DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST FOR VIBRATION TRANSDUCER CALIBRATION SYSTEM (MIS-35934)

Transcription

1 TECHNICAL MANUAL HEADQUARTERS DEPARTMENT OF THE ARMY WASHINGTON, DC, 6 March 1986 DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST FOR VIBRATION TRANSDUCER CALIBRATION SYSTEM (MIS-35934) NSN Current as of 15 December 1985 REPORTING ERRORS AND RECOMENDING IMPROVEMENTS You can help improve this manual. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Mail your letter or DA Form 2028 (Recommended Changes to Publications and Blank Forms) to: Commander, US Army TMDE Support Group, ATTN: AMXTM-LML, Redstone Arsenal, AL A reply will be furnished directly to you. TABLE OF CONTENTS Page Section I. INTRODUCTION... 1 Section II. REPAIR PARTS LIST Group 0010 Vibration transducer Oscilloscope Circuit card assembly Al and A Circuit card assembly A1A Oscilloscope subassembly AlA Circuit card assembly A Circuit card assembly A Circuit card assembly Switch assembly A4A Circuit card assembly A Circuit card assembly A Circuit card assembly A Section III. SPECIAL TOOLS LIST (Not applicable)... Section IV. NATIONAL STOCK NUMBER AND PART NUMBER INDEX... I-1 i

2 DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST SECTION I. INTRODUCTION 1. Scope. This RPSTL lists and authorizes spares and repair parts required for performance of direct and general support maintenance of Vibration Transducer Calibration System (MIS-35934). It authorizes the requisitioning, issue, and disposition of spares and repair parts as indicated by the Source, Maintenance and Recoverability (SMR) codes. 2. General. In addition to this section I, Introduction, this Repair Parts and Special Tools List is divided into the following sections: a. Section II. Repair Parts List. A list of spares and repair parts authorized by this RPSTL for use in the performance of maintenance. Parts lists are composed of functional groups in ascending numeric sequence. Parts are listed in alphabetical sequence within each figure number. b. Section III. Special Tools List. Not applicable. c. Section IV. National Stock Number and Part Number Index. A list, in National Item Identification Number (NIIN) sequence, of all National Stock Numbered items (NSN) appearing in the listing, followed by a list in alphanumeric sequence of all part numbers appearing in the listing. NSN s and part numbers-are cross-referenced to the figure and item number appearance. 3. Explanation of Columns (Section II) a. Item No. (Column (1)). Indicates the number used to identify each item appearing in the listing. b. SMR CODE (Column (2)). The Source, Maintenance, and Recoverability (SMR) code is a 5-position code containing supply/requisitioning information, maintenance category authorization criteria, and disposition instructions as shown in the following breakdown: Source Maintenance Recoverability Code Code Code 1st 5th position XX two positions XX X How you get an item 3rd position 4th position Who determines disposition action on Who can install Who can do an unserviceable replace or use complete repair* item the item on the item *Complete Repair: Maintenance capacity, capability, and authority to perform all the corrective maintenance tasks of the "Repair" function in a use/user environment in order to restore serviceability to a failed item. 1

3 (1) Source Code. The source code tells you how you get an item needed for maintenance, repair, or overhaul of an end item/equipment. Source codes are always the first two positions of the SMR code. Explanation of source codes follows: Code PA - Explanation Stocked items; use the applicable NSN to request/requisition items with this code. This item is authorized to the category indicated by the code entered in the 3d position of the SMR code. (2) Maintenance Code. Maintenance codes tell you the level(s) of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of the SMR code as follows: (a) The maintenance code entered in the third position tells you the lowest maintenance level authorized to remove, replace, and use an item. The maintenance code entered in the third position will indicate authorization to the following level of maintenance. Code H Application/Explanation -General support category can remove, replace, and use the item. (b) The maintenance code entered in the fourth position tells you whether or not the item is to be repaired and identifies the lowest maintenance level with the capability to do complete repair (i.e., perform all authorized repair functions). This position will contain one of the following codes. Code H Z Application/Explanation -General support is the lowest category that can do complete repair of the item. -Nonreparable. No repair is authorized. (3) Recoverability Code. Recoverability codes are assigned to items to indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the SMR code as follows: Recoverability Codes Z H Definition -Nonreparable item. When unserviceable, condemn and dispose of the item at the level of maintenance shown In the third position of the SMR code. -Reparable item. When uneconomically reparable, condemn and dispose of the item at the general support level. c. FSCM (Column (3)). The Federal Supply Code for Manufacturer (FSCM) is a 5-digit numeric code which is used to identify the manufacturer, distributor, or Government agency, etc., that supplies the item. 2

4 d. PART NUMBER (Column (4)). Indicates the primary number used by the manufacturer (individual, company, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications standards, and inspection requirements to identify an item or range of items. NOTE: When you use an NSN to requisition an item, the item you receive may have a different part number from the part ordered, but go ahead and use or furnish it as the replacement part. e. DESCRIPTION AND USABLE ON CODE (UOC) (Column (S)). This column includes the following information: (1) The Federal item name and, when required, a minimum description to Identify the item. (2) The usable on code, when applicable (see paragraph 5, Special Information). f. QTY (Column (6)). The QTY (quantity per figure column) indicates the quantity of the item used in the parts list which is prepared for a functional group, subfunctional group, or an assembly. 4. Explanation of Columns (Section IV) a. NATIONAL STOCK NUMBER (NSN) INDEX (1) STOCK NUMBER column. This column lists the NSN by National Item Identification Number (NIIN) sequence. The NIIN consists of the last nine digits of the NSN NSN (i.e., ). When using this column to locate an Item, Ignore the first 4 digits of the NSN. However, the NIIN complete NSN should be used when ordering items by stock number. (2) FIG. column. Indicates the figure number used to identify each item appearing In the listing. The figures are in numerical order in Section II. (3) ITEM column. The item number identifies the item associated with the figure listed in the adjacent FIG. column. This item is also identified by the NSN listed on the same line. b. PART NUMBER INDEX. Part numbers in this index are listed by part number In ascending alphanumeric sequence (i.e., vertical arrangement of letter and number combination which places the first letter or digit of each group in order A through Z, followed by the numbers 0 through 9 and each following letter or digit in like order). (1) FSCM column. The Federal Supply Code for Manufacturer (FSCM) is a 5-digit numeric code used to identify the manufacturer, distributor, or Government agency, etc., that supplies the Item. (2) PART NUMBER column. Indicates the primary number used by the manufacturer (individual, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications standards, and Inspection requirements to identify an item or range of items. (3) STOCK NUMBER column. This column lists the NSN for the associated part number and manufacturer identified in the PART NUMBER and FSC.M columns to the left. The part number line entry (with NSN, when available) 3

5 identifies the first figure/item number appearance for which the part number is applicable. The part number is not listed for additional figure/item number appearances identified by that part number. (4) FIG. column. This column lists the number of the figure where the item is located in Section II. (5) ITEM column. The item number is that number assigned to the item as it appears in the figure referenced in the adjacent figure number column. 5. Special Information a. Repair parts for components of standards sets which can be identified as existing in the supply system will be requisitioned through normal supply channels from the appropriate supply commodity manager. b. Repair parts for components of standards sets which cannot be identified as to proper supply source will be requisitioned from USAMICOM, using routing identifier B64 and furnishing, as a minimum, the following as exception data. (1) Component stock number of the individual end item to be repaired. (2) Component manufacturer s equipment model number and serial number. (3) The equipment manufacturer s stock number as listed in the appropriate manual for the desired repair part. (4) The repair part reference designation, circuit reference, circuit symbol schematic designation, or reference number as listed in the manufacturer s manual. (5) The technical specification of the repair part as contained in the appropriate manufacturer s manual. (6) The title and date of the manufacturer s manual from which the information in a and b(3), (4), and (5) above was taken. c. For requisitioning miscellaneous consumable maintenance supplies or expendable supplies, use CTA d. The usable on code appears in the lower left corner of the Description column heading. Usable on codes are shown as "UOC" in the Description column (justified left) on the first line applicable item description/nomenclature. Uncoded items are applicable to all models. e. This RPSTL does not contain illustration for items listed in Section II, since the manufacturer s manuals contain exploded view illustrations which are adequate for repair parts location. Copies of the manufacturer s manuals on Unholtz- Dickie Model U-D 351-S2 are furnished with the equipment for which this RPSTL is prepared. The figure and item numbers in the listing are for locating the item within this RPSTL. 6. How to Locate Repair Parts a. When National Stock Number or Part Number is Not Known. 4

6 (1) First. Refer to the parts list to locate the item by description. This list is listed in alphabetical sequence within each figure number. (2) Second. After locating the item in the Repair Parts List, refer to the Part Number Index to find the NSN. b. When National Stock Number or Part Number is Known. (1) First. Using the Index of National Stock Numbers and Part Numbers, find the pertinent National Stock Number or Part Number. The NSN index is in National Item Identification Number (NIIN) sequence. The part numbers in the Part Number index are listed in ascending alphanumeric sequence. Both indexes cross-reference you to the illustration figure and item number of the item you are looking for. (2) Second. After finding the figure and item number, verify that the item is the one you re looking for, then locate the item number in the repair parts list for the figure. 7. Abbreviations. Not applicable. 5

7 SECTION II (1) (2) (3) (4) (5) (6) ITEM SMR PART NO. CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP FIGURE 1 VIBRATION, TRANSDUCER MIS (18876) 10 PAHZZ CAPACITOR,FIXED,MET PAHZZ TP36C CAPACITOR,VARIABLE PAHZZ CONNECTOR,RECEPTACL PAHZZ L0C328 CONNECTOR,RECEPTACL PAHZZ MS3102R18-4P CONNECTOR.RECEPTACL PAHZZ MS3102R14S1P CONNECTOR.RECEPTACL PAHZZ VTL2C2 COUPLER,OPTOELECTRO PAHZZ DISPLAY,OPTOELECTRO PAHZZ FUSE.CARTRIDGE PAHZZ F02A250V2A FUSE,CARTRIDGE PAHZZ RAW10 FUSE,CARTRIDGE PAHZZ F02B250V1-2AS FUSE.CARTRIDGE PAHZZ MICROCIRCUIT,LINEAR PAHZZ M38510/10103BGC MICROCIRCUIT.LINEAR PAHZZ MICROCIRCUIT,LINEAR PAHZZ UA7815UC MICROCIRCUIT,LINEAR PAHZZ LM320T-15 MICROCIRCUIT.LINEAR PAHZZ NE531N MICROCIRCUIT,LINEAR PAHZZ M38510/10201BCB MICROCIRCUIT,LINEAR PAHZZ MICROCIRCUIT,LINEAR PAHZZ M38510/00302BCB MICROCIRCUIT,DIGITA PAHZZ AD540J MICROCIRCUIT PAHZZ TL083MJ MICROCIRCUIT,LINEAR... I 240 PAHZZ P MICROCIRCUIT,LINEAR PAHZZ DG200BA MICROCIRCUIT,DIGITA PAHZZ B2113 PLATE DG PAHZZ PREAMPLIFIER,SCINTI PAHZZ RESISTOR,FIXED,WIRE PAHZZ RESISTOR,FIXED,WIRE PAHZZ B2092 RING-CLAMP PAHZZ JAN1N4460 SEMICONDUCTCR DEVIC PAHZZ JAN1N914 SEMICONDUCTCR DEVIC PAHZZ JAN1N1186 SEMICONDUCTCR DEVIC PAHZZ JAN1N938B SEMICONDUCTCR DEVIC PAHZZ SHEAR MOUNT PAHZZ SWITCH,TOGGLE PAHZZ N4919 TRANSISTOR... 1 GROUP FIGURE 2 OSCILLOSCOPE MIS Comp 8 (18876) 1200A/B (28480) 10 PAHZZ BEZEL,INSTRUMENT MC PAHZZ BUMPER,PLASTIC PAHZZ BUSHING,MACHINE THR PAHZZ CABLE ASSEMBLY,POWE PAHZZ CABLE.ASSEMBLY POWE PAHHH CIRCUIT CARD ASSEMB... 2 BOARDS,FOR PARTS SEE GROUP FIGURE PAHHH CIRCUIT CARD ASSEMB A3 BOARD,FOR 1 PARTS SEE GROUP 0060,FIGURE

8 SECTION II (1) (2) (3) (4) (5) (6) ITEM SMR PART NO. CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 80 PAHHH CIRCUIT CARD ASSEMB A5 BOARD,FCR... 1 PARTS SEE GROUP 0010),FIGURE PAHHH CIRCUIT CARD ASSEMB A6 BOARD,FOR 1 PARTS SEE GROUP 0110,FIGURE PAHHH CIRCUIT CARD ASSEMB A7 BOARD,FCR 1 PARTS SEE GROUP 0120.FIGURE PAHHH CIRCUIT CARD ASSEMB A4 BOARD,FOR 1 PARTS SEE GROUP 0070,FIGURE PAHZZ COIL,ELECTRICAL PAHZZ CONNECTOR,RECEPTACL PAHZZ COUPLING,SHAFT,RIGI PAHZZ ELECTRON TUBE PAHZZ FELT,MECHANICAL,PRE PAHZZ FILTER,LIGHT PAHZZ FD2B250V1-1/2A FUSE,CARTRIDGE PAHZZ FUSE CARTRIDGE PAHZZ FUSEHOLDER,EXTRACTO PAHZZ INSULATOR PAHZZ JACK,TIP PAHZZ KNOB PAHZZ KNOB PAHZZ KNOB PAHZZ KNOB PAHZZ KNOB PAHZZ KNOB PAHZZ KNOB PAHZZ KNOB PAHZZ POST,BINDING,ELECTR PAHZZ POST,BINDING,ELECTR PAHZZ RCR07G473JS RESISTOR,FIXED,COMP PAHZZ RCR07G104JS RESISTOR,FIXED,COMP PAHZZ RV2NAYSD503A RESISTOR,VARIABLE.N PAHZZ RESISTOR,VARIABLE,W PAHZZ RESISTOR,VARIABLE,N PAHZZ RV2NAYSD252A RESISTOR,VARIABLE,N PAHZZ SHIELD,LIGHT PAHZZ SOCKET,PLUG-IN.ELEC PAHZZ SUPPORT CIRCUIT PAHZZ SUPPORT,SHIELD PAHZZ SWITCH,PUSH PAHZZ A1242A SWITCH,SLIDE PAHZZ SWITCH,TOGGLE PAHZZ S TERMINAL BOARD PAHZZ TRANSFORMER,POWER PAHZZ TRANSISTOR PAHZZ TRANSISTOR PAHZZ B52600F12 WASHER,FLAT

9 SECTION II (1) (2) (3) (4) (5) (6) ITEM SMR PART NO. CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP FIGURE 3 CIRCUIT CARD ASSEMBLY (28480) 10 PAHZZ CAPACITOR SET,MATCH PAHHZ CIRCUIT CARD ASSEMB FOR PARTS SEE 1 GROUP 0040 FIGURE 4,A1A1 BOARD PAHZZ KNOB PAHZZ OSCILLOSCOPE SUBASS FOR PARTS SEE... 1 GROUP 0050 FIGURE 5,A1A2 BOARD PAHZZ SWITCH,LEVER... 2 GROUP FIGURE 4 CIRCUIT CARD ASSEMBLY (28480) 10 PAHZZ M39003/ CAPACITOR,FIXED,ELE PAHZZ M CAPACITOR.FIXED,CER M 30 PAHZZ C0G0-210 CAPACITOR,FIXED,CER... 2 F 40 PAHZZ C0G0-110G CAPACITOR.FIXED,CER PAHZZ CAPACITOR.FIXED,CER PAHZZ D106F1C0DC4 CAPACITOR,FIXED,ELE PAHZZ M39003/ CAPACITOR,FIXED,ELE PAHZZ CAPACITOR,FIXED,MIC PAHZZ P47352 CAPACITOR,FIXED,PLA PAHZZ R CAPACITOR,VARIABLE PAHZZ TXBE B HEAT SINK,ELECTRICA PAHZZ RCR07G101JS RESISTOR,FIXED,COMP PAHZZ RCR07G273JS RESISTOR,FIXED,COMP PAHZZ RCR07G474JS RESISTOR,FIXED,COMP PAHZZ RCR07G221JS RESISTOR,FIXED,COMP PAHZZ RCR07G333JS RESISTOR,FIXED,COMP PAHZZ RCR07G123JS RESISTOR,FIXED,COMP PAHZZ RNC70K1004FS RESISTOR,FIXED,FILM PAHZZ RNC70K4642FS RESISTOR,FIXED,FILM PAHZZ RNC55K8250FS RESISTOR,FIXED,FILM PAHZZ RNC55K2740FS RESISTOR.FIXED,FILM PAHZZ RNC55K1002FS RESISTOR,FIXED.FILM PAHZZ RNC55K1213FS RESISTOR.FIXED,FILM PAHZZ RNC55K5621FS RESISTOR,FIXED,FILM PAHZZ RNC55K4751FS RESISTOR,FIXED,FILM PAHZZ RNC55K3C12FS RESISTOR,FIXED,FILM PAHZZ RLR07C68R0GR RESISTOR,FIXED.FILM PAHZZ RESISTOR,VARIABLE,N PAHZZ SEMICONDUCTOR DEVIC PAHZZ SEMICONDUCTOR DEVIC PAHZZ JAN1N965B SEMICONDUCTOR DEVIC PAHZZ JAN1N754A SEMICONDUCTOR DEVIC

10 SECTION II (1) (2) (3) (4) (5) (6) ITEM SMR PART NO. CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 340 PAHZZ SEMICONDUCTOR DEVIC PAHZZ N3956 SEMICONDUCTOR DEVIC PAHZZ SEMICONDUCTOR DEVIC PAHZZ TRANSISTOR PAHZZ TRANSISTOR PAHZZ N3906 TRANSISTOR PAHZZ TRANSISTOR PAHZZ A TRANSISTOR... 2 GROUP FIGURE 5 OSCILLOSCOPE SUBASSEMBLY (28480) 10 PAHZZ CM15FD201F03 CAPACITOR.FIXED,MIC PAHZZ CV11C450 CAPACITOR.VARIABLE PAHZZ CV11A070 CAPACITOR,VARIABLE PAHZZ COUPLING,SHAFT,FLEX PAHZZ RESISTOR.FIXED.FILM PAHZZ RNC55K1022FS RESISTOR,FIXED,FILM PAHZZ RNC55K2002FS RESISTOR.FIXED,FILM PAHZZ RNC55K6651FS RESISTOR.FIXED,FILM PAHZZ RNC55K2211FS RESISTOR,FIXED,FILM PAHZZ RNC55K1051FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,FIXED,FILM PAHZZ RNC55K1000FS RESISITOR,FIXED,FILM PAHZZ RNC55K49R9FS RESISTOR,FIXED,FILM PAHZZ RNC55K20R0FS RESISTOR,FIXED,FILM PAHZZ RNC55K10R0FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,VARIABLE,W PAHZZ RESISTOR,VARIABLE,N... 1 GROUP FIGURE 6 CIRCUIT CARD ASSEMBLY (28480) 10 PAHZZ CAPACITOR,FIXED,CER PAHZZ C0K0-209 CAPACITOR,FIXED,CER... 4 C 30 PAHZZ CAPACITOR,FIXED,CER PAHZZ CK63AW103M CAPACITOR,FIXED,CER PAHZZ D106F100DC4 CAPACITOR,FIXED,ELE PAHZZ CMR05E620GODR CAPACITOR,FIXED,MIC PAHZZ CAPACITOR,FIXED.MIC PAHZZ CAPACITOR,FIXED,MIC PAHZZ CAPACITOR,FIXED,PAP PAHZZ MS COIL,RADIO FREQUENC PAHZZ RCR07G471JS RESISTOR,FIXED,COMP PAHZZ RCR07G125JS RESISTOR FIXED,COMP PAHZZ RCR07G105JS RESISTOR,FIXED,COMP PAHZZ RCR07G221JS RESISTOR,FIXED.COMP

11 SECTION II (1) (2) (3) (4) (5) (6) ITEM SMR PART NO. CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 150 PAHZZ RNC70K1301FS RESISTOR,FIXED.FILM PAHZZ RESISTOR,FIXED,FILM PAHZZ RNC55K1002FS RESISTOR.FIXED.FILM PAHZZ RNC55K1211FS RESISTOR,FIXED,FILM PAHZZ RNC55K13C2FS RESISTOR.FIXED.FILM PAHZZ RNC55K1000FS RESISTOR,FIXED,FILM PAHZZ RNC55K4322FS RESISTOR,FIXED,FILM PAHZZ RNC55H7503FS RESISTOR,FIXED,FILM PAHZZ RNC55K2611FS RESISTOR,FIXED,FILM PAHZZ RNC55K1332FS RESISTOR,FIXED,FILM PAHZZ RNC55K51R1FS RESISTOR,FIXED,FILM PAHZZ RNC55K68R1FS RESISTOR,FIXED,FILM PAHZZ RNC55K3163FS RESISTOR,FIXED,FILM PAHZZ RNC55K1621FS RESISTOR,FIXED,FILM PAHZZ RNC55K5111FS RESISTOR.FIXED,FILM PAHZZ RNC55K3321FS RESISTOR,FIXED,FILM PAHZZ RNC55K1102FS RESISTOR,FIXED,FILM PAHZZ RNC55K8251FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,FIXED,FILM PAHZZ RNC55K4320FS RESISTOR,FIXED,FILM PAHZZ RNC55K5112FS RESISTOR,FIXED,FILM PAHZZ RNC55K1213FS RESISTOR,FIXED,FILM PAHZZ RNC55K4220FS RESISTOR.FIXED,FILM PAHZZ RESISTOR,FIXED,FILM PAHZZ RESISTOR,VARIABLE,N PAHZZ SEMICONDUCTOR DEVIC PAHZZ N3956 SEMICONDUCTOR DEVIC PAHZZ TRANSISTOR PAHZZ JAN2N344C TRANSISTOR PAHZZ TRANSISTOR PAHZZ N3906 TRANSISTOR... 2 GROUP FIGURE 7 CIRCUIT CARD ASSEMBLY (28480) 10 PAHZZ M39003/ CAPACITOR,FIXED,ELE PAHZZ CAPACITOR,VARIABLE PAHHZ CIRCUIT CARD ASSEMB FOR PARTS SEE 1 GROUP 0080 FIGURE PAHZZ RNC60K9093FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,FIXED,COMP PAHZZ RESISTOR,VARIABLE,N PAHZZ RV2NAYSD203A RESISTOR,VARIABLE,N PAHZZ SWITCH ASSEMBLY, RO A4A2 BOARD,FOR PARTS SEE 1 GROUP 0090, FIGURE PAHZZ SWITCH,LEVER PAHZZ SWITCH,LEVER PAHZZ SWITCH,LEVER PAHZZ SWITCH.LEVER PAHZZ SWITCH,PUSH

12 SECTION II (1) (2) (3) (4) (5) (6) ITEM SMR PART NO. CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP FIGURE 8 CIRCUIT CARD ASSEMBLY (28480) 10 PAHZZ M39003/ CAPACITOR,FIXED,ELE PAHZZ CK60AWI02M CAPACITOR,FIXED,CER PAHZZ CAPACITOR,FIXED,CER PAHZZ C0G0-110G CAPACITOR,FIXED,CER PAHZZ CC22UJ270F CAPACITOR,FIXED,CER PAHZZ CK63AW103M CAPACITOR,FIXED,CER PAHZZ CM10FD201G03 CAPACITOR,FIXED,MIC PAHZZ CAPACITOR,FIXED,MIC PAHZZ RCR07G105JS RESISTOR,FIXED,COMP PAHZZ RESISTOR,FIXED,COMP PAHZZ RCR07G104JS RESISTOR,FIXED,COMP PAHZZ RCR07G333JS RESISTOR,FIXED,COMP PAHZZ RCR07G474JS RESISTOR.FIXED,COMP PAHZZ RCR07G221JS RESISTOR.FIXED,COMP PAHZZ RCR20G153JS RESISTOR,FIXED,COMP PAHZZ RESISTOR,FIXED,COMP PAHZZ RESISTOR,FIXED,COMP PAHZZ RNC55K3922FS RESISTOR,FIXED,FILM PAHZZ RNC60K5111FS RESISTOR.FIXED,FILM PAHZZ RNC55K4641FS RESISTOR,FIXED,FILM PAHZZ RNC55K2212FS RESISTOR,FIXED,FILM PAHZZ RNC55K4751FS RESISTOR,FIXED,FILM PAHZZ RNC60K1821FS RESISTOR,FIXED,FILM PAHZZ RNC55K1212FS RESISTOR,FIXED,FILM PAHZZ RNC55K3011FS RESISTOR,FIXED,FILM PAHZZ RNC60K1002FS RESISTOR,FIXED,FILM PAHZZ RNC55K1502FS RESISTOR,FIXED,FILM PAHZZ RNC55K1001FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,FIXED,FILM PAHZZ RNC55K1623FS RESISTOR,FIXED,FILM PAHZZ RLR07C1503GS RESISTOR,FIXED,FILM PAHZZ RNC55K1501FS RESISTOR.FIXED,FILM PAHZZ RNC55K1332FS RESISTOR,FIXED,FILM PAHZZ RNC55K1102FS RESISTOR,FIXED,FILM PAHZZ RNC55K3012FS RESISTOR,FIXED,FILM PAHZZ RNC60K4222FS RESISTOR,FIXED,FILM PAHZZ RNC55K6811FS RESISTOR,FIXED,FILM PAHZZ RNC55J2741FS RESISTOR.FIXED,FILM PAHZZ RNC55K9091FS RESISTOR,FIXED,FILM PAHZZ RNC55K2002FS RESISTOR,FIXED,FILM PAHZZ RNC55K4752FS RESISTOR,FIXED,FILM PAHZZ RNC55K1003FS RESISTOR,FIXED,FILM PAHZZ RNC60K6191FS RESISTOR,FIXED,FILM PAHZZ RNC55K3920FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,VARIABLE,N PAHZZ RESISTOR,VARIABLE,N PAHZZ RESISTOR,VARIABLE,N

13 SECTION II (1) (2) (3) (4) (5) (6) ITEM SMR PART NO. CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 510 PAHZZ RESISTOR,VARIABLE,N PAHZZ N3956 SEMICONDUCTOR DEVIC PAHZZ SEMICONDUCTOR DEVIC PAHZZ SEMICONDUCTOR DEVIC PAHZZ JAN1N758A SEMICONDUCTOR DEVIC PAHZZ JAN1N965B SEMICONDUCTOR DEVIC PAHZZ JAN1N753A SEMICONDUCTOR DEVIC PAHZZ SEMICONDUCTOR DEVIC PAHZZ TRANSISTOR PAHZZ N3906 TRANSISTOR PAHZZ TRANSISTOR PAHZZ TRANSISTOR PAHZZ TRANSISTOR... 1 GROUP FIGURE 9 SWITCH ASSEMBLY (28480) 10 PAHZZ CABLE ASSEMBLY-SWIT PAHZZ Z5UC 103M CAPACITOR,FIXED,CER PAHZZ C0G0-110G CAPACITOR,FIXED,CER PAHZZ CAPACITOR.FIXED,MIC PAHZZ CAPACITOR,FIXED,PAP PAHZZ P33252 CAPACITOR,FIXED,PLA PAHZZ CAPACITOR,FIXED,PLA PAHZZ P10452 CAPACITOR,FIXED,PLA PAHZZ CAPACITOR,FIXED,PLA PAHZZ CAPACITOR,FIXED,PLA PAHZZ COUPLING,SHAFT,FLEX PAHZZ RNC55K1212FS RESISTOR,FIXED,FILM PAHZZ RNC60K1004FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,FIXED,FILM PAHZZ PME70T0-3005F RESISTOR,FIXED,FILM PAHZZ RNC55K1003FS RESISTOR,FIXED,FILM PAHZZ RNC55K2003FS RESISTOR,FIXED,FILM PAHZZ RNC55K1742FS RESISTOR,FIXED,FILM PAHZZ RNC55K1823FS RESISTOR,FIXED,FILM PAHZZ RNC55K3923FS RESISTOR,FIXED,FILM PAHZZ RNC55K3922FS RESISTOR,FIXED,FILM PAHZZ RNC55K3012FS RESISTOR,FIXED,FILM PAHZZ RNC55K1623FS RESISTOR,FIXED,FILM PAHZZ RNC55K1002FS RESISTOR,FIXED.FILM PAHZZ RNC55K4992FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,VARIABLE,N PAHZZ N3956 SEMICONDUCTOR DEVIC PAHZZ SWITCH ASSEMBSLY, RO PAHZZ SWITCH,ROTARY PAHZZ TRANSISTOR

14 SECTION II (1) (2) (3) (4) (5) (6) ITEM SMR PART NO. CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP FIGURE 10 CIRCUIT CARD ASSEMBLY (28480) 10 PAHZZ CAPACITOR,FIXED,ELE PAHZZ CAPACITOR,FIXED,ELE PAHZZ M39003/ CAPACITOR,FIXED,ELE PAHZZ CAPACITOR,FIXED,ELE PAHZZ M39003/ CAPACITOR,FIXED,ELE PAHZZ P10452 CAPACITOR,FIXED,PLA PAHZZ CLIP,ELECTRICAL PAHZZ F02A250V1/2A FUSE,CARTRIDGE PAHZZ F02A250V1/4A FUSE,CARTRIDGE PAHZZ RCR07G332JS RESISTOR,FIXED,COMP PAHZZ RCR07G103JS RESISTOR,FIXED,COMP PAHZZ RCR07G474JS RESISTOR,FIXED,COMP PAHZZ RCR07G333JS RESISTOR,FIXED,COMP PAHZZ RCR07G563JS RESISTOR,FIXED,COMP PAHZZ RCR07G102JS RESISTOR,FIXED,COMP PAHZZ RESISTOR.FIXED,FILM PAHZZ RNC55K1000FS RESISTOR,FIXED,FILM PAHZZ RCR07G104JS RESISTOR,FIXED,COMP PAHZZ RNC55K43R2FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,FIXED,FILM PAHZZ RNC60K1182FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,FIXED,FILM PAHZZ RNC55K3321FS RESISTOR,FIXED,FILM PAHZZ RNC60K1502FS RESISTOR,FIXED,FILM PAHZZ RNC55K2870FS RESISTOR,FIXED,FILM PAHZZ RNC60K6811FS RESISTOR,FIXED,FILM PAHZZ RNC60K1272FS RESISTOR,FIXED,FILM PAHZZ RNC60K1242FS RESISTOR.FIXED,FILM PAHZZ RNC55K2212FS RESISTOR,FIXED.FILM PAHZZ RNC55K4322FS RESISTOR,FIXED.FILM PAHZZ RNC55K2002DS RESISTOR,FIXED,FILM PAHZZ RNC55H2862BS RESISTOR,FIXED,FILM PAHZZ RESISTOR,VARIABLE,N PAHZZ JAN1N979B SEMICONDUCTOR DEVIC PAHZZ JAN1N752A SEMICONDUCTOR DEVIC PAHZZ JAN1N941B SEMICONDUCTOR DEVIC PAHZZ N3956 SEMICONDUCTOR DEVIC PAHZZ SEMICONDUCTOR DEVIC PAHZZ JAN1N5614 SEMICONDUCTCR DEVIC PAHZZ TRANSISTOR PAHZZ TRANSISTOR PAHZZ N3906 TRANSISTOR PAHZZ TRANSISTOR

15 SECTION II (1) (2) (3) (4) (5) (6) ITEM SMR PART NO. CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP FIGURE 11 CIRCUIT CARD ASSEMBLY (28480) 10 PAHZZ CAPACITOR,FIXED,CER PAHZZ CAPACITOR,FIXED,CER PAHZZ X5U0503M CAPACITOR,FIXED,CER PAHZZ CAPACITOR,FIXED,CER PAHZZ CAPACITCR.FIXED,ELE PAHZZ D106F100DC4 CAPACITOR,FIXED,ELE PAHZZ CAPACITOR,FIXED,PLA PAHZZ P22492XB2 CAPACITOR,FIXED,PLA PAHZZ P33352 CAPACITOR,FIXED,PLA PAHZZ MS COIL,RADIO FREOUENC PAHZZ MS COIL,RADIO FREQUENC PAHZZ LAMP,GLOW PAHZZ RCR20G222JS RESISTOR,FIXED,COMP PAHZZ RCR07G102JS RESISTOR,FIXED,COMP PAHZZ RESISTOR,FIXED,COMP PAHZZ RCR20G100JS RESISTOR,FIXED,COMP PAHZZ RCR07G221JS RESISTOR,FIXED,COMP PAHZZ RCR07G151JS RESISTOR.FIXED,COMP PAHZZ RCR20G563JS RESISTOR,FIXED,COMP PAHZZ RCR07G105JS RESISTOR,FIXED,COMP PAHZZ RCR20G121JS RESISTOR,FIXED,COMP PAHZZ RCR07G473JS RESISTOR,FIXED,COMP PAHZZ RNC55K3320FS RESISTOR,FIXED,FILM PAHZZ RNC55K4322FS RESISTOR.FIXED,FILM PAHZZ RNC60K1502FS RESISTOR,FIXED,FILM PAHZZ RNC55K1001FS RESISTOR,FIXED,FILM PAHZZ RESISTOR.FIXED,FILM PAHZZ RESISTOR,FIXED,FILM PAHZZ RNC55K2372FS RESISTOR,FIXED,FILM PAHZZ RNC55K6811FS RESISTOR,FIXED,FILM PAHZZ RNC55K5111FS RESISTOR,FIXED,FILM PAHZZ RNC60K6193FS RESISTOR,FIXED,FILM PAHZZ RNC70K4122FS RESISTOR,FIXED,FILM PAHZZ RL42S432GTX RESISTOR,FIXED,FILM PAHZZ RNC55K1003FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,FIXED,FILM PAHZZ RNC55K1101FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,FIXED,FILM PAHZZ RNC55K3922FS RESISTOR,FIXED,FILM PAHZZ RNC55K8061FS RESISTOR,FIXED,FILM PAHZZ RNC55K8252FS RESISTOR,FIXED,FILM PAHZZ RESISTOR,VARIABLE,N PAHZZ RESISTOR,VARIABLE,N PAHZZ JAN1N751A SEMICONDUCTOR DEVIC PAHZZ SEMICONDUCTOR DEVIC PAHZZ SEMICONDUCTOR DEVIC PAHZZ N3956 SEMICONDUCTOR DEVIC

16 SECTION II (1) (2) (3) (4) (5) (6) ITEM SMR PART NO. CODE FSCM NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 530 PAHZZ TRANSISTOR PAHZZ N3906 TRANSISTOR PAHZZ TRANSISTOR PAHZZ TRANSISTOR PAHZZ TRANSISTOR PAHZZ TRANSISTOR PAHZZ FD3 WASHER,FLAT... 1 GROUP FIGURE 12 CIRCUIT CARD ASSEMBLY (28480) 10 PAHZZ CAPACITOR,FIXED,CER PAHZZ RCR07G153JS RESISTOR,FIXED,COMP PAHZZ RESISTOR,FIXED,COMP PAHZZ SEMCONDUCTOR DEVIC PAHZZ TRANSFORMER,POWER

17 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-1

18 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-2

19 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-3

20 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-4

21 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM AD540J A B B CC22UJ270F CK60AW102M CK63AW103M CMR05E620GODR CM10FD201G CM15FD201F CV11A CV11C DG200BA F02A250V1/2A F02A250V1/4A F02A250V2A F02B250V1-1/2A F02B250V1-2AS JAN1N JAN1N JAN1N JAN1N751A JAN1N752A JAN1N753A JAN1N754A JAN1N758A JAN1N JAN1N938B JAN1N941B JAN1N965B JAN1N979B JAN2N KAW LM320T L MS MS3102R14S1P MS3102R18-4P MS MS M38510/00302BCB M36510/10103BGC M38510/10201BCB M39003/ M39003/ M39003/ M39003/ I-5

22 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM NE531N PME70T0-3005F RCR07G101JS RCR07G102JS RCR07G103JS RCR07G104JS RCR07GI05JS RCR07G123JS RCR07G125JS RCR07G125JS RCR07G153JS RCR07G221JS RCR07G273JS RCR07G332JS RCR07G333JS RCR07G471JS RCR07G473JS RCR07G474JS RCR07G563JS RCR20G100JS RCR20G121JS RCR20G153JS RCR20G222JS RCR20G563JS RLR07C1503GS RLR07C68ROGR RL42S432GTX RNC55H2862BS RNC55H7503FS RNC55J2741FS RNC55K10R0FS RNC55K100CFS RNC55K1001FS RNC55K1002FS I-6

23 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM RNC55K1002FS RNC55K1003FS RNC55K1022FS RNC55K1051FS RNC55K1101FS RNC55K1102FS RNC55K1211FS RNC55K1212FS RNC55K1213FS RNC55K1302FS RNC55K1332FS RNC55K1501FS RNC55K1502FS RNC55K1621FS RNC55K1623FS RNC55K1742FS RNCS5K1823FS RNC55K20R0FS RNC55K2002DS RNC55K2002FS RNC55K2003FS RNC55K2211FS RNC55K2212FS RNC55K2372FS RNC55K2611FS RNC55K2740FS RNC55K2870FS RNC55K3011FS RNC55K3012FS RNC55K3163FS RNC55K3320FS RNC55K3321FS RNC55K3920FS RNC55K3922FS RNC55K3923FS RNC55K4220FS RNC55K43R2FS I-7

24 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM RNC55K4320FS RNC55K4322FS RNC55K4641FS RNC55K4751FS RNC55K4752FS RNC55K49R9FS RNC55K4992FS RNC55K51R1FS RNC55K5111FS RNC55K5112FS RNC55K5621FS RNC55K6651FS RNC55K68R1FS RNC55K6811FS RNC55K8061FS RNC55K8250FS RNC55K8251FS RNC55K8252FS RNC55K9091FS RNC60K1002FS RNC60K1004FS RNC60K1182FS RNC60K1242FS RNC60K1272FS RNC60K1502FS RNC60K1821FS RNC60K4222FS RNC60K5111FS RNC60K6191FS RNC60K6193FS RNC60K6311FS RNC60K9093FS RNC70K1004FS RNC70K1301FS RNC70K4122FS RNC70K4642FS RV2NAYSD203A RV2NAYSD252A RV2NAYSD503A SCC TL083MJ TP36C TXBE B UA7815UC VTL2C I-8

25 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM I-9

26 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM Z M N A1242A B52600FD B52600F I-10

27 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM N N I-11

28 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX FSCM PART NUMBER STOCK NUMBER FIG. ITEM P22492XB P P P P D106F100DC G F K C G0-110G P R M M X5U0503M I-12

29 By Order of the Secretary of the Army: Official: R. L. DILWORTH Brigadier General, United States Army The Adjutant General JOHN A. WICKHAM, JR. General, United States Army Chief of Staff Distribution: To be distributed in accordance with DA Form 12-34C, Block No. 319, requirements for calibration procedures publications. U.S. GOVERNMENT PRINTING OFFICE: /40636

30 PIN:

31 This fine document... Was brought to you by me: Liberated Manuals -- free army and government manuals Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap watermarks and other junk on it, and sell it. Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it... They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends? I am setting this document FREE. This document was made by the US Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on. I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines: <A HREF= Military and Government Manuals</A> Sincerely Igor Chudov Chicago Machinery Movers