Palm Beach County Fleet Management Asset Maintenance History

Transcription

1 Workorder: Meter Reading: 0 In Date: 10/02/2007 Close Date: 10/02/2007 PREDELIVERY INSPECTION PreDelivery Inspection 2.00 Charge: 0.00 Charge: Workorder: Meter Reading: 9 WASH In Date: 03/06/2008 Close Date: 03/11/2008 Wash Veh Charge: 0.00 Charge: Workorder: Meter Reading: 151 In Date: 06/03/2008 Close Date: 06/06/2008 BROKEN WINDSHIELD SUPPORT BRACKET BOLTS Fabricate, Weld, Repair & Replace Damaged Windshield Supportbracket & Roof Support 3.00 Charge: 2.00 Charge: Workorder: Meter Reading: 462 In Date: 04/27/2009 Close Date: 05/12/2009 Pm Service Verify Chains Loose; Remove Chains, Lube, Reinstall & Adjust C/S Belt Loose; Verify Bad Belt; R&R Belt Charge: P.M.SERVICE/SEE NOTE 7.75 L LUBRIPLATE CHAIN&CABLE LUBE,03050CRC 1.00 V BELT WHITE LITHIUM (CRC 05037) 1.00 FUEL FILTER /40 OIL 3.00 OIL FILTER AIR FILTERFRM CA9248 WIX Charge:

2 Workorder: Meter Reading: 684 In Date: 02/22/2010 Close Date: 02/26/2010 Left rear tire flat, leaking around valve stem. C/C: Left Rear Leaking From Vehicle Stem. Verify. Stem Rotted Out, Remove Two Tires. R&R Two Valve Stems. Plug One Tire. Nitro Fill Charge: 2.00 Charge: Workorder: Meter Reading: 704 In Date: 03/17/2010 Close Date: 03/23/2010 R/REAR TIRE FLAT Repair Nail In Right Rear Tire Charge: 0.00 Charge: Workorder: Meter Reading: 730 In Date: 04/14/2010 Close Date: 04/15/2010 C/C: Needs Battery. Verify, Battery Tested Bad. R&R Battery, Check Charging System. Charge: Needs a new battery 0.75 GROUP U1 BATTERY (ACD U1240W) Charge: Workorder: Meter Reading: 759 In Date: 05/19/2010 Close Date: 05/27/2010 P. M. C/C: Belt Jumps Off Pulleys. Test Drive, Verify. C/C: Belt Falls Off. Fabricate Bracket On Pulley/Clutch To Keep Belt Aligned. Wash Vehicle For Service & Repair. Charge: P. M., & drive belt came off 2 times, check bracket AIR FILTERFRM CA9248 WIX OIL FILTER /40 OIL 4.00 FUEL FILTER Charge:

3 Workorder: Meter Reading: 759 In Date: 07/14/2010 Close Date: 07/14/2010 Front left tire came off From: Caloosa Park, Congress Ave, Boynton Bch. To: Sr Shop Charge: 0.00 Charge: 0.00 Commercial Charge: Workorder: Meter Reading: 801 In Date: 07/14/2010 Close Date: 07/19/2010 C/C: Tire Came Off. Verify, Center Broke Out Of Rim. Install New Rim To Equipment. Charge: TOW IN,L/FRONT TIRE CAME OFF 1.00 L/FRONT WHEEL ASSY Charge: Workorder: Meter Reading: 1058 In Date: 04/08/2011 Close Date: 04/11/2011 C/C: Tire Leak. Replace Valve Stem, Plug Multiple Times, Mount, Add 12 Psi Of N2. Charge: Check right rear tire valve stem Charge:

4 Workorder: Meter Reading: 1145 In Date: 07/14/2011 Close Date: 07/28/2011 P. M. Service. Replace Two Rear Tires, Mount, Add Nitrogen. C/C: Replace Seats. Replace Drivers Seat. Repair Passenger Side Seat. C/C: Rear Tires Going Flat. Verify, Passenger Center Tire Bad. Repair Hole & Replace Valve Stems, Fill With N2. Wash Vehicle Before Pm & Repair. Charge: P. M., Drivers side seat needs replacement, & rear tire keeps going flat AIR FILTERFRM CA9248 WIX /40 OIL 4.00 FUEL FILTER 1.00 OIL FILTER X NHS CAYMAN AT 2.00 DRIVER SEAT 1.00 TIRE DISPOSAL FEE Charge: Workorder: Meter Reading: 1353 In Date: 03/09/2012 Close Date: 03/19/2012 Replace Passenger Seat Replace Left Front Tire Ck Charging Sys, Ck And Replace Bad Battery Repair Left Rear Tire Charge: does not start on monday after sitting all weekend left front tire needs replacing/ left rear tire 3.75 GROUP U1 BATTERY (ACD U1240W) 1.00 PASSENGER SEAT 1.00 TIRE DISPOSAL FEE X INNOVA CAYMAN AT Charge: Workorder: Meter Reading: 1353 In Date: 03/19/2012 Close Date: 03/28/2012 right outer tie rod end C/C Right Outter Tie Rod End, Replace/Adjust Tie Rod R/R Spindle Test Drive 3.00 R/FRONT SPINLE ASSY. SHOP SUPPLIES R/FRONT TIE ROD END 1.00 Charge: Charge:

5 Workorder: Meter Reading: 1598 In Date: 10/11/2012 Close Date: 10/22/2012 Pm Ck Chains Loose Verify Complaint Remove Rear Tires Adj Chains Lube Reinstall Test Run Ck Rr Tire Leaking Verify Multipule Ties Leaking Plug All Rr Two Valve Stems Add N2 Wash Eq For Svc And Repairs Charge: P.M.SERVICE,CHAIN SLAPPING NOISE,R/REAR TIRE LOW ON AIR ALL THE TIME 9.50 L LUBRIPLATE 1.00 PH6607 OIL FILTER LBF 1.00 FUEL FILTER 1.00 CA9248 AIR FILTER LBF w40 BULK SOUTH REG Charge: Workorder: Meter Reading: 1873 In Date: 05/10/2013 Close Date: 05/24/2013 Ck Windshield Repair Windshield Disassemble Front End Fabricate Reinstall Windshield Ck When Hot Stalls When Ideling Test Drive Multiple Times Unable To Verify Complaint Clean Fuel System Charge: when hot keeps stallling out when idling, bolt for roof top broken, brackets for windshield broken 7.00 WINDSHIELD CHANEL Charge:

6 Workorder: Meter Reading: 2113 In Date: 11/12/2013 Close Date: 11/22/2013 Pm Ck Switch Tailgate Vibrating Etc Replace Tailgate Latches Repair Headlight Switch Ck Sont Start Verify Starter Replace Starter Test Run Ck Front Tires Replace Front Tires Mount Add N2 Charge: pm, starter gone, headlight switch came out, rear tail gale arm missing 9.50 MACS BATTERY CLEANER 1.00 NAPAGOLD FUEL FILTER 1.00 NAPAGOLD AIR FILTER 1.00 STARTER MOTOR ASSY 1.00 NAPAGOLD OIL FILTER X TIRE 2.00 LATCH 1.00 LATCH w40 BULK SOUTH REG 4.00 Charge: 1, Workorder: Meter Reading: 2300 In Date: 03/31/2014 Close Date: 04/25/2014 Ck Clutch Broken Replace Engine Clutch Test Drive Ck Replace Rear Tires Replace Four Rear Tires Mount Add N2 Install New Rr Tail Gate Latch Verify Chains Loose Remove Chains Lube Remove Links Reinstall And Adj Charge: clutch broken, right tail gate arm missing, new back tires 8.00 TIRE DISPOSAL FEE HD FIELD TRAC 4.00 CLUTCH 1.00 LATCH 1.00 CLUTCH , Charge: Workorder: Meter Reading: 2321 In Date: 05/07/2014 Close Date: 05/16/2014 Ck For No StartTest And Replace Battery And Ck Charigng Sys Replaced Ign Switch And Key Charge: no start/ starter key broken 2.00 IGNITION KEY 1.00 U1A 300 CCA 1.00 IGNITION Charge:

7 Workorder: Meter Reading: 2345 In Date: 06/02/2014 Close Date: 06/12/2014 keeps stalling out Ck Stalling Out Verify Fans Not Turning On Over Heating Found Bad Temp Sensor Reassemble Eq Test Drive 3.00 SHOP SUPPLIES 1GAL RTU ANTIFREEZE SWITCH 1.00 Charge: Charge: Workorder: Meter Reading: 2444 In Date: 09/03/2014 Close Date: 09/15/2014 Ck Stalls Out Test Drive Multiple Times Drainand Clean Fuel Tank Rr Fuel Filter Test Drive Charge: KEEPS STALLING OUT 3.00 NAPAGOLD FUEL FILTER Charge: Workorder: Meter Reading: 2457 In Date: 09/16/2014 Close Date: 09/30/2014 Check Stalling Problem, Diagnose Fuel Problem. Replace Fuel Shut Off Solenoid Test Drive Ok Charge: stalls out after an hour 3.00 SOLENOID 1.00 NAPAGOLD AIR FILTER Charge:

8 Workorder: Meter Reading: 2517 pm In Date: 11/18/2014 Close Date: 11/26/2014 P.M.Service. Verify Needs Front Tires. R/R Front Tires. Wash Equipt. Charge: X FIELD TRAC 2.00 NAPAGOLD AIR FILTER 1.00 NAPAGOLD FUEL FILTER w40 BULK SOUTH REG 4.00 TIRE DISPOSAL FEE 2.00 NAPAGOLD OIL FILTER Charge: Workorder: Meter Reading: 2582 In Date: 01/16/2015 Close Date: 02/26/2015 Battery Test Bad Test Starter And Alternator Replace Battery Remove Valve Cover To Replace Glow Plug Replace Valve Cover Gasket Test Run Charge: HARD TO START IN THE MORNING 3.75 BATTERY 1.00 GLOW PLUG 3.00 VALVE COVER GASKET Charge: Workorder: Meter Reading: 2606 stalls out In Date: 03/24/2015 Close Date: 03/27/2015 Ck Out Test Run For 3 Unable To Duplicate Condition. Replaced Fuel Filter And Ck Fuel And Cooling Sys Charge: 3.00 NAPAGOLD FUEL FILTER Charge:

9 Workorder: Meter Reading: 2858 In Date: 12/04/2015 Close Date: 12/09/2015 Pm Ck Flat Tire Replace Dry Rotted Tire Right Rear Wash Eq Charge: pm, right rear tire needs air all the time 6.00 NAPAGOLD AIR FILTER 1.00 NAPAGOLD FUEL FILTER 1.00 NAPAGOLD OIL FILTER w40 BULK SOUTH REG HD FIELD TRAC 4.00 TIRE DISPOSAL FEE Charge: Workorder: Meter Reading: 3107 In Date: 05/26/2016 Close Date: 06/14/2016 C/C Tire Needs Replaced.Replace Three Rear Tires.Mount.Add N2. C/C Tires Need Repair.Repair Multiple Flat Tires. Verify Chains Binding.Remove Chains.Remove One Link.Adjust Both Chains And Lubricate. Wash Equipment. Charge: Back light and rear tire need replace 7.00 TIRE DISPOSAL FEE HD FIELD TRAC Charge: Workorder: Meter Reading: 3177 In Date: 07/19/2016 Close Date: 07/28/2016 Both rear tires keep going flat. C/C Rear Tires Flat.Verify Multiple Tires Flat.Repair Tires And Correct N2 Levels 2.00 Charge: 2.00 Charge:

10 Workorder: Meter Reading: 3199 In Date: 08/10/2016 Close Date: 09/09/2016 Verify Battery Dead, Test Battery Bad, R/R Battery, C/K Charging System. C/C Overheating, Found Bad Belt. R/R V Belt For Alt.&Water Pump. C/C R/Rear Tire Flat. R/R R/Rear Tire. Correct All N2 Level Verify Chains Loose. Remove Rear SproClicts And Chains. Remove Links &Reinstall And Adjust. Charge: Over heats and right rear tire flat V BELT 1.00 M DRIVE BELT J 1.00 BATTERY Charge: Workorder: Meter Reading: 3261 In Date: 10/13/2016 Close Date: 10/18/2016 C/C No Crank/No Start.Replace Starter. Charge: Check for no crank/no start PS/STR Charge: Workorder: Meter Reading: 3328 In Date: 11/15/2016 Close Date: 12/30/2016 P.M.Service C/C Slow To Start. Found Glow Plugs Shorting Out Damaged Module. R/R 3Glow Plugs & Module Replace Bad Battery Wash Equipment Repair Multiple Hoses In Tire Charge: Hard to start in am. P.M.SERVICE 9.75 NAPAGOLD FUEL FILTER 1.00 BATTERY 1.00 NAPAGOLD OIL FILTER w40 BULK SOUTH REG 3.00 NAPAGOLD AIR FILTER 1.00 MODULE 1.00 GLOW PLUG 3.00 Charge:

11 Workorder: Meter Reading: 3366 In Date: 01/31/2017 Close Date: 01/31/2017 Transition Prep Charge Transition Prep Charge 2.00 Charge: 0.00 Charge: Total Charges: 6, Total Charges: 8, Total Comm. Charges: