TECHNICAL MANUAL DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS FOR RADIO SET AN/URC-92 (NSN )

Transcription

1 TECHNICAL MANUAL DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS FOR RADIO SET AN/URC-92 (NSN ) H E A D Q U A R T E R S, D E P A R T M E N T O F T H E A R M Y D E C E M B E R

2 } TECHNICAL MANUAL HEADQUARTERS DEPARTMENT OF THE ARMY No P WASHINGTON, DC, 14 December 1979 DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS FOR RADIO SET AN/URC-92 (NSN ) Current as of 1 March 1979 REPORTING OF ERRORS You can improve this manual by recommending improvements using DA Form located in the back of the manual. Simply tear out the self-addressed form, fill it out as shown on the sample, fold it where shown, and drop it in the mail. If there are no blank DA Forms in the back of your manual, use the standard DA Form 2028 (Recommended Changes to Publications and Blank Forms) and forward to the Commander, US Army Communications and Electronics Materiel Readiness Command, ATTN: DRSEL-ME-MQ, Fort Monmouth, NJ In either case a reply will be furnished direct to you. Table of Contents Illus Page Figure SECTION I. Introduction...1 II. Repair Parts List...5 Group 00 Radio Set AN/URC Telegraph Key Headset (no parts authorized) 03 Handset Antenna AS3286/URC (no parts authorized) 05 Antenna AS3287/URC (no parts authorized) 06 Electrical Equipment Mounting Base MT-4981/URC Receiver-Transmitter RT-1277/URC Back Panel-Exploded View Receiver-Transmitter-Rear Receiver-Transmitter-Center Receiver-Transmitter-Front Spectrum Generator CCA Low Digit Generator CCA Translator CCA VHF Divider CCA VHF VCO CCA VHF Mixer CCA IF Filter CCA Sideband Generator CCA Audio CCA Power Supply Assembly Power Supply, Exploded View Power Supply Assembly, Chassis, Exploded View Regulator Assembly Synthesizer Mother Board Receiver/Exciter Mother Board DC Inverter Assembly DC Inverter, Exploded View DC Inverter CCA RF Power Amplifier Assembly RF Power Amplifier CCA i

3 Illus Page Figure Group 0715 Main Harness Assembly Main Harness, Rear Filter Module Assembly Odd Channel Filter Assembly Even Channel Filter Assembly Receiver Filter Assembly Motor Control Board Assembly Motor Control Board CCA Front Panel Assembly Main Harness Front Panel, A-Transmit, B-Receive Relay Main Harness-Front Panel Circuit Card Assembly (no parts authorized) Circuit Card Assembly (no parts authorized) Speaker Driver CCA Decoder CCA Display CCA Tuning Control Coupler Unit CU-2229/URC-92 View A View B View C Main Harness K2-K3 Relay Assembly Control Logic CCA Phase and Amplitude Control CCA Regulator CCA Phase and Amplitude Assembly Phase and Amplitude CCA Relay Control Assembly Servo Control Assembly Servo Control CCA C1 Assembly Filter CCA Rear Panel Assembly, Exploded View Front Panel Assembly, Exploded View Electrical Equipment Mounting Base MT-4982/URC SECTION III. Special Tools List (Not applicable) IV. National Stock Number and Part Number Index ii

4 1. Scope This manual lists spares and repair parts; special tools; special test, measurement, and diagnostic equipment (TMDE), and other special support equipment required for performance of organizational, direct support, and general support maintenance of the AN/URC-92. It authorizes the requisitioning and issue of spares and repair parts as indicated by the source and maintenance codes. 2. General This Repair Parts-and Special Tools List is divided into the following sections: a. Section II. Repair Parts List. A list of spares and repair parts authorized for use in the performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in numeric sequence, with the parts in each group listed in figure and item number sequence. b. Section III. Special Tools List. Not applicable. c. Section IV. National Stock Number and Part Number Index. A list, in National item identification number (NIIN) sequence, of all National stock numbers (NSN) appearing in the listings, followed by a list, in alphameric sequence, of all part numbers appearing in the listings. National stock numbers and part numbers are cross-referenced to each illustration figure and item number appearance. 3. Explanation of Columns a. Illustration. This column is divided as follows: (1) Figure number. Indicates the figure number of the illustration on which the item is shown. (2) Item number. The number used to identify item called out in the illustration. b. Source, Maintenance, and Recoverability (SMR) Codes. (1) Source code. Source codes indicate the manner of acquiring support items for maintenance, repair, or overhaul of end items. Source codes are entered in the first and second positions of the Uniform SMR Code format as follows: Code Definition PA - Item procured and stocked for anticipated or known usage. PD - Support item, excluding support equipment, procured for initial issue or outfitting and stocked only for subsequent or additional initial issues or outfittings. Not subject to automatic replenishment. AO - Item to be assembled at organizational level. AH - Item to be assembled at general support maintenance level. SECTION I INTRODUCTION 1 CodeDefinition XA - Item is not procured or stocked because the requirements for the item will result in the replacement of the next higher assembly. XD - A support item that is not stocked. When required, item will be procured through normal supply channels. NOTE Cannibalization or salvage may be used as a source of supply for any items source coded above except those coded XA and aircraft support items as restricted by AR (2) Maintenance code. Maintenance codes are assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of the Uniform SMR Code format as follows: (a) The maintenance code entered in the third position will indicate the lowest maintenance level authorized to remove, replace, and use the support item. The maintenance code entered in the third position will indicate one of the following levels of maintenance: Code Application/Explanation O - Support item is removed, replaced, used at the organizational level. F - Support item is removed, replaced, used at the direct support level. H - Support item is removed, replaced, used at the general support level. (b) The maintenance code entered in the fourth position indicates whether the item is to be repaired and identifies the lowest maintenance level with the capability to perform complete repair (i.e., all authorized maintenance functions). This position will contain one of the following maintenance codes: Code Application/Explanation O - The lowest maintenance level capable of complete repair of the support item is the organizational level. F - The lowest maintenance level capable of complete repair of the support item is the direct support level. H - The lowest maintenance level capable of complete repair of the support item is the general support level. D - The lowest maintenance level capable of complete repair of the support item is the depot level. Z - Nonreparable. No repair is authorized. (3) Recoverability code. Recoverability codes are assigned to support items to indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows:

5 Recoverability codes Definition Z - Nonreparable item. When unserviceable, condemn and dispose at the level indicated in position 3. O - Reparable item. When uneconomically reparable, condemn and dispose at organizational level. H - Reparable item. When uneconomically reparable, condemn and dispose at the general support level. D - Reparable item. When beyond lower level repair capability, return to depot. Condemnation and disposal not authorized below depot level. c. National Stock Number. Indicates the National stock number assigned to the item and will be used for requisitioning purposes. d. Part Number. Indicates the primary number used by the manufacturer (individual, company, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications, standards, and inspection requirements to identify an item or range of items. NOTE When a stock numbered item is requisitioned, the repair part received may have a different part number than the part being replaced. e. Federal Supply Code for Manufacturer (FSCM.) The FSCM is a 5-digit numeric code listed in SB which is used to identify the manufacturer, distributor, or Government agency, etc. f. Description. Indicates the Federal item name and, if required, a minimum description to identify the item. g. Unit of Measure (U/M). Indicates the standard of the basic quantity of the listed item as used in performing the actual maintenance function. This measure is expressed by a two-character alphabetical abbreviation (e.g., ea, in, pr, etc). When the unit of measure differs from the unit of issue, the lowest unit of issue that will satisfy the required units of measure will be requisitioned. h. Quantity Incorporated in Unit. Indicates the quantity of the item used in the breakout shown on the illustration figure, which is prepared for a functional group, subfunctional group, or an assembly. 4. Special Information a. Detailed assembly instructions for items source coded to be assembled are found in TM (to be published). Assembly components are listed immediately following the item to be assembled. b. The following publications pertain to the AN/URC-92 and its components: TM , Radio Set AN/URC-92. TM P, Radio Set AN/URC-92. TM , Radio Set AN/URC-92 (to be published). c. National stock numbers (NSN's) that are missing from P source coded items have been applied for and will be added to this TM by future change/revision when they are entered in the Army Master Data File (AMDF). Until the NSN's are established and published, submit exception requisitions to: Commander, US Army Communications and Electronics Materiel Readiness Command, ATTN: DRSEL-MM, Fort Monmouth, NJ for the part required to support your equipment. 5. How to Locate Repair Parts a. When National stock number or part number is unknown. (1) First. Using the table of contents, determine the functional group within which the item belongs. This is necessary since illustrations are prepared for functional groups and listings are divided into the same groups. (2) Second. Find the illustration covering the functional group to which the item belongs. (3) Third. Identify the item on the illustration and note the illustration figure and item number of the item. (4) Fourth. Using the Repair Parts Listing, find the figure and item number noted on the illustration. b. When National stock number or part number is known. (1) First. Using the Index of National Stock Numbers and Part Numbers, find the pertinent National stock number or part number. This index is in NIIN sequence followed by a list of part numbers in alphameric sequence, cross-referenced to the illustration figure number and item number. (2) Second. After finding the figure and item number, locate the figure and item number in the repair parts list. 6. Abbreviations Not applicable. 2/3 Blank

6 Figure 1. Radio Set AN/URC-92. 4

7 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 00 RADIO SET AN/URC XAODD RT1277URC RCVR-XMTR... EA AOOOO MT4981URC MTG BASE, ELEC EQPT... EA PAOZZ M HEADSET... EA AOOOO TELEGRAPH KEY ASSY... EA AOOOO HANDSET ASSY... EA AOOOO MT4982URC MTG BASE, ELEC EQPT... EA PDOZZ AS3287URC ANTENNA, RADIO... EA PDOZZ AS3286URC ANTENNA, RADIO... EA AOOOO CU2229URC COUPLER UNIT... EA 1 5

8 Figure 2. Telegraph Key. 6

9 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 01 TELEGRAPH KEY 2 1 PAOZZ KEY, TELEGRAPH... EA XDOZZ PJ-055B PLUG, TELEPHONE... EA XDOZZ SPACER, SLEEVE...- EA PAOZZ MS TERMINAL, LUG... EA 2 7

10 Figure 3. Handset. 8

11 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 03 HANDSET 3 1 PAOZZ H-33F/PT MlCROPHONE, HANDSET... EA PAOZZ MS3106A-14S-5P CONN, RCPT, ELEC... EA PAOZZ AN ADAPTER, CABLE CLAMP... EA PAOZZ AN BUSHING, RUBBER... EA 1 9

12 Figure 4. Electrical Equipment Mounting Base MT-4981/URC

13 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 06 ELECTRICAL EQUIP MOUNTING BASE MT-4981/URC XDOZZ SIDE BAR, MTG BASE... EA XDOZZ SCREW, MACHINE... EA PAOZZ MS WASHER, LOCK... EA PAOZZ MS SCREW, MACHINE... EA XDOZZ RETAINER, FRONT... EA XDOZZ NUT, PLAIN, HEX... EA XDOZZ STIFFENER, FRONT... EA XDOZZ H64-AA ISOLATOR, SHOCK/VIB... EA XDOZZ STIFFENER, MIDDLE... EA XDOZZ STIFFENER, REAR... EA XDOZZ H64-AA ISOLATOR, SHOCK/VIB... EA XDOZZ STRAP, GROUND... EA XDOZZ PLATE, MTG BASE... EA XDOZZ AN R SCREW, MACHINE... EA XDOZZ REAR BAR, MTG BASE... EA 2 11

14 Figure 5. Receiver-Transmitter RT-1277/URC

15 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 07 RECEIVER TRANSMITTER RT-1277/URC XDHZZ SCREW MACHINE... EA XDHZZ COVER, TOP... EA XDHZZ MS B SCREW, MACHINE...- EA XDHZZ PLATE, COVER... EA XDHZZ MS SCREW, MACHINE... EA PAHZZ MS WASHER, LOCK... EA XDHZZ PLATE, COVER... EA XDHZZ WASHER, SPLIT, LOCK... EA PAHZZ MS B SCREW, MACHINE... EA XDHZZ SC-B CATCH, CLAMPING... EA XDHZZ GASKET, ANT CPLR PNL...- EA XAFHH TUNING CONTROL... EA XDHZZ WASHER, FLAT... EA XDHZZ MS B SCREW, MACHINE... EA PAOZZ NAS CAP, PROTECTIVE, DUST... EA XDHZZ SPACER, SLEEVE...- EA XDHZZ 8154-PH INSULATOR, BUSHING... EA XDHZZ PLATE, COVER... EA PAHZZ L A WASHER, LOCK... EA XDHZZ MS352b SCREW, MACHINE... EA PAHZZ MS SCREW, MACHINE... EA XDHZZ PLATE, COVER... EA PAOZZ MS WASHER, LOCK... EA PAHZZ MS SCREW, MACHINE... EA XDHZZ NUT, PLAIN, HEX... EA XDHZZ STRIKE, CATCH... EA XDHZZ MS B SCREW, MACHINE... EA XDHZZ GASKET... EA XDHZZ GASKET... EA XDHZZ BUMPER... EA ZDHZZ BUMPER... EA XDHZZ NUT, PLAIN, HEX... EA XDHZZ COVER, BOTTOM... EA XDHZZ GASKET... EA PAHZZ MS SCREW, MACHINE... EA PAHZZ M SCREW, MACHINE... EA XDHZZ M SCREW, MACHINE... EA PAHZZ M WASHER, LOCK... EA PADZZ NAS CAP, PROTECTIVE, DUST... EA 1 13

16 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC 5 40 PAOZZ NAS CAP, PROTECTIVE, DUST... EA PAOZZ NAS CAP, PROTECTIVE, DUST... EA PAOZZ NAS CAP, PROTECTIVE, DUST... EA PAHZZ M WASHER, LOCK... EA XDHZZ MS SCREW, MACHINE... EA XDHZZ NUT, PLAIN, HEX... EA XDHZZ STRIKE, CATCH... EA 4 14/(15 BLANK)

17 Figure 6. Receiver-Transmitter RT-1277/URC-92, Back Panel-Exploded View. 16

18 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC 6 1 PAHZZ MS SCREW, MACHINE... EA PAHZZ MS WASHER, LOCK... EA XDHZZ TRANSISTOR... EA XDHZZ 9223PH POST, ELEC-MECH EQPT... EA XDHZZ HT SINK, ELEC-ELEC... EA XDHZZ KH RELAY, SPRING... EA XAHHH DC INVERTER ASSY...- EA XDHZZ GASKET... EA PAOZZ MDL FUSE, CARTRIDGE USED WITH 26V POWER SOURCE... EA PAOZZ MDL FUSE, CARTRIDGE USED WITH 13V POWER SOURCE... EA PAOZZ MDL FUSE, CARTRIDGE USED WITH 230V POWER SOURCE... EA A PAOZZ MDL FUSE, CARTRIDGE USED WITH 115V POWER SOURCE... EA XDHZZ AL FUSE, HOLDER... EA PAHZZ MS SCREW, MACHINE... EA PAHZZ CONNECTOR, RECEPTACL... EA XDHZZ TERMINAL, LUG... EA XDHZZ WASHER, LOCK... EA PAHZZ MS3102A-24-11P CONNECTOR, RECEPTACL... EA XDHZZ 10SS-S CAPACITOR, FIXED... EA PAHZZ MS3102A-18-19S CONNECTOR, RECEPTACL... EA PAHZZ B250F103Z CAPACITOR, FIXED, CER... EA XDHZZ TERMINAL, LUG... EA PAHZZ NUT, PLAIN, HEXAGON... EA XDHZZ ZD1A CAPACITOR, FIXED... EA PAHZZ NUT, PLAIN, HEXAGON... EA PAHZZ IN SEMICONDUCTOR DEVIC... EA PAHZZ MS3102A-28-21S CONNECTOR, RECEPTACL... EA PAHZZ MS SCREW, MACHINE... EA XDHZZ TERMINAL, LUG... EA PAHZZ MS SCREW, MACHINE... EA PAHZZ MS WASHER, LOCK... EA XDHZZ NUT, PLAIN, HEX... EA XDHZZ WASHER, FLAT... EA 2 17

19 Figure 7. Receiver-Transmitter RT-1277/URC-92-Rear. 18

20 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC 7 1 XDHZZ GASKET... EA XDHZZ SCREW, MACHINE... EA XDHHH SIDE RAIL, RIGHT... EA XDHZZ GASKET... EA XDHHH BRACKET, ANGLE... EA PAHZZ SCREW, MACHINE... EA XDHZZ MS SCREW, MACHINE... EA XDHZZ CLAMP, CABLE... EA XDHZZ BRACKET, ANGLE... EA PAHZZ MS WASHER, LOCK... EA PAHZZ MS SCREW, MACHINE... EA XDHHH SIDE RAIL, LEFT... EA PAHZZ NUT, PLAIN, HEXAGON... EA PAHZZ WASHER, FLAT... EA XAHHH PANEL, REAR... EA PAHZZ MS SCREW, MACHINE... EA XDHZZ GASKET... EA 2 19

21 Figure 8. Receiver-Transmitter RT-1277/URC-Center. 20

22 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC 8 1 PAHZZ TCXO, 5MHZ... EA PAHZZ MS WASHER, LOCK... EA PAHZZ MS SCREW, MACHINE... EA PAHZZ 531O MS WASHER, LOCK... EA XDHZZ MS SCREW, MACHINE... EA XDHZZ GUIDE, CKT CD ASSY... EA XDHZZ FMAG SKT, PLAIN ELEC... EA XDHZZ SCREW, MACHINE... EA PAHZZ MS SCREW, MACHINE... EA PAHZZ NUT, PLAIN, HEXAGON... EA PAHZZ C F103Z CAPACITOR, FIXED, CER... EA XDHZZ J COIL, RF, FIXED, 47UH... EA XAHHH CHASSIS, MAIN... EA PAHZZ CONN, RCPT, ELEC... EA PAHZZ CONN, RCPT, ELEC... EA XDHZZ TERMINAL, LUG... EA XDHZZ WASHER, LOCK, SPLIT... EA XDHZZ NUT, PLAIN, HEX... EA XDHZZ TERMINAL, STUD... EA XAHHH MOTHER BD, SYNTH... EA PAHZZ WASHER, FLAT... EA PAHZZ MS SCREW MACHINE... EA XDHZZ RUBBER CHANNEL... EA XDHZZ BRACKET, ANGLE...- EA XDHZZ BRACKET, ANGLE... EA XAHHH MOTHER BD REV/EXCTR... EA XDHZZ CLAMP, CABLE... EA PAHZZ CONNECTOR RF, SM... EA PAHZZ CONN, RCPT, ELEC... EA XDHZZ NUT, PLAIN, HEX... EA PAHZZ MS WASHER, LOCK... EA XDHZZ SHIELD, FREQ STD... EA PAHZZ MS SCREW, MACHINE... EA PAHZZ WASHER, FLAT... EA XDHZZ TERMINAL, LUG,... EA AHHHH ADAPTER PLATE ASSY... EA PAHZZ CONNECTOR.RECEPTACL... EA PAHZZ MS SCREW, MACHINE... EA PAHZZ NUT, PAIN, HEXAGON... EA PAHZZ MS SCREW, MACHINE... EA 2 21

23 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC 8 41 XDHZZ PLATE, INSTRUCTION... EA 1 22/(23 BLANK)

24 Figure 9. Receiver-Transmitter RT-1277/URC-92-Front. 24

25 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC 9 1 PAHZZ U MS SCREW MACHINE... EA PAHZZ MS WASHER, LOCK... EA XDHHH PLATE, ELEC SHIELD... EA PAFHH VHF VCO ASSY... EA PAHZZ MS WASHER, LOCK... EA XDHZZ SCREW, MACHINE, HEX... EA PAHZZ CONN, RCPT ELEC... EA PAFHD SPECTRUM GEN ASSY... EA PAFHD LOW DIGIT GEN ASSY... EA PAFHD TRANSLATOR ASSY... EA PAFHH VHF DIVIDER ASSY... EA XDHZZ 50240L GUIDE, CKT CD ASSY... EA XAHHH FRONT PANEL ASSY... EA XDHZZ 050L SCREW, MACHINE... EA XDHZZ PLATE, IDENT, INTLK... EA XDHZZ SCREW, DRIVE... EA XDHZZ SCREW, MACHINE... EA XDHZZ WASHER, LOCK, SPLIT... EA PAHZZ MS SCREW, MACHINE... EA XDHZZ GASKET... EA PAHZZ MS SCREW, MACHINE... EA PAHZZ MS SCREW MACHINE... EA PAHZZ MS WASHER, LOCK... EA XDHZZ BRACKET ANGLE... EA PAFHH AUDIO ASSY... EA PAFHH IF FILTER ASSY... EA PAFHH SIDEBAND GEN ASSY... EA XDHZZ PLATE, ELEC SHIELD... EA PAFHH VHF MIXER ASSY... EA PAHHH FILTER ASSY... EA XDHZZ GASKET... EA AHHHH COAX CABLE ASSY... EA PAHZZ CONNECTOR, PLUG, ELEC... EA XDHZZ RG174/U CABLE, COAX... EA XDHZZ GASKET... EA 1 25

26 Figure 10. Spectrum Generator Circuit Card Assembly (sheet 1 of 2). 27

27 Figure 10. Spectrum Generator Circuit Card Assembly (sheet 2 of 2). 28

28 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 0701 SPECTRUM GENERATOR CCA 10 1 PAHZZ C F103Z CAPACITOR, FIXED... EA PAHZZ 3CX7R104XD100C CAPACITOR, FIXED... EA XDHZZ CM04C0910J CAPACITOR, FIXED... EA XDHZZ CM04CD20D CAPACITOR, FIXED....EA XDHZZ CM50E0131J CAPACITOR, FIXED... EA XDHZZ CM05FO27LJ CAPACITOR, FIXED... EA XDHZZ CM05FC30LJ CAPACITOR, FIXED... EA XDHZZ CM04CD100D CAPACITOR, FIXED, MIC... EA XDHZZ CM04E0410J CAPACITOR, FIXED, MIC... EA PAHZZ CM0F01101J CAPACITOR, FIXED... EA XDHZZ CM05FD331J CAPACITOR, FIXED... EA XDHZZ CM06FD222G CAPACITOR, FIXED, MIC... EA XDHZZ CM0SFC751J CAPAClTOR, FIXED... EA XDHZZ CM0SF0121J CAPACITOR, FIXED... EA XDHZZ CM0SFDIL1J CAPACITOR, FIXED, MIC... EA XDHZZ CM04E0680J CAPACITOR, FIXED, MIC... EA XDHZZ CM J CAPACITOR, FIXED, MIC... EA XDHZZ CM0SFDIS1J CAPACITOR, FIXED, MIC... EA XDHZZ CM50FD361J CAPACITOR, FIXED... EA XDHZZ CM04ED560J CAPACITOR, FIXED, MIC... EA XDHZZ CM04ED820J CAPACITOR, FIXED, MIC... EA PAHZZ N SEMICONDUCTOR DEVIC... EA PAHZZ NBD SEMICONDUCTOR DEVIC... EA XDHZZ J COIL, RF, FXD, 220UH... EA XDHZZ COIL, RF, VAR, 0.68UH... EA XDHZZ J COIL, RF, FXD, 22UH... EA XDHZZ J COIL, RF, FXD, 47UH... EA XDHZZ J COIL, RF, FXD, 1UH... EA XDHZZ J COIL, RF, FXD, 2.2UH... EA XDHZZ COIL, RF, VAR, 15UH... EA XDHZZ J COIL, RF, FXD, 47UH... EA XDHZZ COIL, RF, VAR, 1UH... EA PAHZZ N TRANSISTOR... EA PAHZZ N TRANSISTOR... EA PAHZZ MFE TRANSISTOR... EA XDHZZ RC07GF560J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF392J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF822J RESISTOR, FIXED, COMP... EA XDHZZ RC0TGF222J RESISTOR... EA 5 29

29 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC XDHZZ RC07GF221J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF391J RESISTOR, FIXED, COMP... EA XDHZZ RC07GFS62J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF681J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF472J RESISTOR, FIXED, COMP... EA PAHZZ RC07GF102J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF220J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF682J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF123J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF223J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF821J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF100J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF683J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF333J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF152J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF471J RESISTOR, FIXED, COMP... EA XDHZZ RC07GFL04J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF700J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF270J RESISTOR, FIXED, COMP... EA XDHZZ RC07GFL01J RESISTOR, FIXED, COMP... EA PAHZZ JB31J RESISTOR, THERMAL... EA XDHZZ TRANSFORMER... EA PAHZZ CA MICROCIRCUIT, LINEAR... EA XDHZZ SN5400N INTEGRATED CIRCUIT... EA PAHZZ N8280A INTEGRATED CIRCUIT... EA XDHZZ SN54H72N INTEGRATED CIRCUIT... EA 1 30

30 Figure 11. Low Digit Generator Circuit Card Assembly (sheet 1 of 2). 31

31 Figure 11. Low Digit Generator Circuit Card Assembly (sheet 2 of 2). 32

32 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 0702 LOW DIGIT GENERATOR CCA 11 1 XDHZZ 196D335X9035JA CAPACITOR, FIXED EA PAHZZ 3CX7R104X0100C CAPACITOR, FIXED EA XDHZZ 65F12AA CAPACITOR, FIXED EA XDHZZ F10AC CAPACITOR, FIXED EA XDHZZ 196D334X9035HA CAPACITOR, FIXED EA PAHZZ D CAPACITOR, VARIABLE EA XDHZZ CMN05FD121J CAPACITOR, FIXED EA XDHZZ CM04ED820J CAPACITOR, FIXED, MIC... EA PAHZZ CM04FD151J CAPACITOR, FIXED, MIC... EA PAHZZ C069B250F103Z CAPACITOR, FIXED, CER... EA I XDHZZ CM04CD070D CAPACITOR, FIXED, MIC... EA PAHZZ CM04D101J CAPACITOR, FIXED EA XDHZZ CM04ED270J CAPACITOR, FIXED, MIC EA XDHZZ CM04ED680J CAPACITOR, FIXED, MIC EA XDHZZ CM04CD050D CAPACITOR, FIXED, MIC EA XDHZZ CM04JD111J CAPACITOR, FIXED EA XDHZZ CM04CD120J CAPACITOR, FIXED, MIC EA XDHZZ CM04ED620J CAPACITOR, FIXED, MIC EA XDHZZ CM05ED131J CAPACITOR, FIXED EA XDHZZ 196D156X9015JA CAPACITOR, FIXED EA XDHZZ 1CX7R102X0100C CAPACITOR, FIXED EA XDHZZ X9035HA CAPACITOR, FIXED EA XDHZZ CD7FA911J CAPACITOR, FIXED EA XDHZZ CM05FC681J CAPACITOR, FIXED EA XDHZZ CM05FD181J CAPACITOR, FIXED, MIC EA PAHZZ MV SEMICONDUCTOR DEVIC... EA PAHZZ MV SEMICOND DVC EA XDHZZ N SEMICONDUCTOR DEVIC... EA PAHZZ N SEMICONDUCTOR DEVIC EA XDHZZ J COIL, RF, FXD, 33UH EA XDHZZ COIL, RF, VAR, 1UH EA XDHZZ J COIL, RF, FXD, 150UH EA XDHZZ J COIL, RF, FXD, 3.3UH EA XDHZZ J COIL, RF, FXD, 220UH EA XDHZZ J COIL, RF, FXD. 82UH EA XDHZZ J COIL, RF, FXD, 68UH EA XDHZZ J COIL, RF, FXD, 1UH EA XDHZZ J COIL, RF, FXD, 8.2UH EA XDHZZ J COIL, RF, FXD, 15UH EA 2 33

33 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC XDHZZ J COIL, RF, FXD, 47UH... EA PAHZZ N TRANSISTOR EA XDHZZ N TRANSISTOR EA PAHZZ MFE TRANSISTOR EA PAHZZ N TRANSISTOR EA XDHZZ RC07GF821J RESISTOR, FIXED, COMP EA XDHZZ RC07GF472J RESISTOR, FIXED, COMP EA XDHZZ RN55C3322F RESISTOR, FIXED, FILM...- EA XDHZZ RC07GF392J RESISTOR, FIXED, COMP EA XDHZZ RN55C1652F RESISTOR, FIXED, FILM... EA XDHZZ RC07GF681J RESISTOR, FIXED, COMP EA XDHZZ RC07GF220J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF121J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF272J RESISTOR, FIXED, COMP... EA XDHZZ 59050U RC07GF562J RESISTOR, FIXED, COMP...- EA XDHZZ RC07GF224J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF223J RESISTOR, FIXED, COMP.... EA XDHZZ RC07GF473J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF151J RESISTOR, FIXED, COMP... EA PAHZZ RC07GF102J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF221J RESISTOR, FIXED, COMP EA XDHZZ RC07GF103J RESISTOR, FIXED, COMP EA XDHZZ RC07GF225J RESISTOR, FIXED, COMP EA XDHZZ RC07GF471J RESISTOR, FIXED, COMP EA XDHZZ RC07GF222J RESISTOR EA XDHZZ i-8818 RC07GF153J RESISTOR, FIXED, COMP EA XDHZZ RC07GF101J RESISTOR, FIXED, COMP EA XDHZZ RC07GF332J RESISTOR, FIXED, COMP EA XDHZZ RC07GF470J RESISTOR, FIXED, COMP EA XDHZZ RC07GF561J RESISTOR, FIXED, COMP EA PAHZZ JB31J RESISTOR, THERMAL EA XDHZZ JACK, TIP EA XDHZZ JACK, TIP EA PAHZZ CA MICROCIRCUIT, LINEAR... EA PAHZZ P MICROCIRCUIT, DIGITA EA XDHZZ N7430N INTEGRATED CIRCUIT EA XDHZZ N7400N INTEGRATED, CIRCUIT... EA PAHZZ N8290A MICROCIRCUIT, DIGITA... EA PAHZZ N8280A INTEGRATED CIRCUIT EA 3 34

34 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC XDHZZ SN7472N INTEGRATED CIRCUIT EA 1 35/(36 blank)

35 Figure 12. Translator Circuit Card Assembly (sheet 1 of 2). 37

36 Figure 12. Translator Circuit Card Assembly (sheet 2 of 2). 38

37 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 0703 TRANSLATOR CCA 12 1 XDHZZ CD6ED820J CAPACITOR, FIXED EA XDHZZ CD7FA821J CAPACITOR, FIXED EA XDHZZ CM046D020D CAPACITOR, FIXED EA PAHZZ CM04FD101J CAPACITOR, FIXED EA XDHZZ CM04FD201J CAPACITOR, FIXED, MIC... EA XDHZZ CD7FC201J CAPACITOR, FIXED EA PAHZZ 8121M050W5R103M CAPACITOR, FIXED EA XDHZZ CD7FA681J CAPACITOR, FIXED EA XDHZZ CM04CD CAPACITOR, FIXED, MIC... EA XDHZZ CM04CD200J CAPACITOR, FIXED EA XDHZZ CM04ED470J CAPACITOR, FIXED, MIC... EA PAHZZ 3CX7R104X CAPACITOR, FIXED EA XDHZZ CM04CD180J CAPACITOR, FIXED, MIC... EA XDHZZ CD6EC330J CAPACITOR, FIXED EA XDHZZ CM04ED330J CAPACITOR, FIXED, MIC... EA PAHZZ CM04FD151J CAPACITOR, FIXED, MIC... EA XDHZZ CM04ED240J CAPACITOR, FIXED, MIC... EA XDHZZ CM04ED620J CAPACITOR, FIXED, MIC.... EA XDHZZ CD7FA561J CAPACITOR, FIXED EA XDHZZ CM04FD121G CAPACITOR, FIXED, MIC... EA XDHZZ CD7FA471J CAPACITOR, FIXED, MIC.... EA XDHZZ CAP, FXD 0.5PF, 500V EA XDHZZ CM04CD070J CAPACITOR, FIXED EA XDHZZ CM04CD050D CAPACITOR, FIXED, MIC... EA XDHZZ CM04ED560J CAPACITOR, FIXED, MIC... EA XDHZZ CM04FD181J CAPACITOR, FIXED, MIC EA XDHZZ CM04FC271J CAPACITOR, FIXED EA XDHZZ CM04CD150J CAPACITOR, FIXED, MIC... EA XDHZZ CM04CD120J CAPACITOR, FIXED, MIC... EA XDHZZ 196D156X9015JA CAPACITOR, FIXED, ELE... EA PAHZZ MBD SEMICONDUCTOR DEVIC... EA PAHZZ N SEMICONDUCTOR, DEVIC.... EA PAHZZ MV SEMICOND, DVC EA XDHZZ COIL, RF, VAR, 0.68UH EA XDHZZ J COIL, RF, FXD, 22UH EA XDHZZ COIL, RF, VAR, 1UH EA XDHZZ J COIL, RF, FXD, 4.7UH EA XDHZZ COIL, RF, VAR, 0.18 UH EA XDHZZ J COIL, RF, FXD, 6.8UH EA 1 39

38 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC XDHZZ COIL, RF, FXD, 2.2UH EA XDHZZ J COIL, RF, FXD, 8.2UH EA XDHZZ J COIL, RF, FXD, 0.68UH EA XDHZZ COIL, RF, VAR, 5.6UH EA 1 12 '4 XDHZZ COIL, RF, FXD, 0.18UH EA XDHZZ J COIL, RF, FXD, 3.3UH EA XDHZZ J COIL, RF, FXD, 0.56UH EA XDHZZ J COIL, RF, FXD, 0.22UH EA XDHZZ J COIL, RF, FXD, 2.7UH EA PAHZZ N TRANSISTOR EA PAHZZ MFE TRANSISTOR EA PAHZZ N TRANSISTOR EA PAHZZ MFE TRANSISTOR EA XDHZZ RC07GF333J RESISTOR, FIXED, COMP EA XDHZZ RC07GF103J RESISTOR, FIXED, COMP... EA PAHZZ RC07GF102J RESISTOR, FIXED, COMP EA XDHZZ RC07GF151J RESISTOR, FIXED, COMP EA XDHZZ RC07GF222J RESISTOR EA XDHZZ RC07GF332J RESISTOR, FIXED, COMP EA XDHZZ RC07GF104J RESISTOR, FIXED, COMP EA XDHZZ RC07GF124J RESISTOR, FIXED, COMP EA XDHZZ RC07GF473J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF223J RESISTOR, FIXED, COMP EA XDHZZ RC07GF224J RESISTOR, FIXED, COMP EA XDHZZ RC07GF101J RESISTOR, FIXED EA XDHZZ RC07GF221J RESISTOR, FIXED, COMP EA XDHZZ RC07GF561J RESISTOR, FIXED, COMP EA XDHZZ RC07GF471J RESISTOR, FIXED, COMP EA XDHZZ RC07GF821J RESISTOR, FIXED, COMP EA XDHZZ RC07GF820J RESISTOR, FIXED, COMP EA XDHZZ RC07GF560J RESISTOR, FIXED, COMP EA XDHZZ RC07GF220J RESISTOR, FIXED, COMP EA XDHZZ RC07GF822J RESISTOR, FIXED, COMP EA XDHZZ RC07GF392J RESISTOR, FIXED, COMP EA XDHZZ RC07GF472J RESISTOR, FIXED, COMP EA XDHZZ RC07GF682J RESISTOR, FIXED, COMP EA XDHZZ RC07GF122J RESISTOR, FIXED, COMP EA XDHZZ RC07GF123J RESISTOR, FIXED, COMP EA XDHZZ 3389P RESISTOR, VARIABLE EA XDHZZ RC07GF680J RESISTOR, FIXED, COMP EA 1 40

39 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC XDHZZ RC07GF181J RESISTOR, FIXED, COMP EA XDHZZ RC07GF152J RESISTOR, FIXED, COMP EA XDHZZ RC07GF182J RESISTOR, FIXED, COMP EA PAHZZ TRANSFORMER EA PAHZZ TRANSFORMER EA PAHZZ CONN, RCPT, ELEC EA XDHZZ JACK, TIP EA PAHZZ CA MICROCIRCUIT, LINEAR... EA XDHZZ CRYSTAL, QUARTZ EA XDHZZ CRYSTAL, QUARTZ EA 1 41/(42 blank)

40 Figure 13. VHF Divider Circuit Card Assembly (sheet 1 of 2) 43

41 Figure 13. VHF Divider Circuit Card Assembly (sheet 2 of 2) 44

42 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 0704 VHF DIVIDER CCA 13 1 PAHZZ C069B250F103Z CAPACITOR, FIXED, CER... EA XDHZZ 0281L CAP, FXD, FEEDTHRU EA XDHZZ CM04ED470J CAPACITOR, FIXED, MIC... EA XDHZZ 196D335X9035JA CAPACITOR, FIXED EA PAHZZ 3CX7R104X0100C CAPACITOR, FIXED EA PAHZZ CM04FD101J CAPACITOR, FIXED EA PAHZZ N SEMICONDUCTOR DEVIC... EA XDHZZ J COIL, RF, FXD, 22UH EA XDHZZ J COIL, RF, FXD, 15UH EA PAHZZ N TRANSISTOR EA PAHZZ 2N TRANSISTOR EA PAHZZ N TRANSISTOR EA XDHZZ RC07GF560J RESISTOR, FIXED, COMP EA XDHZZ RC07GF101J RESISTOR, FIXED, COMP EA XDHZZ RC07GF821J RESISTOR, FIXED, COMP EA XDHZZ RC07GF471J RESISTOR, FIXED, COMP EA PAHZZ RC07GF102J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF331J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF272J RESISTOR, FIXED, COMP EA XDHZZ RC07GF220J RESISTOR, FIXED, COMP EA XDHZZ RC07GF222J RESISTOR EA XDHZZ RC07GF151J RESISTOR, FIXED, COMP EA XDHZZ RC07GF226J RESISTOR, FIXED, COMP EA XDHZZ SN7400N INTEGRATED CIRCUIT EA XDHZZ SN74S112N INTEGRATED CIRCUIT EA PAHZZ N8290A MICROCIRCUIT, DIGITA... EA XDHZZ SN7401N INTEGRATED CIRCUIT EA XDHZZ SN74716N INTEGRATED CIRCUIT EA XDHZZ SN1430N INTEGRATED CIRCUIT EA XDHZZ S74H72N INTEGRATED CIRCUIT EA PAHZZ MC4044P MICROCIRCUIT, DIGITA... EA XDHZZ JACK, TIP EA AHHHH FEEDTHRU ASSY EA XDHZZ BRKT, FEEDTHRU EA 1 45/(46 blank)

43 Figure 14. VHF VCO Circuit Card Assembly (sheet 1 of 2). 47

44 Figure 14. VHF VCO Circuit Card Assembly (sheet 2 of 2). 48

45 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 0705 VHF VCO CCA 14 1 PAHZZ 3CX7R104X0100C CAPACITOR, FIXED EA XDHZZ 196D476X9020PE CAPACITOR, FIXED EA XDHZZ CD7FA471J CAPACITOR, FIXED, MIC... EA XDHZZ D105X9035HA CAPACITOR, FIXED, ELE EA XDHZZ D226X9015KA CAPACITOR, FIXED EA PAHZZ CM04FD151J CAPACITOR, FIXED, MIC... EA XDHZZ CD7FC151J CAPACITOR, FIXED EA PAHZZ A CAPACITOR, VARIABLE... EA XDHZZ 196D335X9035JA CAPACITOR, FIXED D EA XDHZZ CM04CD070D CAPACITOR, FIXED, MIC EA XDHZZ CM04CD050D CAPACITOR, FIXED, MIC EA PAHZZ CM04FD101J CAPACITOR, FIXED EA PAHZZ CAPACITOR, VARIABLE... EA XDHZZ CM04CD180J CAPACITOR, FIXED, MIC EA PAHZZ CD69B250F103Z CAPACITOR, FIXED, CER... EA XDHZZ CAPACITOR, FIXED EA XDHZZ CAPACITOR, FIXED EA PAHZZ N SEMICONDUCTOR DEVIC... EA PAHZZ MV SEMICOND DVC EA PAHZZ MBD SEMICONDUCTOR DEVIC... EA PAHZZ MV SEMICONDUCTOR DEVIC... EA PAHZZ CONN, RCPT, ELEC EA XDHZZ COIL, RF, VAR EA XDHZZ COIL, RADIO FREQUENC... EA XDHZZ J COIL RR, FXD, 10UH EA XDHZZ COIL, RF, VAR EA XDHZZ COIL RF, VAR EA XDHZZ COIL, RF, FXD EA XDHZZ COIL, RF, VAR EA XDHZZ COIL, RF, FXD EA XDHZZ COIL, RF, FXD 0.27UH EA PAHZZ N TRANSISTOR EA PAHZZ MFE TRANSISTOR EA PAHZZ N TRANSISTOR EA XDHZZ RC07GF270J RESISTOR, FIXED, COMP EA XDHZZ RC07GF101J RESISTOR, FIXED, COMP EA XDHZZ RC07GF182J RESISTOR, FIXED, COMP EA XDHZZ RC07GF562J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF561J RESISTOR, FIXED, COMP EA 2 49

46 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC XDHZZ RC07GF181J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF472J RESISTOR, FIXED, COMP EA XDHZZ RN55C1372F RESISTOR, FIXED, FILM EA XDHZZ RN55C6811F RESISTOR, FIXED, FILM EA XDHZZ RC07GF332J RESISTOR, FIXED, COMP EA XDHZZ RN55C4750F RESISTOR, FIXED, FILM EA XDHZZ RC07GF103J RESISTOR, FIXED, COMP EA XDHZZ RN55C2671F RESISTOR, FIXED, FILM... EA XDHZZ RC07GF104J RESISTOR, FIXED, COMP EA XDHZZ RC07GF473J RESISTOR, FIXED, COMP... EA PAHZZ RC07GF102J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF221J RESISTOR, FIXED, COMP EA XDHZZ RC07GF100J RESISTOR, FIXED, COMP EA XDHZZ RC07GF682J RESISTOR, FIXED, COMP EA XDHZZ RC07GF220J RESISTOR, FIXED, COMP EA XDHZZ TRANSFORMER, RF EA XDHZZ TRANSFORMER, RF EA PAHZZ MS SCREW, MACHINE EA PAHZZ MS WASHER, LOCK EA PAHZZ WASHER, FLAT EA XDHZZ SHIELD PLATE, FRONT EA XDHZZ SHIELD, FRONT EA XAHZZ PRINTED WIRING BD EA XDHZZ SHIELD, REAR EA 1 50

47 Figure 15. VHF Mixer Circuit Card Assembly (sheet 1 of 2). 51

48 Figure 15. VHF Mixer Circuit Card Assembly (sheet 2 of 2). 52

49 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 0706 VHF MIXER CCA 15 1 PAHZZ C F103Z CAPACITOR, FIXED, CER... EA XDHZZ CM06FD202G CAPACITOR, FIXED, MIC... EA XDHZZ CM06FD332G CAPACITOR, FIXED, MIC EA XDHZZ CM06FD272G CAPACITOR, FIXED, MIC EA XDHZZ CM06FD152G CAPACITOR, FIXED, MIC EA XDHZZ CM06FD182G CAPACITOR, FIXED, MIC EA XDHZZ CM05ED750G CAPACITOR, FIXED, MIC EA XDHZZ CM05ED560J CAPACITOR, FIXED, MIC EA XDHZZ CM05FD151J CAPACITOR, FIXED, MIC EA XDHZZ CM06FD242G CAPACITOR, FIXED, MIC EA XDHZZ CM06FD122G CAPACITOR, FIXED, MIC EA XDHZZ CM06FD911G CAPACITOR, FIXED, MIC EA XDHZZ 65F11AC CAPACITOR, FIXED EA XDHZZ CM04CD200J CAPACITOR, FIXED EA PAHZZ CM04FD101J CAPACITOR, FIXED EA PAHZZ 198D105X9050H CAPACITOR, FIXED EA PAHZZ 3CX7R104X0100C CAPACITOR, FIXED EA XDHZZ 196D476X9020PE CAPACITOR, FIXED, ELE EA XDHZZ X9035HA CAPACITOR, FIXED EA XDHZZ D105X9035HA CAPACITOR, FIXED, ELE... EA XDHZZ 1CX7R102XD100C CAPACITOR, FIXED EA XDHZZ CM05FD221J CAPACITOR, FIXED, MIC... EA PAHZZ A CAPACITOR, FIXED EA XDHZZ CM04CD100J CAPACITOR, FIXED EA XDHZZ CM04ED470J CAPACITOR, FIXED, MIC EA XDHZZ CM04ED330J CAPACITOR, FIXED, MIC EA XDHZZ CM04ED251G CAPACITOR, FIXED EA XDHZZ CM04ED430J CAPACITOR, FIXED EA XDHZZ CM05FD501J CAPACITOR, FIXED EA XDHZZ CM05FD131G CAPACITOR, FIXED, MIC EA XDHZZ CM05FD501J CAPACITOR, FIXED EA PAHZZ N SEMICONDUCTOR DEVIC... EA XDHZZ N SEMICONDUCTOR DEVIC... EA PAHZZ MBD SEMICONDUCTOR DEVIC... EA XDHZZ FILTER, BAND PASS EA XDHZZ J COIL, RF, FXD, 6.8UH EA XDHZZ J COIL, RF, FXD, 12UH EA XDHZZ J COIL, RF, FXD, 15UH EA XDHZZ J COIL, RF, FXD, 8.2UH EA 1 53

50 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC XDHZZ J COIL, RF, FXD, 4.7UH EA XDHZZ J COIL, RADIO FREQUENC... EA XDHZZ 446-6J COIL, RF, FXD, 0.27UH EA XDHZZ J COIL, RF, FXD, 1.8UH EA XDHZZ J COIL, RF, FXD, 0.68UH EA XDHZZ J COIL, RF, FXD, 2.2UH EA XDHZZ J COIL, RF, FXD, 0.82UH EA XDHZZ J COIL, RF, FXD, 0.56UH EA XDHZZ J COIL, RF, FXD, 3.9UH EA PAHZZ N TRANSISTOR EA PAHZZ TRANSISTOR EA PAHZZ N TRANSISTOR EA PAHZZ N TRANSISTOR EA PAHZZ TRANSISTOR EA XDHZZ RC07GF222J RESISTOR EA XDHZZ RC07GF152J RESISTOR, FIXED, COMP EA XDHZZ RC07GF270J RESISTOR, FIXED, COMP EA XDHZZ RC07GF100J RESISTOR, FIXED, COMP EA XDHZZ RC07GF121J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF103J RESISTOR, FIXED, COMP EA XDHZZ RC07GF470J RESISTOR, FIXED, COMP EA XDHZZ RC07GF104J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF821J RESISTOR, FIXED, COMP EA XDHZZ RC07GF272J RESISTOR, FIXED, COMP EA XDHZZ RC07GF561J RESISTOR, FIXED, COMP EA XDHZZ RC07GF221J RESISTOR, FIXED, COMP EA XDHZZ 3329H RESISTOR, VARIABLE EA XDHZZ RC07GF122J RESISTOR, FIXED, COMP EA XDHZZ RC07GF472J RESISTOR, FIXED, COMP EA XDHZZ RC07GF682J RESISTOR, FIXED, COMP EA PAHZZ RC07GF102J RESISTOR, FIXED, COMP EA XDHZZ RC07GF471J RESISTOR, FIXED, COMP EA XDHZZ RC07GF560J RESISTOR, FIXED, COMP EA XDHZZ RC07GF680J RESISTOR, FIXED, COMP EA XDHZZ RC07GF220J RESISTOR, FIXED, COMP EA XDHZZ TRANSFORMER... EA XDHZZ TRANSFORMER EA XDHZZ TRANSFORMER EA XDHZZ TRANSFORMER EA XDHZZ TRANSFORMER EA 2 54

51 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC XDHZZ TRANSFORMER, VAR EA XDHZZ INSULATOR, DISK EA XDHZZ PLATE, ELEC SHIELD EA I XDHZZ PLATE, ELEC SHIELD EA I XDHZZ PLATE, ELEC SHIELD EA XDHZZ 9511B-B POST, ELEC-MECH EQPT... EA XDHZZ SHIELD, VHF MIXER EA XDHZZ PLATE, ELEC SHIELD EA PAHZZ MS SCREW, MACHINE EA 4 55/(56 blank)

52 Figure 16. IF Filter Circuit Card Assembly (sheet 1 of 2) 57

53 Figure 16. IF Filter Circuit Card Assembly (sheet 2 of 2) 57

54 SECTION II (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM U/M UNIT UOC GROUP 0707 IF FILTER CCA 16 1 PAHZZ C069B250F103Z CAPACITOR, FIXED, CER... EA XDHZZ CM04CD100D CAPACITOR, FIXED, MIC EA XDHZZ CAPACITOR, FIXED EA XDHZZ 196D156X9015JA CAPACITOR, FIXED, ELE... EA XDHZZ CM05FD221J CAPACITOR, FIXED, MIC... EA PAHZZ 3CXR7104X0100C CAPACITOR, FIXED EA CM04ED820J CAPACITOR, FIXED, MIC... EA XDHZZ CM05FD361J CAPACITOR, FIXED EA PAHZZ N SEMICONDUCTOR DEVIC... EA XDHZZ FILTER, BAND PASS EA XDHZZ FILTER, BAND PASS EA XDHZZ FILTER, BAND PASS EA XDHZZ J COIL, RF, FXD, 150UH EA XDHZZ COIL, RF, VAR, 3.3UH EA XDHZZ J COIL, RF, FXD, 22UH EA XDHZZ J COIL, RF, FXD, 1.5UH EA PAHZZ N TRANSISTOR EA XDHZZ RC07GF101J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF270J RESISTOR, FIXED, COMP EA XDHZZ RC07GF471J RESISTOR, FIXED, COMP.... EA PAHZZ RC07GF102J RESISTOR, FIXED, COMP EA XDHZZ RC07GF180J RESISTOR, FIXED, COMP EA XDHZZ RC07GF152J RESISTOR, FIXED, COMP EA XDHZZ RC07GF822J RESISTOR, FIXED, COMP... EA XDHZZ RC07GF472J RESISTOR, FIXED, COMP EA XDHZZ RC07GF221J RESISTOR, FIXED, COMP EA XDHZZ RC07GF821J RESISTOR, FIXED, COMP EA XDHZZ RC07GF331J RESISTOR, FIXED, COMP EA XDHZZ RC07GF220J RESISTOR, FIXED, COMP EA XDHZZ RC07GF560J RESISTOR, FIXED, COMP EA XDHZZ RC07GF103J RESISTOR, FIXED, COMP EA XDHZZ RC07GF100J RESISTOR, FIXED, COMP EA XDHZZ RL07GF272J RESISTOR, FIXED, COMP EA XDHZZ RC07GF562J RESISTOR, FIXED, COMP EA XDHZZ RC07GF561J RESISTOR, FIXED, COMP EA XDHZZ RC07GF392J RESISTOR, FIXED, COMP EA XDHZZ RC07GF151J RESISTOR, FIXED, COMP... EA PAHZZ CA MICROCIRCUIT, LINEAR... EA 2 59/(60 blank)

55 Figure 17. Sideband Generator Circuit Card Assembly (sheet 1 of 2). 61

56 Figure 17. Sideband Generator Circuit Card Assembly (sheet 2 of 2). 62