Illustrated Parts Manual

Transcription

1 Illustrated Parts Manual Beginning S/N: 1400 P/N 000-

2 KEY TO ABBREVIATIONS USED IN THIS MANUAL Abbreviation What it Represents º (Dimension)Degrees (Angle) " (Dimension)inches (-)Negative (Polarity) (+) Positive (Polarity) ATAll-Terrain CCWCounter-clockwise Conn Connector CWClockwise D Diameter DCDeck, Collection (number refers to size in inches) DM Deck, Mulching (number refers to size in inches) DRDeck, Rear Discharge (number refers to size in inches) DSDeck, Side Discharge (number refers to size in inches) DUGarlock (Bearing) ESNA (Fastener)Nylon Insert Locknut FSC Forward Speed Control GA Gauge gal gallon GHSGrass Handling System GR (Fastener)Grade HDHeavy Duty HP Horse Power IDIdentification or Inside Diameter LLength LHLeft Hand (orientated with operator on seat) LP Low Profile mm (Dimension)millimeters MS (Fastener)Machine Screw NS (as part number) Item is not sold by Walker Manufacturing OD Outside Diameter oz ounce PFH (Fastener) Phillips Flat Head P/NPart Number PPH (Fastener)Phillips Pan Head PTH (Fastener)Phillips Truss Head PTO Power Take-Off QKSQuick Slide qtquart RH Right Hand (orientated with operator on seat) SAE (Fastener)Society of Automotive Engineers SBH (Fastener)Socket Button Head (Bolt) SDSide Discharge SFH (Fastener)Slotted Flat Head SHC (Fastener) Socket Head Cap SHL (Fastener) Shoulder (Bolt) SM (Fastener)Sheet Metal (Screw) S/N Serial Number SpgSpring SQH (Fastener)Square Head SS (Fastener) Stainless Steel ST (Fastener)Self-Tapping (Screw) Term Terminal V Volts NOTE: In some instances, combinations of abbreviations may be used (eg PPHMS - Phillips Pan Head Machine Screw)

3 ILLUSTRATED PARTS LIST Section of Tractor Covered Page Section of Tractor Covered Page Decals Tractor Decals Body / Chassis Assemblies Body / Chassis Assembly4 Rear Body Assembly Tractor Components Main Component Power Transmission8 Engine Group 10 Hydrostatic Ground Drive Assemblies1 Steering Control Assemblies14 GHS Group1 GHS Powerfil Assembly (0)18 GHS 0 Bushel Catcher Assembly0 Electrical Components Electrical Assembly Electrical Assemblies (GHS 0 Bushel Components)4 Electrical Connectors Maintenance Lubrication Points8 Wiring Schematic 0 Maintenance And Service Record Sheet1 Warranty Limited Warranty 1

4 TRACTOR DECALS ITEM PART DESCRIPTION LOCATION NO NO NO REQ D GHS Walker Product Decals Walker (8" Round) 0 Bushel Catcher (one on each side) Axle Lockout Chassis 800- LH Fender Body, LH near Seat Decal, S14i Body Made in USA Body RH Fender Body, RH near Seat 1 Danger Decals Warning Decals Caution Decals Danger, Pinch Point 0 Bushel Catcher Mounting Frame Assembly (one on each side) Danger, Engine Exhaust Engine Danger, Rotating Blower Blades Body, Near Body Chute 1 Maintenance Decals Removable Screen 0 Bushel Catcher Removable Screen Important, Engine Cooling Engine Fuel Recommendations Engine Engine Service Light Body PTO Alignment Arrow Universal Joint Tube Assembly 1 NOTE: All parts requiring decals are shipped with decals applied

5 < TRACTOR DECALS % Ethanol maximum 1% MTBE maximum 8 Octane or higher (R+M)/ (AKI) 90 Octane min (RON) Unleaded Gasoline Only IMPORTANT Decks Parts Manual for Deck Decals

6 BODY / CHASSIS ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Seat Assembly 1 10 Seat 1-4 Compression Spring Retainer Washer Washer (/8 x 1-1/4 x 1/4) 84-1 Rubber Bumper (1 x 0) 440- Shock Mount (1-1/4 x /4) Rear Bumper Assembly 1- Catcher Pivot Bushing Rear Bumper Catcher Pivot Plate 10 1 Roller Wheel (" Rubber) Body Assembly 11 0 Leaf Spring Welded Body Body Guide, Upper Rubber Bumper (1 x 0) 1 NS Body ID Plate Edge Molding, Lever Opening Hinge (19") 1 Tilt-Up Latch Assembly** Plastic Tip Spring Arm, Tilt-Up Latch Spring Pivot Bushing Compression Spring (/8 x /8) Mount Angle, LH Hook, Tilt-Up Latch Mount Angle, RH 1 Chassis Assembly Chassis Side Cover, RH Chassis Frame 1-1 Retainer Collar (1") 1 (Includes Item # F41) Pivot Bearing Tail Wheel Fork Bearing, Tail Wheel 1 0 Tail Wheel & Tire Assembly (1 x 0-) Tail Wheel Tire (1 x 0-) * 0 Tail Wheel & Hub ( x 4) * 08-1 Axle Spacer Tube (-/8) Chassis Side Cover, LH mm Ball Stud 14-4 Gas Spring Assembly 1 (Includes Item # 4) 8-1 Body Latch Hook 1 84 Plastic Tip, Red 1 8 Extension Spring (1/4 x ) Body Guide, Lower 1 Deck Support Arm & Hitch Assemblies Grease Fitting Support Arm Bushing (-1/1) Deck Arm Mount Deck Support Arm, LH (Includes Item # 40) Hitch Pin (#) 4 0- Deck Arm Hydro Mount, LH Deck Arm Hydro Mount, RH Deck Support Arm, RH (Includes Item # 40) 1 Fasteners F Keps Nut 1/4-0 Keps Nut 14 F00 1/4-0 ESNA Nut 1 /1-18 Whiz Locknut F01 /8-1 Keps Nut F01 /8-1 Whiz Locknut 4 F014 /8-1 ESNA Nut F01 1/-1 Self-Locking Nut 1 F00 /1-18 ESNA Nut 1 F x /8 PPHMS F09 1/4-0 x 1/ Hex Bolt 4 F01 1/4-0 x /8 Hex Bolt 8 F04 /1-18 x /4 Hex Bolt 8 F04 /8-1 x -1/4 Hex Bolt F048 1/ SAE Washer F049 /1 SAE Washer 8 F0 /1 Int Star Lock Washer F09 /8 Wave Spring Washer F09 /1-18 x 1 Hex Bolt 1 F11 1/4-0 x 1-1/4 Hex Bolt 1 F11 /8-1 x /8 Hex Bolt 4 F18 1 x 00 x 04 Washer F00 /1-0 x Grade 8 Bolt F0 # x /1 Drive Pin F /8 x 1-1/4 x 1/8 Washer F41 x 8 x 10 Washer 4 F4 1/4-0 x 1/ PTHMS 8 F /8 x 1-11/1 Shoulder Bolt F9 1/-1 x 8-1/ Hex Bolt, GR 1 F41 Coil Roll Pin (/4 x 9/1) 1 F4 /1 Conical Washer F41 /1-4 x /1 Set Screw F48 /1-18 x -/4 Hex Bolt 4 F4 1/4-0 x /8 Carriage Bolt * Service Part Only ** Complete Tilt-Up Latch Assembly Kit available by ordering kit # 4 4

7 < F4 F4 1 1 F04 F00 F4 F4 F09 F04 F04 F04 F04 F09 F09 F01 F01 F01 F F F F18 F18 F F014 F41 F41 F04 F01 F014 F01 F41 F01 F11 F11 F F F41 F9 F048 F01 1 F F F F00 F09 F09 F04 Hydrostatic Ground Drive Assemblies F00 F11 8 F04 F04 F049 F049 F049 F049 F00 F00 F0 F48 F48 F11 F01 F01 F11 F0 F09 BODY / CHASSIS ASSEMBLY

8 REAR BODY ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Rear Body Assembly 1 1 Catcher Support Frame Heat Shield Rear Body Tie-In Rear Body Panel, LH Fuel Pump Guard Grommet (1 x 1-/4) Rear Body Panel, RH Catcher Handle Plate, RH Catcher Handle Plate, LH Spring Clip mm Ball Stud 1 14 Gas Spring Assembly 1 (Includes Items # 10 & 11) Fasteners F Keps Nut 1/4-0 Keps Nut /1-18 Whiz Locknut 10 F x /8 PPHMS F01 1/4-0 x /8 Hex Bolt F04 /1-18 x /4 Hex Bolt 8 F18 1/4 x 1 Fender Washer F90 1/4-0 x /8 Carriage Bolt F4 1/4-0 x /8 Carriage Bolt 1 NOTE: Rear Bumper Assembly for GHS Models is not shown here BODY / CHASSIS ASSEMBLY, Page 4

9 REAR BODY ASSEMBLY GHS 0 Bushel Catcher Assembly F GHS 0 Bushel Catcher Assembly 11 9 F90 F18 1 F90 8 F18 F0 F0 F01 F01 F4 F18 GHS 0 Bushel Catcher Assembly F04 F0 F00 4 F00 F00 Body / Chassis Assembly

10 MAIN COMPONENT POWER TRANSMISSION ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D PTO Drive Assembly Handle Grip, Black Clutch Lever 1 80 Grease Fitting Clutch Actuator Bolt (/1) 1 80 Knuckle Joint Grease Fitting (90 Degree) 1 8- /1-18 x 1-/4 Stud Pivot Bushing (/1 ID) 9 - Clutch Arm 1 10 Plastic Washer (1 x 48 x 0) 11 8 Pivot Bearing (/1 x 9/1) Ball Joint (/1-4LH) (Nylon Lined) Clutch Arm Support Bracket Clutch Pull Rod 8-/ Ball Joint (/1-4) (Nylon Lined) Extension Spring (/4 x 4) Ball Joint (/1-4) W/O Stud Spring (/4 x -1/) V-Groove Idler (4") PTO Drive Belt Washer (/1 x 1-/8) 1 8- PTO Drive Pulley (/B) Grease Fitting (4 Degree) PTO / Clutch / Brake Actuator 1 (Includes Items # & 8) Guide Top Belt Guide Base 1 8- PTO / Clutch / Brake Support Fiberglide Bearing Inner Race (-1/4) Belt Guide Mount 1 Engine Belt Tightener Assembly Clutch Spacer Washer (1 x x 0) Compound Pulley, 4/B 1 (Includes Items # F1 & F11) 4- Engine Drive Belt (BX0-K) Bushing 00 x 1 x Engine Idler Arm (Includes Item # ) Extension Spring (/4 x ) 1 - Engine Pulley (4-1/4B) 1 (Includes Items # F0 & F11) 8-10 Spacer (1 x 10 x /1) Bearing W/Collar (/4) Jackshaft Bearing Housing Jackshaft (/4 x 110) 1 Blower Brake Assembly 4 - Clevis Pin W/Hole (1/4 x /8) Brake Band (14-1/) Brake Band Link, Front Fasteners 1/4-0 Keps Nut F00 1/4-0 ESNA Nut 1 /1-18 Whiz Locknut 11 F010 /1-4 ESNA Nut F01 /8-1 Keps Nut 1 F019 1/4-0 ESNA Wing Nut F04 /1-4 Jam Nut F09 1/4-0 x 1/ Hex Bolt 1 F01 1/4-0 x /8 Hex Bolt F04 /1-18 x /4 Hex Bolt F0 /1-18 x 1-1/4 Hex Bolt 1 F040 /8-1 x 1-1/ Hex Bolt F049 /1 SAE Washer 1 F00 1/4 SAE Washer F01 /8 SAE Washer 1 F04 AN901 Washer F00 AN901 Washer F01 1/4 Star Lock Washer 1 F0 /8 Int Star Lock Washer F0 1/4 x 1/4 x /4 Key 1 F0 /1 x /1 x 1 Key 1 F09 / x 1/ Cotter Pin 1 F09 /1-18 x 1 Hex Bolt F10 /8-1 x /8 Hex Bolt F1 /1 x /1 x 1-/4 Key 1 F11 /1-18 x /8 Set Screw 4 F18 1/4 x 1 Fender Washer 1 F18 1 x 00 x 04 Washer 1 F41 x 8 x 10 Washer 1 F1 /1-18 x 1-/4 Hex Bolt 1 F0 1/4-0 LP Nylock 1 F /1-4 Hex Nut, LH 1 F9 /8-1 x -1/4 Hex Bolt 1 F4 1/4-0 x /8 Carriage Bolt F /1-4 x -1/ Hex Bolt 1 F94 /8-4 x 1 Hex Bolt 1 8

11 MAIN COMPONENT POWER TRANSMISSION 1 F F % Ethanol maximum 1% MTBE maximum 8 Octane or higher (R+M)/ (AKI) 90 Octane min (RON) Unleaded Gasoline Only IMPORTANT 9 41 F010 F F00 F00 F010 1 F04 F18 F0 F04 F F18 F09 F01 F41 F040 F F0 F F F10 F0 F09 F0 F94 1 F F00 F019 F0 F11 1 F11 F1 F11 F01 F01 F040 F F Engine Group F4 Hydrostatic Ground Drive Assemblies GHS Group 8 F04 F9 F01 F F09 F1 GHS Group Body / Chassis Assembly 9

12 ENGINE GROUP ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Fuel Assembly Hose Clamp (/1) 1 8 Cable Clamp (1/) M11 Fuel Line (/1 x 10") 1** Quick Coupler Straight (/1 x /1) Stepless Ear Clamp, Black (1) NS Fuel Line (Kohler) Quick Connecter (/1 x /1-4) Cable Clamp (9/1 x #10) 1 9 NS Fuel Valve (Kohler) Hose Clamp (1/) Fuel Filter Cable Clamp (1/) 18 Hole 4 1 M4 Fuel Line (1/4 x ") 1** 14 NS Fuel Line (Kohler) 1 1 M111 Fuel Line (1/4 x 10") 1** 1 M4 Fuel Line (1/4 x 1") 1** 1 NS Pump, Pulse " Spacer 19 NS Fuel Pump Module (Kohler) Fuel Bracket Spacer Engine Assembly 1 NS 14 HP Engine (Kohler) EFI 1 NS Air Cleaner Cartridge (Kohler) 1 0- Engine Spacer Exhaust Pipe Heat Shield Heat Shield Cover Engine Brace 1 Throttle Assembly Throttle Cable Control Lever, Throttle and Choke Throttle Control Knob, Red Control Assembly * (Includes Items # 8, 1- & F01) 11-4 Throttle Control and Cable Assembly * (Complete Control and Cable Assembly) Control Bracket Friction Washer (1) Control Lock Tab Bearing, Delrin ( x 9 x 0) 1 Exhaust Assembly Inner Heat Shield 1 NS Gasket, Muffler (Kohler) 1 NS Sensor, Oxygen (Kohler) Muffler Muffler Heat Shield 1 40 NS Nut (Kohler) Fasteners F Keps Nut 1 1/4-0 Keps Nut F00 1/4-0 ESNA Nut 1 /1-18 Whiz Locknut 4 F01 /8-1 Whiz Locknut 4 F x /8 PPHMS 1 F x 1/ PPHMS F01 1/4-0 x /8 Hex Bolt F04 /1-18 x /4 Hex Bolt 4 F040 /8-1 x 1-1/ Hex Bolt F041 /8-1 x 1-/4 Hex Bolt F044 /1-4 x /4 Hex Bolt F00 1/4 SAE Washer F01 /8 SAE Washer 4 F0 /1 Ext Star Lock Washer F x 1/4 x /8 SHL Bolt 1 F184 1/4-0 x 1/ Hex Bolt, SS 4 F18 1/4 Internal Star Lock Washer, SS 4 F01 1/4 Belleville Spring Washer F 1/4-0 x 1-/4 Hex Bolt 1 F98 1/4-0 x Hex Bolt F9 1/4-0 Flange Top Lock Nut 1 * Service Part Only ** Required hose specifications: M111-1/4" ID fuel/oil/vapor hose (Gates or equivalent) M11 - /1" ID fuel/oil/vapor hose (Gates or equivalent) M4-1/4" ID low permeation (<1g/m^/day) fuel hose (Parker 8904 or equivalent) M4 - /1" ID low permeation (<1g/m^/day) fuel hose (Parker 890 or equivalent) 10

13 ENGINE GROUP Rear Body Assembly F98 F0 F F0 F00 F0 F0 1 F0 4 0 F F0 F00 10 F9 F F00 8 F F F0 Electrical Assembly F00 1 F00 F F01 F01 10% Ethanol maximum 1% MTBE maximum 8 Octane or higher (R+M)/ (AKI) 90 Octane min (RON) Unleaded Gasoline Only IMPORTANT Rear Body Assembly F044 F0 F0 F0 F00 F0 F00 F00 F0 F044 F04 F00 4 F0 F14 F00 4 F00 1 F00 F F00 F00 0 F0 Body / Chassis Assembly 8 F01 F184 F18 9 F041 F F184 F18 F18 F184 F18 F184 11

14 HYDROSTATIC GROUND DRIVE ASSEMBLIES ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Transaxle Reservoir Assembly Oil Expansion Reservoir (1) Reservoir Bottle Mount Hose Clamp (1//1) Reservoir Bottom Caps Elbow (1/4 x 1/) Hose Clamp (1/) 4 M111 Hose (1/4 x 14") 1** Straight Thread Hose Fitting Hose Clamp (/1) 10 M111 Hose (1/4 x -/8") 1** /4 x 1/4 x 1/4 Tee 1 1 M111 Hose (1/4 x 1-/8") 1** Reservoir Hose Guide Hose (1/ x 1-/4) 1 Ground Drive Assemblies Hydro-Gear ZT100, RH Lockout Arm, RH Bow Tie Cotter Pin Idler Spring Bushing Torsion Spring Idler Arm Hydro Fan Washer 0-1 Hydro Fan 44-1 Hydro Pulley (40) Splined Hydro Fan Nut 41- Transmission Drive Pulley (-1/4MV) 1 (Includes Items # F0 & F11) -1 Ground Drive Belt (Micro V) Idler Pulley Spacer Bushing (/1) Lockout Arm, LH Hydro-Gear ZT100, LH Spacer Tube 4 1 Shock Mount / Body Lift Arm 1 (Includes Item # ) 80 Grease Fitting Parking Brake Assembly Handle Grip, Red Parking Brake Lever 1 (Includes Item # ) 40-1 Brake Actuator Pull 1 80 Clevis (/8) Parking Brake Pull Rod Clevis Pin (/1 x /4) Parking Brake Pull Mount, Inner Parking Brake Pull Mount, Outer 4-1 Compression Spring (-1/) 4 Extension Spring (1/ x -1/4) Parking Brake Actuator Clevis Pin (/1 x 1-1/8) 1 Wheel Assembly 4 0- Wheel & Tire (18 x 00-8) Fasteners 1/4-0 Keps Nut F00 1/4-0 ESNA Nut /1-18 Whiz Locknut 8 F01 /8-1 Whiz Locknut F01 1/-0 Wheel Lug Nut 8 F00 /1-18 ESNA Nut F09 1/4-0 x 1/ Hex Bolt 1 F01 1/4-0 x /8 Hex Bolt 9 F04 /1-18 x /4 Hex Bolt F041 /8-1 x 1-/4 Hex Bolt 1 F04 /8-1 x -1/4 Hex Bolt F00 1/4 SAE Washer F0 /1 x /1 x 1 Key 1 F09 / x 1/ Cotter Pin F x 1/ PTHMS F11 /1-18 x /8 Set Screw F18 1/4 x /8 x 1/8 Washer F18 1 x 00 x 04 Washer F1 /1-18 x 1-/4 Hex Bolt 1 F /8-1 Jam Nut 1 F88 /8-1 x -1/ Hex Bolt F489 Washer 1/4 x /8 x F9 Washer 10 OD x 1 ID x 1/8 F /1-18 x -1/ Socket Cap Bolt 4 * Service Part Only ** Required hose specifications: M111-1/4" ID fuel/oil/vapor hose (Gates or equivalent) 1

15 HYDROSTATIC GROUND DRIVE ASSEMBLIES 1 F00 F00 F F01 4 F Body / Chassis Assembly F9 4 F11 F F19 F0 1 F F F04 F01 8 F01 F F04 1 F19 1 F01 F18 F F9 Main Component Power Transmission 4 F F F00 F09 9 F09 F F F Body / Chassis Assembly F88 F09 9 F F18 8 F 1 4 F04 F1 Body / Chassis Assembly F01 4 F01 1

16 STEERING CONTROL ASSEMBLIES ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Steering Lever & FSC Assemblies 1 8 FSC Knob FSC Lever Assembly (Includes Item # 4) * 10-1 Step Washer Grease Fitting Ball Joint (/1-4/LH) W/O Stud Control Rod (4-1/1) Ball Joint (/1-4) W/O Stud Extension Spring (/4 x -1/) FSC Friction Actuator Fiberglide Bearing Speed Control Actuator, RH 1 (Includes Items # 10 & 1) Steering Pivot (1/4-0 x 1-/8) Grease Fitting (4 Degree) mm Ball Stud Steering Lever Dampener Assembly 1 4- Washer /1 x /4 x Steering Arm Pivot Sleeve Fiberglide Bearing (1/") Steering Lever Actuator 0-1 Compression Spring (-1/) Control Rod (-/4) 1- Seal Retainer 1 Transmission Control Arm Stop 4 1- Transmission Control Arm, RH 1 1- Transmission Control Arm, LH Speed Control Actuator, LH 1 (Includes Items # 10 & 1) Steering Pivot Shaft W/Stop Pivot Rod Bushing / Plastic FSC Friction Washer 1 (1-1/ x 1-1/ x 1/1) FSC Friction Washer (1-1/ x /8 x 1/1) FSC Cam 1 Extension Spring (1/ x -1/4) 40 D-Clip Steering Lever Tube W/Tab 4-10 Steering Lever Handle / Adjustable (Includes Items # & F4) 80- Handle Grip, Foam (-1/) Fasteners 1/4-0 Keps Nut F00 1/4-0 ESNA Nut /1-18 Whiz Locknut 8 F010 /1-4 ESNA Nut F04 /1-4 Jam Nut F0 /1-18 x 1-1/4 Hex Bolt 1 F044 /1-4 x /4 Hex Bolt F09 /8 Wave Spring Washer 1 F09 /1-18 x 1 Hex Bolt 4 F14 1/4-0 Jam Nut F1 /1-18 Hex Nut 1 F18 1 x 00 x 04 Washer 8 F188 1/4-0 Self-Locking Nut 4 F19 /8-4 Self-Locking Nut 1 F198 0 x x 040 Washer, SS F11 1/4-0 x /8 Hex Bolt 1 F /1-18 x /8 Hex Bolt F1 /8 x /8 Shoulder Bolt 1 F4 1/4-0 x 0 Knurled Bolt 4 F /1-4 Hex Nut, LH 1 F8 1/4 x 1-1/4 Roll Pin 1 F8 /1-18 x 1-1/ x /8 Shoulder Bolt 1 F91 1/4-0 x 1/ Set Screw, SS F40 Belleville Washer /8 x 118, SS 1 F4 /1-18 Flange Nut 1 * Service Part Only 14

17 STEERING CONTROL ASSEMBLIES Hydrostatic Ground Drive Assemblies 1 F91 F14 F18 F09 F18 F4 4 F09 F198 F188 F4 4 F09 F8 F04 F18 F1 8 F0 F8 10 F F188 F 11 F09 1 F00 10 F F F F18 F044 F04 F00 F 4 F F044 1 F04 F18 Hydrostatic Ground Drive Assemblies 1 F91 F14 Hydrostatic Ground Drive Assemblies F198 4 F Body / Chassis Assembly F40 F19 F F1 1

18 GHS GROUP ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Delivery Chute Assembly Elbow Delivery Spout Backing Plate, Grass-Pak Switch 1 9- Grass-Pak Housing Spacer Rear Clip Notched, Chute Mount 1 Side Clip, Chute Mount 0- Body Chute Outside Chute Cover Lip Inside Chute Cover Lip Delivery Chute W/Clips 1 (Includes Items # 4,, F09 & F411) Blower Assembly Blower Scroll Flanged Bearing (/4") Sleeve 10 x x / Flange Bearing (/4") Machine Flat Receiver Cone U-Joint Tube/9" OAL Spline 1 (Includes Item # F0) 1 4- Blower Spacer Blower Wheel Blower Faceplate Fixed Chute 1 Fasteners F Keps Nut 1/4-0 Keps Nut 14 F01 /8-1 Whiz Locknut F x /8 PPHMS 4 F01 1/4-0 x /8 Hex Bolt F0 1/4-0 x /4 Hex Bolt 4 F08 /8-1 x 1 Hex Bolt F00 1/4 SAE Washer 4 F0 /1 x /1 x 1 Key 1 F0 /8-1 x /8 SQH Set Screw 1 F09 A/AD Aluminum Pop Rivet 14 F19 /1-18 x 1 Carriage Bolt F411 /1 Bulbex Rivet F1 1/4-0 x Hex Bolt 11 F 1/4-0 x -1/ Hex Bolt 1 F1 /1-18 Flange Top Lock Nut F 10-4 x /8 Carriage Bolt NOTE: ELECTRICAL CONNECTORS, Page, for identification of all Electrical Wiring Service Parts 1

19 GHS GROUP Electrical Connectors 1 F Electrical Assemblies (GHS 0 Bushel Components) GHS 0 Bushel Catcher Assembly 8 9 F411 F09 F411 F0 F411 F09 4 F00 F00 GHS Powerfil Assembly (0) Main Component Power Transmission F01 F00 F00 Main Component Power Transmission 10 F 1 F1 1 F00 F 18 F F19 Body / Chassis Assembly F0 F0 F0 F08 F01 F01 1 F F

20 GHS POWERFIL ASSEMBLY (0) ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D 0 GHS Powerfil Assembly 1 Ball Joint (1/4-8) - Bushing, Powerfil Actuator 4-1 Compression Spring (1/ x ) 4 8- Powerfil Actuator Rod 1 49 Actuator Rod Assembly * (Includes Items # 1- & F00) 8-1 Powerfil Push Rod 1 1- Bearing Cap, Powerfil Pivot Bearing (#SPP) Pivot, Delivery Spout Pivot Mount Actuator Motor (1V) 1 (Includes Items # 11 & 1) Motor Mount Washer * Motor Mount Nut (/8-4) * 1 4 Actuator Arm 1 Fasteners F Keps Nut 10 F00 1/4-8 Hex Nut F x 1/ PPHMS 1 F x /8 PTH Screw F04 AN901 Washer 1 F08 /1 Rivet Backup Washer 1 F x 1-1/4 SHC Screw 1 F109 1/8 x /8 Roll Pin 1 F x 1/ PTHMS F1 AN901L Washer 1 F8 1/4-8 Keps Nut 1 * Service Part Only 18

21 GHS POWERFIL ASSEMBLY (0) F101 F00 1 F F00 Electrical Assemblies (GHS 0 Bushel Components) 10 F0 F08 F00 F00 F109 Electrical Assemblies (GHS 0 Bushel Components) F F1 F04 GHS 0 Bushel Catcher Assembly F00 F8 F0 F19 F0 F19 9 F00 F00 F19 GHS Group 19

22 GHS 0 BUSHEL CATCHER ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Upper Baffle Screen Assembly (Removable) 1 1- Removable Screen (/1 Hole) 1** (Includes Items #, F0 & F190) 0 Knob / Threaded Insert (10-4) 09- Channel Top Channel Bottom 8-1 Edge Molding (1-/4") 1 0 Screen Seal (-1/4") 1 0 Mustache Spring C-Channel With Spring 1 (Includes Items # & F40) 0 Exhaust Deflector Door Assembly 9 0- Upper Door Seal Catcher Box Door (Includes Frame) 1 (Includes Items # 9, 11, 1, 14, F09, F08, F0 & F411) 11 8 Handle Lower Door Stiffener (0) Door Guide Upper Door Stiffener 1 GHS 0 Bushel Catcher Assembly 1 0- Center Strap (0) Upper Frame Doubler (0) 1 0- Lower Frame Doubler (0) Outside Box Strap (0) Catcher Door Finger Center Frame Doubler Catcher Mount Catcher Dump Flap Spacer (0) Catcher Dump Flap With Plate Backing Plate / Dump Flap 1 0- Pivot Bushing (1/ x 9/1) 4 0- Bushing 08- Hinge Plate, LH Catcher Door Arm, LH Gas Spring Cover, LH Spring Clip Gas Spring 1-1 /4 Ball Stud - Gas Spring Plate /1 Ball Stud 1-1 Box Support, Gas Spring -1 Handle, Catcher Lift 11- Chute Cover Wire Harness Channel Bushel Catcher Box Catcher W/Powerfil (Includes Door) * Powerfil Cover Plate Hinge Plate, RH Gas Spring Cover, RH Catcher Door Arm, RH Reinforcing Strap Decal Plate, Round (Set of ) Door Arm Stop 98- Optional Dump Bag (Not Shown) May be ordered as an option Contact your Walker dealer Fasteners F Keps Nut 1/4-0 Keps Nut 1 /1-18 Whiz Locknut F00 /1-18 ESNA Nut F x /8 PPHMS F x /8 PPHMS 1 F09 1/4-0 x 1/ Hex Bolt 4 F049 /1 SAE Washer 4 F00 1/4 SAE Washer F09 A/AD Aluminum Pop Rivet 4 F08 /1 Rivet Backup Washer 4 F x 1/ PTHMS F x 1/ PTHMS 14 F18 1/4 x 1 Fender Washer 4 F190 #10 Internal Star Lock Washer F19 1/4-0 x 1 PPHMS, SS 4 F0 1/4-0 x 1-1/4 PPHMS, SS 4 F4 1/4-0 x /8 PPHMS, SS 10 F /1-18 x Hex Bolt F0 /1D x 1/L Rivet, SS 4 F40 Rivet, Aluminum 4 F1 Aluminum Pop Rivet F0 1/4-0 x /8 Hex Bolt F90 1/4-0 x /8 Carriage Bolt 4 F411 /1 Bulbex Rivet F4 1/4-0 x /8 Carriage Bolt 4 F04 1/4-0 Whiz Locknut 1 F4 /1 x /8 Aluminum Rivet, Black F40 1/4-0 x 1-/4 PPHMS, SS 1 * Service Part Only ** This screen can be replaced by P/N 1- Removable Screen (/4" holes) for improved air flow performance in wet conditions 0

23 GHS 0 BUSHEL CATCHER ASSEMBLY F00 F19 4 F00 1 F19 F0 F00 F40 8 F40 F40 F0 F00 F19 F00 F0 F190 4 F19 F F F0 4 F0 0 1 F1 41 F00 Electrical Assemblies (GHS 0 Bushel Components) F90 F094 F0 4 F Rear Body Assembly F0 F 9 F19 F19 F09 F00 F1 F411 F411 F411 F00 F411 F00 4 F00 F049 F00 F4 F18 F09 44 F4 F4 F4 18 F4 F04 F F4 1 F04 F04 1 F04 F19 F0 F411 F09 F04 F00 F F00 F049 F0 F19 F00 F049 F00 4 F1 F19 F4 F00 F0 Rear Body Assembly F1 1 0 F90 1 F411 F0 F00 F00 F08 0 F4 1 F4 F40 F F0 18 F4 F04 F19 F4 1 F00 F09 8 F F4 F0 F00 9 F0 F0 1 F0 F0 11 F19 F19 F19 F00 8 F00 F00 1

24 ELECTRICAL ASSEMBLY ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Electrical Assembly Delta Hex Nut Safety Switch (NO), Delta Threaded Wire Saddle ( Wires) Cable Clamp (1/) Cable Tie (18# x -/4") NS Rectifier Amp Fuse 1 8 NS Fuse Holder (Kohler) Circuit Breaker / Fuse Holder Circuit Breaker (0 Amp) 1 Auto Reset / Sealed Jumper Wire Safety Switch (NC), Delta Side Mount Safety Switch (NO), Delta Side Mount Safety Switch Plate Relay Switch 0/40 Amp (NC) Wire Harness Assembly Cable Clamp (/8 x 1/4) Hourmeter (Global) Ignition Switch (With Keys) 1 (Includes Items # 0, 1 & F49) 0 84 Plastic Tip / Red Key Set W/Umbrella Red Indicator Light Assembly 1 8 Warning Horn Boot, Circuit Breaker Circuit Breaker ( Amp) 1 Battery Assembly 940- Battery Cable (") 1 9 Battery Terminal Insul, Black (-) Battery Terminal Insul, Red (+) 1 9 NS Battery (1V/00CA/Wet) Battery Guard Hook Bolt Battery Cable (") 1 Fasteners F Keps Nut 1/4-0 Keps Nut F019 1/4-0 ESNA Wing Nut F x /8 PPHMS 4 F x 1/ PPHMS F09 1/4-0 x 1/ Hex Bolt F01 1/4-0 x /8 Hex Bolt F0 1/4-0 x /4 Hex Bolt F00 1/4 SAE Washer F0 /1 Ext Star Lock Washer F11 /8 x 1-1/4 x 0 Washer F14 1/4-0 Jam Nut 1 F18 1/4 x /8 x 1/8 Washer F11 1/4-0 x /8 Hex Bolt 1 F 10- Keps Nut F49 Washer 8 ID 11 OD, SS 1 F49 M8 x 0 Hex Bolt F0 - x /8 Hex Trim MS, SS 4 F0 - Nylock Nut 4 NOTE: ELECTRICAL CONNECTORS, Page, for identification of all Electrical Wiring Service Parts NOTE: Decals for this assembly are not shown here TRACTOR DECALS, Page, for Decal listing and placement information

25 ELECTRICAL ASSEMBLY 19 A Body / Chassis Assembly F E B G F 4 C 1 Body / Chassis Assembly H I F0 1 F00 F0 1 F11 F0 1 F 11 1 Main Component Power Transmission K GRN/ WHT D <1 F49 F0 F0 F F0 F00 F0 L F00 F09 M 4 1 F019 F18 F0 Body / Chassis Assembly F019 F18 F00 1 F00 F F00 F09 Steering Control Assemblies F0 14 F0 1 F11 F14 J O RED PUR F49 F0 N Body / Chassis Assembly Engine Group END VIEWS ARE SHOWN FROM BACK OF PLUG GRN DETAIL A PUR/WHT PUR/WHT WHT DETAIL B YEL RED BLU RED/WHT DETAIL C PUR/RED PUR PUR/WHT PUR/WHT PUR/WHT DETAIL D BRN BLU DETAIL E PUR/WHT TAN BRN/WHT DETAIL F YEL DETAIL G PUR/RED PUR YEL/BLU BRN DETAIL H WHT WHT PUR/RED DETAIL I PUR/WHT PUR/WHT ORG BRN/WHT ORG/WHT RED/WHT DETAIL J ORG PUR PUR PUR/WHT PUR/WHT DETAIL K PUR/RED DETAIL L DETAIL M DETAIL N DETAIL O YEL/BLU ORG/WHT PINK RED PINK GRN WHT PUR GRN/WHT GRN/WHT RED/WHT PUR TAN

26 ELECTRICAL ASSEMBLIES (GHS 0 BUSHEL COMPONENTS) ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Horn & Harness Channel Assemblies 1 - Horn, Full Signal * 9- Grommet (/1 x /4) 9-1 Cable Tie (18# x -/4") 1 Harness & Grass-Pak Switch Assemblies Powerfil Wire Harness (0/100) 1 8 Cable Clamp (1/4) 94- Aluminum Shaft & Vane Assembly Grass-Pak Switch Assembly 1 Fasteners F Keps Nut 4 F x /8 PPHMS 1 F x /8 PTH Screw 1 F x 1/ PTHMS F Keps Nut, SS F x 1/ Hex Head, SS * Service Part Only NOTE: ELECTRICAL CONNECTORS, Page for identification of all Electrical Wiring Service Parts 4

27 ELECTRICAL ASSEMBLIES (GHS 0 BUSHEL COMPONENTS) GHS 0 Bushel Catcher Assembly A 1 F00 F19 to (-) RED to (+) GHS Powerfil Assembly (0) /WHT GHS 0 Bushel Catcher Assembly B Electrical Assembly 4 GHS Group F0 GHS Group F00 F00 END VIEWS ARE SHOWN FROM BACK OF PLUG /WHT DETAIL A WHT RED /WHT DETAIL B F0 F09 F09 F08

28 ELECTRICAL CONNECTORS ITEM PART DESCRIPTION NO NO NO REQ D ITEM PART DESCRIPTION NO NO NO REQ D Electrical Wiring Service Parts GA Butt Connector * GA Butt Connector * GA Shrink Connector * GA Shrink Connector * 99-1 Wire Terminal Adapter * GA Bullet Conn, Male * GA Bullet Conn, Female * GA Spg Loaded Term, Female * Wire Clip, Female * /4 x 1-14 GA QDF Terminal * /1 x -18 GA QKS Term, Female * GA QKS Term, Female GA Spg Loaded Term, Male * * /4 x -18 GA QKS Term, Male * GA Ring Term (#8) Nylon Insulated * /4 x 1-14 GA QKS Term, Male * GA Ring Lug (/1) Insulated * GA Ring Term (#10) * GA Ring Term (/1) Insulated * GA Ring Term (/1) * GA Ring Term (# 10) Insulated * GA Ring Term (1/) * 99-1 GA Ring Terminal (1/4) * GA Ring Term (1/4) * GA Ring Term (1/4) Insulated * GA Ring Term (#10) Insulated * 94-4 Single Connector, Male * Way Connector, Male * Way Locking Connector, Female * Way Connector, Male * Way Connector, Female * Way Locking Connector, Male * Way Connector, Male * Way Connector, Male * Way Locking Connector, Male * Way Locking Connector, Female * Way Connector, Male * Way Connector, Female * Way Connector, Male * Way Connector, Male * Way Connector, Female * Way Connector, Male Way Connector, Male * * Way Connector, Male * Way Connector, Female * Way Connector, Male * Way Connector (M) * Way Connector (Female) * Packard Plug (Male) * Packard Plug (Female) * * Service Part Only NOTE: Not all Electrical Connectors are used with all assemblies NOTE: ELECTRICAL ASSEMBLY, Page, for locations of Wiring Harness, Electrical Components and of all Electrical Wiring Service Parts

29 ELECTRICAL CONNECTORS

30 LUBRICATION POINTS ITEM LOCATION LUBRICATION NO NO TYPE PLACES ITEM LOCATION LUBRICATION NO NO TYPE PLACES Lubrication Points 1 Steering Lever Pivot Grease FSC Lever Pivot Grease 1 Deck-to-PTO Coupling Grease 1 (Grease Spline Slide Area) 4 Universal Joint Tube Assembly Grease* 1 Deck Support Arm Pivot Grease Hydro Idler Pivot Grease 1 PTO Clutch Lever Pivot Grease 1 8 Body Latch Pivot Oil 1 9 Transaxle Oil Reservoir Oil/0W Clutch Actuator Push Rod Grease 1 (Grease Slide Area) 11 PTO Belt Tightener Pivot Grease 1 1 Brake Band Pivot Pins (Clevis) Oil 1 Catcher Hinge Point Oil 14 Throttle Control Cable Ends Oil 1 Engine Dipstick / Oil Filler Oil** 1 1 Engine Idler Pivot Grease 1 1 Parking Brake Lever Grease 1 18 Throttle Control Pivot Oil 1 * Grease every hours ** S14i Operator s Manual for procedure for checking and changing oil in Engine Crankcase NOTE: See Model S14i Operator s Manual (P/N 000-) for proper lubrication intervals 8

31 LUBRICATION POINTS &

32 FUSWIRING SCHEMATIC BATTERY WALKER MODEL S14i Beginning S/N IGNITION SWITCH CIRCUITS CASE GROUND TO MOTOR MOUNT ORG/WHT PUR/WHT PUR/WHT PTO SWITCH PUR/RED ORG PUR/WHT RELAY - C 0 PUR/RED 8 8 R POWERFIL MOTOR - RED HORN + WHT GRASS PAK SWITCH R RED RED/WHT WHT PINK TAN DARK GRN PUR YEL/BLU GRN/WHT 0 AMP CIRCUIT BREAKER RED PUR BLU STARTER SOLENOID ENGINE RED RED/WHT ALTERNATOR 1Y MAGNETO 9X FUEL PUMP Y ENGINE MIL 4X LOW OIL X Y ENGINE GROUND STARTER SOLENOID X ALTERNATOR 1X X OFF START RUN G + M B + A / S1 + S B + A S1 = START CIRCUIT S = START/ACCESSORY CIRCUIT M = MAGNETO GROUND CIRCUIT B = BATTERY CIRCUIT A = ACCESSORY CIRCUIT G = GROUND CIRCUIT RELAY - A START RELAY OFF 0 + 8A START RUN PTO ON 0 + 8A RELAY - B IGNITION RELAY OFF 0 + 8A START RUN PTO ON 0 + 8A RELAY - C PTO INTERLOCK RELAY OFF 0 + 8A START RUN PTO ON A ORG ORG/WHT BRN/WHT RELAY - B 0 BRN GRN/WHT PUR GRN/WHT REGULATOR/RECTIFIER WHT 8 8A WHT PUR RELAY - A 0 YEL 8 8 PUR/ RED EPUR/RED RED PINK FUEL PUMP MODULE 8 8A YEL/BLU BRN BLU PUR/RED SEAT SWITCH RED PUR/WHT ORG FSC NEUTRAL INTERLOCK SWITCH PUR AMP CIRCUIT BREAKER PUR/WHT PUR/WHT DARK GRN - WARNING HORN + - RED/WHT WHT YEL M G S1 B S A RED/WHT BLU RED PUR PUR PUR/ WHT PUR/WHT PUR/WHT ENGINE SERVICE LIGHT TAN BRN/WHT HOUR METER 0

33 MAINTENANCE AND SERVICE RECORD SHEET DATE SERVICE ENGINE ITEM HOURS 1

34 MAINTENANCE AND SERVICE RECORD SHEET DATE SERVICE ENGINE ITEM HOURS

35 1 WHAT THIS WARRANTY COVERS, AND FOR HOW LONG: LIMITED WARRANTY FOR WALKER MODEL S14i RIDER MOWER Walker Manufacturing company will, at its option, repair or replace, without charge, any part covered by this warranty which is found to be defective in material and/or workmanship within one (1) year* after date of sale to the original retail purchaser unless the product is used for rental purposes, in which case this warranty is limited to ninety (90) days At Walker s request, customer will make the defective part available for inspection by Walker and/or return the defective part to Walker, transportation charges prepaid All parts and components of the Walker Mower are covered by this warranty except the following components which are warranted separately by their respective manufacturers: Kohler Engine Battery The available warranties covering these items are furnished with each mower Walker does not assume any warranty obli gation, liability or modification for these items, which are covered exclusively by the stated warranty of the respective man ufacturers noted above * A two () year or 000 hour (whichever comes first) warranty is offered for Hydro-Gear ZT100 hydrostatic transmissions; covers full cost of replacement up to 1000 hours of use, and after 1000 hours warranty coverage is prorated against 000 hours WHAT THIS WARRANTY DOES NOT COVER: A This warranty does not cover defects caused by depreciation or damage caused by normal wear, accidents, improper maintenance, improper use or abuse of the product, alterations, or failure to follow the instructions contained in the Operator s Manual for operation and maintenance B The customer shall pay any charges for making service calls and/or for transporting the mower to and from the place where the inspection and/or warranty work is performed HOW TO OBTAIN SERVICE UNDER THIS WARRANTY: Warranty service can be arranged by contacting the dealer where you purchased the mower or by contacting Walker Man ufacturing Company, 9 East Harmony Road, Ft Collins, CO 808 Proof of the date of purchase may be required to verify warranty coverage 4 WARRANTY LIMITATION: A THERE IS NO OTHER EXPRESS WARRANTY ANY WARRANTY THAT MAY BE IMPLIED FROM THIS PURCHASE INCLUDING MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE IS HEREBY LIMITED TO THE DURATION OF THIS WARRANTY AND TO THE EXTENT PERMITTED BY LAW ANY AND ALL IMPLIED WARRANTIES ARE EXCLUDED Some states do not allow limitations on how long an implied warranty lasts, so the above limitations may not apply to you B WALKER WILL NOT BE LIABLE FOR ANY INCIDENTAL, CONSEQUENTIAL, OR SPECIAL DAMAGES AND/OR EXPENSES IN CONNECTION WITH THE PURCHASE OR USE OF THE MOWER Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation(s) or exclusion(s) may not apply to you C Only the warranty expressed in this limited warranty shall apply and no dealer, distributor, or individual is authorized to amend, modify, or extend this warranty in any way Accordingly, additional statements such as dealer advertising or presentations, whether oral or written, do not constitute warranties by Walker, and should not be relied upon D This warranty gives you specific legal rights, and you may also have other rights which vary from state to state

36 WALKER MFG CO 9 E HARMONY ROAD, FORT COLLINS, CO 808 (90) 1-14 FORM NO 101 PRINTED IN USA wwwwalkermowerscom 01 WALKER MFG CO