TECHNICAL MANUAL TRUCK, FORKLIFT, ELECTRIC, SOLID RUBBER TIRES, 6000 LB CAPACITY, 180 IN. LIFT

Transcription

1 TM P TECHNICAL MANUAL TRUCK, FORKLIFT, ELECTRIC, SOLID RUBBER TIRES, 6000 LB CAPACITY, 180 IN. LIFT (DREXEL DYNAMICS MODEL FL60-EE5600) (ARMY MODEL MHE-206) NSN This manual supersedes TM P, dated April 1971, and TM P, dated 7 April Approved for public release; distribution is unlimited HEADQUARTERS, DEPARTMENT OF THE ARMY NOVEMBER 1992

2 TM P C1 CHANGE HEADQUARTERS DEPARTMENT OF THE ARMY NO. 1 Washington D.C., 24 June 1993 UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS TRUCK, FORKLIFT, ELECTRIC, SOLID RUBBER TIRES, 4000 LB CAPACITY, 144 IN. LIFT (DREXEL DYNAMICS MODEL FL-40-EE-5600M) (ARMY MODEL MHE-206) NSN TM P, dated 23 November 1992, is changed as follows 1. Cover. The manual title is changed to read as shown above 2. Remove old pages and Insert new pages 3. New or changed material Is indicated by a vertical bar in the margin of the page Remove Pages Insert Pages i and ii i and ii 3 and 4 3 and 4 4. File this change sheet In front of the publication for reference purposes. Approved for public release: distribution is unlimited. 1

3 By Order of the Secretary of the Army. GORDON R. SULLIVAN General, United States Army Chief of Staff Official: MILTON H. HAMILTON Administrative Assistant to the Secretary of the Army Distribution: To be distributed In accordance with DA Form E, Block 5975, requirements for TM

4 TECHNICAL MANUAL TM P* HEADQUARTERS DEPARTMENT OF THE ARMY Washington, D.C., UNIT DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS TRUCK, FORKLIFT, ELECTRIC, SOLID RUBBER TIRES, 4000 LB CAPACITY, 144 IN. LIFT (DREXEL DYNAMICS MODEL FL-40-EE-5600M) (ARMY MODEL MHE-206) NSN Current as of 16 September 1992 REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this manual If you find any mistakes or if you know of a way to improve the procedures, please let us know Mall your letter, DA Form 2028 (Recommended Changes to Publications and Blank Forms), or DA Form , located In the back of this manual, direct to Commander, U S Army Tank- Automotive Command, ATTN AMSTA-MB, Warren, Ml A reply will be furnished to you. Approved for public release, distribution is unlimited. TABLE OF CONTENTS Page llus Fig SECTION I. INTRODUCTION 1 SECTION II. REPAIR PARTS LIST 1-1 GROUP 03 FUEL SYSTEM ACCELERATOR CONTROLS ACCELERATOR CONTROLS ACCELERATOR SWITCH GROUP 06 ELECTRICAL SYSTEM INSTRUMENT OR ENGINE CONTROL PANEL SILICON CONTROL RECTIFIER FORWARD-REVERSE CONTACTOR LINE AND PUMP CONTACTORS SHORTING CONTACTOR This manual supersedes TM P, dated 7 April 1971, and TM P, dated 7 April 1971 Change 1

5 TM P TABLE OF CONTENTS (Con t) Page Illus Fig MISCELLANEOUS ITEMS FUSE BLOCKS CONTROL BOX ASSEMBLY TERMINAL BOARDS. FUSES, RELAY, AND ATTACHING HARDWARE LIGHTS VEHICLE LIGHTS HORN, SIREN HORN, SWITCHES, AND ATTACHING HARDWARE BATTERIES, STORAGE BATTERY FRAME AND COMPARTMENT GROUP 07 TRANSMISSION TRANSMISSION SHIFTING COMPONENTS DIRECTIONAL SWITCH CONTROL CABLE DIRECTIONAL SWITCH SERVO UNIT STACK VALVE STACK VALVE ASSEMBLY GROUP 10 FRONT AXLE FRONT AXLE ASSEMBLY DRIVE AXLE ASSEMBLY OUTER HOUSING DIFFERENTIAL DIFFERENTIAL STEERING AND LEANING WHEEL MECHANISM DRIVE AXLE MOTOR ASSEMBLY (FRONT) GROUP 11 REAR AXLE REAR AXLE ASSEMBLY STEERING AXLE GROUP 12 BRAKES HANDBRAKES DRIVE AXLE BRAKE AND MOTOR SUPPORT SERVICE BRAKES SERVICE BRAKES HYDRAULIC BRAKE SYSTEM BRAKE LINES MASTER CYLINDER CYLINDER AND LINES MECHANICAL BRAKE SYSTEM BRAKE PEDAL GROUP 13 WHEELS AND TRACKS WHEEL ASSEMBLY WHEEL ASSEMBLY (FRONT) WHEEL ASSEMBLY (REAR) ii

6 TM P TABLE OF CONTENTS (Con t) Page Illus Fig TIRES, TUBES, TIRE CHAINS TIRE (FRONT) TIRE (REAR) GROUP 14 STEERING MECHANICAL STEERING GEAR ASSEMBLY STEERING BOOSTER STEERING GEAR STEERING DRAG LINK TIE-ROD GROUP 18 BODY, CAB, HOOD, AND HULL BODY, CAB, HOOD, AND HULL ASSEMBLIES OVERHEAD GUARD CONSOLE FLOORS, SUBFLOORS, AND RELATED COMPONENTS FLOOR PLATES AND ACCELERATOR PEDAL UPHOLSTERY, SEATS, AND CARPETS OPERATOR S SEAT SEAT SUPPORT AND SAFETY CONTROLS GROUP 24 HYDRAULIC AND FLUID SYSTEMS PUMP AND MOTOR HYDRAULIC PUMP COUPLING HYDRAULIC PUMP HYDRAULIC PUMP MOTOR TILT CYLINDERS AND TILT CRANK TILT CYLINDER MAST COLUMN LIFT FORKS AND CYLINDER YOKE LIFT CYLINDER LIFT MAST LIFT FORK CARRIER STRAINERS. FILTERS, LINES, AND FITTINGS. ETC HYDRAULIC FILTER HYDRAULIC LINES AND FITTINGS LIQUID TANKS OR RESERVOIRS HYDRAULIC RESERVOIR GROUP 47 GAGES (NONELECTRICAL), WEIGHING AND MEASURING DEVICES HOURMETER HOURMETER GROUP 94 REPAIR KITS REPAIR KITS... KITS-1 REPAIR KITS... KITS-1 KITS GROUP 95 GENERAL USE STANDARDIZED PARTS BULK MATERIEL...BULK-1 BULK MATERIEL...BULK-1 BULK iii

7 TM P TABLE OF CONTENTS (Con t) Page Illus Fig SECTION III. SECTION IV. SPECIAL TOOLS (NOT APPLICABLE) CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX... I-1 PART NUMBER INDEX... I-10 FIGURE AND ITEM NUMBER INDEX... I-38 iv

8 TM P UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS SECTION I. INTRODUCTION 1. Scope. This RPSTL lists and authorizes spares and repair parts; special tools, special test, measurement, and diagnostic equipment (TMDE), and other special support equipment required for performance of Unit, Direct Support, and General Support Maintenance of the Forklift Truck It authorizes the requisitioning, issue, and disposition of spares, repair parts and special tools as indicated by the source, maintenance and recoverability (SMR) codes 2. General. In addition to Section I Introduction, this Repair Parts and Special Tools List Is divided into the following sections. a. Section II. Repair Parts List A list of spares and repair parts authorized by this RPSTL for use in the performance of maintenance The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in ascending alphanumeric sequence, with the parts in each group listed in ascending figure and Item number sequence Bulk materials are listed in item name sequence Repair kits are listed separately In their own functional group within Section II Repair parts for reparable special tools are also listed In the section Items listed are shown on the associated illustration(s)/figure(s). b. Section III. Special Tools List A list of special tools, special TMDE, and other special support equipment authorized by this RPSTL (as indicated by Basis of Issue (BOI) information in DESCRIPTION AND USABLE ON CODE column) for the performance of maintenance. c. Section IV. Cross-reference Indexes. A list, In National Item Identification Number (NIIN) sequence, of all National stock numbered items appearing in the listing, followed by a list In alphanumeric sequence of all part numbers appearing In the listings National stock numbers and part numbers are cross-referenced to each illustration/figure and item number appearance. The figure and item number index lists figure and Item numbers in alphanumeric sequence and crossreferences NSN, CAGE, and part numbers. 3. Explanation of Columns (Sections II and Ill). a. ITEM NO (Column (1)) Indicates the number used to identify items called out In the illustration b. SMR CODE (Column (2)). The Source, Maintenance, and Recoverability (SMR) code is a 5- position code containing supply/requisitioning information, maintenance category authorization criteria, and disposition instructions, as shown In the following breakout: 1st two positions 3d position Who can Install, replace, or use the item Source Code XXxxx How you get an item. Maintenance Code xxxxx Recoverability Code xxxxx 4th position Who can do complete repair* on the Item. Who determines disposition action on an unserviceable Item. 5th position *Complete Repair: Maintenance capacity, capability, and authority to perform all corrective maintenance tasks of the "Repair" function In a use/user environment In order to restore serviceability to a failed Item. (1) Source Code The source code tells you how to get an Item needed for maintenance, repair, or overhaul of an end item/equipment Explanations of source codes follows: 1

9 TM P Code Application/Explanation PA Stocked items, use the applicable NSN to PB request/requisition Items with these source PC** codes. They are authorized to the category PD indicated by the code entered In the 3d PE position of the SMR code PF ** Items coded PC are subject to PG deterioration. Items with these codes are not to be KD requested/requisitioned individually. They KF are part of a kit which is authorized to the maintenance category Indicated in the 3d position of the SMR code The complete kit must be requisitioned and applied. MO-(Made at UMI AVUM Level) MF-(Made at DS/ AVUM Level) MH-(Made at GS ML-(Made at Specialized Repair Activity (SRA)) MD-(Made at Depot) AO-(Assembled by UMI AVUM Level) AF-(Assembled by DS/AVIM Level) AH-(Assembled by GS Category) AL-(Assembled by SRA) AD-(Assembled by Depot) XA- XB- Items with these codes are not to be requested/requisitioned individually They must be made from bulk material which is identified by the part number in the DESCRIPTION AND USABLE ON CODE (UOC) column and listed In the Bulk Material group of the repair parts list in this RPSTL If the item is authorized to you by the 3d position code of the SMR code, but the source code indicates It is made at a higher level, order the item from the higher level of maintenance Items with these codes are not to be requested/requisitioned individually The parts that make up the assembled Item must be requisitioned or fabricated and assembled at the level of maintenance Indicated by the source code. If the 3d position code of the SMR code authorizes you to replace the item, but the source code Indicates the Item is assembled at a higher level, order the item from the higher level of maintenance Do not requisition an "XA"-coded Item Order its next higher assembly (Also refer to the NOTE following.) If an "XB" item is not available from salvage, order It using the CAGE and part number given. XC- XD- Installation drawing, diagram, Instruction sheet, field service drawing, that is identified by the manufacturer s part number. Item is not stocked Order an "XD"-coded item through normal supply channels using the CAGE and part number given, If no NSN is available. NOTE: Cannibalization or controlled exchange, when authorized, may be used as a source of supply for items with the above source codes, except for those source coded "XA" or those aircraft support items restricted by requirements of AR (2) Maintenance Code Maintenance codes tell you the level(s) of maintenance authorized to USE and REPAIR support items The maintenance codes are entered In the third and fourth positions of the SMR code as follows: (a) The maintenance code entered In the third position tells you the lowest maintenance level authorized to remove, replace, and use an Item The maintenance code entered In the third position will indicate authorization to one of the following levels of maintenance. Code Application/Explanation C - Crew or operator maintenance done within unit maintenance or aviation unit maintenance. O- Unit maintenance or aviation unit category can remove, replace, and use the Item F - Direct support or aviation intermediate level can remove, replace, and use the item. H - General support level can remove, replace, and use the Item. L - Specialized repair activity can remove, replace, and use the item. D - Depot level can remove, replace, and use the Item. (b) The maintenance code entered in the fourth position tells whether or not the Item is to be repaired and Identifies the lowest maintenance level with the capability to do complete repair (i.e, perform all authorized repair functions). (NOTE: Some limited repair may be done on the Item at a lower level of maintenance, If authorized by the Maintenance Allocation Chart (MAC) and SMR codes) This position will contain one of the following maintenance codes Code Application/Explanation O - F - Unit maintenance or aviation unit is the lowest level that can do complete repair of the Item. Direct support or aviation Intermediate is the lowest level than can do complete repair of the Item. 2

10 H - L - General support is the lowest level that can do complete repair of the item. Specialized repair activity is the lowest level that can do complete repair of the item D Depot is the lowest level that can do complete repair of the item. TM P the item by means of Its engineering drawings, specifications standards, and inspection requirements to Identify an item or range of Items. NOTE: When you use an NSN to requisition an Item, the Item you receive may have a different part number from the part ordered. Z - B - Nonreparable No repair is authorized. No repair is authorized (No parts or special tools are authorized for the maintenance of a "B"-coded item) However, the item may be reconditioned by adjusting, lubricating, etc, at the user level (3) Recoverability Code Recoverability codes are assigned to items to Indicate the disposition action on unserviceable Items The recoverability code is entered in the fifth position of the SMR code as follows: Code Application/Explanation Z - Nonreparable item. When unserviceable, condemn and dispose of the item at the level of maintenance shown In the 3d position of the SMR code. O - Reparable item. When uneconomically reparable, condemn and dispose of the item at unit maintenance or aviation unit level. F - Reparable item. When uneconomically reparable, condemn and dispose of the item at the direct support or aviation intermediate level. H - Reparable item. When uneconomically reparable, condemn and dispose of the item at the general support level D - Reparable item. When beyond lower level repair capability, return to depot. Condemnation and disposal of item not authorized below depot level. e. DESCRIPTION AND USABLE ON CODE (UOC) (Column (5)). This column includes the following information: (1) The Federal Item name and, when required, a minimum description to identify the item. Applicable. (2) Physical security classification Not (3) Items that are Included In kits and sets are listed below the name of the kit or set on Figure KIT (4) Spare/repair parts that make up an assembled Item are listed Immediately following the assembled Item line entry. (5) Part numbers for bulk materials are referenced in this column In the line item entry for the Item to be manufactured/fabricated. (6) When the item is not used with all serial numbers of the same model, the effective serial numbers are shown on the last line(s) of the description (before UOC). Not Applicable. (7) The usable on code, when applicable (see paragraph 5, Special Information). (8) In the Special Tools List section, the basis of issue (BOI) appears as the last line(s) In the entry for each special tool, special TMDE, and other special support equipment When density of equipments supported exceeds density spread indicated in the basis of Issue, the total authorization Is Increased proportionately. L - Reparable item Condemnation and disposal of Item not authorized below specialized repair activity (SRA). (9) The statement "END OF FIGURE" appears just below the last item description in Column 5 for a given figure In both Section II and Section III. A - Item requires special handling or condemnation procedures because of specific reasons (e g, precious metal content, high dollar value, critical material, or hazardous material). Refer to appropriate manuals/directives for specific instructions. c. CAGEC (Column (3)). The Commercial and Government Entity (CAGE) Code (C) is a 5-digit alphanumeric code which is used to identify the manufacturer, distributor, or Government agency, etc, that supplies the item. d. PART NUMBER (Column (4)). Indicates the primary number used by the manufacturer (individual, company, firm, corporation, or Government activity), which controls the design and characteristics of f. QTY (Column (6)). The QTY (quantity per figure column) Indicates the quantity of the item used in the breakout shown on the illustration/figure, which is prepared for a functional group, subfunctional group, or an assembly. A "V" appearing in this column In lieu of a quantity indicates that the quantity is vanable and the quantity may vary from application to application. 4. Explanation of Columns (Section IV). a. NATIONAL STOCK NUMBER (NSN) INDEX. (1) STOCK NUMBER column This column lists the NSN by National Item Identification Number (NIIN) 3

11 TM P sequence The NIIN consists of the last nine NSN digits of the NSN (i e, ) When NIIN using this column to locate an Item, ignore the first 4 digits of the NSN However, the complete NSN should be used when ordering Items by stock number. (2) FIG column. This column Iists the number of the figure where the item Is identified/located The figures are in numerical order In Section II and Section III. (3) ITEM column The Item number Identifies the Item associated with the figure Iisted In the adjacent FIG column This Item is also identified by the NSN listed on the same line. b. PARTNUMBER INDEX Part numbers in this index are listed by part number in ascending alphanumeric sequence (i e, vertical arrangement of letter and number combination which places the first letter or digit of each group in order A through Z, followed by the numbers 0 through 9 and each following letter or digit in like order). (1) CAGEC column The Commercial and Government Entity (CAGE) Code (C) is a 5digit alphanumeric code used to identify the manufacturer, distributor, or Government agency, etc, that supplies the item. (2) PART NUMBER column. Indicates the primary number used by the manufacturer (individual, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of Its engineering drawings, specifications standards, and inspection requirements to identify an item or range of Items. (3) STOCK NUMBER column This column lists the NSN for the associated part number and manufacturer identified in the PART NUMBER and CAGE columns to the left. (4) FIG column. This column lists the number of the figure where the item is Identified/located In Sections II and III. (5) ITEM column. The Item number is that number assigned to the Item as It appears In the figure referenced In the adjacent figure number column. c. FIGURE AND ITEM NUMBER INDEX. (1) FIG. column. This column lists the number of the figure where the Item is identified/located In Sections II and III. (2) ITEM column. The item number is that number assigned to the Item as It appears In the figure referenced In the adjacent figure number column. (3) STOCK NUMBER column This column lists the NSN for the Item. (4) CAGEC column The Commercial and Government Entity (CAGE) Code (C) is a 5-digit alphanumeric code used to identify the manufacturer, distributor, or Government agency, etc, that supplies the Item. (5) PART NUMBER column Indicates the primary number used by the manufacturer (individual, firm, corporation, or Government activity), which controls the design and characteristics of the Item by means of Its engineering drawings, specifications standards and inspection requirements to identify an Item or range of items. 5. Special Information. a. USABLE ON CODE. The usable on code appears in the lower left corner of the Description column heading Not Applicable. b. FABRICATION INSTRUCTIONS BulK materials required to manufacture Items are listed in the Bulk Material Functional Group of this RPSTL Part numbers for bulk materials are also referenced in the Description column of the line Item entry for the Item to be manufactured/fabricated Detailed fabrication instructions for Items source coded to be manufactured or fabricated are found in TM c. ASSEMBLY INSTRUCTIONS Detailed assembly instructions for Items source coded to be assembled from component spare/repair parts are found In TM or TM Items that make up the assembly are listed immediately following the assembly Item entry or reference Is made to an applicable figure. d. KITS Line item entries for repair parts kits appear In group 9401 In Section II. e. INDEX NUMBERS. Items which have the word BULK In the figure column will have an index number shown in the Item number column This Index number is a cross-reference between the National Stock Number/Part Number Index and the bulk material list In Section II. f. ASSOCIATED PUBLICATIONS. The publications listed below pertain to the Forklift Truck and Its components: Publication LO TM TM Short Title Forklift Truck, Army Model MHE-206 Forklift Truck, Army Model MHE-206 Forklift Truck, Army Model MHE-206 Change 1 4 *U.S. GOVERNMENT PRINTING OFFICE /

12 TM P 6. How to Locate Repair Parts. a. When National Stock Number or Part Number Is Not Known: (1) First. Using the table of contents, determine the assembly group or subassembly group to which the Item belongs This is necessary since figures are prepared for assembly groups and subassembly groups, and listings are divided into the same groups. (2) Second Find the figure covering the assembly group or subassembly group to which the item belongs. (3) Third Identify the item on the figure and use the Figure and Item Number Index to find the NSN. b. When National Stock Number or Part Number is Known: (1) First Using the National Stock Number or Part Number Index, find the pertinent National Stock Number or Part Number The NSN Index Is In National Item Identification Number (NIIN) sequence (see paragraph 4 a (1)) The part numbers In the Part Number Index are listed In ascending alphanumeric sequence (see paragraph 4 b) Both indexes cross-reference you to the illustration/figure and Item number of the Item you are looking for. (2) Second Turn to the figure and item number, verify that the item is the one you re looking for, then locate the item number In the repair parts list for the figure. 7. Abbreviations. For standard abbreviations see MIL-STD-12D, Military Standard Abbreviations for Use on Drawings, Specificatlons, Standards, and in Technical Documents. Abbreviations Explanation NIIN... National Item Identification Number (consists of the last 9 digits of the NSN) RPSTL... Repair Parts and Special Tools List 5

13 TM P TA FIGURE 1. ACCELERATOR CONTROLS.

14 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 03 FUEL SYSTEM GROUP 0312 ACCELERATOR, THROTTLE, OR CHOKE CONTROLS FIG. 1 ACCELERATOR CONTROLS 1 XBOZZ SHAFT, ACCELERATOR PAOZZ MS PIN,SPRING COUPLING TO ROD PAOZZ MS SETSCREW OUPLING ACCELERATOR 1 SHAFT TO SWITCH... 4 XBOZZ COUPLING ACCELERATOR SHAFT TO 1 SWITCH... 5 PAFZZ MS WASHER,LOCK ACCELERATOR SWITCH TO 3 CONSOLE... 6 PAFZZ MS SCREWICAP,HEXAGON ACCELERATOR 3 SWITCH TO CONSOLE... 7 XDOZZ LEO69FBMW SPRING,HELICAL,EXTE ACCELERATOR 1 RETURN... 8 XBOZZ ROD ACCELERATOR SHAFT TO PEDAL PAOZZ MS PIN,COTTER YOLE PIN TO ROD PAOZZ MS SCREW, MACHINE PILLOW BLOCK TO 2 CONSOLE PAOZZ MS WASHER,LOCK PILLOW BLOCK TO CONSOLE PAOZZ MS WASHER,FLAT PILLOW BLOCK TO CONSOLE XBOZZ PPB6 BLOCK,PILLOW ACCELERATOR SHAFT PAOZZ A PIN,STRAIGHT,HEADED ACCELERATOR 1 SHAFT TO ROD... END OF FIGURE 1-1

15 TM P FIGURE 2. ACCELERATOR SWITCH

16 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0312 ACCELERATOR, THROTTLE, OR CHOKE CONTROLS FIG. 2 ACCELERATOR SWITCH 1 XBFZZ IC3012BH733AEO1 SWITCH,ACCELERATOR CONSOLE PAFZZ P1 RESISTOR,VARIABLEtW XBFZZ A7157P1 BRACKET PAFZZ MS SCREW,MACHINE POTENTIOMETER... 1 BRACKET MOUNTING... 5 XBFZZ A4009P1 GEAR PINION PAFZZ MS SCREW,CAP,SOCKET PINION GEAR CLAMP XBFLZ A3197P3 CLAMP PINION GEAR PAFZZ MS WASHER,LOCK PINION GEAR CLAMP PAFZZ MS WASHER,FLAT POTENTIOMETER TO 1 BRACKET MOUNTING PAFZZ MS NUT,PLAIN,HEXAGON POTENTIOMETER 2 TO BRACKET MOUNTING 11 PAFZZ BOX CONNECTOR,ELECT PAFZZ PACKING,PREFORMED CONNECTOR XBFZZ B3008P1 COVER,CASE PAFZZ MS WASHER,LOCK COVER MOUNTING PAFZZ MS SCREW,MACHINE COVER MOUNTING PAFZZ LOCKNUT,ELECTRICAL PAFZZ MS21044N3 NUT,SELF-LOCKING SWITCH BRACKET 2 18 PAFZZ MS SCREW,MACHINE SWITCH BRACKET 2 MOUNTING PAFZZ MS KEY, WOODRUFF COLLAR TO SHAFT XBFZZ COLLAR,STOP XBFZZ N179P2105B6 SETSCREW COLLAR TO SHAFT PAFZZ MS SETSCREW STOP TO SHAFT XBFZZ A7156P1 HUB, GEAR XBFZZ A4008P2 GEAR,SECTOR XAFZZ C869P60 CAM,SWITCH ACTUATING PAFZZ MS WASHER,FLAT CAM TO SHAFT PAFZZ MS WASHER,LOCK CAM TO SHAFT XBFZZ N57P21010B6 SCREW,CAP,HEXAGON CAM TO SHAFT XAFZZ C869P500 CAM,SWITCH XBFZZ A6348P2 SCREW,MACHINE ADJUSTING XBFZZ A6348P1 SCREW,MACHINE ADJUSTING XBFZZ A5694P2 STOP,SHAFT ROTATION PAFZZ MS SCREW,MACHINE SWITCH MOUNTING PAFZZ MS WASHER,LOCK SWITCH MOUNTING XDFZZ P2 SHAFT,OPERATING XAFZZ A7159G3 CASE,ASSEMBLY XDFZZ A7159G3 BUSHING PFFZZ S800A-2 SWITCH?ELECTRICAL PAFZZ M SCREW,MACHINE SWITCH BRACKET 2 40 PAFZZ MS WASHER,LOCK SWITCH BRACKET... 2 MOUNTING 2-1

17 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 41 XBFZZ A5943P2 BRACKET SWITCH MOUNTING PAFZZ MS SCREW,MACHINE BRACKET MOUNTING PAFZZ MS WASHER1LOCK BRACKET MOUNTING XBFZZ A7162G1 BRACKET,MOUNTING PAFZZ MS SCREW,MACHINE TERMINAL STRIP 2 46 PAFZZ MS WASHER,LOCK TERMINAL STRIP TO 1 BRACKET PAFZZ MS SCREW, MACHINE TERMINAL STRIP 2 BRACKET MOUNTING XBFZZ A5258P1 BRACKET,TERMINAL STRIP MOUNTING XDFZZ A8468P2 STRIP, TERMINAL PAFZZ MS SCREW,MACHINE TERMINAL STRIP... 4 END OF FIGURE 2-2

18 TM P TA FIGURE 3. SILICON CONTROL RECTIFIER

19 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 06 ELECTRICAL SYSTEM GROUP 0607 INSTRUMENT OR ENGINE CONTROL PANEL FIG. 3 SILICON CONTROL RECTIFIER 1 XDFZZ C4483F273X670G4 CONTROL RECTIFIER PFFZZ A1247P6 SPACER CARD PUL OSCILLATOR-MIXER 2 TO PLUG MOUNTING... 3 PAFZZ MS WASHER,FLAT OSCILLATOR-MIXER PLUG 2 4 PAFZZ MS WASHER,LOCK OSCILLATOR-MIXER PLUG 2 5 XBFZZ N57P9018B6 SCREW, SPECIAL OSCILLATOR-MIXER 2 PLUG MOUNTING... 6 XBFZZ A846BP4 BOARD, TERMINAL XDFZZ A7105P2 LOCK CONTROL RECTIFIER PAFZZ MS WASHER, FLAT LOCK MOUNTING PAFZZ MS WASHER,LOCK LOCK MOUNTING PAFZZ MS SCREW,MACHINE LOCK MOUNTING PAFZZ MS WASHER,LOCK TERMINAL BOARD 4 12 PAFZZ MS SCREW,MACHINE TERMINAL BOARD 4 13 XBFZZ A7950 BRACKET TERMINAL BOARD MOUNTING PAFZZ A5981P10 SEMICONDUCTOR PAFZZ MS NUT,PLAIN,HEXAGON RECTIFIER 1 TERMINAL PAFZZ MS WASHER,LOCK RECTIFIER TERMINAL PAFZZ M WASHER,FLAT RECTIFIER TERMINAL PAFZZ MS SCREW,MACHINE RECTIFIER TERMINAL PAFZZ A5986G2 SEMICONDUCTOR CHOKE PAFZZ MS SCREW,MACHINE SEMICONDUCTOR 2 DEVICE MOUNTING PAFZZ MS WASHER, LOCK SEMICONDUCTOR DEVICE 2 22 PAFZZ MS WASHER,FLAT SEMICONDUCTOR DEVICE 2 23 XDFZZ A7547P1 INSULATION CAPACITOR TO BASE 1 24 XBFZZ N57P16074B6 SCREW, SPECIAL CAPACITOR MOUNTING PAFZZ JHP NUT,PLAIN,HEXAGON CAPACITOR 2 M OUNTING PAFZZ MS WASHER,LOCK CAPACITOR MOUNTING XDFZZ AS137P1 BRACKET CAPACITOR PAFZZ A7130P1 CAPACITOR,FIXED PAFZZ MS SCREW,MACHINE FUSEHOLDER BRACKET 2 30 PAFZZ MS WASHER,LOCK FUSEHOLDER BRACKET 2 31 XBFZZ A4760P6 BRACKET FUSEHOLDER MOUNTING

20 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 32 XDFZZ A392P16 FUSE,ELECTRICAL RECTIFIER XBFZZ A389P1 FUSEHOLDER XBFZZ R80 HARNESS,WIRE CONTROL RECTIFIER XDFZZ C4484A170 ISOLATOR CIRCUIT XBFZZ N57P16064B6 SCREW,SPECIAL PAFZZ MS WASHER,LOCK TRANSFORMER MOUNTING PAFZZ MS WASHER,FLAT TRANSFORMER MOUNTING PAFZZ A7104G1 PROTECTOR,THERMAL PAFZZ A5981P15 SEMICONDUCTOR DEVIC PAFZZ A5981P1 SEMICONDUCTOR PAFZZ MS WASHER,LOCK CONNECTION PAFZZ MS WASHER,FLAT CONNECTION XOFZZ A7105P1 LOCK CONTROL RECTIFIER PAFZZ MS SCREW,MACHINE CONTROL RECTIFIER 3 LOCK PAFZZ MS WASHER,LOCK CONTROL RECTIFIER LOCK PAFZZ MS WASHER,FLAT CONTROL RECTIFIER LOCK PAFZZ G1 TRANSFORMER PAFZZ MS WASHER,LOCK CONNECTION TO 4 TRANSFORMER PAFZZ MS WASHER,FLAT CONNECTION TO 4 TRANSFORMER XBFZZ A5963G4 BASE ASSEMBLY PAFZZ A5981P13 CONTROL RECTIFIER PFFZZ MS NUT,PLAIN,HEXAGON RESISTOR STRIP 1 54 PAFZZ MS WASHER,LOCK RESISTOR,STRIP 2 55 PAFZZ MS WASHER,FLAT RESISTOR,STRIP 1 56 XBFZZ N26P21008B6 SCREW,SPECIAL RESISTOR STRIP 2 57 XDFZZ A7582P1 RESISTOR,STRIP PAFZZ S11-3 WASHER,FLAT RESISTOR STRIP 1 59 PAFZZ MS WASHER,LOCK OSCILLATOR-MIXER 2 60 PAFZZ MS SCREW,MACHINE OSCILLATOR-MIXER 2 61 PAFZZ MS SCREW,CAP,HEXAGON H CONTROL 3 RECTIFIER MOUNTING PAFZZ MS WASHER,FLAT CONTROL RECTIFIER PAFZZ AN WASHER,LOCK CONTROL RECTIFIER 3 64 PAFZZ MS NUT,PLAIN,HEXAGON CONTROL 3 RECTIFIER MOUNTING... END OF FIGURE 3-2

21 TM P TA FIGURE 4. FORWARD-REVERSE CONTACTOR

22 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0607 INSTRUMENT OR ENGINE CONTROL PANEL FIG. 4 FORWARD-REVERSE CONTACTOR 1 PAFZZ SCREW, ASSEMBLED WAS FORWARD AND 3 REVERSE CONTACTOR MOUNTING 2 PAFZZ MS WASHER,LOCK FORWARD AND REVERSE 3 CONTACTOR MOUNTING 3 XDFZZ C2800M124A412X5 RELAY,ELECTROMAGNET FORWARD AND... 1 REVERSE... 4 PFFZZ A9807P1 SHIM SUPPORT TO BASE MOUNTING PFFZZ B5712P1 SUPPORT STATIONARY CONTACT TIP 2 MOUNTING 6 PFFZZ B5712P4 SUPPORT MOVABLE CONTACT TIP 2 7 PFFZZ A5789G1 CONTACT (PART OF KIT,FSN ) PAFZZ M C NUT,SELF-LOCKING CONTACT TIP TO 8 PLATE MOUNTING PAFZZ MS WASHER,LOCK CONTACT TIP TO PLATE 8 10 XDFZZ P8 STRIP,CONNECTION STATIONARY 1 CONTACT SUPPORT PAFZZ MS WASHER,FLAT BRACKET TO SUPPORT 2 MOUNTING PAFZZ MS WASHER,LOCK BRACKET AND SUPPORT 4 13 XDFZZ N26P21010B6 SCREW,MACHINE BRACKET AND SUPPORT 4 MOUNTING XDFZZ N26P23008B6 SCREW,MACHINE CONTACT SUPPORT 2 STRIP MOUNTING PAFZZ MS WASHER,LOCK CONTACT SUPPORT STRIP 2 16 PAFZZ MS WASHER,FLAT CONTACT SUPPORT STRIP 1 17 XBFZZ P1 BRACKET STATIONARY CONTACT TIP... 1 MOUNTING XBFZZ A9808 SUPPORT STATIONARY CONTACT TIP 1 19 XDFZZ MDJ1... SPRING,HELICAL, COMP RETAINING PIN PAFZZ A7306 WASHER,RECESSED RETAINING PIN PAFZZ MS RING,RETAINING PIN TO MOVABLE 2 CONTACT TIP XDFZZ A9938P1 PIN,RETAINING COMPRESSION SPRING PAFZZ MS SCREW,MACHINE PLATE TO SUPPORT 2 24 PAFZZ MS WASHER,LOCK PLATE TO SUPPORT 2 25 PAFZZ MS BOLT,MACHINE CONNECTION PAFZZ M5S WASHER,LOCK CONNECTION XBFZZ SPACER CONNECTION SCREW

23 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 28 PAFZZ MS SCREW,CAP,HEXAGON H SHUNT TO 2 MOVABLE SUPPORT PAFZZ MS WASHER,LOCK TERMINAL AND SHUNT 2 MOUNTING PFFZZ P4 SUPPORT, ARMATURE XOFZZ A7816P1 SUPPORT SWITCH MOUNTING PAFZZ MS SCREW,MACHINE SWITCH AND ARMATURE 4 SUPPORT MOUNTING PAFZZ MS WASHER,LOCK SWITCH AND ARMATURE 4 SUPPORT MOUNTING PAFZZ MS WASHER, FLAT SWITCH AND ARMATURE 4 SUPPORT MOUNTING PAOZZ A4259P3 SWITCH,SENSITIVE (PART OF KIT,FSN ) PFFZZ G1 LEAD (PART OF KIT,FSN ) PART OF KIT P/N 1C2800M124A412X PAFZZ MS SCREW,MACHINE SWITCH TO SUPPORT 4 38 PAFZZ MS WASHER,LOCK SWITCH TO SUPPORT 4 39 PAFZZ MS SCREW,MACHINE GUIDE TO FULCRUM 4 40 PAOZZ MS WASHER,LOCK GUIDE TO FULCRUM 4 41 XDFZZ LHTE040 NUT,SELF-LOCKING,HE CONTACTOR 2 ADJUSTING SCREW XDFZZ A7822P2 SCREW COMPRESSION SPRING PFFZZ SPRING (PART OF KIT,FSN ) PAFZZ A7306 WASHER,RECESSED RETAINING PIN AND 4 ADJUSTING SCREW PAFZZ MS WASHER,LOCK TERMINAL MOUNTING XDFZZ N26P23008B6 SCREW,MACHINE TERMINAL MOUNTING PAFZZ MS WASHER,FLAT TERMINAL AND SHUNT 2 48 PAFZZ AN WASHER,LOCK TERMINAL AND SHUNT 2 49 XDFZZ N26P21010B6 SCREW,MACHINE TERMINAL AND SHUNT 2 50 XBFZZ TERMINAL XDFZZ A5968P1 CLIP,TERMINAL XBFZZ B5713G2 ARMATURE XDFZZ G1 FRAME,MAGNET W/CORE XDFZZ A552P2 FULCRUM ADJUSTING SCREW XDFZZ P3 WASHER,SPRING OPERATING COIL 2 56 PAFZZ D10154G32A COIL,ELECTRICAL XDFZZ A7814P1 GUIDE,ARMATURE XBFZZ P3 PLATE STATIONARY CONTACT TIP PAFZZ MS WASHER,LOCK OPERATING COIL 4 CONNECTION

24 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 60 PAFZZ MS SCREW,MACHINE OPERATING COIL 4 CONNECTIION PAFZZ MS RING,RETAINING OPERATING COIL PAFZZ MS WASHER,FLAT STATIONARY CONTACT 4 SUPPORT TO BASE MOUNTING PAFZZ MS WA SHER,LOCK STATIONARY CONTACT 4 SUPPORT TO BASE MOUNTING PAFZZ MS SCREW,MACHINE STATIONARY CONTACT 4 SUPPORT TO BASE MOUNTING XBFZZ B316P1 INSULATION CONTACTOR ASSEMBLY TO 1 PANEL MOUNTING XBFZZ B5713G2 SHIM ARMATURE MOUNTING PAFZZ MS SCREW,MACHINE MAGNET FRAME TO 4 BASE MOUNTING XBFZZ B5795P2 BASE... 1 END OF FIGURE 4-3

25 TM P FIGURE 5. LINE AND PUMP CONTACTORS.

26 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0607 INSTRUMENT OR ENGINE CONTROL PANEL FIG. 5 LINE AND PUMP CONTACTORS 1 PAFZZ MS SCREW,CAP,HEXAGON CONTACTOR 60 2 PAFZZ MS WASHER,LOCK CONTACTOR MOUNTING PAFZZ MS WASHER1FLAT CONTACTOR MOUNTING PFFZZ C2800M120A414 RELAY,ELECTROMAGNET LINE CONTACTOR 1 ASSEMBLY... 4 XDFZZ C2800M120A412 RELAY,ELECTROMAGNET PUMP CONTACTOR 1 ASSEMBLY... 5 PFFZZ A9807P1 SHIM SUPPORT TO BASE MOUNTING PAFZZ MS SCREW,MACHINE STATIONARY SUPPORT 4 TO BASE MOUNTING... 7 PAFZZ MS WASHER,LOCK STATIONARY SUPPORT TO 4 BASE MOUNTING PAFZZ MS WASHER,FLAT STATIONARY SUPPORT TO 4 BASE MOUNTING XDFZZ N26P23008B6 SCREW,MACHINE CABLE CONNECTION PAFZZ MS WASHER,LOCK CABLE CONNECTION PFFZZ P1 SUPPORT STATIONARY CONTACT TIP 2 12 PAFZZ B316P2 INSULATOR,PLATE CONTACTOR TO PANEL PFFZZ A5789G1 CONTACT (PART OF KIT,FSN ) PAFZZ M C NUT,SELF-LOCKING CONTACT TIP TO 2 SUPPORT MOUNTING PAFZZ MS WASHER,LOCK CONTACT TIP TO 2 SUPPORT MOUNTING PFFZZ P4 SUPPORT MOVABLE CONTACT TIP 17 XDFZZ MDJ1 SPRING,HELICAL,COMP MOVABLE 2 CONTACT TIP PAFZZ MS RING,RETAINING PIN TO MOVABLE 2 CONTACT TIP PAFZZ A7306 WASHER,RECESSED COMPRESSION XDFZZ A9938P1 PIN,RETAINING COMPRESSION SPRING XDFZZ A7814P1 GUIDE,ARMATURE PAFZZ MS RING,RETAINING OPERATING COIL XDFZZ P3 WASHER,SPRING OPERATING COIL 2 24 PFFZZ B5713G1 ARMATURE,RELAY PFFZZ B5713G4 ARMATURE,RELAY ARMATURE TO MAGNET 2 FRAME MOUNTING PAFZZ MS SCREW,CAPVHEXAGON SHUNT TO 2 MOVABLE SUPPORT MOUNTING PAFZZ MS WASHER,LOCK SHUNT TO MOVABLE 2 SUPPORT MOUNTING PAFZZ MS SCREW,MACHINE GUIDE TO FULCRUM 4 5-1

27 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 29 PAFZZ MS WASHER,LOCK GUIDE TO FULCRUM 4 30 XBFZZ MS SUPPORT,ARMATURE PAFZZ MS SCREW,MACHINE SWITCH AND ARMATURE 4 SUPPORT MOUNTING PAFZZ MS WASHER,LOCK SWITCH AND ARMATURE 4 SUPPORT MOUNTNNG PAFZZ MS WASHER,FLAT SWITCH AND ARMATURE 4 SUPPORT MOUNTING XDFZZ LHTE040 NUT,SELF-LOCKING,HE CONTACTOR 2 ADJUSTING SCREW XDFZZ A7822P2 SCREW COMPRESSION SPRING PFFZZ SPRING (PART OF KIT,FSN ) PAFZZ A7306 WASHER,RECESSED COMPRESSION XDFZZ BA552PZ FULCRUM ADJUSTING SCREW PFFZZ G1 LEAD (PART OF KIT,FSN ) PART OF KIT P/N IC2800M120A XDFZZ N26P21010B6 SCREW,MACHINE TERMINAL AND SHUNT 2 41 PAFZZ M WASHER,LOCK TERMINAL AND SHUNT 2 42 PAFZZ MS WASHER,FLAT TERMINAL AND SHUNT 2 43 PAFZZ MS WASHER,LOCK TERMINAL MOUNTING XOFZZ N26P23008B6 SCREW, MACHINE TERMINAL MOUNTING XDFZZ A5968Pl CLIP1 TERMINAL XDFZZ P1 TERMINAL PAFZZ D154G33A COIL,ELECTRICAL (USED WITH RELAY 1 FSN ,ONLY) PAFZZ D154G32A COILTELECTRICAL (USED WITH RELAY, 1 FSN ,ONLY) PAFZZ MS WASHER,LOCK STOP TO POST MOUNTING PAFZZ MS SCREW,MACHINE STOP TO POST PAFZZ MS WASHER,LOCK COIL CONNECTIONS PAFZZ MS SCREW,MACHINE OPERATING COIL 4 CONNECTION XBFZZ N401P69 WASHER ARMATURE STOP XDFZZ G1 FRAME,MAGNET W/CORE PFFZZ A8482P3 SPACER SUPPORTING POST TO MAGNET 12 FRAME PAFZZ MS WASHER,LOCK ARMATURE STOP POST XDFZZ A9807P2 POST ARMATURE STOP PFFLZ A8326G1 RELAY,BASE PAFZZ MS WASHER,LOCK BASE TO MAGNET CORE 4 59 PAFZZ MS SCREW,MACHINE BASE TO MAGNET CORE 4 END OF FIGURE 5-2

28 TM P FIGURE 6. SHORTING CONTACTOR

29 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0607 INSTRUMENT OR ENGINE CONTROL PANEL FIG. 6 SHORTING CONTACTOR 1 PAFZZ MS SCREW,CAP,HEXAGON H CONTACTOR TO 2 PANEL MOUNTING... 2 PAFZZ MS WASHER,LOCK CONTACTOR TO PANEL 2 3 PAFZZ MS WASHER,FLAT CONTACTOR TO PANEL 2 4 XDFZZ C2800M120K412X5 CONTACTOR ASSEMBLY 1A PFFZZ P1 SUPPORT STATIONARY CONTACT TIP 1 6 PFFZZ A9807P1 SHIM SUPPORT TO BASE MOUNTING PAFZZ MS SCREW,MACHINE STATIONARY SUPPORT 2 TO BASE MOUNTING... 8 PAFZZ MS WASHER,LOCK STATIONARY SUPPORT TO 2 BASE MOUNTING... 9 PAFZZ M5S WASHER,FLAT STATIONARY SUPPORT TO 2 BASE MOUNTING PAFZZ MS WASHER,LOCK CABLE CONNECTION XDFZZ N26P23008B6 SCREW,MACHINE CABLE CONNECTION PFFZZ A5789G1 CONTACT (PART OF KIT,FSN ) PAFZZ M C NUT,SELF-LOCKING CONTACT TIP TO 2 SUPPORT PAFZZ MS WASHER,LOCK CONTACT TIP TO 2 SUPPORT MOUNTING PFFZZ B5712P4 SUPPORT MOVABLE CONTACT TIP 1 16 PAFZZ ld154g32a COIL,ELECTRICAL XDFZZ P3 WASHER,SPRING OPERATING COIL 1 18 KFFZZ A746 SPRING (PART OF KIT,FSN ) PAFZZ MS RING,RETAINING PIN TO MOVABLE 1 CONTACT TIP PAFZZ A7306 WASHER,RECESSED COMPRESSION XDFZZ A9938P1 PIN,RETAINING COMPRESSION SPRING XBFZZ N401P69 WASHER STOP FOR ARMATURE PAFZZ MS SCREW,MACHINE STOP TO POST 2 24 PAFZZ MS WASHER,LOCK STOP TO POST MOUNTING PAFZZ MS RING,RETAINING OPERATING COIL XDFZZ A552P2 FULCRUM ADJUSTING SCREW PAFZZ MS SCREW,MACHINE GUIDE TO ARMATURE 2 28 PAFZZ M5S WASHER,LOCK GUIDE TO ARMATURE 2 29 PAFZZ MS SCREW,CAP,HEXAGON SHUNT TO

30 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY MOVABLE SUPPORT MOUNTING PAFZZ MS WASHER,LOCK SHUNT TO MOVABLE 1 SUPPORT MOUNTING XDFZZ A7816P1 SUPPORT SWITCH MOUNTING PAFZZ MS SCREW,MACHINE SWITCH AND ARMATURE 2 SUPPORT MOUNTING PAFZZ MS WASHER,LOCK SWITCH AND AMATURE 2 SUPPORT MOUNTING PAFZZ MS WASHER,FLAT SWITCH AND AMATURE 2 SUPPORT MOUNTING XDFZZ LHTE040 NUT,SELF-LOCKING,HE CONTACTOR 2 ADJUSTING SCREW PAFZZ A7306 WASHER, RECESSED COPMRESSION PFFZZ SPRING XDFZZ A7822P2 SCREW COMPRESSION SPRING PAOZZ A4259P3 SWITCH, SENSITIVE PFFZZ G1 LEAD (PART OF KIT,FSN ) PAFZZ MS SCREW,MACHINE SWITCH TO SUPPORT 2 42 PAFZZ MS WASHER,LOCK SWITCH TO SUPPORT 2 43 PAFZZ MS WASHER,LOCK TERMINAL ZDFZZ N26P SCREW,MACHINE TERMINAL MOUNTING XDFZZ P1 TERMINAL PAFZZ MS WASHER,FLAT PAFZZ MS WASHER,LOCK TERMINAL AND SHUNT 1 48 XDFZZ N26P21010B6 SCREW,MACHINE TERMINAL AND SHUNT 1 49 XDFZZ A5968P1 CLIP,TERMINAL PFFZZ P4 SUPPORT ARMATURE MOUNTING PFFZZ G4 ARMATURE,RELAY ARMATURE TO MAGNET 1 FRAME MOUNTING PFFZZ G4 ARMATURE,RELAY XDFZZ A7815P1 GUIDE,ARMATURE XDFZZ G1 FRAME,MAGNET W/CORE XDFZZ A9807P2 POST ARMATURE STOP PAFZZ MS WASHER,LOCK STOP FOR ARMATURE XDFZZ A8482P3 SPACER SUPPORT POST TO MAGNET 6 FRAME PAFZZ MS SCREW,MACHINE OPERATING COIL 2 CONNECTIONS PFFZZ A8326G1 RELAY,BASE PAFZZ MS WASHER,LOCK BASE TO MAGNET CORE PAFZZ MS SCREW,MACHINE BASE TO MAGNET CORE 62 PAFZZ B8316P2 INSULATOR,PLATE... 1 END OF FIGURE 6-2

31 TM P TA FIGURE 7. FUSE BLOCKS.

32 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0608 MISCELLANEOUS ITEMS FIG. 7 FUSE BLOCKS 1 XBOZZ BAR, BUS FUSE TO FUSE XBFZZ BASE XBFZZ INSULATOR BASE TO PANEL XBFZZ FUSE BLOCK ASSEMBLY DRIVE MOTOR PAFZZ MS SCREW, MACHINE BASE TO PANEL PAOZZ ACK250 FUSE, CARTRIDGE DRIVE MOTOR PAOZZ MS NUT, HEXAGON PAFZZ MS WASHER, LOCK DRIVER MOTOR FUSE XDFZZ MS BOLT, MACHINE CONNECTING POST PAOZZ MS WASHERVFLAT DRIVE MOTOR FUSE POST XBFZZ FUSE BLOCK ASSEMBLY PUMP MOTOR PAOZZ MS WASHER, LOCK PUMP MOTOR FUSE PAOZZ MS NUT, PLAIN1HEXAGON PUMP MOTOR FUSE PAFZZ TBD WASHER, FLAT PUMP MOTOR FUSE POST XBFZZ BASE XBFZZ INSULATOR BASE TO PANEL PAOZZ ACK175 FUSE, CARTRIDGE PUMP MOTOR PAFZZ M5S SCREW, MACHINE BASE TO PANEL PAFZZ FFB575 BOLT, MACHINE CONNECTING POST... 2 END OF FIGURE 7-1

33 TM P TA FIGURE 8. CONTROL BOX ASSEMBLY.

34 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0608 MISCELLANEOUS ITEMS FIG. 8 CONTROL BOX ASSEMBLY 1 XBFZZ COMPONENTS ASSEMBLY XBFZZ SUPPORT, CONTROL BOX PAFZZ MS WASHER, LOCK BOX TO SUPPORT PAFZZ MS NUT, PLAIN, HEXAGON BOX TO SUPPORT XBFZZ BOX, CONTROL PAFZZ MS SCREW, CAP, HEXAGON H BOX TO SUPPORT PAFZZ MS NUT, PLAIN, HEXAGON BOX TO SUPPORT PAOZZ M5S WASHER, LOCK COVER MOUNTING PAOZZ MS SCREW, MACHINE COVER MOUNTING XBOZZ COVER PAFZZ MS NUTTPLAIN, HEXAGON PANEL MOUNTING PAFZZ MS WASHER, LOCK PANEL MOUNTING PAOZZ SWITCH, PUSH-PULL LIGHT PAFZZ PACKING, PREFORMED CONNECTOR PAFZZ BOX CONNECTOR, ELECT PAFZZ BOX CONNECTOR, ELECT CONTROL BOX PAFZZ LOCKNUT, ELECTRICAL ELECTRICAL OUTLETS PAFZZ MS SCREW, CAP, HEXAGON H BOX TO SUPPORT PAFZZ MS SCREW, CAP, HEXAGON H PANEL MOUNTING PAFZZ MS NUT, PLAIN, HEXAGON ELECTRICAL... 6 COMPONENTS BOX MOUNTING PAFZZ AN WASHER, LOCK ELECTRICAL COMPONENTS... 6 BOX MOUNTING PAFZZ MS SCREW, CAP, HEXAGON H ELECTRICAL... 6 COMPONENTS BOX MOUNTING PAFZZ MS NUT, PLAIN, HEXAGON BOX TO SUPPORT PAFZZ AN WASHER, LOCK BOX TO SUPPORT... 2 END OF FIGURE 8-1

35 TM P *Part of Item 1 **Part of Item 7 TA FIGURE 9. TERMINAL BOARDS, FUSES, RELAY, AND ATTACHING HARDWARE.

36 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0608 MISCELLANEOUS ITEMS FIG. 9 TERMINAL BOARDS, FUSES, RELAY, AND ATTACHING HARDWARE 1 XBFZZ PANEL, COMPONENTS XDFZZ VN. RELAY, TIME DELAY PAFZZ MS WASHER, LOCK RELAY MOUNTING PAFZZ MS SCREW, MACHINE RELAY MOUNTING PAFZZ MS WASHER, LOCK TERMINAL BOARD PAFZZ MS SCREW, MACHINE TERMINAL BOARD PAFZZ TB12. TERMINAL BOARD PAFZZ MS SCREW, MACHINE TERMINAL BOARD CONNECTORS... 9 PAFZZ MS WASHER, LOCK TERMINAL BOARD CONNECTORS PAFZZ M5S SCREW, MACHINE FILTER MOUNTING PAFZZ MS WASHER, FLAT FILTER MOUNTING PAFZZ B6203G22. FILTER, ELECTRICAL HOURMETER AND 1 HORN PAFZZ MS SCREW, MACHINE FUSEHOLDER MOUNTING PAFZZ M WASHER, LOCK FUSEHOLDER MOUNTING PAFZZ F02A125VlOAS. FUSE, CARTRIDGE XBFZZ FUSEHOLDER XBFZZ SPACER FUSEHOLDER TO PANEL XDFZZ B6203G14. RESISTOR, FIXED, WIRE TIME DELAY... 1 RELAY... END OF FIGURE 9-1

37 TM P FIGURE 10. VEHICLE LIGHTS.

38 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0609 LIGHTS FIG. 10 VEHICLE LIGHTS 1 XBOZZ CLAMP, CABLE HEADLIGHT PAOZZ NUT, PLAIN, HEXAGON CABLE CLAMP PAOZZ KG V HEADLIGHT 36V PAOZZ LAMP, SEALED UNIT HEADLIGHT PAOZZ TAILLIGHT VEHICULAR PFOZZ LENSILIGHT PAOZZ LAMP, INCANDESCENT TAILLIGHT PAOZZ LAMP, INCANDESCENT STOPLIGHT PAOZZ MS WASHER, LOCK TAILLIGHT BRACKET TO... 4 FRAME PAOZZ MS SCREW, CAP, HEXAGON TAILLIGHT... 4 BRACKET TO FRAME PAOZZ MS NUT, PLAIN, HEXAGON CABLE CLAMP XBOZZ CLAMP, CABLETAILLIGHT CABLE PAOZZ MS WASHER, LOCKCABLE CLAMP MOUNTING PAOZZ MS SCREW, MACHINE CABLE CLAMP MOUNTING PAOZZ A12113 GROMMET, NONMETALLIC TAILLIGHT LEAD XBOZZ BRACKET, TAILLIGHT PAOZZ MS NUT, PLAIN, HEXAGON TAILLIGHT TO... 2 BRACKET PAOZZ M WASHER, LOCK TAILLIGHT TO BRACKET PAOZZ MS SCREWIMACHINE CABLE CLAMP MOUNTING PAOZZ MS WASHER, LOCK CABLE CLAMP MOUNTING... 6 END OF FIGURE 10-1

39 TM P TA FIGURE 11. HORN, SWITCHES, AND ATTACHING HARDWARE.

40 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0611 HORN, SIREN FIG. 11 HORN, SWITCHES, AND ATTACHING HARDWARE 1 PAOZZ AN SCREW, MACHINE EMERGENCY MICROSWITCH. 2 2 PAOZZ MS WASHER, LOCK EMERGENCY MICROSWITCH XBOZZ BRACKET, SWITCH PAOZZ CR2940UM200AC SWITCH, PUSH-BUTTON EMERGENCY STOP PAOZZ MS WASHER, LOCK EMERGENCY SWITCH... 2 BRACKET MOUNTING... 6 PAOZZ MS SCREW, MACHINE EMERGENCY SWITCH... 2 BRACKER... 7 XDFZZ SWITCH, SENSITIVE EMERGENCY SWITCH PAOZZ MS NUT, PLAIN, HEXAGON EMERGENCY... 2 MICROSWITCH MOUNTING... 9 PAFZZ MS GROMMET, NONMETALLIC DIRECTIONAL... 1 CONTROL CABLE PAOZZ MS SCREW, MACHINE HORN FILTER MOUNTING PAOZZ MS SCREW, MACHINE HORN MOUNTING PAFZZ MS WASHER1FLAT U-BOLT, STEERING GEAR PAFZZ MS NUTIPLAIN, HEXAGON U-BOLT STEERING... 2 GEAR XDFZZ BOLT, U STEERING GEAR TO CONSOLE PAOZZ MS WASHER, LOCK HORN MOUNTING PAOZZ S50A HORN, ELECTRICAL PAOZZ JHP NUT, PLAIN, HEXAGON HORN MOUNTING XDOZZ TBD LEAD ELECTRICAL HORN TO RELAY PAOZZ MS NUT, PLAIN, HEXAGON HORN FILTER PAOZZ MS WASHER, FLAT HORN FILTER MOUNTING PAOZZ G22 FILTER, HORN... 1 END OF FIGURE 11-1

41 TM P TA FIGURE 12. BATTERY FRAME AND COMAPARTMENT.

42 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0612 BATTERIES, STORAGE FIG. 12 BATTERY FRAME AND COMPARTMENT 1 XBOZZ ANGLE, RETAINING BATTERY, LH XBOZZ COVER, BATTERY LEFT SIDE PAFZZ BZE6-2RQ8 SWITCH, SENSITIVE CONNECTOR LATCH XDFZZ B2-2R0784 SWITCH, SENSITIVE BATTERY... 1 CONNECTOR, REPLACEMENT PART... 5 PAFZZ PACKING, PREFORMED CONNECTOR MOOZZ TYPESJO-16-4 CABLE, PORTABLE CONNECTOR TO... 2 BATTERY MAKE FROM CABLE P/N PAFZZ MS NUT, PLAIN, HEXAGON MICROSWITCH TO... 2 LATCH... 8 XBFZZ LATCH, ASSEMBLY BATTERY CONNECTOR PAOZZ B CONNECTOR, BATTERY PAOZZ MS WASHER, LOCK BATTERY CONNECTOR AND... 4 LATCH MOUNTING PAOZZ MS SCREW, CAP, HEXAGON H BATTERY... 4 CONNECTOR AND LATCH MOUNTING PFOZZ MS STRAP, RETAINING PAFZZ BOX CONNECTOR, ELECT MICROSWITCH... 1 LEAD PAFZZ MS SCREW, MACHINE MICROSWITCH TO LATCH XBFZZ DD10002 WASHER, LOCK...MICROSWITCH TO LATCH 2 16 PAOZZ MS WASHER, LOCK...CABLE CLIP MOUNTING 1 17 PAOZZ MS SCREW, CAP, HEXAGON CABLE CLIP MOOZZ CABLE ASSEMBLY BATTERY CONNECTOR... 2 TO CONTROL PANEL MAKE FROM P/N PAOZZ MS FITTING, LUBRICATION, XBHZZ FRAMEMMAIN XBFZZ TBD GUARD PLATE PUMP MOTOR PAOZZ DISCHARGER, ELECTROS STATIC... 2 DISCHARGE PAOZZ MS WASHER, FLAT STATIC DISCHARGE PAOZZ MS SCREW, CAP, HEXAGON H STATIC... 2 DISCHARGE STRAP TO FRAME PAFZZ BUSHING, SLEEVE MAST PIVOT PAOZZ M SCREW, CAP, HEXAGON H COVER PLATE... 4 MOUNTING., XBOZZ PLATE, COVER PFOZZ MS NUT, PLAIN, HEXAGON COVER PLATE PAOZZ MS WASHER1LOCK COVER PLATE MOUNTING PAFZZ MS NUT, PLAIN, HEXAGON PUMP MOTOR GUARD PAFZZ MS WASHER, LOCK PUMP MOTOR GUARD

43 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 31 PAFZZ MS SCREW, CAP, HEXAGON H PUMP MOTOR... 3 GUARD XBOZZ AN WASHER, LOCK BOTTOM COVER TO FRAME PAOZZ MS SCREW, CAP, HEXAGON H BOTTOM COVER... 4 TO FRAME XBOZZ COVER BOTTOM OF FRAME XBOZZ ANGLE, RETAINING BATTERY, RH XBFZZ ROLLER ASSEMBLY PAFZZ MS PIN, COTTER BATTERY ROLLER ASSEMBLY XBFZZ PIN BATTERY ROLLER ASSEMBL Y XBOZZ COVER, BATTERY RIGHT SIDE XBOZZ PINTOWING PAOFA TSC21 BATTERY, STORAGE PAOZZ TERMINAL, LUG XDOZZ SP TERMINAL, LUG XBFZZ COVER, BATTERY XBFZZ PLYWOODO XBFZZ BURR PAFZZ MS20426A3-8. RIVETISOLID XBFZZ PLATE, COVER XBFZZ PULLIDOOR PAFZZ MS20426A8-8. RIVET, SOLID DOOR PULL TO COVER XBFZZ HINGE... 1 END OF FIGURE 12-2

44 TM P TA FIGURE 13. DIRECTIONAL SWITCH CONTROL CABLE.

45 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 07 TRANSMISSION GROUP 0705 TRANSMISSION SHIFTING COMPONENTS FIG. 13 DIRECTIONAL SWITCH CONTROL CABLE 1 PAOZZ MS NUT, CROWN CABLE XBOZZ CONTROL ASSEMBLY DIRECTIONAL CABLE PAOZZ NUT, PLAIN, HEXAGON CONTROL CABLE 1 TO SEAT BRAKE... 4 PAOZZ A. PIN, STRAIGHT, HEADED DIRECTIONAL... 1 SWITCH CABLE... 5 PAOZZ A. PIN, STRAIGHT, HEADED DIRECTIONAL... 1 SWITCH CABLE... 6 PAOZZ MS PIN, COTTER CABLE TO DIRECTIONAL... 1 SWITCH... 7 XDOZZ B76.CABLE ASSEMBLY DIRECTIONAL SWITCH... 1 TO SEAT... 8 XDOZZ TBD NUT, PLAIN, HEXAGON PAOZZ A32370 SEAL, SPECIAL CONTROL CABLE XDOZZ A32371 SEAL, MOLDED PAOZZ MS NUT, PLAIN, HEXAGON CONTROL CABLE... 4 ASSEMBLY MOUNTING PAOZZ M5S WASHER, FLAT CONTROL CABLE... 4 ASSEMBLY MOUNTING XDOZZ TBD. WASHER, FLAT SEAL PROTECTOR PAOZZ MS WASHER, FLAT SPRING RETAINING XDOZZ LCO59G12MW. SPRING CONTROL CABLE TO SEAT BRAKE XDOZZ TBD WASHER BEVEL CONTROL CABLE TO... 2 CONSOLE... END OF FIGURE 13-1

46 TM P FIGURE 14. DIRECTIONAL SWITCH.

47 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0705 TRANSMISSION SHIFTING COMPONENTS FIG. 14 DIRECTIONAL SWITCH 1 PAFZZ CD3A2870D7G1 SWITCH, ELECTRICAL PAFZZ C5G1. LEVER, MANUAL CONTRO PAFZZ K KNOB PAFZZ X2. SPRING ROLLER ARM ASSY XAFZZ D5G1. BOARD ASSEMBLY XBFZZ B3X2. COVER, ACCESS XDFZZ TBD. SCREW, FILLISTER, HD COVER TO... 2 HOUSING... 8 XDFZZ X6. WASHER, FLAT COVER TO HOUSING PAFZZ SA9556. SCREW ASSEMBLED WAS TERMINAL... 2 BOARD MOUNTING PAFZZ DG2. TERMINAL BOARD ASSE PAFZZ X1. SPRING, HELICAL, COMP CONTACT FINGER PAFZZ DlG1. CONTACT, ELECTRICAL DIRECTIONAL... 2 SWITCH PAFZZ C3G1. CARRIER ASSEMBLY MOVABLE CONTACT PAFZZ MS WASHER, FLAT OPERATING SHAFT PAFZZ MS WASHER, LOCK OPERATING SHAFT PAFZZ MS SCREW, CAP, SOCKET OPERATING SHAFT XDFZZ D24G1. SHAFT ASSEMBLY XBFZZ D23X1. LEVER, TRIP PAFZZ MS WASHER, FLAT PAFZZ MS WASHER, LOCK PAFZZ MS NUT, PLAINHEXAGON XDFZZ B8G2. HOUSING AND BEARING PAFZZ C9X2. CLAMP, SPRING STEEL SWITCH MOUNTING PAOZZ MS SCREW, CAP, HEXAGON H CLAMP... 4 DIRECTIONAL SWITCH PAFZZ AN WASHER, LOCK CLAMP PFFZZ D3X18. WASHER, FLAT OPERATING SHAFT XDFZZ X10. BUSHING, SLEEVE PAFZZ MS WASHER, LOCK HINGE PIN, CLIP PAFZZ AN SCREW, MACHINE HINGE PIN CLIP PAFZZ X6. PIN, HINGE CLIP HINGE PIN PAFZZ X4. PIN PAFZZ SHAFT PAFZZ MS SCREW, MACHINE HANDLE MOUNTING XDFZZ C1G1. ARM, ROLLER... 2 END OF FIGURE 14-1

48 TM P TA FIGURE 15. STACK VALVE.

49 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0714 SERVO UNIT FIG. 15 STACK VALVE 1 PAFZZ MS NUT, PLAIN, HEXAGON STACK VALVE PAFZZ AN WASHER, LOCK STACK VALVE MOUNTING PAFZZ MS WASHER, FLAT STACK VALVE MOUNTING PAFZZ MS SCREW, CAP, HEXAGON H STACK VALVE PAFZZ BZE6-2RQ8 SWITCH, SENSITIVE STACK VALVE., PAFZZ BZ2RQ784. SWITCH, SENSITIVE STACK VALVE PAFZZ MS WASHER, LOCK MICROSWITCH MOUNTING PAFZZ MS NUT, PLAIN, HEXAGON MICROSWITCH PAFZZ MS WASHER, FLAT MICROSWITCH MOUNTING PAFZZ MS SCREW, MACHINE STACK MICROSWITCH XBFZZ BRACKET, SWITCH STACK VALVE... 1 END OF FIGURE 15-1

50 TM P TA FIGURE 16. STACK VALVE ASSEMBLY.

51 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0714 SERVO UNIT FIG. 16 STACK VALVE ASSEMBLY 1 PAFFF CM11N01R17TDE21 VALVE, LINEAR, DIRECT PAFZZ PLUG, MACHINE THREAD RELIEF VALVE... 2 AND BODY FILLER... 3 PAFZZ O RING PLUG KFFZZ RING, QUANDRANT (PART OF KIT, FSN ) PART OF KIT P/N CMllNO1Rl7TDE21CDE KFFZZ PACKING, PREFORMED (PART OF KIT,... 2 FSN ) PART OF KIT P/N CM11NOIR17TDE XBOZZ HANDLEVLIFT XDOZZ KNOB, CONTROL PAOZZ PIN XDOZZ ROD LEVER PIVOT PAOZZ RING, RETAINING LEVER PIVOT ROD KFFZZ SEAL (PART OF KIT, FSN ) XBOZZ HANDLE, TILT XDOZZ B19.. KNOB, CONTROL XBFZZ ADAPTERSTRAIGHT XBFZZ RING ADAPTER XDFZZ CM11N01R17D. SECTION, OUTLET XBFZZ SCREW, CAP, HEXAGON VALVE BODY KFFZZ RETAINER (PART OF KIT, FSN ) PART OF KIT P/N CMlNORl7TDE PFFZZ TILT, CAM KFFZZ SEAL (PART OF KIT, FSN ) PART OF KIT P/N CMllNO1R17TDE KFFZZ SEAL (PART OF KIT, FSN ) PART OF KIT P/N CM11NOIR17TDE PAFZZ SHIM PAFZZ BALL, BEARING PAFZZ SPRING, HELICAL, COMP PFFZZ M PACKING, PREFORMED (PART OF KIT,... 2 FSN ) PFFZZ RETAINER, PACKING (PART OF KIT, FSN ) PART OF KIT P/N CMllNO1R17TDE PAFZZ PLUG POWER STEERING PFFZZ LIFT, CAM XDFZZ SPRING, CENTERING PFFZZ RING, QUADRANT (PART OF KIT, FSN ) PFFZZ PACKING, PREFORMED (PART OF KIT... 2 FSN )

52 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 32 PAFZZ SLEEVE PAFZZ RETAINER., PAFZZ SCREW, MACHINE SPOOL RETAINER XDFZZ CM11N01R17T. SECTION, INLET R PAFZZ WASHER, SLOTTED, PAFZZ NUT, PLAIN, HEXAGON VALVE BODY PAFZZ PISTONVALVE PAFZZ SPRING, HELICAL, COMP RELIEF SETTING... 1 END OF FIGURE 16-2

53 TM P TA FIGURE 17. DRIVE AXLE ASSEMBLY.

54 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 10 FRONT AXLE GROUP 1000 FRONT AXLE ASSEMBLY FIG.17 DRIVE AXLE ASSEMBLY 1 PAFZZ MS NUT, PLAIN, HEXAGON DRIVE ASSEMBLY PAFZZ MS WASHER, LOCK DRIVE ASSEMBLY FRAME PAFZZ MS WASHER, FLAT DRIVE ASSEMBLY MOUNTING PAFZZ MS WASHER, LOCK FRONT AXLE MOUNTING PAFZZ MS SCREW, CAP, HEXAGON FRONT AXLE PAFZZ MS SCREWVCAP, HEXAGON H DRIVE ASSEMBLY... 2 END OF FIGURE 17-1

55 TM P TA FIGURE 18. OUTER HOUSING.

56 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1000 FRONT AXLE ASSEMBLY FIG. 18 OUTER HOUSING 1 PAOZZ K687 ELBOW PAOZZ C679 FITTING BRAKE LINE XDOZZ C680 ELBOW, FITTING BRAKE LINE (OPPOSITE) PAOZZ MS WASHER, LOCK BRAKE LINE XDOZZ X113 NUT, PLAIN, HEXAGON BRAKE LINE... 4 FITTING... 6 PAOZZ J1336 SCREW, BLEEDER PAFZZ N112-1 NUT, PLAIN, HEXAGON SPINDLE TO AXLE... 6 HOUSING... 8 PAFZZ MS WASHER, LOCK SPINDLE TO AXLE HOUSING XDOZZ E1149 FITTING BLEEDER SCREW XDOZZ F1150 FITTING BLEEDER SCREW (OPPOSITE) PAHZZ A CONE DIFFERENTIAL BEARING PAHZZ A CUP DIFFERENTIAL BEARING PAHZZ X596 GASKET AXLE TO FINAL DRIVE PAHZZ P614 GASKET AXLE TO FINAL DRIVE XDFZZ S BOLT, SPECIAL XDHZZ R1032 HOUSING AXLE, LEFT HAND XDHZZ HOUSING AXLE, RIGHT HAND XDFZZ X389. STUD, PLAIN AXLE TO FINAL DRIVE HOUSING PAFZZ DOWEL AXLE TO FINAL DRIVE HOUSING PAFZZ MS WASHER, LOCK AXLE TO FINAL DRIVE... 8 HOUSING PAFZZ MS WASHER, LOCK AXLE TO FINAL DRIVE... 8 HOUSING PAFZZ N110-1 NUT, PLAIN, HEXAGON AXLE TO FINAL DRIVE HOUSING XDFZZ SHAFT, AXLE PAHZZ Y311 BEARING AXLE SHAFT PAHZZ N716 GASKET GEAR CASE TO HOUSING PAHZZ H86 COLLAR AXLE SHAFT BEARING RETAINER... 2 END OF FIGURE 18-1

57 TM P FIGURE 19. DIFFERENTIAL..

58 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1002 DIFFERENTIAL FIG. 19 DIFFERENTIAL 1 PAHZZ WASHER, THRUST PINION PAHZZ L64 SPIOER, DIFFERENTIAL PAHZZ GEAR, BEVEL DIFFERENTIAL SIDE PAHZZ S825 BEARING, WASHER, THRU DIFFERENTIAL... 2 SIDE GEAR... 5 XDHZZ F266 CASE, DIFFERENTIAL XBFZZ LW1622 WIRE, LOCK DIFFERENTIAL CASE BOLT XDFZZ X249 SCREW, CAP, HEXAGON H DIFFERENTIAL... 8 CASE 8 XDHZZ X161 RIVET, TUBULAR BEVEL PINION BEARING... 2 RETAINER 9 PAFZZ RETAINER, PINION BEA REAR PAFZZ Y1299 RING, RETAINING PINION BEARING PAFZZ N66 BEARING, ROLLER, CYLI BEVEL PINION XDFZZ Y597 GASKET ADAPTER PLATE XBHZZ R252 CAGE BEVEL PINION BEARING XDHZZ A PINION, BEVEL W/GEAR PAHZL RV7610 RIVET, SOLID BEVEL GEAR TO DIFFERENTIAL CASE PFHZZ N1938 SHIM BEVEL PINION BEARING PAHZZ P1940 SHIM BEVEL PINION BEARING PAHZZ C237 RING, SNAP, BEARING, A BEVEL PINION PAHZZ BEARING BEVEL PINION, FRONT XDFZZ W673 WASHER BEVEL PINION PAFZZ SEAL, PLAIN PINION BEARING PAFZZ Y389 GASKET BEVEL PINION BEARING COVER XDFZZ D472 SPACER, GEAR CUP BEVEL PINION,... 2 BEARING COVER XDFZZ W309 RETAINER PINION BEARING, OIL SEAL PAFZZ MS WASHER, LOCK PINION BEARING PAFZZ S269-1 BOLT, MACHINE PINION BEARING PAFZZ H34 RING, BEARING INNER BEVEL PINION XDFZZ Z598 GASKET, ADAPTER PAHZZ T124 PINION, DIFFERENTIAL XOHZZ CASE, DIFFERENTIAL FLANGE HALF PFHZZ HOUSING FINAL DRIVE PAOZZ MS PLUG, PIPE, MAGNETIC OIL DRAIN... 1 MAGNETIC PAOZZ MS S PLUG, PIPE OIL LEVEL PAOZZ MS BOLT, MACHINE COPPER SEAL PAOZZ SEAL, COPPER... 1 END OF FIGURE 19-1

59 TM P FIGURE 20. DRIVE AXLE MOTOR ASSEMBLY (FRONT).

60 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1004 STEERING AND LEANING WHEEL MECHANISM FIG. 20 DRIVE AXLE MOTOR ASSEMBLY (FRONT) 1 XBFZZ DRIVE ASSEMBLY PAOZZ MS SCREW, MACHINE THERMOSTAT MOUNTING PAOZZ MS WASHER, LOCK THERMOSTAT MOUNTING PAOZZ MS WASHER, FLAT THERMOSTAT MOUNTING XDOZZ L SWITCH, THERMOSTATIC DRIVE MOTOR XDOZZ FI2300. BOOT THERMOSTAT XBFFF MOTOR, TRACTION XDHZZ COIL ASSEMBLY, FIELD PFFZZ A280790G02... BUSHING ASSEMBLY FIELD WINDING... 3 CONNECTION PAFZZ MS NUT, PLAIN, HEXAGON BUSHING... 6 ASSEMBLY PAFZZ MS WASHER, LOCK TERMINAL MOUNTING PAFZZ MS WASHER, FLAT TERMINAL MOUNTING PAFZZ MS SCREW, CAP, HEXAGON H TERMINAL PAFZZ A TERMINAL, LUG COIL TO STUD PAHZZ MS SCREW, MACHINE MAIN POLE TO FRAME XBHZZ C479G06.. FRAME XDHZZ POLE, MAIN XDFZZ B ARMATUREICOMPLETE XAFZZ N... NUT XAFZZ K G02... COMMUTATOR XAFZZ A... COILS XAFZZ SHAFT XAFZZ B349ED KEY XDFZZ B349ED KEY PAFZZ PPFS264.. BOLT, MACHINE MOTOR SUPPORT TO... 8 MOTOR PAFZZ MS WASHER1LOCK MOTOR SUPPORT TO... 8 MOTOR XBFZZ B545821AEOO1.. BRACKET, BEARING DRIVE END PAFZZ BEARING, BALL, ANNULA YOKE AND... 1 BEARING SUPPORT XBFZZ AN SCREW, MACHINE BRUSH HOLDER TO... 8 YOKE AND BEARING SUPPORT PAFZZ MS WASHER, FLAT BRUSH HOLDER TO YOKE... 8 AND BEARING SUPPORT PAFZZ A SPRING, SPIRAL, TORSI BRUSH HOLDER PAFZZ K BRUSH, ELECTRICAL CO PAFZZ MS SCREW, MACHINE BRUSH MOUNTING PAFZZ MS WASHER, LOCK BRUSH MOUNTING XDFZZ A BUSHING BRUSH HOLDER TO YOKE AND... 8 BEARING SUPPORT XDFZZ C HOLDER, BRUSH

61 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 38 XDFZZ A INSULATOR BRUSH HOLDER TO SUPPORT XDFZZ A299GO1. CONNECTOR, LONG XDFZZ A CONNECTOR, SHORT PAFZZ MS WASHER, LOCK CONNECTOR MOUNTING PAFZZ MS SCREW, MACHINE COVER TO COVER XBFZZ C553G02.. COVER, HALF BRUSH XDFZZ MS BOLT, MACHINE SUPPORT MOUNTING PAFZZ MS WASHER, LOCK SUPPORT MOUNTING XBFZZ N26P23008C6.. SCREW, SLOTTED CONNECTOR MOUNTING XDFZZ D395BC001.. SUPPORT1YOKE AND PFFZZ A280190G02.. BUSHING ASSEMBLY ELECTRICAL... 2 CONNECTIONS PAFZZ MS NUT, PLAIN, HEXAGON PAFZZ MS WASHER, LOCK STUD AND BUSHING... 4 ASSEMBLY PAFZZ MS WASHER, FLAT STUD AND BUSHING... 4 ASSEMBLY PAFZZ MS SCREW, CAP, HEXAGON H STUD AND... 2 BUSHING ASSEMBLY PAFZZ MS SCREW, DRIVE COVER TO SUPPORT XDFZZ K G13.. CONNECTOR, CROSS XBFZZ C553G01.. COVER HALF, WITH NUT... 1 END OF FIGURE 20-2

62 TM P FIGURE 21. STEERING AXLE

63 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 11 REAR AXLE GROUP 1100 REAR AXLE ASSEMBLY FIG. 21 STEERING AXLE 1 XBFZZ SCREW, CAP, SOCKET STOP MOUNTING XBFZZ STOP ARTICULATING AXLE PAFZZ MS SCREW CAP HEXAGON H STEERING AXLE... 4 SUPPORT TO FRAME... 4 XBFZZ BUSHING SUPPORT BLOCK XBFZZ BLOCK, SUPPORT XBFZZ SHIM AXLE TO SUPPORT BLOCK PAOZZ MS FITTING, LUBRICATION PAFZZ MS WASHER, LOCK PAFZZ MS NUT, PLAIN, HEXAGON STEERING AXLE... 4 SUPPORT BLOCK TO FRAME XBFZZ AXLE ASSEMBLY XDFZZ MH18161 BEARING, NEEDLE WITH OIL HOLE XBFZZ PIN, KING PAOZZ MS FITTINGVLUBRICATION PAFZZ BEARING, WASHER, THRU SPINDLE XBFZZ SPINDLE, RIGHT HAND PAFZZ TT BEARING, WASHER, THRU... SPINDLE TO AXLE 2 17 PAFZZ MS NUT, PLAIN, SLOTTED, H TIE ROD PAFZZ MS PIN, COTTER TIE ROD PAFZZ MS WASHER, FLAT TIE ROD PAFZZ MS SETSCREW KING PIN LOCKING XBFZZ AXLE, ARTICULATING PAFZZ MS21044N8 NUT, LOCK, NYLON BEARING HOUSING TO... 6 AXLE WELOMENT XBFZZ SPINDLE, LEFT HAND PAFZZ AN178HI3A BOLT, CLOSE TOLERANC AXLE WELDMENT XDFZZ BELLCRANK ASSEMBLY STEERING XAFZZ BELLCRANK PAFZZ B BEARING, SLEEVE BELLCRANK, SHAFT XAFZZ HOUSING PAOZZ MS FITTING, LUBRICATION BELLCRANK... 1 HOUSING XAFZZ ARM, LEVER BELLCRANK XBFZZ KEY BELLCRANK END OF FIGURE

64 TM P FIGURE 22. DRIVE AXLE BRAKE AND MOTOR SUPPORT.

65 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 12 BRAKES GROUP 1201 HANDBRAKES FIG. 22 DRIVE AXLE BRAKE AND MOTOR SUPPORT 1 PAFZZ MS PIN, STRAIGHT, HEADED BRAKE CRANK TO... 1 MOTOR SUPPORT... 2 PAFZZ MS PIN, COTTER...BRAKE ROD AND CRANK PIN. 2 3 XBFZZ CRANK, BRAKE DRIVE MOTOR XBFZZ A PIN, YOKE BRAKE ROD TO CRANK XBFZZ A YOKE, ROD END BRAKE ROD PAFZZ MS NUT, PLAIN, HEXAGON BRAKE ROD PFFZZ BRAKE ROD BRAKE ACTUATING XBFZZ A PIN, YOKE BRAKE ROD TO LEVER., PAFZZ MS246b5-151 PIN, COTTER BRAKE ACTUATING ROD PIN XBFZZ SUPPORT TRACTION MOTOR MOUNTING XDFHH DRUM, BRAKE TRACTION MOTOR PAFZZ COUPLING, SHAFT, FLEX TRACTION MOTOR PAFZZ CHAIN TRACTION MOTOR DRIVE XDFZZ COUPLING, HALF DRIVEN, TRACTION MOTOR PAFZZ T228 NUT, PLAIN, CASTELLAT PINION DRIVE PAFZZ MS PIN, COTTER PINION DRIVE PAFZZ MS WASHER, LOCK BRAKEDRUM MOUNTING PAOZZ MS SCREW, CAP, HEXAGON H BRAKEDRUM PAFZZ MS WASHER1LOCK MOTOR SUPPORT TO... 7 DIFFERENTIAL HOUSING PAFZZ BOLT, MACHINE MOTOR SUPPORT TO... 7 DIFFERENTIAL HOUSING PAFZZ BRAKE, SHOE TYPE PAFZZ SPRING, HELICAL, EXTE BRAKE SHOES PAFZZ BRAKE SHOE WITH LINING PAFZZ SPRING BRAKE SHOE TO BACK-UP PLATE PAFZZ MS BOLT, MACHINE MOUNTING BRACKET AND... 6 SPACER TO BRAKE ASSEMBLY XBFZZ SPREADER, BRAKE PAFZZ MS WASHER, LOCK MOUNTING BRACKET AND... 6 SPACER TO BRAKE ASSEMBLY XBFZZ PLATE, BACK-UP XBFZZ SPACER MOUNTING BRACKET TO BRAKE... 2 ASSEMBLY XBFZZ BRACKET, MOUNTING BRAKE PAFZZ M NUT, PLAIN, HEXAGON... MOUNTING BRACKET 6 AND SPACER BRAKE ASSEMBLY PAFZZ MS WASHER, LOCK BRACKET TO SUPPORTR PAFZZ M SCREW, CAP, HEXAGON H BRACKET TO... 4 SUPPORT XDFZZ K6 NUT, SLOTTED CLAMPING SCREW PAFZZ MS PIN, COTTER CLAMPING SCREW XBFZZ LEVER SPREADER, BRAKE PAFZZ MS SCREW, CAP, HEXAGON H LEVER END OF FIGURE

66 TM P FIGURE 23. SERVICE BRAKES

67 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1202 SERVICE BRAKES FIG. 23 SERVICE BRAKES 1 PAOZZ Al RETAINER BRAKE ASSEMBLY PAOZZ M91 SPRING, HELICAL BRAKE ASSEMBLY PAOZZ A3722A105 BRAKE SHOE BRAKE PAOZZ L-12 SPRING, HELICAL, EXTE BRAKE SHOE PAFZZ MS NUT, PLAIN, HEXAGON BRAKE TO FINAL DRIVE... 6 PAFZZ MS WASHER, LOCK BRAKE XBFZZ M377 ROD BRAKE ASSEMBLY, ANTI-RATTLE PAOZZ WA15 WASHER, LOCK BRAKE CYLINDER PAOZZ MS BOLT, MACHINE BRAKE CYLINDER PAFZZ A2747C3 BOLT, BLANK ADJUSTING CAM XBFZZ J36 PLATE, BACKING BRAKE TO FINAL DRIVE... 2 CASE XDFZZ Z78 DOWEL, BRAKE TU FINA BRAKE TO FINAL... 4 DRIVE CASE PAFZZ Kll SPRING ADJUSTING CAM PAOZZ SPRING, RETAINING BRAKE ASSEMBLY PAFZZ Z182 CAM, ADJUSTING., END OF FIGURE

68 TM P FIGURE 24. BRAKE LINES

69 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1204 HYDRAULIC BRAKE SYSTEM FIG. 24 BRAKE LINES 1 PAOZZ NAS594-4 NUT, TUBING WHEEL CYLINDER LINE PFOZZ FC-5735-D REDUCER, BOSS... BRAKE CYLINDER TO TUBE 1 3 PAOZZ FC17 WASHER, FLAT...BRAKE CYLINDER ADAPTER 1 GASKET... 4 PAOZZ AN818-4 NUT, TUBING COUPLING BRAKE LINE MOOZZ TUBE, BRAKE LINE MAKE FROM TUBE P/N PAOZZ X3 ELBOW, PIPE TO TUBE BRAKE LINE PAOZZ MS SCREW, MACHINE BRAKE TUBE TO FRAME XDOZZ MSZ1919G3 CLAMP, TUBE BRAKE LINE PAOZZ X3 TEE, TUBE BRAKE LINE END OF FIGURE

70 TM P FIGURE 25. MASTER CYLINDER

71 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1204 HYDRAULIC BRAKE SYSTEM FIG. 25 MASTER CYLINDER 1 PAOZZ CYLINDER ASSEMBLY, H MASTER BRAKE PAOZZ F12103.CAP, FILLER OPENING PAOZZ FC6019.WASHER, NONMETALLIC COVER XBFZZ FD8832 *HOUSING PFFZZ FC10901.BOOT (PART OF KIT, FSN )... 6 XDOZZ ROD, CAM BRAKE CYLINDER PFOZZ MS SCREW, CAP, HEXAGON H MASTER... 2 CYLINDER MOUNTING... 8 PAOZZ AN WASHER, LOCK MASTER CYLINDER PAOZZ MS NUT, PLAIN, HEXAGON MASTER CYLINDER END OF FIGURE

72 TM P FIGURE 26. CYLINDER AND LINES

73 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1204 HYDRAULIC BRAKE SYSTEM FIG. 26 CYLINDER AND LINES 1 PFOZZ SPACER PAOZZ J686 GASKET, ADAPTER HYDRAULIC INLET XBOZZ C683 ADAPTER, WHEEL PAOZZ K687 ELBOW BRAKE LINE XDOZZ R850X TUBE ASSEMBLY BRAKE ACTUATING PFOZZ L-3158 TUBE ASSEMBLY, METAL BRAKE BLEEDER XDOZZ M-3159 TUBE ASSEMBLY, METAL BRAKE BLEEDER... 1 (OPPOSITE)... 7 PAOZZ E993 ADAPTER, SCREW BRAKE BLEEDER PAOZZ M13 LINK, WHEEL CYLINDER PAOZZ CYLINDER ASSEMBLY, H RH PAOZZ A1-3761E5 CYLINDER ASSEMBLY, H LH KFFZZ FC368.BOOT (PART OF KIT, FSN ) PART OF KIT P/N A1-3761E5S., KFFZZ FC1311. PISTON (PART OF KIT, FSN ) PART OF KIT P/N A1-3761E KFFZZ FC857. CUP (PART OF KIT, FSN ) PART OF KIT P/N A1-3761E KFFZZ FC860. SPRING (PART OF KIT, FSN ) END OF FIGURE

74 TM P FIGURE 27. BRAKE PEDAL

75 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1206 MECHANICAL BRAKE SYSTEM FIG. 27 BRAKE PEDAL 1 PAOZZ PEDAL BRAKE PAOZZ MS BOLT, MACHINE BRAKE PEDAL TO LEVER PAOZZ MS WASHER, FLAT BRAKE PEDAL TO LEVER XBOZZ LEVER, BRAKE PAOZZ LE069FlMW SPRING, HELICAL, EXTE BRAKE LEVER TO... 1 FRAME... 6 PAOZZ MS PIN, COTTER LINK TO BRAKE AND CRANK... 3 LEVER... 7 PAOZZ MS PIN, COTTER BRAKE LEVER AND CRANK... 2 TO FRAME... 8 XBOZZ CRANK, BRAKE PAOZZ BK75S4 PIN, STRAIGHT, HEADED LINK TO BRAKE... 3 AND CRANK LEVERVER PAOZZ A END, YOKE, ADJUSTING PAFZZ BZE6-2RN2 SWITCH, SENSITIVE FOOT BRAKE PAFZZ PA2.ARM, SWITCH ACTUATOR MICRO SWITCH PAFZZ BZ2RN702.SWITCH, SENSITIVE REPLACEMENT PAFZZ MS NUT, PLAIN, HEXAGON MICRO SWITCH* PAFZZ MS WASHER, LOCK MICRO SWITCH PAFZZ MS SCREW, MACHINE MICRO SWITCH PFOZZ MS NUT, PLAIN, HEXAGON CLEVIS XBOZZ CLEVIS, CAM BRAKE CYLINDER PAOZZ MS NUT, PLAIN, HEXAGON BRAKE PEDAL TO... 1 LEVER PAOZZ MS WASHER, LOCK BRAKE PEDAL TO LEVER END OF FIGURE

76 TM P FIGURE 28. WHEEL ASSEMBLY (FRONT).

77 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 13 WHEELS AND TRACKS GROUP 1311 WHEEL ASSEMBLY FIG. 28 WHEEL ASSEMBLY (FRONT) 1 PAOZZ X359 BOLT, WHEEL PAOZZ MS WASHER, FLAT BEARING RETAINER PAOZZ NUT, PLAIN, HEXAGON XDOZZ COVER HUB PAOZZ M5S SCREW, MACHINE HUB COVER PAOZZ MS PIN, COTTER NUT TO HUB * PAOZZ LM6704B8 CONE AND ROLLERS OUTER PAOZZ LM67010 CUP, BEARING OUTER XBOZZ WHEEL ASSEMBLY XBOZZ HUB, WHEEL PAOZZ CUP, TAPERED ROLLER INNER PAOZZ CONE AND ROLLERS INNER PAOZZ X1357 SEAL, BEARING SPINDLE END OF FIGURE

78 TM P FIGURE 29. WHEEL ASSEMBLY (REAR)

79 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1311 WHEEL ASSEMBLY FIG. 29 WHEEL ASSEMBLY (REAR) 1 PFFFF AXLE ASSEMBLY, AUTOM PFOZZ L246.BRAKE DRUM XDOZZ Q95 PLUG BRAKE INSPECTION HOLE XDOZZ R96 PLUG, BRAKE PFOZZ MS SCREW, CAP, HEXAGON H BRAKE LINE... 4 FITTING, SPECIAL... 6 PAHZZ D368 CASE FINAL DRIVE GEAR XDFZZ SN714-1.STUD, PLAIN BRAKE TO FINAL DRIVE... 8 CASE... 8 PAHZZ B340 SEAL, PLAIN ENCASED FINAL DRIVE GEAR PAFZZ J10 COVER, ACCESS PAFZZ X57 NUT WHEEL SPINDLE PAFZA Y363 WASHER, FLAT HUB BEARING NUT PAHZZ CONE AND ROLLER FINAL DRIVE, GEAR... 2 BEARING PAHZZ CUP, TAPERED ROLLER FINAL DRIVE2 GEAR BEARING PFHZZ J1388 GEAR, INTERNAL FINAL DRIVE, INTERNAL PFFZZ NL NUT, SPINDLE SPINDLE TO HOUSING PAHZZ CUP, TAPERED ROLLER FINAL DRIVE,... 2 GEAR BEARING XDHZZ CONE AND ROLLER FINAL DRIVE GEAR... 2 BEARING PAFZZ MS PIN, COTTER WHEEL SPINDLE PAFZZ X50 SPINDLE, WHEEL, NONDR PAFZZ M5S SCREW, CAP, HEXAGON H SPINDLE TO... 6 AXLE HOUSING PAFZZ X1101 STUD, PLAIN BRAKE DRUM AND GEAR DRIVE PAFZZ MS WASHER, LOCK GEAR CASE, FINAL DRIVE PFFZZ MS SCREW, CAP, HEXAGON H GEAR CASE, FINAL DRIVE PFOZZ V334 BUSHING, TAPERED WHEEL STUD PAOZZ MS WASHER, LOCK WHEEL STUD PAOZZ N18-1 NUT, PLAIN, HEXAGON BRAKEDRUM END OF FIGURE

80 TM P FIGURE 30. TIRE (FRONT)

81 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1313 TIRES, TUBES, TIRE CHAINS FIG. 30 TIRE (FRONT) 1 PAHZZ MS TIRE SOLID RUBBER END OF FIGURE

82 TM P FIGURE 31. TIRE (REAR)

83 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1313 TIRES, TUBES, TIRE CHAINS FIG. 31 TIRE (REAR) 1 PAHZZ ZZ-T-391 TIRE, SOLID RUBBER END OF FIGURE

84 TM P FIGURE 32. STEERING BOOSTER

85 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 14 STEERING GROUP 1401 MECHANICAL STEERING GEAR ASSEMBLY FIG. 32 STEERING BOOSTER 1 PAFZZ MS SCREW, MACHINE MICROSWITCH PAFZZ MS WASHERIFLAT PAFZZ BZE6-2RN2 SWITCH, SENSITIVE STEERING BOOSTER PAFZZ BZ2RN702.SWITCH, SENSITIVE REPLACEMENT PAFZZ PA2.ARM, SWITCH ACTUATOR MICROSWITCH XBFZZ BOOSTER ASSEMBLY PAOZZ BOOT, DUST AND MOIST PAFZZ BOLT CAP TO SUBASSEMBLY XBFZZ HOUSING PAFZZ MS21044N7.NUT, SELF-LOCKING, HE BALL STUD... 1 CLAMP PAFZZ MS PIN, COTTER NUT TO BALL STUD PAFZZ TIE ROD END, STEERIN REAR PAFZZ MS NUT XDOZZ DUST COVER XDOZZ STUD ASSEMBLY XDFZZ RING, RETAINING PLUG* XDFZZ WASHER PLUG SPACING* XDFZZ PIN, STRAIGHT PFOZZ X FITTINGILUBRICATION PAFZZ SCREW, CAP, HEXAGON H BALL STUD... 1 CLAMP PAFZZ MS NUT, PLAIN, SLOTTED, H BALL STUD PAFZZ PLUG1ADJUSTING BALL PAFZZ SEAT, BALL SOCKET PAFZZ STUDOBALL* PAFZZ SPRING, STEERING PAFZZ SCREW VALVE PAFZZ W WASHER, FLAT VALVE.* PAFZZ SLEEVE, BALL STUDD PAFZZ CYLINDER* XBFZZ PIN, COTTER VALVE PAFZZ X NUT, PLAIN, E XTENDED PAOZZ PACKING, PREFORMEO (PART OF KIT,... 1 FSN ) PFFZZ SEAL (PART OF KIT, FSN ) PAFZZ BODY PAFZZ BALL, POPPET CHECK...* 1 36 PAFZZ STEM, FLUID VALVE KFFZZ RING (PART OF KIT, FSN ) PART OF KIT P/N XDFZZ SEAL (PART OF KIT, FSN ) KFFZZ WASHER (PART OF KIT, FSN

86 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 7605) PART OF KIT P/N KFFZZ *RETAINER (PART OF KIT, FSN ) PART OF KIT P/N PFFZZ RING (PART OF KIT, FSN ) KFFZZ SCRAPER (PART OF KIT, FSN ) PART OF KIT P/N PFFZZ N *SNAP RING (PART OF KIT, FSN ) PAFZZ TIE ROD END, STEERIN FRONT PAFZZ MS21044N7 NUT, SELF-LOCKING HEXAGON XDOZZ STUD ASSEMBLY PAFZZ SCREW, CAP, HEXAGON H CLAMP XDOZZ DUST COVER PAFZZ MS NUT XDFZZ SPOOL KFFZZ O RING...(PART OF KIT, FSN ) PART OF KIT P/N KFFZZ RING (PART OF KITTFSN ) PART OF KIT P/N PAFZZ WASHER, FLAT SPRING SEAT PAFZZ SPACER, SLEEVE VALVE PAFZZ SPRING, HELICAL, COMP VALVE PAFZZ MS NUT, PLAIN, HEXAGON MICROSWITCH PAFZZ MS WASHER, LOCK MICROSWITCH MOUNTING END OF FIGURE

87 TM P FIGURE 33. STEERING GEAR

88 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1401 MECHANICAL STEERING GEAR ASSEMBLY FIG. 33 STEERING GEAR 1 PAFZZ MS NUT, PLAIN, HEXAGON PITMAN ARM STOP... 2 SCREW... 2 PAFZZ MS SCREW, CAP, HEXAGON, H STEERING GEAR PAFZZ MS SCREW, CAP, HEXAGON STEERING GEAR PAFZZ MS WASHER, LOCK STEERING GEAR MOUNTING XDFZZ GEAR ASSEMBLY PFOZZ MS SCREW, TAPPING, THREA HORN MOUNTING PAOZZ HORN BUTTON KITI PAOZZ NUT, PLAIN, HEXAGON STEERING WHEEL PAOZZ KEY, WOODRUFF STEERING WHEEL PAOZZ STEERING WHEEL PAFZZ SPRING PAFZZ SEAT PAFZZ BEARING, BALL PAFZZ MS NUT, PLAIN, HEXAGON STEERING CLAMP PAFZZ MS WASHER, LOCK... STEERING CLAMP 1 16 PFFZZ MS BOLT, MACHINE... STEERING CLAMP 1 17 XDFZZ CLAMP JACKET TO SHAFT ASSEMBLY...CC 1 18 XBFZZ JACKET, STEERING PAOZZ MS SCREW, MACHINE CONTACT COVER PFOZZ COVER, CONNECTOR PAOZZ MS SCREW, TAPPING CONTACT MOUNTING PAOZZ CONNECTOR ASSEMBLY.* PAFZZ MS NUT, PLAIN, HEXAGON PITMAN ARM PAFZZ MS WASHER, LOCK PITMAN ARM MOUNTING XBFZZ ARM, PITMAN PAFZZ SEAL, PLAIN ENCASED PAFZZ BEARING, SLEEVE SHAFT XBFZZ HOUSING, STEERING PAOZZ PLUG, PIPE PAFZZ SHAFTIPITMAN XDFZZ SCREW, ADJUSTING PAFZZ AM WASHER, FLAT ADJUSTING SCREW PAFZZ GASKET COVER PLATE PAFZZ BEARING, SLEEVE COVER XBFZZ COVER, HOUSING PAFZZ MS WASHER, LOCK... COVER PLATE MOUNTING 3 37 PFFZZ BOLT, MACHINE... COVER PLATE MOUNTING PAFZZ CSA NUT, PLAIN, HEXAGON ADJUSTING SCREW... 1 LOCK XDFZZ CLAMP

89 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 40 XBFZZ PLATE, END PAFZZ RETAINER AND ROLLER XBFZZ AN SCREW, RETAINER TUBE PAFZZ MS WASHER, LOCK RETAINER TUBE CLAMP XDFZZ TUBE, RETAINER XDFZZ SHAFT ASSEMBLY STEERING XAFZZ NUT, BALL PAFZZ MS BALL, BEARING XBFZZ HOUSING, BEARING XDFZZ NUT, PLAIN, HEXAGON BEARING HOUSING... 1 TO HOUSING END OF FIGURE

90 TM P FIGURE 34. STEERING DRAG LINK

91 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1401 MECHANICAL STEERING GEAR ASSEMBLY FIG. 34 STEERING DRAG LINK 1 PAFZZ MS PIN, COTTER DRAG LINK TO PITMAN ARM PAFZZ MS NUT, PLAIN, SLOTTED, H DRAG LINK TO... 2 PITMAN ARM... 3 PAFZZ MS WASHER1FLAT DRAG LINK TO PITMAN ARM XBFZZ DRAG LINK STEERING PAOZZ MS FITTING, LUBRICATION DRAG LINK PAFZZ BALL JOINT DRAG LINK XBFZZ *NUT, JAM SPECIAL DRAG LINK PAFZZ MS SCREW, CAP, SOCKET...ACTUATOR TO DRAG 2 LINK... 9 PAFZZ MS WASHER, LOCK ACTUATOR TO DRAG LINK XBFZZ ACTUATOR STEERING BOOSTER SWITCH XBFZZ TUBE ASSEMBLY DRAG LINK END OF FIGURE

92 TM P FIGURE 35. TIE-ROD.

93 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1401 MECHANICAL STEERING GEAR ASSEMBLY FIG. 35 TIE-ROD 1 PAFZZ TIE ROD1STEERING XBFZZ NUT, JAM BALL JOINT XBFZZ TUBE PAFZZ ES176R TIE ROD END, STEERIN TIE ROD PAOZZ MS FITTING, LUBRICATION BALL JOINT... 4 END OF FIGURE 35-1

94 TM P FIGURE 36. OVERHEAD GUARD

95 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 18 BODY, CAB, HOOD, AND HULL GROUP 1801 BODY, CAB, HOODO AND HULL ASSEMBLIES FIG. 36 OVERHEAD GUARD 1 XBOZZ GUARD, OVERHEAD PAOZZ MS SCREW, MACHINE EXTINGUISHER MOUTING PAOZZ MS SCREW, CAP, HEXAGON OVERHEAD GUARD PAOZZ AN WASHER, LOCK OVERHEAD GUARD MOUNTING. 4 5 PAOZZ MS NUT, PLAIN,HEXAGON...OVERHEAD GUARD 4 END OF FIGURE 36-1

96 TM P TA FIGURE 37. CONSOLE

97 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1801 BODY, CAB, HOOOD AND HULL ASSEMBLIES FIG. 37 CONSOLE 1 XBOZZ COVER, HORN PAOZZ MS SCREW, MACHINE...HORN COVER MOUNTING 4 3 PAOZZ MS SCREW, MACHINE...STACK VALVE ACCESS 6 COVER MOUNTINGC... 4 PAOZZ MS WASHER, LOCK STACK VALVE ACCESS... 6 COVER MOUNTING... 5 XBOZZ COVER, CONSOLE STACK VALVE ACCESS PAFZZ MS SCREW, CAP, HEXAGON CONSOLE ASSEMBLY.. 4 TO FRAME... 7 PAFZZ MS WASHER, LOCK CONSOLE ASSEMBLY TO... 4 FRAME... 8 PAFZZ MS NUT,PLAIN,HEXAGON XBFZZ CONSOLE PAOZZ MS WASHER, LOCK HORN COVER MOUNTING PAOZZ JHP NUT, PLAIN, HEXAGON HORN COVER... 4 END OF FIGURE 37-1

98 TM P TA FIGURE 38. FLOOR PLATES AND ACCELERATOR PEDAL

99 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1805 FLOORS, SUBFLOORS, AND RELATED COMPONENTS FIG. 38 FLOOR PLATES AND ACCELERATOR PEDAL 1 XBOZZ PLATE,FLOOR LEFT SIDE FRONT PAOZZ MS SCREW, CAP, HEXAGON H PAOZZ MS WASHER, FLAT... FLOORPLATE MOUNTING 6 4 PAOZZ MS WASHER, LOCK... FLOORPLATE MOUNTING 6 5 PAOZZ MS NUT, PLAIN, HEXAGON FLOORPLATE PAOZZ MS WASHER, LOCK ACCELERATOR PEDAL PAOZZ MS SCREW, CAP1HEXAGON H ACCELERATOR... 2 PEDAL MOUNTINGC... 8 PAOZZ PEDAL, CONTROL PAOZZ MS C31 PIN, STRAIGHT HEADED ACCELERATOR... 1 PEDAL TO SHAFTT PAOZZ MS PIN, COTTER ACCELERATOR PEDAL TO ROD PAOZZ MS SCREW, CAP, HEXAGON H ACCELERATOR... 1 PEDAL STOP PAOZZ MS NUT, PLAIN, HEXAGON ACCELERATOR... 2 PEDAL STOP PAOZZ MS SCREW1CAP, HEXAGON FLOORPLATE XDOZZ HOSE FLOORPLATE XBOZZ PLATE, FLOOR RIGHT HAND XBOZZ PLATE, FLOOR REAR PAOZZ MS SCREW, MACHINE FLOORPLATE MOUNTING... 2 END OF FIGURE 38-1

100 TM P FIGURE 39. OPERATOR S SEAT

101 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1806 UPHOLSTERY, SEATS.AND CARPETS FIG. 39 OPERATOR S SEAT 1 XBOZZ SEAT, ASSEMBLY OPERATOR XDOZZ SCREW1ASSEMBLED WAS SEAT AND... 5 BACKREST MOUNTING... 3 XDOZZ WR.SLIDE, ADJUSTABLE RIGHT HAND XDOZZ SLIDE, LEFT HAND PAOZZ MS WASHER, FLAT SEAT SLIDE TO FRAME PAOZZ MS WASHER, LOCK SEAT SLIDE TO PLATE PAOZZ MS NUT, PLAIN,HEXAGON SEAT SLIDE TO... 4 PLATE... 8 XBOZZ SCREW, FILLISTER SLIDE TO SHELL XDOZZ C.CUSHION, SEAT, VEHICU PAOZZ XSP.SPRING, HELICAL, EXTE SLIDE ADJUSTOR PAOZZ BRACKET SEAT XBOZZ K.SHELLSEAT... 1 END OF FIGURE 39-1

102 TM P FIGURE 40. SEAT SUPPORT AND SAFELY CONTROLS

103 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1806 UPHOLSTERY, SEATS, AND CARPETS FIG. 40 SEAT SUPPORT AND SAFETY CONTROLS 1 XBOZZ SUPPORT, SEAT XBOZZ LEVER SEAT ACTUATED PAOZZ BEARING, BALL, ANNULA LEVER PAOZZ AN WASHER, LOCK BEARING MOUNTING PAOZZ MS NUT, PLAIN, HEXAGON BEARING MOUNTING PAOZZ BK75S4 PIN, STRAIGHT, HEADED CONTROL ROD TO... 1 LEVER... 7 PAOZZ MS PIN, COTTER ROD AND LEVER XBOZZ ROD, CONTROL PAOZZ MS WASHER, FLAT CONTROL ROD XDOZZ SPRING, HELICAL,COMP CONTROL ROD PAOZZ MS PIN, COTTER CABLE TO ROD PIN PAOZZ lA PIN, STRAIGHT, HEADED CABLE TO ROD XBOZZ CABLE ASSEMBLY BRAKE CRANK TO SEAT... 1 BRAKE CONTROL ROD PAOZZ MS NUT, PLAIN, HEXAGON CABLE PAOZZ A CLEVIS, ROD END CABLE PAOZZ MS PIN, COTTER CABLE TO BRAKE CRANK PAOZZ BK75S4 PIN, STRAIGHT, HEADED CABLE TO BRAKE... 2 CRANK 18 PAOZZ MS WASHER, LOCK SUPPORT TO FRAME PAOZZ MS SCREW, CAP,HEXAGON H SUPPORT TO... 4 FRAME XBOZZ SPACER, PULLEY PAOZZ PULLEY, GROOVE CONTROL CABLE PAOZZ MS NUT, PLAIN, HEXAGON PILLEY TO SEAT... 1 BRACKET PAOZZ M5S WASHER, LOCK...PULLEY TO SEAT BRACKET 1 24 PAOZZ CONTROL CABLE ASSEM HAND LEVER TO... 1 BRAKE CRANK PAOZZ MS NUT, PLAIN, HEXAGON CABLE PAOZZ A CLEVIS, ROD END CABLE XDOZZ BOLT, MACHINE PULLEY TO SEAT BRACKET PAOZZ MS NUT, PLAIN, HEXAGON SUPPORT TO FRAME XBOZZ BRACKET SEAT MOUNTING PAOZZ BZE6-2RN2 SWITCH, SENSITIVE SEAT ACTIVATED XBOZZ DD10002 WASHER, LOCK SWITCH MOUNTING PAOZZ MS SCREW, MACHINE SWITCH MOUNTING PAOZZ MS NUT, PLAIN, HEXAGON BRAKE LEVER... 2 ASSEMBLY MOUNTING PAOZZ AN WASHER, LOCK BRAKE LEVER ASSEMBLY PAOZZ C LEVER ASSEMBLY PAOZZ MS C39 PIN,STRAIGHT, HEADED LEVER ASSEMBLY PAOZZ MS WASHER, FLAT...LEVER ASSEMBLY 1 38 PAOZZ MS PIN, COTTER...LEVER ASSY

104 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 39 PAOZZ MS PIN, COTTER LINK PIN XBOZZ LINK CONTROL CABLE TO BRAKE LEVER PAOZZ lA PIN, STRAIGHT, HEADED LEVER PAOZZ PULLEY, GROOVE CONTROL CABLE PAOZZ MS PIN, COTTER...PULLEY TO SEAT BRACKET 1 44 PAOZZ MS WASHER, FLAT...LEVER TO SEAT BRACKET 1 45 PAOZZ MS WASHER, FLAT... SEAT SUPPORT MOUNTING 2 46 PAOZZ MS SCREW, CAP, SOCKET HE SEAT SUPPORT PAOZZ MS SCREW, CAP, HEXAGON H BRAKE LEVER... 2 ASSEMBLY MOUNTING XBOZZ PLATE, SEAT... 1 END OF FIGURE 40-2

105 TM P FIGURE 41. HYDRAULIC PUMP COUPLING

106 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 24 HYDRAULIC AND FLUID SYSTEMS GROUP 2401 PUMP AND MOTOR FIG. 41 HYDRAULIC PUMP COUPLING 1 PAFZZ MS WASHER, LOCK PUMP TO MOTOR PAFZZ MS SCREW, CAP, HEXAGON H PAFZZ MS SETSCREW CHAIN COUPLING TO SHAFTS PFFZZ COUPLING ASSEMBLY PUMP TO MOTOR PAFZZ COUPLING DRIVING PAFZZ CHAIN, ROLLER DOUBLE ROLLER PAFZZ COUPLING DRIVEN... 1 END OF FIGURE 41-1

107 TM P FIGURE 42. HYDRAULIC PUMP

108 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2401 PUMP AND MOTOR FIG. 42 HYDRAULIC PUMP 1 PAFZZ PUMP, ROTARY XAFZZ KIT, VANE (PART OF KIT, P/N ) KFFZZ ROTOR (PART OF KIT, P/N )... 1 PART OF KIT P/N l KFFZZ RING (PART OF KIT, P/N ) PART... 1 OF KIT P/N PAFZZ BACPllS236 PACKING, PREFORMED (PART OF KIT, P/... 2 N ).) XDFZZ PRESSURE PLATE PAFZZ BUSHING PAFZZ SPRING, HELICAL, COMP...PRESSURE PLATE 1 9 PAFZZ SCREW, CAP, HEXAGON H... COVER MOUNTING 4 10 XBFZZ COVER PAFZZ MS PIN, STRAIGHT, HEADLE COVER RING... 2 BODY PFFZZ PUMP BODY, ROTARY PAFZZ SEAL, PLAIN ENCASED XDFZZ MS RING, RETAINING PAFZZ BEARING BALL PAFZZ SCD16871 KEY, MACHINE PAFZZ RING, RETAINING XBFZZ SHAFT... 1 END OF FIGURE 42-1

109 TM P FIGURE 43. HYDRAULIC PUMP MOTOR.

110 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2401 PUMP AND MOTOR FIG. 43 HYDRAULIC PUMP MOTOR 1 XBFZZ JUMPER CONNECTION S1 TO A PAFZZ TERMINAL, LUG., PAOZZ MS SCREW, MACHINE THERMOSTAT TO MOTOR PAOZZ MS WASHER,LOCK THERMOSTAT TO MOTOR PAOZZ MS WASHER, FLAT THERMOSTAT MOUNTING XDOZZ L SWITCH, THERMOSTATIC PUMP MOTOR PAOZZ F12300 BOOT, DUST AND MOIST XBFFF MOTOR, PUMP XBHZZ COILS, FIELD PFFZZ A280790G02 BUSHING ASSEMBLY FIELD WINDING... 3 CONNECTION PAFZZ MS WASHER, FLAT STUD AND BUSHING... 6 ASSEMBLY, PAFZZ MS SCREW, CAP, HEXAGON H PAFZZ MS NUT, PLAIN HEXAGON PAFZZ MS WASHER, LOCK STUD AND BUSHING... 6 ASSEMBLY, PAFZZ A TERMINAL, LUG COIL TO STUD XBHZZ A280790G06 FRAME PAHZZ MS SCREW, MACHINE MAIN POLE TO FRAME... 8 MOUNTING,.,.G XDFZZ ARMATURE, COMPLETE XAFZZ N NUT, LOCK COMMUTATOR TO SHAFT... 1 SPECIAL XAFZZ COMMUTATOR ARMATURE ASSEMBLY XAFZZ COILS, ARMATURE XAFZZ E0036 KEY COMMUTATOR XAFZZ SHAFT XDFZZ B349ED071 KEY, ARMATURE XBHZZ POLE, MAIN XDFZZ N3400P606 KEY CHAIN COUPLING TO SHAFT PAFZZ PPFS264 BEARING, BALL, ANNULA DRIVE END PAFZZ MS WASHER, LOCK DRIVE END BEARING BRACKET TO FRAME PAFZZ MS BOLT, MACHINE DRIVE END BEARING... 8 BRACKET TO FRAME XBFZZ B FOOT MOTOR MOUNTING XBFZZ C400AC001 BRACKET, BEARING DRIVE END PAFZZ BH2595 BEARING, BALL, ANNULA YOKE AND... 1 BEARING SUPPORT.T XDFZZ A INSULATOR BRUSH HOLDER TO SUPPORT XDFZZ C HOLDER,BRUSH XDFZZ A BUSHING BRUSH HOLDER TO YOKE AND... 8 BEARING SUPPORT XBFZZ AN SCREW, MACHINE BRUSH HOLDER TO... 8 YOKE AND BEARING SUPPORT PAFZZ K BRUSH, ELECTRICAL CO PAFZZ MS WASHER, FLAT BRUSH HOLDER TO

111 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY YOKEAND BEARING SUPPORT PAFZZ MS WASHER, LOCK BRUSH MOUNTING PAFZZ M SCREW, MACHINE...BRUSH MOUNTING 8 41 PAFZZ MS SCREW, MACHINE... COVER TO COVER 1 42 XBFZZ C553G02 COVER, HALF... BRUSH 1 43 PAFZZ MS WASHER, LOCK... YOKE AND BEARING 4 SUPPORT TO FRAME XDFZZ MS BOLT, MACHINE YOKE AND BEARING... 4 SUPPORT TO FRAME 45 XDFZZ A299GO1 CONNECTOR LONG PAFZZ A SPRING, SPIRAL, TORSI BRUSH HOLDER XDFZZ A CONNECTOR SHORT PAFZZ MS WASHER, LOCK CONNECTORS, LONG AND... 4 SHORT 49 XBFZZ N26P23008C6 SCREW, SLOTTED CONNECTORS, LONG AND... 4 SHORT PAFZZ MS BOLT, MACHINE FOOT TO YOKE AND... 3 BEARING SUPPORT XDFZZ D395UEG1 SUPPORT YOLK BEARIN PAFZZ MS SCREW, DRIVE COVER TO SUPPORT PFFZZ A280790G02 BUSHING ASSEMBLY ELECTRICAL... 2 CONNECTIONS PAFZZ MS NUT,HEXAGON STUD AND BUSHING... 4 ASSEMBLY PAFZZ MS WASHER, LOCK STUD AND BUSHING... 4 ASSEMBLY PAFZZ MS WASHER, FLAT STUD AND BUSHING... 4 ASSEMBLY PAFZZ MS SCREW, CAP, HEXAGON H XDFZZ K G13 CONNECTOR, CROSS XBFZZ C553G01 COVER HALFIWITH NUT PAFZZ MS SCREW, CAP, HEXAGON H PAFZZ MS WASHERTFLAT PAFZZ MS WASHERILOCK PAFZZ MS NUT, PLAIN, HEXAGON PUMP AND MOTOR... 4 TO FRAMEM... END OF FIGURE 43-2

112 TM P FIGURE 44. TILT CYLINDER

113 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2404 TILT CYLINDERS AND TILT CRANK FIG. 44 TILT CYLINDER 1 XBOZZ PIN CYLINDER TO FRAME MOUNTING PAOZZ MS PIN, COTTER CYLINDER PIN TO FRAME PAOFF CYLINDER ASSEMBLYVA TILT KFFZZ C SEAL (PART OF KIT, FSN ) PART OF KIT P/N 6982.,... 5 XAFZZ C210-4 PISTON PAFZZ MS SETSCREW HEAD TO HOUSING, KFFZZ C210-9 BUSHING (PART OF KIT, FSN ) PART OF KIT P/N PAFZZ MS SETSCREW GLAND TO HEAD XBFZZ C210-1 HEAD KFFZZ C RING (PART OF KIT, FSN ) PART OF KIT P/N PAFZZ MS SETSCREW CLEVIS TO PISTON ROD XBFZZ C CLEVIS, ACTUATING KFFZZ C WIPER (PART OF KIT, FSN ) PART OF KIT P/N XDFZZ GLAND KFFZZ C SEAL (PART OF KIT, FSN ) PART OF KIT P/N 6982.,., KFFZZ C RING (PART OF KIT, FSN ) PART OF KIT P/N XBFZZ C210-5 ROD, PISTON XBFZZ C210-3 HOUSING CYLINDER,... 2 END OF FIGURE 44-1

114 TM P FIGURE 45. LIFT FORKS AND CYLINDER YOKE

115 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 45 LIFT FORKS AND CYLINDER YOKE 1 PAOZZ MS PIN, COTTER MAST TO TILT CYLINDER... 4 PIN... 2 XBOZZ PIN, CYLINDER, TILT MAST TO TILT... 2 CYLINOERDER... 3 XBFZZ PIN, PIVOT, MAST PAFZZ AN WASHER, LOCK PIVOT PIN TO MAST PAFZZ MS SCREW, CAP, HEXAGON H PIVOT PIN TO... 2 MAST... 6 XDFZZ MAST ASSEMBLY PAOZZ MS WASHER, LOCK LOAD BACKREST MOUNTING PAOZZ MS SCREW, CAP, HEXAGON H LOAD BACKREST XBOZZ BACKREST, LOADO PAFZZ MS WASHER, LOCK STOP LATCH SCREW PFFZZ SCREW SPECIAL STOP LATCH XBFZZ WEARPLATE, GUIDE CYLINDER YOKE TO... 2 MAST PFFZZ PIN, BEARING CYLINDER YOKE XDFZZ BEARING, BALL, ANNULA CYLINDER YOKE PAFZZ MS PIN, COTTER CYLINDER YOKE IDLER PAFZZ M WASHER, LOCK CYLINDER YOKE TO LIFT... 4 CYLINDER PAFZZ MS SCREW, CAP, HEXAGON CYLINDER YOKE... 4 TO LIFT CYLINDER PAFZZ AN WASHER, LOCK GUIDE WEARPLATE TO... 4 CYLINDER YOKEO.K PAFZZ MS SCREW,CAP, HEXAGON H GUIDE WEAR... 4 PLATE TO CYLINDER YOKE XBFZZ YOKE, CYLINDER XBOZZ FORK, LIFTING XBFZZ ABC LATCH ASSEMBLY FORK LOCKING XBFZZ ABC PIN, SPRING LATCH HANDLE PFFZZ ABC HANDLE, LATCH XBFZZ B PINTLOCKING FORK XAFZZ ABC SPRING... 2 END OF FIGURE 45-1

116 TM P FIGURE 46. LIFT CYLINDER

117 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 46 LIFT CYLINDER 1 XBFHH CYLINDER ASSEMBLY XBFZZ C211-3 BARREL, CYLINDER PAFZZ MS SETSCREW HEAD LOCKING XDFZZ RING, WEAR PAFZZ WW-P-471ACABCA PLUG, PIPE BARREL XDFZZ BUSHING KFFZZ C RING (PART OF KIT, FSN ) PART OF KIT P/N KFFZZ C RING (PART OF KIT, FSN ) PART OF KIT P/N XBFZZ C211-8A GLAND, ROD KFFZZ C211-55A WIPER (PART OF KIT, FSN ) PART OF KIT P/N KFFZZ RETAINER (PART OF KIT, FSN ) PART OF KIT P/N KFFZZ C SEAL SET (PART OF K[T, FSN ) PART OF KIT PIN KFFZZ SLEEVE (PART OF KIT, FSN ) PART OF KIT P/N PAFZZ C BREATHER,FILTER XDFZZ WIRE FABRIC KFFZZ C211-55B WIPER (PART OF KIT, FSN ) PART OF KIT P/N PAFZZ MS SETSCREW GLAND TO ROD XBFZZ C211-8B GLAND XBFZZ C RODIC YLINDER KFFZZ C SEAL SET (PART OF KIT, FSN ) PART OF KIT P/N XBFZZ C211-1 HEAD, CYLINDER PAFZZ MS SETSCREW HEAD LOCKING XBFZZ C211-5A ROD... 1 END OF FIGURE 46-1

118 TM P FIGURE 47. LIFT MAST

119 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 47 LIFT MAST 1 XBOZZ BL634 CHAIN, LIFT XBOZZ PIN, CLEVIS CHAIN ATTACHING PAOZZ MS PIN, COTTER LIFT CHAIN CLEVIS PIN XBOZZ SPACER CHAIN END XDOIZ CLEVIS, ROD ENDO PAOZZ MS NUT, PLAIN, HEXAGON CLEVIS TO TIE ROD XBOZZ SV26-3 ROD CHAIN TO MAST PAOZZ MS21044N14 NUT, SELF-LOCKING ROD TO MAST XBHZZ AN505UB SCREW, FLATHEAD MAST PAHZZ SPACER, PLATE MAST XBHZZ SHIM BEARING PAD TO MAST XBHZZ SHIM, BEARING PAD PAHZZ BRACKET, ANGLE MAST PAHZZ MS WASHER, LOCK BEARING PAD TO MAST PAFZZ MS SCREW, CAP, HEXAGON H BEARING PAD TO MAST XBHZZ SHIM, BEARING PAD PAHZZ SPACER, PLATE PAHZZ MS SCREW, MACHINE, FLAT BEARING PAD TO... 4 MAST PAHZZ MS PIN, COTTER IDLER PIN TO MAST PFHZZ PIN, BEARING TO MAST XDHZZ BEARING, BALL,ANNULA MAST CHAIN XBHZZ SHIM BRACE TO MAST...V 23 XBHZZ BRACE 1ST STAGE MAST PAHZZ MS WASHER, LOCK BRACE TO 1ST STAGE MAST PAHZZ MS SCREW, CAP, HEXAGON H BRACE TO 1ST... 4 STAGE MAST PAHZZ MS SCREW, MACHINE, FLAT BEARING PAD TO... 4 MAST XBHZZ MAST, TELESCOPIC 1ST STAGE PAHZZ LATCH, DOOR, VEHICULA PAHZZ LATCH, LOCKING 1ST STAGE MAST TO ND STAGE MAST XBHZZ BLOCK, STOP 2ND STAGE MAST PAHZZ MS SCREW, CAP, SOCKET STOP BLOCK TO 2ND... 6 STAGE MAST XDHZZ LATCH, LOCKING 1ST STAGE MAST TO ND STAGE PAHZZ LATCH 1ST STAGE LATCH TO 2NO STAGE... 1 MAST XBHZZ MAST, TELESCOPE 2ND STAGE PAHZO MS WASHER, FLAT PAD TO MAST XBHZZ AN505UB SCREWIFLATHEA PAHZZ PAD,BEARING XBHZZ SHIM, BEARING PAD PAHZZ MS NUT, PLAIN, HEXAGON PAD TO MAST PAHZZ MS SCREW, CAP, SOCKET HE STOP PAD TO

120 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY MAST PAHZZ MS WASHER, LOCK STOP PAD TO MAST XBHZZ PADSTOP FIXED MAST XBHZZ SHIM STOP PAD TO MAST PAHZZ MS NUT, PLAIN, HEXAGON FIXED MAST PAHZZ MS WASHER, LOCK FIXED MAST XBHZZ MASTIFIXED XBHZZ AN505UB SCREW, MACHINE BEARING PAD TO MAST XAHZZ PAD, BEARING TOP FIXED MAST XBHZZ SHIM BEARING PAD TO MAST PFHZZ SCREW SPECIAL FIXED MAST PAHZZ MS WASHERIFLAT BEARING PAD TO MAST PAHZZ M5S WASHER, LOCK BEARING PAD TO MAST PAHZZ MS NUT,PLAIN, HEXAGON BEARING PAD TO... 4 MAST... END OF FIGURE 47-2

121 TM P FIGURE 48. LIFT FORK CARRIER

122 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 48 LIFT FORK CARRIER 1XBHZZ SCREW, CAP, SOCKET MODIFIED, STOP PAHZZ MS RING, RETAINING ROLLER RETAINER PAHZZ BEARING, BALLIANNULA XDHZZ BEARINGISIDE PAHZZ DISK, BACKUP SIDE BEARING XBHZZ CARRIER, FORK PAHZZ MS SETSCREW SIDE BEARING ADJUSTING... 4 END OF FIGURE 48-1

123 TM P FIGURE 49. HYDRAULIC FILTER.

124 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES, AND FITTINGS, ETC. FIG. 49 HYDRAULIC FILTER 1 PAOZZ BUSHING,PIPE TUBE TO FILTER PAOZZ AN ADAPTER,STRAIGHT,PI FILTER INLET MOOZZ TBD TUBE OIL FILTER TO RESERVOIR,MAKE... 1 FROM TUBE,P/N PAOZZ NUT, SLEEVE PAOZZ MS NUT TUBE COUPLING PAOZZ MS SLEEVE,TUBE NUT XDOZZ TUBE, STEEL, 13 IN MOOZZ TBD TUBE OIL FILTERIMAKE FROM TUBE,P/N PAOZZ NUT, SLEEVE PAOZZ TUBE, METALLIC PAOZZ MS ELBOW,PIPE TO TUBE FILTER TO... 1 RESERVOIR LINE. 12 PAOZZ MS SCREW,CAP,HEXAGON H FILTER MOUNTING PAOZZ AN WASHER, LOCK FILTER MOUNTING PAOZZ OFM FILTER, FLUID PAOZZ POPPET,CHECK VALVE XDOZZ SPRING, HELICAL COMP PAOZZ WASHER,FLAT XDOZZ RING RETAINING SPRING AND POPPET XDOZZ BASE PAOZZ CH331PL FILTER ELEMENT,FLUI PAOZZ SPRING,HELICAL,COMP ELEMENT PFOZZ BODY PFOZZ BOLT,EXTERNALLY REL XDOZZ WASHER... 1 END OF FIGURE 49-1

125 TM P FIGURE 50. HYDRAULIC LINES AND FITTINGS

126 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES, AND FITTINGS, ETC. FIG. 50 HYDRAULIC LINES AND FITTINGS 1 XBOZZ TIE, WRAP LOCK HYDRAULIC LINES PAOZZ HOSE ASSEMBLY STACK VALVE TO TILT... 1 CYLINDER... 3 PAOZZ FITTING, HOSE PAOZZ SA9 TEE, TUBE TO BOSS TILT CYLINDER,... 2 RIGHT SIDE... 5 PAOZZ R3 PACKING,PREFORMED TILT CYLINDER... 4 CONNECTIONS... 6 PAOZZ HOSE ASSEMBLY, NONME STACK VALVE TO... 1 TILT CYLINDER... 7 XAOZZ ORIFICE PAOZZ FITTING, HOSE XBFZZ ELBOW OUTLET TO STACK VALVE XBFZZ ELBOW INLET, FROM RESERVOIR XBFZZ REDUCER INLET FOR ELBOW XDOZZ HOSE ASSEMBLY PUMP TO RESERVOIR XDOZZ BE12-12NJ FITTING HOSE XDOZZ HOSE ASSEMBLY STACK VALVE TO... 1 FILTER AND STEERING BOOSTER XDOZZ FITTING HOSE XDOZZ TEE, TUBE STEERING BOOSTER TO... 1 FILTER AND STACK VALVE PAOZZ MS51500A8-8 ADAPTER, STRAIGHT, PI STEERING... 1 BOOSTER TO FILTER AND STACK VALVE XDOZZ HOSE ASSEMBLY BOOSTER TO FILTER... 1 AND STACK VALVE PAOZZ ADAPTER, STRAIGHT, TU XDOZZ SALX6 ELBOW, TUBE TO BOSS STEERING BOOSTER PAOZZ R3 PACKING, PREFORMED BOOSTER... 2 CONNECTIONS XDOZZ HOSE ASSEMBLY STACK VALVE TO... 1 STEERING BOOSTER PAOZZ ADAPTER STRAIGHT, TU PAOZZ M551527A6 ELBOW, TUBE TO BOSS STEERING BOOSTER XDOZZ SA6 ELBOW, PIPE TO TUBE TANK LINE PFOZZ HOSE ASSEMBLY, NONME TILT CYLINDER... 1 CONNECTING, REAR PAOZZ FITTING, HOSE PFOZZ HOSE ASSEMBLY, NONME TILT CYLINDER... 1 CONNECTING, FRONT PAOZZ FITTING, HOSE PAOZZ MS51527-A6 ELBOW, TUBE TO BOSS TILT CYLINDER,... 2 LEFT SIDE XDOZZ HOSE ASSEMBLY STACK VALVE TO PUMP XDOZZ FITTING HOSE PAOZZ MS NIPPLE, TUBE PUMP LINE MOOZZ TBD TUBE ASSEMBLY PUMPLINE HOSE TO

127 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY STACK VALVE,MAKE FROM TUBE P/N PAOZZ NUT, SLEEVE XDOZZ PIPE, STEEL10 IN PAOZZ OSW6 ELBOW, TUBE LIFT CYLINDER LINE XDOZZ ORIFICE, NOZZLE PAOZZ SA2 ADAPTER, STRAIGHT TU LIFT CYLINDER PAOZZ OR3 PACKINGPREFORMED PAOZZ MS NIPPLE, TUBE LIFT CYLINDER MOOZZ TBD TUBE ASSEMBLY HOSE TO LIFT... 1 CYLINDER, MAKE FROM PIPE, P/N XDOZZ TUBE, STEEL, 14 IN PAOZZ NUT, SLEEVE PAOZZ HOSE ASSEMBLY, NONME XDOZZ FITTING HOSE MOOZZ TBD TUBE ASSEMBLY LIFT CYLINDER TO... 1 STACK VALVE, MAKE FROM TUBE, P/N 1353A 48 PAOZZ MS NUT, TUBE COUPLING PAOZZ TUBE, STEEL, 11 IN PAOZZ NUT, SLEEVE PAOZZ MS SLEEVE, TUBE NUT PAOZZ MS ELBOW, PIPE TO TUBE XDOZZ ELBOW, PIPE TO TUBE STACK VALVE XDOZZ ELBOW, PIPE TO TUBE VALVE, STACK... 1 PUMP LINE PAOZZ PLUG, PIPE PUMP TO STACK VALVE LINE... 1 END OF FIGURE 50-2

128 TM P SECTION II FIGURE 51. HYDRAULIC RESERVOIR

129 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2408 LIQUID TANKS OR RESERVOIRS FIG. 51 HYDRAULIC RESERVOIR 1 XBFZZ RESERVOIR ASSEMBLY HYDRAULIC FLUID PAOZZ A1OOW PARTS KIT, HYDRAULIC XBOZZ A100-1W CAP ASSEMBLY XDOZZ A100-2 ADAPTER PAOZZ A100-4 GASKET FILTER MOUNTING TO ACCESS... 2 COVER... 6 PAOZZ A100-3 SCREEN, FILTER WITH MOUNTING... 1 FLANGE... 7 PAOZZ MS PLUG, PIPE RESERVOIR XDOZZ L SWITCH, THERMOSTATIC HYDRAULIC TANK PAOZZ MS WASHER, LOCK THERMOSTAT TO... 4 RESERVOIR PAOZZ AN SCREW, ROUNDHEAD THERMOSTAT TO... 4 RESERVOIR PAOZZ F12300 BOOT, DUST AND MOIST THERMOSTAT 2 COVER PAFZZ AN ADAPTER, STRAIGHT, PI FILTER TO... 1 RESERVOIR XBFZZ PC12 REDUCER SUMP FILTER PAFZZ M306 FILTER ELEMENT, FLUI PAOZZ GASKET ACCESS COVER TO RESERVOIR XBOZZ COVER, ACCESS PAOZZ MS WASHER, LOCK ACCESS COVER TO... 4 RESERVOIR XBOZZ AN SCREW, MACHINE ACCESS COVER TO... 4 RESERVOIR PADZZ MS SCREW, TAPPING FILTER TO TANK PAFZZ MS WASHER, FLAT RESERVOIR MOUNTING PAFZZ AN WASHER, LOCK RESERVOIR MOUNTING PAFZZ MS SCREW, CAP, HEXAGON H RESERVOIR... 4 MOUNTING END OF FIGURE 51-1

130 TM P SECTION II FIGURE 52. HOURMETER

131 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 47 GAGES (NONELECTRICAL), WEIGHING AND MEASURING DEVICES GROUP 4703 HOURMETER FIG. 52 HOURMETER 1 PAOZZ MS SCREW, MACHINE HOURMETER MOUNTING XDOZZ GASKET HOURMETER MOUNTING PAOZZ M3971/1-5 METER, TIME TOTALIZI PAOZZ MS WASHER, LOCK HOURMETER MOUNTING PAOZZ MS NUT, PLAIN, HEXAGON HOURMETER... 3 MOUNTING END OF FIGURE 52-1

132 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 94 REPAIR KITS GROUP 9401 REPAIR KITS FIG. KITS PAFZZ FC11301 PARTS KIT MASTER BRAKE CYLINDER... 1 BOOT (1) 25-5 XDFZZ KIT,REPAIR TILT CYLINDER... 2 BUSHING (2) 44-7 O-RING (2) RING (2) SEAL (2) SEAL (2) 44-4 WIPER (2) PAFZZ PARTS KIT,HYDRAULIC LIFT CYLINDER... 1 O-RING (1) 46-8 RETAINER (1) SEAL SET (1) SEAL SET (1) RING (1) 46-7 SLEEVE (1) WIPER (1) WIPER (1) PAFZZ KIT, CYLINDER BRAKE... 2 BOOT (4) CUP (4) PISTON (4) SPRING (2) PAFZZ KIT REPAIR CONTACTO FORWARD 1 REVERSE CONTACTOR... 1 CONTACT (8) 4-7 LEAD (2) 4-36 SPRING (2) 4-43 SWITCH (2) 4-35 PAFZZ KIT,REPAIR 1A CONTACTOR... 1 CONTACT (2) 6-15 LEAD (1) 6-40 SPRING (1) 6-37 SPRING (1) 6-18 SWITCH (1) 6-39 PAFZZ KIT,REPAIR LINE AND PUMP CONTACTOR... 2 CONTACT (4) 5-13 LEAD (2) 5-39 SPRING (1) 5-36 PAFZZ PACKING ASSORTMENT STEERING... 1 O-RING (1) O-RING (1) O-RING (1) RING (1) SEAL (3) PAFZZ PARTS KIT STEERING... 1 KITS-1

133 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY RETAINER (1) RING (1) SCRAPER (1) SEAL (1) SNAP RING (1) WASHER (1) PAFZZ KIT,SEAL STACK VALVE... 1 O-RING (2) O-RING (2) QUAD RING (2) QUAD RING (2) 16-4 RETAINER (1) RING (2) 16-5 SEAL (1) RING (2) SEAL (1) SEAL (1) PAFZZ PARTS KIT,ROTARY PU... 1 KIT,VANE (1) 42-2 O-RING (2) 42-5 RING (1) 42-4 ROTOR (1) 42-3 END OF FIGURE KITS-2

134 (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 95 GENERAL USE STANDARDIZED PARTS GROUP 9501 BULK MATERIEL FIG. BULK 1 PAOZZ CABLE,ELECTRICAL AWG NO.25 FEET... V REQUIRERD FOR EACH CABLE... 2 PAOZZ CORD ELECTRICAL... V 3 XDOZZ TUBE METAL... V 4 XDOZZ K P4 WIRE,ELECTRICAL REQUIRED FOR EACH... V LEAD... END OF FIGURE BULK-1

135 SECTION IV CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-1

136 SECTION IV CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS BULK I-2

137 SECTION IV CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM BULK I-3

138 SECTION IV CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS KITS I-4

139 SECTION IV CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM B KITS KITS KITS KITS I-5

140 SECTION IV CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-6

141 SECTION IV CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS I-7

142 SECTION IV CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM S I-8

143 SECTION IV CROSS-REFERENCE INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS KITS I-9

144 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM ACK ACK AM1OO AN178H13A AN AN505UB AN505UB AN AN AN AN AN AN AN AN AN AN AN A1-3761E A100-1W AIOO AO A A100W A A2747C A A A A3722A BACPllS BE12-12NJ BH BK75S L I-10

145 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM BZE6-2RN BZE6-2RQ B12RN BZ2RQ B R B CD3A2870D7GI CH331PL CMllNOIR17D CMllNO1R17T CMllNO1R17TDE CR2940UM200AC CSA C C C C C C C C C C C C C C C C C C C211-5A C211-5B C211-55A C211-55B C211-8A C211-8B ES176R FC-5735-D FC FC KITS FC FC

146 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM FC FC FC FC FD FF F[ FO2AI25VlOAS F F IC2800M120A IC2800M120A IC2800M124A412X IC3012BH733AE IC4484A JHP KG V K K K P4 BULK K G K G LCO59G12MW LE069F8MW LE069FIMW LHTE LM LM LW MH MS MS MS MS MS MS MS MS

147 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS C MS C MS20426A MS20426A MS MS MS S MS21044N MS21044N MS21044N MS21044N MS MS21919G MS MS MS MS MS MS

148 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS NS MS MS MS MS MS MS MS MS MS MS MS

149 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS I-15

150 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS I-16

151 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS I-17

152 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS

153 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS M5S MS MS MS MS MS MS MS MS MS MS I-19

154 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS NS MS MS MS MS MS MS MS MS MS MS MSS51500A MS51527-A MS51527A M5S MS MS MS MS MS MS MS MS MS MS M5S MS MS I-20

155 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MHS MS MS MS MS MS MS MS MS MS MS MS M5S MS MS MS MS I-21

156 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS M C M M3971/ NAS NL N11O N N179P2105B N N26P N26P N26P23008B N26P23008C I-22

157 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM N26P23008C N3400P N401P N N57P16064B N57P16074B N57P21010B N57P9018B PPB RV SA SCD SN SV S S80OA TBD TSC TT TYPESJO WA WW-P-471ACABCA ZZ-T OFM C2800M120K412X C4483F273X670G ID154G32A ld154g33a I-23

158 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM SA SW R ABC B A8C ABC ABC A4259P J PC D395BC D395UEG H N Y D V S C B5712P P P G G G P X X I-24

159 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A G G B3008P X A1247P A7814P A7816P A7822P A A A B2744G B2895P A299G A A8482P A5789G A8468P A8468P4 3 6 I-25

160 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A9807P A9807P A A9938P X B1956P D M C869P C869P M D W A A3197P A5694P T D Y W Y D Z Q R C H A5137P A5258P A6348P A6348P C C C E E F J I-26

161 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM K A7547P A7582P A W L A4008P A4009PL A4760P A5943P A5963G A5968P A5981P A5981P A5981P A5981P A5986G A7104G A7105P A7105P A7130P A7156P A7157P A7159G A7162G Y I-27

162 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM T MS A8326G B316P B316P X S50A XSP VN I-28

163 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A A A A A L Kll N P Y Z N P X R850X M I-29

164 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM C479G C553G C553G B3X B8G C1G C3G C5G C9X DlG X D24G D5G D5G X X X X X X X X D3X PPFS BULK F L A A280790G A280790G A I-30

165 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A AE A A J TB X L R J D J L M R X X X BULK I-31

166 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM BULK I-32

167 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM SP N KITS I-33

168 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM KITS KITS KITS KITS KITS I-34

169 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM I-35

170 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A389P A392P A A552P B PA SA R C X WR X R C400AC SA SALX R I-36

171 SECTION IV CROSS-REFERENCE INDEXES PART NUMBER INDEX CAGEC PART NUMBER STOCK NUMBER FIG. ITEM P K C K P KITS KITS KITS KITS E ED MDJ B P P G G P I-37

172 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER BULK BULK BULK BULK K P4 KITS KITS FC11301 KITS KITS KITS KITS KITS KITS KITS KITS KITS MS MS MS MS LE069F8MW MS MS MS MS PPB A IC3012BH733AE B1956P A7157P MS A4009P MS A3197P MS MS MS B3008P MS MS MS21044N MS MS N179P2105B MS I-38

173 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER A7156P A4008P C869P MS MS N57P21010B C869P A6348P A6348PI A5694P MS MS B2895P A7159G A7159G S800A MS MS A5943P MS MS A7162G MS MS MS A5258P A8468P MS C4483F273X670G l51a1247p MS MS N57P9018B A8468P A7105P MS MS MS MS MS A A5981P MS MS MS MS A5986G MS MS MS A7547P1 I-39

174 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER N57P16074B JHP MS A5137P A7130P MS MS A4760P A392P A389Pl R IC4484A N57P MS MS A7104G A5981P A5981P MS MS A7105P MS MS MS G MS MS A5963G A5981P MS MS MS N26P21008B A7582PI S MS MS MS MS AN M5S MS [C2800M124A412X A9807P B5712P B5712P A5789G M C MS I-40

175 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER P MS MS N26P N26P23008B MS MS P A MDJ A MS A9938P MS MS MS MS MS MS P A7816P MS MS MS A4259P G MS MS M5S MS LHTE A7822P A MS N26P23008B MS AN N26P21010B A5968P B5713G G A552P P G32A A7814P P MS MS I-41

176 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS MS MS MS P B5713G MS P MS MS MS IC2800M120A lc2800m120a A9807PL MS MS MS N26P23008B MS B5712P B316P A5789G M C MS P MDJ MS A A9938P A7814P MS P B5713G B5713G MS MS MS M MS MS M5S MS LHTE A7822P A A552P G N26P MS MS I-42

177 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS N26P23008B A5968P P G32A G33A MS MS MS MS N401P G A8482P MS A9807P A8326G MS MS MS MS MS C2800M120K412X P A9807P MS MS MS MS N26P23008B A5789G M C MS B5712P G32A P A MS A A9938Pl N401P MS MS MS A552P MS MS MS MS A7816P MS I-43

178 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS MS LHTE A A7822P A4259P G MS MS MS N26P P MS MS N26P21010B A5968P P B5713G G A7814P G A9807P MS A8482P MS A8326G MS MS B316P MS ACK MS MS MS MS MS MS TBD ACK MS FFB I-44

179 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS MS MS MS MS MS MS MS MS MS MS AN MS MS AN VN MS MS MS MS TB MS M5S MS MS B6203G MS MS F02A125VIOAS B6203G KG V MS MS MS I-45

180 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS MS A MS MS MS MS AN MS CR2940UM200AC MS MS MS MS MS MS MS MS MS S50A JHP TBD MS MS B6203G BZE6-2RQ R TYPESJO MS MS MS MS MS DD MS MS MS TBD I-46

181 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS MS MS MS MS MS MS MS AN MS MS TSC SP MS20426A MS20426A MS A A MS B TBD A A MS MS TBD MS LC059G12MW TBO C03A287007G C5G K X2 I-47

182 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER D5G X TBD X SA D5G X D1G C3G MS MS MS D24G D23X MS MS MS G C9X MS AN X X MS AN X X MS CIG MS AN MS MS BZE6-2RQ BZ2RQ MS MS MS MS CMllNO1R17TDE I-48

183 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER CM11NO1RI7D MS CMllNO1R17T MS MS MS MS MS MS K C C MS X J N MS E F A A X P S I-49

184 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER R X MS MS N11O-I Y N H Z L S F LW X X Y N Y R A RV N P C D W Y W MS S H Z T MS MS S MS MS MS MS L I-50

185 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER FI A280790G MS MS MS MS A MS C479G B N K GO A B349E B349ED PPFS MS MS B545821AE AN MS A K MS MS A C A A299G A MS MS C553G MS MS N26P23008C BC A280790G MS MS MS MS MS K G C553G I-51

186 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS MS MS M MH MS TT MS MS MS MS MS21044N AN178Hl3A B MS MS MS A A MS A MS T MS MS MS MS

187 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS MS MS MS M5S K MS M5S A M A3722A L MS MS M3? WA MS A2747C J Kll NAS FC-5735-D FC AN X MS MS21919G X F FC FD FC M5S AN MS J686 I-53

188 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER C K R850X M L E M D A1-3761E FC FC FC FC MS MS LEO69FlMW MS MS BK A BZE6-2RN PA BZ2RN M MS M M MS MS X M MS MS LM LM X L Q R MS I-54

189 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER D SN J X Y J NL MS X MS X MS MS V MS N M ZZ-T MS MS BZE6-2RN BZ2RN PA MS21044N MS MS X MS W I-55

190 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER X N MS21044N M M M MS MS MS MS M MS MS M5S MS MS I-56

191 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS MS AM MS CSA AN MS MS MS MS MS MS MS M ES176R MS MS MS AN MS MS MS I-57

192 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS M5S MS MS MS JHP M MS MS MS MS M5S MS C MS M5S M MS MS WR MS M5S MS C XSP K AN MS BK75S MS MS MS lA MS A I-58

193 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS BK75S MS MS MS MS MS A MS SZE6-2RN D MS MS AN C MS C MS MS MS A MS MS MS MS MS MS M M BACP MS I-59

194 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS SCD MS MS MS L F A280790G MS S MS MS MS A A280790G MS N ED ED N3400P PPFS MS MS C400AC H A C A AN K MS MS MS MS C553G MS MS I-60

195 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER A299G A A MS N26P23008C MS D395UEG MS A280790G MS MS MS MS K G C553G MS MS MS MS MS C C MS C MS C C MS C C C C C C MS AN MS MS MS MS I-61

196 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS MS MS AN MS ABC ABC ABC B ABC C MS WW-P-471ACABCA C C C211-8A C211-55A C C C211-55B MS C211-8B C211-5B C C MS C211-SA BL MS MS SV MS21044N AN505UB MS MS I-62

197 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS MS MS MS MS MS MS AN505UB MS MS MS MS MS AN505UB MS MS MS MS MS AN TBD MS MS I-63

198 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER TBD MS MS AN OFM CH331PL A R BE12-12NJ MS51500A SALX R MS51527A SA MS51527-A MS TBD I-64

199 SECTION IV CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER SW SA R MS TBD TBD MS MS MS A100W A100-1W A A A MS L MS AN F AN PC M MS ANS MS MS AN MS MS M3971/ MS MS I-65

200 By Order of the Secretary of the Army: GORDON R. SULLIVAN General, United States Army Chief of Staff Official MILTON H. HAMILTON Administrative Assistant to the Secretary of the Army Distribution: To be distributed in accordance with DA Form E, Block 5975, requirements for TM P. U S GOVERNMENT PRINTINC OFFICE /80071

201

202 PIN:

203 This fine document... Was brought to you by me: Liberated Manuals -- free army and government manuals Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap watermarks and other junk on it, and sell it. Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it... They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends? I am setting this document FREE. This document was made by the US Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on. I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines: <A HREF= Military and Government Manuals</A> Sincerely Igor Chudov Chicago Machinery Movers