VIN PLATE DECODING INFORMATION

Transcription

1 VIN PLATE DECODING INFORMATION thru 17 Country Make Vehicle Type Other Line Series Body Style Engine Check Digit Model Year Assy. Plant Sequence No. The following table interprets the VIN Plate position shown above. Position Interpretation Codes = Description 1 Country of Origin 1 = Built in U.S. by DaimlerChrysler Corporation 2 Assembler 3 Vehicle Type 3 = Passenger Car 4 GVWR & Pass. Safety E = Restraint System Active Driver & Passenger Air Bag 5 Vehicle Line R = Viper R/T-10 R = Viper GTS 6 Series 6 = Viper RT/10 (D-S27) 6 = Viper GTS-Coupe (D-S29) 7 Body Style 5 = Convertible - Open Body 9 = 2 Door Specialty Coupe 8 Engine E = 8.0L V10 SFI (EWB) 9 Check Digit 0 = Check Digit 10 Model Year V = Assembly Plant V = New Mack Development Center 12 thru 17 Vehicle Build Sequence Model Year Assembly Sequence

2 Group - 2 Front Suspension & Drive Illustration Title Group - 2 Front Suspension & Drive Group-Fig. No. Front Suspension Suspension, Front... Fig Front Suspension 1997 SR

3 Suspension, Front Suspension, Front Figure SPRING, Front Suspension Coil, Front Absorber AR SHIM, Coil Over Shock Spring, Spring Seat SEAT, Spring, Front Absorber SHOCK ABSORBER, Suspension, Front BOLT, Hex Flange Head, M14x2.00x NUT RETAINER, Stabilizer Bar Grommet STABILIZER BAR, Front LINK, Sway Eliminator, Stabilzer Bar NUT, Hex, M BUSHING, Stabilizer Bar, Stabilzer Bar Clamp SCREW, M10x1.50x30.00 (Not Serv.), (NOT SERVICED) ARM, ControlUpper FITTING, Ball Joint, Zirc, Lube SEAL, Ball Joint BUSHING, Control ArmUpper WASHER, Control Arm Pivot,.627x1.30x.089, Upper RETAINER, Control Arm BushingUpper AA 4 NUT, Hex Lock, AA 4 BALL JOINT, Upper Control Arm, (NOT SERVICED) PIN, Cotter, Cotter.125x AA 4 NUT, Hex Lock, NUT, Hex, ARM, Control Lower, Right Lower, Left CAM, Front Suspension Control Arm, Adjusting NUT, Hex, KNUCKLE, Front Left Right

4 Suspension, Front Figure NUT, Hex, SHIM, Control Arm, Front Adjusting BOLT, Control Arm Cam, Lower BOLT, Hex Flange Head, M10x1.50x BUSHING, Control Arm BALL JOINT, Lower Control Arm, Serviced with Control Arm, (NOT SERVICED) 34 BRACKET, Shock Mounting Right Left BOLT, M10x1.50x65.00 [Not Serv.], (NOT SERVICED) NUT, Hex Flange Lock, M14x1.50, M10x AA 2 BUSHING, Shock Absorber

5 Group - 3 Rear Axle Illustration Title Group - 3 Rear Axle Group-Fig. No. Rear Axle Differential Assembly, Rear... Fig Differential and Housing Differential Assembly, Rear... Fig Rear Axle Shafts Shaft, Rear Axle... Fig Rear Axle Differential and Housing Rear Axle Shafts 1997 SR

6 Differential Assembly, Rear Differential Assembly, Rear Figure AB 1 DIFFERENTIAL, Rear Axle, Rear Complete 3.0 Ratio

7 Differential Assembly, Rear Differential Assembly, Rear Figure BOLT, Hex Head, M16x WASHER, Flat, M15.02x28x NUT, Hex Flange Head Locking, M14x SEAL, Drive Pinion, Oil Front PLUG, Differential Housing, (Fill) BOLT, Differential Cover

8 Shaft, Rear Axle Shaft, Rear Axle Figure SHAFT, Axle Half, Rear Axle CLAMP, U-Joint BOLT, Hex Flange Head, M8x1.0x U JOINT, Inner

9 Group - 4 Parking Brake Illustration Title Group - 4 Parking Brake Group-Fig. No. Parking Brake Lever and Cables Lever Assembly And Cables Parking Brake... Fig Parking Brake Lever and Cables 1997 SR

10 Lever Assembly And Cables Parking Brake Lever Assembly And Cables Parking Brake Figure LEVER, Park Brake 0PS531KA 1 29 Carmel Tan 1 27 Carmel Tan 0PS53SB Bright Blue 1 29 Bright Blue 0PS53SR Red 0PS53SX Flat Black 1 29 Flat Black CABLE, Parking Brake SCREW, x BOLT AND CONED WASHER, Hex Head, M8x25x CLIP, (Serviced in Item #2) ***, (NOT SERVICED) NUT AND WASHER, Hex Nut-Coned Washer, M8 x 1.25

11 Group - 5 Service Brakes Illustration Title Group - 5 Service Brakes Group-Fig. No. Front Brakes Brakes, Front... Fig Rear Brakes Brakes, Rear... Fig Power Brake Booster Booster, Power Brake... Fig Brake Master Cylinder Master Cylinder, Brake... Fig Brake Lines and Hoses Lines And Hoses, Brake... Fig Brake Pedals Pedal, Brake... Fig Front Brakes Rear Brakes Power Brake Booster Brake Master Cylinder Brake Lines and Hoses Brake Pedals 1997 SR

12 Brakes, Front Brakes, Front Figure BEARING, Suspension Trailing, with Hub ROTOR, Brake, Vented WASHER, Flat (Not Serv.), (NOT SERVICED) BOLT, Hex Head (Not Serv.), (NOT SERVICED) 5 KNUCKLE, Front Left Right BLEEDER SCREW PKG, BRAKE 7 CALIPER, Disc Brake Left Right AA 1 PAD KIT, Front Disc Brake, with PIN and CLIP PACKAGE SCREW AND WASHER, Hex Head, M12x1.75x40, Caliper to Knuckle BOLT, D Head,.50-20x BOLT, Hex Flange Head, M10x1.50x NUT, Hex Flange, M22x1.25, Wheel Bearing Clamp GASKET, Front Wheel Bearing

13 Brakes, Rear Brakes, Rear Figure HUB AND BEARING, Brake ROTOR, Brake, Rear Brake Vented 3 KNUCKLE, Rear Left Right 4 CALIPER, Disc Brake Right Left AA 1 PAD KIT, Rear Disc Brake, with Pin and Clip Package BLEEDER SCREW PKG, BRAKE SCREW, Socket Head, M8x1.25x60, Caliper Mounting BOLT, Hex Head, M10x1.25x80, Caliper Mounting BOLT, D Head,.50-20x SCREW AND WASHER, Hex Head Locking,.50-20x2.25 Grade PIN, Cotter, M5x NUT AND WASHER PACKAGE, Front Hub NUT, Hex Flange, M22x1.25, (Axle Shaft Hub) WASHER, Flat, M23x43x PLATE, Brake Torque

14 Booster, Power Brake Booster, Power Brake Figure BOOSTER, POWER BRAKE Sales Code EWB= 8.0L V10 SFI BOOSTER, Power Brake AR GROMMET, Brake Booster Check Valve VALVE, Brake Booster Check NUT AND WASHER, Hex Nut-Coned Washer, M8 x BOOT, Brake Booster Push Rod AR SEAL, Brake Booster To Dash GASKET, Brake Master Cylinder, M/Cyl. to Booster NUT, Hex Lock, M8x HOSE, Vacuum Supply, 11/32 rough stock

15 Master Cylinder, Brake Master Cylinder, Brake Figure PIN, Master Cylinder Reservoir MASTER CYLINDER, Brake GROMMET, Master Cylinder Reservoir AR RESERVOIR, Brake Master Cylinder CLIP, M/Cyl. Push Rod

16 Lines And Hoses, Brake Lines And Hoses, Brake Figure TUBE, Steel, Foot Roll, Roll Stock CLIP, Parking Brake Cable, Front Brake Tube 3 HOSE, Front Wheel Disc Right Left WASHER, Brake Hose, to Caliper BOLT, Hex Head, M10x1.0x21.75, Brake Hose to Caliper BOLT AND CONED WASHER, Hex Head, M8x25x NUT, Inverted Flare, SCREW, x CLIP, Tube, Front Brake Tubes TUBE, Brake, M/Cyl. to Prop. Valve, Primary TUBE, Brake, M/Cyl. to Prop. Valve, Secondary AB 1 VALVE, Proportioning NUT, Inverted Flare,.50-20x.625, Brake Tube to Valve BOLT, Hex Head, M8x14, Valve and Bracket Mounting NUT AND WASHER, Hex Nut-Coned Washer, M6 x 1.00, Valve Mounting Bolt CLIP, Fuel Bundle, Brake and Fuel Tubes CLIP, Tube, Rear Brake Tube AR TUBE, Brake, Rear Brake TEE, Brake Tube, Front to Rear Brake Tubes 20 HOSE, Brake Right Left SCREW AND WASHER, Hex Head Header Point, M10x1x14, Brake Hose Bracket to Caliper(Rea r) ***

17 Pedal, Brake Pedal, Brake Figure AB 1 PEDAL, Brake, Clutch, and Accelerator, Brake CLIP, M/Cylinder Push Rod to Pedal NUT, Hex Flange, M8x AA 1 KNOB, BRAKE AND CLUTCH, ADJUSTING, Pedal Adjusting NUT, Hex Flange Lock, M6 Phosphate, M6x WASHER, (NOT SERVICED) PAD, Brake Pedal

18 Group - 6 Clutch Illustration Title Group - 6 Clutch Group-Fig. No. Clutch Clutch, (EWB)... Fig Clutch Housing Clutch Housing... Fig Clutch Controls Clutch Actuation System... Fig Clutch Pedals Clutch Pedal... Fig Clutch Clutch Housing Clutch Controls Clutch Pedals 1997 SR

19 Clutch, (EWB) Clutch, (EWB) Figure CLUTCH, (EWB) NOTE; EWB = 8.0L V AC 1 EWB PLATE, Clutch Pressure, Plate and Disc, Clutch EWB SCREW, Flange Head, x1.125

20 Clutch Housing Clutch Housing Figure CLUTCH HOUSING NOTE: DEC - 6 Spd Manual Trans DEC HOUSING, Clutch BEARING, Clutch Release, Clutch Concentric Slave SCREW, Hex Head, x2.75, Trans. to Engine Att x BOLT, Hex Head, x2.25, Trans. to Engine Att x COVER, Transmission Dust, Clutch Housing SCREW AND WASHER, Hex Head,.25-20x.50, ( x5.00) BOLT, Hex Head, (M8x1.25x25.00) WASHER, Flat, ID.484 OD 890 Thk.0710

21 Clutch Actuation System Clutch Actuation System Figure ACTUATOR, Hydraulic Clutch BUSHING, Hydraulic Clutch Actuator, Self Retaining

22 Clutch Pedal Clutch Pedal Figure AB 1 PEDAL, Brake, Clutch, and Accelerator PAD, Brake Pedal

23 Group - 7 Cooling Illustration Title Group - 7 Cooling Group-Fig. No. Radiator and Related Parts Radiator And Related Parts... Fig Radiator Air Baf es... Fig Water Pump and Related Parts Water Pump And Related Parts... Fig Tank, Coolant Engine Coolant Reserve And Pressurized Coolant Tank... Fig Pulleys and Related Parts Pulleys, Drive... Fig Drive Belts Belts, Drive... Fig Lines, Transmission Oil Cooler Oil Cooler And Lines... Fig Radiator and Related Parts Water Pump and Related Parts Tank, Coolant Engine Pulleys and Related Parts Drive Belts Lines, Transmission Oil Cooler 1997 SR

24 Radiator And Related Parts Radiator And Related Parts Figure RADIATOR AND RELATED S NOTE: Sales Codes: EWB = 8.0L V10 SFI CLAMP, Radiator, Hose HOSE, Coolant Reserve Tank, Outlet to Water Pump HOSE, Coolant Reserve Tank, Thermostat to Inlet CLAMP, Radiator SHROUD, Fan, Radiator -6 BRACKET, Bulkhead Right Left AR SHIM, Radiator, Support Lower RADIATOR, Engine Cooling AB Mopar Coolant 3 Year Formula 1 Gallon ISOLATOR, Radiator, Lower CAP, Pressurized Coolant, Radiator NUT AND WASHER, Hex Nut-Sealing Washer, M6 x SHIELD, Radiator,, Splash, Serviced in Fan Module, (NOT SERVICED) FAN MODULE, Radiator Cooling NUT AND WASHER, Hex Nut-Sealing Washer, M6 x EWB THERMOSTAT, 195 Degrees EWB GASKET, Thermostat, Thermostat EWB HOUSING, Thermostat EWB NIPPLE, Heater Return, Water Return RETAINER, Radiator Closure, Radiator Closure AR SHIM AR SHIM

25 Radiator Air Baf es Radiator Air Baf es Figure RADIATOR AIR BAFFLES NOTE: Sales Codes: EWB = 8.0L V10 SFI BAFFLE, Radiator, Upper Left Air U-NUT, SCREW AND WASHER, Hex Head, M5x.8x COVER, Baf e Air Upper, Upper Air Baf e DUCT, Air Filter To Baf e, Air Filter to Baf e BRACKET, Radiator, Radiator PIN, Push, M6.3x20.5, Baf e Att BAFFLE, Radiator, Lower Air RIVET, M4.9x PIN, Retainer, Push BAFFLE, Radiator, Upper Right Air

26 Water Pump And Related Parts Water Pump And Related Parts Figure WATER PUMP AND RELATED S NOTE: Sales Codes: EWB = 8.0L V10 SFI AB 1 EWB PUMP, Water, Water EWB GASKET, Water Pump, Pump HUB, Water Pump Pulley, (NOT SERVICED) EWB PULLEY, Water Pump, Pump EWB SCREW, Hex Head, x.75, Pulley Att EWB SCREW, Hex Flange Head, x1.50, Pump Att.

27 Coolant Reserve And Pressurized Coolant Tank Coolant Reserve And Pressurized Coolant Tank Figure COOLANT RESERVE AND PRESSURIZED COOLANT TANK NOTE: Sales Codes: EWB = 8.0L V10 SFI CAP, Coolant Reserve Tank, Reserve Tank TANK, Coolant Reserve, Coolant Reserve U-NUT, (NOT SERVICED) CLAMP, Hose, M28.9 x SCREW, (NOT SERVICED) HOSE, Coolant Reserve Tank, High Pressure Coolant BOTTLE, Pressurized Coolant, Pressurized Coolant CAP, Pressurized Coolant, Tank TUBE, Coolant Reserve Tank, Low Pressure Coolant CLIP, Hose CLAMP, Hose EWB HOSE, Coolant Reserve Tank, Tank to Water Pump

28 Pulleys, Drive Pulleys, Drive Figure PULLEYS, DRIVE NOTE: Sales Codes: EWB = 8.0L V10 SFI EWB PULLEY, Idler EWB PULLEY, Crankshaft, Drive EWB BUSHING, Idler Pulley EWB TENSIONER PACKAGE, Belt, Belt EWB NUT, Hex Flange, M10x1.5, Tensioner Att EWB PULLEY, Crankshaft, Water Pump EWB SCREW, Hex Head, x AB 1 EWB BELT, Accessory Drive LABEL, Belt Routing, Belt Routing

29 Belts, Drive Belts, Drive Figure BELTS, DRIVE NOTE: Sales Codes: EWB = 8.0L V10 SFI EWB BELT, Accessory Drive, Without Air Conditioning AB 1 EWB BELT, A/CAir Conditioning

30 Oil Cooler And Lines Oil Cooler And Lines Figure LINE, Oil Cooler Inlet LINE, Oil Cooler Outlet COOLER, Engine Oil U-NUT, M8x BOLT, Hex Head

31 Group - 8 Electrical Spark Plugs-Cables-Coils Alternators Modules Relays Sensors Single Board Engine Controllers Switches Horns Starters Battery Tray and Cables Lamps - Front, Rear and Courtesy Wiring-Engine & Related Parts Wiring-Headlamp to Dash Wiring-Instrument Panel Wiring-Body & Accessories Wiring Repair 1997 SR

32 Illustration Title Group - 8 Electrical Group-Fig. No. Starters Starter... Fig Alternators Alternators... Fig Modules Modules... Fig Relays Relays, Fuses, Circuit Beakers... Fig Sensors Sensors... Fig Single Board Engine Controllers Single Board Controllers... Fig Switches Switches... Fig Horns Horns... Fig Battery Tray and Cables Battery Tray and Cables...Fig Lamps - Front, Rear and Courtesy Lamps and Wiring - Front...Fig Lamps and Wiring - Rear... Fig Wiring-Engine & Related Parts Wiring - Engine and Related Parts...Fig Wiring-Headlamp to Dash Wiring - Headlamp to Dash...Fig Wiring-Instrument Panel Wiring - Instrument Panel...Fig Wiring-Body & Accessories Wiring - Body and Accessories...Fig Wiring Repair Connector Repair Package...Fig Spark Plugs-Cables-Coils Spark Plugs - Cables - Coil...Fig SR

33 Starter Starter Figure STARTER EWB= 8.0L V10 SFI EWB STARTER, Complete (Mtg. Screw ) EWB SCREW, Hex Flange Head, x1.50

34 Alternators Alternators Figure ALTERNATORS EWB= 8.0L V10 SFI EWB ALTERNATOR, Electrical, Complete (Generator) (Mounting Screw ) BRACKET, Alternator (Serviced w/cover ASSEMBLY, Chain Case # ), (NOT SERVICED) EWB TENSIONER PACKAGE, Belt, Automatic (Mounting Nut ) EWB SPACER, Alternator, Alternator Bracket

35 Modules Modules Figure MODULE, Daytime Running Lamp SCREW, x.875, (NOT SERVICED) 3 0MB62SX4AB 1 AIR BAG, Passenger 4 0MB62SX4AB 1 SCREW, Round Head, x1.00, (NOT SERVICED) BEZEL, Security Indicator WIRING, LED Security MODULE, Wiper STRAP, Module Mounting AB 1 MODULE, Air Bag Control BOX, Antenna Ampli er SCREW, Tapping,.19-16x1.75, (NOT SERVICED) 12 0LB45JX8 1 AIR BAG, Driver CHIME, Warning 14 MODULE, Keyless Entry Receiver AC 1 Export STRAP, Module Mounting 16 TRANSMITTER, Keyless Entry Export AR AB 1 MODULE, Lighting Control, Instrument Panel lamp dimmer

36 Relays, Fuses, Circuit Beakers Relays, Fuses, Circuit Beakers Figure RELAY, Electrical, Fuel Pump RELAY, Electrical, Time Delay, Passive Restraint AA 3 RELAY, Electrical, Radiator Fan RELAY, Electrical, Heated Rear Window RELAY, Mini, Plug-in 5T BREAKER, Circuit

37 Sensors Sensors Figure SENSORS EWB= 8.0L V10 SFI DEC= MANUAL 6-SPEED DEC SOLENOID, Transmission Skip Shift DEC SENSOR, Vehicle Speed DEC SOLENOID, Transmission, Reverse Lockout EWB SENSOR, Ambient Temperature, Intake Charge Temp EWB SENSOR, Crankshaft EWB SHIELD, Crank Position Sensor EWB SENSOR, Camshaft EWB SENSOR, MAP 9 SENSOR, Oxygen EWB 18 inch, Pigtail, Front EWB 18 inch, Double Shield, Rear EWB SENSOR, Throttle Position SENSOR, Battery Temperature DEC SENSOR, Vehicle Speed

38 Single Board Controllers Single Board Controllers Figure MODULE, Engine Controller AC 1 Federal, Canada AC 1 Europe AB 1 COVER, Module, JTEC Module SCREW, Tapping,.19-16x1.75

39 Switches Switches Figure SWITCHES EWB= 8.0L V10 SFI DEC= MANUAL 6-SPEED SWITCH, Stop Lamp, Stop Lamp/Speed Control (Clutch Inter-Lock) CLIP, (NOT SERVICED) EWB SENDING UNIT, Temperature Gauge DEC SWITCH, Back Up Lamp SWITCH, Clutch Starter Interlock EWB SWITCH, Oil Pressure EWB SENDING UNIT, Oil Pressure SWITCH, Electric Back Light SWITCH, Door Ajar, Under Hood Security Alarm -10 BRACKET, Wiring AB 1 Up to 02/10/ AC 1 After 02/10/ SWITCH, Strut, Rear Hatch Alarm -12 SWITCH, Headlamp Export -13 KNOB, Head Lamp Switch Export -14 SWITCH, Ignition Upto After SCREW, Ignition Switch -16 SWITCH, Door Handle SWITCH, Power Window SWITCH, Windshield Wiper SWITCH, Disarm, (NOT REQUIRED) SWITCH, Multifunction

40 Horns Horns Figure HORN, High Note Up to AB 1 After HORN, Low Note Up to AB 1 After SCREWHorn Mounting

41 Battery Tray and Cables Battery Tray and Cables Figure BOLT, Hex Head, x.95, Side Post Battery COVER, Battery Terminal, Battery Side Post, Negative COVER, Battery Terminal, Battery Side Post, Positive RETAINER, Battery Hold Down, Battery Tray 5 SCREW AND WASHER, Hex Head, M8x1.25x D 27 1 D 29 w/washer 6 WIRING, Uni ed Body AB AB AB 1 WIRING, Battery Negative AB 1 WIRING, Battery Positive TRAY, Battery 0VU01207 Repair Battery Terminal End Side Post ( Ten Per Box) BA078730EX Mopar Power Pro 6 0VU01205 Repair Battery Terminal End Top Post ( Ten Per Box) NUT, U, M6x SENSOR, Battery Temperature -12 LABEL, Battery AA 1 English/French AA AMP Maintenance

42 Lamps and Wiring - Front Lamps and Wiring - Front Figure LAMP, Side Marker Federal, Canada 2 27 Federal, Canada Export NUT AND WASHER, Hex Nut-Coned Washer, , Side Marker Lamp To Fascia LAMP, Front FenderSide Repeater, Export BULB, 8/4Side Repeater Lamp, Export GASKET, Side Marker LampExport WIRING, Side Repeater LampExport 7 COVER, Fog Lamp Left 1 27 Left 8 LAMP, Fog Fog 2 27 Fog -9 SCREW,.19-16x For Lamp to Adapter 4 29 For Lamp to Adapter BULB PACKAGE, 55 Watt, Fog Lamp (H3) -11 BRACKET, Fog Lamp Fog Lamp Fascia Front 2 27 Fog Lamp Fascia Front -12 SEAL, Fog Lamp HEADLAMP AB 1 Right AB 1 Left AB 1 Federal, Canada, Right AB 1 Federal, Canada, Left -14 L BULB, Headlamp -15 L BULB, 9011, high beam, Right & Left

43 Lamps and Wiring - Front Figure L03157NA 1 BULB, 3157 NAK, Park & Turn Signal (#3157NA) L ST SilverStar NUT AND WASHER, Hex Nut-Coned Washer, M8 x NUT, Wing, Headlamp Mounting

44 Lamps and Wiring - Rear Lamps and Wiring - Rear Figure LAMP, Tail Stop Turn Right 1 27 Right Left 1 27 Left Export, Right 1 27 Export, Right Export, Left 1 27 Export, Left 2 LAMP, Back-Up and Turn Signal Right Left BULB, P-25-2Tail Lamp 4 WIRING, Taillamp Export NUT, Wing, M6Tail Lamp LAMP, License Plate SCREW, Not Serviced, (NOT SERVICED) 8 BULB, 168 L License, CHMSL 1 29 License, Dome 9 1 WIRING, License Lamp, Serviced in Uni-Body Harness, (NOT SERVICED), LAMP, High Mounted Stop, Hi-Mtd. Stop AR GROMMET, Lamp, CHMSL BRACKET, High Mounted Stop Lamp CLIP, Panel Fastener, CHMSL Bracket to Lamp SCREW, Not Serviced, (NOT SERVICED) SCREW, Not Serviced, (NOT SERVICED) PANEL, Chmsl Cover, Cover BRACKET, Not Serviced, (NOT SERVICED) 18 RIVET, Blind,.156x.460

45 Lamps and Wiring - Rear Figure LAMP, Liftgate Chmsl

46 Wiring - Engine and Related Parts Wiring - Engine and Related Parts Figure WIRING - ENGINE AND RELATED S EWB= 8.0L V10 SFI 1 WIRING, Engine AB 1 EWB Lower EWB Intake EWB WIRING, Alternator -3 BRACKET, Wire Harness EWB 3/8 x 1/ AA 1 EWB 1/4 x 1/ EWB BRACKET, Wiring Harness, Wiring Assembly AB 1 WIRING, Battery Negative EWB WIRING, Engine Ground EWB SENDING UNIT, Oil Pressure

47 Wiring - Headlamp to Dash Wiring - Headlamp to Dash Figure WIRING, Headlamp to Dash AD 1 Up to 02/10/ AE 1 After 02/10/97-2 FLASHER Combination COVER, Power Distribution Center -4 LABEL, Fuse Block Fuse & Relay Top Cover Fuse Identi cation Top Cover Fuses LABEL, Relay Identi cation, ISO Relay (Top Cover)

48 Wiring - Instrument Panel Wiring - Instrument Panel Figure AC 1 WIRING, Instrument Panel AR BLOCK, Fuse -3 FLASHER Turn Signal Combination

49 Wiring - Body and Accessories Wiring - Body and Accessories Figure WIRING - BODY AND ACCESSORIES EWB= 8.0L V10 SFI 1 WIRING, Uni ed Body AB AB WIRING, Transmission AB 1 WIRING, Battery Positive AB 1 WIRING, Battery Negative AB 1 EWB HARNESS, CCV To Air Cleaner AC 1 EWB HARNESS, Canister Purge AB 1 EWB HARNESS, PCV -8 WIRING, Door AB 1 Left AB 1 Right WIRING, Side Repeater Lamp, Export WIRING, Side Marker Jumper AC 1 29 WIRING, Electric Back LightGround WIRING, Heater and A/C, Sub-Assy AA 1 27 WIRING, Mirror Jumper

50 Connector Repair Package Connector Repair Package Figure AA 1 WIRING PACKAGE, Underhood Connector Repair, For Electrical Connector Repair Information visit the World Wide Web at

51 Spark Plugs - Cables - Coil Spark Plugs - Cables - Coil Figure SPARK PLUGS - CABLES - COIL EWB= 8.0L V10 SFI AA 1 EWB CABLE PACKAGE, Ignition, Spark Plug 2 WIRE, Spark Plug EWB [#1] EWB [#2] EWB [#3] EWB [#4] EWB [#5] EWB [#6] EWB [#7] EWB [#8] EWB [#9] EWB [#10] EWB SPARK PLUG, RC-12-LYC5 0SP00436 Canadian Aftermarket Part EWB SEPERATOR, Ignition Cable, Attaches to Thermo.Housing, 4 or 5 Place EWB SHIELD, Heat, Spark Plug -6 COIL, Ignition EWB Six Lead EWB Four Lead

52 Group - 08A Instrument Panel and Radios and Consoles Illustration Title Group - 08A Instrument Panel and Radios and Consoles Group-Fig. No. Instrument Panel Instrument Panel... Fig. 08A Instrument Panel Cluster Gauge Cluster... Fig. 08A Radio, Antenna, and Speakers Radios... Fig. 08A Antenna-Speakers... Fig. 08A Consoles Console... Fig. 08A A-100 Instrument Panel 08A-200 Instrument Panel Cluster 08A-300 Radio, Antenna, and Speakers 08A-400 Consoles 1997 SR

53 Instrument Panel Instrument Panel Figure 08A LB39SX4AD 1 FASCIA, Instrument Panel 2 SUPPORT, Instrument Panel Right Left 3 PANEL, Instrument Closure AB 1 Right AB 1 Left SCREW, Self Tapping, M4.2x1.69x CLIP, Push, , Fascia Mounting CARRIER, Instrument Panel 7 PLATE, Instrument Panel Support Right Left SCREW 9 0LB36BX7AC 1 PAD, Instrument Panel, Black, Lower, Right 10 0QN71SX7AB 1 PAD, Instrument Panel, Black, Lower, Left 11 BEZEL, Instrument Panel 0KS79MX4AB 1 29 Black, Center 0PK84MX4AB 1 27 Black, Center -12 CLIP, M5.35x Center Bezel attaching 6 27 Center Bezel attaching 13 0D221SX8 1 ASH RECEIVER, Rear Door SCREW COVER, Fuse Access LABEL, Fuse Block, Fuse Identi cation 17 AIR BAG, Passenger 0MB62MX4 1 Black 0MB62SX4AB 1 Black, Export 18 0MB62SX4AB 1 U-NUT, [ ], (NOT SERVICED), 19 0MB62SX4AB 1 SCREW, x.625, (NOT SERVICED) NUT, M5x.8 21 SWITCH, Headlamp

54 Instrument Panel Figure 08A Export AB 1 MODULE, Lighting Control, Instrument Panel Lamp dimming CAP WASHER, (NOT SERVICED) SCREW, [ x2.00], (NOT SERVICED) WIRING, LED Security, w/red Lens BEZEL, Windshield Frame

55 Gauge Cluster Gauge Cluster Figure 08A GAUGE, Speedometer AB 1 With MPH AB 1 With KPH AB 1 GAUGE, Tachometer AB 1 MODULE, Message Center, Warning Indicators 4 GAUGE, Oil Pressure AB AB 1 Export 5 GAUGE, Temperature AB AB 1 Export AB 1 GAUGE, Volt AB 1 GAUGE, Fuel CHIMNEY, Cluster, Turn Signal

56 Radios Radios Figure 08A-305 RADIOS RBH=PREMIUM, ALPINE STEREO W/CD 1 RADIO, AM/FM with CD AB 1 Sales Code (RBH) AB 1 Sales Code (RBH), Export SCREW, Self Tapping, M4.2x1.69x19.05, Radio Attaching BRACKET, Radio

57 Antenna-Speakers Antenna-Speakers Figure 08A ANTENNA, Serviced with Windshield, (NOT REQUIRED) AC 1 COVER, Antenna Opening AC 1 SPEAKER, 6.5", All Speakers Serviced Only By ALPINE Dealer, (NOT SERVICED) D 29 GRILLE, SpeakerDoor SCREW, x1.5 Not Serviced, (NOT SERVICED) GRILLE, SpeakerCenter RING, Speaker, (NOT SERVICED) SCREW, x.750, (NOT SERVICED) AMPLIFIER, Radio, Serviced Only By ALPINE Dealer, (NOT SERVICED) BRACKET, Ampli er Retainer BOLT AND CONED WASHER, Hex Head, M6x20x14, Ampli er Retainer Attaching BRACKET, Ampli er, Assembly NUT AND WASHER, Hex Nut-Sealing Washer, M6 x 1.00Ampli er Attaching CABLE, Ampli er Box, With Shield GROMMET, Antenna Ampli er BOX, Antenna Ampli er SCREW, X.375, (NOT SERVICED) HOLDER, Fuse, Block

58 Console Console Figure 08A D221SX8 1 ASH RECEIVER, Rear Door, (Black) -2 CLIP, Ash Receiver Retention BEZEL, Instrument Panel, Center 0KS79MX PK84MX PK84MX4 1 SCREW, (NOT SERVICED) 5 0PF25TX7 1 CONSOLE, Front, Assembly (Items 7 & 8 Included) Black 6 0PF25TX7 1 SCREW, (NOT SERVICED) -7 SHELL, Cigar Lighter with Clamp 1 27 with Clamp KNOB AND ELEMENT, Cigar Lighter 9 0PD66TX9 1 D 29 BOOT, Parking Brake Lever, Black 10 0PD67TX9 1 D 29 BOOT, Gearshift, Black, Leather BOOT, Gearshift, Rubber Base

59 Group - 9 Engine Mounting Illustration Title Group - 9 Engine Mounting Group-Fig. No. Engine Mounting Engine Mounting, Front 8.0L Engine... Fig Engine Mounting, Rear 8.0L Engine... Fig Engine Mounting 1997 SR

60 Engine Mounting, Front 8.0L Engine Engine Mounting, Front 8.0L Engine Figure EWB BOLT, Alternator, w/washer, ( x4.00) EWB NUT, EWB BRACKET PACKAGE, Engine Mount EWB SHIELD, Heat, Engine Mount 5 INSULATOR, Engine Mount EWB Left EWB Right NUT AND WASHER, Hex Nut-Coned Washer,

61 Engine Mounting, Rear 8.0L Engine Engine Mounting, Rear 8.0L Engine Figure BOLT, M10x1.50x75, Trans. Crossmember to Frame, NUT, Hex Flange Lock, M14x1.50, Trans. Crossmember to Frame, MOUNT, Transmission SCREW AND WASHER, Hex Head, M10x1.5x CROSSMEMBER, Transmission NUT, Hex Flange Lock, M14x1.50, Mount to Trans. Crossmember,

62 Group - 8.0L Engine 8.0L Ten Cylinder 8.0L-100 Engine Identi cation 8.0L-1100 Oil Cooler 8.0L-200 Cylinder Head 8.0L-300 Cylinder Block 8.0L-400 Crankshaft, Piston and Torque Converter 8.0L-500 Camshafts & Valves 8.0L-600 Timing Belt and Cover 8.0L-700 Engine Oiling 8.0L-800 Manifolds 8.0L-900 Crankcase Ventilation 1997 SR

63 Illustration Title Group - 8.0L Engine 8.0L Ten Cylinder Group-Fig. No. Engine Identi cation I.D. Location 8.0L Engine...Fig. 8.0L Cylinder Head Cylinder Head 8.0L Engine... Fig. 8.0L Cylinder Block Cylinder Block 8.0L Engine... Fig. 8.0L Crankshaft, Piston and Torque Converter Crankshaft and Pistons 8.0L Engine... Fig. 8.0L Camshafts & Valves Camshafts and Valves 8.0L Engine... Fig. 8.0L Timing Belt and Cover Timing Belt and Cover 8.0L Engine... Fig. 8.0L Engine Oiling Engine Oiling 8.0L Engine... Fig. 8.0L Manifolds Manifolds, Intake and Exhaust 8.0L Engine... Fig. 8.0L Crankcase Ventilation Crankcase Ventilation 8.0L Engine... Fig. 8.0L Oil Cooler Oil Cooler 8.0L Engine... Fig. 8.0L SR

64 I.D. Location 8.0L Engine I.D. Location 8.0L Engine Figure 8.0L-110 I.D. LOCATION 8.0L ENGINE VIN Number located on right rear side of cylinder block in front of clutch housing. SERIAL Number located on right lower front of cylinder block abov LABEL, Equipmemt Identi cation, (NOT SERVICED)

65 Cylinder Head 8.0L Engine Cylinder Head 8.0L Engine Figure 8.0L-210 CYLINDER HEAD 8.0L ENGINE NOTE: Sales Code [EWB] = 8.0L V10 SFI Engine EWB GASKET PACKAGE, Engine Upper EWB COVER, Cylinder Head EWB COVER, Cylinder Head AB 1 EWB CAP, Oil Filler, Mobil 1 Graphics on cap EWB SCREW, Hex Flange Head,.25-20x EWB GASKET, Valve Cover EWB HEAD, Cylinder AA AR EWB GASKET, Cylinder Head EWB BOLT, Cylinder Head EWB SCREW, Hex Flange Head,.25-20x1.00

66 Cylinder Block 8.0L Engine Cylinder Block 8.0L Engine Figure 8.0L EWB GASKET PACKAGE, Engine Lower EWB BLOCK, Short AA Mopar 0W-40 Mobil 1 Engine Oil R AA Mopar Reman 8.0L Long Block (EWB) J EWB DOWEL, Oil Pump EWB PLUG, Cylinder Block Oil Hole EWB PIN, Dowel

67 Crankshaft and Pistons 8.0L Engine Crankshaft and Pistons 8.0L Engine Figure 8.0L EWB PISTON RING SET, COMPLETE ENGINE, STD AB AR EWB PISTON, ENGINE, [+.010 Oversize], Standard 3 PISTON AA AR EWB [+.010 Oversize] AA AR EWB [+.020 Oversize] EWB PIN, Piston EWB ROD, Connecting EWB BOLT, Connecting Rod EWB CRANKSHAFT EWB BEARING, Pilot EWB BOLT, Hex Head, x EWB RETAINER, Crankshaft Rear Oil Seal EWB GEAR, Ring EWB GASKET, Rear Oil Seal Retainer EWB BEARING, Connecting Rod, STD EWB FLYWHEEL EWB NUT, Hex, BEARING PACKAGE, Crankshaft, Standard AR EWB Main -# Magenta AR EWB Main -# White - Clear AR EWB Main -# Orange AR EWB Main -# Black AA AR EWB Main -# Yellow 17 BEARING PACKAGE, Crankshaft, Thrust AA AR EWB Standard,+.030 Outside Diameter AA AR EWB [.001 Undersized,+.030 Outside Diameter] AA AR EWB [.002 Undersized,+.030 Outside Diameter] AA AR EWB [.020 Undersized,+.030 Outside Diameter] AA AR EWB [.010 Undersized, Standard,Outside Diameter] 18 BEARING PACKAGE, Crankshaft Thrust, Standard Size AR EWB Magenta

68 Crankshaft and Pistons 8.0L Engine Figure 8.0L EWB White-Clear AR EWB Orange AR EWB Black AA AR EWB Yellow 19 BEARING PACKAGE, Crankshaft AA AR EWB Standard, Main, Outside Diameter AA 1 EWB [.001 Undersized, Main,+.030 Outside Diameter] AA AR EWB [.002 Undersized, Main,+.030 Outside Diameter] AA AR EWB [.010 Undersized, Main,+.030 Outside Diameter] AA AR EWB [.010 Undersized, Main, Standard,Outside Diameter] AA AR EWB BEARING PACKAGE, Crankshaft,.009" U/S AA AR EWB BEARING PACKAGE, Crankshaft thrust,.009" U/S AA AR EWB BEARING PACKAGE, Crankshaft,.010" U/S AA AR EWB BEARING PACKAGE, Crankshaft thrust,.010" U/S AA AR EWB BEARING PACKAGE, Crankshaft,.011" U/S AA AR EWB BEARING PACKAGE, Crankshaft thrust,.011" U/S EWB KEY, Crankshaft Sprocket EWB DAMPER, Crankshaft EWB WASHER, Flat,.78x EWB SCREW, Hex Head,.75-16x EWB BOLT, Bearing Cap EWB BOLT, Bearing Cap EWB STUD, x5.670

69 Camshafts and Valves 8.0L Engine Camshafts and Valves 8.0L Engine Figure 8.0L EWB ROCKER ARM, Valve EWB PIVOT, Rocker Arm EWB RETAINER, Rocker Arm Pedestal EWB BOLT, Hex Flange Head, x EWB LOCK, Valve Spring Retainer EWB RETAINER, Valve Spring EWB SPRING PACKAGE, Valve EWB SEAT, Valve Spring EWB SEAL, Valve Guide, Intake EWB SEAL, Valve Guide, Exhaust EWB VALVE, Intake, Standard AA AR EWB VALVE, Intake,.003" O/S, Orange AA AR EWB VALVE, Intake,.015" O/S, Orange EWB VALVE, Exhaust, Standard AA AR EWB VALVE, Exhaust,.005" O/S, Orange AA AR EWB VALVE, Exhaust,.015" O/S, Orange AA AR EWB VALVE, Exhaust,.030" O/S, Orange AA AR EWB INSERT, Valve Guide EWB PLUG, Camshaft EWB DOWEL,.25x EWB TAPPET PACKAGE, Valve EWB CAMSHAFT, Engine AA 1 EWB CAMSHAFT, Engine,.002" O/S Journal, Brown -24 CAMSHAFT, Engine AA 1 EWB [+.003 Oversized Journal - Blue] AA 1 EWB [+.030 Oversized Journal - White] EWB PUSH ROD, Valve EWB YOKE, Tappet Aligning EWB BOLT,.25-20x.88

70 Timing Belt and Cover 8.0L Engine Timing Belt and Cover 8.0L Engine Figure 8.0L EWB PLATE, Camshaft Thrust EWB SCREW, Hex Head, x EWB CHAIN PACKAGE, Timing EWB KEY, Crankshaft Sprocket EWB BOLT, Hex Head, x EWB SCREW, Hex Flange Head, x EWB GASKET, Chain Case Cover EWB COVER, Timing Case EWB SEAL, Crankshaft Oil, Front

71 Engine Oiling 8.0L Engine Engine Oiling 8.0L Engine Figure 8.0L EWB CAP, Oil Pressure Relief Valve EWB SPRING, Oil Pressure Relief Valve AB 2 EWB PLUNGER, Oil Pressure Relief Valve, Serviced in Case Cover EWB VALVE, Oil Cooler Pressure EWB COVER, Timing Case EWB ROTOR SET, Oil Pump EWB COVER, Engine Oil Pump EWB SCREW, Torx Head,.25-20x EWB INDICATOR, Engine Oil Level EWB TUBE, Engine Oil Indicator EWB PICKUP, Engine Oil EWB SCREW, Pan Head,.19-24x EWB NUT, Hex, EWB FILTER, Engine Oil 0FE00292 Canadian Aftermarket Part BA BULK PACK (12) Performance Mobil 1, 15W - 50 Tri-Synthetic Engine Oil- Recommended Fill for 6.1L & 8.3L P Performance Mobil 1, 5W - 30 Tri-Synthetic Engine Oil, Quart EWB CONNECTOR, Oil Filter EWB SCREW, Hex Flange Head,.25-20x EWB ADAPTER, Oil Filter EWB SEAL, Drain Plug EWB GASKET, Oil Filter Adapter EWB CONNECTOR, Engine Oil Cooler EWB GASKET, Oil Pan EWB PAN, Engine Oil EWB SCREW, Hex Flange Head,.25-20x EWB PLUG, Oil Drain EWB TRAY, Windage EWB SEAL, Rear Main Crankshaft

72 Manifolds, Intake and Exhaust 8.0L Engine Manifolds, Intake and Exhaust 8.0L Engine Figure 8.0L EWB MANIFOLD, Intake EWB PLUG, Cylinder Block Oil Hole EWB SCREW, Hex Flange Head,.25-20x EWB GASKET, Intake Manifold EWB GASKET, Exhaust Manifold 6 MANIFOLD, Exhaust EWB Right EWB Left EWB WASHER, Coned,.340 x.750 x EWB BOLT, Hex Head EWB STUD SHIELD, Exhaust Manifold EWB SHIELD, Crank Position Sensor NUT AND WASHER, Hex Nut-E Teeth Washer, EWB PLUG, Cylinder Block Oil Hole EWB VALVE, Shrader

73 Crankcase Ventilation 8.0L Engine Crankcase Ventilation 8.0L Engine Figure 8.0L EWB GROMMET, Crankcase Vent EWB VALVE, PCV EWB HARNESS, PCV EWB HOSE, PCV Inlet EWB HARNESS, CCV To Air Cleaner

74 Oil Cooler 8.0L Engine Oil Cooler 8.0L Engine Figure 8.0L LINE, Oil Cooler Inlet LINE, Oil Cooler Outlet COOLER, Engine Oil U-NUT, M8x BOLT, Hex Head

75 Group - 11 Exhaust Illustration Title Group - 11 Exhaust Group-Fig. No. Exhaust System Exhaust System, U.S. and Canada... Fig Exhaust System, Export...Fig Heat Shields Heat Shield...Fig Exhaust System Heat Shields 1997 SR

76 Exhaust System, U.S. and Canada Exhaust System, U.S. and Canada Figure ISOLATOR, Exhaust Support SUPPORT, Exhaust Isolator ISOLATOR, Exhaust SUPPORT, Exhaust Isolator BOLT, Shoulder, x MUFFLER, Exhaust, w/pipe NUT AND WASHER, Hex Nut-Coned Washer, M8 x 1.25, Hanger HANGER, Muf er, Rear 9 RESONATOR AND PIPE, Exhaust AA 1 Right AA 1 Left 10 INSULATION, Thermal Sill Inner Right Left BOLT AND CONED WASHER, Hex Head, M8x45x CLAMP, Exhaust, 57.2mm AA 1 CLAMP, Exhaust, 2 1/2 Band 14 CONVERTER, Catalytic Right Left GASKET, Exhaust, Ring, Exhaust Pipe to Manifold NUT, Hex Flange, M8x HANGER BAR, Muf er SCREW, Hex Head, M x 20, Hanger Bar,

77 Exhaust System, Export Exhaust System, Export Figure ISOLATOR, Exhaust Support SUPPORT, Exhaust Isolator ISOLATOR, Exhaust SUPPORT, Exhaust Isolator BOLT, Shoulder, x MUFFLER, Exhaust Right Left NUT AND WASHER, Hex Nut-Coned Washer, M8 x 1.25, Hanger HANGER, Muf er, Rear 9 MUFFLER, Exhaust Right Left 10 INSULATION, Thermal Sill Inner Right Left BOLT AND CONED WASHER, Hex Head, M8x45x CLAMP, Exhaust, Muf er Tip 13 CONVERTER, Catalytic Right Left GASKET, Exhaust, Ring, Exhaust Manifold to Exhaust Assembly NUT, Hex Flange, M8x HANGER BAR, Muf er, Muf er Hanger SCREW, Hex Head, M x 20, Hanger Bar CLAMP, Exhaust, 57.2mm AA 1 CLAMP, Exhaust, 2 1/2 Band

78 Heat Shield Heat Shield Figure SHIELD, Heat Right Left SCREW, Shield, ( x.875) U-NUT,.25-20, Shield SHIELD, Heat, Rear Muf er SCREW TAPPING & WASHER, Hex Head, X.500, Shield, ( x.500)

79 Group - 13 Frames and Bumpers Illustration Title Group - 13 Frames and Bumpers Group-Fig. No. Frames Frame...Fig Front Bumper and Fascia Fascia, Front...Fig Rear Bumper and Fascia Fascia, Rear...Fig Frames Front Bumper and Fascia Rear Bumper and Fascia 1997 SR

80 Frame Frame Figure FRAME AA 1 Rear Right, Rail AA 1 Rear Left, Rail AA 1 FRAME, Front Clip CROSSMEMBER, Front Frame 4 SILL, Body Side AA 1 Right AA 1 Left 5 STRUT, Support to Upper Rail Right Left SCREW, M6x1x SCREW BRACKET, Sportbar STUD PLATE, Sport Bar Support Bracket SCREW AND WASHER, M10x1.50x35Front Cross Member AB 1 CROSSMEMBER, Differential, Differential Pinion Mtg AB 1 SCREW, (NOT SERVICED) NUT, Hex Flange Lock, M14x1.50Transmission, Cross Member To Frame

81 Fascia, Front Fascia, Front Figure FASCIA, Front 0KS721BEAB 1 Blue/White (APV) 0KS72LRNAC 1 29 Red (APA) BUMPER, Fascia, Reinforcement -3 ADAPTER, Bumper Fascia Right Left FOAM AND TAPE, Fascia -5 FOAM AND TAPE, Frt Fascia Grille Opng, GT SEAL, Front Fascia To Hood, Fascia to Hood SCREW NUT, Hex Flange Lock, M5 9 PANEL, Front Facsia Right Left U-NUT, SCREW AND WASHER, Hex Head, M5x.8x NUT, (NOT SERVICED) NUT, (NOT SERVICED) SHIM, (NOT SERVICED) BOLT, (NOT SERVICED) HANDLE AND CABLE, Hood Release, w/cable Hood Release SCREW, (NOT SERVICED) PAD, Bulkhead Spacer, Hood Alignment BRACKET, Hood Latch, Hood Latch SCREW, (NOT SERVICED) -21 NUT AND WASHER, Hex Nut-Coned Washer, SCUFFER, Fascia Front, Clear Tape

82 Fascia, Front Figure Right Left

83 Fascia, Rear Fascia, Rear Figure FASCIA, Rear AA 1 29 EXPORT AA 1 27 Primed AA 1 29 Primed 0HC801BEAB 1 27 Stripes - Dual Painted (Blue & White) 0LB011BEAB 1 29 Stripes - Dual Painted (Blue & White) EXPORT 0LB051BEAB 1 29 Stripes - Dual Painted (Blue & White) BUMPER, Fascia, Reinforcement -3 ADAPTER, Bumper Fascia Right 1 27 Right Left 1 29 Left FOAM AND TAPE, FasciaRear LICENSE PLATE KIT FRAME, License PlateExport SCREW, Splash Shield to Frame NUT AND WASHER, Fascia to Quarter Panel SCREW,.19-16x SCREW, Fascia to Lower Splash U-NUT, NUT AND WASHER, Hex Nut-Coned Washer, M10 x SHIM, Not Serviced, (NOT SERVICED) 14 RETAINER, Rear Fascia Right Left

84 Group - 14 Fuel Tank, Fuel Accelerator Pedal Fuel Tank Filler Tube Fuel Lines Fuel Rail Fuel Pump and Sending Unit Throttle Body Throttle Controls Air Cleaner 1997 SR

85 Illustration Title Group - 14 Fuel Group-Fig. No. Tank, Fuel Fuel Tank...Fig Fuel Tank Filler Tube Fuel Filler Tube...Fig Fuel Lines Fuel Lines And Filter...Fig Fuel Rail Fuel Supply Tube...Fig Fuel Pump and Sending Unit Fuel Module...Fig Throttle Body Throttle Body...Fig Throttle Controls Throttle Controls...Fig Air Cleaner Air Cleaner...Fig Accelerator Pedal Accelerator Pedal...Fig SR

86 Fuel Tank Fuel Tank Figure TANK, Fuel STRAP, Fuel Tank SCREW AND WASHER, Hex Head, M8x1.25x25, Locking, (NOT SERVICED)

87 Fuel Filler Tube Fuel Filler Tube Figure TUBE, Fuel Filler TUBE, Fuel Filler Vent AB AB CLAMP, HOSE CLAMP, Vent Hose 4 CAP, Fuel Filler Monza Metal Base Fuel Filler Tube SCREW, Tapping,.19-16x.75, (NOT SERVICED), 6 CLAMP, Hose NUT, Hex Flange With Serration, (NOT SERVICED) SHIELD, Fuel Filler Door

88 Fuel Lines And Filter Fuel Lines And Filter Figure TUBE BUNDLE, Fuel Lines SCREW, M8x1.25x25, (NOT SERVICED) FILTER, Fuel CLIP, Tube TUBE, Fuel CLIP, Fuel Bundle CLIP, Parking Brake Cable, Fuel Line SCREW, Fuel Line Clip, ( x.875)

89 Fuel Supply Tube Fuel Supply Tube Figure EWB RAIL, Fuel EWB SCREW, Hex Flange Head,.25-20x1.00, Injector Mounting EWB RETAINER, Fuel Injector EWB INJECTOR, Fuel, Fuel

90 Fuel Module Fuel Module Figure NUT, Fuel Pump Module SEAL, Fuel Pump and Level Unit, Fuel Module AA 1 MODULE KIT, Fuel Pump/Level Unit AA 1 LEVEL UNIT KIT, Fuel AA 1 FILTER KIT, Fuel, Module VALVE, Fuel Tank Rollover Safety, Rollover

91 Throttle Body Throttle Body Figure EWB SCREW, Hex Flange Head,.25-20x1.00, Throttle Body 2 THROTTLE BODY EWB Right EWB Left 3 SENSOR PACKAGE, Throttle Position EWB [HCD] 1 EWB [HAA] EWB GASKET, Throttle Body To Intake EWB MOTOR AND BODY, IACV, AIS EWB SCREW, Hex Flange Head,.25-20x1.00, AIS EWB MOTOR KIT, A.I.S., AIS Motor Consists of: 1-Motor, AIS Stepping 2-Screw, AIS Motor 1-O-Ring, Throttle Body EWB GASKET, A.I.S. Motor HOSE, A.I.S. Supply EWB CONNECTOR, Emission Hose, Elbow, Map Sensor

92 Throttle Controls Throttle Controls Figure CABLE, Accelerator AB 1 BRACKET, Accelerator Cable EWB SCREW, Hex Flange Head,.25-20x EWB LINKAGE, Throttle Body RETAINER, Throttle Cable EWB SCREW, Adjusting, Linkage Adjusting EWB CLIP, Stud, Accelerator Cable

93 Air Cleaner Air Cleaner Figure HOUSING, Air Inlet AA HOUSING, Air Outlet Air Outlet 1 29 Air Outlet 3 TUBE, Air Cleaner to T/Body Air Cleaner to Throttle Body 2 29 Air Cleaner to Throttle Body 4 SCREW, Air Cleaner Cover Air Cleaner to Shroud 1 29 Air Cleaner to Shroud AB 1 TUBE, Crankcase Vent To Air Cleaner, Crankcase Vent to Air Cleaner CLAMP, Hose, M28.9 x 1.60, AIS Hose HOSE, A.I.S. Supply, Air Cleaner 8 ELEMENT, Air Cleaner Crankcase Vent Filter 1 29 Crankcase Vent Filter 9 ELEMENT, Air Cleaner AB 2 29 Air Cleaner Filter 2 27 Air Cleaner Filter SCREW, Air Cleaner HOSE, Crankcase Vent, Crankcase Vent to Air Cleaner

94 Accelerator Pedal Accelerator Pedal Figure AB 1 PEDAL, Brake, Clutch, and Accelerator SEAL, Accelerator Shaft Bracket NUT, Hex Flange Lock, M6 Phosphate

95 Group - 16 Propeller Shafts and U-Joints Illustration Title Group - 16 Propeller Shafts and U-Joints Group-Fig. No. Propeller Shaft Shaft, Propeller...Fig Propeller Shaft 1997 SR

96 Shaft, Propeller Shaft, Propeller Figure U JOINT SHAFT, Drive, Propeller BOLT, Hex Flange Head, M8x1.0x CLAMP, U-Joint STRAP, Bearing (For Shipping, (NOT SERVICED)

97 Group - 17 Rear Suspension Illustration Title Group - 17 Rear Suspension Group-Fig. No. Rear Suspension Suspension, Rear...Fig Rear Suspension 1997 SR

98 Suspension, Rear Suspension, Rear Figure SHOCK ABSORBER, Suspension, Rear PIN, Cotter,.125X NUT, Hex, NUT, M10x NUT, Hex, SCREW AND WASHER, M10x1.5x LINK, Trailing Rear Suspension, with Boot BOLT, Hex Flange Head, M14x2.00x SCREW, M14x2.00x NUT, M14x LINK, Rear Suspension Assist SCREW, W/Washer M10x1.50x30.00, (NOT SER- VICED) NUT, Hex, M NUT, Hex Jam, M10x ARM, ControlUpper 16 ARM, Control Lower, Right Lower, Left CAM, Front Suspension Control Arm NUT, Engine Mounting, M12 x SCREW, W/Washer M12x1.75x95.00, (NOT SER- VICED) NUT, Hex Jam, M10x SHIM, Tow Link To Frame AR (NOM) AR (2U) AR (4U) AR (6U) AR (2D) AR (4D) AR (6D) BAR, Rear Sway

99 Suspension, Rear Figure SPRING, Rear Coil BRACKET, Suspension, Rear Shock RETAINER, Stabilizer Bar Grommet BUSHING, Stabilizer Bar NUT, KNUCKLE, Rear Left Right AB 4 BALL JOINT, Lower Control Arm ROD, Toe Link AA 2 BUSHING, Shock Absorber

100 Group - 19 Steering Illustration Title Group - 19 Steering Group-Fig. No. Steering Wheel Wheel, Steering...Fig Steering Column Column Assembly And Mounting...Fig Steering Gear Gear, Rack & Pinion Power And Attaching Parts...Fig Steering Linkage Tie Rod Ends...Fig Power Steering Pump Pump And Hoses, Power Steering...Fig Steering Wheel Steering Column Steering Gear Steering Linkage Power Steering Pump 1997 SR

101 Wheel, Steering Wheel, Steering Figure WHEEL, Steering 0PB41SX9 1 Flat Black 0PB41TR1 1 Red 0PB41TB4 1 Bright blue 2 0LB45JX8 1 AIR BAG, Driver, Air Bag SCREW, Hex Flange Head, M6x1x SWITCH, Horn, (Serviced with Wheel), (NOT SERVICED) CLOCKSPRING NUT, Hex Flange Lock, M14x1.5

102 Column Assembly And Mounting Column Assembly And Mounting Figure COLUMN, Steering, Tilt, w/o Switchs LEVER, Tilt Column Release SHAFT, Steering Column, Intermediate Gear To Column SCREW, Hex Flange Head, M10x1.5x DW57PX8 1 SHROUD, Steering Column, (Paint as Require), Lower 6 0DH69JX8 1 D SHROUD, Lock Housing, (Paint as Require), Upper 7 0BA67KX8 1 SHROUD, Steering Column, Fixed (Paint as Required), Lower 8 0BA65KX8 1 SHROUD, Steering Column, Fixed (Paint as Required), Upper SCREW, Filister Head, #8-16x SCREW, (NOT SERVICED) STUD, M6x1.00x WASHER, (NOT SERVICED) NUT, Hex Flange Lock, M8 Phosphate, Steering Column to Toe Box Attch NUT, Retainer, M6 x NUT, U, M6x SWITCH, Ignition SCREW, Ignition Switch

103 Gear, Rack & Pinion Power And Attaching Parts Gear, Rack & Pinion Power And Attaching Parts Figure END, Tie Rod, Package BOOT, Steering Gear, Package GEAR, Power Steering, Rack and Pinion Power WASHER, Flat S BOLT, Hex Head, x NUT, Pivot Arm NUT, PIN, Cotter ISOLATOR, Steering Gear, Gear Mtg O RING, Steering Gear, Gear Bushing AR SHIM, Steering Gear, 0.5mm AR SHIM, Steering Gear, 1.0mm AR SHIM, Steering Gear, 1.5mm AR SHIM, Steering Gear, 3.0mm

104 Tie Rod Ends Tie Rod Ends Figure END, Tie Rod NUT, PIN, Cotter NUT, Jam (Service in Tie Rod End), (NOT SERVICED)

105 Pump And Hoses, Power Steering Pump And Hoses, Power Steering Figure PUMP AND HOSES, POWER STEERING Note: Sales Code EWB= 8.0L V10 SFI EWB PUMP, Power Steering, w/o Pulley, Reservoir, Cap (Just Pump) Mopar Power Steering Fluid Quart EWB BRACKET, Power Steering Pump, Mounting EWB SCREW AND WASHER, Hex Head, x3.50, w/washer Pump To Bracket EWB SCREW, Hex Flange Head, x1.50, w/washer Bracket To Engine EWB CAP, Power Steering Reservoir HOSE, Power Steering Pressure HOSE, Power Steering Return CLAMP, Hose, Return Hose EWB PULLEY, Power Steering Pump COOLER, Power Steering HOSE, Power Steering Return, Pump To Cooler SCREW AND WASHER, Hex Head,.25-20x EWB RESERVOIR, Power Steering Pump

106 Group - T56 Manual Transmission 6 Speed Illustration Title Group - T56 Manual Transmission 6 Speed Group-Fig. No. Transmission Transmission Assembly... Fig. T Case & Extension Case And Extension... Fig. T Transmission Mounting Transmission Mounting... Fig. T Gear Train Gear Train... Fig. T Forks and Rails Shift Forks, Rails, Miscellaneous Parts... Fig. T Gear Shift Controls Gear Shift...Fig. T T Transmission T Gear Shift Controls T Case & Extension T Transmission Mounting T Gear Train T Forks and Rails 1997 SR

107 Transmission Assembly Transmission Assembly Figure T TRANSMISSION ASSEMBLY NOTE; DEC - 6 Spd Manual Trans DEC TRANSMISSION, 6 speed Mopar Automatic Transmission Fluid Quart AC Mopar Automatic Transmission Fluid Gallon

108 Case And Extension Case And Extension Figure T CASE AND EXTENSION NOTE; DEC - 6 Spd Manual Trans DEC CASE, Transmission DEC PLUG, Oil Fill, Drain DEC ADAPTER, Transmission, Front AA 1 DEC CASE, Transmission Rear, Rear DEC STUD, Extension DEC NUT, Transmission Case, Rear Housing DEC DOWEL, Transmission Case, Front Case Adapter Dowel DEC DOWEL, Transmission Case, Hollow DEC SEAL, Input Shaft, Input Shaft DEC BOLT, Transmission Case DEC MAGNET, Transmission DEC BOLT, Transmission Case DEC BREATHER, Transmission Case DEC PLUG, Oil Fill, Front Adapter Inspection DEC VENT, Transmission Pipe DEC CLIP, Vent Tube, Vent Tube DEC SEAL, Extension Yoke, Rear

109 Transmission Mounting Transmission Mounting Figure T CROSSMEMBER, Transmission, Transmission Mounting NUT, Hex Flange Lock, M14x SCREW AND WASHER, Hex Head, M10x1.5x45, w/ WASHER (M10x1.50x45.00) MOUNT, Transmission, Transmission BOLT, M10x1.50x SCREW AND WASHER, M10x1.50x PLATE, Floor Console

110 Gear Train Gear Train Figure T GEAR TRAIN NOTE; DEC - 6 Spd Manual Trans DEC INPUT SHAFT PACKAGE, Transaxle, w/bearing DEC BEARING PACKAGE, Input Shaft DEC STOP RING, Synchronizer, 3rd and 4th Synchro DEC BEARING PACKAGE, Mainshaft, Front DEC SNAP RING DEC STRUT, Synchronizer DEC SPRING, 3rd And 4th Synchronizer DEC GEAR, Third DEC NEEDLE BEARING, Third Gear DEC SPACER, Third Gear DEC BEARING CONE, Idler Gear, Reverse DEC MAINSHAFT, Transmission DEC NEEDLE BEARING, Third Gear, 2nd Speed Needle DEC GEAR, Second DEC SNAP RING, Mainshaft DEC FRICTION CONE, Second Gear Inner DEC FRICTION CONE, Second Gear Inner DEC RING, 1st and 2nd Speed Blocker DEC KEY, Synchronizer DEC SPRING, Synchronizer DEC SNAP RING DEC SNAP RING DEC NEEDLE BEARING, First Gear, 1st Speed Needle DEC GEAR, First DEC BEARING PACKAGE, Mainshaft, Rear DEC THRUST WASHER, First And Second Gear DEC GEAR, Fifth, 5th - 6th Speed Driven DEC STRUT, Synchronizer DEC SPRING, Synchronizer DEC RETAINER, Reverse Syncro

111 Gear Train Figure T DEC WASHER, Reverse Thrust DEC WASHER, Reverse Wave DEC RING, Reverse Blocker DEC SNAP RING DEC NEEDLE BEARING, Reverse Gear DEC GEAR, Reverse DEC WASHER, Reverse Thrust DEC WASHER, Mainshaft DEC NEEDLE BEARING, Mainshaft Rear DEC SNAP RING, Mainshaft, Bearing Race DEC SNAP RING, Mainshaft Rear DEC SNAP RING, Speedo, Yoke Stop DEC ROTOR, Speedometer DEC BEARING PACKAGE, Countershaft, Front DEC GEAR, Cluster DEC BEARING PACKAGE, Countershaft, Rear DEC GEAR, Sixth DEC BEARING, Sixth Gear DEC STRUT, Synchronizer DEC SPRING, Synchronizer DEC STOP RING, Synchronizer DEC SNAP RING DEC GEAR, Countershaft Fifth DEC NEEDLE BEARING, Fifth Gear DEC GEAR, Countershaft DEC BEARING PACKAGE, Mainshaft, Countershaft Extension DEC SPACER, Sixth Gear DEC THRUST WASHER, Sixth Gear DEC FUNNEL, Counter Shaft, Extension DEC IDLER SHAFT, Transmission, Reverse DEC GEAR, Reverse Idler DEC WASHER, Reverse Idler

112 Gear Train Figure T DEC BOLT, Reverse Idler Bracket DEC BRACKET, Reverse Idler Shaft

113 Shift Forks, Rails, Miscellaneous Parts Shift Forks, Rails, Miscellaneous Parts Figure T SHIFT FORKS, RAILS, MISCELLANEOUS S NOTE; DEC - 6 Spd Manual Trans DEC RAIL, Top, Top Shift DEC FORK, Third and Fourth DEC PAD, Shift Fork, 3rd - 4th Shift Fork DEC FORK, First and Second DEC PAD, Shift Fork, 1st - 2nd Shift Fork DEC RAIL, Reverse Shift DEC FORK, Transmission, Reverse DEC PAD, Shift Fork, 5th, 6th and Reverse DEC FORK, Fifth Shift, 5th and 6th Shift DEC PIN, Roll, Reverse Collar DEC COLLAR, Reverse Shift DEC LEVER, Fifth and Sixth, w/ BUSHING DEC LEVER, Reverse DEC PIN, Roll, Reverse Lever DEC PLATE, Shift, 1st - 2nd and 3rd - 4th Shift DEC ARM, Gearshift Selector DEC PIN, Roll, Selector Arm DEC PLATE, Transmission Module, Interlock DEC BOLT, Shift Lever Guide DEC BUSHING, Shift Rail, Top Shift Rail DEC PLATE, Transmission Shifter, Guide 6th Speed DEC LEVER, Offset, Offset Front DEC SPRING, Detent Offset DEC BALL, Check, Offset Detent DEC BOLT, Guide Plate DEC LEVER, First and Fourth DEC PIN, Roll, Skip Shift DEC PIN, Roll, Front Offset Lever DEC SNAP RING, Shift Fork, 5th - 6th Shift Fork DEC BUSHING, Shift Rail, Top Shift Rail DEC SNAP RING, Shift Fork, Reverse Fork

114 Shift Forks, Rails, Miscellaneous Parts Figure T DEC PLATE, Transmission Shifter, Front Shifter Cover DEC BOLT, Shifter Cover, Front Shifter Cover DEC HOUSING, Shift DEC O RING, Shift Detent Housing, Transmission DEC BOLT, Shifter Cover DEC LEVER, Offset, Rear DEC PIN, Roll, Rear Offset Lever DEC SNAP RING, Reverse Inhibitor, Reverse Lockout DEC O RING, Reverse Inhibitor, Manual Transmission, Reverse Lockout DEC LEVER, Gearshift DEC O RING, Shift Detent Housing, Transmission

115 Gear Shift Gear Shift Figure T KNOB, Gearshift 0HD421KA 1 Carmel-Tan 0HD42LX9 1 Flat Black 0HD42SB4 1 Bright Blue 0HD42SR1 1 Red ISOLATOR, Shift Lever NUT, Hex Jam,.50-20, Lock ( )

116 Group - 22 Wheels, Covers and Jacks Illustration Title Group - 22 Wheels, Covers and Jacks Group-Fig. No. Wheels and Hardware Wheels And Hardware...Fig Wheel Covers and Center Caps Caps, Wheel...Fig Jack Stowage Jack Stowage...Fig Spare Tire Stowage Wheel, Spare...Fig Wheels and Hardware Wheel Covers and Center Caps Jack Stowage Spare Tire Stowage 1997 SR

117 Wheels And Hardware Wheels And Hardware Figure WHEEL, Aluminum 0MC25PAK 2 Silver, Front 0MC25PYM 2 Gold, Front 0MC36PAK 2 Silver, Rear 0MC36PYM 2 Gold, Rear 0QV40SZ2AA 2 Polished Aluminum, Front 0QV41SZ2AA 2 Polished Aluminum, Rear NUT, Hex,.50-20, Wheel TOOL, Wheel Cap Removal STEM, Wheel Valve

118 Caps, Wheel Caps, Wheel Figure CAP, Wheel Center 0MC48PAK 4 27 Silver [WFS] 0MC48PYM 4 27 Gold [WFS] 0MC48SY Yellow [WFS] 0PU30SZ2AB 4 Aluminum [WFL]

119 Jack Stowage Jack Stowage Figure WINGNUT, Jack and Tire Hold Down, Jack Hold Down JACK, Scissor -3 BELT, Jack Stowage WRENCH, Wheel Lug Nut TOOL, Wheel Cap Removal LABEL, Tire Storage, Jacking Instructions BAG, Jack Tool Storage, Tool Stowage

120 Wheel, Spare Wheel, Spare Figure WINGNUT, Jack and Tire Hold Down, Tire Hold Down RETAINER, Spare Tire, Spare Wheel Mounting WHEEL, Spare, Mini-Spare, Aluminum BOLT, x3.75, Spare Tire Stowage -5 0LB98SX9AB 1 29 COVER, Spare Tire, Spare Tire

121 Group - 23D Wiper/Lock Cylinder and Keys Illustration Title Group - 23D Wiper/Lock Cylinder and Keys Group-Fig. No. Lock Cylinders and Keys Lock Cylinders and Keys... Fig. 23D Windshield Wiper and Washer Systems Windshield Wiper and Washer...Fig. 23D D-100 Lock Cylinders and Keys 23D-200 Windshield Wiper and Washer Systems 1997 SR

122 Lock Cylinders and Keys Lock Cylinders and Keys Figure 23D-110 LOCK CYLINDERS AND KEYS NOTE: All Lock Cylinders are Uncoded AA 1 29 KEY, Ignition, Snake Head Logo KEY, Blank AA 1 CYLINDER, Ignition Lock TUMBLER, Door and Deck Number 1, Wide, Also Ignition TUMBLER, Door and Deck Number 2, Wide, Also Ignition TUMBLER, Door and Deck Number 3, Wide, Also Ignition TUMBLER, Door and Deck Number 4, Wide, Also Ignition SPRING, Door and Deck Tumbler, Also Ignition CYLINDER, Deck Lid Lock, Also Ignition TUMBLER, Door and Deck Number 1, Wide TUMBLER, Door and Deck Number 2, Wide TUMBLER, Door and Deck Number 3, Wide TUMBLER, Door and Deck Number 4, Wide SPRING, Door and Deck Tumbler CYLINDER, Glove Box Lock TUMBLER, Ignition Number 1, Glove Box Only, Not Ignition TUMBLER, Ignition Number 2, Glove Box Only, Not Ignition TUMBLER, Ignition Number 3, Glove Box Only, Not Ignition TUMBLER, Ignition Number 4, Glove Box Only, Not Ignition SPRING, Lock Cylinder Tumbler, Glove Box Only, Not Ignition NUT, Cylinder Lock GASKET, Key Cylinder Isolator, Decklid,w/Foam CAP, Lock Cylinder, Decklid, Bright GASKET, Lock Cylinder CAP, Ignition Cylinder, Black Plastic SHUTTER, Door, Deck Lid, Black SPRING, Deck Lid Return LEVER, Deck Lid Lock Cylinder

123 Lock Cylinders and Keys Figure 23D MODULE, Keyless Entry Receiver AC 1 Export TRANSMITTER, Keyless Entry AR Export AR STRAP, Module Mounting

124 Windshield Wiper and Washer Windshield Wiper and Washer Figure 23D NUT AND WASHER, Hex Nut-Coned Washer, M8 x 1.25, Wiper Arm Attaching 2 ARM, Wiper Right Left BLADE, Wiper WBW00016AD WB000016AE Mopar Alternative Winter Wiper Blades Mopar V-Line Alternative Part 4 HWV HOSE, Washer And Vacuum, 50 Foot Roll 5/32" CHECK VALVE, Washer CONNECTOR, Washer Hose, In Line SEAL, Wiper Motor 8 MOTOR, Wiper Right Left SCREW, M6x1x25, Wiper Motor Attaching RESERVOIR, Washer CAP, Washer Reservoir, Reservoir SCREW AND WASHER,.25-20x GROMMET, Windshield Washer Pump PUMP, Washer, Windshield, with Seal SWITCH, Windshield Wiper, without Bracket

125 Group - 24 Air Conditioning & Heater Illustration Title Group - 24 Air Conditioning & Heater Group-Fig. No. Air Conditioner and Heater Units Blower Motor...Fig Hevac Unit...Fig Air Conditioner and Heater Plumbing Heater Plumbing...Fig Plumbing, A/C Unit...Fig Air Conditioner and Heater Controls Control Assembly...Fig Air Conditioning Compressor Compressor, A/C...Fig Air Ducts and Outlets Vents And Outlets...Fig Air Conditioner and Heater Units Air Conditioner and Heater Plumbing Air Conditioner and Heater Controls Air Conditioning Compressor Air Ducts and Outlets 1997 SR

126 Blower Motor Blower Motor Figure AB 1 PLENUM, Blower Motor Inlet, Inlet, w/seal, Blower Motor AB 1 SCREW, (NOT SERVICED) AB 1 SCREW, (NOT SERVICED) BLOWER, w/scroll, Blower NUT AND WASHER, Hex Nut-Coned Washer, M6 x RESISTOR, Blower Motor, Motor

127 Hevac Unit Hevac Unit Figure HOUSING, A/C And Heater AB 1 DUCT, A/C And Heater, Recirculating CLIP, Spring COVER, Heater, Actuator ACTUATOR, Heater Door ACTUATOR, Fresh Air Door ACTUATOR, Recirculation Door, Vacuum HARNESS, A/C And Heater Vacuum WIRING, Heater and A/C, Thermostat THERMOSTAT, Air Conditioning BRACKET, Heater Core CORE, Heater, w/seals EVAPORATOR, Air Conditioning VALVE, A/C Expansion, Exspansion SEAL KIT, A/C And Heater Unit, Seal

128 Heater Plumbing Heater Plumbing Figure HEATER PLUMBING NOTE: Sales Codes: EWB = 8.0L V10 SFI VALVE, Water Control CABLE, A/C And Heater Control, Heater Control HOSE, Water Valve To Heater Core, Valve to Core CLAMP, Heater Hose SCREW, x EWB HOSE, Engine to Water Valve EWB HOSE, Heater Core To Engine EWB TUBE, Heater Return, Heater Return AB 2 CLAMP

129 Plumbing, A/C Unit Plumbing, A/C Unit Figure LINE, A/C Suction O RING, A/C Line, 5/8 inch O RING, A/C Line AA 1 VALVE CORE, Service Port CLIP, Wrap Around CAP, A/C Check Valve LINE, A/C Liquid AA 1 O RING, A/C Line, Drier AA 1 O RING, A/C Line, Condenser AA 1 VALVE CORE, Service Port AA 1 CAP, A/C Charge Valve LINE, A/C Discharge O RING, A/C Line CLIP, Discharge Line, 1/2" RECEIVER DRIER, w/bracket DECAL, A/C System Speci cation, English SWITCH, Dual Pressure TUBE, Filter Drier to Evaporator, w/switch, Tube/Harness CONDENSER, Air Conditioning, w/bushings HOSE, Drain, Drain BRACKET, A/C CondenserUpper

130 Control Assembly Control Assembly Figure CONTROL, A/C And Heater, Temperature KNOB, Temperature Control, Serviced in Control, (NOT SERVICED)

131 Compressor, A/C Compressor, A/C Figure COMPRESSOR, A/C NOTE: Sales Codes: EWB = 8.0L V10 SFI EWB COMPRESSOR, Air Conditioning EWB SCREW AND WASHER, Hex Head, x EWB MANIFOLD KIT, A/C Compressor EWB SEAL, Manifold To Compressor AA 1 EWB PULLEY HUB KIT, A/C Compressor EWB CLUTCH OVERHAUL KIT, A/C Compressor EWB COIL, Stator, A/C Compressor Clutch

132 Vents And Outlets Vents And Outlets Figure AIR OUTLET, Heater and A/C, Air Outlet DUCT, Air Outlet, Left, Heater, Left 3 SCREW, Self Tapping, M4.2x1.69x ADAPTER, Defroster Duct, Defroster Duct VENT, A/C Duct Right, Right Duct VENT, A/C Duct Left, Left Duct

133 Group - 25 Emission Systems Illustration Title Group - 25 Emission Systems Group-Fig. No. Emission Labels Emission Labels...Fig Vacuum Canister Vacuum Canister...Fig Emission Harness Emission Harness...Fig Emission Labels Vacuum Canister Emission Harness 1997 SR

134 Emission Labels Emission Labels Figure EMISSION LABELS NOTE: NAA=Federal Emissions. NAE=California Emissions. 1 LABEL, Emission AA 1 Export NAA U.S. NAA Mexico/Canada NAA NAE

135 Vacuum Canister Vacuum Canister Figure AB 1 CANISTER, Vapor BRACKET PACKAGE, Leak Detection Pump NUT, Hex, CAP, Vapor Canister, Dust, STUD, M6X1.00X X BOLT, x1.50, Canister Strap, 1997

136 Emission Harness Emission Harness Figure AC 1 EWB HARNESS, Canister Purge AB 1 HARNESS, Purge Body BRACKET, Duty Cycle Purge Solenoid AB 1 SOLENOID, Duty Cycle Purge NUT AND WASHER, Hex Nut-Sealing Washer, M6 x SCREW AND WASHER, M6x1x ELBOW, Vapor Tube Harness,.25x Degree, Duty Cycle Purge Harness, (90 Degree 1/ 4x1/4), SPACER, Speed Control Servo

137 Group - DSR Doors and Related Parts Illustration Title Group - DSR Doors and Related Parts Group-Fig. No. Front Door Door, Front Shell And Hinges... Fig. DSR Door, Front Glass Viper Fig. DSR Door, Front Glass And Regulator Viper Fig. DSR Door, Front Lock And Controls... Fig. DSR Exterior Mirror Mirrors, Exterior... Fig. DSR Weatherstrips and Seals Door, Front Seals Viper Fig. DSR Door, Front Weatherstrips And Seals Viper Fig. DSR DSR-100 Front Door DSR-500 Exterior Mirror DSR-600 Weatherstrips and Seals 1997 SR

138 Door, Front Shell And Hinges Door, Front Shell And Hinges Figure DSR DOOR, Front, Service Dealer Paint AC 1 29 Right AC 1 29 Left Up to , Right AB 1 27 w/notch for Belt Weatherstrip, Right AC 1 27 After , Right Up to , Left AB 1 27 w/notch for Belt Weatherstrip, Left AC 1 27 After , Left 2 COVER, B Pillar Trim Panel, Stanchion Cover, includes Sealer Tape 0ME74MX Right 0ME75MX Left 0QB96JX8AE 1 27 Right 0QB97JX8AE 1 27 Left BRACKETStanchion Cover, Mounting PUSH PIN, Front Door Glass Run With Weatherstrip, Push WASHER, (NOT SERVICED) SCREW, (NOT SERVICED) HINGE, Front Door SCREW, Pan Head, M8x1.25x SCREW AND WASHER, Hex Head, M8x1.25x NUT, (NOT SERVICED) NUT, Hex, M6x SCREW, Self Tapping, M4.2x1.69x COVER, Hinge Right 1 29 Right Left 1 29 Left AR SPACER, Fender, AR SCREW, (NOT SERVICED)

139 Door, Front Glass Viper 27 Door, Front Glass Viper 27 Figure DSR GLASS, Door Right Left STORAGE KIT, Multipurpose, (NOT SERVICED) SCREW, (NOT SERVICED)

140 Door, Front Glass And Regulator Viper 29 Door, Front Glass And Regulator Viper 29 Figure DSR GLASS, Front Door D 29 Right DD09128GTY D 29 Left Collision Replacement Glass 2 UPSTOP, Front Door Window Glass Glass SCREW AND WASHER, Hex Head, M6x1x20 4 CHANNEL, Front Door Glass Right Left Right Left 5 SCREW, Hex Flange Head, M6x1x NUT AND WASHER, Hex Nut-Coned Washer, M6 x CHANNEL, Door Glass AB 1 29 Right AB 1 29 Left SCREW AND WASHER, Hex Head, M6x1x NUT, Hex, M6x STABILIZER, Door Glass Belt 11 REGULATOR, Front Door Window Right 1 27 Right Left 1 27 Left

141 Door, Front Lock And Controls Door, Front Lock And Controls Figure DSR LATCH, Front Door Right 1 27 Right Left SCREW AND WASHER, Hex Head, M6x1x20, Latch 3 HOUSING, Door Remote Control Right Left 4 SCREW, Pan Head, x D 27 Housing 2 D 29 Housing 5 2 U-NUT, (NOT SERVICED), STRIKER, Door Latch AR SPACER, Door Lock Striker SCREW, Flat Head, M8x1.25x INTERLOCK, Door Restraint AR SPACER, Lower Door Restraint INSULATOR, Restraint System SCREW, Flange Head, M6x1x18, Interlock HANDLE, Inside Release, Manual Overide, Serviced in Trim Panel, (NOT SERVICED) 14 HANDLE, Front Door 0PS20SX Black, Right 0PS20TX Flat Black, Right 0PS21SX Black, Left 0PS21TX Flat Black, Left 1 27 Black, Right 1 29 Flat Black, Right 1 27 Black, Left 1 29 Flat Black, Left 15 NUT PIN, Snap, Switch Att.

142 Mirrors, Exterior Mirrors, Exterior Figure DSR MIRROR, Outside Rearview, Left Side Export Use Service Dealer Paint, Right Service Dealer Paint, Left SCREW, use , (NOT SERVICED),

143 Door, Front Seals Viper 27 Door, Front Seals Viper 27 Figure DSR SEAL, Door Right Left SEAL, Door, Secondary 3 WEATHERSTRIP, A-Pillar to Roof, Body Mounted AE 1 27 Right AE 1 27 Left PIN PUSH,.150x.410, Weatherstrip 5 RETAINER, B Pillar Weatherstrip AB 1 27 Right AB 1 27 Left

144 Door, Front Weatherstrips And Seals Viper 29 Door, Front Weatherstrips And Seals Viper 29 Figure DSR TAPE, Foam, Flange 2 RETAINER, Front Pillar to Glass AB 1 29 Right AB 1 29 Left AB 1 SCREW, (NOT SERVICED) 4 WEATHERSTRIP, Door Glass AB 1 29 Right AB 1 29 Left -5 WEATHERSTRIP, Door Belt Right Left

145 Group - ESR Exterior Ornamentation Illustration Title Group - ESR Exterior Ornamentation Group-Fig. No. Medallions Name Plates... Fig. ESR Decals Decals... Fig. ESR ESR-100 Medallions ESR-300 Decals 1997 SR

146 Name Plates Name Plates Figure ESR MEDALLION, Viper Head, Hood 0JW27M1R 1 27 Red 0JW27M3X 1 27 Black 0JW27S3B 1 27 Blue -2 0QY90HV5AA 2 29 NAMEPLATE, HOOD, GTS, Red -3 0QY89HV5AA 2 27 NAMEPLATE, HOOD, RT/10, Red 4 MEDALLION, Viper Head, Deck Lid 0JW40M1R 1 27 Red 0JW40M3X 1 27 Black 0JW40S3B 1 27 Blue -5 0MB59TV DECAL, GTS-R, Deck Lid, Red -6 NAMEPLATE, Chrysler 0GM69MV Champagne Viper GTS 0GM69SBB 1 27 Blue Viper GTS

147 Decals Decals Figure ESR DECAL, Dodge 0GC54LV Orange Red [RN], Rear Fascia 1 29 Orange Red [RN], Rear Fascia 0GC54SBB 1 29 Blue [BE], Rear Fascia 1 27 Blue [BE], Rear Fascia 2 DECAL, Viper R/T 10 0GC43SW White, VIPER [W1], Rear Fascia 0GC43SX Black, VIPER [X3], Rear Fascia 0MB59SBB 1 29 Blue, VIPER GTS, Rear Fascia 0MB59TV Red, VIPER GTS, Rear Fascia 0GC43LV Orange Red, VIPER [RN], Rear Fascia 0GC43SBB 1 27 Blue [BE], Rear Fascia 3 MEDALLION, Hood 0PF00T1R 1 D 29 Viper Head [RN] 0PF00S3B 1 29 Viper Head [BE] 4 DECAL, VIPER GTS 0MB61SBB 2 29 Blue 0MB61TV Red 5 0QY83HY2AA 2 DECAL, PRANCING SNAKE, GOLD 6 0QY88SY4AA 2 DECAL, PRANCING SNAKE, YELLOW

148 Group - ISR Interior Trim Illustration Title Group - ISR Interior Trim Group-Fig. No. Headliner and Visor Visors And Footrest... Fig. ISR Headliner Viper, Coupe... Fig. ISR Quarter Panels and Scuff Plates Quarter And Rear Bulkhead Panels Viper, Convertible... Fig. ISR Quarter And Rear Bulkhead Panels Viper, Coupe... Fig. ISR Door Sill Scuff Plate... Fig. ISR Carpets, Mats and Insulation Carpet, Front And Rear... Fig. ISR Door Trim Panels-Front Door Panels... Fig. ISR Front Seats Seat, Front... Fig. ISR Seat Belts Front-Outer and Inner Belt - Front Seat-outer... Fig. ISR ISR-100 Headliner and Visor ISR-200 Quarter Panels and Scuff Plates ISR-300 Carpets, Mats and Insulation ISR-400 Door Trim Panels-Front ISR-500 Front Seats ISR-700 Seat Belts Front-Outer and Inner 1997 SR

149 Visors And Footrest Visors And Footrest Figure ISR VISOR, W/Mirror 0LH30SX7 1 D 29 *O0 Black, (Use Up To ), Right 0LH31SX7 1 D 29 *O0 Black, (Use Up To ), Left 0RF481X7AA 1 *O0 Black, (Use After ), Right 0RF491X7AA 1 *O0 Black, (Use After ), Left SCREW, Self Tapping, M4.2x1.69x19.05, Visor Attaching ( x.750) SCREW, ( x.625), (NOT SERVICED) FOOTREST, Panel -5 LABEL, Air Bag Warning AA 1 27 *O0 Dash Warning (Removable) 1 29 *O0 Dash Warning (Removable) AA 1 Canada Only AA 2 English/French 5 Points

150 Headliner Viper, Coupe Headliner Viper, Coupe Figure ISR LC06DX9AB 1 29 *O0 PANEL, Headliner, Black, (Includes Dome Lamp, Not Serviced Separately), Headliner 2 0PB58DX9 1 D 29 *O0 NET, Cargo, Black, Overhead Storage 3 0QE54DX *O0 BEZEL KIT, HEADLINER, Black, Headliner SCREW, Self Tapping, M4.2x1.69x19.05, Attaching, Roof NUT, Push,.19, Attaching, For.190 Screw, Headliner 6 0QK37SX *O0 RETAINER, Headliner, Black

151 Quarter And Rear Bulkhead Panels Viper, Convertible Quarter And Rear Bulkhead Panels Viper, Convertible Figure ISR PANEL, Bulkhead Trim 0LC171X7AB 1 29 *O0 0QB891X7AB 1 27 *O LATCH, Glovebox -3 BOLT, M6.3x *O *O SCREW, Tapping, x1, Tapping x1 5 BEZEL, Seat Belt 0HC76LX *O0 Right 1 27 *O0 Right 0HC81LX *O0 Left 1 27 *O0 Left 6 STRIKER, Glove Box Door Latch *O0 Latch 1 29 *O0 Latch D 29 BUMPER, Console Lid, Lid 8 HINGE, Glovebox D 29 *O0 Lid 1 27 *O0 Lid 9 DOOR, Rear Cargo 0QE531X *O0 Non-Locking 0RE851X7AA 1 29 *O0 Locking 1 27 *O0 Locking 10 PANEL, Quarter Trim 0PS121X7AB 1 27 *O0 Right 0PS131X7AB 1 27 *O0 Left 11 SCREW AND WASHER, Oval Truss Head, x x x NUT/SPRING, "U"1THD, For Screw AA 2 29 PATCH, Floor Pan Rear Corner, Deadener Bulkhead 14 COVER, Quarter Trim Opening 0QV58DX9AB 1 27 *O0 Right

152 Quarter And Rear Bulkhead Panels Viper, Convertible Figure ISR *O0 Right 0QV59DX9AB 1 27 *O0 Left 1 29 *O0 Left

153 Quarter And Rear Bulkhead Panels Viper, Coupe Quarter And Rear Bulkhead Panels Viper, Coupe Figure ISR-215 QUARTER AND REAR BULKHEAD PANELS VIPER, COUPE ACC = GT2 Champion Edition Group 1 BIN, Floor Console D 29 *O0 Bulkhead Top Storage 1 27 *O0 Bulkhead Top Storage 2 PANEL, Bulkhead Trim 0LC171X7AB 1 29 *O0 Includes Items 1 Thru 7 0QB891X7AB 1 27 *O0 Includes Items 1 Thru 7-3 BOLT, M6.3x *O0 M6.3X *O0 M6.3X BEZEL, Seat Belt 0HC76LX *O0 Right 1 27 *O0 Right 0HC81LX *O0 Left 1 27 *O0 Left D 29 BUMPER, Console Lid, Lid 6 STRIKER, Glove Box Door Latch *O0 Latch 1 27 *O0 Latch 7 HINGE, Glovebox D 29 *O0 Lid 1 27 *O0 Lid 8 DOOR, Rear Cargo 0QE531X *O0 Non-Locking 0RE851X7AA 1 27 *O0 Locking, With Latch (P894DX9) LATCH, Glovebox 10 PANEL, Quarter 0QL021X7AC 1 29 *O0 Black, Right 0QL02SX7AC 1 29 *O0 Graphite, Champion Edition (ACC), Right 0QL031X7AC 1 29 *O0 Black, Left 0QL03SX7AC 1 29 *O0 Graphite, Champion Edition (ACC), Left 11 SCREW AND WASHER, Oval Truss Head, x x18x x18x.984

154 Quarter And Rear Bulkhead Panels Viper, Coupe Figure ISR BUMPER, Steel Insert, Steel Insert BRACKET, Quarter Trim SCREW, Pan Head, x1.15, x AA 2 29 PATCH, Floor Pan Rear Corner, Deadener Bulkhead 16 COVER, Quarter Trim Opening 0QV58DX9AB 1 27 *O0 Right 1 29 *O0 Right 0QV59DX9AB 1 27 *O0 Left 1 29 *O0 Left

155 Door Sill Scuff Plate Door Sill Scuff Plate Figure ISR SILL COVER, Interior 0KS20DX9AB 1 *O0 Right 0KS21DX9AB 1 *O0 Left SCREW, Tapping, x AA 8 PLUG, Body,.75 Diameter

156 Carpet, Front And Rear Carpet, Front And Rear Figure ISR QD07SX9 1 *O0 CARPET, Front Floor, 12 ozleft 2 0QD06SX9 1 *O0 CARPET, Front Floor, 12 ozright 3 0LC11DX9 1 D 29 *O0 CARPET, Cargo Side Trim, Cargo Compartment,, Upper 4 0LC12DX9 1 D 29 *O0 CARPET, Luggage Compartment, Cargo Compartment,, Lower AA 2 29 WASHER, Rubber Mount, Rubber Mount 6 0LC07SX7AB 1 29 *O0 PANEL, Cargo Door Header Trim, Cargo, Rear 7 PANEL, Cargo Door Header Trim 0QK42SX *O0 Right 0QK43SX *O0 Left NUT, Push,.19, (For.190 Screw) SCREW, SCREW, x1.00,, (NOT SERVICED) 10 PAD, Bulkhead Spacer SCREW AND WASHER, Oval Truss Head, x NUT, Push,.19, Push

157 Door Panels Door Panels Figure ISR PANEL, Door Trim Front 0QV62TX9AA 1 *O0 (Use Up To ), Right 0QV63TX9AA 1 *O0 (Use Up To ), Left 0QY20TX9AA 1 *O0 With Notch At Door Opening (B-Pillar), Right 0QY21TX9AA 1 *O0 With Notch At Door Opening (B-Pillar), Left 0RT741X7AA 1 *O0 (Use After ), Right 0RT751X7AA 1 *O0 (Use After ), Left 2 BEZEL, Remote Control 0EK02PX9 1 *O0 Right 0EK03PX9 1 *O0 Left NUT, Push,.19, Push SCREW, Self Tapping, M4.2x1.69x SCREW, SCREW, x.500, (NOT SERVICED) 6 COVER, B Pillar Trim Panel 0ME68JX8 1 D 29 *O0 Right 0ME69JX8 1 D 29 *O0 Left 0QB92JX *O0 Right 0QB93JX *O0 Left BUMPER, Steel Insert D 29 SCREW, Pan Head, M5X0.80X SCREW, SCREW, x1.500, (NOT SERVICED) PUSH PIN, Front Door Glass Run With Weatherstrip 11 WATERSHIELD, Front Door Right 1 27 Right Left 1 27 Left 12 BEZEL, Door Trim Panel 0MS38MX4AB 1 *O0 Right 0MS39MX4AB 1 *O0 Left *O0 PIN, Door Panel, Push-In

158 Seat, Front Seat, Front Figure ISR SEAT BACK, Front 0RZ961XKAA 1 27 *O0 Black/Tan (CLXK), Right 0RZ96SX9AA 1 *O0 Black, (CLX9), Right 0RZ971XKAA 1 27 *O0 Black/Tan (CLXK), Left 0RZ97SX9AA 1 *O0 Black, (CLX9), Left 2 0QE61SX9 1 *O0 CUSHION, Front Seat, Complete, Frame, Cover, Pad 3 0QE63SX9 1 *O0 GUIDE, Seat Belt NUT AND WASHER, Hex Nut-Coned Washer, M8 x 1.25, M8x1.25, Rear Seat To Floor Pan Attach SCREW AND WASHER, Hex Head, M8x1.25x25, Seat Track To Floor Riser *O0 PIN, Actuator Front *O0 RECLINER, Seat Back BRACKET, Serv. With Item 2, (NOT SERVICED)

159 Belt - Front Seat-outer Belt - Front Seat-outer Figure ISR SEAT BELT, Front 0MB86SX9 2 D 27 *O0 U.S. and Canada 2 D 29 *O0 U.S. and Canada 0PD74RX9 2 *O0 Export SCREW, Pan Head, x SPACER, Seat Belt Retainer SCREW, Pan Head, x SEAT BELT, Buckle Half Right Left SCREW, Pan Head Shoulder, x1.87, (Included With Buckle) -7 RETAINER PACKAGE, Child Seat Tether *O0 Hardware Package, Child Seat 1 27 *O *O0 Hardware Package, Child Seat *O0 EXTENDER, Seat Belt

160 Group - SSR Body Sheet Metal Except Doors SSR-1000 Splash Shields SSR-1100 Roof - Hard & Folding Top SSR-1300 Deck Lid SSR-1400 Rear Shelf Panel SSR-200 Floor Pan SSR-400 Fender SSR-500 Hood & Hood Release SSR-600 Cowl and Dash Panel SSR-700 Glass, Windshield, Backlite, Mirror SSR-900 Quarter Panel 1997 SR