Palm Beach County Fleet Management Asset Maintenance History

Size: px

Start display at page:

Download "Palm Beach County Fleet Management Asset Maintenance History"

Ethelbert McDaniel
5 years ago
Views:

1 Workorder: Meter Reading: 0 Labor In Date: 01/31/2002 Close Date: 01/31/2002 Problem: WASH VEHICLE WASH VEHICLE - PRE-DELIVERY INSPECTION - MAKE DUPLICATE KEYS FOR NEW VEHICLE Workorder: Meter Reading: 2771 Labor In Date: 08/02/2002 Close Date: 08/06/2002 Problem: P.M.SERVICE,TRANS CHECK TRANS. ADD TRANS FLUID.25 MILES TEST DRIVE.FOUND TRANSNO PROBLEM AT THIS TIME. Workorder: Meter Reading: 0 Labor In Date: 10/08/2002 Close Date: 10/08/2002 Problem: 002 KEYS ISSUED OUT 10/08/ KEYS ISSUED OUT 10/08/02 Workorder: Meter Reading: 5657 Labor In Date: 03/04/2003 Close Date: 03/06/2003 Problem: P.M.SERVICE SERVICE REAR BRAKES. - INSTALL HOW'S MY DRIVING STICKER : 0.00 L/F PH1218 FRM PH5 WIX OIL FILTER 1.00 ATFD TRANS FLUID MERCON V : DUPLICATE VEHICLE KEYS : 6.00 L/F PH1218 FRM PH5 WIX OIL FILTER :

2 Workorder: Meter Reading: 6479 Labor In Date: 04/18/2003 Close Date: 04/21/2003 Problem: L/F TIRE LEAKS REPAIR TIRE - R/R CUSTOM CENTER CAP/TIGHTEN OTHERS Workorder: Meter Reading: 9847 Labor In Date: 09/30/2003 Close Date: 10/02/2003 Problem: P.M.SERVICE SERVICE REAR BRAKES. Workorder: Meter Reading: Labor In Date: 02/04/2004 Close Date: 02/12/2004 Problem: POOR SHIFTING ON TAKE OFF CHECK FUEL SYS. R&R FUEL FILTER. - TRANS SYS SCAN TEST.(PASS)TEST DRIVE TO VERIFY DRIVER COMPLAINT.FOUND NO PROBLEM AT THIS TIME. Workorder: Meter Reading: Labor In Date: 05/11/2004 Close Date: 05/14/2004 Problem: P.M.SERVICE SERVICE REAR BRAKES : 2.00 AF7996 AIR FILTER USE FRM CA L/F PH1218 FRM PH5 WIX OIL FILTER : L/F G580 FRM G7333 WIX FUEL FILTER : 8.67 L/F PH1218 FRM PH5 WIX OIL FILTER 1.00 L/F G580 FRM G7333 WIX FUEL FILTER :

3 Workorder: Meter Reading: Labor In Date: 05/12/2004 Close Date: 05/14/2004 Problem: NAIL IN LEFT FRONT TIRE REPAIR TIRE AS NEEDED Workorder: Meter Reading: Labor In Date: 09/24/2004 Close Date: 09/29/2004 Problem: FLAT TIRE REPAIR LEFT REAR TIRE Workorder: Meter Reading: Labor In Date: 10/30/2004 Close Date: 11/16/2004 Problem: P.M.SERVICE SERVICE REAR BRAKES. - TRANSPORT & PICKUP VEHICLE AT DEALER.(LEAKING L/REAR AXLE SEAL) : : 2.00 AF7996 AIR FILTER USE FRM CA Workorder: In Date: : Meter Reading: Labor 05/16/2005 Close Date: 05/23/2005 3

4 Workorder: Meter Reading: Labor In Date: 05/16/2005 Close Date: 05/23/2005 Problem: P.M.SERVICE CHECK CHARGING SYS. R&R BATTERY. - R&R FAN BELT. - CLEAN & CHECK P/S FOR LEAK.R&R HYDRAULIC BOOSTER AND FLUSH SYS. TEST DRIVE. - R&R 4 TIRES. Workorder: Meter Reading: 0 Labor In Date: 04/26/2005 Close Date: 06/01/2005 Problem: AUTO TOW FLORIDA INC T078929/T AUTO TOW FLORIDA INC T078929/T Commercial Charge: Workorder: Meter Reading: Labor In Date: 12/19/2005 Close Date: 12/21/2005 Problem: P.M.SERVICE R&R REAR WHEEL CYLINDERS.SERVICE REAR BRAKES.TEST DRIVE. Workorder: In Date: Meter Reading: Labor 01/17/2006 Close Date: 01/18/ BATTERY GROUP HYDRAULIC BOOSTER 1.00 BP193 EXTENSION BOLT TERMIMAL EXTENSION /75R16 WRANGLER RT/S E FAN BELT A P/STEERING FLUID /75R16 WRANGLER RT/S E 1.00 TR416 VALVE STEM : 1, : 0.00 WC79768 WHEEL CYLINDER RAY WC BRAKE FLUID BRAKE FLUID :

5 Workorder: Meter Reading: Labor In Date: 01/17/2006 Close Date: 01/18/2006 Problem: DEAD BATTERY CHECK CHARGING SYS. R&R BATTERY BATTERY GROUP Workorder: Meter Reading: Labor In Date: 07/18/2006 Close Date: 07/20/2006 Problem: P.M.SERVICE,SEE NOTE SERVICE REAR BRAKES.TEST DRIVE. - REPAIR L/FRONT ARM REST. Workorder: Meter Reading: 0 Labor In Date: 08/07/2006 Close Date: 08/07/2006 Problem: 002 KEYS ISSUED OUT 08/07/ KEYS ISSUED OUT 08/07/06 Workorder: Meter Reading: Labor In Date: 08/07/2006 Close Date: 08/08/2006 Problem: CAGE DOOR LOOSE/RATTLES FABRICATE & REPAIR CAGE DOOR LOCK : AF7996 AIR FILTER USE FRM CA : DUPLICATE VEHICLE KEYS : 6.00 Workorder: In Date: : Meter Reading: Labor 01/24/2007 Close Date: 01/31/2007 5

6 Workorder: Meter Reading: Labor In Date: 01/24/2007 Close Date: 01/31/2007 Problem: P.M SERVICE SERVICE TRANSMISSION,REPLACE FILTER AND TEST DRIVE. - CLEAN AND ADJUST REAR BRAKES. - REPLACE SERPENTINE BELT. - FILL TIRES WITH NITROGEN. Workorder: Meter Reading: Labor In Date: 10/04/2007 Close Date: 10/15/2007 Problem: P.M SERVICE,COOLING SYSTEM INSPECTION TOPOFF COOLING SYS & PRESSURE TEST.FOUND WATER PUMP LEAKING FAN CLUTCH NOT LOCKING UP.INSTALL WATER PUMP FAN CLUTCH AND FLUSH & FILL SYS - BATTERY FAILED LOAD TEST,LEAKING AT BOTTOM.CLEANED TRAY AND INSTALL NEW BATTERY - REAR DRUM SERVICE - BALANCE ALL 4 TIRES Workorder: In Date: Meter Reading: Labor 04/18/2008 Close Date: 04/25/ DRAIN PLUG GMC/CHEVY 1.00 FT1203 TRANS FILTER LBF T709 WIX K SERP BELT 1.00 SYN/ATF TRANS FLUID SYNTHETIC : GROUP 78 BATTERY (ACD 78PS) INJECTOR CLEANER DON'T REORDER 1.00 ANTIFREEZE EXT/LIFE ALL MAKES (PEAK 407) BR BLACK SILICONE WATER PUMP FAN CLUTCH :

7 Workorder: Meter Reading: Labor In Date: 04/18/2008 Close Date: 04/25/2008 Problem: P.M. SERVICE.SEE NOTE PRESSURE TEST.R&R DEFECTIVE WATER PUMP,INTAKE TO EPL LEVER INTAKE GASKETS,REPL THERMOSTAT & GASKET.FLUSH COOLING SYS & REFILL.REPL CAP/RO - INDUCTION DECARB AND SYS CLEANING FLUSH INJECTORS. - SERVICE REAR BRAKES,CLEAN,INSPECT AND ADJUST REAR BRAKES. - REPL 1 VALVE STEM MOUNT ON RIGHT REAR.HIGH SPEED BALANCE ALL4 TIRES.NITRO FILL TIRES. Workorder: In Date: Meter Reading: Labor 10/06/2008 Close Date: 10/17/2008 CA9269 AIR FILTER LBF LAF7653 WIX INTAKE MANIFOLD GASKET SET 1.00 THERMOSTAT 1.00 D465 IGNITION ROTOR (ACD) 1.00 D329A IGN CAP (ACD) 1.00 L17301A ENGINE FOG KIT HARD CARBON (SMART BLEND) 1.00 WG16 WHITE LITHIUM (CRC 05037) 1.00 L17040 INJECT CLEANER ONE PART (SMART BLEND) 1.00 TR416 VALVE STEM 1.00 ANTIFREEZE EXT/LIFE ALL MAKES (PEAK 407) :

8 Workorder: Meter Reading: Labor In Date: 10/06/2008 Close Date: 10/17/2008 Problem: P.M. SERVICE.SEE LIST CHECK BATTERY AND CHARGING SYS.BATTERY FAILED REPLACE BATTERY WITH NEW. - ENGINE RUN ROUGH DIAG ENGINE CONTROL SYS CODE P0300 TUNEUP PLUGS IGNITION WIRES CAP AND ROTOR. - SERVICE REAR BRKES,CK WHEEL CYLINDERS LEAKING,REPL L/R R/R BLEED SYS AND TEST DRIVE OK - REAR AXLES SEAL FAILED R&R L/R R/R WITH NEW AND SERVICE R/DIFFERENTIAL - HYDRO BOOSTER FAILED LEAK HYDRAULIC FLUID,R&R WITH NEW. - ROTATE AND HIGH SPEED BALANCE AL 4 TIRES. Workorder: Meter Reading: Labor In Date: 03/30/2009 Close Date: 03/31/2009 Problem: P.M SERVICE,CHECK ENGINE LIGHT ON,RUNS ROUGH PERFORM COMPUTER DIAG.P0300 INSPECT IGNITION SYS. REPLACE IGN CAP AND ROTOR,CLEAR CODES AND RETEST. - SERVICE REAR BRAKES.INSPECT,CLEAN AND ADJUST. - ROTATE AND HI SPEED BALANCE ALL 4 TIRES. NITRO FILL TO SPECS GROUP 78 BATTERY (ACD 78PS) SPARKPLUG 8.00 D329A IGN CAP (ACD) 1.00 WC79768 WHEEL CYLINDER RAY WC W140 GEAR LUBE SYNTHETIC (MC XY75W140QL) WHEEL SEAL (NATIONAL 2081) A P/STEERING FLUID 2.00 CA9269 AIR FILTER LBF LAF7653 WIX HYDRO BOOSTER 1.00 IGNITION WIRE SET BRAKE FLUID BRAKE FLUID 1.00 D465 IGNITION ROTOR (ACD) 1.00 BP193 EXTENSION BOLT TERMIMAL EXTENSION : 1, D465 IGNITION ROTOR (ACD) 1.00 D329A IGN CAP (ACD) :

9 Workorder: Meter Reading: Labor In Date: 10/19/2009 Close Date: 11/04/2009 Problem: P.M service, see notes P.M service. - Diagnose brake light circuits, replace both rear wire harnesses to tail lamps, repair damaged & corroded connectors for trailer plug socket. - Mount two new tires, rotate & balance all four tires. - Service rear drum brakes. - Alignment. Workorder: Meter Reading: Labor In Date: 04/29/2010 Close Date: 05/06/2010 Problem: P.M service, see note P.M service. - Mount two new tires, rotate & balance all four tires. - Machine both rear brake drums, install new shoes & wheel cylinders, bleed system & adjust, test drive. - Remove L/F door panel & replace broken arm rest. - Test starting & charging system, diagnose failed starter & replace. - Diagnose rough idle, replace worn ign cap & rotor. Workorder: In Date: Meter Reading: Labor 11/01/2010 Close Date: 11/15/ M ELECTRIC TAPE STOCK # BIG G DEGREASER STOCK# TR416 VALVE STEM 2.00 TIRE DISPOSAL FEE 2.00 TAIL LIGHT HARNESS LT245/75R16 WRANGLER SR-A E 2.00 TAIL LIGHT HARNESS : LEFT FRONT DOOR ARM REST 1.00 D465 IGNITION ROTOR (ACD) 1.00 STARTER / A 1.00 D329A IGN CAP (ACD) 1.00 TIRE DISPOSAL FEE 2.00 TR416 VALVE STEM LT245/75R16 WRANGLER SR-A E BRAKE FLUID BRAKE FLUID 2.00 WHEEL CYLINDERS 2.00 REAR BRAKE SHOES SET :

10 Workorder: Meter Reading: Labor In Date: 11/01/2010 Close Date: 11/15/2010 Problem: Pm service also see notes on transmission performance Perform pm service. - Inspect and replace failed radiator fan clutch with new. - Inspect and service transmission.replace filter and gasket.flush and renew fliud. - Perform rear drum brakes service and adjust brake shoes. - Rotate and balance all four tires. CA9269 AIR FILTER LBF LAF7653 WIX FT1203 TRANS FILTER LBF T709 WIX FAN CLUTCH 1.00 SYN/ATF TRANS FLUID SYNTHETIC Workorder: Meter Reading: Labor In Date: 05/16/2011 Close Date: 06/06/2011 Problem: P.M. Service.Check Engine Light.Trans. Slipping Perform pm service. - Test and replace failed third brake lamp bulb and right stop lamp bulbs with new. - Pressure test and inspect cooling system.replace failed water pump and bypass hose with new.install new radiator cap.reverse flush and renew coolant. - Perform rear drum brakes service and adjust brake shoes. - Rotate and balance all four tires. Workorder: Meter Reading: Labor In Date: 06/17/2011 Close Date: 06/28/2011 Problem: Will not start Computer diagnose for no start concern.remove cover to engine compartment.test and replace failed distributor cap and rotor with new.clear codes and road test : WATER PUMP (ACD) 1.00 RADIATOR CAP 1.00 ANTIFREEZE EXT/LIFE ALL MAKES (PEAK 407) 2.00 BY-PASS HOSE : D329A IGN CAP (ACD) 1.00 D465 IGNITION ROTOR (ACD) :

11 Workorder: Meter Reading: Labor In Date: 07/15/2011 Close Date: 07/22/2011 Problem: Check engine light on and hard to start and stalling on turns 2.00 see notes. - Test starting and charging system.battery failed load test after recharge.replace failed battery with new. - Rotate,index and road force balance all four tires to correct steering wheel nibble around turns. GROUP 78 BATTERY (ACD 78PS) 1.00 Workorder: Meter Reading: Labor In Date: 11/09/2011 Close Date: 11/30/2011 Problem: P.M. service and check engine light and runs rough/hard to 8.75 start and won't go over 55 mph. - Perform pm service. - Computer diagnose for hard start.test and replace failed distributor assembly with new.clear codes with scan tool and road test. - Perform rear drum brake service and adjust brake shoes. - Rotate and balance all four tires. Workorder: Meter Reading: Labor In Date: 05/31/2012 Close Date: 06/28/2012 Problem: Pm service and check engine light on,runs rough Perform pm service. - Pressure test and inspect cooling system.replace failed water pump and radiator with new.reverse flush and renew coolant. - Inspect and replace failed left rear door handle and side door outer handle with new. - Computer diagnose for run rough concern.perform fuel injectors flush.tets and replace eight failed spark plugs with new.adjust timing and perform crank/cam sensors relearnwith scan tool. - Rotate and balance all four tires : DISTRIBUTOR : RADIATOR WATER PUMP (ACD) 1.00 REAR DOOR HANDLE 1.00 SIDE DOOR OUTER HANDLE 1.00 ANTIFREEZE EXT/LIFE ALL MAKES (PEAK 407) SPARKPLUG 8.00 KA8A THROTTLE BODY/ UP ENGINE SERVICE KIT

12 Workorder: Meter Reading: Labor In Date: 12/21/2012 Close Date: 01/08/2013 Problem: P.M. service and check brake lights P.M. Service. - Service and adjust rear brakes. - Rotate and balance all tires. - Replace left brake light bulb. Workorder: Meter Reading: Labor In Date: 01/28/2013 Close Date: 01/28/2013 Problem: Transition Prep Charge Transition Prep Charge 1, : NAPAGOLD OIL FILTER WIPER BLADES : : 0.00 Total Comm. Charges: Total Labor Charges: 8, Total Charges: 7,

Palm Beach County Fleet Management Asset Maintenance History

Palm Beach County Fleet Management Asset Maintenance History 10162875 2006 CHEVROLET TRAILBLAZER Suv, Lg Mid Size, 4X4 Workorder 636370 Meter 0 In Date 03/27/2006 Closed 03/27/2006 Problem WASH VEHICLE - Wash Vehicle - Pre-delivery Inspection 2.50 Labor 125.00 Parts