-18 Whiz Locknut F0 5/16-24 ESNA Nut 1 F012 3/8-16 Keps Nut 1 F024 5/16-24 Jam Nut 2 F029 1/4-20 x 1/2 Hex Bolt 1 F031 1/4-20 x 5/8 Hex Bolt 6 F034 5/16-18 x 3/4 Hex Bolt 5 F035 5/16-18 x 1-1/4 Hex Bolt 1 F040 3/8-16 x 1-1/2 Hex Bolt 2 F049 5/16 SAE Washer 1 F050 1/4 SAE Washer 3 F054 AN Washer 2 F060 AN Washer 2 F061 1/4 Star Lock Washer 1 F063 3/8 Int Star Lock Washer 2 F06 3/16 x 3/16 x 1 Key 1 F069 3/32 x 1/2 Cotter Pin 1 F6 3/8-16 x 5/8 Hex Bolt 2 F116 1/4-20 x 1-1/4 Hex Bolt 1 F135 3/16 x 3/16 x 1-3/4 Key 1 F11 5/16-18 x 3/8 Set Screw 6 F18 1/4 x 1 Fender Washer 1 F19 1/4-20 x 1 Hex Bolt 1 F x 00 x 04 Washer 1 F x 85 x Washer 1 F350 1/4-20 LP Nylock 1 F33 5/16-24 Hex Nut, LH 1 F393 3/8-16 x 3-1/4 Hex Bolt 1 F44 1/4 x 1/4 x 1 Key 1 F535 5/16-24 x 2-1/2 Hex Bolt 1 8 Use only genuine Walker replacement parts

11 MAIN COMPONENT POWER TRANSMISSION 1 2 F F Engine Group F008 F F060 F060 F0 1 F024 F183 F F034 F18 F029 F061 F241 F F F350 F33 F11 F F6 F063 F F005 F11 28 F44 F11 F F11 29 F135 F11 F050 F F012 F535 3 F049 F19 F F F054 F393 Hydrostatic Ground Drive Assemblies GHS Group F034 F031 F050 2 Body / Chassis Assembly Use only genuine Walker replacement parts 9

12 ENGINE GROUP ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Engine Assembly Engine Brace 1 2 NS 14 HP Engine (Subaru) Air Cleaner Assembly 1 (Includes Items # 3-5) Air Cleaner Cartridge Safety Filter Insert Air Cleaner Band Hose Clamp (1-1/4 to 1-3-/4) Air Intake Hose Hose Clamp (1/2) Degree Elbow 5/16" 1 11 M24 Fuel Line (5/16 x 1") 1** Intake Tube 1 13 M24 Fuel Line (5/16 x 6") 1** Intake Pipe / Gasket Engine Spacer 1 Exhaust Assembly 16 NS Nut 2 1 NS Gasket, Muffler Muffler Muffler Heat Shield 1 Throttle and Choke Assemblies Fasteners -24 Keps Nut 6 1/4-20 Keps Nut 3 F005 1/4-20 ESNA Nut 2 5/16-18 Whiz Locknut 5 F013 3/8-16 Whiz Locknut 4 F x 3/8 PPHMS 4 F034 5/16-18 x 3/4 Hex Bolt 3 F040 3/8-16 x 1-1/2 Hex Bolt 4 F044 5/16-24 x 3/4 Hex Bolt 2 F050 1/4 SAE Washer 4 F051 3/8 SAE Washer 4 F052 5/16 Ext Star Lock Washer 2 F x 1/4 x 3/8 SHL Bolt 2 F184 1/4-20 x 1/2 Hex Bolt, SS 4 F185 1/4 Internal Star Lock Washer, SS 4 F201 1/4 Belleville Spring Washer 4 F211 1/4-20 x /8 Hex Bolt 3 F539 Washer 281 x 50 x * Service Part Only ** Required hose specifications: M24 5/16" ID low permeation (<15g/m^2/day) fuel hose (Parker or equivalent) Throttle Cable Choke Cable Control Lever, Throttle and Choke Throttle Control Knob, Red Choke Control Knob, Black Control Assembly, Throttle and Choke * (Includes Items # 22, & F201) 28-2 Throttle Control and Cable Assembly * (Complete Control and Cable Assembly) Choke Control and Cable Assembly * (Complete Control and Cable Assembly) Control Bracket Friction Washer (125) Control Lock Tab Bearing, Nylon (255 x 39 x 250) 2 Use only genuine Walker replacement parts

13 ENGINE GROUP F013 F F F052 F F044 F052 F F164 F F201 F F F050 Body / Chassis Assembly 16 F F040 F539 F211 F184 F211 F185 F211 F184 F185 F185 F F185 F184 Use only genuine Walker replacement parts 11

14 HYDROSTATIC GROUND DRIVE ASSEMBLIES ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Ground Drive Assemblies Oil Expansion Reservoir Hose Clamp (3/4 to 1-1/2) O-Ring (15/16 x 1-1/8) Oil Reservoir Retainer O-Ring (3/8 x 1/2) Hydro-Gear ZT30, RH Lockout Arm, RH Bow Tie Cotter Pin Idler Spring Bushing Torsion Spring Idler Arm Hydro Fan Washer Hydro Fan Hydro Pulley (405) Splined Hydro Fan Nut Transmission Drive Pulley (3-1/4MV) 1 (Includes Items # F06 & F11) Ground Drive Belt (Micro V) Idler Pulley Spacer Bushing (5/16) Lockout Arm, LH Hydro-Gear ZT30, LH Spacer Tube Shock Mount / Body Lift Arm 1 (Includes Item # 24) Grease Fitting 2 Parking Brake Assembly Handle Grip, Red Parking Brake Lever 1 (Includes Item # 24) Brake Actuator Pull Clevis (3/8) Parking Brake Pull Rod Clevis Pin (5/16 x 3/4) Parking Brake Pull Mount, Inner Parking Brake Pull Mount, Outer Compression Spring (2-1/2) Extension Spring (1/2 x 3-1/4) Parking Brake Actuator Clevis Pin (5/16 x 1-1/8) 1 Wheel Assembly Wheel & Tire (18 x 00-8) Standard Tire (18 x 00-8) * Standard Wheel (8 x ) * Tire Tube (18 x 850-8) * Fasteners 1/4-20 Keps Nut 3 5/16-18 Whiz Locknut 9 F013 3/8-16 Whiz Locknut 4 F015 1/2-20 Wheel Lug Nut 8 F020 5/16-18 ESNA Nut 2 F029 1/4-20 x 1/2 Hex Bolt 1 F031 1/4-20 x 5/8 Hex Bolt 3 F034 5/16-18 x 3/4 Hex Bolt 2 F041 3/8-16 x 1-3/4 Hex Bolt 1 F042 3/8-16 x 2-1/4 Hex Bolt 2 F06 3/16 x 3/16 x 1 Key 1 F069 3/32 x 1/2 Cotter Pin 5 F x 1/2 PTHMS 2 F11 5/16-18 x 3/8 Set Screw 2 F182 1/4 x 5/8 x 1/8 Washer 2 F x 00 x 04 Washer 3 F316 5/16-18 x 1-3/4 Hex Bolt 1 F336 3/8-16 Jam Nut 1 F388 3/8-16 x 2-1/2 Hex Bolt 2 F489 Washer 1/4 x /8 x F529 Washer OD x 515 ID x 1/8 2 F533 5/16-18 x 3-1/2 Socket Cap Bolt 4 * Service Part Only 12 Use only genuine Walker replacement parts

15 HYDROSTATIC GROUND DRIVE ASSEMBLIES 1 F029 Body / Chassis Assembly F013 5 F042 F F F F11 F F129 F013 F042 F F F F F06 F F529 1 Main Component Power Transmission F489 F388 F F F183 F336 Body / Chassis Assembly F F069 F069 F F F F316 F034 Body / Chassis Assembly F031 3 F015 Use only genuine Walker replacement parts 13

16 STEERING CONTROL ASSEMBLIES ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Steering Lever & FSC Assemblies FSC Knob FSC Lever Assembly (Includes Item # 4) * Step Washer Grease Fitting Ball Joint (5/16-24/LH) W/O Stud Control Rod (4-15/16) Ball Joint (5/16-24) Extension Spring (3/4 x 6-1/2) FSC Friction Actuator Fiberglide Bearing Speed Control Actuator, RH 1 (Includes Items # & 13) Steering Pivot (1/4-20 x 1-5/8) Grease Fitting (45 Degree) mm Ball Stud Steering Lever Spring, Dampener Actuator Washer Fiberglide Bearing (1/2") Steering Lever Actuator Compression Spring (2-1/2) Control Rod (6-1/2) Ball Joint (5/16-24) W/O Stud Seal Retainer Transmission Control Arm Stop Transmission Control Arm, RH Transmission Control Arm, LH Speed Control Actuator, LH 1 (Includes Items # & 13) Steering Pivot Shaft W/Stop Pivot Rod Bushing / Plastic FSC Friction Washer 1 (1-1/2 x 1-1/32 x 1/16) FSC Friction Washer (1-1/2 x 3/8 x 1/16) FSC Cam Extension Spring (1/2 x 3-1/4) D-Clip Steering Lever Tube W/Tab Steering Lever Handle / Adjustable 2 (Includes Items # 36 & F345) Handle Grip, Foam (5-1/2) 2 Fasteners 1/4-20 Keps Nut 2 F005 1/4-20 ESNA Nut 2 5/16-18 Whiz Locknut 6 F0 5/16-24 ESNA Nut 2 F024 5/16-24 Jam Nut 3 F035 5/16-18 x 1-1/4 Hex Bolt 1 F044 5/16-24 x 3/4 Hex Bolt 2 F059 3/8 Wave Spring Washer 1 F093 5/16-18 x 1 Hex Bolt 2 F146 1/4-20 Jam Nut 2 F16 5/16-18 Hex Nut 1 F x 00 x 04 Washer 6 F188 1/4-20 Self-Locking Nut 4 F192 3/8-24 Self-Locking Nut 1 F x 625 x 040 Washer, SS 2 F211 1/4-20 x /8 Hex Bolt 1 F312 3/8 x 3/8 Shoulder Bolt 1 F345 1/4-20 x 0 Knurled Bolt 4 F360 1/4-20 x 3/8 Hex Bolt 2 F33 5/16-24 Hex Nut, LH 1 F385 1/4 x 1-1/4 Roll Pin 1 F386 5/16-18 x 1-1/2 x 3/8 Shoulder Bolt 1 F391 1/4-20 x 1/2 Set Screw, SS 2 F40 Belleville Washer 3/8 x 118, SS 1 F42 5/16-18 Flange Nut 1 * Service Part Only 14 Use only genuine Walker replacement parts

17 STEERING CONTROL ASSEMBLIES Hydrostatic Ground Drive Assemblies 1 23 F391 F146 F183 F093 F F F198 F093 F188 F F059 F386 F024 F183 8 F16 F035 F385 2 F188 F F F093 F005 F F F F183 F044 F024 F005 F F F F024 F Hydrostatic Ground Drive Assemblies 13 2 F391 F Hydrostatic Ground Drive Assemblies F F Body / Chassis Assembly F40 F192 F F312 Use only genuine Walker replacement parts 15

18 GHS GROUP ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Delivery Chute Assembly Elbow Delivery Spout Backing Plate, Grass-Pak Switch Rear Clip, Chute Mount Side Clip, Chute Mount Body Chute Outside Chute Cover Lip Inside Chute Cover Lip Delivery Chute W/Clips 1 (Includes Items # 3, 4, F09 & F411) Blower Assembly Blower Scroll Flanged Bearing (3/4") Sleeve 3150 x 35 x 3/ Receiver Cone U-Joint Tube/95" OAL Spline 1 (Includes Item # F06) Blower Wheel Blower Faceplate Blower Ring Fixed Chute 1 (Includes Items # 18, 19 & F09) Rubber Flap Backing Plate 2 Fasteners -24 Keps Nut 6 1/4-20 Keps Nut 18 5/16-18 Whiz Locknut 2 F013 3/8-16 Whiz Locknut 2 F x 3/8 PPHMS 4 F x 1/2 PPHMS 2 F031 1/4-20 x 5/8 Hex Bolt 2 F032 1/4-20 x 3/4 Hex Bolt 4 F038 3/8-16 x 1 Hex Bolt 2 F050 1/4 SAE Washer 2 F06 3/16 x 3/16 x 1 Key 1 F06 3/8-16 x 5/8 SQH Set Screw 1 F09 A/A66D Aluminum Pop Rivet 14 F169 5/16-18 x 1 Carriage Bolt 2 F411 3/16 Bulbex Rivet 6 F426 1/4-20 x 1/2 Carriage Bolt 4 F531 1/4-20 x 5 Hex Bolt 11 F532 1/4-20 x 5-1/2 Hex Bolt 1 NOTE: ELECTRICAL CONNECTORS, Page 26, for identification of all Electrical Wiring Service Parts 16 Use only genuine Walker replacement parts

19 GHS GROUP Electrical Connectors F Electrical Assemblies (GHS 0 Bushel Components) GHS 0 Bushel Catcher Assembly 8 4 F411 F09 F411 F025 F411 F GHS Powerfil Assembly (0) F031 Main Component Power Transmission Main Component Power Transmission F050 9 F532 F F F531 F F169 F013 Body / Chassis Assembly F06 F06 F032 F038 F013 F Use only genuine Walker replacement parts

20 GHS POWERFIL ASSEMBLY (0) ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D 0 GHS Powerfil Assembly Ball Joint (1/4-28) Bushing, Powerfil Actuator Compression Spring (1/2 x 2) Powerfil Actuator Rod Actuator Rod Assembly * (Includes Items # 1-5 & F003) Powerfil Push Rod Bearing Cap, Powerfil Pivot Bearing (#S3PP) Pivot, Delivery Spout Pivot Mount Actuator Motor (12V) 1 (Includes Items # 11 & 12) Motor Mount Washer Motor Mount Nut (5/8-24) * * Actuator Arm 1 Fasteners -24 Keps Nut F003 1/4-28 Hex Nut 3 F x 1/2 PPHMS 1 F03-24 x 5/8 PTH Screw 2 F054 AN Washer 1 F085 3/16 Rivet Backup Washer 1 F1-24 x 1-1/4 SHC Screw 1 F9 1/8 x 5/8 Roll Pin 1 F x 1/2 PTHMS 6 F261 AN960616L Washer 1 F28 1/4-28 Keps Nut 1 * Service Part Only 18 Use only genuine Walker replacement parts

21 GHS POWERFIL ASSEMBLY (0) F1 F003 1 F Electrical Assemblies (GHS 0 Bushel Components) F026 F F003 F9 Electrical Assemblies (GHS 0 Bushel Components) F261 F054 GHS 0 Bushel Catcher Assembly F28 F03 F129 F03 F129 9 F129 GHS Group Use only genuine Walker replacement parts 19

22 GHS 0 BUSHEL CATCHER ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Upper Baffle Screen Assembly (Removable) Removable Screen (3/16 Hole) 1** (Includes Items # 2, F025 & F190) Knob / Threaded Insert (-24) Channel Top Channel Bottom Edge Molding (21-3/4") Screen Seal (24") Mustache Spring C-Channel With Spring 1 (Includes Items # & F340) 0 Exhaust Deflector Door Assembly Upper Door Seal Catcher Box Door (Includes Frame) 1 (Includes Items # 9, 11, 12, 14, F09, F085, F330 & F411) Handle Lower Door Stiffener (0) Door Guide Upper Door Stiffener 1 GHS 0 Bushel Catcher Assembly Center Strap (0) Upper Frame Doubler (0) Lower Frame Doubler (0) Outside Box Strap (0) Catcher Door Finger Center Frame Doubler Catcher Mount Pivot Bushing (1/2 x 9/16) Bushing Hinge Plate, LH Catcher Door Arm, LH Gas Spring Cover, LH Spring Clip Gas Spring /4 Ball Stud Gas Spring Plate /16 Ball Stud Box Support, Gas Spring Handle, Catcher Lift Chute Cover Grommet (3/8 x 11/16) Wire Harness Channel Bushel Catcher Box Catcher W/Powerfil (Includes Door) * Powerfil Cover Plate Hinge Plate, RH Gas Spring Cover, RH Catcher Door Arm, RH Reinforcing Strap Decal Plate, Round (Set of 2) Optional Dump Bag (Not Shown) May be ordered as an option Contact your Walker dealer Fasteners -24 Keps Nut 23 1/4-20 Keps Nut 2 5/16-18 Whiz Locknut 2 F020 5/16-18 ESNA Nut 2 F x 3/8 PPHMS 6 F02-24 x 5/8 PPHMS 8 F029 1/4-20 x 1/2 Hex Bolt 2 F049 5/16 SAE Washer 4 F050 1/4 SAE Washer 6 F09 A/A66D Aluminum Pop Rivet 14 F085 3/16 Rivet Backup Washer 8 F x 1/2 PTHMS 6 F x 1/2 PTHMS 14 F18 1/4 x 1 Fender Washer 4 F190 # Internal Star Lock Washer 2 F195 1/4-20 x 3/4 PPHMS, SS 4 F196 1/4-20 x 1 PPHMS, SS 4 F230 1/4-20 x 1-1/4 PPHMS, SS 4 F242 1/4-20 x /8 PPHMS, SS 6 F25 5/16-18 x 2 Hex Bolt 2 F330 3/16D x 21/32L Rivet, SS 4 F340 Rivet, Aluminum 4 F351 Aluminum Pop Rivet 6 F360 1/4-20 x 3/8 Hex Bolt 4 F390 1/4-20 x /8 Carriage Bolt 4 F411 3/16 Bulbex Rivet 21 F4 1/4-20 x 5/8 Carriage Bolt 4 F503 1/4-20 x 1-1/2 PPHMS, SS 1 F524 3/16 x 3/8 Aluminum Rivet, Black 6 * Service Part Only ** This screen can be replaced by P/N 512- Removable Screen (3/4" holes) for improved air flow performance in wet conditions 20 Use only genuine Walker replacement parts

23 GHS 0 BUSHEL CATCHER ASSEMBLY F F129 F025 F340 8 F340 F F025 F129 F025 F F129 F09 14 F085 F411 9 F02 40 F02 F094 F F351 Electrical Assemblies (GHS 0 Bushel Components) 38 Rear Body Assembly F25 31 F049 F F F02 39 F F029 F050 F351 F411 F411 F411 F F049 F020 F4 F18 F F524 F242 F242 F F F390 F242 F09 F411 F F050 F F050 1 F085 F196 F F F242 F F F242 F196 F F020 F F F129 F F029 F049 F F129 F25 F02 Rear Body Assembly F F360 F F02 F02 12 F02 F F129 F129 F Use only genuine Walker replacement parts 21

24 ELECTRICAL ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Electrical Assembly Delta Hex Nut Safety Switch (NO), Delta Threaded Wire Saddle (3 Wires) Cable Clamp (1/2) Cable Tie (18# x 3-3/4") Wire Harness Assembly Safety Switch (NC), Delta Side Mount Safety Switch (NO), Delta Side Mount Safety Switch Plate Relay Switch (30/40 Amp) NC 3 (Includes Items # 11 & 12) Relay Switch (30/40 Amp) Relay Mount * * Hourmeter (Global) Ignition Switch (with Keys) 1 (Includes Items # 15, 16 & F349) Plastic Tip / Red Key Set W/Umbrella Boot, Circuit Breaker Circuit Breaker (15 Amp) 1 Battery Assembly Battery Cable (-) Battery Terminal Insul, Black (-) Battery Terminal Insul, Red (+) 1 22 NS Battery (12V/300CA/Wet) Battery Protector Plate Hook Bolt Battery Cable (33") Cable Clamp (9/16 x 1/4) 1 Fasteners -24 Keps Nut 4 1/4-20 Keps Nut 5 F019 1/4-20 ESNA Wing Nut 2 F x 3/8 PPHMS 1 F x 1/2 PPHMS 3 F029 1/4-20 x 1/2 Hex Bolt 3 F031 1/4-20 x 5/8 Hex Bolt 2 F050 1/4 SAE Washer 4 F112 5/8 x 1-1/4 x 03 Washer 3 F146 1/4-20 Jam Nut 1 F211 1/4-20 x /8 Hex Bolt 1 F349 Washer 835 ID 1122 OD, SS 1 F x /8 Hex Trim MS, SS 4 F Nylock Nut 4 * Service Part Only NOTE: ELECTRICAL CONNECTORS, Page 26, for identification of all Electrical Wiring Service Parts NOTE: Decals for this assembly are not shown here TRACTOR DECALS, Page 2, for Decal listing and placement information 22 Use only genuine Walker replacement parts

25 ELECTRICAL ASSEMBLY F A 13 D 1 18 B F C <15 Body / Chassis Assembly Main Component Power Transmission F025 4 Body / Chassis Assembly 19 5 F E F G F026 F506 F505 I WHT/ 6 PUR/WHT J F019 F F019 F F F031 F F029 Steering Control Assemblies F506 9 F505 F211 F146 8 H YEL RED F029 Body / Chassis Assembly END VIEWS ARE SHOWN FROM BACK OF PLUG WHT DETAIL A YEL DETAIL G RED BLU RED/WHT PUR/WHT PUR DETAIL B RED RED DETAIL H PUR/WHT DETAIL C BRN BLU DETAIL I DETAIL D BRN/WHT DETAIL J YEL DETAIL E PUR PUR YEL BRN DETAIL F WHT /WHT PUR/RED PUR RED/WHT ORG PUR PUR/RED ORG/WHT ORG BRN/WHT ORG/WHT Use only genuine Walker replacement parts 23

26 ELECTRICAL ASSEMBLIES (GHS 0 BUSHEL COMPONENTS) ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Horn & Harness Channel Assemblies Horn, Full Signal * Adapter Harness Grommet (3/16 x 3/4) Cable Tie (18# x 3-3/4") 1 Harness & Grass-Pak Switch Assemblies / 0 Wire Harness Grommet (3/8 x 11/16) Cable Clamp (1/4) Aluminum Shaft & Vane Assembly Grass-Pak Switch Assembly 1 Fasteners -24 Keps Nut 4 F x 3/8 PPHMS 1 F03-24 x 5/8 PTH Screw 1 F x 1/2 PTHMS 2 F Keps Nut, SS 2 F x 1/2 Hex Head, SS 2 * Service Part Only NOTE: ELECTRICAL CONNECTORS, Page 26 for identification of all Electrical Wiring Service Parts 24 Use only genuine Walker replacement parts

27 ELECTRICAL ASSEMBLIES (GHS 0 BUSHEL COMPONENTS) GHS 0 Bushel Catcher Assembly /WHT 4 A to (-) RED to (+) GHS Powerfil Assembly (0) F129 F129 GHS 0 Bushel Catcher Assembly /WHT GHS 0 Bushel Catcher Assembly B Electrical Assembly 5 6 GHS Group F025 GHS Group DETAIL A RED WHT DETAIL B /WHT /WHT F03 F509 F509 F508 8 END VIEWS ARE SHOWN FROM BACK OF PLUG /WHT 9 Use only genuine Walker replacement parts 25

28 ELECTRICAL CONNECTORS ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Electrical Wiring Service Parts GA Butt Connector * GA Butt Connector * GA Shrink Connector * GA Shrink Connector * Wire Terminal Adapter * GA Bullet Conn, Male * GA Bullet Conn, Female * GA Spg Loaded Term, Female * Wire Clip, Female * /4 x GA QKS Term, Female * /16 x GA QKS Term, Female * GA QKS Term, Female GA Spg Loaded Term, Male * * /4 x GA QKS Term, Male * GA Ring Term (#8) Nylon Insulated * /4 x GA QKS Term, Male * GA Ring Lug (5/16) * GA Ring Term, # * GA Ring Term (5/16) * GA Ring Term (5/16) * GA Ring Term, # * GA Ring Term (1/2) * GA Ring Terminal (1/4) * GA Ring Term (1/4) * GA Ring Term (1/4) * GA Ring Term, # * Single Connector, Male * Way Connector, Male * Way Locking Connector, Female * Way Connector, Male * Way Connector, Female * Way Locking Connector, Male * Way Connector, Male * Way Connector, Male * Way Locking Connector, Male * Way Locking Connector, Female * Way Connector, Male * Way Connector, Female * Way Connector, Male * Way Connector, Male * Way Connector, Female * Way Connector, Male Way Connector, Male * * Way Connector, Male * Way Connector, Female * Way Connector, Male * Way Connector (M) * Way Connector (Female) * Packard Plug (Male) * Packard Plug (Female) * * Service Part Only NOTE: Not all Electrical Connectors are used with all assemblies NOTE: ELECTRICAL ASSEMBLY, Page 22, for locations of Wiring Harness, Electrical Components and of all Electrical Wiring Service Parts 26 Use only genuine Walker replacement parts

29 ELECTRICAL CONNECTORS Use only genuine Walker replacement parts 2

30 LUBRICATION POINTS ITEM LOCATION LUBRICATION NO NO TYPE PLACES ITEM LOCATION LUBRICATION NO NO TYPE PLACES Lubrication Points 1 Steering Lever Pivot Grease 2 2 FSC Lever Pivot Grease 1 3 Deck-to-PTO Coupling Grease 1 (Grease Spline Slide Area) 4 Transaxle Oil Reservoir Oil/20W Universal Joint Tube Assembly Grease* 1 6 Deck Support Arm Pivot Grease 2 Hydro Idler Pivot Grease 1 8 PTO Clutch Lever Pivot Grease 1 9 Body Latch Pivot Oil 1 Clutch Actuator Push Rod Grease 1 (Grease Slide Area) 11 PTO Belt Tightener Pivot Grease 1 12 Engine Dipstick / Oil Filler Oil** 1 13 Catcher Hinge Point Oil 2 14 Choke Control Cable Ends Oil 2 15 Throttle Control Cable Ends Oil 2 16 Engine Idler Pivot Grease 1 1 Parking Brake Lever Grease 1 18 Choke Control Pivot Oil 1 19 Throttle Control Pivot Oil 1 * Grease every eight (8) hours ** Engine Oil in Operator s Manual NOTE: See Model S14 Operator s Manual (P/N ) for proper lubrication intervals 28 Use only genuine Walker replacement parts

31 LUBRICATION POINTS & & Use only genuine Walker replacement parts 29

32 WIRING SCHEMATIC BATTERY WALKER MODEL S14 Beginning S/N IGNITION SWITCH CIRCUITS ORG/WHT CASE GROUND TO MOTOR MOUNT ORG R POWERFIL MOTOR WHT OFF START RUN G + M B + A / S1 + S2 B + A S1 = START CIRCUIT S2 = START/ACCESSORY CIRCUIT M = MAGNETO GROUND CIRCUIT B = BATTERY CIRCUIT A = ACCESSORY CIRCUIT G = GROUND CIRCUIT - HORN + RED GRASS PAK SWITCH R YEL RED STARTER STARTER SOLENOID RELAY - A START RELAY OFF A START RUN PUR PTO SWITCH PUR/WHT WHT/ ALTERNATOR MAGNETO ENGINE GROUND ENGINE RELAY - B IGNITION RELAY OFF A START RUN PUR/RED PUR RELAY - C 30 PUR/RED RELAY - C PTO INTERLOCK RELAY OFF A START RUN PTO ON A ORG ORG/WHT BRN/WHT RELAY - B 30 BRN A WHT WHT/ PUR PUR RELAY - A 30 YEL A YEL BRN BLU SEAT SWITCH PUR/WHT ORG RED FSC NEUTRAL INTERLOCK SWITCH 15 AMP CIRCUIT BREAKER RED/WHT WHT M G YEL S1 B RED RED S2 A PUR RED/WHT BLU PUR/WHT BRN/WHT HOUR METER 30 Use only genuine Walker replacement parts

33 OPERATOR S NOTES Use only genuine Walker replacement parts 31

34 OPERATOR S NOTES 32 Use only genuine Walker replacement parts

35 1 WHAT THIS WARRANTY COVERS, AND FOR HOW LONG: LIMITED WARRANTY FOR WALKER MODEL S14 RIDER MOWER Walker Manufacturing company will, at its option, repair or replace, without charge, any part covered by this warranty which is found to be defective in material and/or workmanship within one (1) year* after date of sale to the original retail purchaser unless the product is used for rental purposes, in which case this warranty is limited to ninety (90) days At Walker s request, customer will make the defective part available for inspection by Walker and/or return the defective part to Walker, transportation charges prepaid All parts and components of the Walker Mower are covered by this warranty except the following components which are warranted separately by their respective manufacturers: Subaru Engine Hydro-Gear Transaxles Battery Tires The available warranties covering these items are furnished with each mower Walker does not assume any warranty obli gation, liability or modification for these items, which are covered exclusively by the stated warranty of the respective man ufacturers noted above * A two (2) year or 2000 hour (whichever comes first) warranty is offered for Hydro-Gear ZT30 hydrostatic transmissions; covers full cost of replacement up to 00 hours of use, and after 00 hours warranty coverage is prorated against 2000 hours 2 WHAT THIS WARRANTY DOES NOT COVER: A This warranty does not cover defects caused by depreciation or damage caused by normal wear, accidents, improper maintenance, improper use or abuse of the product, alterations, or failure to follow the instructions contained in the Operator s Manual for operation and maintenance B The customer shall pay any charges for making service calls and/or for transporting the mower to and from the place where the inspection and/or warranty work is performed 3 HOW TO OBTAIN SERVICE UNDER THIS WARRANTY: Warranty service can be arranged by contacting the dealer where you purchased the mower or by contacting Walker Man ufacturing Company, 5925 East Harmony Road, Ft Collins, CO Proof of the date of purchase may be required to verify warranty coverage 4 WARRANTY LIMITATION: A THERE IS NO OTHER EXPRESS WARRANTY ANY WARRANTY THAT MAY BE IMPLIED FROM THIS PURCHASE INCLUDING MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE IS HEREBY LIMITED TO THE DURATION OF THIS WARRANTY AND TO THE EXTENT PERMITTED BY LAW ANY AND ALL IMPLIED WARRANTIES ARE EXCLUDED Some states do not allow limitations on how long an implied warranty lasts, so the above limitations may not apply to you B WALKER WILL NOT BE LIABLE FOR ANY INCIDENTAL, CONSEQUENTIAL, OR SPECIAL DAMAGES AND/OR EXPENSES IN CONNECTION WITH THE PURCHASE OR USE OF THE MOWER Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation(s) or exclusion(s) may not apply to you C Only the warranty expressed in this limited warranty shall apply and no dealer, distributor, or individual is authorized to amend, modify, or extend this warranty in any way Accordingly, additional statements such as dealer advertising or presentations, whether oral or written, do not constitute warranties by Walker, and should not be relied upon D This warranty gives you specific legal rights, and you may also have other rights which vary from state to state 33

36 WALKER MFG CO 5925 E HARMONY ROAD, FORT COLLINS, CO (90) FORM NO PRINTED IN USA wwwwalkermowerscom 2014 WALKER MFG CO