Palm Beach County Fleet Management Asset Maintenance History

Transcription

1 Workorder: Meter Reading: 0 In Date: 08/11/2008 Close Date: 08/11/2008 PREDELIVERY INSPECTION PreDelivery Inspection 4.00 Charge: 0.00 Charge: Workorder: Meter Reading: 5262 In Date: 01/05/2009 Close Date: 01/12/2009 Perform Pm Service Rotate And Hi Speed Balance All 6 Tires. Charge: P.M. SERVICE CS10263 FUEL FILTER (USE CS10263A ) 1.00 CA10270 AIR FILTER MTC FA1886 WIX CA10262 AIR FILTER MTC FA1883 WIX /40 OIL CA10262 AIR FILTER MTC FA1883 WIX OIL FILTERFRM CH9549 WIX CS10263 FUEL FILTER (USE CS10263A ) 1.00 CS10263 FUEL FILTER (USE CS10263A ) 1.00 USED FIREX REFURBED FIRE EXTINGSHERS Charge: Workorder: Meter Reading: 6557 In Date: 02/12/2009 Close Date: 02/18/2009 To/Fr Dealer For Recall 08B07 Charge: RECALL 08B Charge:

2 Workorder: Meter Reading: In Date: 05/15/2009 Close Date: 05/20/2009 BOTH FUEL CAPS MISSING AND ENGINE LIGHT ON Replace Both Missing Fuel Caps,Scan Per Codes & Clear Evap Code FUEL CAP (FORD) SHOP SUPPLIES FUEL CAP (FORD) 1.00 Charge: Charge: Workorder: Meter Reading: In Date: 06/04/2009 Close Date: 06/15/2009 Pm Service Inspect Brake Sys,Right Rear,Calipar,Top Bolt Missing.Instalnew Calipar Sliders And Bolts. Nitro Service All 6 Tires. Charge: P.M. SERVICE.BRAKES SQUEALS OIL FILTERFRM CH9549 WIX CS10263 FUEL FILTER (USE CS10263A ) /40 OIL REAR CALIPER PIN AND BOLT KIT Charge: Workorder: Meter Reading: P.M. Service. In Date: 11/13/2009 Close Date: 12/04/2009 P.M Service. Repair R/F Tire, Rotate & Balance All Six Tires. Repair Open Ground Circuit At Tag Light Assembly. Remove Radio'S & Misc Items From Truck For Dealer To Replace Floor Mat. To/From Dealer For Warrenty Floor Mat. Charge: /40 OIL OIL FILTERFRM CH9549 WIX CS10263 FUEL FILTER (USE CS10263A ) WIPER BLADES 20" BLADE 2.00 USED FIREX REFURBED FIRE EXTINGSHERS 1.00 PM22A ADDITIVE DIESEL FUEL (M/CRAFT) 1.00 FLOOR MAT SET 1.00 Charge: ,

3 Workorder: Meter Reading: P.M service. In Date: 04/27/2010 Close Date: 04/29/2010 P.M Service. Mount, Balance & Nitrofill Six New Tires. Alignment. Charge: OIL FILTERFRM CH9549 WIX WIPER BLADES 20" BLADE 2.00 CS10263 FUEL FILTER (USE CS10263A ) /40 OIL TR416 VALVE STEM 6.00 TIRE DISPOSAL FEE LT245/75R17 WRANGLER SRA E , Charge: Workorder: Meter Reading: In Date: 10/12/2010 Close Date: 10/18/2010 P.M. Service. Check Inop Power Outlet.Replace Blown Fuse. Rotate And Balance All Six Tires. Charge: P.M. service and cigarette lighter inop and canceiver OIL FILTERFRM CH9549 WIX CS10263 FUEL FILTER (USE CS10263A ) 1.00 USED FIREX REFURBED FIRE EXTINGSHERS /40 OIL WIPER BLADES 20" BLADE FUSE 20 AMP GMC C3Z9A343A SEAL KIT FUEL FILTER (FORD) 1.00 CA10270 AIR FILTER MTC FA1886 WIX Charge: Workorder: Meter Reading: In Date: 10/15/2010 Close Date: 10/19/2010 Flash Canceiver Charge: flash canceiver spot Charge:

4 Workorder: Meter Reading: In Date: 03/30/2011 Close Date: 04/07/2011 Perform Pm Service. Test Starting And Charging System.Both Batteries Failed Load Test After Recharge.Replace Both Failed Batteries With New. Test And Replace Both Failed Led Tail Lamps And Dome Lamp Bulb With New. Inspect And Service Transmission.Flush And Renew Transmission Fluid. Repair One Flat Right Rear Tire.Nitrogen Fill And Balance All Six. Charge: Pm service also see notes on jump starting vehicle CS10263 FUEL FILTER (USE CS10263A ) 1.00 CA10270 AIR FILTER MTC FA1886 WIX D3TZ2457B BRAKE PEDAL PAD A P/STEERING FLUID C3Z9A343A SEAL KIT FUEL FILTER (FORD) 1.00 SYN/ATF TRANS FLUID SYNTHETIC PM22A ADDITIVE DIESEL FUEL (M/CRAFT) 1.00 GROUP 65 BATTERY (MTC BXT65850) R TAIL LIGHT 4" RED 42 LED WIPER BLADES 20" BLADE OIL FILTERFRM CH9549 WIX /40 OIL Charge: Workorder: Meter Reading: In Date: 09/23/2011 Close Date: 09/23/2011 Transition Prep Charge Transition Prep Charge 2.00 Charge: 0.00 Charge: 0.00 Workorder: Meter Reading: RR FLAT In Date: 07/29/2011 Close Date: 11/28/2011 John Prince Park Charge: 0.00 Charge: 0.00 Commercial Charge:

5 Workorder: Meter Reading: perform pm In Date: 06/10/2013 Close Date: 06/20/2013 Pm Service Charge Batteries Test Clean Asset And Get Ready For Transfer Repair R/F Tire Charge: 6.50 NAPAGOLD FUEL FILTER WIPER BLADES NAPAGOLD OIL FILTER OIL Charge: Workorder: Meter Reading: In Date: 07/02/2013 Close Date: 09/18/2013 Install Light Bar.Fabricate Wiring And Install Control Box. Install Computer Stand. Pressure Test And Inspect Cooling System.Replace Leaking Upper And Lower Radiator Hoses.Flush And Refill Cooling System. Charge: Request for new computer stand,light bar and two pipe racks asper Mr Geraldo lower hose 1.00 SX2AAAA LIGHT BAR LED 1.00 TOOL BOX EXTENDERS 1.00 COOLANT FORD GOLD 2.00 FUSE HOLDER 2.00 RADIATOR HOSE 1.00 VINYL ELECTRICAL TAPE HITCH PINCLIP 1.00 COMPUTER TRAY 1.00 COMPUTER STAND 1.00 PEAK GLOBAL 2.00 CURVED RADIATOR HOSE 1.00 Charge: 4, Workorder: Meter Reading: In Date: 07/16/2013 Close Date: 07/23/2013 Weld And Fabricate Light Bar And Brackets. Charge: fab/ weld light bar bracket /4X2X4X20 ALUM ANGLE CLR RTV SILCN SEALANT Charge:

6 Workorder: Meter Reading: wont fuel In Date: 08/14/2013 Close Date: 08/16/2013 Ck Canceiver No Power Repair Loose Connection At Module 1.00 Charge: 2.00 Charge: Workorder: Meter Reading: In Date: 08/20/2013 Close Date: Charge: Truck overheats at stand still Charge: 0.00 Workorder: Meter Reading: In Date: 03/07/2014 Close Date: 03/07/ Key(s) issued 1 Key(S) Issued 0.20 DUPLICATE VEHICLE KEYS 1.00 Charge: 3.00 Charge: Workorder: Meter Reading: Light Tower In Date: 04/02/2014 Close Date: 07/07/2014 Install Light And Tower Charge: 7.00 POWER SUPPLY CORD 1.00 UBOLT 2.00 PERMANENT MOUNT W WIR 1.00 HITCH MOUNT LIGHT POLE 1.00 FUSE HOLDER Charge:

7 Workorder: Meter Reading: In Date: 05/16/2014 Close Date: 06/11/2014 P.M. Service. Test Batteries And Charging Systemreplace Bad Batteries. Test And Replace Defective Blower Resistor. Replace And Balance Six New Tires. Replace Left And Right Amber Marker Light On Body.Replace Brake Lights. Replace Idler Pulley And Serpentine Belt.Replace A/C Belt. Complete Wheel Alignment.Test Drive. Charge: Pm service and check blower speeds PTEX SUP WTHRSTRP ADH 1.00 IDLER PULLEY SMOOTH 1.00 DRIVE BELT 1.00 M C BASE MOUNT KIT 2.00 LED M C LAMP 2.00 WIPER BLADE 2.00 NAPAGOLD OIL FILTER 1.00 BLOWER RESISTOR OIL TIRE DISPOSAL FEE 6.00 BIGG DEGREASER 1.00 BULB 1.00 BATTERY 2.00 A/C BELT 1.00 FUEL FILTER FORD ONLY 1.00 LED SUP MDL DIO 2.00 TR416 VALVE STEM LT24575R Charge: 2, , Workorder: Meter Reading: wont fuel In Date: 07/29/2014 Close Date: 07/30/2014 Test And Remove Canceiver, Issue Fuel Card Charge: Charge:

8 Workorder: Meter Reading: pintle pin In Date: 08/06/2014 Close Date: 08/11/2014 Install New Pintle Pin W/Chain 0.50 PINTLE PIN W/CHAIN 1.00 Charge: 2.61 Charge: Workorder: Meter Reading: In Date: 08/13/2014 Close Date: 08/27/2014 Replace Defective Brake Deactivation Switch.Code P0703 Water Leak Test.Remove And Reseal Third Brake Light Cap.Retest And Clean Headliner. Computer Diagnose For Limp Mode.P0088.Perform Tsb Reprogram Pcm With Updated Calibration.Clear Codes And Test Drive. Charge: Check for water leak.install water tank and hose hooks.truck goes into limp mode BRAKE PRESSURE SWITCH 1.00 CLR RTV SILCN SEALANT Charge: Workorder: Meter Reading: In Date: 08/26/2014 Close Date: 08/28/2014 Fabricate Mounting Bracket And Hold Down. Mount Tank And Plumb Drain Valve To Mako Charge: Install water tank 7.00 BALL VALVE 1.00 HOSE FITTING 1.00 BRASS PIPE NIPPLE Charge:

9 Workorder: Meter Reading: In Date: 12/09/2014 Close Date: 01/15/2015 Pm Service. Inspect And Replace Broken Serpentine Belt And Tensioner. Diagnose For Hard To Steer And Replace Defective Power Steering Pump.Steering Gear And Resevoir.Flush And Refill Fluid. Inspect And Replace Two Defective Front Shocks.Fabricate And Replace Two Defective Front Body Mounts. Complete Front End Alignment And Test Drive. Rotate And Balance All Six Tires. Charge: Pm service.no power steering and power brake OIL NAPAGOLD OIL FILTER 1.00 WIPER BLADE 2.00 BRAKE CLEANER 1.00 TENSIONERHEAVY DUTY 1.00 USED FIRE X REFURBISHED 1.00 GEAR BOX 1.00 FUEL FILTER FORD ONLY 1.00 POWER STEERING PULLEY 1.00 POWER STEERING PUMP 1.00 SERPENTINE BELT 1.00 REMAN PS PUMP 1.00 RESERVOIR 1.00 BODY MOUNT KIT 2.00 GAS GRANDE FLEET SHOC 2.00 SYNATF TRANS FLUID S 3.00 SEAL KIT 1.00 Charge: 1, , Workorder: Meter Reading: In Date: 05/22/2015 Close Date: 06/02/2015 Diagnose Abs Lamp On And Brake Pulls.Scan Test. C1145 And C1155.Test Circuits And Replace Both Defective Front Wheel Speed Sensors.Replace Front Pads And Both Front Calipers.Resurface Front Rotors.Flu Charge: ABS light on and brake pulls to one side.no power SENSOR ASY BRAKE FLUID BRA 2.00 REMAN BRAKE CALIPER 1.00 REMAN BRAKE CALIPER 1.00 BRAKE CLEANER 1.00 PADS 1.00 Charge:

10 Workorder: Meter Reading: In Date: 06/29/2015 Close Date: 06/29/ Key(s) issued 1 Key(S) Issued 0.30 DUPLICATE VEHICLE KEYS 1.00 Charge: 3.00 Charge: Workorder: Meter Reading: Pm service. In Date: 07/21/2015 Close Date: 08/11/2015 P.M. Service. Replace Rear Center Marker Light Assemble.Replace Both Tail Lamps. Replace Four Rear Cab Mounts. Rotate And Balance All Six Tires. Charge: MAC WITE LITHIUM GRES 1.00 LED M C LAMP 3.00 BODY MOUNT KIT 4.00 WIPER BLADE 2.00 NAPAGOLD AIR FILTER 1.00 NAPAGOLD OIL FILTER 1.00 PINTLE PIN W/CHAIN OIL WD40 16OZ 1.00 USED FIRE X REFURBISHED 1.00 FUEL FILTER FORD ONLY 1.00 LED SUP MDL DIO 2.00 Charge:

11 Workorder: Meter Reading: Pm service. In Date: 03/15/2016 Close Date: 03/31/2016 Pm Service. Resurface Both Rear Brake Rotors.Replace Both Rear Calipers And Brake Pads.Flush And Bleed Brake System.Test Drive. Replace Two Front Tires.Rotate And Balance All Six. Dismantle Light Bar To Check And Replace Defective Strobe Light Bulbs. Replace Hitch Pintle Pin. Check Starting And Charging System.Both Batteries Failed Loadtest After Recharge.Replace Both Defective Batteries And Left Side Battery Hold Down. Replace Both Defective Front Suspension Bump Stops. Charge: NAPAGOLD OIL FILTER OIL FUEL FILTER FORD ONLY 1.00 REMAN BRAKE CALIPER " WIPER BLADE 2.00 BRAKE CLEANER LT24575R TR416 VALVE STEM 2.00 B FLUID DOT 332OZ 2.00 PINTLE PIN W/CHAIN 1.00 BATTERY 2.00 TIRE DISPOSAL FEE 2.00 REMAN BRAKE CALIPER 1.00 SPACER 1.00 DICKIES FLOORMAT 1.00 bumper 2.00 STG WHEEL COV FORD 1.00 CORNER LED MODULE 2.00 BRAKE PAD 1.00 Charge: 1, Workorder: Meter Reading: 6108 In Date: 03/29/2016 Close Date: 04/06/2016 Remove Cab Protector Repair Body Mounts And Fab New Plates Charge: Straiten cab protector 6.00 CLR RTV SILCN SEALANT 2.00 GRAY SEA 1.00 angle steel 1.00 Charge:

12 Workorder: Meter Reading: In Date: 08/08/2016 Close Date: 08/08/ Detail Vehicle Wash Ticket(S) Issued 1 Detail Vehicle Wash Ticket(s) Issued Charge: 0.00 Charge: 0.00 Commercial Charge: Workorder: Meter Reading: In Date: 08/25/2016 Close Date: 09/08/2016 P.M. Service. Replace Four Tires,Rotate And Balance All Six. Check A/C System.R&R Dash And Replace Leaking Evaporator,Accumulator And Orifice.Flush System.Vacuum And Recharge To Specs.Leak Check. Inspect And Service Rear Differential. Repair Safety Chain On Fold Down Bin Door. Charge: P.M. service and A/C not cold ACCUMULATOR 1.00 USED FIRE X REFURBISHED OIL TIRE DISPOSAL FEE QT SYNGEAR OIL EVAPOTATOR CORE LT24575R NAPAGOLD OIL FILTER 1.00 WASHER FLUID CONCENTR 1.00 FUEL FILTER FORD ONLY 1.00 PTEX ULTRA GREY 3OZ 1.00 TUBE FILTER 1.00 E8 A/C OIL UNIV W DYE 1.00 AC VALVE CORE HIGH 1.00 R134A LV SHOP RAPID SEAL KIT 1.00 Charge: 1, , Workorder: Meter Reading: In Date: 09/27/2016 Close Date: 10/31/2016 Towed in will not go over 45 mph. Transport Vehicle To Dealer For High Pressure Fuel Pump Replacement Charge: 2.00 Charge: Commercial Charge: 2,

13 Workorder: Meter Reading: In Date: 09/26/2016 Close Date: 09/28/2016 Tow From: Lw Turnpike Service Plaza N. Bound To: Vista transmission issues, wont go over 40 mph Charge: 0.00 Charge: 0.00 Commercial Charge: Workorder: Meter Reading: P.M. service In Date: 05/19/2017 Close Date: 05/25/2017 P.M.Service. High Speed Balance All Six Tires.Rotate And Nitro Filled. Replace Both Headlights Due To Condensation Inside Bulbs. Replace Corroded Trailer Connector Replace Both Blown Brake Light Bulbs.Replace Broken Right Rear Marker Light Assembly. Replace Both Batteries.Check Batteries And Charging System. Replace Both Broken Windshield Washer Nozzles.Retest. Repair Broken Hook On Left Fold Down Bin Safety Chain.Bend Hook Back And Reinstall Chain Into Bin. Charge: BATTERY 2.00 LED SUP MDL DIO " WIPER BLADE 2.00 trailer plug 1.00 WASHER FLUID CONCENTR 1.00 NAPAGOLD OIL FILTER 1.00 WASHER NOZZLE 1.00 FUEL FILTER FORD ONLY 1.00 HALOGEN LAMP OIL NAPAGOLD AIR FILTER 1.00 M C BASE MOUNT KIT Charge: Workorder: Meter Reading: In Date: 06/08/2017 Close Date: 06/16/2017 Replace Driver Side Mirror Assembly Charge: replace driver mirror 1.00 MIRROR Charge:

14 Workorder: Meter Reading: In Date: 08/09/2017 Close Date: 08/09/2017 Transition Prep Charge Transition Prep Charge 2.00 Charge: 0.00 Charge: 0.00 Total Charges: 16, Total Charges: 13, Total Comm. Charges: 2,