TECHNICAL MANUAL FIELD AND SUSTAINMENT MAINTENANCE, FOR

Transcription

1 TECHNICAL MANUAL FIELD AND SUSTAINMENT MAINTENANCE, REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) FOR TRUCK, FORKLIFT, DED, PNEUMATIC TIRE, ARTICULATED FRAME STEER, 4,000 LB CAPACITY ROUGH TERRAIN, ARMY MODEL MHE 237 (J.I. CASE MODEL M4K) (NSN ) *, Dated 30 April 1992 including all changes. DISTRIBUTION STATEMENT A - Approved for public release; distribution is unlimited. HEADQUARTERS, DEPARTMENT OF THE ARMY JULY 2008

2 only Left Blank. This page is blank.

3 LIST OF EFFECTIVE PAGES/WORK PACKAGES NOTE: Zero in the Change No. column indicates and original page or work package. Original...15 July 2008 Date of issue for the original manual is: TOTAL NUMBER OF PAGES FOR FRONT AND REAR MATTER IS 24 AND TOTAL NUMBER OF WORK PACKAGES IS 4 CONSISTING OF THE FOLLOWING: Page/WP No. *Change No. Cover/(Back blank) 0 A/(B blank) 0 i to vii/(viii blank) 0 WP 0001 (6 pgs) 0 WP 0002 (294 pgs) 0 WP 0003 (4 pgs) 0 WP 0004 (90 pgs) 0 Back Cover 0 * Zero in this column indicates an original page or work package. A/(B blank)

4

5 * TECHNICAL MANUAL HEADQUARTERS DEPARTMENT OF THE ARMY Washington, D.C., 15 July 2008 FIELD AND SUSTAINMENT MAINTENANCE, REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) FOR TRUCK, FORKLIFT, DED, PNEUMATIC TIRE, ARTICULATED FRAME STEER, 4,000 LB CAPACITY ROUGH TERRAIN, ARMY MODEL MHE 237 (J.I. CASE MODEL M4K) (NSN ) REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this publication. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Submit your DA Form 2028 (Recommended Changes to Equipment Technical Publications), through the Internet, on the Army Electronic Product Support (AEPS) website. The Internet address is If you need a password, scroll down and click on ACCESS REQUEST FORM. The DA Form 2028 is located in the ONLINE FORMS PROCESSING section of the AEPS. Fill out the form and click on SUBMIT. Using this form on the AEPS will enable us to respond quicker to your comments and better manage the DA Form 2028 program. You may also mail, fax or your letter, DA Form 2028 direct to: AMSTA- LC-LMPP/TECH PUBS, TACOM-RI, 1 Rock Island Arsenal, Rock Island, IL The e- mail address is: TACOM-TECH-PUBS@conus.army.mil. The fax number is DSN or Commercial (309) *Supersedes dated 30 April 1992, including all changes. DISTRIBUTION STATEMENT A - Approved for public release; distribution is unlimited. TABLE OF CONTENTS WP 0001 REPAIR PARTS AND SPECIAL TOOLS LIST INTRODUCTION WP 0002 REPAIR PARTS LISTepair Parts List Illus/Fig GROUP 01 ENGINE 0100 ENGINE ASSEMBLY ENGINE, MOUNTING BRACKET, AND LIFT BRACKETS CRANKCASE, BLOCK, CYLINDER HEAD CYLINDER BLOCK ASSEMBLY CYLINDER HEAD Page i

6 TABLE OF CONTENTS (Con t) Illus/Fig Page 0102 CRANKSHAFT CRANKSHAFT FLYWHEEL ASSEMBLY FLYWHEEL AND HOUSING PISTONS, CONNECTING RODS PISTON AND CONNECTING RODS VALVES, CAMSHAFTS, AND TIMING SYSTEM ROCKER ARMS AND VALVES TIMING GEAR COVER AND IDLER GEAR CAMSHAFT ENGINE LUBRICATION SYSTEM OIL PUMP OIL PANS OIL FILTER AND DIPSTICK ARMY OIL ANALYSIS PROGRAM (AOAP) KIT MANIFOLDS MANIFOLDS GROUP 03 FUEL SYSTEM 0301 CARBERETOR,FUEL INJECTOR FUEL INJECTOR LINES FUEL INJECTOR FUEL PUMPS FUEL INJECTION PUMP MOUNTING AND GEAR FUEL INJECTION PUMP, GOVERNOR, AND SOLENOID, MODEL FUEL INJECTION PUMP, MODEL FUEL PUMPS AND LINES AIR CLEANER AIR CLEANER TANKS, LINES, FITTINGS, AND HEADERS FUEL TANK AND LINES FUEL FILTERS FUEL STRAINER AND IN-LINE FUEL FILTER FUEL FILTERS ENGINE STARTING AIDS QUICK START KIT ii

7 TABLE OF CONTENTS (Con t) Illus/Fig Page 0312 ACCELERATOR, THROTTLE, OR CHOKE CABLES ACCELERATOR GROUP 04 EXHAUST SYSTEM 0401 MUFFLER AND PIPES MUFFLER AND PIPES GROUP 05 COOLING SYSTEM 0501 RADIATOR, EVAPORATIVE COOLER, OR HEAT EXCHANGER RADIATOR WATER MANIFOLD,HEADERS, THERMOSTATS, AND GASKET THERMOSTAT WATER PUMP WATER PUMP FAN ASSEMBLY FAN BLADE GROUP 06 ELECTRICAL SYSTEM 0601 GENERATOR, ALTERNATOR ALTERNATOR AND MOUNTING ALTERNATOR STARTING MOTOR STARTER AND MOUNTING FOR MODEL STARTER AND MOUNTING FOR MODEL INSTRUMENT OR CONTROL INSTRUMENT PANEL MISCELLANEOUS ITEMS SLAVE RECEPTACLE LIGHTS FLOODLIGHTS BLACKOUT DRIVING LAMP BLACKOUT STOPLIGHT-TAILLIGHT STOP AND TAILLIGHT SENDING UNITS AND WARNING SWITCHES SENDING UNITS iii

8 TABLE OF CONTENTS (Con t) Illus/Fig Page 0611 HORN, SIREN HORN AND BACKUP ALARM BATTRIES, STORAGE (WET OR DRY) BATTERIES AND RELATED PARTS HULL OR CHASSIS WIRING HARNESS FRONT MAIN WIRING HARNESS REAR MAIN WIRING HARNESS, RELAY PANEL, AND COMPONENTS GROUP 07 TRANSMISSION 0700 TRANSMISSION ASSEMBLY TRANSMISSION MOUNTING TORQUE CONVERTER OR FLUID COUPLING TORQUE CONVERTER GROUP CONVERTER HOUSING TRANSMISSION ASSEMBLY TRANSMISSION ASSEMBLY (UPPER) TRANSMISSION ASSEMBLY (LOWER) TRANSMISSION CASE INTERMEDIATE CLUTCH LOW CLUTCH ASSEMBLY FORWARD CLUTCH ASSEMBLY THIRD CLUTCH ASSEMBLY REVERSE AND SECOND CLUTCH ASSEMBLY COOLERS, PUMPS, MOTORS CHARGING PUMP AND MOTOR CONTROL VALVE AND MOUNTING MODULATION VALVE ASSEMBLY TRANSMISSION LINKAGE CONTROL (FORWARD) TRANSMISSION LINKAGE CONTROL (AFT) AXLE DISCONNECT TRANSMISSION COOLER AND LINES GROUP 09 PROPELLER AND PROPELLER SHAFTS 0900 PROPELLER SHAFTS FRONT DRIVE SHAFT ASSEMBLY CENTER DRIVESHAFT ASSEMBLY REAR DRIVESHAFT ASSEMBLY iv

9 TABLE OF CONTENTS (Con t) Illus/Fig Page GROUP 10 FRONT AXLE 1000 FRONT AXLE ASSEMBLY FRONT AXLE ASSEMBLY AND MOUNTING DIFFERENTIAL FRONT AXLE DIFFERENTIAL CARRIER ASSEMBLY GROUP 11 REAR AXLE 1100 REAR AXLE ASSEMBLY REAR AXLE ASSEMBLY AND MOUNTING DIFFERENTIAL GROUP 12 BRAKES REAR AXLE DIFFERENTIAL CARRIER ASSEMBLY HAND BRAKES PARKING BRAKE LINKAGE PARKING BRAKE ASSEMBLY SERVICE BRAKES SERVICE BRAKES HYDRAULIC BRAKE SYSTEM SERVICE BRAKE PEDAL AND DECLUTCH PEDAL SERVICE BRAKE HYDRAULIC BRAKE VALVE SERVICE BRAKE LINES GROUP 13 WHEELS AND TRACKS 1311 WHEEL ASSEMBLY WHEELS AND TIRES GROUP 14 STEERING 1407 POWER STEERING GEAR ASSEMBLY STEERING GEAR AND STEERING COLUMN HYDRAULIC PUMP OR FLUID MOTOR ASSEMBLY HYDRAULIC PUMP AND MOUNTING HOSES, LINES, AND FITTINGS HOSES, LINES, AND FITTINGS HYDRAULIC OR AIR CYLINDER STEERING CYLINDER ASSEMBLY AND MOUNTING v

10 TABLE OF CONTENTS (Con t) Illus/Fig Page GROUP 15 FRAME AND TOWING ATTACHMENTS 1501 FRAME, TOWING ATTACHMENTS, AND DRAWBARS ROLLOVER PROTECTIVE STRUCTURE CHASSIS FRAME PINTLES AND TOWING ATTACHMENTS TOW BAR AND PINTLE HOOK GROUP 18 BODY, CAB, HOOD, AND HULL 1801 BODY, CAB, HOOD, AND HULL ASSEMBLIES GRILLE HOOD AND REAR FENDERS HOOD AND FRONT FENDERS UPHOLSTERY SEATS AND CARPETS OPERATOR'S SEAT ASSEMBLY NOISE BAFFLE PLATE GROUP 24 HYDRAULIC LIFT COMPONENTS 2402 HYDRAULIC CONTROL VALVE HYDRAULIC CONTROL VALVE MOUNTING HYDRAULIC CONTROL VALVE, LEFT SIDE COVER PLATE HYDRAULIC CONTROL VALVE, ROTATE, SIDE SHIFT, AND TILTSECTIONS HYDRAULIC CONTROL VALVE,LIFT SECTION HYDRAULIC CONTROLS AND/OR MANUAL CONTROLS HYDRAULIC CONTROL LEVERS AND LINKAGE HYDRAULIC TILT CYLINDERS AND TILT CRANK TILT CYLINDER ASSEMBLY AND MOUNTING HYDRAULIC MAST COLUMN MAST AND CARRIAGE (UPPER) HYDRAULIC MAST COLUMN MAST AND CARRIAGE (LOWER) LIFT CYLINDER ASSEMBLY SIDESHIFT CYLINDER ASSEMBLY HYDRAULIC LINES AND FITTINGS MAST AND CARRIAGE HOSES, LINES, AND FITTINGS (SERIAL NUMBERS AND BELOW) MAST AND CARRIAGE HOSES, LINES, AND FITTINGS (SERIAL NUMBERS AND ABOVE) vi

11 TABLE OF CONTENTS (Con t) Illus/Fig Page HYDRAULIC FILTER ASSEMBLY AND HOSES, LINES, AND FITTINGS HYDRAULIC CYLINDERS ROTATION CYLINDER ASSEMBLY LIQUID TANKS OR RESERVOIR HYDRAULIC TANK GROUP 94 REPAIR KITS 9401 REPAIR KITS WP 0003 REPAIR PARTS LIST GROUP 26 TOOLS AND TEST EQUIPMENT 2604 SPECIAL TOOLS SPECIAL TOOLS WP 0004 REPAIR PARTS LIST CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX PART NUMBER INDEX vii/(viii blank)

12

13 WP Repair Parts List 0001 PARTS LIST INFORMATION REPAIR PARTS AND SPECIAL TOOLS LIST INTRODUCTION Scope, General, Explanation of Columns in The Repair Parts Lists and Special Tools List, Explanation of Cross-Reference Indexes, Special Information, How to Locate Repair Parts, Abbreviations SCOPE 0001 This RPSTL lists and authorizes spares and repair parts; special tools; special test, measurement, and diagnostic equipment (TMDE); and other special support equipment required for performance of Unit and Direct Support maintenance of the Truck, Forklift, MHE 237. It authorizes the requisitioning, issue, and disposition of spares, repair parts, and special tools as indicated by the source, maintenance, and recoverability (SMR) codes. GENERAL In addition to the Introduction work package, this RPSTL is divided into the following work packages: a. Repair Parts Lists Work Package. Work package containing lists of spares and repair parts authorized by this RPSTL for use in the performance of maintenance. This work package also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in ascending alphanumeric sequence, with the parts in each group listed in ascending figure and item number sequence. Sending units, brackets, filters, and bolts are listed with the component they mount on. Bulk materials are listed by item name in FIG. BULK at the end of the work package. Repair parts kits are listed separately in their own functional group. Items listed are shown on the associated illustrations. b. Special Tools List Work Package. Work package containing lists of special tools, special TMDE, and special support equipment authorized by this RPSTL [as indicated by Basis of Issue (BOI) information in the DESCRIP- TION AND USABLE ON CODE (UOC) column]. Tools that are components of common tool sets and/or Class VII are listed. c. Cross-Reference Indexes Work Package. There are two cross-reference indexes in this RPSTL: National Stock Number Index and Part Number Index. EXPLANATION OF COLUMNS IN THE REPAIR PARTS LISTS AND SPECIAL TOOLS LIST WORK PACKAGES a. Item No. (Column 1). Indicates the number used to identify items called out in the illustration. b. SMR Code (Column 2). The SMR code containing supply/requisitioning information, maintenance level authorization criteria, and disposition instruction, as shown in the following breakout: SOURCE CODE MAINTENANCE CODE RECOVERABILITY CODE XXxxx xxxxx xxxxx 1st two positions 3rd position 4th position 5th position How you get an item. Who can install, replace, or use the item. Who can do complete repair* on the item. Who determines disposition action on an unserviceable item. * Complete Repair: Maintenance capacity, capability, and authority to perform all corrective maintenance tasks of the Repair function in a use/user environment in order to restore serviceability to a failed item

14 0001 EXPLANATION OF COLUMNS IN THE REPAIR PARTS LISTS AND SPECIAL TOOLS LIST WORK PACKAGES - CONTINUED (1) Source Code. The source code tells you how to get an item needed for maintenance, repair, or overhaul of an end item/equipment. Explanations of source codes follow: Code Application/Explanation PA PB PC PD PE PF PG KD KF KB MO - Made at Unit/ AVUM level MF - Made at DS/AVIM Level MH - Made at GS Level ML - Made at SRA MD - Made at Depot AO-Assembled by Unit/ AVUM level AF-Assembled by DS/ AVIM level AH-Assembled by GS level AL-Assembled by SRA AD-Assembled by Depot XA XB XC XD Stocked items; use the applicable NSN to request/requisition items with these source codes. They are authorized to the maintenance category indicated by the code entered in the third position of the SMR code. Items coded PC are subject to deterioration Items with these codes are not to be requested/requisitioned individually. They are part of a kit which is authorized to the maintenance level indicated in the third position of the SMR code. The complete kit must be requisitioned and applied Items with these codes are not to be requested/requisitioned individually. They must be made from bulk materiel which is identified by the part number in the DESCRIPTION AND USABLE ON CODE (UOC) column and listed in the bulk materiel group work package of the RPSTL. If the item is authorized to you by the third position of the SMR code, but the source code indicates it is made at a higher level, order the item from the higher level of maintenance Items with these codes are not to be requested/requisitioned individually. The parts that make up the assembled item must be requisitioned or fabricated and assembled at the level of maintenance indicated by the source code. If the third position of the SMR code authorizes you to replace the item, but the source code indicates the item is assembled at a higher level, order the item from the higher level of maintenance Do not requisition an XA coded item. Order the next higher assembly (refer to NOTE below). If an item is not available from salvage, order it using the CAGEC and P/N. Installation drawings, diagrams, instruction sheets, field service drawings; identified by manufacturer s P/N. Item is not stocked. Order an XD-coded item through normal supply channels using the CAGEC and P/N given, if no NSN is available. NOTE Cannibalization of controlled exchange, when authorized, may be used as a source of supply for items with the above source codes, except for those source coded XA or those aircraft support items restricted by requirements of AR

15 0001 EXPLANATION OF COLUMNS IN THE REPAIR PARTS LISTS AND SPECIAL TOOLS LIST WORK PACKAGES - CONTINUED (2) Maintenance Code. Maintenance codes tell you the level(s) of maintenance authorized to use and repair support items. The maintenance codes are entered in the third and fourth positions of the SMR code as follows: (a) Third Position. The maintenance code entered in the third position tells you the lowest maintenance level authorized to remove, replace, and use an item. The maintenance code entered in the third position will indicate authorization to one of the following levels of maintenance: Code Application/Explanation C Crew or Operator maintenance done within Unit/AVUM maintenance. O Unit Level/AVUM maintenance can remove, replace, and use the item. F Direct Support/AVIM maintenance can remove, replace, and use the item. H General Support maintenance can remove, replace, and use the item. L Specialized Repair Activity (SRA) can remove, replace, and use the item. D Depot Maintenance can remove, replace, and use the item. (b) Fourth Position. The maintenance code entered in the fourth position tells you whether or not the item is to be repaired and identifies the lowest maintenance level with the capability to do complete repair (perform all authorized repair functions). NOTE Some limited repair may be done on the item at a lower level of maintenance, if authorized by the Maintenance Allocation Chart (MAC) and SMR codes. Code Application/Explanation O Unit/AVUM is the lowest level that can do complete repair of the item. F Direct Support/AVIM is the lowest level that can do complete repair of the item. H General Support is the lowest level that can do complete repair of the item. L Specialized Repair Activity (SRA) is the lowest level that can do complete repair of the item. D Depot is the lowest level that can do complete repair of the item. Z Nonreparable. No repair is authorized. B No repair is authorized. No parts or special tools are authorized for the maintenance of a B -coded item. However, the item may be reconditioned by adjusting, lubricating, etc., at the user level

16 0001 EXPLANATION OF COLUMNS IN THE REPAIR PARTS LISTS AND SPECIAL TOOLS LIST WORK PACKAGES - CONTINUED (3) Recoverability Code. Recoverability codes are assigned to items to indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the SMR code as follows: Code Application/Explanation Z Nonreparable item. When unserviceable, condemn and dispose of the item at the level of maintenance shown in the third position of the SMR code. O Reparable item. When uneconomically reparable, condemn and dispose of the item at the Unit level maintenance. F Reparable item. When uneconomically reparable, condemn and dispose of the item at Direct Support level. H Reparable item. When uneconomically reparable, condemn and dispose of the item at General Support level. D Reparable item. When beyond lower level repair capability, return to depot. Condemnation and disposal of item are not authorized below depot level. L Reparable item. Condemnation and disposal of item not authorized below Specialized Repair Activity (SRA). A Item requires special handling or condemnation procedures because of specific reasons (e.g., precious metal content, high dollar value, critical material, or hazardous material). Refer to appropriate manuals/directives for specific instructions. c. NSN - (Column 3). The NSN for the item is listed in this column. d. CAGEC (Column 4). The Commercial and Government Entity Code (CAGEC) is a five-digit code which is used to identify the manufacturer, distributor, or Government agency/activity that supplies the item. e. PART NUMBER (Column 5). Indicates the primary number used by the manufacturer (individual, company, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications, standards, and inspection requirements to identify an item or range of items. NOTE When you use an NSN to requisition an item, the item you receive may have a different part number from the part ordered. f. DESCRIPTION AND USABLE ON CODE (UOC) (Column 6). This column includes the following information: (1) The Federal item name and, when required, a minimum description to identify the item. (2) P/Ns of bulk materials are referenced in this column in the line entry to be manufactured or fabricated. (3) Hardness Critical Item (HCI). A support item that provides the equipment with special protection from electromagnetic pulse (EMP) damage during a nuclear attack. (4) The statement END OF FIGURE appears just below the last item description in column (6) for a given figure in both the repair parts list and special tools list work packages

17 0001 EXPLANATION OF COLUMNS IN THE REPAIR PARTS LISTS AND SPECIAL TOOLS LIST WORK PACKAGES - CONTINUED g. QTY (Column 7). The QTY (quantity per figure) column indicates the quantity of the item used in the breakout shown on the illustration/figure, which is prepared for a functional group, subfunctional group, group or an assembly. A V appearing in this column in lieu of a quantity indicates that the quantity is variable and the quantity may vary from application to application. EXPLANATION OF CROSS-REFERENCE INDEXES WORK PACKAGE FORMAT AND COLUMNS a. National Stock Number (NSN) Index Work Package. (1) STOCK NUMBER Column. This column lists the NSN by National Item Identification Number (NIIN) sequence. The NIIN consists of the last nine digits of the NSN (i.e., NSN ). When using this column to locate an item, ignore the first four digits of the NSN. However, the complete NSN should be used when ordering items by stock number. (2) FIG. Column. This column lists the number of the figure where the item is identified/located. The figures are in numerical order in WP and WP (3) ITEM Column. The item number identifies the item associated with the figure listed in the adjacent FIG. column. This item is also identified by the NSN listed on the same line. b. Part Number (P/N) Index Work Package. Part numbers in this index are listed in ascending alphanumeric sequence (i.e., vertical arrangement of letter and number combination which places the first letter or digit of each group in order A through Z, followed by the numbers 0 through 9 and each following letter or digit in like order). (1) PART NUMBER Column. Indicates the P/N assigned to the item. (2) FIG. Column. This column lists the number of the figure where the item is identified/located in the repair parts list and special tools list work packages. (3) ITEM Column. The item number is the number assigned to the item as it appears in the figure referenced in the adjacent figure number column. SPECIAL INFORMATION a. Usable On Code (UOC). The UOC appears in the lower left corner of the DESCRIPTION column heading. Usable on codes are shown as UOC: in the Description Column (justified left) on the first line under the applicable item/nomenclature. Uncoded items are applicable to all models. Identification of the UOC s used in the RPSTL are: b. Fabrication Instructions. Bulk materiels required to manufacture items are listed in the Bulk Materiel functional group of this RPSTL. Part numbers for bulk materiel are also referenced in the Description Column of the line item entry for the item to be manufactured/fabricated. Detailed fabrication instructions for items source coded to be manufactured or fabricated are found in TM c. Index Numbers. Items which have the word BULK in the figure column will have an index number shown in the item number column. This index number is a cross-reference between the NSN/P/N Index work package and the bulk materiel list in the repair parts list work package

18 0001 SPECIAL INFORMATION - CONTINUED d. Associated Publications. The publication(s) listed below pertain to the Truck, Forklift, MHE 237 and its components: Publication Short Title TM Operator s Manual for Truck, Forklift, MHE 237 TM Organizational, DS/GS Maintenance Manual for Truck, Forklift, MHE 237 HOW TO LOCATE REPAIR PARTS a. When National Stock Number is Known: (1) First. If you have the NSN, look in the STOCK NUMBER column of the NSN index work package. The NSN is arranged in NIIN sequence. Note the figure and item number next to the NSN. (2) Second. Turn to the figure and locate the item number. Verify that the item is the one you are looking for. b. When Part Number is Known: ABBREVIATIONS (1) First. If you have the P/N and not the NSN, look in the PART NUMBER column of the P/N index work package. Identify the figure and item number. (2) Second. Look up the item on the figure in the applicable repair parts list work package. For standard abbreviations see ASME Y , Abbreviations and Acronyms. Abbreviation Explanation NIIN National Item Identification Number (consists of the last 9 digits of the NSN) RPSTL Repair Parts and Special Tools Lists SMR Source, Maintenance, and Recoverability Code TMDE Test, Measurement, and Diagnostic Equipment END OF WORK PACKAGE

19 WP 0002 Repair Parts List REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) - 0 1REPAIR PARTS LIST /(2 blank)

20

21 Figure 1. Engine, Mounting Bracket, and Lift Brackets (Sheet 1 of 2)

22 Figure 1. Engine, Mounting Bracket, and Lift Brackets (Sheet 2 of 2)

23 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 01 ENGINE GROUP 0100 ENGINE ASSEMBLY FIG. 1 ENGINE, MOUNTING BRACKET, AND LIFT BRACKETS 1 PFFZZ B1821BH063C350N SCREW,CAP,HEXAGON H XDFZZ CASD35009 WASHER,FLAT XBFZZ D63931 BRACKET,MOUNTING PAFZZ A59516 BUMPER PFFZZ MS WASHER,LOCK PFFZZ MS NUT,PLAIN,HEXAGON PFFZZ M45913/1-10CG5C NUT,SELF-LOCKING,HE PFFZZ T53567 WASHER,FLAT PAFZZ L78455 WASHER,FLAT PFFZZ B1821BH063C250N SCREW,CAP,HEXAGON H PAFHH MODIFICATION KIT,EN PAFHH ENGINE,DIESEL COMPLETE PFOZZ BOLT M8 X PFOZZ BRACKET,ENGINE LIFT FRONT LEFT PFFZZ BRACKET,ENGINE ACCE REAR LIFTING PFOZZ SCREW,CAP,HEXAGON M12 X PFFZZ SCREW,CAP,HEXAGON 5/8-11 X PFFZZ L78455 WASHER,FLAT PFFZZ J BRACKET,ENGINE MOUN PFFZZ WASHER,SPLIT M12 HARDENED PFFZZ SCREW,CAP,HEXAGON M12 X 85MM PFFZZ R43666 WASHER,FLAT PFFZZ NUT,SELF-LOCKING,HE 5/8-11" PFOZZ WASHER,FLAT PFOZZ NUT,PLAIN,HEXAGON PFOZZ BOLT PFOZZ SCREW,CAP,HEXAGON 3/8 X PFFZZ A BRACKET,ENGINE MOUN... 1 END OF FIGURE /(6 blank)

24

25 Figure 2. Cylinder Block Assembly (Sheet 1 of 2)

26 Figure 2. Cylinder Block Assembly (Sheet 2 of 2)

27 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0101 CRANKCASE, BLOCK, CYLINDER HEAD FIG. 2 CYLINDER BLOCK ASSEMBLY 1 PAFZZ PLUG,PIPE XBOZZ A26673 CLIP, FUEL SHUTOFF PFOZZ WASHER,LOCK PFOZZ MS SCREW,CAP,HEXAGON H PFOZZ MS SCREW,DRIVE XBOZZ PLATE, SERIAL NO XBFZZ A632PC1 PLUG,PIPE PAHZZ PLUG,EXPANSION XBFZZ A ADAPTER,SPEEDOMETER XAFZZ A38943.GEAR DRIVE XAFZZ A SHAFT, DRIVE XAFZZ A BODY XAFZZ A22553.BUSHING PAFZZ Y CAP,PROTECTIVE,DUST XAHHH A46351 CYLINDER BLOCK ASSY XBHZZ A36902.STUD,PLAIN PAHZZ A37149.FILLER NECK AND DIPSTICK XBHZZ G49608.BUSHING,SLEEVE KBHZZ A SLEEVE, CYLINDER PART OF KIT P/N 4 A PAHZZ A51916.O-RING PART OF KIT P/N A XBHZZ PLUG,PIPE XBHZZ G49070.PLUG,PIPE PFHZZ A PARTS KIT,BEARING R PFHZZ MS PLUG,EXPANSION XBHZZ A ADAPTOR, OIL FILTER PAHZZ SCREW,CAP,HEXAGON H XBHZZ G2126.CAP, MAIN BEARING FRONT XBHZZ G2128.CAP,MAIN BEARING INTERMEDIATE XBHZZ G2127.CAP,MAIN BEARING CENTER XBHZZ A38385.CAP, MAIN BEARING REAR PFHZZ B1821BH050C450N.SCREW,CAP,HEXAGON H XAHZZ A CYLINDER BLOCK PFHZZ MS PLUG,EXPANSION XBHZZ G49404.WASHER PFHZZ J CYLINDER SLEEVE PFHZZ BOLT,MACHINE M12 X PFHZZ A77424.CAP,FILLER OPENING PFHZZ FILLER NECK,VEHICUL PFHZZ O-RING PART OF KIT P/N A PFHZZ PLUG,EXPANSION PFHZZ PLUG,EXPANSION 18MM PFHZZ PIN,STRAIGHT,HEADLE PFHZZ PLUG,MACHINE THREAD 1/2 " PFHZZ A77782.PLUG,EXPANSION 58MM PFHZZ PIN,STRAIGHT,HEADLE 10MM

28 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 46 PFHZZ PLUG,MACHINE THREAD 3/4" PFHZZ PLUG,EXPANSION OD PFHZZ ENGINE BLOCK,GASOLI PFHZZ BEARING,SLEEVE PFHZZ BOLT,SHOULDER PFHZZ CAP,MAIN BEARING PFHZZ J BEARING,SLEEVE PFHZZ NOZZLE,LUBRICATING, PFHZZ J BUSHING,SLEEVE INTERMEDIATE & REAR 1 55 PFHZZ BUSHING,SLEEVE PFHZZ O-RING PFHZZ BUSHING,SLEEVE 2 3/8" PFHZZ PLUG,EXPANSION 32MM PFHZZ PLUG,EXPANSION PFHZZ PLUG,MACHINE THREAD PFHZZ PLUG,EXPANSION... 1 END OF FIGURE /(11 blank)

29

30 Figure 3. Cylinder Head

31 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0101 CRANKCASE, BLOCK, CYLINDER HEAD FIG. 3 CYLINDER HEAD 1 XBFZZ A39047 BOLT,MACHINE PAFZZ A39046 WASHER,FLAT PFFZZ A51114 POST,ELECTRICAL-MEC XBFZZ A39049 BOLT,MACHINE XBFZZ A39048 BOLT,MACHINE KFFZZ C1 GASKET, CYLINDER PART OF KIT P/N 1 A XAFZZ A CYLINDER HEAD,DIESE PAFZZ G2068.GUIDE,VALVE STEM PAFZZ G2069.GUIDE,VALVE STEM PFFZZ MS PLUG,EXPANSION PAFZZ A STUD,PLAIN MANIFOLD, LONG PAFZZ A29431.STUD,PLAIN MANIFOLD, SHORT XAFHH NSS.CYLINDER HEAD PAFZZ A39268.INSERTS,VALVE SEAT PAFZZ A51500.STUD,PLAIN MANIFOLD, CENTER PAFZZ A STUD,PLAIN MANIFOLD XBFZZ A STUD,PLAIN MANIFOLD, END PFFZZ MS PLUG,EXPANSION PFFZZ PLUG,MACHINE THREAD 1/2 X 14" PFFZZ A77783.PLUG,EXPANSION 21MM PFFHH CYLINDER HEAD,GASOL WITH 1 REMANUFACTURED VALVES PFFZZ PLUG,PIPE 1/8 X 27" PFFZZ SCREW,CAP,HEXAGON H 70 MM PFFZZ BOLT,MACHINE 120 MM PFFZZ GASKET STANDARD PFFZZ GASKET 25MM THICKER PFFZZ GASKET 50MM THICKER... 1 END OF FIGURE /(14 blank)

32

33 Figure 4. Crankshaft (Sheet 1 of 2)

34 Figure 4. Crankshaft (Sheet 2 of 2)

35 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0102 CRANKSHAFT FIG. 4 CRANKSHAFT 1 PAHZZ A36495 BEARING HALF,SLEEVE XBHZZ A36496 LINER KIT, MAIN.002 INCH XBHZZ A36497 BEARING HALF,SLEEVE.010 INCH XBHZZ A36498 BEARING HALF,SLEEVE.020 INCH XBHZZ A36499 BEARING HALF,SLEEVE.030 INCH PAHZZ A36455 BEARING,SLEEVE XBHZZ A36486 BEARING HALF,SLEEVE.002 INCH XBHZZ A36487 BEARING HALF,SLEEVE.010 INCH XBHZZ A36488 BEARING HALF,SLEEVE.020 INCH XBHZZ A36489 BEARING HALF,SLEEVE.030 INCH PAHZZ B0B1 MB-2194P BEARING,SLEEVE XBHZZ A36491 BEARING HALF,SLEEVE.002 INCH XBHZZ A36492 BEARING HALF,SLEEVE.010 INCH XBHZZ A36493 BEARING HALF,SLEEVE.020 INCH XBHZZ A36494 BEARING HALF,SLEEVE.030 INCH PAHZZ A36480 BEARING BRACKET XBHZZ A36481 BEARING HALF,SLEEVE.002 INCH XBHZZ A36482 BEARING HALF,SLEEVE.010 INCH XBHZZ A36483 BEARING HALF,SLEEVE.020 INCH XBHZZ A36484 BEARING HALF,SLEEVE.030 INCH PAHZZ A39132 KEY,WOODRUFF XBHZZ A39288 GEAR,HELICAL XBHZZ A29259 SLINGER, OIL PAHZZ A PULLEY,GROOVE PAHZZ A35673 NUT,CRANKSHAFT KBHZZ A39188 GASKET PART OF KIT P/N A PFHZZ MPD WASHER,LOCK PFHZZ B1821BH025C075N SCREW,CAP,HEXAGON H PFHZZ BUN9 A SCREW,CAP,HEXAGON H XAHZZ A CRANKSHAFT,ENGINE XDHZZ A39113 SEAL,CRANKSHAFT PAHZZ A38390.RETAINER,PACKING PAHZZ A51339.SEAL,PLAIN ENCASED PFHZZ GEAR,HELICAL PFHZZ PIN,STRAIGHT,HEADLE 6.01MM KFHZZ NSS-1.SEAL PART OF KIT P/N A PFFZZ PULLEY,GROOVE PFFZZ J ADAPTER,FLYWHEEL HO PFFZZ BOLT,MACHINE PFHZZ J BEARING HALF,SLEEVE STANDARD PFHZZ A77472.BEARING HALF,SLEEVE 0.25MM U/S PFHZZ A77474.BEARING HALF,SLEEVE 0.50MM U/S PFHZZ A77476.BEARING HALF,SLEEVE 0.75MM U/S PFHZZ A77478.BEARING HALF,SLEEVE 1.0MM U/S PFHZZ A77895.BEARING HALF,SLEEVE STANDARD PFHZZ A77473.BEARING HALF,SLEEVE 0.25MM U/S

36 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 25 PFHZZ A77475.BEARING HALF,SLEEVE 0.50MM U/S PFHZZ A77477.BEARING HALF,SLEEVE 0.75MM U/S PFHZZ A77479.BEARING HALF,SLEEVE 1.0MM U/S PFHZZ GASKET REAR COVER PFHZZ COVER,TIMING GEAR,I XDHZZ NSS SEAL COMES WITH P/N A77890 (10988) PFHZZ BOLT,MACHINE M6 X PFHHH CRANKSHAFT,ENGINE PFHZZ A77889.PARTS KIT,SEAL REPL W/FRONT SEAL, 1 TOOL (2), SHIELD PFHZZ A77890.BEARING,SLEEVE W/WEAR SLEEVE,SEAL, 1 TOOL,SHIELD PFHZZ BEARING,SLEEVE PFHZZ J SEAL,SPECIAL REAR,TOOL,SEAL... 1 END OF FIGURE /(19 blank)

37

38 Figure 5. Flywheel and Housing

39 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0103 FLYWHEEL ASSEMBLY FIG. 5 FLYWHEEL AND HOUSING 1 PFHZZ BOLT,MACHINE M10 X 40MM, FOR USE 10 WITH MODEL ENGINE... 1 PFHZZ A30135 BOLT,MACHINE PFHZZ WASHER,LOCK M10, FOR USE WITH MODEL ENGINE... 2 PFHZZ MS WASHER,LOCK PAHZZ A HOUSING,FLYWHEEL PFFZZ G11716 DEFLECTOR,DIRT AND PFFZZ F98 SCREW,CAP,HEXAGON H PFFZZ CBM21389 WASHER,LOCK PFFZZ MS WASHER,FLAT PFFZZ L STUD,PLAIN FOR USE WITH ENGINE PFHZZ A29363 STUD,PLAIN PAHZZ A FLYWHEEL,ENGINE ASSEMBLE FROM P/N 1 A15466 OR A XAHZZ A FLYWHEEL,ENGINE PAHZZ A GEAR,SPUR PAHZZ A30013 WASHER,FLAT PFHZZ B1821BH044F150D SCREW,CAP,HEXAGON H PFHZZ WASHER,LOCK USED ON ONLY PFHZZ MS WASHER,LOCK PFHZZ NUT,PLAIN,HEXAGON USED ON ONLY PFHZZ MS NUT,PLAIN,HEXAGON PFHZZ MS PIN,SPRING XBOZZ A29068 COVER, TIMING HOLE PFOZZ CBM21389 WASHER,LOCK PFOZZ MS SCREW,CAP,HEXAGON H PFFZZ J PLUG,PIPE PFFZZ O-RING 7/8 X 1 1/ PFFZZ PLUG,MACHINE THREAD PFFZZ BOLT,MACHINE M12 X PFFZZ FLYWHEEL,ENGINE PFFZZ J GEAR,SPUR PFFZZ WASHER,FLAT PFFZZ J SCREW,CAP,HEXAGON H M12 X PFFZZ PLUG,MACHINE THREAD 3/ PFFZZ HOUSING,FLYWHEEL PFFZZ J COVER,ACCESS PFFZZ CLAMP,LOOP PFFZZ J SEAL,PLAIN PART OF KIT P/N A PFFZZ SCREW M8 X END OF FIGURE

40 Figure 6.Pistons and Connecting Rods

41 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0104 PISTONS, CONNECTING RODS FIG. 6 PISTON AND CONNECTING RODS 1 KBHZZ A RING, PISTON, TOP NSS, ORDER KIT 4 PART OF KIT P/N A PART OF KIT P/N A KBHZZ A RING, PISTON NSS, ORDER KIT PART OF 4 KIT P/N A PART OF KIT P/N A KBHZZ A RING, PISTON, OIL NSS, ORDER KIT 4 PART OF KIT P/N A PART OF KIT P/N A KBHZZ A PISTON, 4-INCH BORE PART OF KIT P/N 4 A KBHZZ G46702 RING, RETAINING PART OF KIT P/N 8 A35771 PART OF KIT P/N A PAHZZ A50975 BEARING HAFT,SLEEVE XBHZZ A50976 LINER KIT.002 INCH XBHZZ A50977 LINER KIT.010 INCH XBHZZ A50978 LINER KIT.020 INCH XBHZZ A50979 LINER KIT.030 INCH KBHZZ A35770 PIN, PISTON, PART PART OF KIT P/N 4 A35771 PART OF KIT P/N A PAHZZ A CONNECTING ROD,PIST PAHZZ A44083.BUSHING,SLEEVE XAHZZ A51912.CONNECTING ROD AND PAHZZ A51904.NUT,PLAIN,HEXAGON PAHZZ A51914.BOLT,CLOSE TOLERANC PFHZZ J RING SET,PISTON INCLUDES 1-5 STD PFHZZ J RING SET,PISTON INCLUDES 1-5,STD PFHZZ J RING SET,PISTON INCLUDES 1-5, 50MM 4 O/S PFHZZ J RING SET,PISTON INCLUDES 1-5, MM O/S PFHZZ CONNECTING ROD,PIST PFHZZ BOLT,MACHINE PFHZZ BUSHING,SLEEVE PFHZZ BEARING HALF SET,SL STANDARD PFHZZ BEARING HALF SET,SL.25MM U/S PFHZZ BEARING HALF SET,SL.50MM U/S PFHZZ BEARING HALF SET,SL.75MM U/S PFHZZ BEARING HALF SET,SL 1.00MM U/S PFHZZ B8S PIN,PISTON... 4 END OF FIGURE /(24 blank)

42

43 Figure 7. Rocker Arms and Valves (Sheet 1 of 2)

44 Figure 7. Rocker Arms and Valves (Sheet 2 of 2)

45 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0105 VALVES, CAMSHAFTS, AND TIMING SYSTEM FIG. 7 ROCKER ARMS AND VALVES 1 PFFZZ MS NUT,PLAIN,HEXAGON PAFZZ WASHER,FLAT PAFZZ A GROMMET,METALLIC PART OF KIT P/N 2 A PAFZZ GTB2420 ELBOW,PIPE TO HOSE PAOZZ NAS B CLAMP,HOSE MOOZZ HOSE,NONMETALLIC MAKE FROM HOSE P/ 1 N H PAFZZ A36815 COVER,ENGINE POPPET PAFZZ A43030 GASKET PART OF KIT P/N A PFFZZ B1821BH038C350N SCREW,CAP,HEXAGON H PAFZZ WASHER,FLAT PAFZZ G47079 PUSH ROD,ENGINE POP PAHZZ C1604 TAPPET,ENGINE POPPE PAFZZ A38422 VALVE,POPPET,ENGINE PAFZZ A38423 VALVE,POPPET,ENGINE XBFZZ G49065 WASHER,RECESSED PAFZZ A30025 SPRING,HELICAL,COMP XBFZZ G11717 RETAINER, SPRING KFFZZ G46851 GASKET PART OF KIT P/N A PAFZZ H206 LOCK,VALVE SPRING R PFFZZ B1821BH038C350N SCREW,CAP,HEXAGON H XBFZZ DECAL, ENGINE DATA PAFZZ A51271 STUD,PLAIN AFFFF G11883 ROCKER ARM ASSEMBLY ORDER 1 COMPONENTS PAFZZ G2100.BRACKET,EYE,NONROTA FRONT PAFZZ A38181.SHAFT,STRAIGHT PAFZZ A51148.ROCKER ARM,ENGINE P PAFZZ G48501.SPRING,HELICAL,COMP PAFZZ A51149.ROCKER ARM,ENGINE P PAFZZ A51084.BRACKET,EYE,NONROTA INTERMEDIATE XBHZZ G2101.BRACKET,EYE,NONROTA CENTER XBFZZ A36615.BRACKET,EYE,NONROTA REAR PAOZZ C0-1813Z1 CLAMP,LOOP PFFZZ SCREW,CAP,HEXAGON H PFFZZ WASHER,FLAT PFFZZ GASKET PFFZZ COVER,ACCESS PFFZZ GASKET PFFZZ B8S SCREW,CAP,HEXAGON H PFFZZ SCREW,CAP,HEXAGON H M8 X PFFFF ROCKER ARM,ENGINE P INTAKE PFFZZ B8S SETSCREW PFFZZ A77902.NUT,PLAIN,HEXAGON 3/

46 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 43 PFFZZ WASHER,FLAT PFFZZ MS RING,RETAINING PFFZZ COLLET,VALVE PFFZZ RETAINER,HELICAL CO PFFZZ SPRING,HELICAL,COMP PFFZZ O-RING PFFZZ SEAT,VALVE INTAKE, 14MM O.D PFFZZ GUIDE,VALVE STEM INTAKE & EXHAUST, 4 11MM O.D PFFZZ GUIDE,VALVE STEM EXHAUST 14MM, O.D PFFZZ SEAT,VALVE INTAKE PFFZZ J PAD,VALVE STEM,POPP PFFZZ J VALVE,POPPET,ENGINE INTAKE PFFZZ VALVE,POPPET,ENGINE EXHAUST PFFZZ SEAT,VALVE EXHAUST PFFZZ TAPPET,ENGINE POPPE PFFZZ PUSH ROD,ENGINE POP PFFFF ROCKER ARM,ENGINE P EXHAUST PFFZZ A77902.NUT,PLAIN,HEXAGON 3/ PFFZZ B8S SETSCREW PFFZZ SUPPORT,ROCKER LEVE... 4 END OF FIGURE

47 Figure 8. Timing Gear Cover and Idler Gear (Sheet 1 of 2)

48 Figure 8. Timing Gear Cover and Idler Gear (Sheet 2 of 2)

49 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0105 VALVES,CAMSHAFT AND TIMING SYSTEM FIG. 8 TIMING GEAR COVER AND IDLER GEAR 1 PAHZZ G STUD,PLAIN XBHZZ A COVER, TIMING GEAR XBHZZ A51649.STUD,SELF-LOCKING PAFZZ C1 GASKET PART OF KIT P/N A PAFZZ A51908 COVER,ACCESS PFFZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFFZZ MS NUT,PLAIN,HEXAGON PAFZZ A39110 SEAL,PLAIN ENCASED PFHZZ B1821BH038C200N SCREW,CAP,HEXAGON H XBHZZ G11746 PLATE, LOCK XBHZZ G11732 PLATE,THRUST XBHZZ G11728 SHIM.005 INCH XBHZZ G11729 SHIM.006 INCH XBHZZ G11730 SHIM.007 INCH XDHZZ G11731 SHIM.009 INCH PFHZZ G11852 GEAR,SPUR XAHZZ G11727.GEAR, IDLER XAHZZ G49660.BUSHING, IDLER GEAR PAHZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFHZZ MS WASHER,LOCK PAHZZ G11726 JOURNAL IDLER PFHZZ MS WASHER,FLAT PFHZZ B-0611 SCREW,CAP,HEXAGON H PFHZZ B1821BH038C300N SCREW,CAP,HEXAGON H PFHZZ B1821BH038C150N SCREW,CAP,HEXAGON H PFHZZ MS WASHER,FLAT PFHZZ MS SCREW,CAP,HEXAGON H PFHZZ B1821BH038C125N SCREW,CAP,HEXAGON H PFHZZ MS WASHER,FLAT PFHZZ MS NUT,PLAIN,HEXAGON KBHZZ C1 GASKET, TIMING GEAR PART OF KIT P/N 1 A PFHZZ RING,RETAINING PFHZZ PACKING,PREFORMED PFHZZ SHAFT,SHOULDERED PFHZZ J SCREW,MACHINE M5 X PFHZZ HOUSNG,TIMING PIN PFHZZ GASKET PFHZZ COVER,TIMING GEAR,I TIMING GEAR, 1 INTERNAL PFHZZ SCREW,CAP,HEXAGON H M8 X PFHZZ J SEAL,PLAIN ENCASED PFHZZ CAP,FRONT COVER PFHZZ ADJUSTING DEVICE,BE PFHZZ BOLT,ASSEMBLED WASH PFHZZ A77889 PARTS KIT,SEAL REPL

50 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 42 PFHZZ COVER,TIMING GEAR,I PFHZZ SCREW,CAP,HEXAGON H M8 X PFHZZ GASKET PFHZZ BOLT,ASSEMBLED WASH M12 X PFHZZ J COVER,ACCESS PFHZZ GASKET... 1 END OF FIGURE /(33 blank)

51

52 Figure 9. Camshaft

53 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0105 VALVES, CAMSHAFT, AND TIMING SYSTEM FIG. 9 CAMSHAFT 1 PAHZZ A CAMSHAFT,ENGINE PFHZZ MS KEY,WOODRUFF PAHZZ A29290 PLATE,THRUST CAMSHA PFHZZ MS WASHER,LOCK EXTERNAL TOOTH XBHZZ A30056 BOLT,MACHINE PFHZZ A38931 GEAR,HELICAL PAHZZ A29438 WASHER,KEY PAHZZ A30063 NUT,CAMSHAFT PFHZZ GEAR,SPUR PFHZZ KEY,WOODRUFF PFHZZ CAMSHAFT,ENGINE PFHZZ BRACKET,MOUNTING PFHZZ J SCREW,CAP,HEXAGON H... 2 END OF FIGURE

54 Figure 10. Oil Pump

55 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0106 ENGINE LUBRICATION SYSTEM FIG. 10 OIL PUMP 1 PAHHH A38372 OIL PUMP ASSEMBLY,E PAHZZ A39896.STRAINER,OIL PUMP PFHZZ B1821BH025C125N.SCREW,CAP,HEXAGON H PFHZZ CBM21389.WASHER,LOCK XAHZZ G2039.COVER XAHZZ G49653.BUSHING,SLEEVE KBHZZ C1.GASKET PART OF KIT P/N A XAHZZ G2115.GEAR, OIL PUMP PAHZZ MS KEY,WOODRUFF XAHZZ G11335.SHAFT,STRAIGHT PAHZZ NAS561P4-6.PIN,SPRING XAHZZ G49654.BUSHING, BEARING XAHZZ G2109.BODY, OIL PUMP PAHZZ A VALVE,SAFETY RELIEF XAHZZ G48500.SPRING,HELICAL,COMP XAHZZ A29260.RETAINER,OIL RELIEF XAHZZ G11336.GEAR, DRIVE, OIL PFHZZ AN PIN,COTTER XAHZZ A39321.CAP,PROTECTIVE,DUST XAHZZ G49672.BUSHING,SLEEVE XAHZZ G11334.SHAFT, IDLER XAHZZ G11748.GEAR,SPUR PFHZZ F98.SCREW,CAP,HEXAGON H PFHZZ MS WASHER,LOCK EXTERNAL TOOTH PFHZZ MS SCREW,MACHINE XBHZZ G11337 SHIM XBHZZ G11338 SHIM PAHZZ A27365 O-RING PFHZZ J OIL PUMP ASSEMBLY,E PFHZZ SCREW,CAP,HEXAGON H M10 X PFFZZ GASKET PFFZZ TUBE ASSEMBLY,METAL OIL SUCTION PFFZZ SCREW,CAP,HEXAGON H M8 X END OF FIGURE

56 Figure 11. Oil Pans

57 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0106 ENGINE LUBRICATION SYSTEM FIG. 11 OIL PANS 1 KFFZZ A35273 GASKET, OIL PAN PART OF KIT P/N 1 A PAFZZ WASHER XBFZZ A STRIP PAFZZ A36717 OIL PAN WITH DRAIN PLUG XAFZZ A36718.OIL PAN WELDMENT ASSEMBLY PAFZZ A PLUG,MACHINE THREAD PAFZZ A58608.GASKET PART OF KIT P/N A PFFZZ SCREW,CAP,HEXAGON H M8 X PFFZZ PACKING,PREFORMED PFFZZ J COVER,ACCESS PFFZZ GASKET PFFZZ A77673 PARTS KIT,SEAL REPL INCLUDES OIL 1 PAN, OIL PUMP & DRAIN PLUG GASKETS.. 13 PFFZZ B8S OIL PAN PFFZZ SCREW,CAP,HEXAGON H M8 X PFFZZ WASHER,FLAT PFFZZ J PLUG,PIPE DRAIN PLUG FOR OIL PAN PFFZZ PLUG,MACHINE THREAD PFFZZ J WASHER,FLAT SEALING WASHER 22MM PFFZZ HOSE,NONMETALLIC PFFZZ J CLAMP,HOSE... 1 END OF FIGURE

58 Figure 12. Oil Filter and Dipstick

59 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0106 ENGINE LUBRICATION SYSTEM FIG. 12 OIL FILTER AND DIPSTICK 1 PAOZZ A GAGE ROD-CAP,LIQUID PAOZZ FILTER ELEMENT,FLUI LUBRICATING PFOZZ GAGE ROD-CAP,LIQUID PFOZZ TUBE,BENT,METALLIC PFOZZ GASKET PFOZZ COOLER,LUBRICATING PFOZZ GASKET PFOZZ PLUG,MACHINE THREAD PFOZZ O-RING PFOZZ SCREW,MACHINE PFOZZ J PLUG,PIPE PFOZZ J PLUG,MACHINE THREAD PFOZZ O-RING PFOZZ O-RING PFOZZ PLUNGER,PRESSURE PFOZZ J HEAD,FLUID FILTER PFOZZ ADAPTER,STRAIGHT,PI PFOZZ J FILTER ELEMENT,FLUI PFOZZ B8S VALVE,SAFETY RELIEF OIL PRESSURE... 1 END OF FIGURE

60 Figure 13. Army Oil Analysis Program (AOAP) Kit

61 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0106 ENGINE LUBRICATION SYSTEM FIG. 13 ARMY OIL ANALYSIS PROGRAM (AOAP) KIT 1 XDOZZ KIT,OIL ANALYSIS PAOZZ HV22-24.VALVE,BLEEDER,HYDRA PAOZZ S.NIPPLE,PIPE PAOZZ TEE,PIPE PAOZZ BUSHING,PIPE... 1 END OF FIGURE

62 Figure 14. Manifolds

63 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0108 MANIFOLDS FIG. 14 MANIFOLDS 1 PFOZZ B1821BH038C150N SCREW,CAP,HEXAGON H PFOZZ MS WASHER,FLAT XBOZZ A38188 PLATE, OUTLET COVER PFOZZ C1 GASKET PLATE PAOZZ X CLAMP,BRIDGE PFOZZ MS WASHER,FLAT PFOZZ M45913/1-6CG5C NUT,SELF-LOCKING,HE PAOZZ A MANIFOLD,EXHAUST PAOZZ G46872 GASKET PART OF KIT P/N A PAOZZ C1 GASKET PART OF KIT P/N A PAOZZ A MANIFOLD,INTAKE PFFZZ CW C WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ GASKET PAOZZ A20916 SPACER,RING PAOZZ L10283 ADAPTER BUSHING PFOZZ M45913/1-6CG5C NUT,SELF-LOCKING,HE PAOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFOZZ PLUG,MACHINE THREAD PFOZZ GASKET PFOZZ SCREW,CAP,HEXAGON H M8 X PFOZZ J MANIFOLD,INTAKE PFOZZ J GASKET PART OF KIT P/N A PFOZZ MANIFOLD,EXHAUST PFOZZ J BOLT,ASSEMBLED WASH M10 X PFOZZ GASKET PART OF KIT P/N A END OF FIGURE /(46 blank)

64

65 Figure 15. Fuel Injector Lines (Sheet 1 of 2)

66 Figure 15. Fuel Injector Lines (Sheet 2 of 2)

67 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0301 CARBERETOR,FUEL INJECTOR FIG. 15 FUEL INJECTOR LINES 1 PAFZZ TEE,TUBE PAFZZ A38644 COUPLING,TUBE PAFZZ NUT,TUBE COUPLING PAFZZ ML A BUSHING,NONMETALLIC PAFZZ BUSHING,NONMETALLIC PAFZZ NUT PAFZZ A TUBE,BENT,STEEL PAFZZ TEE,PIPE TO TUBE XBFZZ A38160 LOCKNUT,PIPE AOOZZ MF ELBOW,PIPE TO TUBE PAOZZ FL-3/8.NUT,TUBE COUPLING PAOZZ NUT,TUBE,COUPLING PAOZZ NUT,TUBE,COUPLING PFOZZ A38161 LOCKNUT,PIPE PAOZZ A51784 TUBE,BENT,METALLIC PAOZZ FL3-8X1-4 ELBOW,PIPE TO TUBE PAOZZ ELBOW,PIPE TO HOSE PAFZZ SCREW,MACHINE PAOZZ A58709 BRACKET,INJECTOR PAFZZ A37842 TUBE ASSEMBLY,METAL PFFZZ MS NUT,PLAIN,HEXAGON PAFZZ A37844 TUBE ASSEMBLY,METAL PAFZZ A37846 TUBE ASSEMBLY,METAL PAFZZ A37848 TUBE ASSEMBLY,METAL PAFZZ SPACER,SLEEVE PAFZZ CLAMP ASSEMBLY,NOZZ PFFZZ HANGER,PIPE PFFZZ BUMPER PFFZZ BRACKET,DOUBLE ANGL PFFZZ J SCREW,MACHINE M5 X PFFZZ FAIRLEAD,BLOCK PFFZZ SCREW,CAP,HEXAGON H M5 X PAFZZ B8S TUBE ASSEMBLY,METAL PAFZZ B8S TUBE ASSEMBLY,METAL PAFZZ B8S TUBE ASSEMBLY,METAL PAFZZ B8S TUBE ASSEMBLY,METAL PFFZZ J TUBE ASSEMBLY,METAL PFFZZ BOLT,FLUID PASSAGE PFFZZ J SEAL,PLAIN ENCASED PART OF KIT P/N 4 A PFFZZ FAIRLEAD,BLOCK... 1 END OF FIGURE

68 Figure 16. Fuel Injector

69 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0301 CARBURETOR, FUEL INJECTOR FIG. 16 FUEL INJECTOR 1 PAHZZ NOZZLE,FUEL INJECTI PFHZZ PLATE,NOZZLE LOCATI PAHZZ SPRING,HELICAL,COMP PFHZZ A44369.SEAT,HELICAL COMPRE PFHZZ NUT,PLAIN,HEXAGON XDHZZ SETSCREW PFHZZ ADJUSTER,PRESSURE PAHZZ NUT XAHZZ VALVE, NOZZLE BODY PAFZZ SPACER,SLEEVE PART OF KIT P/N 1 A PAFZZ WASHER,FLAT PART OF KIT P/N A XAHZZ NSS.BODY, NOZZLE PFFZZ J GASKET PAFZZ J INJECTOR ASSEMBLY,F PFFZZ SEAL,NONMETALLIC SP... 4 END OF FIGURE

70 Figure 17. Fuel Injection Pump Mounting and Gear

71 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0302 FUEL PUMPS FIG. 17 FUEL INJECTION PUMP MOUNTING AND GEAR 1 XDFZZ SEAL,ANTIPILFERAGE XBFZZ A30043 WASHER,FLAT PFFZZ MS NUT,PLAIN,HEXAGON PAFZZ G2076 GEAR,HELICAL PFFZZ B8S SPROCKET WHEEL PFFZZ A77775 WASHER,LOCK PFFZZ A41852 NUT,PLAIN,HEXAGON PFFZZ STUD,STRAIGHT,SHOUL M10 X PFFZZ NUT,PLAIN,EXTENDED M END OF FIGURE /(54 blank)

72

73 Figure 18. Fuel Injection Pump, Governor, and Solenoid (Sheet 1 of 2)

74 Figure 18. Fuel Injection Pump, Governor, and Solenoid (Sheet 2 of 2)

75 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0302 FUEL PUMPS FIG. 18 FUEL INJECTION PUMP, GOVERNOR, AND SOLENOID, MODEL PAFHH DB0431AL3813 PUMP,FUEL,METERING PAHZZ BUTTON,THRUST INJEC PAHZZ SPRING,HELICAL,COMP PAHZZ NUT,PLAIN,HEXAGON PAHZZ WASHER,LOCK PAHZZ PIN,SPRING PAHZZ A44710.SHAFT,SHOULDERED PAHZZ PACKING,PREFORMED PAHZZ O-RING PAHZZ SPRING,HELICAL,COMP PAHZZ VALVE,METERING SIZE A XBOZZ VALVE ASSEMBLY,METE SIZE B PAHZZ SPRING,HELICAL,COMP PAHZZ T11924.SEAT,HELICAL COMPRE PAHZZ SPRING,HELICAL,COMP PAHZZ ARM,GOVERNOR PAHZZ SPRING,HELICAL,EXTE PAHZZ N HOOK ASSEMBLY GOVER PAHZZ HOOK,GOVERNOR LINKA PADZZ LINK FUEL INJECTION PADZZ SCREW,MACHINE PADZZ WASHER,SPRING TENSI KBHZZ SOLENOID,FRAME ASSE PAHZZ CTH GASKET PAFZZ WASHER,SHOULDERED XDFZZ WASHER,FLAT PFFZZ MS NUT,PLAIN,HEXAGON PAFZZ WASHER,LOCK PAFZZ LEAD,IGNITION,ENGIN PAFZZ WASHER,FLAT PAHZZ WASHER,LOCK PFHZZ SCREW,MACHINE PAFZZ NUT,SELF-LOCKING,HE XDFZZ WASHER,FLAT PFFZZ MS WASHER,LOCK PAFZZ R91.COUPLING,PIPE XDHZZ SEAL,ANTIPILFERAGE PFHZZ COVER,GOVERNOR CONT PADZZ PIN,STRAIGHT,HEADED PADZZ SHIM PADZZ O-RING PADZZ CAM,SHUT OFF PADZZ LEVER,THROTTLE PAFZZ SEAT,HELICAL COMPRE PAHZZ ARM ASSEMBLY,METERI

76 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 45 PAHZZ SHIM PAHZZ NUT,PLAIN,HEXAGON PAHZZ O-RING PADZZ CAP,ADJUSTING SCREW PADZZ NUT,PLAIN,HEXAGON XDDZZ SETSCREW PADZZ O-RING PAHZZ STUD,SPRING GUIDE PFHZZ WASHER,FLAT PAHZZ SHAFT,SHOULDERED PAHZZ NUT,PLAIN,HEXAGON XBHZZ SCREW,MACHINE XBHZZ SPACER PFHZZ MS SCREW,CAP,SOCKET HE PAHZZ ARM,ADJUSTING SPACE PFHZZ LEVER ASSEMBLY THRO PAHZZ SPRING,HELICAL,TORS PAHZZ RETAINER,HELICAL CO PAHZZ SCREW,CAP,SOCKET HE PAHZZ NUT,PLAIN,HEXAGON PAHZZ SCREW,MACHINE PAHZZ SHAFT ASSY,THROTTLE XAHHH HOUSING ASSEMBLY PAHZZ BUSHING,SLEEVE PAHZZ BOLT,MACHINE PAHZZ COVER,ACCESS PAHZZ SCREW,MACHINE XBHZZ PLUG,MACHINE THREAD PAHZZ M83461/1-020.O-RING PAHZZ O-RING PAHZZ SHIM,ADVANCE SPRING XBHZZ SHIM XBHZZ SHIM PFHZZ R1.SPRING,HELICAL,COMP PAHZZ PISTON,FUEL INJECTO PAHZZ WASHER,CONCAVE PAHZZ GASKET PAHZZ WEIGHT,OVER-SPEED G PFHZZ MS RING,RETAINING XBHZZ RETAINER ASSEMBLY,G XAHZZ RETAINER, GOVERNOR PAHZZ RETAINER,PACKING XDHZZ HUB ASSEMBLY,GOVERN XBHZZ RETAINER ASSEMBLY,G PAHHH HYDRAULIC HEAD AND ROTOR ASSEMBLY PAHZZ SETSCREW PAHZZ WIRE,RETAINER PAHZZ WIRE,VENT XBHZZ WIRE, VENT, OVERSIZE PAHZZ PLUNGER,DETENT STANDARD

77 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 94 PAHZZ SETSCREW PAHZZ PIN,STRAIGHT,HEADLE XBHZZ SHOE SET,CAM ROLLER PAHZZ SPACER,PLATE PAFZZ SPACER,RING PAFZZ BOLT,FLUID PASSAGE PAHZZ PLUG ASSEMBLY,END P PAHZZ BOLT,FLUID PASSAGE PAHZZ O-RING PAFZZ FILTER ELEMENT,FLUI PAHZZ WASHER,FLAT PAHZZ O-RING PAHZZ SPRING,HELICAL,COMP PAHZZ N PIN,STRAIGHT,HEADLE PAHZZ A43869.SEAL,PISTON PAHZZ PLATE,END,FUEL PUMP PAFZZ WASHER,FLAT PAHZZ WASHER,LOCK XDHZZ SCREW PAHZZ CTH O-RING PAHZZ PLUG,MACHINE THREAD PAHZZ THRUST PLATE,FUEL I PAHZZ O-RING XDHZZ BLADE,PUMP,TRANSFER PAHZZ BLADE,TRANSFER PUMP OVERSIZE PAHZZ BLADE,TRANSFER PUMP OVERSIZE PAHZZ LINER,FUEL PUMP PAHZZ SCREW,VALVE RETAINI PAHZZ STOP,DELIVERY VALVE PFHZZ SLIDE,DIRECTIONAL C PAHZZ RING,RETAINING PAHZZ SPRING,HELICAL,COMP PAHZZ SPRING,HELICAL,COMP PAHZZ SPACER,SLEEVE PAHZZ SCREW,CAP,SOCKET HE ADJUSTING PAHZZ SPRING,FLAT PAHZZ O-RING PAHZZ COLLAR,SHAFT PAHZZ BEARING,WASHER,THRU PAHZZ BEARING,SLEEVE PAHZZ O-RING PAHZZ VALVE,SAFETY RELIEF XBHZZ PLUG PAHZZ O-RING PAHZZ SCREW CAM RING ADVA XBHZZ PISTON, POWER XDHZZ GASKET PAHZZ RING,PISTON PAHZZ O-RING PAHZZ M83461/1-020.O-RING

78 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 142 XBHZZ PLUG PFHZZ MS SCREW,DRIVE XBHZZ PLATE,IDENTIFICATIO... 1 END OF FIGURE /(61 blank)

79

80 Figure 19. Fuel Injection Pump

81 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0302 FUEL PUMPS FIG. 19 FUEL INJECTION PUMP, MODEL PAFZZ J PUMP,FUEL CAM ACTUA... 1 END OF FIGURE /(64 blank)

82

83 Figure 20. Fuel Pumps and Lines (Sheet 1 of 2)

84 Figure 20. Fuel Pumps and Lines (Sheet 2 of 2)

85 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0302 FUEL PUMPS FIG. 20 FUEL PUMPS AND LINES 1 PAOZZ ELBOW,HOSE PAOZZ F CLAMP,HOSE MOOZZ D64267 HOSE, FILTER SUPPLY MAKE FROM HOSE, 1 P/N PAOZZ L HOSE,NONMETALLIC PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ CBM21389 WASHER,LOCK PFOZZ MS WASHER,FLAT PFOZZ BUN9 A SCREW,CAP,HEXAGON H PBOZZ L60822 PUMP,FUEL,METERING PAOZZ TERMINAL,QUICK DISC PFOZZ J WASHER,FLAT PFOZZ BOLT,MACHINE M8 X PFOZZ J SCREW,CAP,HEXAGON H PFOZZ J BOLT,FLUID PASSAGE M12 X PFOZZ J BOLT,FLUID PASSAGE PFOZZ J WASHER,FLAT PFOZZ BOLT,FLUID PASSAGE PFOZZ J WASHER,FLAT PFOZZ BOLT,FLUID PASSAGE PFOZZ WASHER,FLAT 12 X 18 X 1-MM PAOZZ B8S TUBE ASSEMBLY,METAL PFOZZ TUBE ASSEMBLY,METAL PAOZZ J PUMP ASSY,SPECIAL PFOZZ B8S GASKET PFOZZ SPACER,PLATE PFOZZ SCREW,CAP,HEXAGON H PAOZZ ADAPTER,STRAIGHT,PI PAOZZ CLAMP,HOSE PAOZZ L HOSE ASSEMBLY,NONME CUT TO FIT PFOZZ SCREW,MACHINE M12 X PFOZZ J WASHER,FLAT... 2 END OF FIGURE

86 Figure 21. Air Cleaner

87 1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0304 AIR CLEANER FIG. 21 AIR CLEANER 1 PAOZZ GAX CAP,AIR CLEANER INT PAOZZ L TUBE,METALLIC PAOZZ A13240 CLAMP,LOOP PAOOO FWG AIR CLEANER,INTAKE XAOZZ NSS.BODY, AIR CLEANER PAOZZ SMP FILTER ELEMENT,INTA XAOZZ P PLATE, IDENTIFICATION PAOZZ P NUT,PLAIN,WING PAOZZ P DEFLECTOR,DIRT AND PAOZZ P CAP,AIR CLEANER INT PAOZZ P CLAMP,LOOP PAOZZ P VALVE,VACUATOR PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK PAOZZ P-7191 CLAMP,LOOP PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFOZZ P NIPPLE,PIPE PAOZZ FB1/8IN ELBOW,PIPE TO TUBE XBOZZ NSR TUBE, NYLON XBOZZ NIPPLE,PIPE PAOZZ B 1/8-27NPT NUT,SELF-LOCKING,HE PFOZZ ELBOW,PIPE PAOZZ L60151 INDICATOR,FILTER WA PAOZZ L HOSE,PREFORMED PFOZZ C36PS CLAMP,HOSE PAOZZ L HOSE,PREFORMED PAOZZ CLAMP,HOSE PAOOO A AIR CLEANER,INTAKE USED WITH MODEL XAOZZ NSS 2.BODY,AIR CLEANER PAOZZ CLAMP,LOOP PAOZZ WASHER,LOCK PAOZZ NUT,PLAIN,HEXAGON PAOZZ SCREW,CAP,HEXAGON PAOZZ A FILTER ELEMENT,INTA SECONDARY PFOZZ PPP NUT,SELF-LOCKING,HE PAOZZ A FILTER ELEMENT,INTA PRIMARY PFOZZ N6779.CAP,PROTECTIVE,DUST PFOZZ MS NUT,PLAIN,HEXAGON 1/ PFOZZ B1821BH025C175N.SCREW,CAP,HEXAGON H 1/4-20 X 1-3/4" 2 40 PFOZZ S VALVE,DUST PAOZZ ELBOW,PIPE TO TUBE XAOZZ NSS-3 SLEEVE PAOZZ A TUBE,NYLON PAOZZ E6818 NIPPLE,PIPE... 1 END OF FIGURE /(70 blank)

88

89 Figure 22. Fuel Tank and Lines (Sheet 1 of 2)

90 Figure 22. Fuel Tank and Lines (Sheet 2 of 2)

91 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0306 TANKS, LINES, FITTINGS, AND HEADERS FIG. 22 FUEL TANK AND LINES 1 PFOZZ SCREW,CAP,HEXAGON H PFOZZ CBM21389 WASHER,LOCK XBOZZ L PLATE, FUEL TANK PAOZZ L GASKET PAOZZ S25B391 NUT,PLAIN,BLIND RIV XBOZZ L74248 TUBE, RETURN PAOZZ F CLAMP,HOSE MOOZZ D64267 HOSE, RETURN MAKE FROM HOSE P/N MOOZZ L HOSE, FUEL MAKE FROM HOSE,P/N PAOZZ C ADAPTER,STRAIGHT,PI PAOZZ L53739 VALVE,PLUG PAOZZ J C ELBOW,PIPE PFOZZ MS S PLUG,PIPE PAOZZ ADAPTER,STRAIGHT,PI PAOZZ L TUBE,BENT,STEEL PAOZZ U CAP,FILLER OPENING PAOZZ CLAMP,HOSE MOOZZ L HOSE,NONMETALLIC 3/8 ID X 9", MAKE 1 FROM (72741) PAOZZ ADAPTER,STRAIGHT,PI PAOZZ ADAPTER,STRAIGHT,PI PAOZZ HOSE,NONMETALLIC... 1 END OF FIGURE

92 Figure 23. Fuel Strainer and In-Line Fuel Filter

93 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0309 FUEL FILTERS FIG. 23 FUEL STRAINER AND IN-LINE FUEL FILTER 1 PAOZZ MS STRAP,TIEDOWN,ELECT PAOZZ BF836K3 FILTER,FLUID PAOZZ L STRAINER,SUCTION... 1 END OF FIGURE

94 Figure 24. Fuel Filters

95 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0309 FUEL FILTERS FIG. 24 FUEL FILTERS 1 AOOOO A FILTER ASSEMBLY,FLU PAOZZ PLUG,MACHINE THREAD PAOZZ O-RING PFOZZ A HEAD,FLUID FILTER PAOZZ BF863.FILTER,FLUID PART OF KIT P/N A PAOZZ O-RING PAOZZ PLUG,MACHINE THREAD PFOZZ MS BOLT,MACHINE PFOZZ MS S.WASHER,LOCK XDOZZ A42315.GASKET PAOZZ PER78.FILTER ELEMENT,FLUI PART OF KIT P/N A PFOZZ STUD,CONTINUOUS THR PAOZZ B8S FILTER,FLUID... 1 END OF FIGURE

96 Figure 25. Quick Start Kit

97 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0311 ENGINE STARTING AIDS FIG. 25 QUICK START KIT 1 PAOZZ A20916 SPACER,RING COPPER PAOZZ L10283 ADAPTER BUSHING PAOZZ C0V0413 CLAMP,LOOP PAOZZ IHP115 PIN,LOCK PAOZZ MS BOLT,MACHINE PFOZZ MS S WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ QK-1027-B51 PARTS KIT,ETHER,STA XAOZZ QA1-2TC.NOZZLE, SPRAY XAOZZ LP TUBE, DELIVERY PAOZZ LP CLAMP ASSEMBLY XBOZZ QS1-2TC.VALVE XDOZZ LP ADAPTER,STRAIGHT,PI PFOZZ LP2290.NUT,PLAIN,WING PFOZZ MS S.WASHER,LOCK PFOZZ LP2287.STUD,PLAIN PFOZZ MS NUT,PLAIN,HEXAGON XAOZZ LP3904.CLAMP PAOZZ LP535 CYLINDER,ENGINE STA... 1 END OF FIGURE /(80 blank)

98

99 Figure 26. Accelerator (Sheet 1 of 2)

100 Figure 26. Accelerator (Sheet 2 of 2)

101 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0312 ACCELERATOR, THROTTLE, OR CHOKE CABLES FIG. 26 ACCELERATOR 1 PAOZZ BALL JOINT PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ A31804 STRAP,RETAINING PAOZZ SCREW,CAP,HEXAGON H PAOZZ L71193 PAD,PEDAL CUT TO FIT PAOZZ L70914 PEDAL,CONTROL PFOZZ B1821BH038C300N SCREW,CAP,HEXAGON H PFOZZ MS WASHER,FLAT PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ R103G BALL JOINT PAOZZ L79116 SPRING,HELICAL,COMP PFOZZ MS WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK XBOZZ L73462 BASE, ACCELERATOR PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PAOZZ L CONTROL ASSEMBLY,PU PFOZZ MS WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK PAOZZ COV-0613 CLAMP,LOOP PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H XDOZZ CLAMP,LOOP PFOZZ MS WASHER,FLAT XBOZZ L77755 BRACKET PFOZZ L12437 BALL JOINT ASSY PFOZZ A2 BRACKET,MOUNTING PFOZZ WASHER,LOCK PFOZZ INSERT,SCREW THREAD PFOZZ SCREW,CAP,HEXAGON H PFOZZ WASHER,FLAT PFOZZ L BRACKET,MOUNTING PFOZZ SCREW,CAP,HEXAGON PFOZZ WASHER,LOCK PFOZZ BRACKET,ANGLE PFOZZ NUT,PLANE HEXAGON PFOZZ WASHER,FLAT PFOZZ SCREW,CAP,HEXAGON PFOZZ WASHER,FLAT PFOZZ WASHER,FLAT PFOZZ BOLT,FLUID PASSAGE PFOZZ R1 WASHER,FLAT

102 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 45 PFOZZ A77512 ELBOW,PIPE TO TUBE PFOZZ B8S SCREW,CAP,HEXAGON H PFOZZ O-RING PART OF KIT P/N A PFOZZ SOLENOID,ELECTRICAL PFOZZ SA4620 SPRING,HELICAL,COMP PFOZZ C1 STRAP,TIEDOWN,ELECT PFOZZ J BOOT,DUST AND MOIST PFOZZ NUT,PLAIN,HEXAGON PFOZZ WASHER,LOCK PFOZZ BALL JOINT ASSEMBLY PFOZZ B8S WASHER,FLAT PFOZZ NUT,PLAIN,HEXAGON PFOZZ J LEVER,REMOTE CONTRO PFOZZ BOLT,MACHINE PFOZZ C1 SPACER,SLEEVE PFOZZ C1 O-RING PFOZZ O-RING PART OF KIT P/N A PFOZZ B8S UNION,TUBE PFOZZ CAP,PIPE PFOZZ TEE,PIPE PFOZZ HOSE ASSEMBLY,NONME PFOZZ C1 BOLT,MACHINE PFOZZ CONNECTING LINK,RIG PFOZZ WASHER,FLAT 6.5MM X 12MM PFOZZ NUT,PLAIN,HEXAGON PFOZZ WASHER,FLAT PFOZZ PLUG,TIMING M PFOZZ J WASHER,LOCK PFOZZ A77720 INSERT,SCREW THREAD... 1 END OF FIGURE

103 Figure 27. Muffler and Pipes (Sheet 1 of 2)

104 Figure 27. Muffler and Pipes (Sheet 2 of 2)

105 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 04 EXHAUST SYSTEM GROUP 0401 MUFFLER AND PIPES FIG. 27 MUFFLER AND PIPES 1 PAOZZ L PIPE,EXHAUST PAOZZ A13240 CLAMP,LOOP PAOZZ NREVA MUFFLER,EXHAUST XBOZZ L BRACKET, MUFFLER PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK PFOZZ MS WASHER,FLAT PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFOZZ MS NUT,PLAIN,HEXAGON XDOZZ C1 GASKET PFOZZ B1821BH038C150N SCREW,CAP,HEXAGON H PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS S WASHER,LOCK PAOZZ L BRACKET,ANGLE PFOZZ MS BOLT,MACHINE PFOZZ M45913/1-5CG5C NUT,SELF-LOCKING,HE PAOZZ L HANGER,ENGINE EXHAU PFOZZ MS WASHER,FLAT PFOZZ MS BOLT,MACHINE PAOZZ C91 CLAMP,LOOP PAOZZ PIPE,EXHAUST PAOZZ L HANGER,ENGINE EXHAU PAOZZ WASHER,FLAT PAOZZ NUT,PLAIN,HEXAGON PAOZZ A CLAMP,LOOP PAOZZ A MUFFLER,EXHAUST PAOZZ D76195 SPACER,SLEEVE PAOZZ BRACKET,ANGLE PFOZZ MS WASHER,FLAT PAOZZ SCREW,CAP,HEXAGON 3/8 X 2" PAOZZ WASHER,LOCK HD M PAOZZ SCREW,CAP,HEXAGON M12 X 25MM PAOZZ WASHER,LOCK 3/8" PAOZZ NUT,PLAIN,HEXAGON 3/8" PAOZZ SCREW,CAP,HEXAGON M10 X PAOZZ WASHER,LOCK M PAOZZ J GASKET PAOZZ ADAPTER AND FLANGE PAOZZ L BRACKET,ANGLE PAOZZ SCREW,CAP HEXAGON... 6 END OF FIGURE /(88 blank)

106

107 Figure 28. Radiater (Sheet 1 of 2)

108 Figure 28. Radiater (Sheet 2 of 2)

109 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 05 COOLING SYSTEM GROUP 0501 RADIATOR, EVAPORATIVE COOLER, OR HEAT EXCHANGER FIG. 28 RADIATOR 1 PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFOZZ H2525M WASHER,LOCK PAOZZ L COVER,ACCESS XBFZZ L SHROUD, RADIATOR XBOZZ L PLATE, INFORMATION, SHIPPING DATA XBOZZ RIVET, POP PAOZZ L RADIATOR,ENGINE COO PAOZZ C36PS CLAMP,HOSE PAOZZ L74743 HOSE,PREFORMED UPPER PAOZZ L HOSE,PREFORMED LOWER PFFZZ M45913/1-6CG5C NUT,SELF-LOCKING,HE XBFZZ D52275 WASHER, SNUB PAFZZ J BUSHING,NONMETALLIC PAFZZ HOSE,NONMETALLIC PAFZZ AA59440/2-010 COCK,DRAIN PFFZZ MS NUT,PLAIN,HEXAGON PAOZZ AAX CAP,FILLER OPENING PFFZZ H2525M WASHER,LOCK PFFZZ MS WASHER,FLAT XBFZZ L50641 STRAP, RADIATOR PFFZZ B1821BH038C125N SCREW,CAP,HEXAGON H PFFZZ MS NUT,PLAIN,HEXAGON PFFZZ ERNA245 WASHER,LOCK PFFZZ B1821BH050C175N SCREW,CAP,HEXAGON H XBOZZ L PLATE, MAINTENANCE PFFZZ B1821BH038C150N SCREW,CAP,HEXAGON H PAFZZ L TANK,RADIATOR,OVERF PFOZZ BOLT,MACHINE M10 X 40MM PFOZZ WASHER,FLAT PFOZZ CB MOUNT,RESILIENT,GEN PFOZZ WASHER,FLAT PFOZZ NUT,PLAIN,HEXAGON PFOZZ A SHROUD,FAN,RADIATOR PFOZZ A1 GUARD,FAN,IMPELLER PFOZZ WASHER,FLAT M PFOZZ A GASKET UPPER RADIATOR MOUNTING PFOZZ SCREW,CAP,HEXAGON M8 X 20MM PFOZZ CLAMP,MECHANICAL UPPER HOSE PFOZZ A1 HOSE,PREFORMED LOWER PFOZZ SCREW,CAP,HEXAGON M10 X 25MM PFOZZ CLAMP,LOOP UPPER HOSE PFOZZ A1 HOSE,PREFORMED UPPER

110 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 43 PFOZZ BRACKET,ANGLE PFOZZ CAP,FILLER OPENING PFOZZ WASHER,LOCK PFOZZ NUT,PLAIN,HEXAGON PAOFF RADIATOR,ENGINE COO PFOZZ A CAP,FILLER OPENING PFOZZ H461 HOSE,NONMETALLIC OVERFILL HOSE... 1 END OF FIGURE /(93 blank)

111

112 Figure 29. Thermostat

113 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0503 WATER MANIFOLD,HEADERS, THERMOSTATS, AND GASKET FIG. 29 THERMOSTAT 1 PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFOZZ H2525M WASHER,LOCK XBOZZ G2144 HOUSING, THERMOSTAT AND WATER 1 OUTLET... 4 PAOZZ C1 GASKET PFOZZ MS THERMOSTAT,FLOW CON PFOZZ J GASKET PFOZZ THERMOSTAT,FLOW CON PFOZZ WATER OUTLET,ENGINE PFOZZ BOLT,ASSEMBLED WASH M8 X PFOZZ J GASKET PART OF KIT P/N A PFOZZ B8S CONNECTION,WATER IN PAOZZ BUSHING,PIPE USED ON ENGINE INSTALL PFOZZ AA59440/2-010 COCK,DRAIN USED ON ENGINE INSTALL PFOZZ L13809 HOSE,NONMETALLIC PFOZZ BOLT,ASSEMBLED WASH M10 X PFOZZ WWP471 PLUG,MACHINE THREAD 1/2 PIPE... 1 END OF FIGURE

114 Figure 30. Water Pump

115 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0504 WATER PUMP FIG. 30 WATER PUMP 1 KFOZZ A38084 GASKET PART OF KIT P/N A PAOZZ S-908 PLUG,PIPE PAOZZ A PUMP,COOLING SYSTEM PAOZZ A OUTLET,PIPE XAOZZ A BODY, WATER PUMP PFFZZ H2525M WASHER,LOCK PFOZZ B-0611 SCREW,CAP,HEXAGON H PAOZZ A38083 GASKET PART OF KIT P/N A PART 1 OF KIT P/N A PFOZZ A37753 IMPELLER,PUMP,CENTR PAOZZ A7085 WASHER,COPPER PFOZZ B-0611 SCREW,CAP,HEXAGON H PAOZZ PT-349 BOLT,MACHINE PAOZZ MS S WASHER,LOCK PAOZZ G11339 PULLEY,GROOVE PAOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK PFOZZ B1821BH038C300N SCREW,CAP,HEXAGON H PFOZZ MS WASHER,FLAT PAOZZ A29433 STUD,PLAIN PAOZZ O-RING PART OF KIT P/N A PART 1 OF KIT P/N A PAOZZ B PLUG,PIPE PAOZZ MS SCREW,CAP,HEXAGON H PFOZZ PARTS KIT,ENGINE WA PFOZZ O-RING 3 1/2 ID X 3/ PFOZZ B8S SCREW,CAP,HEXAGON H M8 X END OF FIGURE

116 Figure 31. Fan Blade

117 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0505 FAN ASSEMBLY FIG. 31 FAN BLADE 1 PAOZZ A IMPELLER,FAN,AXIAL PAOZZ MS BOLT,MACHINE PFOZZ MS S WASHER,LOCK PFOZZ BRACKET,MOUNTING PFOZZ ARM,ADJUSTING,BELT PFOZZ BOLT,ASSEMBLED WASH M10 X PFOZZ SCREW,MACHINE M8 X PFOZZ SCREW,CAP,HEXAGON H M8 X PFOZZ BRACKET,ENGINE ASSY PFOZZ RING,RETAINING PFOZZ HUB,FAN CLUTCH PFOZZ PULLEY,GROOVE PFOZZ A SPACER,SPECIAL SHAP PFOZZ C1 IMPELLER,FAN,AXIAL PFOZZ WASHER,LOCK PFOZZ SCREW,CAP,HEXAGON PFOZZ BOLT,ASSEMBLED WASH M8 X PFOZZ GASKET PFOZZ SCREW,CAP,HEXAGON H M10 X PFOZZ ROLLER,BEARING... 1 END OF FIGURE

118 Figure 32. Alternator and Mounting

119 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0601 GENERATOR, ALTERNATOR FIG. 32 ALTERNATOR AND MOUNTING 1 XBOZZ G11271 SPACER PAOZZ A34705 ARM,ADJUSTING,BELT PFOZZ MS WASHER,FLAT PAOZZ WASHER,SPRING TENSI PAOZZ SCREW,MACHINE PAOZZ S PULLEY,GROOVE PAOZZ MS51066RP50 BELT,V PFOZZ B1821BH038C300N SCREW,CAP,HEXAGON H PAOZZ A BRACKET,ENGINE ACCE PAOZZ L71879 SEMICONDUCTOR DEVIC XDOZZ PLT2I-M30 STRAP,TIEDOWN ELECT PFOZZ H2525M WASHER,LOCK PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFOZZ M45913/1-6CG5C NUT,SELF-LOCKING,HE PAOZZ IMPELLER,FAN,CENTRI PFOZZ SUPPORT,ARMATURE PFOZZ WASHER,LOCK PFOZZ PULLEY,GROOVE PFOZZ R1 IMPELLER,FAN,CENTRI PFOZZ SCREW,CAP,HEXAGON H M8 X PFOZZ ALTERNATOR BRACE PFOZZ BUSHING,SLEEVE PFOZZ WASHER,LOCK PFOZZ BOLT,MACHINE M10 X PFOZZ BOLT,MACHINE M8 X PFOZZ BELT,V... 1 END OF FIGURE

120 Figure 33. Alternator

121 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0601 GENERATOR, ALTERNATOR FIG. 33 ALTERNATOR 1 PAOZF Y875 SAW GENERATOR,ALTERNATI USED ON MODEL PFOZZ A GENERATOR,ENGINE AC USED ON MODEL END OF FIGURE

122 Figure 34. Starter and Mounting for Model

123 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0603 STARTING MOTOR FIG. 34 STARTER AND MOUNTING FOR MODEL PAOZZ L40793 LEAD,IGNITION,ENGIN PFOZZ RD757.TERMINAL,LUG PFOZZ F98 SCREW,CAP,HEXAGON H PFOZZ WASHER,LOCK PFOZZ MS WASHER,FLAT XDFZZ RELAY,ELECTROMAGNET PAOZZ A18311 LEAD,ELECTRICAL XBOZZ L PLATE, SOLENOID PAOZZ SCREW,MACHINE PAOZZ L11342 CIRCUIT BREAKER 25 AMPS PFOZZ MS WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK PAOZZ B1821BH038C200N SCREW,CAP,HEXAGON H PAOZF T0Y2 CME STARTER,ENGINE,ELEC 24 VOLT,USED 1 ON ENGINE 207 ONLY... END OF FIGURE

124 Figure 35. Starter and Mounting for Model

125 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0603 STARTING MOTOR FIG. 35 STARTER AND MOUNTING FOR MODEL PAOZZ 0E5W STARTER,ENGINE,ELEC USED ON MODEL ONLY... 2 PFOZZ WASHER,LOCK PFOZZ BOLT,ASSEMBLED WASH M10 X 35, USED 2 WITH ENGINE END OF FIGURE

126 Figure 36. Instrument Panel

127 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0607 INSTRUMENT OR CONTROL FIG. 36 INSTRUMENT PANEL 1 PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS WASHER,LOCK XDOZZ GAGE,LIQUID QUANTIT PAOZZ D GAGE,LIQUID QUANTIT PRESSURE, PSI... 5 PAOZZ LAMP,INCANDESCENT PAOZZ L73576 RESISTOR,FIXED,WIRE PAOZZ H LIGHT,INDICATOR PAOZZ TERMINAL BODY,QUICK PAOZZ AHU LIGHT,INDICATOR TRANSMISSION TEMP XAOZZ CONNECTOR XDOZZ TERMINAL,QUICK DISC PAOZZ WRR LIGHT,INDICATOR ENGINE OIL PRESSURE 1 13 XAOZZ CONNECTOR XDOZZ TERMINAL,QUICK DISC PAOZZ M4183 LIGHT,INDICATOR ALTERNATOR XAOZZ CONNECTOR XDOZZ TERMINAL,QUICK DISC PAOZZ AHU LIGHT,INDICATOR ENGINE TEMP XAOZZ CONNECTOR XDOZZ TERMINAL,QUICK DISC PAOZZ L71879 SEMICONDUCTOR DEVIC XBOZZ LS220 KEY, IGNITION PFOZZ R44342 NUT,TUBE COUPLING PAOZZ SWITCH,LOCK,IGNITIO SN AND 1 ABOVE PAOZZ SWITCH,LOCK,IGNITIO SN AND 1 BELOW PAOZZ L CIRCUIT BREAKER ASSEMBLY, 6 AMP PAOZZ CIRCUIT BREAKER PAOZZ TERMINAL,QUICK DISC PAOZZ CONTACT SET,RELAY XDOZZ SCREW,MACHINE PAOZZ METER,TIME TOTALIZI XDOZZ L WIRE, LEAD, GROUND, XDOZZ SAEB104.TERMINAL, LUG XDOZZ SAEB106.TERMINAL, LUG PFOZZ MS SWITCH,TOGGLE PAOZZ L CIRCUIT BREAKER ASSEMBLY, 10 AMP PAOZZ TERMINAL,LUG PAOZZ H CIRCUIT BREAKER PAOZZ TERMINAL,QUICK DISC XDOZZ PLT2I-M30 STRAP,TIEDOWN ELECT PAOZZ L CIRCUIT BREAKER ASSEMBLY, 6 AMP PAOZZ TERMINAL,LUG PAOZZ CIRCUIT BREAKER

128 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 43 PAOZZ TERMINAL,QUICK DISC PAOZZ SWITCH,PUSH PAOZZ L60490 BOOT,DUST AND MOIST XDOZZ MS SWITCH ASSEMBLY PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS WASHER,LOCK PFOZZ MS WASHER,FLAT PFOZZ B1821BH044C113N SCREW,CAP,HEXAGON H XBOZZ L PANEL, INSTRUMENT XBOZZ L PLATE, IDENTIFICATION, RANGE 1 CONTROL XBOZZ L PLATE, IDENTIFICATION, SHIFT 1 CONTROL XBOZZ L PLATE, IDENTIFICATION, VEHICLE 1 LIGHTS XBOZZ L PLATE, XBOZZ L PLATE, IDENTIFICATION, REAR 1 FLOODLIGHT SWITCH XBOZZ L PLATE, IDENTIFICATION, FRONT 1 FLOODLIGHT SWITCH XBOZZ L PLATE, IDENTIFICATION, IGNITION XBOZZ L PLATE, IDENTIFICATION, ROTATE 1 CONTROL XBOZZ L PLATE, IDENTIFICATION, SIDE SHIFT 1 CONTROL XBOZZ L PLATE, IDENTIFICATION, LIFT CONTROL 1 62 XBOZZ L PLATE, IDENTIFICATION, TILT CONTROL 1 63 XBOZZ L PLATE IDENTIFICATION,HYDRAULIC 1 FILTER LIGHT PFOZZ AD64ADS RIVET,BLIND PAOZZ SCREW,MACHINE PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS WASHER,LOCK PAOZZ BOOT,VEHICULAR COMP XBOZZ AN931-B5-12 GROMMET, INSTRUMENT PANEL PAOZZ R LAMP,INCANDESCENT PAOZZ WASHER,KEY... 2 END OF FIGURE /(111 blank)

129

130 Figure 37. Slave Receptacle

131 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0608 MISCELLANEOUS ITEMS FIG. 37 SLAVE RECEPTACLE 1 PAOZZ L CABLE ASSY,SPECIAL RECEPTACLE TO 1 GROUND... 2 PFOZZ MS WASHER,FLAT PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ L CABLE ASSY,SPECIAL RECEPTACLE TO 1 STARTER... 5 PFOZZ CONNECTOR,RECEPTACL ELECTRICAL, 1 SLAVE... 6 PAOZZ SCREW,MACHINE PAOZZ CAP,PROTECTIVE,DUST... 1 END OF FIGURE

132 Figure 38. Flood Lights

133 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0609 LIGHTS FIG. 38 FLOODLIGHTS 1 PFOZZ L LEAD WIRE,ELECTRICA PAOZZ W-4 FLOODLIGHT,ELECTRIC PAOZZ E LAMP,INCANDESCENT PAOZZ MN-1030B BOOT,DUST AND MOIST MOOZZ RUBBER ROUND SECTIO MAKE FROM HOSE 2 P/N S PFOZZ L WIRING HARNESS XBOZZ GROMMET, ROPS PAOZZ A1 HEADLIGHT... 1 END OF FIGURE

134 Figure 39. Blackout Driving Lamp

135 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0609 LIGHTS FIG. 39 BLACKOUT DRIVING LAMP 1 PAOZZ HEADLIGHT PAOZZ ADAPTER,CONNECTOR PAOZZ GROMMET,NONMETALLIC PFOZZ HOUSING,LIGHT PAOZZ WASHER,SLOTTED PAOZZ SHELL,ELECTRICAL CO PAOZZ CLIP,RETAINING PFOZZ LAMP UNIT,VEHICULAR WIRING ASSY PAOZZ GL RETAINER,LENS PAOZZ RING,RETAINING PAOZZ SCREW,MACHINE PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M.WASHER,LOCK PAOZZ WASHER,FINISHING PAOZZ LA LAMP,INCANDESCENT... 1 END OF FIGURE

136 Figure 40.Blackout Stoplight-Taillight

137 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0609 LIGHTS FIG. 40 BLACKOUT STOPLIGHT-TAILLIGHT 1 PFOOO MS STOP LIGHT-TAILLIGH 24-VOLT PAOZZ RETAINER,LENS PAOZZ SCREW,MACHINE PAOZZ RING,RETAINING PAOZZ BXANSI1251.LAMP,INCANDESCENT XDOZZ LAMPHOLDER ASSEMBLY PAOZZ O-RING PFOZZ MS LIGHT,PARKING PFOZZ MS SCREW,MACHINE PFOZZ H2525M WASHER,LOCK PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PAOZZ STYLE15 GROMMET,NONMETALLIC... 2 END OF FIGURE

138 Figure 41. Stop and Taillight

139 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0609 LIGHTS FIG. 41 STOP AND TAILLIGHT 1 PAOZZ A1 STOP LIGHT-TAILLIGH PAOZZ LAMP,INCANDESCENT PFOZZ ERNA245 WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ MN-1030B BOOT,DUST AND MOIST... 2 END OF FIGURE

140 Figure 42. Sending Units

141 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0610 SENDING UNITS AND WARNING SWITCHES FIG. 42 SENDING UNITS 1 PAOZZ L SWITCH,THERMOSTATIC ENGINE 1 TEMPERATURE... 1 PAOZZ L SWITCH,THERMOSTATIC TRANSMISSION 1 TEMPERATURE,265F,FOR ENGINE 207 ONLY 2 PFOZZ MS WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ A31060 LEAD,ELECTRICAL PFOZZ MS SCREW,MACHINE PAOZZ L77590 GASKET PAOZZ L TRANSMITTER,LIQUID TANK PAOZZ R4.GASKET PFOZZ MS C NUT,SELF-LOCKING,HE XDOZZ C1 SWITCH,TOGGLE PAOZZ J BUSHING,PIPE USED WITH MODEL XBOZZ FITTING USED ON ENGINE 207 ONLY PAOZZ TEE,PIPE USED ON ENGINE ONLY PAOZZ TEE,PIPE USED ON ENGINE 207 ONLY PAOZZ A SWITCH,PRESSURE OIL PRESSURE 1 SWITCH,FOR ENGINE ONLY PAOZZ D63294 SWITCH,PRESSURE USED ON ENGINE ONLY PAOZZ W10140 RESISTOR,THERMAL OIL PRESSURE 1 SENDER, FOR ENGINE ONLY PAOZZ SWITCH,PRESSURE USED ON ENGINE ONLY PFOZZ MS WASHER,LOCK PAOZZ H SWITCH,PRESSURE FILTER... 1 END OF FIGURE

142 Figure 43. Horn and Backup Alarm

143 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0611 HORN, SIREN FIG. 43 HORN AND BACKUP ALARM 1 PFOZZ B1821BH038C125N SCREW,CAP,HEXAGON H PAOZZ A HORN,ELECTRICAL PFOZZ H2525M WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ D SWITCH,PRESSURE BACK-UP ALARM FOR 1 MODEL PAOZZ M-4010 SWITCH,PRESSURE ALARM FOR MODEL PAOZZ BUSHING,PIPE USED WITH MODEL PFOZZ A-A HORN,ELECTRICAL PAOZZ LEAD,ELECTRICAL GROUNDING PFOZZ RB733.TERMINAL,LUG XAOZZ SAEB104.TERMINAL, LUG... 1 END OF FIGURE

144 Figure 44. Batteries and Related Parts

145 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0612 BATTRIES, STORAGE (WET OR DRY) FIG. 44 BATTERIES AND RELATED PARTS 1 PFOZZ MS BOLT,MACHINE PAOZZ L BRACKET,EYE,NONROTA PAOZZ L CABLE ASSY,SPECIAL XDOFF TLFP BATTERY,STORAGE PAOZZ L LEAD,STORAGE,BATTER STARTER,RED, 1 USED ON ENGINE ONLY... 5 PAOZZ L CABLE ASSY,SPECIAL STARTER, RED PAOZZ L LEAD,STORAGE,BATTER GROUND,USED ON 1 ENGINE ONLY... 6 PAOZZ L14542 LEAD,STORAGE BATTER GROUND XBOZZ Z440 GROMMET PFOZZ L BRACKET,ANGLE PFOZZ MS WASHER,FLAT PAOZZ RECEPTACLE,TURNLOCK PAOZZ WASHER,SPLIT PAOZZ L COVER,BATTERY BOX PAOZZ STUD,TURNLOCK FASTE... 2 END OF FIGURE

146 Figure 45. Front Main Wiring Harness

147 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0613 HULL OR CHASSIS WIRING HARNESS FIG. 45 FRONT MAIN WIRING HARNESS 1 PAOOO L WIRING HARNESS,BRAN XDOZZ SG3106-E28-51S.CONNECTOR,PLUG,ELEC PAOZZ TERMINAL,LUG XDOZZ TERMINAL,QUICK DISC XBOZZ SAETYPE10-156DIA.TERMINAL AWG 6 PAOZZ CONNECTOR BODY,PLUG PFOZZ TERMINAL,QUICK DISC PAOZZ L71879.SEMICONDUCTOR DEVIC PAOZZ NUT,PLAIN,HEXAGON XBOZZ PLUG PAOZZ WASHER,LOCK XBOZZ HD PN.CONNECTOR XBOZZ SOCKET PAOZZ EE CONTACT,ELECTRICAL PAOZZ FUSEHOLDER,EXTRACT PAOZZ L73576.RESISTOR,FIXED,WIRE PAOZZ LAMPHOLDER PAOZZ D4161.CONTACT,ELECTRICAL PFOZZ MS CONNECTOR,PLUG,ELEC PFOZZ TERMINAL,QUICK DISC XBOZZ CONNECTOR, TERMINAL XBOZZ SAEB104.TERMINAL, LUG PFOZZ F98.SCREW,CAP,HEXAGON H PAOZZ C0V0413.CLAMP,LOOP PFOZZ WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ COV-1311.CLAMP,LOOP XDOZZ PLT2I-M30.STRAP,TIEDOWN ELECT PFOZZ CLAMP,LOOP... 3 END OF FIGURE

148 Figure 46. Rear Main Wiring Harness, Relay Panel, and Components (Sheet 1 of 3)

149 Figure 46. Rear Main Wiring Harness, Relay Panel, and Components (Sheet 2 of 3)

150 Figure 46. Rear Main Wiring Harness, Relay Panel, and Components (Sheet 3 of 3)

151 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0613 HULL OR CHASSIS WIRING HARNESS FIG. 46 REAR MAIN WIRING HARNESS, RELAY PANEL, AND COMPONENTS 1 PAOZZ L60834 WIRING HARNESS,BRAN XBOZZ SAEB104.TERMINAL LUG XBOZZ SAEB207.TERMINAL, LUG PFOZZ RB733.TERMINAL,LUG PFOZZ RB2237.TERMINAL,LUG XBOZZ SAETYPE10-156DIA.TERMINAL AWG 7 XBOZZ SAETYPE1-180DIA1.TERMINAL AWG 8 PFOZZ MS TERMINAL,LUG XBOZZ CONNECTOR XDOZZ TERMINAL,QUICK DISC PFOZZ TERMINAL,QUICK DISC PAOZZ U.FUSEHOLDER,EXTRACTO PAOZZ L73576.RESISTOR,FIXED,WIRE PAOZZ L71879.SEMICONDUCTOR DEVIC XBOZZ SOCKET PAOZZ EE CONTACT,ELECTRICAL XBOZZ HD SN.PLUG XBOZZ PLUG PAOZZ X CAPACITOR,FIXED,PAP XBOZZ SAEB203.TERMINAL, LUG XBOZZ SAEB306.TERMINAL, LUG PFOZZ B1821BH038C125N.SCREW,CAP,HEXAGON H PAOZZ D40471.CLAMP,LOOP PFOZZ H2525M.WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ B1821BH038C075D.SCREW,CAP,HEXAGON H PAOZZ C0V0913Z1.CLAMP,LOOP PAOZZ COV-1313.CLAMP,LOOP PAOZZ COV-0613.CLAMP,LOOP XDOZZ PLT2I-M30.STRAP,TIEDOWN ELECT PFOZZ WIRING HARNESS,BRAN PAOZZ WIRING HARNESS,BRAN PFOZZ BRACKET,ANGLE PAOZZ L71879 SEMICONDUCTOR DEVIC PAOZZ L WIRING HARNESS,BRAN PAOZZ L WIRING HARNESS,BRAN PAOZZ A1 RELAY,ELECTROMAGNET STARTER LOCKOUT 1 38 PAOZZ MS NUT,PLAIN,HEXAGON HD 1/4-20" PAOZZ MS WASHER,LOCK 1/4" PAOZZ SCREW,CAP,HEXAGON PAOZZ B1821BH025C075N SCREW,CAP,HEXAGON H 1/4 X 20 X 3/4" 3 42 PAOZZ MS SCREW,MACHINE HD #8-32 X 1" PAOZZ MS SCREW,MACHINE #8-32 X 3/4"

152 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 44 PAOZZ B1821BH025C375N SCREW,CAP,HEXAGON H 1/4-20 X 3.75" PAOZZ L RESISTOR,FIXED,COMP 100 OHM FIXED 1 RESISTER PAOZZ L77823 GROMMET PFOZZ L BRACKET,ANGLE PFOZZ SCREW,CAP,HEXAGON 3/8 X 50" PFOZZ WASHER,FLAT 3/8" PAOZZ WASHER,LOCK PAOZZ NUT,PLAIN,HEXAGON 3/8" PAOZZ SCREW,CAP,HEXAGON H 3/8 X 1.50" PAOZZ SCREW,CAP,HEXAGON PAOZZ WASHER,SPLIT M PAOZZ L CABLE ASSEMBLY,SPEC PAOZZ WASHER,LOCK 3/8" PAOZZ WASHER,LOCK 3/ MOOZZ TBD-123 SPACER SLEEVE 2 3/4"LG, MAKE FROM 2 BULK PVC PN 48925K91 (39428) PAOZZ L COVER,ACCESS PFOZZ MS WASHER,FLAT PAOZZ MS NUT,PLAIN,HEXAGON HD # PAOZZ MS WASHER,LOCK HD # PAOZZ L TERMINAL BLOCK,ELEC PAOZZ C1 RELAY,ELECTROMAGNET STARTER RELAY PAOZZ L LEAD,ELECTRICAL PAOZZ L WIRING HARNESS,BRAN PAOZZ L BRREAKER,CIRCUIT 25 AMP PAOZZ NUT,PLAIN,HEXAGON PAOZZ WASHER,LOCK PAOZZ CLAMP,LOOP PAOZZ L CAPACITOR,FIXED,QUA... 1 END OF FIGURE /(135 blank)

153

154 Figure 47. Transmission Mounting

155 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 07 TRANSMISSION GROUP 0700 TRANSMISSION ASSEMBLY FIG. 47 TRANSMISSION MOUNTING 1 PFOZZ B1821BH038C175N SCREW,CAP,HEXAGON H PFOZZ H2525M WASHER,LOCK PGFHH L TRANSMISSION,HYDRAU PFOZZ MS WASHER,FLAT PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ AA59616ACADBUE PLUG,PIPE PFOZZ A19068 WASHER,FLAT PFOZZ M45913/2-12CG5C NUT,SELF-LOCKING,HE XBOZZ L MOUNT, TRANSMISSION PFOZZ B1821BH075C150N SCREW,CAP,HEXAGON H XBOZZ D34666 WASHER,FLAT PFOZZ ASME-B SCREW,CAP,HEXAGON H PAOZZ A59077 STUD,PLAIN PFOZZ B1821BH038F150N SCREW,CAP,HEXAGON H... 8 END OF FIGURE

156 Figure 48. Torque Converter Group

157 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0708 TORQUE CONVERTER OR FLUID COUPLING FIG. 48 TORQUE CONVERTER GROUP 1 PFHZZ B1821BH038C125N SCREW,CAP,HEXAGON H PFHZZ H2525M WASHER,LOCK PAHZZ SUPPORT,PUMP DRIVE PAHZZ RING,SPECIAL PAHZZ DX175 BEARING,BALL,ANNULA PAHZZ RING,RETAINING PAHZZ GEAR,SPUR PFHZZ B1821BH038C125N SCREW,CAP,HEXAGON H PFHZZ H2525M WASHER,LOCK PAHZZ RING,RETAINING PAHZZ SUPPORT,PUMP DRIVE PAHZZ RING,RETAINING PFHZZ K BEARING,BALL,ANNULA PAHZZ RING,RETAINING PAHZZ GEAR,PUMP DRIVE PAHZZ RING,RETAINING PAHZZ RING,SPECIAL PAHZZ GEAR,IDLER PAHZZ DX175 BEARING,BALL,ANNULA PAHZZ RING,SPECIAL PAHZZ RING,RETAINING PFHZZ GASKET PART OF KIT P/N PAHZZ GEAR,IMPELLER HUB PFHZZ O-RING PART OF KIT P/N D XBHZZ IMPELLER PAHZZ LOCKING PLATE,NUT A PFHZZ A1326 SCREW,CAP,HEXAGON H XBHZZ SPACER, BEARING XBHZZ REACTION MEMBER PAHZZ MS RING,RETAINING XDHZZ D26918 RING,RETAINING XBHZZ TURBINE PAHZZ RING,RETAINING PAHZZ BEARING,BALL,ANNULA PAHZZ WASHER,LOCK KBHZZ O-RING PART OF KIT P/N D XBHZZ COVER, IMPELLER PAHZZ C-516 SCREW ASSEMBLED WASHER XDHZZ D26918 RING,RETAINING KBHZZ K O-RING PART OF KIT P/N D PAHZZ HEAD,HYDRAULIC MOTO PFHZZ MS RING,RETAINING PAHZZ C612 SCREW,CAP,HEXAGON H ASSEMBLED 10 WASHER PAHZZ SPACER,PLATE USED WITH MODEL

158 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 45 PFHZZ SCREW,CAP,HEXAGON 3/8-24 X 1.75" 8 USED WITH MODEL ONLY PFHZZ WASHER,LOCK 3/8", USED WITH MODEL ONLY PAHZZ N14753 PLATE,COMPONENT MOU THIS ITEM 1 INCLUDES ITEMS 44, 45 & 46 FOR USE ON ENGINE XBHZZ DRIVE PLATE USED WITH MODEL PAHZZ DISK,CLUTCH USED WITH 207 MODEL PAHZZ STRAINER ELEMENT,SE PAOZZ G42 GASKET PART OF KIT P/N PAHZZ E DEFLECTOR,DIRT AND PFHZZ B1821BH044C113N SCREW,CAP,HEXAGON H PFHZZ MS WASHER,LOCK PFHZZ SEAL,PLAIN ENCASED PART OF KIT P/N 1 D END OF FIGURE /(141 blank)

159

160 Figure 49. Converter Housing

161 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0708 TORQUE CONVERTER OR FLUID COUPLING FIG. 49 CONVERTER HOUSING 1 PAHZZ PLUG,PIPE PAOZZ BREATHER XBHZZ HOUSING, CONVERTER PAHZZ STUD,PLAIN PAHZZ STUD,PLAIN PAHZZ MU1010-V BEARING,ROLLER,CYLI PFHZZ SEAL RING,METAL PART OF KIT P/N 1 D PFHZZ SPRING,EXPANDER,PIS PART OF KIT P/N 1 D XBHZZ SHAFT,SHOULDERED PFHZZ H2525M WASHER,LOCK PFHZZ B1821BH038C075D SCREW,CAP,HEXAGON H PAHZZ RING,RETAINING PAHZZ C1 RING,PISTON PART OF KIT P/N D PAHZZ RING,RETAINING PAHZZ SPACER,RING XBHZZ BEARING PAHZZ E SHAFT,STRAIGHT PFHZZ MS BALL,BEARING XDHZZ GEAR AND HUB ASSEMB PFHZZ MS SCREW,CAP,HEXAGON H PAHZZ LOCKING PLATE,NUT A XBHZZ PLATE PAHZZ PIN,SPECIAL PAHZZ PIN,HOLLOW PAHZZ BEARING,ROLLER,TAPE XDHZZ GEAR,REVERSE IDLER PAHZZ BUSHING,SLEEVE PAHZZ S-915-A PLUG,PIPE PAHZZ MA241A21020 PLUG,PIPE... 1 END OF FIGURE

162 Figure 50. Transmission Assembly (Upper)

163 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0710 TRANSMISSION ASSEMBLY FIG. 50 TRANSMISSION ASSEMBLY (UPPER) 1 PAHZZ RING,PISTON PART OF KIT P/N PAHZZ M RING,RETAINING PAHZZ RING,SPECIAL PAHZZ AA JABT BEARING,BALL,ANNULA REVERSE AND 1 SECOND SHAFT... 5 PAHZZ S3 BEARING,BALL,ANNULA CLUTCH PAHZZ RING,RETAINING PAHZZ SPACER,RING PAHZZ REVERSE GEAR AND HU PAHZZ RING,RETAINING PAHZZ KSL0 BEARING,BALL,ANNULA CLUTCH DRIVEN PAHZZ RING,RETAINING PAHZZ WASHER,SPRING TENSI PAHZZ SPACER,RING PAHZZ SPRING,HELICAL,COMP PAHZZ RETAINER,HELICAL CO PAHZZ MS RING,RETAINING PAHZZ PIN,SPECIAL REVERSE AND SECOND 1 SHAFT PAHZZ RING,RETAINING PAHZZ N8749 DISK,CLUTCH PAHZZ GEAR,HELICAL FORWARD SHAFT PAHZZ RING RETAINING PAHZZ N-4512 WASHER,RECESSED PAHZZ BEARING,BALL,ANNULA FRONT LOW 1 SPEED CLUTCH SHAFT PAHZZ SPACER,RING FRONT BEARING PAHZZ P9110K BEARING,BALL,ANNULA LOW SPEED PAHZZ RING,RETAINING LOW SPEED GEAR 1 BEARING PAHZZ SPACER,RING LOW SPEED GEAR PAHZZ GEAR,HELICAL LOW SHAFT PAHZZ RING,RETAINING LOW SPEED GEAR 1 BEARING PAHZZ P9110K BEARING,BALL,ANNULA LOW SPEED GEAR PAHZZ RING,RETAINING PAHZZ MS RING,RETAINING PAHZZ RETAINER,HELICAL CO PAHZZ SPRING,HELICAL,COMP PFHZZ MS NUT,PLAIN,HEXAGON PFHZZ MS WASHER,LOCK XDHZZ CAP AND PLUG ASSEMB LOW SHAFT PAHZZ PLUG,MACHINE THREAD PFHZZ O-RING PART OF KIT P/N XDHZZ STUD,PLAIN KBHZZ R1 PACKING,PREFORMED PART OF KIT P/N

164 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY PFHZZ SPACER,RING PART OF KIT P/N PAHZZ RING,RETAINING PAFZZ SPACER,RING PAHZZ N7276 BEARING,BALL,ANNULA LOW SPEED SHAFT 1 46 PAHZZ BEARING,BALL,ANNULA FORWARD SHAFT XDHZZ LOCK CLUTCH OIL SEA XBHZZ SLEEVE, PISTON RING PAHZZ RING,RETAINING PFHZZ RING,PISTON PART OF KIT P/N PAHZZ WJ ROLLER,BEARING PILOT, FORWARD SHAFT 1 52 PAHZZ RING,RETAINING PAHZZ WASHER,SPRING TENSI RETURN PAHZZ SPACER,RING... 1 END OF FIGURE /(147 blank)

165

166 Figure 51. Transmission Assembly (Lower)

167 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0710 TRANSMISSION ASSEMBLY FIG. 51 TRANSMISSION ASSEMBLY (LOWER) 1 PAHZZ ROLL PIN,BRAKE OUTER RACE PAHZZ RING,PISTON,TRANSMI OUTER PAHZZ RING,PISTON PART OF KIT P/N PFHZZ MS RING,RETAINING PAHZZ P9110K BEARING,BALL,ANNULA 3RD CLUTCH 1 SHAFT... 6 PAHZZ RING,RETAINING 3RD CLUTCH FRONT 1 BEARING... 7 PAHZZ SPRING,HELICAL,COMP PAHZZ RETAINER,HELICAL CO PAHZZ MS RING,RETAINING PAHZZ PIN,SPECIAL 3RD CLUTCH SHAFT PAHZZ A1 DISK,CLUTCH 3RD CLUTCH PAHZZ HOUSING,BEARING UNI PAHZZ RING,RETAINING PAHZZ M RING,RETAINING PAHZZ FFB171/04J13A2E BEARING,BALL,ANNULA 3RD CLUTCH 1 DISC HUB PAHZZ M RING,RETAINING PAHZZ MS RING,RETAINING XDHZZ GEARSHAFT,MULTIPLE SHAFT PAHZZ STUD,PLAIN PFHZZ N O-RING PART OF KIT P/N XBHZZ SUPPORT HIGH AND LOW SHIFT RAIL PAHZZ A6308 SPRING,HELICAL,COMP PAHZZ PLUG,PIPE PFHZZ MS BALL,BEARING PAHZZ SEAL,PLAIN ENCASED PART OF KIT P/N PFHZZ H2525M WASHER,LOCK PFHZZ MS NUT,PLAIN,HEXAGON PAHZZ FFB171/08J11E2E BEARING,BALL,ANNULA PAHZZ SPACER,RING PFHZZ MS RING,RETAINING KBHZZ K O-RING PART OF KIT P/N XBHZZ BEARING, CAP, REAR IDLER SHAFT XDHZZ STUD,PLAIN PFHZZ MS WASHER,LOCK PFHZZ MS NUT,PLAIN,HEXAGON PFHZZ MS WASHER,LOCK PFHZZ MS NUT,PLAIN,HEXAGON PAHZZ NUT,SELF-LOCKING,SI PAHZZ WASHER,FLAT PFHZZ K O-RING PART OF KIT P/N XBHZZ CAP, BEARING

168 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 42 XDHZZ STUD,PLAIN KBHZZ K O-RING PART OF KIT P/N KBHZZ K PACKING,PREFORMED PART OF KIT P/N XBHZZ SPACER KBHZZ OIL SEAL PART OF KIT P/N PAHZZ AA JEBT BEARING,BALL,ANNULA OUTPUT SHAFT PAHZZ BEARING,WASHER,THRU XDHZZ SHAFT,SHOULDERED PAHZZ PIN,SHOULDER,HEADLE HIGH AND LOW 1 SHIFT XBHZZ SPACER, SHIFT RAIL PAHZZ SETSCREW XBHZZ FORK HIGH AND LOW SHIFT XBHZZ HUB, RANGE SHIFT PAHZZ WJ RETAINER AND ROLLER XBHZZ SPACER, BEARING PAHZZ WJ RETAINER AND ROLLER XDHZZ GEAR,SPUR PAHZZ BEARING,WASHER,THRU PAHZZ BEARING,BALL,ANNULA OUTPUT SHAFT PAHZZ SEAL,PLAIN ENCASED PART OF KIT P/N PAHZZ E YOKE,UNIVERSAL JOIN PFHZZ K O-RING PART OF KIT P/N PAHZZ WASHER,FLAT PAHZZ NUT,SELF-LOCKING,SI... 1 END OF FIGURE /(151 blank)

169

170 Figure 52. Transmission Case

171 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0710 TRANSMISSION ASSEMBLY FIG. 52 TRANSMISSION CASE 1 PFHZZ Z329PC93 PLUG,PIPE KBHZZ K PACKING,PREFORMED PART OF KIT P/N PAHZZ PLUG,PIPE PFHZZ GASKET PART OF KIT P/N PAHZZ C1 PIN XBHHD COVER,REAR PFHZZ MS WASHER,LOCK PFHZZ B1821BH044C150N SCREW,CAP,HEXAGON H PAHZZ WW-P-471-ACABCA PLUG,PIPE PFOZZ Z329PC93 PLUG,PIPE XBHZZ OIL BAFFLE PFHZZ B1821BH044C075N SCREW,CAP,HEXAGON H PFHZZ MS WASHER,LOCK PAHZZ H-24 CLAMP,LOOP PAOZZ ELBOW,PIPE PAOZZ CA ADAPTER,STRAIGHT,PI PAOZZ L TUBE ASSEMBLY,METAL XAOZZ L TUBE, DIPSTICK XAOZZ NUT,TUBE COUPLING XAOZZ SLEEVE, TUBE PFOZZ JAEJ1508 CLAMP,HOSE PAOZZ R2T HOSE,NONMETALLIC PAOZZ U GAGE ROD-CAP,LIQUID KBHZZ K PACKING,PREFORMED PART OF KIT P/N PAHZZ C1 PIN PFHZZ K O-RING PART OF KIT P/N PAHZZ RETAINER,PACKING THIRD SPEED KBHZZ K PACKING,PREFORMED PART OF KIT P/N PFHZZ MS O-RING PART OF KIT P/N PAHZZ PLUG,PIPE XBHZZ TRANSMISSION CASE PAHZZ SLEEVE XBHZZ SUCTION TUBE ASSY PFHZZ K O-RING PART OF KIT P/N PFHZZ MS S.WASHER,LOCK PAHZZ MS BOLT,MACHINE XBHZZ TUBE, LUBRICATION CLUTCH XBHZZ TUBE, THIRD SPEED PAHZZ TUBE,LUBRICATING PAHZZ SLEEVE PAHZZ SLEEVE PAHZZ TUBE,PRESSURE SPEED CLUTCH... 1 END OF FIGURE

172 Figure 53. Low Clutch Assembly

173 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0713 INTERMEDIATE CLUTCH FIG. 53 LOW CLUTCH ASSEMBLY 1 PAHZZ RING,RETAINING PAHZZ DISK,CLUTCH,VEHICUL PAHZZ DISK,CLUTCH PAHZZ DISK,CLUTCH PAHZZ PISTON,CLUTCH,TRANS PFHZZ PACKING,PREFORMED PART OF KIT P/N PFHZZ PACKING,PREFORMED PART OF KIT P/N XBHZZ VALVE LOW CLUTCH SHAFT DRUM AND 1 BLEED... END OF FIGURE

174 Figure 54. Forward Clutch Assembly

175 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0713 INTERMEDIATE CLUTCH FIG. 54 FORWARD CLUTCH ASSEMBLY 1 PAHZZ RING,RETAINING PAHZZ DISK,CLUTCH,VEHICUL BACKING PAHZZ N7217 DISK,CLUTCH PAHZZ DISK,CLUTCH XBHZZ PISTON, CLUTCH PFHZZ PACKING,PREFORMED PART OF KIT P/N PFHZZ PACKING,PREFORMED PART OF KIT P/N PAHZZ DRUM,FORWARD CLUTCH FORWARD SHAFT.. 1 END OF FIGURE

176 Figure 55. Third Clutch Assembly

177 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0713 INTERMEDIATECLUTCH FIG. 55 THIRD CLUTCH ASSEMBLY 1 PAHZZ RING,RETAINING PAHZZ DISK,CLUTCH,VEHICUL BACKING PAHZZ N7217 DISK,CLUTCH PAHZZ DISK,CLUTCH PAHZZ CLUTCH PISTON AND V PFHZZ PACKING,PREFORMED PART OF KIT P/N PFHZZ PACKING,PREFORMED PART OF KIT P/N PAHZZ DRUM,THIRD CLUTCH... 1 END OF FIGURE

178 Figure 56. Reverse and Second Clutch Assembly

179 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0713 INTERMEDIATE CLUTCH FIG. 56 REVERSE AND SECOND CLUTCH ASSEMBLY 1 PAHZZ RING,RETAINING PAHZZ DISK,CLUTCH,VEHICUL BACKING PAHZZ N7217 DISK,CLUTCH PAHZZ DISK,CLUTCH XBHZZ PISTON, CLUTCH PFHZZ PACKING,PREFORMED PART OF KIT P/N PFHZZ PACKING,PREFORMED PART OF KIT P/N XDHZZ DRUM,CLUTCH PAHZZ CLUTCH PISTON AND V... 1 END OF FIGURE

180 Figure 57. Charging Pump and Motor

181 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG. 57 CHARGING PUMP AND MOTOR 1 PFFZZ B1821BH044C250N SCREW,CAP,HEXAGON H PFFZZ MS SCREW,CAP,HEXAGON H PFFZZ MS NUT,PLAIN,HEXAGON PFFZZ MS WASHER,LOCK PAOZZ HF701 FILTER ELEMENT,FLUI PAFZZ PUMP,CHARGING PAFZZ GASKET PART OF KIT P/N D PAFZZ K O-RING PART OF KIT P/N D PAFZZ MS WASHER,LOCK... 3 END OF FIGURE

182 Figure 58. Control Valve and Mounting

183 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG. 58 CONTROL VALVE AND MOUNTING 1 PFFZZ B1821BH038C375N SCREW,CAP,HEXAGON H PFFZZ H2525M WASHER,LOCK PAFHH VALVE BODY ASSY,TRA PAHZZ N7711.PARTS KIT,VALUE BOD PFHZZ SEAL,OIL PART OF KIT P/N KBHZZ K O-RING PART OF KIT P/N XBHZZ SPRING,SPECIAL PFHZZ CP-15..SEAT,HELICAL COMPRE KBHZZ CUP,HYDRAULIC BRAKE PART OF KIT 1 P/N XBHZZ PISTON, INCHING PAHZZ K O-RING XBHZZ SPOOL, VALVE PAHZZ SPRING,HELICAL,COMP XBHHH HOUSING, CONTROL PAHZZ N7205..SLIDE,DIRECTIONAL C FORWARD AND 1 REVERSE PFHZZ SEAL,PLAIN ENCASED PART OF KIT P/N PAHZZ STOP,SPOOL AND INCH PAOZZ D2NN7A247A SWITCH,SAFETY,NUTRA SWITCH,SAFETY, 1 NEUTRAL,START PAOZZ SWITCH,PUSH USED WITH MODEL PAHZZ M PIN,GROOVED,HEADED PAHZZ T PLUG,PIPE PFHZZ F-01..PLUG,PIPE PAHZZ TUBE,LUBRICATING SELECTOR PAHZZ STOP,SPOOL AND INCH PFHZZ MS BALL,BEARING PAHZZ SPRING,HELICAL,COMP PAFZZ GASKET PART OF KIT P/N PAOZZ MS WASHER,LOCK PFOZZ MS SCREW,MACHINE... 2 END OF FIGURE

184 Figure 59. Modulation Valve Assembly

185 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG. 59 MODULATION VALVE ASSEMBLY 1 PFHZZ MODULATOR,TRANSMISS XAHZZ SPRING, INNER XAHZZ SPRING OUTER XAHZZ NSS.VALVE, ACCUMULATOR XBHZZ K-7.CAP VALVE PFHZZ F-7..PACKING,PREFORMED PART OF KIT P/N XBHZZ SPRING, REGULATOR XAHZZ NSS.SPOOL, REGULATOR PAFZZ GASKET PART OF KIT P/N END OF FIGURE

186 Figure 60. Transmission Linkage Controls (Forward)

187 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG. 60 TRANSMISSION LINKAGE CONTROL (FORWARD) 1 PAOZZ R2 KNOB XBOZZ L LEVER, TRANSMISSION PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS WASHER,FLAT PFOZZ B1821BH050C325N SCREW,CAP,HEXAGON H PAOZZ R2 KNOB XBOZZ L LEVER, TRANSMISSION PFOZZ MS WASHER,FLAT PFOZZ M45913/1-8CG5C NUT,SELF-LOCKING,HE PFOZZ MS PIN,STRAIGHT,HEADED PFOZZ MS PIN,COTTER PAOZZ CLEVIS,ROD END PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ A CONTROL ASSEMBLY,PU PFOZZ SPG1002 BALL JOINT PFOZZ M45913/1-8CG5C NUT,SELF-LOCKING,HE XBOZZ L BRACKET, SUPPORT PFOZZ WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ R24718 SPACER,PLATE PAOZZ C M SPRING,HELICAL,COMP XBOZZ L SPACER PFOZZ B1821BH050C350N SCREW,CAP,HEXAGON H... 1 END OF FIGURE

188 Figure 61. Transmission Linkage Controls (AFT)

189 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG. 61 TRANSMISSION LINKAGE CONTROL (AFT) 1 XBOZZ L SPACER XBOZZ L BELLCRANK INSIDE XBOZZ L13111 SPACER PFOZZ MS WASHER,FLAT PFOZZ MS S WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON XBOZZ L BELLCRANK OUTSIDE PAOZZ D64050 WASHER,FLAT PAOZZ L STUD,PLAIN PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS BOLT,MACHINE PAOZZ L78367 CONNECTING LINK,RIG PFOZZ MS PIN,COTTER PFOZZ MS PIN,STRAIGHT,HEADED PAOZZ A18709 CLEVIS,ROD END PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS WASHER,LOCK PFOZZ B1821BH044C150N SCREW,CAP,HEXAGON H XBOZZ L BRACKET PAOZZ MS BOLT,MACHINE XBOZZ A14078 CLAMP, HOSE PAOZZ A12032 STRAP,RETAINING XBOZZ SST-2-S TILE CABLE PFOZZ CLAMP,LOOP PFOZZ MS S WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ A1 SPACER,SLEEVE... 3 END OF FIGURE

190 Figure 62. Axle Disconnect

191 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0721 COOLERS, PUMPS,MOTORS FIG. 62 AXLE DISCONNECT 1 XBOZZ PIN, STRAIGHT HEADED XBOZZ L LEVER, AXLE PAOZZ KNOB PFOZZ B1821BH038C150N SCREW,CAP,HEXAGON H PAOZZ L CLAMP,LOOP PFOZZ H2525M WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON XBOZZ L LEVER, AXLE LOWER PFOZZ L BRACKET,EYE,ROTATIN XAOZZ L BRACKET, AXLE PAOZZ B BEARING,SLEEVE PFOZZ MS WASHER,FLAT PFOZZ AN PIN,COTTER PFOZZ MS WASHER,FLAT PAOZZ D40471 CLAMP,LOOP PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFOZZ K-500-PC-0001 PIN,COTTER... 1 END OF FIGURE

192 Figure 63. Transmission Cooler and Lines

193 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG. 63 TRANSMISSION COOLER AND LINES 1 XDOZZ S1-10 COOLER,FLUID,TRANSM PFOZZ A733S-102CFG NIPPLE,PIPE PFOZZ MS51506A12 ELBOW,PIPE TO TUBE PFOZZ L TUBE ASSEMBLY,METAL XAOZZ L TUBE PFOZZ AS SLEEVE,FLARED,TUBE PAOZZ MS51531-B12.NUT,TUBE COUPLING PAOZZ L HOSE ASSY,NONMETALL PFOZZ MS51525-A12 ADAPTER,STRAIGHT,TU XBOZZ L TUBE,BENT,METALLIC XAOZZ L TUBE,BENT,METALLIC XAOZZ D34071.SLEEVE,FLARED,TUBE XAOZZ NUT,TUBE COUPLING PAOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK PAOZZ R15257 STRAP,RETAINING PFOZZ B1821BH038C150N SCREW,CAP,HEXAGON H PFOZZ MS S WASHER,LOCK XBOZZ TA CO-18NB CLAMP,LOOP PAOZZ MS BOLT,MACHINE... 4 END OF FIGURE

194 Figure 64. Front Driveshaft Assembly

195 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 09 PROPELLER AND PROPELLER SHAFTS GROUP 0900 PROPELLER SHAFTS FIG. 64 FRONT DRIVE SHAFT ASSEMBLY 1 PAOOO T8R PROPELLER SHAFT PAOZZ D6E9 CSH SCREW,CAP,HEXAGON H PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ CP62N-HWD.SPIDER,UNIVERSAL JO XAOZZ N4-4A..NEEDLE, BEARING XAOZZ N1A..CENTER PFOZZ AS FITTING,LUBRICATION XAOZZ WSP STRAP PAOZZ D28266.WASHER,FLAT PAOZZ NUSL NUT,PLAIN,SLOTTED,H PFOZZ MS PIN,COTTER XAOZZ DRIVE SHAFT, FRONT... 1 END OF FIGURE

196 Figure 65. Center Driveshaft Assembly

197 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0900 PROPELLER SHAFTS FIG. 65 CENTER DRIVESHAFT ASSEMBLY 1 PAOZZ L48916 SHAFT PFOZZ AS FITTING,LUBRICATION PAOZZ SF32RTC BEARING UNIT,BALL PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS WASHER,LOCK PFOZZ B1821BH056C175N SCREW,CAP,HEXAGON H PAOFF L60072 PROPELLER SHAFT WIT PAOZZ AS FITTING,LUBRICATION PAOZZ CP62N-HWD.SPIDER,UNIVERSAL JO XAOZZ N4-4A..NEEDLE, BEARING XAOZZ WSP STRAP XAOZZ N1A..CENTER PFOZZ AS FITTING,LUBRICATION PFOZZ MS NUT,PLAIN,HEXAGON KFOZZ WAR23-1.WASHER, PART OF KIT PART OF KIT P/N 2 DC62N KFOZZ WAFR24-5.WASHER,FLAT PART OF KIT P/N DC62N KFOZZ DCD36-3.CAP, PART OF KIT PART OF KIT P/N 1 DC62N PAOZZ D6E9 CSH SCREW,CAP,HEXAGON H XBOZZ NYSM32-31.YOKE,UNIVERSAL JOIN PAOZZ T8R NLS32-9.PROPELLER SHAFT... 1 END OF FIGURE

198 Figure 66. Rear Driveshaft Assembly

199 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 0900 PROPELLER SHAFTS FIG. 66 REAR DRIVESHAFT ASSEMBLY 1 PAOOO T8R PROPELLER SHAFT WIT PFFZZ AS FITTING,LUBRICATION PAOZZ CP62N-HWD.SPIDER,UNIVERSAL JO XAOZZ N4-4A..NEEDLE, BEARING XAOZZ N1A..CENTER PAOZZ AS FITTING,LUBRICATION XAOZZ WSP STRAP PFOZZ MS NUT,PLAIN,HEXAGON KFOZZ WAR23-1.WASHER, PART OF KIT PART OF KIT P/N 2 DC62N KFOZZ WAFR24-5.WASHER,FELT PART OF KIT P/N DC62N KFOZZ DCD36-3.CAP, PART OF KIT PART OF KIT P/N 1 DC62N PAOZZ T8R NYSM-28-9.PROPELLER SHAFT PAOZZ D6E9 CSH SCREW,CAP,HEXAGON H PAOZZ T8R NLS28-1.YOKE,UNIVERSAL JOIN... 1 END OF FIGURE

200 Figure 67. Front Axle Assembly and Mounting

201 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 10 FRONT AXLE GROUP 1000 FRONT AXLE ASSEMBLY FIG. 67 FRONT AXLE ASSEMBLY AND MOUNTING 1 PAFHH D-140-FSHX-25 AXLE ASSEMBLY,AUTOM PFFZZ B1821BH044C225N.SCREW,CAP,HEXAGON H PFFZZ B1821BH050C150N.SCREW,CAP,HEXAGON H SHORT PFFZZ B1821BH044C150N.SCREW,CAP,HEXAGON H SHORT PAFZZ E1513.WASHER,FLAT PFFZZ C1511.WASHER,FLAT PAFZZ X16.SCREW XAFZZ C3121N456-S.HOUSING ASSEMBLY XAFZZ A3121N456..HOUSING, AXLE PAHZZ PIN,SHOULDER,HEADLE PAOZZ D6E Q-7869.SHAFT,AXLE,AUTOMOTI PFFZZ Z329PC93.PLUG,PIPE XBOHH B53-333H268.HUB AND DRUM ASSY PFFZZ MS NUT,PLAIN,HEXAGON PAFZZ D6E V WASHER,FLAT XBFZZ W23..DRUM, BRAKE PFFHH D6E9 B52-333H268..HUB,WHEEL,VEHICULAR XAFHH A333H268...HUB AND CUP ASSY XAFZZ H268...HUB PAOZZ CONE AND ROLLERS,TA OUTER PAOZZ LTL CONE AND ROLLERS,TA INNER XDFZZ X-1556C...STUD,SHOULDERED PFOZZ NUT,PLAIN,SINGLE BA PAFZZ D6E9 SC716...STUD,PLAIN PAOZZ BB1239A...CUP,TAPERED ROLLER PAFZZ R720.BEARING,WASHER,THRU PAOZZ R NUT,PLAIN,HEXAGON INNER PAOZZ R WASHER,KEY PAOZZ R NUT,PLAIN,HEXAGON OUTER PAOZZ D6E9 2208U411.GASKET PAFZZ D6E P-7868.SHAFT,AXLE,AUTOMOTI PAFZZ BB1142B.BUSHING,TAPERED PFFZZ MS WASHER,LOCK PFFZZ MS NUT,PLAIN,HEXAGON PAOZZ A-4576.CUP,TAPERED ROLLER PAFZZ D6E9 3905L90.DEFLECTOR,DIRT AND PAOZZ CR SEAL,PLAIN ENCASED PFFZZ B1821BH050F150N.SCREW,CAP,HEXAGON H PFFZZ C1511.WASHER,FLAT PFFZZ MS21044N8.NUT,SELF-LOCKING,HE PAOZZ F68200.FITTING,LUBRICATION PAOZZ KF04-02RS ADAPTER,STRAIGHT,PI MOOZZ L60451 HOSE,NONMETALLIC MAKE FROM HOSE, P/ 1 N , USE 27" OF HOSE

202 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 44 PAOZZ C0V0913Z1 CLAMP,LOOP PAOZZ F CLAMP,HOSE PAOZZ KF04-02PS ADAPTER,STRAIGHT,PI PFFZZ M45913/1-10FG5C NUT,SELF-LOCKING,HE PFFZZ T53567 WASHER,FLAT XBFZZ L60186 PLATE, LOWER AXLE PAFZZ R1 BOLT,MACHINE... 8 END OF FIGURE /(185 blank)

203

204 Figure 68. Front Axle Differential Carrier Assembly

205 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1002 DIFFERENTIAL FIG. 68 FRONT AXLE DIFFERENTIAL CARRIER ASSEMBLY 1 PAFHH D6E9 G S-1111/ DIFFERENTIAL,DRIVIN XAHHH A2-3200S1111.CAP AND CARRIER PAHZZ X16..SCREW XBHZZ K1493..PLATE,IDENTIFICATIO XAHZZ S1111..CARRIER XBHZZ Q355..CAP, BEARING XDHZZ U1503..WASHER,FLAT XDHZZ S SCREW,CAP,HEXAGON H PAHHH B PARTS KIT,DRIVING A PAHZZ LTL CONE AND ROLLERS,TA XBHZZ RV7812..RIVET PAHZZ X-1325-S..SCREW,MACHINE PFHZZ C1511..WASHER,FLAT PFHZZ MS21044N8..NUT,SELF-LOCKING,HE XAHHH A8-3235Z884..DIFFERENTIAL ASSY PAHZZ D6E9 A Z DIFFERENTIAL CASE,A XBHZZ X SCREW PFHZZ C WASHER,FLAT XAHZZ W413...CASE, DIFFERENTIAL PLAIN HALF XAHZZ Z884...CASE, DIFFERENTIAL FLANGE HALF PAHZZ D6E Y SPACER,PLATE PAHZZ D6E N GEAR,BEVEL PAHZZ U WASHER,SPRING TENSI PAHZZ D6E A GEAR,BEVEL PAHZZ D6E9 3278Z104...SPIDER,DIFFERENTIAL PAHZZ D6E9 A GEAR SET,BEVEL,MATC PINION PFHZZ X2728.SHIM PFHZZ Y2729.SHIM PFHZZ Z-2730.SHIM PAHZZ E1331.WASHER,FLAT PAHZZ C-939.NUT,SELF-LOCKING,CA PAHZZ E1513.WASHER,FLAT PFHZZ B1821BH044C150N.SCREW,CAP,HEXAGON H PAHZZ D73687.YOKE,UNIVERSAL JOIN COMPANION XBHZZ B3096..SLINGER, OIL PAHZZ A-1205-S SEAL,PLAIN ENCASED XAHZZ X1896..YOKE, COMPANION XBHZZ S6935.SHIM, XBHZZ T6936.SHIM, XBHZZ U6937.SHIM, XBHZZ V6938.SHIM, XBHZZ W6939.SHIM, XBHZZ X6940.SHIM, XBHZZ Y6941.SHIM, XBHZZ Z6942.SHIM,

206 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 38 XBHZZ A6943.SHIM, XBHZZ B6944.SHIM, XBHZZ B6945.SHIM, XBHZZ D6946.SHIM, XBHZZ E6947.SHIM, XBHZZ F6948.SHIM, XBHZZ G6949.SHIM, XBHZZ H6950.SHIM, XBHZZ J6952.SHIM, XBHZZ K6953.SHIM, XBHZZ L6954.SHIM, XBHZZ M6955.SHIM, XBHZZ N6956.SHIM, XBHZZ P6958.SHIM, XBHZZ Q6959.SHIM, XBHZZ R6960.SHIM, XBHZZ S6961.SHIM, XBHZZ T6962.SHIM, XBHZZ U6963.SHIM, XBHZZ V6964.SHIM, XBHZZ W6965.SHIM, XBHZZ X6966.SHIM, XBHZZ Y6967.SHIM, XBHZZ Y6968.SHIM, XBHZZ G6923.SHIM, XBHZZ H6924.SHIM, XBHZZ J6926.SHIM, XBHZZ K6927.SHIM, XBHZZ L6928.SHIM, XBHZZ M6929.SHIM, XBHZZ N6930.SHIM, XBHZZ P6932.SHIM, XBHZZ Q6933.SHIM, XBHZZ R6934.SHIM, XBHHH A2-3226E655.CAGE ASSEMBLY PINION XBHZZ E655..CAGE, ASSEMBLY PINION XBHZZ E655...CAGE, PINION PAHZZ BB4616..CUP,TAPERED ROLLER PAHZZ HM CUP,TAPERED ROLLER PAHZZ TDAA4621A.CONE AND ROLLERS,TA OUTER PAHZZ HM CONE AND ROLLERS,TA INNER XBHHH PINION ASSEMBLY XBHZZ PINION, BEVEL PAHZZ H268..BEARING,ROLLER,CYLI PAHZZ D6E W RING,RETAINING PAHZZ D6E9 JM CUP,TAPERED ROLLER PAHZZ E-57.RING,EXTERNALLY THR ADJUSTING PAHZZ D6E R-2176.PIN,COTTER PAHZZ PLUG,PIPE... 1 END OF FIGURE /(189 blank)

207

208 Figure 69. Rear Axle Assembly and Mounting

209 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 11 REAR AXLE GROUP 1100 REAR AXLE ASSEMBLY FIG. 69 REAR AXLE ASSEMBLY AND MOUNTING 1 PAFHH D-140-FSHX-25 AXLE ASSEMBLY,AUTOM PFFZZ B1821BH044C225N.SCREW,CAP,HEXAGON H PFFZZ B1821BH050C150N.SCREW,CAP,HEXAGON H SHORT PFFZZ B1821BH044C150N.SCREW,CAP,HEXAGON H SHORT PAFZZ E1513.WASHER,FLAT PFFZZ C1511.WASHER,FLAT PAFZZ X16.SCREW XAFZZ C3121N456-S.HOUSING ASSEMBLY XAFZZ A3121N456..HOUSING, AXLE PAHZZ PIN,SHOULDER,HEADLE PAOZZ D6E Q-7869.SHAFT,AXLE,AUTOMOTI PAOZZ PLUG,PIPE XBOHH B53-333H268.HUB AND DRUM ASSY PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ D6E V WASHER,FLAT PFOZZ W23..BRAKE DRUM PFOHH D6E9 B52-333H268..HUB,WHEEL,VEHICULAR XAOHH A333H268...HUB AND CUP ASSY XAOZZ H268...HUB PAOZZ CONE AND ROLLERS,TA OUTER PAOZZ LTL CONE AND ROLLERS,TA INNER XDOZZ X-1556C...STUD,SHOULDERED PFOZZ NUT,PLAIN,SINGLE BA PAFZZ D6E9 SC716...STUD,PLAIN PAOZZ BB1239A.CUP,TAPERED ROLLER PAOZZ R720.BEARING,WASHER,THRU PAOZZ R NUT,PLAIN,HEXAGON INNER PAOZZ R WASHER,KEY PAOZZ R NUT,PLAIN,HEXAGON OUTER PAFZZ D6E9 2208U411.GASKET PAOZZ D6E P-7868 SHAFT,AXLE,AUTOMOTI PAOZZ BB1142B.BUSHING,TAPERED PFOZZ MS WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ A-4576.CUP,TAPERED ROLLER PAOZZ SEAL,PLAIN ENCASED PAOZZ CR SEAL,PLAIN ENCASED PFOZZ B1821BH050F150N.SCREW,CAP,HEXAGON H PFOZZ C1511.WASHER,FLAT PFOZZ MS21044N8.NUT,SELF-LOCKING,HE PAOZZ F68200 FITTING,LUBRICATION PAOZZ KF04-02RS ADAPTER,STRAIGHT,PI MOOZZ L60515 HOSE,NONMETALLIC MAKE FROM HOSE, P/ 1 N

210 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 44 PAOZZ C0V0913Z1 CLAMP,LOOP PAOZZ F CLAMP,HOSE PAOZZ KF04-02PS ADAPTER,STRAIGHT,PI PFFZZ M45913/1-10FG5C NUT,SELF-LOCKING,HE PFFZZ T53567 WASHER,FLAT XBFZZ L60186 PLATE, LOWER AXLE PAFZZ R1 BOLT,MACHINE... 8 END OF FIGURE /(193 blank)

211

212 Figure 70. Rear Axle Differential Carrier Assembly

213 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1102 DIFFERENTIAL FIG. 70 REAR AXLE DIFFERENTIAL CARRIER ASSEMBLY 1 PAFHH D6E9 G S-1111/ DIFFERENTIAL,DRIVIN XAHHH A2-3200S1111.CAP AND CARRIER PAHZZ X16..SCREW XBHZZ K1493..PLATE,IDENTIFICATIO XAHZZ S1111..CARRIER XBHZZ Q355..CAP, BEARING XDHZZ U1503..WASHER,FLAT XBHZZ S SCREW,CAP XBHHH B CASE AND GEAR ASSY, PAHZZ LTL CONE AND ROLLERS,TA XBHZZ RV7812..RIVET PAHZZ X-1325-S..SCREW,MACHINE PFHZZ C1511..WASHER,FLAT PFHZZ MS21044N8..NUT,SELF-LOCKING,HE XAHHH A8-3235Z884..DIFFERENTIAL ASSY PAHZZ A1-3235Z884...DIFFERENTIAL CASE,A XBHZZ X SCREW PFHZZ C WASHER,FLAT XAHZZ W413...CASE, DIFFERENTIAL PLAIN HALF XAHZZ Z884...CASE, DIFFERENTIAL, FLANGE HALF 1 21 PAHZZ D6E Y SPACER,PLATE PAHZZ D6E N GEAR,BEVEL PAHZZ U WASHER,SPRING TENSI PAHZZ D6E A GEAR,BEVEL PAHZZ D6E9 3278Z104...SPIDER,DIFFERENTIAL PAHZZ D6E9 A GEAR SET,BEVEL,MATC PINION PFHZZ X2728.SHIM PFHZZ Y2729.SHIM PFHZZ Z-2730.SHIM PAHZZ E1331.WASHER,FLAT PAHZZ C-939.NUT,SELF-LOCKING,CA PAHZZ E1513.WASHER,FLAT PFHZZ B1821BH044C150N.SCREW,CAP,HEXAGON H PAHZZ D73687.YOKE,UNIVERSAL JOIN COMPANION XBHZZ B3096..SLINGER, OIL PAHZZ A-1205-S SEAL,PLAIN ENCASED XAHZZ X1896..YOKE COMPANION XBHZZ S6935.SHIM, XBHZZ T6936.SHIM, XBHZZ U6937.SHIM, XBHZZ V6938.SHIM, XBHZZ W6939.SHIM, XBHZZ X6940.SHIM, XBHZZ Y6941.SHIM, XBHZZ Z6942.SHIM,

214 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 38 XBHZZ A6943.SHIM, XBHZZ B6944.SHIM, XBHZZ B6945.SHIM, XBHZZ D6946.SHIM, XBHZZ E6947.SHIM, XBHZZ F6948.SHIM, XBHZZ G6949.SHIM, XBHZZ H6950.SHIM, XBHZZ J6952.SHIM, XBHZZ K6953.SHIM, XBHZZ L6954.SHIM, XBHZZ M6955.SHIM, XBHZZ N6956.SHIM, XBHZZ P6958.SHIM, XBHZZ Q6959.SHIM, XBHZZ R6960.SHIM, XBHZZ S6961.SHIM, XBHZZ T6962.SHIM, XBHZZ U6963.SHIM, XBHZZ V6964.SHIM, XBHZZ W6965.SHIM, XBHZZ X6966.SHIM, XBHZZ Y6967.SHIM, XBHZZ Y6968.SHIM, XBHZZ G6923.SHIM, XBHZZ H6924.SHIM, XBHZZ J6926.SHIM, XBHZZ K6927.SHIM, XBHZZ L6928.SHIM, XBHZZ M6929.SHIM, XBHZZ N6930.SHIM, XBHZZ P6932.SHIM, XBHZZ Q6933..SHIM, XBHZZ R6934.SHIM, XBHHH A2-3226E655.CAGE ASSEMBLY, PINION XBHZZ A3226E655..CAGE, ASSEMBLY, PINION XBHZZ E655...CAGE, PINION PAHZZ BB4616..CUP,TAPERED ROLLER PAHZZ HM CUP,TAPERED ROLLER PAHZZ TDAA4621A.CONE AND ROLLERS,TA OUTER PAHZZ HM CONE AND ROLLERS,TA INNER XBHHH PINION ASSEMBLY XBHZZ PINION, BEVEL PAHZZ H268..BEARING,ROLLER,CYLI PAHZZ D6E W RING,RETAINING PAHZZ D6E9 JM CUP,TAPERED ROLLER PAHZZ E-57.RING,EXTERNALLY THR ADJUSTING PAHZZ D6E R-2176.PIN,COTTER PAHZZ PLUG,PIPE... 1 END OF FIGURE /(197 blank)

215

216 Figure 71. Parking Brake Linkage

217 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 12 BRAKES GROUP 1201 HAND BRAKES FIG. 71 PARKING BRAKE LINKAGE 1 PAOZZ CONTROL ASSEMBLY,PU PAOZZ CCV-0917 CLAMP,LOOP PFOZZ MS SCREW,CAP,HEXAGON H PFOZZ ERNA245 WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ L LEVER,MANUAL CONTRO XBOZZ SPACER, LEVER PAOZZ STRAP,RETAINING XBOZZ SPACER, CLAMP PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS S WASHER,LOCK PAOZZ BOLT,MACHINE PFOZZ K-500-PC-0001 PIN,COTTER PFOZZ MS WASHER,FLAT PFOZZ MS PIN,STRAIGHT,HEADED PAOZZ BL BOLT,U XBOZZ L49736 SPACER U-BOLT XBOZZ L BRACKET, PARKING PFOZZ B1821BH044C175N SCREW,CAP,HEXAGON H PFOZZ MS S WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON... 2 END OF FIGURE

218 Figure 72. Parking Brake Assembly

219 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1201 HAND BRAKES FIG. 72 PARKING BRAKE ASSEMBLY 1 PAOZZ BRAKE,SHOE TYPE XBOZZ BACKING PLATE PAOZZ J88.SPACER,SLEEVE PFOZZ D6E9 2247H1256.LEVER,REMOTE CONTRO PFOZZ BRAKE SHOE LINING XAOZZ NSS.BRAKE SHOE PAOZZ SPRING,HELICAL,EXTE PAOZZ BRAKE LINING KIT XAOZZ H-504..RIVET,TUBULAR XBOZZ PLATE,BACKING,BR PAOZZ BRAKE DRUM PFOZZ H2525M WASHER,LOCK PFOZZ A1326 SCREW,CAP,HEXAGON H PFOZZ MS SCREW,CAP,HEXAGON H PAOZZ E-09 WASHER,LOCK XBOZZ SPACER... 4 END OF FIGURE

220 Figure 73. Service Brakes

221 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1202 SERVICE BRAKES FIG. 73 SERVICE BRAKES 1 XDOOO FSH BRAKE ASSEMBLY PFOZZ A-3236-E-1669.PLATE,BACKING,BRAKE PFOZZ H2525M.WASHER,LOCK PFOZZ B1821BH038C075D.SCREW,CAP,HEXAGON H PAOZZ W-49.PIN,STRAIGHT,HEADED PART OF KIT P/N 2 KIT KFOZZ A3-3722D134.SHOE LINING PART OF KIT P/N KIT PAOZZ A-1.SEAT,HELICAL COMPRE PART OF KIT P/N 4 KIT PAOZZ M-91.SPRING,HELICAL,COMP PART OF KIT P/N 2 KIT PAOZZ R-18.SPRING,HELICAL,EXTE PART OF KIT P/N 1 KIT PAOZZ CLIP,RETAINING PART OF KIT P/N 1 KIT PAOZZ FD21083 CYLINDER ASSEMBLY,H... 1 END OF FIGURE

222 Figure 74. Service Brake Pedal and Declutch Pedal

223 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1204 HYDRAULIC BRAKE SYSTEM FIG. 74 SERVICE BRAKE PEDAL AND DECLUTCH PEDAL 1 PFOZZ MS WASHER,LOCK PFOZZ B1821BH044C113N SCREW,CAP,HEXAGON H PFOZZ BUN9 A SCREW,CAP,HEXAGON H XBOZZ L PEDAL, SERVICE PFOZZ MS NUT,PLAIN,HEXAGON XBOZZ L PEDAL, DECLUTCH PAOZZ L SPRING,HELICAL,EXTE PFOZZ BUN9 A SCREW,CAP,HEXAGON H PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS WASHER,FLAT PFOZZ MS S WASHER,LOCK PAOZZ VALVE,CLUTCH CUTOUT XBOZZ L BRACKET, MOUNTING PAOZZ L SPRING,FLAT PFOZZ MS WASHER,LOCK PFOZZ MS SCREW,MACHINE PFOZZ MS BOLT,MACHINE PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ MA241A21020 PLUG,PIPE PFOZZ B1821BH025C125N SCREW,CAP,HEXAGON H PFOZZ AS FITTING,LUBRICATION PAOZZ CLEVIS,ROD END PFOZZ MS PIN,COTTER PFOZZ MS PIN,STRAIGHT,HEADED PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ L76372 PIN,STRAIGHT HE PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ CBM21389 WASHER,LOCK PAOZZ CONNECTOR,ROD END PAOZZ EB SWITCH,PRESSURE... 1 END OF FIGURE

224 Figure 75. Service Brake Hydraulic Brake Valve

225 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1204 HYDRAULIC BRAKE SYSTEM FIG. 75 SERVICE BRAKE HYDRAULIC BRAKE VALVE 1 PAOFF CYLINDER ASSEMBLY, PAOFF BRAKE BOOSTER ASSEM XBFZZ X SPRING, INNER XBFZZ PISTON, INNER XBFZZ PISTON KFFZZ B RING, PISTON PART PART OF KIT P/N KFFZZ X SEAL, PART OF KIT PART OF KIT P/N KFFZZ X RING, BACK-UP, PART PART OF KIT 3 P/N KFFZZ O-RING PART OF KIT PART OF KIT P/N XBFZZ X END PLUG, COVER PAFZZ BOOT,VEHICULAR COMP PART OF KIT 1 P/N XBFZZ ROD, PUSH XBFZZ X ROD, ACTUATOR KFFZZ RING, RETAINING, PART OF KIT P/N PAFZZ X CAP,PROTECTIVE,DUST XBFZZ SPRING, OUTER XAFZZ HOUSING XBFZZ PLUG XBFZZ RING, RETAINING XBFZZ PLUG, END KFFZZ O-RING PART OF KIT, PART OF KIT 1 P/N XBFZZ SPRING PFFZZ SHIM... V 24 PFFZZ SHIM... V 25 PFFZZ SHIM... V 26 XBFZZ X PISTON XBOZZ LABEL PAOZZ SCREW,DRIVE PAOZZ CYLINDER ASSEMBLY XAOZZ HOUSING PAOZZ GASKET PAOZZ CAP,FILLER OPENING PFOZZ H2525M.WASHER,LOCK PFOZZ B1821BH038C125N.SCREW,CAP,HEXAGON H... 3 END OF FIGURE

226 Figure 76. Service Brake Lines

227 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1204 HYDRAULIC BRAKE SYSTEM FIG. 76 SERVICE BRAKE LINES 1 PFOZZ L TUBE,ASSEMBLY,MET BRAKE, SUPPLY XAOZZ FITTING, TUBE XAOZZ L TUBE PAOZZ PLUG,TUBE FITTING PAOZZ TEE,PIPE TO TU PAOZZ L HOSE ASSEMBLY,NONME DECLUTCH VALVE, 1 OUT... 7 PFOZZ L TUBE ASSEMBLY,MET BRAKE SUPPLY XAOZZ FITTING, TUBE XAOZZ L TUBE ASSEMBLY,METAL PAOZZ M1191A ELBOW,PIPE TO TUBE PFOZZ L TUBE ASSEMBLY,MET DECLUTCH INLET XAOZZ FITTING, TUBE, XAOZZ L TUBE PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK PAOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PAOZZ L HOSE ASSEMBLY,NONME DECLUTCH VALVE, 1 INLET PAOZZ CCV0617 CLAMP,LOOP PAOZZ L76365 TEE,TUBE PFOZZ LAL1 L TUBE ASSEMBLY,METAL FRONT BRAKE XAOZZ FITTING, TUBE, XAOZZ L TUBE PAOZZ H BOLT,FLUID PASSAGE PAOZZ FC602 WASHER,FLAT PAOZZ A18531 FITTING,BRAKE PAOZZ FC603F WASHER,FLAT PAOZZ ADAPTER,STRAIGHT,PI PAOZZ A TEE,PIPE XDOZZ PLT2I-M30 STRAP,TIEDOWN ELECT PAOZZ L HOSE ASSEMBLY,NONME PAOZZ C0V0913Z1 CLAMP,LOOP PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H... 1 END OF FIGURE

228 Figure 77. Wheels and Tires

229 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 13 WHEELS AND TRACKS GROUP 1311 WHEEL ASSEMBLY FIG. 77 WHEELS AND TIRES 1 PCOHH KWHL/TIREASSY WHEEL AND TIRE ASSEMBLY PAOZZ VALVE EXTENSION,TIR PFOZZ TYII/CL2/J VALVE,PNEUMATIC TIR PAOZZ L WHEEL,PNEUMATIC TIR PCOFF X/GP1/TYBA/CL2/1.TIRE,PNEUMATIC,VEHI /8PLY END OF FIGURE

230 Figure 78. Steering Gear and Steering Column

231 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 14 STEERING GROUP 1407 POWER STEERING GEAR ASSEMBLY FIG. 78 STEERING GEAR AND STEERING COLUMN 1 PFFFF HGA28015-A STEERING GEAR XAFZZ K67292.HYDRAGUIDE UNIT PAFZZ L SCREW,CAP,HEXAGON H XAFZZ A1..COVER ASSEMBLY, END XAFZZ COVER, END XAFZZ ROLLER, NEEDLE PAFZZ WASHER XAFZZ SEAL,PLAIN PAFZZ SEAL,SPECIAL PAFZZ COMMUTATOR ASSEMBLY XAFZZ HGA COMMUTATOR XAFZZ HGA RING, COMMUTATOR XAFZZ HGA MANIFOLD PAFZZ HGA ROTOR ASSEMBLY XAFZZ HGA LINK, DRIVE XAFZZ SPACER PAFZZ A1..PLUG,MACHINE THREAD XAFZZ K PLUG PAFZZ O-RING XAFZZ PLUG XAFZZ K HOUSING ASSEMBLY XAFZZ HGA HOUSING XAFZZ MS BALL XAFZZ K SPOOL, VALVE XBFZZ MS BEARING,BALL TAPERE PAFZZ L ROLLER,BEARING XBFZZ SPRING,HELICAL,COMP PFFZZ MS BALL,BEARING PAFZZ A1..PLUG ASSEMBLY,STEER PAFZZ O-RING XAFZZ PLUG XAFZZ A TORSION BAR XAFZZ BLANK, TORSION BAR XBFZZ G-403-Q...PIN,STRAIGHT,HEADLE PFFZZ MS BALL,BEARING PAFZZ X1..RING,RETAINING XBFZZ A2..PLUG,MACHINE THREAD XAFZZ A1...PLUG & O-RING XDFZZ O-RING XAFZZ PLUG, O-RING BOSS XBFZZ PIN PAFZZ SEAL,SPECIAL PAFZZ RING,RETAINING PAFZZ WASHER,SHOULDERED A

232 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 45 PAFZZ SEAL,PLAIN PAFZZ R1..BOLT,MACHINE XAFZZ HGA COVER, UPPER PAFZZ PACKING,PREFORMED XAFZZ SHIM, HYDRAGUIDES... V 50 XAFZZ SHIM, HYDRAGUIDES... V 51 XAFZZ SHIM, HYDRAGUIDES... V 52 XAFZZ SHIM, HYDRAGUIDES... V 53 PAFZZ RING,RETAINING PAFZZ BEARING,WASHER,THRU PAFZZ NTA1423..RETAINER AND ROLLER PAFZZ JD BEARING,WASHER,THRU PAFZZ WASHER XAFZZ SPACER PAFZZ CAM,CONTROL XBFZZ G-403-Q..ROLLER,BEARING PAFZZ L828 HGA RING,DRIVE XAFZZ SPACER (DRIVE LINK) PAFZZ A1.COVER ASSEMBLY,CONT AND CABLE 1 ASSEMBLY PAFZZ L SCREW PAFZZ GASKET PFFZZ MS WASHER,FLAT PAFZZ X ELECTRICAL CONTACT PAFZZ A1-737.TUBE ASSEMBLY,METAL XAFZZ BUSHING & RETAINER XAFZZ K TUBE, JACKET XBFZZ A1.CLAMP,TUBE PFFZZ MS NUT,PLAIN,HEXAGON PFFZZ MS WASHER,LOCK XAFZZ CLAMP,LOOP PFFZZ MS BOLT,MACHINE PAFZZ NUT,PLAIN,HEXAGON PAFZZ N6344.LEAD,ELECTRICAL PAFZZ TERMINAL,STUD PAFZZ INSULATOR,BUSHING PFFZZ N O-RING XBFZZ CABLE, HORN, # PAFZZ TERMINAL,QUICK DISC PFFZZ K67242.TUBE,WHEEL,STEERING PAFZZ SCREW,MACHINE PAFZZ RING ASSEMBLY,ELECT PAFZZ X1.RING,RETAINING PAFZZ N6343.COUPLING PFFZZ PIN PFFZZ MS S WASHER,LOCK PFFZZ MS BOLT,MACHINE XDOZZ L HORN BUTTON,VEHICLE THIS HORN 1 BUTTON KIT IS USED ON STEERING WHEELS STAMPED WITH P/N

233 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY A65544 ON UNDERSIDE, FOR ALL OTHER STEERING WHEELS USE KIT NSN: PAOZZ PARTS KIT,HORN BUTT PAOZZ PARTS KIT,HORN BUTT PAOZZ CAP,ELECTRICAL PAOZZ SPRING,HELICAL,COMP PAOZZ SPRING,HELICAL,COMP PAOZZ RECTIFIER,SEMICONDU PAOZZ INSULATOR,BUSHING PFOZZ PLATE ASSEMBLY PAOZZ WASHER,SHOULDERED A PAOZZ WVN A1.COVER,HORN BUTTON PAOZZ CONTACT,ELECTRICAL XDOZZ A65544 STEERING WHEEL THIS STEERING WHEEL 1 USES HORN BUTTON KIT P/N L (10988), ALL OTHERS USE HORN KIT PAOZZ WVN A1 COVER,HUB... 1 END OF FIGURE

234 Figure 79. Hydraulic Pump and Mounting

235 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1410 HYDRAULIC PUMP OR FLUID MOTOR ASSEMBLY FIG. 79 HYDRAULIC PUMP AND MOUNTING 1 PAOFF L PUMP,ROTARY PAFZZ P50N-S.PLUG,MACHINE THREAD XAFZZ PLUG XDOZZ ADAPTER,STRAIGHT PAOZZ L ELBOW,PIPE PAOZZ K16..COUPLING HALF,QUICK PAOZZ H CAP,QUICK,DISCONNEC KFFZZ O-RING, PART OF KIT PART OF KIT 1 P/N XAFZZ BACKPLATE ASSEMBLY XAFZZ S..TUBE, INTAKE XAFZZ C..BACKPLATE, CASTING XAFZZ BUSHING PAFZZ O-RING PART OF KIT P/N PFFZZ THRUST PLATE PART OF KIT P/N XAFZZ BODY XBFZZ PIN, DOWEL XBFZZ GEARSHAFT,HELICAL-S XAFZZ RING, RETAINING XAFZZ GEAR XAFZZ SHAFT, DRIVE XAFZZ KEY KFFZZ DIAPHRAGM, PART OF PART OF KIT P/N KFFZZ GASKET, BACK-UP PART OF KIT P/N PAFZZ GASKET PART OF KIT P/N KFFZZ SEAL, DIAPHRAGM, PART OF KIT P/N PFFZZ SPRING,HELICAL,COMP PART OF KIT P/N XDFZZ BALL,BEARING PART OF KIT P/N XBFZZ GEARSHAFT,BEVEL XAFZZ IDLER, SHAFT XAFZZ RING, RETAINING XAFZZ GEAR PAFZZ BOLT,MACHINE PAFZZ BOLT,MACHINE KFFZZ SEAL,PLAIN ENCASED PART OF KIT P/N PAFZZ PLATE ASSEMBLY,FRON XAFZZ C..FRONTPLATE CASTING XAFZZ BUSHING

236 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 38 XAFZZ BUSHING PAFZZ PLUG,MACHINE THREAD PAOZZ J GASKET PFOZZ MS WASHER,FLAT PFOZZ ERNA245 WASHER,LOCK PFOZZ B1821BH050C150N SCREW,CAP,HEXAGON H... 2 END OF FIGURE /(219 blank)

237

238 Figure 80. Hoses, Lines, and Fittings

239 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1411 HOSES, LINES, AND FITTINGS FIG. 80 HOSES, LINES, AND FITTINGS 1 PAOZZ ELBOW,TUBE TO BOSS 45 DEGREES, 1 PUMP TO SUPPLY HOSE... 2 PAOZZ L HOSE ASSEMBLY,NONME SUPPLY PFOZZ JAEJ1508 CLAMP,HOSE MOOZZ HOSE MAKE FROM HOSE,P/N S XBOZZ ELBOW, BARB FITTING XBOZZ L60497 NIPPLE,PIPE PFOZZ L TUBE ASSEMBLY,METAL STEERING BYPASS 1 8 XAOZZ L TUBE XAOZZ NUT XAOZZ SLEEVE PFOZZ SCREW,CAP,HEXAGON H PAOZZ COV-0513 CLAMP,LOOP PFOZZ MS WASHER,FLAT PFOZZ MS S WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ Y894 FFG2001T VALVE,GLOBE BYPASS PFOZZ LAL1 L TUBE ASSEMBLY,METAL STEERING BYPASS 1 18 XAOZZ L TUBE XAOZZ NUT XAOZZ SLEEVE PFOZZ MS51527A6 ELBOW,TUBE TO BOSS PFOZZ C36PS CLAMP,HOSE XBOZZ L60520 GUARD, STEERING PAOZZ BB06GF06X HOSE ASSEMBLY,NONME STEERING SUPPLY 2 25 PAOZZ L HOSE ASSY,NONMETALL STEERING SUPPLY 2 26 PAOZZ MS STRAP,TIEDOWN,ELECT XDOZZ NUT,PLAIN,HEXAGON XBOZZ L TEE,TUBE PFOZZ L TUBE ASSEMBLY,METAL TOP RIGHT XAOZZ SLEEVE XAOZZ NUT XAOZZ L TUBE PFOZZ L TUBE ASSEMBLY,METAL TOP LEFT XAOZZ SLEEVE XAOZZ NUT XAOZZ L TUBE XBOZZ TEE, STEERING PFOZZ LAL1 L TUBE ASSEMBLY,METAL STEERING SUPPLY 1 39 XAOZZ SLEEVE PAOZZ BTX-S.NUT,TUBE COUPLING XAOZZ L TUBE PFOZZ L TUBE ASSEMBLY,METAL STEERING SUPPLY 1 43 XAOZZ SLEEVE PAOZZ BTX-S.NUT,TUBE COUPLING XAOZZ L TUBE

240 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 46 XDOZZ L TUBE,METALLIC STEERING RETURN XAOZZ L TUBE PAOZZ MS51531-B12.NUT,TUBE COUPLING PAOZZ AS SLEEVE,FLARED,TUBE PFOZZ J C ADAPTER,STRAIGHT,PI... 2 A 51 XBOZZ ADAPTER, STEERING RETURN PFOZZ S ELBOW,TUBE TO BOSS PAOZZ R HOSE ASSEMBLY,NONME STEERING SUPPLY 1 54 PFOZZ L TUBE STEERING, TOP RIGHT XAOZZ L TUBE XAOZZ NUT XAOZZ SLEEVE PFOZZ L TUBE ASSEMBLY,METAL BOTTOM RIGHT XAOZZ L TUBE XAOZZ NUT XAOZZ SLEEVE PFOZZ ADAPTER,STRAIGHT,PI PAOZZ MS STRAP,TIEDOWN,ELECT PFOZZ MS ADAPTER,STRAIGHT,TU PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS S WASHER,LOCK PFOZZ MS WASHER,FLAT XBOZZ S5BXS TEE, RELIEF VALVE PAOZZ L VALVE,SAFETY RELIEF PAOZZ BOLT,MACHINE PFOZZ FSO-08X10 ADAPTER,STRAIGHT,TU PFOZZ L TUBE ASSEMBLY,METAL XAOZZ SLEEVE PFOZZ MS51531B10.NUT,TUBE COUPLING XAOZZ L TUBE PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK PFOZZ MS WASHER,FLAT PAOZZ H STRAP,RETAINING PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PAOZZ ELBOW,TUBE TO BOSS 90 DEGREES... 2 END OF FIGURE /(223 blank)

241

242 Figure 81.Steering Cylinder Assembly and Mounting

243 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1412 HYDRAULIC OR AIR CYLINDER FIG. 81 STEERING CYLINDER ASSEMBLY AND MOUNTING 1 PAOFF G CYLINDER ASSEMBLY,A XBFZZ G34959.ROD ASSY,HYDRAULIC PFFZZ AS FITTING,LUBRICATION XDFZZ BEARING,PLAIN,SELF PFFZZ MS RING,RETAINING PAFZZ G34816.PACKING NUT XAFZZ G GLAND, PACKING KFFZZ D PACKING,PREFORMED PART OF KIT P/N 1 G KFFZZ D WIPER PART OF KIT PART OF KIT P/N 1 G KFFZZ A SEAL PART OF KIT PART OF KIT P/N 1 G KFFZZ O-RING PART OF KIT P/N G PAFZZ SCREW,TAPPING XAFZZ G34954.TUBE XBFZZ D BUSHING AFFFF G35272.PISTON ASSEMBLY,CYL PFFZZ A RING,WIPER PFFZZ O-RING XAFZZ G PISTON PFFZZ G RING,PISTON PFFZZ T53567.WASHER,FLAT PFFZZ B1821BH063F175N.SCREW,CAP,HEXAGON H PAOZZ D25277 RING,RETAINING PAOZZ L PIN,GROOVED,HEADED PAOZZ L60302 PIN,GROOVED,HEADLES... 2 END OF FIGURE

244 Figure 82. Rollover Protective Structure

245 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 15 FRAME AND TOWING ATTACHMENTS GROUP 1501 FRAME, TOWING ATTACHMENTS, AND DRAWBARS FIG. 82 ROLLOVER PROTECTIVE STRUCTURE 1 PAOZZ L CANOPY,PROTECTIVE S WELDED ASSY PFOZZ RIVET,BLIND XBOZZ L PLATE,IDENTIFICATIO PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ ERNA245 WASHER,LOCK XBOZZ L STRAP, ROPS TIE PFOZZ MS WASHER,FLAT PFOZZ B1821BH050C150N SCREW,CAP,HEXAGON H PAOZZ M45913/1-16CG5C NUT,SELF-LOCKING,HE PAOZZ D37732 WASHER,FLAT XBOZZ L PLATE, REINFORCING PAOZZ BOLT,MACHINE XBOZZ L INSULATION BLANKET PFOZZ AD64ADS RIVET,BLIND XDOZZ L PLATE,INSTRUCTION... 2 END OF FIGURE

246 Figure 83. Chassis Frame

247 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1501 FRAME, TOWING ATTACHMENTS, AND DRAWBARS FIG. 83 CHASSIS FRAME 1 PAFZZ L60099 PIN,GROOVED,HEADED PAFZZ B20L BEARING,PLAIN,SELF PFFZZ AS FITTING,LUBRICATION XAHHH L CHASSIS, FRONT WELDED XBFZZ L PLATE, FLOOR, FRONT PFFZZ MS WASHER,FLAT PFFZZ H2525M WASHER,LOCK PFFZZ B1821BH038C125N SCREW,CAP,HEXAGON H XBOZZ RIVET, POP XDOZZ L PLATE,INSTRUCTION STEERING BYPASS 1 VALVE PFOZZ L GUARD,CHASSIS FRONT PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ ERNA245 WASHER,LOCK PFOZZ MS WASHER,FLAT PFOZZ B1821BH050C150N SCREW,CAP,HEXAGON H PFFZZ AS FITTING,LUBRICATION XBOZZ RIVET, POP XBOZZ L PLATE, SAFETY PIN PAFZZ L60008 PIN,STRAIGHT,THREAD PAFZZ D34668 WASHER,FLAT XBFZZ L60200 SPACER, LOWER PAFZZ L60551 BUSHING,SLEEVE PIVOT, LOWER PAOZZ PIN,STRAIGHT,HEADED XAHHH L CHASSIS, REAR XBOZZ L PLATE, DANGER PFHZZ NUT,SELF-LOCKING,HE USE WITH NEW 2 PIN P/N L (10988) PFHZZ M45913/1-20FG5C NUT,SELF-LOCKING,HE USE WITH OLD 2 PIN P/N L60132 (10988) XBHZZ D36434 WASHER, FLAT XBHZZ L47224 WASHER,FLAT XDHZZ L FRAME SECTION,STRUC PAHZZ D30933.BUSHING,SLEEVE XAHZZ L TRUNNION PFHZZ L PIN,STRAIGHT,HEADLE XBHZZ D36478 WASHER, FLAT XBOZZ L PLATE, DIESEL FUEL PFOZZ L PLATE TOWING XBOZZ L DECAL, REGISTRATION PAOZZ A19066 MOUNT,RESILIENT,WEA PAOZZ L47997 BUMPER,RUBBER PFOZZ H2525M WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ L PIN,STRAIGHT,HEADLE

248 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 42 PFOZZ MS PIN,SPRING PFFZZ M45913/1-14FG5C NUT,SELF-LOCKING,HE XDFZZ D26918 RING,RETAINING... 1 END OF FIGURE /(231 blank)

249

250 Figure 84. Two Bar and Pintle Hook

251 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1503 PINTLES AND TOWING ATTACHMENTS FIG. 84 TOW BAR AND PINTLE HOOK 1 PAOZZ L BAR, TOWING VEL PFOZZ MS WASHER,FLAT PFOZZ B1821BH075C275N SCREW,CAP,HEXAGON H PAOZZ L CHAIN ASSEMBLY,SING PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ M45913/2-12CG5C NUT,SELF-LOCKING,HE PFOZZ AA PINTLE ASSEMBLY,TOW PFOZZ ERNA245 WASHER,LOCK PFOZZ B1821BH050C225N SCREW,CAP,HEXAGON H... 4 END OF FIGURE

252 Figure 85. Grille

253 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 18 BODY, CAB, HOOD, AND HULL GROUP 1801 BODY, CAB, HOOD, AND HULL ASSEMBLIES FIG. 85 GRILLE 1 PAOZZ PIN,STRAIGHT,HEADED XBOZZ L BRACKET, UPPER PFOZZ MS WASHER,FLAT PAOZZ H2525M WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON XBOZZ L PLATE, MTG PFOZZ CBM21389 WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ CBM21389 WASHER,LOCK PFOZZ B1821BH038C125N SCREW,CAP,HEXAGON H PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS S WASHER,LOCK PFOZZ MS WASHER,FLAT PFOZZ L11465 SPACER,SLEEVE PAOZZ SCREW,MACHINE PFOZZ B1821BH031C175N BOLT,MACHINE PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ CBM21389 WASHER,LOCK PAOZZ R (25) CYLINDER,LOCK,VEHIC PFOZZ L GRILLE,METAL XBOZZ L PLATE, LATCH PFOZZ B1821BH025C175N SCREW,CAP,HEXAGON H PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ KNOB PAOZZ L BRACKET,ANGLE PFOZZ B1821BH025C175N SCREW,CAP,HEXAGON H PFOZZ W BUMPER PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ MS SCREW,MACHINE... 1 END OF FIGURE

254 Figure 86. Hood and Rear Fenders

255 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1801 BODY, CAB, HOOD, AND HULL ASSEMBLIES FIG. 86 HOOD AND REAR FENDERS 1 PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK PFOZZ MS WASHER,FLAT PFOZZ B1821BH038C125N SCREW,CAP,HEXAGON H PAOZZ PLATE,MOUNTING USED ON ENGINE 2 MODEL PAOZZ SCREW,CAP,HEXAGON USED ON ENGINE 8 MODEL PAOZZ WASHER,LOCK USED ON ENGINE MODEL PAOZZ NUT,PLAIN,HEXAGON USED ON ENGINE 8 MODEL XBOZZ L HOOD, TOP XBOZZ L PANEL,BODY,VEHICULA PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFOZZ AD64ADS RIVET,BLIND XBOZZ L PLATE, SLAVE RECEPTACLE XBOZZ L PLATE, HOOD SUPPORT LH XBOZZ L PLATE, HOOD SUPPORT RH PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS S WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS WASHER,LOCK PFOZZ B1821BH038C150N SCREW,CAP,HEXAGON H XBOZZ L FENDER, REAR PFOZZ L PANEL,SIDE,VEHICULA PFOZZ L HOOD,ENGINE COMPART XDOZZ L MARKER,IDENTIFICATI PFOZZ MS PIN,COTTER PAOZZ T PIN,STRAIGHT,HEADED PAOZZ HOOK,SUPPORT PFOZZ MS WASHER,FLAT PFOZZ SCREW,MACHINE PAOZZ HOOK,HOOD PFOZZ MS SCREW,MACHINE PFOZZ MS WASHER,FLAT PAOZZ A23725 HANDLE,MOUNTING PAOZZ MS BOLT,MACHINE PAOZZ A-80ZP STRAP,RETAINING... 4 END OF FIGURE

256 Figure 87. Hood and Front Fenders

257 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1801 BODY, CAB, HOOD, AND HULL ASSEMBLIES FIG. 87 HOOD AND FRONT FENDERS 1 XBOZZ PLUG, HOLE, FRONT PFOZZ B1821BH050C150N SCREW,CAP,HEXAGON H PFOZZ MS WASHER,FLAT PFOZZ B1821BH025C075N SCREW,CAP,HEXAGON H 1/4-20 X PFOZZ MS WASHER,FLAT 5/ PFOZZ YHH BOX,ACCESSORIES STO PAOZZ WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON 1/ XBOZZ L FENDER, FRONT XBOZZ L PANEL, FRONT COVER PFOZZ AD64ADS RIVET,BLIND XBOZZ L PLATE, AXLE DISCONNECT PFOZZ F98 SCREW,CAP,HEXAGON H PAOZZ FMN6 BEARING,SLEEVE PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ ERNA245 WASHER,LOCK PFOZZ MS WASHER,FLAT PFOZZ H2525M WASHER,LOCK PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFOZZ CBM21389 WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON... 2 END OF FIGURE /(240 blank)

258

259 Figure 88. Operator s Seat Assembly (Sheet 1 of 2)

260 Figure 88. Operator s Seat Assembly (Sheet 2 of 2)

261 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1806 UPHOLSTERY SEATS AND CARPETS FIG. 88 OPERATOR'S SEAT ASSEMBLY 1 PFOOO F140003TB SEAT,VEHICULAR PAOZZ CD.SCREW,MACHINE XAOZZ F RAIL, LH PAOZZ F620401AS.CUSHION,SEAT BACK,V XAOZZ F CUSHION,SEAT BACK,V PAOZZ C ADJUSTER, SEAT PAOZZ CD.SLIDE,STATIONARY,AD PAOZZ WASHER,LOCK PAOZZ CD.NUT,PLAIN,HEXAGON XAOZZ F RAIL, RH PAOZZ D BELT,VEHICULAR SAFE PFOZZ MS SCREW,CAP,HEXAGON H PFOZZ ERNA245 WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ L PLATE,MENDING PAOZZ BOLT,SQUARE NECK PFOZZ MS NUT,PLAIN,WING PAOZZ WASHER,FLAT PCOZZ CASE,MAINTENANCE AN PAOOO SEAT,VEHICULAR MOLDED SEAT PFOZZ SEAT BELT ASSEMBLY COMES WITH 1 BELTS AND ATTACHING HARDWARE XAOZZ S16464.SEAT BELTS PFOZZ S0236.SCREW,CAP,HEXAGON,H M12 X 1.75 X 2 30LG PFOZZ A210.WASHER,FLAT PFOZZ A119.NUT,SELF-LOCKING,HE... 2 END OF FIGURE

262 Figure 89. Noise Baffle Plate

263 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 1806 UPHOLSTERY SEATS AND CARPETS FIG. 89 NOISE BAFFLE PLATE 1 PFOZZ SCREW,CAP,HEXAGON H PFOZZ MS WASHER,FLAT PAOZZ L STRAP,MOUNTING MAT PAOZZ L MAT,FLOOR PAOZZ L ROD END,THREADED PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ ERNA245 WASHER,LOCK... 2 END OF FIGURE

264 Figure 90. Hydraulic Control Valve and Mounting

265 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 24 HYDRAULIC LIFT COMPONENTS GROUP 2402 HYDRAULIC CONTROL VALVE FIG. 90 HYDRAULIC CONTROL VALVE MOUNTING 1 PFFZZ MS SCREW,CAP,HEXAGON H PFFZZ MS WASHER,FLAT XBFZZ L PAN, OIL DRIP PBFHH V A VALVE, CONTROL XDHZZ K-20-4.BOLT XAHZZ SCREW, CAP XAHZZ NUT,HEX XBHZZ SEAL,PLAIN XDHZZ WB..PACKING,PREFORMED PFHZZ MS O-RING XBHHH PLATE, COVER, RIGHT XAHZZ PLATE, COVER XBHHH PLUG PAHZZ O-RING XAHZZ PLUG PFFZZ MS NUT,PLAIN,HEXAGON PFFZZ MS S WASHER,LOCK... 3 END OF FIGURE

266 Figure 91. Hydraulic Control Valve, Left Side Cover Plate

267 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2402 HYDRAULIC CONTROL VALVE FIG. 91 HYDRAULIC CONTROL VALVE, LEFT SIDE COVER PLATE 1 XBFFF COVER, PLATE, LEFT XBFFF PLUG, RELIEF KBFZZ PLUG PART OF KIT, PART OF KIT P/N 1 K KBFZZ PACKING,PREFORMED PART OF KIT P/N 1 K-6132 PART OF KIT P/N K KBFZZ WASHER, BACK-UP PART OF KIT P/N K PART OF KIT P/N K KBFZZ PACKING,PREFORMED PART OF KIT P/N 1 K-6132 PART OF KIT P/N K XBFFF PLUG PAFZZ O-RING XAFZZ PLUG... 1 END OF FIGURE

268 Figure 92. Hydraulic Control Valve, Rotate, Side Shift, and Tiltsections

269 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2402 HYDRAULIC CONTROL VALVE FIG. 92 HYDRAULIC CONTROL VALVE, ROTATE, SIDE SHIFT, AND TILTSECTIONS 1 PAFFF VALVE,LINEAR,DIRECT XAFZZ HOUSING, VALVE XBFFF PLUG, LOAD CHECK XBFFF PLUG, CHECK KBFZZ PLUG PART OF KIT, PART OF KIT 1 P/N K-6030-A... 6 KBFZZ O-RING PART OF KIT P/N K-6030-A 1 PART OF KIT P/N K PFFZZ SPACER,RING PART OF KIT P/N K A PART OF KIT P/N K PAFZZ O-RING PART OF KIT P/N K-6030-A 1 PART OF KIT P/N K PFFZZ WASHER,FLAT PART OF KIT P/N K A PART OF KIT P/N K PAFZZ O-RING PART OF KIT P/N K-6030-A 1 PART OF KIT P/N K PFFZZ SPRING,HELICAL,COMP PART OF KIT 1 P/N K-6030-A PFFZZ DISK,VALVE PART OF KIT P/N K A XBFZZ POSITIONER, SPOOL XDFZZ SCREW PART OF KIT P/N K PFFZZ CAP-PLUG,PROTECTIVE PART OF KIT 1 P/N K PFFZZ MS SCREW,MACHINE PART OF KIT P/N K PFFZZ MS S..WASHER,LOCK PART OF KIT P/N K XDFZZ COLLAR,SPOOL PART OF KIT P/N K PFFZZ COLLAR,SPRING-STOP PART OF KIT P/N 2 K PFFZZ SPRING,HELICAL,COMP PART OF KIT 1 P/N K PAFZZ PACKING ASSORTMENT, XDFZZ RETAINER KBFZZ RING, BACK-UP PART OF KIT P/N K A PFFZZ SEAL PART OF KIT P/N K-6035-A XAFZZ SPOOL XBFZZ RETAINER, SPOOL XAFZZ PLATE, SEAL XAFZZ SCREW, MACHINE... 2 END OF FIGURE

270 Figure 93. Hydraulic Control Valve, Lift Section

271 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2402 HYDRAULIC CONTROL VALVE FIG. 93 HYDRAULIC CONTROL VALVE,LIFT SECTION 1 PAFFF AHU VALVE,LIFT,CONTROL THREE WAY XAFZZ HOUSING, VALVE XBFZZ PLUG, LOAD CHECK XBFZZ PLUG, CHECK KBFZZ PLUG PART OF KIT, PART OF KIT 1 P/N K-6030-A... 6 KBFZZ PACKING,PREFORMED PART OF KIT P/N 1 K-6030-A PART OF KIT P/N K PFFZZ RING, BACKUP PART OF KIT P/N K A PART OF KIT P/N K PAFZZ O-RING PART OF KIT P/N K-6030-A 1 PART OF KIT P/N K PFFZZ WASHER,FLAT PART OF KIT P/N K A PART OF KIT P/N K PAFZZ O-RING PART OF KIT P/N K-6030-A 1 PART OF KIT P/N K PFFZZ SPRING,HELICAL,COMP PART OF KIT 1 P/N K-6030-A PFFZZ DISK,VALVE PART OF KIT P/N K A XBFFF PLUG PAFZZ O-RING PFFZZ PLUG,MACHINE THREAD XBFFF PLUG, THREE WAY XBFZZ PLUG, THREE WAY PFFZZ PLUG,MACHINE THREAD PAFZZ O-RING PAFZZ O-RING PAFZZ O-RING PAFZZ SPACER,RING PAFZZ O-RING XAFZZ PLUG XAFZZ POSITIONER, SPOOL XDFZZ SCREW PART OF KIT P/N K PAFZZ CAP-PLUG,PROTECTIVE PART OF KIT 1 P/N K PFFZZ MS SCREW,MACHINE PART OF KIT P/N K PFFZZ MS S..WASHER,LOCK PART OF KIT P/N K XDFZZ COLLAR,SPOOL PART OF KIT P/N K KBFZZ COLLAR, SPRING PART OF KIT P/N K PFFZZ SPRING,HELICAL,COMP PART OF KIT 1 P/N K

272 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 33 PAFZZ PACKING ASSORTMENT, XDFZZ RETAINER KBFZZ RING, BACK-UP PART OF KIT P/N K A PFFZZ SEAL PART OF KIT P/N K-6035-A XAFZZ SPOOL, THREE WAY XBFZZ RETAINER, SPOOL XAFZZ PLATE, SEAL, XAFZZ SCREW, MACHINE,... 2 END OF FIGURE /(255 blank)

273

274 Figure 94. Hydraulic Control Levers and Linkage

275 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2403 HYDRAULIC CONTROLS AND/OR MANUAL CONTROLS FIG. 94 HYDRAULIC CONTROL LEVERS AND LINKAGE 1 PAOZZ R2 KNOB PAOZZ MS RING,RETAINING XBOZZ L60172 SHAFT, PIVOT, LEVER PFOZZ L LEVER,MANUAL CONTRE PAOZZ FF718-1.BEARING,SLEEVE XAOZZ L LEVER PAOZZ MS WASHER,FLAT XDOZZ L LEVER,MANUAL CONTRO PAOZZ FF718-1.BEARING,SLEEVE XAOZZ L LEVER PFOZZ L LEVER,MANUAL CONTRO PAOZZ FF718-1.BEARING,SLEEVE XAOZZ L LEVER PFOZZ L LEVER,MANUAL CONTRO PAOZZ FF718-1.BEARING,SLEEVE XAOZZ L LEVER XBOZZ L60129 LINK,VALVE PFOZZ MS PIN,STRAIGHT,HEADED PFOZZ MS PIN,COTTER... 8 END OF FIGURE

276 Figure 95. Tilt Cylinder Assembly and Mounting

277 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2404 HYDRAULIC TILT CYLINDERS AND TILT CRANK FIG. 95 TILT CYLINDER ASSEMBLY AND MOUNTING 1 PAFFF A1 CYLINDER ASSEMBLY,A PAFZZ G32317.WASHER,FLAT PFFZZ B1821BH075F250N.SCREW,CAP,HEXAGON H PFFZZ G CYLINDER,ACTUATING, PFFZZ AS FITTING,LUBRICATION PAFZZ D30930.BUSHING,TABULATION PFFZZ G PISTON,LINEAR ACTUA PFFZZ G RING,WEARING PART OF KIT P/N 2 G PFFZZ G GASKET PART OF KIT P/N G PAFZZ G SEAL,PLAIN PAFZZ G PISTON,LINEAR ACTUA PFFZZ G RETAINER ASSEMBLY PAFZZ G PLUG,EXPANSION XAFZZ G GLAND ASSEMBLY XAFZZ G GLAND PAFZZ G SPACER,RING PFFZZ G PACKING,PREFORMED PART OF KIT P/N 1 G PAFZZ NO O-RING PART OF KIT P/N G PAFZZ D PACKING,PREFORMED PART OF KIT P/N 1 G PAFZZ G PLUG,EXPANSION PART OF KIT P/N 1 G PFFZZ G BEARING,SLEEVE PART OF KIT P/N 1 G XAFZZ G ROD PAFZZ L PIN STRAIGHT HEADLE PAFZZ R17756 CONNECTOR,ROD END PFFZZ B1821BH050C175N SCREW,CAP,HEXAGON H PFFZZ ERNA245 WASHER,LOCK PFFZZ MS NUT,PLAIN,HEXAGON PAFZZ D25279 RING,RETAINING PAFZZ D PIN,GROOVED,HEADLES... 2 END OF FIGURE

278 Figure 96. Mast and Carriage (Upper)

279 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2405 HYDRAULIC MAST COLUMN FIG. 96 MAST AND CARRIAGE (UPPER) 1 XBHZZ PIN, ROLL PFHZZ MS SCREW,CAP,HEXAGON H PFHZZ MS WASHER,FLAT PFHZZ L RH CHANNEL,HOSE PFHZZ L CHANNEL,HOSE PFHZZ L CHANNEL,HOSE,LH XBOZZ S RIVET, POP XDOZZ L PLATE,IDENTIFICATIO PAFZZ L SPACER,SLEEVE PAFZZ A34471 BOLT,SHOULDER PAFZZ WASHER,FLAT PFFZZ AMS 5687 WIRE,NONELECTRICAL XBHZZ L MAST WELDMENT, INNER PAHZZ D SPRING,HELICAL COMP PAHZZ PIN,HOLLOW PAHZZ L RETAINER,HELICAL CO PAHZZ L PIN,GROOVED,HEADED PAFZZ L SHIM,BEARING PAFZZ MG307FF BEARING,BALL,ANNULA XBHZZ L MAST WELDMENT, OUTER XBOZZ L PLATE, PATENT,MAST XBOZZ SCREW, DRIVE PFFZZ MS WASHER,LOCK PAFZZ L PLUG,MACHINE THREAD PAFZZ L CHAIN,ROLLER PFFZZ MS NUT,PLAIN,HEXAGON PFFZZ MS WASHER,FLAT XBFZZ BB-1113 BUMPER, HOSE PFFZZ MS SCREW,CAP,HEXAGON H PAFZZ L WASHER,FLAT PAFZZ L BOLT,SHOULDER PFFZZ MS WASHER,FLAT PAFZZ AA839-4 BEARING,SLEEVE XDFZZ L36258 PULLEY KIT PFFZZ L PULLEY,GROOVE PAFZZ SCREW,CAP,SOCKET HE (S/N AND ABOVE) PFFZZ H2525M WASHER,LOCK PFFZZ L BAR,PULLEY PAFZZ L PULLEY,FLAT XAFZZ L PULLEY, CHAIN PAFZZ M084 MU5206TM/W103.BEARING,ROLLER,CYLI PAFZZ L WASHER,FLAT PFFZZ MS RING,RETAINING PAOZZ L GUARD,MECH SERIAL NO AND 1 ABOVE. PART OF KIT P/N L

280 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 45 PAOZZ WASHER,SPECIAL SERIAL NO AND ABOVE. PART OF KIT P/N L PAOZZ WASHER,LOCK SERIAL NO AND 4 ABOVE PART OF KIT P/N L PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H SERIAL NO AND ABOVE PART OF KIT P/N L PFFZZ M45913/1-20FG5C NUT,SELF-LOCKING,HE PAHZZ WASHER,FLAT PAHZZ WASHER,FLAT PAHZZ L AND 131- SHAFT,SHOULDERED PFOZZ AS FITTING,LUBRICATION PAHZZ M45913/3-4CG8C NUT,SELF-LOCKING,HE... 3 END OF FIGURE /(263 blank)

281

282 Figure 97. Mast and Carriage (Lower)

283 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2405 HYDRAULIC MAST COLUMN FIG. 97 MAST AND CARRIAGE (LOWER) 1 PAFZZ MS RING,RETAINING PAFZZ L SPACER,RING PFHZZ L CARRIAGE ASSY MAST PAFZZ L BOLT,CLEVIS PFHZZ MS SCREW,CAP,SOCKET HE PAFZZ L PIN,STRAIGHT,HEADLE PFFZZ A PIN,COTTER PAFZZ L SHIM,BEARING PAFZZ MG307FF BEARING,BALL,ANNULA PFFZZ MS SCREW,CAP,HEXAGON H PFFZZ ERNA245 WASHER,LOCK XBFZZ L STRAP, CYLINDER PFFZZ B1821BH075C325N SCREW,CAP,HEXAGON H XBFZZ MF RING,RETAINING PAFZZ L PIN,TAPERED,THREADE PFFZZ MS WASHER,LOCK PFFZZ MS NUT,PLAIN,HEXAGON PAFZZ L SPACER,SLEEVE PAFZZ L PULLEY,FLAT PAFZZ M084 MU5206TM/W103.BEARING,ROLLER,CYLI XAFZZ L PULLEY, CHAIN PAFZZ WASHER,FLAT PBHZZ L FRAME,SIDE,SHIFT PFFZZ MS WASHER,LOCK PAFZZ NUT,SELF-LOCKING HE PAFZZ MS RING,RETAINING PAFZZ L CHAIN,ROLLER SHIFT XBHHH L CARRIAGE ASSEMBLY XBHZZ D38774.RING,RETAINING PAHZZ L BEARING,SLEEVE XAHZZ L CARRIAGE WELDMENT PFOZZ AS FITTING,LUBRICATION PFHZZ B1821BH038C300N SCREW,CAP,HEXAGON H PAOZZ L FORK,LIFT TRUCK PFHZZ M45913/1-6CG5C NUT,SELF-LOCKING,HE XBHZZ L BAR, FORK TRAVEL PFOZZ MS21044N8 NUT,SELF-LOCKING,HE PAHZZ SCREW,CAP,HEXAGON H XBHZZ L BAR, CARRIAGE XBHZZ L RETAINER, BAR PFHZZ H2525M WASHER,LOCK PFHZZ B1821BH038C125N SCREW,CAP,HEXAGON H PAFZZ BL534 CHAIN,LEAF PFHZZ T7-11P2 BEARING,BALL,ANNULA PAHZZ WASHER,FLAT PFHZZ MS NUT,PLAIN,HEXAGON

284 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 47 PFFZZ MS SCREW,CAP,SOCKET HE XBFZZ CFH-13/4-SB CAM,ROLLER... 4 END OF FIGURE /(267 blank)

285

286 Figure 98. Lift Cylinder Assembly

287 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2405 HYDRAULIC MAST COLUMN FIG. 98 LIFT CYLINDER ASSEMBLY 1 PAFFF G CYLINDER ASSEMBLY,A PFFZZ G PARTS KIT,LINEAR AC PAFZZ VALVE,BLEEDER,HYDRA XAFZZ G CAP, END PAFZZ G PLUG,EXPANSION KFFZZ G RING, BACKUP PART PART OF KIT P/N 1 G KFFZZ O-RING PART OF KIT PART OF KIT 1 P/N G PAFZZ G CYLINDER,TUBE PAFZZ MS RING,RETAINING XAFZZ G PISTON ASSEMBLY ASSEMBLE FROM 1 PARTS KIT P/N G KFFZZ G RING, WEAR PART OF PART OF KIT 2 P/N G KFFZZ G SEAL PART OF KIT P/N G KFFZZ G RING,LOADER PART OF KIT P/N 1 G KFFZZ G RING, BACKUP PART PART OF KIT P/N 2 G XDFZZ O-RING PART OF KIT P/N G PFFZZ G PISTON,LINEAR ACTUA AFFZZ G GLAND ASSEMBLY ASSEMBLE FROM KIT 1 P/N G KFFZZ S WIPER PART OF KIT, PART OF KIT 1 P/N G PAFZZ G PLUG,EXPANSION PART OF KIT P/N 1 G PFFZZ G RETAINER,OIL SEAL KFFZZ G BEARING PART OF KIT PART OF KIT 1 P/N G KFFZZ G SEAL PART OF KIT P/N G KFFZZ S RING, BACKUP PART PART OF KIT P/N 1 G KFFZZ O-RING PART OF KIT PART OF KIT 1 P/N G XAFZZ G TUBE, OUTER, WELD AFFFF G RING ASSEMBLY ASSEMBLE FROM KIT 1 G KFFZZ S WIPER PART OF KIT PART OF KIT P/N 1 G XBFZZ G RING AFFZZ G RETAINER,PACKING ASSEMBLY FROM 1 PARTS KIT P/N G KFFZZ G WIPER PART OF KIT PART OF KIT P/N 1 G

288 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 31 XAFZZ G RETAINER,OIL SEAL PAFZZ G PLUG,EXPANSION PART OF KIT P/N 1 G KFFZZ G BEARING PART OF KIT PART OF KIT 1 P/N G KFFZZ G SEAL PART OF KIT PART OF KIT P/N 1 G KFFZZ G RING,BACKUP PART OF KIT P/N 1 G KFFZZ O-RING PART OF KIT PART OF KIT 1 P/N G PAFZZ G SHAFT,SHOULDERED PFFZZ G RING,WEARING PART OF KIT P/N 2 G END OF FIGURE /(271 blank)

289

290 Figure 99. Sideshift Cylinder Assembly

291 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2405 HYDRAULIC MAST COLUMN FIG. 99 SIDESHIFT CYLINDER ASSEMBLY 1 PAFFF G CYLINDER ASSEMBLY,A XAFZZ G TUBE PFFZZ A1.STUFFING TUBE KFFZZ SEAL,RING PART OF KIT P/N C KFFZZ G RING, BACKUP PART PART OF KIT P/N C XAFZZ G GLAND (NSS) PAFZZ G PLUG,EXPANSION KFFZZ D WIPER PART OF KIT PART OF KIT P/N C KFFZZ D PACKING,PREFORMED PART OF KIT P/N C PAFZZ G CLEVIS,ROD END XAFZZ G PISTON NSS KFFZZ G RING, WEAR PART OF PART OF KIT P/N C KFFZZ G RING, SEAL LOADER PART OF KIT P/N C PAFZZ G PACKING,PREFORMED XBFZZ G PISTON PAFZZ G32317.WASHER,FLAT PFFZZ B1821BH075F250N.SCREW,CAP,HEXAGON H... 1 END OF FIGURE

292 Figure 100. Mast and Carriage Hoses, Lines, and Fittings (Serial Numbers and Below)

293 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2406 HYDRAULIC LINES AND FITTINGS FIG. 100 MAST AND CARRIAGE HOSES, LINES, AND FITTINGS (SERIAL NUMBERS AND BELOW) 1 PAOZZ L HOSE ASSEMBLY,NONME PAOZZ L TUBE,TENSION PAOZZ GD SPRING,HELICAL,CO PAOZZ MS LOCKNUT,TUBE FITTIN PFOZZ L TUBE ASSEMBLY,METAL XAOZZ NUT XAOZZ SLEEVE XAOZZ L TUBE XDOZZ MS51520A5 ADAPTER,STRAIGHT,TU PFOZZ L TUBE ASSEMBLY,METAL XAOZZ L TUBE XAOZZ SLEEVE XAOZZ NUT PAOZZ L HOSE ASSY,NONMETALL PAOZZ J514 ELBOW,TUBE TO BOSS PFOZZ L TUBE ASSEMBLY,METAL XAOZZ L TUBE XAOZZ SLEEVE XAOZZ NUT PFOZZ MS51507-A5 ELBOW,TUBE PFOZZ BS00 L TUBE ASSEMBLY,METAL XAOZZ NUT XAOZZ SLEEVE XAOZZ L TUBE PAOZZ L HOSE ASSEMBLY,NONME PFOZZ MS51522A5S ELBOW,TUBE PFOZZ MS51521A5S ELBOW,TUBE PAOZZ L HOSE ASSY,NONMETALL PAOZZ L HOSE ASSY,NONMETALL SPRING TUBE PAOZZ L HOSE ASSY,NONMETALL OUTER CHANNELS PAOZZ L ELBOW,PIPE... 2 END OF FIGURE

294 Figure 101. Mast and Carriage Hoses, Lines, and Fittings (Serial Numbers and Above)

295 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2406 HYDRAULIC LINES AND FITTINGS FIG. 101 MAST AND CARRIAGE HOSES, LINES, AND FITTINGS (SERIAL NUMBERS AND ABOVE) 1 PAOZZ L HOSE ASSEMBLY,NONME PAOZZ L TUBE,TENSION PAOZZ GD SPRING,HELICAL,CO PAOZZ MS LOCKNUT,TUBE FITTIN PFOZZ L TUBE ASSEMBLY,METAL XAOZZ NUT XAOZZ SLEEVE XAOZZ L TUBE XDOZZ MS51520A5 ADAPTER,STRAIGHT,TU PFOZZ L TUBE ASSEMBLY,METAL XAOZZ L TUBE XAOZZ SLEEVE XAOZZ NUT PAOZZ L HOSE ASSY,NONMETALL PAOZZ J514 ELBOW,TUBE TO BOSS PFOZZ L TUBE ASSEMBLY,METAL XAOZZ L TUBE XAOZZ SLEEVE XAOZZ NUT PFOZZ MS51507-A5 ELBOW,TUBE PFOZZ BS00 L TUBE ASSEMBLY,METAL XAOZZ NUT XAOZZ SLEEVE XAOZZ L TUBE PAOZZ L HOSE ASSEMBLY,NONME PFOZZ MS51522A5S ELBOW,TUBE PFOZZ MS51521A5S ELBOW,TUBE PAOZZ L HOSE ASSY,NONMETALL PAOZZ L HOSE ASSY,NONMETALL PAOZZ L HOSE ASSY,NONMETALL PAOZZ L60751 ADAPTER,STRAIGHT PART OF KIT P/N 4 L PAOZZ NUT,PLAIN,HEXAGON PART OF KIT P/N 4 L PAOZZ L60749 TUBE ASSEMBLY,METAL PAOZZ L60747 TUBE ASSY,METAL PART OF KIT P/N 2 L PAOZZ BOLT,MACHINE PART OF KIT P/N L PAOZZ WASHER,LOCK PART OF KIT P/N L PAOZZ A12032 STRAP,RETAINING PART OF KIT P/N 2 L PAOZZ D39023 NUT,SPACER,PLA PART OF KIT P/N 2 L END OF FIGURE

296 Figure 102. Hydraulic Filter Assembly and Hoses, Lines, and Fittings

297 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2406 HYDRAULIC LINES AND FITTINGS FIG. 102 HYDRAULIC FILTER ASSEMBLY AND HOSES, LINES, AND FITTINGS 1 PFOZZ MSSL TUBE ASSEMBLY,METAL RETURN XAOZZ L TUBE, RETURN PAOZZ AS SLEEVE,FLARED,TUBE PAOZZ MS51531-B12.NUT,TUBE COUPLING PAOZZ ADAPTER,STRAIGHT,TU AOOZZ FS-251-2AOG FILTER ASSEMBLY, HYDRAULIC OIL 1 RETURN... 7 PAOZZ PARTS KIT,SAFETY RE XAOZZ HEAD ASSEMBLY, PAOZZ K23025.SPRING,HELICAL,COMP PAOZZ AT FILTER ELEMENT,FLUI PAOZZ MS51525A20 ADAPTER,STRAIGHT,TU FILTER TO TANK PAOZZ SA6 ELBOW,TUBE TO BOSS PFOZZ S ADAPTER,STRAIGHT,TU XDOZZ ADAPTER,STRAIGHT,TU PFOZZ L TUBE ASSEMBLY,METAL CONTROL VALVE 1 SUPPLY XAOZZ L TUBE PFOZZ MS51531B10.NUT,TUBE COUPLING XAOZZ SLEEVE PAOZZ ELBOW,TUBE PAOZZ L HOSE ASSY,NONMETALL PAOZZ L HOSE ASSY,NONMETALL PAOZZ MS51525A5Z ADAPTER,STRAIGHT,TU PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ MS S WASHER,LOCK PFOZZ MS WASHER,FLAT XDOZZ CLAMP,LOOP PAOZZ D SPACER,SLEEVE PFOZZ B1821BH031C150N SCREW,CAP,HEXAGON H PFOZZ L TUBE ASSEMBLY,METAL CONTROL VALVE 1 RETURN XAOZZ L TUBE PAOZZ MS51531-B12.NUT,TUBE COUPLING PFOZZ AS SLEEVE,FLARED,TUBE PFOZZ MS51510A12 TEE,TUBE PAOZZ ELBOW,TUBE TO BOSS PAOZZ ELBOW,SWIVEL FLANGE PAOZZ ELBOW,TUBE TO BOSS PAOZZ L HOSE ASSY,NONMETALL ROTATE AND 1 SIDE SHIFT PAOZZ L HOSE ASSY,NONMETALL PAOZZ L HOSY ASSY,NONMETALL ROTATE AND 1 SIDE SHIFT PAOZZ L HOSE ASSY,NONMETALL

298 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY 41 PAOZZ L HOSE ASSEMBLY,NONME PAOZZ L TEE,PIPE TO TUBE PAOZZ L HOSE ASSY,NONMETALL PAOZZ RESTRICTOR,FLUID FL PAOZZ ELBOW,TUBE TO BOSS XDOZZ L HOSE ASSY,NONMETALL CONTROL VALVE 1 RETURN PAOZZ L HOSE ASSY,NONMETALL SYSTEM RETURN PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK PFOZZ MS WASHER,FLAT XBOZZ L58147 CLAMP, HOSE PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PFOZZ MS NUT,PLAIN,HEXAGON PFOZZ H2525M WASHER,LOCK PFOZZ MS WASHER,FLAT XBOZZ D41165 CLAMP, TUBE PFOZZ B1821BH038C075D SCREW,CAP,HEXAGON H PAOZZ L HOSE ASSY,NONMETALL PAOZZ C04961FEG0310A HOSE ASSEMBLY,NONME SERIAL NO AND ABOVE PART OF KIT P/N L PAOZZ L HOSE ASSY,METALLIC SERIAL NO AND ABOVE PART OF KIT P/N L PAOZZ C05006FEG0340A HOSE ASSEMBLY,NONME SERIAL NO AND ABOVE PART OF KIT P/N L PAOZZ L HOSE ASSY,METAL SERIAL NO AND ABOVE PART OF KIT P/N L END OF FIGURE /(281 blank)

299

300 Figure 103. Rotation Cylinder Assembly

301 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2407 HYDRAULIC CYLINDERS FIG. 103 ROTATION CYLINDER ASSEMBLY 1 PAFFF G CYLINDER,ACTUATING XBFZZ G TUBE PFFZZ MS RING,RETAINING PAFZZ B20L..BEARING,PLAIN,SELF PFFZZ G PARTS KIT,CYLINDER KFFZZ SEAL,RING PART OF KIT P/N G KFFZZ G RING, BACKUP PART PART OF KIT P/N 1 G XAFZZ G GLAND PAFZZ G PLUG,EXPANSION KFFZZ G WIPER PART OF KIT PART OF KIT P/N 1 G KFFZZ G SEAL PART OF KIT PART OF KIT P/N 1 G PAFZZ G BEARING,PLAIN,ROD E PFFZZ MS RING,RETAINING PAFZZ B20L..BEARING,PLAIN,SELF PFFZZ AS FITTING,LUBRICATION XAFFF G PISTON (NSS) KFFZZ G RING, SEALING PART PART OF KIT 1 P/N G KFFZZ O-RING PART OF KIT PART OF KIT P/N 1 G XBFZZ G PISTON KFFZZ G RING, WEAR PART OF PART OF KIT P/N 1 G PAFZZ WASHER,FLAT PFFZZ B1821BH050F150N.SCREW,CAP,HEXAGON H... 1 END OF FIGURE

302 Figure 104. Hydraulic Tank

303 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 2408 LIQUID TANKS OR RESERVOIR FIG. 104 HYDRAULIC TANK 1 XBOOO L HYDRAULIC TANK, WELDED PAOZZ L GAGE ROD-CAP,LIQUID PAOZZ PLUG,PIPE,MAGNETIC XBOZZ L77125.BAR, HOLD-DOWN XDOZZ PACKING,PREFORMED XBOZZ L77124.COVER, HYDRAULIC PAOZZ N O-RING PAOZZ L78045.WASHER,RECESSED PAOZZ SCREW,CAP,HEXAGON H PAOZZ FILTER ELEMENT,FLUI XBOZZ L DECAL, STAR XBOZZ RIVET, POP XBOZZ L PLATE, IDENTIFICATION, COLD START PFOZZ B1821BH038C150N SCREW,CAP,HEXAGON H PFOZZ MS WASHER,FLAT PFOZZ H2525M WASHER,LOCK PFOZZ MS NUT,PLAIN,HEXAGON PAOZZ S STRAINER ELEMENT,SE XBOZZ L PLATE, IDENTIFICATION XBOZZ RIVET, POP... 4 END OF FIGURE /(286 blank)

304

305 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 94 REPAIR KITS GROUP 9401 REPAIR KITS FIGURE KITS PAHZZ A RING SET,PISTON RE-RING, SET OF RING, PISTON, TOP ( 4) 6-1 RING, PISTON ( 4) 6-2 RING, PISTON, OIL ( 4) 6-3 PAFZZ A GASKET... 1 GASKET ( 8) 7-18 GASKET ( 1) 7-8 GASKET ( 1) 30-8 GASKET ( 1) 30-1 GASKET ( 1) GASKET ( 1) 14-9 GASKET, CYLINDER ( 1) 3-6 GROMMET,METALLIC ( 2) 7-3 O-RING ( 1) SPACER,SLEEVE ( 1) WASHER,FLAT ( 1) PAHZZ A GASKET SET CYLINDER BLOCK... 1 GASKET ( 1) 4-10 GASKET ( 1) 10-7 GASKET ( 1) 8-4 GASKET ( 1) 30-8 GASKET, TIMING GEAR( 1) 8-28 O-RING ( 1) XBHZZ A35771 PARTS KIT,PISTON AS... 1 PIN, PISTON, PART ( 4) 6-7 RING, RETAINING ( 8) 6-5 PAFZZ A44758 GASKET SET... 1 GASKET ( 1) 11-7 GASKET, OIL PAN ( 1) 11-1 PAHZZ A46382 PARTS KIT,PISTON AS... 1 O-RING ( 8) 2-20 PIN, PISTON, PART ( 4) 6-7 PISTON, 4-INCH BORE( 4) 6-4 RING, PISTON, TOP ( 4) 6-1 RING, PISTON ( 4) 6-2 RING, PISTON, OIL ( 4) 6-3 RING, RETAINING ( 8) 6-5 SLEEVE, CYLINDER ( 4) 2-19 PAHZZ A77994 PARTS KIT... 1 GASKET ( 4) GASKET ( 1) GASKET ( 1) KITS

306 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY O-RING ( 1) 2-39 O-RING ( 1) O-RING ( 1) SEAL ( 1) 4-20 SEAL,PLAIN ( 1) 5-32 SEAL,PLAIN ENCASED ( 4) PAOZZ DC62N1 SEAL,DUST... 1 CAP, PART OF KIT ( 1) CAP, PART OF KIT ( 1) WASHER, PART OF KIT( 2) WASHER, PART OF KIT( 2) 66-9 WASHER,FLAT ( 1) WASHER,FELT ( 1) PAFZZ G PARTS KIT,LINEAR USE OF SPECIAL 1 TOOL CAS-1704 REQUIRED... BEARING PART OF KIT( 1) BEARING PART OF KIT( 1) O-RING PART OF KIT( 1) O-RING ( 1) O-RING PART OF KIT( 1) 98-7 O-RING PART OF KIT( 1) PARTS KIT,ROTARY PU( 1)KITS- PLUG,EXPANSION ( 1) PLUG,EXPANSION ( 1) RING, BACKUP PART ( 1) RING, BACKUP PART ( 2) RING, BACKUP PART ( 1) 98-6 RING, WEAR PART OF( 2) RING,BACKUP ( 1) RING,WEARING ( 2) SEAL ( 1) SEAL PART OF KIT ( 1) WIPER PART OF KIT,( 1) WIPER PART OF KIT ( 1) WIPER PART OF KIT ( 1) PAFZZ G PARTS KIT,LINEAR AC... 1 BEARING,SLEEVE ( 1) GASKET ( 1) 95-9 O-RING ( 1) PACKING,PREFORMED ( 1) PACKING,PREFORMED ( 1) PLUG,EXPANSION ( 1) RING,WEARING ( 2) 95-8 PAFZZ C1 PARTS KIT,LINEAR AC... 1 PACKING,PREFORMED ( 1) 99-9 RING, BACKUP PART ( 1) 99-5 RING, SEAL LOADER ( 1) RING, WEAR PART OF ( 1) KITS

307 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY SEAL,RING ( 1) 99-4 WIPER PART OF KIT ( 1) 99-8 PAFZZ G34819 PARTS KIT,LINEAR AC... 1 O-RING ( 1) PACKING,PREFORMED ( 1) 81-8 SEAL PART OF KIT ( 1) WIPER PART OF KIT ( 1) 81-9 PAFZZ G35378 PARTS KIT,LINEAR AC... 1 O-RING PART OF KIT ( 1) RING, BACKUP PART ( 1) RING, SEALING PART( 1) RING, WEAR PART OF ( 1) SEAL PART OF KIT ( 1) SEAL,RING ( 1) WIPER PART OF KIT ( 1) PAHZZ K SEAL KIT... 1 PACKING,PREFORMED ( 1) 91-4 PACKING,PREFORMED ( 1) 91-6 WASHER, BACK-UP ( 2) 91-5 PAHZZ K-6030-A PARTS KIT,ENGINE PO... 1 DISK,VALVE ( 1) DISK,VALVE ( 1) O-RING ( 1) 92-6 O-RING ( 1) 92-8 O-RING ( 1) O-RING ( 1) 93-8 O-RING ( 1) PACKING,PREFORMED ( 1) 93-6 PLUG PART OF KIT, ( 1) 92-5 PLUG PART OF KIT, ( 1) 93-5 RING, BACKUP ( 1) 93-7 SPACER,RING ( 1) 92-7 SPRING,HELICAL,COMP( 1) SPRING,HELICAL,COMP( 1) WASHER,FLAT ( 2) 92-9 WASHER,FLAT ( 2) 93-9 PAHZZ K-6035-A SEAL KIT,VALVE... 1 RING, BACK-UP ( 1) RING, BACK-UP ( 1) SEAL ( 1) SEAL ( 1) PAHZZ K-6125 PARTS KIT,LINEAR AC... 1 CAP-PLUG,PROTECTIVE( 1) CAP-PLUG,PROTECTIVE( 1) COLLAR, SPRING ( 2) COLLAR,SPRING-STOP ( 2) COLLAR,SPOOL ( 1) COLLAR,SPOOL ( 1) KITS

308 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY SCREW ( 2) SCREW ( 2) SCREW,MACHINE ( 1) SCREW,MACHINE ( 1) SPRING,HELICAL,COMP( 1) SPRING,HELICAL,COMP( 1) WASHER,LOCK ( 1) WASHER,LOCK ( 1) PAFZZ K-6132 PARTS KIT,LINEAR DI... 1 PACKING,PREFORMED ( 1) 91-4 PACKING,PREFORMED ( 1) 91-6 PLUG PART OF KIT, ( 1) 91-3 WASHER, BACK-UP ( 2) 91-5 PAOZZ KIT9112 PARTS KIT,BRAKE SHO... 2 CLIP,RETAINING ( 1) PIN,STRAIGHT,HEADED( 2) 73-5 SEAT,HELICAL COMPRE( 4) 73-7 SHOE LINING ( 2) 73-6 SPRING,HELICAL,EXTE( 1) 73-9 SPRING,HELICAL,COMP( 2) 73-8 PAHZZ K6032 SEAL KIT... 1 O-RING ( 1) 92-6 O-RING ( 1) 92-8 O-RING ( 1) O-RING ( 1) 93-8 O-RING ( 1) PACKING,PREFORMED ( 1) 93-6 RING, BACKUP ( 1) 93-7 SPACER,RING ( 1) 92-7 WASHER,FLAT ( 2) 92-9 WASHER,FLAT ( 2) 93-9 PFFZZ L36259 PARTS KIT,CYL GUARD... 1 GUARD,MECH ( 1) SCREW,CAP,HEXAGON H( 4) WASHER,LOCK ( 4) WASHER,SPECIAL ( 4) PFFZZ N365 L36260 PARTS KIT,HYDRAULIC... 1 ADAPTER,STRAIGHT ( 4) BOLT,MACHINE ( 2) HOSE ASSY,METAL ( 1) HOSE ASSEMBLY,NONME( 1) HOSE ASSEMBLY,NONME( 1) HOSE ASSY,METALLIC ( 1) NUT,PLAIN,HEXAGON ( 4) NUT,SPACER,PLA ( 2) STRAP,RETAINING ( 2) TUBE ASSY,METAL ( 2) WASHER,LOCK ( 2) KITS

309 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY PAFZZ G PARTS KIT,ROTARY PU USE OF SPECIAL 1 TOOL CAS-1704 REQUIRED PART OF KIT P/N G RING,LOADER ( 1) SEAL ( 1) PAFZZ PARTS KIT,HYDRAULIC... 1 BOOT,VEHICULAR COMP( 1) O-RING PART OF KIT ( 1) 75-9 O-RING PART OF KIT,( 1) RING, BACK-UP, PART( 3) 75-8 RING, PISTON PART ( 1) 75-6 RING, RETAINING, ( 1) SEAL, PART OF KIT ( 3) 75-7 PAFZZ REPAIR KIT,HYDRAULI... 1 BALL,BEARING ( 2) DIAPHRAGM, PART OF ( 1) GASKET ( 1) GASKET, BACK-UP ( 1) O-RING ( 2) O-RING, PART OF KIT( 1) 79-8 SEAL, DIAPHRAGM, ( 1) SEAL,PLAIN ENCASED ( 1) SPRING,HELICAL,COMP( 2) THRUST PLATE ( 1) PAHZZ D87188 GASKET KIT... 1 GASKET ( 1) 57-7 O-RING ( 1) 57-8 O-RING ( 1) O-RING ( 1) O-RING ( 1) RING,PISTON ( 1) SEAL RING,METAL ( 1) 49-7 SEAL,PLAIN ENCASED ( 1) SPRING,EXPANDER,PIS( 1) 49-8 PAHZZ GASKET SET... 1 CUP,HYDRAULIC BRAKE( 1) 58-9 GASKET ( 1) GASKET ( 1) GASKET ( 1) 52-4 GASKET ( 1) GASKET ( 1) 59-9 O-RING ( 1) O-RING ( 1) O-RING ( 1) O-RING ( 1) O-RING ( 1) O-RING ( 1) O-RING ( 1) KITS

310 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY O-RING ( 1) O-RING ( 1) O-RING ( 1) 58-6 OIL SEAL ( 1) PACKING,PREFORMED ( 2) PACKING,PREFORMED ( 1) 52-2 PACKING,PREFORMED ( 1) PACKING,PREFORMED ( 1) PACKING,PREFORMED ( 1) PACKING,PREFORMED ( 1) 53-6 PACKING,PREFORMED ( 1) 53-7 PACKING,PREFORMED ( 1) 54-6 PACKING,PREFORMED ( 1) 54-7 PACKING,PREFORMED ( 1) 55-6 PACKING,PREFORMED ( 1) 55-7 PACKING,PREFORMED ( 2) 56-6 PACKING,PREFORMED ( 2) 56-7 PACKING,PREFORMED ( 4) 59-6 RING,PISTON ( 3) 50-1 RING,PISTON ( 2) 51-3 RING,PISTON ( 3) SEAL,OIL ( 1) 58-5 SEAL,PLAIN ENCASED ( 1) SEAL,PLAIN ENCASED ( 1) SEAL,PLAIN ENCASED ( 1) SPACER,RING ( 1) PAOZZ A FILTER,FLUID... 1 FILTER ELEMENT,FLUI( 1) FILTER,FLUID ( 1) 24-5 END OF FIGURE KITS

311 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 95 GENERAL USE STANDARDIZED PARTS GROUP 9501 BULK MATERIAL FIGURE BULK. 1 PAOZZ S HOSE,NONMETALLIC... V 2 PAOZZ FC662*12BLK-RL HOSE,NONMETALLIC... V 3 PAOZZ HOSE,NONMETALLIC... V 4 PFOZZ K91 PVC PIPE... V END OF FIGURE BULK /(294 blank)

312

313 WP 0003 WP 0003 Repair Parts List REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) - 0 1SPECIAL TOOLS LIST

314 WP 0003 Figure 105. Special Tools

315 WP 0003 (1) (2) (3) (4) (5) (6) (7) ITEM SMR PART NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY GROUP 26 TOOLS AND TEST EQUIPMENT GROUP 2604 SPECIAL TOOLS FIG. 105 SPECIAL TOOLS 1 PFFZZ CAS-1704 SLEEVE,TOOL,SPECIAL... 2 PEFZZ CAS INSERTER,SEAL... 3 PEFZZ CAS SLEEVE,EXTERNAL TAP... 4 PEHZZ T SCREWDRIVER,SIX POI... END OF FIGURE /(4 blank)

316

317 WP 0004 WP 0004 Repair Parts List REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) - CROSS-REFERENCE INDEXES

318 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

319 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

320 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS

321 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

322 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS KITS KITS

323 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS

324 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

325 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

326 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

327 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

328 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

329 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK KITS KITS

330 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK KITS

331 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS

332 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS KITS KITS

333 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS KITS KITS KITS KITS KITS KITS KITS

334 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS BULK KITS KITS

335 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

336 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS KITS KITS

337 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

338 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

339 WP 0004 CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

340 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A-A A-1205-S A-3236-E D6E9 A AAX AA AA59440/ AA JEBT AA JABT AA59616ACADBUE AA AD64ADS AMS AN AN AN931-B ASME-B AS AS AS AS AS AT D6E9 A Z A1-3235Z BUN9 A

341 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A A A A A A A A A A A A A A A A A A A A A A KITS A A A A A A A A A A A A A A A A A A A A A

342 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A A A A A A A A A A A A A A A A A A KITS A KITS A A A2-3200S A2-3226E A A A A A A A A A A A A A A3-3722D A A A A A A A A3121N

343 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A A3226E A333H A A A A A A35771 KITS A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A

344 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A A A A A A A A A A A A A A A A A A A A A A A A A A A KITS A A KITS A A A A A A A A A A A A A A A A A A A

345 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A A A A A A A A A A A733S-102CFG A A A A A A A A A A A A A A A A A A A A77994 KITS A8-3235Z B BB06GF06X BB1142B BB1239A BB BF836K BF BL

346 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM BXANSI B B1821BH025C075N B1821BH025C125N B1821BH025C175N B1821BH025C375N B1821BH031C150N B1821BH031C175N B1821BH038C075D B1821BH038C075D B1821BH038C125N

347 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM B1821BH038C150N B1821BH038C175N B1821BH038C200N B1821BH038C300N B1821BH038C350N B1821BH038C375N B1821BH038F150N B1821BH044C075N B1821BH044C113N B1821BH044C113N B1821BH044C150N B1821BH044C175N B1821BH044C225N B1821BH044C250N B1821BH044F150D B1821BH050C150N B1821BH050C175N B1821BH050C225N B1821BH050C325N B1821BH050C350N B1821BH050C450N B1821BH050F150N

348 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM B1821BH056C175N B1821BH063C250N B1821BH063C350N B1821BH063F175N B1821BH075C150N B1821BH075C275N B1821BH075C325N B1821BH075F250N B B20L D6E9 B52-333H B53-333H B B CAS CAS CASD CAS CB CBM CCV CCV CFH-13/4-SB T0Y2 CME COV COV COV COV CP CP62N-HWD

349 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM CR D6E9 CSH CW C C0-1813Z C0V C0V0913Z C M C3121N456-S C C36PS D-140-FSHX D D D DB0431AL DCD DC62N KITS DX D D D2NN7A247A D D D D D D D D D D

350 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM D D D D D D D D D D D D D D D D D KITS D EE EE ERNA ERNA E E E E FC FC603F FC662*12BLK-RL BULK FD FFB171/04J13A2E FFB171/08J11E2E

351 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM 2Y894 FFG2001T FF FMN FS-251-2AOG FSH FWG F F140003TB F F F F620401AS F F G-403-Q GAX GL GTB G G G G G G G G G G G G G G G

352 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G KITS G G KITS G G KITS

353 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM G G G G G G G G G G G G G G G G G G G G D6E9 G S-1111/ G G G G G G G G G G G G G G G G G G G G G G KITS G

354 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM G G G G KITS G G G G G G G G G G G G G G G HD PN HD SN HF HGA L828 HGA HGA HGA HGA HGA HGA HGA28015-A HGA HM HM HV H H H2525M H2525M

355 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM H H H H H IHP JAEJ JD D6E9 JM J J J C J C A J J J

356 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J

357 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM J J J J J K K KITS K-500-PC K-6030-A KITS K-6035-A KITS K KITS K KITS KF04-02PS KF04-02RS KIT KITS K K KITS K K K K K K L L L L L L L L LA LP LP LP LP LP LP LP LS L L L L L

358 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L

359 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM L L L L L L L L BS00 L L L L L L L L L L L L L L L L L L L L L L L L L

360 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM L L L L L L L L L L L L L L L L L L L L L L L L L LAL1 L L L L L L L L L L LAL1 L L L L L L L L L L L L

361 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L LAL1 L L L L L L L L L L L L L L L L L

362 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L

363 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM L L L L RH L L L L L L L L L L L L L L L L L L L L L AND L L L L L L L L L L L L L L L L L L KITS 1N365 L KITS L

364 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L L

365 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM L L L M MA241A B0B1 MB-2194P MG307FF MN-1030B MPD MSSL MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS C MS MS MS MS MS MS MS MS MS S MS21044N

366 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS

367 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS S

368 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS

369 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS51066RP MS MS MS MS51506A MS51507-A MS51507-A MS51510A MS51520A MS51521A5S

370 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS51522A5S MS51525-A MS51525A MS51525A5Z MS51527A MS51531-B MS51531B MS MS MS MS MS MS MS MS MS MS MS MS

371 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS

372 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MU1010-V M084 MU5206TM/W M1191A M M45913/1-10CG5C M45913/1-10FG5C M45913/1-14FG5C M45913/1-16CG5C M45913/1-20FG5C M45913/1-5CG5C M45913/1-6CG5C M45913/1-8CG5C

373 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM M45913/2-12CG5C M45913/3-4CG8C M83461/ N NAS B NAS561P NO NSS NSS NSS NSS NTA NUSL N N N N N N N N N N P PER PLT2I-M PPP P P P P P

374 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM P P P9110K QA1-2TC QK-1027-B QS1-2TC R RB RB RD RV R R R103G R R R R R S S S S-915-A SAEB SAEB SAEB SAEB SAEB SAETYPE1-180DIA AWG SAETYPE10-156DIA AWG Y875 SAW SA D6E9 SC

375 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM SF32RTC SG3106-E28-51S SMP SPG SST-2-S S S S BULK S S S25B S S T T TA CO-18NB TBD TDAA4621A TYII/CL2/J T T T7-11P V A WAFR WAR WJ WJ WSP WW-P-471-ACABCA WWP W X X/GP1/TYBA/CL2/ /8PLY X X X X

376 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM X X Z STYLE KITS L L A L S

377 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM BL YHH A R (25) C04961FEG0310A C05006FEG0340A BB C A EB S KSL S ML A B 1/8-27NPT

378 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM T8R NLS T8R NLS T8R NYSM T8R T8R D6E R K P50N-S SA S5BXS Z329PC

379 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM C C H D6E V D6E W D6E W D6E Y C E E R U U

380 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A A E W C C C C C C C

381 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM X X-1325-S C KITS C U F Y

382 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM NREVA GD W J A C

383 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM R S A C X A N N A K CA

384 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM R2T X-1556C S P S WRR S

385 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM NSR Z A B B D E F G G H H J J

386 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM K K L L M M N N P P Q Q R R S S T T U U V V W W

387 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM X X X Y Y Y Y Z D6E9 2208U E R MF

388 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM D6E A D6E N M M D6E9 2247H E5W B H M

389 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM

390 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM

391 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM C C S KITS

392 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM K K K K K K K R R R R A-80ZP CD M X

393 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM WB R C R

394 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM S D6E P D6E Q Q E W Z D6E9 3278Z B8S A T H

395 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM R A A632PC W X A X B8S D6E9 3905L

396 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM B8S B8S

397 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM 0CTH CTH B8S B8S B8S B8S B8S B8S B8S B8S B8S B8S B8S

398 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM B8S B8S A A A LTL B8S LTL KWHL/TIREASSY A X CD A A N U A A A

399 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM 0U E N A K C A H K91 BULK 4 0AHU C C E BULK

400 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MF R CD C D WVN A WVN A D H TLFP K K K FL-3/ NYSM N1A N4-4A

401 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM PT C W C C FL3-8X C

402 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM FB1/8IN AHU BTX-S A KITS A KITS L L L

403 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM FSO-08X AHU

404 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM

405 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM

406 WP 0004 CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM X A A F K R

407 AMSTA-LC-LMPP/TECH PUBS, TACOM-RI 1 Rock Island Arsenal Rock Island, IL July 2008 Unit, DS, and GS RPSTL for Truck, Forklift, DED, Pneumatic Tire, Articulated, Frame Steer, 4000-lb Capacity Rough Terrain, Army Model MHE 237

408 AMSTA-LC-LMPP/TECH PUBS, TACOM-RI 1 Rock Island Arsenal Rock Island, IL July July 2008 Unit, DS, and GS RPSTL for Truck, Forklift, DED, Pneumatic Tire, Articulated, Frame Steer, 4000-lb Capacity Rough Terrain, Army Model MHE Part number supplied for item 2 is incorrect.

409 AMSTA-LC-LMPP/TECH PUBS, TACOM-RI 1 Rock Island Arsenal Rock Island, IL July 2008 Unit, DS, and GS RPSTL for Truck, Forklift, DED, Pneumatic Tire, Articulated, Frame Steer, 4000-lb Capacity Rough Terrain, Army Model MHE 237

410 AMSTA-LC-LMPP/TECH PUBS, TACOM-RI 1 Rock Island Arsenal Rock Island, IL July 2008 Unit, DS, and GS RPSTL for Truck, Forklift, DED, Pneumatic Tire, Articulated, Frame Steer, 4000-lb Capacity Rough Terrain, Army Model MHE 237

411 AMSTA-LC-LMPP/TECH PUBS, TACOM-RI 1 Rock Island Arsenal Rock Island, IL July 2008 Unit, DS, and GS RPSTL for Truck, Forklift, DED, Pneumatic Tire, Articulated, Frame Steer, 4000-lb Capacity Rough Terrain, Army Model MHE 237

412 AMSTA-LC-LMPP/TECH PUBS, TACOM-RI 1 Rock Island Arsenal Rock Island, IL July 2008 Unit, DS, and GS RPSTL for Truck, Forklift, DED, Pneumatic Tire, Articulated, Frame Steer, 4000-lb Capacity Rough Terrain, Army Model MHE 237

413 AMSTA-LC-LMPP/TECH PUBS, TACOM-RI 1 Rock Island Arsenal Rock Island, IL July 2008 Unit, DS, and GS RPSTL for Truck, Forklift, DED, Pneumatic Tire, Articulated, Frame Steer, 4000-lb Capacity Rough Terrain, Army Model MHE 237

414 AMSTA-LC-LMPP/TECH PUBS, TACOM-RI 1 Rock Island Arsenal Rock Island, IL July 2008 Unit, DS, and GS RPSTL for Truck, Forklift, DED, Pneumatic Tire, Articulated, Frame Steer, 4000-lb Capacity Rough Terrain, Army Model MHE 237

415 By Order of the Secretary of the Army: Official: GEORGE W. CASEY, JR. General, United States Army Chief of Staff DISTRIBUTION: To be distributed in accordance with the initial distribution requirements for IDN: , requirements for.

416

417

418

419

420 PIN:

421 This fine document... Was brought to you by me: Liberated Manuals -- free army and government manuals Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap watermarks and other junk on it, and sell it. Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it... They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends? I am setting this document FREE. This document was made by the US Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on. I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines: <A HREF= Military and Government Manuals</A> Sincerely Igor Chudov