Palm Beach County Fleet Management Asset Maintenance History

Size: px

Start display at page:

Download "Palm Beach County Fleet Management Asset Maintenance History"

Tobias White
5 years ago
Views:

1 INTERNATIONAL 4300 Dump Truck, 5 Yard, Steel Workorder Meter 52 In Date 08/02/2005 Closed 08/03/2005 Problem CHECK IN - New Vehicle Check In 8.00 Labor Parts 2.00 Total Workorder Meter 0 In Date 09/15/2005 Closed 09/15/2005 Problem MAKE & APPLY DECALS. CHECK FLUIDS, BELTS, AND OPER - Make & Apply Decals. Check Fluids, Belts, And Operation As Applicable Labor Parts 0.00 Total Workorder Meter 265 In Date 09/23/2005 Closed 09/29/2005 Problem PTO DON'T WORK - To Advanced Truck 2.00 Labor Parts 2.00 Total Workorder Meter 1119 In Date 12/09/2005 Closed 12/13/2005 Problem REPLACE MUD FLAP - R&r Mud Flap - R&r Lights Mud Flap 24x30 Splash Guard(spl ) Labor Parts Total Workorder Meter 1010 In Date 12/12/2005 Closed 01/23/2006 Problem BED WILL NOT LOWER - Lower Bed - To John Prince - Advance Fab And Back Labor Parts 2.00 Total

2 Workorder Meter 7659 In Date 06/12/2006 Closed 07/31/2006 Problem PM SERVICE AND BED WILL NOT LOWER - Pm - Mount Firex (none On Truck) - Repair Center Rear Marker & L F Marker, 3 Rear Reflectors - Free Up Dump Body Valve (won't Move) Hoist In Bent Pin Looseand Yoke Bent At Tailgate Release. - Repair By Advance Truck Eqpt. - Advance Fabricator And Back - Test Run Custom5lb Bracket Firex Stock # lb Firex Abc Stock# Flare Kits Triangle Reflector Kits 1.00 Air Freshener Red Reflector 3" Round Stick(grt 40052) Labor Parts Total 1, Workorder Meter In Date 10/13/2006 Closed 10/25/2006 Problem MOTOR SURGING/AIRLEAK/PTO BRACKET - Leak Tested Air Sys.tighten Various Connections Under Truck And In Engine Compartment. - Fabricate New Bracket And Reinstall Pto Assembly Bracket. - Installed Lap Top Checked For Codes None Present. - Rd Tested Truck No Problem Found Labor Parts 2.00 Total Workorder Meter In Date 01/17/2007 Closed 02/22/2007 Problem REPAIR TARP ASSY - Repair Tarp Assy - Performed Service - Repaired Brackets For Body Up Light And Replaced Switch Also - Filled Tires With Nitrogen - Repaired Wiring For Backup Alarm - Test Run 11/4x.093x24 Tubing Square Aluminum /4x2x20 Alum Flat Bar /4"1x20 Alum Flat Bar 6063 Gauge Ca9346 Air Filter Lbf Laf9099 Wix Female Connector 1.00 B90 Switch Body Up Switch Ring Retaining Aero Tarp Rh Arm Connecting Aero Tarp Lh Arm Connecting Aero Tarp Bushing Insert Aero Tarp Labor Parts Total 1,378.04

3 Workorder Meter In Date 12/06/2007 Closed 12/07/2007 Problem AIR LEAK - To P-nut Island - Replace Drain Valve - Drill & Retap Air Tank Quick Drain (use Also 12104) Labor Parts Total Workorder Meter 0 In Date 02/12/2008 Closed 02/12/2008 Problem TRANSITION PREP - Transition Prep 2.00 Labor Parts 0.00 Total Workorder Meter In Date 04/22/2008 Closed 05/01/2008 Problem PM SERVICE - Pm Service - Replace Batt & Holddown Bolt.ck Chrging Sys. Ok - Repl Tarp/bracket Drill Holes And Secure Bracket W/nuts & Bolts.lube And Test.ok - Replace Bumper (front) - Indicator Light For Body Up Switch Not On Ck For Current At Light & Switch Found Bad Body Up Switch.repl Switch.test Ok - Test Run Ca9346 Air Filter Lbf Laf9099 Wix Front Bumper 1.00 Air Freshener 1.00 Group 31 Stud Battery (acd ct) 2.00 Battery Hold Bolt 2.00 B90 Switch Body Up Switch Tarp 7.5x18 Finished Size Donovan Rh Arm Connecting Aero Tarp Lh Arm Connecting Aero Tarp Labor Parts 1, Total 2, Workorder Meter In Date 07/21/2008 Closed 07/25/2008 Problem SAFETY LATCH - Remove Old Pintle Pin.bend & Cut Chain And Reattach New Pin Pintle Pin Lock Pin 3/8"x2-1/2" Pintle Pin Labor Parts 3.44 Total 63.44

4 Workorder Meter In Date 09/05/2008 Closed 09/22/2008 Problem PM SERVICE - Pm - Pm Transmission.change Oil & Filter. - Repair Side Marker Light,repl Red Lens Rear & Sides. - Diagnose Body Up Light On Continuously.ck Switch.bolt For Deactivation Is Broke.repl Bolt & Adjust,test Operation. - Prop Rod Handle To Hold Body Up. Freight 1.00 Ca9346 Air Filter Lbf Laf9099 Wix Trans Filter Frm C9031 Wix 57740xe 1.00 Syn/atf Trans Fluid Synthetic Air Freshener Red Reflector 3" Round Stick(grt 40052) 3.00 Body Prop Pin 1.00 Roll Pin 1.00 Spring Labor Parts Total 1, Workorder Meter 0 In Date 11/18/2008 Closed 12/08/2008 Problem TIRESOLES OF BROWARD INC - Tiresoles Of Broward Inc 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter 0 In Date 11/18/2008 Closed 12/08/2008 Problem TIRESOLES OF BROWARD INC - Tiresoles Of Broward Inc 0.00 Labor 0.00 Parts 0.00 Total 0.00

5 Workorder Meter In Date 02/03/2009 Closed 03/12/2009 Problem CHECK ENGINE LIGHT IS ON - Diag Ck Eng Light.hookup Laptop,run All Sys Test.determine Ebp Sensor Bad.repl Map Sensor.turno Appears Bad Will Send To Int For Repair - Ck For Low Power Inspect Fuel Sys.clean Sediment Trap Remv Fuel Filter,clean Housing Of Rust Sediment Repl Filter.r&r Fuel Tank For Repl - Road Test Multiple Imrs While Checking Performance. - Pm Service - Or Repair Body Prop Rod. - Fm-vanlinda And International Trucks, Repaired Turbo Labor 1, Ca9346 Air Filter Lbf Laf9099 Wix Tank 1.00 Fittings 2.00 Fuel Tank 1.00 Fuel Tank Used Firex Refurbed Fire Extingshers r Reflector Red 3" Stick On 3.00 Exh Sensor 1.00 Map Sensor 1.00 Parts 1, Total 3, Workorder Meter In Date 05/12/2009 Closed 05/22/2009 Problem WILL NOT RUN - Replace Cam Position Sensor. Replace Crank Position Sensor. R&r Dump Body Control Cam Pos Sensor 1.00 Crank Pos Sensor Labor Parts Total Workorder Meter 0 In Date 05/26/2009 Closed 05/26/2009 Problem SISTERS TOWING & TRANSPORTATON TOW FROM GUNCLUB & - Sisters Towing & Transportaton Tow From Gunclub & Military - Tow To He Shop 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 05/26/2009 Closed 05/29/2009 Problem WILL NOT START - Fuel Filters-drain Fuel Sys-contained Fuel, Clean Fuel Tank Replace Fuel Filter. Bleed Fuel Sys. - Road Test. - To Soouthern And Military Labor Parts Total

6 Workorder Meter 0 In Date 05/11/2009 Closed 05/26/2009 Problem SISTERS TOWING & TRANSPORTATON TOW FROM MILTRY TRL - Sisters Towing & Transportaton Tow From Miltry Trl & Southern Blvd - Tow To He Shop 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 08/05/2009 Closed 08/11/2009 Problem pm service - pm service - clean evaporator and replace filter - nitro all tires - replace batteries - road test - Commercial Workorder Entry replace left rear tire recap by elpex c1 A/c Filter 1.00 Used Firex Refurbed Fire Extingshers Evapor Cleaner Evaporator Cleaner 1.00 Group 31 Stud Battery (acd ct) r225rc Tire Recapped Labor Parts Total 1, Workorder Meter In Date 02/17/2010 Closed 03/17/2010 Problem pm service - pm service - test cooling system replace leval sensor - replace ac filter, clean box and evap. - replace pental hitch safety pin - replace rear marker lights - service and replace filter on p. s. - service trans - test drive - replace r.r.i. tire recap elpex c1 A/c Filter Trans Filter Frm C9031 Wix 57740xe c1 P/steering Filter Wix c1 Gasket P/steering Filter Brake Clean a P/steering Fluid 2.00 Syn/atf Trans Fluid Synthetic r Marker Light 2.5" Red Led Grommet 2.5" Marker Light Adapter Plug Plug Led Marker Light 1.00 Coolant Level Sensor In Reservoir 1.00 H/duty A/freeze Ext/life (cat ) r225rc Tire Recapped Pintle Pin Labor Parts Total 1,457.68

7 Workorder Meter In Date 02/25/2010 Closed 03/02/2010 Problem TIRES - South County Parks 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 02/25/2010 Closed 03/02/2010 Problem service - south county park 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 03/25/2010 Closed 04/06/2010 Problem Tarp - Repair tarp assembly Arm Kit Connection (aero) Crank Tarp (aero) Bushing Insert Aero Tarp Labor Parts Total Workorder Meter In Date 04/01/2010 Closed 04/02/2010 Problem no start - From s county regional park To he shop 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 04/14/2010 Closed 04/16/2010 Problem stalling - scan for codes and replace coolant senser - test cooling system - test drive Coolant Level Sensor In Reservoir Labor Parts Total Workorder Meter In Date 06/16/2010 Closed 06/22/2010 Problem check pto - repair open in wiring for Pto 1.50 Labor Parts 2.00 Total 92.00

8 Workorder Meter In Date 07/20/2010 Closed 09/07/2010 Problem pm service - P.m. - Repair marker lamps - Nitro tires - Test run - Travel to vanlinda - repair sissor linkage - Travel to vanlinda - service call Used Firex Refurbed Fire Extingshers r Marker Light 2.5" Red Led r22.5 R250f Lr G Tire 1.00 Valve Stem Tr572/ Labor Parts Total 1, Workorder Meter In Date 12/27/2010 Closed 12/27/2010 Problem PTO - Repaired Pto 1.00 Labor Parts 2.00 Total Workorder Meter In Date 03/22/2011 Closed 03/30/2011 Problem pm service and check trailer plug - pm service - pto wiring harness melted make and install new - test all lights and trailer plug replace fuses - replace ac door actuator - test drive Ca9346 Air Filter Lbf Laf9099 Wix c1 A/c Filter 1.00 Aw68 Hydro Fluid Hydraulic Oil Fuseholder Imperial c1 Acuator Door Vent Labor Parts Total 1,005.24

9 Workorder Meter In Date 08/09/2011 Closed 08/12/2011 Problem pm service - pm service - tighten exhaust clamp at turbo - replace two rear caps boulevard - test drive c1 A/c Filter Gear Oil Synthetic 75w r225rc Tire Recapped Labor Parts Total Workorder Meter In Date 01/18/2012 Closed 01/24/2012 Problem tires - Replace one frount and one rear tire 11r225rc Tire Recapped Labor 0.00 Parts Total Workorder Meter In Date 02/16/2012 Closed 04/16/2012 Problem pm service and coolant like comes on - P.m. - R&r Serp. belt - Replace res. bottle,sencer,and top off - Repair driverside tarp bar - Nitro tires - Repair Pto leak, R&r pump c1 Belt 1.00 Ca9346 Air Filter Lbf Laf9099 Wix c1 A/c Filter 1.00 Aw68 Hydro Fluid Hydraulic Oil Used Firex Refurbed Fire Extingshers 1.00 H/duty A/freeze Ext/life (cat ) 2.00 Coolant Reservoir 1.00 Coolant Level Sensor 1.00 Coolant Reservoir Cap Swingarm Aero Tarp Arm Kit Connection (aero) 1.00 Pto Pump Assy Labor Parts 1, Total 2,374.96

10 Workorder Meter In Date 08/03/2012 Closed 08/16/2012 Problem check engine light is on low power and pm - pm service - scan and clear codes replace Vgt actuator - test drives c1 A/c Filter 1.00 Vgt Actuator Labor Parts Total 1, Workorder Meter In Date 11/30/2012 Closed 12/04/2012 Problem boulevard replace rro tire - replace rro recap boulevard 11r225rc Tire Recapped Labor 0.00 Parts Total Workorder Meter In Date 02/14/2013 Closed 02/15/2013 Problem trailer plug - replace trailer plug repair wiring 5404 Female Connector Labor Parts Total Workorder Meter In Date 04/03/2013 Closed 04/22/2013 Problem pm service and body prop bent - pm service - install fire ext. - repair hitch - repair lights and wiring - fm to vanlinda Oil Napagold Oil Filter 1.00 Napagold Fuel Filter 1.00 Napagold Air Filter Wiper Blades Used Firex Refurbed F Labor Parts Total 1, Workorder Meter In Date 04/15/2013 Closed 04/16/2013 Problem boulevard replace LRI cap - boulevard replace lri cap Tire Disposal Fee r225rc Tire Recapped Labor 0.00 Parts Total

11 Workorder Meter In Date 04/17/2013 Closed 04/22/2013 Problem repair body prop vanlinda - vanlinda repair body stand 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 08/09/2013 Closed 08/12/2013 Problem replace LRO - Replace Lro Tire Tire Disposal Fee r225rc Tire Recapped Labor 0.00 Parts Total Workorder Meter In Date 08/29/2013 Closed 09/04/2013 Problem lro flat - Lro flat repair 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 09/27/2013 Closed 10/08/2013 Problem pm service - P.m. - Clean Evaporator - Test Run Oil Napagold Oil Filter 1.00 Napagold Fuel Filter 1.00 Wiper Blade 2.00 Napa Cabin Air Filter Gear Oil Syn Labor Parts Total Workorder Meter In Date 10/09/2013 Closed 10/10/2013 Problem Replace LF tire - replace lf tire 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 10/18/2013 Closed 10/23/2013 Problem trailer plug - replace trailer plug 5404 Female Connector Labor Parts Total 75.25

12 Workorder Meter In Date 03/12/2014 Closed 03/13/2014 Problem Repair trail plug - replace trailer plugs - to Jpp Trailer Conn Plug 1.00 Trailer Conn Socket Labor Parts Total Workorder Meter In Date 04/29/2014 Closed 05/15/2014 Problem pm - pm - replace air drier element - replace tarp springs and bushings - test run Oil Napagold Oil Filter 1.00 Napagold Fuel Filter 1.00 Napagold Air Filter 1.00 Wiper Blade 2.00 Used Fire X Refurbished 1.00 Blaster Penetrant 1.00 Cartridge Ad Bushing 4.00 Spring 2.00 Tarp 7.5 X 18 In 1.00 Snap Ring Labor Parts Total 1, Workorder Meter In Date 06/02/2014 Closed 06/25/2014 Problem tire - tire repair 0.00 Labor 0.00 Parts 0.00 Total 0.00

13 Workorder Meter In Date 07/15/2014 Closed 07/30/2014 Problem List - scan codes with laptop. R&r icp sensor. R&r fuel drain valve. remove dog house to access - replace compressor, thermistors, orfice tube, and accumulator with new. replace mode door actuator and blower fan and lpm module. evac and charge system - R&r bench seat - test run - replace 2 batteries and check charging system - To Jp Park Labor 1, Icp Sensor 1.00 Valve Cover Gasket 1.00 Drain Kit 1.00 A C Accumulator 1.00 Orifice Tube Navistar 1.00 R134a Freon 2.00 E8 A/c Oil Univ W Dye 1.00 A/c Compressor 1.00 Fleetrunner Belt c1 Acuator Doo 1.00 Thermistor Kit 1.00 Napa Cabin Air Filter 1.00 O-ring 8.00 A/c O-ring A/c Seal 8.00 A/c Seal Group 31 Stud Delco 2.00 Brake Cleaner 4.00 O-ring 1.00 A/c Tube 1.00 Blower Motor 1.00 Blower Resistor 1.00 Seat R And R 1.00 Parts 3, Total 4, Workorder Meter In Date 07/18/2014 Closed 07/21/2014 Problem RRO tire - Rro tire 11r225rc Tire Recapped 1.00 Tire Disposal Fee Labor 0.00 Parts Total

14 Workorder Meter In Date 10/14/2014 Closed 11/07/2014 Problem Won't Dump - replace hydraulic pump - pm - test run Ptex Thrd Seal Hitemp Oil Napagold Oil Filter 1.00 Napagold Fuel Filter 1.00 Napagold Air Filter 1.00 Wiper Blade 2.00 Pto Pump 1.00 Aw68 Hydro Fluid Hydr Freight Charge Labor Parts Total 1, Workorder Meter In Date 12/04/2014 Closed 12/05/2014 Problem Hyd. Leak - Ck out hyd leak and sent to shop - To Jpp 1.50 Labor Parts 2.00 Total Workorder Meter In Date 04/29/2015 Closed 05/15/2015 Problem PM - Pm - Fix Tarp - Road Test Oil Napagold Oil Filter 1.00 Napagold Fuel Filter 1.00 Napagold Air Filter 1.00 Wiper Blade 2.00 Used Fire X Refurbished 1.00 Washer Fl 1.00 Tarp Bar 1.00 Connect Arm Kit 1.00 Swing Arm Labor Parts Total Workorder Meter In Date 05/12/2015 Closed 05/22/2015 Problem LRI RRI tires - 2 Tires 11r225rc Tire Recapped 2.00 Tire Disposal Fee Labor 0.00 Parts Total

15 Workorder Meter In Date 09/28/2015 Closed 09/29/2015 Problem RRO Replace - Rro tire 11r225rc Tire Recapped 1.00 Tire Disposal Fee Labor 0.00 Parts Total Workorder Meter In Date 10/28/2015 Closed 11/23/2015 Problem PM - Pm - Transmission Service - Ps service - Flush cooling system - Service Ac - Road Test Oil Napagold Oil Filter 1.00 Napagold Fuel Filter 1.00 Napagold Air Filter 1.00 Wiper Blade 2.00 Syn-atf Trans Fluid S Napa Trans Filter 1.00 Psf Qt 2.00 Power Steering Filter 1.00 H Duty Anti-freeze 6.00 Napa Cabin Air Filter Labor Parts Total 1, Workorder Meter In Date 04/06/2016 Closed 04/27/2016 Problem List - R&r fan clutch, temp sencer, and termostat - Flush cooling sytem - Replace drive belt - R&r shocks - Road test - Charge Ac using dye, replace filters Thermostat 1.00 Fan Clutch 1.00 Temp Sensor 1.00 H Duty Anti-freeze 6.00 Serpentine Belt 1.00 front shock 2.00 Napa Cabin Air Filter 1.00 R134a Freon 2.00 E8 A/c Oil Univ W Dye Labor Parts 1, Total 2,083.94

16 Workorder Meter In Date 05/25/2016 Closed 06/09/2016 Problem Tarp - Repair tarp bar Bulb 1.00 Connect Arm Kit 1.00 Tarp Bar 1.00 Cable Tie Labor Parts Total Workorder Meter In Date 07/08/2016 Closed 08/05/ pm Problem PM - Ac service - replace comp, evap, condenser, accummulator, orfice tube evac and charge - replace tarp crank box and tarp bushings - road test Labor 1, Oil Napagold Oil Filter 1.00 Napagold Fuel Filter 1.00 Napagold Air Filter 1.00 Wiper Blade 2.00 Used Fire X Refurbished 1.00 Washer Fluid Concentr 1.00 Napa Cabin Air Filter 1.00 Evaporator 1.00 Accumulator/dryer 1.00 Valve 1.00 condensor 1.00 R134a Freon 2.00 a/c compressor 1.00 A/c Seal 1.00 a/c seal 1.00 O-ring 1.00 A/c O-ring 1.00 Thermistor Kit 1.00 Tarp Kit Chain 1.00 Control Crank Kit 1.00 Bushing 2.00 Parts 2, Total 3, Workorder Meter In Date 09/23/2016 Closed 09/23/2016 Problem leaking fluid - Tow From Jpp behind sm engine shop To vista He 0.00 Labor 0.00 Parts 0.00 Total 0.00

17 Workorder Meter In Date 09/26/2016 Closed 10/21/2016 Problem leaking fluid/tires - water pump - coolant service - replace drive belt - road test Water pump kit 1.00 Rotell Elc Antifeerze 7.00 belt Labor Parts Total Workorder Meter In Date 09/29/2016 Closed 09/30/2016 Problem LRIO Tires - Lrio Tire 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 12/28/2016 Closed 01/12/2017 Problem Brake Noise - To Lake Lytal 2xs - Inspected brake system and found to be Ok - Repaired Tcm cover hitting drive shaft - Added coolent Rotell Elc Antifeerze 1.00 Cable Tie Labor Parts Total

18 Workorder Meter In Date 02/27/2017 Closed 04/04/ Pm Problem PM/list - Service Trans - Service Power Steering - Service Ac - Repair Ac repaired leak and recharged - Replaced steering box, drag link, and steering bar - Service rear diff - Repair air leaks. Replace air tank and fittings. Replace governor fittings and air lines - Diagnost and replaced brake controler - Test Drive Labor 2, Drain Valve 2.00 Drain Valve 3.00 hose made Oil Napagold Oil Filter 1.00 Napagold Fuel Filter 1.00 Napagold Air Filter 1.00 Wiper Blade 2.00 Washer Fluid Concentr 1.00 Non-chlor Brake Clnr 3.00 Napa Trans Filter 1.00 Syn-atf Trans Fluid S Psf Qt 2.00 Power Steering Filter 1.00 Napa Cabin Air Filter 1.00 Freon He Shop 3.00 A/c Valve Core 1.00 A/c Valve Core 1.00 V Core 1.00 A/c Service Cap 2.00 Used Fire X Refurbished cart Palladium 2 Grs 1.00 steering arm Gear Oil Gear air tank front 1.00 Brake Control 1.00 Gear Asm c1 Gasket P-st 1.00 steering link 1.00 Tube-nylon-black Parts 2, Total 5, Workorder Meter In Date 06/12/2017 Closed 06/20/2017 Problem battery - replace 2 batteries check charge system - test run Group 31 Stud Delco Labor Parts Total

19 Workorder Meter In Date 08/30/2017 Closed 11/02/2017 Problem brakes - abs light on. R&r diff assembly due to broken axle - road test - to total truck Labor 2, Cable Tie 2.00 rear axle housing Gear Oil Gear U Bolt 4.00 Nut 7/ Washer 8.00 Brake Shoe Kits- New 2.00 Non-chlor Brake Clnr 3.00 Brake Drum 2.00 Bleeder Valve 1.00 Nut R Wheel 1.00 Napa Ep Grease 4 Can 1.00 Lock Whl 1.00 Axle Shaft 1.00 Gfil Gasket 1.00 Pilt/brg 1.00 Wheel Speed Sensor Nat Cable Tie 1.00 Parts 6, Total 9, Workorder Meter In Date 11/02/2017 Closed 11/02/2017 Problem Transition Prep Charge - Transition Prep Charge 2.00 Labor Parts 0.00 Total

Palm Beach County Fleet Management Asset Maintenance History

Palm Beach County Fleet Management Asset Maintenance History Workorder: 633791 Meter Reading: 54 CHECK IN In Date: 02/03/2006 Close Date: 02/07/2006 Ck In Charge: 10.00 2.00 Charge: 500.00 Workorder: 635149 Meter Reading: 76 RECHECK In Date: 03/02/2006 Close Date: