Palm Beach County Fleet Management Asset Maintenance History

Transcription

1 Workorder: Meter Reading: 0 In Date: 09/05/2007 Close Date: 09/05/2007 PREDELIVERY INSPECTION PreDelivery Inspection 4.00 Charge: 0.00 Charge: Workorder: Meter Reading: 43 BLADES In Date: 04/28/2008 Close Date: 04/29/2008 Flip Blades,Install New Bolts And Nuts. To System 3 Charge: BLADE BOLT ALAMO ROLL PIN ALAMO BLADE NUT ALAMO LOCK WASHER ALAMO Charge: Workorder: Meter Reading: 43 PM SERVICE In Date: 05/07/2008 Close Date: 05/12/2008 Pm Service FmSystem Iii Charge: 7.00 AL A/FILTER INN. FRM NONE WIX AL AIR FILTER FRM NONE WIX RE OIL FILTER FRM NONE WIX RE FUEL FILTER FRM NONE WIX RE FUEL STRAINER (USE WIX 33270) Charge:

2 Workorder: Meter Reading: 73 In Date: 09/03/2008 Close Date: 09/30/2008 Order.Install Sway Support & Adj Mower Deck.Ck Rear Tire Pressure And Inflate Rr Blades To Pine Hurst Water Plant To Mako Hose Replace Hyd Door Cyl Mower Deck,Tighten Plugs In Hyd Cooler To Stop Leak SWAY BAR KIT SWAY BLOCK 1.00 SWAY BLOCK 1.00 SPRING LOCK 2.00 SCREW 2.00 SPRING PIN 2.00 ADJUSTING STRAP BLADE ALAMO MACHETE BLADE NUT ALAMO 2.00 SWAY BLOCK 1.00 PIN 2.00 PLATE 1.00 SWAY BLOCK 1.00 SWAY KIT 1.00 SCREW ROLL PIN ALAMO 2.00 PLATE BLADE BOLT ALAMO 2.00 HYD FILTER LOCK WASHER ALAMO 2.00 Charge: 1, Charge: Commercial Charge: Workorder: Meter Reading: 95 In Date: 06/12/2009 Close Date: 06/17/2009 ENGINE LIGHT IS ON Check Cooling Sys, Clean Bleed Out Radiator.Condensor And Coolers To Sys 3 Charge: 2.00 Charge:

3 Workorder: Meter Reading: In Date: 06/16/2009 Close Date: 06/30/2009 Charge: 0.00 Charge: 0.00 Workorder: Meter Reading: In Date: 07/02/2009 Close Date: 07/13/2009 P.M. Service Sys. 3 And Back Charge: 6.50 AL A/FILTER INN. FRM NONE WIX AL AIR FILTER FRM NONE WIX RE FUEL FILTER FRM NONE WIX RE OIL FILTER FRM NONE WIX AL HYDR FILTER FRM NONE WIX NONE /40 OIL RE FUEL FILTER FRM NONE WIX Charge: Workorder: Meter Reading: 99 In Date: 07/15/2009 Close Date: 07/20/2009 LEAKING DIESEL Repair Leaking Diesel 0.50 Charge: 0.00 Charge:

4 Workorder: Meter Reading: 103 In Date: 07/16/2009 Close Date: 07/22/2009 Boom Will Not Ext. Clean And Lube Boom 211# Flip Blades Cut Bolts With Torch Replace Bolts 164# Shop To System 3 Charge: boom will not retract LOCK WASHER ALAMO ROLL PIN ALAMO BLADE NUT ALAMO BLADE BOLT ALAMO Y648 GRAPHITE LUBE (IMPERIAL 6590) 1.00 Charge: Workorder: Meter Reading: 118 Blades In Date: 09/14/2009 Close Date: 09/15/2009 Replace Blades Shop To C Rock Charge: BLADE BOLT ALAMO BLADE NUT ALAMO BLADE ALAMO MACHETE ROLL PIN ALAMO Charge: Workorder: Meter Reading: In Date: 02/25/2010 Close Date: 03/01/2010 P.M. System 3 Charge: 6.50 AL A/FILTER INN. FRM NONE WIX AL AIR FILTER FRM NONE WIX RE FUEL FILTER FRM NONE WIX RE FUEL FILTER FRM NONE WIX /40 OIL RE OIL FILTER FRM NONE WIX AL CAB A/FILTER FRM NONE WIX NONE 1.00 SL4 DIELECTRIC GREASE Charge:

5 Workorder: Meter Reading: 143 In Date: 06/07/2010 Close Date: 06/09/2010 Flip Blades Fm To System 3 Charge: Flip the blades Charge: Workorder: Meter Reading: 153 hyd. filter In Date: 06/16/2010 Close Date: 07/28/2010 Replace Hyd. Filter Fm To S Rock Charge: 3.00 P6881 HYDR FILTER LBF LFH4959 WIX Q HYDR FILTER (PARKER)GRG 1XPG HYDRAULIC FILTER (ALAMO) Charge: Workorder: Meter Reading: 160 In Date: 06/17/2010 Close Date: 06/22/2010 C/C: Hydraulic Line Leaking. Verify, Multiple Fittings Leaking. Tighten Lines, Check Fluid Level. Charge: Tighten fittings in hydraulic hoses (leaking) Charge:

6 Workorder: Meter Reading: In Date: 08/19/2010 Close Date: 09/01/2010 Pm Service Fm To System 3 Replace Hyd. Filter And Housing Charge: RE FUEL FILTER FRM NONE WIX RE OIL FILTER FRM NONE WIX FILTER HOUSING 1.00 AIR FILTER 1.00 AL CAB A/FILTER FRM NONE WIX NONE 1.00 AL A/FILTER INN. FRM NONE WIX RE FUEL FILTER FRM NONE WIX /40 OIL , Charge: Workorder: Meter Reading: 171 Filter In Date: 11/15/2010 Close Date: 12/07/2010 Replace Hyd. Filters Sys. 3 2Xs Install Pin Kit For Boom R&R Blades Charge: 9.50 P6881 HYDR FILTER LBF LFH4959 WIX HYD FILTER 2.00 EPB21NFC HYD FILTER (UFI) BLADE BOLT ALAMO BLADE NUT ALAMO ROLL PIN ALAMO 2.00 HYD FILTER 1.00 PEDESTAL PIN KIT BLADE ALAMO MACHETE LOCK WASHER ALAMO , Charge:

7 Workorder: Meter Reading: In Date: 03/22/2011 Close Date: 04/04/2011 Pm Service Fm To S Rock Remove Grill To Replace Headlight Charge: RE FUEL FILTER FRM NONE WIX RE FUEL FILTER FRM NONE WIX AL A/FILTER INN. FRM NONE WIX RE OIL FILTER FRM NONE WIX AL AIR FILTER FRM NONE WIX /40 OIL AL CAB A/FILTER FRM NONE WIX NONE 1.00 HEADLIGHT ASSY 1.00 AL HYDR FILTER FRM NONE WIX NONE 1.00 TY6354 HYDR FLUID TRACTORS (JOHN DEERE) Charge: Workorder: Meter Reading: 175 In Date: 04/14/2011 Close Date: 04/15/2011 Repair Leak At Hyd. Line And Add Oil Fm To System 8 Charge: Repair the hyd leak 2.25 AW68 HYDRO FLUID HYDRAULIC OIL Charge:

8 Workorder: Meter Reading: 209 pm service In Date: 09/27/2011 Close Date: 03/15/2012 Pm Service Fm To S Rock Replace Turret, Swing Cylinders,Bearings Replace Hyd. Filters, Fittings And Rerout Hoses Check Swing Stow Boom Send To Shop SWING CYLINDER 2.00 CAR WASH SOAP STOCK # WASHER 1.00 BEARING 1.00 WASHER 4.00 AL CAB A/FILTER FRM NONE WIX NONE 1.00 TURRET KIT 1.00 LOCKNUT 2.00 RE OIL FILTER FRM NONE WIX AL HYDR FILTER FRM NONE WIX NONE 1.00 TURRET PIN /40 OIL BOLT 8.00 LOCK WASHER 8.00 BOLT P6881 HYDR FILTER LBF LFH4959 WIX BLADE NUT ALAMO 2.00 TURRET 1.00 BOLT Q HYDR FILTER (PARKER)GRG 1XPG AL AIR FILTER FRM NONE WIX ROLL PIN ALAMO 2.00 RE FUEL FILTER FRM NONE WIX HYDRAUKIC FITTING HYDRAULIC FILTER (ALAMO) 1.00 AL A/FILTER INN. FRM NONE WIX PIN LOCK WASHER ALAMO 2.00 RE FUEL FILTER FRM NONE WIX WLDMT PIN 1.00 BOLT BUSHING BLADE ALAMO MACHETE 1.00 SLOTTED NUT BLADE BOLT ALAMO

9 Charge: 12, Charge: 3, Workorder: Meter Reading: 209 In Date: 03/16/2012 Close Date: 03/20/2012 Tow From: Fleet Se Shop To: South Wud transport back after repair Charge: 0.00 Charge: 0.00 Commercial Charge: Workorder: Meter Reading: In Date: 05/22/2012 Close Date: 05/25/2012 Pm Service Fm To S Roc Charge: 6.50 RE OIL FILTER FRM NONE WIX AL AIR FILTER FRM NONE WIX /40 OIL AL CAB A/FILTER FRM NONE WIX NONE BRAKE CLEAN 1.00 RE FUEL FILTER FRM NONE WIX AL A/FILTER INN. FRM NONE WIX RE FUEL FILTER FRM NONE WIX Charge: Workorder: Meter Reading: 225 hyd. filter In Date: 07/12/2012 Close Date: 08/07/2012 Replace Fuel Filter,Return Filter Sencer, And Control Box Assembly Jog & Turnpike 2Xs And Crock 2Xs Charge: 9.00 CONTROL MODULE 1.00 PRESSURE SENSOR SWITCH 1.00 P6881 HYDR FILTER LBF LFH4959 WIX Q HYDR FILTER (PARKER)GRG 1XPG HYDRAULIC FILTER (ALAMO) 1.00 Charge: 4,

10 Workorder: Meter Reading: 225 In Date: 09/10/2012 Close Date: 09/26/2012 Repair 3 Point Hitch By Everglades Deck Won't Lower Charge: 0.00 Charge: 0.00 Commercial Charge: 1, Workorder: Meter Reading: 240 hyd. slow In Date: 10/25/2012 Close Date: 10/30/2012 Tested Mower And Topped Off Hyd. Oil Secure Ecu And Replaced Cover Delray Shop Charge: 3.50 AW68 HYDRO FLUID HYDR Charge: Workorder: Meter Reading: 252 hyd. runs hot In Date: 11/29/2012 Close Date: 11/30/2012 Clean Hyd. Cooler Run Hyd. System Up To Temp And Check For Fan Operation Fm To System 3 Charge: Charge: Workorder: Meter Reading: 257 In Date: 12/07/2012 Close Date: 12/13/2012 Flip Blades And Replace Bolts Fm To Pinehurst Charge: flip mower blades LOCK WASHER 2.00 PIN BLADE NUT AL BLADE BOLT A Charge:

11 Workorder: Meter Reading: 257 In Date: 12/13/2012 Close Date: 01/15/2013 Repair Hyd. Over Heats By Everglades Tractor hyd. overheating Charge: 0.00 Charge: 0.00 Commercial Charge: Workorder: Meter Reading: 272 hyd. leak In Date: 02/14/2013 Close Date: 02/19/2013 Replace Hyd. Mower Head Fm To System 8 To Mako Charge: 3.50 HYD FITTING 2.00 HYDRAULIC HOSE Charge: Workorder: Meter Reading: In Date: 03/07/2013 Close Date: 03/11/2013 Pm Service Fm To S Roc Charge: w40 serv truck AIR FILTER 1.00 AIR FILTER 1.00 FUEL FILTER RE FUEL FILTER RE NAPAGOLD OIL FILTER 1.00 DIELECT SILICONE COMP Charge:

12 Workorder: Meter Reading: 306 Hyd. leak In Date: 06/17/2013 Close Date: 08/16/2013 Replace Mower Control Hoses Replace Right Side Window Fm To System 8 Replace Blades Charge: BLADE NUT AL 2.00 ROPE HYDRAULIC HOSE CABLE TIE 1.00 WEAR SLIDE DIPPER 3.00 LOCK NUT HYD FITTING 2.00 BOLT BLADE ALAMO 1.00 HYD HOSE FITTING 2.00 PIN LOCK WASHER 2.00 ALAMO DOOR KIT BLADE BOLT A , Charge: 1, Workorder: Meter Reading: 306 transport In Date: 08/07/2013 Close Date: 09/04/2013 Tow From: Vista To: Jog Boca Charge: 0.00 Charge: 0.00 Commercial Charge:

13 Workorder: Meter Reading: In Date: 09/06/2013 Close Date: 09/10/2013 Pm Service Fm To S Roc Charge: w40 serv truck FUEL FILTER RE NAPAGOLD OIL FILTER 1.00 FUEL FIL Charge: Workorder: Meter Reading: 317 lr flat In Date: 11/20/2013 Close Date: 11/22/2013 Lf Flat Charge: 0.00 Charge: 0.00 Commercial Charge: Workorder: Meter Reading: 321 blades In Date: 11/21/2013 Close Date: 11/22/2013 Flip Mower Blades Fm To System 8 Charge: Charge: Workorder: Meter Reading: 326 Replace Pin In Date: 12/12/2013 Close Date: 12/18/2013 Replace Mower Deck Pin And Tighten Mounting Bolts 2.00 Fm To C Roc Charge: 2.00 Charge:

14 Workorder: Meter Reading: 335 pm In Date: 04/14/2014 Close Date: 05/22/2014 Pm To Sroc Jump Start R&R Battery Replace Air Filter Housing Charge: DLT BATTERY DELCO 1.00 ANGLE 1.00 NAPAGOLD OIL FILTER HYDRAULIC FI 1.00 WIPER BLADE 1.00 AL CAB FILTER 1.00 NAPA HYDRAULIC FILTER 1.00 NAPAGOLD FUEL FILTER 1.00 FUEL FIL OIL AL HYDR FILTER 1.00 AIR CLEANER HANDLE 1.00 JHOOK BOLT 2.00 LOCK NUT Charge: Workorder: Meter Reading: 350 Hyd. Leak In Date: 05/29/2014 Close Date: 06/04/2014 Replace Swivel Hose To Sys, 2 To Mako For Hose Test Drive Charge: 4.00 HOSE MAKE UP Charge:

15 Workorder: Meter Reading: 343 Blades In Date: 06/04/2014 Close Date: 06/12/2014 Replace Blades To System 2 Replace Hose To Tilt Cylinder To Mako Test Run Charge: 6.50 HOSE MAKE UP BLADE ALAMO BLADE NUT AL 2.00 PIN BLADE BOLT A LOCK WASHER Charge: Workorder: Meter Reading: 381 In Date: 08/21/2014 Close Date: 08/27/2014 Repair Hydraulic Leak Lube Boom Dipper Replace Blades To Mako Test Run Charge: Hyd. Leak, Boom Chadder, Brake, Blades 8.00 PIN 2.00 MACS CHAIN CABLE LUBE BLADE ALAMO 1.00 AW68 HYDRO FLUID HYDR HOSE MAKE UP BLADE NUT AL BLADE BOLT A LOCK WASHER Charge:

16 Workorder: Meter Reading: 405 P.M. In Date: 11/04/2014 Close Date: 02/10/2015 Pm Service Ac To Sroc Replace Battery Hold Down Replace Head Liner Flip Blades Pulled Roof And Replace Drip Pan And Evaporator Core Sys. 3 2Xs HEADLINER 1.00 NAPAGOLD OIL FILTER 1.00 PUSH NUT 2.00 FUEL FIL 1.00 BUSHING 2.00 BLOWER RESISTOR 1.00 TY6354 HYDR FLUID TRA 2.00 NAPAGOLD FUEL FILTER 1.00 WASHER 2.00 NAPA HYDRAULIC FILTER 1.00 DRAIN KIT 1.00 NAPA CABIN AIR FILTER 2.00 A/C EVAPORATOR CLEANER 1.00 PAD 1.00 GASKET 2.00 GASKET 2.00 WEATHERSTRIP 1.00 PAD 1.00 AIR FRESHENER 1.00 PAD 1.00 EVAPORATOR BOX 1.00 PAD 1.00 VALVE 1.00 LABEL 1.00 JHOOK BOLT 2.00 COVER 1.00 ANGLE w40 serv truck SNAP RING 2.00 AL HYDR FILTER 1.00 WIPER BLADE 1.00 RECEIVER/DRIER HYDRAULIC FI

17 Charge: 3, Charge: 2, Workorder: Meter Reading: 398 Transport In Date: 11/18/2013 Close Date: 12/18/2014 Tow From: Jog Rd To: 1500 Jog Rd Charge: 0.00 Charge: 0.00 Commercial Charge: Workorder: Meter Reading: 398 Lowboy Move In Date: 12/13/2013 Close Date: 12/18/2014 Tow From: 8100 Forest Hill Blvd To: Jog Rd Charge: 0.00 Charge: 0.00 Commercial Charge: Workorder: Meter Reading: 425 pm In Date: 05/05/2015 Close Date: 05/07/2015 Pm To Sroc Road Test Charge: 9.50 AL HYDR FILTER HYDRAULIC FI 1.00 TY6354 HYDR FLUID TRA w40 serv truck FUEL FIL 1.00 NAPA HYDRAULIC FILTER 1.00 NAPAGOLD OIL FILTER 1.00 NAPAGOLD FUEL FILTER Charge:

18 Workorder: Meter Reading: 427 In Date: 05/14/2015 Close Date: 06/16/2015 Check Boom Controls. R&R Joystick. Check Wiring For Lower Boom. Replace Bad Resistor Board To System 3 R&R Blades Charge: Boom Controls MAVERICK JOYSTICK BLADE ALAMO BLADE NUT AL BLADE BOLT A LOCK WASHER 2.00 PIN 2.00 CABLE TIE 1.00 Charge: 5, , Workorder: Meter Reading: 427 In Date: 07/02/2015 Close Date: 09/15/2015 Replace Solenoid Lock Valve And Return Filter. Check Wiring From Joy Stick To Valve Solenoid. Replace Up Button On Joy Stick To System 8 4Xs. To System 3 Interior Lh Panel R&R Boom Hose Top Off Fluid To Mako Charge: joy stick control HYDRAULIC HOSE HYD FITTING 2.00 NAPA HYDRAULIC FILTER 1.00 AL HYDR FILTER 1.00 SOLENOID VALVE ASSY HYDRAULIC FI 2.00 PANEL 1.00 SOLENOID W/ ORING 2.00 AW68 HYDRO FLUID HYDR 6.00 PILOT 2.00 HARNESS RESISTOR 1.00 NAPA HYDRAULIC FILTER 1.00 Charge: 3, , Workorder: Meter Reading: 427 shop In Date: 06/23/2015 Close Date: 07/15/2015 Tow From: Fleet To: Pratt Whitney Charge: 0.00 Charge: 0.00 Commercial Charge:

19 Workorder: Meter Reading: 479 Flip Blades In Date: 11/17/2015 Close Date: 11/25/2015 Flip Blades To Pinehurst Charge: BLADE NUT AL BLADE BOLT A LOCK WASHER 2.00 PIN Charge: Workorder: Meter Reading: 491 PM In Date: 12/22/2015 Close Date: 02/12/2016 Pm Cut Fence Out Of Mower Deck To Sys. 8 2Xs Rd Test Charge: NAPA HYDRAULIC FILTER 1.00 AL HYDR FILTER 1.00 TY6354 HYDR FLUID TRA w40 serv truck NAPAGOLD FUEL FILTER HYDRAULIC FI 1.00 NAPA CABIN AIR FILTER 2.00 PM22A ADDITIVE DIES 1.00 FUEL FIL " WIPER BLADE 2.00 NAPAGOLD OIL FILTER Charge:

20 Workorder: Meter Reading: 509 Blades In Date: 05/11/2016 Close Date: 05/19/2016 Replace Blades To System 8 Charge: BLADE ALAMO BLADE BOLT A BLADE NUT AL LOCK WASHER 2.00 PIN Charge: Workorder: Meter Reading: 517 Deck Swing In Date: 07/08/2016 Close Date: 07/08/2016 Replace Bolt In Rotation To Sys 3 Charge: Charge:

21 Workorder: Meter Reading: 542 Flip Blades In Date: 09/14/2016 Close Date: 10/13/2016 Flip Blades Pm To Sroc 2Xs R&R Serpentine Belt. Remove Front Driveshaft And Fan To Access Replace And Adjust Headlight Assemblys Test Run Charge: USED FIRE X REFURBISHED 1.00 NAPA GAL 15W NAPAGOLD OIL FILTER 1.00 FUEL FIL 1.00 NAPAGOLD FUEL FILTER " WIPER BLADE 2.00 NAPA HYDRAULIC FILTER 1.00 AL HYDR FILTER HYDRAULIC FI 1.00 MULTITRAC HYD FLUID 2.00 NAPA CABIN AIR FILTER 2.00 NAPA QT 15W L FAN BELT JOHN 1.00 head light 2.00 HEADLIGHT 2.00 ADJUSTING STRAP 6.00 NONCHLOR BRAKE CLNR 2.00 Charge: 1, ,

22 Workorder: Meter Reading: 578 PM In Date: 04/14/2017 Close Date: 05/11/2017 Pm To Sroc Test Run Blades Charge: BLADE BOLT A BLADE NUT AL LOCK WASHER 2.00 PIN w40 serv truck 5.00 NAPAGOLD FUEL FILTER HYDRAULIC FI 1.00 AL HYDR FILTER 1.00 NAPA CABIN AIR FILTER 2.00 WIPER BLADE BLADE ALAMO 1.00 NAPAGOLD OIL FILTER 1.00 FUEL FIL 1.00 NAPA HYDRAULIC FILTER Charge: Workorder: Meter Reading: 617 In Date: 10/20/2017 Close Date: 10/24/2017 Flip Blades Charge: Flipped mower blades Charge:

23 Workorder: Meter Reading: 617 PM In Date: 11/17/2017 Close Date: 12/15/2017 Lube FUEL FIL 1.00 NAPAGOLD OIL FILTER 1.00 NAPA CABIN AIR FILTER 2.00 WIPER BLADE 2.00 NAPAGOLD FUEL FILTER 1.00 USED FIRE X REFURBISHED 1.00 L GEAR SHIELD 1.00 PREM BLUE 15W40 1 GAL 6.00 Charge: Charge: 0.00 Workorder: Meter Reading: 629 In Date: 12/19/2017 Close Date: 12/19/2017 Transition Prep Charge Transition Prep Charge 2.00 Charge: 0.00 Charge: Total Charges: 45, Total Charges: 23, Total Comm. Charges: 3,