SIGNAL GENERATOR, SG-1171/U

Transcription

1 TM P TECHNICAL MANUAL ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR SIGNAL GENERATOR, SG-1171/U (NSN ) HEADQUARTERS, DEPARTMENT OF THE ARMY 20 APRIL 1984

2

3 TM P Technical Manual No P HEADQUARTERS DEPARTMENT OF THE ARMY Washington, DC, 20 April 1984 ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR SIGNAL GENERATOR SG-1171/U (NSN ) Current as of 29 December 1983 REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this manual. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Mail your letter, DA Form 2028 (Recommended Changes to Publications and Blank Forms), or DA Form located in back of this manual direct to Commander, US Army Communications- Electronics Command and Fort Monmouth, ATTN: DRSEL-ME-MP, Fort Monmouth, NJ In either case, a reply will be furnished direct to you. TABLE OF CONTENTS Page Illus Figure Section I. Introduction II. Repair Parts List Group 00 Signal Generator SG-1171/U Main Board Assembly Auxiliary Board Assembly Front Panel Assembly Rear Panel Assembly Cover Assembly Section III. Special Tools List (Not Applicable) IV. National Stock Number and Part Number Index l/(ii blank)

4

5 TM P SECTION I INTRODUCTION 1. Scope This manual lists spares and repair parts; special tools; special test, measurement, and diagnostic equipment (TMDE), and other special support equipment required for performance of organizational, direct support, and general support maintenance of the SG-1171/U. It authorizes the requisitioning and issue of spares and repair parts as indicated by the source and maintenance codes. 2. General This Repair Parts and Special Tools List is divided into the following sections: a. Section II. Repair Parts List. A list of spares and repair parts authorized for use in the performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in numeric sequence, with the parts in each group listed in figure and item number sequence. b. Section III. Special Tools List. Not applicable. c. Section IV. National Stock Number and Part Number Index. A list, in National item identification number (NIIN) sequence, of all National stock numbers (NSN) appearing in the listings, followed by a list, in alphameric sequence, of all part numbers appearing in the listings. National stock numbers and part numbers are cross-referenced to each illustration figure and item number appearance. 3. Explanation of Columns a. Illustration. This column is divided as follows: (1) Figure number. Indicates the figure number of the illustration on which the item is shown. (2) Item number. The number used to identify item called out in the illustration. b. Source, Maintenance, and Recoverability (SMR) Codes. (1) Source code. Source codes indicate the manner of acquiring support items for maintenance, repair, or overhaul of end items. Source codes are entered in the first and second positions of the Uniform SMR Code format as follows: Code Definition PA -- Item procured and stocked for anticipated or known usage. PC -- Item procured and stocked and which otherwise would be coded PA except that it is deteriorative in nature. PC -- Item procured and stocked to provide for sustained support for the life of the equipment. It is applied to an item peculiar to the equipment which, because of probable discontinuance or shutdown of production facilities, would prove uneconomical to reproduce at a later time. XA -- Item is not procured or stocked because the requirements for the item will result in the replacement of the next higher assembly. XB -- Item is not procured or stocked. If not available through salvage, requisition. XD -- A support item that is not stocked. When required, item will be procured through normal supply channels. 1

6 TM P NOTE Cannibalization or salvage may be used as a source of supply for any items source coded above except those coded XA and aircraft support items as restricted by AR (2) Maintenance code. Maintenance codes are assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth format (a) The maintenance code entered in the third position will indicate the lowest maintenance level authorized to remove replace, and use the support item. The maintenance code entered in the third position will indicate one of the fol lowing levels of maintenance: Code O H positions of the Uniform SMR Code as follows: Application/Explanation -- Support item is removed, replaced, used at the organizational level. -- Support item is removed, replaced, used at the general support level. (b) The maintenance code entered in the fourth position indicates whether the item is to be repaired and identifies the lowest maintenance level with the capability to perform complete repair (i.e., all authorized maintenance functions). This position will contain one of the following maintenance codes: Code Application/Explanation on unserviceable items. The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows: Recoverability codes Definition H -- The lowest maintenance level capable of complete repair of the support item is the general support level. z -- Nonreparable. No repair is authorized. g. Unit of Measure (U/M). Indicates the standard of the basic quantity of (3) Recoverability code. Recoverability codes are assigned to support the actual maintenance function. This the listed item as used in performing items to indicate the disposition action measure is expressed by a two-character z -- Nonreparable item. When unserviceable, condemn and dispose at the level indicated in position 3. H -- Reparable item. When uneconomically reparable, condemn and pose at the general support c. National Stock Number. Ind the National stock number assigned the item and will be used for requi tioning purposes. dislevel. icates to sid. Federal Supply Code for Manufacturer (FSCM). The FSCM is a 5-digit numeric code listed in SB /42 which is used to identify the manufacturer, distributor, or Government agency, etc. e. Part Number. Indicates the primary number the manufacturer (individual, company, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications, standards, and inspection requirements to identify an item or range of items. NOTE When a stock numbered item is requisitioned, the repair part received may have a different part number than the part being replaced. f. Description. Indicates the Federal item name and, if required, a minimum description to identify the item. 2

7 TM P alphabetical abbreviation (e.e., ea, in, pr, etc). When the unit of measure differs from the unit of issue, the lowest unit of issue that will satisfy the required units of measure will be requisitioned. h. Quantity Incorporated in Unit. Indicates the quantity of the item used in the breakout shown-on the illustration figure, which is prepared for a functional group, subfunctional group, or an assembly. 4. Special Information a. The following publications pertain to SG-1171/U and its components: TM , Signal Generator, SG-1171/U (To be published.) TM , Signal Generator, SG-1171/U (To be published.) b. National stock numbers (NSN S) that are missing from P source coded items have been applied for and will be added to this TM by future change/revision when they are entered in the Army Master Data File (AMDF). Until the NSN S are established and published, submit exception requisitions to: Commander, US Army Communications-Electronics Command and Fort Monmouth, ATTN: DRSEL-MM, Fort Monmouth, NJ for the part required to support your equipment. (3) Third. Identify the item on the illustration and note the illustration figure and item number of the item. (4) Fourth. Using the Repair Parts Listing, find the figure and item number noted on the illustration. b. When National stock number or part number is known. (1) First. Using the Index of National Stock Numbers and part Numbers, find the pertinent National stock number or part number. This index is in NIIN sequence followed by a list of part numbers in alphameric sequence, cross-referenced to the illustration figure number and item number. (2) Second. After finding the figure and number, locate the figure and item number in the repair parts list. 6. Abbreviations Not applicable. (Next printed page is 4.) 5. How to Locate Repair Parts a. When National stock number or part number is unknown. (1) First. Using the table of contents, determine the functional group within which the item belongs. This is necessary since illustrations are prepared for functional groups and listings are divided into the same groups. (2) Second. Find the illustration covering the functional group to which the item belongs. 3

8 TM P Figure 1. 4

9 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT GROUP 00 SIGNAL GENERATOR SG-1171/0 1 1 XBHZZ COVER ASSY EA PAHZZ P37AS440R5C SCREW,SELF-LOCKING EA PAHZZ LP22D62P6 SCREW,SELF-LOCKING EA PAHZZ STANDOFF EA PAHZZ MS SCREW,MACHINE EA PAHHH CIRCUIT CARD ASSEMB EA PAHHH CIRCUIT CARD ASSEMB EA PAHZZ MS SCREW,MACHINE EA PAHZZ MS WASHER,LOCK EA PADZZ RD-67-1-SB KNOB EA XBHZZ AD32A8S RIVET EA PAOZZ PB-67-1-SB-R KNOB EA XBHZZ PLATE,IDENT EA PAHZZ TY-523M STRAP,TIEDOWN,ELECT EA XBHHH PANEL ASSY,FRONT EA XBHHH PANEL ASSY,REAR EA PAOZZ CORD ASSEMBLY,ELECT EA PAHZZ M03-F STANDOFF EA PAHZZ M03-F STANDOFF EA 4 5/(6 BLANK)

10

11 TM P Figure 2. Main Board Assembly (Sheet 1 of 4). 7

12 TM P Figure 2. 8

13 TM P Figure 2. 9

14 TM P Figure 2. 10

15 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT GROUP 01 MAIN BOARD PCA (A1) 2 1 PAHZZ DAP MOUNTING PAD,ELECTR EA PAHZZ HEAT SINK,ELECTRICA EA PAHZZ HEAT SINK,ELECTRICA EA PAHZZ Z TERMINAL,STUD EA XBHZZ SPACER EA PAHZZ B51547F015 INSULATOR,BUSHING EA PAHZZ MS WASHER,FLAT EA PAHZZ MS NUT,PLAIN,HEXAGON EA PAHZZ MS SCREW,MACHINE EA PAHZZ MS WASHER,LOCK EA PAHZZ TERMINAL EA PAHZZ N SPACER EA PAHZZ SWITCH,ROTARY EA PAHZZ POTENTIONMETER EA PAHZZ POT-SWITCH EA PAHZZ SWITCH,ROTARY EA PAHZZ SWITCH ASSY,SW5 EA PAHZZ CAPACITOR,FIXED,CER EA PAHZZ CK50BX100K CAPACTOR,FIXED,CER EA PAHZZ DD-101 CAPACITOR,FIXED,CER EA PAHZZ DD102 CAPACITOR,FIXED,CER EA PAHZZ CAC02Z50103Z100A CAPACITOR,FIXED,CER EA PAHZZ CAC03Z5U104Z050A CAPACITOR,FIXED,CER EA PAHZZ DDT60N150KAB CAPACITOR,FIXED,CER EA PAHZZ CK60BX220K CAPACITOR,FIXED,CER EA PAHZZ CK60AX221K CAPACITOR,FIXED,CER EA PAHZZ DD-222SLL CAPACITOR,FIXED,CER EA PAHZZ DD-300 CAPACITOR,FIXED,CER EA PHAZZ CK60AX331K CAPACITOR,FIXED,CER EA PAHZZ DD-561SLL CAPAICTOR,FIXED,CER EA PAHZZ DD-680 CAPACITOR,FIXED,CER EA PAHZZ DD-681 CAPACITOR,FIXED,CER EA PAHZZ CMR05F101GODR CAPACITOR,FIXED,MIC EA PAHZZ DM15-150J CAPACITOR,FIXED,MIC EA PAHZZ DM15-221J CAPACITOR,FIXED,MIC EA PAHZZ DM15-300J CAPACITOR,FIXED,MIC EA PAHZZ CMR05E470GUDR CAPACITOR,FIXED,MIC EA PAHZZ DM15-680J CAPACITOR,FIXED,MIC EA 2 11

16 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT 2 40 PAHZZ DM15F821F0300WV4 CAPACITOR,MICA EA CR 2 41 PAHZZ L0LB1EV4R7S CAPACITOR,FIXED ELE EA PAHZZ P10291WD3 CAPACITOR,FIXED,PLA EA PAHZZ P10391WD3 CAPACITOR,FIXED,PLA EA PAHZZ P10491WD3 CAPACITOR,FIXED,PLA EA PAHZZ P10591YD3 CAPAICTOR,FIXED,PLA EA PAHZZ STRIRO /1 CAPACITOR,VARIABLE EA PF 2 47 PAHZZ F1560 CAPAICTOR,FIXED CER EA PAHZZ D105X9035AS CAPACITOR,FIXED,ELE EA PAHZZ CAPACITOR,FIXED,ELE EA PAHZZ CAPACITOR SET,MATCH EA PAHZZ CONNECTOR,PLUG,ELEC EA PAHZZ SOCKET COAXIAL EA PAHZZ SPRING,SOCKET EA PAHZZ CONNECTOR,RECEPTACL EA PAHZZ INSULATOR,STANDOFF EA PAHZZ /3B COIL,RADIO FREQUENC EA PAHZZ AR1K RESISTOR,VARIABLE,N EA PAHZZ AR10K RESISTOR,VARIABLE,N EA PAHZZ AR100K RESISTOR,VARAIBLE,N EA PAHZZ AR200 RESISTOR,VARIABLE,N EA PAHZZ AR2K RESISTOR,VARIABLE,N EA PAHZZ RCR20G220JS RESISTOR,FIXED,COMP EA PAHZZ RCR20G101JS RESISTOR,FIXED,COMP EA PAHZZ RCR20G165JS RESISTOR,FIXED,COMP EA PAHZZ RCR20G275JS RESISTOR,FIXED,COMP EA PAHZZ RCR20G515JS RESISTOR EA PAHZZ RCR20G821JS RESISTOR,FIXED,COMP EA PAHZZ RNR FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1001FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1002FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1003FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D10R0FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1052FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1101FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1240FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1302FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1500FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1501FM RESISTOR,FIXED,FILM EA 14 12

17 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT 2 79 PAHZZ RNR55D1502FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1503FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D15R0FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1621FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1650FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1781FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1912FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1961FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1962FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2000FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2001FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2052FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2150FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D21R5FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2210FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2211FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2371FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2490FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2491FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2492FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D27R4FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2871FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D3011FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D3012FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D3160FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D3322FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D33R2FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D3651FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D3920FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D42R2FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4640FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4641FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D46R4FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4751FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4990FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4991FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4992FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D5110FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D51R1FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D5230FM RESISTOR,FIXED,FILM EA 2 13

18 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT PAHZZ RNR55D5491FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D54R9FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D5760FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D5761FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D6040FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D6191FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D61R9FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D68R1FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D6981FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D7500FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D7501FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D7871FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D82R5FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D90R9FM RESISTOR,FIXED,FILM EA PAHZZ RNR60D1001FM RESISTOR,FIXED,FILM EA PAHZZ RNR60D1004FM RESISTOR,FIXED,FILM EA PAHZZ RNR60D1501FM RESISTOR,FIXED,FILM EA PAHZZ RNR60D4993FM RESISTOR,FIXED,FILM EA PAHZZ RNR60D6190FM RESISTOR EA PAHZZ RNR60D6983FM RESISTOR,FIXED,FILM EA PAHZZ RNR60D7500FM RESISTOR,FIXED,FILM EA PAHZZ RNR65D1210FM RESISTOR,FIXED,FILM EA PAHZZ RNR70D1000FM RESISTOR,FIXED,FILM EA PAHZZ RESISTOR,SET EA PAHZZ ML181 RESISTOR EA PAHZZ JANTX1N746A SEMICONDUCTOR DEVIC EA PAHZZ N823A SEMICONDUCTOR DEVIC EA PAHZZ FD777 SEMICONDUCTOR DEVIC EA PAHZZ JANTX1N4148 SEMICONDUCTOR DEVIC EA PAHZZ JAN1N5712 SEMICONDUCTOR DEVIC EA PAHZZ SEMICONDUCTOR DEVIS EA PAHZZ SEMICONDUCTOR DEVIC EA PAHZZ LD36-C LIGHT EMITTING DIOD EA PAHZZ JANTX2N2905A TRANSISTOR EA PAHZZ JANTX2N3468 TRANSISTOR EA PAHZZ N3563 TRANSISTOR EA PAHZZ N3565 TRANSISTOR EA PAHZZ JAN2N869A TRANSISTOR EA PAHZZ N3725 TRANSISTOR EA 1 14

19 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT PAHZZ JANTX2N3866 TRANSISTOR EA PAHZZ N3903 TRANSISTOR EA PAHZZ N3905 TRANSISTOR EA PAHZZ N4258 TRANSISTOR EA PAHZZ N5160 TRANSISTOR EA PAHZZ N5460 TRANSISTOR EA PAHZZ N5462 TRANSISTOR EA PAHZZ N5485 TRANSISTOR EA PAHZZ N5486 TRANSISTOR EA PAHZZ T139 TRANSISTOR ASSEMBLY EA PAHZZ SEMICONDUCTOR DEVIC EA PAHZZ SEMICONDUCTOR DEVIC EA PAHZZ SEMICONDUCTOR DEVIC EA PAHZZ LB12J2 RESISTOR,THERMAL EA PGHZZ L MICROCIRCUIT,LINEAR EA PGHZZ LH337-T MICROCIRCUIT EA PGHZZ LF356N MICROCIRCUIT,LINEAR EA PAHZZ LM741CN MICROCIRCUIT,LINEAR EA PGHZZ MICROCIRCUIT,LINEAR EA PGHZZ CA3049T MICROCIRCUIT,LINEAR EA PGHZZ CA3080 MICROCIRCUIT,LINEAR EA PGHZZ M HCX MICROCIRCUIT,DIGITA EA PAHZZ MA7805UC MICROCIRCUIT EA PAHZZ LS107A MICROCIRCUIT EA PAHZZ C SOCKET EA 1 15

20 TM P Figure 3. Auxiliary Board Assembly (Sheet 1 of 3). 16

21 TM P Figure 3. Auxiliary Board Assembly (Sheet 2 of 3). 17

22 TM P Figure 3. Auxiliary Board Assembly (Sheet 3 of 3). 18

23 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT GROUP 02 AUXILIARY BOARD PCA (A2) 3 1 PAHZZ SWITCH,ROTARY EA PAHZZ SWITCH,ROTARY EA PAHZZ SWITCH,ROTARY EA XBHZZ SHIELD EA XBHZZ LP22PD626 SCREW EA XBHZZ /4-11 STANDOFF EA PAHZZ SOCKET,PLUG-IN ELEC EA PAHZZ SOCKET COAXIAL EA PAHZZ P3Y9AV2Q SWITCH,TOGGLE EA PAHZZ P3Y9AV2Q SWITCH,TOGGLE EA PAHZZ P3Y9AV2Q SWITCH,TOGGLE EA XBHZZ RIVET,TUBULAR EA XBHZZ SS153-1D-5A STANDOFF EA XBHZZ BRACKET, SWITCH EA PAHZZ MS WASHER,FLAT EA PAHZZ CABLE ASSEMBLY EA PAHZZ CK60BX100K CAPACITOR,FIXED,CER EA PAHZZ DD102 CAPACITOR,FIXED,CER EA PAHZZ CAC02Z5U103Z100A CAPACITOR,FIXED,CER EA PAHZZ CAC03Z5U104Z050A CAPACITOR,FIXED,CER EA PAHZZ DD330 CAPACITOR,FIXED,CER EA PAHZZ DD-681 CAPACITOR,FIXED,CER EA PAHZZ DM15-911J CAPACITOR,FIXED,MIC EA PAHZZ CAPACITOR,FIXED,ELE EA PGHZZ TLB1H470M CAPACITOR,FIXED,ELE EA PCHZZ TL81H471M CAPACITOR,FIXED,ELE EA PAHZZ P10491WD3 CAPACITOR,FIXED,PLA EA PAHZZ CSR13E106KP CAPACITOR,FIXED,ELE EA PAHZZ CONNECTOR,PLUG,ELE EA PAHZZ SPRING,SOCKET EA PAHZZ CONNECTOR,RECEPTACL EA PAHZZ AR100 RESISTOR,VARIABLE,N3 EA PAHZZ AR1K RESISTOR,VARIABLE,N EA PAHZZ AR100K RESISTOR,VARIABLE,N EA PAHZZ AR200 RESISTOR,VARIABLE,N EA PAHZZ AR2K RESISTOR,VARIABLE,N EA PAHZZ AR500 RESISTOR,VARIABLE,N EA PAHZZ RCR20G221JS RESISTOR,FIXED,COMP EA PAHZZ RNR55D1001FM RESISTOR,FIXED,FILM EA 2 19

24 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT 3 41 PAHZZ RNR55D1002FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1102FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1211FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1500FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1501FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1502FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1503FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D1621FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2371FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2492FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D2871FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D3010FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D3011FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D3012FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D3160FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D33R2FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D3572FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4321FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4641FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4751FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4752FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4990FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D4991FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D5761FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D6040FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D6191FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D6981FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D7501FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D9090FM RESISTOR,FIXED,FILM EA PAHZZ RNR55D9091FM RESISTOR,FIXED,FILM EA PAHZZ RNR60D1004FM RESISTOR,FIXED,FILM EA PAHZZ N823A SEMICONDUCTOR DEVIC EA PAHZZ N4581 SEMICONDUCTOR DEVIC EA PAHZZ N3964 SEMICONDUCTOR DEVIC EA PAHZZ JANTX1N4148 SEMICONDUCTOR DEVIC EA PAHZZ N3903 TRANSISTOR EA PAHZZ N3905 TRANSISTOR EA PGHZZ MICROCIRCUIT,LINEAR EA PGHZZ LF356N MICROCIRCUIT,LINEAR EA PGHZZ MC1458P1 MICROCIRCUIT,LINEAR EA 2 20

25 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT 3 81 PGHZZ MC1496L MICROCIRCUIT,LINEAR EA PGHZZ ICL8038CCPD MICROCIRCUIT,DIGITA EA 1 21

26 TM P Figure 4. Front Panel Assembly. 22

27 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT GROUP 03 FRONT PANEL ASSEMBLY (A3) 4 1 XBHZZ PANEL,FRONT EA XBHZZ INDICATOR,DIAL EA PAHZZ MS NUT,PLAIN,HEXAGON EA PAHZZ LAMP,INCANDESCENT EA PAHZZ CONNECTOR,PLUG,ELEC EA XBHZZ WM-1-33 MARKER,WIRE EA PAHZZ CONTACT,ELECTRICAL EA PAHZZ KC CONNECTOR,RECEPTACL EA PAHZZ TERMINAL,LUG EA PAHZZ KC79-46 CONNECTOR EA XAHZZ L2FF BEARING,SLEEVE EA PHAZZ DIAL,CONTROL EA PAHZZ LP22D62P6 SCREW,SELF-LOCKING EA PAHZZ P37AS440R5C SCREW,SELF-LOCKING EA PAHZZ MS WASHER,LOCK EA PAHZZ MS TERMINAL,LUG EA PAHZZ FA632 NUT,SELF-LOCKING,HE EA 1 23

28 TM P Figure 5. 24

29 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT GROUP 04 REAR PANEL ASSEMBLY (A4) 5 1 XBHZZ PANEL,REAR EA PAHZZ TRANSFORMER,POWER EA PAHZZ MS WASHER,FLAT EA PAHZZ MS WASHER,LOCK EA PAHZZ MS NUT,PLAIN,HEXAGON EA PAHZZ SCREW,SELF-TAPPING EA PAHZZ FA632 NUT,SELF-LOCKING,HE EA PAHZZ MS TERMINAL,LUG EA PAHZZ TERMINAL,LUG EA XBHZZ POSI EA PAHZZ P37AS440R5C SCREW,SELF-LOCKING EA XBHZZ INSULATOR EA PGHZZ MC7812CT MICROCIRCUIT,DIGITA EA PAHZZ A7824 MICROCIRCUIT EA PAHZZ MC7912CT MICROCIRCUIT,LINEAR EA PAHZZ A7924 MICROCIRCUIT EA PAHZZ B51547F015 INSULATOR,BUSHING EA PAHZZ MS NUT,PLAIN,HEXAGON EA PAHZZ CONNECTOR BODY,PLUG EA PAHZZ CONTACT,ELECTRICAL EA PAHZZ CONNECTOR,RECEPTACL EA PAHZZ CONTACT,ELECTRICAL EA XBHZZ SHIELD,PWR EA PAHZZ SWITCH,PUSH EA XBHZZ INSULATOR EA PAHZZ LUG,SOLDERING EA XBHZZ PLATE,INSULATOR EA XDHZZ TYB-23M STRAP,TIEDOWN,ELECT EA PAHZZ SCREW,SELF-LOCKING EA PAHZZ LP22D62P6 SCREW,SELF-LOCKING EA PAOZZ FUSE,CARTRIDGE EA PAHZZ MS SCREW,MACHINE EA PAHZZ VJ1 POWER SUPPLY SUBASS EA XBHZZ END BELL EA XBHZZ LABEL,WARNING EA XBHZZ LABEL,IDENT EA PAHZZ KC CONNECTOR,RECEPTACL EA 1 25

30 TM P Figure 6. Cover Assembly. 26

31 TM P SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER FSCM NUMBER USABLE ON CODE U/M UNIT GROUP 05 COVER ASSEMBLY 6 1 XBHZZ COVER ASSY,TOP EA XBHZZ EXPANDER EA XBHZZ COVER ASSY,BUTTON EA PAHZZ MS SCREW,MACHINE EA PAHZZ BAIL ASSEMBLY EA PAHZZ C NUT,SHEET SPRING EA 6 27

32 SECTION IV TM P NATIONAL STOCK NUMBER AND PART NUMBER INDEX FIGURE ITEM FIGURE ITEM STOCK NUMBER NO. NO. STOCK NUMBER NO. NO

33 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX TM P FIGURE ITEM FIGURE ITEM STOCK NUMBER NO. NO. STOCK NUMBER NO. NO FIGURE ITEM FIGURE ITEM FSCM PART NUMBER NO. NO. FSCM PART NUMBER NO. NO AD32ABS KC A KC A LB12J B51547F LD36-C B51547F LF356N CAC02Z5U103Z100A LF356N CAC02Z5U103Z100A LM337-T CAC03Z5U104Z050A LM741CN CAC03Z5U104Z050A LP22D62P CA3049T LP22D62P CA LP22D62P CK60AX221K LP22PD CK60AX331K MA7805UC CK60BX100K MC1458P CK60BX100K MC1496L CK60BX220K MC7812CT CMR05E470GODR MC7912CT CMR05F101GODR ML CSR13E106KP MS C MS C MS DD MS DD-222SLL MS DD MS DD-561SLL MS DD MS DD MS DD MS DD MS DD MS DD MS DM15-150J MS DM15-221J MS DM15-300J MS DM15-680J MS DM15-911J MS DM15F821F0300WV4CR M BCX ECEB1EV4R7S P37AS440R5C FD P37AS440R5C ICL8038CCPD P37AS440R5C T RB-67-1-SB-M JANTX1N RB-67-1-SB-0-M JANTX1N RCR20G101JS JANTX1N746A RCR20G165JS JANTX2N2905A RCR20G220JS JANTX2N RCR20G221JS JANTX2N RCR20G275JS JAN1N RCR20G515JS JAN2N869A RCR20G821JS KC RNR55D10R0FM

34 SECTION IV TM P NATIONAL STOCK NUMBER AND PART NUMBER INDEX FIGURE ITEM FIGURE ITEM FSCM PART NUMBER NO. NO. FSCM PART NUMBER NO. NO RNR55D1000FM RNR55D6040FM RNR55D1001FM RNR55D61R9FM RNR55D1001FM RNR55D6191FM RNR55D1002FM RNR55D6191FM RNR55D1002FM RNR55D68R1FM RNR55D1003FM RNR55D6981FM RNR55D1052FM RNR55D6981FM RNR55D1101FM RNR55D7500FM RNR55D1102FM RNR55D7501FM RNR55D1211FM RNR55D7501FM RNR55D1240FM RNR55D7871FM RNR55D1302FM RNR55D82R5FM RNR55D15R0FM RNR55D90R9FM RNR55D1500FM RNR55D9090FM RNR55D1500FM RNR55D9091FM RNR55D1501FM RNR55D9091FM RNR55D1501FM RNR60D1001FM RNR55D1502FM RNR60D1004FM RNR55D1502FM RNR60D1004FM RNR55D1503FM RNR60D1501FM RNR55D1503FM RNR60D4993FM RNR55D1621FM RNR60D6190FM RNR55D1621FM RNR60D6983FM RNR55D1650FM RNR60D7500FM RNR55D1781FM RNR65D1210FM RNR55D1912FM RNR70D1000FM RNR55D1961FM SS153-1D-5A RNR55D1962FM TLB1H470M RNR55D2000FM TLB1H471M RNR55D2001FM TY-523M RNR55D2052FM TYB-23M RNR55D21R5FM WM RNR55D2150FM RNR55D2210FM RNR55D2211FM RNR55D2371FM N RNR55D2371FM N RNR55D2490FM N823A RNR55D2491FM N823A RNR55D2492FM N RNR55D2492FM DAP RNR55D27R4FM RNR55D2871FM RNR55D2871FM RNR55D3010FM RNR55D3011FM RNR55D3011FM RNR55D3012FM Z RNR55D3012FM RNR55D3160FM RNR55D3160FM RNR55D33R2FM RNR55D33R2FM RNR55D3322FM RNR55D3572FM RNR55D3651FM RNR55D3920FM RNR55D42R2FM RNR55D4321FM RNR55D46R4FM RNR55D4640FM RNR55D4641FM RNR55D4641FM RNR55D4751FM RNR55D4751FM RNR55D4752FM RNR55D4990FM RNR55D4990FM RNR55D4991FM RNR55D4991FM RNR55D4992FM RNR55D51R1FM RNR55D5110FM RNR55D5230FM RNR55D54R9FM RNR55D5491FM M03-F RNR55D5760FM M03-F RNR55D5761FM RNR55D5761FM RNR55D6040FM D105X9035AS

35 TM P SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX FIGURE ITEM FIGURE ITEM FSCM PART NUMBER NO. NO. FSCM PART NUMBER NO. NO B 1/ DDT60N150KAB N N N N N N N F N N /3B N VJ N N N STRIK /13PF FA FA P3Y9AV2Q P3Y9AV2Q P3Y9AV2Q LS107A P10291WD P10391WD P10491WD P10491WD P10591YD AR1K AR1K AR10K AR AR100K AR100K AR2K AR2K AR AR L2FF AR /(32 BLANK)

36

37

38

39 TM P

40

41 TM P

42

43 TM P

44

45 TM P

46

47 By Order of the Secretary of the Army: JOHN A. WICKHAM, JR. General, United States Army Chief of Staff ROBERT M. JOYCE Major General, United States Army The Adjutant General DISTRIBUTION: To be distributed in accordance with DA Form 12-34B, requirements Maintenance Manuals. for TMDE/Calibration

48

49

50 PIN:

51 This fine document... Was brought to you by me: Liberated Manuals -- free army and government manuals Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap watermarks and other junk on it, and sell it. Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it... They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends? I am setting this document FREE. This document was made by the US Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on. I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines: <A HREF= Military and Government Manuals</A> Sincerely Igor Chudov Chicago Machinery Movers