Palm Beach County Fleet Management Asset Maintenance History

Transcription

1 Workorder: In Date: 01/30/2003 Close Date: 02/19/2003 Replaced PlugReplaced Wiring From Dist Box Make Asset No# Non Pottable Decals Charge: REPLACE TRAILERPLUG MALE CONNECTOR TRAILER WIRE 6 WIRE 14 GAUGE Charge: Workorder: In Date: 01/31/2003 Close Date: 01/31/2003 PREDELIVERY INSPECTION PreDelivery Inspection 4.00 Charge: 0.00 Charge: Workorder: OIL In Date: 02/04/2003 Close Date: 02/06/2003 Check For Oil Leak Test Run Charge: W30 MOTOR OIL Charge: Workorder: In Date: 02/13/2003 Close Date: 02/13/2003 VEHICLE TAG Vehicle Tag Charge VEHICLE TAG 1.00 Charge: Charge: 0.00 Workorder: In Date: 04/04/2003 Close Date: 04/04/2003 VEHICLE TAG CHARGE Tag Charge VEHICLE TAG CHARGE 1.00 Charge: Charge:

2 Workorder: In Date: 05/15/2003 Close Date: 05/27/2003 Rewire Male Plug Charge: REPAIR TAIL LAMPS Charge: Workorder: In Date: 11/05/2003 Close Date: 11/13/2003 Test Trailer Light CircuitsCheck Ground Circuit Charge: LIGHTS DON'T WORK* R/R LENS BROKEN RED MARKER LIGHT SQUARE Charge: Workorder: In Date: 04/26/2006 Close Date: 04/27/2006 Repair Tire Charge: NAIL IN RT RR TIRE Charge: Workorder: In Date: 04/11/2007 Close Date: 04/25/2007 Pm Service Replaced Right Rear Brake AssemblyRepaired Broken Wire On Left Rear Brake. Eqpt Pm Service Test Run Charge: PM PRESSURE WASHER AND TRAILER PH6607 OIL FILTER LBF PH2876 WIX DON'T USE 2.00 SAE 30W OIL 2.00 BPR6ES SPARK PLUG R/R BRAKE ASSB SEAL 4.00 AIR FILTER 17210ZJ Charge:

3 Workorder: In Date: 05/29/2008 Close Date: 06/06/2008 Pm Service Aps Service Reattach Belt Guards On Both Engines Service Pressure Pumps X2 Water Contaminator Test Run Charge: PM TRAILER AND PRESSURE WASHER, PINS FOR HITCH LEG SEAL 4.00 BPR6ES SPARK PLUG WT ND OIL WT ND OIL 3.00 PH6607 OIL FILTER LBF PH2876 WIX DON'T USE FUEL FILTER BRIGGS & STRATTON WT ND OIL Charge: Workorder: WELD In Date: 06/04/2008 Close Date: 06/05/2008 Fabricate 4 Corner Aluminum Braces To Weld To Unit. Weld Existing Cracks At All 4 Corners. Weld On 4 Corner Braces For Extra Support. Charge: /8X1X1X20 ALUM ANGLE ARCHITECTURAL Charge: Workorder: In Date: 10/16/2008 Close Date: 10/21/2008 Ck For No StartUnable To Prime Carbs. R/R Fuel Lines & Primprimer Bulbs & Clear Lines Still Had Intermittent Operation Of Primer Bulbs Test Run Charge: REFUELED,WILL NOT START 3.50 PRIMER BULB Charge:

4 Workorder: In Date: 07/29/2009 Close Date: 07/31/2009 Pm Trailer Service Both Pressure Washers Adjust Brakes Blank Line Replace R/R Tailight,Repair Wires Replace Battery Replace Tire Charge: P.M. SERVICE PS1250F1 BATTERY (POWER SONIC PS1250F1) 1.00 BPR6ES SPARK PLUG WT ND OIL SEAL 4.00 PH6607 OIL FILTER LBF PH2876 WIX DON'T USE Charge: Workorder: In Date: 08/27/2009 Close Date: 08/31/2009 LEFT ENGINE SMOKES UNDER LOAD,CHECK BOTH ENGINES Ck Oil Level Level Trailer And Set Engine Oil To Proper Level Test Run 0.50 Charge: 2.00 Charge: Workorder: In Date: 06/28/2010 Close Date: 07/14/2010 Pm Service Both Pressure Washers Charge Battery And Ck R/R Battery R/R Primer Bulb Left Engine Charge: pm/ fuel leak/ battery MARINE 27 BATTERY DEEP CYCLE (ACD M27MF EXD NG27) SEAL 4.00 PH6607 OIL FILTER LBF PH2876 WIX DON'T USE /16 PRIMER BULB Charge:

5 Workorder: In Date: 07/22/2010 Close Date: 09/07/2010 Only Commercial Repair Transport To Vanlinda And Back To Shop HITCH LOCK BROKEN 2.00 COUPLER 1.00 Charge: Charge: Commercial Charge: Workorder: replace belts In Date: 02/25/2011 Close Date: 03/29/2011 Replace Motor To Pump Drive Belts On Both Auxilary Motors And Replace Supply Hose O Pump (Left) Replace All 4 Tires Charge: 6.00 TR416 VALVE STEM 4.00 TIRE DISPOSAL FEE 4.00 BELTS X16 TIRE E 4.00 Charge: Workorder: In Date: 08/05/2011 Close Date: 08/11/2011 Pm Trailer Ck Service Pressure Washer Sys X2 W/Pump Drain And Refiller Repalce Male Plug Replace 2 Dry Rotted Primer Bulbs Remoount Tag Charge: PM / Replace Trailer Light Plug ZE8015 FUEL FILTER HONDA MALE CONNECTOR 1.00 PH6607 OIL FILTER LBF PH2876 WIX DON'T USE WT ND OIL /4 PRIMER BULB 2.00 PREFILTER 2.00 AIR FILTER 2.00 BPR6ES SPARK PLUG Charge:

6 Workorder: In Date: 09/02/2011 Close Date: 09/19/2011 Replace Botls And Adjust On Right Side Pressure Washer Charge: BELTS OFF RIGHT SIDE / TIGHTEN ALL BELTS AS NEEDED 1.00 BELT Charge: Workorder: In Date: 10/14/2011 Close Date: 10/19/2011 Replace Trailer Plug Repalce L.Tail Lamp Bulb & R/Marker Bulb Charge: replace trailer plug MALE CONNECTOR Charge: Workorder: In Date: 10/22/2012 Close Date: 10/31/2012 Pm Trailer Replace Trailer Plug Replace Breakway Battery Service Pressure Washers R&R Belt Guard To Adjsut Belts From Engines To Pumps Charge: PM / Engine runs rough / No pressure TRAILER CONN PLUG FUEL FILTER B 2.00 OIL FILTER 1.00 PH6607 OIL FILTER LBF BATTERY PO 1.00 SPARK PLUG SEAL 4.00 Charge:

7 Workorder: pm service In Date: 10/15/2013 Close Date: 10/22/2013 Pm 2 Pressure Cleaners Service Trailer Charge: 8.00 OIL FILTER NO SUPERCEDE 2.00 FUEL FILTER 2.00 SEAL Charge: Workorder: dead battery In Date: 02/25/2014 Close Date: 02/27/2014 Ck Charging Sys, Ck For Draw, Charge Ck Batery R/R Bad Batery R/R 2 Rear Tires (One Run Flat, One Bald In Center) Charge: X16LT E 10PLY 2.00 MARINE 27 BATTERY DEE 1.00 TIRE DISPOSAL FEE Charge: Workorder: In Date: 10/20/2014 Close Date: 10/28/2014 Pm Replace Breakaway Battery Service Trailer Repair Ground To L/Rear Tail Lamp Repair Broken Wiring To R/Rear Brake Charge: pm/ wands/ reel/ see notes 9.50 NAPAGOLD OIL FILTER 2.00 FUEL FILTER 2.00 SPARK PLUG V5AMP/HOUR BATTERY Charge:

8 Workorder: In Date: 11/07/2014 Close Date: 11/20/2014 Replace All 6 Belts On Both Pumps And Reinstall All Belt Guards Replace Both Return Hoses From Pressure Regulator To Tank Ck BrakesAll Working From Trailer Plug And Breakaway Switch Charge: hoses/ belts/ brakes/ see notes 4.50 VBELT Charge: Workorder: In Date: 12/12/2014 Close Date: 12/23/2014 Weld Hitch Repair need new hitch welded on Charge: 0.00 Charge: 0.00 Commercial Charge: Workorder: In Date: 12/12/2014 Close Date: 12/30/2014 Replace Tow Hooks W/Spring Clip Replace Brake Away Battery Charge: replacetow hooks, spring clips are missing /16 COUPLER V5AMP/HOUR BATTERY 2.00 GLOS BLK /16 CLEVIS SLIP HOOK Charge:

9 Workorder: In Date: 11/13/2015 Close Date: 11/24/2015 Service Pressure Cleaner Service Trailer Replace Burnt Bulbs Charge: pm service/ see notes 7.50 NAPAGOLD OIL FILTER 2.00 BULB 2.00 BULB 2.00 FUEL FILTER 2.00 SEAL 4.00 GREASE CAP 4.00 NAPA 10W30 QT 4.00 SPARK PLUG 4.00 BULB Charge: Workorder: In Date: 11/13/2015 Close Date: 11/19/2015 Tire Service 2601 Vista/ Fleet Replace 2 Tires Front Axle replace 2 tires front axle Charge: 0.00 Charge: 0.00 Commercial Charge: Workorder: In Date: 11/18/2015 Close Date: 11/19/2015 Tire Service Vista Mount/Dismount mount/dismount Charge: 0.00 Charge: 0.00 Commercial Charge:

10 Workorder: In Date: 11/20/2015 Close Date: 11/30/2015 Only Charge: 2 NEW TIRES TIRE DISPOSAL FEE 2.00 GLADIATOR QR25 ST225/90R GLADIATOR QR25 ST225/90R Charge: 0.00 Workorder: In Date: 08/24/2016 Close Date: 08/29/2016 Reinstall Belt Guards And Check Belts Charge: belt covers loose/ check belt tension Charge: Workorder: pm service In Date: 01/04/2017 Close Date: 01/24/2017 Pm Replace Pressure Washer Battery And Trailer Breakaway Battery Service Trailer Replace Trailer Plug Charge: MALE TRAILER CONNECTOR 1.00 GROUP 27 MARINE 1.00 SEAL 4.00 SPARK PLUG 4.00 NAPA 10W30 QT 4.00 FUEL FILTER 2.00 NAPAGOLD OIL FILTER V5AMP/HOUR BATTERY 1.00 Charge:

11 Workorder: new tires In Date: 01/10/2017 Close Date: 01/24/2017 Only Charge: GLADIATOR QR25 ST225/90R TIRE DISPOSAL FEE Charge: 0.00 Workorder: In Date: 01/06/2017 Close Date: 01/10/2017 Tire Service 2601 Vista Needs 2 Rear Tires Replaced needs 2 rear tires replaced Charge: 0.00 Charge: 0.00 Commercial Charge: Total Charges: 3, Total Charges: 7, Total Comm. Charges: 1,