TECHNICAL MANUAL. *This manual supersedes TM P, dated 1 May 2005, including all changes.

Transcription

1 MARINE CORPS TM 10802A-OI/2A TECHNICAL MANUAL FIELD MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST FOR TACTICAL WATER PURIFICATION SYSTEM (TWPS) ARMY NSN MARINE CORPS NSN *This manual supersedes TM P, dated 1 May 2005, including all changes. DISTRIBUTION STATEMENT A - Approved for public release; distribution is unlimited. HEADQUARTERS, DEPARTMENT OF THE ARMY HEADQUARTERS, U.S. MARINE CORPS PCN MAY 2008

2

3 LIST OF EFFECTIVE PAGES/WORK PACKAGES NOTE: This manual supersedes TM P, dated 1 May Zero in the Change No. column indicates an original page or work package. Original May 2008 Date of issue for the original manual is: TOTAL NUMBER OF PAGES FOR FRONT AND REAR MATTER IS 20 AND TOTAL NUMBER OF WORK PACKAGES IS 70 CONSISTING OF THE FOLLOWING: Page/WP No. Change No. Title...0 A...0 B blank...0 i iii...0 WP A/B BLANK

4

5 MARINE CORPS TM 10802A-OI/2A HEADQUARTERS, DEPARTMENT OF THE ARMY U.S. MARINE CORPS WASHINGTON, DC, 15 MAY 2008 TECHNICAL MANUAL FIELD MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST FOR TACTICAL WATER PURIFICATION SYSTEM (TWPS) ARMY NSN MARINE CORPS NSN REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this publication. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Submit your DA Form 2028 (Recommended Changes to Equipment Technical Publications), through the Internet, on the Army Electronic Product Support (AEPS) website. The Internet address is The DA Form 2028 is located under the Public Applications section in the AEPS Public Home Page. Fill out the form and click on SUBMIT. Using this form on the AEPS will enable us to respond quicker to your comments and better manage the DA Form 2028 program. You may also mail, fax or your letter or DA Form 2028 directly to: AMSTA-LC-LMIT/TECH PUBS, TACOM-RI, 1 Rock Island Arsenal, Rock Island, IL The address is TACOM-TECH-PUBS@conus.army.mil. The fax number is DSN or Commercial (309) *This manual supersedes TM P, dated 1 May 2005, including all changes. DISTRIBUTION STATEMENT A - Approved for public release; distribution is unlimited. i

6 TABLE OF CONTENTS WP Sequence No. CHAPTER 1 INTRODUCTION Introduction to Repair Parts and Special Tools List CHAPTER 2 REPAIR PARTS LIST Group 01 Raw Water System Raw Water System Hose Assemblies and Adaptors Diesel Engine-Driven Pump Assembly P Electric Motor-Driven Pump Assembly P Cyclone Separator Group 02 Product Water Distribution System Product Water Distribution System Hose Assemblies and Adaptors Electric Motor-Driven Pump Assembly P Group 03 Micro-Filtration System Micro-Filtration System Hose Assemblies MF Feed Pump Assembly P Piping Assembly F Strainer S-2 Assembly Piping Assembly F Filter Module Assembly Piping Assembly M Piping Assembly R Piping Assembly C Group 04 Reverse Osmosis System Reverse Osmosis System RO Feed Tank Assembly T Piping Assembly M RO Feed Pump Assembly P Piping Assembly M High Pressure Pump Assemblies P-5 and P Piping Assembly H Turbocharger Assembly Piping Assembly H ii

7 TABLE OF CONTENTS - Continued WP Sequence No. RO Vessels ROV-1 through ROV Piping Assembly H Piping Assembly R Piping Assembly R Piping Assembly P Group 05 Chemical Injection System Chemical Injection System Group 06 Air System Air System Air Compressor Assembly Air Compressor AF2 CO1 Assembly Air System Section Pressure Switch Assembly and Air Receiver Tank R Air System Section Air System Section Air System Section Feed Flow Control Panel Assembly Air System Hoses and Tubing Group 07 Electrical System Operation Control and Power Distribution System Operation Control System Operator Control Top Panel Assembly Operator Control Sub-Panel Assembly Power Distribution System Power Distribution Panel Power Cables Instrument / Solenoid Panel Group 08 Skid TWPS Skid Group 09 NBC System NBC Tank Group 10 NBC Survivability System NBC Survivability System iii

8 TABLE OF CONTENTS - Continued WP Sequence No. Group 11 Cold Weather System Space Heater General Purpose Transformer Ice Intake Strainer and Heating Blankets Group 12 Cleaning Waste Storage System Adaptors Group 13 Ocean Intake Structure System Hose Assemblies and Fittings Group 14 Extended Distribution System Extended Distribution System Hose Assemblies and Adaptors Diesel Engine-Driven Pump Assembly P Group 15 Flat Rack Assembly Flat Rack Assembly (A-TWPS Only) Group 16 Waste Discharge System Hose Assemblies and Adaptors Group 99 Bulk Materials Bulk Materials CHAPTER 3 SPECIAL TOOLS Special Tools CHAPTER 4 CROSS-REFERENCE INDICES National Stock Number (NSN) Index Part Number (P/N) Index iv

9 CHAPTER 1 INTRODUCTION

10

11 TACTICAL WATER PURIFICATION SYSTEM (TWPS) REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) INTRODUCTION INTRODUCTION SCOPE This RPSTL lists and authorizes spares and repair parts; special tools; special test, measurement and diagnostic equipment (TMDE); and other special support equipment required for performance of Field Maintenance of the Tactical Water Purification System (TWPS). It authorizes the requisitioning, issue and disposition of spares, repair parts and special tools as indicated by the source, maintenance and recoverability (SMR) codes. GENERAL In addition to the Introduction work package, this RPSTL is divided into the following work packages. 1. Repair Parts List Work Packages. Work packages containing lists of spares and repair parts authorized by this RPSTL for use in the performance of maintenance. These work packages also include parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in ascending alphanumeric sequence, with the parts in each group listed in ascending figure and item number sequence. Sending units, brackets, filters and bolts are listed with the component they mount on. Bulk materials are listed by item name in FIG. BULK at the end of the work packages. Repair parts kits are listed separately in their own functional group and work package. Repair parts for reparable special tools are also listed in a separate work package. Items listed are shown on the associated illustrations. 2. Special Tools List Work Packages. Work packages containing lists of special tools, special TMDE and special support equipment authorized by this RPSTL (as indicated by Basis of Issue (BOI) information in the DESCRIPTION AND USABLE ON CODE (UOC) column). Tools that are components of common tool sets and/or Class VII are not listed. 3. Cross-Reference Indexes Work Packages. There are two cross-reference indexes work packages in this RPSTL: the National Stock Number (NSN) Index work package and the Part Number (P/N) Index work package. The National Stock Number Index work package refers you to the figure and item number. The Part Number Index work package refers you to the figure and item number. EXPLANATION OF COLUMNS IN THE REPAIR PARTS LIST AND SPECIAL TOOLS LIST WORK PACKAGES ITEM NO. (Column (1)). Indicates the number used to identify items called out in the illustration. SMR CODE (Column (2)). The SMR code containing supply/requisitioning information, maintenance level authorization criteria and disposition instruction, as shown in the following breakout:

12 TACTICAL WATER PURIFICATION SYSTEM (TWPS) REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) INTRODUCTION TABLE 1. SMR Code Explanation. Source Code Maintenance Code Recoverability Code XX XX X 1 st two positions: How to get an item. 3 rd position: Who can install, replace or use the item. 4 th position: Who can do complete repair* on the item. 5 th position: Who determines disposition action on unserviceable items. *Complete Repair: Maintenance capacity, capability and authority to perform all corrective maintenance tasks of the "Repair" function in a use/user environment in order to restore serviceability to a failed item. Source Code. The source code tells you how you get an item needed for maintenance, repair or overhaul of an end item/equipment. Explanations of source codes follow: Source Code PA PB PC PD PE PF PG PH PR PZ KD KF KB MO - Made at Unit/AMC level MF - Made at DS/ASB level MH - Made at Sustainment level ML - Made at SRA/TASMG MD - Made at depot MG Navy only AO - Assembled by Unit/AMC level AF - Assembled by DS/ASB level AH - Assembled by Sustainment level AL - Assembled by SRA/TASMG Application/Explanation NOTE Items coded PC are subject to deterioration. Stock items; use the applicable NSN to requisition/request items with these source codes. They are authorized to the level indicated by the code entered in the third position of the SMR code. Items with these codes are not to be requested/requisitioned individually. They are part of a kit which is authorized to the maintenance level indicated in the 3rd position of the SMR code. The complete kit must be requisitioned and applied. Items with these codes are not to be requisitioned/requested individually. They must be made from bulk material which is identified by the part number in the DESCRIPTION AND USABLE ON CODE (UOC) column and listed in the bulk material group work package of the RPSTL. If the item is authorized to you by the third position code of the SMR code, but the source code indicates it is made at higher level, order the item from the higher level of maintenance. Items with these codes are not to be requested/requisitioned individually. The parts that make up the assembled item must be requisitioned or fabricated and assembled at the level of maintenance indicated by the source code. If the third position of the SMR code authorizes you to replace the item, but the source

13 TACTICAL WATER PURIFICATION SYSTEM (TWPS) REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) INTRODUCTION Source Code AD - Assembled by depot AG Navy only XA XB XC XD Application/Explanation code indicates the item is assembled at a higher level, order the item from the higher level of maintenance. Do not requisition an "XA" coded item. Order the next higher assembly. (Refer to NOTE below.) If an item is not available from salvage, order it using the CAGEC and P/N. Installation drawings, diagrams, instruction sheets, field service drawings; identified by manufacturer's part number. Item is not stocked. Order an XD-coded item through local purchase or normal supply channels using the CAGEC and part number given, if no NSN is available. NOTE Cannibalization or controlled exchange, when authorized, may be used as a source of supply for items with the above source codes except for those items source coded "XA" or those aircraft support items restricted by requirements of AR Maintenance Code. Maintenance codes tell you the level(s) of maintenance authorized to use and repair support items. The maintenance codes are entered in the third and fourth positions of the SMR code as follows: Third Position. The maintenance code entered in the third position tells you the lowest maintenance level authorized to remove, replace and use an item. The maintenance code entered in the third position will indicate authorization to the following levels of maintenance: Maintenance Code Application/Explanation O* - Unit level/amc maintenance can remove, replace and use the item. F - Direct support/asb maintenance can remove, replace and use the item. H - Sustainment maintenance can remove, replace and use the item. L - Specialized repair activity/tasmg can remove, replace and use the item. G - Afloat and ashore intermediate maintenance can remove, replace and use the item (Navy only). K - Contractor facility can remove, replace and use the item. Z - Item is not authorized to be removed, replaced or used at any maintenance level. D - Depot can remove, replace and use the item. *NOTE Army may use C in the third position. However, for joint service publications, Army will use O. Fourth Position. The maintenance code entered in the fourth position tells you whether or not the item is to be repaired and identifies the lowest maintenance level with the capability to do complete repair (perform all authorized repair functions)

14 TACTICAL WATER PURIFICATION SYSTEM (TWPS) REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) INTRODUCTION NOTE Some limited repair may be done on the item at a lower level of maintenance, if authorized by the Maintenance Allocation Chart (MAC) and SMR codes. Maintenance Code O F H L D G K Z B Application/Explanation Unit/AMC is the lowest level that can do complete repair of the item. Direct support/asb is the lowest level that can do complete repair of the item Sustainment is the lowest level that can do complete repair of the item. Specialized repair activity/tasmg is the lowest level that can do complete repair of the item. Depot is the lowest level that can do complete repair of the item. Both afloat and ashore intermediate levels are capable of complete repair of item (Navy only). Complete repair is done at contractor facility. Nonreparable. No repair is authorized. No repair is authorized. No parts or special tools are authorized for maintenance of "B" coded item. However, the item may be reconditioned by adjusting, lubricating, etc., at the user level. Recoverability Code. Recoverability codes are assigned to items to indicate the disposition action on unserviceable items. The recoverability code is shown in the fifth position of the SMR code as follows: Recoverability Code Z O F H D Application/Explanation Nonreparable item. When unserviceable, condemn and dispose of the item at the level of maintenance shown in the third position of the SMR code. Reparable item. When uneconomically reparable, condemn and dispose of the item at the service/amc level. Reparable item. When uneconomically reparable, condemn and dispose of the item at the field level/asb. Reparable item. When uneconomically reparable, condemn and dispose of the item at the below depot sustainment level. Reparable item. When beyond lower level repair capability, return to depot. Condemnation and disposal of item are not authorized below depot level

15 TACTICAL WATER PURIFICATION SYSTEM (TWPS) REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) INTRODUCTION Recoverability Code L A G K Application/Explanation Reparable item. Condemnation and disposal not authorized below Specialized Repair Activity (SRA) or theatre aviation sustainment maintenance group (TASMG). Item requires special handling or condemnation procedures because of specific reasons (such as precious metal content, high dollar value, critical material or hazardous material). Refer to appropriate manuals/directives for specific instructions. Field level reparable item. Condemn and dispose at either afloat or ashore intermediate levels (Navy only). Reparable item. Condemnation and disposal to be performed at contractor facility. NSN (Column (3)). The NSN for the item is listed in this column. CAGEC (Column (4)). The Commercial and Government Entity Code (CAGEC) is a five-digit code which is used to identify the manufacturer, distributor or Government agency/activity that supplies the item. PART NUMBER (Column (5)). Indicates the primary number used by the manufacturer (individual, company, firm, corporation or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications, standards and inspection requirements to identify an item or range of items. NOTE When you use an NSN to requisition an item, the item you receive may have a different part number from the number listed. DESCRIPTION AND USABLE ON CODE (UOC) (Column (6)). This column includes the following information: 1. The federal item name, and when required, a minimum description to identify the item. 2. Part numbers of bulk materials are referenced in this column in the line entry to be manufactured or fabricated. 3. Hardness Critical Item (HCI). A support item that provides the equipment with special protection from electromagnetic pulse (EMP) damage during a nuclear attack. 4. The statement END OF FIGURE appears just below the last item description in column (6) for a given figure in both the repair parts list and special tools list work packages. QTY (Column (7)). The QTY (quantity per figure) column indicates the quantity of the item used in the breakout shown on the illustration/figure, which is prepared for a functional group, subfunctional group or an assembly. A "V" appearing in this column instead of a quantity indicates that the quantity is variable and quantity may change from application to application

16 TACTICAL WATER PURIFICATION SYSTEM (TWPS) REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) INTRODUCTION EXPLANATION OF CROSS-REFERENCE INDEXES WORK PACKAGES FORMAT AND COLUMNS 1. National Stock Number (NSN) Index Work Package. NSN s in this index are listed in National Item Identification Number (NIIN) sequence. STOCK NUMBER Column. This column lists the NSN in NIIN sequence. The NIIN consists of the last nine digits of the NSN. When using this column to locate an item, ignore the first four digits of the NSN. However, the complete NSN should be used when ordering items by stock number. For example, if the NSN is , the NIIN is FIG. Column. This column lists the number of the figure where the item is identified/located. The figures are in numerical order in the repair parts list and special tools list work packages. ITEM Column. The item number identifies the item associated with the figure listed in the adjacent FIG. column. This item is also identified by the NSN listed on the same line. 2. Part Number (P/N) Index Work Package. Part numbers in this index are listed in ascending Alphanumeric sequence (vertical arrangement of letter and number combinations which place the first letter or digit of each group in order A through Z, followed by the numbers 0 through 9 and each following letter or digit in like order). PART NUMBER Column. Indicates the part number assigned to the item. FIG. Column. This column lists the number of the figure where the item is identified/located in the repair parts list and special tools list work packages. ITEM Column. The item number is the number assigned to the item as it appears in the figure referenced in the adjacent figure number column. SPECIAL INFORMATION UOC. The UOC appears in the lower left corner of the Description Column heading. Usable on codes are shown as "UOC:..." in the Description Column (justified left) on the first line under the applicable item/nomenclature. Uncoded items are applicable to all models. Identification of the UOCs used in the RPSTL are: Code TWA TWM Used On Model A-TWPS Model MC-TWPS Fabrication Instructions. Bulk materials required to manufacture items are listed in the bulk material functional group of this RPSTL. Part numbers for bulk material are also referenced in the Description Column of the line item entry for the item to be manufactured/fabricated. Index Numbers. Items which have the word BULK in the figure column will have an index number shown in the item number column. This index number is a cross-reference between the NSN/Part Number (P/N) Index work packages and the bulk material list in the repair parts list work package

17 TACTICAL WATER PURIFICATION SYSTEM (TWPS) REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) INTRODUCTION Associated Publications. The publications listed below pertain to the A-TWPS and MC-TWPS: Publication TM TM TM TM P TM &P TM &P Short Title Operator Manual for Tactical Water Purification System Field Maintenance Manual for Tactical Water Purification System Operator, Unit, Direct Support, and General Support Maintenance Manual for Generator Set, Skid Mounted, Tactical Quiet, 60kW, MEP-806B, 50/60 Hz Unit, Direct Support, and General Support Maintenance Repair Parts and Special Tools List for Generator Set, Skid Mounted, Tactical Quiet, 60kW, MEP-806B, 50/60 Hz Operator and Unit Maintenance Manual (Including Repair Parts and Special Tools List) for Water Quality Analysis Set: Purification (WQAS-P) Operator and Unit Maintenance Manual (Including Repair Parts and Special Tools List) for Tank, Fabric, Collapsible, Water Storage, 3000 Gallons HOW TO LOCATE REPAIR PARTS 1. When NSNs or Part Numbers Are Not Known. First. Using the table of contents, determine the assembly group to which the item belongs. This is necessary since figures are prepared for assembly groups and subassembly groups and lists are divided into the same groups. Second. Find the figure covering the functional group or the subfunctional group to which the item belongs. Third. Identify the item on the figure and note the number(s). Fourth. Look in the repair parts list work packages for the figure and item numbers. The NSNs and part numbers are on the same line as the associated item numbers. 2. When NSN Is Known. First. If you have the NSN, look in the STOCK NUMBER column of the NSN index work package. The NSN is arranged in NIIN sequence. Note the figure and item number next to the NSN. Second. Turn to the figure and locate the item number. Verify that the item is the one you are looking for. 3. When P/N Is Known. First. If you have the part number and not the NSN, look in the PART NUMBER column of the part number index work package. Identify the figure and item number. Second. Look up the item on the figure in the applicable repair parts list work package /8 BLANK

18

19 CHAPTER 2 REPAIR PARTS LIST

20

21

22 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM RAW WATER SYSTEM Figure 1. Raw Water System BLANK / 2

23 GROUP 01 RAW WATER SYSTEM RAW WATER SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 1 RAW WATER SYSTEM 1 PBOZZ B1X ANCHOR, MARINE, FLUKE PBOOO U5N ASSY, ANCHOR ROPE PBOOO U5N STRAINER, FLOATING INLET PBOOO U5N ASSY, HOSE F PBOOO U5N ASSY, ADAPTER A PBOOO U5N ASSY, ADAPTER A PBOFF U5N ASSY, PUMP P PBOOO U5N ASSY, HOSE F PBOFF U5N ASSY, PUMP P PBOOO U5N ASSY, ELBOW A PBOOO U5N ASSY, HOSE F PBOOO U5N SEPARATOR, CYCLONE (CS-1) PBOOO U5N ASSY, VALVE A PBOOO U5N ASSY, HOSE F PBOOO U5N VALVE, DIAPHRAGM, STOP A PBOZZ U5N ASSY, HOSE F (7) QTY END OF FIGURE

24 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM RAW WATER SYSTEM Figure 2. Anchor Rope Assembly

25 GROUP 01 RAW WATER SYSTEM RAW WATER SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 2 ANCHOR ROPE ASSEMBLY 1 PBOZZ B1X ANCHOR, MARINE, FLUKE PBOOO U5N ASSY, ANCHOR ROPE PAOZZ T33. LINK, CHAIN, DETACHABLE PAOZZ B1X BLOCK, SINGLE MOOZZ 9L ROPE, FIBROUS, MAKE FROM BULK MATERIAL NSN , CUT TO LENGTH 125 FT., MELT ENDS TO PREVENT FRAYING... 1 (7) QTY END OF FIGURE

26 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM RAW WATER SYSTEM Figure 3. Suction Strainer

27 GROUP 01 RAW WATER SYSTEM RAW WATER SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 3 SUCTION STRAINER 1 PBOOO U5N STRAINER, SUCTION PAOZZ NW7. GASKET... 1 (7) QTY END OF FIGURE / 8 BLANK

28

29

30 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM HOSE ASSEMBLIES AND ADAPTORS Figure 4. Hose Assemblies and Adaptors BLANK / 2

31 GROUP 01 RAW WATER SYSTEM HOSE ASSEMBLIES AND ADAPTORS REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 4 HOSE ASSEMBLIES AND ADAPTORS 1 PBOOO U5N ASSY, HOSE F PAOZZ NW7. GASKET PBOOO U5N ASSY, HOSE F PAOZZ NW5. GASKET PBOOO U5N ASSY, HOSE F PAOZZ NW5. GASKET PBOZZ U5N ASSY, HOSE F PBOOO U5N ASSY, ELBOW A PAOZZ NW5. GASKET PBOOO U5N ASSY, VALVE A PAOZZ NW2. GASKET PAOOO D-FDAPOLY. COUPLING HALF PAOZZ PHN1 884C-020. NIPPLE, PIPE PBOZZ PHN VALVE, BALL PAOZZ F-SS. COUPLING HALF PBOOO U5N VALVE, DIAPHRAGM, STOP A PAOZZ NW5. GASKET PAOOO D-FDAPOLY. COUPLING HALF PAOZZ K81. BUSHING, PIPE PAOZZ PHN1 886C-005. NIPPLE, PIPE PBOZZ PHN VALVE ASSEMBLY PAOZZ A-FDAPOLY. COUPLING HALF PBOOO U5N ASSY, HOSE F PAOZZ NW5. GASKET PBOOO U5N ASSY, ADAPTER A PAOZZ NW2. GASKET PAOOO D-FDAPOLY. COUPLING HALF PAOZZ PHN1 884C-020. NIPPLE, PIPE PBOZZ PHN1 V100. VALVE, BALL PAOZZ PHN C. BUSHING, PIPE PAOZZ PHN1 805C-020. TEE, PIPE PAOZZ F-SS. COUPLING HALF PAOZZ K71. NIPPLE, PIPE PAOOO DSL-SS. COUPLING HALF PAOZZ NW5. GASKET PBOOO U5N ASSY, ADAPTER A PAOZZ A-SS. COUPLING HALF,SELF-SEALING 1 38 PAOZZ K739. BUSHING, REDUCER PAOZZ P STRAP/BUCKLE ASSEMBLY PAOZZ K17. CLAMP, HOSE PBOZZ PVDF. VALVE, CHECK PAOZZ A-SS. COUPLING HALF, QUICK DISCONNECT 1 43 PBOZZ HBS30/40/50 CAM ASSEMBLY... 2 END OF FIGURE (7) QTY / 4 BLANK

32

33

34 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P A , 17, 18, 19, 20, A Reverse View Figure 5. Diesel Engine Pump Assembly P BLANK / 2

35 GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-1 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 5 DIESEL ENGINE PUMP ASSEMBLY P-1 1 PBOFF AK42 L48EE-DE-SFA ENGINE, DIESEL PAOZZ A628. SCREW, CAP, HEX PAOZZ WASHER, LOCK PAOZZ MS WASHER, FLAT MOOZZ HOSE, NON-METALLIC... 2 (MAKE FROM BULK MATERIAL. CUT TO LENGTH 18 IN.) 6 PBOOO U5N TANK UNIT, FUEL PBOFF U5N FRAME PBOOO PUMP, CENTRIFUGAL PBOOO U5N ASSY, JUNCTION BOX PAOZZ NASM SCREW, CAP, HEX PAOZZ A029. WASHER, SEAL PAOZZ A029. O-RING XBOZZ 0U5N ENCLOSURE, ELECTRICAL PAOZZ PA87. BOOT, DUST AND MOISTURE PAOZZ MS SWITCH, TOGGLE PAOZZ MS3452W14S-7S. CONNECTOR, RECEPTACLE PAOZZ GASKET PAOZZ MS DA.. COVER, ELECTRICAL CONNECTOR PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PAOZZ MS SCREW, MACHINE PAOZZ AA LOCKNUT, ELECTRICAL PX01S 23 PAOZZ O-RING PAOZZ BOX CONNECTOR, ELECTRICAL PBOZZ U5N CABLE ASSEMBLY, SPECIAL PURPOSE PAOZZ MS3452W16S-5P. CONNECTOR, RECEPTACLE PAOZZ A GASKET PAOZZ MS DA.. COVER, ELECTRICAL CONNECTOR PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PAOZZ N6NY-006C-0-M CLAMP, LOOP PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ T14 BOLT, EYE PAOZZ MS WASHER, LOCK PAOZZ E NUT, PLAIN, HEX PAOZZ MS WASHER, FLAT PAOZZ WASHER, LOCK... 1 END OF FIGURE (7) QTY

36 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 6. Fuel Tank Assembly

37 GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-1 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 6 FUEL TANK ASSEMBLY 1 PBOOO U5N TANK, FUEL, ENGINE PBOZZ AK CAP, FILLER OPENING PAOZZ AK FILTER, GAS PAOZZ AK O-RING PAOZZ AK PLUG, EXPANSION PAOZZ AK O-RING PAOZZ AK FILTER ELEMENT PAOZZ MS WASHER, FLAT PAOZZ A530. WASHER, LOCK PAOZZ A318. SCREW, MACHINE PAOZZ AK O-RING PAOZZ AK COCK, SHUTOFF PBOOO U5N HOSE ASSY, RETURN PAOZZ CLAMP, HOSE MOOZZ K19-YEL. INSULATION SLEEVING... 1 MAKE FROM BULK MATERIAL,NSN , CUT TO LENGTH 3 INCKES 16 MOOZZ HOSE, NONMETALLIC... 1 MAKE FROM BULK MATERIAL, NSN , CUT TO LENGTH 3 INCHES 17 PAOZZ PLCD22004V. COUPLING HALF, MALE PBOOO U5N HOSE ASSY, SUPPLY PAOZZ CLAMP, HOSE MOOZZ K19-RED. INSULATION SLEEVING,ELECTRICAL 1 MAKE FROM BULK MATERIAL, NSN , CUT TO LENGTH 0.1 FT 21 MOOZZ HOSE, NONMETALLIC... 1 MAKE FROM BULK MATERIAL, NSN , CUT TO LENGTH 5.3 INCHES 22 PAOZZ PLCD17006V. COUPLING HALF, FEMALE XBOZZ 0U5N FRAME, TANK, END XBOZZ 0U5N FRAME, TANK, BACK PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, CAP, HEX PAOZZ AK NUT, PLAIN, HEX... 2 END OF FIGURE (7) QTY

38 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 7. P-1 Centrifugal Pump

39 GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-1 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 7 P-1 CENTRIFUGAL PUMP 1 KFOZZ C31796 SEAL ASSEMBLY, SHAFT... 1 (PART OF KITS P/Ns AND 33636) 2 PAOZZ A322 SCREW, CAP, HEX PAOZZ A429 WASHER, LOCK PAOZZ A190 WASHER, FLAT KFOZZ C33592 HUB, BODY... 1 (PART OF KITS P/Ns and 33636) 6 KFOZZ C22294 IMPELLER, PUMP (PART OF KIT P/N 33636) KFOZZ GASKET... 1 (PART OF KITS P/Ns AND 33636) 8 KFOZZ C21249 SCREW, MACHINE (PART OF KIT P/N 33636). 2 9 KFOZZ C27978 PLATE, WEAR, ROTARY PUMP... 1 (PART OF KIT P/N 33636) 10 PAOZZ U5N7 755MFZ1 VALVE, PLUG KFOZZ GASKET (PART OF KIT P/N 33636) PAOOO V-FDAPOLY CAP, PROTECTIVE PAOZZ NW5. GASKET PAOZZ F-SS COUPLING HALF, QUICK PAOZZ C51 CHAIN, WELDLESS PAOZZ GASKET PAOZZ VALVE FLAPPER, PUMP PBOZZ BSL-SS COUPLING HALF, SELF PAOZZ NW5. GASKET PAOZZ W-FDAPOLY PLUG, PROTECTIVE PBOZZ CLAMP, SYNCHRO PAOZZ NUT, PLAIN, HEX PAOZZ STUD, PLAIN PAOZZ SCREW, CAP, HEX PAOZZ WASHER, LOCK KFOZZ NUT, SELF-LOCKING, CAP... (PART OF KIT P/N 33636) 2 PBOZZ KIT, SEAL REPAIR GASKET (1) 7...SEAL ASSEMBLY, SHAFT (1) 1...HUB, BODY (1) 5 PBOZZ KIT, PUMP OVERHAUL GASKET (1) 7...GASKET (2) IMPELLER, PUMP (1) 6...NUT, SELF-LOCKING, CAP (2) PLATE, WEAR, ROTARY PUMP (1) 9... SCREW, MACHINE (2) 8...SEAL ASSEMBLY, SHAFT (1) 1...HUB, BODY (1) 5 END OF FIGURE (7) QTY

40 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 8. Air Cleaner, Hand Starter, and Muffler

41 GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-1 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 8 AIR CLEANER, HAND STARTER, AND MUFFLER 1 PAOOO AK AIR CLEANER, INTAKE PAOZZ AK FILTER ELEMENT PAOZZ AK GASKET PAOZZ AK GASKET PAOZZ S HEATING ELEMENT PBOOO AK STARTER, ENGINE, HAND PAOZZ AK HANDLE, STARTING XBOZZ 0U5N SHIELD, EXHAUST PAOZZ AK PNEUMATIC MUFFLER PAOZZ AK GASKET XBOOO 0U5N JUMPER, ELECTRICAL MOOZZ 1HVR WIRE, ELECTRICAL MAKE FROM BULK... 1 MATERIAL.NSN , CUT TO LENGTH 8 INCHES 13 PAOZZ PN10-14R. TERMINAL LUG PAOZZ AK SCREW, CAP, HEX... 3 END OF FIGURE (7) QTY

42 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 9. Fuel Injection and Oil Systems

43 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 9 FUEL INJECTION AND OIL SYSTEMS 1 PBOOO U5N HOSE ASSY, SUPPLY PAOZZ CLAMP, HOSE MOOZZ HOSE, NONMETALLIC, MAKE FROM... 1 BULK MATERIAL, NSN , CUT TO 14 LENGTH 14 IN. 4 MOOZZ K19-RED. INSULATION,SLEEVING,ELECTRICAL 1 MAKE FROM BULK MATERIAL, NSN , CUT TO LENGTH 0.1 FT 5 PAOZZ PLCD22004V. COUPLING HALF, MALE PBOOO U5N HOSE ASSY, RETURN PAOZZ CLAMP, HOSE MOOZZ HOSE, NONMETALLIC... 1 MAKE FROM BULK MATERIAL,NSN , CUT TO LENGTH 16 INCHES 9 MOOZZ K19-YEL. INSULATION,SLEEVING,ELECTRICAL 1 MAKE FROM BULK MATERIAL,NSN , CUT TO LENGTH 0.1 FT 10 PAOZZ PLCD17006V. COUPLING HALF, FEMALE XBOOO 0U5N JUMPER, ELECTRICAL MOOZZ MTW-10-YEL. WIRE, ELECTRICAL... 1 (MAKE FROM BULK. CUT TO 3 IN.) 13 PAOZZ PN10-14R. TERMINAL LUG PAOZZ AK O-RING PAOZZ AK GAGE ROD-CAP PAOZZ AK NIPPLE, PIPE PAOZZ AK GASKET PAOZZ AK GASKET PAOZZ AK STRAINER, OIL PUMP PBOZZ AK SPRING, HELICAL (REGULATOR) PBOZZ AK SPRING, HELICAL (THROTTLE RETURN) PAOZZ AK GASKET PBOZZ AK PUMP, FUEL, METERING PAOZZ AK GASKET PAOZZ AK SPACER, SLEEVE PBOZZ AK INJECTOR ASSY, FUEL PBOZZ AK PIPE, FUEL INJECTION PAOZZ AK NUT, PLAIN, HEX PAOZZ AK PLUG, PIPE (OIL DRAIN) PAOZZ AK SCREW, CAP, HEX PAOZZ AK KNOB, MANUAL CONTROL XBOZZ 0AK STAY, HANDLE PAOZZ S HANDLE, MANUAL CONTROL PAOZZ GUY SPRING, HELICAL, COMPRESSION... 1 END OF FIGURE (7) QTY

44 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 10. Electric Starter System

45 GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-1 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 10 ELECTRIC STARTER SYSTEM 1 XBOZZ 0U5N BRACKET PAOZZ MS WASHER, FLAT PAOZZ A136. SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ U5N CABLE ASSY, POWER PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, FLAT PAOZZ M45913/1-4CS3. NUT, SELF-LOCKING PBOZZ S STARTER, ENGINE, ELECTRIC... 1 (7) QTY END OF FIGURE

46 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 11. Cylinder Head Valves and Gaskets

47 GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-1 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 11 CYLINDER HEAD VALVES AND GASKETS 1 PAFZZ AK GASKET, CYLINDER HEAD PAFZZ AK INSERT, ENGINE VALVE SEAT PAFZZ AK O-RING PAOZZ AK GASKET PAFZZ AK VALVE, POPPET, ENGINE PAFZZ AK VALVE, POPPET, ENGINE PAFZZ GUY O-RING PAFZZ AK CYLINDER HEAD PAFZZ AK PUSH ROD, ENGINE PAFZZ AK WASHER, FLAT PAFZZ AK NUT, CAP PAFZZ S SCREW PAFZZ AK ROCKER ARM ASSEMBLY PAFZZ AK LOCK, VALVE SPRING RETAINER PAFZZ AK SEAT, SPRING PAFZZ AK SPRING, HELICAL PAFZZ AK WASHER, FLAT PAFZZ AK NUT, PLAIN, HEX PAOZZ AK BOLT, MACHINE PAOZZ AK PLUNGER, QUICK RELEASE PAOZZ AK PLUNGER, DETENT PAOZZ AK COVER PLATE, VALVE... 1 (7) QTY END OF FIGURE

48 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 12. Crankcase Gasket and Piston Rings

49 GROUP 01 RAW WATER SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-1 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 12 CRANKCASE GASKET AND PISTON RINGS 1 PAFZZ AK RING SET, PISTON PAFZZ GUY GASKET, CRANKCASE PAFZZ AK SEAL, PLAIN ENCASED... 1 (7) QTY END OF FIGURE / 18 BLANK

50

51

52 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM ELECTRIC MOTOR-DRIVEN PUMP ASSEMBLY P A A 16, 17, 18, 19, 20, Figure 13. Electric Motor Driven Pump Assembly P BLANK / 2

53 GROUP 01 RAW WATER SYSTEM ELECTRIC MOTOR-DRIVEN PUMP ASSEMBLY P-2 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 13 ELECTRIC PUMP ASSY P-2 1 PBOOO PUMP, CENTRIFUGAL PAOZZ MS BOLT, MACHINE PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PBOFF U5N FRAME PBOOO U5N ASSY, JUNCTION BOX PAOZZ NASM SCREW, CAP, HEX PAOZZ A029. WASHER, SEAL PAOZZ A029. O-RING XBOZZ 0U5N ENCLOSURE, ELECTRICAL PAOOO GP3102E20-15P. CONNECTOR, RECEPTACLE PAOZZ A GASKET PAOZZ MS DA.. COVER, ELECTRICAL CONNECTOR PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PAOOO MS3452W14S-7S. CONNECTOR, RECEPTACLE PAOZZ GASKET PAOZZ MS DA.. COVER, ELECTRICAL CONNECTOR PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PAOZZ MS SCREW, MACHINE PAOOO MS3452W18-10S. CONNECTOR, RECEPTACLE PAOZZ GASKET PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE... 4 (7) QTY END OF FIGURE

54 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM ELECTRIC MOTOR-DRIVEN PUMP ASSEMBLY P Figure 14. P-2 Centrifugal Pump

55 GROUP 01 RAW WATER SYSTEM ELECTRIC MOTOR-DRIVEN PUMP ASSEMBLY P-2 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 14 P-2 CENTRIFUGAL PUMP 1 KFOZZ C31796 SEAL ASSEMBLY, SHAFT... 1 (PART OF KITS P/Ns AND 33638) 2 KFOZZ C33590 HUB, BODY... 1 (PART OF KITS P/Ns AND 33638) 3 KFOZZ C22294 IMPELLER, PUMP... 1 (PART OF KIT P/N 33638) 4 KFOZZ GASKET... (PART OF KITS P/Ns AND 33638) 1 5 KFOZZ C21249 SCREW, MACHINE (PART OF KIT P/N 33638). 2 6 KFOZZ C27978 PLATE, WEAR, ROTARY PUMP... 1 (PART OF KIT P/N 33638) 7 PAOZZ U5N7 755MFZ1 VALVE, PLUG KFOZZ GASKET (PART OF KIT P/N 33638) PAOOO V-FDAPOLY CAP, PROTECTIVE PAOZZ NW5. GASKET PAOZZ C51 CHAIN, WELDLESS PAOZZ F-SS COUPLING HALF PAOZZ GASKET PAOZZ VALVE FLAPPER, PUMP PAOZZ K71 NIPPLE, PIPE PBOOO DSL-SS COUPLER PAOZZ W-FDAPOLY PLUG, PROTECTIVE PBOZZ C26197 MOTOR ASSEMBLY, ELECTRIC PBOZZ U5N CABLE ASSEMBLY, SPECIAL PAOZZ JN SPLICE, CONDUCTOR PAOZZ PN14-10R-C TERMINAL, LUG PBOZZ CGB195-SG BOX CONNECTOR, ELEC PAOZZ O-RING PAOZZ AA LOCKNUT, ELECTRICAL PX01S 25 PAOZZ PLT1.5I-M STRAP, TIEDOWN, ELECTRICAL PBOZZ CLAMP, SYNCHRO PAOZZ SCREW, CAP, HEX PAOZZ WASHER, LOCK KFOZZ NUT, SELF-LOCKING, CAP... 2 (PART OF KIT P/N 33638) 30 PAOZZ NUT, PLAIN, HEX PAOZZ STUD, PLAIN... 6 (7) QTY

56 GROUP 01 RAW WATER SYSTEM ELECTRIC MOTOR-DRIVEN PUMP ASSEMBLY P-2 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 14 P-2 CENTRIFUGAL PUMP PBOZZ KIT, SEAL REPAIR... V...GASKET (1) 4...HUB, BODY (1) 2...SEAL ASSEMBLY, SHAFT (1) - 1 PBOZZ KIT, PUMP OVERHAUL... V...GASKET (1) 4...GASKET (2) 8...HUB, BODY (1) 2... IMPELLER, PUMP (1) 3...NUT, SELF-LOCKING, CAP (2) PLATE, WEAR, ROTARY PUMP (1) 6... SCREW, MACHINE (2) 5...SEAL ASSEMBLY, SHAFT (1) 1 (7) QTY END OF FIGURE

57

58 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 01 RAW WATER SYSTEM CYCLONE SEPARATOR Figure 15. Cyclone Separator BLANK/2

59 GROUP 01 RAW WATER SYSTEM CYCLONE SEPARATOR REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 01 RAW WATER SYSTEM FIGURE 15 CYCLONE SEPARATOR 1 PAOOO D-FDAPOLY COUPLING HALF PAOZZ NW5. GASKET XBOZZ K738 BUSHING, PIPE XBOZZ 0EXU ELBOW, PIPE XBOZZ 00ZP1 SP-IS46NKCL NIPPLE, PIPE PAOZZ F-FDAPOLY COUPLING HALF PBOZZ RZJ0 ILS SS SEPARATOR, CYCLONE PAOZZ KXJ3 FS-1400P-300 CLAMP, CUSHIONING PAOZZ K735 BUSHING, PIPE XBOZZ 0U5N7 SST45 1 ELBOW, PIPE PAOOO B-SS COUPLING HALF PAOZZ NW2. GASKET XBOOO 0U5N FRAME ASSEMBLY XBOOO 0U5N LEG, RIGHT PAOOO A CATCH, CLAMPING PAOZZ MS21044N06... NUT, SELF-LOCKING, HEX PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, MACHINE PAOZZ A036. NUT, SELF-LOCKING, HEX PAOZZ MS WASHER, FLAT PAOZZ A256. WASHER, FLAT PAOZZ A844. SCREW, CAP,HEX MOOZZ T32. ROPE, WIRE, MAKE FROM BULK 2 MATERIAL, NSN , CUT TO LENGTH 1.1 FT 24 PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT PAOZZ MS21044N06.. NUT, SELF-LOCKING, HEX XBOOO 0U5N LEG, LEFT PAOOO B.. LOOP, STRAP FASTENER PAOZZ MS21044N06... NUT, SELF-LOCKING, HEX PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, MACHINE... 2 END OF FIGURE (7) QTY / 4 BLANK

60

61

62 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM PRODUCT WATER DISTRIBUTION SYSTEM Figure 16. Product Water Distribution System BLANK / 2

63 GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM PRODUCT WATER DISTRIBUTION SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM FIGURE 16 PRODUCT WATER DISTRIBUTION SYSTEM 1 PBOOO U5N ASSY, ADAPTER A PBOOO U5N ASSY, HOSE P PBOOO NUA7 03K-ZT-TNK-A TANK, WATER, 3000 GAL PBOFF U5N ASSY, PUMP P PBOOO U5N ASSY, HOSE P PBOOO U5N ASSY, HOSE P PBOOO U5N ASSY, ADAPTER A PBOOO U5N ASSY, HOSE P PBOOO U5N ASSY, HOSE P PBOOO U5N ASSY, NOZZLE, DISTRIBUTION PBOOO U5N ASSY, ADAPTER A (7) QTY END OF FIGURE / 4 BLANK

64

65

66 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM HOSE ASSEMBLIES AND ADAPTORS Figure 17. Hose Assemblies and Adaptors BLANK / 2

67 GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM HOSE ASSEMBLIES AND ADAPTORS REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM FIGURE 17 HOSE ASSEMBLIES AND ADAPTORS 1 PBOOO U5N ASSY, HOSE P PAOZZ W-FDAPOLY. PLUG, PROTECTIVE PAOZZ NW5. GASKET PBOOO U5N ASSY, ADAPTER A PAOZZ W-FDAPOLY. PLUG, PROTECTIVE PAOZZ NW5. GASKET PBOOO U5N ASSY, HOSE P PAOOO V-FDAPOLY. CAP, PROTECTIVE PAOZZ NW5.. GASKET PBOOO U5N ASSY, NOZZLE, DISTRIBUTION PAOZZ W-FDAPOLY. PLUG, PROTECTIVE PAOZZ NW5. GASKET PAOZZ CAP, PROTECTIVE PBOOO U5N ASSY, HOSE P PAOOO V-FDAPOLY. CAP, PROTECTIVE PAOZZ NW5.. GASKET PBOOO U5N ASSY, ADAPTER A PAOOO V-FDAPOLY. CAP, PROTECTIVE PAOZZ NW5. GASKET PAOZZ F-FDAPOLY. COUPLING HALF PBOZZ PHN VALVE, BALL PAOZZ PHN1 887C-025. NIPPLE, PIPE PAOZZ PHN1 805C-020. TEE, PIPE PAOZZ PHN1 887C-030. NIPPLE, PIPE PAOOO D-FDAPOLY. COUPLING HALF PAOZZ W-FDAPOLY. PLUG, PROTECTIVE PBOOO U5N ASSY, ADAPTER A PAOOO V-FDAPOLY. CAP, PROTECTIVE PAOZZ NW5.. GASKET PAOZZ A-FDAPOLY. COUPLING HALF PAOZZ PHN C. BUSHING, PIPE PAOZZ PHN1 886C-020. NIPPLE, PIPE PBOZZ PHN VALVE, BALL PAOZZ A-FDAPOLY. ADAPTER, STRAIGHT PAOZZ NW4. GASKET PAOOO V-FDAPOLY. CAP, PROTECTIVE PBOOO U5N ASSY, HOSE P PAOZZ NW4. GASKET PAOZZ W-FDAPOLY. PLUG, PROTECTIVE PAOOO V-FDAPOLY. CAP, PROTECTIVE PAOZZ NW4.. GASKET PBOOO U5N ASSEMBLY, HOSE P PAOOO V-FDAPOLY. CAP, PROTECTIVE PAOZZ NW5.. GASKET... 1 END OF FIGURE (7) QTY / 4 BLANK

68

69

70 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM ELECTRIC MOTOR-DRIVEN PUMP ASSEMBLY P A A 16, 17, 18, 19, 20, Figure 18. Electric Motor-Driven Pump Assembly P BLANK / 2

71 GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM ELECTRIC MOTOR-DRIVEN PUMP ASSEMBLY P-7 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM FIGURE 18 ELECTRIC MOTOR-DRIVEN PUMP ASSEMBLY P-7 1 PBOOO PUMP, CENTRIFUGAL PAOZZ MS BOLT, MACHINE PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PBOFF U5N FRAME PBOOO U5N ASSY, JUNCTION BOX PAOZZ NASM SCREW, CAP, HEX PAOZZ A029. WASHER, SEAL PAOZZ A029. O-RING XBOZZ 0U5N ENCLOSURE, ELECTRICAL PAOZZ MS3452W24-2P. CONNECTOR, RECEPTACLE PAOZZ GASKET PAOZZ MS DA.. COVER, ELECTRICAL CONNECTOR PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PAOZZ MS3452W14S-7S. CONNECTOR, RECEPTACLE PAOZZ GASKET PAOZZ MS DA.. COVER, ELECTRICAL CONNECTOR PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PAOZZ MS SCREW, MACHINE PAOZZ MS3452W18-10S. CONNECTOR, RECEPTACLE PAOZZ GASKET PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK... 4 (7) QTY END OF FIGURE

72 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM ELECTRIC MOTOR-DRIVEN PUMP ASSEMBLY P Figure 19. P-7 Centrifugal Pump

73 GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM ELECTRIC MOTOR-DRIVEN PUMP ASSEMBLY P-7 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM FIGURE 19 P-7 PUMP ASSEMBLY 1 KFOZZ C31796 SEAL ASSEMBLY, SHAFT... 1 (PART OF KITS P/Ns AND 33638) 2 KFOZZ C33590 HUB, BODY... 1 (PART OF KITS P/Ns AND 33638) 3 KFOZZ C22294 IMPELLER, PUMP... 1 (PART OF KIT P/N 33638) 4 KFOZZ GASKET... (PART OF KITS P/Ns AND 33638) 1 5 KFOZZ C21249 SCREW, MACHINE (PART OF KIT P/N 33638). 2 6 KFOZZ C27978 PLATE, WEAR, ROTARY PUMP... 1 (PART OF KIT P/N 33638) 7 PAOZZ U5N7 755MFZ1 VALVE, PLUG KFOZZ GASKET (PART OF KIT P/N 33638) PAOOO V-FDAPOLY CAP, PROTECTIVE PAOZZ NW5. GASKET PAOZZ C51 CHAIN, WELDLESS PAOZZ F-SS COUPLING HALF PAOZZ GASKET PAOZZ VALVE FLAPPER, PUMP PAOZZ K71 NIPPLE, PIPE PAOZZ A-SS COUPLING HALF PBOZZ C26197 MOTOR ASSEMBLY, ELECTRIC PBOZZ U5N CABLE ASSEMBLY, SPECIAL PAOZZ JN SPLICE, CONDUCTOR PAOZZ PN14-10R-C TERMINAL, LUG PBOZZ CGB195-SG BOX CONNECTOR, ELEC PAOZZ O-RING PAOZZ AA LOCKNUT, ELECTRICAL PX01S 24 PAOZZ PLT1.5I-M STRAP, TIEDOWN, ELECTRICAL PBOZZ CLAMP, SYNCHRO PAOZZ SCREW, CAP, HEX PAOZZ WASHER, LOCK KFOZZ NUT, SELF-LOCKING, CAP... 2 (PART OF KIT P/N 33638) 29 PAOZZ NUT, PLAIN, HEX PAOZZ STUD, PLAIN... 6 (7) QTY

74 GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM ELECTRIC MOTOR-DRIVEN PUMP ASSEMBLY P-7 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 02 PRODUCT WATER DISTRIBUTION SYSTEM FIGURE 19 P-7 PUMP ASSEMBLY PBOZZ KIT, SEAL REPAIR GASKET (1) 4...SEAL ASSEMBLY, SHAFT (1) 1... HUB, BODY (1) - 2 PBOZZ KIT, PUMP OVERHAUL GASKET (1) 4...GASKET (2) 8... IMPELLER, PUMP (1) 3...NUT, SELF-LOCKING, CAP (2) PLATE, WEAR, ROTARY PUMP (1) 6... SCREW, MACHINE (2) 5...SEAL ASSEMBLY, SHAFT (1) 1... HUB, BODY (1) - 2 (7) QTY END OF FIGURE

75

76 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM MICRO-FILTRATION SYSTEM Figure 20. Micro-Filtration System Off Skid BLANK / 2

77 GROUP 03 MICRO-FILTRATION SYSTEM MICRO-FILTRATION SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 20 MICRO-FILTRATION SYSTEM OFF SKID 1 PBOOO NUA7 01K-OT-TNK TANK, FABRIC, COLLAPSIBLE PBOZZ EXU STRAINER, MF FEED TANK PAOZZ U5N ROPE, MF STRAINER PBOOO U5N HOSE ASSEMBLY, F05, 3-IN. X 3-FT PBOFF U5N PUMP ASSEMBLY, MICRO-FILTRATION, P PBOOO U5N HOSE ASSEMBLY, F07, 3-IN. X 10-FT PBOOO U5N TRIPOD ASSEMBLY PBOZZ Y0Q2 60-ALQR2. TRIPOD, TEST EQUIPMENT XBOZZ 0U5N HOSE SUPPORT PAOZZ T73. STRAP, RETAINING... 1 (7) QTY END OF FIGURE

78 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM MICRO-FILTRATION SYSTEM Figure 21. Micro-Filtration System

79 GROUP 03 MICRO-FILTRATION SYSTEM MICRO-FILTRATION SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 21 MICRO-FILTRATION SYSTEM 1 XBOOO 0EXU3 799-D PIPING ASSEMBLY F XBOOO 0EXU ASSEMBLY, STRAINER S XBOOO 0EXU3 799-D PIPING ASSEMBLY F XBOOO 0EXU3 732-D MODULE / ADAPTER ASSEMBLY XBOOO 0EXU3 799-D PIPING ASSEMBLY M XBOOO 0EXU3 799-D PIPING ASSEMBLY R XBOOO 0EXU3 799-D PIPING ASSEMBLY C (7) QTY END OF FIGURE / 6 BLANK

80

81

82 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM HOSE ASSEMBLIES Figure 22. Hose Assemblies BLANK / 2

83 GROUP 03 MICRO-FILTRATION SYSTEM HOSE ASSEMBLIES REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 22 HOSE ASSEMBLIES 1 PBOOO U5N ASSEMBLY, HOSE F05, 3 IN X 3 FT PAOZZ NW7. GASKET PBOOO U5N ASSEMBLY, HOSE F07, 3 IN X 10 FT PAOZZ NW7. GASKET... 1 (7) QTY END OF FIGURE / 4 BLANK

84

85

86 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM MF FEED PUMP ASSEMBLY P A Rotated 90 16, 17, 18, 19, 20, A Figure 23. MF Feed Pump Assembly P BLANK / 2

87 GROUP 03 MICRO-FILTRATION SYSTEM MF FEED PUMP ASSEMBLY P-3 REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 23 MF FEED PUMP ASSY P-3 1 PBOOO TWN3 CC PUMP UNIT, CENTRIFUGAL PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK XBOFF 0U5N FRAME PBOOO U5N ENCLOSURE ASSEMBLY PAOZZ NASM SCREW, CAP, HEX PAOZZ A029. WASHER, SEAL PAOZZ A029. WASHER, SEAL XBOZZ 0U5N ENCLOSURE, ELECTRICAL PAOOO MS3102E22-28P. CONNECTOR, RECEPTACLE PAOZZ GASKET PAOZZ MS DA. COVER, ELECTRICAL CONNECTOR PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PAOOO MS3452W14S-7S. CONNECTOR, RECEPTAC LE PAOZZ GASKET PAOZZ MS DA. COVER, ELECTRICAL CONNECTOR PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PAOZZ MS SCREW, MACHINE PAOOO MS3452W18-10S. CONNECTOR, RECEPTACLE PAOZZ GASKET PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE... 4 (7) QTY END OF FIGURE

88 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM MF FEED PUMP ASSEMBLY P A A Reverse View Figure 24. P-3 MF Feed Pump and Motor

89 GROUP 03 MICRO-FILTRATION SYSTEM MF FEED PUMP ASSEMBLY P-3 REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 24 P-3 MF FEED PUMP AND MOTOR 1 PAOZZ TWN3 GX GASKET (PART OF KIT P/N ) PAOZZ SEAL, MECHANICAL... 1 (PART OF KIT P/N ) 3 PBOZZ TWN3 BX SLEEVE, SHAFT, PUMP PAOZZ TWN3 GX O-RING (PART OF KIT P/N ) PAOZZ TWN3 GX KEY, WOODRUFF PAOZZ TWN3 BI ½-IN IMPELLER, PUMP PAOZZ TWN3 GX GASKET (PART OF KIT P/N ) PAOZZ TWN3 BI SCREW, CAP, HEX PAOZZ TWN3 BW RING, WEARING PAOZZ C51 CHAIN, WELDLESS PAOZZ W-FDAPOLY PLUG, PROTECTIVE PBOOO X20B-SS REDUCER, PIPE PAOZZ NW7 GASKET PBOOO X25B-SS REDUCER, PIPE PAOZZ U5N7 755MFZ1 VALVE, PLUG PAOZZ K412 BUSHING, PIPE PAOZZ K44 ELBOW, PIPE PAOZZ MS SCREW, CAP, HEX PBOOO TWN3 GM5G14303 MOTOR ASSEMBLY PBOZZ U5N CABLE ASSEMBLY, SPECIAL PAOZZ BOX CONNECTOR, ELECTRICAL PAOZZ PLT1.5I-M STRAP, TIEDOWN, ELECTRICAL XDOZZ GASKET PAOZZ AA P- LOCKNUT, ELECTRICAL S 25 PAOZZ PN14-10R-C TERMINAL, LUG PAOZZ JN SPLICE, CONDUCTOR... 3 PBOZZ SEAL ASSEMBLY KIT, SHAFT 1... GASKET (1) 1... SEAL, MECHANICAL (1) 2...O-RING (1) 4... GASKET (1) 7 (7) QTY END OF FIGURE / 6 BLANK

90

91

92 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F Figure 25. MF Piping Assembly F BLANK / 2

93 GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F10 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 25 MF PIPING ASSEMBLY F10 1 XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU ELBOW, PIPE PAOZZ EXU VALVE, BALL (V-109) PAOZZ B2HF-SS ADAPTER, STRAIGHT MOOZZ K67 TUBING, NONMETALLIC,MAKE FROM BULK 1 MATERIAL, NSN , CUT TO LENGTH 91 INCHES 6 XBOZZ 0EXU ADAPTER PAOOO EXU CAP, PROTECTIVE PAOZZ NW7. GASKET... 1 (7) QTY END OF FIGURE / 4 BLANK

94

95

96 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM STRAINER S-2 ASSEMBLY Figure 26. Strainer S-2 Assembly BLANK / 2

97 GROUP 03 MICRO-FILTRATION SYSTEM STRAINER S-2 ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 26 STRAINER S-2 ASSEMBLY 1 PAOZZ E CLAMP, HOSE PBOZZ EXU STRAINER ELEMENT, SEDIMENT PAOZZ EXU O-RING XBOZZ 0EXU BODY, STRAINER PAOZZ Z NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT XBOZZ 0U5N BRACKET, ANGLE PAOZZ MS SCREW, CAP, HEX... 8 (7) QTY END OF FIGURE / 4 BLANK

98

99

100 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F Figure 27. MF Piping Assembly F BLANK / 2

101 GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F11 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 27 MF PIPING ASSEMBLY F11 1 PAOZZ MHHM-4-S CLAMP, LOOP PAOZZ EXU O-RING XBOZZ 0EXU PIPE SPOOL XBOZZ 0EXU ELBOW, PIPE PAOZZ EXU NIPPLE, PIPE PBOZZ EXU VALVE, BALL (V-110) XBOZZ 0EXU NIPPLE, PIPE PAOZZ EXU NUT, SELF-LOCKING PAOZZ EXU WASHER, FLAT XBOZZ 0EXU PIPE SPOOL PBOOO EXU ASSY, VALVE V PAOZZ EXU SCREW, CAP, HEX PBOZZ KMP GAGE, PRESSURE, DIAL XBOZZ 0EXU ELBOW, PIPE PBOZZ F1A11B2T20S TRANSMITTER, RATE OF FLOW XBOZZ 0EXU PIPE SPOOL XBOZZ 0EXU PIPE SPOOL PBOOO EXU ASSY, VALVE V XBOZZ 0EXU PIPE SPOOL PAOZZ EXU SCREW, CAP, HEX XCOOO 0U5N ASSY, PIPE RESTRAINT PBOZZ CE49 PTX TRANSMITTER, PRESSURE PT (0-100 PSIA) 23 PAOZZ EXU GASKET XBOZZ 0EXU EXPANSION JOINT PBOOO EXU ASSY, VALVE V PAOZZ CLAMP, HOSE XBOOO 0U5N HANGER, PIPE PAOZZ KXJ3 FS-7409 ST6. BOLT, MACHINE PAOZZ KXJ3 FS-1/2 NS ST. NUT, SELF-LOCKING PAOZZ EXU COUPLING, CLAMP, GROOVED PAOZZ STYLE 77/75/78-3.0IN GR E GASKET... 1 END OF FIGURE (7) QTY

102 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F Figure 28. Valve Assembly V

103 GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F11 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER 1 PBOOO MRP-009U-K- S081 2 PBOZZ GDV KFOZZ PR BH2 9 4 KFOZZ PR UN6 7 5 KFOZZ PR BA0 7 6 KFOZZ PR KY3 0 7 KFOZZ PR YN8 5 8 KFOZZ PR US6 3 9 KFOZZ PR KB KFOZZ PR ER KFOZZ PR PQ KFOZZ PR BD KFOZZ PR MQ KFOZZ PR BZ4 1 (6) (7) DESCRIPTION AND USABLE ON CODE (UOC) QTY GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 28 VALVE ASSEMBLY V-111 ACTUATOR, HYDRAULIC-PNEUMATIC... 1 VALVE, BUTTERFLY... 1 O-RING, END CAP... (PART OF KITP/N MRP-009-RPKT-N) RING, SUPPORT, PISTON... (PART OF KIT P/N MRP-009-RPKT-N) O-RING, PISTON... (PART OF KIT P/N MRP-009-RPKT-N) PAD, BACKING, PISTON... (PART OF KIT P/N MRP-009-RPKT-N) O-RING, AIR CONNECTION PLATE... (PART OF KIT P/N MRP-009-RPKT-N) O-RING, TOP, SHAFT... (PART OF KIT P/N MRP-009-RPKT-N) BEARING, TOP... (PART OF KIT P/N MRP-009-RPKT-N) SPACER, TOP... (PART OF KIT P/N MRP-009-RPKT-N) SPACER. BOTTOM... (PART OF KIT P/N MRP-009-RPKT-N) BEARING, BOTTOM... (PART OF KIT P/N MRP-009-RPKT-N) O-RING, BOTTOM, SHAFT... (PART OF KIT P/N MRP-009-RPKT-N) O-RING, BASE PLATE... (PART OF KIT P/N MRP-009-RPKT-N) 15 PAOZZ EXU SCREW, CAP, HEX PAOZZ EXU WASHER, LOCK PAOZZ EXU A241 SCREW, CAP, HEX PAOZZ EXU A170 WASHER, FLAT PAOZZ MRP-009-RPKT- N REPAIR KIT, ACTUATOR BEARING, TOP (1) BEARING, BOTTOM (1) O-RING, AIR CONNECTION PLATE (2) O-RING, BASE PLATE (1) O-RING, BOTTOM, SHAFT (1) O-RING, END CAP (2) O-RING, PISTON (2) O-RING, TOP, SHAFT (1) PAD, BACKING, PISTON (2) RING, SUPPORT, PISTON (2) SPACER. BOTTOM (1) SPACER, TOP (1) - 10 END OF FIGURE

104 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F Figure 29. Valve Assembly V

105 GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F11 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER 1 PBOOO MRP-004U-K- S081 2 PBOZZ GDV KFOZZ PR NM9 2 (6) (7) DESCRIPTION AND USABLE ON CODE (UOC) QTY GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 29 VALVE ASSEMBLY V-112 ACTUATOR, HYDRAULIC-PNEUMATIC... 1 VALVE, BUTTERFLY... 1 O-RING, END CAP... (PART OF KIT P/N MRP-004-RPKT-N) 4 KFOZZ PR FT95 RING, SUPPORT, PISTON... (PART OF KIT P/N MRP-004-RPKT-N) 5 KFOZZ PR FQ3 O-RING, PISTON... 5 (PART OF KIT P/N MRP-004-RPKT-N) 6 KFOZZ PR NF0 0 7 KFOZZ PR MN 85 8 KFOZZ PR CM5 0 9 KFOZZ PR NU KFOZZ PR RG KFOZZ PR RG KFOZZ PR GQ KFOZZ PR CM KFOZZ PR YW9 3 PAD, BACKING, PISTON... (PART OF KIT P/N MRP-004-RPKT-N) O-RING, AIR CONNECTION PLATE... (PART OF KIT P/N MRP-004-RPKT-N) O-RING, TOP, SHAFT... (PART OF KIT P/N MRP-004-RPKT-N) BEARING, TOP... (PART OF KIT P/N MRP-004-RPKT-N) SPACER, TOP... (PART OF KIT P/N MRP-004-RPKT-N) SPACER. BOTTOM... (PART OF KIT P/N MRP-004-RPKT-N) BEARING, BOTTOM... (PART OF KIT P/N MRP-004-RPKT-N) O-RING, BOTTOM, SHAFT... (PART OF KIT P/N MRP-004-RPKT-N) O-RING, BASE PLATE... (PART OF KIT P/N MRP-004-RPKT-N) 15 PAOZZ EXU SCREW, CAP, HEX PAOZZ EXU WASHER, LOCK PAOZZ EXU A241 SCREW, CAP, HEX PAOZZ EXU A170 WASHER, FLAT PAOZZ MRP-004-RPKT- N REPAIR KIT, ACTUATOR BEARING, TOP (1) BEARING, BOTTOM (1) O-RING, AIR CONNECTION PLATE (2) O-RING, BASE PLATE (1) O-RING, BOTTOM, SHAFT (1) O-RING, END CAP (2) O-RING, PISTON (2) O-RING, TOP, SHAFT (1) PAD, BACKING, PISTON (2) RING, SUPPORT, PISTON (2) SPACER. BOTTOM (1) SPACER, TOP (1) - 10 END OF FIGURE

106 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F Figure 30. MF Pipe Restraint Assembly

107 GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F11 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER 1 PAOZZ MS S316 (6) (7) DESCRIPTION AND USABLE ON CODE (UOC) QTY GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 30 MF PIPE RESTRAINT ASSEMBLY SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS21044C08 NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT XBOZZ 0U5N CLAMP PAOZZ U5N CLAMP, HOSE PAOZZ MS24693-C52 SCREW, MACHINE PAOZZ MS24693-C56 SCREW, MACHINE PAOZZ U5N BRACKET, MOUNTING XBOZZ 0U5N BLOCK, MOUNTING PAOZZ KXJ3 FS-1/2 NS ST NUT, SELF-LOCKING... 2 END OF FIGURE

108 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F Figure 31. Valve Assembly V

109 GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY F11 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 31 VALVE ASSEMBLY V PBOOO MRP-009U-K-S080 ACTUATOR, HYDRAULIC-PNEUMATIC PAOZZ CAM STOP, TRAVEL ADJUST PBOZZ GDV VALVE, BUTTERFLY KFOZZ PR BH29 O-RING, END CAP... 2 (PART OF KIT P/N MRP-009-RPKT-N) 5 KFOZZ PR UN67 RING, SUPPORT, PISTON... 2 (PART OF KIT P/N MRP-009-RPKT-N) 6 KFOZZ PR BA07 O-RING, PISTON... 2 (PART OF KIT P/N MRP-009-RPKT-N) 7 KFOZZ PR KY30 PAD, BACKING, PISTON... 2 (PART OF KIT P/N MRP-009-RPKT-N) 8 KFOZZ PR YN85 O-RING, AIR CONNECTION PLATE... 2 (PART OF KIT P/N MRP-009-RPKT-N) 9 KFOZZ PR US63 O-RING, TOP, SHAFT... 1 (PART OF KIT P/N MRP-009-RPKT-N) 10 KFOZZ PR KB28 BEARING, TOP... 1 (PART OF KIT P/N MRP-009-RPKT-N) 11 KFOZZ PR ER22 SPACER, TOP... 1 (PART OF KIT P/N MRP-009-RPKT-N) 12 KFOZZ PR PQ97 SPACER. BOTTOM... 1 (PART OF KIT P/N MRP-009-RPKT-N) 13 KFOZZ PR BD58 BEARING, BOTTOM... 1 (PART OF KIT P/N MRP-009-RPKT-N) 14 KFOZZ PR MQ45 O-RING, BOTTOM, SHAFT... 1 (PART OF KIT P/N MRP-009-RPKT-N) 15 KFOZZ PR BZ41 O-RING, BASE PLATE... 1 (PART OF KIT P/N MRP-009-RPKT-N) 16 PAOZZ EXU NUT, PLAIN, HEX PAOZZ EXU WASHER, LOCK PAOZZ EXU A241 SCREW, CAP, HEX PAOZZ EXU A170 WASHER, FLAT... 8 PAOZZ MRP-009-RPKT-N REPAIR KIT, ACTUATOR 1... BEARING, TOP (1) BEARING, BOTTOM (1) O-RING, AIR CONNECTION PLATE (2) O-RING, BASE PLATE (1) O-RING, BOTTOM, SHAFT (1) O-RING, END CAP (2) O-RING, PISTON (2) O-RING, TOP, SHAFT (1) PAD, BACKING, PISTON (2) RING, SUPPORT, PISTON (2) SPACER. BOTTOM (1) SPACER, TOP (1) - 11 END OF FIGURE (7) QTY / 12 BLANK

110

111

112 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM FILTER MODULE ASSEMBLY Figure 32. MF Module / Adapter Assembly (Front View) BLANK / 2

113 GROUP 03 MICRO-FILTRATION SYSTEM FILTER MODULE ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 32 MF MODULE /ADAPTER ASSEMBLY 1 PAOZZ B2HF-SS ADAPTER, STRAIGHT PBOZZ EXU VALVE, BALL (V-114, V-203, V-403) XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU TEE, PIPE XBOZZ 0EXU BUSHING, PIPE XBOZZ 0EXU NIPPLE, PIPE PBOZZ EXU VALVE, CHECK (V-911) PAOZZ SS-PB6-PM6 ADAPTER, STRAIGHT XBOZZ 0EXU ELBOW, PIPE XBOOO FILTER MODULE ASSEMBLY XBOZZ 0EXU NIPPLE, PIPE PBOZZ EXU VALVE, CHECK (V-912) XBOZZ SS-PB12-PM12 ADAPTER, STRAIGHT XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU ELBOW, PIPE XBOZZ 0EXU NIPPLE, PIPE PAOZZ K68 ADAPTER, STRAIGHT MOOZZ K67 TUBING, NONMETALLIC, MAKE FROM BULK 1 MATERIAL, NSN , CUT TO LENGTH 42 INCHES 19 MOOZZ K67 TUBING, NONMETALLIC, MAKE FROM BULK 1 MATERIAL, NSN , CUT TO LENGTH 45 INCHES 20 XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU ELBOW, PIPE... 1 END OF FIGURE (7) QTY

114 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM FILTER MODULE ASSEMBLY Figure 33. MF Filter Module Assembly (Rear View)

115 GROUP 03 MICRO-FILTRATION SYSTEM FILTER MODULE ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 33 MF FILTER MODULE ASSEMBLY 1 PAOZZ NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT XBOOO 0U5N BRACKET, ANGLE PAOZZ WASHER, FLAT PAOZZ DIN127B-M12-A4C WASHER, LOCK PAOZZ NUT, PLAIN, HEX PAOZZ MS SCREW, CAP, HEX (1¾ ) PAOZZ MS SCREW, CAP, HEX (4¼ ) PAOZZ U5N SPACER, SLEEVE XBOZZ 0EXU PIPING ADAPTER PAOZZ O-RING PAOZZ EXU O-RING XBOZZ ROD, TIE PBOOO FILTER, WATER PURIFICATION PAOZZ U5N SPACER, SLEEVE XBOZZ 0EXU PIPING ADAPTER XBOOO 0U5N BRACKET, ANGLE PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, CAP, HEX (1¼ ) XBOOO 0U5N BRACKET, ANGLE PAOZZ U5N SPACER, SLEEVE XBOZZ 0EXU PIPING ADAPTER XBOZZ 0EXU PIPING ADAPTER XBOOO 0U5N BRACKET, ANGLE... 1 (7) QTY END OF FIGURE

116 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM FILTER MODULE ASSEMBLY Figure 34. Filtration Module

117 GROUP 03 MICRO-FILTRATION SYSTEM FILTER MODULE ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 34 FILTRATION MODULE 1 PAOZZ RING, RETAINING PBOZZ FZH HEAD, FLUID FILTER PAOZZ EXU O-RING PAOZZ EXU O-RING PBOZZ EXU PLUNGER, ACTUATOR PAOZZ EXU O-RING PAOZZ EXU O-RING PBOZZ EXU FILTER BODY, FLUID PAOZZ EXU O-RING PBOZZ EXU CLIP, RETAINING PBOZZ EXU FILTER BODY, WATER PAOZZ EXU O-RING PBOZZ U5N FILTER ELEMENT, WATER... 1 (7) QTY END OF FIGURE / 8 BLANK

118

119

120 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY M Figure 35. MF Piping Assembly M BLANK / 2

121 GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY M01 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 35 MF PIPING ASSEMBLY M01 1 PAOZZ EXU SCREW, CAP, HEX PAOZZ EXU WASHER, FLAT PAOZZ EXU NUT, SELF-LOCKING XBOZZ 0EXU PIPE SPOOL PBOOO EXU ASSY, VALVE V (SEE FIGURE 29 FOR BREAKDOWN) 6 PBOZZ KMP GAGE, PRESSURE PBOZZ CE49 PTX (0- TRANSMITTER, PRESSURE PT PSIA) 8 PBOOO EXU ASSY, VALVE V XBOZZ 0EXU PLUG, PIPE XBOZZ 0EXU PIPE SPOOL PBOOO EXU COUPLING, PIPE PAOZZ EXU GASKET PAOZZ CLAMP, HOSE XBOZZ 0U5N HANGER, PIPE PAOZZ KXJ3 FS-7409 ST6. BOLT, MACHINE PAOZZ KXJ3 FS-1/2 NS ST. NUT, SELF-LOCKING MOOZZ K67 TUBING, NONMETALLIC... 1 (CUT TO LENGTH FROM BULK 80 INCHES) 18 PAOZZ K68 ADAPTER, STRAIGHT PBOZZ EXU VALVE, BALL XBOZZ 0EXU NIPPLE, PIPE PAOZZ EXU GASKET XBOZZ 0EXU EXPANSION JOINT PAOZZ EXU SCREW, CAP, HEX... 8 END OF FIGURE (7) QTY

122 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY M Figure 36. Valve Assembly V

123 GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY M01 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER 1 PBOZZ SE08 PP4NU-36K01- PV9DF-3Z 2 PBOOO MRP-004U-K- S081 3 PBOZZ GDV (6) (7) DESCRIPTION AND USABLE ON CODE (UOC) QTY GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 36 VALVE ASSEMBLY V-202 POSITIONER, VALVE... 1 ACTUATOR, HYDRAULIC-PNEUMATIC... 1 VALVE, BUTTERFLY KFOZZ PR NM92 O-RING, BASE PLATE... 1 (PART OF KIT P/N MRP-004-RPKT-N) 5 KFOZZ PR FT95 O-RING, BOTTOM, SHAFT... 1 (PART OF KIT P/N MRP-004-RPKT-N) 6 KFOZZ PR FQ35 BEARING, BOTTOM... 1 (PART OF KIT P/N MRP-004-RPKT-N) 7 KFOZZ PR NF00 SPACER. BOTTOM... 1 (PART OF KIT P/N MRP-004-RPKT-N) 8 KFOZZ PR MN85 SPACER, TOP... 1 (PART OF KIT P/N MRP-004-RPKT-N) 9 KFOZZ PR CM50 BEARING, TOP... 1 (PART OF KIT P/N MRP-004-RPKT-N) 10 KFOZZ PR NU60 O-RING, TOP, SHAFT... 1 (PART OF KIT P/N MRP-004-RPKT-N) 11 KFOZZ PR RG46 PAD, BACKING, PISTON... 2 (PART OF KIT P/N MRP-004-RPKT-N) 12 KFOZZ PR RG46 O-RING, AIR CONNECTION PLATE... 2 (PART OF KIT P/N MRP-004-RPKT-N) 13 KFOZZ PR GQ11 O-RING, PISTON... 2 (PART OF KIT P/N MRP-004-RPKT-N) 14 KFOZZ PR CM50 RING, SUPPORT, PISTON... 2 (PART OF KIT P/N MRP-004-RPKT-N) 15 KFOZZ PR YW93 O-RING, END CAP... 2 (PART OF KIT P/N MRP-004-RPKT-N) 16 PAOZZ EXU SCREW, CAP, HEX PAOZZ EXU WASHER, LOCK PAOZZ EXU A241 SCREW, CAP, HEX PAOZZ EXU A170 WASHER, FLAT... 8 PAOZZ MRP-004-RPKT-N REPAIR KIT, ACTUATOR BEARING, TOP (1) BEARING, BOTTOM (1) O-RING, AIR CONNECTION PLATE (2) O-RING, BASE PLATE (1) O-RING, BOTTOM, SHAFT (1) O-RING, END CAP (2) O-RING, PISTON (2) O-RING, TOP, SHAFT (1) PAD, BACKING, PISTON (2) RING, SUPPORT, PISTON (2) SPACER. BOTTOM (1) SPACER, TOP (1) - 8 END OF FIGURE / 6 BLANK

124

125

126 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY R Figure 37. MF Piping Assembly R BLANK / 2

127 GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY R01 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 37 MF PIPING ASSEMBLY R01 1 PAOZZ MHHM-4-S CLAMP, LOOP PAOZZ EXU O-RING XBOZZ 0EXU PIPE SPOOL PAOZZ EXU SCREW, CAP, HEX PAOZZ EXU WASHER, FLAT PBOOO EXU ASSY, VALVE V (SEE FIGURE 28 FOR BREAKDOWN) 7 PAOZZ EXU NUT, SELF-LOCKING, HEX PAOZZ CLAMP, HOSE XBOOO 0U5N HANGER, PIPE PAOZZ KXJ3 FS-7409 ST6. BOLT MACHINE PAOZZ KXJ3 FS-1/2 NS ST. NUT, SELF-LOCKING XBOZZ 0EXU PIPE SPOOL PBOOO EXU COUPLING, PIPE PBOZZ EXU GASKET XBOZZ 0EXU ELBOW, PIPE PAOZZ EXU UNION, PIPE PBOZZ EXU DISK, RUPTURABLE XBOZZ 0EXU NIPPLE, PIPE PAOOO EXU CAP, PROTECTIVE PAOZZ NW8. GASKET XBOZZ 0EXU ADAPTER XBOZZ 0EXU PIPE SPOOL PAOZZ CLAMP, HOSE XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU ELBOW, PIPE XBOZZ 0EXU NIPPLE, PIPE PBOZZ EXU VALVE, BALL (V-412) XBOZZ 0EXU NIPPLE, PIPE PAOZZ EXU CLAMP, HOSE MOOZZ 0EXU HOSE, NONMETALLIC... 1 (MAKE FROM BULK MATERIAL NSN CUT TO LENGTH 4 IN.). 31 XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU ELBOW, PIPE XBOZZ 0EXU NIPPLE, PIPE PBOOO EXU ASSY, VALVE V (SEE FIGURE 29 FOR BREAKDOWN) 35 XBOZZ 0EXU PIPE SPOOL PAOZZ EXU CLAMP, LOOP PAOZZ EXU O-RING XBOZZ 0EXU PIPE SPOOL XBOZZ 0EXU PIPE SPOOL PAOZZ EXU SCREW, CAP, HEX PAOZZ EXU GASKET XBOZZ 0EXU EXPANSION JOINT... 1 END OF FIGURE (7) QTY / 4 BLANK

128

129

130 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY C Figure 38. MF Piping Assembly C BLANK / 2

131 GROUP 03 MICRO-FILTRATION SYSTEM PIPING ASSEMBLY C01 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 03 MICRO-FILTRATION SYSTEM FIGURE 38 MF PIPING ASSEMBLY C01 1 PAOOO EXU COUPLING, CLAMP, GROOVED PAOZZ STYLE 77/75/78-. GASKET IN GR E 3 XBOOO 0EXU PIPE SPOOL PBOZZ EXU VALVE, BALL (V-704) PBOOO EXU COUPLING, PIPE PBOZZ EXU GASKET PAOZZ CLAMP, HOSE XBOOO 0U5N HANGER, PIPE PAOZZ KXJ3 FS-7409 ST6. BOLT, MACHINE PAOZZ KXJ3 FS-1/2 NS ST. NUT, SELF-LOCKING PBOOO EXU COUPLING, PIPE PBOZZ EXU GASKET XBOOO 0U5N HANGER, PIPE PAOZZ KXJ3 FS-7409 ST6. BOLT, MACHINE PAOZZ KXJ3 FS-1/2 NS ST. NUT, SELF-LOCKING PAOZZ CLAMP, HOSE PBOZZ EXU VALVE, BALL (V-703) PAOZZ CLAMP, HOSE MOOZZ EXU HOSE, NONMETALLIC... (MAKE FROM BULK MATERIAL NSN CUT TO LENGTH 4 IN.). 1 END OF FIGURE (7) QTY / 4 BLANK

132

133 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM REVERSE OSMOSIS SYSTEM Figure 39. Reverse Osmosis System (Sheet 1 of 2)

134 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM REVERSE OSMOSIS SYSTEM Figure 39. Reverse Osmosis System (Sheet 2 of 2)

135 GROUP 04 REVERSE OSMOSIS SYSTEM REVERSE OSMOSIS SYSTEM REPAIR PARTS LIST (1) ITE M NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 39 REVERSE OSMOSIS SYSTEM 1 XBOOO 0EXU3 732-D RO FEED TANK ASSEMBLY T PBFFF YQYO 80E120-2 RO VESSELS (ROV-1 THROUGH ROV-5) XBOOO 0EXU3 799-D PIPING ASSEMBLY H XBOOO 0EXU3 799-D PIPING ASSEMBLY H XCOOO 0U5N HIGH PRESSURE PUMP ASSEMBLY... 1 INSTALL P-5/P-6 6 PBOOO TEM TURBOCHARGER ASSEMBLY XBOOO 0EXU3 799-D PIPING ASSEMBLY M PBOOO U5N RO FEED PUMP ASSEMBLY P XBOOO 0EXU3 799-D PIPING ASSEMBLY M XBOOO 0EXU3 799-D PIPING ASSEMBLY H XBOOO 0EXU3 799-D PIPING ASSEMBLY P01 MANIFOLD XBOOO 0EXU3 799-D PIPING ASSEMBLY P01 OUTLET XBOOO 0EXU3 799-D PIPING ASSEMBLY R XBOOO 0EXU3 799-D PIPING ASSEMBLY R END OF FIGURE (7) QTY /4 BLANK

136

137

138 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM RO FEED TANK ASSEMBLY T Figure 40. RO Feed Tank Assembly T BLANK / 2

139 GROUP 04 REVERSE OSMOSIS SYSTEM RO FEED TANK ASSEMBLY T-2 REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) (4) (5) (6) DESCRIPTION AND USABLE ON CODE (UOC) NSN CAGEC PART NUMBER QTY GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 40 RO FEED TANK ASSEMBLY T-2 1 MOOZZ K78 STRIP, FOAM RUBBER... MAKE FROM BULK MATERIAL, NSN , CUT TO LENGTH AS NEEDED 2 PAOZZ EXU SCREW, MACHINE XBOZZ 0EXU COVER, TANK PAOZZ EXU WASHER, LOCK PAOZZ EXU NUT, PLAIN, HEX PAOZZ A26 HINGE, BUTT PAOZZ EXU3 32-A GASKET XBOOO 0EXU3 19-B-9778 COVER PLATE PAOZZ EXU WASHER, FLAT PAOZZ EXU SCREW, CAP, HEX XBOZZ 0EXU TANK XBOZZ 0EXU STRAINER S XBOOO 0EXU ASSY, FLAPPER VENT PAOZZ EXU SCREW, CAP, HEX PAOZZ EXU WASHER, FLAT PAOZZ EXU3 19-B COVER PAOZZ EXU3 19-B COVER, FLAPPER PAOZZ EXU3 32-B GASKET PAOZZ EXU3 32-B GASKET PAOZZ EXU ROD, WELDING PAOZZ EXU3 255-B COVER, ACCESS PAOZZ EXU PAD, DEMISTING PAOZZ EXU3 32-A GASKET XBOZZ 0EXU SUPPORT PLATE XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU TEE, PIPE PAOZZ EXU ADAPTER, STRAIGHT PAOZZ CLAMP, HOSE MOOZZ K67 TUBING, NONMETALLIC... (MAKE FROM BULK MATERIAL. CUT TO 3 LENGTH AS NEEDED) 30 PBOZZ HEATING ELEMENT, ELECTRICAL XBOZZ 0U5N STRAP, RO TANK PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, CAP, HEX PAOZZ U5N INSULATOR, PLATE PAOOO TC-215-UBSS CLAMP, MACHINE, HOLD PAOZZ TC BUMPER, NONMETALLIC PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT XBOZZ 0U5N BRACKET, CLAMP PAOZZ MS21044C08 NUT, SELF-LOCKING PBOZZ CE49 PTX TRANSMITTER, PRESSURE (LT-201)... 1 (0-1.5 PSIG) 43 XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU ELBOW PIPE... 1 (7)

140 GROUP 04 REVERSE OSMOSIS SYSTEM RO FEED TANK ASSEMBLY T-2 REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 40 RO FEED TANK ASSEMBLY T-2 45 PAOZZ B2HF-SS ADAPTER, STRAIGHT PBOZZ EXU VALVE, BALL (V-210) XBOZZ 0EXU NIPPLE, PIPE PAOZZ ST2.5 MONEL THERMOWELL PBOZZ AA0251D47 THERMOMETER, SELF-INDICATING (TI-202) PAOZZ BOX CONNECTOR, ELECTRICAL PAOZZ PACKING WITH RETAINER PAOZZ AA P- LOCKNUT, ELECTRICAL S 53 PAOZZ MS TERMINAL, LUG... 2 END OF FIGURE (7) QTY

141

142 0022 FIELD REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) Figure 41. RO Piping Assembly M BLANK / 2

143 0022 FIELD REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 41 RO PIPING ASSEMBLY M02 1 PAOZZ CLAMP, HOSE MOOZZ 0EXU HOSE, NONMETALLIC... 1 (MAKE FROM BULK MATERIAL NSN CUT TO LENGTH 4 IN.). 3 XBOZZ 0EXU PIPE SPOOL PAOZZ NUT, SELF-LOCKING, HEX PAOZZ MS WASHER, FLAT PAOZZ EXU GASKET PAOZZ MS SCREW, CAP, HEX... 4 END OF FIGURE (7) QTY / 4 BLANK

144

145

146 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM RO FEED PUMP ASSEMBLY P Figure 42. RO Feed Pump Assembly P BLANK / 2

147 GROUP 04 REVERSE OSMOSIS SYSTEM RO FEED PUMP ASSEMBLY P-4 PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 42 RO FEED PUMP ASSEMBLY P-4 1 XBOOO 0TWN3 CC PUMP UNIT, CENTRIFUGAL PAOZZ M45913/1-6CS3 NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT PAOZZ P WASHER, FLAT PAOZZ P MOUNT, RESILIENT PAOZZ MS SCREW, CAP, HEX XBOZZ 0U5N BASE, PUMP PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, LOCK... 4 (7) QTY END OF FIGURE

148 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM RO FEED PUMP ASSEMBLY P Figure 43. P-4 RO Feed Pump and Motor

149 GROUP 04 REVERSE OSMOSIS SYSTEM RO FEED PUMP ASSEMBLY P-4 PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 43 P-4 RO FEED PUMP AND MOTOR 1 PAOZZ TWN3 GX GASKET (PART OF KIT P/N GS ) PAOZZ SEAL ASSEMBLY, SHAFT... 1 (PART OF KIT P/N GS ) 3 PBOZZ TWN3 BX SLEEVE, SHAFT, PUMP PAOZZ TWN3 GX O-RING (PART OF KIT P/N GS ) PAOZZ TWN3 GX KEY, WOODRUFF PAOZZ IMPELLER, PUMP PAOZZ TWN3 GX GASKET (PART OF KIT P/N GS ) PAOZZ TWN3 BI SCREW, CAP, HEX PAOZZ TWN3 BW RING, WEARING XBOZZ 0EXU ELBOW, PIPE XBOZZ 0EXU NIPPLE, PIPE PBOZZ EXU VALVE, BALL XBOZZ 0EXU ADAPTER, STRAIGHT MOOZZ TUBING, NONMETALLIC,MAKE FROM BULK 1 MATERIAL, NSN , CUT TO LENGTH 158 INCHES 15 PBOOO TWN3 GM5G12803 MOTOR, AC PAOZZ BOX CONNECTOR, ELECTRICAL PAOZZ JN SPLICE, CONDUCTOR PAOZZ PN14-10R-C. TERMINAL, LUG PAOZZ PLT1.SI-M. STRAP, TIEDOWN, ELECTRICAL PAOZZ GASKET PAOZZ MS SCREW, CAP, HEX PAOZZ AA P- 02-S LOCKNUT, ELECTRICAL... 1 PBOOO TWN3 GS SEAL ASSEMBLY KIT, SHAFT GASKET (1) SEAL ASSEMBLY, SHAFT (1) O-RING (1) 4... GASKET (1) - 7 (7) QTY END OF FIGURE / 6 BLANK

150

151

152 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY M Figure 44. RO Piping Assembly M BLANK / 2

153 GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY M03 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 44 RO PIPING ASSEMBLY M03 1 PAOZZ EXU SCREW, CAP, HEX PAOZZ EXU WASHER, FLAT XBOZZ 0EXU PIPE SPOOL PBOOO U5N TRANSMITTER, TEMPERATURE (TT-201) PBOZZ CRL3 T5ALHPT (W8). TRANSMITTER, TEMPERATURE PBOZZ CRL3 RTD43W3-SS25. RESISTOR, THERMAL PBOZZ CRL H-. THERMOWELL... 1 U2.5MONEL 8 PBOZZ EXU GASKET PBOZZ EXU VALVE, BUTTERFLY (V-212) XBOZZ 0EXU PIPE SPOOL PAOZZ EXU NUT, SELF-LOCKING, HEX PAOZZ EXU O-RING PAOZZ MHHM-4-S CLAMP, LOOP XBOZZ 0EXU STRAINER XBOZZ 0EXU PIPING LINE XBOZZ 0EXU NIPPLE, PIPE PBOZZ EXU VALVE, BALL (V-213, V-214) PAOZZ B2HF-SS ADAPTER, STRAIGHT MOOZZ K67 TUBING, NONMETALLIC,MAKE FROM BULK 2 MATERIAL,NSN , CUT TO LENGTH 75 INCHES 20 PBOOO EXU COUPLING, CLAMP, GROOVED PAOZZ STYLE 77/75/78-. GASKET IN GR E 22 PAOZZ CLAMP, HOSE XBOOO 0U5N HANGER, PIPE PAOZZ KXJ3 FS-7409 ST6. BOLT, MACHINE PAOZZ KXJ3 FS-1/2 NS ST. NUT, SELF-LOCKING PBOZZ KMP GAGE, PRESSURE PBOZZ CE49 PTX TRANSMITTER, PRESSURE... 1 (0-100 PSIA) 28 XBOZZ 0EXU PIPE SPOOL PBOOO EXU COUPLING ASSY, PIPE PAOZZ EXU GASKET XBOZZ 0EXU PIPE SPOOL PBOOO EXU COUPLING, GROOVED PAOZZ E-1.0IN. GASKET PBOZZ EXU HOSE ASSY, NONMETALLIC PAOZZ K68 ADAPTER, STRAIGHT PAOZZ EXU SCREW, CAP, HEX PBOZZ EXU GASKET PAOZZ EXU WASHER, FLAT PAOZZ EXU NUT, SELF-LOCKING, HEX... 4 END OF FIGURE (7) QTY / 4 BLANK

154

155 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM HIGH PRESSURE PUMP ASSEMBLIES P-5 AND P Figure 45. High-Pressure Pumps P-5 and P-6 Installation (Sheet 1 of 2)

156 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM HIGH PRESSURE PUMP ASSEMBLIES P-5 AND P Figure 45. High-Pressure Pumps P-5 and P-6 Installation (Sheet 2 of 2)

157 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM HIGH PRESSURE PUMP ASSEMBLIES P-5 AND P (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 45 HIGH PRESSURE PUMPS P-5 AND P-6 INSTALLATION 1 PBOOO EXU PUMP/MOTOR ASSEMBLY, (C0MPOSITE) 2 2 PAOZZ EXU NUT, SELF-LOCKING, HEX PAOZZ EXU WASHER, FLAT PAOZZ MOUNT, RESILIENT PAOZZ P MOUNT, RESILIENT PAOZZ P WASHER, FLAT PAOZZ MS SCREW, CAP, HEX PAOZZ D5S SCREW, TAPPING PAOZZ A212. WASHER, SEAL PAOZZ D5S G. GASKET PAOZZ JN C. SPLICE, CONDUCTOR PAOZZ INSULATOR, BUSHING PAOZZ SPLICE, CONDUCTOR PAOZZ PLT1.5 I-M. STRAP, TIEDOWN, ELECTRICAL PAOZZ PN10-14R. TERMINAL, LUG PAOZZ AA P-. LOCK NUT, ELECTRICAL S 17 PAOZZ PACKING WITH RETAINER PAOZZ BOX CONNECTOR, ELECTRICAL PBOOO D5S MOTOR, AC PAOZZ D5S COVER, ACCESS PAOZZ RW SCREW, CAP, HEX PAOZZ KEY, MACHINE PBOZZ P COUPLING HALF, SHAFT PBOZZ INSERT, COUPLING, FLEXIBLE PBOZZ P COUPLING HALF, SHAFT PAOZZ K467. ADAPTER, STRAIGHT PBOOO P COMPOSITE PUMP, RADIAL PISTONS PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ K458 ADAPTER, STRAIGHT PAOZZ K461 ADAPTER, STRAIGHT MOOZZ TUBING, NON-METALLIC,MAKE FROM BULK 6 MATERIAL,NSN , CUT TO LENGTH AS NEEDED 33 PAOZZ K608 TEE, PIPE TO TUBE XBOOO 0U5N BRACKET, ANGLE PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, FLAT PAOZZ M45913/1-4CS3. NUT, SELF-LOCKING, HEX PBOZZ EXU VALVE, BALL (V-215) PAOZZ X CLAMP, LOOP PAOZZ MS SCREW, CAP, HEX MOOZZ K76 TUBING, NON-METALLIC... 1 (MAKE FROM BULK MATERIAL. NSN ,CUT TO LENGTH 3 FT 42 PAOZZ K912 STRAP, TIEDOWN, ELECTRICAL... 1 (7) QTY

158 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM HIGH PRESSURE PUMP ASSEMBLIES P-5 AND P (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 45 HIGH-PRESSURE PUMPS P-5 AND P-6 INSTALLATION 43 PBOFF 0U5N PUMP/MOTOR ASSEMBLY,(METAL) PAOZZ EXU NUT, SELF-LOCKING, HEX PAOZZ EXU WASHER, FLAT PAOZZ MOUNT, RESILIENT PAOZZ P MOUNT, RESILIENT PAOZZ P WASHER, SNUBBING PAOZZ MS SCREW, CAP, HEX PAOZZ D5S SCREW, TAPPING PAOZZ A212. WASHER, SEALING PAOZZ D5S G. GASKET PAOZZ JN C. SPLICE, CONDUCTOR PAOZZ INSULATOR, BUSHING PAOZZ SPLICE, CONDUCTOR PAOZZ PLT 1.5 I-M. STRAP, TIEDOWN, ELECTRICAL PAOZZ PN10-14R. TERMINAL, LUG PAOZZ AA P-. LOCK NUT, ELECTRICAL S 59 PAOZZ PACKING WITH RETAINER PAOZZ BOX CONNECTOR, ELECTRICAL PBOZZ D5S MOTOR, AC PAOZZ D5S COVER, ACCESS 1 63 PAOZZ RW SCREW, CAP, HEX PAOZZ KEY, MACHINE XBOZZ R5418 M COUPLING HALF, SHAFT XBOZZ R5418 N570N. INSERT, COUPLING, FLEXIBLE XBOZZ R5418 M COUPLING HALF, SHAFT XBOZZ R5418 M M. ADAPTER, MOTOR 1 69 PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, CAP, HEX PBOOO R B3101. METAL PUMP, AXIAL PISTONS MOOZZ TUBING, NON-METALLIC,MAKE FROM BULK 4 MATERIAL,NSN ,CUT TO O LENGTH AS NEEDED 75 PAOZZ K608 TEE, PIPE TO TUBE 1 76 XBOZZ 0U5N BRACKET, ANGLE PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, FLAT PAOZZ M45913/1-4CS3. NUT, SELF-LOCKING, HEX PAOZZ K461 ADAPTER, STRAIGHT,PIPE TO HOSE 2 81 PBOZZ EXU VALVE, BALL (V-215) PAOZZ CLAMP, HOSE... 7 END OF FIGURE (7) QTY

159 GROUP 04 REVERSE OSMOSIS SYSTEM HIGH PRESSURE PUMP ASSEMBLIES P-5 AND P-6 REPAIR PARTS LIST Figure 46. High-Pressure Pump (Sheet 1 of 2)

160 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM HIGH PRESSURE PUMP ASSEMBLIES P-5 AND P Figure 46. High-Pressure Pump (Sheet 2 of 2)

161 GROUP 04 REVERSE OSMOSIS SYSTEM HIGH PRESSURE PUMP ASSEMBLIES P-5 AND P-6 REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 46 HIGH-PRESSURE PUMP 1 PAOZZ SCREW, CAP, HEX PAOZZ WASHER, LOCK PAOZZ RETAINER, PACKING, OUTLET NIPPLE PAOZZ RETAINER, PACKING, INLET NIPPLE PAOZZ P NIPPLE, PIPE PAOZZ RING, RETAINING KFOZZ O-RING (PART OF KIT P/N P517371) PAOZZ P SCREW, CAP, HEX PAOZZ WASHER, LOCK PAOZZ WASHER, FLAT XBOZZ P MANIFOLD KFOZZ O-RING (PART OF KIT P/N P517371) KFOZZ O-RING (PART OF KIT P/N P517371) KFOZZ O-RING (PART OF KIT P/N P517371) KFOZZ P DISC, VALVE (PART OF SET P/N P517370) 16 XBOZZ P VALVE HOUSING KFOZZ O-RING (PART OF KIT P/N P517371) KFOZZ PISTON, VALVE... 9 (PART OF SET P/N P517369) 19 KFOZZ O-RING (PART OF KIT P/N P517371) KFOZZ O-RING (PART OF KIT P/N P517371) PAOZZ P CYLINDER SLEEVE XBOZZ P BODY PAOZZ BEARING, SLEEVE PBOZZ RING, PISTON XBOZZ P CAM XBOZZ P SPACER, CAM PAOZZ BEARING, SLEEVE PAOZZ P BEARING, WASHER, THRUST PBOZZ P PLATE, RETAINING, BEARING KFOZZ O-RING (PART OF KIT P/N P517371) PBOZZ P SEAL ASSEMBLY, SHAFT XBOZZ P ADAPTER, MOTOR PAOZZ P SCREW, CAP, HEX PAOZZ P COVER, ACCESS PAOZZ WASHER, LOCK... 2 (7) QTY

162 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM HIGH PRESSURE PUMP ASSEMBLIES P-5 AND P ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 46 HIGH-PRESSURE PUMP 36 KFOZZ R L9085 KEY (PART OF KIT P/N 180B4031) PBOZZ R B3315 RING, SEAL RETAINING KFOZZ R B0699 O-RING (PART OF KIT P/N 180B4031) KFOZZ R H0064 SHAFT SEAL ASSEMBLY (PART OF KIT P/N 180B4031) KFOZZ R X0062 SCREW, MACHINE (PART OF KIT P/N 180B4031) KFOZZ R X0759 SCREW, CAP, HEX (PART OF KIT P/N 180B4031) PFOZZ R B3312 CONNECTOR,FLUID,PUM 1 43 KFOZZ R H0083 O-RING (PART OF KIT 180B4031) PBOZZ R B3333 SPACER, RING 1 45 PBOZZ R B3335 PLATE,RETAIINING,BEARING 1 46 PBOZZ R Z0361 ADAPTER, STRAIGHT, TU 1 47 KFOZZ R B0587 O-RING (PART OF KIT 180B4031) PBOZZ R Z0362 ADAPTER, STRAIGHT, TU XAOZZ R B5705 CASING, PUMP KFOZZ R B5704 RETAINING PLATE (PART OF KIT P/N 180B4035) KFOZZ R B3322 PISTON (PART OF KIT P/N 180B4035) KFOZZ R B3344 STOP BUSHING (PART OF KIT P/N 180B4031) 1 53 PBOZZ R B3313 RETAINIER, BALL,BEARING XAOZZ R B5700 CYLINDER BARREL PBOZZ R B3345 CLIP, BRANCH, JOINT B 2 56 KFOZZ R B1649 O-RING (PART OF KIT 180B4031) PFOZZ R B3310 PORT FLANGE KFOZZ R B3321 PIN (PART OF KIT P/N 180B4031) KFOZZ R B3320 PIN, GUIDE (PART OF KIT P/N 180B4031) KFOZZ R B3307 PORT PLATE (PART OF KIT P/N 180B4035) KFOZZ R B5702 VALVE PLATE (PART OF KIT P/N 180B4035) KFOZZ R B0265 BACKUP RING (PART OF KIT P/N 180B4031) KFOZZ R B1438 O-RING (PART OF KIT 180B4031) KFOZZ R L9083 PIN (PART OF KIT P/N 180B4031) KFOZZ R H0020 O-RING (PART OF KIT 180B4031)... 1 (7) QTY

163 GROUP 04 REVERSE OSMOSIS SYSTEM HIGH PRESSURE PUMP ASSEMBLIES P-5 AND P-6 REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 46 HIGH PRESSURE PUMP PBOZZ P PISTON SET PISTON, VALVE (9) 18 PBOZZ P DISC VALVE SET DISC, VALVE (18) 15 PBOZZ P KIT, O-RING O-RING (2) 7...O-RING (1) 12...O-RING (1) 13...O-RING (1) 14...O-RING (3) 17...O-RING (9) 19...O-RING (9) 20...O-RING (1) - 30 PBOZZ R B4031 KIT, SEAL, O-RINGS & SPARE PARTS KEY (1) O-RING (1) 38...SHAFT SEAL ASSEMBLY (1) SCREW, MACHINE (1) SCREW, CAP, HEX (16) O-RING (2) 43...O-RING (2) STOP BUSHING (1) O-RING (2) 56...PIN (1) PIN, GUIDE (1) BACKUP-RING (9) 62...O-RING (9) 63...PIN (4) O-RING (1) - 65 INSERT, COUPLING, FLEXIBLE (1) FIG PBOZZ R B4035 REPAIR KIT, PUMPING, 6000-HR SERVICE 1... RETAINING PLATE (1) PISTON (9) PORT PLATE (1) VALVE PLATE (1) BACKUP-RING (9) 62 (7) QTY END OF FIGURE /10 BLANK

164

165

166 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY H Figure 47. RO Piping Assembly H BLANK / 2

167 GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY H01 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 47 PIPING ASSEMBLY H01 1 PBOOO EXU COUPLING, GROOVED PAOZZ E-1.0IN. GASKET XBOZZ 0EXU PIPE SPOOL PBOOO EXU COUPLING, CLAMP, GROOVED PAOZZ E-1.5IN. GASKET MOOZZ K67 TUBING, NONMETALLIC,MAKE FROM BULK 1 MATERIAL,NSN ,CUT TO LENGTH 132 INCHES 7 PAOZZ B2HF-SS ADAPTER, STRAIGHT PBOZZ EXU VALVE, BALL (V-302 AND V-301) PAOZZ HCS-16-M-SS- CLAMP, BLOCK... 1 RSG-16-8P 10 XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU PIPE SPOOL XBOZZ 0EXU PIPE SPOOL PAOZZ HCS-32-M-SS- CLAMP, BLOCK... 3 RSG-32-24P 14 PBOZZ EXU VALVE, SAFETY RELIEF (RV-301) XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU ELBOW, PIPE XBOZZ 0EXU PIPE SPOOL PBOZZ EXU HOSE ASSY, NONMETALLIC XBOZZ 0EXU BUSHING, PIPE PBOZZ KMP GAGE, PRESSURE (PI-301) MOOZZ K67 TUBING, NONMETALLIC,MAKE FROM BULK MATERIAL,NSN , CUT TO LENGTH AS NEEDED 1 END OF FIGURE (7) QTY / 4 BLANK

168

169

170 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM TURBOCHARGER ASSEMBLY Figure 48. Turbocharger Assembly BLANK / 2

171 GROUP 04 REVERSE OSMOSIS SYSTEM TURBOCHARGER ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 48 TURBOCHARGER ASSEMBLY 1 PAOZZ MS WASHER, FLAT PAOZZ M45913/1-8CG5C NUT, SELF-LOCKING, HEX PBOOO TEM0 HTCII-50 TURBOCHARGER PAOZZ EXU NIPPLE, TUBE XBOZZ 0U5N BASE, TURBOCHARGER PAOZZ EXU ELBOW, PIPE TO TUBE PAOZZ SS-400-NFSET FERRULE, BRAZING PAOZZ U5N TUBE, METALLIC PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, CAP, HEX PAOZZ P MOUNT, RESILIENT PBOZZ M-4P4T VALVE, BLEEDER (V-303 AND V-410) MOOZZ B4 1B TUBING, NONMETALLIC... 2 (CUT TO LENGTH 96 IN.) 15 PAOZZ U060L4A FERRULE, COMPRESSION XBOZZ 0U5N BRACKET, ANGLE... 1 END OF FIGURE (7) QTY

172 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM TURBOCHARGER ASSEMBLY Figure 49. Turbocharger

173 GROUP 04 REVERSE OSMOSIS SYSTEM TURBOCHARGER ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 49 TURBOCHARGER 1 KFOZZ TEM O-RING (PART OF KIT P/N HTCII-50 RA) KFOZZ TEM O-RING (PART OF KIT P/N HTCII-50 RA) KFOZZ TEM BEARING, THRUST... 1 (PART OF KIT P/N HTCII-50 RA) 4 KFOZZ TEM RING, RETAINING... 2 (PART OF KIT P/N HTCII-50 RA) 5 KFOZZ TEM T IMPELLER, PUMP (TURBINE)... 1 (PART OF KIT P/N HTCII-50 RA) 6 KFOZZ TEM KEY, WOODRUFF... 1 (PART OF KIT P/N HTCII-50 RA) 7 KFOZZ 0TEM BEARING, SLEEVE... 1 (PART OF KIT P/N HTCII-50 RA) 8 KFOZZ TEM P IMPELLER, PUMP... 1 (PART OF KIT P/N HTCII-50 RA) 9 KFOZZ TEM WASHER, FLAT... 1 (PART OF KIT P/N HTCII-50 RA) 10 KFOZZ TEM NUT, RETAINING... 1 (PART OF KIT P/N HTCII-50 RA) 11 KFOZZ TEM BEARING, SLEEVE... 1 (PART OF KIT P/N HTCII-50 RA) 12 PAOZZ MS SCREW, CAP HEX PAOZZ SS ADAPTER, STRAIGHT PAOZZ TEM TUBE ASSEMBLY, METAL... 1 PBOZZ TEM0 HTCII-50 RA KIT, REPAIR IMPELLER, PUMP (1) IMPELLER, TURBINE (1) WASHER, FLAT (1) KEY, IMPELLER (1) NUT, RETAINING (1) BEARING, SLEEVE (1) BEARING, SLEEVE (1) BEARING, THRUST (1) O-RING (4) O-RING (2) RING, RETAINING (2) - 4 (7) QTY END OF FIGURE / 6 BLANK

174

175

176 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY H Figure 50. RO Piping Assembly H BLANK / 2

177 GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY H03 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 50 RO PIPING ASSEMBLY H03 1 PBOOO EXU COUPLING, CLAMP, GROOVED PAOZZ E-1.5IN. GASKET PAOZZ EXU HOSE ASSEMBLY, NONMETALLIC PBOZZ EXU VALVE, NEEDLE (V-913) PBOZZ EXU NIPPLE, PIPE PBOZZ EXU ELBOW, PIPE XBOZZ 0EXU PIPE SPOOL XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU ELBOW, PIPE PBOZZ EXU VALVE, SAFETY RELIEF (RV-302) XBOZZ 0EXU ELBOW, PIPE XBOZZ 0EXU NIPPLE, PIPE XBOOO 0U5N HANGER, PIPE PAOZZ KXJ3 FS-7409 ST6. BOLT, MACHINE PAOZZ KXJ3 FS-1/2 NS ST. NUT, SELF-LOCKING PAOZZ HCS-32-M-SS- CLAMP, BLOCK... 4 RSG-32-24P 17 XBOZZ 0EXU PIPE SPOOL PBOZZ KMP GAGE, PRESSURE (PI-304) PBOZZ CE49 PTX (0- TRANSMITTER, PRESSURE (PT-302) PSIA) 20 XBOZZ 0EXU PIPE SPOOL XBOZZ 0EXU NIPPLE, PIPE PBOZZ EXU VALVE, BALL (V-304) PAOZZ B2HF-SS ADAPTER, STRAIGHT MOOZZ K67 TUBING, NONMETALLIC... 1 (CUT TO LENGTH 122 IN.) 25 XBOZZ 0EXU PIPE SPOOL PBOOO EXU COUPLING, CLAMP, GROOVED PAOZZ E-1.0IN. GASKET XBOOO 0EXU PIPE SPOOL PBOZZ EXU VALVE, BALL (V-701)... 1 END OF FIGURE (7) QTY / 4 BLANK

178

179

180 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM RO VESSELS ROV-1 THROUGH ROV Figure 51. RO Vessel Installation BLANK / 2

181 GROUP 04 REVERSE OSMOSIS SYSTEM RO VESSELS ROV-1 THROUGH ROV-5 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 51 RO VESSEL INSTALLATION 1 XBOZZ 0U5N SUPPORT, RO VESSEL PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, CAP, HEX PAOZZ E NUT, PLAIN, HEX PAOZZ MS SCREW, CAP, HEX PAOZZ K13 BUMPER PBFFF YQYO 80E120-2 RO VESSEL ASSEMBLY PAOZZ M45913/1-6CS3. NUT, SELF-LOCKING, HEX PAOZZ MS WASHER, FLAT PAOZZ YQYO SADDLE, PIPE COVERING PAOZZ U5N BOLT, HOOK PAOZZ U5N RUBBER STRIP PAOZZ U5N CLAMP, LOOP... 2 (7) QTY END OF FIGURE

182 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM RO VESSELS ROV-1 THROUGH ROV (SAME AS BREAKDOWN BELOW) Figure 52. RO Vessel Assembly

183 GROUP 04 REVERSE OSMOSIS SYSTEM RO VESSELS ROV-1 THROUGH ROV-5 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 52 RO VESSEL ASSEMBLY 1 XAFZZ 2M769 NO NUMBER SHELL PBOZZ YQYO SPACER, SLEEVE PBOZZ K36 O-RING PBOZZ YQYO ADAPTER, STRAIGHT PBOZZ YQYO O-RING PBOZZ YQYO CONNECTOR, FLUID, PUMP PBOZZ YQYO RING, RETAINING PBOZZ SW30HR-380 FILTER ELEMENT, FLUID PBOZZ E PACKING, PREFORMED (BRINE SEAL) PBOZZ M11493 STUD, PLAIN PBOZZ YQYO SEAL, PLAIN PBOZZ M PLATE, RETAINING, SEAL PBOZZ YQYO RETAINING, PACKING PBOZZ AK RETAINER SET, PORT PBOZZ YQYO BRACKET, EYE PBOZZ YQYO PORT, FEEDER-REJECT PBOZZ M NUT, PLAIN, HEX PBOZZ EXU3 632-B-7930 SIMULATOR, ELEMENT PBOZZ 1YQY SPACER... 2 (7) QTY END OF FIGURE / 6 BLANK

184

185

186 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY H Figure 53. RO Piping Assembly H BLANK / 2

187 GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY H04 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 53 RO PIPING ASSEMBLY H04 1 XBOZZ 0EXU PIPE SPOOL PBOOO EXU COUPLING, CLAMP, GROOVED PAOZZ E-1.5IN. GASKET... 1 (7) QTY END OF FIGURE / 4 BLANK

188

189

190 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY R Figure 54. RO Piping Assembly R BLANK / 2

191 GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY R02 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 54 RO PIPING ASSEMBLY R02 1 PBOOO EXU COUPLING, CLAMP, GROOVED PAOZZ E-1.5IN. GASKET XBOZZ 0EXU PIPE SPOOL XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU TEE, PIPE XBOZZ 0EXU ELBOW, PIPE PBOZZ EXU VALVE, NEEDLE (HCV-401) XBOZZ 0EXU NIPPLE, PIPE PAOZZ MS CLAMP, HOSE MOOZZ 0ABC1 K X300 HOSE, NONMETALLIC,MAKE FROM BULK 1 MATERIAL,NSN , CUT TO LEBGHT 21 INCHES 11 MOOZZ 0ABC1 K X300 HOSE,, NONMETALLIC,(MAKE FROM BULK 1 MATERIAL, NSN CUT TO LENGTH 36 INCHES 12 PBOZZ EXU VALVE, BALL (V-408, HCV-401A) PAOZZ CLAMP, HOSE PBOZZ KMP GAGE, PRESSURE (PI-401) XBOZZ 0EXU BUSHING, PIPE MOOZZ K67 TUBING, NONMETALLIC,MAKE FROM BULK 1 MATERIAL,NSN ,CUT TO LENGTH 96 INCHES 17 PAOZZ B2HF-SS ADAPTER, STRAIGHT PBOOO EXU COUPLING, CLAMP, GROOVED PAOZZ E-1.0IN. GASKET XBOZZ 0EXU PIPE SPOOL... 1 END OF FIGURE (7) QTY / 4 BLANK

192

193

194 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY R Figure 55. RO Piping Assembly R BLANK / 2

195 GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY R03 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 55 RO PIPING ASSEMBLY R03 1 PBOZZ EXU VALVE, CHECK (V-411) PBOOO EXU COUPLING, CLAMP, GROOVED PAOZZ E-1.5IN. GASKET PBOZZ F1A11B2T20S TRANSMITTER, RATE OF FLOW (FE-401) XBOOO 0EXU PIPE SPOOL PBOZZ EXU VALVE, BALL (V-702) PAOZZ EXU CLAMP, HOSE MOOZZ 0EXU HOSE, NONMETALLIC... 3 (MAKE FROM BULK MATERIAL, NSN CUT TO LENGTH 4 IN.) 9 XBOZZ 0EXU PIPE SPOOL PAOZZ CLAMP, HOSE XBOZZ 0EXU PIPE SPOOL PBOOO EXU COUPLING, PIPE PAOZZ EXU GASKET XBOZZ 0EXU NIPPLE, PIPE XBOZZ 0EXU BUSHING, PIPE XBOZZ 0EXU TEE, PIPE XBOZZ 0EXU NIPPLE, PIPE PBOOO EXU COUPLING, CLAMP, GROOVED PAOZZ E-1.0IN. GASKET XBOZZ 0EXU PIPE SPOOL XBOZZ 0EXU PIPE SPOOL... 1 (7) QTY END OF FIGURE / 4 BLANK

196

197

198 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY P A 19 B OR 13 OR Figure 56. RO Piping Assembly P01 Manifold BLANK / 2

199 GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY P01 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 56 RO PIPING ASSEMBLY P01 MANIFOLD 1 PAOZZ CLAMP, HOSE XBOZZ 0EXU PIPE SPOOL PAOZZ CLAMP, HOSE PAOZZ CLAMP, HOSE MOOZZ 0EXU HOSE, NONMETALLIC... 2 (MAKE FROM BULK MATERIAL, NSN CUT TO LENGTH 4 IN.) 6 XBOOO 0U5N HANGER, PIPE PAOZZ KXJ3 FS-7409 ST6. BOLT, MACHINE PAOZZ KXJ3 FS-1/2 NS ST. NUT, SELF-LOCKING PAOZZ CLAMP, BLOCK XBOZZ 0EXU PIPE SPOOL PAOZZ SS-16-RB-8 BUSHING, PIPE XBOZZ 0EXU NIPPLE, PIPE... 8 (8 LOCATIONS EXCEPT AT A AND B ) 13 XBOZZ 0EXU NIPPLE, PIPE (AT LOCATION A ) XBOZZ 0EXU NIPPLE, PIPE (AT LOCATION B ) MOOZZ 0ABC1 K X300 TUBING, NONMETALLIC,MAKE FROM BULK 10 MATERIAL,NSN , CUT TO LENGTH AS NEEDED. 16 PAOZZ B2HF-SS ADAPTER, STRAIGHT PBOZZ EXU VALVE, BALL (V-501 THROUGH V-510) MOOZZ K67 TUBING, NONMETALLIC,MAKE FROM BULK 10 MATERIAL, NSN , CUT TO LENGTH AS NEEDED 19 PAOZZ E-05E-NYL ADAPTER, STRAIGHT END OF FIGURE (7) QTY

200 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY P Figure 57. RO Piping Assembly P01 Outlet

201 GROUP 04 REVERSE OSMOSIS SYSTEM PIPING ASSEMBLY P01 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER 1 PAOZZ TYPE B SIZE 79 (6) (7) DESCRIPTION AND USABLE ON CODE (UOC) QTY GROUP 04 REVERSE OSMOSIS SYSTEM FIGURE 57 RO PIPING ASSEMBLY P01 OUTLET CLAMP, HOSE MOOZZ 0EXU HOSE, NONMETALLIC... 1 (MAKE FROM BULK MATERIAL, NSN CUT TO LENGTH 4 IN.). 3 PAOZZ EXU O-RING PAOZZ E CLAMP, HOSE PBOZZ A6A CELL, SALINITY DETECTOR (CE-501A) PBOZZ KMP GAGE, PRESSURE (PI-501) PAOZZ CLAMP, BLOCK XBOOO 0U5N HANGER, PIPE PAOZZ KXJ3 FS-7409 ST6. BOLT, MACHINE PAOZZ KXJ3 FS-1/2 NS ST. NUT, SELF-LOCKING PBOZZ F1A11B2T20S TRANSMITTER, RATE OF FLOW (FE-501) XBOZZ 0EXU PIPE SPOOL XBOOO 0U5N HANGER, PIPE PAOZZ KXJ3 FS-7409 ST6. BOLT, MACHINE PAOZZ KXJ3 FS-1/2 NS ST. NUT, SELF-LOCKING PAOZZ CLAMP, HOSE PBOZZ EXU ELBOW, PIPE PBOOO U5N HOSE ASSEMBLY, OUTLET PAOZZ NW4. GASKET PAOZZ W-FDAPOLY PLUG, PROTECTIVE XBOZZ 0EXU PIPE SPOOL PAOZZ MHHS-2-S CLAMP, HOSE PAOZZ EXU GASKET PBOZZ EXU VALVE, CHECK (V-512) MOOZZ K67 TUBING, NONMETALLIC,MAKE FROM BULK 1 MATERIAL, NSN ,CUT TO LENGTH 80 INCHES 26 PAOZZ CLAMP, HOSE PAOZZ B2HF-SS ADAPTER, STRAIGHT PBOZZ EXU VALVE, BALL (V-511) XBOZZ 0EXU NIPPLE, PIPE PBOZZ EXU ELBOW, PIPE XBOZZ 0EXU ELBOW, PIPE PBOZZ EXU VALVE, SAFETY RELIEF (RV-501) PBOZZ EXU FERRULE, GROOVED CLAMP COUPLING PAOZZ EXU O-RING PBOZZ EXU VALVE, CHECK (VB-501) PBOZZ E6A CELL, SALINITY DETECTOR (CE-501B)... 1 END OF FIGURE / 6 BLANK

202

203

204 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 05 CHEMICAL INJECTION SYSTEM CHEMICAL INJECTION SYSTEM Figure 58. Chemical Injection System BLANK / 2

205 GROUP 05 CHEMICAL INJECTION SYSTEM CHEMICAL INJECTION SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 05 CHEMICAL INJECTION SYSTEM FIGURE 58 CHEMICAL INJECTION SYSTEM 1 PBOOO AA SI PUMP, RECIPROCATING PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT PAOZZ KNOB, SPEED CONTROL PAOZZ KNOB, STROKE CONTROL PAOZZ SHIELD, CONTROL PAOZZ MS21044C08. NUT, SELF-LOCKING XBOZZ 0U5N BASE, MOUNTING PAOZZ MS BOLT, MACHINE PAOZZ MS WASHER, FLAT PAOZZ Y3H NUT, SELF-LOCKING PAOZZ U5N LID, UTILITY PAIL, BLUE PAOZZ U5N LID, UTILITY PAIL, YELLOW PAOZZ U5N LID, UTILITY PAIL, RED PBOZZ U5N PAIL, UTILITY, RED PBOZZ U5N PAIL, UTILITY, YELLOW PBOZZ U5N PAIL, UTILITY, BLUE PBOOO U5N ADAPTOR ASSEMBLY, A PAOZZ NW5. GASKET PAOZZ PLT1.5I-M STRAP, TIE-DOWN, ELECTRICAL PAOZZ BOX CONNECTOR, ELECTRICAL PAOZZ O-RING PAOZZ AA LOCK NUT, ELECTRICAL PX01S 24 PAOZZ BOX CONNECTOR, ELECTRICAL XBOOO 0U5N ENCLOSURE, ELECTRICAL PAOZZ JN C SPLICE, CONDUCTOR PAOZZ JN C NUT, SLEEVE... 3 (7) QTY END OF FIGURE

206 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 05 CHEMICAL INJECTION SYSTEM CHEMICAL INJECTION SYSTEM Figure 59. Chemical Injection Pump, Valves, and Injectors (Typical 1 of 3)

207 GROUP 05 CHEMICAL INJECTION SYSTEM CHEMICAL INJECTION SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 05 CHEMICAL INJECTION SYSTEM FIGURE 59 CHEMICAL INJECTION PUMP, VALVES, AND INJECTORS 1 PBOOO VALVE, STOP-CHECK PAOZZ O-RING (PART OF KIT PN RPM/ ) PAOZZ SPRING, HELICAL, COMPRESSION... 1 (PART OF KIT PN RPM/ ) 4 PAOZZ BALL, CHECK... 1 (PART OF KIT PN RPM/ ) 5 MOOZZ TUBING, NONMETALLIC,MAKE FROM BULK 2 MATERIAL,NSN , CUT TO LENGTH AS NEEDED 6 PBOZZ VALVE, LINEAR PAOZZ WASHER, FLAT... 4 (PART OF KIT PN RPM/ ) 8 PAOZZ CARTRIDGE, CHECK VALVE... 3 (PART OF KIT PN RPM/ ) 9 PBOZZ AA151 DRIVE ASSEMBLY PBOZZ DIAPHRAGM, PUMP... 1 (PART OF KIT PN RPM/ ) 11 PBOOO HEAD, HYDRAULIC MOTOR-PUMP PAOZZ WASHER, FLAT PAOZZ MS SCREW, MACHINE... 4 (PART OF KIT PN RPM/ ) 14 MOOZZ EB TUBING, NONMETALLIC... 1 (CUT TO LENGTH FROM BULK - 36 IN.) 15 PBOOO VALVE, FOOT PBOZZ WEIGHT, CHECK VALVE PBOOO VALVE, FOOT... 1 PAOZZ RPM/ REPAIR KIT, PUMPING ASSEMBLY BALL, CHECK (1) 4... CARTRIDGE ASSEMBLY (3) 8... DIAPHRAGM, PUMP (1) O-RING (4) 2...SCREW, MACHINE (4) 13...SPRING, COMPRESSION (1) 3... WASHER, FLAT (4) 7 (7) QTY END OF FIGURE / 6 BLANK

208

209

210 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM AIR SYSTEM Figure 60. Air System BLANK / 2

211 GROUP 06 AIR SYSTEM AIR SYSTEM REPAIR PARTS LIST (1) ITE M NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 60 AIR SYSTEM 1 XBOOO 0U5N AIR SYSTEM SECTION XBOOO 0U5N AIR SYSTEM SECTION PAOOO NB13- SWITCH, PRESSURE XBOOO 0U5N AIR SYSTEM SECTION XCOFF 0U5N AIR COMPRESSOR ASSEMBLY XBOOO 0U5N AIR SYSTEM SECTION XBOZZ N265-CGA346 CYLINDER, AIR XBOOO 0U5N AF2/CO1 ASSEMBLY XDOOO 0U5N FEED FLOW CONTROL PANEL ASSEMBLY... 1 END OF FIGURE (7) QTY / 4 BLANK

212

213

214 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM AIR COMPRESSOR ASSEMBLY Figure 61. Air Compressor Assembly BLANK / 2

215 GROUP 06 AIR SYSTEM AIR COMPRESSOR ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 61 AIR COMPRESSOR ASSEMBLY 1 XBOOO 0U5N SHIELD PLATE, REAR PAOZZ NASM SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N PLATE, BRACKET XBOOO 0U5N SHIELD, BELT GUARD PAOZZ NASM SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOOO 0U5N FRAME, BELT GUARD PAOZZ MS BOLT, MACHINE PAOZZ MS WASHER, FLAT PAOZZ Y3H NUT, SELF-LOCKING XBOOO 0U5N SHIELD PLATE, FRONT PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ NASM SCREW, CAP, HEX PBOOO C-BH/TWPS COMPRESSOR UNIT, RECIPROCATING PAOZZ Y3H NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT PAOZZ MS BOLT, MACHINE PAOZZ NP0 A76 BELT, V XBOOO 0U5N BRACE PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, FLAT PAOZZ M45913/1-6CS3. NUT, SELF-LOCKING XBOOO 0U5N BASE, AIR COMP PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, FLAT PAOZZ M45913/1-6CS3. NUT, SELF-LOCKING PAOZZ MS SCREW, CAP, HEX S PAOZZ MS WASHER, FLAT PAOZZ EXU NUT, SELF-LOCKING XBOOO 0U5N BRACKET PAOZZ MS BOLT, MACHINE PAOZZ MS WASHER, FLAT PAOZZ Y3H NUT, SELF-LOCKING XBOOO M280 BASE, MOTOR PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, FLAT PAOZZ M45913/1-6CS3. NUT, SELF-LOCKING... 4 (7) QTY

216 GROUP 06 AIR SYSTEM AIR COMPRESSOR ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 61 AIR COMPRESSOR ASSEMBLY 45 PBOOO EXU MOTOR, AC PAOZZ M45913/1-6CS3. NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT PAOZZ STB-4550 BOX CONNECTOR, ELECTRICAL PAOZZ O-RING PAOZZ REDUCING WASHER PAOZZ PLT1.5I-M STRAP, TIE-DOWN, ELECTRICAL PAOZZ AA P- LOCKNUT, ELECTRICAL S 53 PAOZZ PN14-10R-C TERMINAL, LUG PAOZZ JN SPLICE, CONDUCTOR PAOZZ D5S COVER, ACCESS PAOZZ D5S SCREW, TAPPING PAOZZ D5S GASKET... 1 END OF FIGURE (7) QTY

217

218 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM AIR COMPRESSOR Figure 62. Air Compressor BLANK / 2

219 GROUP 06 AIR SYSTEM AIR COMPRESSOR REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 62 AIR COMPRESSOR 1 PAOZZ SWT-0006 SWITCH, THERMOSTATIC (TSH-901) PBOZZ HEAD, VALVE # PAOZZ N SCREW, CAP, HEX PAOZZ N03521 O-RING PAOZZ GAGE ROD, LIQUID LEVEL PBOOO HEAD, VALVE # PAOZZ SCR-180. SCREW, CAP, HEX PAOOO FILTER ASSEMBLY PAOZZ N O-RING PAOZZ N FILTER ELEMENT, INTAKE AIR PAOZZ N O-RING PAOZZ SPRING, HELICAL PBOOO HEAD, VALVE # PAOZZ SCR-180. SCREW, CAP, HEX XBOZZ TUBE, OIL RETURN PBOZZ VALVE, REGULATING PAOZZ NO3707 PLUG, PIPE PAOZZ GASKET PBOZZ N00083 OIL PUMP, COMPRESSOR XBOZZ TUBE, OIL SUPPLY XCOOO 0U5N ASSY, COMPRESSOR DRAIN PAOZZ K122. NIPPLE, PIPE PAOZZ K412. ELBOW, PIPE PAOZZ K138. NIPPLE, PIPE PAOZZ K139. NIPPLE, PIPE PAOZZ K472. ELBOW, PIPE PAOZZ U5N SOLENOID ASSEMBLY PBOZZ U5N VALVE, SOLENOID (XV-910) PAOZZ K132. NIPPLE, PIPE PBOZZ SS-4P4T4. VALVE, PLUG (V-901) PAOOO FILTER ASSEMBLY XAOZZ FILTER HEAD PAOZZ VALVE PLATE PAOZZ CONE, BAFFLE FILTER ELEMENT, INTAKE AIR... PAOZZ N02726 (SINTERED METAL) 1 36 PAOZZ SCREW, CAP, HEX PAOZZ N O-RING XAOZZ HOUSING, FILTER XAOZZ COLLAR, THREADED... 1 END OF FIGURE (7) QTY / 4 BLANK

220

221

222 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM AF2 CO1 ASSEMBLY Figure 63. AF2 - CO1 Assembly BLANK / 2

223 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM AF2 CO1 ASSEMBLY (1) (2) (3) (4) (5) (6) (7) ITEM NO. SMR CODE NSN CAGEC PART NUMBER DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 63 AF2 - CO1 ASSEMBLY 1 XBOOO /TWPS PURIFIER UNIT, AIR (AF2) PAOZZ SCREW, MACHINE XBOZZ COVER PLATE XAOZZ FILTER HEAD PAOZZ N O-RING PAOZZ N O-RING PBOZZ A. CARTRIDGE, PURIFIER XAOZZ FILTER HOUSING XAOZZ FILTER BOTTOM PAOZZ U5N RUBBER STRIP XBOZZ 0U5N BRACKET PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS BOLT, MACHINE PAOOO SS-7R4-TA4- HOSE, NONMETALLIC... 1 PM PAOZZ SS-400-NFSET. FERRULE, BRAZING PAOZZ J514 ELBOW, PIPE TO TUBE PAOZZ VAL-0169/TWPS VALVE, RELIEF (RV-901) PAOZZ SS ADAPTER, STRAIGHT XBOOO /TWPS SEPARATOR, OIL/WATER (CO1) XAOZZ HEAD, SEPARATOR PAOZZ N O-RING PBOZZ FILTER ELEMENT XAOZZ HOUSING, SEPARATOR XAOZZ BOTTOM PLUG PAOZZ U5N RUBBER STRIP XBOZZ 0U5N BRACKET PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS BOLT, MACHINE PAOZZ K132 NIPPLE, PIPE PAOZZ SS-4P4T4 VALVE, PLUG (V-902, V-904) PAOZZ NIPPLE, PIPE PAOZZ K472 ELBOW, PIPE PAOZZ U5N VALVE, SOLENOID (XV-911) PAOZZ U5N SOLENOID ASSEMBLY PAOZZ K138 NIPPLE, PIPE PAOZZ K412 ELBOW, PIPE PAOZZ K141 NIPPLE, PIPE PAOZZ K133 NIPPLE, PIPE XBOZZ 0U5N PROTECTOR, VALVE PAOZZ M45913/1-4CS3. NUT, SELF-LOCKING PAOZZ NASM SCREW, CAP, HEX XBOZZ 0U5N PLATE, MOUNTING PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, FLAT... 8 QTY

224 GROUP 06 AIR SYSTEM AF2 CO1 ASSEMBLY REPAIR PARTS LIST (1) (2) (3) (4) (5) (6) (7) ITEM NO. SMR CODE NSN CAGEC PART NUMBER DESCRIPTION AND USABLE ON CODE (UOC) 47 PAOZZ M45913/1-6CS3. NUT, SELF-LOCKING PAOZZ SS600-3TTF TEE, PIPE TO TUBE PAOZZ SS-600-NFSET FERRULE, HANDLE PAOZZ SS-6-TA-1-4 ADAPTER, STRAIGHT PAOZZ SS ELBOW, PIPE TO TUBE PAOZZ VAL-0007 VALVE, CHECK (V-903) PAOZZ A420. SCREW, CAP, HEX PAOZZ A210. WASHER, LOCK PAOZZ MS WASHER, FLAT... 2 QTY END OF FIGURE

225

226 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM AIR SYSTEM SECTION Figure 64. Air System Section BLANK / 2

227 GROUP 06 AIR SYSTEM AIR SYSTEM SECTION 1 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 64 AIR SYSTEM SECTION 1 1 PAOZZ AS1124 CAP, PROTECTIVE PAOZZ VAL-0053 PRESSURE VALVE (V-905) PAOZZ K12 NIPPLE, PIPE PAOZZ AS4859K02 COUPLING, PIPE PAOZZ ME ELBOW, PIPE PAOZZ VAL-0007 VALVE, CHECK (V-906) PAOZZ U5N BUSHING, PIPE PAOZZ MMO-SS TEE, PIPE PBOZZ KMP GAGE, PRESSURE (PI-901) PAOZZ SPNX1 3/8SS NIPPLE, PIPE PAOZZ AN918-6K CROSS, PIPE PAOZZ VALVE, REGULATING (PRV-901) PAOZZ /4KMM00-SS CROSS, PIPE PAOZZ U5N BUSHING, PIPE PBOZZ KMP GAGE, PRESSURE (PI-902) PAOZZ PF31-12 TEE, PIPE PAOZZ K195 NIPPLE, PIPE PAOZZ A ELBOW, PIPE PAOZZ RST-5 ADAPTER, STRAIGHT PAOZZ K585 REDUCER, PIPE PAOZZ FEV01- VALVE, PRESSURE EQUALIZING (RV-902)... 1 KM PAOZZ T5 BOLT, U PAOZZ AA COUPLING HALF, QD C 24 PAOZZ K64 CAP, PROTECTIVE PAOZZ T6 BOLT, U PAOZZ MS WASHER, FLAT PAOZZ Y3H NUT, SELF-LOCKING... 6 END OF FIGURE (7) QTY / 4 BLANK

228

229

230 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM PRESSURE SWITCH ASSEMBLY AND AIR RECEIVER TANK R Figure 65. Pressure Switch Assembly BLANK / 2

231 GROUP 06 AIR SYSTEM PRESSURE SWITCH ASSEMBLY AND AIR RECEIVER TANK R-1 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER 1 PAOOO NB (6) (7) DESCRIPTION AND USABLE ON CODE (UOC) QTY GROUP 06 AIR SYSTEM FIGURE 65 PRESSURE SWITCH ASSEMBLY SWITCH, PRESSURE (PSL/PSH-901) PAOZZ Y3H NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT PAOZZ MS BOLT, MACHINE PAOZZ GASKET PAOZZ GASKET XDOZZ B TB. REDUCER, THREADED PAOZZ MS TERMINAL, LUG PAOZZ CGB192-SG. BOX CONNECTOR, ELECTRICAL... 1 END OF FIGURE

232 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM PRESSURE SWITCH ASSEMBLY AND AIR RECEIVER TANK R Figure 66. Air Receiver Tank R

233 GROUP 06 AIR SYSTEM PRESSURE SWITCH ASSEMBLY AND AIR RECEIVER TANK R-1 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 66 AIR RECEIVER TANK R-1 1 PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N CLAMP PAOZZ U5N PAD, NEOPRENE XBOZZ N265-CGA346 CYLINDER, AIR XBOZZ NIPPLE, PIPE PAOZZ NUT, TUBE COUPLING... 1 (7) QTY END OF FIGURE / 6 BLANK

234

235

236 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM AIR SYSTEM SECTION Figure 67. Air System Section BLANK / 2

237 GROUP 06 AIR SYSTEM AIR SYSTEM SECTION 3 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 67 AIR SYSTEM SECTION 3 1 PAOZZ RST-5 ADAPTER, STRAIGHT PAOZZ A ELBOW, PIPE PAOZZ SPNX1 3/8SS NIPPLE, PIPE PAOZZ X3-4PTRSS BUSHING, PIPE PAOZZ U5N SOLENOID ASSEMBLY PAOZZ U5N VALVE, SOLENOID (XV-901) PAOZZ K485 CROSS, PIPE PAOZZ /4X3/8PTRSS BUSHING, PIPE PAOZZ SS-6HC-1-6 ADAPTER, STRAIGHT PAOZZ VALVE, REGULATING (PRV-902) PAOZZ X1-2PTRSS BUSHING, PIPE PAOZZ NIPPLEPIPE316 NIPPLE, PIPE PAOZZ MU02 PS UNION, PIPE PAOZZ SS-8-CS CROSS, PIPE PAOZZ SAE J BUSHING, PIPE S 16 PAOZZ NIPPLE, PIPE PAOZZ U5N VALVE, SOLENOID (XV-903) PAOZZ /8FF-SS ELBOW, PIPE PAOZZ U5N SOLENOID ASSEMBLY PAOZZ K614 ELBOW, PIPE PAOZZ U5N BUSHING, PIPE PAOZZ EXU NIPPLE, PIPE PAOZZ U5N TEE, PIPE PBOZZ ZP1 F220B VALVE, BALL (V-915) PAOZZ KMP GAGE, PRESSURE (PI-903) PAOZZ A127 NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT PAOZZ T6 BOLT, U... 2 (7) QTY END OF FIGURE / 4 BLANK

238

239

240 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM AIR SYSTEM SECTION Figure 68. Air System Section BLANK / 2

241 GROUP 06 AIR SYSTEM AIR SYSTEM SECTION 4 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 68 AIR SYSTEM SECTION 4 1 PAOZZ Y3H NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT XDOZZ 0U5N SPACER PAOZZ U5N SOLENOID ASSEMBLY PAOZZ NIPPLE, PIPE PAOZZ /8FF-SS ELBOW, PIPE PAOZZ SS-6HC-1-6 ADAPTER, STRAIGHT PAOZZ T5 BOLT, U PAOZZ U5N VALVE, SOLENOID (XV-902) PAOZZ SAE J BUSHING, PIPE S 11 PAOZZ K23 VALVE, CHECK (V-908) PAOZZ NIPPLEPIPE316 NIPPLE, PIPE PAOZZ RST-5 ADAPTER, STRAIGHT PAOZZ X1-2PTRSS BUSHING, PIPE PAOZZ PF31-12 TEE, PIPE PAOZZ SPNX1 3/8SS NIPPLE, PIPE PAOZZ A ELBOW, PIPE... 1 (7) QTY END OF FIGURE / 4 BLANK

242

243

244 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM AIR SYSTEM SECTION Figure 69. Air System Section BLANK / 2

245 GROUP 06 AIR SYSTEM AIR SYSTEM SECTION 6 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 69 AIR SYSTEM SECTION 6 1 PAOZZ SS-6HC-1-6 ADAPTER, STRAIGHT PAOZZ U5N BUSHING, PIPE PAOZZ K444 COUPLING, PIPE PAOZZ NIPPLEPIPE316 NIPPLE, PIPE PAOZZ WSA-04-FM0 TRAP, MOISTURE (CO2) PAOZZ SS-63TF8RT VALVE, BALL (V-909, V-910) PAOZZ K434 TEE, PIPE PAOZZ ADAPTER, STRAIGHT PAOZZ T3 BOLT, U PAOZZ MS WASHER, FLAT PAOZZ M45913/1-4CS3 NUT, SELF-LOCKING XBOZZ 0U5N SPACER XBOZZ 0U5N BRACKET, MOUNTING PAOZZ MS BOLT, MACHINE... 2 (7) QTY END OF FIGURE / 4 BLANK

246

247 GROUP 06 AIR SYSYEM FEED FLOW CONTROL PANEL REPAIR PARTS LIST Figure 70. Feed Flow Control Panel Assembly (Sheet 1 of 2)

248 GROUP 06 AIR SYSTEM FEED FLOW CONTROL PANEL ASSEMBLY REPAIR PARTS LIST Figure 70. Feed Flow Control Panel Assembly (Sheet 2 of 2)

249 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM FEED FLOW CONTROL PANEL ASSEMBLY (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 70 FEED FLOW CONTROL PANEL ASSEMBLY 1 PAOZZ NASM35307 SCREW, CAP, HEX PAOZZ MS WASHER, FLAT PAOZZ MS NUT, SELF-LOCKING PBOZZ U5N SOLENOID ASSEMBLY PBOZZ U5N VALVE, SOLENOID (XV-912) PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT PAOZZ MS21044C3. NUT, SELF-LOCKING PAOZZ KMP GAGE, PRESSURE (PI-904) PAOZZ CONNECTOR, BULKHEAD PAOZZ VALVE, REGULATING (PRV-904) PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N PANEL PBOZZ U5N TRANSMITTER,PRESSURE PAOZZ SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT MOOZZ B4 1B TUBING, NONMETALLIC, MAKE FROM BULK 12 MATERIAL, NSN ,CUT TO LENGTH AS NEEDED 21 PAOZZ TEE, TUBE PAOZZ ELBOW, TUBE PAOZZ SWIVEL JOINT, PIPE PAOZZ ELBOW, PIPE PAOZZ TEE, TUBE PAOZZ B42XS4 VALVE, PLUG (V-914) PAOZZ U060L4A FERRULE, COMPRESSION... 3 (7) QTY END OF FIGURE /4 BLANK

250

251

252 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM AIR SYSTEM HOSES AND TUBING Figure 71. Air System Hoses BLANK / 2

253 GROUP 06 AIR SYSTEM AIR SYSTEM HOSES AND TUBING REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 71 AIR SYSTEM HOSES 1 PBOOO EYE3 SS-7R4TA4TA4-113 HOSE ASSEMBLY, NONMETALLIC PAOZZ SS-400-NFSET. FERRULE, BRAZING PAOZZ MS SS ADAPTER, STRAIGHT PAOZZ SS ADAPTER, STRAIGHT PAOZZ J514 ELBOW, PIPE TO TUBE PBOOO EYE3 SS-7R4TA4TA4-18 HOSE ASSEMBLY, NONMETALLIC PAOZZ SS-400-NFSET. FERRULE, BRAZING PBOOO EYE3 SS-7R6TA6TA6-84 HOSE ASSEMBLY, NONMETALLIC PAOZZ SS-600-NFSET. FERRULE, HANDLE PAOZZ SS ADAPTER, STRAIGHT MOOZZ PB-6 HOSE, NONMETALLIC, MAKE FROM 3 BULK MATERIAL, NSN CUT TO LENGTH AS NEEDED 12 MOOZZ PB-12 HOSE, NONMETALLIC, MAKE FROM BULK MATERIAL, NSN CUT TO LENGTH AS NEEDED 3 13 PAOZZ SS-8M0-6-4 UNION, PIPE PBOOO EYE3 SS-7R4TA4TA4-60 HOSE ASSEMBLY, NONMETALLIC PAOZZ SS-400-NFSET. FERRULE, BRAZING PAOZZ SS-400-R-6 REDUCER, TUBE...1 END OF FIGURE (7) QTY

254 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 06 AIR SYSTEM AIR SYSTEM HOSES AND TUBING FROM TO LENGTH Tee Item 5 Feed Flow Control Panel (Tee Bottom Corner) 114-in. Feed Flow Control Panel (Top Center) (3-15 psig air) Valve 202 (Port I) 186-in. Instrument Panel Port 401 Valve in. Instrument Panel Port 201 Valve in. Instrument Panel Port 402 Valve in. Instrument Panel Port 111 Valve in. Instrument Panel Port 112 Valve in. Instrument Panel Port 113 Valve in. Tee Item 5 (100 psig air) Valve 202 Positioner (Port S) 240-in. Valve 202 Positioner (Port C2) Valve 202 (Port A) 12-in. Valve 909 Tee Item 4 22-in. Tee Item 4 Instrument Panel Supply 3-in. Tee Item 5 Tee Item 4 88-in. Figure 72. Air System Tubing

255 GROUP 06 AIR SYSTEM AIR SYSTEM HOSES AND TUBING REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 06 AIR SYSTEM FIGURE 72 AIR SYSTEM TUBING 1 PAOZZ SWIVEL JOINT, PIPE MOOZZ 093B4 1B HOSE, NONMETALLIC, MAKE FROM BULK 12 MATERIAL, NSN CUT TO LENGTH AS NEEDED 3 MOOZZ 093B4 1A HOSE, NONMETALLIC, MAKE FROM BULK MATERIAL, NSN CUT TO LENGTH AS NEEDED 1 4 PBOZZ TEE, TUBE PBOZZ TEE, TUBE PAOZZ ELBOW, PIPE... 6 END OF FIGURE (7) QTY / 6 BLANK

256

257 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM OPERATION CONTROL AND POWER DISTRIBUTION SYSTEM Figure 73. Operation Control and Power Distribution System (Sheet 1 of 2)

258 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM OPERATION CONTROL AND POWER DISTRIBUTION SYSTEM Figure 73. Operation Control and Power Distribution System (Sheet 2 of 2)

259 GROUP 07 ELECTRICAL SYSTEM OPERATION CONTROL AND POWER DISTRIBUTION SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 73 OPERATION CONTROL AND POWER DISTRIBUTION SYSTEM 1 XCOOO 0U5N ELECTRICAL SUBSYSTEM. 1 2 XBOOO 0U5N OPERATION CONTROL SYSTEM PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK XBOOO 0U5N POWER DISTRIBUTION SYSTEM PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ CHASE NIPPLE, CONDUIT PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT XBOZZ 0U5N PLATE, REINFORCEMENT PAOZZ TDG3 R HANDLE, DOOR XBOZZ 0U5N SPACER GASKET, PDP XBOZZ 0U5N SPACER, PDP, OCP PAOZZ LOCKNUT, ELECTRICAL PAOZZ M45913/1-6CS3. NUT, SELF LOCKING... 6 (7) QTY END OF FIGURE /4 BLANK

260

261

262 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM OPERATION CONTROL SYSTEM Figure 74. Operation Control System BLANK / 2

263 GROUP 07 ELECTRICAL SYSTEM OPERATION CONTROL SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 74 OPERATION CONTROL SYSTEM 1 XBOOO 0U5N HINGE, PANEL PAOZZ M45913/1-4CS3. NUT, SELF LOCK PAOZZ MS WASHER, LOCK PAOZZ A535. SCREW, MACHINE PAOZZ MS SCREW, CAP PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOOO 0U5N TOP PANEL ASSY PAOZZ A610. THUMB SCREW XBOZZ 0U5N PANEL & SHIELD ASSY PAOZZ MS WASHER, LOCK PAOZZ Y3H NUT, SELF LOCKING XBOZZ 0U5N LEFT BRACKET ASSY PAOZZ MS SCREW, MACHINE PAOZZ A214. WASHER, SEALING PAOZZ MS WASHER, FLAT PAOZZ Y3H NUT, SELF LOCKING XBOZZ 0U5N TOP BRACKET ASSY PAOZZ Y3H NUT, SELF LOCKING PAOZZ MS WASHER, FLAT PAOZZ A214. WASHER, SEALING PAOZZ MS SCREW, CAP HEX HD XBOZZ 0U5N RIGHT BRACKET ASSY PAOZZ Y3H NUT, SELF LOCKING PAOZZ MS WASHER, FLAT PAOZZ A214. WASHER, SEALING PAOZZ MS SCREW, MACHINE XBOZZ 0U5N BOTTOM BRACKET ASSY PAOZZ Y3H NUT, SELF LOCKING PAOZZ MS WASHER, FLAT PAOZZ A214. WASHER, SEALING PAOZZ MS SCREW, CAP HEX HD XBOZZ 0U5N GASKET, PANEL, LEFT XBOZZ 0U5N GASKET, PANEL, TOP XBOZZ 0U5N GASKET, PANEL, RIGHT XBOZZ 0U5N GASKET, PANEL BOTTOM XBOOO 0U5N SUB-PANEL ASSY PAOZZ MS SCREW, HEX HEAD PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ TA7 VC2-1 VAPOR CAPSULE PAOOO U5N CABLE ASSEMBLY PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT PAOZZ Y3H NUT, SELF LOCKING... 4 (7) QTY

264 GROUP 07 ELECTRICAL SYSTEM OPERATION CONTROL SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 74 OPERATION CONTROL SYSTEM 46 PAOOO U5N CABLE ASSEMBLY PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT PAOZZ Y3H NUT, SELF LOCKING PAOZZ MS C COVER, ELECTRICAL CONNECTOR PAOZZ GASKET XBOOO 0U5N HARNESS, ISP PA0ZZ LOCKNUT, ELECTRICAL PAOZZ PACKING WITH RETAINER PAOZZ STB150. BOX CONNECTOR, ELECTRICAL XBOOO 0U5N HARNESS, CHEMICAL PUMPS PA0ZZ AA LOCKNUT, ELECTRICAL PXOIS 58 PAOZZ O-RING PAOZZ BOX CONNECTOR, ELECTRICAL... 1 END OF FIGURE (7) QTY

265

266 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM OPERATOR CONTROL TOP PANEL ASSEMBLY Figure 75. Top Panel Assembly BLANK / 2

267 GROUP 07 ELECTRICAL SYSTEM OPERATOR CONTROL TOP PANEL ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 75 TOP PANEL ASSEMBLY 1 PAOOO T50B2 METER, TIME TOTALIZING PAOZZ MS SCREW, MACHINE PAOZZ U5N SHIELDING GASKET PAOZZ MS WASHER, LOCK PAOZZ MS21044N06. NUT, SELF-LOCKING PAOOO T-PSH16A LIGHT, INDICATOR, AMBER PAOZZ U5N SHIELDING GASKET PAOZZ T-N122A. LENS, LIGHT, AMBER PAOZZ HO47 880T-N320A. LIGHT, PANEL, AMBER PAOOO T-PSH16R LIGHT, INDICATOR, RED PAOZZ T-N355R. LIGHT PANEL, RED PAOZZ T-N122R. LENS, LIGHT, RED PAOZZ U5N SHIELDING GASKET PAOOO CUB4L20 DISPLAY, OPTOELECTRONIC PAOZZ U5N SHIELDING GASKET PAOOO CUB4L020 DISPLAY, OPTOELECTRONIC PAOZZ U5N SHIELDING GASKET PAOZZ SC110M ALARM-MONITOR PAOOO T-J20A SWITCH, ROTARY PAOZZ U5N SHIELDING GASKET PAOOO KR3EH5 PUSH BUTTON PAOZZ U5N SHIELDING GASKET PAOOO K2105 RESISTOR, VARIABLE PAOZZ U5N SHIELDING GASKET PAOOO T-PBH16GD1 PUSH BUTTON PAOZZ U5N SHIELDING GASKET PAOOO E0736 SWITCH, ROTARY PAOZZ U5N SHIELDING GASKET PAOOO T-J17A SWITCH, ROTARY PAOZZ U5N SHIELDING GASKET PAOOO T-16HRH17KB6DX SWITCH, ROTARY PAOZZ U5N SHIELDING GASKET PAOZZ T-N60R. LIGHT, PANEL, RED PAOOO T-FXTPH16RA1 PUSH BUTTON PAOZZ T-N304R. LENS, LIGHT PAOZZ U5N SHIELDING GASKET PAOZZ T-N75R. LIGHT, PANEL, RED PAOOO T-PBH16RD2 PUSH BUTTON PAOZZ U5N SHIELDING GASKET PAOZZ AT432 KNOB, SWITCH PAOZZ TS3N SWITCH, ROTARY PAOZZ H-46-6A DIAL, CONTROL PAOZZ S POTENTIOMETER RESISTOR,... VARIABLE 1 (7) QTY

268 GROUP 07 ELECTRICAL SYSTEM OPERATOR CONTROL TOP PANEL ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 75 TOP PANEL ASSEMBLY 44 PAOOO T-PSH16G LIGHT, INDICATOR, GREEN PAOZZ U5N SHIELDING GASKET PAOZZ T-N122G. CAP, LENS, GREEN PAOZZ T-N355G. LIGHT, PANEL, GREEN XBOZZ 0U5N PANEL, OPERATOR... 1 (7) QTY END OF FIGURE

269 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM OPERATOR CONTROL SUB PANEL ASSEMBLY SEE SHEET 2 FOR BREAKDOWN Figure 76. Sub Panel Assembly (Sheet 1 of 2)

270 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM OPERATOR CONTROL SUB PANEL ASSEMBLY Figure 76. Sub Panel Assembly (Sheet 2 of 2)

271 GROUP 07 ELECTRICAL SYSTEM OPERATOR CONTROL SUB PANEL ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 76 SUB PANEL ASSEMBLY 1 PAOZZ U5N MEMORY MODULE,REV A... 1 PREPROGRAMMED FOR COMPOSITE BODY PUMP 1 PAOZZ U5N MEMORY MODULE., REV B. 1 PREPROGRAMED FOR METAL BODY PUMP 2 PAOZZ L532 COMPUTER DIGI SLC 5/ PAOZZ IA16 CIRCUIT CARD ASSEMBLY PAOZZ OW16 RELAY MODULE OUTPUT 16 PT PAOZZ AS TRIAC ELECTRONIC COMP ASSY PAOZZ N2 RACK CARD PAOZZ NO4I 4 PT ELECTRONIC COMP ASSY PAOZZ NI8 ELECTRONIC COMP ASSY 8 PT PAOZZ P4 POWER SUPPLY XCOZZ CHASSIS, 13 SLOT PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK XBOZZ 0U5N WIRE DUCT LID XBOZZ 0U5N WIRE DUCT TYP E IV PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N WIRE DUCT LID XBOZZ 0U5N WIRE DUCT TYP I PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ FAL TERMINAL, BOARD PAOZZ PS5R-E24 POWER SUPPLY, INSTRUMENTATION PAOZZ DU12 S281-Z4 CIRCUIT BREAKER PAOZZ F RELAY, SOLID STATE PAOZZ KRPA-14AN-120 RELAY, ELECTROMAGNETIC PAOZZ E892 SOCKET, PLUG-IN, ELEC COMP PAOZZ W1 FILTER, RADIO FREQUENCY PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N DIN RAIL TYP E II PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N WIRE DUCT LID XBOZZ 0U5N WIRE DUCT TYPE III PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ BNL-5 CLIP, END STRAP XBOZZ 0U5N DIN RAIL, TYP E I PAOZZ MS SCREW, MACHINE... 5 (7) QTY

272 GROUP 07 ELECTRICAL SYSTEM OPERATOR CONTROL SUB PANEL ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 76 SUB PANEL ASSEMBLY 45 PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N WIRE DUCT, TYP II PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N WIRE DUCT TYPE V PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ D-AH4002B HEATER, SPACE PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK XCOZZ 0U5N BACK PANEL SUB ASSY PAOZZ FAL TERMINAL, BOARD (DC) PAOZZ FAL TERMINAL, BOARD (AC) PAOZZ S894 P820W-2BK-ND RESISTOR, FIXED PAOZZ FAL COVER, TERMINAL PAOZZ KY1 KEY, SWITCH PAOZZ YPSC8 BASE, ELECTRIAL RELAY PAOZZ YTDML-120AL RELAY, ELECTRO MAGNETIC PAOZZ YNDS8 SOCKET, PLUG-IN ELEC... 1 (7) QTY END OF FIGURE

273

274 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM POWER DISTRIBUTION SYSTEM Figure 77. Power Distribution System (Sheet 1 of 3) BLANK / 2

275 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM POWER DISTRIBUTION SYSTEM Figure 77. Power Distribution System (Sheet 2 of 3)

276 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM POWER DISTRIBUTION SYSTEM TO GENERATOR TO AIR COMPRESSOR TO RO PUMP P TO HP PUMP P TO HP PUMP P TO TANK HEATER H TO TANK HEATER H1 Figure 77. Power Distribution System (Sheet 3 of 3)

277 GROUP 07 ELECTRICAL SYSTEM POWER DISTRIBUTION SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 77 POWER DISTRIBUTION SYSTEM 1 PAOZZ B395 MS3102E-16S-8S CONNECTOR, RECEPTACLE PAOZZ MS SCREW, MACHINE PAOZZ Y3H WASHER, FLAT PAOZZ MS21044N06. NUT, SELF LOCKING PAOZZ MS DA COVER, ELECTRICAL CONNECTOR PAOZZ A GASKET PAOZZ SWITCH, ROTARY PAOZZ U5N SHIELDING GASKET PAOZZ PLATE, WALL PAOZZ MS SCREW, MACHINE PAOZZ Y3H WASHER, FLAT PAOZZ MS21044N06. NUT, SELF LOCKING PAOZZ I CONNECTOR, RECEPTACLE PAOZZ MS SCREW, MACHINE PAOZZ Y3H WASHER, FLAT PAOZZ MS21044N06. NUT, SELF LOCKING PAOZZ T-H17A SWITCH, ROTARY PAOZZ U5N SHIELDING GASKET PAOZZ MS3102R16-10S CONNECTOR, RECEPTACLE PAOZZ MS SCREW, MACHINE PAOZZ Y3H WASHER, FLAT PAOZZ MS21044N06. NUT, SELF LOCKING PAOZZ K7VD-HM SWITCH, ROTARY PAOZZ MS3452W165-5S CONNECTOR, RECEPTACLE PAOZZ MS SCREW, MACHINE PAOZZ Y3H WASHER, FLAT PAOZZ MS21044N06. NUT, SELF LOCKING PAOZZ A GASKET PAOZZ MS3452W20-15S CONNECTOR, RECEPTACLE PAOZZ MS SCREW, MACHINE PAOZZ Y3H WASHER, FLAT PAOZZ MS21044N06. NUT, SELF LOCKING PAOZZ MS DA COVER, ELECTRICAL CONNECTOR PAOZZ A GASKET PAOZZ MS3102E-22-28S CONNECTOR, RECEPTACLE PAOZZ MS SCREW, MACHINE PAOZZ Y3H WASHER, FLAT PAOZZ MS21044N06. NUT, SELF LOCKING PAOZZ MS DA COVER, ELECTRICAL CONNECTOR PAOZZ MS3452W24-2S CONNECTOR, RECEPTACLE PAOZZ MS SCREW, MACHINE PAOZZ MS21044N06. NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT PAOZZ GASKET PAOZZ MS DA COVER, ELECTRICAL CONNECTOR... 1 (7) QTY

278 GROUP 07 ELECTRICAL SYSTEM POWER DISTRIBUTION SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 77 POWER DISTRIBUTION SYSTEM 46 PAOZZ MS3102E16S-6S CONNECTOR,RECEPTACLE PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT PAOZZ Y3H NUT, SELF LOCKING XBOOO 0U5N POWER DISTRIBUTION PANEL ASSY PAOZZ MS SCREW, HEX HEAD PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ TA7 VC2-1 VAPOR CAPSULE XBOOO 0U5N ENCLOSURE, ELECTRICAL XBOOO 0U5N ENCLOSURE, PDP XBOOO 0U5N POWER CABLE, PDP (ARMY) PAOZZ A-A III-RX-. LOCKNUT, ELECTRICAL S 59 PAOZZ PACKING WITH RETAINER PAOZZ BOX CONNECTOR, ELECTRICAL XBOOO 0U5N POWER CABLE, PDP (MARINE CORPS) PAOZZ LOCKNUT, ELECTRICAL PAOZZ SEALING RING PAOZZ BOX CONNECTOR, ELECTRICAL PAOZZ S SHIELDING GASKET, ELECTRONIC 1 66 PAOZZ 0U5N CONNECTOR ASSEMBLY PAOZZ MS SCREW, MACHINE PAOZZ Y3H WASHER, FLAT PAOZZ MS21044N06. NUT, SELF LOCKING PAOZZ MS CA COVER, RECEPTACLE XBOOO 0U5N CONDUIT HARNESS, AIR COMPRESSOR PAOZZ AA LOCKNUT, ELECTRICAL PX01S 73 PAOZZ O- RING PAOZZ STB BOX CONNECTOR, ELECTRICAL XBOZZ 0U5N CONDUIT HARNESS, RO PUMP P PAOZZ AA LOCKNUT, ELECTRICAL PX01S 77 PAOZZ O- RING PAOZZ BOX CONNECTOR, ELECTRICAL XBOZZ 0U5N CONDUIT HARNESS, HP PUMP P PAOZZ AA P-. LOCKNUT, ELECTRICAL S 81 PAOZZ PACKING WITH RETAINER PAOZZ BOX CONNECTOR, ELECTRICAL XBOZZ 0U5N CONDUIT HARNESS, HP PUMP P PAOZZ AA P-. LOCKNUT, ELECTRICAL S 85 PAOZZ PACKING WITH RETAINER PAOZZ BOX CONNECTOR, ELECTRICAL XBOZZ 0U5N CONDUIT HARNESS, TANK HEATER H PAOZZ AA P- 02-S. LOCKNUT, ELECTRICAL... 1 (7) QTY

279 GROUP 07 ELECTRICAL SYSTEM POWER DISTRIBUTION SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 77 POWER DISTRIBUTION SYSTEM 89 PAOZZ PACKING WITH RETAINER PAOZZ BOX CONNECTOR, ELECTRICAL XBOZZ 0U5N CONDUIT HARNESS, TANK HEATER H PAOZZ AA P-. LOCKNUT, ELECTRICAL S 93 PAOZZ PACKING WITH RETAINER PAOZZ BOX CONNECTOR, ELECTRICAL PAOZZ CIRCUIT BREAKER HANDLE STOP PLATE 1 END OF FIGURE (7) QTY /8 BLANK

280

281 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM POWER DISTRIBUTION PANEL Figure 78. Power Distribution Panel (Sheet 1 of 2)

282 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM POWER DISTRIBUTION PANEL Figure 78. Power Distribution Panel (Sheet 2 of 2)

283 GROUP 07 ELECTRICAL SYSTEM POWER DISTRIBUTION PANEL REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 78 POWER DISTRIBUTION PANEL 1 PAOZZ S203-D63 CIRCUIT BREAKER PAOZZ S2C-SH6R TRIPPER, CIRCUIT BREAKER PAOZZ S203-D16 CIRCUIT BREAKER PAOZZ F204AC-25/0.3 CIRCUIT BREAKER PAOZZ S203-D20 CIRCUIT BREAKER PAOZZ S203-D10 CIRCUIT BREAKER PAOZZ BNL-5 CLIP, END, STRAP XBOZZ 0U5N DIN RAIL TYPE II PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ F202AC-25/0.3 CIRCUIT BREAKER PAOZZ S202-C16 CIRCUIT BREAKER PAOZZ S203-C25 CIRCUIT BREAKER PAOZZ RV5/250 ABSORBER, OVERVOLTAGE PAOZZ A COIL, ELECTRICAL PAOZZ A COIL, ELECTRICAL PAOZZ S201-C8 CIRCUIT BREAKER PAOZZ S201-C4 CIRCUIT BREAKER PAOZZ S202-D4 CIRCUIT BREAKER PAOZZ S201-C2 CIRCUIT BREAKER XBOZZ 0U5N DIN RAIL TYPE IV PAOZZ MS SCREW, MACH INE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ S202-D6 CIRCUIT BREAKER PAOZZ TA25DU8.5 RELAY, THERMAL PAOZZ TA25DU6.5 CIRCUIT BREAKER PAOZZ A CONTACTOR, MAGNETIC PAOZZ TA24DU14 CIRCUIT BREAKER PAOZZ TA42DU42 CIRCUIT BREAKER XBOZZ 0U5N DIN RAIL TYPE III PAOZZ MS SCREW, MACH INE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ SZ-KS18/56N/3 WIRING BRIDGE JUMPER XBOZZ SZ-KS18/56N/2 WIRING BRIDGE JUMPER PAOZZ Y407 OVR40-320D-440P ARRESTOR, ELECTRICAL SURGE XBOZZ 0U5N DIN RAIL TYPE I PAOZZ MS SCREW, MACH INE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N WIRE DUCT N,TYP II PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT... 5 (7) QTY

284 GROUP 07 ELECTRICAL SYSTEM POWER DISTRIBUTION PANEL REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGE C (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 78 POWER DISTRIBUTION PANEL 47 XBOZZ 0U5N WIRE DUCT LID PAOZZ K5VD-M SWITCH, ROTARY PAOZZ U5N SHAFT, SHOULDERED PAOZZ S3N125TW THERMAL RELEASE, CIRCUIT BREAKER XBOZZ 0U5N WIRE DUCT W, TYP II PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N WIRE DUCT LID XBOZZ 3WCG DISTRIBUTION BLOCK PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE XBOZZ 3WCG DISTRIBUTION BLOCK PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PAOZZ R505 XT40-3Y201 ARRESTOR, ELECTRICAL SURGE PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK XBOZZ 0U5N WIRE DUCT LID XBOZZ 0U5N WIRE DUCT, N TYPE III PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ T41.5K1 TRANSFORMER, POWER PAOZZ NUT, PLAIN, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N WIRE DUCT W, TYP I PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N WIRE DUCT LID XBOZZ 0U5N WIRE DUCT N, TYPE PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N WIRE DUCT LID PAOZZ PK15GTA TERMINAL BOARD 2 85 PAOZZ SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS21044C08. NUT, SELF LOCKING XBOZZ 3WCG COVER (WITH 2 SCREWS), DIST BLOCK XBOZZ 3WCG COVER (WITH 2 SCREWS), DIST BLOCK XBOZZ 0U5N BACK PANEL, SUB ASSY... 1 (7) QTY END OF FIGURE

285

286 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 07 ELECTRICAL SYSTEM POWER CABLES TO RW PUMP P TO RW PUMP P TO MF FEED PUMP P TO DISTRIBUTION PUMP P TO DISTRIBUTION PUMP P-8 Figure 79. Power Cables BLANK / 2

287 GROUP 07 ELECTRICAL SYSTEM POWER CABLES REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 79 POWER CABLES 1 PBOOO U5N POWER CABLE, RW PUMP PAOZZ MS3452W16S-5P. CONNECTOR, RECEPTACLE PAOZZ CAP-PLUG PAOZZ BS002B1508A4A. BACKSHELL PAOZZ MS3106F16S-5S. CONNECTOR PBOOO U5N POWER CABLE, RW PUMP PAOZZ MS3456W20-15P. CONNECTOR PAOZZ CAP-PLUG PAOZZ BS002B1712A6A. BACKSHELL PAOZZ BA002B1712AA. ADAPTER BUSHING PAOZZ MS3456W20-15S. CONNECTOR PBOOO U5N POWER CABLE, MF PUMP PAOZZ MS3106F22-28P. CONNECTOR, PLUG PAOZZ CAP-PLUG PAOZZ BA002B2012AA. ADAPTER BUSHING PAOZZ BS002B2012A6A. BACKSHELL PAOZZ MS3106E22-28S. CONNECTOR, RECEPTACLE PBOOO U5N POWER CABLE, DIST PUMP, ELECTRIC PAOZZ MS3456W24-2P. CONNECTOR PAOZZ CAP-PLUG PAOZZ BS002B2112A6A. BACKSHELL PAOZZ BA002B2112AA. ADAPTER BUSHING PAOZZ MS3456W24-2S. CONNECTOR PBOOO U5N POWER CABLE, DIST PUMP, DIESEL PAOZZ MS3456W16S-6P. CONNECTOR, PLUG PAOZZ CAP-PLUG PAOZZ BS002B1508A4A. BACKSHELL PAOZZ MS3456W16S-6S. CONNECTOR, PLUG... 1 (7) QTY END OF FIGURE / 4 BLANK

288

289

290 TACTICAL WATER PURIFICATION SYSTEM GROUP 07 ELECTRICAL SYSTEM INSTRUMENT / SOLENOID PANEL Figure 80. Instrument / Solenoid Panel Installation BLANK / 2

291 GROUP 07 ELECTRICAL SYSTEM INSTRUMENT / SOLENOID PANEL REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 80 INSTRUMENT/SOLENOID PANEL INSTALLATION 1 XBOOO 0U5N ISP ASSEMBLY PAOZZ MS WASHER, FLAT PAOZZ M45913/1-4 CS3. NUT, SELF-LOCKING PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, CAP, HEX... 4 (7) QTY END OF FIGURE

292 TACTICAL WATER PURIFICATION SYSTEM GROUP 07 ELECTRICAL SYSTEM INSTRUMENT / SOLENOID PANEL PLACES PLACES PLACE Figure 81. Instrument / Solenoid Panel (Sheet 1 of 3)

293 TACTICAL WATER PURIFICATION SYSTEM GROUP 07 ELECTRICAL SYSTEM INSTRUMENT / SOLENOID PANEL CABLE FROM CONDUCTIVITY SENSOR CE-501A CABLE FROM FLOW SENSOR FE-102 CABLE FROM FLOW SENSOR FE CABLE FROM CONDUCTIVITY SENSOR CE-501B CABLE FROM FLOW SENSOR FE-401 CABLE FROM OCP TO TRANSDUCER PT TO TRANSDUCER PT-101 CABLE FROM TRANSDUCER PT TO I/P TRANSDUCER FY TO TRANSDUCER PT-101 TO PRESSURE SWITCH PSL-901 TO SOLENOID XV-901 TO SOLENOID XV TO TRANSDUCER PT-302 TO TEMP TRANSMITTER TT-201 TO TEMP SWITCH TSH-901 TO SOLENOID XV-902 TO SOLENOID XV TO SOLENOID XV-910 TO SOLENOID XV-912 Figure 81. Instrument / Solenoid Panel (Sheet 2 of 3)

294 TACTICAL WATER PURIFICATION SYSTEM GROUP 07 ELECTRICAL SYSTEM INSTRUMENT / SOLENOID PANEL Figure 81. Instrument / Solenoid Panel (Sheet 3 of 3)

295 GROUP 07 ELECTRICAL SYSTEM INSTRUMENT / SOLENOID PANEL REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 81 INSTRUMENT / SOLENOID PANEL 1 PAOOO CB192-SG BOX CONNECTOR, ELECTRICAL PAOZZ O-RING PAOZZ LOCKNUT, ELECTRICAL PAO STB38 BOX CONNECTOR, ELECTRICAL PAOZZ TDG3 R HANDLE, DOOR XBOOO 0U5N ELECTRICAL ENCLOSURE PAOZZ BOX CONNECTOR, ELECTRICAL PAOZZ HT ADAPTER, STRAIGHT PAOZZ HT ADAPTER, STRAIGHT XBOZZ 0U5N CONDUIT ASSEMBLY XBOZZ 0U5N CABLE ASSEMBLY, TRANSDUCER PT XBOZZ 0U5N CONDUIT ASSEMBLY XBOZZ 0U5N CABLE ASSEMBLY, TRANSDUCER PT XBOZZ 0U5N CONDUIT ASSEMBLY XBOZZ 0U5N CABLE ASSEMBLY, TRANSDUCER PT XBOZZ 0U5N CABLE ASSEMBLY, TEMP TRANS TT XBOZZ 0U5N CABLE ASSEMBLY, TEMP SWITCH TSH XBOZZ 0U5N CABLE ASSEMBLY, SOLENOID XV XBOZZ 0U5N CABLE ASSEMBLY, SOLENOID XV XBOZZ 0U5N CABLE ASSEMBLY, SOLENOID XV XBOZZ 0U5N CABLE ASSEMBLY, SOLENOID XV XBOZZ 0U5N CABLE ASSEMBLY, SOLENOID XV XBOZZ 0U5N CABLE ASSEMBLY, SOLENOID XV XBOZZ 0U5N CABLE ASSEMBLY, PRESSURE SW PSL XBOZZ 0U5N CABLE ASSEMBLY, TRANSDUCER FY XBOZZ 0U5N CABLE ASSEMBLY, TRANSDUCER PT PAOZZ MS D SWITCH, TOGGLE PAOZZ AT215 PLATE, WALL PAOZZ C33AINN ANALYZER PAOZZ PRO-F3A1N TRANSMITTER, RATE OF FLOW. 3 (7) QTY END OF FIGURE

296 TACTICAL WATER PURIFICATION SYSTEM GROUP 07 ELECTRICAL SYSTEM INSTRUMENT / SOLENOID PANEL Figure 82. Solenoid Panel

297 GROUP 07 ELECTRICAL SYSTEM INSTRUMENT / SOLENOID PANEL REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 07 ELECTRICAL SYSTEM FIGURE 82 SOLENOID PANEL 1 XBOOO 0U5N ISP SUB PANEL PAOOO U5N VALVE, LINEAR PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PBOZZ SWIVEL JOINT, PIPE PBOZZ SWING JOINT, PIPE TO TUBE PBOZZ A-13-00A-DM-.. VALVE, SOLENOID... 6 DJAA-1BA 9 PBOZZ DM-DJAA-1BA... SOLENOID, ELECTRICAL XBOZZ 4H336 1B TUBING, NYLON, 250 PS XBOZZ 4H336 1A TUBING, NYLON, 220 PS XBOZZ 0U5N WIRE DUCT PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE XBOZZ 0U5N LID, WIRE DUCT XBOZZ 0U5N LID, WIRE DUCT XBOOO 0U5N WIRE DUCT PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE XBOOO 0U5N DIN RAIL PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ Ms SCREW, MACHINE PAOZZ FAL COVER, TERMINAL PAOZZ FAL TERMINAL, BOARD (DC) PAOZZ FAL TERMINAL, GROUND PAOZZ FAL TERMINAL, BOARD (AC) END OF FIGURE (7) QTY / 10 BLANK

298

299

300 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 08 SKID TWPS SKID B Reverse View 25 A Reverse View B 9 A Figure 83. Marine Corps TWPS Skid BLANK / 2

301 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 08 SKID ASSEMBLY REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 08 SKID FIGURE 83 MARINE CORPS TWPS SKID 1 XBOFF 0U5N SKID ASSEMBLY XBOZZ 0U5N ROOF, OPERATION STATION PAOZZ A460. PIN, QUICK RELEASE PAOZZ U5N PAD, CUSHIONING PAOFF U5N BEAM,STRUCTURAL PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, CAP, HEX XBOFF 0U5N FRAME XBOFF 0U5N END SECTION PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, CAP, HEX PAOZZ MS SCREW, CAP, HEX PAOZZ M45913/1-6CS3.. NUT, SELF-LOCKING XBOFF 0U5N END SECTION PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ M45913/1-6CS3.. NUT, SELF-LOCKING PAOZZ MS SCREW, CAP, HEX XBOZZ 0U5N CHAIN, TRANSPORT XBOZZ 0U5N CHAIN, TRANSPORT XBOZZ 0U5N TIEDOWN PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, FLAT PAOZZ UGP NUT, SELF-LOCKING, HEX XBOZZ 0U5N TIEDOWN 1 30 PAOZZ UGP NUT, SELF-LOCKING, HEX PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, CAP, HEX... 2 (7) QTY END OF FIGURE

302 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 08 SKID TWPS SKID Figure 84. Army TWPS Skid Assembly

303 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 08 SKID ASSEMBLY REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 08 SKID FIGURE 84 ARMY TWPS SKID ASSEMBLY 1 XBOFF 0U5N SKID ASSEMBLY PBOFF U5N BEAM, STRUCTURAL PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, CAP, HEX XBOFF 0U5N FRAME XBOFF 0U5N END SECTION PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, CAP, HEX PAOZZ MS SCREW, CAP, HEX PAOZZ M45913/1-6CS3.. NUT, SELF-LOCKING XBOFF 0U5N END SECTION PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ M45913/1-6CS3.. NUT, SELF-LOCKING PAOZZ MS SCREW, CAP, HEX... 2 (7) QTY END OF FIGURE / 6 BLANK

304

305

306 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 09 NBC SYSTEM NBC TANK Figure 85. NBC Tank BLANK / 2

307 GROUP 09 NBC SYSTEM NBC TANK REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 09 NBC SYSTEM FIGURE 85 NBC TANK 1 PBOOO EXU3 732-D ASSY, NBC TANK PAOZZ V-FDAPOLY. CAP, PROTECTIVE PAOZZ F-FDAPOLY. ADAPTER, STRAIGHT PAOZZ EXU ELBOW, PIPE PAOZZ EXU GASKET PA0ZZ EXU CLAMP, SYNCHRO PAOZZ EXU O-RING PAOZZ K73. PLUG, PROTECTIVE PAOZZ EXU CLAMP, LOOP PAOZZ PIPE, METALLIC PAOZZ B-PDAPOLY. ADAPTER, STRAIGHT PAOZZ W-FDAPOLY. PLUG, PROTECTIVE,DUST AND MOISTU 1 13 PAOZZ EXU BOLT, U PAOZZ MS NUT, PLAIN, HEX PBOOO U5N HOSE ASSY, NONMETALLIC PBOZZ A6H1 N-CPL. ADAPTER, STRAIGHT MOOZZ TUBING, NONMETALLIC, MAKE FROM 1 BULK MATERIAL NSN , CUT TO LENGTH AS NEEDED 18 PBOOO VALVE, STOP-CHECK PAOZZ WASHER, FLAT... 1 (PART OF KIT PN RPM/ ) 20 PAOZZ BALL, CHECK... 1 (PART OF KIT PN RPM/ ) 21 PAOZZ SPRING, HELICAL, COMPRESSION... (PART OF KIT PN RPM/ ) 1 22 PAOZZ O-RING (PART OF KIT PN RPM/ ) XBOZZ 0U5N BRACKET PAOZZ MS BOLT, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N BLOCK, SPACER... 2 PAOZZ RPM/ KIT, REPAIR BALL, CHECK (1) O-RING (1) 21...SPRING, COMPRESSION (1) WASHER, FLAT (1) 18 (7) QTY END OF FIGURE / 4 BLANK

308

309 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 10 NBC SURVIVABILITY SYSTEM NBC SURVIVABILITY SYSTEM THERE ARE NO REPARABLE COMPONENTS IN THE NBC SURVIVABILITY SYSTEM /2 BLANK

310

311

312 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 11 COLD WEATHER SYSTEM SPACE HEATER Figure 86. Space Heater BLANK / 2

313 GROUP 11 COLD WEATHER SYSTEM SPACE HEATER REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 11 COLD WEATHER SYSTEM FIGURE 86 SPACE HEATER 1 PBOZZ CAH SWITCH, THERMOSTATIC XBOZZ CAH-EUR FAN XBOOO B-200 ASSEMBLY, BURNER HEAD PBOZZ B-201. NOZZLE, OIL BURNER PBOZZ B-202. WASHER, FLAT PBOZZ B-203. SPRING, HELICAL PBOZZ B-207. SPARK PLUG PAOZZ A353. SCREW, SELF-DRILLING PBOZZ CAH SWITCH, OPTOELECTRONIC PBOZZ CAH FILTER, FUEL PBOZZ M-103 FILTER ELEMENT, OUTPUT AIR PBOZZ M-104 FILTER ELEMENT, INTAKE AIR PBOOO MOTOR, DIRECT CURRENT PAOZZ CAH-139 (D). NUT, SELF-LOCKING, HEX PBOOO CAH TRANSFORMER (WITH SPARK PLUG WIRE) PAOZZ MS SCREW, MACHINE PAOZZ MS SCREW, MACHINE PBOZZ CAH-114 (D) RELAY ASSEMBLY PBOZZ CAH VALVE, SAFETY RELIEF PAOZZ MS SCREW, MACHINE PBOOO CAH SWITCH, THERMOSTATIC PAOZZ MS SCREW, MACHINE PBOZZ CAH CABLE ASSEMBLY, SPECIAL PURPOSE PBOZZ CAH-132 PIPE, AIR-COND.-HEATING PAOZZ CAH-139 NUT, SELF-LOCKING, HEX PAOZZ CAH WASHER, FLAT PAOZZ CAH SCREW, CAP, HEX PAOZZ MS SCREW, MACHINE PBOOO CONTROL BOX, ELECTRICAL PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT PBOZZ CAP, PROTECTIVE... 1 (7) QTY END OF FIGURE / 4 BLANK

314

315

316 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 11 COLD WEATHER SYSTEM GENERAL PURPOSE TRANSFORMER Figure 87. General Purpose Transformer BLANK / 2

317 GROUP 11 COLD WEATHER SYSTEM GENERAL PURPOSE TRANSFORMER REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 11 COLD WEATHER SYSTEM FIGURE 87 GENERAL PURPOSE TRANSFORMER 1 PAOZZ U5N COVER, ACCESS PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT MOOZZ K12 RUBBER STRIP... 4 (MAKE FROM BULK MATERIAL. CUT TO LENGTH AS NEEDED) 5 XBOZZ 0U5N ENCLOSURE, TRANSFORMER PAOZZ 05NM0 TF S TRANSFORMER, CURRENT PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT PAOZZ M45913/1-4CS3. NUT, SELF LOCKING PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT PAOZZ MS20365-C1032A. NUT, SELF LOCKING PAOZZ AA PX01S LOCKNUT, ELECTRICAL PAOZZ BBU50 BUSHING, ELECTRICAL PAOZZ CHASE NIPPLE, CONDUIT PAOZZ SEALING RING PAOZZ BOX CONNECTOR, ELECTRICAL PAOZZ PN18-10R TERMINAL, LUG PAOZZ SPLICE, CONDUCTOR PAOZZ MS CA COVER, ELECTRICAL CONNECTOR PAOZZ MS3116J12-3P CONNECTOR, PLUG, ELECTRICAL XBOZZ SOOW 18/3 CABLE, ELECTRICAL PAOZZ U5N CABLE ASSEMBLY,SPECIAL PURPOSE 1 24 PAOZZ PN-10-10R-L TERMINAL, LUG PAOZZ MS SCREW, MACHINE... 1 (7) QTY END OF FIGURE / 4 BLANK

318

319

320 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 11 COLD WEATHER SYSTEM ICE INTAKE STRAINER AND HEATING BLANKETS , 4, 5, 6, 7, 8, 9, 10, 11, 12, 13, 14, 15 16, 17 Figure 88. Ice Intake Strainer and Heating Blankets BLANK / 2

321 GROUP 11 COLD WEATHER SYSTEM ICE INTAKE STRAINER AND HEATING BLANKETS REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 11 COLD WEATHER SYSTEM FIGURE 88 ICE INTAKE STRAINER AND HEATING BLANKETS 1 PBOOO U5N STRAINER, SEDIMENT PAOZZ NW7. GASKET PBOOO U5N HEATING BLANKET, ELECTRICAL (F01-1) PBOOO U5N HEATING BLANKET, ELECTRICAL (F03-1) PBOOO U5N HEATING BLANKET, ELECTRICAL (F03-2) PBOOO U5N HEATING BLANKET, ELECTRICAL (F12) PBOOO U5N HEATING BLANKET, ELECTRICAL (F07) PBOOO U5N HEATING BLANKET, ELECTRICAL (P02) PBOOO U5N HEATING BLANKET, ELECTRICAL (P03-1).. 2 (A-TWPS) 10 PBOOO U5N HEATING BLANKET, ELECTRICAL (P03-1).. 1 (MC-TWPS) 11 PBOOO U5N HEATING BLANKET, ELECTRICAL (P03-2).. 1 (A-TWPS) 12 PBOOO U5N HEATING BLANKET, ELECTRICAL (P04)... 2 (A-TWPS) 13 PBOOO U5N HEATING BLANKET, ELECTRICAL (P04)... 1 (MC-TWPS) 14 PBOOO U5N HEATING BLANKET, ELECTRICAL (P05)... 4 (A-TWPS) 15 PBOOO U5N HEATING BLANKET, ELECTRICAL (P05)... (MC-TWPS) 2 16 PBOOO U5N HEATING BLANKET, ELECTRICAL (F01-2) PBOOO U5N HEAT BLANKET ASSEMBLY (A-02) PAOZZ D253-1AL INSULATION SLEEVING... 1 (ALL HEATING BLANKETS) 19 PAOZZ BS002B1404A BACKSHELL, ELECTRICAL CONNECTOR... 1 (ALL HEATING BLANKETS) 20 PAOZZ MS3456W14S7P CONNECTOR, PLUG... 1 (ALL HEATING BLANKETS) 21 PAOZZ CAP-PLUG, PROTECTIVE... 1 (ALL HEATING BLANKETS) 22 PAOZZ CAP-PLUG, PROTECTIVE... 1 (FO1-2 AND A-02 HEATING BLANKETS ONLY) 23 PAOZZ MS3451W14S-7S CONNECTOR, PLUG... (FO1-2 AND A-02 HEATING BLANKETS ONLY) 1 END OF FIGURE (7) QTY / 4 BLANK

322

323

324 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 12 CLEANING WASTE STORAGE SYSTEM ADAPTORS Figure 89. Cleaning Waste Storage System Adaptors BLANK / 2

325 GROUP 12 CLEANING WASTE STORAGE SYSTEM ADAPTORS REPAIR PARTS LIST ) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 12 CLEANING WASTE STORAGE SYSTEM FIGURE 89 CLEANING WASTE STORAGE SYSTEM ADAPTORS 1 PBOOO U5N VALVE, FLOW CONTROL A PAOZZ A-FDAPOLY. COUPLING HALF, SELF-SEALING PAOZZ PHN1 887C-030. NIPPLE, PIPE PBOZZ PHN VALVE, BALL PAOOO D-FDAPOLY. COUPLING HALF, QUICK DISCONNECT PAOZZ NW5.. GASKET PBOZZ NUA7 01.5K-ZT-TNK TANK, FABRIC, COLLAPSIBLE... 1 (7) QTY END OF FIGURE / 4 BLANK

326

327

328 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 13 OCEAN INTAKE STRUCTURE SYSTEM HOSE ASSEMBLIES AND FITTINGS , Figure 90. Hose Assemblies and Fittings BLANK / 2

329 GROUP 13 OCEAN INTAKE STRUCTURE SYSTEM HOSE ASSEMBLIES AND FITTINGS REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 13 OCEAN INTAKE STRUCTURE SYSTEM FIGURE 90 HOSE ASSEMBLIES AND FITTINGS 1 PBOZZ EXU CPVC PIPE ASSY... 4 (WELLPOINT AND BACKWASH VALVE) 2 PBOZZ EXU COUPLING, PIPE PBOZZ EXU NIPPLE, PIPE (60-IN. RISER) PBOZZ EXU NIPPLE, PIPE (24-IN. RISER) PBOOO EXU ELBOW PIPE ASSY PAOZZ NW5. GASKET, 2-IN PBOOO EXU TEE, PIPE TO HOSE PAOZZ NW5. GASKET, 2-IN PBOOO EXU TEE, PIPE TO HOSE PAOZZ NW7. GASKET, 3-IN PBOOO EXU COUPLING ASSEMBLY, HOSE PAOZZ NW5. GASKET, 2-IN (7) QTY END OF FIGURE / 4 BLANK

330

331

332 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 14 EXTENDED DISTRIBUTION SYSTEM EXTENDED DISTRIBUTION SYSTEM Figure 91. Extended Distribution System BLANK / 2

333 GROUP 14 EXTENDED DISTRIBUTION SYSTEM EXTENDED DISTRIBUTION SYSTEM REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 14 EXTENDED DISTRIBUTION SYSTEM FIGURE 91 EXTENDED DISTRIBUTION SYSTEM 1 PBOOO U5N ASSY, ADAPTOR A PBOOO NUA7 03K-ZT-TNK-A TANK, WATER, 3000 GAL PBOOO U5N ASSY, HOSE P PBOFF U5N ASSY, PUMP P PBOOO U5N ASSY, NOZZLE PBOOO U5N ASSY, HOSE P PBOOO U5N ASSY, HOSE P PBOOO U5N ASSY, ADAPTOR A PBOOO U5N ASSY, ADAPTOR A (7) QTY END OF FIGURE / 4 BLANK

334

335

336 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 14 EXTENDED DISTRIBUTION SYSTEM HOSE ASSEMBLIES AND ADAPTORS Figure 92. Extended Distribution System Hose Assemblies and Adaptors BLANK / 2

337 GROUP 14 EXTENDED DISTRIBUTION SYSTEM HOSE ASSEMBLIES AND ADAPTORS REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 14 EXTENDED DISTRIBUTION SYSTEM FIGURE 92 EXTENDED DISTRIBUTION SYSTEM HOSE ASSEMBLIES AND ADAPTORS 1 PBOOO U5N ASSY, NOZZLE PAOZZ W-FDAPOLY. PLUG, PROTECTIVE PAOZZ NW5. GASKET PAOZZ CAP, PROTECTIVE PBOOO U5N ASSY, ADAPTOR A PAOZZ W-FDAPOLY. PLUG, PROTECTIVE PAOZZ NW5. GASKET PBOOO U5N ASSY, HOSE P PAOOO V-FDAPOLY. CAP, PROTECTIVE PAOZZ NW5.. GASKET PBOOO U5N ASSY, HOSE P PAOZZ W-FDAPOLY. PLUG, PROTECTIVE PAOZZ NW5. GASKET PBOOO U5N ASSY, ADAPTOR A PAOOO V-FDAPOLY. CAP, PROTECTIVE PAOZZ NW5.. GASKET PAOZZ A-FDAPOLY. COUPLING HALF, SELF-SEALING PAOZZ PHN C. BUSHING, PIPE PAOZZ PHN1 886C-020. NIPPLE, PIPE PBOZZ PHN VALVE, BALL PAOZZ A-FDAPOLY. ADAPTER, STRAIGHT PAOZZ NW4. GASKET PAOOO V-FDAPOLY. CAP, PROTECTIVE PBOOO U5N ASSY, ADAPTOR A PAOOO V-FDAPOLY. CAP, PROTECTIVE PAOZZ NW5.. GASKET PAOZZ F-FDAPOLY. COUPLING HALF PBOZZ PHN VALVE, BALL PAOZZ PHN1 887C-025. NIPPLE, PIPE PAOZZ PHN1 805C-020. TEE, PIPE PAOZZ PHN1 887C-030. NIPPLE, PIPE PAOOO D-FDAPOLY. COUPLING HALF PAOZZ W-FDAPOLY. PLUG, PROTECTIVE PBOOO U5N ASSY, HOSE P PAOOO V-FDAPOLY. CAP, PROTECTIVE PAOZZ NW5.. GASKET... 1 (7) QTY END OF FIGURE / 4 BLANK

338

339

340 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P A , 17, 18, 19, 20, A Reverse View Figure 93. Diesel Engine Pump Assembly P BLANK / 2

341 GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-8 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGE C (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 14 EXTENDED DISTRIBUTION SYSTEM FIGURE 93 DIESEL ENGINE PUMP ASSEMBLY P-8 1 PBOFF AK42 L48EE-DE-SFA ENGINE, DIESEL PAOZZ A628. SCREW, CAP, HEX PAOZZ WASHER, LOCK PAOZZ MS WASHER, FLAT MOOZZ HOSE, NON-METALLIC, MAKE FROM BULK 2 MATERIAL,NSN , CUT TO LENGTH 18 INCHES 6 PBOOO U5N TANK UNIT, FUEL DISPENSING PBOFF U5N FRAME PBOOO PUMP, CENTRIFUGAL PBOOO U5N HOUSING, FUEL PUMP PAOZZ NASM SCREW, CAP, HEX PAOZZ A029. WASHER, SEAL PAOZZ A029. O-RING XBOZZ 0U5N ENCLOSURE, ELECTRICAL PAOZZ PA87. BOOT, DUST AND MOISTURE PAOZZ MS SWITCH, TOGGLE PAOZZ MS3452W14S-7S. CONNECTOR, RECEPTACLE PAOZZ GASKET PAOZZ MS DA.. COVER, ELECTRICAL CONNECTOR PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PAOZZ MS SCREW, MACHINE PAOZZ AA LOCKNUT, ELECTRICAL PX01S 23 PAOZZ O-RING PAOZZ BOX CONNECTOR, ELECTRICAL PBOZZ U5N CABLE ASSEMBLY, POWER PAOZZ MS3452W16S-6P. CONNECTOR, RECEPTACLE PAOZZ A GASKET PAOZZ MS DA.. COVER, ELECTRICAL CONNECTOR PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, MACHINE PAOZZ N6NY-006C-0-M CLAMP, LOOP PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ T14 BOLT, EYE PAOZZ MS WASHER, LOCK PAOZZ E NUT, PLAIN, HEX PAOZZ MS WASHER, FLAT PAOZZ WASHER, LOCK... 1 END OF FIGURE (7) QTY

342 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 94. Fuel Tank Assembly

343 GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-8 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 14 EXTENDED DISTRIBUTION SYSTEM FIGURE 94 FUEL TANK ASSEMBLY 1 PBOOO U5N TANK, FUEL, ENGINE PBOZZ AK CAP, FILLER OPENING PAOZZ AK FILTER, GAS PAOZZ AK GASKET PAOZZ AK PLUG, EXPANSION (DRAIN) PAOZZ AK O-RING PAOZZ AK FILTER ELEMENT PAOZZ MS WASHER, FLAT PAOZZ A530. WASHER, LOCK PAOZZ A318. SCREW, MACHINE PAOZZ AK O-RING PAOZZ AK COCK, SHUTOFF PBOOO U5N HOSE ASSY, RETURN PAOZZ CLAMP, HOSE MOOZZ K19-YEL. TUBING, HEAT SHRINK,MAKE FROM BULK 1 MATERIAL, NSN , CUT TO LENGTH 0.1 FT 16 MOOZZ HOSE, NONMETALLIC,MAKE FROM BULK 1 MATERIAL, NSN , CUT TO LENGTH 3 INCHES 17 PAOZZ PLCD22004V. COUPLING HALF, MALE PBOOO U5N HOSE ASSY, SUPPLY PAOZZ CLAMP, HOSE MOOZZ K19-RED. TUBING, HEAT SHRINK,MAKE FROM 1 BULK MATERIAL, NSN , CUT TO LENGTH 0.1 FT 21 MOOZZ HOSE, NONMETALLIC, MAKE FROM BULK 1 MATERIAL, NSN , CUT TO LENGTH 5.3 IN. 22 PAOZZ PLCD17006V. COUPLING HALF, FEMALE XBOZZ 0U5N FRAME, TANK, END XBOZZ 0U5N FRAME, TANK, BACK PAOZZ MS WASHER, FLAT PAOZZ MS WASHER, LOCK PAOZZ MS SCREW, CAP, HEX PAOZZ AK NUT, PLAIN, HEX... 2 END OF FIGURE (7) QTY

344 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 95. P-8 Centrifugal Pump

345 GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-8 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 14 EXTENDED DISTRIBUTION SYSTEM FIGURE 95 P-8 CENTRIFUGAL PUMP 1 KFOZZ C31796 SEAL ASSEMBLY, SHAFT... 1 (PART OF KITS P/Ns AND 33636) 2 PAOZZ A322 SCREW, CAP, HEX PAOZZ A429 WASHER, LOCK PAOZZ A190 WASHER, FLAT KFOZZ C33592 HUB, BODY... 1 (PART OF KITS P/Ns and 33636) 6 KFOZZ C22294 IMPELLER, PUMP (PART OF KIT P/N 33636) KFOZZ GASKET... 1 (PART OF KITS P/Ns AND 33636) 8 KFOZZ C21249 SCREW, MACHINE (PART OF KIT P/N 33636). 2 9 KFOZZ C27978 PLATE, WEAR, ROTARY PUMP... 1 (PART OF KIT P/N 33636) 10 PAOZZ U5N7 755MFZ1 VALVE, PLUG KFOZZ GASKET (PART OF KIT P/N 33636) PAOOO V-FDAPOLY CAP, PROTECTIVE PAOZZ NW5. GASKET PAOZZ F-SS COUPLING HALF PAOZZ C51 CHAIN, WELDLESS PAOZZ GASKET PAOZZ VALVE FLAPPER, PUMP PBOZZ CLAMP, SYNCHRO PAOZZ NUT, PLAIN, HEX PAOZZ STUD, PLAIN PAOZZ SCREW, CAP, HEX PAOZZ WASHER, LOCK KFOZZ NUT, SELF-LOCKING, CAP... (PART OF KIT P/N 33636) 2 PBOZZ KIT, SEAL REPAIR GASKET (1) 7...SEAL ASSEMBLY, SHAFT (1) 1...HUB, BODY (1) 5 PBOZZ KIT, PUMP OVERHAUL GASKET (1) 7...GASKET (2) IMPELLER, PUMP (1) 6...NUT, SELF-LOCKING, CAP (2) PLATE, WEAR, ROTARY PUMP (1) 9... SCREW, MACHINE (2) 8...SEAL ASSEMBLY, SHAFT (1) 1...HUB, BODY (1) 5 (7) QTY END OF FIGURE

346 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 96. Air Cleaner, Hand Starter, and Muffler

347 GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-8 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 14 EXTENDED DISTRIBUTION SYSTEM FIGURE 96 AIR CLEANER, HAND STARTER, AND MUFFLER 1 PAOOO AK AIR CLEANER, INTAKE PAOZZ AK FILTER ELEMENT PAOZZ AK GASKET PAOZZ AK GASKET PAOZZ OAK HEATING ELEMENT PBOOO AK STARTER, ENGINE, HAND PAOZZ AK HANDLE, STARTING ROPE XBOZZ 0U5N SHIELD, EXHAUST PAOZZ AK PNEUMATIC MUFFLER PAOZZ AK GASKET XBOOO 0U5N JUMPER, ELECTRICAL MOOZZ HVR WIRE, ELECTRICAL,MAKE FROM BULK... 1 MATERIAL, NSN , CUT TO LENGTH 8 INCHES 13 PAOZZ PN10-14R. TERMINAL LUG PAOZZ AK SCREW, CAP, HEX... 3 END OF FIGURE (7) QTY

348 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 97. Fuel Injection and Oil Systems

349 GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-8 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 14 EXTENDED DISTRIBUTION SYSTEM FIGURE 97 FUEL INJECTION AND OIL SYSTEMS 1 PBOOO U5N HOSE ASSY, SUPPLY PAOZZ CLAMP, HOSE MOOZZ HOSE, NONMETALLIC, MAKE FROM 1 BULK MATERIAL, NSN , CUT TO LENGTH 14 INCHES 4 MOOZZ K19-RED. INSULATION SLEEVING, MAKE FROM 1 BULK. MATERIAL, NSN , CUT TO LENGTH 0.1 INCHES 5 PAOZZ PLCD22004V. COUPLING HALF, MALE PBOOO U5N HOSE ASSY, RETURN PAOZZ CLAMP, HOSE MOOZZ HOSE, NONMETALLIC, MAKE FROM BULK MATERIAL, NSN , CUT TO LENGTH 16 INCHES 1 9 MOOZZ K19-YEL.. INSULATION SLEEVING, MAKE FROM BULK. MATERIAL, NSN , CUT TO LENGTH 0.1 FT 10 PAOZZ PLCD17006V. COUPLING HALF, FEMALE XBOOO 0U5N JUMPER, ELECTRICAL MOOZZ MTW-10-YEL. WIRE, ELECTRICAL... 1 (MAKE FROM BULK. CUT TO 3 IN.) 13 PAOZZ PN10-14R. TERMINAL LUG PAOZZ AK O-RING PAOZZ AK GAGE ROD-CAP PAOZZ AK NIPPLE, PIPE PAOZZ AK GASKET PAOZZ AK GASKET PAOZZ AK STRAINER, OIL PUMP PBOZZ AK SPRING, HELICAL (REGULATOR) PBOZZ AK SPRING, HELICAL (THROTTLE RETURN) PAOZZ AK GASKET PBOZZ AK PUMP, FUEL, METERING PAOZZ AK GASKET PAOZZ AK SPACER, SLEEVE PBOZZ AK INJECTOR ASSY, FUEL PBOZZ AK PIPE, FUEL INJECTION PAOZZ AK NUT, PLAIN, HEX PAOZZ AK PLUG, PIPE (OIL DRAIN) PAOZZ AK SCREW, CAP, HEX PAOZZ AK HANDLE, MANUAL CONTROL XBOZZ 0AK STAY, HANDLE PAOZZ S HANDLE, MANUAL CONTROL PAOZZ GUY SPRING, HELICAL, COMPRESSION... 1 END OF FIGURE (7) QTY

350 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 98. Electric Starter System

351 GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-8 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 14 EXTENDED DISTRIBUTION SYSTEM FIGURE 98 ELECTRIC STARTER SYSTEM 1 XBOZZ 0U5N BRACKET PAOZZ MS WASHER, FLAT PAOZZ A136. SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ U5N CABLE ASSY, POWER PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, FLAT PAOZZ M45913/1-4CS3. NUT, SELF-LOCKING PBOZZ S STARTER, ENGINE, ELECTRIC... 1 (7) QTY END OF FIGURE

352 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 99. Cylinder Head Valves and Gaskets

353 GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-8 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 14 EXTENDED DISTRIBUTION SYSTEM FIGURE 99 CYLINDER HEAD VALVES AND GASKETS 1 PAFZZ AK GASKET, CYLINDER HEAD PAFZZ AK CAP, VALVE PAFZZ AK SEAL, PLAIN PAOZZ AK GASKET PAFZZ AK VALVE, POPPET, ENGINE PAFZZ AK VALVE, POPPET, ENGINE PAFZZ GUY O-RING PAFZZ AK CYLINDER HEAD PAFZZ AK PUSH ROD, ENGINE PAFZZ AK WASHER, FLAT PAFZZ AK NUT, CAP PAFZZ S SCREW PAFZZ AK ROCKER ARM ASSEMBLY PAFZZ AK LOCK, VALVE SPRING RETAINER PAFZZ AK SEAT, SPRING PAFZZ AK SPRING, HELICAL PAFZZ AK WASHER, FLAT PAFZZ AK NUT, PLAIN, HEX PAOZZ AK BOLT, MACHINE PAOZZ AK HOLDER, PLUNGER PAOZZ AK PLUNGER, DETENT PAOZZ AK VALVE COVER ASSEMBLY... 1 (7) QTY END OF FIGURE

354 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P Figure 100. Crankcase Gasket and Piston Rings

355 GROUP 14 EXTENDED DISTRIBUTION SYSTEM DIESEL ENGINE-DRIVEN PUMP ASSEMBLY P-8 REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 14 EXTENDED DISTRIBUTION SYSTEM FIGURE 100 CRANKCASE GASKET AND PISTON RINGS 1 PAFZZ AK RING SET, PISTON PAFZZ GUY GASKET, CRANKCASE PAFZZ AK SEAL, PLAIN ENCASED... 1 (7) QTY END OF FIGURE / 18 BLANK

356

357

358 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 101. Flat Rack Assembly BLANK / 2

359 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 15 FLAT RACK ASSEMBLY FIGURE 101 FLAT RACK ASSEMBLY 1 PBOOO U5N END PANEL ASSEMBLY (PANEL #1) PBOOO U5N END PANEL ASSEMBLY (PANEL #2) PBOOO U5N PANEL ASSEMBLY TYPE I (PANEL #3) PBOOO U5N PANEL ASSEMBLY TYPE II (PANEL #4) PBOOO U5N PANEL ASSEMBLY TYPE III (PANEL #5) PBOOO U5N END PANEL ASSEMBLY (PANEL #6) PBOOO U5N END PANEL ASSEMBLY (PANEL #7) PBOFF U5N FRAME ASSEMBLY, FLAT RACK PBOOO U5N SUPPORT STAND ASSEMBLY PBOFF U5N FABRIC WALL... 1 (7) QTY END OF FIGURE

360 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 102. End Panel Assembly Panel #

361 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) QTY GROUP 15 FLAT RACK ASSEMBLY FIGURE 102 END PANEL ASSEMBLY PANEL #1 1 PBOOO U5N END PANEL ASSEMBLY (PANEL #1) PAOZZ C LATCH, SEALED LEVER PAOZZ S GASKET XBOZZ 0U5N PLATE, BACKING XBOZZ 0U5N COVER... 1 (7) END OF FIGURE

362 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 103. End Panel Assembly Panel #

363 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) QTY GROUP 15 FLAT RACK ASSEMBLY FIGURE 103 END PANEL ASSEMBLY PANEL #2 1 PBOOO U5N END PANEL ASSEMBLY (PANEL #2) PAOZZ C LATCH, SEALED LEVER PAOZZ S GASKET XBOZZ 0U5N PLATE, BACKING MOOZZ K55. STRIP, FOAM RUBBER, MAKE FROM BULK MATERIAL, NSN , CUT TO LENGTH AS NEEDED 2 (7) END OF FIGURE

364 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 104. Panel Assembly Type I Panel #

365 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 15 FLAT RACK ASSEMBLY FIGURE 104 PANEL ASSEMBLY TYPE I PANEL #3 1 PBOOO U5N PANEL ASSEMBLY TYPE 1 (PANEL #3) PAOZZ C LATCH, SEALED LEVER PAOZZ S GASKET XBOZZ 0U5N PLATE, BACKING MOOZZ K55. STRIP, FOAM RUBBER,MAKE FROM BULK MATERIAL,NSN , CUTT TO LENGTH AS NEEDED 2 (7) QTY END OF FIGURE

366 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 105. Panel Assembly Type II Panel #

367 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 15 FLAT RACK ASSEMBLY FIGURE 105 PANEL ASSEMBLY TYPE II PANEL #4 1 PBOOO U5N PANEL ASSEMBLY TYPE II (PANEL #4) PAOZZ C LATCH, SEALED LEVER PAOZZ S GASKET XBOZZ 0U5N PLATE, BACKING...12 (7) QTY END OF FIGURE

368 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 106. Panel Assembly Type III Panel #

369 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) QTY GROUP 15 FLAT RACK ASSEMBLY FIGURE 106 END PANEL ASSEMBLY PANEL #5 1 PBOOO U5N PANEL ASSEMBLY TYPE III (PANEL #5) PAOZZ C LATCH, SEALED LEVER PAOZZ S GASKET XBOZZ 0U5N PLATE, BACKING PAOZZ STEP, POLE PAOZZ NASM SCREW, CAP, HEX PAOZZ MS WASHER, FLAT XBOZZ 0U5N PLATE, BACKING PAOZZ MS WASHER, LOCK PAOZZ NUT, PLAIN, HEXAGON... 2 (7) END OF FIGURE

370 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 107. End Panel Assembly Panel #

371 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) QTY GROUP 15 FLAT RACK ASSEMBLY FIGURE 107 END PANEL ASSEMBLY PANEL #6 1 PBOOO U5N END PANEL ASSEMBLY (PANEL #6) PAOZZ C LATCH, SEALED LEVER PAOZZ S GASKET XBOZZ 0U5N PLATE, BACKING MOOZZ K55. STRIP, FOAM RUBBER,(MAKE FROM BULK MATERIAL, NSN , CUT TO LENGTH AS NEEDED 4 (7) END OF FIGURE

372 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 108. End Panel Assembly Panel #

373 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) QTY GROUP 15 FLAT RACK ASSEMBLY FIGURE 108 END PANEL ASSEMBLY PANEL #7 1 PBOOO U5N END PANEL ASSEMBLY (PANEL #7) PAOZZ C LATCH, SEALED LEVER PAOZZ S GASKET XBOZZ 0U5N PLATE, BACKING (7) END OF FIGURE

374 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 109. Frame Assembly

375 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 15 FLAT RACK ASSEMBLY FIGURE 109 FRAME ASSEMBLY 1 XBOZZ 0U5N JAMB, BOTTOM XBOZZ 0U5N DIVIDER, PANEL MOOZZ B2X3/16A SEAL, NONMETALLIC CHANNEL... 8 (CUT TO LENGTH FROM BULK) 4 PAOZZ SN HINGE, ACCESS DOOR PAOZZ MS24693-C276. SCREW, MACHINE XBOZZ 0U5N KEEPER, HINGE COVER XBOOO 0U5N WINCH/BEAM ASSEMBLY XBOZZ 0U5N BAIL BAR XBOOO 0U5N UPPER PANEL ASSEMBLY XBOZZ 0U5N ROLLER PAOZZ HANDLE, BAIL PAOZZ MS SCREW, MACHINE PAOZZ MS WASHER, FLAT PAOZZ M45913/1-4CS3. NUT, SELF-LOCKING XBOOO 0U5N LOWER PANEL ASSEMBLY PBOOO U5N SUPPORT STAND ASSEMBLY XBOOO 0U5N SUPPORT ARM ASSEMBLY PAOZZ B LOOP, STRAP FASTENER PAOZZ M24243/6-. RIVET, BLIND... 2 A806H 20 MOOZZ FASTENER TAPE, HOOK (MAKE FROM BULK MATERIAL. CUT TO LENGTH AS NEEDED) 21 MOOZZ FASTENER TAPE, HOOK... 1 (MAKE FROM BULK MATERIAL. CUT TO LENGTH 7 FT.) END OF FIGURE (7) QTY

376 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 110. Upper and Lower Panel Assemblies

377 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 15 FLAT RACK ASSEMBLY FIGURE 110 UPPER AND LOWER PANEL ASSEMBLIES 1 XBOOO 0U5N UPPER PANEL ASSEMBLY PAOZZ MS24693-C98. SCREW, MACHINE PAOZZ B. LOOP, STRAP FASTENER PAOZZ MS21044N3.. NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, MACHINE PAOZZ C LATCH, SEALED LEVER PAOZZ S GASKET XBOZZ 0U5N PLATE, BACKING MOOZZ B2X3/16A. SEAL, NONMETALLIC CHANNEL,MAKE FROM BULK MATERIAL,NSN ,CUT TO LENGTH 14 FT 1 11 XBOOO 0U5N LOWER PANEL ASSEMBLY PAOZZ MS24693-C97. SCREW, MACHINE PAOZZ B. LOOP, STRAP FASTENER PAOZZ MS21044N3.. NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, MACHINE MOOZZ X-1058 BT. SEAL, NONMETALLIC SPECIAL SHAPE... 1 (MAKE FROM BULK MATERIAL. CUT TO LENGTH 14 FT.) 18 PAOZZ C LATCH, SEALED LEVER PAOZZ S GASKET XBOZZ 0U5N PLATE, BACKING XBOZZ 0U5N BRACKET PAOZZ A029.. NUT, PLAIN, HEX PAOZZ A029.. WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N PLATE, SUPPORT PAOZZ A548.. BOLT, MACHINE... 8 END OF FIGURE (7) QTY

378 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 111. Support Arm Assembly

379 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 15 FLAT RACK ASSEMBLY FIGURE 111 SUPPORT ARM ASSEMBLY 1 PAOZZ MS SCREW, CAP, HEX PAOZZ MS WASHER, FLAT XBOZZ 0U5N BRACKET XBOZZ 0U5N PLATE, WASHER PAOZZ MS24693-C106 SCREW, MACHINE PAOZZ M45913/1-6CS3 NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT PAOZZ M45913/1-4CS3 NUT, SELF-LOCKING XBOZZ 0U5N SUPPORT ARM, INNER XBOZZ 0U5N SUPPORT ARM, OUTER PAOZZ A135 PIN, RETAINING PAOZZ NASM35307 SCREW, CAP, HEX PAOZZ MS WASHER, LOCK... 4 (7) QTY END OF FIGURE

380 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 112. Support Stand Assembly

381 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 15 FLAT RACK ASSEMBLY FIGURE 112 SUPPORT STAND ASSEMBLY 1 XBOZZ 0U5N SUPPORT ARM XBOZZ 0U5N VERTICAL SUPPORT PAOZZ A135 PIN, RETAINING PAOZZ M45913/1-6CS3 NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT XBOZZ 0U5N FOOT PLATE PAOZZ MS SCREW, CAP, HEX... 1 (7) QTY END OF FIGURE

382 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 113. Winch/Beam Assembly

383 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 15 FLAT RACK ASSEMBLY FIGURE 113 WINCH/BEAM ASSEMBLY 1 PAOZZ PWA NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT PAOZZ MS S316 SCREW, CAP, HEX XBOZZ 0U5N BEAM, WINCH PAOZZ T24 WINCH, DRUM, HAND OPERATED PAOZZ M45913/1-6CS3. NUT, SELF-LOCKING PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, CAP, HEX XBOZZ T15 BLOCK, TACKLE PAOZZ MS24693-C97. SCREW, MACHINE PAOZZ MS WASHER, FLAT PAOZZ M45913/1-4CS3. NUT, SELF-LOCKING PAOZZ T55 WIRE ROPE ASSEMBLY...1 (7) QTY END OF FIGURE

384 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 114. Bail Bar and Roller

385 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 15 FLAT RACK ASSEMBLY FIGURE 114 BAIL BAR AND ROLLER 1 XBOZZ 0U5N BAIL BAR XDOZZ 0Y3H SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ B1821BH050C1. SCREW, CAP, HEX N 6 PAOZZ MS NUT, PLAIN, HEX PAOZZ MS SCREW, CAP, HEX PAOZZ OY3H3 175NF5. NUT, PLAIN, HEX PAOZZ OY3H3 175WS. WASHER, LOCK PAOZZ U5N SHIM (AS REQUIRED)... V 11 PAOZZ Y3H CH5. SCREW, CAP, HEX XBOZZ 0U5N ROLLER PAOZZ A125. PIN, SAFETY SNAP PAOZZ MS WASHER, FLAT XBOZZ 0U5N SHAFT, ROLLER... 1 END OF FIGURE (7) QTY

386 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY FIGURE ON FOLLOWING PAGES

387 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY , 14, Figure 115. Panel Divider, Bottom Jamb, and TWPS and TQG Mounting Hardware (Sheet 1 of 2)

388 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY Figure 115. Panel Divider, Bottom Jamb, and TWPS and TQG Mounting Hardware (Sheet 2 of 2)

389 GROUP 15 FLAT RACK ASSEMBLY FLAT RACK ASSEMBLY REPAIR PARTS LIST (1) ITEM NO. (2) SMR CODE (3) NSN (4) CAGEC (5) PART NUMBER (6) DESCRIPTION AND USABLE ON CODE (UOC) GROUP 15 FLAT RACK ASSEMBLY FIGURE 115 PANEL DIVIDER, BOTTOM JAMB, AND TWPS AND TQG MOUNTING HARDWARE 1 XBOZZ 0U5N JAMB, BOTTOM PAOZZ NASM SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT XBOZZ 0U5N DIVIDER, PANEL PAOZZ NASM SCREW, CAP, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ MS NUT, PLAIN, HEX PAOZZ MS WASHER, LOCK PAOZZ MS WASHER, FLAT PAOZZ MS SCREW, CAP, HEX PAOZZ K653 SHIM, (AS REQUIRED)... V 14 PAOZZ AY7 B.060-PACK REG SHIM, (AS REQUIRED)... V 15 PAOZZ K82 SHIM, (AS REQUIRED)... V 16 PAOZZ A035 WASHER, BEVEL... 4 (7) QTY END OF FIGURE /34 BLANK

390

391

392 TACTICAL WATER PURIFICATION SYSTEM (TWPS) GROUP 16 WASTE DISCHARGE SYSTEM HOSE ASSEMBLIES AND ADAPTORS Figure 116. Waste Discharge System Hose Assemblies and Adaptors BLANK / 2