Illustrated Parts Manual
|
|
- Merilyn Moore
- 5 years ago
- Views:
Transcription
1 Illustrated Parts Manual Beginning S/N: 4 Effective Date: 0-0- P/N 000-0
2 KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation What it Represents º (Dimension) Degrees (Angle) " (Dimension) inches (-)Negative (Polarity) (+) Positive (Polarity) AT All-Terrain CCW Counter-clockwise Conn Connector CW Clockwise D Diameter DC Deck, Collection (number refers to size in inches) DM Deck, Mulching (number refers to size in inches) DR Deck, Rear Discharge (number refers to size in inches) DSDeck, Side Discharge (number refers to size in inches) DU Garlock (Bearing) ESNA (Fastener)Nylon Insert Locknut FSC Forward Speed Control GA Gauge gal gallon GHS Grass Handling System GR (Fastener)Grade HD Heavy Duty HP Horse Power ID Identification or Inside Diameter L Length LH Left Hand (orientated with operator on seat) LP Low Profile mm (Dimension) millimeters MS (Fastener)Machine Screw NS (as part number) Item is not sold by Walker Manufacturing OD Outside Diameter oz ounce PFH (Fastener) Phillips Flat Head P/NPart Number PPH (Fastener)Phillips Pan Head PTH (Fastener)Phillips Truss Head PTO Power Take-Off QKS Quick Slide qtquart RH Right Hand (orientated with operator on seat) SAE (Fastener)Society of Automotive Engineers SBH (Fastener)Socket Button Head (Bolt) SDSide Discharge SFH (Fastener)Slotted Flat Head SHC (Fastener) Socket Head Cap SHL (Fastener) Shoulder (Bolt) SM (Fastener)Sheet Metal (Screw) S/N Serial Number Spg Spring SQH (Fastener) Square Head SS (Fastener) Stainless Steel ST (Fastener)Self-Tapping (Screw) Term Terminal V Volts NOTE: In some instances, combinations of abbreviations may be used (eg PPHMS - Phillips Pan Head Machine Screw)
3 ILLUSTRATED PARTS LIST Section of Tractor Covered Page Section of Tractor Covered Page Decals Tractor Decals Body / Chassis Assemblies Body / Chassis Assembly (GHS Models) 4 Rear Body Assembly (GHS Models) 6 Body Assembly (SD Models) Tractor Components Main Component Power Transmission (GHS Models) 0 (SD Models) Engine Group4 Hydrostatic Ground Drive Assemblies6 Steering Control Assemblies Throttle & Choke Control Assembl 0 Parking Brake Assembly GHS Group 4 GHS Powerfil Assembly (00) 6 GHS 00 Bushel Catcher Assembly Instrument Panel Assembly 0 Electrical Components Electrical Assembly Electrical Assemblies (GHS 00 Bushel Components)4 Electrical Connectors 6 Maintenance Lubrication Points Wiring Schematic 40 Warranty Limited Warranty 4
4 TRACTOR DECALS ITEM PART DESCRIPTION LOCATION NO NO NO NO REQ D GHS REQ D SD Walker Product and Operation Decals 600- RH Fender Body, RH Side Near Seat 00 Walker Mower (4" Round) Utility Bed (one on each side) Walker (" Round) 00 Bushel Catcher (one on each side) Decal, T Body 6- Made in USA Body Danger Decals Warning Decals Caution Decals Warning, Read Manual Body 0- Decal, Hydro Warning Bridge Assembly and LH Gear Axle Drive Assembly 600- Danger, Engine Exhaust Front Body, LH Side Danger, Pinch Point 00 Bushel Catcher Mounting Frame Assembly 0 (one on each side) Danger, Rotating Blower Blades Body, Near Body Chute 0 Maintenance Decals Parking Brake Body, RH Side below Seat 600- Body Latch Decal Body, RH Side below Seat 0- Fuel Recommendations Precleaner Tube 4 Important, Engine Cooling Engine 6 Removable Screen 00 Bushel Catcher Removable Screen Front Body Closure Rear Cross Member, Body Oil Level Jackshaft Support 0- Axle Oil Level Gear Axle Drive Assemblies (one on each) 600- Choke Body, LH Side Throttle Body, LH Side 6 PTO Alignment Arrow Universal Joint Tube Assembly NS Sealed Reservoir Hydrostatic Drives (one on each) NOTE: All parts requiring decals are shipped with decals applied
5 TRACTOR DECALS SD Model Decks Parts Manual for Deck Decals GHS Model Decks Parts Manual for Deck Decals Use only genuine Walker replacement parts
6 BODY / CHASSIS ASSEMBLY (GHS MODELS) ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Seat Assembly 0 Seat 0- Seat Spring Plate -4 Compression Spring 4 4- Rubber Bumper ( x 0) 46 Washer (/ ID x -/4 OD x /) 6 4- Retainer Washer 440- Shock Mount (-/4 x /4) Rear Bumper Assembly (GHS Models Only)* 6 GHS Rear Bumper 6- Catcher Pivot Bushing 0 6 Roller Wheel (" Rubber) - Catcher Pivot Plate Body Assembly NS Body ID Plate - Dome Plug (/6) 4-0 Dome Plug (/6) 4 Rubber Bumper (0 OD x ) 4 6 Heat Deflector 4 Panel Guard -4 Dome Plug (/) 4 - Dome Plug (/6) mm Ball Stud 4 Gas Spring Assembly (Includes Item # 0) 44 Rubber Bumper ( OD x 0) - Body Latch Hook (-/ Side Bars) 4 Extension Spring (/4 x ) 4 Plastic Tip, Red 6 - Dome Plug (/4) 00-4 Front Body 0 Edge Molding, Lever Opening - Dome Plug (/) 0 - Dome Plug (/6) Tilt-Up Latch Assembly*** 4 Plastic Tip 44-0 Spring Arm, Tilt-Up Latch 44-0 Spring Pivot Bushing Compression Spring (/ x /) 44- Mount Angle, LH Hook, Tilt-Up Latch 44-4 Mount Angle, RH Chassis Assembly 6- Retainer Collar (") (Includes Item # F4) 0- Pivot Bearing Tail Wheel Fork 4 0- Grease Fitting (4 Degree) 4 0 Nut, Tail Wheel Axle 4 0- Seal, Outer (-/4 x -/) Spacer, Tail Wheel Axle (0 x ID x OD) 4 0 Bearing Cone (/4 ID) Tail Wheel & Tire Assembly ( x 00-6) (With Bearing Race) 0- Tail Wheel Tire ( x 00-6) 06 Wheel & Hub (6 x ) ** ** (Includes Items # 4 & Bearing Race) 0- Bearing Race ** 4 6- Seal, Reverse Lip 4 0 Tail Wheel Axle (/4 x 0-/) 4 00 Wheel & Tire Assembly ( x 0-) 00- Drive Tire ( x 0-) ** 00-4 Wide Wheel ( x ) ** Chassis Frame (T / 0 gal) Fasteners F Keps Nut /4-0 Keps Nut F00 /4-0 ESNA Nut F00 /6- Whiz Locknut F0 /-6 Keps Nut F0 /-6 Whiz Locknut F04 /-6 ESNA Nut 4 F00 /6- ESNA Nut F0 0-4 x / PPHMS F0 /4-0 x / Hex Bolt F0 /4-0 x / Hex Bolt F04 /6- x /4 Hex Bolt F0 /-6 x Hex Bolt 6 F040 /-6 x -/ Hex Bolt F04 /-6 x -/4 Hex Bolt F00 /4 SAE Washer F0 / SAE Washer F0 / Wave Spring Washer F0 /6- x Hex Bolt F /-6 x / Hex Bolt F /-0 x -/4 Wheel Lug Bolt F0 /6- x /4 Set Screw, Knurl Point F06 # x /6 Drive Pin F /6 Split Lock Washer F /6-4 x -/4 Hex Bolt F / x -/4 x / Washer F4 x x 0 Washer 4 F / x -/6 Shoulder Bolt F4 Coil Roll Pin (/64 x /6) F4 /6 Conical Washer * F4 /6-4 x /6 Set Screw Rear Bumper Assembly for SD Models is not shown here BODY ASSEMBLY (SD MODELS), Page ** Service Part Only *** Complete Tilt-Up Latch Assembly Kit available by ordering kit # 4 4
7 BODY / CHASSIS ASSEMBLY (GHS MODELS) F0 6 F0 F4 F4 6 F4 0 4 F0 F F00 F F0 6 GHS Group F F F04 F00 F00 F00 6 F0 F0 F04 F0 F0 F04 F0 F4 F0 F0 F04 F4 F F4 F0 F04 0 F4 F00 F04 F0 6 F040 4 F00 F0 F00 F F00 F0 F00 F0 F F F F F F F0 F Electrical Assembly
8 REAR BODY ASSEMBLY (GHS MODELS) ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Rear Body Assembly (GHS Models) 0- Insulation Foam Pad ( x 0) 0 Heat Shield -4 Catcher Handle Plate, RH 4 - Catcher Handle Plate, LH 6- Catcher Support Frame, Insulation Foam Pad, RH 0- Insulation Foam Pad, LH Cable Clamp (/) 4 Gas Spring Assembly (Includes Items # & ) 0-4 Splash Guard 4 Spring Clip 46 mm Ball Stud 0- Rear Body Panel Fasteners F Keps Nut 4 /4-0 Keps Nut F00 /6- Whiz Locknut F0 0-4 x / PPHMS F x / PPHMS F0 0-4 x / PPHMS F0 /4-0 x / Hex Bolt F0 /4-0 x /4 Hex Bolt F0 /6 Rivet Backup Washer F /4 x Fender Washer F0 /4-0 x / Carriage Bolt NOTE: Rear Bumper Assembly for GHS Models is not shown here BODY / CHASSIS ASSEMBLY (GHS MODELS), Page 4 6
9 REAR BODY ASSEMBLY (GHS MODELS) GHS 00 Bushel Catcher Assembly F06 F0 F0 F00 F0 F F00 F0 F0 F00 F0 6 F0 0 F06 F00 4 Body / Chassis Assembly (GHS Models) F00 F06 F00
10 BODY ASSEMBLY (SD MODELS) ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Utility Bed Assembly 60-0 Bed Liner ( x ) 60- Utility Bed (Includes Item # ) 0- Insulation Foam Pad, RH 4 0- Insulation Foam Pad, LH Rear Bumper Assembly (SD Models) - Cover Plate 6 4 Gas Spring Assembly (Includes Items # & ) 4 Spring Clip 46 mm Ball Stud Rear Bumper 0 6 Roller Wheel (" Rubber) 0- Rear Body Panel - Splash Guard with Mat (Includes Item # ) - Rubber Mat ( x ) Fasteners F Keps Nut 6 F00 /6- Whiz Locknut F0 /-6 Keps Nut 6 F0 /-6 Whiz Locknut 4 F04 /-6 ESNA Nut F0 0-4 x / PPHMS F x / PPHMS F0 0-4 x / PPHMS F0 /-6 x Hex Bolt 6 F040 /-6 x -/ Hex Bolt F04 /-6 x -/4 Hex Bolt F0 / SAE Washer 4 F0 / Wave Spring Washer F 0-4 x / PTHMS 4 NOTE: BODY / CHASSIS ASSEMBLY (GHS MODELS), Page 4 for all common parts used on both models
11 BODY ASSEMBLY (SD MODELS) F00 F040 F0 F0 F F0 F0 F0 F04 F0 F F0 F0 F04 0 F00 F0 F0 F06 F00 F00 Body / Chassis Assembly (GHS Models) F00 F06 F00 Body / Chassis Assembly (GHS Models)
12 MAIN COMPONENT POWER TRANSMISSION (GHS MODELS) ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Clutch Lever Assembly - Clutch Lever (Includes Items # & ) 0 Grease Fitting 40 Handle Grip, Black Clutch Actuator Bolt (/) 0- Knuckle Joint (/ ID) Compression Spring (/4 x -/) 0- Pushrod, Clutch Actuator (Threaded Tube) (Includes Item # ) 0-0 Clutch Actuator Rod Assembly (Includes Items #, 4-, F04, F6 & F) 0- Fiberglide Bearing Inner Race (-/4) 6 PTO Belt Tightener 4 Retainer Washer (/ x -/4) 4 4- Clutch Idler Pulley 4 Clutch Idler Pulley Assembly * (Includes Items # - & F00) 4 6 Bearing (/4) 4- Hub, Idler Pulley 6 PTO Belt Tightener Stop Plastic Washer ( x 4 x 0) Pivot Bearing (/6 x /6) - Clevis Spring Pin 0 0 Clevis (/4) 0 Brake Actuator Rod 0 Bearing, Brake Actuator - Clevis Pin (/4 x 00) 4 0 Brake Spring (/ x -/) 6 Brake Actuator (Includes Items # & ) PTO Drive Shaft Assembly Dipstick, Gearbox - Mount Bracket, Brake Band Brake Band Guide 00- PTO Gearbox / Flange Pulley 0 4 Idler Pulley (") 4 Ground Drive Belt, Micro-V -6 Universal Joint Tube Assembly / Spline - Quick Coupler Installation Tool 4 - Clevis Pin W/Hole (/4 x /) 04 Brake Band (4-/) Drive Belt (VX0) 6- PTO Drive Pulley (4-//V) (Includes Items # F6 & F6) - Engine Pulley, Bolt On (4//V) (Includes Items # F6 & F6) 0 Engine PTO Belt Jackshaft Assembly Idler Pulley (/ Groove) Spacer Bushing (/6) 4 4- Idler Arm Inner Race (-/) 44 - Extension Spring (/4 x ) 4 Starter Relay Mount 46 6 Bearing W/Collar (/4) 4 4- Transmission Drive Pulley (-/4MV) (Includes Items # F06 & F) 4 Cable Clamp (/ x /4) 4 4 Transmission Belt Tightener Arm 0 - Hydro Jackshaft Mount 4- Hydro Jackshaft Mount Assembly * (Includes Items #,, 4, 46, 0 & ) Jackshaft (/4 x -/) 40-4 Jackshaft Drive Pulley (/V) (Includes Items # F06 & F) Fasteners F00 /4- Hex Nut /4-0 Keps Nut F00 /4-0 ESNA Nut F00 /6- Whiz Locknut F0 /-6 Keps Nut F0 /4-0 x / Hex Bolt F040 /-6 x -/ Hex Bolt F04 /-6 x -/4 Hex Bolt F04 /-6 x -/4 Hex Bolt F04 /-6 x Hex Bolt F04 /-6 x 4-/ Hex Bolt F04 AN6066 Washer F06 /4 Internal Star Lock Washer F06 /6 x /6 x Key F06 / x / Cotter Pin F00 -/4 Internal Snap Ring F00 /4-0 x -/ Hex Bolt F6 /4-0 x -/4 Hex Bolt F /6- x / x SHL Bolt F /6- x / Hex Bolt F /4-0 x -/4 Hex Bolt F6 /6 Split Lock Washer 4 F /6- x / Set Screw 4 F /4 x Fender Washer F /4 x / x / Washer F6 /64 x / Cotter Pin F6 /6- x / Hex Bolt 4 F4 x x 0 Washer F /6- x -/ Hex Bolt F6 AN6066L Washer F6 /-6 Jam Nut F /-6 ESNA LP Nut * Service Part Only
13 MAIN COMPONENT POWER TRANSMISSION (GHS MODELS) F F6 F6 F6 F00 F00 4 F04 6 F06 F F6 F6 6 F04 F6 F04 F 6 F F F06 F0 0 F00 F00 0 F6 4 F0 F6 F0 0 F00 F00 4 F04 F04 F6 F6 F 6 GHS Group 4 Hydrostatic Ground Drive Assemblies F040 0 F0 GHS Group Engine Group F F F F04 F F04 4 F4 F F06 F0 F 4 Hydrostatic Ground Drive Assemblies Hydrostatic Ground Drive Assemblies Body / Chassis Assembly (GHS Models) F0 F F F F F00 4 F6 F6 GHS Group F0 0
14 MAIN COMPONENT POWER TRANSMISSION (SD MODELS) ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Clutch Lever Assembly - Clutch Lever (Includes Items # & ) 0 Grease Fitting 40 Handle Grip, Black Clutch Actuator Bolt (/) 0- Knuckle Joint (/ ID) Compression Spring (/4 x -/) 0- Pushrod, Clutch Actuator (Threaded Tube) (Includes Item # ) 0-0 Clutch Actuator Rod Assembly (Includes Items #, 4-, F04, F6 & F) 0- Fiberglide Bearing Inner Race (-/4) 6 PTO Belt Tightener 4 Retainer Washer (/ x -/4) 4 4- Clutch Idler Pulley 4 Clutch Idler Pulley Assembly * (Includes Items # - & F00) 4 6 Bearing (/4) 4- Hub, Idler Pulley 6 PTO Belt Tightener Stop Plastic Washer ( x 4 x 0) Pivot Bearing (/6 x /6) - Clevis Spring Pin 0 0 Clevis (/4) 0 Brake Actuator Rod 0 Bearing, Brake Actuator - Clevis Pin (/4 x 00) 4 0 Brake Spring (/ x -/) 6 Brake Actuator (Includes Items # & ) PTO Drive Shaft Assembly Dipstick, Gearbox - Mount Bracket, Brake Band Brake Band Guide 00- PTO Gearbox / Flange Pulley 0 4 Idler Pulley (") 4 Ground Drive Belt, Micro-V -6 Universal Joint Tube Assembly / Spine - Quick Coupler Installation Tool 4 - Clevis Pin W/Hole (/4 x /) 04 Brake Band (4-/) Drive Belt (VX0) 6- PTO Drive Pulley (4-//V) (Includes Items # F6 & F6) - Engine Pulley, Bolt On (4//V) (Includes Items # F6 & F6) 0 Engine PTO Belt Jackshaft Assembly Idler Pulley (/ Groove) 4 6- Spacer Bushing (/6) 4 4- Idler Arm Inner Race (-/) 44 - Extension Spring (/4 x ) 4 Starter Relay Mount 46 6 Bearing W/Collar (/4) 4 4- Transmission Drive Pulley (-/4MV) (Includes Items # F06 & F) 4 Cable Clamp (/ x /4) Idler Pulley Spring Mount 0 4 Transmission Belt Tightener Arm - Hydro Jackshaft Mount 4- Hydro Jackshaft Mount Assembly * (Includes Items #,, 4, 46, & ) Jackshaft (/4 x -/) 40-4 Jackshaft Drive Pulley (/V) (Includes Items # F06 & F) Fasteners F00 /4- Hex Nut /4-0 Keps Nut F00 /4-0 ESNA Nut F00 /6- Whiz Locknut F0 /-6 Keps Nut F0 /4-0 x / Hex Bolt F040 /-6 x -/ Hex Bolt F04 /-6 x -/4 Hex Bolt F04 /-6 x -/4 Hex Bolt F04 /-6 x Hex Bolt F04 /-6 x 4-/ Hex Bolt F04 AN6066 Washer F06 /4 Internal Star Lock Washer F06 /6 x /6 x Key F06 / x / Cotter Pin F00 -/4 Internal Snap Ring F00 /4-0 x -/ Hex Bolt F6 /4-0 x -/4 Hex Bolt F /6- x / x SHL Bolt F /6- x / Hex Bolt F6 /6 Split Lock Washer 4 F /6- x / Set Screw 4 F /4 x Fender Washer F /4 x / x / Washer F6 /64 x / Cotter Pin F6 /6- x / Hex Bolt 4 F4 x x 0 Washer F /6- x -/ Hex Bolt F6 AN6066L Washer F6 /-6 Jam Nut F /-6 ESNA LP Nut * Service Part Only
15 MAIN COMPONENT POWER TRANSMISSION (SD MODELS) F F6 F6 F6 F00 4 F04 6 F04 F6 F04 F F 6 F F F06 F0 0 F00 F6 F F6 F0 F6 F6 F0 0 F00 F00 4 F04 F04 F6 F6 F 6 F00 F Hydrostatic Ground Drive Assemblies F040 0 F0 Engine Group F F 46 F04 F04 F F04 4 F4 F F06 F0 F00 4 Hydrostatic Ground Drive Assemblies Hydrostatic Ground Drive Assemblies Body / Chassis Assembly (GHS Models) F0 F F F F F F6 F6 GHS Group 0 F0
16 ENGINE GROUP ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Precleaner Assembly 06- Remote Precleaner (Includes Item # ) 440 Shock Mount ( x /4) 0-0 Rear Precleaner Mount 4 0 Elbow, Precleaner 40- Hose Clamp (-/" to ") 6 0- Air Flow Indicator (Vacuum 0" HO) 0- Air Cleaner Assembly * (Includes Items # 6, - & ) 0- Air Cleaner Band 00- Safety Filter Insert Air Cleaner Cartridge 0- Air Cleaner Draw Latch 0- Air Cleaner Cap (Includes Item # ) 00- Vacuator Valve Air Hose, Cleaner 0- Tube Support Arm Precleaner Tube, GHS/SD 0-4 Indicator Nipple Engine Assembly NS Fuel Pump (Kohler) - Hose Clamp (/) 4 0 NS Fuel Line, Engine (Kohler) * 00 Fuel Filter * NS Rectifier * 06-4 Regulator Mount 4 NS Oil Filter (Kohler 000) NS -hp Engine 6 4 Bumper, Rubber (0 OD x ) 00- Engine Bumper Mount Cable Clamp (/) Fuel Tank Assembly M46 Fuel Line, Tank (/4 x 0-/") ** 0 0- Bushing, Rubber M Fuel Line (/6 x ") ** 06- Hose (/4 x 6) 0 Fuel Tank Support Fuel Filter, In Tank 0- Fuel Tank, 4 Gallon, Gas (Black) (Includes Items # 0,, 4 & -40) /4 Ratchet Fuel Cap * 0- Fuel Tank Gauge - Roll Over Grommet (00 x -/) 04- Roll Over Valve Tank Tube Elbow (") Exhaust Assembly 4 0- Muffler Grass Shield (Includes Items # F00 & F0) 4 4 NS Screw (Kohler M-6406-S) 4 NS Gasket (Kohler) 44 NS Nut (Kohler) Muffler Upright Support 4 0- Muffler Heat Shield Muffler Heat Deflector W/Knurled Inserts 4 0- Muffler Heat Shield Endcap 0 0- Muffler Brace 0 Engine Brace Fasteners F Keps Nut /4-0 Keps Nut 6 F00 /6- Whiz Locknut F0 /-6 Keps Nut F0 0-4 x / PPHMS F x / PPHMS F0 /4-0 x / Hex Bolt 4 F0 /4-0 x / Hex Bolt F0 /-6 x Hex Bolt F00 /4 SAE Washer 4 F0 /6 External Star Lock Washer F0 /6 Int Star Lock Washer F06 /4 Internal Star Lock Washer 4 F06 / Internal Star Lock Washer F0 A/A66D Aluminum Pop Rivet F00 /4-0 x -/ Hex Bolt F0 /6- x / Hex Bolt F06 /-6 x / Hex Bolt F0 AN6046 Washer F 0-4 x / PTHMS F /4-0 x -/4 Hex Bolt F40 /6-4 x Hex Bolt F / Split Lock Washer 4 F /6- x -/ Hex Bolt F6 /6 SAE Washer F M6 x 0 Nut 4 F /- x -/ Hex Bolt 4 F4 M x x Hex Bolt F4 M6 x 0 x 4 Stud * Service Part Only ** Required hose specifications: M - /6" ID fuel/oil/vapor hose (Gates 4-00 or equivalent) M46 - /4" ID low permeation (<g/m^/day) fuel hose (Parker 04 or equivalent) NOTE: Kohler Engine Decal (NS) for Engine Identification Number
17 F F0 F0 F06 F06 F0 4 F F0 F40 F F06 F06 F0 F00 F00 F00 F0 F00 F00 F F F00 F F F4 F06 F00 F0 F00 F0 F F00 F00 F F F0 F00 F0 F4 F0 F0 F06 F0 F0 F0 ENGINE GROUP
18 HYDROSTATIC GROUND DRIVE ASSEMBLIES ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Transmission Lockout Assembly 0- Transmission Lockout Assembly * (Includes Items # -, F0, F0 & F0) 4 Plastic Tip 0 Lockout Cam (Includes Item # F0) 4 0- Lockout Lever 0- Lockout Mount ** Ground Drive Assemblies Bridge Assembly 64- Hydro Fan, CCW 06 Hydrostatic Drive, CW (00-0) 606- Air Vent Valve * Gear Axle Drive Assembly (Includes Items # & ) 60- Pipe Plug (/4 NPTF) 4 6 Cable Retainer (Uses existing bolt on Gear Axle Drive Assembly) 6- Pinion Gear 4 64 Spacer, Pinion Gear 60 O-Ring Seal 6 44 Hydro Pulley (-//MV) (Includes Items # F064 & F) 64- Hydro Fan, CW 0 Hydrostatic Drive, CCW (00-0) Deck Support Arm Assemblies Outboard Mount, LH Deck Support Arm, LH (Includes Item # 4) - Hitch Pin (# 6) 64- Deck Support Arm, RH (Includes Item # 4) 640- Outboard Mount, RH 4 0 Grease Fitting 640- Support Arm Bushing (-/6) Transmission Repair Parts 6 0- Input Shaft * 0- Bearing, Input Shaft * 0- Snap Ring * 0- Seal, Input Shaft * 0 0 Reservoir to Casting Gasket * 04 Reservoir Cap and Gasket * 0 Transmission Reservoir Kit * 0- Rubber Bladder * O-Ring & Plug Assembly * 0- Seal, Control Shaft * Fasteners F0 /-6 Keps Nut F0 0-4 ESNA Nut F0 0-4 x / PPHMS F06 /4-0 x / SBH Screw F0 /-6 x Hex Bolt 4 F040 /-6 x -/ Hex Bolt 4 F04 /-6 x Hex Bolt 6 F0 /6 Internal Star Lock Washer 4 F06 / Internal Star Lock Washer 6 F064 / x / Woodruff Key (#) 4 F0 A/A4D Aluminum Pop Rivet F60 External Snap Ring (66 Shaft) F /4 x Fender Washer F4 /6 x -/4 x / Washer F00 /6-0 x Grade Bolt F44 /6-0 x /4 Hex Bolt F6 /-6 x 4 Hex Bolt All Thread F /6- x /6 Set Screw 4 (Unbrako Knurl Point) * Service Part Only ** Part not used on Jackshaft side of tractor 6
19 HYDROSTATIC GROUND DRIVE ASSEMBLIES F0 F F0 F0 F06 F06 Main Component Power Transmission (GHS Models) F6 F6 F04 F06 F0 F0 F0 4 F F F60 F44 F0 4 F064 6 F06 F F064 F F F064 F F06 0 F00 F0 4 6 F040 F4 F4 4 F064 F60 F06 4 F0 F0 F44 F06 F04 F00 0
20 STEERING CONTROL ASSEMBLIES ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Transmission Spring Assemblies 60- Shock Mount Gear Drive, RH 46 0mm Ball Stud 4 - Steering Lever Dampener Assembly Shock Mount Gear Drive, LH 4- Ball Joint (/6-4) Nylon Lined 6 6- Transmission Control Arm, LH - Control Rod (6") 66- Compression Spring (-/) 46- Steering Lever Actuator 0 0- Fiberglide Bearing /" -4 Control Rod (4-/4") Transmission Control Arm, RH Steering Lever & FSC Assemblies FSC Actuator Rod 4 Bearing, Delrin ( ID x OD x 0) 4- FSC Actuator Cam 6 0 Grease Fitting 6 4 FSC Friction Washer (-/ x / x /6) 40- FSC Friction Body (Includes Item # 6) 4- FSC Key W/Stop 40- FSC Control Assembly * (Includes Items # -, F & F) 0 0- Handle Grip, Foam (-/) Extension Spring (/4 x -/) 40 D-Clip - Steering Lever Support 4 Pivot Pin, Steering Lever 4-0 Steering Lever Assembly, LH / Adjustable (Includes Items #, 0, 6, F60 & F4) 4- Steering Lever Arm, LH / Adjustable * Steering Lever Handle, Adjustable (Includes Items # 0 & F4) Extension Spring (/4 x 6-/4) 0 Clevis (/4") - Clevis Pin (/4 x 00) Speed Control Stop 40-0 Steering Lever Assembly, RH / Adjustable (Includes Items #, 0, 6, F60 & F4) 40- Steering Lever Arm, RH / Adjustable * 6 FSC Knob 0 FSC Lever Assembly (Includes Item # 6) 4 - Cable Tie (0# x ") Fasteners F00 /4- Hex Nut /4-0 Keps Nut 6 F00 /6- Jam Nut F00 /6-4 Keps Nut F00 /6- Whiz Locknut F00 /6-4 ESNA Nut F04 /6-4 Jam Nut F0 /4-0 x / Hex Bolt F0 /4-0 x /4 Hex Bolt 4 F04 /6- x /4 Hex Bolt F00 /4 SAE Washer F0 / SAE Washer F064 / x / Woodruff Key (#) F06 / x Cotter Pin F06 / x / Cotter Pin F0 /6- x Hex Bolt F x 00 x 04 Washer F6 /64 x / Cotter Pin F /4-0 Self-Locking Nut 4 F /-4 Self-Locking Nut F / Belleville Spring Washer F 0 x 6 x 040 Washer, SS F4 /4-0 x 0 Knurled Bolt 4 F /-6 ESNA LP Nut F60 /4-0 x / Hex Bolt F40 04 x x 00 Washer F4 Washer /4 x / x 00 * Service Part Only
21 STEERING CONTROL ASSEMBLIES F00 Hydrostatic Ground Drive Assemblies Electrical Assembly F0 6 Hydrostatic Ground Drive Assemblies F0 4 F F4 F60 F40 F4 0 F00 6 F F F F00 F0 4 F F0 F00 F6 F04 F F F04 4 F00 F00 6 F00 F06 F0 6 F00 6 F06 F064 F0 F F 0 F4 F00 F F 6 F04 F064 F0 F F00 F00 0 F4 F60
22 THROTTLE & CHOKE CONTROL ASSEMBLIES ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Throttle & Choke Control Assemblies - Throttle Cable - Choke Cable Bearing, Delrin ( x x 0) 4 0- Control Lock Tab 0-0 Friction Washer () 6 0- Control Lever, Throttle & Choke 0- Throttle Control Knob, Red 0- Friction Washer (06) 0- Control Bracket 0 0 Control Assembly (Includes Items # 4-6,, & F0) Throttle Control and Cable * Assembly (Includes Item # ) Choke Control and Cable * Assembly (Includes Item # ) 0-6 Choke Control Knob, Black Insulation Sleeve (/ x 6) - Cable Tie (# x -/4") Fasteners F Keps Nut 4 F00 /4-0 ESNA Nut F0 0-4 x / PPHMS 4 F00 /4 SAE Washer F x /4 x / SHL Bolt F0 /4 Belleville Spring Washer 4 * Service Part Only 0
23 THROTTLE & CHOKE CONTROL ASSEMBLIES F00 Body / Chassis Assembly (GHS Models) 0 F00 F0 4 6 Engine Group F64 F00 F00 F0 GHS Group
24 PARKING BRAKE ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Parking Brake Assembly 406- Handle Grip, Red 406- Parking Brake Lever (4-/4) 406- Lever Mount 4 0 Grease Fitting 40 Clevis Pin (/6 x /) Brake Actuator Arm 40 Pin, Transmission Lock 40 Clevis 40 Compression Spring (/ x /4) 0 4 Rubber Dust Shield (/ x / x /) 6- O-Ring Seal (/4 x /) 4 40 Plunger Bushing, Gear Axle 404- Brake Actuator Mount 4 4 Clevis Pin (/6 x /) Cable Clamp (/4) 6 40 Brake Control Cable, LH (") 40 Brake Control Cable, RH (0") 40- Cable Mount Bracket 40- Cable Pull Rod 0 Ball Joint (/4-) Fasteners F Keps Nut F00 /4- Hex Nut /4-0 Keps Nut 4 F0 0-4 x / PPHMS F0 /4-0 x / Hex Bolt F0 /4-0 x /4 Hex Bolt F04 AN6066 Washer F0 /4 E Retainer Ring F06 #0 SAE Washer 4 F0 / x / Roll Pin F / x /4 Cotter Pin F / x -/4 x 0 Washer F /6 x / Cotter Pin 4 F6 AN6066L Washer F /4- Keps Nut
25 PARKING BRAKE ASSEMBLY Body / Chassis Assembly (GHS Models) F0 0 F00 F F F0 F0 F6 4 F06 F06 6 F0 F0 F F6 0 6 F0 F00 F0 F00 4 F04 F F F0 F06 F F6 F04 F06 F F F Hydrostatic Ground Drive Assemblies
26 GHS GROUP ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Delivery Chute Assembly - Elbow Delivery Spout - Backing Plate, Grass-Pak Switch Rear Clip, Chute Mount 4 Side Clip, Chute Mount - Delivery Chute W/Clips / 00 (Includes Items #, 4, 6, F6 & F4) 6-0 Front Clip, Chute Mount 0-4 Body Chute (0 Blower) Blower Belt Tightener Assembly -6 Blower Drive Pulley (Includes Items # F0, F4 & F) 4- Blower Belt (Micro-V) 0 - Blower Pulley (Mirco-V) (Includes Items # F06, F0 & F4) 64- Torsion Spring 0- Fiberglide Bearing 0- Grease Fitting (4 Deg) Blower Belt Tightener Arm 0-4 Inner Race (-/) 6 4 Retainer Washer (/ x -/4) 4 Idler Pulley (") Blower Assembly 44 Blower Assembly (0") (Includes Items # -4,, F00, F0, F00, F, F6 & F46) 6 Bearing W/Collar (/4) Blower Housing (0) 4- Blower Output Shaft (0) 4 Blower Wheel (0") 4- Blower Faceplate (0) 4 6 Intake Tube (0 Blower) - Intake Cover / GHS 6-4 Skid Bar (0" Blower) Fasteners F Keps Nut 6 /4-0 Keps Nut F00 /6- Whiz Locknut F0 /-6 Keps Nut F x / PPHMS F0 /4-0 x / Hex Bolt F04 /6- x /4 Hex Bolt F0 /-6 x -/4 Hex Bolt F040 /-6 x -/ Hex Bolt F04 /-6 x -/4 Hex Bolt F00 /4 SAE Washer F04 AN6066 Washer F06 /6 x /6 x Key F0 /6- x / SQH Set Screw F0 A/A66D Aluminum Pop Rivet 6 F0 /6 Rivet Backup Washer F00 /4-0 x -/ Hex Bolt F4 /6- x / SQH Set Screw F 0-4 x / PTHMS 4 F /6- x / Hex Bolt F /4-0 x -/4 Hex Bolt F6 /6 Split Lock Washer F /6-4 Hex Nut F /6 Split Lock Washer F /4 x /4 Woodruff Key (# 06) F /6-4 x -/4 Hex Bolt F6 A/A6D Alum Pop Rivet (/6D x /L) F4 /6 Bulbex Rivet 6 F46 /4-0 x / Carriage Bolt 4
27 GHS GROUP Electrical Connectors F06 F0 Electrical Assemblies (GHS 00 Bushel Components) Main Component Power Transmission (GHS or SD Models) 4 F4 F4 F00 F0 F F6 6 F F4 4 F0 F4 F06 F4 F0 0 F00 F F46 F040 F00 F0 F04 6 F04 4 Main Component Power Transmission (GHS Models) F0 0 F00 F6 F F0 F00 4 Body / Chassis Assembly (GHS Models) F00 F F 6 F0 F04 F0 F
28 GHS POWERFIL ASSEMBLY (00) ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D 00 GHS Powerfil Assembly - Bearing Cap, Powerfil - Pivot Bearing (#SPP) - Pivot, Delivery Spout 4 - Pivot Mount Ball Joint (/4-) 6 - Powerfil Push Rod - Bushing, Powerfil Actuator 4 - Compression Spring (/ x ) - Powerfil Actuator Rod 4 Actuator Rod Assembly * (Includes Items # - & F00) 0 4 Actuator Arm - Motor Mount Nut (/-4) * - Motor Mount Washer * 6- Grommet (/6 x /4) 4 - Actuator Motor (V) (Includes Items # & ) Fasteners F Keps Nut 0 F00 /4- Hex Nut F x / PPHMS F0 0-4 x / PTH Screw F04 AN6066 Washer F0 /6 Rivet Backup Washer F0 0-4 x -/4 SHC Screw F0 / x / Roll Pin F 0-4 x / PTHMS 6 F6 AN6066L Washer F /4- Keps Nut * Service Part Only 6
29 GHS POWERFIL ASSEMBLY (00) F0 F00 0 F0 F00 F00 F06 4 F00 Electrical Assemblies (GHS 00 Bushel Components) F00 6 F6 F00 F0 Electrical Assemblies (GHS 00 Bushel Components) 4 F F04 F F00 F0 F F0 F F00 GHS Group
30 GHS 00 BUSHEL CATCHER ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Upper Baffle Screen Assembly (Removable) - Removable Screen (/6 Hole) ** (Includes Items #,, F0 & F0) 06 Knob / Threaded Insert (0-4) 606- Channel Top, LH Channel Bottom 6- Edge Molding (6") 6 0 Screen Seal (-/) 0 Mustache Spring 606 C-Channel (00) C-Channel With Spring (00) * (Includes Items #, & F40) Channel Top, RH 00 Exhaust Deflector Door Assembly Upper Seal Support 60- Upper Door Seal 60- Backup Plate Catcher Box Door, Gray (Includes Items # 0-4, 6,, F0, F0 & F4) 4 Handle 60- Door Mount, LH Upper Door Stiffener 60- Lower Door Stiffener 60- Door Guide 60- Door Mount, RH GHS 00 Bushel Catcher Assembly Center Strap 60- Upper Frame Doubler 60- Outside Box Strap, LH 60- Lower Frame Doubler Center Frame Doubler 60- Catcher Door Finger Catcher Mount 60-4 Catcher Dump Flap W/Plate Backing Plate, Dump Flap 4 Reinforcing Strap 0 0- Pivot Bushing Inner 0- Decal Plate, Round (Set of ) 60- Pivot Bushing (/ x /6) 60- Hinge Plate, LH 4 0- Outside Torsion Bushing 60-4 Upper Arm 6 4- Ball Joint (/6-4) 4 - /6 Ball Stud -4 Gas Spring 4 Spring Clip Gas Spring Cover, LH Lower Arm Pivot Bushing Outer 4 - /4 Ball Stud 44-6 Gas Spring Plate Box Support, Gas Spring 46 - Handle, Catcher Lift 4 - Grommet (/6) 4 Grommet (/ x / x /6) 4 Wire Harness Channel Catcher W/O Powerfil, Gray * (Includes Door) Catcher W/Powerfil, Gray * (Includes Door) Bushel Catcher Box, Gray * 60- Powerfil Cover Plate - Gas Spring Cover, RH 60- Hinge Plate, RH Torsion Bar - Optional Dump Bag (Not Shown) May be ordered as an option Contact your Walker dealer Fasteners F Keps Nut /4-0 Keps Nut F00 /6- Whiz Locknut 4 F00 /6- ESNA Nut F04 /6-4 Jam Nut 4 F0 0-4 x / PPHMS 4 F x / PPHMS F0 0-4 x / PPHMS 6 F0 /4-0 x / Hex Bolt 0 F04 /6 SAE Washer F00 /4 SAE Washer F06 / x Cotter Pin F0 A/A66D Aluminum Pop Rivet 4 F0 /6 Rivet Backup Washer F04 - x / PTHMS 6 F 0-4 x / PTHMS F0 #0 Internal Star Lock Washer F /4-0 x /4 PPHMS, SS 4 F6 /4-0 x PPHMS, SS 4 F0 /6- x -/4 Hex Bolt F0 /4-0 x -/4 PPHMS, SS 4 F4 /4-0 x / PPHMS, SS F0 /6D x /L Rivet, SS F40 Rivet, Aluminum 4 F Aluminum Pop Rivet 6 F60 /4-0 x / Hex Bolt F0 /4-0 x / Carriage Bolt 4 F4 /6 Bulbex Rivet 0 F46 /6- x /4 SBH Cap Screw, SS 4 F0 /4-0 x -/ PPHMS, SS * F4 /6 x / Aluminum Rivet, Black 6 Service Part Only ** This screen can be replaced by P/N - Removable Screen (/4" holes) for improved air flow performance in wet conditions
31 GHS 00 BUSHEL CATCHER ASSEMBLY F F00 F 4 F00 F06 F0 F04 F0 F0 F F00 F F00 F F00 F0 4 F F0 Rear Body Assembly (GHS Models) F F0 F0 F 0 F F04 F04 F F00 4 F40 F46 F00 F00 F00 F00 F00 6 F46 F F F F0 F F00 4 F00 F00 4 F06 F40 F00 0 F00 F40 F04 4 Rear Body Assembly (GHS Models) F40 F F00 0 F0 F F06 F04 F4 F4 F00 F4 F0 F00 F F0 F0 F0 F6 F00 4 F 0 F0 F00 F00 F00 F 4 F 44 4 F0 F0 F0 4 F0 F6 6 F F F0 4 4 F F04 4 F0 F0 F0 F0 F60 F0 F00 F04 F04 F F46 F04 F0 F46 F60 F00 F0 F0 F F04 F0 F00 F00 0 F06 F0 F0 4 F0
32 INSTRUMENT PANEL ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Instrument Panel Assembly 0- Instrument Panel Cover (Optional) ** 06-4 Instrument Panel Assembly (Includes Items # -,, -,, F, F0, F & F4) 0- Panel Frame 0- Panel Faceplate W/Decal 4 6 Panel Gasket 64 Relay Switch (0/40 Amp) NC (Includes Items # & 0) 6 4- Boot, Circuit Breaker 4- Circuit Breaker ( Amp) - Switch Boot Toggle Switch (Off-On) 0 Voltmeter Gauge 0- Hourmeter (Global) - Cable Tie (# x -/4") 4- Wire Harness, Instrument Panel Lining, Panel Box (/) Panel Box Mount Plate 6 - Grommet (/ x -/6) 0- Shock Mount (0 x ) Panel Box W/Graphic 64-6 Relay Switch (0/40 Amp) * Relay Mount * 6 Warning Horn 60- Ignition Switch (with Keys) (Includes Items # 4, & F4) 6- Red Indicator Light Assembly 4 4 Plastic Tip, Red 60- Key Set W/Umbrella * Fasteners /4-0 Keps Nut 6 F #6 x / PPHSMS, SS F J Clip, Instrument Panel F0 6- x / PPHMS F 6- Keps Nut F4 Washer ID OD, SS * Service Part Only ** May be ordered as an option Contact your Walker dealer NOTE: ELECTRICAL CONNECTORS, Page 6 for identification of all Electrical Wiring Service Parts 0
33 INSTRUMENT PANEL ASSEMBLY DETAIL H F 4 F4 F0 4 6 DETAIL F DETAIL G GRA 0 I DETAIL I YEL YEL DETAIL C YEL DETAIL B BLU /WHT WHT DETAIL D B GRN GRA DETAIL E BRN/ GRA WHT C F ORG D E F F G J K H GRN GRN WHT DETAIL K ORG BRN/WHT 4 0 DETAIL J GRA BLU BLU YEL /WHT A 6 DETAIL A BLU 0 F END VIEWS ARE SHOWN FROM BACK OF PLUG
34 ELECTRICAL ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Harness Assembly - Cable Tie (0# x ") Safety Switch (NO) Cable Clamp (/4) Wire Harness Cable Clamp (/) 6 0 Wire Harness ( / 00) 0-6 Regulator Adapter Harness - Cable Clamp ( x /4) 64 Relay Switch (0/40 Amp) NC (Includes Items # & 0) Time Delay Module 4- Time Delay Harness 4 Circuit Breaker (0 Amp) Auto Reset / Sealed 4 Positive Battery Lead Wire (Red) 4 4- Safety Switch (NO) - Cable Tie (# x -/4") 6 4- Safety Switch (NO) 0-6 Riser Plate, Seat Switch -6 Grommet ( x -/4) 64- Relay Mount * Relay Switch (0/40 Amp) * Fasteners F Keps Nut 0 /4-0 Keps Nut 4 F00 /6- Whiz Locknut F0 /4-0 ESNA Wing Nut F0 0-4 x / PPHMS F x / PPHMS F0 /4-0 x / Hex Bolt F0 /4-0 x /4 Hex Bolt F00 /4 SAE Washer 4 F06 /4 Star Lock Washer F0 A/A66D Aluminum Pop Rivet 4 F0 /6 Rivet Backup Washer F0 /6- x Hex Bolt F4 0- x / Taptite Machine Screw F 0-4 x / PTHMS F 0- Keps Nut F4 M6 x 0 x SCH Screw * Service Part Only NOTE: ELECTRICAL CONNECTORS, Page 6 for identification of all Electrical Wiring Service Parts Battery Assembly 6 Negative Battery Cable Battery Terminal Insul, Red (+) 44- Battery Hold-Down Bar 4 Hook Bolt 0- Battery Pan 6 NS Battery (V/00CCA/Dry) Battery Terminal Insul, Black (-) 4- Wire Saddle ( Wires)
35 ELECTRICAL ASSEMBLY DETAIL E DETAIL F WHT GRN GRN Electrical Assemblies (GHS 00 Bushel Components) DETAIL G ORG ORG 6 F00 F06 G DETAIL D GRN BRN GRA Main Component Power Transmission (GHS or SD Models) DETAIL B ORG B F06 F0 F00 BRN /WHT GRA WHT F00 GRA WHT GRN BRN 4 F4 H To Kohler Engine F0 F0 F4 Engine Group To Kohler Engine I F0 DETAIL A GRA /YEL GRA F0 F06 A F00 F0 F0 F0 6 F00 F0 F00 F F00 4 F00 F0 F00 C F06 BRN/ WHT D 0 F F0 F00 DETAIL C BRN E F Main Component Power Transmission (GHS Models) F4 F0 Instrument Panel Assembly DETAIL H YEL GRN WHT BLU DETAIL I WHT WHT F END VIEWS ARE SHOWN FROM BACK OF PLUG 6 F0 F00 F0
36 ELECTRICAL ASSEMBLIES (GHS 00 BUSHEL COMPONENTS) ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D 00 Harness Components -4 Adapter Harness - Cable Tie (# x -/4") Frame Clip (/6) Cable Tie (0# x ") 6- Horn, Full Signal * 6 0 / 00 Wire Harness - Grommet, Cut (/ x /) Grass-Pak Switch Assemblies 4-6 Aluminum Shaft & Vane Assembly - Grass-Pak Switch Assembly 0 Cable Clamp (/4) Fasteners F Keps Nut 4 F0 0-4 x / PPHMS F0 0-4 x / PTH Screw F 0-4 x / PTHMS F Keps Nut, SS F x / Hex Head, SS * Service Part Only NOTE: ELECTRICAL CONNECTORS, Page 6 for identification of all Electrical Wiring Service Parts 4
37 ELECTRICAL ASSEMBLIES (GHS 00 BUSHEL COMPONENTS) GHS Powerfil Assembly (00) F00 A /WHT F F GHS 00 Bushel Catcher Assembly 4 to (+) /WHT GHS 00 Bushel Catcher Assembly B Electrical Assembly to (-) GHS 00 Bushel Catcher Assembly 6 GHS Group F0 GHS Group F00 0 F00 DETAIL A WHT /WHT /WHT 0 F0 F0 F0 F0 DETAIL B /WHT END VIEWS ARE SHOWN FROM BACK OF PLUG
38 ELECTRICAL CONNECTORS ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Electrical Wiring Service Parts GA Butt Connector * GA Butt Connector * GA Shrink Connector * GA Shrink Connector * - Wire Terminal Adapter * GA Bullet Conn, Male * GA Bullet Conn, Female * GA Spg Loaded Term, Female * 40- Wire Clip, Female * 0 6 /4 x 6-4 GA QKS Term, Female * 6- /6 x - GA QKS Term, Female * GA QKS Term, Female GA Spg Loaded Term, Male * * /4 x - GA QKS Term, Male * GA Ring Term (#) Nylon Insulated * 6 6- /4 x 6-4 GA QKS Term, Male * 6-6 GA Ring Lug (/6) * 6- - GA Ring Term, #0 * GA Ring Term (/6) * GA Ring Term (/6) * GA Ring Term, # 0 * GA Ring Term (/) * GA Ring Terminal (/4) * GA Ring Term (/4) * GA Ring Term (/4) * GA Ring Term, #0 * 4-4 Single Connector, Male * 4 -Way Connector, Male * 4- -Way Locking Connector, Female * Way Connector, Male * 4- -Way Connector, Female * 4-0 -Way Locking Connector, Male * 40- -Way Connector, Male * Way Connector, Male * 44 -Way Locking Connector, Male * Way Locking Connector, Female * 4-4-Way Connector, Male * 4-4-Way Connector, Female * 4- -Way Connector, Male * Way Connector, Male * Way Connector, Female * Way Connector, Male Way Connector, Male * * Way Connector, Male * Way Connector, Female * Way Connector, Male * Way Connector (M) * Way Connector (Female) * Packard Plug (Male) * Packard Plug (Female) * * Service Part Only NOTE: Not all Electrical Connectors are used with all assemblies NOTE: ELECTRICAL ASSEMBLY, Page for locations of Wiring Harness and of all Electrical Wiring Service Parts 6
39 ELECTRICAL CONNECTORS
40 LUBRICATION POINTS ITEM LOCATION LUBRICATION NO NO TYPE PLACES ITEM LOCATION LUBRICATION NO NO TYPE PLACES Lubrication Points Steering Lever Pivot Grease 4 Body Hinge Point Oil Deck-to-PTO Coupling Grease (Grease Spline Slide Area) 4 FSC Actuator Rod Pivot Pins Oil (FSC) Friction Body Pivot Grease 6 FSC Lever Pivot Grease FSC Lever Fork Grease (Grease Slide Area) Deck Support Arm Pivot Grease Universal Joint Tube Assembly Grease* 0 Parking Brake Lever Grease Universal Joint Quick Connect Grease Spline (Grease Slide Area) Gear Axle Oil** Belt Tightener Pivot, Grease Jackshaft Drive 4 PTO Clutch Lever Pivot Grease Clutch Actuator Push Rod Grease 6 Belt Tightener Pivot, Grease PTO Clutch Brake Actuator Rod and Brake Oil Band Pivot Pins (Clevis) Brake Actuator Pivot Grease Throttle Control Cable Ends Oil 0 Catcher Hinge Point Oil Rear Wheel Bearings Grease Choke Control Cable Ends Oil Engine Oil Oil** 4 Belt Tightener Pivot, Grease Blower Drive (GHS Model Only) Belt Tightener Pivot, Grease Ground Drive 6 PTO Gearbox Dipstick Oil** Hydrostatic Drive Oil** Choke Control Pivot Oil Throttle Control Pivot Oil * Grease every eight () hours ** MT Owner s Manual for procedure for checking and changing oil in Engine Crankcase, Hydrostatic Transmissions and Gear Axles NOTE: See Model MT Owner s Manual (P/N 000-6) for proper lubrication intervals
41 LUBRICATION POINTS 4 6 & &
42 WIRING SCHEMATIC ORG R POWERFIL MOTOR YEL - HORN + BLU GRASS PAK SWITCH STARTER STARTER SOLENOID R WALKER MODEL T IGNITION SWITCH CIRCUITS OFF G + M START B + A / S + S RUN B + A S = START CIRCUIT S = START/ACCESSORY CIRCUIT M = MAGNETO GROUND CIRCUIT B = BATTERY CIRCUIT A = ACCESSORY CIRCUIT G = GROUND CIRCUIT RELAY - B IGNITION RELAY OFF 0 + A START 0 + A PTO ON OPEN WHT GRN WHT GRN MAGNETO REGULATOR OIL PRESSURE SWITCH ENGINE RELAY - A START RELAY OFF OPEN START 0 + RUN OPEN OFF START RUN RELAY - C DELAY RELAY 0 + A OPEN OPEN BLU OIL TEMP SWITCH OPTIONAL LIGHT GRA CYLINDER HEAD TEMP SWITCH GRA OPTIONAL LIGHT WHT YEL WHT YEL GRA GRA BLU GRN BLU GRN LIGHTS HOUR METER - + WHT FSC NEUTRAL INTERLOCK SWITCH BRN/WHT VOLTAGE METER - + GRN BRN 0 AMP CIRCUIT BREAKER BATTERY + _ CHASSIS GROUND RELAY - C GRN SEAT SWITCH 6 A 0 WHT GRA /YEL GRN TIME GRA DELAY MODULE PTO INTERLOCK SWITCH GRA BRN ORG BLU AMP CIRCUIT BREAKER BRN/WHT - HORN + BLU BLU YEL BLU OIL PRESSURE LIGHT OVER TEMP LIGHT B M G S S A WHT BRN GRA RELAY - B 0 A PTO RELAY - A YEL /WHT ORG 40
43 WHAT THIS WARRANTY COVERS, AND FOR HOW LONG: LIMITED WARRANTY FOR WALKER COMMERCIAL RIDER MOWER Walker Manufacturing company will, at its option, repair or replace, without charge, any part covered by this warranty which is found to be defective in material and/or workmanship within one () year* after date of sale to the original retail purchaser unless the product is used for rental purposes, in which case this warranty is limited to ninety (0) days At Walker s request, customer will make the defective part available for inspection by Walker and/or return the defective part to Walker, transportation charges prepaid All parts and components of the Walker Mower are covered by this warranty except the following components which are warranted separately by their respective manufacturers: Kohler Engine Battery The available warranties covering these items are furnished with each mower Walker does not assume any warranty obligation, liability or modification for these items, which are covered exclusively by the stated warranty of the respective manufacturers noted above * Extended warranties are offered for the following powertrain components: A three () year unlimited hour warranty is offered for the Walker P/N 600- Gear Axle Assembly A three () year or 000 hour (whichever comes first) warranty is offered for Eaton Model Hydrostatic transmissions; covers full cost of replacement up to 000 hours of use, and after 000 hours warranty coverage is prorated against 000 hours WHAT THIS WARRANTY DOES NOT COVER: A This warranty does not cover defects caused by depreciation or damage caused by normal wear, accidents, improper maintenance, improper use or abuse of the product, alterations, or failure to follow the instructions contained in the Operator s Manual for operation and maintenance B The customer shall pay any charges for making service calls and/or for transporting the mower to and from the place where the inspection and/or warranty work is performed HOW TO OBTAIN SERVICE UNDER THIS WARRANTY: Warranty service can be arranged by contacting the dealer where you purchased the mower or by contacting Walker Manufacturing Company, East Harmony Road, Ft Collins, CO 0 Proof of the date of purchase may be required to verify warranty cover age 4 WARRANTY LIMITATION: A THERE IS NO OTHER EXPRESS WARRANTY ANY WARRANTY THAT MAY BE IMPLIED FROM THIS CHASE INCLUDING MERCHANTABILITY AND FITNESS FOR A PARTICULAR POSE IS HEREBY LIMITED TO THE DURATION OF THIS WARRANTY AND TO THE EXTENT PERMITTED BY LAW ANY AND ALL IMPLIED WARRANTIES ARE EXCLUDED Some states do not allow limitations on how long an implied warranty lasts, so the above limitations may not apply to you B WALKER WILL NOT BE LIABLE FOR ANY INCIDENTAL, CONSEQUENTIAL, OR SPECIAL DAMAGES AND/OR EXPENSES IN CONNECTION WITH THE CHASE OR USE OF THE MOWER Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation(s) or exclusion(s) may not apply to you C Only the warranty expressed in this limited warranty shall apply and no dealer, distributor, or individual is authorized to amend, modify, or extend this warranty in any way Accordingly, additional statements such as dealer advertising or presentations, whether oral or written, do not constitute warranties by Walker, and should not be relied upon D This warranty gives you specific legal rights, and you may also have other rights which vary from state to state 4
44 WALKER MFG CO E HARMONY ROAD, FORT COLLINS, CO 0 (0) -64 FORM NO 0 PRINTED IN USA wwwwalkermowerscom 0 WALKER MFG CO
Illustrated Parts Manual
Illustrated Parts Manual Beginning S/N: 15718 Effective Date: 115 P/N 000-17 KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation What it Represents º (Dimension)Degrees (Angle) " (Dimension)inches (-)Negative
More informationILLUSTRATED PARTS MANUAL
ILLUSTRATED PARTS MANUAL Model MT (20.0 HP / 25.0 HP & 26.0 HP EFI) (Covers Serial Numbers 98-37480 and on) Effective Date: P/N 8000-4 Bound P/N 8000-5 3-Ring 3/29/00 Price $5.00 KEY TO ABBREVIATIONS USED
More informationIllustrated Parts Manual
Illustrated Parts Manual Beginning S/N: 128442 Effective Date: 050514 P/N 5000-2 KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation What it Represents º (Dimension)Degrees (Angle) " (Dimension)inches
More informationIllustrated Parts Manual
588-2 0 lb ft (8 N m) 800-9 800-58- Illustrated Parts Manual Multi Deck and Carrier Frame Assemblies DU2-2 DU2A-2 DU8-2 Effective Date: 0725 P/N 5000-0 KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation
More informationIllustrated Parts Manual
Illustrated Parts Manual Beginning S/N: 18901 P/N 000-0 KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation What it Represents º (Dimension)Degrees (Angle) " (Dimension)inches (-)Negative (Polarity)
More informationIllustrated Parts Manual
Illustrated Parts Manual Beginning S/N: 125166 Effective Date: 10-23-13 P/N 4000-10 KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation What it Represents º (Dimension)Degrees (Angle) " (Dimension)inches
More informationIllustrated Parts Manual
Illustrated Parts Manual Beginning S/N: 60 Effective Date: 00 P/N 000- KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation What it Represents º (Dimension)Degrees (Angle) " (Dimension)inches (-)Negative
More informationILLUSTRATED PARTS MANUAL
ILLUSTRATED PARTS MANUAL Model MDD (0.9 HP Diesel) (Covers 00 Production) TM Effective Date: P/N 000-0-0-0 Price $.00 KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation What it Represents º (Dimension)...
More informationIllustrated Parts Manual
Illustrated Parts Manual Beginning S/N: 1400 P/N 000- KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation What it Represents º (Dimension)Degrees (Angle) " (Dimension)inches (-)Negative (Polarity) (+)
More informationILLUSTRATED PARTS MANUAL
ILLUSTRATED PARTS MANUAL Model MBS9 Beginning S/N: 58 Effective Date: 0-9- P/N 000-6 KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation What it Represents º (Dimension)Degrees (Angle) " (Dimension)inches
More informationParts Manual SERIES CVT Lawn Tractor. Model LT1040 CUB CADET LLC, P.O. BOX CLEVELAND, OHIO PRINTED IN U.S.A.
Parts Manual CVT Lawn Tractor SERIES 000 Model LT00 PRINTED IN U.S.A. CUB CADET LLC, P.O. BOX CLEVELAND, OHIO -00 FORM -00C.fm (//00) SERIES 000 CVT LAWN TRACTORS TABLE OF CONTENTS DESCRIPTION PAGE Axle,
More informationChampion Series Zero-Turn Riders & Mower Decks
Parts Manual Champion Series Zero-Turn Riders & Mower Decks HP Tractors Mfg. No. Description Champion, HP Zero-Turn Rider Champion, HP Zero-Turn Rider (CE) 0HP Tractors Mfg. No. Description Champion, 0HP
More information365L (2001) Page 1 of 36 54" Deck Assembly
365L (2001) Page 1 of 36 54" Deck Assembly 365L (2001) Page 2 of 36 54" Deck Assembly 1 720-0241 1 S Wing Nut Knob 2 703-2817 1 Belt Cover LH 3 703-2816 1 Belt Cover RH 4 747-3306 1 Idler Spring Mounting
More information13AU609H063 (1999) Page 1 of 25 Axle & Wheels Front And Steering Assembly
13AU609H063 (1999) Page 1 of 25 Axle & Wheels Front And Steering Assembly 13AU609H063 (1999) Page 2 of 25 Axle & Wheels Front And Steering Assembly 1 683-0304 1 S Frame 2 710-0604A 1 /P Self-tapping Screw,
More informationS/N 1H019H - 1H310H Page 1 of 33 46" Cutting Deck Assembly
1180 S/N 1H019H - 1H310H Page 1 of 33 46" Cutting Deck Assembly 1180 S/N 1H019H - 1H310H Page 2 of 33 46" Cutting Deck Assembly 1 17982 1 S Reinforcement Spindle Plate 2 618-0430 1 S Spindle Assembly w/
More informationCommercial Walk-Behind Mower Fixed Deck, Pistol Grip, Hydro Drive with 48in TURBO FORCE Cutting Unit
Form No. 3391-869 Rev A Commercial Walk-Behind Mower Fixed Deck, Pistol Grip, Hydro Drive with 48in TURBO FORCE Cutting Unit Model No. 39938 Serial No. 315000001 and Up Register at www.toro.com. Original
More informationCommercial Walk-Behind Mower Fixed Deck, Pistol Grip, Gear Drive with 32in Cutting Unit
Form No. 3391-559 Rev A Commercial Walk-Behind Mower Fixed Deck, Pistol Grip, Gear Drive with 32in Cutting Unit Model No. 30632 Serial No. 315000001 and Up Register at www.toro.com. Original Instructions
More informationForm No Rev A. DH 140 Lawn Tractor Model No Serial No and Up
Form No. 3369-934 Rev A DH 140 Lawn Tractor Model No. 74560 Serial No. 311000001 and Up Register at www.toro.com. Original Instructions (EN) Ordering Replacement Parts To order replacement parts, please
More informationIllustrated Parts List
Illustrated Parts List Hydrostatic Lawn Tractor IMPORTANT: Read safety rules and instructions carefully before operating equipment. Warning: This unit is equipped with an internal combustion engine and
More information14A6816H190 GT-2150 (2003) Page 1 of 28 Carburetor
14A6816H190 GT-2150 (2003) Page 1 of 28 Carburetor 14A6816H190 GT-2150 (2003) Page 2 of 28 Carburetor TC-640221 1 /P Carburetor (Incl 184 of Engine Parts Lists) 1 TC-640216 1 Throttle Shaft & Lever Assembly
More informationREAR ENGINE RIDER 42 MOWER SERIES 22
Parts Manual for REAR ENGINE RIDER MOWER SERIES MODELS 1BVE CONTENTS DESCRIPTION PAGE(S) DESCRIPTION PAGE(S) WHEELS- TIRES... - FRONT END, STEERING.... - MAIN CASE... - DIFFERENTIAL, R. H. FENDER... 8-9
More informationYARD CRUISER HYDRO DRIVE HZ SERIES 3 & YZ SERIES 4
Parts Manual for HYDRO DRIVE HZ SERIES 3 & YZ SERIES 4 MODEL HZS15423KVE HZS18483BVE YZ16424BVE YZ20484BVE McDonough, GA, 30253 U.S.A. COPYRIGHT 2005 SNAPPER PRODUCTS, INC. ALL RIGHTS RESERVED. Revision
More informationTimeCutter MX 5060 Riding Mower Model No Serial No and Up
Form No. 3371-775 Rev B TimeCutter MX 5060 Riding Mower Model No. 74641 Serial No. 312000001 and Up Register at www.toro.com. Original Instructions (EN) *3371-775* B Ordering Replacement Parts To order
More informationPacer Series Transaxle Drive Walk-Behind Mower
Parts Manual Pacer Series Transaxle Drive Walk-Behind Mower 15HP Product Mfg. No. Description 1694895 Pacer, 15HP B&S Walk-Behind 2690447 Pacer, 15HP B&S w/34" Deck 17HP Product Mfg. No. Description 5900630
More informationPARTS CATALOG ODYSSEY INCLUDES MOWER
PARTS CATALOG 8-3350 ODYSSEY INCLUDES MOWER INDEX PAINT ENGINES GENERAL INFO PRODUCT IDENTIFICATION NUMBERS (P.I.N.) OR SERIAL NUMBERS (S/N) ENGINE MODEL, SERIAL AND SPECIFICATION NUMBERS TRACTOR MODEL
More informationS/N 1H019H - 1H310H Page 1 of 48 42" Cutting Deck Assembly
1170 S/N 1H019H - 1H310H Page 1 of 48 42" Cutting Deck Assembly 1170 S/N 1H019H - 1H310H Page 2 of 48 42" Cutting Deck Assembly 4 683-0254 1 S Deck Adjustment Bracket w/ Weld Nut 9 710-0528 1 /P Hex Cap
More informationHydro Cut Series Walk-Behind Mowers
Parts Manual HP Product Mfg. No. Description 92 Hydro Cut, HP Kawasaki, 2 inch (CE) Hydro Cut Series Walk-Behind Mowers Rev. 0/200 Table Of Contents PRODUCT COMPONENTS PAGES Engine Deck & Handle Bars
More information25 Horsepower Hydrostatic Zero-Turn Commercial Riding Mower
MMZ 2, 260 2 Horsepower Hydrostatic Zero-Turn Commercial Riding Mower ILLUSTRATED PARTS LIST " Float Cutter Deck - Figure 1 3 1 27 32 17 6 1 11 31 36 3 19 7 23 1 33 38 18 37 22 3 20 2 10 2 12 21 30 39
More informationTimeCutter MX 5050 Riding Mower
Form No. 3388-237 Rev C TimeCutter MX 5050 Riding Mower Model No. 74770 Serial No. 315000001 and Up Register at www.toro.com. Original Instructions (EN) *3388-237* C Ordering Replacement Parts To order
More informationMid-Size ProLine, T-Bar, Gear Drive 13 HP with 91cm Side Discharge Mower
Form Number 3350-754 Rev B Mid-Size ProLine, T-Bar, Gear Drive 13 HP with 91cm Side Discharge Mower Model No. 30314TE - 250000001 and up. Parts Catalog Ordering Replacement Parts To order replacement parts,
More informationDH 210 Lawn Tractor. Model No Serial No and Up * * A. Register at Original Instructions (EN)
Form No. 3404-439 Rev A DH 210 Lawn Tractor Model No. 74585 Serial No. 313000001 and Up Register at www.toro.com. Original Instructions (EN) *3404-439* A Ordering Replacement Parts To order replacement
More informationMid-Size ProLine, Pistol Grip, Gear Drive 15 HP with 36in Side Discharge Mower
Form Number Mid-Size ProLine, Pistol Grip, Gear Drive 15 HP with 36in Side Discharge Mower Model No. 30529-250000001 and up. Parts Catalog Ordering Replacement Parts To order replacement parts, please
More informationCommercial Debris Blower. Parts Manual. Patent Number 7,841,004,B1
Commercial Debris Blower Parts Manual Patent,81,00,B1 REV. 0/1/01 Blower BLOWER COMPONENTS 1 --660 Safety Cover Locking Button 1--00 Safety Cover 1 18 /-18 x / Flange Bolt 1--00 Safety Cover Ring 1 1 /-18
More informationParts Manual Zero Turn Mower / Z 254i
Parts Manual Zero Turn Mower / Z 254i 967324201-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support
More informationM-ZT 61. Parts Manual. Zero Turn Mower /
Parts Manual M-ZT 61 Zero Turn Mower / 967177008-01 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support
More informationPart s Catalog. LX500 Lawn Tractor. Model No. 13AP60RP744. Original Instructions (EN) (01/31/06)
Part s Catalog For Parts Call 0-- or 0-- LX00 Lawn Tractor Model No. AP0RP Original Instructions (EN) -0 (0//0) For Parts Call 0-- or 0-- Model P0RP NUMBER --00 Turf Tire, 0 x 0.0 x -000-00 Rim,.0 x.0-0-0
More informationPart s Catalog. GT2100 Garden Tractor. Model No. 14AP80RP744. Original Instructions (EN) (01/31/06)
Part s Catalog GT0 Garden Tractor Model No. AP0RP Original Instructions (EN) -0 (0//0) Model P0RP -0-00 Turf Tire, x. x -0-00 Rim,.0 x.0-00 Lug Nut, /- -00A-0 Wheel Assembly, x. x -00-00 Rim Assembly,.0
More informationHydrostatic Zero-Turn Commercial Riding Mower
Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment 54" Fabricated Deck ILLUSTRATED PARTS LIST TABLE OF CONTENTS Frame Assembly.................................. 3 54" Fabricated
More informationHydrostatic Zero-Turn Commercial Riding Mower
Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment 0" Fabricated Deck ILLUSTRATED PARTS LIST TABLE OF CONTENTS Frame Assembly.................................. 3 0" Fabricated Cutter
More informationParts Manual Zero Turn Mower / Z 248F
Parts Manual Zero Turn Mower / Z 248F 967262501-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support
More informationParts Manual MZ5225 /
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. Parts Manual MZ5225 / 966690502 Please
More informationParts Manual. RZT SERIES TRACTOR Model Number RZT 42 w/42" Mower Deck. CUB CADET LLC P.O. BOX CLEVELAND, OHIO [www.cubcadet.
Parts Manual RZT SERIES TRACTOR Model Number RZT w/" Mower Deck CUB CADET LLC P.O. BOX CLEVELAND, OHIO -00 [www.cubcadet.com] PRINTED IN U.S.A. FORM NO. -0D (/0) -- MODEL RZT TABLE OF CONTENTS DESCRIPTION
More informationEUROPEAN REAR ENGINE RIDER SERIES 20
Parts Manual for EUROPEAN REAR ENGINE RIDER SERIES 20 MODEL E281320BE E331520KVE McDonough, GA, 30253 U.S.A. Briggs & Startton Yard Power Products Group Copyright 2006 Briggs & Startton Corporation Milwaukee,
More informationParts Manual PZ Please read the operator manual carefully and make sure you understand the instructions before using the machine.
Parts Manual PZ 60 967 045601-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support in service questions,
More informationMid Size Traction Unit
FORM NO. 3318 701 ProLine Mid Size Traction Unit 18 H.P. Kohler Gear Drive Model No. 30183 790001 & Up Parts Catalog 3318 701 ORDERING REPLACEMENT PARTS To order replacement parts, please supply: the part
More informationGrandStand Mower With 122cm TURBO FORCE Cutting Unit
Form No. 3397-823 Rev A GrandStand Mower With 122cm TURBO FORCE Cutting Unit Model No. 74504TE Serial No. 316000001 and Up Register at www.toro.com. Original Instructions (EN) *3397-823* A Ordering Replacement
More informationREAR ENGINE RIDER EUROPEAN SERIES 22
Parts Manual for REAR ENGINE RIDER EUROPEAN SERIES 22 MODELS E2822BE E2822BE E1522KVE CONTENTS DESCRIPTION PAGE(S) DESCRIPTION PAGE(S) WHEELS, TIRES...2, DRIVE DISC ASSEMBLY... 22 FRONT END, STEERING...4,
More informationParts Manual Zero Turn Mower / Z
Parts Manual Zero Turn Mower / Z 254 967324101-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support
More informationMZ 52LE. Parts Manual. Zero Turn Mower /
Parts Manual MZ 52LE Zero Turn Mower / 9677406-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support
More informationParts Manual MZ52 /
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. Parts Manual MZ52 / 962401 Please
More informationForm No Rev A. TimeCutter Z5040 Riding Mower Model No Serial No and Up
Form No. 3366-478 Rev A TimeCutter Z5040 Riding Mower Model No. 74632 Serial No. 311000001 and Up Register at www.toro.com. Original Instructions (EN) Ordering Replacement Parts To order replacement parts,
More informationWhen you need spare parts or support in service questions, warranty issues, etc., please consult the following professional: Engine
Parts Manual LZ5 / 968999 LZ30 / 9689996 Please read the operator s manual carefully and make sure you understand the instructions before using the machine. English D R O When you need spare parts or support
More informationMTD LLC, P.O. BOX CLEVELAND, OHIO
Illustrated Parts Manual Zero Turn Tractors MTD LLC, P.O. BOX CLEVELAND, OHIO -001 Printed In USA Form No. -0 (March, 0) Seat Adjustment, All Models 1 1 1 1 1 1 1. - Hex Hd. Wshr Screw, #- x.. -00 Flangelock
More informationParts Manual Rev. A
115 97 79-27 Rev. A Parts Manual Z 248F / 967 844801-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. Gasoline containing a maximum of
More informationRZ3016. Parts Manual. Zero Turn Mower /
Parts Manual RZ30 Zero Turn Mower / 966612302-04 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support in
More informationELECTRIC CLUTCH HYDRO DRIVE RMO TRACTORS LT-200 SERIES
Parts Manual for ELECTRIC CLUTCH HYDRO DRIVE RMO TRACTORS LT-200 SERIES MODEL ELT18538 (2690497) ELT2044 (2690498) LT18538 (2690440) LT18500 (2690518) LT2042 (2690441) LT2044 (2690442) LT22500 (2690443)
More informationProline 13HP Mid Size Traction Unit
Form No. 3323 888 Proline 13HP Mid Size Traction Unit Model No. 30159 200000001 & Up Parts Catalog Ordering Replacement Parts To order replacement parts, please supply: the part number, the quantity, and
More information312000x98A Lawn Tractor (2002) Page 1 of 19 Chassis & Hood
312000x98A Lawn Tractor (2002) Page 1 of 19 Chassis & Hood 312000x98A Lawn Tractor (2002) Page 2 of 19 Chassis & Hood 1 690566 Seat 2 028X23 Cap, Push On 3 094057 Spring 4 26X229 Screw 5 1001054 Bolt,
More informationPlease read the operator manual carefully and make sure you understand the instructions before using the machine.
967327901-00 Parts Zero Manual Turn Mower Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support in service
More informationParts Manual. Coronet / 2400 Series Riders & Mower Decks RMO. 13HP Product. 16HP Product. Mower Decks
Parts Manual 13HP Product Mfg. No. Description 1694610 Coronet, 13HP Hydro RMO Coronet / 2400 Series Riders & Mower Decks RMO 1694612 Coronet, 13HP Hydro RMO (CE) 1694613 2413H, 13HP Hydro RMO 1694614
More informationZ253 Z Master with 62in SFS Side Discharge Mower
Form No. REV A Z Z Master with 6in SFS Side Discharge Mower Model No. 00000 and Up Parts Catalog Ordering Replacement Parts To order replacement parts, please supply: the part number, the quantity, and
More informationLawn Mower. 22in Recycler. Parts Catalog. Form Number Rev A. Model No and up.
Form Number 3360-869 Rev A 22in Recycler Lawn Mower Model No. 20334-290000001 and up. Parts Catalog Ordering Replacement Parts To order replacement parts, please supply the part number, the quantity, and
More informationParts Manual Rev. A
115 97 25-27 Rev. A Parts Manual Z 242F / 967 844702-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. Gasoline containing a maximum of
More informationYARD TRACTOR ELECTRIC CLUTCH HYDRO DRIVE REAR DISCHARGE SERIES 0
Parts Manual for YARD TRACTOR ELECTRIC CLUTCH HYDRO DRIVE REAR DISCHARGE SERIES 0 MODEL RD1740 (2690155) RD1840 (1694384) RD2040 (2690114) McDonough, GA, 30253 U.S.A. COPYRIGHT 2005 SNAPPER PRODUCTS, INC.
More informationPARTS LIST. Reproduction. Not for. Mower Decks. Mfg. No. Description EZM2042, 20HP B&S w/42" Mower Deck (2009)
PARTS LIST Mower Decks Mfg. No. Description 7800490 EZM2042, 20HP B&S w/42" Mower Deck (2009) Manual Part No. Revision A Rev. Date: 11/5/2009 Table Of Contents PRODUCT COMPONENTS PAGES Frame, Body & Seat
More informationParts Manual P-ZT54 /
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. Parts Manual P-ZT54 / 9913402 Please
More informationTimeCutter SS 4235 Riding Mower Model No Serial No and Up
Form No. 3375-760 Rev B TimeCutter SS 4235 Riding Mower Model No. 74633 Serial No. 313000001 and Up Register at www.toro.com. Original Instructions (EN) *3375-760* B Ordering Replacement Parts To order
More information19-52ZX TimeCutter Riding Mower
Form Number 3350-173 Rev C 19-52ZX TimeCutter Riding Mower ZX Model No. 74802-240000001 and up. Parts Catalog Ordering Replacement Parts To order replacement parts, please supply the part number, the quantity,
More information465606x692A Lawn Tractor (2001) Page 1 of 25 Drive Assembly
465606x692A Lawn Tractor (2001) Page 1 of 25 Drive Assembly 465606x692A Lawn Tractor (2001) Page 2 of 25 Drive Assembly 1 26X249 Screw 2 095315 Knob, Parking Brake 3 711691 Nut, Push 4 1001217 Z Rod, Parking
More informationParts Manual SPEEDZTR 30 /
Parts Manual SPEEDZTR 30 / 966676201 Please read the operator s manual carefully and make sure you understand the instructions before using the machine. Gasoline containing up to 10% ethanol (E10) is acceptable
More informationTimeCutter SS 4200 Riding Mower
Form No. 3409-413 Rev A TimeCutter SS 4200 Riding Mower Model No. 74720 Serial No. 400000000 and Up Register at www.toro.com. Original Instructions (EN) *3409-413* A Ordering Replacement Parts To order
More informationParts Manual Rev. A Z 246 /
115 97 16-27 Rev. A Parts Manual Z 246 / 967 844501-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. Gasoline containing a maximum of
More informationTimeCutter SS 4225 Riding Mower
Form No. 3388-210 Rev A TimeCutter SS 4225 Riding Mower Model No. 74721 Serial No. 315000001 and Up Register at www.toro.com. Original Instructions (EN) *3388-210* A Ordering Replacement Parts To order
More informationSECTION 12: ILLUSTRATED PARTS LIST
SECTION : ILLUSTRTED S LIST (for choke) (for throttle) 0 0-0 Screw, #- x.0 0-0 Screw, /- x.0 0-0 Screw, /- x.0 0- Screw, #0- x. 0- Socket Cap Screw, /- x. 0- Self-tapping Screw, /- x. -00 Flange Lock Nut,
More informationEnglish. Please read the operator s manual carefully and make sure you understand the instructions before using the machine.
Parts Manual MZ5225 / 99991 MZ125 / 99991 MZ22 / 999919 MZ5225BF / 999920 MZ125BF / 999921 MZ5225C / 99994 MZ125C / 999949 MZ25 / 99990 Please read the operator s manual carefully and make sure you understand
More informationTimeCutter ZS 5000 Riding Mower
Form No. 3409-408 Rev A TimeCutter ZS 5000 Riding Mower Model No. 74661 Serial No. 400000000 and Up Register at www.toro.com. Original Instructions (EN) *3409-408* A Ordering Replacement Parts To order
More informationRepair Parts Manual For: SR-125. Zero Turn Radius Mower P (4/11)
Repair Parts Manual For: SR-125 Zero Turn Radius Mower P-12763 (4/11) COUNTRY CLIPPER WRANGLER - SR125 ZERO TURN RADIUS MOWER TABLE OF CONTENTS MOWER DECK... SPINDLE ASSEMBLY... RUBBER CHUTE ASSEMBLY...
More informationLAWN TRACTORS MANUAL CLUTCH HYDRO DRIVE SERIES "G"
Parts Manual for LAWN TRACTORS MANUAL CLUTCH HYDRO DRIVE SERIES "G" MODEL ELT145H33GBV LT145H33GBV LT145H38GBV LT150H38GKV WLT145H38GKV McDonough, GA, 30253 U.S.A. COPYRIGHT 2006 SNAPPER PRODUCTS, INC.
More informationLAWN TRACTORS ELECTRIC CLUTCH HYDRO DRIVE SERIES "G"
Parts Manual for LAWN TRACTORS ELECTRIC CLUTCH HYDRO DRIVE SERIES "G" MODEL LT160H42GBV LT160H42GBV2 LT180H48GBV2 WLT160H42GBV WLT180H48GBV2 McDonough, GA, 30253 U.S.A. COPYRIGHT 2006 SNAPPER PRODUCTS,
More informationParts Manual Rev. A
115 96 28-27 Rev. A Parts Manual Z 242F / 967 271802-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. Gasoline containing a maximum of
More informationParts Manual WH3615/ WH4817/ WH5217/ English
Parts Manual WH6/66400 WH48/664002 WH2/66400 Please read the operator s manual carefully and make sure you understand the instructions before using the machine. English 2008 HTC. All rights reserved. Beatrice,
More information74901, Z Master G3 Riding Mower, with 48in TURBO FORCE Side Discharge Mower, 2011 (SN ) : BRAKE HANDLE ASSEMBLY NO.
74901, Z Master G3 Riding Mower, with 48in TURBO FORCE Side Discharge Mower, 2011 (SN 311000001-311999999) : BRAKE HANDLE ASSEMBLY NO. 1 Page 1 of 52 74901, Z Master G3 Riding Mower, with 48in TURBO FORCE
More information72B27LD PARTS MANUAL
7 2 B 2 7 L D PARTS MANUAL 6 MID-CUT SECTION 6 MID-CUT DECK ASSEMBLY 25 24 23 26 22 00 20 9B SEE NOTE A 9A 75 34 6 2 87 98 05 03 2 90 2 68 53 93 02 69 5 49 5 7 8 0 0 9 36 88 8 58 97 3 46 59 3 72 92 76
More information72K850ZP PARTS MANUAL
7 2 K 8 5 0 Z P PARTS MANUAL 72 MID-CUT GAS ENGINE OPTION SECTION 72 MID-CUT DECK ASSEMBLY 72" Mid-Cut Deck Assembly # PART NO. QTY DESCRIPTION 1 582096 1 72" MC DECK WELDMENT 2 582098 1 72" DECK CHANNEL
More informationZERO TURN HYDRO DRIVE 20 & 24 HP 42" & 50" 150Z SERIES
Parts Manual for ZERO TURN HYDRO DRIVE 20 & 24 HP 42" & 50" 150Z SERIES MODEL ZT2042150ZBVE (2690645) ZT2450150ZBVE (2690647) McDonough, GA, 30253 U.S.A. Briggs & Startton Yard Power Products Group Copyright
More informationParts Manual for LAWN TRACTORS MANUAL CLUTCH HYDRO DRIVE SERIES F MODELS LT145H33FBV LT145H38FBV ELT145H33FBV
Parts Manual for LAWN TRACTORS MANUAL CLUTCH HYDRO DRIVE SERIES F MODELS LT145H33FBV LT145H38FBV ELT145H33FBV IT IS THE POLICY OF SNAPPER TO IMPROVE ITS PRODUCTS WHENEVER IT IS POSSIBLE AND PRACTICAL TO
More informationPage 1 of HP B&S Vanguard Engine
1405 Page 1 of 41 14 HP B&S Vanguard Engine 1405 Page 2 of 41 14 HP B&S Vanguard Engine Ref # Part Number Qty S/P/F Description BS-28Q777-0647-E1 1 14 HP B&S Vanguard Engine 1 BS-496412 1 Cylinder Assembly
More information1438HXL LAWN TRACTOR
FORM NO. 3318 846 1438HXL LAWN TRACTOR Model No. 71215 7900001 & Up Parts Catalog 3318 846 ORDERING REPLACEMENT PARTS To order replacement parts, please supply: the part number, the quantity, and the description
More informationREPAIR PARTS MANUAL. MODEL NO. WEX12H36B Lawn Tractor REV 1 RD/MH PRINTED IN U.S.A.
MANUAL MODEL NO. WEXHB Lawn Tractor.. REV RD/MH PRINTED IN U.S.A. HOW TO USE THIS MANUAL This manual is designed to provide the customer with a means to identify the parts on his/her tractor when ordering
More informationForm No Rev B. 22in Recycler Lawn Mower Model No Serial No and Up
Form No. 3360-875 Rev B 22in Recycler Lawn Mower Model No. 20333 Serial No. 290000001 and Up Register at www.toro.com. Original Instructions (EN) Ordering Replacement Parts To order replacement parts,
More informationRetriever 5800G/P/D. revised 2/01 Form Number
Retriever 5800G/P/D PARTS LIST Advance MODELS 56482005, 56482010, 56482015 This parts list is for machines after serial number 221134 All models covered in this manual are OBSOLETE revised 2/01 Form Number
More informationYARD CRUISER HYDRO DRIVE HZ SERIES 1 & 2
Parts Manual for YARD CRUISER HYDRO DRIVE HZ SERIES 1 & 2 MODELS HZS11BVE HZS181BVE HZS1521KVE HZS1522KVE HZS1681BVE HZS1882BVE TM HZS11BE Model shown CONTENTS DESCRIPTION PAGE(S) DESCRIPTION PAGE(S) WHEELS-
More informationLawnmower. 22in Recycler. Parts Catalog. Form Number Model No and up.
Form Number 3352-570 22in Recycler Lawnmower Model No. 20041-250000001 and up. Parts Catalog Ordering Replacement Parts To order replacement parts, please supply the part number, the quantity, and the
More informationParts Manual M-ZT52 /
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. Parts Manual M-ZT52 / 961001 Please
More informationSPEEDZTR 30 ZTR Parts Manual
SPEEDZTR 30 ZTR Parts Manual SPEEDZTR 30 / 968999702 SPEEDZTR 30 / 96899971 Please read the operator s manual carefully and make sure you understand the instructions before using the machine. English When
More informationZ400 Z Master With 48in 7-Gauge Side Discharge Mower
Form Number 3353-616 Rev A Z400 Z Master With 48in 7-Gauge Side Discharge Mower Model No. 74412-260000001 and up. Parts Catalog Ordering Replacement Parts To order replacement parts, please supply the
More informationParts Manual for the Wright Z
Parts Manual for the Wright Z Serial numbers 40581 & Higher Check www.wrightmfg.com for the latest revision Rev 9/2007 Shown with OPTIONAL Grass Collection System 2006 Wright Manufacturing Inc., All Rights
More informationMODEL x692A REPAIR PARTS HOOD & GRILL
MODEL 0xA HOOD & GRILL 0 0 0 0 0 0 0 0 MODEL 0xA Screw x0 Dash 00 Trim. 00 Cable Hood Assemnly 00E00 Screw x Lens & Reflector Assembly Cap, Pivot 0 Bolt, Shoulder x 0 Base, Pivot 0 Brace, Right Grille
More informationMid Size Traction Unit
FORM NO. 3319 398 ProLine Mid Size Traction Unit 14 H.P. Kohler Gear Drive Model No. 30177 695101 Thru 696000 Parts Catalog 3319 398 ORDERING REPLACEMENT PARTS To order replacement parts, please supply:
More information34 DECK ASSEMBLY A. SEE THE DECAL LIST SECTION FOR ALL DECALS /8 STD. FLAT WASHER TENSIONER w/ BUSHING
3 4 B 1 8 Z PARTS MANUAL 20 21 21 24 24 25 25 26 26 33 34 41 38 39 51 38 37 72 36 43 47 48 44 60 80 35 33 40 50 42 34 30 65 32 66 59 58 57 58 59 18 52 29 49 83 83 17 17 6 7 9 79 50 50 63 72 72 80 64 64
More information