Palm Beach County Fleet Management Asset Maintenance History

Transcription

1 Meter Reading: 0 Labor 03/08/2002 Close Date: 03/08/2002 PRE-DELIVERY INSPECTION Meter Reading: 55 Labor 04/03/2002 Close Date: 04/15/2002 SPECIAL ORDER FILTERS & BLADES PER CUSTOMER REQUEST Meter Reading: 63 Labor 04/08/2002 Close Date: 04/23/2002 P.M. SERVICE /40 OIL 2.00 REPLACE SAFETY CHUTE,L/F GREASE 3.50 CAP,REINSTALL TENSIONER PULLEY & R/R DRIVE BELT FOR BLADES.**NECESSARY TO REMOVE BROKEN BOLT.DRILL OUT PERFORM TUNE-UP RC14YC SPARK PLUG Meter Reading: 155 Labor 05/31/2002 Close Date: 06/27/2002 SPECIAL ORDER DISCHARGE CHUTE. **CUSTOMER WILL DO INSTALLATION CHUTE LABEL Meter Reading: 442 Labor 09/09/2002 Close Date: 09/20/2002 1

2 Meter Reading: 442 Labor 09/09/2002 Close Date: 09/20/2002 ORDER REPLACE ALL ANTI SCALP WHEELS BUSHINGS BOLTS 1.20 WASHER 24H BUSHING CAP SCREWS 19H ANTI SCALP WHEEL AM LOCK NUT T REPALCE 2 REAR TIRE MOUNT AND INSTALL TURF CHIEF 2.00 SET UP WARRANTY REPAIR FOR SHORTED BRAKE SWITCH AND WIRING Meter Reading: 556 Labor 10/28/2002 Close Date: 10/29/2002 CK STARTING SYSTEM 0.50 RR BATTERY 1.00 GROUP 22NF BATTERY (ACD 351) 1.00 TEST CHARGING SYSTEM Meter Reading: 560 Labor 11/06/2002 Close Date: 11/18/2002 REPLACE FRONT CASTER WHEEL TIRES 1.00 TIRE TCU RR LEFT SIDE FUEL TANK ASSEMBLY 0.50 FUEL TANK TCA

3 Meter Reading: 560 Labor 11/06/2002 Close Date: 11/18/2002 REPLACED ALL ANTI SEAL WHEELS AND DISCHARGE CHUTE 2.00 ROLLER M STUD M ANTI SCALP WHEEL AM BOLT 19H WASHER 24H LOCK NUT T LOCK NUT 14M BUSHING M DISCHARGE CHUTE AM RR BEST BUFFLER & SHEILD 1.50 SHIELD TCU MUFFLER AM GASKET M Meter Reading: 611 Labor 01/03/2003 Close Date: 01/07/2003 REMOVE CARB & INTAKE & REMOVE BOLT FROM INTAKE PORT OF R-S HEAD Meter Reading: 711 Labor 03/10/2003 Close Date: 03/14/2003 PM KOLER AIR FILTER FRM CA8507,JD# GY PH7575 OIL FILTER L/F#PH G1 FRAM 1/4" FUEL FILTER WIX L/F G1/ /40 OIL 2.00 PERFORM TUNE UP 1.50 RC14YC SPARK PLUG RR DECK BELT PUMP BELT PTO BELT RR DECK BELT TENSIONER PRESS OUT BUSHING & REPAIR CK STARTER CIRCUIT TO VERIFY CUSTOMER CONCERNS SYS OK TCU10002 V BELT 1.00 TCU10003 V BELT 1.00 TCU10005 V BELT

4 Meter Reading: 711 Labor 03/10/2003 Close Date: 03/14/2003 REPAIR REAR TIRE Meter Reading: 836 Labor 04/30/2003 Close Date: 05/07/2003 SUPPLIED CUSTOMER WITH SPARE SPARK PLUG PER REQUEST 0.50 RC14YC SPARK PLUG Meter Reading: 851 Labor 05/14/2003 Close Date: 05/20/2003 SUPPLIED CUSTOMER WITH BATTERY 0.50 GROUP 22NF BATTERY (ACD 351) Meter Reading: 861 Labor 06/04/2003 Close Date: 06/26/2003 PERFORM TUNE UP 1.30 RC14YC SPARK PLUG CLEAN CARB & AIR CLEANER HOUSING KOLER AIR FILTER FRM CA8507,JD# GY CARB CLEANER 1.00 RR BLADE TENSIONER PULLEY EXTRA TIME NECES. TO REMOVE BROKEN BOLT INSTALL BELT COVER & RINGS 0.80 RING M CAP SCREW 19H WASHER 24H BUSHING TCU SHIELD TCU RR FRONT CASTER WHEELS & SPACES 0.70 SPACER TCU TIRE AND WHEEL TCA REMOVE DEBRIS FROM L/R TIRE & RIM

5 Meter Reading: 899 Labor 08/08/2003 Close Date: 08/15/2003 REPLACE L/REAR TIRE TURF CHIEF 1.00 REPLACE IGN SWITCH 1.00 JOHM92426 KEY 1.00 JOHTCA51267 KEY SWITCH 1.00 JOHTCU51053 NUT 1.00 JOHTCU51054 COVER 1.00 SAFETY INSPEC SVC BATTERY CLEAN AIR FILTER Meter Reading: 910 Labor 11/18/2003 Close Date: 12/05/2003 REPLACE PTO AND MOWER DECK BELTS V BELT V BELT 1.00 REPLACE MOWER CHUTE AND SEAT ARM BRACKETS CHUTE BRACKET BRACKET KNOB 4.00 PM KOLER AIR FILTER FRM CA8507,JD# GY PH561 OIL FILTER WIX PH7575 OIL FILTER L/F#PH G1 FRAM 1/4" FUEL FILTER WIX L/F G1/ AW68 HYDRO FLUID HYDRAULIC OIL INJECTOR CLEANER DON'T REORDER /40 OIL 2.00 REPLACE SPARK PLUGS AND TUNE UP 1.00 RC14YC SPARK PLUG REPLACE RR TIRE TURF CHIEF 1.00 TEST RUN

6 Meter Reading: 910 Labor 03/12/2004 Close Date: 03/22/2004 INSTALL TIRE SEALER AND REPAIR TIRE Meter Reading: 910 Labor 05/18/2004 Close Date: 06/09/2004 PM /40 OIL KOLER AIR FILTER FRM CA8507,JD# GY PH3614 OIL FILTER LBF PH2835 WIX WIX OIL FILTER L/F# PH2814 FRAM PH G1 FRAM 1/4" FUEL FILTER WIX L/F G1/ REPLACE CHUTE ANTI SCALP WHEELS PINTLE PIN 1.00 JOHM88183 RING 4.00 JOHAM KIT 2.00 JOHTCU10075 CAP 2.00 JOHAM CUITE 1.00 REPLACE MAIN CENTER SPINDAL ASSY 1.50 JOHTCA13807 SPINDLE Meter Reading: 910 Labor 07/22/2004 Close Date: 07/30/2004 REPLACE FUEL SHUT OFF VALVE 1.30 JOHTCA51304 SHUT OFF VALVE 1.00 REPLACE 2 FRONT TIRES CARLISLE RIB 04 TIRE Meter Reading: 910 Labor 08/11/2004 Close Date: 08/30/2004 6

7 Meter Reading: 910 Labor 08/11/2004 Close Date: 08/30/2004 REPLACE PUMP DRIVE BELT AND PULLEY TEST RUN 2.00 JOHM88183 RINGS 4.00 JOHTCA10058 PULLEY 1.00 JOHTCU10002 V BELT Meter Reading: 910 Labor 12/09/2004 Close Date: 12/21/2004 REPLACE DISCHARGE CHUTE 0.50 AM CHURE Meter Reading: 910 Labor 04/06/2005 Close Date: 04/28/2005 REPLACE STARTER & BRAKE SWITCH 1.80 STARTER AM SWITCH TCA P.M. SERVICE INJECTOR CLEANER DON'T REORDER /40 OIL KOLER AIR FILTER FRM CA8507,JD# GY PH3614 OIL FILTER LBF PH2835 WIX B&S OIL FILTER FRAM PH8170 WIX G1 FRAM 1/4" FUEL FILTER WIX L/F G1/ REPLACE MUFFLER & CHOKE CABLE & TUNE-UP 2.70 BKR5E SPARK PLUG MUFFLER AM GASKETS M CHOKE CABLE TCA

8 Meter Reading: 910 Labor 04/06/2005 Close Date: 04/28/2005 REPLACE PTO & MOWER DECK BELTS & PULLEYS,GAS CAPS,SHUTE, SEAT ASSY.,ANTI-SCALP WHEELS & STEERING SHOCKS 5.00 IDLERS AM SEAT ASSY. TCA PULLEY TCA GAS CAPS CA PULLEY TCA ABSORBER TCU CHUTE AM BELT TCU BELT TCU PULLEY TCA ANTI-SCALPWHEEL KIT AM SHIELD RINGS M REPLACE BATTERY & CHECK CHARGING SYSTEM 1.00 GROUP 22NF BATTERY (ACD 351) Meter Reading: 910 Labor 08/15/2005 Close Date: 08/24/2005 REPLACE 4 TIRES TURF CHIEF CARLISLE TIRES 2.00 REPLACE DRIVE BEL TENSION SPRING 3.00 JOHAM GUARD 1.00 JOHTCU10010 SPRING 1.00 JOHTCU CAP 2.00 JOHM77167 V-BELT 1.00 JOHM V-BELT 1.00 REPLACE CHUCK CHUCK Meter Reading: 910 Labor 09/14/2005 Close Date: 09/16/2005 ORDER 3 SETS OF BLADES 0.50 JOHM MOWER BLADES

9 Meter Reading: 910 Labor 09/14/2005 Close Date: 09/16/ Meter Reading: 911 Labor 09/27/2005 Close Date: 09/28/2005 PM SERVICE INJECTOR CLEANER DON'T REORDER /40 OIL KOLER AIR FILTER FRM CA8507,JD# GY PH3614 OIL FILTER LBF PH2835 WIX B&S OIL FILTER FRAM PH8170 WIX G1 FRAM 1/4" FUEL FILTER WIX L/F G1/ G2 FUEL FILTER 5/16" WIX L/F G G2 FUEL FILTER 5/16" WIX L/F G TUNE-UP 1.00 BKR5E SPARK PLUG REPAIR MOWING DECK, RECONDITION BATTERY TRAY 3.00 REINSTALL DECK DRIVE Meter Reading: 1 Labor 10/04/2005 Close Date: 10/11/2005 REPLACE HOUR METER 1.00 JOHTCA REPLACE MOWING DECK BELT, & TENSION BELT 1.20 JOHTCU10005 V-BELT 1.00 JOHTCU51101 SPRING Meter Reading: 1 Labor 02/22/2006 Close Date: 03/02/2006 9

10 Meter Reading: 1 Labor 02/22/2006 Close Date: 03/02/2006 ORDERED BLADES AND TINES 0.50 TCA10064 WHEELS 2.00 TC10077 SPACER 1.00 M BLADES 6.00 TCU10077 SPACER Meter Reading: 328 Labor 05/23/2006 Close Date: 05/25/2006 ORDER BLADES 0.50 M MOWER BLADE Meter Reading: 328 Labor 06/02/2006 Close Date: 06/12/2006 PM SERVICE AIR FILT CA PH3614 OIL FILTER LBF PH2835 WIX B&S OIL FILTER FRAM PH8170 WIX G1 FRAM 1/4" FUEL FILTER WIX L/F G1/ INJECTOR CLEANER DON'T REORDER /40 OIL 4.00 REFURBISH DECK INCLUDING REPLACE ALL 3.50 M ROLLER 2.00 ROLLERS STRIGHTEN AND WELD ALL M STUD 1.00 DEFLECTORS REPLACE DECK CHAINS 14M7400 LOCK NUT M8874 SCREW 4.00 M BUSHING 4.00 AM WHEELS 4.00 M WASHER M7396 LOCK NUT 4.00 M SPRING H3205 CAP SCREW 4.00 TCHU51100 NUT 4.00 TCA51038 LINK CHAIN 4.00 N LOCK NUT

11 Meter Reading: 328 Labor 06/02/2006 Close Date: 06/12/2006 REPLACE MUFFLER GASKETS 1.00 M GASKET 2.00 M BLADES Meter Reading: 359 Labor 06/22/2006 Close Date: 07/03/2006 REPLACE R/S HYDRO DRIVE PUMP 5.50 TCU10075 CAPS AIR FILTER KIT KOHLER, JDEER GY PH3614 OIL FILTER LBF PH2835 WIX TCA10020 HYDRAULIC PUMP 1.00 BKR5E SPARK PLUG AW68 HYDRO FLUID HYDRAULIC OIL PRESSURE WASH 1.00 ING. AWITCH REPLACE R & R BODY PANELS FOR REPLACEMENT 1.00 TCA51267 ING SWITCH 1.00 TCU51053 NUT 1.00 TCU5154 COVER Meter Reading: 362 Labor 07/18/2006 Close Date: 07/19/2006 PRESSURE WASH TO CK FOR OIL LEAK; R&R 1.70 LEFT VALVE COVER; CLEAN & RESEAL; RUN TO CK FOR LEAK Meter Reading: 381 Labor 08/16/2006 Close Date: 08/22/2006 REPLACE DECK BELT & IDLER PULLEY 1.00 BELT TCU PULLEY TCA R&R MUFFLER & HEAT SHIELDS 1.30 MUFFLER AM GASKET M

12 Meter Reading: 381 Labor 08/16/2006 Close Date: 08/22/ Meter Reading: 403 Labor 09/11/2006 Close Date: 09/13/2006 INSPECT PTO & DRIVE SYS; R&R PTO CLUTCH ASSY; REPLACE DECK JACK SHAFT & PTO BELT 3.10 TEST RUN 0.50 JACK SHAFT TCA PTO BELT TCU CLUTCH TCA Meter Reading: 566 Labor 02/22/2007 Close Date: 03/06/2007 CLEAN & INSPECT FOR OIL LEAK; R&R FT ENGINE SEAL BRAKE CLEAN 1.00 FT SEAL M Meter Reading: 601 Labor 03/29/2007 Close Date: 03/30/2007 REPAIR DECK BAFFLING (WELD) Meter Reading: 601 Labor 04/10/2007 Close Date: 04/17/2007 PM SERVICE AIR FILTER KIT KOHLER, JDEER GY PH3614 OIL FILTER LBF PH2835 WIX B&S OIL FILTER FRAM PH8170 WIX G1 FRAM 1/4" FUEL FILTER WIX L/F G1/ INJECTOR CLEANER DON'T REORDER /40 OIL

13 Meter Reading: 601 Labor 04/10/2007 Close Date: 04/17/2007 REPLACE DRIVE BELT 1.00 BELT TCU REPLACE 2 FT TIRES 1.00 TIRES Meter Reading: 657 Labor 05/25/2007 Close Date: 05/31/2007 CHECK PULLEY & ADJUST; REPLACE BROKEN BELT; CLEAN OF DEBRIS AND MUD 1.25 BELT TUC Meter Reading: 675 Labor 06/12/2007 Close Date: 06/25/2007 REPLACE BLADE SHAFT COVER; REPLACE 2 FT ROLLERS, WHEELS, RINGS & ROLLER SHAFT 0.75 LOCKNUT 14M ROLLERS M ROD M RINGS M R/S SHIELD TCU Meter Reading: 726 Labor 07/11/2007 Close Date: 07/20/2007 PRESSURE WASH DIRT & OIL FROM BOTTOM; REPLACE CLUTCH TO DECK BELT (DAMAGED BY SHARP OBJECT) PARTS ONLYASH DIRT & OIL FROM BOTTOM; REPLACE CLUTCH TO DECK BELT (DAMAGED BY SHARP OBJECT) 2.00 V BELT TCU HA238C STROBE BULB USE WHELEN #S30HAC 1.00 HA238C STROBE BULB USE WHELEN #S30HAC R RED MARKER LIGHT RECTANGULAR R RED MARKER LIGHT RECTANGULAR

14 Meter Reading: 726 Labor 08/08/2007 Close Date: 08/17/2007 C/C BACK PULLEY INOP; VERIFY COMPLAINT; 1.00 BELT FELL OFF; REMOVE PULLEY & REPAIR DENT; REINSTALL BELT & PULLEY; TEST DRIVE Meter Reading: 726 Labor 08/30/2007 Close Date: 09/21/2007 C/S BELT IN BACK; VERIFY COMPLAINT; PUMP BELT & PTO BELT BROKEN; REPLACE BELTS, SPRINGS, PULLEYS & BOLTS;TEST DRIVE;REPL DUST CAPS REPAIR REAR CLUTCH GUARD; GRIND OFF OLD ONE; FABRICATE & WELD ON NEW ONE DUST CAPS TCU BELT TCU LOCK NUTS U WASHERS 24H PULLEY TCA CAP SCREW 19H CAP SCREW 19H CAP SCREW 19H SLEEVE TCU SPRING TCU BUSHING TCU BUSHING TCU Meter Reading: 915 Labor 10/29/2007 Close Date: 10/31/2007 REPLACE 2 REAR TIRES & ROTATE 2 FT TIRES TURF CHIEF 2.00 TIRE DISPOSAL FEE 2.00 TIRE DISPOSAL FEE 2.00 TIRES CARB CLEANER 1.00 WD40 SPRAY LUBE STOCK# REMOVE BROKEN BOLT IN BRAKE BAND; 1.25 REPLACE BOLT & REMOUNT BAND; DRILL OUT OLD BROKEN BOLT 14

15 Meter Reading: 915 Labor 10/29/2007 Close Date: 10/31/2007 REMOVE BELT TENSIONER;STRAIGHTEN BRACKET; REPL ALL BOLTS; REINSTALL TENSIONER; REPAIR BENT PULLEY FT WHEEL BRGS COMPLETELY DRY OF GREASE; LUBRICATE ALL & REINSTALL Meter Reading: 915 Labor 10/30/2007 Close Date: 11/20/2007 REPLACE 2 FT ROLLERS, STUD & NUT; NO LEAK FOUND AT THIS TIME 0.75 LOCKNUT 14M ROLLERS M STUD M REPLACE PTO SWITCH & TEST 0.75 PTO SWITCH AM Meter Reading: 918 Labor 11/26/2007 Close Date: 12/31/2007 CK AIR FILTER BREATHER HOSE & REPLACE; CLEAN OIL FROM SURFACE & TEST RUN C/S PULLEY UNDER MOWER LOOSE; R&R BELT, IDLER ARM, ALL SPACERS/BUSHINGS, BOLTS, NUTS & PULLEY; TEST DRIVE BRTHR HOSE MIU BELT TCU SPRING TCU CAP SCREW 19H LOCKNUTS U BOLT 19H CAP SCREW 19H ARM TCA PULLEY TCA SPACER TCU BUSHING TCU BUSHING TCU LOCKNUTS U

16 Meter Reading: 918 Labor 11/26/2007 Close Date: 12/31/ Meter Reading: 1176 Labor 02/27/2008 Close Date: 02/29/2008 PM SERVICE AIR FILTER KIT KOHLER, JDEER GY PH3614 OIL FILTER LBF PH2835 WIX B&S OIL FILTER FRAM PH8170 WIX G1 FRAM 1/4" FUEL FILTER WIX L/F G1/ INJECTOR CLEANER DON'T REORDER /40 OIL 3.00 CLEAN DECK; REALIGN WHEEL & CRACKED 4.25 DECK; PATCH & FAB PANEL&WHEEL SUPPORT; WELD CRACKED DECK & REPAIR SUPPORTS; CLEAN WELDS & PAINT Meter Reading: 1176 Labor 02/29/2008 Close Date: 03/14/2008 REMOVE & CLEAN OIL COOLER; CLEAN FITTINGS; REPLACE COOLER & O RINGS; TEST FOR LEAKS REPLACE FT DECK WHEEL & STUD; REPLACE L/S BELT SHIELD O RINGS 2.00 HYD OIL COOLER 1.00 AW68 HYDRO FLUID HYDRAULIC OIL R/F DECK WHEEL 1.00 L/S PULLEY SHIELD Meter Reading: 1198 Labor 03/21/2008 Close Date: 03/25/2008 REMOVE WATER-FOULED, CLEAN & REINSTALL; CK FOR SPARK, FUEL &COMPRESSION; CHANGE H20-CONTAMINATED OIL; REPL O/F & TEST RUN FOR 45 MINS /40 OIL B&S OIL FILTER FRAM PH8170 WIX

17 Meter Reading: 1198 Labor 03/21/2008 Close Date: 03/25/2008 CK BATTERY & CHARGE; FOUND 1 BAD CELL; REPLACE BATTERY 0.75 GROUP 22NF BATTERY (ACD 351) Meter Reading: 1237 Labor 05/20/2008 Close Date: 05/28/2008 C/S LEAKS OIL; VERIFY COMPLAINT; 3.50 DISASSEMBLE TOP END OF ENGINE; INSTALL SILICONE ON VALVE COVER; REASSEMBLE & CLEAN AREA; TEST DRIVE Meter Reading: 1315 Labor 06/17/2008 Close Date: 06/30/2008 OIL LEAKING DUE TO OVERFILLING; AIR FILTER SATURATED W/OIL; DRAIN OIL & REFILL; REPLACE AIR FILTER; TEST DRIVE; WASH DOWN MOWER & ENGINE AIR FILTER KIT KOHLER, JDEER GY /40 OIL Meter Reading: 1321 Labor 06/25/2008 Close Date: 07/08/2008 REPLACE 2 DECK WHEELS; FABRICATE & WELD R/S OF DECK & BRACE WHEEL; REMOVE BROKEN PULLEY; REPLACE PULLEY & BUSHING; REPL BROKEN DIPSTICK 7.00 WHEEL KIT 1.00 PULLEY 1.00 BUSHING 1.00 DIPSTICK 1.00 REPLACE CRACKED & TORN DRIVE BELT 1.00 TCU10002 PUMP DRIVE BELT JDEERE M665 ZTR 1.00 GASKET 1.00 R&R LEAKING CRANKCASE BREATHER GASKET 1.25 WHEEL KIT

18 Meter Reading: 1321 Labor 06/25/2008 Close Date: 07/08/2008 REPAIR R/R TIRE 1.00 TEST RUN Meter Reading: 1333 Labor 07/10/2008 Close Date: 09/16/2008 R&R 2 SPARK PLUGS; TEST; SPARK GOOD; COIL HAS PROB HEATING UP & LOSING SPARK; DIAGNOSE; REMOVE FT COVER & REPLACE 2 COILS REMOVE CARB&CLEAN; REMOVE DIRT FROM FUEL BOWL;REP VAC LEAK; NO COMPRESSION ON CYL; DISASS ENGE & REPL CYL HEAD; TEST 45MINS;CUTS&RUNS WELL TEST DRIVE 4 HRS TO MAKE SURE OF REPAIRS & VERIFY FIXES IGN COILS 2.00 BKR5E SPARK PLUG CYL KIT 1.00 RETAINERS 2.00 L/S CYL 1.00 SPRINGS 2.00 INTAKE VALVE 1.00 EXHAUST VALVE 1.00 SEAL 1.00 RETAINERS 2.00 CAPS 2.00 REPLACE FT ROLLERS ON DECK 0.50 ROLLERS 2.00 STUD 1.00 LOCK NUT 1.00 PUSH RODS 2.00 REPLACE GROUND & POSITIVE CABLES & BATT 1.00 TERM ENDS; REPAIR STARTER WIRES & POWER WIRES; CK CHARGING SYS 18

19 Meter Reading: 1366 Labor 09/17/2008 Close Date: 09/29/2008 C/S REPL FT WHL BRGS; VERIFY COMPLAINT; R&R ALL FT WHL BRGS;R&R CASTER FORK BRGS; TEST DRIVE L/R TIRE GOES FLAT; PLUG TIRE & ADD FIX-A-FLAT; 22 PSI BEARINGS 4.00 BEARINGS 4.00 BEARINGS 3.00 CAGES 4.00 SPACERS 2.00 SEALS Meter Reading: 1366 Labor 10/10/2008 Close Date: 10/10/2008 INSTALL FT MIDDLE ROLLERS; PARTS PROVIDED BY DRIVER Meter Reading: 1382 Labor 10/15/2008 Close Date: 10/29/2008 C/S PROBLEMS STARTING; VERIFY COMPLAINT; STARTER IS NO GOOD;R&R STARTER 1.75 STARTER Meter Reading: 3883 Labor 10/28/2008 Close Date: 11/06/2008 C/S BLADES WON'T ENGAGE; R&R BLOWN FUSE; 3.75 REPAIR BROKEN CLTCHWIRE; VERIFY AFTER DIAGNOSIS MULTIPLE SHORTS IN PTO WIRING;REPAIR,TEST & LUBE Meter Reading: 1403 Labor 11/18/2008 Close Date: 01/30/

20 Meter Reading: 1403 Labor 11/18/2008 Close Date: 01/30/2009 REMOVE AND SEAL FRONT ENGINE COVER /40 OIL /40 OIL BRAKE CLEAN 1.00 PH3614 OIL FILTER LBF PH2835 WIX G1 FRAM 1/4" FUEL FILTER WIX L/F G1/ PM SERVICE 4.00 AW68 HYDRO FLUID HYDRAULIC OIL B&S OIL FILTER FRAM PH8170 WIX Meter Reading: 1411 Labor 02/05/2009 Close Date: 02/19/2009 REPAIR IGNITION LEAD IN HARNESS; INSTALL NEW FUSE HOLDER IN-LINE FUSEHOLDER 30 AMP Meter Reading: 1440 Labor 03/31/2009 Close Date: 04/07/2009 C/S DRIVE BELT PULLEY BROKEN; VERIFY CONCERN; FABRICATE & REPAIR BROKEN PULLEY TENSIONER BOLT; REINSTALL DRIVE BELT; TEST DRIVE Y648 GRAPHITE LUBE (IMPERIAL 6590) Meter Reading: 1449 Labor 04/09/2009 Close Date: 04/13/2009 C/S FT DECK WHEEL NEEDS REPLACED; VERIFY 3.00 CONCERN; FAB, WELD&REPAIR DECK WHEEL SUPPORT; REPLACE WHEEL & BOLT; TEST DRIVE REPAIR NAIL IN R/F TIRE 0.50 ROLLERS 2.00 STUD 1.00 LOCK NUT

21 Meter Reading: 1449 Labor 04/09/2009 Close Date: 04/13/ Meter Reading: 1489 Labor 05/13/2009 Close Date: 05/22/2009 C/S MIDDLE BLADE DOESN'T SPIN; VERIFY 2.00 COMPLAINT; REMOVE SPINDLE ASSY; RETAP THREADS & REINSTALL; TEST DRIVE Meter Reading: Labor 06/12/2009 Close Date: 06/26/2009 REPLACE DECK BELT, PTO BELT, PULLEYS & SAFETY SHIELD FOR R/S; TEST DRIVE 3.50 REPLACE LEAKING OIL COOLER HOSE 1.25 IDLERS 2.00 SHIELD 1.00 DECK BELT 1.00 PTO BELT 1.00 C/S CK STARTING SYS; VERIFY CONCERN; 2.25 RECHARGE BATT & CHECK CHARGING/STARTING SYS; FOUND DAMAGED WIRES TO STARTER; REPAIR WIRING HARNESS Meter Reading: 1558 Labor 07/07/2009 Close Date: 07/15/2009 C/S REAR BELT TENSIONER PROBLEM. R/R TENSIONER PULLEY AND DUST CAP VERIFIED MAC. RUNNING BAD AND LEAK OIL. REPAIR VALVE COVER GASKETS AND IGN.SYSTEM TUNE UP.TEST DRIVE PULLEY 1.00 CAP 1.00 BUSHING 1.00 BKR5E SPARK PLUG AIR FILTER KIT KOHLER, JDEER GY

22 Meter Reading: 1558 Labor 07/07/2009 Close Date: 07/15/2009 Shop Supplies SHOP SUPPLIES Meter Reading: 1561 Labor 07/16/2009 Close Date: 07/31/2009 C/S EXHAUST LEAK?VERIFY;NEEDS CYLINDER 2.00 HEAD ASY.;MUFFLER;SHIELD&DEFLECTOR ASY. NOT CPST EFFECTIVE TO REPAIR.REASSEMBLE UNIT FOR DISPOSAL. Shop Supplies SHOP SUPPLIES Meter Reading: 0 Labor 08/21/2009 Close Date: 08/21/2009 Transition Prep Charge