Palm Beach County Fleet Management Asset Maintenance History

Size: px

Start display at page:

Download "Palm Beach County Fleet Management Asset Maintenance History"

Milo Bates
5 years ago
Views:

1 Workorder: In Date: 08/07/2001 Close Date: 08/07/2001 PREDELIVERY INSPECTION PreDelivery Inspection 3.00 Charge: 0.00 Charge: Workorder: In Date: 12/06/2001 Close Date: 12/12/2001 BRAKES STAY ON WHEN HOOKED UP TO TRUCK. Rewire Trailer Light Plug. Repair Wires On Right Wheel Brake Check Tires, All Oils In Pressure Washer Engine, Pump & Gear Box. Charge: 2.00 Charge: Workorder: In Date: 02/28/2002 Close Date: 03/07/2002 Check Cranking System. Found Bad Relay.R/R Relay With Updated One. Required Drilling & Changing Wire Ends. R/R Pull Rope Recoil. Check All Lights. Replaced Missing Pigtail. Charge: NO START/PULL ROPE BROKEN/FIX LIGHTS 3.20 TC101M/5403 TRAILER PLUG MALE TRAILER PLUG, E9TZ11450B SOLENOID STD SS Charge:

2 Workorder: PM In Date: 12/03/2002 Close Date: 12/04/2002 Pm Tune Up Rr All Nipples & Couplers Pm Charge: /40 OIL B&S OIL FILTER FRAM PH8170 WIX RC14YC SPARK PLUG Charge: Workorder: In Date: 02/21/2003 Close Date: 02/25/2003 Repair Wiring Replace Trailer Plug & Ck All Lights Load Test Battery Ck All Connections & Starter Circuits Charge: CHECK LIGHT CORD CHECK BATTERY 1.50 TC101M/5403 TRAILER PLUG MALE TRAILER PLUG, Charge: Workorder: In Date: 03/26/2003 Close Date: 04/11/2003 Ck For Oil Leak Rr Both Valve Cover Gaskets Travel From Sr Shop To Pick Up Charge: CHECK OIL LEAK 2.50 VALVE COVER GASKET Charge:

3 Workorder: In Date: 12/03/2003 Close Date: 12/11/2003 Pm Svc On Trailer And Pressure Cleaner Tune Up To Replace Spark Plugs Flush Diesel From Fuel Sys Replace L Tire Charge: GAS TANK FILLED WITH DIESEL 7.00 RC14YC SPARK PLUG /40 OIL CARLISLE TRLR 1.00 PH4967 OIL FILTER LBF PH2840 WIX Charge: Workorder: In Date: 05/12/2004 Close Date: 05/25/2004 NO PRESSURE,CHECK HOSE FITTINGS Replace Pressure Regulator Valve Assy And Therm Relief Valve Test Flow And Pressure 2.50 AL607 PRESSURE REG. VALVE SHOP SUPPLIES PRESSURE RELIEF VALV 1.00 Charge: Charge: Workorder: In Date: 11/04/2004 Close Date: 11/23/2004 Pm Replace Battery Flush Water From Fuel Sys And Clean Out Carb Tune Up Charge: NO START,LEAKING GAS 7.30 PH4967 OIL FILTER LBF PH2840 WIX BKR5E SPARK PLUG INJECTOR CLEANER DON'T REORDER 1.00 GROUP U1 BATTERY (ACD U1240W) /40 OIL Charge:

4 Workorder: In Date: 06/07/2005 Close Date: 07/18/2005 Hydraulic Oil Replace Pump Assembly, Unlader, Valve And Filter Assembly Pm Service Test Run Pressure Cleaner Charge: NO PRESSURE,NEED HYD OIL 9.50 AR XW21.28 PUMP INJECTOR CLEANER DON'T REORDER /40 OIL 2.00 AL 607 UNLOADER SWITCH CABLE 1.00 AW68 HYDRO FLUID HYDRAULIC OIL /2 FILTER 1.00 PS1250F1 BATTERY (POWER SONIC PS1250F1) 1.00 PH4967 OIL FILTER LBF PH2840 WIX Charge: 1, Workorder: In Date: 10/20/2005 Close Date: 11/08/2005 Replace Battery Repair Spray Gun Charge: NO START,CHECK SPRAY NOZZLES 2.00 GROUP U1 BATTERY (ACD U1240W) Charge: Workorder: In Date: 10/11/2006 Close Date: 10/16/2006 Pm Service R&R Fuel Tank; Clean Out Water; Remove Carb Float & Needle; Clean Bowl Of Water & Rust Fill 2 Tires W/Nitrogen Charge: P.M.SERVICE S FUEL FILTER BRIGGS & STRATON /40 OIL 2.00 PH4967 OIL FILTER LBF PH2840 WIX Charge:

5 Workorder: In Date: 10/18/2006 Close Date: 10/25/2006 Remove Pump From Engine; Drain & Repl Oil Twice; Clean H20 Out; Remove Head, Unstick Valves; Clean & Repair; Repl O Ring Order & Assemble 2 Spray Wands W/Couplers & Tips Charge: WATER WONT COME OUT OF TANK/TWO SPRAY HOSES INOP SPRAY BAR ASSY 1.00 TIP SET 1.00 PRESSURE WANDS W30 MOTOR OIL 4.00 SYN/ATF TRANS FLUID SYNTHETIC 1.00 Charge: Workorder: In Date: 10/09/2007 Close Date: 10/17/2007 Pm Service Pm Service On Pressure Washer; Flush Fluid 3 Times; Add Fluid & Test Run Charge: P.M.SERVICE TRAILER AND MOTOR /40 OIL 2.00 PH4967 OIL FILTER LBF PH2840 WIX INJECTOR CLEANER DON'T REORDER W30 MOTOR OIL 3.00 Charge: Workorder: STALLS In Date: 03/24/2008 Close Date: 03/28/2008 Remove Fuel, Drain Tank & Clean; R&R Fuel Filter Disassemble Carb & Change Out Passages; Readjust Float & Idle; Test Run Pump & Motor Assy; Tests Ok Charge: S FUEL FILTER BRIGGS & STRATON CARB CLEANER Charge:

6 Workorder: In Date: 01/09/2009 Close Date: 02/12/2009 Pm Service C/S Water Is Mixed In W/Oil; Verify Water Pump Has Water In Oil; Flush Out Pump & Side Pump; Add Oil & Test Run Charge: P.M.SERVICE/SEE NOTE W30 MOTOR OIL /40 OIL WHITE LITHIUM (CRC 05037) Charge: Workorder: In Date: 03/04/2009 Close Date: 03/11/2009 C/S No Start; Verify Bad Battery; R&R Battery; Ck Charging System C/S Stalls Under Load; Test Run To Verify; Rebuild Unloader Valve & Clean All Fittings; Clean Filter; Test Run; Repair Spray Washer Charge: ENGINE STALLS WITH LOAD 4.50 GROUP U1 BATTERY (ACD U1240W) Charge: Workorder: In Date: 03/13/2009 Close Date: 03/25/2009 C/S Stalls When Pulling Wand; Verify Complaint; R&R Pump Regulator & Adjust; Test Run 30 Mins Charge: STALLS WHEN YOU PULL THE TRIGER ON THE WAND PUMP REG 1.00 STEEL PLUG 1.00 HOSE BARB 1.00 NIPPLES 2.00 FITTING 1.00 Charge:

7 Workorder: In Date: 03/30/2009 Close Date: 04/09/2009 C/S Stalls While Running; Verify; R&R Spark Plug & F/Filter;Clean Fuel Sys; R&R Fuel Lines; Test Run 4 Hrs; Install Carb Kit Charge: STALLS WHILE RUNNING 2.00 CARB KIT 1.00 BKR5E SPARK PLUG CARB CLEANER S FUEL FILTER BRIGGS & STRATON 1.00 Charge: Workorder: In Date: 05/08/2009 Close Date: 05/12/2009 BROKEN TAIL LIGHT LENS. R&R Tailight Lens W/Good Used One 0.25 Charge: 0.00 Charge: Workorder: In Date: 08/19/2009 Close Date: 08/27/2009 C/S No Pressure & Oil Is White; Verify Bad Pistons On Pump & All Seals Bad; Flush Pump Multiple Times; R&R Pump; Install All Fittings; Fill Pump W/Fluid & Fill Gear Reduction Box; Test Run Charge: NO PRESSURE/OIL IS WHITE 5.00 PUMPOIL PUMP OIL 1.00 SPRAYER PRESSURE PUMP ASY /40 OIL Charge:

8 Workorder: In Date: 11/18/2009 Close Date: 12/31/2009 C/C: Motor Loosing Power. Verify, 2Nd Cylinder No Spark. Swap Ignition Coil, R/R Ingnition Coil. Comp Check, Tune Up Motor. C/C: No Pressure. R/R Pressure Regulator. Adjust & Test Run. Charge: LOOSE PRESSURE 5.00 PRESSURE REGULATOR 1.00 IGN. COIL Charge: Workorder: In Date: 12/29/2009 Close Date: 12/31/2009 RIGHT REAR TURN SIGNAL LIGHT IS NOT WORKING. Unable To Repair Light Assembly, R/R Light Assembly RH TAIL LIGHT GROTE# Charge: Charge: Workorder: In Date: 01/22/2010 Close Date: 01/29/2010 P. M. Service Trailer Brake Drums. Tail Lights Inoperable. R/R One Tail Light Bulb, Rear Right Side. Repair Ground On Tail Light Assy. Charge: P.M.SERVICE AIR FILTER, B & S WIX /40 OIL BRAKE CLEAN 1.00 PH4967 OIL FILTER LBF PH2840 WIX Charge:

9 Workorder: In Date: 03/29/2010 Close Date: 03/31/2010 P. M. SERVICE P.M. Inspection, (Pm Done 2 Months Ago) Inspect Lube Levels, Check Brakes, Test Run Pressure Washer Charge: 2.00 Charge: Workorder: In Date: 04/06/2010 Close Date: 04/08/2010 C/C Pressure Up & Down Back Firing, R&R Spark Plugs. R&R Fuel Filter, Drain Fuel Tank, Clean Lines, Clean Carb., Repair Choke Lever, Test Run. Charge: Pressure up & down, and backfiring S FUEL FILTER BRIGGS & STRATON CARB CLEANER 1.00 BKR5E SPARK PLUG Charge: Workorder: In Date: 09/23/2010 Close Date: 09/29/2010 Replace Both Tires. Repair Rr Brake Light Wire Harness. Charge: Check right tail light, brake & blinker, & replace two tires TIRE DISPOSAL FEE 2.00 ST225/75D15 TIRES 2.00 WASTE FEE Charge:

10 Workorder: In Date: 01/11/2011 Close Date: 01/24/2011 C/C: Battery Dead. Check Charging System, Test Battery, Bad. R&R Battery. C/C: Handle Broken. R&R Handle, Flush & Change Pump Oil. Verify, Regulator Not Working. R&R Regulator, Install New Bolts. Check Charging Voltage Output. Charge: Battery is dead, pressure washer handle needs replacing /40 OIL 2.00 GROUP U1 BATTERY (ACD U1240W) 1.00 PUMPOIL PUMP OIL 1.00 JACK HANDLE 1.00 REGULATOR SCREWS 2.00 VOLTAGE REGULATOR Charge: Workorder: In Date: 04/13/2011 Close Date: 05/11/2011 P. M. Service Service Electronic Trailor Brakes. Repack Wheel Bearings, Replace 12V Battery. Inspect Wiring. C/C: Lights. Replace Male Lights Connector. Repair Multiple Wiring. Replace L/H Tail Light Assy. Nail In Passenger Trailer Tire. Dismount, Patch, Mount, Balance, Add N2. Service Pump. Change Fluid Pump Oil. Test Run. Charge: P. M., & Right side signal light out PH4967 OIL FILTER LBF PH2840 WIX MALE CONNECTOR LH TAIL LIGHT GROTE# /40 OIL 2.00 PS1250F1 BATTERY (POWER SONIC PS1250F1) Charge: Workorder: In Date: 10/11/2011 Close Date: 10/31/2011 May be water in the pump C/C: Water In Pump Oil Verify, Slight Contaminated. Drain, Flush, Refill With Pump Oil. Test Run SHOP SUPPLIES PUMPOIL PUMP OIL /40 OIL 1.00 Charge: Charge:

11 Workorder: In Date: 11/03/2011 Close Date: 11/15/2011 C/C: Won'T Start. Verify, Fuel Tank/Carb Full Of Water. Drain All Contaminated Fuel. Overhaul Carb/Fuel System. R&R Filter, & Test Run. Charge: WONT START CARB CLEANER S FUEL FILTER BRIGGS & STRATON Charge: Workorder: In Date: 11/08/2011 Close Date: 12/09/2011 C/C: Water Inside, Pump Knocking. Verify Internal Damage To Pump. R&R Pump, Hose, & Wand. Reassemble. Test Run. Charge: Water inside pump, it's also knocking 5.00 FEMALE QC PLUG 3/ MALE QC 3/8 SOCKET 2.00 TIP PRESSURE CLEANER 1.00 PRESSURE HOSE PC 3/8X50' 1.00 AR PRESSURE PUMP ASSY TRIGGER GUN ASSY PUMPOIL PUMP OIL 1.00 Charge: 1, Workorder: In Date: 12/12/2011 Close Date: 12/19/2011 Tank needs to be cleaned out, algae in tank clogging filter to pump. C/C: Clean Algae From Tank. Flush Tank Multiple Times. Clear Lines. Clean Inside Tank. Test Run Charge: 2.00 Charge:

12 Workorder: In Date: 01/31/2012 Close Date: 02/08/2012 Signal light out Replace Left Rear Brake Light Bulb Charge: 0.00 Charge: Workorder: In Date: 02/09/2012 Close Date: 02/24/2012 C/C: Muffler Falling Off. Replace Muffler, Remove Old One, Install New Gaskets & Muffler. C/C: No Pressure. Verify, Engine Running On One Cylinder When Under Load. R&R Two Ignition Solenoid. C/C: Won'T Shut Off. Repair Ground Wire To Ignition Switch. Charge: No pressure, won't turn off, muffler loose (see notes) 6.00 ARMATURE MAGNETO 2.00 EXHAUST FLANGE 2.00 MUFFLER 1.00 GASKET EXH Charge: Workorder: In Date: 03/13/2012 Close Date: 03/14/2012 water line to pump broken Cc Water Line Broken Repair Water Hose Test Run 0.25 Charge: 0.00 Charge:

13 Workorder: In Date: 04/03/2012 Close Date: 04/20/2012 Ck Wont Start Verify Bad Starter Solenoid Rr Solenoid Test Run Ck Wont Stay Running Verify Water In Fuel Tank Due To Not Covering Motor Rr Fuel Filter Replace Carb Drain Fuel Tank Reassemble Tes Run Verify Storage Box Falling Off Remove Oil Fastening Bolts Drill Out Replace All Bolts Charge: won't stay running 5.50 CARBURETOR CARB CLEANER S FUEL FILTER BRIGGS & STRATON 1.00 E9TZ11450B SOLENOID STD SS Charge: Workorder: pm service In Date: 05/14/2012 Close Date: 05/16/2012 Pm Service Service Electronic Trailer Brakes Replace Emergency Cable Repair Trailer Wiring Replace Batton Change Poump Oil In Water Pump Test Run Charge: 8.50 PS1250F1 BATTERY (POWER SONIC PS1250F1) /40 OIL BRAKE CLEAN 1.00 PUMPOIL PUMP OIL SWITCH CABLE 1.00 PH4967 OIL FILTER LBF PH2840 WIX Charge: Workorder: In Date: 07/19/2012 Close Date: 07/26/2012 Ck Wont Start Verify Car Stuck Open Drained Gas Into Intake Crank Case Drain Oil Pull Plugs Etc Overhaoul Carb Charge: carb over flowing will not start S FUEL FILTER BRIGGS & STRATON CARB CLEANER /40 OIL Charge:

14 Workorder: In Date: 07/27/2012 Close Date: 09/12/2012 Ck Cont Start Trouble Shoot Disassemble Found Fly Wheel Came Apart Damaging Engine Block Purchase Short Block Assemble Engine Test Run Multiple Ck Repair Tool Box Lid Weld Lid Back On Repair Filter Assembly Charge: battery dead/ engine locked up will not start OZ. AERO KROIL AEROSOL SPRAY 1.00 BKR5E SPARK PLUG SHORT BLOCK 1.00 ALTERNATOR 1.00 FLYWHEEL 1.00 PH4967 OIL FILTER LBF PH2840 WIX AIR FILTER, B & S WIX Charge: 1, Workorder: throttle stuck In Date: 09/12/2012 Close Date: 09/19/2012 Throttle Stuck Verify Broken Throttle Cable Remove Throttle Assy Repair Lubricate Cable And Throttle Reassemble Charge: Charge: Workorder: wont start In Date: 09/19/2012 Close Date: 09/27/2012 Ck Sont Start Verify Complait Verify Diode Wires On Ignition Coil Damaged Repair And Repair And Reasemble Test Run 3.00 Charge: 2.00 Charge:

15 Workorder: In Date: 11/19/2012 Close Date: 11/30/2012 Rr Pressure Washer Hose Assy Charge: NEEDS 50' PRESSURE WASHER HOSE PRESSURE WASHER HOSE Charge: Workorder: In Date: 05/06/2013 Close Date: 05/17/2013 Pm Ck Light Lens Broken Verify Multiple Light Broken Replace Lr Tail Light And Fl Running Light Base Ck Wont Start Verify Fuel Tank Full Of Water Clean Tank And Fuel Lines Refill Over Haul Carb Test Run Flush Pump And Gear Reduction Box Add New Pump Oil Charge: pm, pressure washer is not starting, broken side mirror light lens 9.50 US 440 SERIES LAMP 1.00 MARKER LIGHT w40 BULK SOUTH REG 2.00 PUMPOIL PUMP OIL 1.00 NAPAGOLD OIL FILTER BASE MOUNT 19 S Charge: Workorder: In Date: 05/24/2013 Close Date: 06/07/2013 not starting at all pressure washer C/C: Not Starting. Verify Complaint. Damaged Wiring For Ignition, Needs Replacing. Daryl Called To Have Equip Picked Up & Sent To Parks Dept To Install New Diesel Motor Charge: 2.00 Charge:

16 Workorder: In Date: 07/23/2014 Close Date: 07/31/2014 Pm Svc Electrica; Brakes Replace Break Away Switch Ck Tires Replace Two Tires Mount Balance Add N2 Repalce Two Tail Light Bulbs Repair Entire Wiring Harness For Tail Lights Replace E Brake Battery Ck Charging Sys Charge: pm, needs tires 9.75 BREAKAWAY SWITCH R BULB 2.00 MALE TRAILER CONNECTOR V5AMP/HOUR BATTERY 1.00 TIRE DISPOSAL FEE Charge: Workorder: In Date: 03/11/2016 Close Date: 03/24/2016 Pm Verify Brake Away Switch Damanged Replace Break Away Switch Assm Svc Elec Trailer Drum Brakes Test Emergency Brake Away Battery Test Bad Replace Battery Repair Connections Install Pintle Pin To Hitch Ck Wire Harness Repair Harness To Lights Repair Grounds Clean Sockets Etc Charge: PM, CK WIRE HARNESS 9.75 PINTLE PIN W/CHAIN 1.00 BREAKAWAY SWITCH V5AMP/HOUR BATTERY Charge: Workorder: In Date: 11/15/2016 Close Date: 11/15/2016 Transition Prep Charge Transition Prep Charge 2.00 Charge: 0.00 Charge: 0.00 Total Charges: 7, Total Charges: 11, Total Comm. Charges:

Palm Beach County Fleet Management Asset Maintenance History

Palm Beach County Fleet Management Asset Maintenance History 10133148 2001 PRESSURE PRO SSG4735VAE Trailer, W/Pressure Cleaner Workorder 143726 Meter 0 In Date 07/24/2001 Closed 07/24/2001 Problem PRE-DELIVERY INSPECTION - Pre-delivery Inspection 2.00 Labor 90.00