COLUMN DESCRIPTIONS AND FUNCTIONS: COL # LENGTH TUBING TYPE COLUMN DESCRIPTION L1-1A 5M METAL CAP 1.0um MXT-WAX MM METAL CAP L1-1B 60M METAL CAP

Transcription

1

2

3

4

5

6

7

8

9 COLUMN DESCRIPTIONS AND FUNCTIONS: COL # LENGTH TUBING TYPE COLUMN DESCRIPTION L1-1A 5M METAL CAP 1.0um MXT-WAX MM METAL CAP L1-1B 60M METAL CAP 1.5um MXT MM METAL CAP FUNCTION OF COLUMN COMPLETES SEPARATION COMPLETES SEPARATION Siemens Applied Automation REV. CODE COLUMN DESCRIPTIONS AND FUNCTIONS 1 USER PURCHASER SHEET PAGE CSPC SHELL EOEG PROJECT SIEMENS PTE LTD NO of 1 LOCATION TAG P.O. PROJECT JOB NANHAI, CHINA 310QIA-691-TX

10

11

12 NOTES: UNLESS OTHERWISE SPECIFIED 1. CYCLE TIME: APPLICATION METHOD CYCLE CLOCK NUMBER NUMBER (SECONDS) STREAM COMPOSITION(S), REPEATABILITY IS EXPRESSED AS PERCENT OF FULL SCALE: STREAM 1 : DEG CONCENTRATION CAL METHOD RESULT COMPONENT NORMAL RANGE UNITS REPEATABILITY DET. STREAM NO. ORDER DIETHYLENE GLYCOL PPMW 1 L_FID TRIETHYLENE GLYCOL 99.4 WT% 1 1 TETRAETHYLENE GLYCOL PPMW 1 L_FID Siemens Applied Automation REV. CODE 1 STREAM COMPOSITION DATA USER PURCHASER SHEET PAGE CSPC SHELL EOEG PROJECT SIEMENS PTE LTD NO of 1 LOCATION TAG P.O. PROJECT JOB NANHAI, CHINA 310QIA-691-TX

13 PART NO. ITEM DESCRIPTION STANDARD PARTS AND KITS Power Entry and Control Module (PECM) with 2 Temperature Controllers and SVCM Control Filter, Power Supply Line Assembly PCBA, PECM Control Board PCBA, PECM SSR Board Fuse Kit Solid State Relay Kit PECM to SSR Cable and Connector Kit Cable Harness Kit Power Supply Module for GC, with Cables Maintenance Panel Kit Level 2 - Universal Kit, Syscon Plus with flash Termination, CAN Bus Memory Replacement Module; 32k-bytes Dynamic RAM EPC Module Complete with Manifold and Seals Wiring Distribution Board Internal Ethernet Cable Kit Purge Control Assembly Module Fan, 24vdc, 0.26amp, modified Regulator & Gauge, Module Regulator & Gauge, Module Fitting Kit Gasket and Seal Kit Hardware Kit Solenoid Valve Control Module with o-rings (no electronics) Solenoid Kit Solenoid tube manifold kit Fitting, Ferrule, 1/16"T, SST, Valco, (ZF1) LDV Fitting, Nut, 1/16"T, SST, Valco, (ZN1) LDV Syscon Battery, Lithium, 3.6V/2.4A-h, AA size SNECON board T-Limit Resistor Board for unused heater circuits, 12.4K Ohms Compact Flash Memory, 64 MB, type PCBA IC2 ISA IF BD Cable, IDE, 19" for Compact Flash Siemens Applied Automation Rev. Code 0 SPARE PARTS LIST USER PURCHASER SHEET NO. PAGE CSPC SHELL EOEG PROJECT SIEMENS PTE LTD Sheet 10.1 PAGE 1 LOCATION Tag P.O. PROJECT SERIAL NO. NANHAI CHINA 310QIA-691-TX

14 PART NO. ITEM DESCRIPTION CUSTOM PARTS FOR THIS PROJECT SYSCON TO MMI WITH SHIELD - for CE areas APU, 230 VAC, WITHOUT ENCLOSURE FUSE, EX, 230VAC, 200MA SWITCH, APU CABLE/SWITCH/LED DISCONNECTOR UNIT, 8 RELAYS, VAC DISCONNECTOR UNIT, 16 RELAYS, VAC RELAY, POWER, EEX ME, 4 POLE N/O KIT, APU, PROPORTIONAL VALVE 230V FID, 302A ASSEMBLY MODULE, IGNITION, FID / FPD KIT, SEAL, FID MAXUM II KIT, FILTER FID MAXUM II KIT, QUARTZ JET, FID MAXUM II RESTRICTOR, COMBUSTION AIR, SS RESTRICTOR, ADMIXED AIR, SS RESTRICTOR, HYDROGEN, SS INSERT ASS'Y,302, FLAME ARRESTOR FLAME ARRESTER, 302, OUTPUT CABLE, FID SIGNAL RTD, Push-IN Style Heater, 1" Cartridge, 220V HEATER, FID/FPD, 220V, ASSEMB PCBA,MEZ,ELECTR0,1NA/20NA DUAL RGE FID Cable, Ignition, DPM Extension Detector, Filament, 2-Cell Cable, Assy, MI 4-Wire (Filament Detector) KIT, 2-CELL, FILAMENT RTD probe, bare element, 100 ohm for PTGC IS Barrier assembly for bare RTD probe in PTGC Siemens needle valve kit, low temp (PTFE ferrule system) Siemens needle valve kit, hi temp (graphite ferrule system) SLIV (US Version), deep inj, 0.6uL, glass liner in vaporizing chamber Glass liner for SLIV valves Piston & Plunger, Groove, 0.6 ul, SS SAA LIV Seal, PTFE/Glass (15%), C - DEFAULT VALVE SEAL SLIV O-Ring Kit ( 10 small, 20 large, 5 Belleville Springs) SAA LIV Glass Liner, Deep Injection, Glass Sample Passage, LIV, 1/8", SS V Heater Block (includes RTD's and heater) slotted tube to adapt US version SLIV to heater block Gasket Siemens Applied Automation Rev. Code 0 SPARE PARTS LIST USER PURCHASER SHEET NO. PAGE CSPC SHELL EOEG PROJECT SIEMENS PTE LTD Sheet 10.1 PAGE 2 LOCATION Tag P.O. PROJECT SERIAL NO. NANHAI CHINA 310QIA-691-TX

15 PART NO. ITEM DESCRIPTION Fitting: oven to EC, Male connector, 3/8"T x 9/16-18, SST Nut (where power and RTD lines enter EC from oven) Power connector RTD connector Power cable SNE - RTD cable Pressure Regulator, Low Flow, 5-60 PSI 1/8" NPT Ports, (Masoneilan) F, FTun... R28010 Pressure Regulator, 250 lb. Max.Inlet/0-125 PSI, Outlet, ¼" NPT Inlet & Outlet 2 1/8" NPT Outlet Ports, Reference Flow Restrictor for carrier gas to detector reference KIT, RELAY, SOLID STATE, MAXUM II Air Bath Heater II Assembly Heater, Farnam 1400W 115/230V PROBE, DUAL RTD, AIRFLOW, 100 OHM,W/BEND Probe, RTD 100ohm, 1/8T, 14" leads, 3 wire PCBA, DPM CONNECTOR BOARD, ASSY PCBA, Base DPM for all detectors except TCD Valve Rotor, Internal loop, 0.2 / 0.5 ul, Valcon P K T-Limit Board SPECIAL COLUMN, L1-1A, (RESTEK # ), PART # SUPPLIES 3 COLUMNS COLUMN, L1-1B Siemens Applied Automation Rev. Code 0 SPARE PARTS LIST USER PURCHASER SHEET NO. PAGE CSPC SHELL EOEG PROJECT SIEMENS PTE LTD Sheet 10.1 PAGE 3 LOCATION Tag P.O. PROJECT SERIAL NO. NANHAI CHINA 310QIA-691-TX