CHAPTER 4 PARTS PARTS BY PICTORIAL. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation.

Size: px

Start display at page:

Download "CHAPTER 4 PARTS PARTS BY PICTORIAL. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation."

Melvin Paul
6 years ago
Views:

1 CHAPTER 4 PARTS PARTS BY PICTORIAL This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. NOTE: The following is a breakdown description for Serial Numbers: Serial Number Location - Rear Cabinet top right hand side. Example: 0194B Month MFG. 94 Year MFG. B Serial Rev Number of Units Built. SERIAL B SOFTWARE STARTS WITH 2. XX ON POWER UP. KEY NS = Not Shown * = Ford # = Crysler 12/98 Page 4-1

2 FRONT VIEW ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. Headsign, Sun Decal Label, Service Control Panel, Assy. See Page 4-5 8a. Master Filter Kit R Suction Separator See Page 4-9 8b. Master Filter Kit (R134a)½ Moisture Indicator Latch a. Caster, W / Brake (Post) N.S.* Desiccant Bags (Qty. 10) b. Caster, W / Brake (Bolt) N.S.* Master Filter Drier Switch, Service N.S.* Gasket NOTE: * = Included in Master Filter Kit NOTE: Casters for Sun version use shaft type. Casters for Snap-On version use post type. 12/98 Page 4-2

3 WARNG CAUTION CHAPTER 4 PARTS (B) REAR VIEW MACHE MUST BE LEVEL TO OPERATE PROPERLY FOR USE WITH R134a ONLY HIGH LOW VIRG & OIL TANKS MOUNTED UPSIDE DOWN ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. Label, "Caution Vent" a. Heater Blanket, 110VAC Label, "French Use of" b. Heater Blanket, 220VAC Label, "Caution Use of" Bumpers Bracket Switch, Tank (2) Label, "Service Procedure" Connector, CPC 4 Pin Label, "Warning" Label, Info Guide Fitting, R12 Bulkhead * Label, R134a ONLY Fitting, R134a Bulkhead Label, Caution Sensor, Temperature Label, Eye Warning a. Strap, Right (30 lb.) Switch, On/Off/ b. Strap, Right (50 lb.) A.C. socket c. Strap, Left Latch a. Caster, W/O Brake, (Shaft) a. Tank, 30 lb. R b. Caster, W/O Brake, (Bolt) b. Tank, 50 lb. R a. Bracket, Oil c. Tank, 30 lb. R134a b. Screw, Thumb d. Tank, 50 lb. R134a a. Cyl. Disposable Oil Switch, Double Float b. Cyl. FORD Oil a. Filter, R12 Inline c. Cyl. R134a Polyol Ester Oil EAK0163L00A 30b. Filter, R134a Inline a. Load Cell Cable, Tank Float b. Mount, Shock (4) N.S. Cord, A.C Switch, Oil N.S. Probe, Temp. (Vehicle) Fitting, 90 Degree /98 Page 4-3

4 HP TRANS LP TRANS HP CO PRG TRANS LP CO CHAPTER 4 PARTS (B) TOP VIEW OF PUMP COMPARTMENT MT1 2 1 ROTATION ROTATION LET OUTLET OIL MT2 MT3 7 11a OUTLET b LET OUT OIL ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. Condenser c. Relay (On Pump 110v) a. Fan, Axial (115v) d. Relay (On Pump 220v) b. Fan, Axial (220v) e. Resistor Connector, 14 Pin Switch, (Momentary) Board, Plumbing a. Oil Reservoir, Temprite Manifold Block See Page b. Oil Separator, Small a. Compressor (110) Solenoid, Separator b. Compressor (220) Fitting, Tubo Board, Relay Elbow, 90º a. Capacitor, Start (110v) Nipple, Hex b. Capacitor, Start (220v) NS. Kilxon Overload Protector a. Cap (Pump Relay 110v) NS. Compressor Oil GS/300 viscosity (24oz.) 9b. Cap (Pump Relay 220v) /98 Page 4-4

5 HOLD/ENTER RESTART AUTO RECLAIM CANCEL AMOUNT TEMP SEQUENCE ONLY RECLAIM FULL RECLAIM EMPTY VACUUM TIME HOLD-TIME CHARGE AMOUNT AUTO SEQUENCE RECLAIMG VACUUM VACUUM HOLD CHARGG TEMPERATURE AMOUNT PROGRESS COMPLETED HOLD RECLAIM FULL RECLAIM EMPTY VACUUM TIME HOLD-TIME CHARGE AMOUNT AUTO SEQUENCE RECLAIMG VACUUM VACUUM HOLD CHARGG TEMPERATURE AMOUNT PROGRESS COMPLETED HOLD UP DOWN ON/OFF HOLD/ENTER RESTART UP DOWN CANCEL AMOUNT TEMP ON/OFF CHAPTER 4 PARTS (B) TOP OF HEADFRAME SUCTION PRESSURE OUTLET TEMPERATURE TANK ENTER FUNCTION STATUS DISCHARGE PRESSURE AMBIENT TEMPERATURE 12 HOLD FUNCTION VALUE ADJUSTPOWER UNDER CONTROL PANEL MRC/MTC CONTROL PANEL SUCTION PRESSURE DISCHARGE PRESSURE Snap-on 13 OUTLET TEMPERATURE AMBIENT TEMPERATURE TANK 5 2a 2b 2c ENTER FUNCTION HOLD CONTROLS VALUE ADJUST FUNCTION POWER STATUS AUTO SEQUENCE RECLAIM ONLY ACT CONTROL PANEL 1 3 TOP VIEW 4 ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1a. Power Supply (110V.A.C.) W. H. (Rt. Display) b. Power Supply (220V.A.C.) Board, Led Driver c. Power Supply (100V.A.C.) W.H. (Led Display) a. Fuse, F1 (.25 amp) Board, Processor b. Fuse, F2 (1 amp) W.H. (Left Display) c. Fuse, F3 (3 amp) a. Control Panel MRC Alarm b. Control Panel MRC Transformer Control Panel, Snap-on a. Varistor (115 V) N.S. Cord, A.C b. Varistor (220 V) N.S. Pem-Nut Board, LCD Driver /98 Page 4-5

6 MANIFOLD BLOCK ASSEMBLY PUMP S5 9 LP CO Prg. Trans S4 MT3 S6 S14 S1 S3 S7 8 5 HP CO HP Trans MT1 MT2 Low Pres. Trans ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. Manifold Transducer, Low Pres Solenoid, N.C Transducer, Purge Pres * Solenoid, N.O.(S7 X-Over) Switch, High Pressure * Solenoid, N.C. (Purge) Switch, Low Pressure Transducer, High Pressure N.S. Plunger, (In Solenoid) * Refers to Feed Through N.S. Allen Screw (Qty.=5) Close to Scale ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. O-Ring (Tiny S7) O-Ring 2oz O-Ring (Small) NS O-Ring Block Kit (Qty 42) O-Ring (Medium) NS Screw, Phillips O-Ring (Large) NS Permabond O-Ring (Front Blocks) NS Super Lube, 3 oz /98 Page 4-6

7 HOSE PART NUMBERS Hand Valve H11 V1 H12 H13 LOW PRESSURE TRANSDUCER 30"HG PSI TO LOW PRESSURE HOSE T1 S6 VACUUM NC S7 CROSSOVER NO HIGH PRESSURE TRANSDUCER 30"HG PSI HIGH PRESSURE CUTOFF - N.C. OPEN AT 375 PSI T2 TO HIGH PRESSURE HOSE T3 T4 CHECK VALVE S9 VIRG CHECK VALVE S8 OIL CHECK VALVE S10 RECLAIM PURGE TRANSDUCER 30"HG to 500 PSI S14 PURGE S3 VENT LOW PRESSURE CUTOFF - N.O. CLOSES AT 20 PSI NC NC NC NO NC SUCTION SEPARATOR NC S12 "0" NC VENT FROM BLOCK S13 LIQUID S1 CONDENSER NC BYPASS (not used) NC S5 SUCTION SEPARATOR NC H6 MOISTURE DICATOR H1 H10 H9 OIL BOTTLE H8 LIQUID H7 VAPOR H5 CONDENSER T6 T5 PRESSURE H2 VACUUM PUMP VACUUM VIRG TANK MASTER FILTER H4 OUT S4 OIL RETURN H3 RECLAIM TANK RETURN OIL SEPARATOR/RESERVOIR NC SCALE ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER T1 Tube (Aluminum) H8a Hose, 37 R-12 Blue T2 Tube (Aluminum) H8b Hose, 37 R-134a Blue T3 Tube (Aluminum) H9a Hose, 33 R-12 Yel T4 Tube (Aluminum) H9b Hose, 33 R-134a Yel T5 Tube (Aluminum) H10a Hose, 46 R-12 Blue T6 Tube (Aluminum) H10b Hose, 46 R-134a Blue H1 Hose, 18: Red H11a Hose, 96 Blue (90º) H2 Hose, 24 Red H11b Hose, 96 Red (90º) H3 Hose, H12a Hose, 10 Blue H4a Hose, 22 R-12 Blue H12b Hose, 10 Red H4b Hose, 22 R-134a Blue H13a Hose, 96 Blue (90º) EAH0001C02A H5a Hose, 22 R-12 Blue H13b Hose, 96 Red (90º) EAH0001C01A H5b Hose, 22 R-134a Blue V1 Valve, Hand H6a Hose, 36 R-12 Red N.S. R134a Utility (36 ) H6b Hose, 36 R-134a Red N.S. R134a Utility (8 ) H7a Hose, 46 R-12 Red H7b Hose, 46 R-134a Red NOTE: The first production run of MRC-450 s (0093) were made with ¼ flare fitting, this kit will update unit to current level. 12/98 Page 4-7

ADAPTERS / FITTGS GM ADAPTER FORD ADAPTER 0647-0196-01 0647-0200-01 LARGE GM ADAPTER QUICK DISCONNECT GM/FORD ADAPTER QUICK DISCONNECT 0647-0199-01 0647-0197-01 O-RG 0617-0212-01 SCREEN 0301-0951-01

8 ADAPTERS / FITTGS GM ADAPTER FORD ADAPTER LARGE GM ADAPTER QUICK DISCONNECT GM/FORD ADAPTER QUICK DISCONNECT O-RG SCREEN LE FILTER FILTER WRENCH (R-12) (R134a) HIGH HIGH LOW LOW O-Ring Kit EAK0027C00AS O-Ring Kit ARG /98 Page 4-8

9 SUCTION SEPARATOR VIEW ITEM DESCRIPTION EQUI SERV # 1. Cap and shield Fitting, nipple Atomizer Fitting a. Float Switch Assembly b. Float Plate Fitting, nipple Gasket, Bowl Thumbscrew Washer Ring, Mounting Bowl Bowl, Suction Separator (Aluminum) Gauge, Liquid Level O-Ring, Bottom Cap Bowl, Bottom Cap Bowl Kit, Metal (Solid bowl) EAK0071C00AS 12/98 Page 4-9

10 PARTS ALPHABETICAL ORDER NAME PART NUMBER COMMENTS Adapter, FORD X Standard Screw Fitting Adapter, GM X Standard Screw Fitting Adapter, GM X Quick Disconnect Adapter, GM/FORD X Quick Disconnect Adapter, High X Uniweld Adapter, Low X Uniweld Alarm X X Board, LCD Driver X X Board, Led Driver X X Board, Plumbing X X Board, Processor X X Board, Relay X X Bowl X X Bowl, Separator X X Bowl, Bottom Cap X X Bowl, Metal Kit EAK0071C00AS X X Bracket X X Rear Hose Bracket, Oil X X Bumpers X X Fitting, Bulkhead X Fitting, Bulkhead X Cable, Tank Float X X Cap and Shield X X Top of S. S. bowl Capacitor X X (Pump Relay 110v) Capacitor X X (Pump Relay 220v) Capacitor, Start X X (110v) Capacitor, Start X X (220v) Caster, W / Brake X X Caster, W/O Brake X X Caster, W / Brake X X Caster, W/O Brake X X Compressor X X (110) Compressor X X (220) Compressor Oil X X 3GS/300 viscosity (24oz.) Condenser X Connector, 14 Pin X Connector, CPC 4 Pin X Control Panel X MRC-400 Control Panel X MRC-450 Control Panel X X ACT-4100/ACT-4500 Cord, A.C X X Crush Washer X X Copper Cylinder, Disposable Oil X Cylinder, FORD Oil X Desiccant Bags X (Qty. 10) Desiccant Bags X (Qty. 10) Elbow, 90º X X Fan, Axial X X (115v) Fan, Axial X X (220v) Filter, Inline X ¼ Flare Filter, Inline X ½ Acme Fitting, 90 Degree X X Fitting, Atomizer X X Fitting, nipple X X In S. S. bowl 12/98 Page 4-10

11 NAME PART NUMBER COMMENTS Fitting, Tubo X X Fitting, nipple X X In S. S. bowl Float X X Fuse, F X X (.25 amp) Fuse, F X X (1 amp) Fuse, F X X (3 amp) Gasket X X Gauge, Liquid level X X Metal Bowl Headsign, Sun Decal X X Heater Blanket, X X 110VAC Heater Blanket, X X 220VAC Hose, 10 Blue X X Vehicle Hose Hose, 10 Red X X Vehicle Hose Hose, 18 Red X X Input Side of Compressor Hose, 22 R-12 Blue X Output Side of Master Filter Hose, 22 R-12 Blue X Input Side of Master Filter Hose, 22 R-134a Blue X Input & Output Side of Master Filter Hose, 24 Red X X Output Side of Compressor Hose, 33 R-134a Yel X Output Side of Oil Cylinder, R134a Hose, 33 R-12 Yel X Output Side of Oil Cylinder, R12 Hose, 36 R-12 Red X Output Side of Moisture Indicator Hose, 36 R-134a Red X Output Side of Moisture Indicator Hose, 37 R-12 Blue X Output Side of Recovery Tank Hose, 37 R-134a Blue X Output Side of Recovery Tank Hose, 46 R-12 Blue X Output Side of Virgin Tank Hose, 46 R-12 Red X Input Side of Recovery Tank Hose, 46 R-134a Blue X Output Side of Virgin Tank Hose, 46 R-134a Red X Input Side of Recovery Tank Hose, 96 Blue (90º) X Vehicle Hose Hose, 96 Blue (90º) EAH0001C02A X Vehicle Hose Hose, 96 Red (90º) X Vehicle Hose Hose, 96 Red (90º) EAH0001C01A X Vehcile Hose Indicator, Moisture X X Inlet Tube X X Kit, Master Filter X Filter, 10 Desiccant Bags, & O-Ring Kit, Master Filter X Filter, 10 Desiccant Bags, & O-Ring Kit, O-Ring ARG04040 X For R-134a Adapters -09/-10 Kit, O-Ring EAK0027C00AS X For R-134a Adapters -07/-08 Label X R134a ONLY Label X X "Caution Use of" Label X X "Warning" Label X X "Service Procedure" Label X X Info Guide Label X X "Caution Vent" Label X X "French Use of" Label X X Eye Warning Label X X Caution Latch X X Load Cell X X Master Filter Drier X Master Filter Drier X Mount, Shock X X Qty. (4) Nipple, Hex X X O-Ring X X (Tiny S7) O-Ring X X (Small) O-Ring X X (Medium) O-Ring X X (Large) CHAPTER 4 PARTS (B) 12/98 Page 4-11

12 NAME PART NUMBER COMMENTS O-Ring X X Between the front 2 blocks O-Ring X X O-ring kit for entire block, Qty. 42 O-Ring X Inline hand valve O-Ring X 2 ounce oil charge cylinder O-Ring, Bottom of bowl X X Metal bowl Permabond X X Plate X X In S. S. bowl Power Supply X X (110V.A.C.) Power Supply X X (100V.A.C.) Power Supply X X (220V.A.C.) Probe, Temp X X (Vehicle) Relay X X (On Pump 220v) Relay X X (On Pump 110v) Resistor X X Screw, Phillips X X Screw, Thumb X X Oil Bracket Sensor X X Temperature Solenoid X X Normally Closed Solenoid X X Normally Open; (S7 Xover / S14 Purge) Solenoid, Separator X X Strap, Velcro X X Left Strap, Velcro X X Right (30 lb.) Strap, Velcro X X Right (50 lb.) Suction Separator X X Super Lube X X 3 oz. Switch X X Low Pressure Switch X X High Pressure Switch X X Double Float Switch X X (Momentary) Switch X X Service Switch X X Tank (2) Switch X X On/Off Switch X X Oil Switch X X Float Tank, Recovery X 30 lb. Tank, Recovery X 50 lb. Tank, Recovery X X Vehicle temperature probe Thumbscrew X X Metal Bowl Tank, Recovery X 50 lb. Temperature Probe X X Vehicle Transducer X X Low Pressure Transducer X X High Pressure Transducer X X Purge Pressure Transformer X X Tube (Aluminum) X X To Low Pressure Side Tube (Aluminum) X X To High Pressure Side Tube (Aluminum) X X Input Side of Condenser Tube (Aluminum) X X Output side of Oil Separator Tube (Aluminum) X X Input Side of Suction Separator Bowl Tube (Aluminum) X X Output Side of Suction Separator Bowl Valve, Hand X Varistor X X (115 V) Varistor X X (220 V) Wrench, Filter X X Washer X X Metal bowl 12/98 Page 4-12

13 PARTS NUMERICAL ORDER CHAPTER 4 PARTS (B) NAME PART NUMBER COMMENTS Wrench, Filter X X Condenser X Cylinder, Disposable Oil X Cylinder, FORD Oil X Relay X X (On Pump 220v) Relay X X (On Pump 110v) Capacitor, Start X X (110v) Capacitor, Start X X (220v) Solenoid, Separator X X Solenoid X X Normally Closed Solenoid X X Normally Open; (S7 Xover / S14 Purge) Alarm X X Gauge, Liquid level X X Metal Bowl Bowl X X Bowl, Separator X X Bowl, Bottom Cap X X Washer X X Metal bowl Screw, Phillips X X Strap, Velcro X X Left Strap, Velcro X X Right (30 lb.) Strap, Velcro X X Right (50 lb.) Transducer X X Low Pressure Transducer X X High Pressure Transducer X X Purge Pressure Heater Blanket, X X 110VAC Heater Blanket, X X 220VAC Float X X Switch X X Low Pressure Switch X X High Pressure Mount, Shock X X Qty. (4) Fan, Axial X X (115v) Fan, Axial X X (220v) O-Ring X X (Tiny S7) O-Ring X X (Small) O-Ring X X (Medium) O-Ring X X (Large) O-Ring X X Between the front 2 blocks O-Ring X X O-ring kit for entire block, Qty. 42 O-Ring X Inline hand valve O-Ring X 2 ounce oil charge cylinder O-Ring, Bottom of bowl X X Metal bowl Permabond X X Elbow, 90º X X Adapter, GM X Standard Screw Fitting Adapter, GM/FORD X Quick Disconnect Fitting, 90 Degree X X Adapter, GM X Quick Disconnect Adapter, FORD X Standard Screw Fitting Fitting, Tubo X X Fitting, Bulkhead X Fitting, Bulkhead X Adapter, Low X Uniweld Adapter, High X Uniweld Crush Washer X X Copper Desiccant Bags X (Qty. 10) Desiccant Bags X (Qty. 10) 12/98 Page 4-13

14 NAME PART NUMBER COMMENTS Screw, Thumb X X Oil Bracket Compressor Oil X X 3GS/300 viscosity (24oz.) Super Lube X X 3 oz. Label X R134a ONLY Label X X "Caution Use of" Headsign, Sun Decal X X Label X X "Warning" Label X X "Service Procedure" Label X X Info Guide Label X X "Caution Vent" Label X X "French Use of" Label X X Eye Warning Label X X Caution Resistor X X Fuse, F X X (1 amp) Fuse, F X X (3 amp) Fuse, F X X (.25 amp) Switch X X Double Float Switch X X (Momentary) Switch X X Service Switch X X Tank (2) Thumbscrew X X Metal Bowl Kit, Master Filter X Filter, 10 Desiccant Bags, & O-Ring Kit, Master Filter X Filter, 10 Desiccant Bags, & O-Ring Bumpers X X Switch X X On/Off Switch X X Oil Caster, W/O Brake X X Caster, W / Brake X X Caster, W/O Brake X X Caster, W / Brake X X Hose, 10 Red X X Vehicle Hose Hose, 10 Blue X X Vehicle Hose Hose, 33 R-12 Yel X Output Side of Oil Cylinder, R12 Hose, 22 R-134a Blue X Input & Output Side of Master Filter Hose, 46 R-134a Red X Input Side of Recovery Tank Hose, 37 R-134a Blue X Output Side of Recovery Tank Hose, 46 R-134a Blue X Output Side of Virgin Tank Hose, 36 R-134a Red X Output Side of Moisture Indicator Hose, 18 Red X X Input Side of Compressor Hose, 24 Red X X Output Side of Compressor Hose, 96 Blue (90º) X Vehicle Hose Hose, 96 Red (90º) X Vehicle Hose Hose, 22 R-12 Blue X Output Side of Master Filter Hose, 46 R-12 Red X Input Side of Recovery Tank Hose, 37 R-12 Blue X Output Side of Recovery Tank Hose, 46 R-12 Blue X Output Side of Virgin Tank Hose, 36 R-12 Red X Output Side of Moisture Indicator Hose, 22 R-12 Blue X Input Side of Master Filter Hose, 33 R-134a Yel X Output Side of Oil Cylinder, R134a Gasket X X Connector, CPC 4 Pin X Connector, 14 Pin X Fitting, nipple X X In S. S. bowl Fitting, nipple X X In S. S. bowl 12/98 Page 4-14

15 NAME PART NUMBER COMMENTS Plate X X In S. S. bowl Valve, Hand X Latch X X Cord, A.C X X Cable, Tank Float X X Probe, Temp X X Vehicle Temperature Probe X X Vehicle Board, LCD Driver X X Board, Led Driver X X Board, Processor X X Board, Relay X X Board, Plumbing X X Control Panel X MRC-400 Control Panel X MRC-450 Control Panel X X ACT-4100/ACT-4500 Varistor X X (115 V) Varistor X X (220 V) Master Filter Drier X Switch X X Float Suction Separator X X Compressor X X (110) Compressor X X (220) Power Supply X X (110V.A.C.) Power Supply X X (100V.A.C.) Power Supply X X (220V.A.C.) Tank, Recovery X 30 lb. Tank, Recovery X 50 lb. Tank, Recovery X X Vehicle temperature probe Tank, Recovery X 50 lb. Transformer X X Load Cell X X Indicator, Moisture X X Capacitor X X (Pump Relay 110v) Capacitor X X (Pump Relay 220v) Sensor X X Temperature Filter, Inline X ¼ Flare Filter, Inline X ½ Acme Master Filter Drier X Tube (Aluminum) X X To Low Pressure Side Tube (Aluminum) X X To High Pressure Side Tube (Aluminum) X X Input Side of Condenser Tube (Aluminum) X X Output side of Oil Separator Tube (Aluminum) X X Input Side of Suction Separator Bowl Tube (Aluminum) X X Output Side of Suction Separator Bowl Bracket X X Rear Hose Bracket, Oil X X Cap and Shield X X Top of S. S. bowl Fitting, Atomizer X X Kit, O-Ring ARG04040 X For R-134a Adapters -09/-10 Hose, 96 Red (90º) EAH0001C01A X Vehcile Hose Hose, 96 Blue (90º) EAH0001C02A X Vehicle Hose Kit, O-Ring EAK0027C00AS X For R-134a Adapters -07/-08 Bowl, Metal Kit EAK0071C00AS X X 12/98 Page 4-15

16 12/98 Page 4-16

17 All information contained or disclosed in this document is considered confidential and proprietary by Sun Electric Corporation. All manufacturing, use, reproduction and sales rights are reserved by Sun Electric Corporation and the information contained herein shall not be used in whole or in part without the express written consent of Sun Electric Corporation. MA POWER SWITCH CIRCUIT BREAKER 1 TB1 1 T1 TRANSFORMER H2 PROCESSOR BD J2 H3 J1 LCD BD (LEFT) LED BOARD AC PLUG 3 H1 LE FILTER 4 5 J4 J5 H4 J1 2 6 HEATER BLANKET FAN FAN 2 J1 H5 ALARM H20 H20 H19 K1 K2 J8 H6 J1 H H H H H H H H H H H H H H H H H H H H COMPRESSOR ASSY. PROTECTOR C S M K1 3 C1 1 2 C2 R1 RELAY BD. J H18 S H17 HIGH PRESS. SWITCH H16 H16 J12 J4 J7 J7 J3 J6 H9 H8 H7 J1 J5 J8 PLUMBG BD J11 J2 J3 LCD BD (RIGHT) H10 H10 H10 H13 H13 H13 H13 H11 H11 HIGH PRESSURE TRANSDUCER LOW PRESSURE TRANSDUCER PURGE PRESSURE TRANSDUCER SS PRESSURE SWITCH SS FLOAT SWITCH SUCTION SEPARATOR SERVICE SWITCH OIL ON VIRG ON H12 EXTERNAL TEMPERATURE PROBE H15 P9 H14 J9 J10 J13 H11 RECOVERY ON LOAD CELL TEMPERATURE SENSOR RECOVERY TANK SUN ELECTRIC CORPORATION One Sun Parkway Crystal Lake, Illinois U.S.A. MODEL: MRC-400/450 DWG REV: 0895 REV A. DWG BY: T. WILSON CHK BY: F. ZOFSKI TITLE: "SERIAL B" TERCONNECTION DIAGRAM DWG: PAGE:

CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation.

CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. CHAPTER 4 PARTS PARTS BY PICTORIAL This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. NOTE: The following is a breakdown description for Serial