TECHNICAL MANUAL ORGANIZATIONAL MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS

Transcription

1 TECHNICAL MANUAL ORGANIZATIONAL MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS NON-TILT MIXER, CONCRETE NSN T. L. SMITH COMPANY MODEL 499A HEADQUARTERS, DEPARTMENT OF THE ARMY 21 JANUARY 1985

2 * TECHNICAL MANUAL HEADQUARTERS DEPARTMENT OF THE ARMY Washington, D.C. 21 January 1985 ORGANIZATIONAL MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS NON-TILT MIXER, CONCRETE NSN T.L. SMITH COMPANY MODEL 499A Current as of 18 May 1984 REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this manual. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Mail your letter, DA Form 2028 (Recommended Changes to Publications and Blank Forms), or DA Form located in back of this manual direct to: U.S. Army Tank-Automotive Command, ATTN: AMSTA- MB, Warren, MI A reply will be furnished to you. TABLE OF CONTENTS Page SECTION I. INTRODUCTION 1 SECTION II. REPAIR PARTS LIST 7 Illus Fig GROUP 01 ENGINE 0101 CRANKCASE, BLOCK, CYLINDER HEAD... 7 CRANKCASE ASSEMBLY CYLINDER HEAD,, VALVE COVER AND MAIN BEARING FLYWHEEL ASSEMBLY * This publication supersedes TM P dated 6 March 1972 and all changes. i

3 TABLE OF CONTENTS Page Illus Fig FLYWHEEL AND RING GEAR VALVES, CAMSHAFTS AND TIMING SYSTEM TIMING COVER ENGINE LUBRICATION SYSTEM OIL PAN AND CRANKCASE COVER OIL FILTER COMPONENTS OIL LINES AND FITTINGS ENGINE STARTING SYSTEMS HAND CRANK MOUNTING HARDWARE MANIFOLDS MANIFOLD GROUP 02 CLUTCH 0200 CLUTCH ASSEMBLY CLUTCH ASSEMBLY GROUP 03 FUEL SYSTEM 0301 CARBURETOR, FUEL INJECTOR CARBURETOR ASSEMBLY FUEL PUMPS FUEL PUMP ADAPTER COVER AIR CLEANER AIR CLEANER AND HOSE TANKS, LINES, FITTINGS, HEADERS FUEL TANK AND SUPPORTS ENGINE SPEED GOVERNOR AND CONTROLS GOVERNOR CONTROL GOVERNOR LINKAGE FUEL FILTERS FUEL FILTER ASSEMBLY ACCELERATOR, THROTTLE OR CHOKE CONTROLS CHOKE CONTROL GROUP 04 EXHAUST SYSTEM 0401 MUFFLER AND PIPES MUFFLER AND ADAPTER GROUP 05 COOLING SYSTEM 0502 COWLING, DEFLECTORS, AIR DUCTS, SHROUDS, ETC AIR SHROUDS WATER PUMP WATER PUMP GROUP 06 ELECTRICAL SYSTEM 0601 GENERATOR, ALTERNATOR ALTERNATOR ASSEMBLY GENERATOR REGULATOR ALTERNATOR REGULATOR STARTING MOTOR STARTING MOTOR STARTER MOUNTING AND WIRING ii

4 TABLE OF CONTENTS Page Illus Fig 0605 IGNITION COMPONENTS MAGNETO, SPARK PLUGS AND LEADS MAGNETO ASSEMBLY MAGNETO ROTOR INSTRUMENT OR ENGINE CONTROL PANEL INSTRUMENT PANEL SENDING UNITS AND WARNING SWITCHES HI TEMPERATURE AND FUEL SENDING UNITS BATTERIES, STORAGE BATTERY AND BOX CHASSIS WIRING ENGINE WIRING GROUP 10 FRONT AXLE 1004 STEERING AND LEANING WHEEL MECHANISM STEERING KNUCKLE GROUP 13 WHEELS AND TRACKS 1311 WHEEL ASSEMBLY HUB AND WHEEL TIRES, TUBES, TIRE CHAINS TIRE AND TUBE GROUP 15 FRAME, TOWING ATTACHMENTS, AND DRAWBARS 1501 FRAME ASSEMBLY LOWER FRAME GROUP 18 BODY, CAB, HOOD AND HULL 1801 BODY, CAB, HOOD AND HULL ASSEMBLIES ENGINE HOUSING ENGINE COVERS AND SIDE PANELS ENGINE PLATFORM AND SPLASH GUARDS STOWAGE RACKS, BOXES, STRAPS, CARRYING CASES, CABLE REELS, HOSE REELS, ETC TOOL BOX AND MOUNTING HARDWARE GROUP 47 GAGES (NON ELECTRICAL) 4701 INSTRUMENTS (SPEED AND DISTANCE) HOURMETER TACHOMETER GROUP 73 CONCRETE AND ASPHALT EQUIPMENT COMPONENTS 7301 POWER LOADER SKIP POWER LOADING SKIP UPPER HOIST DRUMS DRUM ROLLERS CONTROLS, MACHINERY CONTROLS AND OPERATING LEVERS VIBRATOR AND BEARING MAIN DRIVE HOIST ASSEMBLY iii

5 TABLE OF CONTENTS Page Illus Fig DRIVE ASSEMBLY DRIVE SHEAVE AND GUARD POWER TAKE OFF ASSEMBLY FEEDER OR CONVEYOR DISCHARGE DISCHARGE UNIT WATER SYSTEM WATER TANK ASSEMBLY WATER SYSTEM GROUP 76 FIRE FIGHTING EQUIPMENT 7638 PORTABLE FIRE FIGHTING EQUIPMENT FIRE EXTINGUISHER MOUNTING SECTION III. SPECIAL. TOOLS LIST (NOT APPLICABLE) SECTION IV. NATIONAL STOCK AND 121 PART INDEX iv

6 ORGANIZATIONAL MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS 1. Scope. SECTION I INTRODUCTION This manual lists and authorizes spares and repair parts; special tools; special Test, Measurement, and Diagnostic Equipment (TMDE); and other special support equipment required for performance of organizational support maintenance of the Non-Tilt Mixer, Concrete. It authorizes the requisitioning, issue, and disposition of spares, repair parts and special tools as indicated by the Source, Maintenance and Recoverability (SMR) codes. 2. General. This Repair Parts and Special Tools List is divided into the following sections: a. Section II. Repair Parts List. A list of spares and repair parts authorized by this RPSTL for use in the performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in ascending alphanumeric sequence, with the parts in each group listed in ascending figure and item number sequence. Bulk materials are listed in NSN sequence. b. Section III Special Tools List. A list of special tools, special TMDE, and other special support equipment authorized by this RPSTL for the performance of maintenance. c. Section IV. National Stock Number and Part Number Index. A list, in National Item Identification Number (NIIN) sequence, of all National Stock Numbers (NSN) appearing in the listings, followed by a list in alphanumeric sequence of all part numbers appearing in the listings. National stock numbers and part numbers are cross-referenced to each illustration figure and item number appearance. 3. Explanation of Columns. a. Illustration (Column (1)). This column is divided as follows: (1) ((a) FIG ) Figure Number. Indicates the figure number illustrating an exploded view of a functional group. (2) ((b) ITEM ). Indicates the number used to identify items called out in the illustration. b. SMR (Column (2)). The Source, Maintenance, and Recoverability (SMR) code is a 5-position code containing supply/requisitioning information, maintenance category authorization criteria, and disposition instructions, as shown in the following breakout: Source Code XX How you get an item Maintenance Code 1st two positions 3d position Who can install, replace or use the item XX Recoverability Code X Who determines disposition action on an unserviceable item 4th position Who can do complete repair* on the item 5th position *Complete Repair: Maintenance capacity, capability, and authority to perform all the corrective maintenance tasks of the "Repair" function in a use/user environment in order to restore serviceability to a failed item. 1

7 (1) Source Code. The source code tells you how you get an item needed for maintenance, repair, or overhaul of an end item/equipment. Source codes are always the first two positions of the SMR code. Explanations of source codes follow: PA PB PC PD PE PF PG KD KF KB Code Explanation Stocked items; use the applicable NSN to request/requisition items with these source codes. They are authorized to the category indicated by the code entered in the 3d position of the SMR code. Items with these codes are not to be requested/requisitioned individually. They are part of a kit which is authorized to the maintenance category indicated in the 3d position of the SMR code. The complete kit must be requisitioned and applied. MO-(Made at Org Category) MF-(Made at DS Category) MH-(Made at GS Category) MD-(Made at Depot) Items with these codes are not to be requested/requisitioned individually. They must be made from bulk material which is identified by NSN in the Description column and listed in the Bulk Material group in the repair parts list in this manual. If the item is authorized to you by the 3d position code of the SMR code, but the source code indicates it is made at a higher category, order the item from the higher category of maintenance. AO-(Assembled by Org Category AF-(Assembled by DS Category AH- (Assembled by GS Category AD- (Assembled by Depot) Items with these codes are not to be requested/requisitioned individually. The parts that make up the assembled item must be requisitioned or fabricated and assembled at the category of maintenance indicated by the source code. If the 3d position code of the SMR code authorizes you to replace the item, but the source code indicates the item is assembled at a higher category, order the item from the higher category of maintenance XA XB XC XD Do not requisition an "XA"-coded item. Order its next higher assembly. (Also, refer to the NOTE below.) If an "XB" item is not available from salvage, order it using the FSCM and part number given. Installation drawing, diagram, instruction sheet, field service drawing, that is identified by manufacturer's part number. Not applicable. Item is not stocked. Order an "XD"-coded item through normal supply channels using the FSCM and part number given, if no NSN is available. NOTE: Cannibalization or controlled exchange, when authorized, may be used as a source of supply for items with the above source codes, except for those source coded "XA". (2) Maintenance Code. Maintenance codes tell you the category(s) of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of the SMR Code as follows: (a) The maintenance code entered in the third position tells you the lowest maintenance category authorized to remove, replace, and use an item. The maintenance code entered in the third position will indicate authorization to one of the following categories of maintenance. 2

8 Code Application/Explanation C - Crew or operator maintenance done within organizational maintenance. O - Organizational category can remove, replace, and use the item. (b) The maintenance code entered in the fourth position tells you whether or not the item is to be repaired and identifies the lowest maintenance category with the capability to do complete repair (i.e., perform all authorized repair functions). (NOTE: Some limited repair may be done on the item at a lower category of maintenance, if authorized by the Maintenance Allocation Chart (MAC) and SMR codes.) This position will contain one of the following maintenance codes. Code Application/Explanation O - Organizational is the lowest category that can do complete repair of the item. F - Direct support is the lowest category that can do complete repair of the item. H - General support is the lowest category that can do complete repair of the item. L - Specialized repair activity is the lowest category that can do complete repair of the item. D - Depot is the lowest category that can do complete repair of the item. Z - Nonreparable. No repair is authorized. B - No repair is authorized. (No parts or special tools are authorized for the maintenance of a "B" coded item.) However, the item may be reconditioned by adjusting, lubricating, etc., at the user level. (3) Recoverability Code. Recoverability codes are assigned to items to indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the SMR code as follows: Recoverability Definition Codes Z - Nonreparable item. When unserviceable, condemn and dispose of the item at the category of maintenance shown in 3d position of SMR code. O - Reparable item. When uneconomically reparable, condemn and dispose of the item at organizational category. F - Reparable item. When uneconomically reparable, condemn and dispose of the item at the direct support category. H - Reparable item. When uneconomically reparable, condemn and dispose of the item at the general support category. D - Reparable item. When beyond lower category repair capability, return to depot. Condemnation and disposal of item not authorized below depot category. L - Reparable item. Condemnation and disposal not authorized below specialized repair activity. A - Item requires special handling or condemnation procedures because of specific reasons (i.e., precious metal content, high dollar value, critical material or hazardous material). Refer to appropriate manuals/directives for specific instructions c. NATIONAL STOCK (Column (3)). Lists the National Stock Number (NSN) assigned to the item. Use the NSN for requests/requisitions. d. FSCM (Column (4)). The Federal Supply Code for Manufacturer (FSCM) is a 5-digit numeric code which is used to identify the manufacturer, distributor, or Government agency, etc., that supplies the item. e. PART (Column (5)). Indicates the primary number used by the manufacturer (individual, 3

9 company, firm, corporation, or Government activity), which controls the design and characteristic of the item by means of its engineering drawings, specifications standards, and inspection requirements to identify an item or range of items. NOTE: When you use an NSN to requisition an item, the item you receive may have a different part number from the part ordered, but go ahead and use or furnish it as the replacement part. f. DESCRIPTION (Column (6)). This column includes the following information: (1) The Federal item name and, when required, a minimum description to identify the item. (2) The physical security classification. Not applicable. (3) Items that are included in kits and sets are listed below the name of the kit or set. (4) Spare/repair parts that make up an assembled item are listed immediately following the assembled item line entry. If the first item of a figure is indented, the assembly appears as the last item in the previous figure. (5) NSN's for bulk materials are referenced in the description column in the line item entry for the item to be manufactured/fabricated. (6) When the part to be used differs between serial numbers of the same model, the effective serial numbers are shown as the last line of the description. (7) The USABLE ON. Not applicable. (8) In the Special Tools List section, the Basis Of Issue (BOI) appears as the last line(s) in the entry for each special tool, special TMDE, and other special support equipment. When density of equipments supported exceeds density spread indicated in the basis of issue, the total authorization is increased proportionately. g. U/M (Column (7)). The Unit of Measure (U/M) indicates the measure (e.g., foot, gallon, pound) or count (e.g., each, dozen, gross) of a listed item. A two-character alpha code (e.g., FT, GL, LB, EA, DZ, GR) appears in this column to indicate the measure or count. If the U/M code appearing in this column differs from the Unit of Issue (U/l) code listed in the Army Master Data File (AMDF), request the lowest U/l that will satisfy your needs. h. QTY INC IN UNIT (Column (8)). The Quantity Incorporated in Unit QTY INC IN UNIT) indicates the quantity of the item used in the breakout shown on the illustration figure, which is prepared for a functional group, subfunctional group, or an assembly. A "V" appearing in this column in lieu of a quantity indicates that no specific quantity is applicable (e.g., shims, spacers). 4. SPECIAL INFORMATION. a. Bulk materials required to manufacture items are listed in the Bulk Material Group of this manual. NSN's for bulk materials are also referenced in the description column of the line item entry for the item to be manufactured/fabricated. Detailed manufacturing instructions for items source coded to be manufactured or fabricated are found in TM b. Detailed assembly instructions for items source coded to be assembled from component spare/repair parts are found in TM Items that make up the assembly are listed immediately following the assembled item entry. c. Line item entries for repair parts kits and sets appear as the last entries in the repair parts listing for the figure in which their parts are listed as repair parts. d. Items which have the word BULK in the figure number column will have an index number shown in the item number column. This index number is furnished for use as a cross-reference between the National Stock Number/Part Number Index and the Bulk Material List in Section II. 4

10 e. The following publications pertain to the Non-Tilt Mixer, Concrete, and its components: TM Non-Tilt Mixer, Concrete, Model 499A TM Non-Tilt Mixer, Concrete, Model 499A TM P Non-Tilt Mixer, Concrete, Model 499A LO Non-Tilt Mixer, Concrete, Model 499A LO Non-Tilt Mixer, Concrete, Model 499A f. The illustrations in this manual are identical to those published in the TM P. Only those parts coded "C" or "O" in the third position of the SMR code are listed in the tabular listing; therefore, there may be a break in the item number sequence. Only illustrations containing organizational unit authorized items appear in this manual. 5. How to Locate Repair Parts. a. When National Stock Number or Part Number is Not Known: (1) First. Using the table of contents, determine the functional group to which the item belongs. This is necessary since figures are prepared for functional groups, and listings are divided into the same groups. (2) Second. Find the figure covering the functional group to which the item belongs. (3) Third. Identify the item on the figure and note the item number of the item. (4) Fourth. Refer to the Repair Parts List for the figure to find the line item entry for the item number noted on the figure. b. When National Stock Number or Part Number is Known: (1) First.: Using the Index of National Stock Numbers and Part Numbers, find the pertinent national stock number or part number. The NSN Index is in National Item Identification Number (NIIN)* sequence. The part numbers in the Part Number Index are listed in ascending alphanumeric sequence. Both indexes cross-reference you to the illustration figure and item number of the item you are looking for. *The NIIN consists of the last 9 digits of the NSN NSN (i.e., ) NIIN (2) Second. After finding the figure and item number, verify that the item is the one you're looking for, then locate the item number in the repair parts list for the figure. 6. Abbreviations. For standard abbreviations see MIL-STD-12D, Military Standard Abbreviations For Use On Drawing, Specifications, Standards And In Technical Documents. 5

11 FIGURE 1. CRANKCASE ASSEMBLY. 6

12 SECTION II REPAIR PARTS LIST (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 01-ENGINE 0101-CRANKCASE, BLOCK, CYLINDER HEAD 1 4 PFOZZ PC615 STUD CYLINDER BLOCK TO CRANKCASE... EA 12 7

13 FIGURE 2. CYLINDER HEAD, VALVE COVER AND MAIN BEARING. 8

14 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0101(CONT) 2 7 PAOZZ MS NUT, PLAIN HEXAGON... EA PAOZZ MS WASHER, LOCK... EA PAOZZ PC369 STUD PLAIN TO CYLINDER BLOCK... EA PAOZZ MS BOLT, MACHINE VALVE COVER EA PAOZZ MS WASHER, FLAT VALVE COVER... EA PAOZZ SA-68 COVER, ACCESS VALVE INSPECTION... EA PFOZZ QD612A GASKET VALVE INSPECTION COVER PART OF KIT P/N Q12G, Q29... EA 4 9

15 FIGURE 3. FLYWHEEL AND RING GEAR. 10

16 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0103-FLYWHEEL ASSEMBLY 3 1 PFOZZ PD123 NUT, PLAIN HEX FLYWHEEL MTG EA XDOZZ PE66 WASHER, LOCK FLYWHEEL MTG... EA PFOHH N FLYWHEEL ASSEMBLY... EA PAOZZ MS KEY WOODRUFF FLYWHEEL MTG... EA XDOZZ RK170 OIL SLINGER... EA 1 11

17 FIGURE 4. TIMING COVER. 12

18 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0105-VALVES, CAMSHAFTS AND TIMING SYSTEM 4 5 PFOZZ MS PLUG, PIPE... EA 1 13

19 FIGURE 5. OIL PAN AND CRANKCASE COVER. 14

20 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0106-ENGINE LUBRICATION SYSTEM 5 1 PFOZZ QD595A GASKET OIL FILTER PAD PART OF KIT P/N Q12G... EA PFOZZ SA65C PLATE, COVER OIL FILTER PAD... EA PAOZZ MS WASHER, LOCK OIL FILTER PAD... EA PAOZZ MS BOLT, MACHINE... EA PFOZZ L060-1 BREATHER... EA XDOZZ LJ3004 TUBE OIL FILLER... EA PFOZZ RC91 STRAINER ELEMENT, SE... EA PFOZZ RJ173 GAGE ROD-CAP, LIQUID EA XDOZZ RF1495M TUBE, ADAPTER OIL DIPSTICK EA PAOZZ PLUG, PIPE... EA 1 15

21 FIGURE 6. OIL FILTER COMPONENTS. 16

22 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 6 1 PAOOO COVER, FLUID FILTER... EA PFOZZ CAP SCREW EA PAOZZ WASHER, FLAT EA PFOZZ A COVER... EA PAOZZ SPRING HELICAL COMP EA PAOZZ GASKET COVER... EA XDOZZ C21P CARTRIDGE FILTER ELEMENT... EA PAOZZ NUT, PLAIN, SQUARE EA PFOZZ MS WASHER, LOCK... EA PAOZZ BOLT, SPECIAL... EA PAOZZ STRAP, RETAINING... EA PAOZZ FILTER BODY, FLUID EA 1 17

23 FIGURE 7. OIL LINES AND FITTINGS. 18

24 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0106(CONT) 7 1 XDOZZ RM1319B HOSE ASSEMBLY GOVERNOR TO GAGE... EA PFOZZ RF ELBOW COUPLING GOVERNOR HOUSING... EA PAOZZ MS ADAPTER, STRAIGHT GOVERNOR HOUSING RETURN LINE EA PAOZZ RF1225 ELBOW, PIPE TO TUBE OIL LINE AT OIL PRESSURE GAGE EA PAOZZ MS COUPLING PIPE... EA PAOZZ RS11 GAGE, PRESSURE, DIAL EA PAOZZ RM-1320-G HOSE ASSEMBLY, RUBBE... EA PFOZZ RM-1320-C LINE, FLEX OIL PRESSURE EA XDOZZ RF1359 ELBOW EA PAOZZ MS NUT, PLAIN, HEXAGON MOUNTING OIL FILTER TO HOSE PAN... EA PFOZZ MS WASHER, LOCK... EA PAOZZ MS WASHER, FLAT EA PAOZZ MS FILTER FLUID... EA PAOZZ PH542 DAMPNER, VIBRAT OIL FILTER MOUNTING... EA PAOZZ RM472 TUBE ASSEMBLY, METAL... EA PFOZZ A127 TEE OIL LINE... EA PAOZZ PH198 GROMMET, NONMETALLIC... EA 4 19

25 FIGURE 8. HAND CRANK MOUNTING HARDWARE. 20

26 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 8 1 PFOZZ MS NUT, HEX... EA PAOZZ MS WASHER, LOCK... EA XDOZZ PK187 CLIP, SPRING CRANK MTG EA PFOZZ MS SCREW, HEX HD... EA XDOZZ NAS561P8-26 PIN START CRANK... EA PFOZZ PG491 BRACKET STARTCRANK... EA 1 21

27 FIGURE 9. MANIFOLD 22

28 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT MANIFOLDS 9 1 PFOZZ XD17 SCREW, HEX HD EA PFOZZ MS WASHER, LOCK... EA PFOOO LD228S1 MANIFOLD ASSEMBLY... EA PFOZZ LD227D5.MANIFOLD UPPER BRANCH EA PAOZZ MS S.PLUG, PIPE, MULTIAPPL... EA PFOZZ QB79.GASKET INLET MANIFOLD PART OF KIT P/N Q12G, Q29... EA PFOZZ QB75.GASKET MANIFOLD PART OF KIT P/N Q12G, Q29... EA PFOZZ MS SCREW, TAP PLUGGING... EA PAOZZ LD228.MANIFOLD... EA PFOZZ PC154.STUD... EA PFOZZ QB78.GASKET EXHAUST MANIFOLD PART OF KIT P/N Q12G, Q29... EA PFOZZ MS WASHER, LOCK LOWER TO UPPER MANIFOLD... EA PAOZZ MS NUT PLAIN HEXAGON... EA 8 9 PAOZZ Q29 GASKET SET VALVE GRINDING EA GASKET... EA GASKET... EA GASKET... EA GASKET... EA 1 23

29 FIGURE 10. CLUTCH ASSEMBLY. 24

30 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT PAOZZ MS SCREW MACHINE... EA PAOZZ MS WASHER, LOCK EXTERNAL TEETH... EA PFOZZ CL-4973 LOCK ADJUST... EA 1 25

31 FIGURE 11. CARBURETOR ASSEMBLY. 26

32 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 03-FUEL SYSTEM 0301-CARBURETOR, FUEL INJECTOR 11 1 XDOFF CARBURETOR... EA XDOZZ T52-57.RETAINER SHAFT SEAL PART OF KIT P/N LQ39... EA XDOZZ T48-9.SEAL THROTTLE SHIFT PART OF KIT P/N LQ39... EA XDOZZ C75.BUSHING THROTTLE SHIFT... EA PAOZZ C GASKET FLANGE PART OF KIT P/N Q12G, LQ39... EA XDOZZ T315S5-4.SCREW AND WASHER THROTTLE PLATE... EA XDOZZ C PLATE, THROTTLE EA XDOZZ C46-6.NEEDLE IDLE ADJ PART OF KIT P/N LQ39... EA XDOZZ C SPRING IDLE NEEDLE... EA XDOZZ T91-3.PLUG... EA XAOZZ C SHIFT AND STOP LEVER THROTTLE... EA XDOZZ T858-12NP.SCREW THROTTLE STOP EA XDOZZ T301S10-10.SCREW BOWL TO BODY ASSEMBLY... EA XDOZZ C SCREW CHOKE BRACKET ASSEMBLY... EA XAOZZ C SHAFT, CHOKE... EA XAOZZ C106-2.LEVER, CHOKE... EA XDOZZ T8S8-7.SCREW CHOKE LEVER SWIVEL EA XDOZZ T22S8.NUT CHOKE SHAFT... EA XDOZZ T41-10.WASHER, LOCK CHOKE SHAFT NUT... EA XDOZZ C112-6.SPRING CHOKE LEVER RETURN... EA XDOZZ T8S8-8.SCREWBRACKET CLIP... EA XDOZZ C110-7.CLIPBRACKET TUBE... EA XAOZZ C109-60C.BRACKET, CHOKE... EA XDOZZ T21S8.NUT CLAMP SCREW... EA XDOZZ C131-4X2.RETAINER CHOKE SHAFT SEAL PART OF KIT P/N LQ39... EA XDOZZ T57-4.SEAL CHOKE SHAFT PART OF KIT P/N LQ39... EA XAOZZ C PLATE, CHOKE EA XAOZZ T315S5-4.SCREW AND WASHER CHOKE PLATE... EA 2 27

33 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0301 (CONT.) XDOZZ CR37-1X1.PLUGCHOKE SHAFT HOLE PART OF KIT P/N LQ39... EA XDOZZ C GASKETBOWL TO BODY PART OF KIT P/N 93C EA XDOZZ T56-48.WASHER, FIBER DISCHARGE JET PART OF KIT P/N 93C , LQ EA XDOZZ C JET, DISCHARGE XDOZZ C JET, WELL VENT... EA XAOZZ B VENTURI... EA XDOZZ C FLOAT AND HINGE ASSEMBLY... EA XDOZZ C JET, IDLE... EA 1 28

34 TA FIGURE 12. FUEL PUMP ADAPTER COVER. 30

35 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0302-FUEL PUMPS 12 1 PFOZZ MS SCREW, CAP, HEX HD PUMP PAD COVER... EA PAOZZ MS WASHER, LOCK PUMP PAD COVER... EA PFOZZ SA69 COVER FUEL PUMP ADAPTER HOLE... EA PFOZZ QD67 GASKETFUEL PUMP PAD COVER PART OF KIT P/N Q12G... EA 1 31

36 FIGURE 13. AIR CLEANER AND HOSE. 32

37 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0304-AIR CLEANER 13 1 PAOZZ LK11 CLAMP, HOSE... EA PFOZZ LL167 ELBOW, RUBBER AIR CLEANER... EA PFOZZ CLAMP, HOSE... EA PFOZZ L062 CAP, WEATHER AIR CLEANER... EA PFOOO MS AIR CLEANER, INTAKE... EA PAOZZ P CUP, OIL INNER... EA PAOZZ P17703.CUP, AIR CLEANER... EA XDOZZ AAH MOUNTING BAND ASSEMBLY... EA PAOZZ P CLAMP LOOP... EA PAOZZ P PACKING, PREFORMED... EA PFOZZ PC564 STUD AIR CLEANER MOUNTING... EA PAOZZ MS WASHER, LOCK... EA PFOZZ PH542 VIBRATION DAMPNER AIR CLEANER... EA PAOZZ MS WASHER, LOCK... EA PAOZZ MS NUT PLAIN HEXAGON... EA 8 33

38 FIGURE 14. FUEL TANK AND SUPPORTS. 34

39 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0306-TANKS, LINES, FITTINGS, HEADERS 14 1 XDOZZ WC STRAP, FUEL TANK... EA PAOZZ MS NUT, HEXAGON... EA XDOZZ XC FELT, SAE F3... EA XDOFF YC TANK, FUEL ASSEMBLY... EA XDOZZ YC CAP AND CHAIN FUEL... EA XDOZZ XC FELT, SAE F3... EA XDOZZ XC STRAIGHT FIT FUEL STRAINER... EA XDOZZ XC STAND PIPE ASSEMBLY... EA PFOZZ PH198 GROMMET FUEL LINE... EA XDOZZ RM1320A FUEL LINE... EA XDOZZ WC CRADLE SUPPORT ASSEMBLY... EA PAOZZ MS WASHER, LOCK... EA PAOZZ MS SCREW, CAP HEX HD... EA PAOZZ MS SCREW, CAP HEX HD... EA PFOZZ MS SCREW CAP HEXAGON H... EA XDOZZ WC SUPPORT, TANK... EA PAOZZ MS WASHER, LOCK... EA PAOZZ MS NUT, PLAIN, HEXAGON... EA 1 35

40 FIGURE 15. GOVERNOR CONTROL. 36

41 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0308-ENGINE SPEED GOVERNOR AND CONTROLS 15 1 PFOFF TT45L1 GOVERNOR CONTROL ASSEMBLY... EA PFOZZ PD173A.LOCKNUT, ADJUSTING SCREW... EA PFOZZ TC368A.PIN ADJUSTING SCREW SWIVEL... EA PFOZZ PK121.RETAIN ADJUSTING SCREW, SPRING... EA PFOZZ PM111-1.SPRING, ADJUSTING SCREW... EA XDOZZ P11156.SCREW, ADJUSTING... EA PAOZZ A82-1.PIN, COTTER... EA PAOZZ MS PIN, COTTER... EA PAOZZ NAS C..CHAIN, WELDED... EA PAOZZ VE527.CONTROL, PUSH-PULL... EA PFOZZ TC365.PIN VARIABLE SPEED LEVER SUPPORT... EA PAOZZ MS WASHER, LOCK SUPPORT PIN... EA PFOZZ VB134A.LEVER, VARIABLE SPEED... EA PAOZZ MS WASHER, FLAT... EA PAOZZ MS SCREW, MACHINE COTTER PIN LEVER... EA 1 37

42 FIGURE 16. GOVERNOR LINKAGE. 38

43 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0308(CONT) 16 3 PFOZZ TB109 ADAPTER TACHOMETER... EA PAOZZ MS PLUG, EXPANSION... EA PAOZZ VE674A BALL JOINT CONTROL ROD... EA PFOZZ VE689 LEVER CONTROL ROD TO CARBURETOR... EA PFOZZ HF594 SPACER CARBURETOR LEVER... EA PAOZZ MS WASHER, LOCK GOVERNOR CONTROL ROD... EA PAOZZ MS NUT, HEX GOV CONTROL ROD... EA XDOZZ PN76 SPRING GOVERNOR... EA 1 39

44 FIGURE 17. FUEL FILTER ASSEMBLY. 40

45 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0309-FUEL FILTERS 17 1 PDOZZ YC STRAINER, FUEL... EA XDOOO OW449T FILTER, FLUID... EA PFOZZ A11211.SCREEN, FILTER PART OF KIT P/N LQ32... EA PFOZZ GASKET, BOWL PART OF KIT P/N LQ32... EA PFOZZ W363.BOWL, GLASS PART OF KIT P/N LQ32... EA PFOZZ B.CLAMP WIRE AND THREADED NUT... EA 1 17 PAOZZ LQ32 PARTS KIT FUEL STRA... EA SCREEN, FILTER... EA GASKET, BOWL... EA BOWL, GLASS... EA 1 41

46 TA FIGURE 18. CHOKE CONTROL. 42

47 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0312-ACCELERATOR, THROTTLE OR CHOKE CONTROLS 18 1 PFOZZ VE693 CHOKE CONTROL... EA 1 43

48 FIGURE 19. MUFFLER AND ADAPTER. 44

49 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 04-EXHAUST SYSTEM 0401-MUFFLER AND PIPES 19 1 XDOZZ WD98 MUFFLER, EXHAUST... EA PFOZZ MS SCREW, HEX HEAD MUFFLER ADAPTER FLANGE... EA PBOZZ LF129 ADAPTER, STRAIGHT FL... EA PAOZZ QD727 GASKET MUFFLER ADAPTER FLANGE... EA PFOZZ LF130 ADAPTER, FLANGE MUFFLER FEMALE... EA PFOZZ MS WASHER, LOCK MUFFLER ADAPTER FLANGE... EA PAOZZ MS NUT, PLAIN, HEXAGON STEEL... EA PAOZZ MS NIPPLE, PIPE... EA 1 45

50 FIGURE 20. AIR SHROUDS. 46

51 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 05-COOLING SYSTEM 0502-COWLING, DEFLECTORS, AIR DUCTS, SHROUDS, ETC PFOZZ SE79C SHROUD CYLINDER HEAD LH SIDE... EA PAOZZ MS SCREW, MACHINE RH END COVER TOP HOLE... EA PFOZZ MS LOCK, WASHER FLYWHEEL SCREEN... EA PFOZZ SE83C COVER, REAR SHROUD RH SIDE... EA PAOZZ MS SCREW, MACHINE... EA PFOZZ SE78C7 SHROUD CYLINDER HEAD RD SIDE... EA PFOZZ SE80 COVER, SIDE FLYWHEEL SHROUD... EA PAOZZ MS SCREW, CAP, HEXAGON... EA PFOZZ SE74YA SHROUD FLYWHEEL... EA PFOZZ SE20B3 SCREEN FLYWHEEL SHROUD... EA PFOZZ SE75B SHROUD LOWER CYLINDER RH SIDE... EA PFOZZ MS SCREW, HEXAGON HEAD... EA PAOZZ MS WASHER, LOCK FLYWHEEL SHROUD... EA PAOZZ MS SCREW, CAP, HEXAGON... EA PFOZZ SE76B SHROUD LOWER CYLINDER LH SIDE... EA PFOZZ MS SCREW, HEXAGON HEAD CYLINDER HEAD DEFLECTOR LH EA PFOZZ SE82C COVER REAR SHROUD LH SIDE... EA PFOZZ SE77D DEFLECTOR CYLINDER HEAD RH SIDE... EA PFOZZ SE77C DEFLECTOR, CYLINDER LH... EA 1 47

52 FIGURE 21. WATER PUMP. 48

53 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0504-WATER PUMP 21 1 XDOOO XC WATER PUMP... EA XDOZZ XC SHEAVE WATER PUMP... EA XDOZZ HH PLUG, DRAIN... EA XDOZZ HH KEY... EA PAOZZ MS SCREW, CAP, HEXAGON... EA PFOZZ MS WASHER, CU;... EA PAOZZ MS WASHER, LOCK... EA PAOZZ MS NUT, PLAIN, HEXAGON... EA 4 49

54 FIGURE 22. ALTERNATOR ASSEMBLY. 50

55 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 06-ELECTRICAL SYSTEM 0601-GENERATOR, ALTERNATOR 22 1 PAOZZ YJ64 RECTIFIER, MODULE... EA XDOZZ YB350 INSULATOR AMMETER WIRE CONNECTOR... EA PBOZZ YL WIRE ASSEMBLY, STATO... EA PBOZZ YB79 ALTERNATOR, ASSEMBLY... EA PFOZZ NAS561P6-18 ROLL PIN STATOR MOUNTING... EA PAOZZ MS WASHER, LOCK... EA PAOZZ XB106 SCREW, MACHINE... EA 4 51

56 TA FIGURE 23. ALTERNATOR REGULATOR. 52

57 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0602-GENERATOR REGULATOR 23 1 PAOZZ MS SCREW, MACHINE... EA XAOZZ YD353 SH1ELD REGULATOR MODULE... EA PFOZZ YJ65 REGULATOR... EA PAOZZ MS WASHER, LOCK MODULE MOUNTING... EA PFOZZ MS NUT, PLAIN, HEXAGON... EA 2 53

58 FIGURE 24. STARTING MOTOR. 54

59 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0603-STARTING MOTOR 24 1 XDOFF MB4018T STARTER, ENGINE ELEC... EA XDOZZ MZ1024AD.COVER BAND... EA 1 55

60 TA FIGURE 25. STARTER MOUNTING AND WIRING. 56

61 SECTION II (1) ILLUSTRATION (2) (3) (4) (5) (6) (7) (8) QTY (a) (b) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART USABLE IN FSCM ON U/M UNIT 0603(CONT) 25 1 PFOZZ PC396 STUD STARTER BRACKET... EA PAOZZ MS WASHER, LOCK... EA PAOZZ MS NUT PLAIN HEXAGON... EA PFOZZ YL CABLE STARTER TO SWITCH... EA PAOZZ MS NUT, PLAIN, HEXAGON... EA PAOZZ MS WASHER, LOCK STARTER SWITCH MOUNTING... EA PFOZZ ALEX61360 SWITCH... EA PFOZZ MS SCREW, HEXAGON HEAD STARTER SWITCH MOUNTING.. EA PFOZZ MS SCREW CAP HEXAGON... EA PFOZZ MS WASHER, LOCK STARTER MOUNTING... EA PFOZZ PG514A BRACKET STARTER SUPPORT... EA 1 57

62 TA FIGURE 26. MAGNETO, SPARK PLUGS AND LEADS. 58

63 SECTION II (1) ILLUSTRATION (2) (3) (4) (5) (6) (7) (8) QTY (a) (b) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART USABLE IN FSCM ON U/M UNIT 0605-IGNITION COMPONENTS 26 1 PAOZZ MS SPARK PLUG SMD EA PAOZZ MS LEAD AND CONDUIT AS SPARK PLUG 1 AND 4... EA PFOZZ MSJ LEAD AND CONDUIT AS SPARK PLUG 2... EA PFOZZ PC110 STUD MAGNETO MOUNTING... EA PAOZZ MS WASHER, LOCK MAGNETO... EA PAOZZ MS NUT, PLAIN, HEXAGON MAGNETO STUD... EA PFOZZ MS WASHER, LOCK MAGNETO SCREW... EA PAOZZ MS SCREW, CAP, HEXAGON H... EA PAOZZ MS SCREW, MACHINE MAGNETO GROUND STRAP... EA PAOZZ MS WASHER, LOCK... EA PAOZZ YL355-5 LEAD, ELECTRICAL MAGNETO... EA PAOZZ MS CABLE ASSEMBLY, SPEC SPARK PLUG 3... EA PFOZZ PG558 CLIP SHIELDED CABLE... EA PAOZZ MS SCREW, MACHINE CABLE CLIP... EA PBOFF FMZVE4B7-4 MAGNETO, IGNITION... EA 1 59

64 FIGURE 27. MAGNETO ASSEMBLY. 60

65 SECTION II (1) ILLUSTRATION (2) (3) (4) (5) (6) (7) (8) QTY (a) (b) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART USABLE IN FSCM ON U/M UNIT 0605(CONT) PAOZZ A6032A.FILTERING DISK;FLUI END CAP... EA XDOZZ A1233.MESH, COPPER SHIELD... EA PAOOO A1232.HOOD, VENT, MA... EA XDOZZ N..SCREW VENT HOOD... EA 1 61

66 FIGURE 28. MAGNETO ROTOR. 62

67 SECTION II (1) ILLUSTRATION (2) (3) (4) (5) (6) (7) (8) QTY (a) (b) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART USABLE IN FSCM ON U/M UNIT 0605(CONT) PAOZZ C6032B.STRAINER, ELEMENT SE FRAME... EA PAOZZ B6030A.VENT, COVER, MAGNETO... EA XDOZZ S4L.SCREW HOOD VENT... EA 1 63

68 FIGURE 29. INSTRUMENT PANEL. 64

69 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0607-INSTRUMENT OR ENGINE CONTROL PANEL 29 1 XDOZZ HH CLIP,WIRE... EA XDOZZ M1L57 WIRE ASSEMBLY FUEL GAGE TO SENDING UNIT... EA XDOZZ M1L59 WIRE ASSEMBLY FUEL GAGE TO IGNITION SWITCH EA XDOZZ WE197LT18 PANEL FRONT ENGINE HOUSING... EA XDOZZ XC GAGE, FUEL... EA XDOZZ A AMMETER... EA PAOZZ SD109 TAG, IDENTIFICATION... EA PFOZZ PE80A WASHER, LOCK IGNITION SWITCH MOUNTING... EA PAOZZ MS NUT, PLAIN HEXAGON FRONT PANEL TO FLYWHEEL SHROUD... EA PAOZZ MS WASHER, LOCK BETWEEN PANEL AND FLYWHEEL SHIELD... EA PFOZZ PH377 GROMMET, RUBBER... EA PFOZZ YL374-5 WIRE ASSEMBLY AMMETER TO STARTER SWITCH EA PFOZZ C GROMMET, RUBBER... EA PFOZZ YL132 WIRE ASSEMBLY AMMETER TO IGNITION SWITCH. EA XDOZZ YL WIRE, IGNITION GROUND SWITCH TO MAGNETO... EA PAOZZ YC26 SWITCH, IGNITION GRO... EA PAOZZ MS SCREW, MACHINE FRONT PANEL TO FLYWHEEL SHROUD... EA PAOZZ MS WASHER, LOCK FRONT PANEL TO FLYWHEEL SHROUD... EA 4 65

70 66 FIGURE 30. HI TEMPERATURE AND FUEL SENDING UNITS.

71 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0610-SENDING UNITS AND WARNING SWITCHES 30 1 PFOZZ MS SCREW, CAP, HEXAGON H... EA PAOZZ MS WASHER, FLAT... EA PAOZZ YC66DS1 SWITCH, THERMOSTATIC... EA PAOZZ YL LEAD, ELECTRICAL... EA PFOZZ AN520PB10-7 SCREW, ROUND SLOTTED HEAD.... EA PFOOO AS SENDING UNIT ASSEMBLY... EA XDOZZ ARM, FLOAT SENDING UNIT... EA XDOZZ FLOAT SENDING UNIT... EA I 30 9 XDOZZ GASKET... EA 1 67

72 FIGURE 31. BATTERY AND BOX. 68

73 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0612-BATTERIES, STORAGE 31 1 XDOOO YC BATTERY BOX ASSEMBLY... EA XDOZZ XC HOLDDOWN, BATTERY... EA PAOZZ MS NUT PLAIN HEXAGON... EA XDOZZ XC BOX, BATTERY... EA PAOZZ MS NUT, PLAIN, HEXAGON... EA PAOZZ MS WASHER LOCK... EA XDOZZ XC GROMMET... EA PFOZZ MS CAPSCREW HEXAGON HEAD... EA XDOZZ XC BATTERY... EA PFOZZ XC CABLE BATTERY TO GROUND... EA PAOZZ MS TERMINAL, LUG... EA PAOZZ MS ADAPTER BATTERY TER... EA PFOZZ XC CABLE TERMINAL CONNECTOR... EA PAOZZ XC LEAD ELECTRICAL BATTERY TO START SWITCH.. EA 1 69

74 FIGURE 32. ENGINE WIRING. 70

75 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 0613-CHASSIS WIRING 32 1 XDOZZ HH SCREW, SHEET METAL... EA XDOZZ HH SCREW, SHEET METAL... EA XDOZZ H CLAMP, CABLE... EA XDOZZ YL WIRE, GUARD ENGINE AT OIL FILTER PAD COVER EA PAOZZ MS WASHER, LOCK GROUND WIRE... EA 2 71

76 FIGURE 33. STEERING KNUCKLE. 72

77 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 10-FRONT AXLE 1004-STEERING AND LEANING WHEEL MECHANISM 33 5 PAOZZ MS FITTING, LUBRICATION... EA PAOZZ MS FITTING, LUBRICATION... EA 1 73

78 FIGURE 34. HUB AND WHEEL. 74

79 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 13-WHEELS AND TRACKS 1311-WHEEL ASSEMBLY 34 1 XDOZZ SEAL... EA PFOZZ A CONE, BEARING... EA PAOZZ CUP, TAPERED ROLLER... EA XDOZZ XC HUB, WHEEL... EA PAOZZ CUP, TAPERED ROLLER... EA PFOZZ A BEARING, CONE... EA PAOZZ MS WASHER, FLAT... EA XDOZZ HHOO NUT CASTELATED HEXAGON... EA XDOZZ CAP, GREASE... EA XDOZZ RIM, WHEEL... EA PAOZZ BOLT, WHEEL MOUNTING... EA PAOZZ MS PIN, COTTER... EA 4 75.

80 FIGURE 35. TIRE AND TUBE. 76

81 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 1313-TIRES, TUBES, TIRE CHAINS 35 1 XDOOO XC TIRE, PNEUMATIC... EA XDOOO XC TUBE, INNER... EA 4 77

82 FIGURE 36. LOWER FRAME. 78

83 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 15-FRAME, TOWING ATTACHMENTS, AND DRAWBARS 1501-FRAME ASSEMBLY 36 7 XDOZZ WC CHAIN, SAFETY... EA XDOZZ U57616 LINK, CONNECTING... EA 2 79

84 FIGURE 37. ENGINE HOUSING. 80

85 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 18-BODY, CAB, HOOD AND HULL 1801-BODY, CAB, HOOD AND HULL ASSEMBLIES 37 1 PAOZZ MS SCREW, MACHINE CANOPY TANK SUPPORT... EA PAOZZ MS WASHER, LOCK... EA XDOZZ PG1100 STRIP SUPPORT CANOPY... EA PAOZZ WE198A1T HOUSING, UPPER CENTE... EA PAOZZ MS SCREW, MACHINE PARTITION PLATE... EA PAOZZ MS NUT, PLAIN, HEXAGON... EA XDOZZ PG1098 BRACE HOUSING AT AIR CLEANER... EA PAOZZ MS SCREW, TAPPING, THREA FRONT PANEL TO SHROUD... EA PAOZZ MS SCREW, CAP, HEXAGON H BRACKET TO FRONT PANEL... EA PAOZZ MS WASHER, FLAT FRONT HOUSING PANEL BRACES EA XDOZZ WE218T PLATE, PARTITION CANOPY... EA PAOZZ PG401 BRACE, HOUSING TAKE-OFF END... EA XDOZZ PG1097 BRACE HOUSING AT OIL FILTER... EA XDOZZ PG1099 ANGLE, REINFORCING AIR CLEANER... EA PAOZZ MS WASHER, FLAT AIR CLEANER SUPPORT... EA 4 81

86 FIGURE 38. ENGINE COVERS AND SIDE PANELS. 82

87 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 1801 (CONT) 38 1 PAOZZ MS NUT, PLAIN, HEXAGON REAR PANEL TO CYLINDER BLOCK... EA PAOZZ MS WASHER, LOCK... EA PAOZZ MS WASHER, FLAT REAR PANEL TO CYLINDER BLOCK EA XDOZZ PC566 STUD REAR PANEL TO BLOCK LH SIDE... EA PFOZZ HF380 SPACER REAR PANEL TO CYLINDER BLOCK... EA XDOZZ PC565 STUD REAR PANEL TO BLOCK RH SIDE... EA PAOZZ WE196 DOOR, HOUSING... EA XDOZZ WE199A25T PANEL, REAR ENGINE COMPARTMENT... EA PAOZZ MS PIN, COTTER DOOR CLIP... EA PAOZZ MS WASHER, FLAT DOOR CLIP... EA PAOZZ PM137 SPRING, HELICAL,COMP DOOR CLIP... EA PAOZZ MS NUT, PLAIN, HEXAGON SIDE RAILS TO ENGINE SUPPORTS... EA PAOZZ MS WASHER, LOCK SIDE RAILS TO ENGINE SUPPORT EA PAOZZ PG323 CLIP, DOOR ENGINE HD... EA XDOZZ WE195T RAIL, SIDE ENGINE SUPPORT R AND L SIDE... EA PFOZZ MS SCREW, CAP, HEXAGON H SIDE RAILS TO ENGINE SUPPORT... EA PAOZZ MS SCREW, MACHINE REAR PANEL TO ENGINE SUPPORT... EA PAOZZ MS SCREW, MACHINE FUEL TANK SUPPORT TO PANEL... EA XDOZZ WE192VT SUPPORT ASSEMBLY FUEL TANK... EA 1 83

88 FIGURE 39. ENGINE PLATFORM AND SPLASH GUARDS. 84

89 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION 1801 (CONT) USABLE ON (7) U/M (8) QTY INC IN UNIT 39 1 XDOOO YC UPPER HOIST AND FRAME... EA XDOZZ YC SUPPORT MOTOR TOP PLATE... EA PAOZZ MS SCREW, CAP HEXAGON... EA XDOZZ XC GUIDE, CABLE... EA XDOZZ YC GUARD... EA PAOZZ MS SCREW, CAP, HEXAGON H... EA PFOZZ MS BOLT, MACHINE HEXAGO... EA PAOZZ MS NUT, PLAIN, HEXAGON... EA PAOZZ MS WASHER, LOCK... EA PAOZZ MS SCREW, CAP, HEXAGON H... EA XDOZZ XC STOP,COVER... EA PAOZZ MS WASHER,LOCK... EA 4 i PFOZZ NUT,HEXAGON... EA XDOZZ WC GUARD,SPLASH DISCHARGE SIDE... EA PAOZZ MS BOLT MACHINE... EA PAOZZ MS NUT, PLAIN HEXAGON... EA PAOZZ MS WASHER,LOCK... EA XDOZZ WC GUARD, SPLASH CHARGE SIDE... EA PAOZZ MS NUT, PLAIN, HEXAGON... EA PAOZZ MS WASHER LOCK... EA XDOZZ HH WASHER, BEVEL... EA XDOZZ YC SUPPORT MOTOR SIDE 2... EA XDOZZ XC CLIP, HOLDOWN... A XDOZZ WC DOOR MOTOR SUPPORT... EA PAOZZ XC05723-O00.SPRING, HELICAL... EA PAOZZ WASHER, FLAT... EA PAOZZ MS PIN, COTTER... EA XDOZZ YC SUPPORT MOTOR SIDE 1... EA PAOZZ MS WASHER, FLAT... EA 4 85

90 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 1801(CONT) PAOZZ MS SCREW HEXAGON HEAD... EA PAOZZ MS SCREW,CAP,HEXAGON H... EA PAOZZ MS SCREW,CAP,HEXAGON H... EA 2 86/(87 blank)

91 TA FIGURE 40. TOOL BOX AND MOUNTING HARDWARE. 88

92 SECTION II (1) ILLUSTRATION (a) (b) FIG ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 1808-STOWAGE RACKS, BOXES, STRAPS, CARRYING CASES, CABLE REELS, HOSE REELS, ETC PAOZZ MS SCREW, HEXAGON, HE... EA XBOZZ WC BOX, TOOL... EA PAOZZ MS WASHER, FLAT... EA PAOZZ MS NUT, PLAIN, HEXAGON... EA 4 89

93 FIGURE 41. HOURMETER TACHOMETER. 90

94 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 47-GAGES (NON ELECTRICAL) 4701-INSTRUMENTS (SPEED AND DISTANCE) 41 1 PAOZZ SHAFT ASSEMBLY, FLEX TACHOMETER DRIVE... EA PBOZZ AMB TACHOMETER, MECHANIC... EA PAOZZ MS NUT, PLAIN HEXAGON TACHOMETER MOUNTING. EA PBOZZ D ADAPTER, TACHOMETER... EA 1 91

95 FIGURE 42. POWER LOADING SKIP. 92

96 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 73-CONCRETE AND ASPHALT EQUIPMENT COMPONENTS 7301-POWER LOADER SKIP 42 2 XDOZZ HH COTTER PIN... EA XDOZZ XC HOOK, SKIP... EA XDOZZ GREASE FITTING... EA 2 93

97 FIGURE 43. UPPER HOIST. 94

98 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7301 (CONT) 43 7 XDOZZ HH FITTING, GREASE... EA XDOZZ COUPLING... EA XDOZZ NIPPLE, PIPE... EA 2 95

99 FIGURE 44. DRUM ROLLERS. 96

100 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7302-DRUMS 44 2 PAOZZ MS FITTING, LUBRICATION... EA 2 97

101 FIGURE 45. CONTROLS AND OPERATING LEVERS. 98

102 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7303-CONTROLS, MACHINERY PAOZZ MS FITTING... EA 1 99

103 FIGURE 46. VIBRATOR AND BEARING. 100

104 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7303(CONT) 46 8 PAOZZ MS FITTING,LUBRICATION.... EA PAOZZ MS FITTING,LUBRICATION.... EA 1 101

105 FIGURE 47. HOIST ASSEMBLY. 102

106 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7305-MAIN DRIVE 47 8 PAOZZ MS FITTING,LUBRICATION... EA XDOZZ HH BUSHING,PIPE EA PAOZZ WWN351 NIPPLE,PIPE EA XDOZZ COUPLING,PIPE... EA XDOZZ FITTING,LUBRICATION... EA 1 103

107 FIGURE 48. DRIVE ASSEMBLY. 104

108 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7305(CONT) PFOZZ MS PLUG,PIPE... EA PFOZZ MIL18174 ELBOW,PIPE EA XDOZZ HH PLUG,VENT... EA PAOZZ PIPEPLUG PLUG,PIPE... EA 1 105

109 FIGURE 49. DRIVE SHEAVE AND GUARD. 106

110 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7305(CONT) 49 1 XDOZZ WC GUARD MOTOR BELT... EA PAOZZ MS SCREW,CAP,HEXAGON H... EA PAOZZ MS WASHER,LOCK... EA PAOZZ MS NUT,PLAIN,HEXAGON... EA XDOZZ HH BELTPUMP DRIVE EA XDOZZ HH BELTHOIST DRIVE EA 1 107

111 FIGURE 50. POWER TAKE OFF ASSEMBLY 108

112 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7305(CONT) 50 4 PAOZZ MS SCREW,MACHINECOVER HOUSING..... EA PAOZZ MS WASHER,LOCKCOVER HOUSING... EA XDOZZ BH158 COVER CLUTCH INSPECTION... EA PAOZZ QD652 CORK SHEETCOVER... EA PAOZZ MS S PIPE PLUGOIL LEVEL HOLE... EA PAOZZ MS S PIPE PLUG,MULTIAPPL OIL DRAIN HOLE... EA PAOZZ MS ELBOW PIPE EA PFOZZ L044 BREATHER... EA PAOZZ MS SCREW,CAP,HEXAGON H CLUTCH LEVER... EA PFOZZ VB-55-1 LEVER,CLUTCH ENGAGING EA 1 109

113 FIGURE 51. DISCHARGE 110

114 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7312-FEEDER OR CONVEYOR DISCHARGE 51 9 PAOZZ MS FITTING,LUBRICATION... EA PAOZZ MS FITTING,LUBRICATION... EA PAOZZ MS FITTING,LUBRICATION... EA 2 111

115 FIGURE 52. WATER TANK ASSEMBLY. 112

116 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7319-WATER SYSTEM 52 2 PAOZZ MS BOLT,MACHINE... EA XDOZZ WW521TYPE1 ELBOW,PIPE EA PAOZZ MS NUT,PLAIN HEXAGON... EA PAOZZ MS WASHER,LOCK... EA XDOZZ XC STUD... EA PAOZZ XM GASKET WATER TANK... EA XDOZZ WC COVER SYPHON TANK... EA PAOZZ MS SCREW,CAP,HEXAGON H... EA PFOZZ XC GASKET VENT VALVE... EA PFOZZ XC VALVE ASSEMBLY... EA 1 113

117 FIGURE 53. WATER SYSTEM. 114

118 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7319(CONT) 53 1 XDOZZ HH PIPE TUBE... EA XDOZZ HH ELBOW PIPE EA XDOZZ XB NIPPLE HOSE... EA XDOZZ HH CLAMP,HOSE... EA XDOZZ XC CLIP WATER HOSE... EA PAOZZ MS WASHER,LOCK... EA PFOZZ MS SCREW,CAP HEXAGON H... EA PAOZZ Wl 1/2 HOSE,NONMETALLIC... EA PAOZZ XC SPRING,HELICAL COMP EA PFOZZ XC RING,SNAP... EA XBOOO WC WATER TERMINAL ASSEMBLY... EA XDOZZ XB NIPPLE,HOSE... EA XDOZZ HH STANDARD ELBOW EA XDOZZ HH NIPPLE,PIPE... EA XDOZZ XC U-BOLT... EA PAOZZ MS WASHER,LOCK... EA PAOZZ MS NUT,PLAIN,HEXAGON... EA XDOZZ HH STREET ELBOW... EA XDOOO XC VALVE,WATER... EA PFOZZ XC WRENCH,WATER VALVE... EA XDOZZ XC BRACKET WATER VALVE EA PFOZZ NUT,HEXAGON....EA PAOZZ Wl 1/2 HOSE,NONMETALLIC... EA PAOZZ MS SCREW,CAP,HEXAGON H... EA PAOZZ MS WASHER,FLAT EA XBOFF WC NOZZLE,WATER SUB-ASSEMBLY... EA PAOZZ MS SET SCREW... EA XDOZZ XC NOZZLE,WATER... EA XDOZZ XC ELBOW EA 1 115

119 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT 7319(CONT) PAOZZ WWP521.ELBOW,PIPE EA XDOZZ XB NIPPLE HOSE... EA PAOZZ MS WASHER,LOCK... EA PAOZZ MS NUT,PLAIN,HEXAGON... EA XDOZZ HH HOSE,WATER... EA XDOZZ HH ELBOW,PIPE EA XDOZZ HH BUSHING,REDUCING... EA PAOZZ WWP521 ELBOW,PIPE EA 1 116/(117 blank)

120 FIGURE 54. FIRE EXTINGUISHER MOUNTING.

121 SECTION II (1) ILLUSTRATION (a) FIG (b) ITEM (2) SMR (3) NATIONAL STOCK (4) FSCM (5) PART (6) DESCRIPTION USABLE ON (7) U/M (8) QTY INC IN UNIT GROUP 76-FIRE FIGHTING EQUIPMENT 7638-PORTABLE FIRE FIGHTING EQUIPMENT 54 1 XDOZZ HH NUT,HEXAGON... EA XDOZZ HH LOCKWASHER.... EA XDOZZ HH SCREW,FLAT HEAD MAC... EA 4 119/(120 blank)

122 SECTION IV NATIONAL STOCK AND PART INDEX NATIONAL FIGURE ITEM NATIONAL FIGURE ITEM STOCK STOCK

123 SECTION IV NATIONAL STOCK AND PART INDEX NATIONAL FIGURE ITEM NATIONAL FIGURE ITEM STOCK STOCK

124 SECTION IV NATIONAL STOCK AND PART INDEX NATIONAL FIGURE ITEM NATIONAL FIGURE ITEM STOCK STOCK KIT KIT

125 SECTION IV NATIONAL STOCK AND PART INDEX NATIONAL FIGURE ITEM NATIONAL FIGURE ITEM FSCM PART STOCK FSCM PART STOCK AAH MS ALEX MS AN520PB MS A MS A MS A MS A MS A6032A MS A MS BH MS B6030A MS CL MS C MS C21P MS S C6032B MS S FMZVE4B MS S HF MS HF MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS HH MS H MS LD227D MS LD MS LD228S MS LF MS LF MS LJ MS LK MS LL MS LQ KIT MS L MS L MS L MS MB4018T MS MIL MS MSJ MS MS MS

126 SECTION IV NATIONAL STOCK AND PART INDEX NATIONAL FIGURE ITEM NATIONAL FIGURE ITEM FSCM PART STOCK FSCM PART STOCK MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS M1L MS M1L MS NAS C MS NAS561P MS NAS561P MS Nl MS PC MS PC MS PC MS PC MS PC MS PC

127 SECTION IV NATIONAL STOCK AND PART INDEX NATIONAL FIGURE ITEM NATIONAL FIGURE ITEM FSCM PART STOCK FSCM PART STOCK PC SE77C PC SE77D PD SE78C PD173A SE79C PE SE PE80A SE82C PG SE83C PG TB PG TC PG TC368A PG TT45L PG VB PG VB134A PG514A VE PG VE674A PH VE PH VE PH WC PH WC PH WC P WC PK WC PK WC PM WC PM WC PN WC P WC P WC P WC P WD QB WE192VT QB WE195T QB WE QD595A WE197LT QD612A WE198A1T QD WE199A25T QD WE218T QD WWN Q KIT WWP RC WWP RF WW521TYPE RF XB RF XB RF1495M XB RJ XB RK C RM-1320-C XC RM-1320-G XC RM1319B XC RM1320A XC RM XC RS XC SA XC SA65C XC SA XC SD XC SE20B XC SE74YA XC SE75B XC SE76B XC

128 SECTION IV NATIONAL STOCK AND PART INDEX NATIONAL FIGURE ITEM NATIONAL FIGURE ITEM FSCM PART STOCK FSCM PART STOCK XC XC XC XC XC A XC XC XC XC A XC XC XC MZ1024AD XC U XC XC A XC XC XC XC XD AS XM YB YB AMB YC C YC S4L YC YC N YC W1 1/ YC W1 1/ YC D YC YC YC B YC66DS CR37-1X YD C YJ C YJ C YL C109-60C YL C YL C YL C YL C131-4X YL C YL C YL C W C OW449T C C C C C C PIPEPLUG T21S T22S T301S T315S B T315S A T T T

129 SECTION IV NATIONAL STOCK AND PART INDEX NATIONAL FIGURE ITEM FSCM PART STOCK T T T8S T8S T858-12NP T

130 By Order of the Secretary of the Army: JOHN A. WICKHAM, JR. General, United States Army Chief of Staff Official: DONALD J. DELANDRO Brigadier General, United States Army The Adjutant General Distribution: To be distributed in accordance with DA Form 12-25B, Organizational Maintenance requirements for Distributors, Mixers, Concrete. U.S. GOVERNMENT PRINTING OFFICE: /20010

131

132 THE METRIC SYSTEM AND EQUIVALENTS

133 PIN:

134 This fine document... Was brought to you by me: Liberated Manuals -- free army and government manuals Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap watermarks and other junk on it, and sell it. Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it... They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends? I am setting this document FREE. This document was made by the US Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on. I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines: <A HREF= Military and Government Manuals</A> Sincerely Igor Chudov Chicago Machinery Movers